space shuftlt~ progran
TRANSCRIPT
Space,I
Shuftlt"~ ProgranMSC-03321
0 CD N2''O t, It* toLS o ~,.~rt rt C W
Ln t.,-
P) HPo t%.)C.4 U) Z 10 OD
ID F W C
'J Lfl HN
I-'.H i*~
i (n ::t 3 tid
./ 0 Ot
t- b .7/2 S
t tti t, n
;,, ~ ~ tC: ab
*= to tv
, k - H F
i- t, 2
;~ Wl P tvttC
' 0 tv ' 0z3C) f H. 0 t0
PT' =,
) JC o D I
FH C)
-i
!'
CcU
I[O_
· '--J
I -Phase B Final Report Expendable Second Stage .
Reusable Space Shuttle Booster.,-.Volume VII. Preliminary Design Drawings"
n Cz z
D H Ifi AEn
mm \
1(
r it
0wm
rmM
NM5
-
Contract NAS9-10960, Exhibit BDRL MSFC-DRL-221, DRL Line Itemi 6
DRD MA-078-U2SD 71-140-725 June 1971
Reproduced by
PRICES NATIONAL TECHNICAL .SUBJECT W CANGE INFORMATION SERVICE US Department of Commerce .
Springfield, VA. 22151
SpaceDivision * NorthAmericanRockwell 12214 Lakewood Boue",Downey, Cafornia 9
I
SD 71-140-7(MSC-03321)
25 June 1971
PHASE B FINAL REPORTEXPENDABLE SECOND STAGE
REUSABLE SPACE SHUTTLE BOOSTER
Volume VIIPreliminary Design Drawings
Contract NAS9-10960, Exhibit BDRL MSFC -DRL-221, DRL Line Item 6
DRD MA-078-U2
Approved by
\ [ JF B. HelloVice President and General Manager
Space Shuttle Program
Space Division . North American Rockwell 12214 LAKEWOOD BOULEVARD * DOWNEY. CALIFORNIA 90241
i
/ =
o
0FOREWORD
The Space Shuttle Phase B studies are directed toward the definitionof an economical space transportation system. In addition to the missionswhich can be satisfied with the shuttle payload capability, the NationalAeronautics and Space Administration has missions planned.that requirespace vehicles to place payloads in excess of 100,000 pounds in earth orbit.To satisfy this requirement, a cost-effective multimission space shuttlesystem with large lift capability is needed. Such a system would utilize areusable shuttle booster and an expendable second stage. The expendablesecond stage would be complementary to the space shuttle system andimpose minimum impact on the reusable booster.
To assist the expendable second stage concept, a two-phase studywas authorized by NASA. Phase A efforts, which ended in December 1970,concentrated on performance, configuration, and basic aerodynamic con-siderations. Basic trade studies were carried out on a relatively largenumber of configurations. At the conclusion of Phase A, the contractorproposed a single configuration. Phase B commenced on February 1, 1971(per Technical Directive Number 503) based on the recommended system.Whereas a large number of payload configurations were considered in theinitial phase, Phase B was begun with specific emphasis placed on threerepresentative payload configurations. The entire Phase B activity has beendirected toward handling the three representative payload configurations inthe mostacceptable manner. Results of this activity are reported in this12-volume Phase B final report.
Executive SummaryTechnical SummaryWind Tunnel Test DataDetail Mass Properties DataOperations and ResourcesInterface Control DrawingsPreliminary Design DrawingsPreliminary CEI Specification - Part 1Preliminary System SpecificationTechnology RequirementsCost and Schedule EstimatesDesign Data Book
SD 71-140-1SD 71-140-2SD 71-140-3SD 71-140-4SD 71-140-5SD 71-140-6SD 71-140-7SD 71-140-8SD 7I-140-9SD 71-140-10SD 71-140-11SD 71-140-12
This document is Volume VII, Preliminary Design Drawings.
- iii -
SD 71-140-7
C.
VolumeVolumeVolumeVolumeVolumeVolumeVolumeVolumeVolumeVolumeVolumeVolume
IIIIIIIVVVIVIIVIIIIXXXIXII
0CONTENTS
Section Page
1.0 INTRODUCTION I... 11. 1 System Concept . . . . 11.2 Selected Vehicles . . . . . . 1
2.0 DRAWING CONTENT AND DRAWING NUMBER SYSTEM 42. 1 Drawing Content . . . . . . . 42. 2 Drawing Number System . . . . . . 4
3.0 MATED CONFIGURATIONS . . . 11
4.0 EXPENDABLE SECOND STAGE (ESS-MODIFIED S-Il) . . 15
5.0 BOOSTER . . . . . . . . . . . 57
6.0 OPERATIONS 67
7.0 APPENDIX A. ALTERNATE ESS/BOOSTER CONFIGURATION(EXTERNAL HYDROGEN TANK STUDY) . . . 80
8.0 APPENDIX B. ALTERNATE ESS CONFIGURATION 82
9.0 APPENDIX C. TRADE STUDY REFERENCE DRAWINGS 84
- iv -
SD 71-140-7
0
ILLUSTRATIONS
ESS Study Engineering Drawing Assignment
S080-0001S080-0002S080-0003V080-0001V080-1000V080-1001V080-1002V080-1003V080-1006V080-1007V080-1008
V080-2000V080-Z001V080-2002V080-2003V080-2004V080-2005V080-2006V080-2008V080-2009V080-2010
V080-3000V080-3001V080-7002VX80-001376Z014076Z024076Z024176Z024376Z114076Z1149
B-9U/ESS/RNS Mated Configuration (3-View)B-9U/ESS/Space Station Mated Configuration (3-View)B-9U/ESS/Space Tug Mated Configuration (3-View) .ESS Inboard Profile, Subsystem ArrangementESS Space Allotment, General ArrangementESS Forward Skirt Structure DiagramESS Aft Skirt Structure Diagram . .ESS Thrust Cone Structure Diagram .
ESS Heat Shield Base-Main Engines .
ESS Thermal Protection Subsystem-StructureESS Docking Provision-ESS/SS Orbiter ConfigurationESS Main Propulsion System SchematicESS Propellant Feed Subsystem LayoutESS OMS and APS Tankage Fuel Lines LayoutESS Attitude Control Propulsion Subsystem InstallationESS Engine Servicing Subsystem LayoutESS Pressurization Subsystem ..
ESS Engine Compartment Conditioning System .ESS Auxiliary Propulsion Subsystem SchematicESS Thrust Vector Control Layout . .
ESS Stage/Engine Connect Panel Layout-RecoverableEngine ....
ESS Avionics Subsystem Block Diagram .
ESS Avionics Containers InstallationESS/Payload Separation Subsystem . .
ESS/Payload Adapter-ESS/Space Tug ConfigurationBasic Configuration-B-9U Booster .
Inboard Profile-B-9U BoosterLines and Geometry-B-9U Booster ..
B-9U Booster (3-View) .. .
Basic Configuration-ESS/B-9U BoosterBody Structural Arrangement-ESS Modified
- V_
SD 71-140-7
Figure
2-1
I Drawing
Page
7
1213141617181920212223242527293031444546
4753545556585960616263
0Drawing
76Z122376Z 122576Z 1226S080-5002
VA70-3201
VA70-5510
VA70-5530
VA70 -5540
VA70-5602
76Z 140076Z 140276Z 1403
76Z 140476Z 140576Z1261V080-1009S080-5001
S080-5003V080-0002V080-1004V080-1005V080-700176Z0253
S080-0004V080-0003GD Sketch
Page
Booster/ESS Fixed-Platform Separation System . . 64
Booster/ESS Movable-Platform Separation System . . 65Booster/ESS Tension Links Separation System . . 66ESS Recoverable Hardware-Horizontal/Vertical
Engine Orientation . . . . . . . . 68Midbody Structural Arrangement for Space Shuttle
Orbiter-Configuration 161C . . . . . 69Manipulator Installation for Space Shuttle Orbiter-
Configuration 161C . . . . . . . 71Payload Retention System for Space Shuttle Orbiter-
Configuration 161C (A) . . . . . . . . 72Cargo Transfer Tunnel Installation for Space Shuttle
Orbiter-Configuration 161C . . . . . . 73
Deployment Mechanism Installation for Air-BreathingEngine System . . .. . . . . 74
KSC Maintenance and Checkout Hangar, Floor Plan . 75KSC Maintenance and Checkout Hangar, Sections/Views . 76KSC Maintenance and Checkout Hangar, VAB Mating
Bay . . . . . . . . . . . 77KSC Launch Pads 39A and 39B, Plan . . . . 78KSC Launch Pads 39A and 39B, Plan 4 Section Views . 79Basic Configuration-ESS/B-17E Booster . . . . 81ESS Single Space Shuttle Orbiter, General Arrangement . 83Umbilical Arm Effects-Angular-Positioned ESS/Space
Shuttle Booster . . . . . . . . 85ESS/Booster Belly to Tower-Launch Configuration. . 86ESS Inboard Profile-w-PhaSe B Baseline . . . . 88
ESS Interbody Fairing-ESS/Booster Attachment . . 89
ESS Separable Aft Skirt Alternate Concept . . . 90
Platform Concept-ESS/Booster Separation . . 91ESS/Booster Fixed-Platform Separation SystemConcept . . . . . . . . . . . 92
B-9U/161C/ESS Mated Comparison .. 93
ESS Initial Phase B Baseline Configuration . . . 94
ESS/B-9U Booster Interface Concept . . . . . 95
- vi-
SD 71-140-7
1.0 INTRODUCTION
01.0 INTRODUCTION
1.1 SYSTEM CONCEPT
The prime objective of the Expendable Second Stage (ESS) study was todetermine the feasibility and cost-effectiveness of and to produce a preliminarydesign for a system suitable for a wide variety of advanced space missionsbeginning in the last half of 1979. The overall system is intended to meetevolving NASA/DOD system requirements through the most economical useof shuttle/ESS system elements.
The space shuttle orbiter's cargo bay is 15 feet in diameter and60 feet in length. Payloads larger than this bay can be accommodated byusing the ESS mounted on the reusable booster. In addition to the capabilityof placing large payloads in orbit, the expendable second stage constitutesan element of a larger shuttle mission. To reduce cost, it has been assumedthat a space shuttle orbiter will be available after it has completed itsprimary up-mission. By performing a rendezvous and docking maneuverwith the ESS, the orbiter could remove high-value components from the ESSby means of a manipulator arm arrangement on the orbiter. After thecomponents are placed in the cargo bay of the orbiter, the orbiter wouldreturn to the launch site. The recovered components would be refurbishedand made available for use in subsequent ESS flights. In this concept, theESS must have provisions for docking with the orbiter and means to facilitateremoval (minimum EVA) of the components. Following the removal of com-ponents, the ESS will deorbit to a safe impact area.
ESS preliminary design drawings are provided to illustrate thefeatures of this concept.
1.2 SELECTED VEHICLES
1. 2. 1 Expendable Second Stage Vehicle
Phase B activity on the expendable second stage has been directedtoward selecting a baseline system based on a derivative of the Saturn S-IIstage, shown on Drawing V080-0002, Zone 33, in Appendix C. The ESS isequipped with two space shuttle orbiter engines. The hydrogen tank volumeis reduced from the basic S-II stage by the deletion of one hydrogen ring(approximately 99 inches). Other features of the selected ESS include theuse of shuttle orbiter auxiliary propulsion system elements for the orbitmaneuvering system and the attitude control propulsion system. In addition,
-SD 71-140-7SD 71-140-7
0the design features the use of orbiter avionics elements. To preclude theneed for jettisoning hardware from the reusable booster at staging -toachieve an all-azimuth launch capability -the ESS incorporates a modifiedS-II aft skirt. The selected ESS vehicle is shown on NR Drawing No. V080-0001, Inboard Profile General Arrangement. The features mentioned hereare shown in the various preliminary design drawings included in thisvolume.
1. 2.2 B-9U Booster Vehicle
The Space Shuttle Phase B Study has resulted in the selection of areusable booster with a mission gross weight of approximately 4. 2 millionpounds. This booster (designated the GDC B-9U) features 12 engines, eachproducing 550,000 pounds of thrust at sea level. It is designed to launch anorbiter weighing approximately 859,000 pounds. Although a modified attach-ment system has been defined to accommodate the ESS, the system can beinstalled for an ESS flight and removed following the flight with only minimaleffect on the booster in terms of accommodating an orbiter launch.
The preliminary design drawings included in this volume emphasizebooster modifications that have been defined to permit the booster to launchboth the space shuttle orbiter and an expendable second stage with the threespecified payloads. Also included are preliminary design drawings thatreflect launch operations at KSC.
Complete details of the booster are included in SD 71-114-2(3),Booster Vehicle Definition. In addition to the information referenced above,this volume contains the following basic drawings: B-9U Booster InboardProfile (General Dynamics Drawing No. 76Z0240), Booster Lines (GDDrawing No. 76Z0Z41), and Booster 3-View (GD Drawing No. 76Z0243).The B-9U/ESS Booster Basic Configuration is shown on General DynamicsDrawing No. 76Z1140.
1.2.3 Specified Payloads
The Phase B design activity has been oriented to accommodate threeNASA-specified payload configurations, which cover the spectrum (weightand size envelope) of anticipated payloads. Payload variables include weight,size, and shape.
1.2.3.1 ESS/Booster /Space Station
The heaviest of the three payloads is the MDAC space station, whichweighs 176,960 pounds. The mated configuration is shown on NR DrawingNo. S080-0002.
-2
SD 71-140-7
01.2.3.2 ESS/Booster/RNS
The largest aerodynamic shape and the lightest payload are combinedin the NR reusable nuclear stage (RNS) without engine. The RNS weighs83,000 pounds. The mated configuration of the ESS/booster/RNS is shownon NR Drawing S080-0001.
1.2.3.3 ESS/Booster/Space Tug
The smallest aerodynamic shape and medium-weight payload is theNR space tug, with a designated weight of 107,180 pounds. However, sincethe payload is less than 33 feet in diameter (diameter of ESS vehicle), itrequires an adapter between the payload (15-foot diamneter) and the ESS.
A potential shape is shown on NR Drawing No. VX80-0013. The matedconfiguration for the ESS/booster/space tug is shown on NR Drawing
No. S080-0003.
- 3 -
SD 71-140-7
rlo
bZ 0
2.0 DRAWING CONTENT AND DRAWING NUMBER SYSTEM m z
"OD- Z.,
-<
-- It
m~r-i
02.0 DRAWING CONTENT AND DRAWING NUMBER SYSTEM
2.1 DRAWING CONTENT
The preliminary design drawings in this volume clearly identify thepayloads for each of the combinations shown. Also, the physical propertiesof the three payloads are indicated in the three mated-configuration prelim-inary design drawings. The main body of this volume contains preliminarydesign drawings of the selected system; several alternate configurationsare shown in the Appendixes. The selected expendable second stage isshown with the booster selected for the Orbiter External Hydrogen Tankstudy (the selected ESS is shown with an alternate main engine arrangement).In addition, the selected ESS (with one shuttle orbiter engine) is shown incombination with the baseline B-9U booster.
2. 2 DRAWING NUMBER SYSTEM
The following drawing number system was used in the ExpendableSecond Stage study for all drawings submitted with the final report. Forthis study, the basic 080 designation was used.
The Phase B drawings, except those of General Dynamics, are sub-mitted for the selected configuration with the drawing prefix and groupnumber, as shown below:
X80 -XXXX
T --- ~Group Number
Prefix Number
2.2.1 Drawing Prefix Usage
The following prefixes are applicable:
V080 - Expendable Second Stage (ESS) Vehicle Drawings
FS80 - ESS Field-Installed Support Equipment Drawings
G080 - ESS Support Equipment Drawings
-4 -SD 71-140-7
0M080 - ESS Manufacturing Drawings
R080 - ESS Model and Mockup Drawings
S080 - ESS Combined-Vehicle Drawings
VX81 - ESS Payload Drawings
2.2.2 Group Number Usage
A four-digit group number is ued, with the first digit designating thevarious functional activities and the remaining digits assigned sequentially.
XXXX
~~~~T ~Sequential Number
Function Designation (seeParagraph 2.2.3)
2. 2.3 Function Designation Usage
The functions are designated as follows:
Function No. Function Name
0XXX General
Structure
Propulsion
Avioni c s
Vehicle Support
Mechanical
Examples
Configuration Control,3 -View
Thrust Structure,Forward Skirt
OMS, ACPS
Avionics GeneralArrangement
Electric and HydraulicPower
Separation Mechanism
-5-
SD 71-140-7
1 XXX
2XXX
3XXX
4XXX
5XXX
02.2.4 Drawing Control
Except those for Manufacturing, all drawings were monitored,approved, controlled, and maintained by the Structure and Mechanismsgroup. These responsibilities included the following:
1. Assignment of all drawing numbers for drawings to be includedin the final report.
2. Approval of all drawings before distribution.
3. Preparation and maintenance of a drawing list that identifies alldrawings applicable to each prefix (including General Dynamicsdrawings).
4. Maintenance of a program file of all drawings and revisions(including General Dynamics drawings).
2. 2. 5 General Dynamics Drawings
General Dynamics drawings applicable only to the ESS program wereprepared in accordance with the General Dynamics format, using a specificprefix to indicate the ESS usage - i. e. , space shuttle drawings are76Z0XXX and ESS drawings are 76ZlXXX.
General Dynamics drawings include the ESS separation system,booster, and launch facility modifications. Other related General Dynamicsbooster drawings are referenced to the NR report SD-71-128-Z, DesignEvaluation Drawings for a Space Shuttle System, Volume II, Booster.
2. 2. 6 ESS/WBS Numbers Relationship
Figure 2-1, ESS Study Engineering Drawing Assignment, shows therelationship of the preliminary design drawing numbering system to theWBS numbering system.
2. 2. 7 ESS Vehicle Drawing Numbers
Following is the list of ESS vehicle drawing numbers for the selectedsystem. A complete list of drawings is presented in the front of thisvolume under Illustrations.
Number Description
S080-0001 ESS/B-9U/RNS-3-View Mated Configuration
-6-SD 71-140-7
0 w
NU)
r>4 < < N
0Z °- Cd cor
rn
0
Itr
W
a-i
nH
I
_ _~~~~1
0
Ci)
~-4 rn _
U)
I) rn °0 .. O
| M
| -O <
1. x
z
0
O a
rn 1
E1-
0p4
U2U)
It
0)
LO
-c
-4
000
000
z I
0 a
to
I
L
.-4
O0< F, %-
¢ H' I
Z -4~0 %
O U)_
,: rn0 rg rln
C,1
Cn as
. R 8r
C.)
S Hrn I _u U)0 HZ rn
rn
-S
U r )
Z >n.tor
-4
U)Pa4
rn
C'co
ON
P.I
0
000
U
<-0
U)0vo
)-4
0
Co
W 00
0 >
r)
s0°
09
U
0rnACL)
Lz00
W 0
w
p40-o
W I
rn>- rW -
%4:
0
4:-4c
4:
U
- r 0
I P r- 4
0 -44
toI-
0r-4
r-4
U) UW
| t D0V-4
0Co00I00
0 Wr rn
CU)
I -4
rEnC z~oWF- 0< K
H
-I
o-
H
o~
[.-,
0
:F--4Pz
0
R
0
az
C.)00'.4
0
0
0
0I0oO
,-400
010o0
rn0)Earn00:
9 D0r^) ~ -4
aO . O ,
N n gO 00m az 8 -
0 HO
bd 0 d
o
HO 0
P 0> I
.-~
I
IA
oW 'n0
0
o'ws O0
0)r-I
-14
!"to
,N o
I0
-0C0
-
r4-4
r-
U 0
Co
0
P) 0
pi _
Ez Mp. O
000
C.,'N
-
IW-
0
0
Co0,
3.i-C')
S-
-4
O:E O
gooco0
0wL.
It-
n
._J0O-LL
0s
W
rn
II-
t
I7-
_)
r.C)
bl,.<
U)
CL
onbl,
5 H
'-4
bfr.
4-)
th
[4
* CO
O o oO O oC.
r-4 C'. CO)0 0
0! I oo
00 00Co o Co
+ + +
0. 0) 0.U) U) a
rn tn rn
rn En rn
CO U)
LL
I-.On
0
-30LL
ZLC
La.g1OJ
i
. -~~~r
o0 1. ~0
C ) 8. w
~ w rn(D n
!:D)
rn
3 o_ r
0 rn r0
Description
S080-0002
S080-0003
S080-5002
V080-0001
V080-0001
V080-1000
V080-1001
V080-1002
V080-1003
V080-1006
V080-1007
V080-1008
V080-2000
V080-2001
ESS/B-9U/Space Station-3-View Mated
Configuration
ESS/B-9U /Space Tug-3-View Mated
Configuration
Expendable Second Stage Recoverable
Hardware -Horizontal/Vertical Engine
Orientation
Expendable Second Stage InboardProfile, General Arrangement
Expendable Second Stage Inboard
Profile, Phase B Baseline
Expendable Second Stage Space
Allotment, General Arrangement
Expendable Second Stage Forward SkirtStructure Diagram
Expendable Second Stage Aft SkirtStructure Diagram
Expendable Second Stage Thrust Cone
Structure Diagram
Expendable Second Stage Heat Shield
Base-Main Engines
Expendable Second Stage Thermal
Protection Subsystem-Structure
Expendable Second Stage Docking
Provision-ESS/SS Orbiter Configuration
Expendable Second Stage Main Propulsion
System Schematic
Expendable Second Stage Propellant Feed
Subsystem Layout
- 8 -SD 71-140-7
Numb e r
0
De s c ription
V080-2002
V080-2003
V080-2004
V080-2005
V080-2006
V080-2008
V080-2009
V080-Z2010
V080 -3000
V080-3001
VX80-0013
Expendable Second Stage Orbit Maneuver-ing System and APS Tankage Fuel LinesLayout
Expendable Second Stage Installation-Attitude Control Propulsion Subsystem
Expendable Second Stage EngineServicing Subsystem
Expendable Second Stage PressurizationSubsystem
Expendable Second Stage Engine Compart-ment Conditioning System
Expendable Second Stage Auxiliary Pro-pulsion Subsystem Schematic
Expendable Second Stage Thrust VectorControl Layout
Expendable Second Stage/Engine ConnectPanel-Recoverable Engine
Expendable Second Stage Avionics Sub-system Block Diagram
Expendable Second Stage AvionicsContainers Installation
Expendable Second Stage PayloadAdapter-ESS/Space Tug Configuration
- 9 -
SD 71-140-7
Numb e r
0
02. 2.8 S-II Applicable Drawing Numbers
Following is a list of S-II major assembly drawings which may be
used for the ESS vehicle without structural or functional revisions. Detail
drawing breakouts are not included but may be structured from the major
assemblies.
Number De s c ription
V7-316002 Systems Tunnel
(V7-332142 LH 2 Forward Bulkhead
V7-332242 LH 2 Cylinder No. 6
V7-332442 LH 2 Cylinder No. 4
V7-332542 LH 2 Cylinder No. 3
V7-332742 LH 2 Cylinder No. 1
V7-333102 Common Bulkhead
V7-333202 Aft LO 2 Bulkhead
V7-490004 LO2 Tank Vent
V7-490007 LH 2 Tank Vent
V7-480008 L0 2 and LH 2 Fill and Drain Lines
Drawings for the other major assemblies required are not included
because they entail structural or functional revisions to be compatible with
the ESS vehicle system.
- 10 -
SD 71-140-7
C-)3.0 MATED CONFIGURATIONS OzZGC
cq r-5zLA
03.0 MATED CONFIGURATIONS
- 11 -
SD 71-140-7
Page intentionally left blank
Page intentionally left blank
Page intentionally.left blank
xrn
z
4.0 EXPENDABLE SECOND STAGE (ESS-MODIFIED S-lI) is(Inrn
C(D
--4
0)I,
04.0 EXPENDABLE SECOND STAGE (ESS-MODIFIED S-Il)
- 15 -
SD 71-140-7
Page intentionally left blank
Page intentionally left blank
Page intentionally left blank
Page intentionally left blank
Page intentionally left blank
Page intentionally left blank
Page intentionally left blank
a
Page intentionally left blank
0OU
C)2J
:rC)~
.4
i
(,]
1-1I
Io
m V
-f4 4
YWA ' n
4 _
o >
, r
( b
m
C.
o o4 o
u I , z I ,'^ '^ - =- I
03 0 or 1 - Zc . ON _ -I
T Ut 3 f IEl
I i 5i
"4
!/2
I -
a T a a I.. , , =__,
Ij.
m0-i
0
kV%klk )
4,)r~
-C
I-r-
i:I,1
01
0-J0LL2
UO
A
t;g
9AS
7
.1.
uJ
(9(1)
uJLLI
ZU
<(1I-I >)
D F-
U') V)
C*.
U
r 0
aE.). C
.- mE
C) <U-
P. 0~Z®n(7
w
0z0 _
" fi
t S
m4aEto
x
i
U.4
9.
9f
I
.^ a; :ji a:i
~,
.1 I
.4v,
O~
LI
t I
&M
L-1
Page intentionally left blank
Page intentionally left blank
I
Page intentionally left blank
Page intentionally left blank
Page intentionally left blank
Page intentionally left blank
14j~~~~.....'11 4J F-~~~~~~~~~~z LJ C
CD
VI .41~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~J
Ki x~~~~~c
1k - ~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~k .2,3C
to -~~~~~~~~~~~~~~I
LL~~~~~~~~~~~~L
t~~~~~~~~~~~~~to~~~~~~~~~~t
4..
-. 1k~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~1
UVaX m
U
xl
tN
114
i�
,It
Z,
4
�ul I'll
1� -
V",J)
N
%Z
q 4
\4
K'a
U,
z U,
~b
T-Iq
.1:
r O,
a
4
'4
ki
kU
IC
F-.-
rj)
I
00-J0La
.-L,
i
St
i tDI-
< 0>LI
: 0
1 Auw
j ulo
OM
4cmu
a 'a
'4J
IU
I~
4l
KI'UJ
L.k
'0
l S20i L
UO
ViII,)
N
'14
[,-I
C
-!
CJ)
LU
-e
w1
m0
-J
u1l
..i>
:2
-u
0 ~u
.1W Ul I,
J4,
k
J
U
o~~~~~~~~~~~~~~~~~~~~~~o
tS~~~~~~~~~~~~~~~~~~~~~~~~~~~-
:~~~~~~~~~~
1V) Ii
~ ~ ~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~. CI
'U "I~~~~~~~~~I
/lb~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~4
'U
oz~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~C
M,,i!~h1O
3w_j a~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~I
0
-- N
VJ)
~NJN
n
,J
NJ
Q
iV
'ItON
f-..- ' i<
41,
tN..
t17)
u t
ILr)
lf)
inso
Lgo
zrQ
yt)
4V)
Q.
,-
L.j
,.,.
I'i
i
;,t
I
u
'4
's
'4
I
l-At A.
-Av 7
lCJ
U)
4U0
-J
0H
uJ
*,
"i \~
1
-J'
0 V~~~~~
49
z *
to l3s .
i-:k Zku t3� �
A
aZ
U
I
Us
L
0DI.
DIP
aQ
a co
tit
'4
5
go
a
LAJ
U
i * II ISQOO-OSOAI __0
U ~~~~~~~~~~O W
CD
o ~ ~ ~ ~ ~ ~ ~ ~ ~ ~ ~~~~~~~L
z§o
00LO coo
_ . _
AL EI-I::1 l.l~l- -il
%U
U ain
a
to
II4J
SOOZ-0oo0A
I:t"D 0:
U)-Z V)
IJ-X(f)
'i
'4
49 )
' 7 - --' 1
v
m
9
x
kis.
'a''3
I'-0
IC)--! r
uQ
(4:LJ
0LLj
LLJ
M,
.8.1
, a
3
. . ....0
co'5U*)
I))
1nG
m
LA@
t -
_ 2a
bLI
t)
'0
I4 .
1')fn
ma
Ira
To
F-Q
Un
d~LJ
8-J
w
LL.
.
. W9.
u
U
0
2 r:2 Cfb eI
3 L VI
11
'IiU,'a.
"I
LiJ2ul
YF o
5131
tI t
Dic
'4
Ij
0a
a
l"-I0ho
-- 4-4
ut/2
-4 W
V4 h1
"7
*i
U
I')
D
169CD
13
Cj
3
Y) V4-
t 1
4nkI"
4I)3v
I
0a
20
NLL aZ
0
oIC',.-I
I
I 2
-J
o
I-
00
i-j
0OJ
'A)
bA
'U
44v
'2
CJig£
-w
(r) L.I se
' '
I Ut
'-I L
V)
I0IU
k AVIU)
§U)
;-dulIL 4
Jo
Ea
a
r-C't
-
a)LI)
* M
. I
I
v
-1 i
q
Page intentionally left blank
E a z
i~~~~cLii ~ ~ L
alai~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~l
I/ ~:i , '( )" ~"( ~~~~~~~~~~~~~~.' m
: , _~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~U
~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~I -I i
n~~~~~~~~~~i
II - II __~~~~~~~~~~~~~~~~~~~~~~I1
LL
0
'~ 4 0
._ ~- .. I.,s~~~~~~~~~~,-- -.~~~~~~~~~~~~~~
z \ 1-J.-',
Page intentionally left blank
s [ I O)AOZ-o09A
N
0-
Li9
SCY
£L
00
_ .-- - a- ------ -- 0w
It~~~~~4 D
V i, Iif) AcWIV~
, _
Us)
1
g lVj'Ui
I VT
N i,
en 3,UJ)
*n _ S I
VU
a v 4
Iru
C
-
Q mO
1 aIt- U-
/
C9-I
.
0__ n.
11 --
AP
C4
q4
a
UI
U I
dWI
NI
l'MU
.0zj . i
t, 9'
_ z
-J0La.
to In
......I. . .T-r-r,-r
_a I [' I _ r --- "Irr T [ I II II
t
M
III---- 1-1----- IiI
i . . I .
L+
I A I _O
I
m
¢,
I
II
I
I .4U I
.- \
1 / K(I
r-
o
-.
:z
Ld
uJ
2¢ I iLL
I Q
0,
,- ,
_ _l ,
_TF I
i Vz Q 0 $ u £ 5s ̂ ~~~~~~~~~~~,/ °
t4 l
-I
XSAX~~~~~~~~ I \'I) f e IV
c
*6
I -,�' I
-I-tTrn 1 r--
. .1
.I.
\-.
%_I
im
1 .inU-0W
2
_ m
. J
0K U
I~~~~~~~~~~~~~~~~~~~~~~~~~
2----~~~~~~~~~
IIW:z�j'2W
P%
IsI !"
1,u Taz do
,,, [ Iooz-osox:iW-i
W, a
W .,z >g
w , u.
I ,kj z?(I-I)~,
I ~L
,, , I ~ '&:~ , I~, ",
R
iiQ .
cZ d.8
C2
, M'
cnwm
\ii0t /I
iI I l; r ~i
I =F-I I
.1
gj I - wv - I' I -- I -I -1... ..· I I.11~~~~~~~~~~~~~~~~~~~~~ '''--1
1 to 1M -M t- s -X w - -- i --p--l-
- 4
F --
cu I
p-t- 4l_I:
(~ -- jl _ A- L-
XiA~~~~~~~~~e~~
I I i I | I 1, I .1 I Ij I . I 0: ; 1 41, J- J'1: ~~~~~~~.I. . . .7- rT,i iI I
t=R��
I A I ~
I
I:j
�tz
6I-Li.
I
I
I
i
I
t
6
- 11
uI
0
RR,
5
,-
II'
q4
i
I
r
,,I
co
-1
i0
I I&A% U
.L140
I
F2 6¢auJ~
Ott
o.~Jui Z
' O
Li):
-.0
i,
a, O!8i'gol
;"
It
o
r-I::
o~
i..I 'l A
_ I m
2
LO_ co
9 C
N_.,
O 1-
~~r
ck
_ hi
_J
:2O~acX t) ot
o F rdol r~
,,4 .t"I ~ _
M I
4-
2ul
,,6.. IU
_ _
o1
-- r, -L~t J'-'~.' I-~~~~~~~~~~~~~
a
..
1
4-
00,
: -I _ .
L
I
p, i' 12 i <}
? .-1 i, o I w
X fl 0 4^ M~
0 z
0
LI_'t
V%
_ -
V 0Li
10
I
:aWa
i
1'lil; :71:
III1
-I-,.-_3Tco
Tou..J ..,u co~r$
us . Ima
*,, 1I 'ooz-0ooti
w
A000 [m 'L a
14t
ig,, C| 't
II
7
i
T-lH
I
AI
II .
II,I.,
I
I
,I
II
I
m . OJop-OoOA 4
In
:2 f
O2"8
u5
2
,.I
a
b
mIL.'
Zi
0LJ
A::
Ul
Ld
7
I'-
'-4
I-4
--I,-.-
[,,.
b73
(4lI
i UJ
I R.J
2
0 DL
U
U,
m
.4 m t I 0IM-080A.'
P,
i-Es
rI
(
/I
U
v LL
-i-0
-22 L:
a
0He~
~oI-13 2 g1 O100o <j
RC- Y
'-'4
9cnjgo
/I
Frr-V!
I)o
I.-
[.
ILU
!-425 R
a
:2
211-.U
COI
o2uo ,,n02p0
II
u
-- . >~~~~~~~~~~~~~~~~
' . . _ .f
z i
u m
vaI u m O OoloGQA-og^ 4 '3
e'-
N~~
I 1°
-' -+
.... ~ ... .C I
_ X
' i6, -!l
.7U
U~~~~~~~~~~~~~~~~~~~~~~~~~~U
n .
in~~~~~~~~~~~~~~iU
vlA .:LLI e
,,, .L '. Z. I:2~ ~ ~ ~~~~~~~~~~~~~~~~~~~~~~~~~ LO 9 O
o I I At A~o
L
gal~~~~~~~~~~~~p
oJ~~~~~~~~~~~~~~~~~~~~~~~~~~~~~o
|t I .. o
C:^ Q . X , ,z, .......
jzri iaIt
-- ~~~~~~~ ,-- .... -.LL
I...
/.~~~~~~~~~~~u
in~~~~~~~~~~~~~~~~~~~~~~~~~~i
W~~( 2
12 P
IC
Page intentionally left blank
Page intentionally left blank
Page intentionally left blank
Page intentionally left blank
en
0D.co
5.0 BOOSTER 00--Ini
0
5.0 BOOSTER
- 57 -
SD 71-140-7
W q. ; -1 i%~d:,t~~~~W~.~~~~~~~~~~~~~~~~~~~~~~~~~~~~''
4---
I--
i
I
i I 1 ii~a -i i ( R*'I- II: l I �4I I . i I I
II
I
iIII
I!
'I
i
l
I
I-. I
. II1
1i
I
)i
I
-Ii
i
ra
III *I -
11
IV11 i .
k%c1�
I- i
(- 7 I
I ) I E.
I ;I ,~I!I.,
i
I
IfII
IIi
iIIIIIIi
IIIiIi
I I
I
II
IIII
iII
iii
II
I
Ii
it
I
I I.I1
17i
;9 I -
t R
I %
I
i
i
- lI_
II
,i/
I
I I'aL
I
IIIIIII
,
I
I I
IIIIIIIIII
I I
&I
II
.1III
i
I
IIII
- IIIII
I
iII
iIII
iI
I
t
.
IiIIII
III
IV
II
I
.
I
II1.-I- -I
I
I
1.
to
9.1f,
A, N
j1 R
I 't. '
L.01T
...JI~
'fiE,I
I-U
I
I I
I 5
i IIII'l 1`1"'I I
o
tq k
\1
v"i
I~)
.1
t
Ik4I"Inm
z4)
i
v
\
tutjkIq
(C
Ick
tI
II
c
vs14
4 , I
L.(v~~i~~9' ,4:I I'>-n ,, &I
LI,f, I
t, I..
I
N.l i:;
i:I'
ZI
kI
I
iII
I
i
I"I~
I\
,- -.~ -;11 I -I I~~~~~-LI
II- i 1-
! ,S,
I~~l . _ ' /
.,,, NH /,I
I .i .
/ It
.
-1
I i
I'liI�li
.k
It
,\
lI
L?
l
IQ __.
. I _ S '
I
, I;J:
i'
t!,4
I
-.-
: - '
-4
"I
iv I
I
I' i1R k.1 'I
la1
-- - I
I
-h
I
T- -
I'[ i - -1.'
T ,/. !I.
-
I
t. _ \,.
I ,
I
i
Y X-
Y i
;'1 qr I/
* I
i1)- -
_ r It 1
. -,
t,
It
4 it
I i
I I
I
�l
I
I
t .i I
�wI I I I4
1;I,- i
I I. I
11
.
°
~
t
l[
I 'j1iJ:I I
-:!-t-
-I
Page intentionally left blank
Page intentionally left blank
I
IIii
01,4�L
IN1+N
ii
I
I
I
i
i
i
---4 I /~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~
I-.---, - -li ~ 9
o I" Q Q
: 4
N N N N N
,- K K, K K
I I i I 1 1 H 11I II
Il
,-4
I[ .r-
uQ
I L
ILL
-I
C
I-
3Li
I
Ii !
I ;Il l
I i
0
i~3
LUV
00
IJ'
OLL.
-Nbw
2- I
b *-D 1 1
I
Page intentionally left blank
Page intentionally left blank
Page intentionally left blank
Page intentionally left blank
Page intentionally left blank
6.0 OPERATIONS
0
6.0 OPERATIONS
- 67 -
SD 71-140-7
Page intentionally left blank
Page intentionally left blank
Page intentionally left blank
Page intentionally left blank
Page intentionally left blank
Page intentionally left blank
Page intentionally left blank
I}
7,*
I '
iii ii X tf l
I I
-
-
I:)
LU
s ilotLL
,i1
.- X- w
I U
0-J0U-
. -. . - .. .- . -- - - - -. - -
. i
?)
U
I I
t,
I
t -I
. r
5J a 16 ad
I I XI .01
C. I | Hilt. asIiFeel n s@t
i LL
I.,
I--
0.- I0U-
- -w _ - . -. _ - -
I i
0.I LU
' .
aI
I.
"U)
I1
0II.-
. - __ .- .. - - - ~ ~ . -' _ -· " -. . -
_I
.. ._ _
* ~ ~~~~ ~~~ ~~ ~~ ~~~~~~~Il .a I. -I .
IC-
0
I-
la.
0-J0U-
-r -.*- -- -- �. - - *�-w - - -- -. - - .- -- r - -
I:I:L'
I1
7-1
I· !
'i
.t Ie¢
el a- -
i i n - id -
*;, .~~:~:, A.
S. ~~~~~~~~
E-~~~~~~~~~~~~~~~1 s-4 -- l -N
00
--
*~~~~~~~~~. //I Aleh
'~ / /
ill.~~~~~i0
N C
''~ /(;~~~~IT l.
'U'-i=~As~~~~~~~ ~R !!'LF~~ t-bil~ ILI~ "~--~~I. -/ 'I
(.X .lT
I . , .1~~~~\ _.1~~~~~~~~~
C s-Z!
r
ak
Z.tk
[, !I
.1
i1!q2
en
- I
!..ll'
1
C.1 I; 2I-'24
r
i1 t
. p -
Iz-
0
I �IiIiI
I
IIIi
.Ii
i
I Ii
iii
31 .
i R
Lll
iL
I )a-li
rn(No
0>
(m
7.0 APPENDIX A. ALTERNATE ESS/BOOSTER CONFIGURATION ox0o>(EXTERNAL HYDROGEN TANK STUDY) z.
-- InZm
z mn
07.0 APPENDIX A. ALTERNATE ESS/BOOSTER CONFIGURATION
(EXTERNAL HYDROGEN TANK STUDY)
- 80 -
SD 71-140-7
Page intentionally left blank
8.0 APPENDIX B. ALTERNATE ESS CONFIGURATION
ODm
b
f m
o zG) 0Cn rOZ Z~
Ir-
--iIi1M~l-,
O
8.0 APPENDIX B. ALTERNATE ESS CONFIGURATION
- 82 -
SD 71-140-7
Page intentionally left blank
',010
m"IV· -TI'-mm
n;
9.0 APPENDIX C. TRADE STUDY REFERENCE DRAWINGS n
C
09.0 APPENDIX C. TRADE STUDY REFERENCE DRAWINGS
- 84 -
SD 71-140-7
Page intentionally left blank
Page intentionally left blank
Page intentionally left blank
Page intentionally left blank
Page intentionally left blank
Page intentionally left blank
Page intentionally left blank
I
LL
0U-
n! il
4 ;Ii~
'1
d Af, A
(. l
I'- IIn'- 4
tz
I _ 4 1
I-,il
-.,
0r-
IC .
! 1-
: r- .
i pql. . n
. ,
t
I-
I 'p
.'-
I'A.!I
I.
I
It
ii, !.~I-- . . ~
t
r
I
Il
'4.- -. I ..-
I
I
IiII
.. . ....
Page intentionally left blank
Page intentionally left blank
Page intentionally left blank