HEALTH AND SAFETY ADVICE
FOR BRICKLAYERS
52048-CITB Bricklayer Book(B).indd 1 12/9/07 11:27:02
Where there are unsafe acts illustrated in the photographs - the scenarios were re-created for illustration purposes and no one was put at risk at any time.
52048-CITB Bricklayer Book(B).indd 2 12/9/07 11:27:02
Contents
Introduction________________________________________ 2
Bricklayer__________________________________________ 4
Health and Safety Law & Training _____________________ 5
Hand Hygiene ______________________________________ 9
Hazardous Substances_____________________________ 10
Working at Heights_________________________________ 12
Slips Trips and Falls________________________________ 16
Safety in Excavations ______________________________ 18
Dust and Flying Particles ___________________________ 21
Noise ____________________________________________ 22
Manual Handling __________________________________ 22
Power and Hand Tools _____________________________ 24
Hand-Arm Vibration Syndrome (HAV)_________________ 25
Electricity _________________________________________ 27
Sun Exposure _____________________________________ 28
Slinging and Load Handling _________________________ 29
First Aid __________________________________________ 29
About CITB _______________________________________ 30
Notes ____________________________________________ 32
1
52048-CITB Bricklayer Book(B).indd 1 12/9/07 11:27:02
This booklet is part of a range that have been produced by CITB to provide advice and guidance on Health and Safety issues relating to trade persons working in the construction industry such as bricklayers, plasters, painters
and joiners, with the aim of helping to eliminate and reduce the risk of, accidents,
injury and ill-health.
The booklets are in an easy to use pocket-size format and will be a good reference point to both existing and new entrant trade persons working in the industry and will also provide advice to supervisors, managers and directors to help improve health and safety performance on site.
Some health and safety risks you may face on site include:
INTRODUCTION
2
52048-CITB Bricklayer Book(B).indd 2 12/9/07 11:27:02
Working in the construction industry is both rewarding and satisfying but as the list shows you could be exposed to various risks if the correct safe methods of work as described in this booklet are not followed.
Think about the various Health & Safety risks that could be found on your site, speak to your supervisor or person/s in charge about ways of eliminating or reducing those risks and stay safe and healthy.
3
52048-CITB Bricklayer Book(B).indd 3 12/9/07 11:27:02
Your trade has been around since biblical times and provides a valuable service to your industry. In order to sustain this valuable service you need to look after yourself and the industry needs to look after you; it also needs you to look after
others including those new to the industry such as apprentices and persons from
other countries.
As stated, your job is valuable and if you were asked to describe your job role to someone it would probably include the following wide range of activities.
and using plumb lines and a mason’s level as required.
bonding materials.
removing any excess mortar .
bricks .
installations using refractory or acid-resistant bricks, concretes, or other material.
deadline to get the job done.
methods to solve construction problems.
documentation for clients.
other regulations,
workers.
BRICKLAYER
4
52048-CITB Bricklayer Book(B).indd 4 12/9/07 11:27:03
Your health, safety and welfare at work are protected by law, your employer has a duty to protect you and keep you informed about health and safety and provide adequate information, instruction, supervision and training to
enable you to carry out your work in a safe manner.
You also have legal duties too as follows:
others who may be affected by your work such as otherworkers or members of the public.
wearing of personal protective equipment.
training requirements.
provided by your employer, this could be machinery, tools or personal protective equipment.
health, safety or welfare.
Self-employed persons also have duties under the law in relation to their own Health and Safety and ensuring that their work does not put others at risk.
If you think there is a health and safety
discuss it with your supervisor, H&S adviser or person in charge.
HEALTH AND SAFETY LAW& TRAINING
5
52048-CITB Bricklayer Book(B).indd 5 12/9/07 11:27:04
The Construction (Design and Management) Regulations (Northern Ireland) CDM
The updated CDM regulations place a responsibility on you and emphasises the importance of competence at all levels in
shall report any defect which he/she is aware of, which may endanger the health and safety of himself/herself or another person.
Health and Safety on Site
A number of initiatives have been launched to promote and improve good practice by reducing accidents and ill health. These initiatives are supported by Northern Ireland construction companies, Health and Safety Executive for Northern Ireland (HSENI) employers and training bodies.
BuildHealth launched in 2006 to improve the health of construction workers in Northern Ireland by: preventing work related ill health: supporting and rehabilitating ill workers and using the workplace as a setting in which to improve health.
reducing accidents and eliminating death in the industry. One of the targets is to reduce the number of major injury accidents to construction workers by 50% by 2008.
You have a part to play in this process by working safely, staying healthy, preventing injury to yourself and others and not being complacent.
Always inspect equipment that you have been given and report any defects, if you see any defects in scaffolding, ladders and mobile towers that could cause serious injury or death, report immediately. Only repair if authorised to do so by your employer or person in charge, and only if you are trained and competent.
If an accident should happen it must be reported to your supervisor, manager or a responsible person and a record
6
52048-CITB Bricklayer Book(B).indd 6 12/9/07 11:27:04
should be kept, most employers have a no-blame-culture, and encourage reporting of any problems that you see that could
reoccurrence.
Information gained from reported accidents can be used to improve health and safety on site.
systems of work you can help to improve the standards of Health and Safety on your site.
Health and Safety Training
CITB encourages the adequate training of all those working in the Northern Ireland construction industry to enroll with
designed to meet the needs of both clients and contractors to improve the training standards of the industry. When employees are registered with the appropriate registration scheme, clients are advised that the workforce on their sites have received safety training and, where appropriate, have a stated level of occupational competence.
Having a recognised registration card is a good starting point in showing proof of health and safety training but more
such as:
7
52048-CITB Bricklayer Book(B).indd 7 12/9/07 11:27:04
This is not an exhaustive list and other training requirements may be necessary as and when required.
Adequate training can help prevent accidents and ill-health and make for a more motivated and productive workforce. Ensure that you have received adequate training required to
All construction personnel should adopt the principles and practices stated in this document, where reasonably practicable. This booklet is intended as a good practice health & safety guide and should be supported by relevant training and the HSENI publications
Welfare Facilities - Health and Hygiene
Your employer or the person in control of any site has a
provided. These include washing, toilet and rest facilities.
There is also a requirement for facilities to be made available for the storage of clothes that are not worn during working hours, the storage of clothes that are not taken home and for changing clothes when specialist clothing is required to be worn at the work place.
Washing facilities on site should include hot and cold water, soap and basins large enough to wash forearms.
Do not abuse these facilities ensure you keep them clean and tidy, and report any vandalism.
If you are working with hazardous substances such as asbestos or lead, specialist welfare facilities must be provided.
8
52048-CITB Bricklayer Book(B).indd 8 12/9/07 11:27:04
Hand hygiene is essential. The hands are the most likely part of the body to come into contact with harmful substances. Failure to take basic precautions can lead to skin complaints.
Dirty hands should be cleaned using proper supplied skin cleansing products. Do
not clean hands with white spirit, thinners, petrol, turpentine etc.
Always ensure that you wash your hands after a visit to the toilet.
Always ensure that your hands are clean before handling food.
Anyone who prepares food for others must have been trained in food hygiene procedures.
Failure to observe basic hygiene precautions could lead to food poisoning, which at worst can be fatal.
HAND HYGIENE
9
52048-CITB Bricklayer Book(B).indd 9 12/9/07 11:27:04
DermatitisDirect skin contact with mortar could cause contact dermatitis and burns; your employer needs to explain precautions required and the danger of exposure.
percentage of bricklayers leave the industry due to severe dermatitis.
Direct skin contact should be avoided, the correct CE marked PVC gloves must be used when handling mortar.
Suitable gloves should be worn when handling potentially hazardous materials.
Training on how to treat exposure should be given by your employer, you must tell your supervisor if you see early signs of dermatitis.
HAZARDOUSSUBSTANCES
10
52048-CITB Bricklayer Book(B).indd 10 12/9/07 11:27:04
AsbestosBreathing asbestos dust can cause serious damage to the lungs and cause cancer. There is no known cure for asbestos related diseases.
Many buildings built or refurbished before the mid 1980’s contain asbestos. Materials containing asbestos should be
exposure to asbestos. Asbestos insulation board, asbestos coatings and asbestos insulation should only be removed by a licensed contractor.
If you suspect you have been exposed to asbestos or you
charge immediately.
11
52048-CITB Bricklayer Book(B).indd 11 12/9/07 11:27:05
Serious or even fatal injury could occur if you fall from height.
inspected after substantial alternation or repair, after any event likely to affect stability like strong winds and at regular
intervals not exceeding seven days.
Any faults found must be put right, scaffolding should be tagged to warn others if faults have been found.
Your employer should ensure that any scaffolding, which you are using, is safe.
load rating and provision of loading bays with your employer or supervisor.
if the scaffolding collapses on top of you.
provided and inspected, ask for evidence that the scaffoldhas been erected by a competent person and inspected.
competent persons can erect and inspect scaffolding.
be unsafe, report this to your supervisor or any other personin charge immediately.
never remove ties or handrails.
walls, don’t be fooled into using unsafe platforms.
use a suitable lanyard and inspect before and during use, you must be trained in the safe use of harnesses.
from falls is in place and secure.
be trained in the safe use of these machines.
WORKING AT HEIGHTS
12
52048-CITB Bricklayer Book(B).indd 12 12/9/07 11:27:05
ALLOY TOWER SCAFFOLDS
Alloy Tower scaffolds are used widely in the construction industry and a number of accidents happen each year mainly due to the tower not being properly erected or used. An aluminium tower can easily overturn as they are light and manoeuvrable.
Before Use
Do not erect or inspect an alloy tower unless you are trained and competent to do so.
wheels or feet properly supported.
Do not use crushable material such as bricks or building blocks to take the weight of any part of the tower.
As a guide, if towers are to be used in exposed conditions or outside, the height of the working platform should be no more than three times the minimum base dimension.
Remember the following as a guide.
the tower.
materials.
or support rubbish chute.
not climb on the tower.
the tower.
necessary.
13
52048-CITB Bricklayer Book(B).indd 13 12/9/07 11:27:06
the structure.
Ladders
outwards and as a rule of thumb needs to be ‘four up to one out’.
above the working platform. This provides a handhold for people getting on
and off.
stiles to prevent slipping.
condition and examined regularly to make sure they are free from defects.
this can hide defects.
condition, adequately secured
a ladder, make sure it is long enough and positioned to reach the work safely.
points of contact.
ladder access.
Ladders should be correctly angled; four up to one out.
14
52048-CITB Bricklayer Book(B).indd 14 12/9/07 11:27:06
Stepladders
designed with special handholds.
used in accordance with the manufacturer’s instructions.
Falling objects
Can cause injury to your head, body and feet, and to someone working in the area below you, or members of the public passing close to the site. Make sure no debris falls from height, place objects in a safe place and use a suitable chute for materials going into a skip.
Make sure all necessary precautions are taken as follows:
in skip.
supplied and worn at all times.
required.
protective footwear.
15
52048-CITB Bricklayer Book(B).indd 15 12/9/07 11:27:06
You or others could suffer sprains or fractures if you trip over waste including brick bands and pallet debris. Slips at height could result in a serious fall.
as even a surface as possible.
non slip soles.
the day.
disposed of in skip.
surfaces.
kept clean and any damage reported.
on site.
Tripping hazards like these are common on site – report them to your supervisor immediately
SLIPS TRIPS &FALLS
16
52048-CITB Bricklayer Book(B).indd 16 12/9/07 11:27:07
Stepping on nails and sharp objects
To help prevent foot injuries the following should be implemented
and mid soles should be providedto all those working on site.
waste or stored timber.
wear safety boots and dispose of waste in skips.
Struck or crushed by moving vehicles on site
You could suffer serious or even fatal injuries from vehicles and machines on site – particularly when they are reversing.
agreed route.
for vehicles or plant as you could be struck or run over.
Never except a lift on an item of plant unless a proper passenger
machine manufacture for this purpose
Never approach a machine operator from behind his/her vehicle as you could be crushed.
17
52048-CITB Bricklayer Book(B).indd 17 12/9/07 11:27:07
Every year, people are killed or seriously injured when working in excavations. Excavation work has to be properly planned, managed, supervised and carried out to prevent accidents. This
guide provides advice for those involved in excavation work.
Think before you enter an excavation.
battered back? Do not go into unsupported trenches.
dangerous. You may have to bend down or kneel in thetrench.
machinery?
been provided and secured? Do not climb over the sides of the excavation.
been done?
the fumes are heavier than air, you could beovercome by fumes and collapse.
equipment such as generators or compressors in, or near the edge of, an excavation unless fumes can be ducted away or the area can be ventilated.
SAFETY IN EXCAVATIONS
18
52048-CITB Bricklayer Book(B).indd 18 12/9/07 11:27:08
and in extreme cases death, always use the correct type of gloves to protect your hands including wet suits and boots.
height as you could fall into the trench.
Ask if the excavation has been inspected, look for evidence that a competent person has inspected the excavation:
stability of the excavation.
person buried under this amount in a trench would quickly suffocate & die.
Safety in Confined spaces
- shafts - ceiling voids - tunnels- boilers - sewers - deep excavations- box girders - manholes - cellars and basements
and serious injury if proper control methods are not followed.
done on the outside should never be allowed.
absolutely necessary to do so and never unless you have received adequate training.
been carried out, emergency procedures are in place and a permit to work has been issued.
19
52048-CITB Bricklayer Book(B).indd 19 12/9/07 11:27:08
If no provision has been put in place to rescue you should anything go wrong, do not enter.
Those that could be killed include not only people working
proper training and equipment.
oxygen. This can occur due to a build up of gases in the space.
As with excavations, do not site petrol or diesel-engined equipment such as generators or compressors in, or near the
or the area can be ventilated.
or enter has been issued, ask questions if in doubt, ask about the emergency procedures, has the equipment been inspected have all persons been trained, was the training adequate and provided by a competent person.
Preparing for a safe confined space entry
20
52048-CITB Bricklayer Book(B).indd 20 12/9/07 11:27:08
Cutting bricks can cause brick fragments and dust to enter the eyes and other parts of the body.
The cutting action generates high levels of dust, which often contains high
crystalline silica content. Breathing in this dust can lead to the development of
respiratory ill health, in particular scarring of the lung tissue (silicosis) which can result in serious breathing
Make sure you have been trained in abrasive wheels prior to using this equipment
Goggles should be worn at all times to prevent dust particles entering the eyes. Angle grinders should be replaced by a
exposure.
Proper dust extraction equipment should be used, hire companies can provide details on the latest equipment such as wet systems or methods available to prevent dust exposure.
Dust masks should be worn when required, all persons using equipment must be trained in the safe use of that equipment
DUST & FLYINGPARTICLES
21
52048-CITB Bricklayer Book(B).indd 21 12/9/07 11:27:09
Noise generated from use of equipment e.g. angle grinder and concrete saw.
Workers using grinders or working near others doing so may suffer hearing loss.
block splitters, removing high noise levels from the work.
be working close enough to cause problems.
work does start close by.
Make sure you have been trained correctly as you could suffer from back injury and
long-term pain if you regularly lift or carry loads.
and lifted to scaffold using lifting equipment such as a telescopic handler
etc.
site to prevent taking up water.
height.
scaffold.
arrangements.
NOISE
MANUALHANDLING
22
52048-CITB Bricklayer Book(B).indd 22 12/9/07 11:27:09
positioned using suitable lifting equipment by trainedpersons.
frequent breaks.
positions, performing repetitive tasks, or lifting.
Apply the following to help prevent injury
device where practical to do so.
your back.
stability.
don’t jerk.
load, plan you route.
Don’t lift this way – you are risking permanent injury
Use mechanical lifting aids whenever possible
23
52048-CITB Bricklayer Book(B).indd 23 12/9/07 11:27:09
All hand tools and equipment should be visually checked for faults before use, if using electrical powered equipment
connection should be used or equipment should be 110 volt or battery operated
Don’t use a chisel like this
enter the eyes or other parts of the body, ensure the mushroomed head is ground off safely, using eye protection and grinding in a safe area.
Ensure tools are used correctly and as intended by the manufacture, don’t get involved in horseplay.
Do not use power tools unless you have been trained and authorised to do so.
Ensure you report any defects and that all equipment is inspected before and after use.
Your employer should ensure that a maintenance record is available and kept up-to-date, power tools should be pat tested.
POWER AND HAND TOOLS
24
52048-CITB Bricklayer Book(B).indd 24 12/9/07 11:27:09
What is Hand-Arm Vibration?Hand-arm vibration is vibration transmitted onto your hands and arms when you use hand-held powered work equipment such as concrete saws
Prolonged vibration is known to affect blood vessels, nerves, muscles, tendons and other body parts.
The main complaint arising from continued vibration from hand tools is Vibration White Finger (VWF), in which surface blood vessels become damaged, resulting in circulatory problems, pain and in the worse cases gangrene
When Are You at Risk?
You are at risk if you regularly use hand-held or hand guided power tools and machines such as:
mowers.
HAND-ARMVIBRATION SYNDROME
(HAV)
25
52048-CITB Bricklayer Book(B).indd 25 12/9/07 11:27:10
You are also at risk if you hold work pieces which vibrate while being processed by powered machinery such as pedestal grinders.
How You Can Help Reduce the Risks
It is your employer’s responsibility to protect your welfare, but you should help by asking your employer if your job could be done in a different way, without using vibrating tools and machines. If this cannot happen:
quickly and expose you to less hand-arm vibration).
been properly maintained and repaired to avoid increased vibration caused by faults or general wear.
doing other jobs in between.
you have to.
when next used.
Encourage good blood circulation by:
hat, waterproofs and use heating pads if available).
26
52048-CITB Bricklayer Book(B).indd 26 12/9/07 11:27:10
Electric shock is a major hazard on a building site, a 240 volt supply is often enough to kill a person, which is why 110 volt supplies are used. If 110 volt supply
make sure it is tested.
Don’t take chances with electrical cables, treat all cables as live until you know otherwise.
If using powered hand tools make sure that the supply voltage is correct for the equipment.
All plugs and leads are in good condition and free from defect.
Ensure only correct fuses are used ‘no nails’.
Don’t make any temporary repairs, have those that are trained repair all equipment.
them run through water, wet areas or mud.
If cables have to be on the ground ensure that they are protected from damage and not a trip hazard.
Do not use extension leads that are still wound on a reel as the cable can melt due to heat build up.
Do not use insulating tape to cover breaks on a cable, have it repaired, all electrical equipment must be inspected and tested before use.
ELECTRICITY
27
52048-CITB Bricklayer Book(B).indd 27 12/9/07 11:27:10
Too much sunlight is harmful to your skin.
In the short term, even mild reddening of the skin from sun exposure is a sign of damage. Sunburn can blister the skin and make it peel.
Longer term problems can arise. Too much sun speeds up ageing of the skin, making it
leathery, mottled and wrinkled. The most serious effect is an increased chance of developing skin cancer.
What can you do to protect yourself?
the back of the neck.
and especially at lunch time.
exposed skin.
in shape, size or color, itching or bleeding.
SUNEXPOSURE
28
52048-CITB Bricklayer Book(B).indd 28 12/9/07 11:27:10
Slinging and load handling is perhaps the most vital part of any lifting operation.
Do not get involved in any slinging operations unless you have been adequately trained and authorised to do
so.
Failure to follow this advice could lead to death or injury.
First aid provision is all about treating an injured person immediately and contacting
the emergency services if need be. In extreme cases it saves lives.
the risks and the numbers employed.
name.
event of an injury or health problem on site.
SLINGING ANDLOAD
HANDLING
FIRSTAID
29
52048-CITB Bricklayer Book(B).indd 29 12/9/07 11:27:10
CITB
The purpose of CITB is to encourage the adequate training of those employed in, or intending to be employed in, the construction industry in NI, by establishing the training needs of the industry, encouraging and advising the industry to train and ensuring the adequate provision and standard of training in the industry.
Through Legislation CITB is authorised to raise a levy from the N.I. construction industry to fund its activities and services that aim to encourage adequate training.
The levy is redistributed through CITB grants, and other activities including training advice & support from the regional advisory team, recruitment & education, research, standards &
training division TASC.
For further Information about health & safety training and publications contact CITB at:
Construction Industry Training BoardNutts Corner Training Centre
Tel: 028 9082 5466Fax: 028 9082 5693Email: [email protected]
30
52048-CITB Bricklayer Book(B).indd 30 12/9/07 11:27:10
ConstructionSkills is the Sector Skills Council for the
industry from professional consultancies to major contractors and SMEs. Established as a Sector Skills Council in 2003, ConstructionSkills is working to deliver a safe, professional
ConstructionSkills is a partnership between CIC, CITB NI and CITB -ConstructionSkills. All three partners are committed to working together to deliver industry-led skills and training solutions through the Sector Skills Agreement for construction. We work to negotiate the best partnership and funding deals for the construction industry to help raise standards and we develop the skills products and services employers need.
The Construction Employers Federation (CEF) Health & Safety Practioners Group assisted with the development and content of this booklet.
This booklet is also supported by the HSENI.
For information on HSENI’s health & safety publications contact HSENI at:
Advice Helpline: 0800 0320 121Tel: 028 9024 3249Fax: 028 9054 6896Email: [email protected]
31
52048-CITB Bricklayer Book(B).indd 31 12/9/07 11:27:10
Notes
32
52048-CITB Bricklayer Book(B).indd 32 12/9/07 11:27:10
Disclaimer: The information contained in this publication is intended to provide general guidance only and should not be regarded as a complete and authoritative statement of the law. CITB does not accept or assume any liability or duty of care for any actions taken as a result of the information contained within this publication. You should not act upon the
representation or warranty (express or implied) is given as to the accuracy or completeness of the information contained in this publication, and, to the extent permitted by law, CITB, its members, employees and agents do not accept or assume any liability, responsibility or duty of care for any consequences of you or anyone else acting, or refraining to act, in reliance on the information contained in this publication or for any decision based on it.
52048-CITB Bricklayer Book(B).indd 33 12/9/07 11:27:11
Construction Industry Training BoardNutts Corner Training Centre
CrumlinCo. Antrim
Tel: 028 9082 5466Fax: 028 9082 5693
Email: [email protected]
CITB - Construction Skills, CIC and CITB (NI) are working in partnership as the Sector Skills Council for Construction.
Part of the Skills for Business Network of 25 employer led Sector Skills Councils.
Construction Industry T
52048-CITB Bricklayer Book(B).indd 34 12/9/07 11:27:11