tm 11-6625-422-24p technical manual organizational, … · *tm 11-6625-422-24p technical manual...

TM 11-6625-422-24P

TECHNICAL MANUAL

ORGANIZATIONAL, DIRECT SUPPORT AND GENERAL SUPPORT MAINTENANCEREPAIR PARTS AND SPECIAL TOOLS LISTS

(INCLUDED DEPOT MAINTENANCE REPAIR PARTS AND SPECIAL TOOLS)

FOR

TEST SETS, TELETYPEWRITERAN/GGM-1 (NSN 6625-00-897-5505)

AN/GGM-2 (NSN 6625-00-893-1726)AN/GGM-3 (NSN 6625-00-893-1727)AN/GGM-4 (NSN 6625-00-893-1728)

ANDAN/GGM-5 (NSN 662500-893-1735)

HEADQUATERS, DEPARTMENT OF THE ARMYFEBRUARY 1978

*TM 11-6625-422-24PTECHNICAL MANUAL HEADQUARTERS

DEPARTMENT OF THE ARMYNo.11-6625-422-24P WASHINGTON, DC, 6 February 1978

ORGANIZATIONAL, DIRECT SUPPORT, ANDGENERAL SUPPORT MAINTENANCE

REPAIR PARTS AND SPECIAL TOOLS LISTS(INCLUDING DEPOT MAINTENANCE REPAIR

PARTS AND SPECIAL TOOLS)FOR

TEST SETS, TELETYPEWRITERAN/GGM-1 (NSN 6625-00-897-5505)AN/GGM-2 (NSN 6625-00-893-1726)AN/GGM-3 (NSN 6625-00-893-1727)AN/GGM-4 (NSN 6625-00-893-1728)

ANDAN/GGM-5 (NSN 662500-893-1735)

Current as of 23 September 1977

REPORTING OF ERRORSYou can improve this manual by recommending improvements using DA Form

2028-2 (Test) located in the back of the manual. Simply tear out the self addressed form, fill it outas shown on the sample, fold it where shown, and drop it in the mail.

If there are no blank DA Form 2028-2 (Test) in the back of your manual, use thestandard DA Form 2028 (Recommended Changes to Publications and Blank Forms) and forward tothe Commander, US Army Electronics Command, ATTN: DRSEL-MA-Q, Fort Monmouth, NewJersey 07703.

In either case a reply will be furnished direct to you.

Table of Contents

IllusPage Figure

SECTION I. Introduction ............................................................................................................. 1II. Repair parts list ........................................................................................................ 5

Group 00 Test Sets, Teletypewriter AN/GGM-1, ANGGM-2 ................................................... 5 1-401 Test Set, Teletypewriter TS-1512/GGM (See TM 11-6625-422-25P-2 for parts)

0101 Assembly (Al) (See TM 11-6625-422-25P-2 for parts)010101 Front panel (AlA1) (See TM 11-6625-422-25P-2 for parts)010102 Rear panel assembly (A1A2) (See TM 11-6625-422-25P-2 for parts)0102 Main assembly (A2) (See TM 11-6625422-25P-2 for parts)010201 Printed circuit board (A2A1) (See TM 11-6625-422-25P-2 for parts)010202 Printed circuit board A2A2) (See TM 11-6625-422-25P-2 for parts)010203 Printed circuit board (A2A3) (See TM 11-6625-422-25P-2 for parts)010204 Printed circuit board A2A4) (See TM 11-11-6625-422-25P-2 for parts)010205 Printed circuit board (A2A5) (See TM 11-6625-422-25P-2 for parts)010206 Printed circuit board (A2A6) (See TM 11-6625-422-25P-2 for parts)010207 Printed circuit board (A2A7) (See TM 11-6625-422-25P-2 for parts)010208 Printed circuit board (A2A8) (See TM 11-6625422-25P-2 for parts)

*This manual supersedes TM 11-6625-422-24P, 31 July 1973.i

TM 11-6625-422-24PTable of Contents-Continued

IllusPage Figure

Group 010209 Printed circuit board (A2A9) (See TM 11-6625-422-25P-2 for parts)010210 Extender board (A2A10) (See TM 11-6625422-25P-2 for parts)010211 Printed circuit board (A2All (See TM 11-6625-422-25P-2 for parts)010212 Printed circuit board (A2A12) (See TM 11-6625-422-25P-2 for parts)010213 Printed circuit board (A2A13) (See TM 11-6625-422-25P-2 for parts)010214 Printed circuit board (A2A14) (See TM 11-6625422-25P-2 for parts)010215 Printed circuit board (A2A15) (See TM 11-6625-422-25P-2 for parts)010216 Printed circuit board (A2A16) (See TM 11-6625422-25P-2 for parts)010217 Printed circuit board (A2A17) (See TM 11-6625-422-25P-2 for parts)010218 Printed circuit board (A2A18) (See TM 11-6625-422-25P-2 for parts)

02 Oscilloscope OS-119/GGM (See TM 11-6625422-24P-3 for parts)03 Generator, Time Base SG-430GGM (See TM 11-6625-422-25P-4 for parts)

0301 Variable baud oscillator assembly (PC-467) (See TM 11-6625-422-25P-4 for parts)0302 37.5 baud oscillator assembly (PC457) (See TM 11-6625-422-25P-4 for p arts)0303 46.5 baud oscillator assembly (PC-463) (See TM 11-6625-422-25P-4 for parts)0304 61.1 baud oscillator assembly (PC-463) (See TM 11-6625-422-25P-4 for parts)0305 742 baud oscillator assembly (See TM 11-6625422-25P-4 for parts)0306 112.5 baud oscillator assembly (See TM 11-625-422-25P-4 for parts)0307 150 baud oscillator assembly (See TM 11-6625422-25P-4 for parts)0308 Alarm assembly (PC-484) (See TM 11-6625-422-25P-4 for parts)

04 Generator, Test pattern SG-431/GGM (See TM 11-6625-422-25P-5 for parts)0401 Electronic relay assembly (AlA3) (See TM 11-6625-422-25P-5 for parts)0402 Printed circuit card assembly (A2A1) (See TM 11-6625-422-25P-5 for parts)0403 Printed circuit card assembly (A2A2) (See TM 11-6625-422-25P-5 for parts)0404 Printed circuit card assembly (A2A3) (See TM 11-6625422-25P-5 for parts)0405 Printed circuit card assembly (A2A4) (See TM 11-6625-422-25P-5 for parts)0406 Printed circuit card assembly (A2A5) (See TM 11-6625-422-25P-5 for parts)0407 Printed circuit card assembly (A2A6) (See TM 11-6625-422-25P-5 for parts)0408 Printed circuit card assembly (A2A7) (See TM 11-625-422-25P-5 for parts)0409 Printed circuit card assembly (A2A8) (See TM 11-6625-422-25P-5 for parts)0410 Printed circuit card assembly (A2A9) (See TM 11-6625422-25P-5 for parts)0411 Printed circuit card assembly (A2A10) (See TM 11-6625-422-25P-5 for parts)0412 Printed circuit card assembly (A2A11) (See TM 11-662422-25P-5 for parts)0413 Printed circuit card assembly (A2A12) (See TM 11-6625-422-25P-5 for parts)0414 Printed circuit card assembly (A2A13) (See TM 114625-422-25P-5 for parts)0415 Printed circuit card assembly (A2A14) (See TM 11-6625-422-25P-5 for parts)0416 Printed circuit card assembly (A2A15) (See TM 11-6625-422-25P-5 for parts)0417 Printed circuit card assembly (A2A16) (See TM 11-6625422-25P-5 for parts)0418 Printed circuit card assembly (A2A17) (See TM 114625-422-25P-5 for parts)0419 Printed circuit card assembly (A2A18) (See TM 11-6625 422-25P-5 for parts)0420 Printed circuit card assembly (A2A19) (See TM 11-6625-422-25P-5 for parts)0421 Printed circuit card assembly (A2A20) (See TM 11-625-422-25P-5 for parts)0422 Printed circuit card assembly (A2A21) (See TM 11-6625-422-25P-5 for parts)

05 Power Supply PP-2971/GGM (See TM 11-6625-422-25P-5 for parts)00 Test Sets, Teletypewriter AN/GGM-3, AN/GGM4 ...............................................................15 5-701 Test Set, Teletypewriter TS-1512/GGM (See TM 11-6625-422-25P-2 for parts)02 Oscilloscope OS-119/GGM (See TM 11-6625422-24P-3 for parts)03 Generator, Test Pattern SG-431/GGM (See TM 11-6625-422-25P-5 for parts)04 Power Supply PP-2971/GGM (See TM 11-6625-422-25P-1 for parts)00 Test Set, Teletypewriter AN/GGM-5 ...................................................................................27 8-1001 Test Set, Teletypewriter TS-1512/GGM (See TM 11-6625-422-25P-2 for parts)02 Power Supply PP-2971/GGM (See TM 11-6625422-25P-1 for parts)

SECTION III. Special tools list (Not applicable)IV. National stock number and part

number index .....................................................................................................................32

ii

TM 11-6622-42-24P

SECTION IINTRODUCTION

1. ScopeThis manual lists spares and repair parts; special tools;special test, measurement, and diagnostic equipment(TMDE), and other special support equipment requiredfor performance of organizational, direct support, andgeneral support maintenance of the AN/GGM-1,AN/GGM- 2, AN/GGM-3, AN/GGM-4, and AN/GGM-5. Itauthorizes the requisitioning and issue of spares andrepair parts as indicated by the source and maintenancecodes.

2. GeneralThis Repair Parts and Special Tools List is divided intothe following sections:

a. Section II. Repair Parts List. A list of sparesand repair parts authorized for use in the performance ofmaintenance. The list also includes parts which must beremoved for re- placement of the authorized parts. Partslists are composed of functional groups in numericsequence, with the parts in each group listed in figureand item number sequence.

b. Section III. Special Tools List. Not applicable.

c. Section IV. National Stock Number and PartNumber Index. A list, in National item identificationnumber (NIIN) sequence, of all National stock numbers(NSN) appearing in the listings, followed by a list, inalphanumeric sequence, of all part numbers appearing inthe listings. National stock numbers and part numbersare cross-referenced to each illustration figure and itemnumber appearance.

3. Explanation of Columnsa. Illustration. This column is divided as follows:

(1). Figure number. Indicates the figure number ofthe illustration on which the item is shown.

(2). Item number. The number used to identify itemcalled out in the illustration.

b. Source, Maintenance, and Recoverability (SMR)Codes.

(1). Source code. Source codes indicate the

manner of acquiring support items for maintenance,repair, or overhaul of end items. Source codes areentered in the first and second positions of the UniformSMR Code format as follows:

Code DefinitionPA. Item procured and stocked for anticipated or

known usage.

XD. A support item that is not stocked. Whenrequired, item will be procured through normalsupply channels.

NOTECannibalization or salvage may be used as a source ofsupply for any items source coded above except thosecoded XA and aircraft support items as restricted by AR70042.

(2). Maintenance code. Maintenance codes areassigned to indicate the levels of maintenanceauthorized to USE and REPAIR support items. Themaintenance codes are entered in the third and fourthpositions of the Uniform SMR Code format as follows:

(a). The maintenance code entered in the thirdposition will indicate the lowest maintenance levelauthorized to remove, replace, and use the support item.The maintenance code entered in the third position willindicate one of the following levels of maintenance:Code Application/Explanation

C. Crew or operator maintenance performed withinorganizational maintenance.

O. Support item is removed, replaced, used at theorganizational level.

H. Support item is removed, replaced, used at thegeneral, support level.

(b). The maintenance code entered in the fourthposition indicates whether the item is to be repaired andidentifies the lowest maintenance level with the capabilityto perform complete repair (i.e., all authorizedmaintenance functions). This position will contain one ofthe following maintenance codes:

1

TM 11-6625-422-24P

Code Application ExplanationH. The lowest maintenance level capable of

complete repair of the support item is thegeneral support level.

Z. Nonreparable. No repair is authorized.

(3). Recoverability code. Recoverability codes areassigned to support items to indicate the dispositionaction on unserviceable items. The recoverability code isentered in the fifth position of the Uniform SMR Codeformat as follows:

Recoverabilitycodes DefinitionZ. Nonreparable item When unserviceable,

condemn and dispose at the level indicated inposition 3.

H. Reparable item. When uneconmicallyrepairable, condemn and dispose at the generalsupport level.

D. Reparable item. When beyond lower level repaircapability, return to depot. Condemnation anddisposal not authorized below depot level.

c. National Stock Number. Indicates the Nationalstock number assigned to the item and will be used forrequisitioning purposes.

d. Part Number. Indicates the primary numberused by the manufacturer (individual, company, firm,corporation, or Government activity), which controls thedesign and characteristics of the item by means of itsengineering drawings, specifications, standards, andinspection requirements to identify an item or range ofitems.

NOTEWhen a stock numbered item is requisitioned, the repairpart received may have a different part number than thepart being replaced.

e. Federal Supply Code for Manufactures (FSCM). TheFSCM is a 5-digit numeric code listed in SB 708-42which is used to identify the manufacturer, distributor, orGovernment agency, etc.f. Description. Indicates the Federal item name and, ifrequired, a minimum description to identify the item.g. Unit of Measure (U/M). Indicates the standard of thebasic quantity of the listed item as used in performing theactual maintenance function. This measure is expressedby a two- character alphabetical abbreviation (e.g., ea, in,pr, etc). When the unit of measure differs from the unitof issue, the lowest unit of issue that

will satisfy the required units of measure will berequisitioned.

h. Quantity Incorporated in Unit. Indicates thequantity of the item used in the breakout shown on theillustration figure, which is pre- pared for a functionalgroup, subfunctional group, or an assembly.

4. Special Informationa. Usable on codes are shown in the description

column. Uncoded items are applicable to all models.Identification of the usable on codes used in thispublication are:

Code Used onANW AN/GGM-15G8 AN/GGM-25G9 AN/GGM-35HA AN/GGM45HB AN/GGM-5

b. The following publications pertain to theAN/GGM-1, AN/GGM-2, AN/GGM-3, AN/ GGM-4, andAN/GGM-5 and its components:

TM 11-6625-422-12, Test Sets, TeletypewriterAN/GGM-1, AN/GGM-2, AN/GGM-3,AN/GGM-4, and AN/GGM-5

TM 11-6625-422-24P-3, Oscilloscope OS-119/GGM

TM 11-6625-422-25P-1, Power Supply PP-2971/GGM

TM 11-6625-422-25P-2, Test Set, TeletypewriterTS-1512/GGM

TM 11-6625-422-25P-4, Generator, Time BaseSG-430(P)/GGM

TM 11-6625422-25P-5, Generator, Test PatternSG431/GGM

TM 11-6625422-35/1, Power Supply PP-2971/GGM

TM 11-6625422-35/2, Test Set, TeletypewriterTS-1512/GGM

TM 11-6625422-35/3, Oscilloscope OS-119/GGM

TM 11-6625-422-35/5, Generator, Test PatternSG431/GGM

5. How to Locate Repair Partsa. When National stock number or part number is

unknown.(1). First. Using the table of contents,

determine the functional group within which the itembelongs. This is necessary since the illustrations areprepared for functional groups and listings are dividedinto the same groups.

(2). Second. Find the illustration covering thefunctional group to which the item belongs.

2

TM 11-6625-422-24P

(3). Third. Identify the item on the illustration andnote the illustration figure and item number of the item.

(4). Fourth. Using the Repair Parts Listing, find thefigure and item number noted on the illustration.

b. When National stock number or part number isknown.

(1). First. Using the Index of National StockNumbers and Part Numbers, find the pertinent Nationalstock number or part number. This

index is in NIIN sequence followed by a list of partnumbers in alphanumeric sequence, cross- referencedto the illustration figure number and item number.

(2). Second. After finding the figure and itemnumber, locate the figure and item number in the repairparts list.

6. Abbreviations

Not applicable.

(Next printed page is 4)

3

TM 11-6625-422-24P

Figure 1. Test Sets, Teletypewriter AN/GGM-1 and AN/GGM-2 (Sheet 1 of 2)

4

TM 11-6625-422-24P

Figure 1. Test Sets, Teletypewriter AN/GGM-1 and AN/GGM-2 (Sheet 2 of 2).4.1

SECTION II TM11-6625-422-24P

(1) (2) (3) (4) (5) (6) (7) (8)ILLUSTRATION DESCRIPTION

(a) (b) NATIONAL QTYFIG ITEM SMR STOCK PART INCNO. NO. CODE NUMBER NUMBER FSCM USABLE ON CODE U/M IN

UNIT

GROUP 00 TEST SETS,TELETYPEWRITERAN/GGM-1 AND AN/GGN-2

1 1 PAOHD 6625-00-893-1734 PP-2971/GGM 80058 POWER SUPPLY........................... ANW,SG8 EA 11 2 PAOHD 6625-00-893-1732 OS-119/GGM 80058 OSCILLOSCOPE ........................... ANW,SG8 EA 11 3 PAOHD 6625-00-893-1730 SG-431/GGM 80058 GENERATOR,TEST PATT............. ANW,SG8 EA 11 4 PAOHD 6625-00-893-1731 SG-430/GGM 80058 GENERATOR,TIME BASE............. ANW,SG8 EA 11 5 PAOHD 6625-00-893-1729 TS1512GGM 80058 TEST SET,TTY............................... ANW,SG8 EA 11 6 PAOHH 6625-00-573-3871’ RS2ADACV 96238 RACK,SHELF ADAPTER ..........................AW EA 11 7 PAOHH 6625-00-573-3875 RS2ADACV 96238 RACK,SHELF ADAPTER .................... ANMW EA 11 8 PAOHH 6625-00-893-1733 D10010 96238 CART,TTY TEST SET.............................. 5S3 EA 11 9 XDHZZ 7679-1 15165 RAIL,CART............................................... 5G8 EA 11 10 XDHZZ 7670 15165 DRAWER,ELEC EQUIP ........................... 5G8 EA 21 11 PAHZZ 5935-00-665-5717 26-190-32 02660 CONNECTOR,RCPT.ELEC.......................568 EA 41 12 XDHZZ 7674 15165 SHELF,STORAGE.................................. 56G8 EA 11 13 XDHZZ 7679-2 15165 RAIL,CART............................................. 56G8 EA 11 14 XDHZZ J8748 96238 COVER,REAR.......................................... 5G8 EA 11 15 PAOHH 6625-00-573-3880 EHIDACV 96238 EQUIPMENT HOUSING........................... 5G8 EA 11 16 PAHZZ 5935-00-660-5207 5278 74545 CONNECTOR,RCPT,ELEC...................... 5G8 EA 11 17 PAHZZ 5935-00-581-2507 5279 74545 CONNECTOR,RCPT,ELEC.................... 56G8 EA 1

5/(6 blank)

TM11-6625-422-24P

Figure 2. Test Sets, Teletypewriter AN/GGM-1 and AN/GGM-2 (Sheet 1 of 2).7

TM 11-6625-422-24P

Figure 2. Test Sets, Teletypewriter AN/GGM-1 and AN/GGM-2 (Sheet 2 of 2).

8




UNIT

2 1 PAHZZ 6625-00-936-3078 812024 96238 COVER,TERM STRIP .....................................ANW EA 32 2 XDH2Z 010375 96238 PANEL,REAR..................................................ANW EA 12 3 PAHZZ 5935-00-280-2264 DA15S 71468 CONNECTOR.RCPT,ELEC.............................ANW EA 12 4 PAHZZ 5940-00-581-3600 334 79963 TERMINAL,LUG ..............................................ANW EA 132 5 PAHZZ 5935-00-665-5717 26-190-32 02660 CONNECTOR,RCPT,ELEC.............................ANW EA 22 6 PAHZZ 5935-00-665-5718 UG1094U 80058 CONNECTOR,RCPT.......................................ANW EA 132 7 XDHZZ B11190 96238 PLATE,CONNECTOR .....................................ANW EA 12 8 PAHZZ 6625-00-762-0028 B53443000 96238 STRIP,MARKING ............................................ANW EA 12 9 XDHZZ B9915 96238 STRIP,MARKER..............................................ANW EA 12 10 XDHZZ 9237A140-1 06540 SPACER,SLEEVE...........................................ANW EA 42 11 PAHZZ 5325-00-276-6091 MS35489-19 96906 GROMMET,RUBBER......................................ANW EA 12 12 XDHZZ 600AC22 75382 TERMINAL BOARD.........................................ANW EA 32 13 PAOZZ 5920-00-284-6785 FOZD2ROOB 81349 FUSE,CARTRIDGE.........................................ANW EA 12 14 PAHZZ 5920-00-556-0144 342003 75915 FUSEHOLDER ................................................ANW EA 12 15 PAHZZ 5985-00-682-2700 MX554AU 80058 CONNECTOR ,PLUG ,ELEC ..........................ANW EA 12 16 PAHZZ 5935-00-665-5717 26-190-32 02660 CONNECTOR,RCPT,ELEC.............................ANW EA 22 17 XDHZZ D10429 96238 PANEL,REAR..................................................ANW EA 1

9

TM11-6625-422-24P

Figure 3. Test Sets, Teletypewriter AN/GGM-1 and AN/GGM-2, Housing, Rear View.10




UNIT

3 1 XDHZZ D10375 96238 PANEL,REAR......................................... 56G8 EA 13 2 XDHZZ C8843 96238 DOOR ,CONSOLE ,REAR ....................... 5G8 EA 13 3 PAHZZ 5340-00-860-3840 45-20-401-10 94222 LATCH,PANEL DOOR ........................... 56G8 EA 13 4 PAHZZ 5935-00-280-2264 DA15S 71468 CONNECTOR,RCPT,ELEC.................... 56G8 EA 13 5 PAHZZ 5935-00-660-7008 5256 74545 CONNECTOR,RCPT,ELEC.................... 56G8 EA 43 6 PAHZZ 5935-00-665-5718 UG1094U 80058 CONNECTOR,RCPT,ELEC...................... 5G8 EA 133 7 PAHZZ 5985-00-682-2700 MX554AU 80058 CONNECTOR,PLUG,ELEC ................... 56G8 EA 123 8 XDHZZ 7680 15165 SPACER,SLEEVE.................................. 56G8 EA 43 9 PAHZZ 5940-00-581-3600 334 79963 TERMINAL,LUG ..................................... 56G8 EA 133 10 XDHZZ D10429 96238 PANEL,REAR........................................... 5G8 EA 1

11

TM11-6625-422-24P

Figure 4. Test Sets, Teletypewriter AN/GGM-1 and AN/GGM-2, Cable Assemblies.12




UNIT

4 1 PAOHH 6625-00-061-2040 CX-8411/GGM 80058 CABLE ASSY,SP,ELEC ..................ANW,5G8 EA 14 2 PAHZZ 5935-00-280-2264 DA15S 71468 CONNECTOR,RCPT,ELEC............ANW,SGB EA 14 3 PAHZZ 6145-00-061-2453 1181-20 70331 CABLE,SP,ELEC............................ ANW,5GB FT 54 4 PAHZZ 5935-00-783-9133 0A24658 71468 SHIELD,ELEC CONN......................ANW,5G8 EA 24 5 PAHZZ 5935-00-173-7748 DA1SP 71468 CONNECTOR,RCPT,ELEC............ ANW,SG8 EA 14 6 PAOHH 6625-00-061-2041 CX-8412/GGM 80058 CABLE ASSY,SP,BELEC............... ANW,SG8 EA 14 7 PAHZZ 5935-00-061-7296 C11745-3 96238 CONNECTOR,PLUG,ELEC ............ANW,5G8 EA 14 8 PAHZZ 6145-00-061-1799 1329 70331 CABLE,SP,ELEC............................ ANW,SG8 FT 54 9 PAHZZ 5935-00-259-3608 26-159-32 02660 CONNECTOR,PLUG,ELEC ...........ANW, 5G8 EA 14 10 PAOZZ 6150-00-889-0872 CX-8414/GGN-2 80058 CABLE ASSY,SP,ELEC ........................... 5G8 EA 14 11 PAOHH 5995-00-889-0866 CX-8415/GGM-2 80058 CABLE ASSY,SP,ELEC ............................588 EA 14 12 XDHZZ 16-14 70903 TERMINAL,LUG .......................................5GB EA 34 13 PAHZZ 15935-00-577-0284 5274 71183 CONNECTOR,PLUG,ELEC ..................... 5G8 EA 14 14 PAHZZ 6145-00-284-0579 CO-3MGF3-18-033C 81349 CABLE,SP,ELEC....................................5SG8 FT 24 15 PAOHH 5995-00-086-7300 CX-8413/GGM 80058 CABLE ASSY,SP,ELEC ................. ANW,SG8 EA 14 16 XDHZZ YEA14-1143 09922 TEIRMINAL,LUG .............................ANW,5G8 EA 34 17 PAHZZ 6145-00-504-1015 C0-03MGF3-16-036081349 CABLE,SP,ELEC............................ANW,SGB FT 6

13

TM11-6625-422-24P

Figure 5. Test Sets, Teletypewriter AN/GGM-3 and AN/GGM-4.14




UNIT

GROUP 00 TEST SETS,TELETYPEWRITERAN/GGM-3 AND AN/GGM-4

5 1 PAOHD 6625-00-893-1734 PP-2971/GGM 80058 POWER SUPPLY............................. 5G9,5HA EA 15 2 PAOHD 6625-00-893-732 05-19/GGM 80058 OSCILLOSCOPE ............................ SG9,SHA EA 15 3 PAOHD 6625-00-893-1730 SG-431/GGM 80058 GENERATOR.TEST PATT....................... 5G9 EA 15 4 XDHZZ 8C12187 29623 PANEL,BLANK......................................... 5G9 EA 15 5 PAOHD 6625-00-893-1729 TS1512GGM 80058 TEST SET,TTY................................ SG9,SHA EA 15 6 PAOHH 6625-00-573-3872 j RS2BDACV 96238 RACK,SHELF ADAPTER ......................... 5G9 EA 15 7 PAOHH 6625-00-573-3875BRS1ADACV 96238 RACK,SHELF ADAPTER .................5G9,SHA EA 1

15/(16 blank)

TM11-6625-422-24P


TM11-6625-422-24P


18

TM11-6625-422-24P


19

TM11-6625-422-24P





UNIT

6 1 PAHZZ 6625-00-936-3078 B12024 96238 COVER,TERM STRIP ...................... 5G9,5HA EA 36 2 XDHZZ D10375 96238 PANEL,REAR................................... 5G9,5HA EA 16 3 PAHZZ 5935-00-280-2264 DA15SS 71468 CONNECTOR,RCPT,ELEC............56G9,SHA EA 16 4 PAHZZ 6625-00-762-0028 853443000 96238 STRIP,HARKING...................................... 5G9 EA 16 5 PAHZZ 5940-00-581-3600 334 79963 TERMINAL,LUG ...............................5G9,SHA EA 36 6 PAHZZ 5935-00-665-5718 UG1094U 80058 CONNECTOR,RCPT,ELEC.............. 5G9,5HA EA 66 7 XDHZZ Blll890 96238 PLATE,CONNECTOR ......................5G9,SHA EA 16 8 XDHZZ B9915 96238 STRIP,MARKER....................................... 5G9 EA 16 9 XDHZZ 9237A140-1 06540 SPACER,SLEEVE............................5G9,SHA EA 46 10 PAHZZ 5935-00-665-5717 26-190-32 02660 CONNECTOR,RCPT,ELEC.............. 5G9,5HA EA 26 11 PAHZZ 5325-00-276-6091 MS35489-19 96906 GROMMET,RUBBER....................... 5G9,5HA EA 16 12 XOHZZ 60OAC22 75382 TERMINAL BOARD..........................5G9,SHA EA 36 13 PAOZZ 5920-00-284-6785 F02D2ROOB 81349 FUSE,CARTRIDGE.......................... 5G9,5HA EA 16 14 PAHZZ 5920-00-556-0144 342003 75915 FUSEHOLDER ................................. 5G9,5HA EA 16 15 PAHZZ 5985-00-682-2700 MX554AU 80058 CONNECTOR,PLUG,ELEC ............. 5G9,5HA EA 16 16 PAHZZ 6625-00-889-0790 D10438 96238 PANEL,REAR........................................... 5G9 EA 16 17 PAHZZ 5985-00-682-2700 MX554AU 80058 CONNECTOR,PLUG................................ 5G9 EA 66 18 XDHZZ A9942 96238 STRIP,MARKER....................................... 5G9 EA 16 19 XDHHH 810531 96238 RELAY ASSEMBLY.................................. 5G9 EA 16 20 PAHZZ 5920-00-556-0144 342003 75915 FUSEHOLDER ......................................... 5G9 EA 16 21 PACZZ 5920-00-284-9493 F02GR125A 81349 FUSE,CARTRIDGE.................................. 5G9 EA 16 22 PAOZZ 5355-00-556-0151 MS91528-10D28 96906 KNOB ....................................................... 5G9 EA 16 23 PAHZZ 5935-00-665-5717 26-190-32 02660 CONNECTOR,RCPT,ELEC...................... 5G9 EA 16 24 PAHZZ 5935-00-665-5718 UG1094U 80058 CONNECTOR,RCPT,ELEC...................... 5G9 EA 26 25 PAOZZ 5920-00-583-5057 342003SA2 75915 CAP,ELECTRICAL ................................... 5G9 EA 16 26 PAHZZ 5945-00-878-8864 RN88 04773 BASE,RELAY ........................................... 5G9 EA 16 27 XDHZZ AM332 04773 BRACKET,ANGLE.................................... 5G9 EA 26 28 XDHZZ C7308 96238 COVER,RELAY HOUSING ...................... 5G9 EA 16 29 PAHZZ 5935-00-201-4783 TSlOIPO1 71785 SOCKET,ELCTRN TUBE......................... 5G9 EA 16 30 PAHZZ 5910-00-892-7735 A7309 96238 COVER SOCKET ..................................... 5G9 EA 16 31 XOHZZ PC640-1 83330 PCB .......................................................... 5G9 EA 16 32 PAHZZ 5815-00-019-5891 PC640-2 96238 RELAY SUBASSEMBLY .......................... 5G9 EA 16 33 XDHZZ WMF4S68E 14655 CAPACITOR,FXD,PLSTC........................ 5G9 EA 26 34 PAHZZ 5910-00-056-4557 WMF4S1E 14655 CAPACITOR,FXD,PLSTC........................ 5G9 EA 46 35 PACZZ 5945-00-542-7058 72AD2160TSTCP 78277 RELAY,ARMATURE................................. 5G9 EA 16 36 PAHZZ 5950-00-820-1227 3500-32 99800 COIL,RF ................................................... 5G9 EA 26 37 PAHZZ 5905-00-141-1118 RC2OGF390J 81349 RESISTOR,FXD,CMPSN ......................... 5G9 EA 26 38 PAHZZ 5905-00-279-1890 RC20GF391J 81349 RESISTOR,FXO,CMPSN......................... 5G9 EA 16 39 PAHZZ 5905-00-192-3971 RC20GF331J 81349 RESISTOR,FXD,CMPSN ......................... 5G9 EA 16 40 PAHZZ 5905-00-195-6806 RC20GF10O2J 81349 RESISTOR,FXD,CMPSN ......................... 5G9 EA 2

21




UNIT

6 41 XDHZZ 5X200 63743 RESISTOR,FXD,WW ............................... 5G9 EA 26 42 PAHZZ 5905-00-552-5490 RVLAUSA252A 81349 RESISTOR,VARIABLE............................. 5G9 EA 16 43 XDHZZ A10006 96238 STRIP,MARKER.......................................5HA EA 1

22/(23 blank)

TM11-6625-422-24P

Figure 7. Test Sets, Teletypewriter AN/GGM-3 and AN/GGM-4, Cable Assemblies.

24




UNIT

7 1 PAOHH 6625-00-061-2040 CX-8411/GGH 80058 CABLE ASSY,SP.ELEC .................. SG9,SHA EA 17 2 PAHZZ 5935-00-280-2264 DA1SS 71468 CONNECTOR,RCPT,ELEC.............. 6G9.5HA EA 17 3 PAHZZ 6145-00-061-2453 1181-20 70331 CABLE,SP,ELEC............................ 56G9,5HA FT 57 4 XDHZZ 5935-00-783-9133 DA24658 71468 SHIELD,ELEC CONN....................... 5G9.5HA EA 27 5 PAHZZ 5935-00-173-7748 DA15SP 71468 CONNECTOR.RCPT.ELEC..............5G9,SHA EA 17 6 PAOHH 6625-00-061-2041 CX-8412/GGM 80058 CABLE ASSY,SP,ELEC ................... 5G9,5HA EA 17 7 PAHZZ 5935-00-061-7296 C11745-3 96238 CONNECTOR,PLUG.ELEC ............ SG9,SHA EA 17 8 PAHZZ 6145-00-061-1799 1329 70331 CABLE.SP.ELEC..............................5G9,SHA FT 57 9 PAHZZ 5935-00-105-8508 26-159-32 02660 CONNECTOR,PLUG,ELEC .............SG9.5HA EA 17 10 PAOHH 5995-00-086-7300 CX-8413/GGM 80058 CABLE ASSY,SP,ELEC ...................5G9,SHA EA 17 11 XDHZZ YEA14-1143 09922 TERMINAL,LUG ...............................SG9.5HA EA 37 12 PAHZZ 6145-00-504-1015 C0-03MGF3-16-036081349 CABLE,SP,ELEC...............................569,SHA FT 6

25

TM11-6625-422-24P

Figure 8. Test Set, Teletypewriter AN/GGM-5.26




UNIT

GROUP 00 TEST SET, TELETYPEWRITERAN/GGM-5

8 1 PAOHD 6625-00r893-1734 PP-2971/GGM 80058 POWER SUPPLY.....................................5HB EA 18 2 PAOHH 6625-00-573-3173 RS1BDACV 96238 RACK,SHELF ADAPTER .........................SHB EA 18 3 PAOHD 6625-00-893-1729 TS1512GGM 80058 TEST SET,IT ............................................5HB EA 2

27

TM11-6625-422-24P

Figure 9. Test Set, Teletypewriter AN/GGM-5, Adapter Rack 1B, Rear View.28




UNIT

9 1 XDHZZ 010426 96238 PANEL ,REAR..........................................5HB EA 19 2 PAHZZ 5935-00-280-2264 DA15S 71468 CONNECTOR,RCPT ,ELEC.....................5HB EA 19 3 PAHZZ 5935-00-042-7766 26-190-32 02660 CONNECTOR,RCPT ELEC......................5HB EA 29 4 PAHZZ 6625-00-936-3078 812024 96238 COVER,TERM STRIP ..............................5HB EA 29 5 PAHZZ 5325-00-276-6091 MNS35489-19 96906 GROMMET,RUBBER...............................5HB EA 19 6 PAHZZ 5985-00-682-2700 MX554AU 80058 CONNECTOR,PLUG ELEC .....................5HB EA 129 7 PAHZZ 5940-00-581-3600 334 79963 TERMINAL,LUG .......................................5HB EA 249 8 XDHZZ A10006 96238 STRIP,MARKER.......................................5HB EA 19 9 XDHZZ 810066 96238 PLATE,CONNECTOR ..............................5HB EA 19 10 XDHZZ 600AC22 75382 TERMINAL BOARD..................................5HB EA 29 11 PAHZZ 5935-00-665-5718 UG1094U 80058 CONNECTOR,RCPT................................5HB EA 24

29

TM11-6625-422-24P

Figure 10. Test Set, Teletypewriter AN/GGM-5, Cable Assemblies.

30




UNIT

10 1 PAOHH 6625-00-061-2040 CX-8411/6GGM 80058 CABLE ASSY,SP.ELEC ...........................5HB EA 110 2 PAHZZ 5935-00-280-2264 DA15SS 71468 CONNECTOR,RCPT,ELEC......................5HB EA 110 3 PAHZZ 6145-00-061-2453 1181-20 70331 CABLE,SP,ELEC......................................5HB FT 510 4 XDHZZ 5935-00-783-9133 DA24658 71468 SHIELD,ELEC CONI ................................ 5SB EA 210 5 PAHZZ 5935-00-173-7748 DA15P 71468 CONNECTOR,RCPT,ELEC......................5HB EA 110 6 PAOHH 6625-00-061-2041 CX-8412/GGM 80058 CABLE ASSY,SP,ELEC ...........................5HB EA 110 7 PAHZZ 5935-00-042-7766 26-190-32 02660 CONNECTOR,PLUG.ELEC .....................5HB EA 110 8 PAHZZ 6145-00-061-1799 1329 70331 CABLE,SP,ELEC......................................5HB FT 510 9 PAHZZ 5935-00-105-8508 26-159-32 02660 CONNECTOR,PLUG................................SHB EA 110 10 PAOHH 5995-00-086-7300 qX-8413/GGM 80058 CABLE ASSY,SP,ELEC ...........................SHB EA 110 11 XDHZZ YEA14-1143 09922 TERMINAL,LUG....................................................5HB EA 310 12 PAHZZ 6145-00-504-1015 C0-03MGF3-16-0360 81349 CABLE,SP,ELEC......................................5HB FT 6

31

SECTION IV TM11-6625-422-24PNATIONAL STOCK NUMBER INDEX

NOTE: LATEST NATIONAL STOCK NUMBER AND PART NUMBER ASSIGNMENTS ARE INCLUDED AT THE ENDOF INDEX

STOCK NUMBER FIG. ITEM STOCK NUMBER FIG. ITEM

5920-00-556-0144 6 205935-00-042-7766 9 3 5355-00-556-0151 6 225935-00-042-7766 10 7 662500-573-3872 5 6

5935-00-581-2507 1 175940-00-581-3600 2 45940-00-581-3600 3 9

6145-00-061-1799 4 8 5940-00-581-3600 6 56145-00-061-1799 7 8 5940-00-581-3600 9 76145-00-061-1799 10 8 5935-00-660-5207 1 166625-00-061-2040 4 1 5935-00-660-7008 3 56625-00-061-2040 7 1 5935-00-665-5717 1 116625-00-061-2040 10 1 5935-00-665-5717 2 56625-00-061-2041 4 6 5935-00-665-5717 2 166625-00-061-2041 7 6 5935-00-665-5717 6 106625-00-061-2041 10 6 5935-00-665-5717 6 236145-00-061-2453 4 3 5935-00-665-5718 2 66145-00-061-2453 7 3 5935-00-665-5718 3 66145-00-061-2453 10 3 5935-00-665-5718 6 6

5935-00-665-5718 6 245995-00-086-7300 4 15 5935-00-665-5718 9 115995-00-086-7300 7 10 5985-00-682-2700 2 155995-00-086-7300 10 10 5985-00-682-2700 3 75935-00-105-8508 7 9 5985-00-682-2700 6 155935-00-105-8508 10 9 5985-00-682-2700 6 175935-00-173-7748 10 5 5985-00-682-2700 9 65905-00-192-3971 6 39 6625-00-762-0028 2 8

6625-00-762-0028 6 45905-00-195-6806 6 40 5935-00-783-9133 4 45325-00-276-6091 2 11 5935-00-783-9133 7 45325-00-276-6091 6 11 5935-00-783-9133 10 45325-00-276-6091 9 5 5950-00-820-1227 6 365905-00-279-1890 6 38 5340-00-860-3840 3 35935-00-280-2264 2 3 5945-00-878-8864 6 ?65935-00-280-2264 3 4 5995-00-889-0866 4 115935-00-280-2264 4 2 6150-00-889-0872 4 105935-00-280-2264 6 3 6625-00-893-1729 1 55935-00-280-2264 7 2 6625-00-893-1729 5 55935-00-280-2264 9 2 6625-00-893-1729 8 35935-00-280-2264 10 2 6625-00-893-1731 1 4

6625-00-893-1732 1 26145-00-284-0579 4 14 6625-00-893-1732 5 25920-00-284-9493 6 21 6625-00-893-1733 1 86145-00-504-1015 4 17 6625-00-893-1734 1 16145-00-504-1015 7 12 6625-00-893-1734 5 16145-00-504-1015 10 12 6625-00-893-1734 8 15945-00-542-7058 6 355905-00-552-5490 6 42

PART FIG. ITEM PART FIG. ITEMNUMBER FSCM NO. NO. NUMBER FSCM NO. NO.

AM332 04773 6 27 CX-8412/GGM 80058 10 6A10006 96238 6 43 CX-8413/GGM 80058 4 15A10006 96238 9 8 CX-8413/GGM 80058 7 10A7309 96238 6 30 CX-8413/GGM 80058 10 109942 96238 6 18 CX-8414/GGM-2 80058 4 10B10066 96238 9 9 CX-841 5/GGM-2 80058 4 11B10531 96238 6 19 C7308 96238 6 28811190 96238 2 7 C8843 96238 3 2B11190 96238 6 7 DA15P 71468 4 5B12024 96238 2 1 DA15P 71468 7 5812024 96238 6 1 DA15P 71468 10 5B12024 96238 9 4 DA15S 71468 2 3B53443000 96238 2 8 DA15S 71468 3 4853443000 96238 6 4 DA15S 71468 4 2B9915 96238 2 9 DA15S 71468 6 3B9915 96238 6 8 DA15S 71468 7 2CO-03MGF3-16-0360 81349 4 17 DA15S 71468 9 2CO-03MGF3-16-0360 81349 7 12 DA15S 71468 10 2CO-03MGF3-16-0360 81349 10 12 DA24658 71468 4 4CO-3MGF3-18-0330 81349 4 14 DA24658 71468 7 4CX-8411/GGM 80058 4 1 DA24658 71468 10 4CX-8411/GGM 80058 7 1 D10010 96238 1 8CX-8411/GGM 80058 10 1 D10375 96238 2 2CX-8412/GGM 80058 4 6 D10375 96238 3 1CX-8412/GGM 80058 7 6 D10375 96238 6 2

32

SECTION IV TM11-6625-422-24PNATIONAL STOCK NUMBER AND PART NUMBER INDEX

PART FIG. ITEM PART FIG. ITEMNUMBER FSCM NO. NO. NUMBER FSCM NO. NO.

D10426 96238 9 1 YEA14-1143 09922 4 16010429 96238 2 17 YEA14-1143 09922 7 11D10429 96238 3 10 YEA14-1143 09922 10 11D10438 96238 6 16 1181-20 70331 4 3EH1DACV 96238 1 15 1181-20 70331 7 3F02GR125A 81349 6 21 1181-20 70331 10 3J8748 96238 1 14 1329 70331 4 8MS35489-19 96906 2 11 1329 70331 7 8MS35489-19 96906 6 11 1329 70331 10 8MS35489-19 96906 9 5 16-14 70903 4 12MS91528-10D2B 96906 6 22 26-159-32 02660 4 9MX554AU 80058 2 15 26-159-32 02660 7 9MX554AU 80058 3 7 26-159-32 02660 10 9MX554AU 80058 6 15 26-190-32 02660 1 11MX554AU 80058 6 17 26-190-32 02660 2 5MX554AU 80058 9 6 26-190-32 02660 2 16OS-119/GGM 80058 1 2 26-190-32 02660 6 10OS-119/GGM 80058 5 2 26-190-32 02660 6 23PC640-1 83330 6 31 26-190-32 02660 9 3PC640-2 96238 6 32 26-190-32 02660 10 7PP-2971/GGM 80058 1 1 334 79963 2 4PP-2971/GGM 80058 5 1 334 79963 3 9PP-2971/GGM 80058 8 1 334 79963 6 5RC20GF102J 81349 6 40 334 79963 9 7RC20GF331J 81349 6 39 342003 75915 2 14RC20GF390J 81349 6 37 342003 75915 6 14RC20GF391J 81349 6 38 342003 75915 6 20RN88 04773 6 26 342003SA2 75915 6 25RS1ADACV 96238 1 7 3500-32 99800 6 36RS1ADACV 96238 5 7 45-20-401-10 94222 3 3RS1BDACV 96238 8 2 5X200 63743 6 41RS2ADACV 96238 1 6 5256 74545 3 5RS2BDACV 96238 5 6 5274 71183 4 13RVLAUSA252A 81349 6 42 5278 74545 1 16SG-430/GGM 80058 1 4 5279 74545 1 17SG-431/GGM 80058 1 3 600AC22 75382 2 12SG-431/GGM 80058 5 3 600AC22 75382 6 12TSlO1PO) 71785 6 29 600AC22 75382 19 10TS1512GGM 80058 1 5 72AO2160TSTCP 78277 6 35TS1512GGM 80058 5 5 7670 15165 1 10-TS5itm GM 80058 8 3 7674 15165 1 12UG1094U 80058 2 6 7679-1 15165 1 9UG1094U 80058 3 6 7679-2 15165 1 13 UG1O94U 80058 6 6 7680 15165 3 8UG1094U 80058 6 24 8C12187 29623 5 4UG1O94U 80058 9 11 9237A140-1 06540 2 10WMF4S1E 14655 6 34 9237A140-1 06540 6 9WMF4S68E 14655 6 33

LATEST NATIONAL STOCK NUMBER ASSIGNMENTSSTOCK NUMBER FIG. ITEM STOCK NUMBER FIG. ITEM

5815-00-019-5891 6 32 5920-00-284-6785 2 135910-00-056-4557 6 34 5920-00-284-6785 6 135905-00-141-1118 6 37 5920-00-556-0144 2 145935-00-173-7748 4 5 5920-00-556-0144 6 145935-00-173-7748 7 5 5935-00-577-0284 4 135935-00-201-4783 6 29 5920-00-583-5057 6 25

6625-00-893-1730 1 3

LATEST PART NUMBER ASSIGNMENTSPART FIG. ITEM PART FIG. ITEM

NUMBER FSCM NO. NO. NUMBER FSCM NO. NO.

C11745-3 96238 4 7 F02D2ROOB 81349 2 13C11745-3 96238 7 7 F02D2ROOB 81349 6 13

ADDITIONAL LATEST NATIONAL STOCK NUMBER ASSIGNMENTSSTOCK NUMBER FIG. ITEM STOCK NUMBER FIG. ITEM

NO. NO. NO. NO.

5935-00-061-7296 4 7 6625-00-573-3880 1 155935-00-061-7296 7 7 6625-00-889-0790 6 165935-00-259-3608 4 9 5910-00-892-7735 6 306625-00-573-3871 1 6 6625-00-893-1730 5 36625-00-573-3873 8 2 6625-00-936-3078 2 16625-00-573-3875 1 7 6625-00-936-3078 6 16625-00-573-3875 5 7 6625-00-936-3078 9 4

33/(34 BLANK)-1

TM 11-625-422-24PBy Order of the Secretary of the Army:

BERNARD W. ROGERSGeneral, United States Army

Official: Chief of Staff

J. C. PENNINGTONBrigadier General, United States Army

The Adjutant General

Distribution:Active Army:

HISA (Ft. Monmouth) (33) USARMIS (1)USASA (2) USAERDAA (1)COE (1) USAERDAW (1)TSG (1) USACCSO (5)USAARENBD (1) USACC-EUR (5)DARCOM (1) Army Dep (1) exceptTRADOC (2) Fort Carson (5)OS Maj Comd (4) Fort Gillem (10)TECOM (2) Fort Gordon (10)USACC (4) Fort Huachuca (10)MDW (1) Ft Richardson (ECOM Ofc) (2)Armies (2) LBAD (14)Corps (2) SAAD (30)USACCPAC (5) TOAD (14)HQ, 7th Sig Comd (5) SHAD (3)Svc Colleges (1) USA DEP (1)USASIGS (5) Sig Sec USA Dep (1)USAADS (2) Units org under fol TOE: (1)USAFAS (2) 11-97USAARMS (2) 11-98USAIS (2) 11-117USAES (2) 11-500 (AA-AC)USAICS (3) 29-134MAAG (1) 29-136

NG: NoneUSAR: NoneFor explanation of abbreviations used, see AR 310-50.

*U.S. GOVERNMENT PRINTING OFFICE : 1984 0 - 421-302 (10449)

PIN: 023264-000

This fine document...

Was brought to you by me:

Liberated Manuals -- free army and government manuals

Why do I do it? I am tired of sleazy CD-ROM sellers, who take publicly available information, slap “watermarks” and other junk on it, and sell it. Those masters of search engine manipulation make sure that their sites that sell free information, come up first in search engines. They did not create it... They did not even scan it... Why should they get your money? Why are not letting you give those free manuals to your friends?

I am setting this document FREE. This document was made by the US Government and is NOT protected by Copyright. Feel free to share, republish, sell and so on.

I am not asking you for donations, fees or handouts. If you can, please provide a link to liberatedmanuals.com, so that free manuals come up first in search engines:

Free Military and Government Manuals

– SincerelyIgor Chudovhttp://igor.chudov.com/

– Chicago Machinery Movers
http://www.liberatedmanuals.com/https://www.machinerymoverschicago.com/http://igor.chudov.com/http://www.liberatedmanuals.com/

tm 11-6625-422-24p technical manual organizational, … · *tm 11-6625-422-24p technical manual...

Documents