the name to remember. - aaon heating and cooling … out filter service gear drive economizer door...
TRANSCRIPT
Vertical Discharge Condensers
Horizontal Airflow Curb Available on All Models Including Air Handlers
High Performance Composite PanelConstruction – RN Models
P A C K A G E D R O O F T O P U N I T S
S E R I E S
The Name To Remember.
RM 2 to 30 Tons
RN 26 to 70 Tons
The AAON® RM/RN Series continues the
industry leading performance in packaged
rooftop equipment. All units are available
with backward-inclined plenum fans for
energy efficient delivery of airflow and
stable static pressure.
For installation flexibility RM/RN units are
available in four cabinet sizes from 2 to 70
tons cooling capacity and mount to three
common curb sizes.
The 2-15 ton units share a curb, the 16-30
ton share a curb, and the RN 26-70 ton have
a common curb. These curb commonalities
provide ease of installation and a variety
of configurations.
34348 RMRN.qxd 9/21/06 4:29 PM Page 1
Standard Features• Compressors, controls and heating components are
located in a single isolated compartment• Scroll compressors are installed on a sheet metal deck
and rubber isolation mounted for quiet efficient operation• Thermostatic expansion valves on DX coils• Manual reset high pressure cutoff• Automatic reset low pressure cutoff• Roof sloped and cross-broken for proper drainage• Bottom access return and supply air• Single point power connection• Double wall access doors with stainless hinges• Slide out blower assembly for easy service• Notched blower drive belts• Direct drive condenser fans• G90 galvanized cabinet construction• Gray polyurethane paint passes 2000 hour salt spray test• Run test report, wiring diagram, installation manual and
startup form located in control access compartment
Optional Features• Economizer – full modulating or 3-position outside air• Power Exhaust – with or without AAONAIRE® energy
recovery wheel• Gas Heat Exchanger – Stainless Steel• Blower Motors – oversized and/or high efficiency• Blower Fan – VFD volume control• Air Filter – multiple options and monitoring devices• GFI convenience outlet• Smoke Detectors or Firestats – return and/or supply air• Humidity Control:
• Hot Gas Reheat• Modulating Hot Gas Reheat• Return Air Bypass• Hot Gas Bypass
• Compressor isolation valves• Phase and brown-out protection• Disconnect switch• Burglar bars in return and/or supply air• All double wall construction• Drain Pan – Stainless Steel• Horizontal supply and return air curb• Unit available with R-410A refrigerant
Technical DataUnit Size Model EER RatingNominal Capacity in Tons Gas MBh Input Electric kW Length (HW*) Width Height
A 78.0 (118.0)3 sizes to 180 Up to 40 75.0 35.4
2.33.04.25.16.77.9
12.812.811.411.810.410.3
* Length with AAONAIRE® energy recovery wheel.NOTE: 2 to 5 ton models are SEER rated.
020304050607
B 78.0 (118.0)3 sizes to 390 Up to 60 87.0 43.4
8.410.513.214.4
11.211.010.810.6
08101315
C 105.8 (154.1)3 sizes to 480 Up to 100 98.9 59.5
15.417.819.824.926.0
12.211.711.510.4 9.5
1618202530
All components individually labeled for quick identification
Color-coded wiring diagram permanently laminated inside door
Door Stay Rods
Access to controls and compressors while unit operates
Hassle-Free filterreplacement
Gear driven economizer
Slide out fanassembly for
belt and motor service
Sloped drain pan
Double wall access doors
Easy access to heating section for service
RM Series Dimensions in Inches
Exclusive AAON® slide out blower assemblyprovides easy access and service loop.
Optional AAONAIRE® energy recovery wheelenhances IAQ and reduces power consumption.
©Copyright 2004. AAON, Inc.
S E R I E SAccessible, Dependable and Expandable
VERTICAL DISCHARGE 2 to 30 Tons
The AAON® manufactured gas heat exchangertubes have an exclusive patented “dimple” toassure maximum heat transfer.
34348 RMRN.qxd 9/21/06 4:29 PM Page 2
Slide out filter service
Gear driveeconomizer
Door Stay Rods
Compressors and controls in separate compartment
Direct drive condenser fansAll components labeled
Wiring diagram color-coded
Electric or Gas Heat area access door
Dual action zinc cast
lockable handles
Rubber isolationmounts
Direct drive blower(s)with backward-inclinedplenum fan
Highly accessiblecoil service area
Accessible, Dependable and Expandable
S E R I E SVERTICAL DISCHARGE 26 to 70 Tons
Technical DataUnit Size Model EER RatingNominal Capacity in Tons Gas MBh Input Electric kW Length (HW*) Width Height
D 155.0 (203.5)2 sizes to 780 4 to 240 101.8 96.626 to 70
12.011.710.510.810.19.4
* Length with AAONAIRE® energy recovery wheel.
263140506070
RN Series Dimensions in Inches
Horizontal Airflow CurbAvailable on All Models
Standard Features• All cabinet walls, roof and floor shall be a high perform-
ance composite panel constructed with G90 galvanizedsteel on both sides and a closed cell polyurethane foaminterior core providing a rigid, impact resistant surface.All panels have a thermal break with no metal contactfrom inside to outside.• the walls and roof of the conditioned air compart-
ments shall be 2 inches thick with a minimum R valueof 12.5. The roof of the conditioned air compartmentsshall be sloped at a minimum of 1/4 inch per foot
• the floor of the conditioned air and control compart-ments shall be 1 inch thick with a minimum R valueof 6.25
• Access doors with stainless hinges and zinc cast lockable handles
• Drain pan – Stainless Steel• Compressors and unit controls contained within
single isolated compartment• Scroll compressors installed on sheet metal
deck with rubber isolation mounts for quiet efficient operation
• Direct drive blower plenum fan(s)• Blower motor(s) installed on rubber isolation
mounts for quiet efficient operation• Direct drive condenser fan(s)• Bottom access return and supply air• Roof sloped for proper drainage
• Single point power connection• Thermostatic expansion valves on DX coils• Manual reset high pressure cutoff• Automatic reset low pressure cutoff• Run test report, wiring diagram, installation manual
and startup form in control access compartment• Gray polyurethane paint coating which passes
2000 hour salt spray test
Optional Features• Power return with axial fan and economizer• Power exhaust with axial fan and economizer• Power exhaust with plenum fan, economizer and
AAONAIRE® energy recovery wheel• Economizer and empty heat wheel section• Power exhaust with plenum fan, economizer and
empty heat wheel section• Gas heat exchanger - Stainless Steel• Blower motors may be oversized and/or high efficiency• Direct drive blower fan control with VFD or
AAON® banded wheel• Air filters with multiple options, efficiencies and
monitoring devices• GFI convenience outlet• Smoke detectors or firestats in return and/or supply air
Cutaway of panel wall showing thermal break and foam core.
• Humidity Control:• Hot Gas Reheat• Modulating Hot Gas Reheat• Return Air Bypass• Hot Gas Bypass
• Compressor isolation valves• Phase and brown-out protection• Disconnect switch• Burglar bars in return and/or supply air• Horizontal supply and return air curb• Interior metal panels are available as
stainless steel• Unit available with R-410A refrigerant
34348 RMRN.qxd 9/21/06 4:29 PM Page 3
2425 South Yukon AvenueTulsa, OK 74107
918-583-2266Fax 918-583-6094
www.aaon.com
It is the intent of AAON to provide accurate up-to-date specification data. However, in the interest ofongoing product improvement, AAON, Inc. reserves the right to change specifications and/or design of any product without notice, obligation, or liability.
AAON and AAONAIRE are registered trademarks of AAON, Inc. All other trademarks and registered trademarks are the property of their respective owners.
AAON products are covered by one or more of the following U. S. Patents:5,738,167; 5,826,641; 5,839,505; 6,715,312The Name To Remember.
Packaged Rooftop Air Handlers
RM 2-30 TonStandard Features2 to 30 ton air handlers share the same cabinet platform and features as the RMproduct line.
Optional Features• Economizer for full modulating or
3-position outside air• Power exhaust with forward curve fan• Power exhaust with forward curve fan
and economizer• Power exhaust with AAONAIRE® energy
recovery and plenum fan• Humidity Control:
• Hot Gas Reheat• Modulating Hot Gas Reheat• Return Air Bypass• Hot Gas Bypass
• Blower motors may be oversized and/orhigh efficiency
• Blower fan with VFD volume control• Air filters with multiple options and/or
monitoring devices• Smoke detectors or firestats in return
and/or supply air• Phase and brown-out protection• Disconnect switch• Burglar bars in return and/or supply air• All double wall construction• Drain Pan – Stainless Steel• Horizontal supply and return air curb• Unit available with R-410A refrigerant
Technical DataUnitSize Model
Nominal CFM Length (HW*) Width Height
A 78.0 (118.0) 56.5 35.4
8001,2001,6002,0002,4002,800
* Length with AAONAIRE® energy recovery wheel.
020304050607
B 78.0 (118.0) 60.3 43.4
3,2004,0005,2006,000
08101315
C 99.3 (148.3) 62.5 55.0
6,4007,2008,000
10,00012,000
1618202530
D 155.0 (203.5) 101.8 66.1
10,40012,40016,40020,00024,00028,000
263140506070
RN 26-70 TonStandard Features26 to 70 ton air handlers share the same cabinet platform and features as the RN product line.
Optional Features• Economizer for full modulating or
3-position outside air• Economizer, empty heat wheel section• Economizer, empty heat wheel section,
plenum fan power exhaust• Economizer, axial fan power exhaust• Economizer, axial fan power return• Economizer, AAONAIRE® energy
recovery, plenum fan power exhaust• Humidity Control:
• Hot Gas Reheat• Modulating Hot Gas Reheat• Return Air Bypass• Hot Gas Bypass
• Blower motors may be oversized and/or high efficiency
• Blower Fan with VFD volume control• Air filters with multiple options and/or
monitoring devices• Smoke detectors or firestats in return
and/or supply air• Phase and brown-out protection• Disconnect switch• Burglar bars in return and/or supply air• Drain pan – Stainless Steel• Horizontal supply and return air curb• Interior metal panels are available as
stainless steel• Unit available with R-410A refrigerant
Horizontal Airflow Curb Available on All Models
VERTICAL DISCHARGE 800 to 28,000 Nominal CFM
Dimensions in Inches
Rev. 2 03/06 • R 42960
34348 RMRN.qxd 9/21/06 4:29 PM Page 4