safety recall p41 / nhtsa 14v-438 ignition switch
TRANSCRIPT
Safety Recall P41 – Ignition Switch Page 1
October 2015 Dealer Service Instructions for:
Safety Recall P41 / NHTSA 14V-438
Ignition Switch
2005 - 2007 (WK) Jeep Grand Cherokee
2006 - 2007 (XK) Jeep Commander
The ignition switch on about 640,000 of the above vehicles may experience an
unintended change in ignition switch position while driving. This may result in a
loss of engine power, power steering assist, power brake assist or disable the
airbag function. Disabling one or more of the vehicle’s safety features could
increase the risk of vehicle occupant injury during a crash and/or cause a crash
without warning.
The ignition switch and lock cylinder must be replaced.
SPECIAL NOTE: To prevent any misunderstandings about the modification
performed to the vehicle, be sure to explain to the customer the new process
to turn the ignition off (push and turn).
Models
IMPORTANT: Some of the involved vehicles may be in dealer used vehicle
inventory. Dealers should complete this recall service on these vehicles
before retail delivery. Dealers should also perform this recall on vehicles in for
service. Involved vehicles can be determined by using the VIP inquiry process.
Subject
Repair
Copyright 2015, FCA US LLC, All Rights Reserved (wah)
Safety Recall P41 – Ignition Switch Page 2
Part Number Description
CBXTP411AA Ignition Cylinder/Lock Package
Each package contains the following components:
Quantity Description
1 Cylinder, Lock
5 Tumbler, #1 size
5 Tumbler, #2 size
5 Tumbler, #3 size
5 Tumbler, #4 size
2 Pin, Lock Cylinder
2 Spring, Lock Cylinder Spring
11 Springs, Tumbler
1 Grease, Tumbler
Each dealer to whom vehicles in the recall were assigned will receive enough
Ignition Cylinder/Lock Packages to service about 20% of those vehicles.
Part Number Description
CBXTP412AA Switch, Ignition
Part Number Description
CBXTP413AA Label, “Push and Turn”
NOTE: One of each of the above parts must be ordered to repair
each involved vehicle.
No parts return required for this campaign.
No special tools are required to perform this service procedure.
Parts Information
Parts Return
Special Tools
Safety Recall P41 – Ignition Switch Page 3
1. Disconnect the negative battery
cable from battery.
2. Using a plastic trim stick, carefully
remove and save the ignition switch
bezel (Figure 1).
NOTE: The ignition switch bezel
snaps off.
3. Remove and save the silencer pad
(two screws) (Figure 2).
4. Remove and save the knee blocker
(Figure 2).
Service Procedure
Figure 1 – Ignition Switch Bezel
Figure 2 – Silencer Pad and Knee Blocker
IGNITION SWITCH BEZEL
PLASTIC TRIM STICK
KNEE BLOCKER
SILENCER PAD
Safety Recall P41 – Ignition Switch Page 4
5. Using a T20 TORX® bit,
remove and save the two key
cylinder housing retaining
screws (Figure 3).
6. Remove and save the instrument
panel bezel (Figure 4 or
Figure 5).
Service Procedure (Continued)
Figure 3 – Key Cylinder Housing Retaining Screws
Figure 4 – WK Instrument Panel Bezel
KEY CYLINDER HOUSING
RETAINING SCREWS
INSTRUMENT PANEL BEZEL
Safety Recall P41 – Ignition Switch Page 5
7. Using a T20 TORX® bit, remove
and save the one key cylinder
housing retaining screw
(Figure 6).
8. Carefully lower the key cylinder
housing assembly and disconnect
two electrical connectors (one at
ignition switch and one at Sentry
Key REmote Entry Module
[SKREEM]).
Service Procedure (Continued)
Figure 5 – XK Instrument Panel Bezel
Figure 6 – Third Key Cylinder Retaining Screw Location
INSTRUMENT PANEL BEZEL
T20 TORX SCREWDRIVER
Safety Recall P41 – Ignition Switch Page 6
9. With the key in the ignition and
in the “RUN” position, press the
park lock cable release tab and
disconnect the cable from the key
cylinder assembly (Figure 7).
10. Place the ignition key cylinder
assembly on a clean work bench
(Figure 8).
11. Remove and save the SKREEM
unit from switch housing
(Figure 8).
Service Procedure (Continued)
Figure 7 – Park Lock Cable Release Tab
Figure 8 – Ignition Key Cylinder Assembly
PARK LOCK
CABLE
PARK LOCK CABLE
RELEASE
TAB
IGNITION
SWITCH
SKREEM UNIT
KEY
IGNITION SWITCH
SKREEM UNIT
KEY
IGNITION SWITCH HOUSING
PARK LOCK CABLE ANCHOR
Safety Recall P41 – Ignition Switch Page 7
12. Using a T10 TORX® bit, remove
and save the one ignition switch
retaining screw from the ignition
switch housing (Figure 9).
13. Using needle nose pliers,
simultaneously press in the two
ignition switch release tabs and
remove the original ignition
switch by pulling the ignition
switch from the ignition switch
housing (Figure 10).
Service Procedure (Continued)
Figure 9 – Ignition Switch Retaining Screw
Figure 10 – Ignition Switch Removal
IGNITION SWITCH
IGNITION SWITCH RETAINING
SCREW
PARK LOCK CABLE ANCHOR
IGNITION SWITCH HOUSING
IGNITION SWITCH
IGNITION SWITCH RELEASE TABS
IGNITION LOCK CASE
IGNITION LOCK
CYLINDER
NEEDLE NOSE PLIERS
Safety Recall P41 – Ignition Switch Page 8
14. Remove and discard the original key lock cylinder from the ignition switch
housing by rotating the key to the “ON” position. Then press on the release tab
and pull the ignition lock case out of the ignition switch housing (Figure 11).
15. Use the following procedure to determine the key code for the vehicle.
a. Log onto DealerCONNECT.
b. Select the “Service” tab.
c. In the “Repair Information” box select “Key Code”.
d. Enter the vehicle VIN number.
e. Select “Reason Code” number 2 “Lock/Replacement Key”.
f. Enter password.
g. Check the small box in the disclaimer box.
h. Select “Search”.
i. Write down the key code information for future reference.
Service Procedure (Continued)
Figure 11 – Remove Original Key Lock Cylinder from Ignition Switch Housing
IGNITION LOCK CYLINDER RELEASE
TAB
RELEASE TAB
WINDOW
IGNITION LOCK CASE
IGNITION SWITCH
HOUSING
KEY
Safety Recall P41 – Ignition Switch Page 9
16. Use the following procedure to code the tumblers for the new lock cylinder to
the original vehicle key:
a. Using the key code obtained in Step 15 of this procedure, use the Key
Code-to-Tumbler Code chart (pages 17 through 32) in this document to
determine the correct tumbler code. Write down the tumbler code for future
reference.
b. Using the tumbler code obtained in Step 16a., layout the tumblers as shown
in Figure 12.
NOTE: The tumblers in the kit are in plastic bags labeled 1 through 4.
Also the tumblers are stamped with a number 1 through 4.
Service Procedure (Continued)
Key Code
M1658
Tumbler Code
2 4 3 3 1 2 1
THE OPENING FOR THE KEY MUST BE ON THE
LEFT SIDE WHEN LAYING OUT THE TUMBLERS
LOCK TUMBLER
Figure 12 – Determining Correct Tumblers and Locations
IGNITION LOCK
CYLINDER
TUMBLER SPRING
HOLES
Safety Recall P41 – Ignition Switch Page 10
c. Place a tumbler spring into the
ignition lock cylinder slot hole
closest to the key side of the
ignition lock cylinder
(Figure 13).
NOTE: The kit contains extra
tumbler springs in case one is
lost and/or damaged during
installation.
d. Insert the correct tumbler for the
first tumbler slot (Figure 13).
CAUTION: Do not force the
tumbler into the ignition lock
cylinder. Use a rocking motion
to engage the tumbler into the
ignition lock cylinder. When the tumbler is properly installed it will not
come out and is spring loaded.
NOTE: The kit contains extra tumblers in order to accommodate all
tumbler codes. The extra tumblers can be discarded or saved for future
repairs.
e. Rotate the ignition lock cylinder ½ turn and install a tumbler spring into the
second ignition lock cylinder slot hole.
f. Insert the correct tumbler for the next tumbler slot.
CAUTION: Do not force the tumbler into the housing. Use a rocking
motion to engage the tumbler into the ignition lock cylinder. When the
tumbler is properly installed it will not come out and is spring loaded.
g. Repeat Steps 16e. and 16f. until all seven lock tumblers have been installed
into the ignition lock cylinder.
17. Push the spring-loaded tumblers into the ignition lock cylinder and insert the
ignition key into the ignition lock cylinder.
Service Procedure (Continued)
Figure 13 – Tumbler and Spring Installation
IGNITION LOCK
CYLINDER
TUMBLER
SPRING
LOCK TUMBLER
Safety Recall P41 – Ignition Switch Page 11
18. Use the following procedure to test fit the ignition lock cylinder into the lock
cylinder (Figure 14):
a. Insert the ignition lock cylinder into the key cylinder (no detent springs or
pin installed).
b. Turn the ignition lock cylinder from stop-to-stop while it is inserted into the
key cylinder:
If there is no binding while turning the ignition lock cylinder, continue
with Step 20 of this procedure.
If there is any binding while turning the ignition lock cylinder, continue
with Step 19 of this procedure.
Service Procedure (Continued)
Figure 14 – Insert Ignition lock cylinder into Lock Cylinder (without Detent Springs and Pins) and Check for Binding
IGNITION LOCK CASE
IGNITION LOCK
CYLINDER
KEY
DETENT SPRING AND DETENT PIN NOT INSTALLED DURING TEST FIT
DETENT SPRING AND DETENT PIN
NOT INSTALLED DURING TEST FIT
Safety Recall P41 – Ignition Switch Page 12
19. Use the following procedure to eliminate any binding of the ignition lock
cylinder in the ignition lock case:
a. Remove the ignition lock cylinder from the ignition lock case.
b. Verify that the correct lock tumblers have been installed.
c. Verify that the key was cut correctly.
d. Verify that the key is not bent, excessively worn or damaged.
NOTE: If a damaged key(s) is found, the cost of key(s) replacement is
the customer’s responsibility.
e. Test fit the ignition lock cylinder in the ignition lock case. There should be
absolutely no binding when turning the ignition lock cylinder. If binding is
still present, repeat Step 19 of this procedure.
CAUTION: Be sure that there is no binding when turning the ignition
lock cylinder in the ignition lock case. If there is binding, determine the
cause and correct the condition. The ignition lock cylinder cannot be
assembled until the binding condition has been identified and the cause
corrected.
Service Procedure (Continued)
Safety Recall P41 – Ignition Switch Page 13
20. Remove the ignition lock cylinder
from the ignition lock case.
21. Apply grease to the detent springs
and detent pins (Figure 15).
22. Install the two detent springs and pins into the ignition lock case (Figure 15).
23. Apply the provided grease to the
ignition lock cylinder tumblers and
the inside of the ignition lock case
(Figure 16).
Service Procedure (Continued)
Figure 15 – Install Detent Springs and Pins
Figure 16 – Grease Tumblers and Ignition Lock Cylinder
IGNITION LOCK CASE
DETENT PIN
IGNITION LOCK
CYLINDER
GREASE
LOWER TUMBLERS
Safety Recall P41 – Ignition Switch Page 14
24. With the ignition key in the ignition lock cylinder, insert the assembly into the
ignition lock case. Turn the ignition lock cylinder clockwise to the key stop
(Figure 17).
NOTE: The first time the ignition lock cylinder is turned to the key stop,
it will require extra effort to get past the detent pins. Verify that the
“Push to Turn” feature is functioning properly.
Service Procedure (Continued)
Figure 17 – Insert Ignition Lock Cylinder into the Ignition Lock Case
IGNITION LOCK CASE
IGNITION LOCK CYLINDER
KEY
DETENT PIN
DETENT PIN
Safety Recall P41 – Ignition Switch Page 15
25. Rotate the key to the “ON” position (lock cylinder retaining tab on side of
ignition lock case can now be depressed) (Figure 18).
26. Insert the lock cylinder assembly into the ignition switch housing (Figure 18).
27. Push the new ignition switch onto the back of the ignition switch housing until
the two retaining tabs snap into place.
28. Using a T10 TORX® bit, install the ignition switch retaining screw.
29. Install the SKREEM module onto the key cylinder assembly.
Service Procedure (Continued)
Figure 18 – Insert Key Lock Cylinder into Lock Housing
IGNITION SWITCH HOUSING
LOCK CYLINDER ASSEMBLY
KEY
LOCK CYLINDER RETAINING TAB
LOCK CYLINDER RETAINING TAB
WINDOW
Safety Recall P41 – Ignition Switch Page 16
30. Test the function of the ignition lock assembly by rotating the key to all
positions. Verify that there is no binding when turning the ignition key.
Correct any binding condition if present before installing the ignition lock
assembly into the vehicle.
31. Use the following procedure to install the ignition lock assembly into the
vehicle:
a. With the key in the ignition and in the “RUN” position, insert the park lock
cable into the key cylinder assembly.
b. Connect two electrical connectors (one at ignition switch and one at Sentry
Key REmote Entry Module [SKREEM]).
c. Place the key cylinder housing assembly into position in the instrument
panel.
d. Using a T20 TORX® bit, install the three key cylinder housing screws.
e. Install the instrument panel bezel.
f. Install the knee blocker.
g. Install the silencer pad (two screws).
h. Install the ignition switch bezel.
32. Connect the negative battery cable to the negative battery post.
Service Procedure (Continued)
Safety Recall P41 – Ignition Switch Page 17
33. Install the “Push and Turn” label in the location shown in Figure 19.
34. Return the vehicle to the customer.
SPECIAL NOTE: To prevent any misunderstandings about the ignition
switch modification performed to the vehicle, explain the new process to
turn the ignition off (push and turn) to the customer.
Service Procedure (Continued)
Figure 19 – “Push and Turn” Label Installation Location
IGNITION KEY
INFORMATION LABEL
Safety Recall P41 – Ignition Switch Page 18
Key Code Tumbler
Code
M0001 2431242
M0002 3133213
M0003 1234311
M0004 1324332
M0005 3432234
M0006 3431312
M0007 4323313
M0008 1244322
M0009 2311211
M0010 1122431
M0011 3434312
M0012 2431312
M0013 4344232
M0014 1233423
M0015 4311224
M0016 3323121
M0017 4243422
M0018 2122313
M0019 2113312
M0020 3131134
M0021 4342432
M0022 1344322
M0023 3442342
M0024 3232312
M0025 1212133
M0026 1343113
M0027 3232132
M0028 2213242
M0029 4321313
M0030 3312132
M0031 3442431
M0032 2323424
M0033 2342124
M0034 2331211
M0035 4213211
M0036 4323132
M0037 2132131
M0038 4234231
M0039 4423311
M0040 4342433
M0041 3212242
M0042 4332342
M0043 2442113
Key Code Tumbler
Code
M0044 3342121
M0045 4324332
M0046 2442442
M0047 2331121
M0048 3224311
M0049 2434312
M0050 3112322
M0051 3421113
M0052 1313131
M0053 2131134
M0054 3432121
M0055 2434223
M0056 2423131
M0057 2131242
M0058 2421312
M0059 2132244
M0060 3212133
M0061 3112134
M0062 4213234
M0063 2433442
M0064 1231233
M0065 2112313
M0066 2431132
M0067 4223343
M0068 3421221
M0069 4342123
M0070 3311231
M0071 2233113
M0072 3121134
M0073 4332132
M0074 2423334
M0075 2422131
M0076 4321212
M0077 2112113
M0078 3443244
M0079 3422433
M0080 3312231
M0081 4242443
M0082 3434231
M0083 4212321
M0084 3321324
M0085 3313132
M0086 2234313
Key Code Tumbler
Code
M0087 4422124
M0088 3323442
M0089 4324323
M0090 2312311
M0091 3134321
M0092 2312432
M0093 1124322
M0094 4421232
M0095 3421132
M0096 1221313
M0097 3244242
M0098 3442311
M0099 2332132
M0100 2424231
M0101 3113242
M0102 2321313
M0103 4332421
M0104 4432231
M0105 3324224
M0106 2323242
M0107 4321311
M0108 3423242
M0109 3312332
M0110 1134432
M0111 3423424
M0112 2433232
M0113 4243234
M0114 3424312
M0115 3431212
M0116 4232443
M0117 3112233
M0118 2312131
M0119 3313443
M0120 4431312
M0121 3132131
M0122 3242313
M0123 4331121
M0124 1323132
M0125 3113224
M0126 4343242
M0127 1323432
M0128 1343423
M0129 3242124
Key Code Tumbler
Code
M0130 2344234
M0131 3113124
M0132 3242442
M0133 2312212
M0134 4312443
M0135 2313232
M0136 4242231
M0137 3131223
M0138 3343224
M0139 1242433
M0140 3231132
M0141 4313124
M0142 2132242
M0143 3234422
M0144 3231313
M0145 1133424
M0146 2212243
M0147 2443234
M0148 2424432
M0149 2232234
M0150 2231131
M0151 3424231
M0152 3243312
M0153 1232113
M0154 2124231
M0155 3434442
M0156 3422443
M0157 2113342
M0158 3221331
M0159 4211321
M0160 4434331
M0161 3442221
M0162 3323213
M0163 3224243
M0164 4224434
M0165 4224421
M0166 4332121
M0167 2332343
M0168 2113344
M0169 3132344
M0170 1224424
M0171 2121242
M0172 2113313
Safety Recall P41 – Ignition Switch Page 19
Key Code Tumbler
Code
M0173 3323342
M0174 3231133
M0175 3131332
M0176 2324442
M0177 3321332
M0178 3112433
M0179 3232231
M0180 2421123
M0181 1334423
M0182 1313242
M0183 3422131
M0184 4223134
M0185 3313431
M0186 3313124
M0187 3431224
M0188 3442421
M0189 3434221
M0190 2342121
M0191 3312124
M0192 3432134
M0193 1313443
M0194 3424232
M0195 4232121
M0196 1344332
M0197 1132434
M0198 2324332
M0199 3223123
M0200 2324221
M0201 1332342
M0202 1224312
M0203 3242243
M0204 3242212
M0205 3213334
M0206 4232323
M0207 2313343
M0208 2432234
M0209 3122332
M0210 2432243
M0211 4232131
M0212 1131234
M0213 3313311
M0214 3132213
M0215 1322131
Key Code Tumbler
Code
M0216 2421321
M0217 2342332
M0218 4342312
M0219 1322121
M0220 2443312
M0221 3234431
M0222 4332313
M0223 1242424
M0224 4243324
M0225 2132421
M0226 4244331
M0227 1123313
M0228 3131322
M0229 1212424
M0230 4324321
M0231 3322432
M0232 3213221
M0233 2244212
M0234 1123244
M0235 4311212
M0236 3324342
M0237 3442324
M0238 3134432
M0239 4223334
M0240 3322434
M0241 1231323
M0242 2112331
M0243 2212132
M0244 4313231
M0245 2443422
M0246 3234311
M0247 4321332
M0248 3421323
M0249 2343334
M0250 2342134
M0251 2124221
M0252 3421212
M0253 1312312
M0254 2421134
M0255 2423312
M0256 3113231
M0257 3211332
M0258 2134432
Key Code Tumbler
Code
M0259 2323342
M0260 2323421
M0261 2243131
M0262 1233124
M0263 4342231
M0264 3121242
M0265 1332124
M0266 2323124
M0267 4332243
M0268 3422131
M0269 1331242
M0270 2342223
M0271 4223124
M0272 3132343
M0273 3133132
M0274 1242244
M0275 2321344
M0276 2213311
M0277 3131221
M0278 2133421
M0279 2342433
M0280 3324324
M0281 3424431
M0282 3242121
M0283 4243442
M0284 4432432
M0285 4342234
M0286 2433242
M0287 2331232
M0288 2342321
M0289 1321321
M0290 1213231
M0291 3112312
M0292 3123131
M0293 3132211
M0294 3431234
M0295 4242113
M0296 1313224
M0297 4332432
M0298 4324224
M0299 2331134
M0300 3434242
M0301 3131212
Key Code Tumbler
Code
M0302 4221311
M0303 3232422
M0304 2212231
M0305 3123121
M0306 3312323
M0307 2121121
M0308 2313133
M0309 1342321
M0310 4212212
M0311 4234312
M0312 2311312
M0313 3231211
M0314 2422442
M0315 4323342
M0316 4221113
M0317 2123313
M0318 2343242
M0319 4212311
M0320 2343134
M0321 4422343
M0322 4313312
M0323 4323213
M0324 3344313
M0325 2433423
M0326 2244324
M0327 4243132
M0328 1334322
M0329 3324331
M0330 2231212
M0331 3311221
M0332 1124312
M0333 2313244
M0334 4342244
M0335 2313424
M0336 1323121
M0337 3242123
M0338 2313432
M0339 3113312
M0340 3113322
M0341 2131224
M0342 4242243
M0343 1334234
M0344 2243212
Safety Recall P41 – Ignition Switch Page 20
Key Code Tumbler
Code
M0345 4233211
M0346 3123423
M0347 2234321
M0348 2342311
M0349 2243134
M0350 1133124
M0351 3324313
M0352 4311234
M0353 2324343
M0354 2334331
M0355 2311234
M0356 4421323
M0357 3113422
M0358 4431321
M0359 1224224
M0360 2232313
M0361 2112434
M0362 3134234
M0363 2312423
M0364 4332113
M0365 1244243
M0366 4332224
M0367 2243421
M0368 2421311
M0369 4422434
M0370 1313432
M0371 4233243
M0372 2431132
M0373 1212423
M0374 3313221
M0375 2313113
M0376 2342123
M0377 1343131
M0378 3321323
M0379 2433224
M0380 4342132
M0381 2132134
M0382 3431123
M0383 2313231
M0384 2243243
M0385 4244243
M0386 2112423
M0387 1321334
Key Code Tumbler
Code
M0388 2324212
M0389 1344324
M0390 4431132
M0391 4313334
M0392 4322443
M0393 4332311
M0394 1244332
M0395 4231311
M0396 3424311
M0397 3321124
M0398 1234422
M0399 2321233
M0400 3122442
M0401 2324433
M0402 4211322
M0403 2234243
M0404 3113324
M0405 1131331
M0406 1344234
M0407 3113331
M0408 1122331
M0409 2432223
M0410 2113423
M0411 2343231
M0412 3231343
M0413 3323242
M0414 2133212
M0415 2234423
M0416 1242322
M0417 4231231
M0418 3112342
M0419 2121331
M0420 2243321
M0421 2321113
M0422 2134443
M0423 1243431
M0424 4344231
M0425 2234224
M0426 4232331
M0427 2123242
M0428 3342212
M0429 3244313
M0430 3232431
Key Code Tumbler
Code
M0431 4322323
M0432 4221121
M0433 1124421
M0434 3243431
M0435 3344231
M0436 2424243
M0437 4224342
M0438 2433132
M0439 2443132
M0440 2431234
M0441 1331312
M0442 2132313
M0443 3113434
M0444 2442211
M0445 2232442
M0446 3311331
M0447 1224432
M0448 2242113
M0449 1343324
M0450 2213313
M0451 1342113
M0452 2313211
M0453 3342331
M0454 4324244
M0455 2334313
M0456 4331322
M0457 3312131
M0458 1334432
M0459 3443442
M0460 2432442
M0461 2112433
M0462 4432243
M0463 1322432
M0464 2342211
M0465 3121331
M0466 1231332
M0467 2134211
M0468 1323342
M0469 1343224
M0470 3242443
M0471 1332232
M0472 3324243
M0473 3432211
Key Code Tumbler
Code
M0474 2432131
M0475 1331234
M0476 2323132
M0477 3224442
M0478 1244213
M0479 3424321
M0480 2443344
M0481 1343342
M0482 4323344
M0483 3434212
M0484 2334442
M0485 3221344
M0486 2124344
M0487 3323131
M0488 3423442
M0489 4334223
M0490 2431134
M0491 3133434
M0492 4423312
M0493 3213331
M0494 2243344
M0495 3121243
M0496 3121343
M0497 4313323
M0498 3442321
M0499 1122422
M0500 3442232
M0501 3211213
M0502 1233133
M0503 3442313
M0504 2431332
M0505 4343134
M0506 2423443
M0507 3131131
M0508 3211243
M0509 1313312
M0510 2342224
M0511 4221312
M0512 4331113
M0513 2244234
M0514 2231211
M0515 2324223
M0516 2442431
Safety Recall P41 – Ignition Switch Page 21
Key Code Tumbler
Code
M0517 4243334
M0518 2312443
M0519 3133443
M0520 4311342
M0521 1211323
M0522 3424342
M0523 2233431
M0524 4334211
M0525 2134221
M0526 3124212
M0527 2124322
M0528 1224221
M0529 4213434
M0530 4223233
M0531 1322113
M0532 1331322
M0533 4331323
M0534 3123422
M0535 1311223
M0536 1242212
M0537 4244311
M0538 3323123
M0539 4321331
M0540 1242224
M0541 1124342
M0542 4323434
M0543 4213443
M0544 1124231
M0545 2342234
M0546 1232344
M0547 2324321
M0548 4324213
M0549 4324433
M0550 2423232
M0551 1244234
M0552 2234212
M0553 2343431
M0554 3233121
M0555 4224312
M0556 3243432
M0557 4431224
M0558 2442432
M0559 2242324
Key Code Tumbler
Code
M0560 3113431
M0561 3224343
M0562 2421121
M0563 1121323
M0564 1243342
M0565 2243224
M0566 3112223
M0567 3443424
M0568 3213313
M0569 1342334
M0570 4231323
M0571 2431123
M0572 2213324
M0573 2443342
M0574 2433432
M0575 3322313
M0576 2133124
M0577 1313133
M0578 2343331
M0579 3431311
M0580 3432231
M0581 2332423
M0582 3423423
M0583 3223113
M0584 1233432
M0585 2432331
M0586 4312313
M0587 2213343
M0588 2313121
M0589 3443223
M0590 1234431
M0591 2431342
M0592 3342134
M0593 3123223
M0594 2334421
M0595 4342221
M0596 2132423
M0597 1131242
M0598 3431113
M0599 4224343
M0600 2133431
M0601 1324224
M0602 2134311
Key Code Tumbler
Code
M0603 2344331
M0604 2334423
M0605 2442134
M0606 3122134
M0607 3342422
M0608 1132421
M0609 2421342
M0610 1131323
M0611 4234321
M0612 2442132
M0613 1231134
M0614 2133132
M0615 1343123
M0616 3223132
M0617 2231323
M0618 3132234
M0619 4332134
M0620 3113311
M0621 2424242
M0622 4234424
M0623 4431313
M0624 3112224
M0625 4212323
M0626 4342324
M0627 3113131
M0628 4242132
M0629 3113443
M0630 1343212
M0631 3134232
M0632 3132124
M0633 4313223
M0634 2431223
M0635 3213312
M0636 2442231
M0637 4232313
M0638 3233442
M0639 4423442
M0640 2324423
M0641 2421232
M0642 4323312
M0643 3431332
M0644 4421331
M0645 3221131
Key Code Tumbler
Code
M0646 4431231
M0647 2443332
M0648 2113223
M0649 2423433
M0650 2423131
M0651 4343131
M0652 4311324
M0653 4343421
M0654 3124223
M0655 1243132
M0656 4334313
M0657 2423113
M0658 1124223
M0659 3344224
M0660 2133131
M0661 4312322
M0662 3223312
M0663 4312232
M0664 1334311
M0665 2234442
M0666 1234234
M0667 3213442
M0668 3344321
M0669 3131243
M0670 2113231
M0671 3424442
M0672 2121113
M0673 3422121
M0674 4234212
M0675 2434244
M0676 4242434
M0677 2133432
M0678 1132211
M0679 4244212
M0680 3123234
M0681 1342311
M0682 3324211
M0683 2443242
M0684 3232321
M0685 2213332
M0686 1212421
M0687 1324243
M0688 2344243
Safety Recall P41 – Ignition Switch Page 22
Key Code Tumbler
Code
M0689 3442332
M0690 2312242
M0691 2344221
M0692 3432113
M0693 3123424
M0694 3133244
M0695 2344231
M0696 1313134
M0697 3344331
M0698 4243244
M0699 3313432
M0700 3131242
M0701 1313313
M0702 1334431
M0703 3424221
M0704 3433231
M0705 4432442
M0706 3313243
M0707 3421321
M0708 3311233
M0709 1312443
M0710 3342123
M0711 4312134
M0712 2311321
M0713 1322311
M0714 1123224
M0715 3134422
M0716 1342242
M0717 3233134
M0718 1332132
M0719 3421131
M0720 3323113
M0721 2124211
M0722 3112442
M0723 1313233
M0724 1244232
M0725 3243313
M0726 2134324
M0727 1343243
M0728 3124221
M0729 4224211
M0730 2332113
M0731 2334232
Key Code Tumbler
Code
M0732 2124423
M0733 3123344
M0734 3123232
M0735 2113331
M0736 4212312
M0737 1322324
M0738 3243223
M0739 2313224
M0740 1343432
M0741 3122133
M0742 3133121
M0743 2432332
M0744 3124243
M0745 2442344
M0746 1242334
M0747 3134311
M0748 3243332
M0749 3313422
M0750 2323231
M0751 3342332
M0752 2124324
M0753 2342113
M0754 4431322
M0755 3324233
M0756 2342344
M0757 4224423
M0758 2331232
M0759 3233242
M0760 3122131
M0761 4334431
M0762 3432442
M0763 2312133
M0764 3234442
M0765 2342443
M0766 3424244
M0767 3342323
M0768 2332124
M0769 2211343
M0770 1313212
M0771 1243432
M0772 3443342
M0773 3242322
M0774 3223131
Key Code Tumbler
Code
M0775 2422334
M0776 3432224
M0777 2334242
M0778 3121332
M0779 4223434
M0780 3422424
M0781 3442234
M0782 2321212
M0783 2134423
M0784 2442332
M0785 3242332
M0786 1123132
M0787 3231234
M0788 3234313
M0789 3424233
M0790 2424234
M0791 2134421
M0792 1243243
M0793 1243211
M0794 3244342
M0795 1213242
M0796 2424324
M0797 3313212
M0798 2334311
M0799 1344223
M0800 4424234
M0801 4213232
M0802 3213324
M0803 1313124
M0804 3342113
M0805 2124422
M0806 2113433
M0807 3112313
M0808 2332421
M0809 1134423
M0810 1213223
M0811 1321234
M0812 4224244
M0813 1131313
M0814 1321231
M0815 3124323
M0816 2131332
M0817 3431134
Key Code Tumbler
Code
M0818 4224234
M0819 4431124
M0820 3112432
M0821 4242331
M0822 4211324
M0823 3112321
M0824 2423121
M0825 2134312
M0826 1313321
M0827 3113223
M0828 3312134
M0829 2431231
M0830 3321132
M0831 3243244
M0832 2244312
M0833 3122344
M0834 1311322
M0835 4331232
M0836 4234342
M0837 1124244
M0838 2433211
M0839 2342212
M0840 2432334
M0841 3213234
M0842 2443322
M0843 1132313
M0844 4342442
M0845 3122443
M0846 4233421
M0847 3431131
M0848 2313443
M0849 3123213
M0850 2423442
M0851 3131123
M0852 4424431
M0853 3421123
M0854 3113424
M0855 3122434
M0856 1243124
M0857 4242344
M0858 4424211
M0859 1322331
M0860 4323423
Safety Recall P41 – Ignition Switch Page 23
Key Code Tumbler
Code
M0861 4423221
M0862 2443313
M0863 4332423
M0864 1242123
M0865 4242121
M0866 2312242
M0867 1221322
M0868 4243242
M0869 3221134
M0870 3124244
M0871 2322431
M0872 4234423
M0873 3443121
M0874 4324442
M0875 4433212
M0876 3342211
M0877 1343443
M0878 3224213
M0879 4422313
M0880 3113313
M0881 3443324
M0882 3244321
M0883 3224313
M0884 2113124
M0885 3224234
M0886 2232423
M0887 4211234
M0888 3234231
M0889 1324342
M0890 2112343
M0891 3442124
M0892 3313234
M0893 1231322
M0894 2231113
M0895 1334211
M0896 3431321
M0897 2332213
M0898 3124324
M0899 2121344
M0900 1132242
M0901 3343422
M0902 3223134
M0903 2324211
Key Code Tumbler
Code
M0904 2133121
M0905 3221313
M0906 1331231
M0907 4313344
M0908 3342311
M0909 3123244
M0910 3124233
M0911 4321221
M0912 2433121
M0913 3212131
M0914 3431211
M0915 3431221
M0916 3242232
M0917 3231113
M0918 3113344
M0919 4224331
M0920 3342423
M0921 2244242
M0922 3212134
M0923 2313223
M0924 2442121
M0925 2124311
M0926 2323423
M0927 2332443
M0928 4321124
M0929 3131133
M0930 4232431
M0931 3242421
M0932 4311233
M0933 4323424
M0934 3211224
M0935 1223134
M0936 3121231
M0937 3424443
M0938 2344232
M0939 1313223
M0940 3113123
M0941 2243221
M0942 1323133
M0943 3323134
M0944 2132422
M0945 4223323
M0946 4312434
Key Code Tumbler
Code
M0947 1124321
M0948 4423432
M0949 3432132
M0950 1234312
M0951 2424342
M0952 2131313
M0953 3213343
M0954 4342242
M0955 2311243
M0956 1232133
M0957 3234242
M0958 3121223
M0959 3231232
M0960 2334422
M0961 2344332
M0962 4434242
M0963 3313434
M0964 3421124
M0965 3121334
M0966 3424242
M0967 2133123
M0968 2112342
M0969 2113321
M0970 1224423
M0971 3212442
M0972 2112224
M0973 1312132
M0974 3324223
M0975 3343134
M0976 2124213
M0977 2112421
M0978 2422134
M0979 3442434
M0980 2434332
M0981 2343212
M0982 3342334
M0983 1321134
M0984 1231242
M0985 1331221
M0986 2113243
M0987 4344211
M0988 1342221
M0989 3134243
Key Code Tumbler
Code
M0990 2312313
M0991 3113234
M0992 4421211
M0993 1231113
M0994 3213321
M0995 3322311
M0996 3123342
M0997 2443311
M0998 2443131
M0999 3211313
M1000 3211242
M1001 2134431
M1002 2134321
M1003 2422124
M1004 3234342
M1005 2124321
M1006 2344312
M1007 3432342
M1008 2243223
M1009 3243211
M1010 2112121
M1011 3342432
M1012 2122334
M1013 3323422
M1014 2131343
M1015 2321311
M1016 4211343
M1017 3234323
M1018 1331131
M1019 3232242
M1020 4334324
M1021 2421224
M1022 3213232
M1023 4331131
M1024 3242433
M1025 3212313
M1026 2132124
M1027 3213224
M1028 4223442
M1029 2133113
M1030 3431334
M1031 2334224
M1032 1323211
Safety Recall P41 – Ignition Switch Page 24
Key Code Tumbler
Code
M1033 4432131
M1034 2443224
M1035 3223431
M1036 2433123
M1037 3324322
M1038 1243321
M1039 2321134
M1040 1331331
M1041 1242311
M1042 3421242
M1043 1312231
M1044 1134311
M1045 2122311
M1046 3434324
M1047 4242313
M1048 1212342
M1049 2133422
M1050 4324324
M1051 4224432
M1052 3131331
M1053 3123334
M1054 3112443
M1055 4343221
M1056 2132331
M1057 3342421
M1058 2112244
M1059 1332423
M1060 3121244
M1061 1243234
M1062 4324312
M1063 2424332
M1064 3113133
M1065 3113242
M1066 2231332
M1067 4421332
M1068 4223443
M1069 2343423
M1070 3213131
M1071 3433421
M1072 1243332
M1073 3322443
M1074 4343121
M1075 2242321
Key Code Tumbler
Code
M1076 2313323
M1077 3113221
M1078 4342311
M1079 1323234
M1080 2244223
M1081 4232421
M1082 2131231
M1083 4423423
M1084 1123421
M1085 3123433
M1086 4431343
M1087 3211343
M1088 2112211
M1089 3313121
M1090 2242312
M1091 4233232
M1092 4234234
M1093 4433243
M1094 1342223
M1095 2442321
M1096 2133442
M1097 4213243
M1098 3134322
M1099 4242424
M1100 3434244
M1101 4232433
M1102 3134431
M1103 3322421
M1104 4313421
M1105 3134332
M1106 3242131
M1107 3122422
M1108 2422443
M1109 3221121
M1110 1232134
M1111 4213342
M1112 3213424
M1113 1332134
M1114 3134221
M1115 2443421
M1116 1134312
M1117 3211312
M1118 2324311
Key Code Tumbler
Code
M1119 1243242
M1120 4233443
M1121 4334423
M1122 3312123
M1123 2432131
M1124 4432433
M1125 3343231
M1126 4313433
M1127 3423324
M1128 1321243
M1129 4343244
M1130 2321324
M1131 4243424
M1132 3232312
M1133 2331244
M1134 1124224
M1135 3213113
M1136 3113442
M1137 4422132
M1138 3324432
M1139 3344342
M1140 1123113
M1141 3242324
M1142 4244232
M1143 2311234
M1144 3442134
M1145 3133242
M1146 4223244
M1147 3311311
M1148 4424324
M1149 1344242
M1150 1334232
M1151 3221113
M1152 2431221
M1153 4434332
M1154 4234224
M1155 3423331
M1156 1342124
M1157 1324223
M1158 4424323
M1159 4432423
M1160 2434431
M1161 4212432
Key Code Tumbler
Code
M1162 2123331
M1163 2443223
M1164 3223121
M1165 2131323
M1166 2324331
M1167 3324323
M1168 3313131
M1169 4431134
M1170 3213243
M1171 2343421
M1172 2342232
M1173 4224324
M1174 2324424
M1175 1243212
M1176 2442434
M1177 1234223
M1178 4322332
M1179 3421231
M1180 1234211
M1181 2113242
M1182 4324311
M1183 4312421
M1184 4221212
M1185 3313223
M1186 2423213
M1187 4324343
M1188 4343432
M1189 2133234
M1190 3232423
M1191 4233442
M1192 1131123
M1193 4432311
M1194 3243311
M1195 2422421
M1196 4323443
M1197 4312211
M1198 2424431
M1199 2424234
M1200 1131322
M1201 3243124
M1202 2312231
M1203 1243113
M1204 4234422
Safety Recall P41 – Ignition Switch Page 25
Key Code Tumbler
Code
M1205 4243221
M1206 2243312
M1207 4421134
M1208 2311342
M1209 1124243
M1210 4232434
M1211 3131313
M1212 3132133
M1213 2432433
M1214 4211224
M1215 3242311
M1216 2422313
M1217 4334421
M1218 1313244
M1219 1324323
M1220 3342431
M1221 1244331
M1222 4321123
M1223 3244213
M1224 4324234
M1225 1312334
M1226 4324423
M1227 3443131
M1228 3224324
M1229 1132231
M1230 2312134
M1231 2431313
M1232 1321132
M1233 1331311
M1234 1233424
M1235 1224421
M1236 3132223
M1237 2123443
M1238 2311231
M1239 3242344
M1240 2434232
M1241 2432121
M1242 3212322
M1243 1342234
M1244 2213432
M1245 4212113
M1246 3323431
M1247 3421311
Key Code Tumbler
Code
M1248 3343113
M1249 2343132
M1250 4232332
M1251 4232322
M1252 3442424
M1253 2113442
M1254 4421313
M1255 1334242
M1256 3342121
M1257 3122432
M1258 4211334
M1259 4231221
M1260 1334243
M1261 4324243
M1262 1312134
M1263 2422132
M1264 3233113
M1265 2134244
M1266 4234324
M1267 3211233
M1268 1313231
M1269 1234324
M1270 4332312
M1271 4232211
M1272 2231121
M1273 3122424
M1274 1242121
M1275 4422331
M1276 2443331
M1277 3124342
M1278 2131331
M1279 3113212
M1280 2113334
M1281 3431322
M1282 3123421
M1283 3112334
M1284 3343312
M1285 2234311
M1286 3213431
M1287 3431242
M1288 3242342
M1289 1313221
M1290 2313321
Key Code Tumbler
Code
M1291 3312423
M1292 1344331
M1293 2442123
M1294 3213433
M1295 4422443
M1296 2112421
M1297 1344231
M1298 3234211
M1299 3221211
M1300 4243344
M1301 1343422
M1302 3421234
M1303 3433124
M1304 3233212
M1305 2211322
M1306 3344221
M1307 1123442
M1308 1331124
M1309 1224442
M1310 4432424
M1311 1211332
M1312 3113423
M1313 3124242
M1314 4332424
M1315 1311331
M1316 3123432
M1317 3422123
M1318 2231344
M1319 3244311
M1320 4342124
M1321 2313312
M1322 2313212
M1323 1343134
M1324 2343432
M1325 4323322
M1326 1244324
M1327 2231311
M1328 2133232
M1329 4342332
M1330 4224321
M1331 4243342
M1332 3242134
M1333 2243123
Key Code Tumbler
Code
M1334 3313423
M1335 2422113
M1336 2242433
M1337 3243121
M1338 3234233
M1339 3113233
M1340 2334234
M1341 3122331
M1342 4342431
M1343 3424332
M1344 2443244
M1345 2234421
M1346 3124343
M1347 4311243
M1348 2422434
M1349 3442322
M1350 3234221
M1351 1231313
M1352 3321133
M1353 4324212
M1354 3422323
M1355 1212331
M1356 2124421
M1357 1231243
M1358 3232311
M1359 4423334
M1360 4212134
M1361 4342423
M1362 4211233
M1363 3443331
M1364 1234221
M1365 3131231
M1366 3213231
M1367 4433242
M1368 2442331
M1369 3312343
M1370 1232424
M1371 1331134
M1372 3424432
M1373 4324432
M1374 3123442
M1375 4332434
M1376 1334421
Safety Recall P41 – Ignition Switch Page 26
Key Code Tumbler
Code
M1377 3442331
M1378 3322423
M1379 3212344
M1380 1311343
M1381 2311331
M1382 3213134
M1383 2313243
M1384 2132133
M1385 3434421
M1386 2124431
M1387 3424323
M1388 4224443
M1389 2423243
M1390 2423343
M1391 4242211
M1392 2244221
M1393 4342223
M1394 1233442
M1395 2133424
M1396 3213121
M1397 3321321
M1398 3442442
M1399 2113132
M1400 3422313
M1401 4342342
M1402 2121322
M1403 3234212
M1404 3212331
M1405 4334342
M1406 3421313
M1407 1122313
M1408 2432224
M1409 2442342
M1410 4242442
M1411 1121243
M1412 1243221
M1413 3244212
M1414 1213313
M1415 3434232
M1416 4311321
M1417 1134242
M1418 3212434
M1419 3442131
Key Code Tumbler
Code
M1420 1311223
M1421 3432311
M1422 3133231
M1423 4324242
M1424 4232134
M1425 2442223
M1426 4244322
M1427 1343211
M1428 4223223
M1429 4223231
M1430 3112423
M1431 3133234
M1432 3434223
M1433 2134212
M1434 2313221
M1435 4334331
M1436 1134212
M1437 2243313
M1438 3134433
M1439 4432312
M1440 2231221
M1441 1211242
M1442 3134343
M1443 2324232
M1444 1324231
M1445 3211324
M1446 1332244
M1447 1234423
M1448 1344343
M1449 3244211
M1450 2442233
M1451 2443221
M1452 2112443
M1453 2312121
M1454 3223213
M1455 3124312
M1456 4343313
M1457 2331132
M1458 3434342
M1459 1124442
M1460 1344232
M1461 3232432
M1462 2213244
Key Code Tumbler
Code
M1463 3242431
M1464 1323243
M1465 3132113
M1466 1313331
M1467 1231224
M1468 4321322
M1469 4224313
M1470 2344223
M1471 3422421
M1472 3311223
M1473 4323131
M1474 3443124
M1475 2211313
M1476 4221134
M1477 3134443
M1478 1343311
M1479 4324422
M1480 3244231
M1481 4221124
M1482 3121321
M1483 3443242
M1484 2432124
M1485 3442123
M1486 2123231
M1487 4232442
M1488 3242211
M1489 2134322
M1490 3313211
M1491 2213212
M1492 3442244
M1493 4234432
M1494 4313442
M1495 3431243
M1496 4233113
M1497 4423321
M1498 4231243
M1499 4332124
M1500 1331233
M1501 4312242
M1502 2442312
M1503 3112243
M1504 1134223
M1505 4422433
Key Code Tumbler
Code
M1506 1232242
M1507 2344212
M1508 1332431
M1509 1342323
M1510 2112424
M1511 1324321
M1512 2421231
M1513 4421242
M1514 4424422
M1515 4212121
M1516 3424421
M1517 4422134
M1518 4424342
M1519 1132113
M1520 1242442
M1521 2243322
M1522 3112331
M1523 3131224
M1524 1332123
M1525 4311323
M1526 1221331
M1527 2123131
M1528 3311322
M1529 4431331
M1530 2343121
M1531 1311313
M1532 3242224
M1533 2242343
M1534 4234213
M1535 2321113
M1536 3443134
M1537 2321242
M1538 4312332
M1539 4313232
M1540 3212231
M1541 3121313
M1542 2124424
M1543 3134233
M1544 2123242
M1545 3243442
M1546 2234243
M1547 2432211
M1548 4432342
Safety Recall P41 – Ignition Switch Page 27
Key Code Tumbler
Code
M1549 2123442
M1550 3122311
M1551 4231324
M1552 4312331
M1553 1134342
M1554 2442211
M1555 4311242
M1556 1242132
M1557 2343442
M1558 3124224
M1559 4324424
M1560 2432342
M1561 3112332
M1562 4313132
M1563 4232113
M1564 1313123
M1565 3121124
M1566 4212113
M1567 3211342
M1568 3243323
M1569 2244231
M1570 4211312
M1571 1312243
M1572 2442422
M1573 3231244
M1574 3243132
M1575 3313113
M1576 2213431
M1577 2342243
M1578 1344312
M1579 3213311
M1580 4213344
M1581 2242234
M1582 3433242
M1583 3123313
M1584 2132433
M1585 2324243
M1586 1243223
M1587 2311213
M1588 3242131
M1589 3421312
M1590 2332224
M1591 1342343
Key Code Tumbler
Code
M1592 1223424
M1593 1243423
M1594 2421344
M1595 2232331
M1596 3432242
M1597 3242113
M1598 1231231
M1599 2434442
M1600 2132231
M1601 1211244
M1602 3131321
M1603 4311332
M1604 3421244
M1605 3312324
M1606 2424443
M1607 3423212
M1608 3123123
M1609 2431334
M1610 3133131
M1611 3112231
M1612 3343232
M1613 4242433
M1614 3123331
M1615 3123231
M1616 4344332
M1617 1133421
M1618 4331234
M1619 2422424
M1620 1343121
M1621 4323324
M1622 4223132
M1623 2422421
M1624 2133423
M1625 4234221
M1626 1231234
M1627 3132232
M1628 1134243
M1629 3243321
M1630 4312311
M1631 2344242
M1632 2332231
M1633 4244332
M1634 1121332
Key Code Tumbler
Code
M1635 3423344
M1636 2132343
M1637 3224212
M1638 4424233
M1639 1323424
M1640 4243131
M1641 3443123
M1642 4224334
M1643 4213224
M1644 2231313
M1645 2423423
M1646 3244322
M1647 2321124
M1648 3124311
M1649 3242432
M1650 2431343
M1651 3223124
M1652 4234242
M1653 4331123
M1654 2234223
M1655 4223344
M1656 4213134
M1657 2431231
M1658 2433121
M1659 2424233
M1660 1324212
M1661 2124234
M1662 3122313
M1663 1321342
M1664 4224243
M1665 1242321
M1666 1224311
M1667 2421211
M1668 3243123
M1669 2443113
M1670 1343431
M1671 1213321
M1672 3431121
M1673 4343123
M1674 3134312
M1675 3243423
M1676 3134423
M1677 3424422
Key Code Tumbler
Code
M1678 2434421
M1679 3211322
M1680 1211224
M1681 4322313
M1682 3344212
M1683 4242124
M1684 4231131
M1685 3422343
M1686 4331332
M1687 4432343
M1688 4242421
M1689 1242432
M1690 3243232
M1691 3132424
M1692 4223313
M1693 4324233
M1694 2234331
M1695 2342331
M1696 4242423
M1697 3243331
M1698 3232134
M1699 3131124
M1700 2211231
M1701 4434232
M1702 4234311
M1703 1334212
M1704 2434322
M1705 2313134
M1706 3234423
M1707 2242443
M1708 2213221
M1709 3211244
M1710 1311232
M1711 4211242
M1712 3221133
M1713 1332211
M1714 2123332
M1715 2423321
M1716 2423424
M1717 2334324
M1718 1223121
M1719 3244312
M1720 3242323
Safety Recall P41 – Ignition Switch Page 28
Key Code Tumbler
Code
M1721 3234232
M1722 2434224
M1723 3442432
M1724 4422321
M1725 1311342
M1726 2431244
M1727 3124334
M1728 3123324
M1729 3311232
M1730 2313131
M1731 4431223
M1732 3434423
M1733 4224442
M1734 3433134
M1735 3244221
M1736 2231242
M1737 3442334
M1738 2422433
M1739 2443324
M1740 3343242
M1741 4322433
M1742 4421121
M1743 2343342
M1744 1343242
M1745 1223113
M1746 1233123
M1747 3112323
M1748 2343224
M1749 3123211
M1750 1212313
M1751 3421343
M1752 2424434
M1753 4212423
M1754 3213423
M1755 3433232
M1756 3442132
M1757 2313431
M1758 3432332
M1759 1324244
M1760 3131233
M1761 3211321
M1762 1243231
M1763 4432132
Key Code Tumbler
Code
M1764 1312124
M1765 2243442
M1766 4312431
M1767 3242331
M1768 3212124
M1769 3312424
M1770 4232343
M1771 1311334
M1772 2134313
M1773 1324233
M1774 3213212
M1775 4331224
M1776 2442213
M1777 2334432
M1778 1133131
M1779 4312212
M1780 3243422
M1781 3421331
M1782 2433223
M1783 2334431
M1784 3423231
M1785 4423324
M1786 2434231
M1787 1312423
M1788 1213443
M1789 1324242
M1790 2332131
M1791 3433422
M1792 2434422
M1793 2124442
M1794 1243323
M1795 2133231
M1796 3344311
M1797 1334324
M1798 3232132
M1799 1212322
M1800 4234233
M1801 2432221
M1802 1331344
M1803 2442243
M1804 4422442
M1805 3324234
M1806 4232123
Key Code Tumbler
Code
M1807 1244342
M1808 3224211
M1809 3343442
M1810 2332431
M1811 1132422
M1812 4422424
M1813 1131332
M1814 2343113
M1815 2334212
M1816 4313343
M1817 4331321
M1818 3131344
M1819 2132223
M1820 4324334
M1821 4212422
M1822 2434242
M1823 3312432
M1824 3123243
M1825 2433243
M1826 1343332
M1827 2343124
M1828 4342212
M1829 3223421
M1830 2434342
M1831 3312431
M1832 3231334
M1833 2433234
M1834 3443421
M1835 2424421
M1836 2344311
M1837 2213242
M1838 2313124
M1839 3432312
M1840 3431232
M1841 4343422
M1842 3233422
M1843 3434224
M1844 1343322
M1845 3233424
M1846 2132442
M1847 2443424
M1848 1342231
M1849 4211342
Key Code Tumbler
Code
M1850 3132231
M1851 1123231
M1852 1223331
M1853 3423443
M1854 2213131
M1855 2434321
M1856 2313234
M1857 2112133
M1858 3231322
M1859 2324342
M1860 2131243
M1861 4231342
M1862 1131243
M1863 2332242
M1864 3424344
M1865 1134321
M1866 3112124
M1867 4212431
M1868 4213324
M1869 3223432
M1870 2331123
M1871 2124312
M1872 3244332
M1873 3344223
M1874 2423221
M1875 3112243
M1876 2211334
M1877 3123224
M1878 2324213
M1879 2432312
M1880 3231121
M1881 2122331
M1882 3312321
M1883 2342131
M1884 3123134
M1885 3343324
M1886 3344243
M1887 3434321
M1888 1342131
M1889 4332331
M1890 3223423
M1891 2213134
M1892 2332132
Safety Recall P41 – Ignition Switch Page 29
Key Code Tumbler
Code
M1893 2442443
M1894 3231342
M1895 3133113
M1896 3132342
M1897 1243311
M1898 2432321
M1899 3134324
M1900 3122433
M1901 3423322
M1902 2133211
M1903 2211213
M1904 3442312
M1905 3122124
M1906 2123134
M1907 2243433
M1908 4322421
M1909 2343324
M1910 4234332
M1911 3213344
M1912 1244242
M1913 4211243
M1914 3123133
M1915 4242432
M1916 1242312
M1917 2234342
M1918 4312133
M1919 2424442
M1920 4243332
M1921 2313342
M1922 2242124
M1923 4234244
M1924 2442421
M1925 4334232
M1926 4243124
M1927 4343224
M1928 2231133
M1929 4311311
M1930 4342424
M1931 4231332
M1932 1243123
M1933 4433131
M1934 2113134
M1935 2331223
Key Code Tumbler
Code
M1936 4231123
M1937 2243342
M1938 2312113
M1939 3342232
M1940 4211213
M1941 1133231
M1942 2323313
M1943 2311243
M1944 3131311
M1945 4433221
M1946 4232213
M1947 3122123
M1948 2324312
M1949 3311224
M1950 4234243
M1951 2431212
M1952 4221323
M1953 2231331
M1954 3432423
M1955 1223242
M1956 1242134
M1957 4313322
M1958 3234224
M1959 3134421
M1960 4224344
M1961 4433121
M1962 2343123
M1963 4243432
M1964 1212421
M1965 4323223
M1966 4212121
M1967 2323223
M1968 2121342
M1969 1244313
M1970 2242431
M1971 3132331
M1972 4231223
M1973 4324221
M1974 3343421
M1975 4421113
M1976 4334234
M1977 3112434
M1978 3422312
Key Code Tumbler
Code
M1979 2134332
M1980 1243312
M1981 4234334
M1982 4233434
M1983 2134234
M1984 2234221
M1985 3443224
M1986 3434424
M1987 1232421
M1988 4331211
M1989 4242342
M1990 4233121
M1991 3343124
M1992 3121344
M1993 1231321
M1994 4224213
M1995 1242124
M1996 3121312
M1997 2312343
M1998 3422342
M1999 3342242
M2000 3433442
M2001 1231312
M2002 2423334
M2003 2242231
M2004 3112234
M2005 2244332
M2006 2213422
M2007 2343311
M2008 1323113
M2009 4213133
M2010 4243223
M2011 3443132
M2012 3443311
M2013 4211211
M2014 2323434
M2015 2433124
M2016 3421322
M2017 2431113
M2018 3134442
M2019 2443134
M2020 2134331
M2021 1223131
Key Code Tumbler
Code
M2022 3312433
M2023 2343422
M2024 3443312
M2025 1122311
M2026 2233421
M2027 4231212
M2028 1322343
M2029 4244313
M2030 3121323
M2031 4334311
M2032 3211231
M2033 4311344
M2034 3234421
M2035 2232243
M2036 1244224
M2037 4234431
M2038 3213211
M2039 4311312
M2040 3244243
M2041 3134211
M2042 1224212
M2043 2432232
M2044 3323424
M2045 2231244
M2046 1232331
M2047 3423121
M2048 4331134
M2049 4322424
M2050 1321113
M2051 2233132
M2052 4331213
M2053 3442242
M2054 3433431
M2055 1233212
M2056 3421342
M2057 1124424
M2058 2433113
M2059 3112344
M2060 2132332
M2061 2131322
M2062 3424334
M2063 2434221
M2064 2422343
Safety Recall P41 – Ignition Switch Page 30
Key Code Tumbler
Code
M2065 4342344
M2066 2443442
M2067 2243311
M2068 3431223
M2069 3223231
M2070 3442113
M2071 2442242
M2072 2312324
M2073 3324232
M2074 3234223
M2075 4322434
M2076 3132322
M2077 3121234
M2078 3443113
M2079 1343234
M2080 4212332
M2081 4422421
M2082 2312331
M2083 3121233
M2084 3243322
M2085 3213244
M2086 2424423
M2087 1232313
M2088 3342234
M2089 3133212
M2090 2423342
M2091 4322331
M2092 4232424
M2093 1312313
M2094 2432123
M2095 4334224
M2096 1312331
M2097 1242423
M2098 3442224
M2099 2442323
M2100 2431311
M2101 2442334
M2102 2343121
M2103 3132313
M2104 4334422
M2105 2113424
M2106 3224323
M2107 2213123
Key Code Tumbler
Code
M2108 4242233
M2109 2431322
M2110 3213133
M2111 3423232
M2112 2243432
M2113 4321323
M2114 4343212
M2115 3422322
M2116 2432443
M2117 3212433
M2118 3234332
M2119 2324244
M2120 2311334
M2121 3131312
M2122 4424242
M2123 4234343
M2124 2242211
M2125 4343342
M2126 2124432
M2127 2342131
M2128 3122343
M2129 4244342
M2130 4312323
M2131 4242312
M2132 1334221
M2133 2331342
M2134 2321242
M2135 3342224
M2136 3124321
M2137 3322342
M2138 2331331
M2139 3121322
M2140 1332432
M2141 1232442
M2142 3433224
M2143 2131234
M2144 3312211
M2145 1332121
M2146 4211244
M2147 2342342
M2148 1213134
M2149 2344211
M2150 2234312
Key Code Tumbler
Code
M2151 1342123
M2152 3243212
M2153 3324332
M2154 2423133
M2155 3112242
M2156 1311243
M2157 1134221
M2158 1132442
M2159 3242423
M2160 3224331
M2161 4311221
M2162 3313342
M2163 2234434
M2164 4244211
M2165 1322313
M2166 2132424
M2167 2443431
M2168 1243422
M2169 4321132
M2170 3123322
M2171 1133132
M2172 2244311
M2173 4243311
M2174 2421132
M2175 3443423
M2176 3243334
M2177 4243321
M2178 2132211
M2179 2344224
M2180 2334211
M2181 3442231
M2182 1342212
M2183 3122423
M2184 4313224
M2185 3431124
M2186 2122442
M2187 3132121
M2188 4321131
M2189 3313344
M2190 3433244
M2191 2342324
M2192 3324242
M2193 3422332
Key Code Tumbler
Code
M2194 3434331
M2195 3224233
M2196 4342334
M2197 4322442
M2198 4432321
M2199 4342321
M2200 4234433
M2201 2432424
M2202 1213124
M2203 4243433
M2204 3432443
M2205 3132244
M2206 2434424
M2207 3421134
M2208 2442423
M2209 2332231
M2210 2324313
M2211 1324221
M2212 4313443
M2213 4323243
M2214 3113244
M2215 4343324
M2216 3134224
M2217 2312123
M2218 4334242
M2219 3422331
M2220 1123422
M2221 1212442
M2222 2243423
M2223 3112424
M2224 2242134
M2225 1323422
M2226 3213342
M2227 2334221
M2228 3244324
M2229 2432134
M2230 4242334
M2231 2244334
M2232 2343312
M2233 3244234
M2234 2242132
M2235 3442344
M2236 4332322
Safety Recall P41 – Ignition Switch Page 31
Key Code Tumbler
Code
M2237 2431131
M2238 3421132
M2239 4423424
M2240 4342422
M2241 3132421
M2242 1343221
M2243 3132123
M2244 3342443
M2245 1331321
M2246 3313244
M2247 3213124
M2248 3113134
M2249 2311342
M2250 2242231
M2251 1121342
M2252 1342342
M2253 3213322
M2254 2334231
M2255 2243131
M2256 1242342
M2257 4234442
M2258 3323211
M2259 2421322
M2260 2342221
M2261 2422331
M2262 2334312
M2263 1242232
M2264 4313424
M2265 2331344
M2266 1313322
M2267 2433422
M2268 1342244
M2269 3211331
M2270 1343421
M2271 1344321
M2272 3213123
M2273 2332432
M2274 2321331
M2275 3213223
M2276 1234244
M2277 3424434
M2278 3422113
M2279 2433213
Key Code Tumbler
Code
M2280 2443124
M2281 3242223
M2282 1234212
M2283 4323421
M2284 1343232
M2285 1212232
M2286 1334342
M2287 1244211
M2288 3344232
M2289 2242421
M2290 3132334
M2291 3434311
M2292 4433423
M2293 3234312
M2294 2442324
M2295 2323134
M2296 4423343
M2297 3231344
M2298 3343132
M2299 2311324
M2300 1231123
M2301 4313434
M2302 4343423
M2303 3423342
M2304 3442443
M2305 3311213
M2306 3243242
M2307 2233231
M2308 3422442
M2309 3243231
M2310 3212424
M2311 3421332
M2312 3211323
M2313 2331124
M2314 3132421
M2315 2121211
M2316 3343431
M2317 3442223
M2318 3431342
M2319 1242231
M2320 2443321
M2321 2344342
M2322 3443231
Key Code Tumbler
Code
M2323 2421232
M2324 4331343
M2325 4243312
M2326 2442124
M2327 2121313
M2328 3423243
M2329 4421322
M2330 2421323
M2331 4424423
M2332 1344224
M2333 2134422
M2334 4334432
M2335 3113432
M2336 4431232
M2337 1242343
M2338 3122324
M2339 3312422
M2340 2244321
M2341 3123431
M2342 4213323
M2343 3322132
M2344 2443231
M2345 4233424
M2346 3124443
M2347 4432124
M2348 2431124
M2349 4313321
M2350 2311242
M2351 3224223
M2352 4232224
M2353 4343431
M2354 3134342
M2355 1231331
M2356 4312422
M2357 3123124
M2358 2313331
M2359 4343311
M2360 2131312
M2361 2332134
M2362 3432331
M2363 2233224
M2364 2424324
M2365 4234323
Key Code Tumbler
Code
M2366 4323311
M2367 4323244
M2368 3342322
M2369 3311242
M2370 3432432
M2371 2443232
M2372 2443123
M2373 3422321
M2374 3234331
M2375 4332232
M2376 2212124
M2377 2242243
M2378 4232232
M2379 4344312
M2380 4244221
M2381 2424211
M2382 3313231
M2383 2423331
M2384 2433231
M2385 1334422
M2386 1321331
M2387 2323443
M2388 4343331
M2389 1213132
M2390 1331212
M2391 1123133
M2392 3123113
M2393 4323124
M2394 2424323
M2395 1331313
M2396 3134323
M2397 4434313
M2398 3422124
M2399 3113321
M2400 3344312
M2401 4344313
M2402 2242132
M2403 1332424
M2404 4332231
M2405 3424322
M2406 3123343
M2407 2344324
M2408 2421244
Safety Recall P41 – Ignition Switch Page 32
Key Code Tumbler
Code
M2409 3232342
M2410 1312342
M2411 4242134
M2412 4233423
M2413 3121224
M2414 4313244
M2415 4224433
M2416 3124332
M2417 1232433
M2418 2213331
M2419 2243124
M2420 3113433
M2421 2434212
M2422 1321242
M2423 3211334
M2424 1223313
M2425 3313123
M2426 3122431
M2427 2431321
M2428 1123331
M2429 2432113
M2430 3134242
M2431 1324423
M2432 3213421
M2433 1233121
M2434 4424432
M2435 2213234
M2436 4323123
M2437 2421212
M2438 4233133
M2439 3433113
M2440 1313311
M2441 2342312
M2442 3244331
M2443 4243423
M2444 2313422
M2445 2323344
M2446 3213422
M2447 1132224
M2448 1224321
M2449 1213331
M2450 3434234
M2451 1321123
Key Code Tumbler
Code
M2452 3423132
M2453 2432212
M2454 2113432
M2455 4332442
M2456 4323442
M2457 4244242
M2458 3423311
M2459 4332443
M2460 4331242
M2461 4231242
M2462 1132134
M2463 3421211
M2464 1234231
M2465 2442234
M2466 3113332
M2467 3231232
M2468 1224322
M2469 3433132
M2470 3244232
M2471 4243231
M2472 2431224
M2473 3342244
M2474 1122423
M2475 1342132
M2476 2423123
M2477 2331224
M2478 2243331
M2479 3311212
M2480 3232443
M2481 2212342
M2482 3233131
M2483 1321313
M2484 2424344
M2485 3224342
M2486 3122334
M2487 3132442
M2488 1133442
M2489 2342442
M2490 2433134
M2491 4423342
M2492 4313134
M2493 4423433
M2494 1243131
Key Code Tumbler
Code
M2495 4242321
M2496 2323431
M2497 3112132
M2498 1224232
M2499 4221132
M2500 2134224
M2501 2334342
M2502 2313311
M2503 1323431
M2504 3431343
M2505 2233422
M2506 3432124
M2507 1312321
M2508 3422134
M2509 2311313
M2510 1332422
M2511 2121133
M2512 1342312
M2513 3442422
M2514 4243212
M2515 3324421
M2516 3423432
M2517 4233432
M2518 4231132
M2519 4433123
M2520 2131321
M2521 4423243
M2522 2343244
M2523 2443212
M2524 4323231
M2525 3423124
M2526 4322431
M2527 4432223
M2528 1313424
M2529 3422311
M2530 3432434
M2531 4433113
M2532 1232131
M2533 3443321
M2534 2323132
M2535 2332342
M2536 4211231
M2537 2232424
Key Code Tumbler
Code
M2538 2231124
M2539 2432324
M2540 4424243
M2541 3312312
M2542 3323244
M2543 3231331
M2544 4344331
M2545 3133243
M2546 4424332
M2547 2432343
M2548 3124234
M2549 3434211
M2550 3324423
M2551 3133123
M2552 4342131
M2553 3431131
M2554 3213432
M2555 2313123
M2556 3442212
M2557 4334212
M2558 4334243
M2559 3242221
M2560 4231124
M2561 3243421
M2562 4334221
M2563 2312124
M2564 1324312
M2565 1324311
M2566 2211331
M2567 1342332
M2568 3432243
M2569 4221232
M2570 2423211
M2571 1322311
M2572 4221321
M2573 1234332
M2574 2434331
M2575 1334332
M2576 4243431
M2577 4322312
M2578 2424422
M2579 2244342
M2580 1321312
Key Code Tumbler
Code
M2581 3134212
2582 3232224
M2583 1132331
M2584 3121132
M2585 2233134
M2586 2124212
M2587 2321121
M2588 4331312
M2589 3311313
M2590 2321131
M2591 3243342
M2592 3321312
M2593 4231234
M2594 2421124
M2595 1232124
M2596 4242223
M2597 2342334
M2598 3224221
M2599 3343322
M2600 2434311
M2601 4422312
M2602 1213312
M2603 4343113
M2604 4324342
M2605 3342342
M2606 4223424
M2607 2442121
M2608 4232221
M2609 2324334
M2610 1331224
M2611 1312242
M2612 2112442
M2613 4243123
M2614 4344242
M2615 4224424
M2616 2422132
M2617 3322331
M2618 4324431
Safety Recall P41 – Ignition Switch Page 34
DRAFT
Claims for vehicles that have been serviced must be submitted on the
DealerCONNECT Claim Entry Screen located on the Service tab. Claims
submitted will be used by FCA to record recall service completions and provide
dealer payments.
Use the following labor operation numbers and time allowances:
Labor Operation Time
Number Allowance
Replace ignition switch and
lock cylinder (WK models) 23-P4-11-82 0.8 hours
Replace ignition switch and
lock cylinder (XK models) 23-P4-11-83 0.9 hours
Add the cost of the recall parts package plus applicable dealer allowance to your
claim.
NOTE: See the Warranty Administration Manual, Recall Claim Processing
Section, for complete recall claim processing instructions.
To view this notification on DealerCONNECT, select “Global Recall System” on
the Service tab, then click on the description of this notification.
All involved vehicle owners known to FCA are being notified of the service
requirement by first class mail. They are requested to schedule appointments for this
service with their dealers. A generic copy of the owner letter is attached.
Enclosed with each owner letter is an Owner Notification postcard to allow owners
to update our records if applicable.
Completion Reporting and Reimbursement
Dealer Notification
Owner Notification and Service Scheduling
Safety Recall P41 – Ignition Switch Page 35
DRAFT
All involved vehicles have been entered into the DealerCONNECT Global Recall
System (GRS) and Vehicle Information Plus (VIP) for dealer inquiry as needed.
GRS provides involved dealers with an updated VIN list of their incomplete
vehicles. The owner’s name, address and phone number are listed if known.
Completed vehicles are removed from GRS within several days of repair claim
submission.
To use this system, click on the “Service” tab and then click on “Global Recall
System.” Your dealer’s VIN list for each recall displayed can be sorted by: those
vehicles that were unsold at recall launch, those with a phone number, city, zip
code, or VIN sequence.
Dealers must perform this repair on all unsold vehicles before retail delivery.
Dealers should also use the VIN list to follow up with all owners to schedule
appointments for this repair.
Recall VIN lists may contain confidential, restricted owner name and address information that
was obtained from the Department of Motor Vehicles of various states. Use of this information
is permitted for this recall only and is strictly prohibited from all other use.
If you have any questions or need assistance in completing this action, please
contact your Service and Parts District Manager.
Customer Services / Field Operations
FCA US LLC
Vehicle Lists, Global Recall System, VIP and Dealer Follow Up
Additional Information
______________________________________________________________________________________
IMPORTANT SAFETY RECALL P41 / NHTSA 14V-438
This notice applies to your vehicle (VIN: xxxxxxxxxxxxxxxxx).
This notice is sent to you in accordance with the National Traffic and Motor Vehicle Safety Act.
Dear: (Name)
FCA has decided that a defect, which relates to motor vehicle safety, exists in certain 2005 through 2007 model
year Jeep® Grand Cherokee vehicles and 2006 and 2007 model year Jeep® Commander vehicles.
The problem is... The ignition switch on your vehicle may experience an unintended change in ignition
switch position while driving. This may result in a loss of engine power, power steering
assist, power brake assist or disable the airbag function. Disabling one or more of the
vehicle’s safety features could increase the risk of vehicle occupant injury during a
crash and/or cause a crash without warning
What your dealer
will do... FCA will repair your vehicle free of charge. To do this, your dealer will replace the
ignition switch and lock cylinder. The work will take about one hour to complete. However,
additional time may be necessary depending on service schedules.
What you must do
to ensure your
safety...
Simply contact your Chrysler, Jeep, Dodge or RAM dealer right away to schedule a
service appointment. Ask the dealer to hold the parts for your vehicle or to order them
before your appointment. Please bring this letter with you to your dealer.
If you need help... If you have questions or concerns which your dealer is unable to resolve, please contact the
FCA Group Recall Assistance Center at either recalls.mopar.com or 1-800-853-1403.
Please help us update our records by filling out the attached prepaid postcard if any of the conditions listed on the
card apply to you or your vehicle. If you have further questions go to recalls.mopar.com.
If you have already experienced this specific condition and have paid to have it repaired, you may visit
www.fcarecallreimbursement.com to submit your reimbursement request online or you can mail your original
receipts and proof of payment to the following address for reimbursement consideration: FCA Customer
Assistance, P.O. Box 21-8004, Auburn Hills, MI 48321-8007, Attention: Recall Reimbursement. Once we
receive and verify the required documents, reimbursement will be sent to you within 60 days. If you’ve had
previous repairs and/or reimbursement you may still need to have the recall repair performed on your vehicle.
If your dealer fails or is unable to remedy this defect without charge and within a reasonable time, you may submit
a written complaint to the Administrator, National Highway Traffic Safety Administration, 1200 New Jersey Ave.,
S.E., Washington, DC 20590, or you can call the toll-free Vehicle Safety Hotline at 1-888-327-4236
(TTY 1-800-424-9153), or go to safercar.gov.
We're sorry for any inconvenience, but we are sincerely concerned about your safety. Thank you for your attention
to this important matter.
Customer Services / Field Operations
FCA US LLC
Note to lessors receiving this recall: Federal regulation requires that you forward this recall notice to the lessee within 10 days.
IGNITION SWITCH