us model canadian model service manual

SERVICE MANUAL

CDX-525RF

SUPPLEMENT-1File this supplement with the service manual.

US ModelCanadian Model

AEP ModelUK Model

E Model

Subject: Mechanism Deck Modification (MG-250D-137)

(ECN-CSA00838)

The mechanism deck was changed from MG-250C-137 to MG-250D-137.At the same time, MAIN and JACK boards were been changed.This supplement contains only a new type mechanism deck and boards.

TABLE OF CONTENTS

1. NEW/FORMER DISCRIMINATION .................... 2

2. DISASSEMBLY ......................................................... 3

3. DIAGRAMS3-1. Note for Printed Wiring Boards

and Schematic Diagrams ................................................ 53-2. Printed Wiring Boards – RF Section – .......................... 63-3. Schematic Diagram – RF Section – ............................... 73-4. Schematic Diagram – MAIN Section (1/2) – ................ 83-5. Schematic Diagram – MAIN Section (2/2) – ................ 93-6. Printed Wiring Boards

–MAIN Board (Component Side) – ............................... 103-7. Printed Wiring Board

–MAIN Board (Conductor Side) – ................................. 113-8. Printed Wiring Boards – JACK Boards – ...................... 12

4. EXPLODED VIEWS ................................................ 12

5. ELECTRICAL PARTS LIST ............................... 17

2

1. NEW/FORMER DISCRIMINATION

7Y187A

C: MG-250C-137 (Former type)D: MG-250D-137 (New type)

3

Note: Follow the disassembly procedure in the numerical order given.

2. DISASSEMBLY

MECHANISM DECK (MG-250D-137)

2 tension spring (FL)

2 tension spring (FL)

1 two dampers (250)

1 two dampers (250)

3 jack flexible board(CNJ901)

firament tape

4 mechanism deck (MG-250D-137)

MAIN BOARD

1 main flexible board(CNJ12)

6 three screws (FP)

7 main board

2 Break the soldering of motor (M104) lead.

3 screw(PTT2 × 4)

4 heat sink

5 two precision screws(P1.7 × 2.5)

4

RF BOARD

4

3 two screws(PTT2 × 4)

5 connector(CNP53)

7 RF board

3 two screws(PS2 × 4)

1 OP flexible board(CNJ11)


6 Break the soldering of lead.

CHUCKING MOTOR ASS’Y (M103)


2 two screws (PTT2 × 4)

4 chucking motor ass’y (M103)

3 retainer (CHM)

55

3. DIAGRAMS

3-1. NOTE FOR PRINTED WIRING BOARDS AND SCHEMATIC DIAGRAMS

Note on Printed Wiring Board:• X : parts extracted from the component side.• Y : parts extracted from the conductor side.• z : Through hole.• b : Pattern from the side which enables seeing.(The other layers' patterns are not indicated.)

Caution:Pattern face side: Parts on the pattern face side seen from(Conductor Side) the pattern face are indicated.Parts face side: Parts on the parts face side seen from(Component Side) the parts face are indicated.

Note on Schematic Diagram:• All capacitors are in µF unless otherwise noted. pF: µµF

50 WV or less are not indicated except for electrolyticsand tantalums.

• All resistors are in Ω and 1/4 W or less unless otherwise

specified.• f : internal component.• C : panel designation.

• U : B+ Line.• H : adjustment for repair.• Power voltage is dc 14.4V and fed with regulated dc power

supply from CD changer controller.• Voltages and waveforms are dc with respect to ground

under no-signal conditions.no mark : CD PLAY

• Voltages are taken with a VOM (Input impedance 10 MΩ).Voltage variations may be noted due to normal produc-tion tolerances.

• Waveforms are taken with a oscilloscope.Voltage variations may be noted due to normal produc-tion tolerances.

• Circled numbers refer to waveforms.• Signal path.J : CD PLAY

Note:The components identi-fied by mark 0 or dottedline with mark 0 are criti-cal for safety.Replace only with partnumber specified.

Note:Les composants identifiés parune marque 0 sont critiquespour la sécurité.Ne les remplacer que par unepièce portant le numérospécifié.

66

CDX-525RF

3-2. PRINTED WIRING BOARDS – RF Section –

• SemiconductorLocation

Ref. No. Location

IC11 D-7IC51 B-9IC52 H-4

Q11 E-8

C52C60

C59

R62

R63 C55 R57

R58

R65

R56

C54

R61 C21

R30

R64

C31

C38

C34

R40

C26

C39

C12

C19

C18

C10

CNP53

C56C5

8

C57 IC52

1-676-014- 11

(11)

RF BOARD (COMPONENT SIDE)

R51

R53

C51

R52

R54

R31

R60

R32

RV14

C22

C24

R39

C28

R37

C25

R34

C29

R41

C35

R47

R42

R43

R45

C37

R46

C36

R44

IC11

C43 C1

7C1

6

C14

R25

R18

R26

C15 R17

R59

C53

R50

C42

C41

R55

R49

R27

C32

C30

C27

C33

R38

R36

R35

R48

R14

R11

R22

R16

C40

R28 C2

3

R33 R1

2

R13

B C E

C13

CNJ11

Q11

1-676-014- 11

(11)

RF BOARD (CONDUCTOR SIDE)

IC51

CNJ12

SW1(LIMIT)

SW BOARD

1-664-104- 11(11)

M101(SPINDLE)

AMAIN

BOARD

OPTICAL PICK-UPBLOCK

(KSS-521A)

OP FLEXIBLE BOARD

1-664-626- 11

SW11CHUCKING END

DETECT

SW12SAVE ENDDETECT

1 2 3 4 5 6 7 8 9 10 11

A

B

C

D

E

F

G

H

I

J

+

1

2

BLU

YEL

YEL

BLU

+

+

+

+

8 5

1 4

17

1

+

3927

40

52

113

14

26

1

26

14871

28 22 21 15

M

MAIN FLEXIBLE BOARD

1-679-339- 11

BP12

(FE)

TP(VC)

TP(FE0)

BP11 (TE)

TP (TE1)

TP(RF)

TP (GND)

05

(Page 10)

77

CDX-525RF

3-3. SCHEMATIC DIAGRAM – RF Section –

The components identified by mark 0 or dottedline with mark 0 are critical for safety.Replace only with part number specified.

Les composants identifiés par une marque 0 sontcritiques pour la sécurité. Ne les remplacer quepar une pièce portant le numéro spécifié.

(Page 8)

88

CDX-525RF

3-4. SCHEMATIC DIAGRAM – MAIN Section (1/2) –

(Page 7)

99

CDX-525RF

3-5. SCHEMATIC DIAGRAM – MAIN Section (2/2) –

1010

CDX-525RF

3-6. PRINTED WIRING BOARDS – MAIN Board (Component Side) –


Ref. No. Location

D201 D-4D202 F-3D203 H-5D204 H-5D205 I-6D206 H-5D207 H-5D301 F-8D311 G-4D416 C-6D417 C-6D501 F-3D502 F-4D503 F-4D504 F-4D505 F-3

IC101 C-9IC202 H-5IC204 F-5IC301 H-4IC302 E-9IC401 B-6

Q202 C-3Q203 I-5Q204 I-6Q205 H-6Q301 F-10Q401 E-5Q402 E-4Q403 D-4Q404 D-4

R213

R212

R104

R105C806

C104

C103

C124

R103

R101

C102

C107

R102

R106

C105

C106

C101

C123

C110

C108

R318

C402

C121

C309

R331

C306

C122 R301

C807

FB101

FB102

FB103

FB40

1

FB41

4

FB41

2

FB41

3

FB41

1

R306

R313

C304

R302 R3

05

R312

R308

R303

C305

R304

R319

R307

R310

R401

C408

C403

C406

R411

R202

R201

C203

C413

C414

C412

R408

R406

R407

R405

FB421

FB422

FB423

R501

C502

C501

C205

C308

R343 R321

C302

C310

C503

C208

C213

C211

C212

R205R206

R203

R208

R204

R311

R207

D505 D503 D502IC204

D311

D301

D417

D416

D504D501

D201

D202

BCE

Q202

B C E

BCE BCE

BCE

Q402

Q403Q404

Q401

Q204B C E

Q205

Q203B C E

D206

D207

D205

Q301

IC302

D203D204

X401IC101IC401

05

1 2

IC301

MAIN BOARD (COMPONENT SIDE)

1-672-619- (12)

12

2E2C1B1E

1

30

31 26

1

50

51

80

81 100

1

2441

64

65 80

40 25

100

A

AK

A

KA

K

1

12

24

13

AK

A

K

A

A

A

K

KA

K7 1

8 14

K

A K

A K

1

4

8

5

A K CEB

AK

AK

AK

A K

A K

IC202

2

13

1-676-340- 11

JACK FLEXIBLE BOARD

BJACK BOARD

CNJ901

1-676-339- 11

MAIN FLEXIBLE BOARD

ARF BOARD

CNJ12

1 13

(ELEVATOR)

MM

1

A

2 3 4 5 6 7 8 9 10 11

B

C

D

E

F

G

H

I

J

12

BLE

RED

X301

C109 +

(Page 6)

(Page 12)

1111

CDX-525RF

3-7. PRINTED WIRING BOARD – MAIN Board (Conductor Side) –


Ref. No. Location

IC201 G-10IC203 E-10

Q201 D-10

MAIN BOARD (CONDUCTOR SIDE)

1-672-619- (12)

12

C409

C401

+

C404

+

C405

+

C411

+

C407

+

C410

+

+

C201

+

C202

+

C207

+

Q201

B

C

E

IC203

1

3

IC201

1

4

SW301(MAGAZINE DETECT)

SW302MAGAZINE IN/OUT

DETECT

RV302ELEVATOR

HEIGHT SENSOR

C204

+C206

+

C209

+

C210

+

BP301

SW303

05

(CHASSIS)

(CHASSIS)

(CHASSIS)

1

A

2 3 4 5 6 7 8 9 10

B

C

D

E

F

G

H

I

J

DOWN

UP

RV301

1212

CDX-525RF

13

12

1522

23

24

8

0

12

3

2018

17

#2

2

#1

MG-250D-137

IC203IC201

13

12

1523

16

22

8

12

2018

7

#2

#1

MG-250C-137

main flexible board

IC203

IC201

3-8. PRINTED WIRING BOARDS – JACK Board – 4. EXPLODED VIEWS

Page Former Type New Type

39

(1) COVER SECTION! : Indicates modificated portion.

Les composants identifiés par unemarque 0 sont critiquens pour lasécurité.Ne les remplacer que par une pièceportant le numéro spécifié.

The components identified bymark 0 or dotted line with mark0 are critical for safety.Replace only with part numberspecified.

• Items marked “*” are not stocked since theyare seldom required for routine service. Somedelay should be anticipated when orderingthese items.

• The mechanical parts with no reference num-ber in the exploded views are not supplied.

• Hardware (# mark) list is given in the last ofthe electrical parts list.

NOTE:• -XX and -X mean standardized parts, so they

may have some difference from the originalone.

• Color Indication of Appearance PartsExample:KNOB, BALANCE (WHITE) . . . (RED)

↑ ↑Parts Color Cabinet's Color

Ref. No. Part No. Description Remark

* 4 1-672-620-12 JACK BOARD

Ref. No. Part No. Description Remark

* 4 1-672-620-11 JACK BOARD

$

Ref. No. Part No. Description RemarkRef. No. Part No. Description Remark

3 1-664-628-11 JACK FLEXIBLE BOARD

* 15 A-3317-606-A MAIN BOARD, COMPLETE

* 16 3-022-694-01 HOLDER (TR3)

3 1-676-340-11 JACK FLEXIBLE BOARD

* 15 A-3326-233-A MAIN BOARD, COMPLETE

24 1-676-339-11 MAIN FLEXIBLE BOARD

$

$

C903

C901

C902

FB90

1FB

902

FB90

3CNJ901

1 13

1-672-620- (12)

12

1-672-620- (12)

12

JACK BOARD (COMPONENT SIDE)

JACK BOARD (CONDUCTOR SIDE)

1-676-340- 11

JACK FLEXIBLE BOARD

B MAIN BOARD

4

5

1

2

3

6

8

7

CN901 (2/2)

AUDIO OUT

IC901

5 4

8 7

6

2 13

CN901 (1/2)

05

CONTROL

(Page 10)

86

4

3 2117!

6

4

211

$

@

@

$

!

13

(2) MECHANISM DECK SECTION-1(MG-250D-137)

#3

#3

#3

51

52

54

Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark

51 X-3375-497-1 CHASSIS (U) SUB ASSY52 3-024-161-01 SPRING (SUT)

54 3-011-997-01 SPRING (STOPPER. LOWER)

14



101 3-024-170-01 SPRING (SB), TENSION* 102 3-024-172-01 BRACKET (EVM)

103 X-3378-136-1 CHASSIS (D.D) SUB ASSYM104 A-3301-123-A ELJ MOTOR ASSY (ELEVATOR)

102

101

103

M104

#12

15



* 151 3-024-150-01 RETAINER (CHM)* 152 X-3378-080-1 BRACKET (CHM. D) ASSY

153 3-010-270-01 COVER (CHM)154 3-321-813-01 WASHER, COTTER POLYETHYLENE155 3-017-139-01 GEAR (NWL)

156 3-010-255-01 ARM (NSW)157 3-573-936-00 STOPPER, REEL158 X-3373-552-1 GEAR (LOAD CAM) ASSY

159 3-010-252-01 ROLLER (CRE)160 3-010-268-01 SPRING (DH), TENSION

* 161 A-3290-194-I MAIN ASSY, CHASSIS (EVY)162 3-010-254-01 SHAFT (ROTARY PREVENTION C)163 3-010-253-01 GEAR (ML)

* 166 A-3317-993-A RF BOARD, COMPLETEM103 A-3301-123-A ELJ MOTOR ASSY (CHUCKING)

163

162

161

160

159

153

152

151

166157

156

158154

155

#8

#4

#6

#6#3

#6

#3

M103

#8

16


201 3-911-215-02 SHEET (LEAD RETAINER)202 3-920-362-01 SCREW (ESCUTCHEON)203 X-3375-219-1 HOLDER (SLED) ASSY204 3-022-841-01 GEAR (SD)205 3-573-936-00 STOPPER, REEL

206 A-3291-958-A SHAFT (SLED) ASSY207 3-010-263-01 DETENT (SHAFT THRUST)


* 208 1-664-104-11 SW BOARD* 209 A-3301-077-B BASE (OPT) (J) ASSY

210 1-664-626-11 OP FLEXIBLE BOARD0211 8-820-010-06 OPTICAL PICK-UP KSS-521A/K1RP

212 3-010-262-01 DETENT (SLED)

M101 A-3291-956-B MOTOR SUB ASSY, SPINDLEM102 A-3291-955-A MOTOR SUB ASSY, SLED

208

206

205 204

203

202

201

212

211

207

209

M101

210

not supplied

not supplied

#10

#5

#5M102

#9

#7

The components identified bymark 0 or dotted line withmark 0 are critical for safety.Replace only with part num-ber specified.

Les composants identifiés par unemarque 0 sont critiques pour lasécurité.Ne les remplacer que par une pièceportant le numéro spécifié.

17

5. ELECTRICAL PARTS LIST

JACK MAIN


* 1-672-620-12 JACK BOARD***********

< CAPACITOR >

C901 1-163-009-11 CERAMIC CHIP 0.001uF 10% 50VC902 1-163-038-00 CERAMIC CHIP 0.1uF 25VC903 1-163-009-11 CERAMIC CHIP 0.001uF 10% 50V

< CONNECTOR >

CN901 1-779-077-31 PLUG, CONNECTOR (CONTROL, AUDIO OUT)CNJ901 1-778-775-21 CONNECTOR, FPC 13P

< FERRITE BEAD >

FB901 1-500-445-21 FERRITE 0uHFB902 1-500-445-21 FERRITE 0uHFB903 1-500-445-21 FERRITE 0uH

< IC LINK >

IC901 1-532-686-21 LINK, IC**************************************************************

* A-3326-233-A MAIN BOARD, COMPLETE**********************

1-676-339-11 MAIN FLEXIBLE BOARD1-676-340-11 JACK FLEXIBLE BOARD3-028-802-01 SPACER (MOUNT 30)

* 3-939-139-01 SPACER

< CAPACITOR >

C101 1-163-038-00 CERAMIC CHIP 0.1uF 25VC102 1-163-251-11 CERAMIC CHIP 100PF 5% 50VC103 1-163-011-11 CERAMIC CHIP 0.0015uF 10% 50VC104 1-163-809-11 CERAMIC CHIP 0.047uF 10% 25VC105 1-164-004-11 CERAMIC CHIP 0.1uF 10% 25V

C106 1-164-182-11 CERAMIC CHIP 0.0033uF 10% 50VC107 1-163-021-11 CERAMIC CHIP 0.01uF 10% 50VC108 1-163-038-00 CERAMIC CHIP 0.1uF 25VC109 1-110-569-11 TANTALUM CHIP 47uF 20% 6.3VC110 1-163-038-00 CERAMIC CHIP 0.1uF 25V

C121 1-163-038-00 CERAMIC CHIP 0.1uF 25VC122 1-163-038-00 CERAMIC CHIP 0.1uF 25VC123 1-163-038-00 CERAMIC CHIP 0.1uF 25VC124 1-163-038-00 CERAMIC CHIP 0.1uF 25VC201 1-124-589-11 ELECT 47uF 20% 16V

NOTE:• Due to standardization, replacements in the

parts list may be different from the parts speci-fied in the diagrams or the components usedon the set.

• -XX and -X mean standardized parts, so theymay have some difference from the originalone.

• RESISTORSAll resistors are in ohms.METAL: Metal-film resistor.METAL OXIDE: Metal oxide-film resistor.F: nonflammable

• Items marked “*” are not stocked since theyare seldom required for routine service.Some delay should be anticipated when order-ing these items.

• SEMICONDUCTORSIn each case, u: µ, for example:uA. . : µA. . uPA. . : µPA. .uPB. . : µPB. . uPC. . : µPC. .uPD. . : µPD. .

• CAPACITORSuF: µF

• COILSuH: µH

Les composants identifiés par unemarque 0 sont critiquens pour lasécurité.Ne les remplacer que par une pièceportant le numéro spécifié.

The components identified bymark 0 or dotted line with mark0 are critical for safety.Replace only with part numberspecified.

When indicating parts by referencenumber, please include the board.

C202 1-126-513-11 ELECT 47uF 20% 6.3VC203 1-163-038-00 CERAMIC CHIP 0.1uF 25VC204 1-115-466-00 ELECT 1000uF 20% 16VC205 1-163-038-00 CERAMIC CHIP 0.1uF 25VC206 1-124-589-11 ELECT 47uF 20% 16V

C207 1-124-589-11 ELECT 47uF 20% 16VC208 1-164-346-11 CERAMIC CHIP 1uF 16VC209 1-124-589-11 ELECT 47uF 20% 16VC210 1-125-701-11 DOUBLE LAYER 0.047F 5.5VC211 1-163-038-00 CERAMIC CHIP 0.1uF 25V

C212 1-164-346-11 CERAMIC CHIP 1uF 16VC213 1-164-346-11 CERAMIC CHIP 1uF 16VC302 1-163-038-00 CERAMIC CHIP 0.1uF 25VC304 1-163-038-00 CERAMIC CHIP 0.1uF 25VC305 1-163-038-00 CERAMIC CHIP 0.1uF 25V

C306 1-163-038-00 CERAMIC CHIP 0.1uF 25VC308 1-163-038-00 CERAMIC CHIP 0.1uF 25VC309 1-163-038-00 CERAMIC CHIP 0.1uF 25VC310 1-163-038-00 CERAMIC CHIP 0.1uF 25VC401 1-124-589-11 ELECT 47uF 20% 16V

C402 1-163-038-00 CERAMIC CHIP 0.1uF 25VC403 1-163-038-00 CERAMIC CHIP 0.1uF 25VC404 1-126-513-11 ELECT 47uF 20% 6.3VC405 1-126-513-11 ELECT 47uF 20% 6.3VC406 1-163-038-00 CERAMIC CHIP 0.1uF 25V

C407 1-126-157-11 ELECT 10uF 20% 16VC408 1-163-038-00 CERAMIC CHIP 0.1uF 25VC409 1-126-513-11 ELECT 47uF 20% 6.3VC410 1-126-157-11 ELECT 10uF 20% 16VC411 1-126-157-11 ELECT 10uF 20% 16V

C412 1-163-009-11 CERAMIC CHIP 0.001uF 10% 50VC413 1-163-251-11 CERAMIC CHIP 100PF 5% 50VC414 1-163-251-11 CERAMIC CHIP 100PF 5% 50VC501 1-163-009-11 CERAMIC CHIP 0.001uF 10% 50VC502 1-163-029-11 CERAMIC CHIP 0.0047uF 50V

C503 1-163-038-00 CERAMIC CHIP 0.1uF 25VC806 1-163-038-00 CERAMIC CHIP 0.1uF 25VC807 1-163-009-11 CERAMIC CHIP 0.001uF 10% 50V

< DIODE >

D201 8-719-210-33 DIODE EC10DS2-TE12L5D202 8-719-210-33 DIODE EC10DS2-TE12L5D203 8-719-988-61 DIODE 1SS355TE-17

18


D204 8-719-422-64 DIODE MA8062-M-TXD205 8-719-038-48 DIODE 1SS319 (TE85R)

D206 8-719-988-61 DIODE 1SS355TE-17D207 8-719-422-62 DIODE MA8062-L-TXD301 8-719-801-78 DIODE 1SS184-TE85LD311 8-719-975-40 DIODE RB411D-T146D416 8-719-422-62 DIODE MA8062-L-TX

D417 8-719-422-62 DIODE MA8062-L-TXD501 8-719-017-94 DIODE MA8180-TXD502 8-719-975-40 DIODE RB411D-T146D503 8-719-975-40 DIODE RB411D-T146D504 8-719-017-94 DIODE MA8180-TX

D505 8-719-975-40 DIODE RB411D-T146

< FERRITE BEAD/SHORT >

FB101 1-500-445-21 FERRITE 0uHFB102 1-500-445-21 FERRITE 0uHFB103 1-500-445-21 FERRITE 0uHFB401 1-500-445-21 FERRITE 0uHFB411 1-216-295-00 SHORT 0

FB412 1-216-295-00 SHORT 0FB413 1-216-295-00 SHORT 0FB414 1-216-295-00 SHORT 0FB421 1-500-445-21 FERRITE 0uHFB422 1-500-445-21 FERRITE 0uH

FB423 1-500-445-21 FERRITE 0uH

< IC >

IC101 8-752-384-15 IC CXD2530QIC201 8-759-054-12 IC PQ09RA1IC202 8-759-363-81 IC XC61AN4002PRIC203 8-759-324-40 IC KIA7805PIIC204 8-759-444-86 IC BA8272F-E2

IC301 8-759-537-09 IC BA6287F-E2IC302 8-752-912-34 IC CXP84124-086QIC401 8-759-494-78 IC TC9464FN-EL

< TRANSISTOR >

Q201 8-729-016-83 TRANSISTOR 2SB1446-TAQ202 8-729-901-00 TRANSISTOR DTC124EKA-T146Q203 8-729-230-49 TRANSISTOR 2SC2712-YG-TE85LQ204 8-729-027-31 TRANSISTOR DTA124EKA-T146Q205 8-729-822-05 TRANSISTOR 2SD1622-ST-TD

Q301 8-729-020-67 TRANSISTOR XN1A312-TXQ401 8-729-901-00 TRANSISTOR DTC124EKA-T146Q402 8-729-027-23 TRANSISTOR DTA114EKA-T146Q403 8-729-015-39 TRANSISTOR UN2226- (TX)Q404 8-729-015-39 TRANSISTOR UN2226- (TX)

< RESISTOR >

R101 1-216-119-00 METAL CHIP 820K 5% 1/10WR102 1-216-105-00 RES-CHIP 220K 5% 1/10WR103 1-216-073-00 METAL CHIP 10K 5% 1/10WR104 1-216-061-00 METAL CHIP 3.3K 5% 1/10WR105 1-216-061-00 METAL CHIP 3.3K 5% 1/10W

R106 1-216-073-00 METAL CHIP 10K 5% 1/10WR201 1-216-073-00 METAL CHIP 10K 5% 1/10W

R202 1-216-049-11 RES-CHIP 1K 5% 1/10WR203 1-216-089-00 RES-CHIP 47K 5% 1/10WR204 1-216-097-00 RES-CHIP 100K 5% 1/10W

R205 1-216-077-00 RES-CHIP 15K 5% 1/10WR206 1-216-057-00 METAL CHIP 2.2K 5% 1/10WR207 1-216-089-00 RES-CHIP 47K 5% 1/10WR208 1-216-689-11 METAL CHIP 39K 0.5% 1/10WR212 1-216-295-00 SHORT 0

R213 1-216-295-00 SHORT 0R301 1-216-065-00 RES-CHIP 4.7K 5% 1/10WR302 1-216-089-00 RES-CHIP 47K 5% 1/10WR303 1-216-065-00 RES-CHIP 4.7K 5% 1/10WR304 1-216-089-00 RES-CHIP 47K 5% 1/10W

R305 1-216-089-00 RES-CHIP 47K 5% 1/10WR306 1-216-089-00 RES-CHIP 47K 5% 1/10WR307 1-216-089-00 RES-CHIP 47K 5% 1/10WR308 1-216-089-00 RES-CHIP 47K 5% 1/10WR310 1-216-089-00 RES-CHIP 47K 5% 1/10W

R311 1-216-089-00 RES-CHIP 47K 5% 1/10WR312 1-216-065-00 RES-CHIP 4.7K 5% 1/10WR313 1-216-097-00 RES-CHIP 100K 5% 1/10WR318 1-216-033-00 METAL CHIP 220 5% 1/10WR319 1-216-089-00 RES-CHIP 47K 5% 1/10W

R321 1-216-073-00 METAL CHIP 10K 5% 1/10WR331 1-216-097-00 RES-CHIP 100K 5% 1/10WR343 1-216-073-00 METAL CHIP 10K 5% 1/10WR401 1-216-035-00 METAL CHIP 270 5% 1/10WR405 1-216-033-00 METAL CHIP 220 5% 1/10W

R406 1-216-033-00 METAL CHIP 220 5% 1/10WR407 1-216-097-00 RES-CHIP 100K 5% 1/10WR408 1-216-097-00 RES-CHIP 100K 5% 1/10WR411 1-216-029-00 METAL CHIP 150 5% 1/10WR501 1-216-089-00 RES-CHIP 47K 5% 1/10W

< VARIABLE RESISTOR >

RV301 1-223-834-11 RES, ADJ, CARBON 47KRV302 1-225-951-21 RES, VAR, SLIDE 10K

(ELEVATOR HEIGHT SENSOR)

< SWITCH >

SW301 1-771-540-11 SWITCH, PUSH (1 KEY) (MAGAZINE DETECT)SW302 1-771-540-11 SWITCH, PUSH (1 KEY)

(MAGAZINE IN/OUT DETECT)SW303 1-571-532-21 SWITCH, TACTIL (Z)

< VIBRATOR >

X301 1-767-261-21 VIBRATOR, CERAMIC (8MHz)X401 1-767-511-11 VIBRATOR, CERAMIC (16.9344MHz)

**************************************************************

* A-3317-993-A RF BOARD, COMPLETE*******************

< CAPACITOR >

C10 1-163-009-11 CERAMIC CHIP 0.001uF 10% 50VC12 1-113-500-11 TANTALUM CHIP 100uF 20% 10VC13 1-163-038-00 CERAMIC CHIP 0.1uF 25VC14 1-165-176-11 CERAMIC CHIP 0.047uF 10% 16VC15 1-164-230-11 CERAMIC CHIP 220PF 5% 50V

MAIN RF

19


C16 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16VC17 1-164-227-11 CERAMIC CHIP 0.022uF 10% 25VC18 1-111-253-11 TANTALUM CHIP 100uF 20% 6.3VC19 1-163-038-00 CERAMIC CHIP 0.1uF 25VC21 1-162-966-11 CERAMIC CHIP 0.0022uF 10% 50V

C22 1-107-823-11 CERAMIC CHIP 0.47uF 10% 16VC23 1-113-682-11 TANTALUM CHIP 33uF 20% 10VC24 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16VC25 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16VC26 1-163-021-11 CERAMIC CHIP 0.01uF 10% 50V

C27 1-164-677-11 CERAMIC CHIP 0.033uF 10% 16VC28 1-164-245-11 CERAMIC CHIP 0.015uF 10% 25VC29 1-165-176-11 CERAMIC CHIP 0.047uF 10% 16VC30 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25VC31 1-113-987-11 TANTALUM CHIP 4.7uF 20% 25V

C32 1-164-677-11 CERAMIC CHIP 0.033uF 10% 16VC33 1-162-915-11 CERAMIC CHIP 10PF 0.5PF 50VC34 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25VC35 1-104-700-11 CERAMIC CHIP 0.027uF 10% 16VC36 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V

C37 1-109-982-11 CERAMIC CHIP 1uF 10% 10VC38 1-104-913-11 TANTALUM CHIP 10uF 20% 16VC39 1-163-038-00 CERAMIC CHIP 0.1uF 25VC40 1-109-982-11 CERAMIC CHIP 1uF 10% 10VC41 1-164-227-11 CERAMIC CHIP 0.022uF 10% 25V

C42 1-164-227-11 CERAMIC CHIP 0.022uF 10% 25VC43 1-164-227-11 CERAMIC CHIP 0.022uF 10% 25VC51 1-163-019-00 CERAMIC CHIP 0.0068uF 10% 50VC52 1-163-038-00 CERAMIC CHIP 0.1uF 25VC53 1-163-038-00 CERAMIC CHIP 0.1uF 25V

C54 1-163-038-00 CERAMIC CHIP 0.1uF 25VC55 1-163-023-00 CERAMIC CHIP 0.015uF 5% 50VC56 1-163-038-00 CERAMIC CHIP 0.1uF 25VC57 1-163-038-00 CERAMIC CHIP 0.1uF 25VC58 1-163-038-00 CERAMIC CHIP 0.1uF 25V

C59 1-163-038-00 CERAMIC CHIP 0.1uF 25VC60 1-104-914-11 TANTALUM CHIP 22uF 20% 16V

< CONNECTOR >

CNJ11 1-778-776-21 CONNECTOR, FPC 17PCNJ12 1-778-777-21 CONNECTOR, FPC 26P

* CNP53 1-580-055-21 PIN, CONNECTOR (SMD) 2P

< IC >

IC11 8-752-082-14 IC CXA1992BRIC51 8-759-071-79 IC BA6297AFPIC52 8-759-537-09 IC BA6287F-E2

< TRANSISTOR >

Q11 8-729-141-48 TRANSISTOR 2SB624T1-BV345

< RESISTOR >

R11 1-218-348-11 RES-CHIP 110K 5% 1/16WR12 1-216-839-11 METAL CHIP 33K 5% 1/16WR13 1-216-839-11 METAL CHIP 33K 5% 1/16WR14 1-218-348-11 RES-CHIP 110K 5% 1/16WR16 1-216-857-11 METAL CHIP 1M 5% 1/16W

R17 1-216-837-11 METAL CHIP 22K 5% 1/16WR18 1-216-841-11 METAL CHIP 47K 5% 1/16WR22 1-216-857-11 METAL CHIP 1M 5% 1/16WR25 1-216-851-11 METAL CHIP 330K 5% 1/16WR26 1-216-845-11 METAL CHIP 100K 5% 1/16W

R27 1-216-295-00 SHORT 0R28 1-216-295-00 SHORT 0R30 1-216-829-11 METAL CHIP 4.7K 5% 1/16WR31 1-216-829-11 METAL CHIP 4.7K 5% 1/16WR32 1-216-837-11 METAL CHIP 22K 5% 1/16W

R33 1-216-158-00 RES-CHIP 22 5% 1/8WR34 1-216-855-11 METAL CHIP 680K 5% 1/16WR35 1-216-835-11 METAL CHIP 15K 5% 1/16WR36 1-216-836-11 METAL CHIP 18K 5% 1/16WR37 1-216-851-11 METAL CHIP 330K 5% 1/16W

R38 1-216-837-11 METAL CHIP 22K 5% 1/16WR39 1-216-847-11 METAL CHIP 150K 5% 1/16WR40 1-218-273-11 RES-CHIP 510K 5% 1/16WR41 1-218-296-11 RES-CHIP 75K 5% 1/16WR42 1-202-930-11 RES-CHIP 750K 5% 1/16W

R43 1-216-849-11 METAL CHIP 220K 5% 1/16WR44 1-216-846-11 METAL CHIP 120K 5% 1/16WR45 1-216-837-11 METAL CHIP 22K 5% 1/16WR46 1-216-847-11 METAL CHIP 150K 5% 1/16WR47 1-216-834-11 METAL CHIP 12K 5% 1/16W

R48 1-216-845-11 METAL CHIP 100K 5% 1/16WR49 1-216-093-11 RES-CHIP 68K 5% 1/10WR50 1-216-841-11 METAL CHIP 47K 5% 1/16WR51 1-216-073-00 METAL CHIP 10K 5% 1/10WR52 1-216-093-11 RES-CHIP 68K 5% 1/10W

R53 1-216-073-00 METAL CHIP 10K 5% 1/10WR54 1-216-073-00 METAL CHIP 10K 5% 1/10WR55 1-216-073-00 METAL CHIP 10K 5% 1/10WR56 1-216-093-11 RES-CHIP 68K 5% 1/10WR57 1-216-081-00 METAL CHIP 22K 5% 1/10W

R58 1-216-093-11 RES-CHIP 68K 5% 1/10WR59 1-216-073-00 METAL CHIP 10K 5% 1/10WR60 1-216-073-00 METAL CHIP 10K 5% 1/10WR61 1-216-073-00 METAL CHIP 10K 5% 1/10WR62 1-216-085-00 METAL CHIP 33K 5% 1/10W

R63 1-216-073-00 METAL CHIP 10K 5% 1/10WR64 1-216-073-00 METAL CHIP 10K 5% 1/10WR65 1-216-073-00 METAL CHIP 10K 5% 1/10W

< VARIABLE RESISTOR >

RV14 1-238-091-11 RES, ADJ, CERMET 22K

< SWITCH >

SW11 1-762-946-12 SWITCH, PUSH (1 KEY) (CHUCKING END DETECT)

SW12 1-762-946-12 SWITCH, PUSH (1 KEY) (SAVE END DETECT)**************************************************************

RF

20


SW

* 1-664-104-11 SW BOARD*********

< SWITCH >

SW1 1-529-565-11 SWITCH, PUSH (1 KEY) (LIMIT)**************************************************************

MISCELLANEOUS**************

210 1-664-626-11 OP FLEXIBLE BOARD0211 8-820-010-06 OPTICAL PICK-UP KSS-521A/K1RP

M101 A-3291-956-B MOTOR SUB ASSY, SPINDLEM102 A-3291-955-A MOTOR SUB ASSY, SLEDM103 A-3301-123-A ELJ MOTOR ASSY (CHUCKING)

M104 A-3301-123-A ELJ MOTOR ASSY (ELEVATOR)************************************************************

**************HARDWARE LIST**************

#3 7-685-781-09 SCREW +PTT 2X4 (S)#4 7-624-104-04 STOPRING 2.0, TYPE -E#5 7-627-554-07 SCREW, PRECISION +P 2X2.2#6 7-628-253-00 SCREW +PS 2X4#7 7-627-553-27 SCREW, PRECISION +P 2X2.5

#8 7-624-102-04 STOPRING 1.5, TYPE-E#9 7-627-850-28 SCREW, PRECISION +P 1.4X3#10 7-627-000-00 SCREW, PRECISION +P 1.7X2.2 TYPE 3#12 7-685-780-09 SCREW +PTT 2X3 (S)

************************************************************

The components identified bymark 0 or dotted line withmark 0 are critical for safety.Replace only with part num-ber specified.

Les composants identifiés par unemarque 0 sont critiques pour lasécurité.Ne les remplacer que par une pièceportant le numéro spécifié.

Sony CorporationMobile Electronics Division Company

9-926-401-8399L0574-1

Printed in Japan C 1999. 12Published by General Engineering Dept.

CDX-525RF

us model canadian model service manual

Documents