aero certification and engineering llc - proprietary & confidential regulatory considerations...
TRANSCRIPT
Aero Certification and Engineering LLC - Proprietary & Confidential
Regulatory considerations for wireless aircraft
systems
April 17, 2007
Aero Certification and Engineering LLC - Proprietary & Confidential
This presentation will give an overview of regulatory considerations in
broadband wireless system design and installation onboard commercial
aircraft. Alternative technologies may offer solutions which deliver the
promise of an internet in the sky.
Aero Certification and Engineering LLC - Proprietary & Confidential
Introduction•Overview to the Wireless Interference Issues
•History of PEDs on Commercial Aircraft•Past Regulatory Reviews & Findings
•Types of Potential Interference•Theoretical & Practical•Incident Reports & Experience•Industry & Regulatory Activities
•Near-Term & Long-Term Outlook
Aero Certification and Engineering LLC - Proprietary & Confidential
History of Wireless Interference Issues - Concern Over PEDs on Aircraft Is Not New
1963 – RTCA SC-88, Report DO-119 - Dealt with FM Radio Receivers Resulted in FAR 91.19 controlled use of PEDs. Recommended prohibiting radios in flight
1988 – RTCA SC-156, Report DO-199 - Concluded PED EMI Exists but Is Low - Recommended FAA Advisory Circular for PEDs - Recommended FCC change classification for PED RF output
Aero Certification and Engineering LLC - Proprietary & Confidential
History of Wireless Interference Issues - Concern Over PEDs on Aircraft Is Not New
1996 – RTCA-177, Report DO-233 - Improved Aircraft Path Loss Factor Measurements - Changed FAR 91.21 to Prohibit PED Use During Critical Flight Phases
2003 – RTCA SC-202 - Deals with Wireless RF LANs and Cell Phones (Intentional Tx)
Aero Certification and Engineering LLC - Proprietary & Confidential
The U.S. Regulatory Situation
•Dual Regulatory Agencies - Cell Phone and Wireless Devices on Aircraft are governed by FCC and FAA Regulations
•The FCC and the FAA Are Coordinating their Activities in Examining the Use of Wireless Devices Onboard Aircraft.
•The FCC and the FAA Are Seeking Technical Guidance in the Regulatory Process from Various Organizations – Notably NASA and RTCA
Aero Certification and Engineering LLC - Proprietary & Confidential
Non-FAA Regulatory Developments in the U.S.
FCC Re-Examining Its Ban on Inflight Cell Phone Use
April 6, 2007 – the U.S. FCC is seeking public comment on whether to permit the airborne operation of "off the shelf" wireless handsets and other devices under the following conditions:
a.) The device operates at its lowest power setting under control of a "pico cell," which is a very small specialized cellular base station installed onboard the aircraft; and
b.) The operation does not interfere with on-ground users.
Aero Certification and Engineering LLC - Proprietary & Confidential
Non-FAA Regulatory Developments (Continued)
Good News for U.S. Passengers Demanding Voice & Data Connectivity (Parity with EuropeanPassengers)
Opposition by Pilot and Flight Attendant Unions
After FCC Comment Period, FCC Likely to Lift Cell Phone Ban Under the Conditions:
a.) Only onboard pico-cell technology allowedb.) Subject to FAA and Airline approval
Good News for AirCell, the U.S. ATG License Holder
•Voice Services Complement to Broadband Service Offering
Aero Certification and Engineering LLC - Proprietary & Confidential
Q: Why Is There A Concern?
A: The Potential for Interference In a Growing Variety of PEDs Brought Onboard. Note the Range of Devices for Which Interference Was Reported in a 9/2004 FAA Incident Report Summary Extracted From NASA-ASRS.
0
1
2
3
4
5
6
7
Aero Certification and Engineering LLC - Proprietary & Confidential
Q: What Systems Are Affected?
A: Many Different Systems Ranging From Non-Essential to Flight Critical, Including Navigational, This FAA Chart Depicts Interference Reports from 1995 to 2002.
0
5
10
15
20
25
30
35
VO
R
LOC
CD
I
Aut
opilo
t
Dis
play
s
FM
S
TC
AS
CO
MM
Rad
ar A
ltim
eter
IRU
ILS
NA
V
Sm
oke
Det
ecto
r
Spo
ilers
Air
data
Aud
io s
yste
m
Nu
mb
er o
f R
epo
rts
Aero Certification and Engineering LLC - Proprietary & Confidential
NASA ASRS PED Interference Reports 1995-2002
Reports per 1000 Airplanes
0.0
5.0
10.0
15.0
20.0
25.0
30.0
35.0
DC-9/MD-80
B737 B727 CRJ-600 B757 B767 F100
Aero Certification and Engineering LLC - Proprietary & Confidential
What Causes Interference to Avionics from PEDs and Wireless Devices?
• Coupling of PED emissions with avionics antenna or components acting as an Antenna.
•Antennas - Leakage Thru Windows, Doors, Seams
•Any Cable (including Seat-to-Seat Cabling)
•Power cables
•Power Supplies
•Poorly Shielded Circuit Board Components
Aero Certification and Engineering LLC - Proprietary & Confidential
What Causes Interference to Avionics from PEDs andWireless Devices (Continued)?
•What Are the Factors Affecting Coupling?•Frequency of Emissions
• Fundamental Frequencies (including Harmonic Frequencies)• Spurious Frequencies
•Power of Emissions•Sensitivity of Avionics Device (Shielding Issue)
Aero Certification and Engineering LLC - Proprietary & Confidential
Front-Door Coupling
Emissions radiated by portable electronic devices can radiate to aircraft antennas through:− Windows− Cargo and
passenger door seams
− Hatches
Aircraft Radio Receiver Antenna
Portable electronic device RF emissions
Radio receiver
Aero Certification and Engineering LLC - Proprietary & Confidential
Back-Door Coupling
Emissions radiated by portable electronic devices can couple directly to aircraft wiring and avionics
RF emissions from portable electronic device
Aero Certification and Engineering LLC - Proprietary & Confidential
NASA Studies on Cell Phones, PEDs & UWB Devices
Multiple Studies Performed – Bluetooth, 802.11, GSM,CDMA, GMRS and FRS Radios
Cell Phones – Some Small (But Not Zero) InterferenceDetected. On/Off Triggered Highest Spurious Emissions
Laptops & PDAs – Emissions Generally Benign But SomeExceedances of DO160D Category M Emission LimitsFor TCAS and DME Bands
GMRS and FRS Radios – Very Noisy – Exceeded Laptops By As Much As 30dB
Aero Certification and Engineering LLC - Proprietary & Confidential
Cabin Wireless LAN (CWLAN) Certification
The FAA Has Issued Several STCs for CWLANSystems for:
•Gulfstream & Dassault Falcon 2000•Bombardier Global Express•B777-200/300 & B747-400•A330 & A340•B757•B737
Aero Certification and Engineering LLC - Proprietary & Confidential
Ground Test & Flight Test Methodologies
•Conduct EMI Assessment to Determine if EMI Flight Test Is Required. If Required (Likely)
•Perform a front-door and back-door transmission test to Validate intentional system transmission levels.
•Identify Average and Maximum Number of PEDs in Use on Aircraft and Associated Operational and Failure Mode Power Levels.
Aero Certification and Engineering LLC - Proprietary & Confidential
Ground Test & Flight Test Methodologies (Continued)
•All Frequency Bands Used by the CWLAN System Need to Be Evaluated•Aircraft Location Tests Required from various locations in the cabin where PED usage is expected (galley, passenger aisles, etc.). • Verify CWLAN System and PED equipment meets the current edition of RTCA/DO-160E section 21, Category M, emission levels.
Aero Certification and Engineering LLC - Proprietary & Confidential
What Should an Airline or System/Component Manufacturer Do to Prevent Wireless Interference?
5 Step Approach
• Ensure That All System Components Pass DO-160E,Category M
• Have Experienced Electrical or Systems DER ReviewThe Aircraft Installation Plan for Potential EMI Issues
• Make Sure Aircraft Wiring Diagram and ElectricalLoad Analysis are Up-To-Date (Verify Current AC Configuration)
• Consider Existing Aircraft Antennae Wire Routing• Careful Consideration for Component Installation
Location for Potential EMI Issue with Antennas or Avionics.
Aero Certification and Engineering LLC - Proprietary & Confidential
Summary
The FAA Recognizes There Is A Small Risk to Sensitive Radio systems from PEDs.
Intentional Transmitters May Interfere WithSome Aircraft Systems That Are Not Qualified to HIRF Requirements.
Aero Certification and Engineering LLC - Proprietary & Confidential
Special Thanks To:
Rolfe Goedecke- Airbus IndustrieKiko Brenneisen- FAA DER & DAR, Aero CertificationRoger Modeen, FAA DER, Boeing (retired)Kreg Doerr – Aero CertificationRich Salter – Lumexis, WAEA TCIoan Leuca, Ph.D. – formerly Connexion By BoeingBill Straus, Ph.D. – NASA/DOT
Aero Certification and Engineering LLC - Proprietary & Confidential
References
“In-Flight Radio Frequency Spectrum Measurements of Commercial Aircraft Cabins,” DOT/FAA/AR-06/41 Office of Aviation Research and Development Washington, DC 20591, Bill Straus, Ph.D. and M. Granger Morgan, Ph.D.
“Recent Developments in Aircraft Wireless Networks,” Obi Orjih, Washington University, May 9, 2006
“Ultrawideband Electromagnetic Interference To Aircraft Radios,” Ely, Jay (NASA); Fuller (Eagle Wings Inc.); Shaver, Timothy (United Airlines)
“Electromagnetic Interference Assessment of CDMA and GSM Wireless Phones To Aircraft Navigation Radios,” Ely, Jay (NASA), Nguyen, Truong (NASA), Koppen, Sandra (Lockheed Martin), Salud, Theresa (Lockheed Martin)
“Guidance on Allowing Transmitting Portable Electronic Devices (T-PEDs) on Aircraft,” RTCA DO-294, December 13, 2006