““REMOVE the STRAIN”REMOVE the STRAIN”

General MaintenanceGeneral Maintenance

• EngineEngine• GeneratorGenerator• Water SystemsWater Systems• Waste SystemsWaste Systems• Overall BoatOverall Boat• Air ConditioningAir Conditioning

EnginesEngines

• Oil LevelsOil Levels• Lower unit oilLower unit oil

– Upper and lower plugsUpper and lower plugs• Oil injection gellingOil injection gelling• Fuel filter-Primary and secondaryFuel filter-Primary and secondary• Grease fittingsGrease fittings• Pull prop- Check for fishing line and lube Pull prop- Check for fishing line and lube

shaft (Special 101)shaft (Special 101)• Corrosion Prevention- Corrosion blockCorrosion Prevention- Corrosion block• Exercise sea cockExercise sea cock

GeneratorGenerator

• StrainerStrainer• OilOil• AntifreezeAntifreeze• Fuel FilterFuel Filter• Power Tune for gummed up carburetorPower Tune for gummed up carburetor• ImpellerImpeller• Anodes in heat exchangerAnodes in heat exchanger• Salt buildup in Catalytic Converter Salt buildup in Catalytic Converter

(Kohler)(Kohler)• Exercise sea cockExercise sea cock

Water SystemsWater Systems

• FilterFilter• Add one ounce of bleach for each 10 Add one ounce of bleach for each 10

gallons of watergallons of water• O-Ring on fill capO-Ring on fill cap

Waste SystemsWaste Systems

• ““Blue Goo” – Very important on vacuflushBlue Goo” – Very important on vacuflush• Clean seal vacu-flush- No AbrasiveClean seal vacu-flush- No Abrasive• Correct toilet paperCorrect toilet paper• Bleach in shower sump pumps monthly Bleach in shower sump pumps monthly

and flushand flush• Trap in sink drains or keep plug in when Trap in sink drains or keep plug in when

not in usenot in use• Exercise sea cockExercise sea cock• Vent FilterVent Filter

Sink

½”CO

OverallOverall

• Rust stain away for stainless-Flush with water Rust stain away for stainless-Flush with water and then coat with corrosion blockand then coat with corrosion block

• Touch up drive/lower unitTouch up drive/lower unit• Pro-polish (Shurhold) or other good waxPro-polish (Shurhold) or other good wax• Woody WaxWoody Wax• Plexus for isinglassPlexus for isinglass• Non Ammonia glass cleanerNon Ammonia glass cleaner• Candle Wax for zippers Candle Wax for zippers • Vaseline with cotton swab for snapsVaseline with cotton swab for snaps• Clean dock lines mild soap and fabric softenerClean dock lines mild soap and fabric softener• Check anchor clevis for wear and safety wireCheck anchor clevis for wear and safety wire

Air ConditioningAir Conditioning

ACAC