the european commission’s science and knowledge service · • low idle, “high idle” (~2000...
TRANSCRIPT
![Page 1: The European Commission’s science and knowledge service · • Low idle, “high idle” (~2000 rpm) • Evaluation of plausible pass/fail limit • Limit should not be more stringent](https://reader034.vdocuments.mx/reader034/viewer/2022052011/602743723c521866c6369163/html5/thumbnails/1.jpg)
The European Commission’s scienceand knowledge service
Joint Research Centre
![Page 2: The European Commission’s science and knowledge service · • Low idle, “high idle” (~2000 rpm) • Evaluation of plausible pass/fail limit • Limit should not be more stringent](https://reader034.vdocuments.mx/reader034/viewer/2022052011/602743723c521866c6369163/html5/thumbnails/2.jpg)
Verification of NPTI-Instruments for Diesel and Petrol Vehicles – first results
R. Suarez-Bertoa, T. Lahde and B. Giechaskiel
Sustainable Transport Unit, Energy Transport & Climate
June 21st 2018, ETH-Zurich, Switzerland
![Page 3: The European Commission’s science and knowledge service · • Low idle, “high idle” (~2000 rpm) • Evaluation of plausible pass/fail limit • Limit should not be more stringent](https://reader034.vdocuments.mx/reader034/viewer/2022052011/602743723c521866c6369163/html5/thumbnails/3.jpg)
Overview
• Since the introduction of Euro 5b standards
diesel passenger cars must present PN emissions
< 6x1011 #/km when tested on the duty cycle.
• The PN limit was achieved using DPFs
![Page 4: The European Commission’s science and knowledge service · • Low idle, “high idle” (~2000 rpm) • Evaluation of plausible pass/fail limit • Limit should not be more stringent](https://reader034.vdocuments.mx/reader034/viewer/2022052011/602743723c521866c6369163/html5/thumbnails/4.jpg)
Overview - The issue - Part I
• Recent studies conducted in The Netherlands,
Switzerland and Belgium have shown that
~10% of DPF-equipped passenger cars:
• present a damaged DPF or
• DPF has been removed.
![Page 5: The European Commission’s science and knowledge service · • Low idle, “high idle” (~2000 rpm) • Evaluation of plausible pass/fail limit • Limit should not be more stringent](https://reader034.vdocuments.mx/reader034/viewer/2022052011/602743723c521866c6369163/html5/thumbnails/5.jpg)
Overview – Current method
• Opacity is used to evaluate compression ignition engine emissions during Periodic Technical Inspection - PTI (Directive 2014/45/EC; Reg. 24).
• Opacimeter: instrument for continuous measurement of the light absorption coefficients of the exhaust gases emitted by vehicles
![Page 6: The European Commission’s science and knowledge service · • Low idle, “high idle” (~2000 rpm) • Evaluation of plausible pass/fail limit • Limit should not be more stringent](https://reader034.vdocuments.mx/reader034/viewer/2022052011/602743723c521866c6369163/html5/thumbnails/6.jpg)
Overview - The issue - Part II
TNO 2017 R10530 | 1.0
Investigation into a Periodic Technical Inspection (PTI) test method to check for presence and proper functioning of Diesel Particulate Filters in light-duty diesel vehicles – part 2
Studies have shown that opacity fails to detect DPF damage or DPF removal.
![Page 7: The European Commission’s science and knowledge service · • Low idle, “high idle” (~2000 rpm) • Evaluation of plausible pass/fail limit • Limit should not be more stringent](https://reader034.vdocuments.mx/reader034/viewer/2022052011/602743723c521866c6369163/html5/thumbnails/7.jpg)
Evaluation of an alternative procedure
• PN measurement• Instruments performance
• Engine operation• Low idle, “high idle” (~2000 rpm)
• Evaluation of plausible pass/fail limit • Limit should not be more stringent than type-
approval (6x1011 #/km)
![Page 8: The European Commission’s science and knowledge service · • Low idle, “high idle” (~2000 rpm) • Evaluation of plausible pass/fail limit • Limit should not be more stringent](https://reader034.vdocuments.mx/reader034/viewer/2022052011/602743723c521866c6369163/html5/thumbnails/8.jpg)
Vehicle and test sequence - 1st campaign
• Euro 6b diesel vehicle (DPF-equipped) – Vehicle 1• Partial bypass
• Tested using WLTP
• Low idle measurements• Ambient air (60’’), followed by raw exhaust at low idle (60’’)
• High idle (2000 rpm) measurements• Raw exhaust at low idle (60’’), follow by high idle (60’’)
![Page 9: The European Commission’s science and knowledge service · • Low idle, “high idle” (~2000 rpm) • Evaluation of plausible pass/fail limit • Limit should not be more stringent](https://reader034.vdocuments.mx/reader034/viewer/2022052011/602743723c521866c6369163/html5/thumbnails/9.jpg)
Instruments used during 1st campaign
• Modified TSI 3795 (NPET for PEMS) Dil+CS+CPC• Testo PEPA Dil+DC• TSI p-Track CPC• Naneos Partector DC• Naneos Automotive Partector DC
![Page 10: The European Commission’s science and knowledge service · • Low idle, “high idle” (~2000 rpm) • Evaluation of plausible pass/fail limit • Limit should not be more stringent](https://reader034.vdocuments.mx/reader034/viewer/2022052011/602743723c521866c6369163/html5/thumbnails/10.jpg)
Raw emissions – Vehicle 1- No bypass
Ambient Air Ambient Air Ambient Air
Raw exhst. Raw exhst.
![Page 11: The European Commission’s science and knowledge service · • Low idle, “high idle” (~2000 rpm) • Evaluation of plausible pass/fail limit • Limit should not be more stringent](https://reader034.vdocuments.mx/reader034/viewer/2022052011/602743723c521866c6369163/html5/thumbnails/11.jpg)
Low idle- Bypass opened
Ambient Air Amb. Air
Raw – low idle
![Page 12: The European Commission’s science and knowledge service · • Low idle, “high idle” (~2000 rpm) • Evaluation of plausible pass/fail limit • Limit should not be more stringent](https://reader034.vdocuments.mx/reader034/viewer/2022052011/602743723c521866c6369163/html5/thumbnails/12.jpg)
Emission factors vs low idle concentration–Vehicle 1
Different levels of partial bypass resulted Emission Factors during the WLTP:
• No bypass EF 2-8x 109 #/km• Near Euro 6 limit 5-7x 1011 #/km• Wide opened 2-4x 1012 #/km
![Page 13: The European Commission’s science and knowledge service · • Low idle, “high idle” (~2000 rpm) • Evaluation of plausible pass/fail limit • Limit should not be more stringent](https://reader034.vdocuments.mx/reader034/viewer/2022052011/602743723c521866c6369163/html5/thumbnails/13.jpg)
Vehicle 2- Euro 6b diesel
Low idle
Amb.Air
Amb.Air
Low idle
High idle
Low idle
Low idle
Amb.Air
Low idle
Amb.Air
Lowidle
Lowidle
Both PN-PEMS
![Page 14: The European Commission’s science and knowledge service · • Low idle, “high idle” (~2000 rpm) • Evaluation of plausible pass/fail limit • Limit should not be more stringent](https://reader034.vdocuments.mx/reader034/viewer/2022052011/602743723c521866c6369163/html5/thumbnails/14.jpg)
Emission factor vs low idle concentration
![Page 15: The European Commission’s science and knowledge service · • Low idle, “high idle” (~2000 rpm) • Evaluation of plausible pass/fail limit • Limit should not be more stringent](https://reader034.vdocuments.mx/reader034/viewer/2022052011/602743723c521866c6369163/html5/thumbnails/15.jpg)
Emission factor vs low idle concentration
TNO 2017 R10530 | 1.0
Investigation into a Periodic Technical Inspection (PTI) test method to check for presence and proper functioning of Diesel Particulate Filters in light-duty diesel vehicles – part 2
![Page 16: The European Commission’s science and knowledge service · • Low idle, “high idle” (~2000 rpm) • Evaluation of plausible pass/fail limit • Limit should not be more stringent](https://reader034.vdocuments.mx/reader034/viewer/2022052011/602743723c521866c6369163/html5/thumbnails/16.jpg)
Instruments used - Campaign II
• PMP >23nm and >3nm Hot dil + ET + CPC• Mod. NPET – TSI/HORIBA Dil + CS + CPC• NM3 – Testo Hot dil +ET + DC• PEPA - Testo Dil + DC• PN-PTI-Prot. – TSI CPC• APA-Prot. – Sensors CPC• METAS – Naneos DC• 2x Naneos Partector DC• CZ-Uni-Prot Ionization chamber
![Page 17: The European Commission’s science and knowledge service · • Low idle, “high idle” (~2000 rpm) • Evaluation of plausible pass/fail limit • Limit should not be more stringent](https://reader034.vdocuments.mx/reader034/viewer/2022052011/602743723c521866c6369163/html5/thumbnails/17.jpg)
Second campaign – Vehicles tested
• Vehicle 1 - Diesel Euro 6b with and w/o a partial bypass
• Vehicle 2 - Diesel Euro 6b
• Vehicle 3 - Gasoline GDI Euro 6c– GPF equipped
• Vehicle 4 - Gasoline GDI Euro 6b
![Page 18: The European Commission’s science and knowledge service · • Low idle, “high idle” (~2000 rpm) • Evaluation of plausible pass/fail limit • Limit should not be more stringent](https://reader034.vdocuments.mx/reader034/viewer/2022052011/602743723c521866c6369163/html5/thumbnails/18.jpg)
Test sequence
• Low idle• Ambient air (30’’), followed by raw exhaust at low idle (30’’)
• High idle - 2000 rpm• Raw exhaust at low idle (30’’), follow by high idle (30’’ at
2000 rpm)
![Page 19: The European Commission’s science and knowledge service · • Low idle, “high idle” (~2000 rpm) • Evaluation of plausible pass/fail limit • Limit should not be more stringent](https://reader034.vdocuments.mx/reader034/viewer/2022052011/602743723c521866c6369163/html5/thumbnails/19.jpg)
Emission profile during test sequence – Veh.1
No bypass Bypass opened
High idle
Low idle
Low idle
EGR shut-off
![Page 20: The European Commission’s science and knowledge service · • Low idle, “high idle” (~2000 rpm) • Evaluation of plausible pass/fail limit • Limit should not be more stringent](https://reader034.vdocuments.mx/reader034/viewer/2022052011/602743723c521866c6369163/html5/thumbnails/20.jpg)
Emission profile GDI during test sequence
• Engine hot but exhaust emissions not stable
• Highly variability over time
• Very high PN emissions• GPF-equipped >100 # cm-3
![Page 21: The European Commission’s science and knowledge service · • Low idle, “high idle” (~2000 rpm) • Evaluation of plausible pass/fail limit • Limit should not be more stringent](https://reader034.vdocuments.mx/reader034/viewer/2022052011/602743723c521866c6369163/html5/thumbnails/21.jpg)
Low idle concentrations measured
• Test1 - Test4 Vehicle 1• Test 1 no bypass• Test 2-3 valve fully opened• Test 4 valve partially opened
• Test 5 Vehicle 2• Test 6 Vehicle 3 (GDI with GPF)• Test 7 Vehicle 4 (GDI)
![Page 22: The European Commission’s science and knowledge service · • Low idle, “high idle” (~2000 rpm) • Evaluation of plausible pass/fail limit • Limit should not be more stringent](https://reader034.vdocuments.mx/reader034/viewer/2022052011/602743723c521866c6369163/html5/thumbnails/22.jpg)
PMP vs ax R2
NPET 1.23 0.99NM3 1.55 0.98METAS 1.64 0.99PEPA 1.77 0.96APA 2.06 0.95TSI 11.1 0.99
Instruments vs PMP (Diesel vehicles)
![Page 23: The European Commission’s science and knowledge service · • Low idle, “high idle” (~2000 rpm) • Evaluation of plausible pass/fail limit • Limit should not be more stringent](https://reader034.vdocuments.mx/reader034/viewer/2022052011/602743723c521866c6369163/html5/thumbnails/23.jpg)
PMP >23nm and >3nm
• High concentration of small solid particles• Diesel vehicle stable over time. GDI highly variable
Vehicle 2- Diesel Vehicle 4 - GDI
![Page 24: The European Commission’s science and knowledge service · • Low idle, “high idle” (~2000 rpm) • Evaluation of plausible pass/fail limit • Limit should not be more stringent](https://reader034.vdocuments.mx/reader034/viewer/2022052011/602743723c521866c6369163/html5/thumbnails/24.jpg)
Lessons learned and Next steps
• Low idle measurement appear to be suitable to detect DPF failures• Should measurements be performed when EGR is active?
• Instruments should avoid measuring volatile fraction.• Cutting size must be defined. Reasonable cut 23nm?
• More data is needed to be able to provide a general pass/fail limit for diesel vehicles.
• Petrol vehicles need to be studied further.
![Page 25: The European Commission’s science and knowledge service · • Low idle, “high idle” (~2000 rpm) • Evaluation of plausible pass/fail limit • Limit should not be more stringent](https://reader034.vdocuments.mx/reader034/viewer/2022052011/602743723c521866c6369163/html5/thumbnails/25.jpg)
Thank youAny questions?You can find me [email protected]
![Page 26: The European Commission’s science and knowledge service · • Low idle, “high idle” (~2000 rpm) • Evaluation of plausible pass/fail limit • Limit should not be more stringent](https://reader034.vdocuments.mx/reader034/viewer/2022052011/602743723c521866c6369163/html5/thumbnails/26.jpg)
High idle- Bypass opened
Low idle
High idle High idle
Low idle
![Page 27: The European Commission’s science and knowledge service · • Low idle, “high idle” (~2000 rpm) • Evaluation of plausible pass/fail limit • Limit should not be more stringent](https://reader034.vdocuments.mx/reader034/viewer/2022052011/602743723c521866c6369163/html5/thumbnails/27.jpg)
Low idle concentrations measured
• Test1 - Test4 Vehicle 1• Test 1 no bypass• Test 2-3 valve fully opened• Test 4 valve partially opened
• Test 5 Vehicle 2
• Test 6 Vehicle 3 (GDI with GPF)
• Test 7 Vehicle 4 (GDI)
![Page 28: The European Commission’s science and knowledge service · • Low idle, “high idle” (~2000 rpm) • Evaluation of plausible pass/fail limit • Limit should not be more stringent](https://reader034.vdocuments.mx/reader034/viewer/2022052011/602743723c521866c6369163/html5/thumbnails/28.jpg)
EEPS measurements of Vehicle 4 - GDI
• GMD ~30nm
• More than 60% were solid sub-23 nm
• Very important to define the cutting size of the instruments that could be use during PTI of diesel and petrol vehicles.