lime use for soil & base...
TRANSCRIPT
![Page 1: Lime Use For Soil & Base Improvementpetersenasphaltconference.org/download/2007/3-3EricBerger.pdfCBR, LTS (%) Ratio LTS: Subgrade 61N 15 200 33.3 82E 12 150 12.5 82W 4 47 11.8 45N](https://reader033.vdocuments.mx/reader033/viewer/2022060817/6096c81d5f33b658b82d4bc7/html5/thumbnails/1.jpg)
Lime Use For Soil & Base Improvement
ApplicationDesignTesting
P3 SymposiumJuly 19, 2007
Eric BergerAppian Way
![Page 2: Lime Use For Soil & Base Improvementpetersenasphaltconference.org/download/2007/3-3EricBerger.pdfCBR, LTS (%) Ratio LTS: Subgrade 61N 15 200 33.3 82E 12 150 12.5 82W 4 47 11.8 45N](https://reader033.vdocuments.mx/reader033/viewer/2022060817/6096c81d5f33b658b82d4bc7/html5/thumbnails/2.jpg)
2
Common Additives for Soil Treatment
Clay Silt/ Sand Gravel
Lime
Asphalt
Portland Cement
Lime/ Fly Ash
Lime
![Page 3: Lime Use For Soil & Base Improvementpetersenasphaltconference.org/download/2007/3-3EricBerger.pdfCBR, LTS (%) Ratio LTS: Subgrade 61N 15 200 33.3 82E 12 150 12.5 82W 4 47 11.8 45N](https://reader033.vdocuments.mx/reader033/viewer/2022060817/6096c81d5f33b658b82d4bc7/html5/thumbnails/3.jpg)
3
Many Uses of Lime
7 10 10.5 12.4
pH
Dry
Modify
Stabilize
![Page 4: Lime Use For Soil & Base Improvementpetersenasphaltconference.org/download/2007/3-3EricBerger.pdfCBR, LTS (%) Ratio LTS: Subgrade 61N 15 200 33.3 82E 12 150 12.5 82W 4 47 11.8 45N](https://reader033.vdocuments.mx/reader033/viewer/2022060817/6096c81d5f33b658b82d4bc7/html5/thumbnails/4.jpg)
4
• Typically moisture sensitive– Expansion potential & swell pressure
• Exhibit poor pavement support– Low R-values, CBRs, & unconfined compressive
strengths• Constructibility problems
– Highly plastic - poor workability– Hard to compact– Yield or pump when wet
Clay Soils
![Page 5: Lime Use For Soil & Base Improvementpetersenasphaltconference.org/download/2007/3-3EricBerger.pdfCBR, LTS (%) Ratio LTS: Subgrade 61N 15 200 33.3 82E 12 150 12.5 82W 4 47 11.8 45N](https://reader033.vdocuments.mx/reader033/viewer/2022060817/6096c81d5f33b658b82d4bc7/html5/thumbnails/5.jpg)
5
Structure of Clay Minerals (1)
>Basic units of silicate clay minerals are Silicon tetrahedrons and Aluminum (or Magnesium) octahedrons. Thousands of these basic units are connected to make up tetrahedral sheets (1) and octahedral sheets (2).
>Different combinations of tetrahedral and octahedral sheets are called layers (i.e. Kaolinite: 1:1; Smectite: 2:1).
>In some clays, these layers are separated by interlayers in which water and different adsorbed cations are found
(2)
(1)
![Page 6: Lime Use For Soil & Base Improvementpetersenasphaltconference.org/download/2007/3-3EricBerger.pdfCBR, LTS (%) Ratio LTS: Subgrade 61N 15 200 33.3 82E 12 150 12.5 82W 4 47 11.8 45N](https://reader033.vdocuments.mx/reader033/viewer/2022060817/6096c81d5f33b658b82d4bc7/html5/thumbnails/6.jpg)
6
Structure of Clay Minerals (2)
Kaolinite:Hexagonal crystals
Size: 0.2 - 2 μm
Surface Area: 10 - 30 m2/g[Magn: 2000 x]
Montmorillonite:Flakes
Size: 0.01 - 1 μm
Surface Area: 650 - 800 m2/g[Magn: 20000 x]
![Page 7: Lime Use For Soil & Base Improvementpetersenasphaltconference.org/download/2007/3-3EricBerger.pdfCBR, LTS (%) Ratio LTS: Subgrade 61N 15 200 33.3 82E 12 150 12.5 82W 4 47 11.8 45N](https://reader033.vdocuments.mx/reader033/viewer/2022060817/6096c81d5f33b658b82d4bc7/html5/thumbnails/7.jpg)
7
The System: Clay – Water - Calcium
Clay
Sur
face
Clay
Sur
face
Negatively charged clay surface attracts cations (+) & water molecules (dipole), causing formation of a ‘double diffused water layer’
Calcium cations (++) replace weaker bonds reducing clay affinity for water
![Page 8: Lime Use For Soil & Base Improvementpetersenasphaltconference.org/download/2007/3-3EricBerger.pdfCBR, LTS (%) Ratio LTS: Subgrade 61N 15 200 33.3 82E 12 150 12.5 82W 4 47 11.8 45N](https://reader033.vdocuments.mx/reader033/viewer/2022060817/6096c81d5f33b658b82d4bc7/html5/thumbnails/8.jpg)
8
Effect of Cation Adsorption on Attracted Water Layer
Ca++ SaturationNa+ Saturation
![Page 9: Lime Use For Soil & Base Improvementpetersenasphaltconference.org/download/2007/3-3EricBerger.pdfCBR, LTS (%) Ratio LTS: Subgrade 61N 15 200 33.3 82E 12 150 12.5 82W 4 47 11.8 45N](https://reader033.vdocuments.mx/reader033/viewer/2022060817/6096c81d5f33b658b82d4bc7/html5/thumbnails/9.jpg)
9
Lime - Soil Reactions:
Immediate Reactions (within hours)• Reduction in Water Content
chemical reaction (CaO + H2O → Ca(OH)2 + heat)* andmixing effect *: not for Hydrated Lime
• Flocculation / Agglomeration of Clay particlestextural change leads to decrease in PI & increase in workability
Medium & Long Term Reaction (days, weeks, months, years)• Pozzolanic reaction between lime and clay particlesRate of pozzolanic reaction depends on- amount and type (‘stability’) of clay minerals- temperature (increase by 100C/500F doubles speed of reaction)- high pH (> 12, “OH-”) and availability of Ca2+ and water
• Recarbonation of Limedecreases amount of Lime available for pozzolanic reaction
![Page 10: Lime Use For Soil & Base Improvementpetersenasphaltconference.org/download/2007/3-3EricBerger.pdfCBR, LTS (%) Ratio LTS: Subgrade 61N 15 200 33.3 82E 12 150 12.5 82W 4 47 11.8 45N](https://reader033.vdocuments.mx/reader033/viewer/2022060817/6096c81d5f33b658b82d4bc7/html5/thumbnails/10.jpg)
10
Pozzolanic Reaction (1)
Hydrated lime (Ca(OH)2 pH > 12)+ water (H2O)
+ Clay (SiO2 & Al2O3 become soluble)= Cementicious material (CSH & CAH)
Natural Clay: 1500X With Ca(OH)2 & 28 day cure
![Page 11: Lime Use For Soil & Base Improvementpetersenasphaltconference.org/download/2007/3-3EricBerger.pdfCBR, LTS (%) Ratio LTS: Subgrade 61N 15 200 33.3 82E 12 150 12.5 82W 4 47 11.8 45N](https://reader033.vdocuments.mx/reader033/viewer/2022060817/6096c81d5f33b658b82d4bc7/html5/thumbnails/11.jpg)
11
Influence of pH on solubility of Silica and Alumina
Pozzolanic Reaction (2)
![Page 12: Lime Use For Soil & Base Improvementpetersenasphaltconference.org/download/2007/3-3EricBerger.pdfCBR, LTS (%) Ratio LTS: Subgrade 61N 15 200 33.3 82E 12 150 12.5 82W 4 47 11.8 45N](https://reader033.vdocuments.mx/reader033/viewer/2022060817/6096c81d5f33b658b82d4bc7/html5/thumbnails/12.jpg)
12
050
100150200250300350
0 2 4 6 8 10 12
% Hydrated Lime
UC
CS
[psi
] Georgia KaolinteVictoria ClayBeaumont ClayWyoming Smectite
Influence of clay-mineralogy on amount of Lime required to produce the pozzolanic reaction:
Ref: Thompson
Pozzolanic Reaction (3)
![Page 13: Lime Use For Soil & Base Improvementpetersenasphaltconference.org/download/2007/3-3EricBerger.pdfCBR, LTS (%) Ratio LTS: Subgrade 61N 15 200 33.3 82E 12 150 12.5 82W 4 47 11.8 45N](https://reader033.vdocuments.mx/reader033/viewer/2022060817/6096c81d5f33b658b82d4bc7/html5/thumbnails/13.jpg)
13
01000200030004000500060007000
UCC
S [kP
a]
A-6(20) A-7-6(20) A-4(2)
Soil Classification
28-d180-d360-d
Effect of Curing Time on Strength Development:(unconfined compressive strength (UCCS) for different California soils)
1 PSI = 6.89 kPaRef: Doty
Strength Increase with Lime Stabilization
![Page 14: Lime Use For Soil & Base Improvementpetersenasphaltconference.org/download/2007/3-3EricBerger.pdfCBR, LTS (%) Ratio LTS: Subgrade 61N 15 200 33.3 82E 12 150 12.5 82W 4 47 11.8 45N](https://reader033.vdocuments.mx/reader033/viewer/2022060817/6096c81d5f33b658b82d4bc7/html5/thumbnails/14.jpg)
14
Case Studies
![Page 15: Lime Use For Soil & Base Improvementpetersenasphaltconference.org/download/2007/3-3EricBerger.pdfCBR, LTS (%) Ratio LTS: Subgrade 61N 15 200 33.3 82E 12 150 12.5 82W 4 47 11.8 45N](https://reader033.vdocuments.mx/reader033/viewer/2022060817/6096c81d5f33b658b82d4bc7/html5/thumbnails/15.jpg)
15
Mississippi Pavements Study
Highway HMA (in.) Yrs of Service
US 45 N 10 17
US 61 N 12 15
US 82W 13 20
US 82E 10 20
![Page 16: Lime Use For Soil & Base Improvementpetersenasphaltconference.org/download/2007/3-3EricBerger.pdfCBR, LTS (%) Ratio LTS: Subgrade 61N 15 200 33.3 82E 12 150 12.5 82W 4 47 11.8 45N](https://reader033.vdocuments.mx/reader033/viewer/2022060817/6096c81d5f33b658b82d4bc7/html5/thumbnails/16.jpg)
16
Comparative Swell
After 12 hrs. of Capillary Rise
Ref: Little
![Page 17: Lime Use For Soil & Base Improvementpetersenasphaltconference.org/download/2007/3-3EricBerger.pdfCBR, LTS (%) Ratio LTS: Subgrade 61N 15 200 33.3 82E 12 150 12.5 82W 4 47 11.8 45N](https://reader033.vdocuments.mx/reader033/viewer/2022060817/6096c81d5f33b658b82d4bc7/html5/thumbnails/17.jpg)
17
Unconfined Compressive Strength (psi)Lime Stabilized Soil
0
100
200
300
400
500
600
61N 82E 82W 45N
Dry
Soak
M.R. Thompsoncriteria, 1970
Ref: Little
![Page 18: Lime Use For Soil & Base Improvementpetersenasphaltconference.org/download/2007/3-3EricBerger.pdfCBR, LTS (%) Ratio LTS: Subgrade 61N 15 200 33.3 82E 12 150 12.5 82W 4 47 11.8 45N](https://reader033.vdocuments.mx/reader033/viewer/2022060817/6096c81d5f33b658b82d4bc7/html5/thumbnails/18.jpg)
18
Pavement
CBR, Subgrade (%)
CBR, LTS (%)
Ratio LTS: Subgrade
61N 15 200 33.3
82E 12 150 12.5
82W 4 47 11.8
45N 10 133 13.3
Field Data with DCP
Ref: Little
![Page 19: Lime Use For Soil & Base Improvementpetersenasphaltconference.org/download/2007/3-3EricBerger.pdfCBR, LTS (%) Ratio LTS: Subgrade 61N 15 200 33.3 82E 12 150 12.5 82W 4 47 11.8 45N](https://reader033.vdocuments.mx/reader033/viewer/2022060817/6096c81d5f33b658b82d4bc7/html5/thumbnails/19.jpg)
19
Pavement Modulus, Subgrade (psi)
Modulus, LTS (psi)
Ratio LTS: Subgrade
61N 13,000 61,000 4.38
82E 17,000 352,000 20.72
82W 17,600 193,000 10.98
45N 17,900 211,000 11.86
Field Data with FWD
Ref: Little
![Page 20: Lime Use For Soil & Base Improvementpetersenasphaltconference.org/download/2007/3-3EricBerger.pdfCBR, LTS (%) Ratio LTS: Subgrade 61N 15 200 33.3 82E 12 150 12.5 82W 4 47 11.8 45N](https://reader033.vdocuments.mx/reader033/viewer/2022060817/6096c81d5f33b658b82d4bc7/html5/thumbnails/20.jpg)
20
Comparison of Design Values
Pavement Lab UCCS,
psi
Lab MR,psi
FieldCBR, %
Fielda2
US 61N 285 50,000 200 0.13
US 82E 264 28,500 150 0.16
US 82 W 235 38,600 47 0.12
US 45N 271 53,000 133 0.14
Ref: Little
![Page 21: Lime Use For Soil & Base Improvementpetersenasphaltconference.org/download/2007/3-3EricBerger.pdfCBR, LTS (%) Ratio LTS: Subgrade 61N 15 200 33.3 82E 12 150 12.5 82W 4 47 11.8 45N](https://reader033.vdocuments.mx/reader033/viewer/2022060817/6096c81d5f33b658b82d4bc7/html5/thumbnails/21.jpg)
21
Pavement Design - Added Strength
A structural value is given to the stabilized subgrade
AASHTO Equation:-SN=a1D1+a2D2+a3D3
where a3=0.11-0.17
Benefits:
e.g. Figure 2.8, AASHTO Guide for e.g. Figure 2.8, AASHTO Guide for Design of Pavement StructuresDesign of Pavement Structures
![Page 22: Lime Use For Soil & Base Improvementpetersenasphaltconference.org/download/2007/3-3EricBerger.pdfCBR, LTS (%) Ratio LTS: Subgrade 61N 15 200 33.3 82E 12 150 12.5 82W 4 47 11.8 45N](https://reader033.vdocuments.mx/reader033/viewer/2022060817/6096c81d5f33b658b82d4bc7/html5/thumbnails/22.jpg)
22
Dougherty Valley
Consideration for Lime Stabilization of the Native Subgrade Soils
• Engineering
• Environmental
• Economics
Ref: ENGEO, Inc.
![Page 23: Lime Use For Soil & Base Improvementpetersenasphaltconference.org/download/2007/3-3EricBerger.pdfCBR, LTS (%) Ratio LTS: Subgrade 61N 15 200 33.3 82E 12 150 12.5 82W 4 47 11.8 45N](https://reader033.vdocuments.mx/reader033/viewer/2022060817/6096c81d5f33b658b82d4bc7/html5/thumbnails/23.jpg)
23
Engineering Benefits
• Reduction of shrink/swell potential of the native clay soils
• Increase load bearing capabilities of the subgrade
• Increase of subgrade R-Value from native 5 to treated +70
• Increased longevity of roadway by continued strength gains of the treated soil, creating a permanent pavement foundation
![Page 24: Lime Use For Soil & Base Improvementpetersenasphaltconference.org/download/2007/3-3EricBerger.pdfCBR, LTS (%) Ratio LTS: Subgrade 61N 15 200 33.3 82E 12 150 12.5 82W 4 47 11.8 45N](https://reader033.vdocuments.mx/reader033/viewer/2022060817/6096c81d5f33b658b82d4bc7/html5/thumbnails/24.jpg)
24
Environmental Benefits
• Reduction in the amount of trucking from approximately 6,000 Truck loads of aggregate base to 2,300.
• Reduction in the amount of wear and tear of existing roadways leading into the site.
• Reduction in the maintenance cost of the existing roadways
• Reduction in further quarry depletions and less air pollution due to trucking requirements
![Page 25: Lime Use For Soil & Base Improvementpetersenasphaltconference.org/download/2007/3-3EricBerger.pdfCBR, LTS (%) Ratio LTS: Subgrade 61N 15 200 33.3 82E 12 150 12.5 82W 4 47 11.8 45N](https://reader033.vdocuments.mx/reader033/viewer/2022060817/6096c81d5f33b658b82d4bc7/html5/thumbnails/25.jpg)
25
Economic Benefits
• Reduction of the pavement section
• Initial design section for a TI 8 required 4.8 inches of AC, 20.4 inches of AB, over compacted subgrade
• Treated section for a TI 8 required 4.8 inches of AC, 8.4 inches AB, over 15 inches of 4 percent lime treated subgrade soils.
• Total reduction of 12 inches of Class 2 Aggregate Base.
• Reduction in the amount of grading required for roadway construction.
• A schedule savings of up to 30 percent during the winter months.
![Page 26: Lime Use For Soil & Base Improvementpetersenasphaltconference.org/download/2007/3-3EricBerger.pdfCBR, LTS (%) Ratio LTS: Subgrade 61N 15 200 33.3 82E 12 150 12.5 82W 4 47 11.8 45N](https://reader033.vdocuments.mx/reader033/viewer/2022060817/6096c81d5f33b658b82d4bc7/html5/thumbnails/26.jpg)
26
• Classify Soil & determine Lime Demand– 25 % passing #200 & PI ≥ 10– Organics < 1 %– Eades & Grim pH test (ASTM D 6276) to determine Lime
demand– Establish moisture-density relationship
• Determine Strength & Stiffness– Unconfined Compressive Strength (ASTM D 5102)
• Fabricate, Cure & Soak Samples– mimic field conditions– normal curing at 720F (210C) for 28 days; accelerated curing
at 1200F (490C) for 48 hours– critical for freeze-thaw zones: time to first winter
Mixture Design & Testing Protocol:
Tests for Lime Stabilization
![Page 27: Lime Use For Soil & Base Improvementpetersenasphaltconference.org/download/2007/3-3EricBerger.pdfCBR, LTS (%) Ratio LTS: Subgrade 61N 15 200 33.3 82E 12 150 12.5 82W 4 47 11.8 45N](https://reader033.vdocuments.mx/reader033/viewer/2022060817/6096c81d5f33b658b82d4bc7/html5/thumbnails/27.jpg)
27
Rapid Change in Soil Texture
Native Clay Lime Treated Clay
![Page 28: Lime Use For Soil & Base Improvementpetersenasphaltconference.org/download/2007/3-3EricBerger.pdfCBR, LTS (%) Ratio LTS: Subgrade 61N 15 200 33.3 82E 12 150 12.5 82W 4 47 11.8 45N](https://reader033.vdocuments.mx/reader033/viewer/2022060817/6096c81d5f33b658b82d4bc7/html5/thumbnails/28.jpg)
28
Influence on Moisture-Density Relation:
Lime treated Soil:- Lower ρdOP at higher
moisture contents
- Proctor-Curve gets“flatter”
1.55
1.60
1.65
1.70
1.75
13 14 15 16 17 18 19 20 21 22 23 24 25
Moisture Content [%]
Com
pact
ed D
ry D
ensi
ty ρ
dOPN
[t/m
3]
97
100
103
106
109
Com
pact
ed D
ry D
ensi
ty ρ
dOPN
[pcf
]No Lime
4% Lime
ρdOP
![Page 29: Lime Use For Soil & Base Improvementpetersenasphaltconference.org/download/2007/3-3EricBerger.pdfCBR, LTS (%) Ratio LTS: Subgrade 61N 15 200 33.3 82E 12 150 12.5 82W 4 47 11.8 45N](https://reader033.vdocuments.mx/reader033/viewer/2022060817/6096c81d5f33b658b82d4bc7/html5/thumbnails/29.jpg)
29
Aggregate Base Modification
![Page 30: Lime Use For Soil & Base Improvementpetersenasphaltconference.org/download/2007/3-3EricBerger.pdfCBR, LTS (%) Ratio LTS: Subgrade 61N 15 200 33.3 82E 12 150 12.5 82W 4 47 11.8 45N](https://reader033.vdocuments.mx/reader033/viewer/2022060817/6096c81d5f33b658b82d4bc7/html5/thumbnails/30.jpg)
30
Why Modify Aggregate Base Material?
Improves engineering properties of marginal or unstable aggregates
Enhances performance of aggregate as a structural material in pavements
Increases source utilization and improves economics of aggregate operation
![Page 31: Lime Use For Soil & Base Improvementpetersenasphaltconference.org/download/2007/3-3EricBerger.pdfCBR, LTS (%) Ratio LTS: Subgrade 61N 15 200 33.3 82E 12 150 12.5 82W 4 47 11.8 45N](https://reader033.vdocuments.mx/reader033/viewer/2022060817/6096c81d5f33b658b82d4bc7/html5/thumbnails/31.jpg)
31
Aggregate Base Modification
• Plasticity or excess fines of treated aggregate are reduced to non-plastic or “acceptable” level
• Clay content is stabilized and particle size increased to become important, marketable part of aggregate
• Strength is gained through pozzolanic reactivity or particle cementation (particularly notable in caliches)
• Production life of pits and quarries can be extended for years by better utilization of marginal materials
![Page 32: Lime Use For Soil & Base Improvementpetersenasphaltconference.org/download/2007/3-3EricBerger.pdfCBR, LTS (%) Ratio LTS: Subgrade 61N 15 200 33.3 82E 12 150 12.5 82W 4 47 11.8 45N](https://reader033.vdocuments.mx/reader033/viewer/2022060817/6096c81d5f33b658b82d4bc7/html5/thumbnails/32.jpg)
32
Aggregate Modification Testing
• Amount of lime will vary by the amount of clay or fines in the material and their plasticity
• Obtain a representative sample of the material to be modified
• Identify material problems– Recommended tests: Plasticity Index, Sand
Equivalent• Determine quantity of lime needed to reduce
plasticity/ increase particle size of fine fraction– Eades Grim pH Test– 1-2% commonly needed
![Page 33: Lime Use For Soil & Base Improvementpetersenasphaltconference.org/download/2007/3-3EricBerger.pdfCBR, LTS (%) Ratio LTS: Subgrade 61N 15 200 33.3 82E 12 150 12.5 82W 4 47 11.8 45N](https://reader033.vdocuments.mx/reader033/viewer/2022060817/6096c81d5f33b658b82d4bc7/html5/thumbnails/33.jpg)
33
Modify Aggregate Plant
• Simple process - components often on hand
• Silo and vane feeder to apply lime to belt– 1-2% commonly needed – quicklime, hydrate,
slurry
• Water spray to hydrate lime so that it reacts with clay or other fines
• Pug mill or belt plows to mix lime and aggregate insuring complete reaction
![Page 34: Lime Use For Soil & Base Improvementpetersenasphaltconference.org/download/2007/3-3EricBerger.pdfCBR, LTS (%) Ratio LTS: Subgrade 61N 15 200 33.3 82E 12 150 12.5 82W 4 47 11.8 45N](https://reader033.vdocuments.mx/reader033/viewer/2022060817/6096c81d5f33b658b82d4bc7/html5/thumbnails/34.jpg)
34
• Eliminates excavation & export costs
• Provides a stable & impermeable layer below base or paving section
• Expansion or swell is decreased & foundation support is increased
• A structural value can be assigned to stabilized subgrade: a3 = 0.11 – 0.17
• Long term strength & performance is achieved
Benefits of Soil Stabilization
![Page 35: Lime Use For Soil & Base Improvementpetersenasphaltconference.org/download/2007/3-3EricBerger.pdfCBR, LTS (%) Ratio LTS: Subgrade 61N 15 200 33.3 82E 12 150 12.5 82W 4 47 11.8 45N](https://reader033.vdocuments.mx/reader033/viewer/2022060817/6096c81d5f33b658b82d4bc7/html5/thumbnails/35.jpg)
35
National Lime Association Publications
• Available for download from: www.lime.org– Lime Stabilization & Mechanistic-Empirical Pavement
Design – Mallela, et al– Mixture Design & Testing Procedures for Lime
Stabilized Soil– Lime-Treated Soil Construction Manual: Lime
Stabilization & Lime Modification– Evaluation of Structural Properties of Lime Stabilized
Soils & Aggregates - Little• Volume I - Structural Performance of Lime Stabilized
Layers• Volume III - Mixture Design