pre-feasibility report - welcome to...

PRE-FEASIBILITY REPORT

OF

CHEJA PATHAR (MASONARY STONE)

MINING PROJECT

(M.L. No. 94/2005, ML Area: 1.0 ha)

Near

(Village- Kundala ki Dhani)

Tehsil - Neem Ka Thana

District- Sikar (Raj.)

PROJECT PROPONENT

Shri Ashok Kumar S/o Shri Ram Kumar Gurjar

1381, S.G.M. Nagar, Faridabad (Haryana)

Pin Code-121001

Contact Person: Shri Manoj Kumar

Contact No.: 9649803020

INDEX

S. NO. PARTICULARS PAGE NO.

1.0 EXECUTIVE SUMMARY 1

2.0 ENVIRONMENTAL MANAGEMENT PLAN 1

2.1.1 AIR POLLUTION CONTROL 1

2.1.2 WATER MANAGEMENT 1

2.1.3 NOISE POLLUTION CONTROL MEASURES 2

2.1.4 LAND RECLAMATION 2

2.1.5 SOLID WASTE MANAGEMENT 2

2.1.6 GREENBELT DEVELOPMENT 2

3.0 INTRODUCTION OF THE PROJECT/ BACKGROUND INFORMATION 2

4.0 Project Description 3

5.0 Site analysis 8

6.0 Planning brief 11

7.0 Proposed infrastructure 11

8.0 Rehabilitation and resettlement (R&R) plan 12

9.0 Project schedule & cost estimates 12

10.0 Analysis of proposal 13

Cheja Pathar (Masonary Stone) Mining Project (M.L. No.94/05, ML Area 1.0 ha)

Near Village: Kundala Ki Dhani, Tehsil –Neem Ka Thana, District-Sikar (Rajasthan)

Pre- Feasibility Report

Shri Ashok Kumar S/o Shri Ram Kumar Gurjar 1

PRE – FEASIBILITY REPORT

1.0 EXECUTIVE SUMMARY

Table-1

Salient features of the Project

S. No. Particulars Details

A. Mining Lease Details

1 Nature of the Project Cheja pathar (Masonary Stone) Mining project

2 Mining Lease Number 94/05

3 Mining Lease Area 1.0 ha

4 Lease Holder (Proposed) Shri Ashok Kumar S/o Shri Ram Kumar Gurjar

B Location

5 Village Kundala Ki Dhani

6 Tehsil Neem Ka Thana

7 District Sikar

8 State Rajasthan

9 Latitude & Longitude FRP Well chhatri road Latitude - 27°46’05.6” N Longitude

- 75°54’19.58’’E

C. Requirement of the Project

10 Water Requirement 3 KLD

11 Manpower Requirement 32 person

12 Cost of the project Rs. 50 Lakhs

13 Cost for Environmental

Protection Measures

Rs. 1.5 lakhs per annum

14 Seismic Zone II

2.0 ENVIRONMENTAL MANAGEMENT PLAN

2.1.1 Air Pollution Control Measures

�� Periodical water spraying on the haul roads will be done.

�� Plantation will be done on lease boundary.

2.1.2 Water Management

�� There is no surface water body within the mining lease area.





�� The rain water collected in mining pit will be diverted in the abandoned pit of

major mineral mining lease and used for water sprinkling and plantation.

�� Domestic waste water generated from office toilet will be disposed in soak pits

via septic tank.

2.1.3 NOISE POLLUTION CONTROL MEASURES

�� Proper maintenance of all machines will be carried out which will reduce noise

generation during operations.

�� Workers exposed to high noise levels will be provided with ear defenders.

2.1.4 Land Reclamation

�� Total mining lease area 1.0 hectares.

�� The excavated area will be converted as water reservoir as well as plantation

on the lease boundary will be done.

2.1.5 Solid Waste Management

�� Lessee dispatches Cheja Pather as ROM. No sorting will take place at site. Thus,

waste will not be generated separately.

2.1.6 Green Belt Development

�� Green Belt will be developed around the mining lease area. Native species will

be planted Local Species will be preferred for plantation.

3.0 INTRODUCTION OF THE PROJECT/ BACKGROUND INFORMATION

Consent to Operate (CTO) has been issued by RSPCB. Now applying for

Environmental Clearance with Cheja Pathar (Masonary Stone) (M.L. No. 94/05, ML

Area 1.0 ha) located near Village: Kundala ki Dhani, Tehsil:Neem Ka Thana, District:

Sikar (Rajasthan) of Shri Ashok Kumar S/o Shri Ram Kumar Gurjar.

(I) Identification of Project and Project Proponent

Shri Ashok Kumar S/o Shri Ram Kumar Gurjar is has a mining lease for

Masonary stone, (M.L. No 94/05, Area 1.0 ha.) Village: Kundala ki Dhani,

Tehsil:Neem Ka Thana, District: Sikar (Rajasthan).

(ii) Brief Description of the Nature of Project

This is Cheja Pathar (Masonary Stone) Mining Project (M.L. No. 94/05, ML Area

1.0 ha).This is an opencast semi mechanized mining project.





(III) Need for the Project & Its Importance to the Country/ Region

The mineral Cheja Pathar (Masonary Stone) is used in various construction

activities and will be sold to nearby areas to fulfill the requirements of the local

region.

(IV) Demand – Supply Gap

Considering the demand of mineral sufficient availability of the mineral in the

area, it is essential to have Cheja Pathar (Masonary Stone) mine to sustain the

supply of mineral for construction purpose.

(v) Imports vs. Indigenous Production

It is a cheap mineral used in construction activities in rural therefore export is

not possible

(vi) Export Possibility

There is no export possibility as these mineral is quite cheap and locally

available in abundance and used in rural areas.

(vii) Domestic/Export Markets

These minerals have only domestic market and will fulfill the requirement of

local.

(viii) Employment Generation (Direct and Indirect) due to the Project

Approx 32 manpower will be needed to run the mine.

4.0 PROJECT DESCRIPTION

(i) Type of Project Including Interlinked And Independent Projects, If Any

There is no interlinked or interdependent project based on mineral produced.

The mineral will be sold directly.

(ii) Location (map showing general location, specific location, and project

boundary & project site layout) with coordinates





Figure1: Location Map





(iii) Details of Alternate Sites Considered

No alternative site has been taken into consideration due to availability of

mineral resources in the area in question.

(iv) Size and magnitude of operation

Proposed production of Cheja Pathar (Masonary Stone) 254000 TPA, Area 1.0

ha.

(v) Project Description with Process Detail

1. Salient features along with project vicinity details of the Mining

project is given below:

Table - 2

Salient Features of the Project

S. No. Particulars Details

1 Name of the Project Cheja pathar (Masonary Stone) Mining project

2 Mineral Cheja pathar (Masonary Stone)

3 Mining Lease Number 94/05

4 Mining Lease Area 1.0 ha

5 Lease Holder (Proposed) Shri Ashok Kumar S/o Shri Ram Kumar Gurjar

7 Elevation Range in the

area

417 mRL to 424 mRL

8 General ground level 400 mRL

10 Ultimate Working Depth 375 mRL

2. Geology of The Area

Mineral resource map of district the rocks of the area belong to Ajabgarh

group of Delhi Supeer Group.

Strategraphic sequence of Regional Geology is given below:

Recent Soil

Post Delhi Pegmatite, Granite, albetite

Delhi Super

Group

Ajabgarh Group Brecciated quartzite,quartzite,Ortho

Quartzite, Phyllite, Impure

marble,amphibolites,Carbonaceous

Phyllite,Quartzite, calc silicate

Alwar Group Massive quartzite,schist,conglomerate

quartzite,calc-silicate





LOCAL GEOLOGY

Recent Soil

Post Delhi Absent

Delhi Super Group Ajabgarh Group Quartzite

3. Method of Mining

Proposed method of mining will be semi mechanized opencast by

forming proper benches by driling, control blasting. The mining is

proposed as per present situation of the deposit.

Hydrauluic machinaries will be deployed for excavation of cheja pather

and loading of the cheja pather. Tippres will be deployed for the

transportation of the cheja pather.

PROCESS FLOW CHART OF MINING

TOP SOIL & O.B. REMOVAL

DRILLING

BLASTING

LOADING

TRANSPORT

TO CONSUMERS

4. Loading & Transport

Tyre mounted Hydraulic excavator will be deployed from time to time

and when required. Trucks and tracor troley will be deployed for

transportation of cheja pather.

5. Waste Generation & Disposal

The lessee dispatches Cheja Pather (Masonary Stone )as ROM. No sorting

will take place at site. Thus, waste will not be generated separately.





6. Conceptual Plan

The conceptual mining plan for 5 years considering proposed capacity of

mine for the mineral has been prepared by considering the probable

category of reserve excluding reserves falling in safety zone.

Area about 0.8518 ha. will be used in mining up to the end of life of

the mine up to 25.0 m. depth. & area about 0.1482 ha. will be used

in plantation on periphery of lease boundary.

At the conceptual stage of mining, the excavated area about 0.8518

ha. out of which area about 0.0204 ha will be backfilled &

reclaimed by Plantation and rest area about 0.8314 ha will be

converted in to water reservoir.

(vi) Raw Material Required Along With Estimated Quantity, Likely Source,

Marketing Area of Final Products, Mode of Transport of Raw Material and

Finished Product

The cheja pather (masonary stone) will be transported tipper and tractor

trolley. No raw material will be required.

(vii) Resources Optimization/ Recycling and Reuse Envisaged in the Project, if

any, should be briefly Outlined

No waste water will be generated from mining operation.Domestic sewage

water generated from office toilet will be disposed in soak pits via septic tank.

(viii) Availability of Water Its Source, Energy /Power Requirement and Source

A. Water requirement:

Total water requirement for the proposed project will be 3 KLD which

will be sourced from nearby villages.

B. Power requirement:

The electric power will not be use for the process of mining.

(ix) Quantity of Waste to Be Generated (Liquid and Solid) And Scheme for

Their Management/Disposal:

Domestic sewage water generated from office toilet will be disposed in soak

pits via septic tank.





5.0 SITE ANALYSIS

(i) Connectivity

The lease area about 1 km from Kundala Ki Dhani. Dispensary, hospital and

educational facilities are available in Neem Ka Thana. Railway line is available

in Neem Ka Thana which is at a distance of about 13 km. The lease area is well

connected through roads.

(ii) Land Form, Land Use and Land Ownership

Existing Land Use Pattern

The total ML area of 1.0 ha comprises of Govt. land.

(iii) Topography

The lease area is undulated terrains. The highest contour is 424 mRL and

lowest is 417 mRL. This provides elevation difference of 7 m RL.

(iv) Existing Land Use Pattern {Agriculture, Non-Agriculture, Forest, Water

Bodies (Including Area Under CRZ)}, Shortest Distances From The

Periphery Of The Project To Periphery Of The Forests, National Park,

Wild Life Sanctuary, Eco Sensitive Areas, Water Bodies (Distance From

The HFL Of The River), CRZ. In Case Of Notified Industrial Area, A Copy Of

The Gazette Notification.

Table – 3

Environmental Settings

S. No. Particular Details

1 Nearest Village Kundala Ki Dhani

2 Nearest city/ town Sikar at distance is ~ 77 Km from the mine site

3 Nearest Railway Station Neem ka Thana Railway Station ~ 13 km

4 Nearest Airport Jaipur international Airport,Jaipur ~ 105 km

5 Archaeological Important Place None, within 10 km radius area of mine site.

6 Ecological Sensitive Areas

(National Park, Wildlife

Sanctuary, Biosphere Reserve

etc.)

There is no National Park, Wild Life Sanctuaries,

Biosphere Reserves, Tiger Reserves, Wildlife

Corridors, etc. within 10 km radius





7 Reserved/Protected Forest

within 10 km radius

• Patan PF ( ~ 6.0 km NE )

• Kharjo PF ( ~ 8.0 km ENE )

• PF ( ~ 8.0 km ENE )

• PF ( ~ 2.5 km SE )

• Gadrata PF ( ~ 5.5 km SSE )

• PF ( ~ 3.0 km SW )

• Ganwari PF ( ~ 1.5 km SSE )

• Dokan PF ( ~ 0.5 km N )

8 Nearest River / water body • Dokan Dam ( ~ 2.0 km ENE )

• Krishnawati Nadi ( ~ 6.5 km ESE )

• Rajpur Dam ( ~ 6.0 km ESE )

• Jhilo Dam ( ~ 7.50 km N )

9. Interstate bounadries No interstate boundary is within 10 km radius of the

lease area.





Figure-2 Key Plan





(V) Existing Infrastructure:

There is no building & structure within mining lease area except some vegetations

existing on the lease area which will be cleared when required. Total lease area is Govt.

Land.

The lease area about 1 km from Kundala KI Dhani. Post and Telegraph, Hospital, Bank,

Education and all market facilities are available at Neem Ka Thana. Jaipur International

Air Port is the nearest airport approx. 105 km from the mine site. Railway facilities

available at Neem Ka Thana which is approx 13 km.The lease area is well connected

through roads.

6.0 PLANNING BRIEF

(i) Planning Concept (Type of Industries, Facilities, and Transportation etc.) Town

and Country Planning/Development Authority Classification

Uses: This is a mining Project

(ii) Population Projection

Manpower required will be engaged from nearby areas. No significant influx of people is

anticipated in the area.

(iii) Land Use Planning

The extent of proposed mining lease area is 1.0 ha. The area comprises of Got. land.

(iv) Assessment of Infrastructure Demand (Physical & Social)

Lessee will assess the demand of infrastructure (Physical & Social) in nearby area of the

proposed mine site and same will be developed under social work

(v) Amenities/Facilities

Mining Management will develop the Amenities/Facilities in the nearby area of the

proposed mine site as per requirement of local people of the nearby area under

corporate social responsibility programs.

7.0 PROPOSED INFRASTRUCTURE

(i) Residential Area (Non Processing Area)

This is not required as mine workers comes from nearby villages. Rest shelter to the

workers already exists in the major mining lease of the lessee.

(ii) Green Belt

Green belt will be developed on strategic area and equal to 33% of the lease area.





(iii) Connectivity

The lease area about 1 km from Kundala KI Dhani. Post and Telegraph, Hospital, Bank,

Education and all market facilities are available at Neem Ka Thana. Jaipur International

Air Port is the nearest airport approx. 105 km from the mine site. Railway facilities

available at Neem Ka Thana which is approx 13 km. from the mine site.

(iv) Water Management (Source & Supply of water)

The water is required for drinking purpose only and drinking water is available by the

water tanks in the lease area.

(v) Sewerage System

Domestic sewage water generated from office toilet will be disposed in soak pits via

septic tank. Outside discharge is not envisaged.

(vi) Industrial Waste Management

No industrial waste water will be generated from this mine mining operation.

(vii) Solid Waste Management

The lessee dispatches Cheja Pather (Masonary Stone) as ROM. No sorting will take place

at site. Thus, waste will not be generated separately

(viii) Power Requirement & Supply/Source

Electric power will not be required in mining operations.

8.0 REHABILITATION AND RESETTLEMENT (R & R) PLAN

(i) Policy To Be Adopted (Central/State) In Respect Of The Project Affected Persons

Including Home Oustees, Land Oustees And Landless Laborers (Brief Outline To

Be Given)

Not Applicable as the lease area falls in Govt. land.

9.0 PROJECT SCHEDULE & COST ESTIMATES

(i) Likely Date Of Start Of Construction And Likely Date Of Completion (Time

Schedule For The Project To Be Given)

This is a case of existing mine Consent to Operate has been already issued by RSPCB.

Now Environmental Clearance required as per As per MoEF Office No. J-

13012/12/2013-IA-II (I) dated 24.12.2013 the project is comes under B2 Category.





(ii) Estimated Project Cost Along With Analysis In Terms Of Economic Viability of the

Project

(i) Total Project Cost : Rs 50.0 Lakhs

(ii) Environment Protection Cost : Rs 1.50 Lakhs Per annum

10.0 ANALYSIS OF PROPOSAL

� Proposed Cheja Pathar (Masonary stone) Mining Lease will result in growth of the

surrounding areas by increasing direct and indirect employment opportunities in the

region including ancillary development and supporting infrastructure. Special emphasis

on Financial and Social benefits will be given to the local people including tribal

population, if any, in the area.

� Development of social amenities will be in the form of medical facilities, education to

underprivileged and creation of self help groups.

� No major adverse effect on environment is envisaged as the required mitigation

measures are inbuilt in the project.

pre-feasibility report - welcome to...

Documents