waterproofing cad details typical waterproofing … · 1) waterproofing should be fully bonded and...
Post on 17-Jul-2020
29 Views
Preview:
TRANSCRIPT
WATERPROOFING CAD DETAILSTYPICAL WATERPROOFING CONNECTIONS
2
WATERPROOFING DETAILSTypical Waterproofing Connection Details
3
WATERPROOFING DETAILS
Typical Waterproofing Connection Details
THE CRITICAL AREAS OF WATERPROOFING
These are the most common areas where waterproofing can fail. To reduce the risks significantly;1) Waterproofing should be fully bonded and continuous.2) Compatibility is crucial. Quality is crucial.3) Get expert input early – Sika has over 100 years of global waterproofing expertise on tap.
Vers
ion:
021
7
BELOW GROUND WATERPROOFING TO BS:8012/2009
Balcony waterproofing over non-habitable space connection to facade
Balcony / podium deck waterproofing over habitable space connection to facade
Masonry walls to toe footing detail connection
Basement to deck connection
Waterproof window reveal and air seal connection
Facade baffle & airseal connection
Basement waterproofing to facade connection
4
WATERPROOFING DETAILSTypical Waterproofing Connection Details
CRITICAL WATERPROOFING CONNECTION DETAILS
The information contained herein and any other advice are given in good faith based on Sika's current knowledge and experience of the products when properly stored, handled and applied under normal conditions in accordance with Sika's recommendations. The information onlyapplies to the application(s) and product(s) expressly referred to herein and is based on laboratory tests which do not replace practical tests. In case of changes in the parameters of the application, such as changes in substrates etc., or in case of a different application, consult Sika'sTechnical Service prior to using Sika products. The information contained herein does not relieve the user of the products from testing them for the intended application and purpose. All orders are accepted subject to our current terms of sale and delivery. Users must always refer tothe most recent issue of the local Product Data Sheet for the product concerned, copies of which will be supplied on request.
Sika (NZ) Ltd
PO Box 19192
Auckland 1746
New Zealand.
Ph. 0800 745 269
www.sika.co.nz
May 2018BlackSeal Elastic / DPM
Sika Blackseal ProtectionSheet or 50mm thick EPS fixedinto position with tape
Minimum 2 coats of SikaBlackseal Elastic applied toprimed substrateNote:Trim this leg of SikaProof Aedge sheet to suit
200mm wide SikaDeckweb Mesh
SikaProof Atape 150
100mm perforated drainage pipe wrappedin geotextile filter fabric - check engineersdetail
DPM500 mm
SikaProof A edge sheet
100mm overlap, adhered to selvedge ofSikaProof A edge sheet
Note:Highly porous blocks anduneven masonry walls shall bebagged with Sika MonoTopFairing Coat or otherappropriate cement basedmortar.
Note:Wall must be flush with slab. If this cannot beachieved then any misalignment must be made flush.
Sika BlackSeal Elastic - Masonry Walls - Wall to Floor Scale 1:5Drawing no: 14
50mm site concrete
100 mm
150
mm
The information contained herein and any other advice are given in good faith based on Sika's current knowledge and experience of the products when properly stored, handled and applied under normal conditions in accordance with Sika's recommendations. The information onlyapplies to the application(s) and product(s) expressly referred to herein and is based on laboratory tests which do not replace practical tests. In case of changes in the parameters of the application, such as changes in substrates etc., or in case of a different application, consult Sika'sTechnical Service prior to using Sika products. The information contained herein does not relieve the user of the products from testing them for the intended application and purpose. All orders are accepted subject to our current terms of sale and delivery. Users must always refer tothe most recent issue of the local Product Data Sheet for the product concerned, copies of which will be supplied on request.
Sika (NZ) Ltd
PO Box 19192
Auckland 1746
New Zealand.
Ph. 0800 745 269
www.sika.co.nz
May 2018Sika BlackSeal Elastic / SikaProof A edge sheet
100 mm
Precast concrete panel
Granular free drainage backfill
Sika BlackSeal ProtectionSheet or 50mm thick EPS fixed
into position with tape
Minimum 2 coats of SikaBlackSeal Elastic applied to
primed substrate
SikaProof A Tape 150
100mm perforated drainagepipe wrapped in geotextile
filter fabric - refer engineersdetail
SikaSwell-P Profile2010 H
SikaGrout-212
100mm overlapadhered to selvedge ofSikaProof A edge sheet
DPM
150
mm
100m
m10
0mm
The information contained herein and any other advice are given in good faith based on Sika's current knowledge and experience of the products when properly stored, handled and applied under normal conditions in accordance with Sika's recommendations. The information onlyapplies to the application(s) and product(s) expressly referred to herein and is based on laboratory tests which do not replace practical tests. In case of changes in the parameters of the application, such as changes in substrates etc., or in case of a different application, consult Sika'sTechnical Service prior to using Sika products. The information contained herein does not relieve the user of the products from testing them for the intended application and purpose. All orders are accepted subject to our current terms of sale and delivery. Users must always refer tothe most recent issue of the local Product Data Sheet for the product concerned, copies of which will be supplied on request.
Sika (NZ) Ltd
PO Box 19192
Auckland 1746
New Zealand.
Ph. 0800 745 269
www.sika.co.nz
May 2018BlackSeal Elastic / SikaProof A
Sika BlackSeal Protection Sheet or 50mmthick EPS fixed into position with tape
100mm perforated drainagepipe wrapped in geotextilefilter fabric - refer engineersdetail
DPM
SikaProof A edge sheet
Sika BlackSeal Elastic applied fullyonto SikaProof A Tape 150
50mm site concrete
SECTION
Note:Highly porous blocks anduneven masonry walls shall bebagged with Sika MonoTopFairing Coat or otherappropriate cement basedmortar.
Sand/cement/BlackSeal Elastic mortar25mm angle fillet
Minimum 2 coats of Sika BlackSealElastic applied to primed substrate
200
mm
min
.
500 mm
150
mm
min
.
The information contained herein and any other advice are given in good faith based on Sika's current knowledge and experience of the products when properly stored, handled and applied under normal conditions in accordance with Sika's recommendations. The information onlyapplies to the application(s) and product(s) expressly referred to herein and is based on laboratory tests which do not replace practical tests. In case of changes in the parameters of the application, such as changes in substrates etc., or in case of a different application, consult Sika'sTechnical Service prior to using Sika products. The information contained herein does not relieve the user of the products from testing them for the intended application and purpose. All orders are accepted subject to our current terms of sale and delivery. Users must always refer tothe most recent issue of the local Product Data Sheet for the product concerned, copies of which will be supplied on request.
Sika (NZ) Ltd
PO Box 19192
Auckland 1746
New Zealand.
Ph. 0800 745 269
www.sika.co.nz
May 2018SikaProof Bentonite/Sikalastic -152
4mm Sikalastic-152 taken 150mm aboveground level and lapped 150mm behindSikaProof Bentonite with 40mm wide strip ofSikaProof Bentonite paste in the lap15
0 m
m15
0 m
m
GROUND LEVEL
Sikaflex-11 FC
25mmx2mm aluminum termination bar fixed atmax. 300mm centres with mechanical fastener
SikaProof Bentonite preapplied to formwork inpre-cast yard
Minimum 6mm Coreflute board protection
Granular free drainage backfill
SECTION
The information contained herein and any other advice are given in good faith based on Sika's current knowledge and experience of the products when properly stored, handled and applied under normal conditions in accordance with Sika's recommendations. The information onlyapplies to the application(s) and product(s) expressly referred to herein and is based on laboratory tests which do not replace practical tests. In case of changes in the parameters of the application, such as changes in substrates etc., or in case of a different application, consult Sika'sTechnical Service prior to using Sika products. The information contained herein does not relieve the user of the products from testing them for the intended application and purpose. All orders are accepted subject to our current terms of sale and delivery. Users must always refer tothe most recent issue of the local Product Data Sheet for the product concerned, copies of which will be supplied on request.
Sika (NZ) Ltd
PO Box 19192
Auckland 1746
New Zealand.
Ph. 0800 745 269
www.sika.co.nz
May 2018Sika Car Park DeckSikaProof P
2 Take Sika Carpark Deck System 150mm onto Sikafloor-400 N Elastic
1 Apply a 300mm wide strip of Sikafloor-400 N Elastic
Sika Carpark Deck System
3 Terminate SikaProof P 150mm onto Sikafloor-400 N Elastic
The information contained herein and any other advice are given in good faith based on Sika's current knowledge and experience of the products when properly stored, handled and applied under normal conditions in accordance with Sika's recommendations. The information onlyapplies to the application(s) and product(s) expressly referred to herein and is based on laboratory tests which do not replace practical tests. In case of changes in the parameters of the application, such as changes in substrates etc., or in case of a different application, consult Sika'sTechnical Service prior to using Sika products. The information contained herein does not relieve the user of the products from testing them for the intended application and purpose. All orders are accepted subject to our current terms of sale and delivery. Users must always refer tothe most recent issue of the local Product Data Sheet for the product concerned, copies of which will be supplied on request.
Sika (NZ) Ltd
PO Box 19192
Auckland 1746
New Zealand.
Ph. 0800 745 269
www.sika.co.nz
May 2018Sika Car Park DeckSikaProof Bentonite
Apply a 300mm wide strip ofSikafloor-400 N Elastic to thevertical concreteStage 1
Terminate SikaProof Bentonite ontothe Sikafloor-400 N Elastic 150mm
Stage 2
150
mm
Take the Sika Car Park Deckdown 150mm onto thepreapplied Sikafloor-400 NElastic
Stage 3
The information contained herein and any other advice are given in good faith based on Sika's current knowledge and experience of the products when properly stored, handled and applied under normal conditions in accordance with Sika's recommendations. The information onlyapplies to the application(s) and product(s) expressly referred to herein and is based on laboratory tests which do not replace practical tests. In case of changes in the parameters of the application, such as changes in substrates etc., or in case of a different application, consult Sika'sTechnical Service prior to using Sika products. The information contained herein does not relieve the user of the products from testing them for the intended application and purpose. All orders are accepted subject to our current terms of sale and delivery. Users must always refer tothe most recent issue of the local Product Data Sheet for the product concerned, copies of which will be supplied on request.
Sika (NZ) Ltd
PO Box 19192
Auckland 1746
New Zealand.
Ph. 0800 745 269
www.sika.co.nz
May 2018Typical Overlap DetailSikaProof A / DPM
SikaProof A lapped underneathdpm bonded to selvedge
Likely to require site concrete tosupport this junction
SikaSwell - A Profile
If DPM exists, cut back to astraight edge
300 mm
SikaProof A-12
The information contained herein and any other advice are given in good faith based on Sika's current knowledge and experience of the products when properly stored, handled and applied under normal conditions in accordance with Sika's recommendations. The information onlyapplies to the application(s) and product(s) expressly referred to herein and is based on laboratory tests which do not replace practical tests. In case of changes in the parameters of the application, such as changes in substrates etc., or in case of a different application, consult Sika'sTechnical Service prior to using Sika products. The information contained herein does not relieve the user of the products from testing them for the intended application and purpose. All orders are accepted subject to our current terms of sale and delivery. Users must always refer tothe most recent issue of the local Product Data Sheet for the product concerned, copies of which will be supplied on request.
Sika (NZ) Ltd
PO Box 19192
Auckland 1746
New Zealand.
Ph. 0800 745 269
www.sika.co.nz
May 2018Typical Overlap Detail SikaProof A/SikaRoof MTC
SikaRoof MTC
150mm wide strip ofSikaProof P
SikaProof A
SWOD 01 · Page 6 SWOD 02 · Page 7 SWOD 03 · Page 8 SWOD 04 · Page 9
SWOD 05 · Page 10 SWOD 06 · Page 11 SWOD 07 · Page 12 SWOD 08 · Page 13
5
WATERPROOFING DETAILS
Typical Waterproofing Connection Details
The information contained herein and any other advice are given in good faith based on Sika's current knowledge and experience of the products when properly stored, handled and applied under normal conditions in accordance with Sika's recommendations. The information onlyapplies to the application(s) and product(s) expressly referred to herein and is based on laboratory tests which do not replace practical tests. In case of changes in the parameters of the application, such as changes in substrates etc., or in case of a different application, consult Sika'sTechnical Service prior to using Sika products. The information contained herein does not relieve the user of the products from testing them for the intended application and purpose. All orders are accepted subject to our current terms of sale and delivery. Users must always refer tothe most recent issue of the local Product Data Sheet for the product concerned, copies of which will be supplied on request.
Sika (NZ) Ltd
PO Box 19192
Auckland 1746
New Zealand.
Ph. 0800 745 269
www.sika.co.nz
May 2018SikaProof Bentonite / Sarnafil
Note:Protect out side withcoreflute before backfilling.Laps to be glued.
Hot air weld
Sarnafil G410-20L Felt loose laid
Sarnafil G410-20L
200mm cover strip of Sarnafil G410-20Lwelded 40mm at sides and ends
SikaProof Bentonite
Lap Sarnafil 300mm min.past top edge of Bentonite
Bentonite trimmed 100mmfrom top of slab10
0mm
Sarnafil U-bar 100mm from concreteedge to allow room for tile pedestal
Termination bar Type IIFully bond vertical section of SarnafilG410-20L Felt with Sarnacol 808
300m
m
The information contained herein and any other advice are given in good faith based on Sika's current knowledge and experience of the products when properly stored, handled and applied under normal conditions in accordance with Sika's recommendations. The information onlyapplies to the application(s) and product(s) expressly referred to herein and is based on laboratory tests which do not replace practical tests. In case of changes in the parameters of the application, such as changes in substrates etc., or in case of a different application, consult Sika'sTechnical Service prior to using Sika products. The information contained herein does not relieve the user of the products from testing them for the intended application and purpose. All orders are accepted subject to our current terms of sale and delivery. Users must always refer tothe most recent issue of the local Product Data Sheet for the product concerned, copies of which will be supplied on request.
Sika (NZ) Ltd
PO Box 19192
Auckland 1746
New Zealand.
Ph. 0800 745 269
www.sika.co.nz
May 2018SikaRoof MTC/SikaProof Bentonite
Second application of SikaRoof-MTC 22reinforced with Sika Reemat and taken
150mm onto the SikaProof Bentonite
SikaProof Bentonite terminated atground level
SikaProof Bentonite overlappingfirst application of SikaRoof-MTC 22
by 150mm
1. Apply SikaRoof MTC
2. Apply SikaProof Bentonite3. Apply SikaRoof MTC
If Bentonite is pre-applied, ensuretop 150mm is left debonded.
SWOD 09 · Page 14 SWOD 10 · Page 15 SWOD 11 · Page 16
The information contained herein and any other advice are given in good faith based on Sika's current knowledge and experience of the products when properly stored, handled and applied under normal conditions in accordance with Sika's recommendations. The information onlyapplies to the application(s) and product(s) expressly referred to herein and is based on laboratory tests which do not replace practical tests. In case of changes in the parameters of the application, such as changes in substrates etc., or in case of a different application, consult Sika'sTechnical Service prior to using Sika products. The information contained herein does not relieve the user of the products from testing them for the intended application and purpose. All orders are accepted subject to our current terms of sale and delivery. Users must always refer tothe most recent issue of the local Product Data Sheet for the product concerned, copies of which will be supplied on request.
Sika (NZ) Ltd
PO Box 19192
Auckland 1746
New Zealand.
Ph. 0800 745 269
www.sika.co.nz
May 2018SikaProof A onto Sarnafil G410 & S327
Sarnafil G410-10L heat welded ontoDilatec ER350 Tape
Dilatec ER350 tape adhered ontoSikaProof A with Sikadur-31
SikaProof A
Sika balcony deck waterproofing and door threshold joint sealingfor concrete decks over habitablespace Scale 1:5
45 Deg. chamfer to screed
Roof membrane extends below window frame Timber threshold board
Sikaflex / SikaHyflex facadesealant air seal backed by a PEF rod to perimeter of trim cavity compatible with balcony waterproofing membrane
Timber threshold board
Roof membrane fixed below window frame
If build is less than 40mm screed must be bonded with emulsion 93 sand & cement slurry
Linear drainage grille along length of door opening. Alternatively, a 12mm gap between deck and sill is required
Tile decking on deck jacks on square of Sarnafil G410-20L FELT
Sill tray & packers
Sikaflex / SikaHyflex facade sealant air seal backed by a PEF rod to perimeter of trim cavity compatible with balcony waterproofing membrane
Sika Screed 1 or Sikascreed binder
Roof screed to fall to roof gullies, fall 1.5 degrees (min.)
Sill tray
Packers
Sill to provide minimum 10mm overhang, with 5mm drainage clearance (vertically & horizontally)
Liquid applied or sheet roof membrane to be extended onto slab beneath door sill
Roof membrane SikaRoof MTC 22or Sarnafil G410-20L FELT fully bonded
SWOD 12 · Page 17
Sikalastic - 152 beneath window / door to run along the entire sill and down the external face of the sill and min. 40mm up the jambs
Sill profile to provide min. 10mm overhang, with 5mm drainage clearance (vertical and horizontal)
Sika concrete masonry reveal waterproofing and window joint sealing detail Scale 1:5
Weathertightness system
Window frame fixed to blockwork, and packed as required
Drip edge formed from plaster or pvc angle
Continuous head and jamb seal Sikaflex / SikaHyflex facade sealant backed by a PEF rod
Plaster or coating finish
Sikaflex / SikaHyflex facade sealant air seal backed by a PEF rod to perimeter of trim cavity
Sikaflex / SikaHyflex facade sealant air seal backed by a PEF rod to perimeter of trim cavity
Sikalastic - 152 waterproof coating or membrane continuous at head and jambs
SWOD 13 · Page 18 SWOD 14 · Page 19
TECHNICAL DRAWINGBalcony deck waterproofing and door threshold joint sealing for concrete decks over non-habitable space
2
015
Sika
(NZ)
Ltd
The information contained herein and any other advice are given in good faith based on Sika’s current knowledge and experience of the products when properly stored, handled and applied under normal conditions in accordance with Sika’s recommendations. The information only applies to the application(s) and product(s) expressly referred to herein and is based on laboratory tests which do not replace practical tests. In case of changes in the parameters of the application, such as changes in substrates etc., or in case of a different application, consult Sika’s Technical Service prior to using Sika products. The information contained herein does not relieve the user of the products from testing them for the intended application and purpose. All orders are accepted subject to our current terms of sale and delivery. Users must always refer to the most recent issue of the local Product Data Sheet for the product concerned, copies of which will be supplied on request.
Technical Drawing NZ · APAC Balcony deck waterproofing and door threshold joint sealing for concrete decks over non-habitable space Oct 2015, Version 1015
Sika (NZ) LimitedSealing & Bonding · Waterproofing85-91 Patiki Road, AvondaleAuckland 1026New Zealand
Phone: 0800 745 269Fax: 0800 745 232Mail: info@nz.sika.comwww.sika.co.nz
6
WATERPROOFING DETAILSTypical Waterproofing Connection Details
Sika Car Park DeckSikaProof P
The information contained herein and any other advice are given in good faith based on Sika's current knowledge and experience of the products when properly stored, handled and applied under normal conditions in accordance with Sika's recommendations. The information onlyapplies to the application(s) and product(s) expressly referred to herein and is based on laboratory tests which do not replace practical tests. In case of changes in the parameters of the application, such as changes in substrates etc., or in case of a different application, consult Sika'sTechnical Service prior to using Sika products. The information contained herein does not relieve the user of the products from testing them for the intended application and purpose. All orders are accepted subject to our current terms of sale and delivery. Users must always refer tothe most recent issue of the local Product Data Sheet for the product concerned, copies of which will be supplied on request.
Sika (NZ) Ltd
PO Box 19192
Auckland 1746
New Zealand.
Ph. 0800 745 269
www.sika.co.nz
May 2018Sika Car Park DeckSikaProof P
2 Take Sika Carpark Deck System 150mm onto Sikafloor-400 N Elastic
1 Apply a 300mm wide strip of Sikafloor-400 N Elastic
Sika Carpark Deck System
3 Terminate SikaProof P 150mm onto Sikafloor-400 N Elastic
7
WATERPROOFING DETAILS
Typical Waterproofing Connection Details
The information contained herein and any other advice are given in good faith based on Sika's current knowledge and experience of the products when properly stored, handled and applied under normal conditions in accordance with Sika's recommendations. The information onlyapplies to the application(s) and product(s) expressly referred to herein and is based on laboratory tests which do not replace practical tests. In case of changes in the parameters of the application, such as changes in substrates etc., or in case of a different application, consult Sika'sTechnical Service prior to using Sika products. The information contained herein does not relieve the user of the products from testing them for the intended application and purpose. All orders are accepted subject to our current terms of sale and delivery. Users must always refer tothe most recent issue of the local Product Data Sheet for the product concerned, copies of which will be supplied on request.
Sika (NZ) Ltd
PO Box 19192
Auckland 1746
New Zealand.
Ph. 0800 745 269
www.sika.co.nz
May 2018Sika Car Park DeckSikaProof Bentonite
Apply a 300mm wide strip ofSikafloor-400 N Elastic to thevertical concreteStage 1
Terminate SikaProof Bentonite ontothe Sikafloor-400 N Elastic 150mm
Stage 2
150
mm
Take the Sika Car Park Deckdown 150mm onto thepreapplied Sikafloor-400 NElastic
Stage 3
8
WATERPROOFING DETAILSTypical Waterproofing Connection Details
The information contained herein and any other advice are given in good faith based on Sika's current knowledge and experience of the products when properly stored, handled and applied under normal conditions in accordance with Sika's recommendations. The information onlyapplies to the application(s) and product(s) expressly referred to herein and is based on laboratory tests which do not replace practical tests. In case of changes in the parameters of the application, such as changes in substrates etc., or in case of a different application, consult Sika'sTechnical Service prior to using Sika products. The information contained herein does not relieve the user of the products from testing them for the intended application and purpose. All orders are accepted subject to our current terms of sale and delivery. Users must always refer tothe most recent issue of the local Product Data Sheet for the product concerned, copies of which will be supplied on request.
Sika (NZ) Ltd
PO Box 19192
Auckland 1746
New Zealand.
Ph. 0800 745 269
www.sika.co.nz
May 2018Typical Overlap DetailSikaProof A / DPM
SikaProof A lapped underneathdpm bonded to selvedge
Likely to require site concrete tosupport this junction
SikaSwell - A Profile
If DPM exists, cut back to astraight edge
300 mm
SikaProof A-12
9
WATERPROOFING DETAILS
Typical Waterproofing Connection Details
The information contained herein and any other advice are given in good faith based on Sika's current knowledge and experience of the products when properly stored, handled and applied under normal conditions in accordance with Sika's recommendations. The information onlyapplies to the application(s) and product(s) expressly referred to herein and is based on laboratory tests which do not replace practical tests. In case of changes in the parameters of the application, such as changes in substrates etc., or in case of a different application, consult Sika'sTechnical Service prior to using Sika products. The information contained herein does not relieve the user of the products from testing them for the intended application and purpose. All orders are accepted subject to our current terms of sale and delivery. Users must always refer tothe most recent issue of the local Product Data Sheet for the product concerned, copies of which will be supplied on request.
Sika (NZ) Ltd
PO Box 19192
Auckland 1746
New Zealand.
Ph. 0800 745 269
www.sika.co.nz
May 2018Typical Overlap Detail SikaProof A/SikaRoof MTC
SikaRoof MTC
150mm wide strip ofSikaProof P
SikaProof A
10
WATERPROOFING DETAILSTypical Waterproofing Connection Details
The information contained herein and any other advice are given in good faith based on Sika's current knowledge and experience of the products when properly stored, handled and applied under normal conditions in accordance with Sika's recommendations. The information onlyapplies to the application(s) and product(s) expressly referred to herein and is based on laboratory tests which do not replace practical tests. In case of changes in the parameters of the application, such as changes in substrates etc., or in case of a different application, consult Sika'sTechnical Service prior to using Sika products. The information contained herein does not relieve the user of the products from testing them for the intended application and purpose. All orders are accepted subject to our current terms of sale and delivery. Users must always refer tothe most recent issue of the local Product Data Sheet for the product concerned, copies of which will be supplied on request.
Sika (NZ) Ltd
PO Box 19192
Auckland 1746
New Zealand.
Ph. 0800 745 269
www.sika.co.nz
May 2018BlackSeal Elastic / DPM
Sika Blackseal ProtectionSheet or 50mm thick EPS fixedinto position with tape
Minimum 2 coats of SikaBlackseal Elastic applied toprimed substrateNote:Trim this leg of SikaProof Aedge sheet to suit
200mm wide SikaDeckweb Mesh
SikaProof Atape 150
100mm perforated drainage pipe wrappedin geotextile filter fabric - check engineersdetail
DPM500 mm
SikaProof A edge sheet
100mm overlap, adhered to selvedge ofSikaProof A edge sheet
Note:Highly porous blocks anduneven masonry walls shall bebagged with Sika MonoTopFairing Coat or otherappropriate cement basedmortar.
Note:Wall must be flush with slab. If this cannot beachieved then any misalignment must be made flush.
Sika BlackSeal Elastic - Masonry Walls - Wall to Floor Scale 1:5Drawing no: 14
50mm site concrete
100 mm
150
mm
11
WATERPROOFING DETAILS
Typical Waterproofing Connection Details
The information contained herein and any other advice are given in good faith based on Sika's current knowledge and experience of the products when properly stored, handled and applied under normal conditions in accordance with Sika's recommendations. The information onlyapplies to the application(s) and product(s) expressly referred to herein and is based on laboratory tests which do not replace practical tests. In case of changes in the parameters of the application, such as changes in substrates etc., or in case of a different application, consult Sika'sTechnical Service prior to using Sika products. The information contained herein does not relieve the user of the products from testing them for the intended application and purpose. All orders are accepted subject to our current terms of sale and delivery. Users must always refer tothe most recent issue of the local Product Data Sheet for the product concerned, copies of which will be supplied on request.
Sika (NZ) Ltd
PO Box 19192
Auckland 1746
New Zealand.
Ph. 0800 745 269
www.sika.co.nz
May 2018Sika BlackSeal Elastic / SikaProof A edge sheet
100 mm
Precast concrete panel
Granular free drainage backfill
Sika BlackSeal ProtectionSheet or 50mm thick EPS fixed
into position with tape
Minimum 2 coats of SikaBlackSeal Elastic applied to
primed substrate
SikaProof A Tape 150
100mm perforated drainagepipe wrapped in geotextile
filter fabric - refer engineersdetail
SikaSwell-P Profile2010 H
SikaGrout-212
100mm overlapadhered to selvedge ofSikaProof A edge sheet
DPM
150
mm
100m
m10
0mm
12
WATERPROOFING DETAILSTypical Waterproofing Connection Details
The information contained herein and any other advice are given in good faith based on Sika's current knowledge and experience of the products when properly stored, handled and applied under normal conditions in accordance with Sika's recommendations. The information onlyapplies to the application(s) and product(s) expressly referred to herein and is based on laboratory tests which do not replace practical tests. In case of changes in the parameters of the application, such as changes in substrates etc., or in case of a different application, consult Sika'sTechnical Service prior to using Sika products. The information contained herein does not relieve the user of the products from testing them for the intended application and purpose. All orders are accepted subject to our current terms of sale and delivery. Users must always refer tothe most recent issue of the local Product Data Sheet for the product concerned, copies of which will be supplied on request.
Sika (NZ) Ltd
PO Box 19192
Auckland 1746
New Zealand.
Ph. 0800 745 269
www.sika.co.nz
May 2018BlackSeal Elastic / SikaProof A
Sika BlackSeal Protection Sheet or 50mmthick EPS fixed into position with tape
100mm perforated drainagepipe wrapped in geotextilefilter fabric - refer engineersdetail
DPM
SikaProof A edge sheet
Sika BlackSeal Elastic applied fullyonto SikaProof A Tape 150
50mm site concrete
SECTION
Note:Highly porous blocks anduneven masonry walls shall bebagged with Sika MonoTopFairing Coat or otherappropriate cement basedmortar.
Sand/cement/BlackSeal Elastic mortar25mm angle fillet
Minimum 2 coats of Sika BlackSealElastic applied to primed substrate
200
mm
min
.
500 mm
150
mm
min
.
13
WATERPROOFING DETAILS
Typical Waterproofing Connection Details
The information contained herein and any other advice are given in good faith based on Sika's current knowledge and experience of the products when properly stored, handled and applied under normal conditions in accordance with Sika's recommendations. The information onlyapplies to the application(s) and product(s) expressly referred to herein and is based on laboratory tests which do not replace practical tests. In case of changes in the parameters of the application, such as changes in substrates etc., or in case of a different application, consult Sika'sTechnical Service prior to using Sika products. The information contained herein does not relieve the user of the products from testing them for the intended application and purpose. All orders are accepted subject to our current terms of sale and delivery. Users must always refer tothe most recent issue of the local Product Data Sheet for the product concerned, copies of which will be supplied on request.
Sika (NZ) Ltd
PO Box 19192
Auckland 1746
New Zealand.
Ph. 0800 745 269
www.sika.co.nz
May 2018SikaProof Bentonite/Sikalastic -152
4mm Sikalastic-152 taken 150mm aboveground level and lapped 150mm behindSikaProof Bentonite with 40mm wide strip ofSikaProof Bentonite paste in the lap15
0 m
m15
0 m
m
GROUND LEVEL
Sikaflex-11 FC
25mmx2mm aluminum termination bar fixed atmax. 300mm centres with mechanical fastener
SikaProof Bentonite preapplied to formwork inpre-cast yard
Minimum 6mm Coreflute board protection
Granular free drainage backfill
SECTION
14
WATERPROOFING DETAILSTypical Waterproofing Connection Details
The information contained herein and any other advice are given in good faith based on Sika's current knowledge and experience of the products when properly stored, handled and applied under normal conditions in accordance with Sika's recommendations. The information onlyapplies to the application(s) and product(s) expressly referred to herein and is based on laboratory tests which do not replace practical tests. In case of changes in the parameters of the application, such as changes in substrates etc., or in case of a different application, consult Sika'sTechnical Service prior to using Sika products. The information contained herein does not relieve the user of the products from testing them for the intended application and purpose. All orders are accepted subject to our current terms of sale and delivery. Users must always refer tothe most recent issue of the local Product Data Sheet for the product concerned, copies of which will be supplied on request.
Sika (NZ) Ltd
PO Box 19192
Auckland 1746
New Zealand.
Ph. 0800 745 269
www.sika.co.nz
May 2018SikaProof Bentonite / Sarnafil
Note:Protect out side withcoreflute before backfilling.Laps to be glued.
Hot air weld
Sarnafil G410-20L Felt loose laid
Sarnafil G410-20L
200mm cover strip of Sarnafil G410-20Lwelded 40mm at sides and ends
SikaProof Bentonite
Lap Sarnafil 300mm min.past top edge of Bentonite
Bentonite trimmed 100mmfrom top of slab10
0mm
Sarnafil U-bar 100mm from concreteedge to allow room for tile pedestal
Termination bar Type IIFully bond vertical section of SarnafilG410-20L Felt with Sarnacol 808
300m
m
15
WATERPROOFING DETAILS
Typical Waterproofing Connection Details
The information contained herein and any other advice are given in good faith based on Sika's current knowledge and experience of the products when properly stored, handled and applied under normal conditions in accordance with Sika's recommendations. The information onlyapplies to the application(s) and product(s) expressly referred to herein and is based on laboratory tests which do not replace practical tests. In case of changes in the parameters of the application, such as changes in substrates etc., or in case of a different application, consult Sika'sTechnical Service prior to using Sika products. The information contained herein does not relieve the user of the products from testing them for the intended application and purpose. All orders are accepted subject to our current terms of sale and delivery. Users must always refer tothe most recent issue of the local Product Data Sheet for the product concerned, copies of which will be supplied on request.
Sika (NZ) Ltd
PO Box 19192
Auckland 1746
New Zealand.
Ph. 0800 745 269
www.sika.co.nz
May 2018SikaRoof MTC/SikaProof Bentonite
Second application of SikaRoof-MTC 22reinforced with Sika Reemat and taken
150mm onto the SikaProof Bentonite
SikaProof Bentonite terminated atground level
SikaProof Bentonite overlappingfirst application of SikaRoof-MTC 22
by 150mm
1. Apply SikaRoof MTC
2. Apply SikaProof Bentonite3. Apply SikaRoof MTC
If Bentonite is pre-applied, ensuretop 150mm is left debonded.
16
WATERPROOFING DETAILSTypical Waterproofing Connection Details
The information contained herein and any other advice are given in good faith based on Sika's current knowledge and experience of the products when properly stored, handled and applied under normal conditions in accordance with Sika's recommendations. The information onlyapplies to the application(s) and product(s) expressly referred to herein and is based on laboratory tests which do not replace practical tests. In case of changes in the parameters of the application, such as changes in substrates etc., or in case of a different application, consult Sika'sTechnical Service prior to using Sika products. The information contained herein does not relieve the user of the products from testing them for the intended application and purpose. All orders are accepted subject to our current terms of sale and delivery. Users must always refer tothe most recent issue of the local Product Data Sheet for the product concerned, copies of which will be supplied on request.
Sika (NZ) Ltd
PO Box 19192
Auckland 1746
New Zealand.
Ph. 0800 745 269
www.sika.co.nz
May 2018SikaProof A onto Sarnafil G410 & S327
Sarnafil G410-10L heat welded ontoDilatec ER350 Tape
Dilatec ER350 tape adhered ontoSikaProof A with Sikadur-31
SikaProof A
17
WATERPROOFING DETAILS
Typical Waterproofing Connection Details
Sika balcony deck waterproofing and door threshold joint sealingfor concrete decks over habitablespace Scale 1:5
45 Deg. chamfer to screed
Roof membrane extends below window frame Timber threshold board
Sikaflex / SikaHyflex facadesealant air seal backed by a PEF rod to perimeter of trim cavity compatible with balcony waterproofing membrane
Timber threshold board
Roof membrane fixed below window frame
If build is less than 40mm screed must be bonded with emulsion 93 sand & cement slurry
Linear drainage grille along length of door opening. Alternatively, a 12mm gap between deck and sill is required
Tile decking on deck jacks on square of Sarnafil G410-20L FELT
Sill tray & packers
Sikaflex / SikaHyflex facade sealant air seal backed by a PEF rod to perimeter of trim cavity compatible with balcony waterproofing membrane
Sika Screed 1 or Sikascreed binder
Roof screed to fall to roof gullies, fall 1.5 degrees (min.)
Sill tray
Packers
Sill to provide minimum 10mm overhang, with 5mm drainage clearance (vertically & horizontally)
Liquid applied or sheet roof membrane to be extended onto slab beneath door sill
Roof membrane SikaRoof MTC 22or Sarnafil G410-20L FELT fully bonded
The information contained herein and any other advice are given in good faith based on Sika's current knowledge and experience of the products when properly stored, handled and applied under normal conditions in accordance with Sika's recommendations. The information onlyapplies to the application(s) and product(s) expressly referred to herein and is based on laboratory tests which do not replace practical tests. In case of changes in the parameters of the application, such as changes in substrates etc., or in case of a different application, consult Sika'sTechnical Service prior to using Sika products. The information contained herein does not relieve the user of the products from testing them for the intended application and purpose. All orders are accepted subject to our current terms of sale and delivery. Users must always refer tothe most recent issue of the local Product Data Sheet for the product concerned, copies of which will be supplied on request.
Sika (NZ) Ltd
PO Box 19192
Auckland 1746
New Zealand.
Ph. 0800 745 269
www.sika.co.nz
May 2018SikaRoof MTC/SikaProof Bentonite
Second application of SikaRoof-MTC 22reinforced with Sika Reemat and taken
150mm onto the SikaProof Bentonite
SikaProof Bentonite terminated atground level
SikaProof Bentonite overlappingfirst application of SikaRoof-MTC 22
by 150mm
1. Apply SikaRoof MTC
2. Apply SikaProof Bentonite3. Apply SikaRoof MTC
If Bentonite is pre-applied, ensuretop 150mm is left debonded.
Sika balcony deck waterproofing & door threshold joint sealing for concrete decks over habitable space
Aug 2014
18
WATERPROOFING DETAILSTypical Waterproofing Connection Details
Sikalastic - 152 beneath window / door to run along the entire sill and down the external face of the sill and min. 40mm up the jambs
Sill profile to provide min. 10mm overhang, with 5mm drainage clearance (vertical and horizontal)
Sika concrete masonry reveal waterproofing and window joint sealing detail Scale 1:5
Weathertightness system
Window frame fixed to blockwork, and packed as required
Drip edge formed from plaster or pvc angle
Continuous head and jamb seal Sikaflex / SikaHyflex facade sealant backed by a PEF rod
Plaster or coating finish
Sikaflex / SikaHyflex facade sealant air seal backed by a PEF rod to perimeter of trim cavity
Sikaflex / SikaHyflex facade sealant air seal backed by a PEF rod to perimeter of trim cavity
Sikalastic - 152 waterproof coating or membrane continuous at head and jambs
The information contained herein and any other advice are given in good faith based on Sika's current knowledge and experience of the products when properly stored, handled and applied under normal conditions in accordance with Sika's recommendations. The information onlyapplies to the application(s) and product(s) expressly referred to herein and is based on laboratory tests which do not replace practical tests. In case of changes in the parameters of the application, such as changes in substrates etc., or in case of a different application, consult Sika'sTechnical Service prior to using Sika products. The information contained herein does not relieve the user of the products from testing them for the intended application and purpose. All orders are accepted subject to our current terms of sale and delivery. Users must always refer tothe most recent issue of the local Product Data Sheet for the product concerned, copies of which will be supplied on request.
Sika (NZ) Ltd
PO Box 19192
Auckland 1746
New Zealand.
Ph. 0800 745 269
www.sika.co.nz
May 2018SikaRoof MTC/SikaProof Bentonite
Second application of SikaRoof-MTC 22reinforced with Sika Reemat and taken
150mm onto the SikaProof Bentonite
SikaProof Bentonite terminated atground level
SikaProof Bentonite overlappingfirst application of SikaRoof-MTC 22
by 150mm
1. Apply SikaRoof MTC
2. Apply SikaProof Bentonite3. Apply SikaRoof MTC
If Bentonite is pre-applied, ensuretop 150mm is left debonded.
Sika balcony deck waterproofing & door threshold joint sealing for concrete decks over habitable space
19
WATERPROOFING DETAILS
Typical Waterproofing Connection Details
TECHNICAL DRAWINGBalcony deck waterproofing and door threshold joint sealing for concrete decks over non-habitable space
2
015
Sika
(NZ)
Ltd
The information contained herein and any other advice are given in good faith based on Sika’s current knowledge and experience of the products when properly stored, handled and applied under normal conditions in accordance with Sika’s recommendations. The information only applies to the application(s) and product(s) expressly referred to herein and is based on laboratory tests which do not replace practical tests. In case of changes in the parameters of the application, such as changes in substrates etc., or in case of a different application, consult Sika’s Technical Service prior to using Sika products. The information contained herein does not relieve the user of the products from testing them for the intended application and purpose. All orders are accepted subject to our current terms of sale and delivery. Users must always refer to the most recent issue of the local Product Data Sheet for the product concerned, copies of which will be supplied on request.
Technical Drawing NZ · APAC Balcony deck waterproofing and door threshold joint sealing for concrete decks over non-habitable space Oct 2015, Version 1015
Sika (NZ) LimitedSealing & Bonding · Waterproofing85-91 Patiki Road, AvondaleAuckland 1026New Zealand
Phone: 0800 745 269Fax: 0800 745 232Mail: info@nz.sika.comwww.sika.co.nz
The information contained herein and any other advice are given in good faith based on Sika's current knowledge and experience of the products when properly stored, handled and applied under normal conditions in accordance with Sika's recommendations. The information onlyapplies to the application(s) and product(s) expressly referred to herein and is based on laboratory tests which do not replace practical tests. In case of changes in the parameters of the application, such as changes in substrates etc., or in case of a different application, consult Sika'sTechnical Service prior to using Sika products. The information contained herein does not relieve the user of the products from testing them for the intended application and purpose. All orders are accepted subject to our current terms of sale and delivery. Users must always refer tothe most recent issue of the local Product Data Sheet for the product concerned, copies of which will be supplied on request.
Sika (NZ) Ltd
PO Box 19192
Auckland 1746
New Zealand.
Ph. 0800 745 269
www.sika.co.nz
May 2018SikaRoof MTC/SikaProof Bentonite
Second application of SikaRoof-MTC 22reinforced with Sika Reemat and taken
150mm onto the SikaProof Bentonite
SikaProof Bentonite terminated atground level
SikaProof Bentonite overlappingfirst application of SikaRoof-MTC 22
by 150mm
1. Apply SikaRoof MTC
2. Apply SikaProof Bentonite3. Apply SikaRoof MTC
If Bentonite is pre-applied, ensuretop 150mm is left debonded.
Sika balcony deck waterproofing & door threshold joint sealing for concrete decks over non-habitable space
Oct 2015
FOR MORE Sika® INFORMATION:
WHO WE ARESika AG, Switzerland, is a globally active specialty chemicals company. Sika supplies the building and construction industry as well as manufacturing industries (automotive, bus, truck, rail, solar and wind power plants, façades). Sika is a leader in processing materials used in sealing, bonding, damping, reinforcing and protecting loadbearing structures. Sika’s product lines feature high quality concrete admixtures, specialty mortars, sealants and adhesives, damping and reinforcing materials, structural strengthening systems, industrial flooring as well as roofing and waterproofing systems.
© S
ika
(NZ
) Ltd
| V
ersi
on N
o.: 1
018
(rep
lace
s02/
17)
top related