flare stack system presentation
TRANSCRIPT
1
FLARE SYSTEM ---
(FLARE STACK SYSTEM)---
(PRESSURE – RELIEVING AND DEPRESSURING SYSTEM)
EQUIPMENT TEAMMAI VAN DUNG
2
FLARE SYSTEM
(FLARE STACK SYSTEM)
On oil production rigs, in refineries and chemical plants, its primary purpose is to act as a safety device to protect vessels or pipes from over-pressuring due to unplanned upsets
EMERGENCY
CONTINUOUS
INTERMITTENT
SERVICES
EQUIPMENT TEAMMAI VAN DUNG
3
FLARE SYSTEM
+ COMPOSITION OF GAS
+ FLOW RATE/ PRESSURE
+ RADIATION
+ SMOKELESS
+ NOISE
+ CONSTRUCTION
+ MAINENANCE
FLARESYSTEM
CONSIDERATION
EQUIPMENT TEAMMAI VAN DUNG
4NCS1
EQUIPMENT TEAMMAI VAN DUNG
SUBHEADER
SUBHEADER
SUBHEADER
SUBHEADER
SUBHEADER
HEADER HEADER
KNOCK-OUT
FLARE TIP
& STACK
FLARE SYSTEM
5
PILOTS
IGNITION DEVICE
STEAM NOZZLE
INERT GAS/
PURGE GAS
MOLECULAR SEAL
KNOCK-OUT
GAS COLLECT HEADERS
DRAIN WATER SEAL DRAIN
RISER STACK
STEAM LINE
GAS LINE
AIR LINE
PURGER
IGNITORMONITOR
FLARE SYSTEM
EQUIPMENT TEAMMAI VAN DUNG
6
FLARE SYSTEM
NCS1EQUIPMENT TEAMMAI VAN DUNG
KNOCK-OUTRISER STACK
PILOT SYSTEM
7
CONSTRUCTION
SELF-SUPPORTED
STRUCTURE DERRICK
STRUCTURE
GUYED-SUPPORTED
STRUCTURENOTE: MAINTENANCE
EQUIPMENT TEAMMAI VAN DUNG
DEAD MAN
8EQUIPMENT TEAMMAI VAN DUNG
PILOT SYSTEM
CONTROL PANNEL
PILOTS
VENT
FROM KNOCK-OUT DRUM
FLARE TIP
FUEL GAS
FUEL
GAS
9
Air-Assisted Flares
Steam-Assisted Flares
Non-Assisted Flares
Pressure-Assisted Flares
Pressure-Assisted Flares
Pilot(s)
FLARE SYSTEM
Pilot igniter(s)
Buyoyancy or velocity seal (op.)Pilot flame detectors (op.)
Flame/detonation arrestor (op.)Davit for tip removal (op.)Ladder and Platforms (op.)Riser Stack
Aircraft warning lightsRain shields (op.)
Wind shields (op.)
……
MAJOR COMPONENTSFLARE TYPES
EQUIPMENT TEAMMAI VAN DUNG
10
FLARE TIP
EQUIPMENT TEAMMAI VAN DUNG
INLET
TOP OF STACK
OUT LETPILOT
11
FLARE TIP
EQUIPMENT TEAMMAI VAN DUNG
(STEAM- ASSISTED)
12
FLARE SYSTEM
13
FLARE TIP
EQUIPMENT TEAMMAI VAN DUNG
SEVERE CONDITION
14
FLARE SYSTEM
PILOT & IGNITOR
SYSTEM
EQUIPMENT TEAMMAI VAN DUNG
15
FLARE SYSTEM
PILOT & IGNITOR
SYSTEM
EQUIPMENT TEAMMAI VAN DUNG
16
FLAME DETECTION EQUIPMETN
EQUIPMENT TEAMMAI VAN DUNG
4.ACOUSTIC SYSTEMS
3.OPTICAL SYSTEMS
2.FLAME IONIZATION
1.THERMOCOUPLES
17
MAINTENANCE
EQUIIPMENT FAILURE
CORROSION
UNSAFETY
BY HELICOPTER
BY DERRICK HADLINGEQUIPMENT TEAMMAI VAN DUNG
18EQUIPMENT TEAMMAI VAN DUNG