monsanto co - marshall€¦ · f. monsanto company-marshall shall maintain a copy of the dust...

Michael L. Parson, Governor

JAN O 7 2019 Ms. Teri Merical Monsanto Company - Marshall 800 North Lindbergh Blvd St. Louis, MO 63167

RE: New Source Review Permit - Project Number: 2018-09-030

Dear Ms. Merical:

Carol S. Comer, Director

Enclosed with this letter is your permit to construct. Please study it carefully and refer to Appendix A for a list of common abbreviations and acronyms used in the permit. Also, note the special conditions on the accompanying pages. The document entitled, "Review of Application for Authority to Construct," is part of the permit and should be kept with this permit in your files. Operation in accordance with these conditions and your new source review permit application is necessary for continued compliance. The reverse side of your permit certificate has important information concerning standard permit conditions and your rights and obligations under the laws and regulations of the State of Missouri.

This permit may include requirements with which you may not be familiar. If you would like the department to meet with you to discuss how to understand and satisfy the requirements contained in this permit, an appointment referred to as a Compliance Assistance Visit (CAV) can be set up with you. To request a CA V, please contact your local regional office or fill out an online request. The regional office contact information can be found at the following website: http://dnr.mo.gov/regions/. The online CAY request can be found at http://dnr.mo.gov/cav/compliance.htm.

If you were adversely affected by this permit decision, you may be entitled to pursue an appeal before the administrative hearing commission pursuant to Sections 621.250 and 643.075.6 RSMo. To appeal, you must file a petition with the administrative hearing commission within thirty days after the date this decision was mailed or the date it was delivered, whichever date was earlier. If any such petition is sent by registered mail or certified mail, it will be deemed filed on the date it is mailed; if it is sent by any method other than registered mail or certified mail, it will be deemed filed on the date it is received by the administrative hearing commission, whose contact information is: Administrative Hearing Commission, United States Post Office Building, 131 West High Street, Third Floor, P.O. Box 1557, Jefferson City, Missouri 65102, phone: 573-751-2422, fax: 573-751-5018, website: www.oa.mo.gov/ahc.

Recycled paper

Ms. Teri Merical Page Two

If you have any questions regarding this permit, please do not hesitate to contact Chad Stephenson, at the Department of Natural Resources' Air Pollution Control Program, P.O. Box 176, Jefferson City, MO 65102 or at (573) 751-4817. Thank you for your attention to this matter.

Sincerely,

AIR POLLUTION CONTROL PROGRAM

tJtJ!,~ Susan Heckenkamp New Source Review Unit Chief

SH:csj

Enclosures

c: Northeast Regional Office PAMS File: 2018-09-030

Permit Number: 012019-002

~[§]MISSOURI Ii: 11 & I DEPARTMENT OF ~ tJ:) NATURAL RESOURCES

MISSOURI AIR CONSERVATION COMMISSION

PERMIT TO CONSTRUCT

Under the authority of RSMo 643 and the Federal Clean Air Act the applicant is authorized to construct the air contaminant source(s) described below, in accordance with the laws, rules and conditions as set forth herein.

Permit Number: 0 1 2 0 1 9 = 0 0 2 Project Number: 2018-09-030 Installation Number: 195-0034

Parent Company: Monsanto Company

Parent Company Address: 800 North Lindbergh Blvd, St. Louis, MO 63167

Installation Name:

Installation Address:

Location Information:

Monsanto Company - Marshall

830 North Miami, Marshall, MO 65340

Saline County, S10, T50N, R21W

Application for Authority to Construct was made for: A new Soy Box Filling Surge Bin (EU-21a) and Soy Box Filling Station (EU22a) and modification to the Mini Bulk Bagger Surge Bin (EU21) and the Mini Bulk Bagger (EU22). This review was conducted in accordance with Section (5), Missouri State Rule 10 CSR 10-6.060, Construction Permits Required.

D Standard Conditions (on reverse) are applicable to this permit.

~ Standard Conditions (on reverse) and Special Conditions are applicable to this permit.

JAN O 7 2019 Effective Date Director or De · nee

Department of Natural Resources

STANDARD CONDITIONS:

Permission to construct may be revoked if you fail to begin construction or modification within two years from the effective date of this permit. Permittee should notify the Enforcement and Compliance Section of the Air Pollution Control Program if construction or modification is not started within two years after the effective date of this permit, or if construction or modification is suspended for one year or more.

You will be in violation of 10 CSR 10-6.060 if you fail to adhere to the specifications and conditions listed in your application, this permit and the project review. In the event that there is a discrepancy between the permit application and this permit, the conditions of this permit shall take precedence. Specifically, all air contaminant control devices shall be operated and maintained as specified in the application, associated plans and specifications.

You must notify the Enforcement and Compliance Section of the Department's Air Pollution Control Program of the anticipated date of start up of this (these) air contaminant source(s). The information must be made available within 30 days of actual startup. Also, you must notify the Department's regional office responsible for the area within which you are located within 15 days after the actual start up of this (these) air contaminant source(s).

A copy of the permit application and this permit and permit review shall be kept at the installation address and shall be made available to Department's personnel upon request.

You may appeal this permit or any of the listed special conditions to the Administrative Hearing Commission (AHC), P.O. Box 1557, Jefferson City, MO 65102, as provided in RSMo 643.075.6 and 621.250.3. If you choose to appeal, you must file a petition with the AHC within 30 days after the date this decision was mailed or the date it was delivered, whichever date was earlier. If any such petition is sent by registered mail or certified mail, it will be deemed filed on the date it is mailed. If it is sent by any method other than registered mail or certified mail, it will be deemed filed on the date it is received by the AHC.

If you choose not to appeal, this certificate, the project review and your application and associated correspondence constitutes your permit to construct. The permit allows you to construct and operate your air contaminant source(s), but in no way relieves you of your obligation to comply with all applicable provisions of the Missouri Air Conservation Law, regulations of the Missouri Department of Natural Resources and other applicable federal, state and local laws and ordinances.

The Air Pollution Control Program invites your questions regarding this air pollution permit. Please contact the Construction Permit Unit using the contact information below.

Contact Information: Missouri Department of Natural Resources

Air Pollution Control Program P.O. Box 176

Jefferson City, MO 65102-0176 (573) 751-4817

The regional office information can be found at the following website: http://dnr.mo.gov/reg ions/

- 2 -

Project No. 2018-09-030 Permit No.

01201 =002 SPECIAL CONDITIONS: The permittee is authorized to construct and operate subject to the following special conditions:

The special conditions listed in this permit were included based on the authority granted to the Missouri Air Pollution Control Program by the Missouri Air Conservation Law (specifically 643. 075) and by the Missouri Rules listed in Title 10, Division 10 of the Code of State Regulations (specifically 10 CSR 10-6.060). For specific details regarding conditions, see 10 CSR 10-6. 060 paragraph (12)(A) 10. "Conditions required by permitting authority."

Monsanto Company - Marshall Saline County, S10, T50N, R21W

1. Superseding Conditions A. The conditions of this permit supersede all the special conditions found in

the previously issued construction permit 072010-0048 issued by the Air Pollution Control Program.

2. Emission Limitation A. The Monsanto Company - Marshall shall emit less than 15.0 tons of

particulate matter less than 10 microns in diameter (PM10) in any consecutive 12-month period from the entire installation as defined in Table 2.

B. The Monsanto Company - Marshall shall demonstrate compliance with the emission limit in Special Condition 2.A by recording the 12-month rolling total PM10 emissions. The Monsanto Company - Marshall shall use electronic forms that contain at minimum the following information: 1) Monthly throughput of each emission unit in tons 2) Emission factor for the unit as stated in Attachment A 3) Source of emission factor as stated in Attachment A 4) Control device type 5) Control efficiency of cartridge filters shall not exceed 99.0 percent 6) Monthly PM10 emissions for each unit in tons 7) Monthly PM10 emissions for the entire installation in tons 8) 12-month total PM10 emissions for the entire installation in tons

3. Control Device Requirement - Cartridge Filter Dust Collectors B. The Monsanto Company - Marshall shall control PM, PM10, and PM2.s

emissions using cartridge filter dust collectors on the following emission units (EU): 1) EU-2: Scalp 2) EU-5: Aspirator 3) EU-6: 17 Bulk Storage Bins 4) EU-7: Cleaner Surge Bin 5) EU-8: Cleaner 6) EU-9: Color Sorter Surge Bin 7) EU-10: Color Sorter Primary

- 3 -

Project No. 2018-09-030

Permit No. 0 1 2 0 1 - 0 0 2

SPECIAL CONDITIONS: The permittee is authorized to construct and operate subject to the following special conditions:

8) EU-11: Color Sorter Secondary 9) EU-12: Gravity Surge Bin #1 10) EU-13: Gravity Table #1 11) EU-14: Gravity Surge Bin #2 12) EU-15: GravityTable#2 13) EU-17: 4 True Bulk Bagging Bins 14) EU-18: 6 Bagging Bins 15) EU-19: Bemis Bagger Surge Bin 16) EU-20: Bemis Bagger 17) EU-21: Mini Bulk Bagger Surge Bin/ Soy Box Filling Surge Bin 18) EU-22: Mini Bulk Bagger/ Soy Box Filling Station 19) EU-33a Transfer Mini Bulk to True Bulk

C. The dust collectors shall be operated and maintained in accordance with the manufacturer's specifications. The dust collectors shall be equipped with a gauge or meter, which indicates the pressure drop across the control device. These gauges or meters shall be located such that the Department of Natural Resources' employees may easily observe them.

D. Replacement cartridges for the dust collectors shall be kept on hand at all times. The cartridges shall be made of materials appropriate for operating conditions expected to occur (i.e. temperature limits, acidic and alkali resistance, and abrasion resistance).

E. Monsanto Company - Marshall shall monitor and record the operating pressure drop across the dust collectors at least once every 24 hours when in operation. The operating pressure drop shall be maintained within the design conditions specified by the filter manufacturer's performance warranty.

F. Monsanto Company- Marshall shall maintain a copy of the dust collectors manufacturer's performance warranty on site.

G. Monsanto Company- Marshall shall maintain an operating and maintenance log for the dust collectors which shall include the following: 1) Incidents of malfunction, with impact on emissions, duration of

event, probable cause, and corrective actions; and 2) Maintenance activities, with inspection schedule, repair actions,

4. Record Keeping and Reporting Requirements A Monsanto Company - Marshall shall maintain all records required by this

permit for not less than five years and shall make them available immediately to any Missouri Department of Natural Resources' personnel upon request.

- 4 -

Project No. 2018-09-030

Permit No. O 1 2 0 = O O

SPECIAL CONDITIONS: The permittee is authorized to construct and operate subject to the following special conditions:

B. Monsanto Company - Marshall shall report to the Air Pollution Control Program's Compliance/Enforcement Section, by mail at P.O. Box 176, Jefferson City, MO 65102 or by email at [email protected], no later than 10 days after the end of the month during which any record required by this permit shows an exceedance of a limitation imposed by this permit.

- 5 -

REVIEW OF APPLICATION FOR AUTHORITY TO CONSTRUCT AND OPERATE SECTION (5) REVIEW

Project Number: 2018-09-030 Installation ID Number: 195-0034

Permit Number: O 1 2 O 1 9 ~ 0 0 2

Installation Address: Parent Company: Monsanto Company - Marshall 830 North Miami

Monsanto Company 800 North Lindbergh Blvd St. Louis, MO 63167 Marshall, MO 65340

Saline County, S10, T50N, R21W

REVIEW SUMMARY

• Monsanto Company - Marshall has applied for authority to construct a new Soy Box Filling Surge Bin (EU-21 a) and Soy Box Filling Station (EU22a) and modification to the Mini Bulk Bagger Surge Bin (EU21) and the Mini Bulk Bagger (EU22).

• The application was deemed complete on October 10, 2018.

• HAP emissions are not expected from the proposed equipment.

• None of the NSPS apply to the installation. 40 CFR 60 Subpart DD, "Standards of Performance for Grain Elevators" does not apply to the equipment because the storage capacity of the grain elevator is less than 2.5 million bushels.

• None of the NESHAPs apply to this installation. None of the currently promulgated MACT regulations apply to the proposed equipment.

• Cartridge filter dust collectors are being used to control the PM10 emissions from the equipment in this permit.

• This review was conducted in accordance with Section (5) of Missouri State Rule 10 CSR 10-6.060, Construction Permits Required. Potential emissions of PM10 are conditioned below the de minimis level.

• This installation is located in Saline County, an attainment/unclassifiable area for all criteria pollutants.

• This installation is not on the List of Named Installations found in 10 CSR 10-6.020(3)(8), Table 2. The installation's major source level is 250 tons per year and fugitive emissions are not counted toward major source applicability.

• Ambient air quality modeling was not performed since potential emissions of the application are below de minimis levels.

- 6 -

• Emissions testing is not required for the equipment as a part of this permit. Testing may be required as part of other state, federal or applicable rules.

• No Operating Permit is required for this installation.

• Approval of this permit is recommended with special conditions.

INSTALLATION DESCRIPTION

The Monsanto Company - Marshall operates an existing soybean storage and conditioning process located at 830 North Miami in Marshall, Missouri of Saline County, which is a minor source. This installation consists of soybean seed receiving, cleaning, sorting, packaging and bulk load out. ,

Operations begin when soybean seed arrive at the facility via hopper trucks, which are unloaded at the Inside Receiving area. If the Inside Receiving area does not have available capacity, the seeds can be routed to storage bins in the Outside Receiving area. Once capacity is available, the seeds are transferred from Outside Receiving to Inside Receiving.

The seeds are next processed through cleaning operations, which include a scalperator, aspirator, and cleaner. Pods and stems collected during the receiving/scalping operation are collected into a separate pod bin. Seeds are collected into storage bins after the aspirator, before being transferred through a surge bin and into the cleaner.

Following the cleaner, the seeds enter a surge bin, pass into the primary and secondary color sorters, enter additional surge bins, and pass through gravity tables. Materials rejected from the cleaner, color sorters, and gravity tables are collected into a cull bin.

The facility previously had a treater drum (EU-16) for application of treatment chemicals. The treater drum has been removed from the facility and no seed treating is currently done at the facility.

From the gravity tables the seeds flow into bagging bins. At this point, the seeds may either be shipped in bulk or flow into surge bins to be packaged into paper bags or mini bulk bags.

If necessary, seeds can be transferred to outside bulk storage bins to await shipment. The facility also has the ability to transfer seeds from mini bulk to bulk load out to trucks.

The facility utilizes multiple haul roads. Traffic on the haul roads is maintained in one direction only. The haul roads consist of both paved and unpaved surfaces.

The following New Source Review permits have been issued to Monsanto Company -Marshall from the Air Pollution Control Program.

- 7 -

T bl 1 P ·t H. t a e ermI IS Ory

Permit Number Description 0792-009 Addition of oravitv separator

072010-004 Grain/Seed handlinQ 072010-004A Amend wording 072010-0048 Control device improvements

PROJECT DESCRIPTION

This permit addresses changes for a seed packaging filling station for hard side box packaging of seeds, as well as an existing Camfil dust collector of the bulk unloading. The seed packing filling station will consist of the existing EU-21 and EU-22 will exhaust to an existing Torit Downflo Dust Collector (CE-7). The Camfil Dust collector will control emissions from the existing Mini Bulk dumping station (EU-33) to True Bulk Loadout.

The new/modified emission units and changes include the following: • EU-21 Mini Bulk Bagger Surge Bin/Soy Box Filling Surge Drum • EU-22 Mini Bulk Bagger/Soy Box Filling Station • CE-8 Camfil GS4 Dust collector to control emission from EU-33a

The maximum capacity of the receiving or processing areas will not be changed as a result of the project. The seed handling and cleaning processes at the facility will not be affected by this project and will continue as currently operated. The project will allow the facility flexibility in seed shipping, as seeds may either be shipped in bulk, paper bags, mini bulk bags, or hard side box packaging after completion.

Table 2 lists emission units of the installation and the maximum hourly design rates taken from permit 072010-004B. As part of this project, a throughput increase is expected for two pieces of existing equipment, the Mini Bulk Bagger Surge Bin/Soy Box Filling Surge Drum (EU-21) and the Mini Bulk Bagger/Soy Box Filling Station (EU-22). The MHDR for the Mini Bulk Bagger Surge Bin/Soy Box Filling Surge Drum (EU-21) and the Mini Bulk Bagger/Soy Box Filling Station (EU-22) were previously 500 bushels/hr. This project is increasing the MHDR for both EU-21 and EU-22 to 850 bushels/hr. Calculations were performed having the density of grain being 60 pounds per bushel.

T bl 2 I t II t" E . . U ·t S a e ns a a I0n m1ssIon nl ummary Emission Unit Emission Point MHDR ·.

Emission Unit No. No. (bushelsm r) .. · Inside Receiving [fugitive] EU-1 EP-1 2,000 Scalp (LMC screen/conveyor) EU-2 EP-2 2,000 Pod Bin [fugitive] EU-3 EP-3 400 Pod Bin Loadout [fugitive] EU-4 EP-4 400 Aspirator EU-5 EP-5 2,000

17 Bulk Storage Bins EU-6 EP-5

2,000 (12 x 3,000 bu; 5 x 1,000 bu) Cleaner Surge Bin EU-7 EP-6 2,000

Cleaner (Crippen 588) EU-8 EP-6 550

Color Sorter Surge Bin EU-9 EP-7 2,000

- 8 -

Color Sorter Primary EU-10 EP-7 550 Color Sorter Secondary EU-11 EP-7 110

Gravity Surge Bin #1 (3600) EU-12 EP-8 500 Gravity Table #1 (Oliver 3600) EU-13 EP-8 500 Gravity Surge Bin #2 (160) EU-14 EP-9 165 Gravity Table #2 (Oliver 160) EU-15 EP-9 165 4 True Bulk/ Bagging Bins (1,000 bu

EU-17 EP-9 500

each)

6 Bagging Bins (2 x 450 bu; 2 x 270 EU-18 EP-11

500 bu; 2 x 250 bu)

Bemis Bagger Surge Bin EU-19 EP-11 500 Bemis Bagger EU-20 EP-11 500 Mini Bulk Bagger Surge Bin/Soy Box

EU-21 EP-11 850 Fillinq Surqe Drum Mini Bulk Bagger/Soy Box Filling

EU-22 EP-11 850 Station

Tower True Bulk Loadout [fugitive] EU-23 EP-12 2,083

Cull Bin (3,000 bu) [fugitive] EU-24 EP-13 200 Cull Loadout [fugitive] EU-25 EP-14 663 Internal Handling [fugitive] EU-26 EP-15 550

Outside Receiving [fugitive] EU-27 EP-16 1,350

30 Outside Storage Bins 1,350 (24 x 3000 bu; 2 x 2,000 bu; 4 x 1500 EU-28 EP-17 bu)

Outside Storage Loadout - x-fer to 1,350

Inside Receiving [fugitive] EU-29 EP-18

Transfer to Outside True Bulk Bins EU-30 EP-19

1,350 [fugitive]

17 Outside True Bulk Bins (1100 bu EU-31 EP-20

1,350 each) Outside True Bulk Bins Loadout

EU-32 EP-21 1,800

[fugitive]

Transfer Mini Bulk to True Bulk EU-33 EP-22

1,800 [fugitive]

Mini Bulk to True Bulk EU-33a EP-22 1,800

Haul Roads [fugitive] EU-34 EP-23 5.63 VMT/hr

EMISSIONS/CONTROLS EVALUATION

The emission factors of soybean storage and handling used in this analysis were obtained from the Environmental Protection Agency (EPA) document AP-42, Compilation of Air Pollutant Emission Factors, Fifth Edition, Section 9.9.1 "Grain Elevators & Processes" (5/2003). The control efficiency used for the cartridge filters was 99% for PM, PM10, and PM2.5.

The following table provides an emissions summary for this installation. Existing potential emissions were taken from 072010-004. Existing actual emissions were taken

- 9 -

from the installation's 2017 EIQ. Potential emissions of the project represent the potential of the modified equipment (EU-21 and EU-22), assuming continuous operation (8760 hours per year). Conditioned potential emissions of the installation account for a voluntary de minimis PM10 annual emission limit requested by Monsanto Company -Marshall.

Table 3: Emissions Summarv (tpy) ' Conditioned

Regulatory Existing Existing

Potential Potential Pollutant De Minimis Potential Actual Emissions of Emissions of

Emissions Levels Emissions

(2017 EIQ) the Project the '

',, ,,' ; Installation

PM 25.0 N/D N/D 0.19 50.00

PM10 15.0 <15.0 2.65 0.09 <15.0

PM2s 10.0 N/D 1.05 0.02 8.29

SOx 40.0 N/A NIA N/A N/A

NOx 40.0 N/A N/A N/A N/A

voe 40.0 N/A1 0.051 N/A N/A

co 100.0 N/A N/A N/A N/A

GHG (CO2e) N/A N/A NIA N/A N/A

GHG (mass) N/A N/A N/A N/A N/A

HAPs 10.0/25.0 N/A1 0.0001 1 N/A N/A

Ethylene 10.0 N/A1 N/D1 N/A

N/A Glycol

N/A = Not Applicable; N/0 = Not Determined 1 Existing potential and actual emissions of VOC and HAPs were from the treater drum (EU-16) that has been removed.

PERMIT RULE APPLICABILITY

This review was conducted in accordance with Section (5) of Missouri State Rule 10 CSR 10-6.060, Construction Permits Required. Potential emissions of PM10 are conditioned below de minimis levels.

APPLICABLE REQUIREMENTS

Monsanto Company - Marshall shall comply with the following applicable requirements. The Missouri Air Conservation Laws and Regulations should be consulted for specific record keeping, monitoring, and reporting requirements. Compliance with these emission standards, based on information submitted in the application, has been verified at the time this application was approved.

- 10 -

GENERAL REQUIREMENTS

• Start-Up, Shutdown, and Malfunction Conditions, 10 CSR 10-6.050

• Submission of Emission Data, Emission Fees and Process Information, 10 CSR 10-6.110

o Per 10 CSR 10-6.110(4)(8)2.8(11) and (4)(8)2.C(II) a full EIQ is required for the first full calendar year the equipment (or modifications) approved by this permit are in operation.

• Restriction of Particulate Matter to the Ambient Air Beyond the Premises of Origin, 10 CSR 10-6.170

• Restriction of Emission of Visible Air Contaminants, 10 CSR 10-6.220

• Restriction of Emission of Odors, 10 CSR 10-6.165

SPECIFIC REQUIREMENTS

• Restriction of Emission of Particulate Matter From Industrial Processes, 10 CSR 10-6.400

STAFF RECOMMENDATION

On the basis of this review conducted in accordance with Section (5), Missouri State Rule 10 CSR 10-6.060, Construction Permits Required, it is recommended that this permit be granted with special conditions.

PERMIT DOCUMENTS

The following documents are incorporated by reference into this permit:

• The Application for Authority to Construct form, dated September 24, 2018, received September 25, 2018, designating Monsanto Company as the owner and operator of the installation.

- 11 -

Emlasloo Unit Emission Emission ConhDI

Pollutant Unit No, Point No. Oev1ce No.

Inside Recel\Cng [fug1t1w] ElJ.1 EP-1 NIA PM PM-10

PM-2 5 Hopper Truck

sec 3-02-oos.-52

Scalp {LMC screenJconwyor) EU-2 EP-2 CD-1 PM PM-10 PM-25

Gram Clea-img sec 3-02-005-37

Pod Bin {fugrt1vej ElJ.3 EP-3 NJA PM PM-10

PM-25 Storage Btn (vent) sec 3-02-005-40

Pod Bm Loadout [fug1t1ve] EU-4 EP-4 NIA PM PM-10

PM-25 Gram Shipping (truck) sec 3-02-005-06

Aspirator ElJ.5 EP-5 CD-2 PM PM-10

PM-25 Gran Cleaimg sec 3-02-oos-31

17 Bulk Storage Bins (12 x 3.000

bu, 5x 1,000 bu) ElJ.6 EP-5 CD-2 PM PM-10

PM-25 Storage Bin (vent) sec 3-02-005-40

Cleaier Surge Bm ElJ.7 EP-8 CD-3 PM PM-10

PM-25 Storage Bm (vent) sec 3-02-005-40

Cleaier (Crippen 588) ElJ.8 EP-8 CD-3 PM PM-10

PM-25 Gran Cleaimg sec 3-02-005-37

Color Sorter Surge Bm ElJ.9 EP-7 CD-4 PM PM-10

PM-25 Storage Bm (vent) sec 3-02-005--40

Color Sorter Pnmary EU-10 EP-7 CD-4 PM PM-10 PM-2 5

Gra:n Haidling sec 3-02-005-30

Color Sorter Secoodary EU-11 EP-7 CD-4 PM PM-10 PM-2 5

Gran Hoodling sec 3-02-005-30

GrtNty Surge Bm #1 (3600) EU-12 EP-8 CD-8 PM PM-10

PM-2 5 Storage Bin (vent) sec 3-02-005-40

Grtr,\ty Table #1 (O/lver 3600) EU-13 EP-8 CD-5 PM PM-10

PM-25 Gram Haidl1ng sec 3-02-005-30

Gra-.ity Surge Bin #2 (160) EU-14 EP-8 CD-8 PM PM-10

PM-25 Storage B1n (wnt) sec 3-02-oos-40

GnNty Table #2 (Oliver 160) EU--15 EP-8 CD-6 PM PM-10 PM-25

Gram Haidlmg sec 3-02-005-30

TreaterDrum[fug1t1w] EU-16 EP-11 CD-7 PM PM-10

PM-2 5 Gra:n Haidling voe sec 3-02-005-30 HAP

4 True Bulk/ Bagging Bins

(1,000 bu each) EIJ..17 EP-B CD-8 PM PM-10

PM-2 5

Storage Bm (vent)

sec 3-02-005-40

NIA"' Nol Applicable

Emll5fon Factor

0 035 00078 00013

0 375 0 22875 0 08625

0 025

0 0063

0 0011

0 086

0 029 0 0049

0 375 022875

0 08625

0 025

0 0063

00011

0 025

0 0063 00011

0 375

022875

0 08625

0 025 0 0063

0 0011

0 061

0 034 0 0058

0 061

0 034

0 0058

0 025 00063

00011

0 122 0 068

00116

0 025 0 0063 0 0011

0 122

0 068 00116

0 061

0 034 00058

Attachment A Project Number: 2018-09-030 Installation Number: 195-0034

Units Source otEF Eml5SlonUnlt

6 Bagging Bms

lbs/ton AP-42 Table 9 91-1 (2x 450 bu, 2x 270bu, 2 x 250 bu) lb/ton AP.-42T~e 99H lb/ton AP-42 Table 9 91-1

Storage Bm {wnt) sec J..02-005-40

lbs/ton AP-42 Table 9 9 1-1 Berms Bagger Surge Bin

lb/ton AP-42 Table 9 9.1-1

lb/ton AP-42 Table 9 9 H Storage Bin (vent) sec 3-02-005-40

lbs/ton AP-42 Table 9 9 1-1 Berns Bagger

lb/ton AP-42 Table 9 9 1-1

lb/ton AP-42Table991-1

Gram Handling sec 3-02-005-30

lbs/ton AP-42 Table 9 91-1 Mmi Bulk Bagger Surge Bm lb/ton AP-42 Table 9 9 1-1


Storage Bin (vent) sec J.-02-005-40

lbs/ton AP-42 Table 9 91-1 Mini Bulk Bagger

lb/Ion AP-42 Table 9 9 1-1

lb/Ion AP-42 Table 9.9 1-1

Grain Handling sec 3-02-005-30

lbs/ton AP-42 Table 9 9 1-1 Tower True Bulk Loadou1 !fug1t1vej

lb/Ion AP-42 Table 9 91-1

lb/ton AP-42 Table 9 91-1

Gram Sh1ppmg (truck) sec 3-02-005-06

lbs/ton AP-42 Table 9 9 1-1 CUii Bm (3,000 bu) {fug1t1ve]


lb/ton AP-42 Table 9 9.1-1

Storage Sm (vent) sec 3-02-005-40

lbs/ton"" AP-42 Table 9 9 1-1 Cull loadout ffug1t1ve] lb/ton AP-42 Table 9 9 1-1


Gram Shipping (truck) sec J.-02-005-06

lbs/ton AP-42 Table 9 9 1-1 Internal Handlmgffug1t1ve) lb/Ion AP-42 Table 9 9 1-1 lb/ton AP-42 Table 9 9 1-1

Gram Handling sec 3-02-oos-30

lbs/ton AP-42 Table 9 91-1 Outside Rece1~ng [fu91t1ve] lbJton AP-42 Table 9 91-1


Hopper Truck sec 3-02-005-52

30 Outside Storage Bins

lbs/ton AP-42 Table 9 9 1-1 (24 x 3000 bu, 2 x 2,000 bu, 4 x 1500 bu) lb/Ion AP-42 Table 9 9 1-1


Storage Bm (vent) sec 3-02-005-40

Outside Storage Loadout x-ferto Inside

lbs/ton AP-42 Table 9 91-1 Rece1~ng{fugrt1wJ lb/ton AP-42 Table 9 9 1-1 lb/Ion AP-42 Table 9 9 1-1

Gram Shipping (truck) sec 3-02-005-06

lbs/ton AP-42Table 9 91-1 Transfer to Outside True Bulk Bms [fug1t1w]


lb/1on AP-42Tab!e991-1 Hopper Truck sec 3-02-005-52

lbs/100 AP-42 Table 9 91-1 17 Outside True Bulk Bins (1100 bu each)



Storage B1n (vent) sec 3-02-oos..~o

lbs/ton AP-42 Table 9 91-1 Outsrde True Bulk Bins Loadout [fug1t1vej


lb/Ion AP-42 Table 9 91-1 Gram Shipping (truck) sec 3-02-005-06

lbs/ton AP-42 Table 9 91-1 Tra,sfer M1rn Bulk to True Bulk [fug1t1vej



NIA NIA See Trea1.mg Sheets Gram Shipping (true k) sec 3-02-005-06

0 025 lbs/ton AP-42Table 9 91-1 Haul Roads [fug1t1-.e)

0 0063 lb/Ion AP-42Table9 91-1 Paved

00011 lb/ton AP-42 Table 9 9 1-1 Unpaved.

- 12 -

Emll&on Emission Control Pollutant

Emlssfon Unlts Soun:eofEF

Unit No, PolntNl:l.. DevtCD No. F.-

EU-18 EP-11 CD-7 PM 0 025 lbs/ion AP-42 Table 9 9 1-1

PM-10 0 0063 lb/ton AP-42 Table 9 9 1-1 PM-2 5 0 0011 lb/ton AP-42 Table 9 9 1-1

ELJ..-19 EP-11 CD-7 PM 0025 lbs/ton AP-42 Table 9 9 1-1

PM-10 0 0063 lb/ton AP-42 Tab1e 9 9 1-1 PM-2 5 0 0011 lb/ton AP-42 Table 9 9 1-1

EU-20 EP-11 CD-7 PM 0061 lbs/1on AP-42 Table 9 9 1-1 PM-10 0034 lb/ton AP-42 Ta~e 99 1-1 PM-2 5 0 0058 lb/ton AP-42 Ta~e 9.9 1-1

EU-21 EP-11 CD-7 PM 0 025 lbs/ton AP-42 Table 9 91-1

PM-10 0 0063 lb/ton AP-42 Table 9 9 1-1

PM-2 5 0 0011 lb/ton AP-42 Table 9 9 1-1

EU-22 EP-11 CD-7 PM 0 061 lbs/ton AP-42 Table 9 9 1-1 PM-10 0034 lb/ton AP-42 Table 9 9 1-1 PM-2 5 0 0058 lb/ton AP-42 Table 9 9 1-1

EU-23 EP-12 NIA PM 0 086 lbs/too AP-42 Table 9 9 1-1 PM-10 0 029 lb/ton AP-42 Table 9 9 1-1 PM-2 5 0 0049 lb/ton AP-42 Table 9 9 1-1

EU-24 EP-13 NIA PM 0 025 lbs/1on AP-42 Table 9 91-1 PM-10 0 0063 lb/ton AP-42 Table 9 91-1 PM-2 5 00011 lb/ton AP-42 Table 9 9 1-1

EU--25 EP-14 NIA PM 0.086 lbs/ton AP-42 Table 9 91-1 PM-10 0 029 lb/ton AP-42 Table 9 9 1-1 PM-2 5 0 0049 lb/ton AP-42 Table 9 9 1-1

EU-26 EP-15 NIA PM 0.061 lbs/ton AP-42 Table 9 91-1 PM-10 0034 lb/ton AP-42 Table 9 9 1-1 PM-2 5 0 0058 lb/ton AP-42 Table 9 9 1-1

EU-27 EP-16 NIA PM 0035 lbs/ton AP-42 Table 9 9 1-1 PM-10 0 0078 lb/ton AP-42 Table 9 91-1 PM-2 5 0 0013 lb/ton AP-42 Table 9 9.1-1

EU--28 EP-17 NIA PM 0.025 lbs/ton AP-42 Table 9 9 1-1 PM-10 0 0063 lb/ton AP-42 Table 9 91-1

PM-2 5 0 0011 lb/ton AP-42 Table 9 9 1-1

EU-29 EP-18 NJA PM 0086 lbs/ton AP-42 Table 9 91-1 PM-10 0029 lb/ton AP-42 Table 9 91-1 PM-2 5 0 0049 lb/too AP-42Table 9 91-1

EU-30 EP-19 NJA PM 0 035 lbs/ton AP-42 Table 9 91-1 PM-10 0 0078 lb/ton AP-42 Table 9 9 1-1

PM-2 5 00013 lb/ton AP-42 Table 9 91-1

EU-31 EP-20 NIA PM 0025 tbs/ton AP-42 Table 9 91-1

PM-10 0 0063 lb/ton AP-42 Table 9 9 1-1 PM-2 5 0 0011 lb/ton AP-42 Table 9 9 1-1

EU-32 EP-21 NIA PM 0086 lbs/ton AP-42 Table 9 91-1 PM-10 0029 lb/ton AP-42 Table 9 9 1-1 PM-2 5 0 0049 lb/ton AP-42 Table 9 91-1

EU-33 EP-22 NJA PM 0.086 lbs/ton AP-42 Table 9 91-1

PM-10 0029 lb/ton AP-42 Table 9 91-1 PM-2 5 0 0049 lb/ton AP-42 Table 9 91-1

EU-34 EP-23 NIA PM-10 24 830 lbs PM10/VMT Applicant Calcula1.1ons PM-10 34 741 lbs PM10/VMT Applicant Calculations

APPENDIX A Abbreviations and Acronyms

% .............. percent

~F .............. degrees Fahrenheit

acfm .. ........ actual cubic feet per minute

BACT ....... Best Available Control Technology

BMPs .... .... Best Management Practices

Btu ............ British thermal unit

CAM ........ Compliance Assurance Monitoring

CAS .......... Chemical Abstracts Service

CEMS ...... Continuous Emission Monitor System

CFR. ......... Code of Federal Regulations

CO ............ carbon monoxide

CO2 ........... carbon dioxide

CO2e ......... carbon dioxide equivalent

COMS ...... Continuous Opacity Monitoring System

CSR .......... Code of State Regulations

dscf ........... dry standard cubic feet

EIQ ........... Emission Inventory Questionnaire

EP ............. Emission Point

EPA .......... Environmental Protection Agency

EU ............ Emission Unit

fps ............. feet per second

ft ............... feet

GACT ...... Generally Available Control Technology

GHG ......... Greenhouse Gas

gpm .......... gallons per minute

gr .............. grains

GWP ........ Global Warming Potential

HAP .......... Hazardous Air Pollutant

hr .............. hour

hp ............. horsepower

lb ............... pound

lbs/hr ........ pounds per hour

MACT ...... Maximum Achievable Control Technology

µg/m3 ........ micrograms per cubic meter

mis ............ meters per second

- 13 -

Mgal ......... 1,000 gallons

MW .......... megawatt

MHDR. ..... maximum hourly design rate

MMBtu .... Million British thermal units

MMCF ..... million cubic feet

MSDS ....... Material Safety Data Sheet

NAAQS .... National Ambient Air Quality Standards

NESHAPs National Emissions Standards for Hazardous Air Pollutants

NOx ........... nitrogen oxides

NSPS ........ New Source Performance Standards

NSR .......... New Source Review

PM ............ particulate matter

PM2.s ......... particulate matter less than 2.5 microns in aerodynamic diameter

PM10 ......... particulate matter less than IO microns in aerodynamic diameter

ppm .......... parts per million

PSD ........... Prevention of Significant Deterioration

PTE .......... potential to emit

RACT ....... Reasonable Available Control Technology

RAL .......... Risk Assessment Level

SCC .......... Source Classification Code

scfm .......... standard cubic feet per minute

SDS ........... Safety Data Sheet

SIC. ........... Standard Industrial Classification

SIP ............ State Implementation Plan

SMAL ....... Screening Model Action Levels

SOx ............ sulfur oxides

S02 ............ sulfur dioxide

SSM .......... Startup, Shutdown & Malfunction

tph ............ tons per hour

tpy ............. tons per year

VMT ... ...... vehicle miles traveled

VOC ......... Volatile Organic Compound

f (o_jec:\- 11. \ 7 Maximum• Emission Emission Emission Control Capture Control PM-10 PM-2.5 voe HAP

Emission Unit Throuohout Unit No. Point No. Pollutant Factor Units Source of EF Eaot No. Eff. Eff. (TPY) PM (TPY) (TPY) (TPY) (TPY)

Mini Bulk Bagger Surg 223,380.0 EU-21 EP-11 PM 0.025 lbs/ton AP-42 Table 9.9.1-1 CE-7 100.00% 99.00% 0.0070 0.0279 0.0012 tons/yr PM-10 0.0063 lb/ton AP-42 Table 9.9.1-1 100.00% 99.00%

PM-2.5 0.0011 lb/ton AP-42 Table 9.9.1-1 100.00% 99.00% Storage Bin (vent)

sec 3-02-005-40 Mini Bulk Bagger 223,380.0 EU-21a EP-11 PM 0.025 lbs/ton AP-42 Table 9.9.1-1 CE-7 100.00% 99.00% 0.0070 0.0279 0.0012

tons/yr PM-10 0.0063 lb/ton AP-42 Table 9.9.1-1 100.00% 9900% PM-2.5 0.0011 lb/ton AP-42 Table 9.9.1-1 100.00% 99.00%

Grain Handling sec 3-02-005-3•

Mini Bulk Bagger 223,380.0 EU-22 EP-11 PM 0.061 lbs/ton AP-42 Table 9.9.1-1 CE-7 100.00% 99.00% 0.0380 0.0681 0.0065 tons/yr PM-10 0.034 lb/ton AP-42 Table 9.9.1-1 100.00% 99.00%

PM-2.5 0.0058 lb/ton AP-42 Table 9 9.1-1 100.00% 99.00% Grain Handling sec 3-02-005-30

Mini Bulk Bagger 223,380.0 EU-22a EP-11 PM 0.061 lbs/ton AP-42 Table 9.9.1-1 CE-7 100.00% 99.00% 0.0380 0.0681 0.0065 tons/yr PM-10 0.034 lb/ton AP-42 Table 9.9.1-1 100.00% 99.00%

PM-2.5 0.0058 lb/ton AP-42 Table 9.9.1-1 100.00% 99.00% Grain Handling sec 3-02-005-30

Total Emissions 0.09 0.19 0.02

MaXJmum* Emission Emission Em1ss1on Emission Unit Thro1JCJhout Unit No Point No Pollutant Factor Inside Recelvfng (fUgltlve] 525,600.0 EU-1 EP-1 PM 0.035

tons/yr PM-10 00078 PM-25 00013

Hopper Truck sec 3---02-0Q5...52

Scalp (LMC screen/conveyor) 525,600 0 EU-2 EP-2 PM 0375 tons/yr PM-10 022875

PM-25 008625 Gram Cleaning sec 3-02--005-37

Pod Bln {fugitive) 105,1200 EU-3 EP-3 PM 0025 Ions/yr PM-10 00093

PM-25 00011 Storage B1n{vent) sec 3-02-005-40

Pod Bin Loadout [fugitive) 105,1200 EU-4 EP-4 PM 0.086 tons/yr PM-10 0029

PM-25 0.0049 Grain Shipping {truck) sec 3-02-005-06

Aspirator 525,600 0 EU-5 EP-5 PM 0375 tons/yr PM-10 022675

PM-25 006625 Gram Cleaning sec 3--02-005-37

17 Bulk Storage Bins (12 x 3,000 bu; 5 x1,000 bu) 525,6000 EU-6 EP-5 PM 0025

tons/yr PM-10 00093 PM-25 00011

Storage Bin (vent) sec 3--02-005-40

Cleaner Surge Bin 525,6000 EU-7 EP-6 PM 0025 tons/yr PM-10 00093

PM-25 00011 Storage Bin (vent) sec 3--02-005-40

Cleaner (Crippen 588) 144,5400 EU-8 EP-8 PM 0375 tons/yr PM-10 022875

PM-25 006625 Gram Cleaning sec 3-02-005-37

Color Sorter Surge Bin 525,600 0 EU-9 EP-7 PM 0025 tons/yr PM-10 00093

PM-25 00011 Storage Bin {vent) sec 3-02-005--40

Color Sorter Primary 144,5400 EU-10 EP-7 PM 0061 tons/yr PM-10 0 034

PM-25 00056 Gram Handling sec 3-02-005-30

Color Sorter Secondary 26,0060 EU-11 EP-7 PM 0061 tons/yr PM-10 0034

PM-25 00058 Grain Handling sec 3-02--005-30

Gravity Surge Bin #1 (3600) 131,4000 EU-12 EP-8 PM 0025 tons/yr PM-10 00093


Gravity Table #1 (Oliver 3600) 131,4000 EU-13 EP-8 PM 0122 tons/yr PM-10 0068

PM-25 00116 Grain Handling _. sec 3-02-005-30

Gravity Surge Bin #2 (160) 43,3620 EU-14 EP-9 PM 0025 Ions/yr PM-10 00093

PM-25 00011 Storage Bin (vent) sec 3--02--005-40

Umts lbs/ton lb/ton lb/ton

lbs/ton ....

lb/ton

lb/Ion

lbs/ton lb/ton lbfton

lbs/ton !bfton lb/too

lbsfton-lb/to, lb/to,

!bslton lb/ton lb/to,

lbslton lb/lo, lb/to,

lbsJton-lb/ton lb/to,

!bslton lb/ton lb/ton

lbsfton lb/to, lb/loo

lbs/ton lbl'ton lb/ton

lbs/ton lb/ton lb/ton


lbs/ton lb/too lb/t.on

Table 1 Potential to Emit

Monsanto Company Marshall, Missouri

Control Capture Control Source of EF E~...+ No Eff. Eff

AP-42Table991-1 "'' 000% 000% AP-42Table991-1 000% 000% AP-42 Table 9 9 1-1 000% 000%

AP-42Table991-1 CE-1 0000% 9900% AP-42 Table 9.91-1 0000% 9900% AP-42 Table 9 91-1 80.00% 9900%

AP-42 Table 9 9 H "'' 0.00% 000% AP-42 Table 9 9 q 000% 0.00% AP-42Table991-1 000% 000%

AP-42Table 991-1 "'' 000% 0.00% AP-42Tab!e991-1 000% 000% AP-42 Table 9 91-1 000% 000%

AP-42 Table 9 91-1 CE-2 10000% 9900% AP-42 Table 9.91-1 100.00% 9900% AP-42 Table 9 91-1 100.00% 9900%

AP-42Table991-1 CE-2 100 00% 9900% AP-42Table991-1 10000% 9900% AP-42 Table 9 91-1 10000% 9900%

AP-42 Table 9 91-1 CE-3 10000% 9900% AP-42 Table 9 91-1 10000% 9900% AP-42 Table 9 91-1 10000% 9900%

AP-42Table991-1 CE-3 100 00% 9900% AP-42 Table 9 9 1-1 100 00% 9900% AP-42 Table 9 9 1-1 100 00% 9900%

AP-42 Table 9 91-1 CE-4 10000% 9900% AP-42Tabte991-1 100 00% 9900% AP-42 Table 9 91-1 100 00% 9900%

AP-42 Table 9 91-1 CE-4 10000% 9900% AP-42 Table 9 91-1 10000% 9900% AP-42 Table 9 91-1 10000% 9900%

AP-42Table991-1 CE-4 100 00% 9900% AP-42 Table 9 9 1-1 100 00% 9900% AP-42 Table 991-1 100 00% 9900%

AP-42 Tab!e 9 91-1 CE-5 10000% 0000% AP-42 Table 9 91-1 10000% 0000% AP-42 Tab!e 9 91-1 10000% 0000%

AP-42Tab!e991·1 CE-5 100 00% 0000% AP·42 Table 991-1 100 00% 0000% AP-42 Table 9 91-1 100 00% 0000%

AP-42Table991-1 CE-6 10000% 9000% AP-42 Table 9 91-1 10000% 9000% AP-42 Table 9 91-1 10000% 9000%

Page 1 ot4

Potential to Emit with Controls

PM 10 'TPYI I PM TPY' I PM-25 voe HAP fTPYl ITPYl ITPY\

20498 I 91BBO 03416

I 12~40 I 20 4994 4 7148

I 0.~11 I 13140 I 00578

1 5242 I 45202 02575

I 0.0012 I

0~ I 02267

00166 I 00657 00029

I 00100 I 00ffi7 I 0.0029

01ffi3 I 02710 00823

I 00100 I 00657 00029

I 00246 I 00441 00042

I O 0049 I O 00BB I O 0008

00~8 I 0 3265 00145

I 089~ I 1 6031 01524

I 00137 I 00542 I 0.0024

Maximum• Em1ss1on Em1ssmn Emission

Em1ss1onUmt Throuohout Unrt No Point No Pollutant Factor Umts Gravity Table #2 (Oliver 160) 43,362 0 EU-15 EP-9 PM 0122 lbs/ton-•

tons/yr PM-10 0068 lb/ton PM-25 00116 lb/ton

Grain Handling .... sec 3-02-005-30

Treater Drum [fugitive] 78,8400 EU-16 EP-10 PM 0061 lbs/ton tons/yr PM-10 0034 lb/ton

PM-25 00058 lb/loo Gram Handling voe NIA NIA sec 3-02-005-30 HAP

4 True Bulk/ Bagging Bin, (1,000 bu

each) 131,4000 EU-17 EP-9 PM 0025 lbs/ton tons/yr PM-10 00063 lb/ton

PM-25 00011 lb/ton Storage 81n (vent) sec 3-02-005-40

6 Bagging B1ns (2 x 450 bu; 2 x 270 bu; 2 x250 bu} 131,4000 EU-18 EP-11 PM 0025 lbs/Ion

tons/yr PM-10 00063 lb/Ion PM-25 00011 lbflon

Stocage 81n (vent) sec 3--02-005-40



Control Capture Control SourceotEF Eao1 No Eff Eff

AP-42Table991-1 CE-6 100 00% 0000% AP-42Tabie991-1 100 00% 0000% AP-42 Table 9 9 H 100 00% 9000%

AP-42Table991-1 "'' 000% 000% AP-42 Table 9 91-1 000% 000% AP-42 Table 9 91-1 000% 000% SeeTreatng Sheets 000% 000%

AP-42 Table 9 9 H CE-6 10000% 0000% AP-42Table991-1 100 00% 0000% AP-42 Table 9 91-1 100 00% 9000%

AP-42Table991-1 CE-7 100 00% 0000% AP-42 Table 9 91-1 100 00% 0000% AP-42Table991-1 100 00% 9000%

Page2af4


PM-10(TPY)I PM/TPY) I ~~;~~ voe HAP /TPYl (TPY)

0147• I 026~ I 00251

1 3403 2 4046 02286 1209 '9

I I 0 0414 I 01643 I 00072

00414 I 01643 I 00072

Maximum• Emission Em1ss1on Emission Emission Umt Throughput UnH:No Point No Pollutant Factor Bemis Bagger surge Bin 131,4000 EU-19 EP-11 PM 0025

tons/yr PM-10 000B3 PM-25 00011

Storage Bm (vent) sec 3-02-005-40

Bemis Bagger 131.4000 EU-20 EP-11 PM 0061 tons/yr PM-10 00~

PM-25 00058 Gram Handling sec 3--02---0Q5...30

Mini Bulk Bagger Surge Bin 223,380 0 EU-21 EP-11 PM 0025 tons/yr PM-10 00063

PM-25 00011

Storage Bin (vent)

sec 3-02-005-40

Mini Bulk Bagger 223,3800 EU-21a EP-11 PM 0025 tons/yr PM-10 000B3

PM-25 00011


Mini Bulk Bagger 223,3800 EU-22 EP-11 PM 0061 tons/yr PM-10 0.034

PM-25 00056 Gram Handling sec 3-02-005--30

Mini Bulk Bagger 223,3800 EU-22a EP-11 PM 0061 tons/yr PM-10 0034

PM-25 00058 Gram Handling sec 3-02-005-30

Tower True Bulk Loadout (fugitive] 547,4124 EU-23 EP-12 PM 0.086 tons/yr PM-10 0029

PM-25 00049 GrainShipp1ng(truck) sec 3-02-oos-00

Cull Bin (3,000 bu} (fugitive] 52,5600 EU-24 EP-13 PM 0025 tons/yr PM-10 000B3


Cull Lcadout [fugitive] 174,236 4 EU-25 EP-14 PM 0086 tons/yr PM-10 0029

PM-25 00049 Grain Shippmg (truck) sec 3-02-005-08

Internal Handllng [fugitive] 144,5400 EU-26 EP-15 PM 0061

tons/yr PM-10 00~ PM-25 00058


Outside Receiving [fugitive] 354,7800 EU-27 EP-16 PM 0035 tons/yr PM-10 00078

PM-25 00013 Hopper Truck sec 3-02-005-52

30 Outside Storage Bins (24 x 3000 bu;

2 x2,000 bu; 4x 1500 bu} 354,7800 EU-28 EP-17 PM 0025 tonsfyr PM-10 00063

PM-?5 00011 Storage Bin (vent) sec 3-02-005-40

Outside Storage Loadout - x-fer to Inside Receiving {fuglttve] 354,780 0 EU-29 EP-18 PM 0086

tons/yr PM-10 0029 PM-25 00049

Grain Shipping (truck) sec 3-02-005-08

Transfer to Outside True Bulk Bins [fugitive] 354,780 0 EU-30 EP-19 PM 0035

Ions/yr PM-10 00078 PM-25 00013

Hopper Truck

Unrts lbs/I.on lb/ton lb/I.on

lbs/ton IMon lbfton

lbs/I.on lb/ton lb/too


lbs/ton lb/ton lb/too

lbs/ton lb/too lb/ton

lbs/ton lb/too lb/Ion

lbsflon lb/Ion lb/loo

lbs/ton lb/loo !Moo

lbs/ton lb/ton

lb/Ion

lbs/ton lb/Ion lb/ton

lbs/ton lbfton lb/ton

lbs/ton lb/ton lb/too

lbs/ton lb/Ion lb/ton



Control Capture Control SourceofEF Eqpt No Eff Eff

AP-42 Tab!e 9.91-1 CE-7 100 00% 9000% AP-42 Tab!e 9 91-1 100 00% 9000% AP-42 Table 9 91-1 100 00% 9000%

AP-42 Table 9 91-1 CE-7 100 00% 9000% AP-42 Table 9 91-1 10000% 9000% AP-42 Table 9 91-1 100 00% 9000%

AP-42 Table 9 91-1 CE-7 10000% 99.00% AP-42 Table 9 91-1 10000% 9900% AP-42 Table 9 91-1 10000% 9900%

AP-42Tabie991-1 CE-7 10000% 9900% AP-42 Table 9 91-1 10000% 9900% AP-42 Table 9 91-1 10000% 9900%

AP-42 Table 9 91-1 CE-7 10000% 9900% AP-42 Table 9 9 1-1 100.00% 9900% AP-42 Table 9 9 1-1 10000% 9900%

AP-42Table991-1 CE-7 100 00% 9900% AP-42 Table 9 9 1-1 10000% 9900% AP-42 Table 9.9 1-1 100 00% 9900%

AP-42 Table 9.9 1-1 ola 000% 000% AP-42 Table 9 9 1-1 000% 000% AP-42 Table 9 9 1-1 000% 000%

AP-42 Table 9 9 1-1 o/a 000% 000% AP-42Table991-1 000% 000% AP-42Table991-1 0.00% 000%

AP-42Table991-1 ola 000% 000% AP-42 Table 9 9.1-1 000% 000% AP-42 Table 99.1-1 000% 000%

AP-42Table991-1 o/a 000% 000% AP-42 Table 9 91-1 0.00% 000% AP-42 Table 9 91-1 000% 000%

AP-42Table 991-1 ola 000% 000% AP-42 Table 9 91-1 000% 000% AP-42 Table 9 91-1 000% 000%

AP-42 Table 9 91-1 of, 000% 000% AP-42Table991-1 000% 000% AP-4? Te:h!A 9 91-1 000% 000%

AP-42 Table 9 91-1 o/a 000% 000% AP-42 Table 9 91-1 000% 000% AP-42 Table 9 91-1 000% 000%

AP-42 Table 9 9 1-1 o/a 000% 000% AP-42 Table 9 9 1-1 000% 000% AP-42Table991-1 000% 000%

Page 3of4


PM-10 TPYll PM TPY I p~~~5 voe HAP TPY TPY

00414 I 01~3 I 00072

022~ I 0 4008 I 00381

00070 00279 00012

I I 00070 00279 00012

I I 0 0380 I 00881 I 00085

0 0380 I 00881 I 00085

79~5 12353871 1 3412

01856 I 0 8570 I 00289

252~ I 74~2 I 04269

2 45n I 44085 I 04192

1 3838 I 8W87 I 02306

11176 44348 01951

I I 51443 I 152555 08692

I 1 3836 62087 02306

I I

Maximum~ Emission Em1ss1on E~=~n I Units Em+ssion Unit ThrouQhput Unrt No Pein! No Pollutant

sec 3-02-oos-s2 I · uutstce rue l:juui 1:uns '"" DU

O 025llbslton each) 354,7800 EU-31 EP-20 PM tons/yr PM-10 00063 lblton

PM-25 0001rlto, Storage 81n (van!)

sec 3---02-005-40

Outside True Bulk Bins Loadout 0 086jlbsfton [fugitive] 473,0400 EU-32 EP-21 PM

tons/yr PM-10 0029 lb/ton PM<J5 ooo,T""' Grain Shipping {truck)

sec 3-02-005-•6

Transfer Mini Bulk to True Bulk 00B6!1bsfton {controlled) 473,040 0 EU-33-a EP-22 PM

tons/yr PM-10 0029 lb/ton PM-25

0 00491''""" Gram Shipping (truck) sec 3-02--005--0a

Haul Roads (fugitive] 8,999,062 4 EU-34 EP-23 PM-10 00048 lb/ton See Tables 2 and 3 for calculatioruJ 5,619,452 PM-10 00072 lb/ton

tons/yr 1 Production Emissions 0.1111!I:b/ton 1 Haul Road Emissions 0.0106 lb/ton

Total Emissions O.li216 lb/ton

Notes: _,.,,.. All Point emIssIons vent indoors {wrth the exception of outside bins and the Oliver 3600 gravity table/ cyclone) 1

Annual PM10 EmIssIons (lpy) - 2000 lb/ton - Sum of Soybean Hauled Over each Road {yr/ton soybean)



Control Capture Control

SoorceofEF Eqpt No Eff Ett

AP-42 Table 9 9 H ,,. 000% 000% AP-42 Table 9 9 1-1 000% 000% AP-42 Table 9 91-1 000% 000%

AP-42Table991-1 '" 000% 000% AP-42 Table 9 91-1 000% 000% AP-4?T2bls991-1 000% 000%

AP-42Table991-1 CE-8 100 00% 9900% AP-42 Table 9 91-1 100 00% 9900% AP-42 Table 9 91-1 100 00% 9900%

Paved HR's (Table 2) n/a 000% 000% Unpaved HR's (Table 3) 000% 000%

Page4of4

Potential to Emil with Controls

PM- 10 TPY) I PM {TPY) I ~~~~~ voe HAP

{TPYJ (TPYl

I I 11176 4 4348 01951

I I 6~91 1203~7 I 11589

00686 02034 00116

I I ,~,

1~1,';, 1 =,';".~ I

38.9 154.9 36.9 I !10.3311 135.9604 11.2799

pm2,5 haul road conservatively assumed equal to pm10

87.26 290,88 48.21 12.09 1.97 <15 50 00017134 8 287354204

r

;;1 !:'. ~ • 'J •

' i )

~!:'.K

l • • j

[fdJ • ,s •

F n

~n -1; ~H

~>~~J~~§!\

i< '

f'.: ;!:'

t; €

~ ~

"').';

HanlRnad tl1

Inside Grain Hau! Road JD No.:) RPCT>iving- Fnter

Plant

length of Haul Road (Feetj:I 490 Trude Wf>ight on ~rtmn of Haul Road

(TonR)· 40

lnsideGrain Rece,vmg Fxit

Plant

720

13

Haul Rrrad f2

OutindP SloragP Bin Grain

RPceiving - Fnter Plant

535

40

Out.Rid I" Storage Bin Grain

Receiving- Fxit Plant

215

13

Soyb .. am; Hauled per Round Trip (TonR):I 27 27 27 Maximum Hourly Amount Hauled

"Haut

Maximum Hourly Vehirlp Miles Trawled

PM Daily Fmisston F,Klor (lhf. PM/VMl)·

PM10 Annual Fmlsrnmn Fartor (lbi, PM10/VM1)·

PM Annual Fmission Factor (lbs PM/VM1)

Maximum Hourly Vehicle Miles TrawlPd (VMT/Hr)

Maximum Annual VPh1rlp MilPl'1 Travele-d (VMl")

Haul Road PM2.5/l0 Emission Factor (\hf. of PM2.5/10/YM.Jl:

Daily M_ax1mum PMlO Fmitmioni,; (lbs/ day)\

Dm]yl.faximum J:'M Fm1-q,;ions (lbs/davl~ Annual Maximum PM10 Fm1ss10ns

(lons/y,,ar)4

Annu.il Maximum PM Fmw,10ns

(tomi/y,,ar)4

Total PM10 PTE ham Unp•nd H•ul Ro.1ds (TPY),

Total PM PTE from Unpaved Haul R~ (TPY):

Not.-s

PM P.mil'lsion Factm

ll~~ so_rbean}"'·:

PM10 Emission Factor

(!b~_"?l'.be•nl'':

13.4456

2.8040

9.5777

19.48

66.55

2.53

8.65

40.50

l'<~.?AA 96

105

0.1013

81083 13.4456 8.1083

1.6909 2.8040 1.6909

5.7758 9.5777 5.7758

1726 14.36 348

5897 4905 11.89

2.24 1.87 0.45

767 6.38 1.55

Table 3 Unpaved Haul Road Emission Factor Calculations


ll~~,~~.a:~~~M~ Haa1Rn.adft3 HaalRoad i4 Hanl Road#S

Tower True Bulk I Tower Trur Bulk I Town True Bulk ()ut<;ideStorage I Outs1deS_torage I Ou~;~~;~;agP ~o_Jm,ide to_lns1de Rect>ivin - Travel

Rere1vmg-Travel Rffe1vmg-Travel f f "d

from Park_mg (mm RinR_ l~ ;;c:,vin;:' t: ArPa l.l1 Rmt1 Jm,idE' Rece1vmg Parking !rea

TowPr True Bulk J.oadout- Fxit

Plant

to Storage Bins Traw•! from Troe

Parking Arpa to I Bulk Area to Tn,e Bulk Area Slorage Rim;

to Storage.Bins -1Tn>P Bulk Storage!Tme BulkStmagP Travel from J.oadout- Fnter l oadoul Fxtl

Storage Rms to Plant Plant Parking Area

4-BO I 2 ---" 100 540 270

13

27

40.50

96

105

8.108.1

16909

57758

40

.2Z... 40.50

105

13.4456

2.8CJ.t0

9.5777 ,--;..

13

40.50

9.6

105

" 62 50

l '"'rl'!,,'!l .

13

25

40.50

:jii):,ij;j·;,,;.::;k

38

40.50

-,~-~",;·,··,(/

;.:~~A~!!&~~':,'"''"''. 105 105 105

n 25

40.50

9.6

105

,:u,:l:filo/·M> .. ,, . ..W:1t-\/Mr;tt.~!!l!<IJ'M!J>·~~c,a_,.,.; .. • 0.0559

8.1083

1.6909

5.7758

0.0928

0.2120

3.8465

13.1388

27400

9.3592

0.0189

0.0,107

2.3738

8.1083

1.6909

5.7758

0.1023

0.1657

3.8465

13.l'IBR

2 7400

9.3592

,cioi:Ro•HO!ii .. ,.; . .; ,. ·

0.0511

00828

2.3738

8.1083

1.6909

57758

- I .ength of Haul Road x jMaximum Hnurly Amount Hauled/ Soybeans H,mlf'd pn Round Trip)

= I f'ngth of H,rnl Road x {Maximum Annual Amount HaulE"d / SoybE"ans Hauled per Round Trip]

540

13

40 50

9.6

105

0.1023

0.1657 -

23738

8.1083

1.6909

5.7758

i'.......<

~ fkj x {SiltC:ontent%/12]"faj x {Truck.We1ghtonSPctiono(Hau!Road / 3]"[b]x ((365-DaysofRam}/365]

<t:S)?~~~~~-~-~,,:~,,~

777 5.77 4 77 21 42 1.75 15.30 472 9.44

26.54 1971 16.711 73.16 597 52.24 16.12 12.24

1.01 0.75 0.62 278 0 23 1 99 0.61 1 23

345 2.56 212 9.51 07ll 679 2.10 419

20.12

68.71

0.02

0.007

170

"' 40.50

105

0.0322

0.0522

38465

13.1388

2.7400

93592

-1.82

16.45

0.63

2.14

1ThP fanltty ulih7PS a ont>-way tr.iffu pattPm for all haul mads. The Maximum Hour VPhlclP M,!..,; TravPlPd pqu.~hon has lwPn upda\Pd to TP!led this pattPrn

~Th,, Maximum Annual VE"h1dP Miles TravPled is <·akulalt>d b.ised on th" fanlity's proposed throughput hm1ts 1Da1ly Maximum PMl0 Fmissions rnku!atE"d a.~ fnllows

Maximum Hourly Vph1de M1lPSTravt'led X PM10 Daily Fm,ssion Fartor X 2~ Hours/Day

'Annual Maximum PMl0 Fm1ssmns <11"(' cah-ulatPd as follows Maximum Annual Vt'h1d,:, Mtles Traveled X PM10 Annual Fm,ssion Fartor / 2000 Pounds/Ton

H~IRn2dMQ

Cu!! Bin l.oadoul-

Plant

i2Q

17

--'"--29.00

:......i..i.:..

0.1170

~<~> 2.6784

91486

19079

6.5168

,LJ ,,,

752

25.69

0.51

1.73

Travel from I Pod Bin Loadout -1Pod Bi~ I oadout Parking Arp,a to F11ter Plant Fxit Plant

Cull Bins

23(]

11.3

19.90

.,/~i.'.':;~~

9.6

105

0.0436

0.0532

·=.1-

2.2287

7.6127

15876

:i.4228

270

6.7

670

9.6

105

0.0952

l 7616

,m,, 1.2548

4.2862

2.84_

9 72

0.28

095

10.3

6.70

9.6

105

00653

0.1216

21377

7.3018

1.5227

s.20n

4.02 6.24

1374 21.11

094 1.45i

3 20 4 96

monsanto co - marshall€¦ · f. monsanto company-marshall shall maintain a copy of the dust...

Documents