paving and kerbs · 2019-03-18 · charcon paving and kerb pocket guide introduction welcome to...
TRANSCRIPT
3
Charcon paving and kerb pocket guide
Contents
Contents 2-3
Introduction 4-5
Kerbs and channels 6
Droppers, crossing kerbs and angles 7
Non-standard droppers and crossing kerbs 8
Transition kerbs, quadrants and edgings 9
Offlets and marker channels 10
Radius kerbs and channels 11
Channels 12
Channels and bollards 13
Access kerbs 14-15
HGV kerbs 16
Road-Pod® 17
Charcon Urban Surface Protection (USP) 18
Flag paving 19-23
Reinforced paving 24
Small element paving 25
Tactile paving 26
Step inserts 27
Block paving 28-32
Infilta range 32-34
Other Aggregate Industries companies 35
(Nominal weights of single units are shown in brackets throughout. All measurements are in mm, unless otherwise stated)
Founding Member
Charcon paving and kerb pocket guide
Introduction
Welcome to Charcon’s range of standard and non-standard paving and kerb products.
Full technical support and guidance on installation, product selection, design and loading, is available from CharconTechnical services and a full commercial landscaping portfoliois available on request.
Tel 01335 372222 Fax 01335 370074 Email [email protected] www.charcon.com
4
5
Charcon paving and kerb pocket guide
British/EuropeanStandardsThe information contained within this guide reflectsdetails of current standardsand is for guidance only.Relevant manufacturing andperformance standards in useat the time of preparing thisguide include the following:
BS EN 1338Concrete paving blocks
BS EN 1339Concrete paving flags
BS EN 1340Concrete kerb units
All Charcon products are also backed by BS EN ISO9001:2008 qualitymanagement systems.
Product appearancePart of the character andappeal of high quality hardlandscape products is thetexture and shade variationbetween individual flags.Although every effort is madeto ensure consistency ofproduct colour, variations mayoccur between batches.
WeatheringAll flag and kerb products willweather over time. The natureand extent of changes inappearance will typically beinfluenced by a combinationof the following:
a) Location
b) Degree of exposure
c) Prevailing weatherconditions
d) Quality of installation
Note: Charcon cannot acceptresponsibility for the effect of‘efflorescence’ which can be a characteristic of all good qualityproducts with high cement content.
The phenomenon may be exhibited byan apparent loss of intensity of colourand the appearance of a milky-whitebloom on the face of the product. Theeffect generally disappears with timeand is in no way detrimental to the performance of the product.
6 Kerbs and channels
Standard kerbs and channelsAll of the straight units and most of the radius units arehydraulically pressed, other units being hammer-compactedor wetcast.
All straight kerbs listed are 914mm (3ft) standard lengths. The 125 x 255 HB2 is also available in 609mm (2ft) lengths.
When ordering please state the dimension first, then the profileand finally the description, if applicable, e.g. 125 x 255 HB HB2.
Non-standard kerbs and channelsSubject to availability and minimum order quantity.
Non-standard kerbs Non-standard channels150 x 305 BN 125 x 255 BN 150 x 150 CS150 x 125 HB 125 x 175 SP 150 x 100 CS125 x 175 BN 125 x 175 HB*
* Made to order
125
150
914125x
150
BN
914
255x
125
CS1
150
x125
CS2
150 or 255
125
75
75
914
125x
255
SP
125
255
914
150x
305
HB 1
150
305
205
12.5 to 15 o o
914
125x
255
HB 2
125
255
155
12.5° to 15°
914125x
150
HB 3
125
150
50
12.5 to 15 o o
Approx. No. units per tonne
Dimensions (mm) Units per tonne Dimensions (mm) Units per tonne
150 x 305 10 125 x 255 15
150 x 175 18 125 x 205 19
150 x 150 21 125 x 175 22
150 x 125 26 125 x 150 26
150 x 100 30
SP (63kg) BN (40kg) CS1 (71 kg) CS2 (41kg)
HB1 (98kg) HB2 (64kg) HB3 (38kg)
7
Charcon paving and kerb pocket guide
Droppers, crossingkerbs and anglesStandard droppers and crossing kerbs 125 x 255 HB - 125 x 150 BN (LH) DL1125 x 255 HB - 125 x 150 BN (RH) DR1125 x 255 SP - 125 x 150 BN (LH) DL2125 x 255 SP - 125 x 150 BN (RH) DR2125 x 150 BN as crossing kerb125 x 255 BN - 125 x 150 BN (LH) 125 x 255 BN - 125 x 150 BN (RH)
Standard Angles 125 x 255 HB Ext angle HBXA125 x 255 SP Ext angle SPXA125 x 255 BN Ext angle BNXA125 x 255 HB Int angle HBIA125 x 255 SP Int angle SPIA125 x 255 BN Int angle BNIA
125
305
305
255
305
255
305
XA (33kg)IA (33kg)
DL 1
125
914
255
150
DR
1
914
150
255
125
DL1 (52kg) DR1 (52kg)
Please contact the Charcon sales office for product availability
8
Charcon paving and kerb pocket guide
Non-standard droppersand crossing kerbsNon-standard droppers and crossing kerbs125 x 255 HB - 125 x 175 WRCC* (LH) DL125 x 255 HB - 125 x 175 WRCC* (RH) DR125 x 175 WRCC* as crossing kerb
Double Pattern125 x 255 HB - 125 x 215 WRCC (LH) Order Code WR1 125 x 215 HB - 125 x 175 WRCC (LH) Order Code WR2 125 x 215 HB - 125 x 175 WRCC (RH) Order Code WR3 125 x 255 HB - 125 x 215 WRCC (RH) Order Code WR4
* NB 25mm Splay
Standard radius droppers125 x 255 HB - 125 x 150 BN (LH)125 x 255 HB - 125 x 150 BN (RH)
Available in 4m, 5m, 6m, 8m and 10m (external only).
125
255
914
215
125
215
914
175
(62kg) (52kg) (49kg)
125
175
914
17525
40
9Transition kerbs, quadrants and edgingsStandard transition kerbs125 x 255 HB RH - 125 x 255 SP LH TR125 x 255 HB LH - 125 x 255 SP RH TL125 x 255 HB LH - 125 x 255 BN RH125 x 255 HB RH - 125 x 255 BN LH
Standard quadrants305 x 255 QHB455 x 255 QHB305 x 255 QSP305 x 255 QBN
EdgingsDimensions (mm) Product Ref. Units per tonne
50 x 150 ER 66
50 x 150 EF 66
50 x 150 EBN 66
50 x 205 EF 45
50 x 205 EBN 45
50 x 205 round top Scotland only 45
50 x 255 EF 36
50 x 255 EBN 36
*75 x 230 round top Scotland only 36
* non-standard size
914
125
255
305 or 455
255
HB305 (42kg), HB455 (90kg)
TL/TR (60kg)
150,
200
or
250
mm
50
150,
200
or
250
mm
50
150,
200
or
250
mm
50Round topedging ER
Flat topedging EF
Bullnosededging EBN
Please contact the Charcon sales office for product availability
Charcon paving and kerb pocket guide
10
Charcon paving and kerb pocket guide
Offlets and marker channelsOfflets (Weir kerbs)Designed to allow surface water to be discharged through theopening in the face of the kerb to a 100mm pipe. Available inHalf Batter only.
Marginal strips and marker channelsMarginal strips and marker channels are hydraulicallypressed and are designed formotorways and other roadswhere raised kerbs are notused. They provide a visiblemarking and act as rumblestrips. Available in straightlengths only.
Manufactured to order only.
(56kg)
125
255
110
914
125
255
8011
560
914
280
(56kg)
229 229419
914
305
19 19
125
Marker channel (68kg)Patent No. 853557
250
Marker ChannePatent No 8535
125
914
Marginal strip (84kg)
11
Charcon paving and kerb pocket guide
Radius kerbs and channelsStandard radius kerbsand channels BS EN 1340All radii over 15 m (40 ft) can be achieved by usingstandard 914 mm (3 ft) or 609 mm (2 ft) kerbs.
Before ordering, check availability of size and profile.
Also when ordering, please state the dimensions first, thenthe profile, then the radiifollowed by Internal or External,(eg. 125x150 BN 4 m ext.)
Size of Units per radius (m) 1/4 circle
0.5 1
1 2
2 4
3 6
4 8
5 10
6 12
8 16
10 20
15 30
Internal kerb external channel External kerb internal channel
Radius calculationRadius = A2 + B2
2B
Approx No. Units per 1/4 circle
Please contact the Charcon sales office for product availability
12
Charcon paving and kerb pocket guide
914
150
455
50
50
Channels
Motorway channels455 x 150
Made to order only.
Dished and fluted channelsAll units are hydraulically pressed. Dished channels as illustratedare normally available from stock. Other channels and dishsizes are available to order in economic quantities.
(110kg)
255 x 125 CD (60kg)305 x 150 CD (89kg)
255 x 75 x FLCH (37kg)150 x 100 CD (30kg)
914
25
150
305
13
100
150
914
255
25
125
914
11
75
255
914
255
13
Charcon paving and kerb pocket guide
Channels and bollards
Drainage channel blocksType A 350 x 175 Type B 305 x 150
Made to order only.
225
175
1219
914 mm (59 kg)
Type A (81kg) Type B (74kg)
1219 mm (92 kg)
Precast concrete bollardsStandard grey and textured grey finishes are available in both sizes.
225
175
914
175
125 91
4
350
914
15075
305
Please contact the Charcon sales office for product availability
14
Charcon paving and kerb pocket guide
Access kerbs
Access kerbThis award-winning kerbsystem is designed to allowlevel-entry access to buses,using innovative markerbumps to indicate precisebus positioning – a majorbenefit for wheelchair usersand other bus passengerswith reduced mobility.
Main unitsKerb height/length (mm) 220 x 1000 160 x 1000 180 x 1000
Standard profile(with marker bump) ¸ ¸ ¸
Standard profile(without marker bump) ¸ ¸
Transition unitsKerb height/length (mm) LH RH
Standard profiles160 x 125 x 1000 ¸ ¸180 x 125 x 1000 ¸ ¸220 x 160 x 1000 ¸ ¸
Quadrant dimensionsDimensions (mm) 90°
Standard profile220 ¸
15
Charcon paving and kerb pocket guide
180mm standard profile with marker bump (150kg)
160mm Standard profile with marker bump (130kg)
160mm Standard profile without marker bump
(120kg)
180mm guided bus(140kg)
323
10312652
130
kerb
hei
ght 2
20
35015
R15
224
R15
10382
kerb
hei
ght 1
60
117
130
43
290
276
103
290
130
kerb
hei
ght 1
60 R15
271
R15
103124
kerb
hei
ght 2
20
177
130
43
350
220mm standard profile with marker bump (170kg)
220mm standard profile without marker bump
(160kg)
310
102.8
310
130
kerb
hei
ght 1
80 R15
11154 8x45˚ chamfer
260
80.6
100
110
129.
4
R20
102.811.3
27.131
0
5∞
5∞5∞
8.7
R15R5
54∞
Please contact the Charcon sales office for product availability
16
Charcon paving and kerb pocket guide
HGV kerbs
HGV kerbThis high-strength anti-vehicular kerb is designed toaccept heavy-duty impact ifnecessary, and to prevent anyvehicle (including HGVs) fromleaving the roadway or otherdesignated areas.
Main units can bemanufactured to acceptdowel bars for extra stability.
Main unitsDimensions (mm) Main kerb section Half unit
Length 1000 500
Height 415 415
Overall width (top) 215 215
Overall width (base) 310 310
Transition unitsDimensions (mm) Transition units type A Transition units type B
Length 1000 1000
Height 415-318 318-220
Overall width (top) 215-170 170-215
Overall width (base) 310 310
Note: Types A and B are both required to create a transition from HGV Kerb to Standard HB2 Kerbing.
(Full unit 220kg)
Transition units to HB2 kerb(left-hand version shown)
Radius units and quadrantsDimensions (mm) Radius units Quadrants 45° 60° 90°
Length see note below
Height 415 415
Overall width (top) 215 215
Overall width (base) 310 310
Note: Radius units available in 36/12, 11/7, 6/4.5, 3, 2 and 1.5 metre externalradius versions, plus 36/12, 11/7, 6/4.5 and 3 metre internal radius versions.
(A – 180kg)
(B – 90kg)
17Road-Pod®
The Road-Pod® is a sustainable precast concrete modularsystem for use as traffic and pedestrian refuge islands.
It offers a very cost effective off-site sustainable solution, with significant savings on cost and installation time. Additionalbenefits include reduction of site time spent in danger andenhancement of pedestrian safety.
A typical unit can be installed over a period of 3-8 hours, withminimum traffic management, compared to 2-3 days with traditionalon-site methods using kerbs, in-situ concrete and asphalt.
The Road-Pod® system is available in a range of sizes to suitvarious applications. There are five types of arrangement, from1.2 m to 1.8 m in width and a number of island combinations.Other widths are available on a made to order basis.
The units come complete with provision for illuminated,reflective or solar powered type bollards, high level and solarpowered columns, cast-in tactile surfaces and lifting points. The weight ranges from 382 kg to 1.93 tonnes.
TriangularGenerally used on junctions
where the road forks.
Semi-circularUsed at road junctions andcrossing points. Infill piecesavailable to enable these units to be elongated.
Please contact the Charcon sales office for product availability
Charcon paving and kerb pocket guide
18
Charcon paving and kerb pocket guide
A pre-applied treatment for paving to easecleaning and maintenance.
Charcon Urban Surface Protection (USP) can be pre-applied to paving before it is delivered and laid. Whilst an element ofcleansing may still be required during the life of the paving, the frequency and severity will be reduced and will lowermaintenance costs.
Charcon USP is supplied as standard on StoneMaster productsand is available on a made to order basis for all other paving.
Features and benefits• A chemically inert, environmentally friendly water based
fluoro polymer
• Does not affect the slip resistance of the coated area
• Does not affect the colourant of the paving
• Can be pre-applied to flag and block paving ranges atmanufacturing plant location.
Charcon Urban SurfaceProtection (USP)
Charcon paving and kerb pocket guide
An integrated range of flag paving products, associated kerbs and setts,offering total hard landscaping solutions for almost all urban residential, traditional or contemporary environments.
Colour Nominal sizes (l x w x h) (mm)
Black Fleck 600 x 600 x 50450 x 450 x 70400 x 400 x 65900 x 600 x 63750 x 600 x 50600 x 600 x 50450 x 450 x 67400 x 400 x 65
Flag paving
EcoPave EcoPave has been developed to maximise resource productivity - minimising waste and optimising renewable materials with82% recycled content.
Colour Nominal sizes (l x w x h) (mm)
Light Buff, Medium Buff, Dark Buff, 750 x 600 x 80Light Grey, Medium Grey, Dark Grey 600 x 600 x 80
600 x 450 x 80450 x 450 x 80450 x 300 x 80
StoneMaster A revolutionary range of paving with all the inherent beauty of indigenous stone with 50% recycled material content.
MalvernPremium quality flag incorporating innovative aggregate formulation with up to 54% recycled material content.
19
Colour Nominal sizes (l x w x h) (mm)
Leemoor (Ground), Andover Silver 400 x 400 x 65Grey (Textured), Andover Cream (Textured) 400 x 400 x 50
Please contact the Charcon sales office for product availability
20
Charcon paving and kerb pocket guide
Colour Nominal sizes (l x w x h) (mm)
Dark Grey (steel reinforced), Silver Grey 750 x 600 x 63(steel reinforced), Standard Grey 600 x 600 x 63(steel and fibre reinforced, pimple finish) 600 x 450 x 72
600 x 600 x 72750 x 600 x 63600 x 600 x 63600 x 450 x 63
Ultrapave Ultrapave is manufactured to replicate natural granite and is steel or fibre reinforced to increase product integrity and prevent trip hazards. It also contains up to 81% recycled material content.
Colour Nominal sizes (l x w x h) (mm)
Grey (Ground), Charcoal (Ground), Buff (Ground), 600 x 600 x 50Black Fleck (Ground), Grey (Textured), Charcoal 450 x 450 x 70(Textured), Buff (Textured), Black Fleck (Textured) 450 x 450 x 50
400 x 400 x 65400 x 400 x 50600 x 600 x 50450 x 450 x 67400 x 400 x 65
Appalachian Combines tradition with innovation byincorporating granite aggregates and up to 75% recycled material content to giveexceptional durability at an affordable price.
Colour Nominal sizes (l x w x h) (mm)
Buff (Ground), Buff (Textured), Grey (Ground), 600x600x50Grey (Textured), French Grey (Textured) 450x450x70
450x450x50400x400x65400x400x50600x600x50450x450x70450x450x50400x400x65
Moordale A revolutionary range of paving with all the inherent beauty of indigenous stone.
Flag paving (continued)
Charcon paving and kerb pocket guide
Colour Nominal sizes (l x w x h) (mm)
Charcoal 900 x 600 x 63750 x 600 x 63600 x 600 x 63600 x 450 x 63450 x 450 x 63
CourtstoneReplicating natural Caithness stonepaving, Courtstone’s detailed riven profileis derived from natural stone masters.
Academy Affordable commercial paving that doesn’t compromise on aesthetics.
Colour Nominal sizes (l x w x h) (mm)
Grey 600 x 600 x 50* 400 x 400 x 65450 x 450 x 70*
*MTO product with a minimum order quantity of 120 packs.
Elite Elite achieves the functional requirement of a deterrent paving, but also offersaesthetic appeal into the bargain.
Colour Nominal sizes (l x w x h) (mm)
Format 2 - Grey, Format 3 - White 298 x 80 x 90-132600 x 600 x 74
21
Please contact the Charcon sales office for product availability
Charcon paving and kerb pocket guide
Colour Nominal sizes (l x w x h) (mm)
Silver Grey, Dark Grey, Mid Grey, Beige, 450 x random length x 50, 63 or 75 Yellow, Pink, Red, Grey-green, Black 600 x random length x 50, 63 or 75
400 x 400 x 50, 63 or 75600 x 600 x 50, 63 or 75
Natural GraniteCharcon Granite paving offers a very durable and attractive solution to any hardlandscaping project. Granite’s unique appearance and it’s fine aesthetics make it ideal for prestigiousprojects that require a high quality and contemporaryappearance. Suitable for both pedestrian andtrafficked areas.
Colour Nominal sizes (l x w x h) (mm)
Buff, Buff Multi, Green, Dark Grey, Red 450 x random length x 50, 63 or 75600 x random length x 50, 63 or 75
Natural SandstoneImported Sandstones in a range of natural colours available in sawn, lightly sandblasted finish. Imported Sandstone offers a cost effective, hard wearing and economicalalternative to indigenous natural stones.
Colour Nominal sizes (l x w x h) (mm)
Hunters Hill, Highmoor, Lowmoor, 450 x random length x 50, 63* or 75*Willow Buff, Sandy Buff, Lazenby Red 600 x random length x 50, 63* or 75*
400 x 400 x 50, 63 or 75600 x 600 x 50, 63 or 75
Natural YorkstoneCharcon offer a wide range of attractive and durable UK sourced stones in a variety of beautiful colours, sizes and finishes, givingdesigners endless opportunities to use the uniqueaesthetic qualities only available with a natural stone.
Flag paving (continued)22
23
Charcon paving and kerb pocket guide
Standard paving sizes A-D
Charcon’s hydraulically pressed paving is available in 50mm (2")and 63mm (2.5") thicknesses.
When ordering, it is only necessary to specify A50, D63, etc.
This paving is available in Grey, Buff or Red with a Standard or special patterned finish (Hobnail or Barfaced).
Patterned in sizes:
A50H, B50H, C50H and D50 (H made to order).
(Bars on Barfaced flags run parallel down the length of the flag.)
Note: non-standard paving in a 37mm thickness and 600 x300 and 900 x 300 in a 50mm thickness, are also available.
Please contact the Charcon sales office for details.
PavingProduct Ref. Units per tonne Units per m2
A50 32 3.7
B50 24 2.8
C50 19 2.2
D50 16 1.9
A63 25 3.7
B63 19 2.8
C63 15 2.2
D63 13 1.9
Type Size (l x w) (mm) Nominal weight (kg)50mm 63mm
A 450 x 600 32 39
B 600 x 600 42 52
C 750 x 600 53 66
D 900 x 600 63 78
Standard Hobnail Barfaced
British standard flag paving
Please contact the Charcon sales office for product availability
24
Charcon paving and kerb pocket guide
Reinforced paving
Aesthetic steel reinforcedpaving (Dark Grey andSilver Grey)Developed in conjunction with Local Authorities andspecifiers for use in cities and town centres.
Functional steel reinforcedpaving (Standard Grey)
An alternative to the aestheticfinish, where a complimentarytraditional appearance is notrequired.
Functional fibre reinforcedpaving (Standard Grey)Steel fibres provide resistancein case of damage, holdingbroken segments together,minimising movement and the risk of trip.
Dimensions and availabilitySize (mm) 600x600 600x450 600x600 600x750
Thickness (mm) 72 72 63 63
Reinforcement steel steel steel steel
Weight per unit (approx kg) 64 47 53 67
Lift weight (tonnes) 0.96 0.71 0.83 1.05
Colour availability Standard Standard Dark Grey Dark GreyGrey Grey Silver Grey Silver Grey
Size (mm) 600x600 600x450 600x750
Thickness (mm) 63 63 63
Reinforcement fibre fibre fibre
Weight per unit (approx kg) 53 40 67
Lift weight (tonnes) 0.91 0.68 1.12
Colour availability Standard Standard StandardGrey Grey Grey
25
Charcon paving and kerb pocket guide
Small element paving
Small element pavingSmall element flag paving is hydraulically pressed and offershigh load-bearing capability and low maintenance with long life expectancy.
Fluted paving Dished paving
600
63
600
Flutes 19 mm wide 5 mm deep
600
63
600
Nominal 50 mm deep
Small element – specificationSize 400x400 400x400 450x450 450x450 450x300 300x300
Thickness 50 65 50 70 65 60
Type F50 F65 E50 E70 J65 G60
Units per tonne 53 41 41 29 48 77
Units per m2 6.3 6.3 5 5 7.3 11.11
m2 per pack 20x2 16x2 20x2 15x2 56 153x2
Colour Grey Grey, Red, Grey, Buff Grey, Buff Grey, Buff GreyBuff
Dished and fluted pavingMade to order only.
Cycle demarcation block
50
20
200
150
95
Please contact the Charcon sales office for product availability
26 Tactile paving
Tactile pavingThis range of paving is designed specifically to meet theDepartment of the Environment, Transport and the Regions‘Guidance on the use of Tactile Paving Surfaces’.
A
B
Dimensions and availabilityProduct Blister Hazard Platform Platform edge Guidance CyclewayRef. edge (off street) (lozenge)
warning (offset blister)
F50 Buff
F50 Red • • • • •
F50 Natural • • • •
F65 Buff • • n/a • •
F65 Red • • n/a • •
F65 Natural • • • n/a • •
E50 Buff n/a n/a n/a n/a n/a
E50 Red n/a n/a n/a n/a n/a
E50 Natural • n/a n/a n/a n/a n/a
E70 Buff • n/a n/a n/a n/a n/a
E70 Red • n/a n/a n/a n/a n/a
E70 Natural • n/a n/a n/a n/a n/a
Stock item • Made to order (subject to minimum quantities) n/a not available
Blister Paving dimensions and typeBlister Size Dimensions (mm) BS EN 1339
(mm) A B TypeA 400 x 400 66.8 33 F
B 450 x 450 64 33 E
Hazard warning pavingcorduroy hazard warning surface
Platform edge warningpaving (off-street)
offset blister
Platform edge warningpaving (on-street)
Cycleway paving
Blister pavingmodule Type A: 6 domesmodule Type B: 7 domes
Guidance paving
27
Charcon paving and kerb pocket guide
Step inserts
Charcon step inserts contrast with the surrounding surfacingmaterial, therefore assisting partially sighted pedestrians – astatutory requirement on steps in all public places
Key benefitsReduced site costsThe installed product will be complete with an insert. Thiseliminates the need for post installation work which is bothcostly and time consuming, as well as creating dirt on thesurface of the paving.
Design optionsThrough a range of standard and bespoke items, this givesspecifiers infinite scope when using Charcon.
Meets current legislationCharcon Step Inserts enable the specifier to meet both DDA,Building Regulations and Health and Safety obligations in this area.
Luminous optionFor use in darker areas, lacking in natural light (eg. trainstations, subways, country areas, the seaside, or insidecommercial buildings including stadia).
Luminous option – lights on Luminous option – lights off
Powered by
Please contact the Charcon sales office for product availability
28
Charcon paving and kerb pocket guide
Block paving
Charcon offers a range of commercial blockpaving suitable for a wide range of applicationsfrom pedestrian projects to heavily traffickedindustrial areas. Please contact the Charconsales office on 01335 372222 for moreinformation and details of other block paving in the Charcon range.
Andover WashedA premium washed block for prestigiousschemes, with up to 50% recycled content.
Colour Nominal sizes (l x w x h) (mm)
Silver Grey, Anthracite Charcoal 600 x 200 x 80300 x 300 x 80300 x 200 x 80200 x 200 x 80200 x 100 x 80100 x 100 x 80
StoneMasterBlock paving which simulates natural yorkstone, StoneMaster products feature up to 50% recycled content.
Colour Nominal sizes (l x w x h) (mm)
Light Buff, Medium Buff, Dark Buff, Light Grey, 600 x 200 x 80Medium Grey, Dark Grey 300 x 300 x 80
300 x 200 x 80200 x 200 x 80200 x 100 x 80100 x 100 x 80
EcoPave blockUtilises over 60% recycled content,rough hewn look with high aestheticappeal.
Colour Nominal sizes (l x w x h) (mm)
Black Fleck 600 x 200 x 80300 x 300 x 80300 x 200 x 80200 x 200 x 80200 x 100 x 80100 x 100 x 80
29
Charcon paving and kerb pocket guide
Woburn RumbledThis cobble-style block has a weathered, time-worn appearance making it ideal for heritage sites and conservation areas,though equally practical for modern highstreet projects.
Colour Nominal sizes (l x w x h) (mm)
Autumn, Graphite, Rustic 201 x 134 x 80134 x 134 x 80100 x 134 x 80
Rustic 300 x 200 x 80200 x 200 x 80
Autumn, Graphite, Rustic 201 x 134 x 60134 x 134 x 60100 x 134 x 60
Colour Nominal sizes (l x w x h) (mm)
Graphite, Rustic 300 x 200 x 80200 x 200 x 80201 x 134 x 80134 x 134 x 80100 x 134 x 80
Graphite, Rustic 201 x 134 x 60134 x 134 x 60100 x 134 x 60
Andover TexturedBlack and white Cornish aggregate providesthis textured block with its stylish appeal.Contains up to 50% recycled material.
Colour Nominal sizes (l x w x h) (mm)
Silver Grey, Charcoal, Cream 600 x 200 x 80300 x 300 x 80300 x 200 x 80200 x 200 x 80200 x 100 x 80100 x 100 x 80
Woburn OriginalWoburn Original has a smooth surfacewhich is ideal for wheels of all types andsuits this block paving to a wide range of modern or traditional environments.
Please contact the Charcon sales office for product availability
30
Charcon paving and kerb pocket guide
Block paving (continued)
CountrysettsCountrysetts are available to provide prestigiouspedestrian environments with rustic character and contain 80% recycled material.
Colour Nominal sizes (l x w x h) (mm)
Silver Grey, Dark Grey 220 x 100 x 10297 x 100 x 102
ManhattanDeveloped to give an excellent closetextured finish to the paved area with50% recycled material content.
JubileeA tough, hard wearing textured blockcapable of handling heavy-use traffickingand meeting most visual design criteria.
Colour Nominal sizes (l x w x h) (mm)
Red, Charcoal 600 x 200 x 80300 x 300 x 80300 x 200 x 80200 x 200 x 80200 x 100 x 80100 x 100 x 80
Colour Nominal sizes (l x w x h) (mm)
Red 600 x 200 x 80300 x 300 x 80300 x 200 x 80200 x 200 x 80200 x 100 x 60200 x 100 x 80100 x 100 x 80
VianovaContemporary polished black pavingusing the finest basalt and graniteaggregates.
Colour Nominal sizes (l x w x h) (mm)
Light Grey, Dark Grey, Anthracite Charcoal 600 x 200 x 80400 x 200 x 80200 x 200 x 80300 x 200 x 80300 x 300 x 80300 x 150 x 80
31
Charcon paving and kerb pocket guide
NightecAn innovative photo luminous blockpaving that glows in the dark for up to ten hours.
Colour Nominal sizes (l x w x h) (mm)
Blue-Green 100 x 100 x 80Available on a made to order basis
GrassgridAn interlocking cavity grid system, Grassgrid offers natural looking hard standing for vehicles and strengthening ofembankments with 50% recycled material content.
Colour Nominal sizes (l x w x h) (mm)
Grey 366 x 274 x 100
EuropaEuropa is a paving block for allapplications from pedestrian projects to heavily trafficked industrial areas.
Colour Nominal sizes (l x w x h) (mm)
Brindle, Charcoal, Red, Buff, 200 x 100 x 80Autumn*, Burnt Oker, Grey
Brindle, Charcoal, Red, Buff, 200 x 100 x 60Autumn*, Burnt Oker, Grey
Brindle, Charcoal, Red, 200 x 100 x 65Buff, Grey
Brindle*, Charcoal*, Red*, 200 x 100 x 80 MLBuff*, Grey*
*Made to order with minimum order of 240 packsA pencil edge option is available in 60mm in Grey, Charcoal and Brindle on a made to order basis with a minimum order of 110 packs.
Europa Mechanical LayIncreasingly, contractors arelooking towards mechanicallaying of block paving toincrease speed and overallefficiency. Packaged in a 90°herringbone pattern, Europa80mm block paving is suitablefor mechanical lay.
Please contact the Charcon sales office for product availability
32
Charcon paving and kerb pocket guide
Infilta rangeStoneMaster InfiltaPermeable block which simulates naturalyorkstone and has up to 50% recycled content. For use within the construction of Sustainable Drainage Systems(SUDS). Charcon USP pre-applied.
Colour Nominal sizes (l x w x h) (mm)
Light Buff Washed, Medium Buff Washed, 200 x 100 x 80
Dark Buff Washed, Light Grey, Medium Grey
Dark Grey
Light Buff Washed, Medium Buff Washed, 201 x 134 x 80
Dark Buff Washed, Light Grey, Medium Grey
Dark Grey
Light Buff Washed, Medium Buff Washed, 134 x 134 x 80
Dark Buff Washed, Light Grey, Medium Grey
Dark Grey
Light Buff Washed, Medium Buff Washed, 100 x 134 x 80
Dark Buff Washed, Light Grey, Medium Grey
Dark Grey
Block paving (continued)
ParliamentPremium Cornish granite gives Parliament its lightly textured, mottled appearance inaddition to outstanding durability and skidresistance. It also contains up to 50%recycled material.
Colour Nominal sizes (l x w x h) (mm)
Grey, Charcoal 600 x 200 x 80 300 x 300 x 80 300 x 200 x 80 200 x 200 x 80 200 x 100 x 60 200 x 100 x 80 100 x 100 x 80
InfiltaA tough, hardwearing, permeable blockfor use within the construction ofSustainable Drainage Systems (SuDS).
Colour Nominal sizes (l x w x h) (mm)
Brindle, Charcoal, Grey, Red 200 x 100 x 80
33
Charcon paving and kerb pocket guide
EcoPave InfiltaPermeable block which uses 60%secondary and recycled materials,minimising waste. For use within theconstruction of Sustainable DrainageSystems (SUDS).
Colour Nominal sizes (l x w x h) (mm)
Black Fleck 200 x 100 x 80201 x 134 x 80134 x 134 x 80100 x 134 x 80
Andover Textured InfiltaStylish permeable block for use within theconstruction of Sustainable Drainage Systems(SUDS) incorporating 50% recycled material.
Colour Nominal sizes (l x w x h) (mm)
Cream, Charcoal, Silver Grey 200 x 100 x 80201 x 134 x 80134 x 134 x 80100 x 134 x 80
Andover Washed InfiltaPremium washed permeable block for usewithin the construction of SustainableDrainage Systems (SUDS) incorporating 50% recycled material.
Colour Nominal sizes (l x w x h) (mm)
Silver Grey, Anthracite Charcoal 200 x 100 x 80201 x 134 x 80134 x 134 x 80100 x 134 x 80
Parliament InfiltaPremium textured permeable block for use within the construction of SustainableDrainage Systems (SUDS) incorporating 50% recycled material.
Colour Nominal sizes (l x w x h) (mm)
Grey, Charcoal 200 x 100 x 80201 x 134 x 80134 x 134 x 80100 x 134 x 80
Please contact the Charcon sales office for product availability
34
Charcon paving and kerb pocket guide
Woburn Rumbled InfiltaPermeable block with rumbled/ weathered appearance. For use within the construction of Sustainable DrainageSystems (SUDS).
Colour Nominal sizes (l x w x h) (mm)
Autumn, Graphite, Rustic 201 x 134 x 60134 x 134 x 60100 x 134 x 60
Woburn Original InfiltaPermeable block with chamferlessprofile. For use within the construction ofSustainable Drainage Systems (SUDS).
Colour Nominal sizes (l x w x h) (mm)
Graphite, Rustic 201 x 134 x 60134 x 134 x 60100 x 134 x 60
Infilta range (continued)
Infilta Mechanical LayIncreasingly, contractors are looking towards mechanical laying of block paving to increase speed and overall efficiency.Contact us for further details.
ManhattanDeveloped to give an excellent closetextured finish to the paved areaincorporating 50% recycled material.
Colour Nominal sizes (l x w x h) (mm)
Red 200 x 100 x 80201 x 134 x 80134 x 134 x 80100 x 134 x 80
JubileeA tough, hard wearing textured blockcapable of handling heavy-usetrafficking while offering visual results.
Colour Nominal sizes (l x w x h) (mm)
Red, Charcoal 200 x 100 x 80201 x 134 x 80134 x 134 x 80100 x 134 x 80
35Other AggregateIndustries companies
Charcon is a major manufacturer of hard landscaping and constructionsystems. Our focus is firmly on the commercial sector, providing highquality, innovative and integrated solutions to architects, specifiers,landscape professionals, housebuilders and civil engineers in almostevery aspect of the construction industry.
Charcon sales (England and Wales) Charcon sales (Scotland) tel: 01335 372222 tel: 0141 7767881
Charcon technical tel: 01335 372222
Masterblock is one of the UK’s largest manufacturers of concrete blockssupplied for the commercial and housing markets. The range ismanufactured in a wide choice of sizes, strengths, formats and finishesoffering total flexibility. Masterblock is extremely cost-effective – a majorsaving is achieved compared with brickwork, and high quality aggregatesfrom our own quarries ensure that full specification requirements are met.
Masterblock sales (Northern) Masterblock sales (Southern)tel: 01524 736636 tel: 01285 646900
Masterblock sales (Scotland) Masterblock technical tel: 01467 651000 tel: 01285 646800
Fyfestone is one of the largest manufacturers of architectural masonrywithin the UK Construction Industry. Its origins date back to the 1950s inthe Aberdeen and Grampian regions of Scotland. Since then, Fyfestonehas become a recognised name for supplying architectural masonrysolutions and is now manufactured throughout the UK.
Fyfestone sales Fyfestone sales(England and Wales) (Scotland and Ireland)tel: 01285 646884 tel: 01467 651000
Fyfestone technical tel: 01285 646800
Whatever your dream home, Bradstone Structural Solutions has anextensive range of top quality, aesthetically pleasing building products tohelp bring it to life. The authentic, economical alternative to natural stone,our reconstituted stone walling, roofing and architectural features offer anexceptional choice of materials, styles, textures, finishes and shades.
Bradstone Structural Solutions Bradstone Structural SolutionsSales tel: 01285 646884 Technical tel: 01285 646884
© Aggregate Industries UK Limited. October 2010
Charcon, Hulland Ward,
Ashbourne, Derbyshire DE6 3ET
Tel: +44 (0)1335 372 222
Fax: +44 (0)1335 370 074
Email: [email protected]
www.charcon.com
CHAR-LIT-POCK