omc 2012 catalogcolor toc - firebird marine & volvo engine gaskets, rear main oil seals section...
TRANSCRIPT
OMC StringerLower Gear Housing Parts (1985 & Older) Section 8
OMC StringerUpper Gear Housing Parts (1985 & Older) Section 7
OMC CobraSeawater Pump Parts (1986-1993) Section 6
Seawater Pump Parts ..................................................................... 60
OMC CobraReplacement Sterndrives (1986-1993) Section 2
OMC CobraUpper Gear Housing Parts (1986-1993) Section 3
OMC CobraLower Gear Housing Parts (1986-1993) Section 4
Cobra SXReplacement Sterndrives (1994 & Up) Section 1
Upper Gear Housing Breakdown (1994 & Up) ............................... 6-7Lower Gear Housing Breakdown (1994 & Up) ............................... 8-9Transom Assembly Breakdown (1994 & Up) .............................. 10-11U-Joint Bellows ................................................................................ 12Exhaust Bellows - External .............................................................. 12Gimbal Bearing ................................................................................ 12Thrust Plates ...................................................................................12Drive Shaft Assembly - Upper ......................................................... 13U-Joints ........................................................................................... 13Gear Housing Seal Kits ................................................................... 13Bearing Carrier Bearings & Oil Seals ...............................................14Shift Lever Oil Seal .......................................................................... 14Drive Shaft - Lower .......................................................................... 15Prop Shaft ....................................................................................... 15Trim Tab ........................................................................................... 16
TABLE OF CONTENTS
www.glmmarine.com
Sterndrive Unit Application ............................................................... 18Complete Upper Gear Housing Assembly ....................................... 19Complete Lower Gear Housing Assembly ....................................... 19
Upper Gear Housing - Complete (1986-1993) ................................. 22Upper Gear Housing - Empty (1986-1993) ...................................... 23Upper Gear Housing - Assembly & Rebuild Kits (1986-1993) ..........24Upper Gear Housing - Seal Kits (1986-1993) ..................................25Upper Gear Housing Kits - Applications (1986-1993) .......................25Upper Gear Set Assembly (1986-1993) .......................................... 26Upper Gear Sets (1986-1993) ......................................................... 27Upper Gear Housing - Breakdown (1986-1993) ........................ 28-29Gear Housing Components (1986-1993) ................................... 30-32Gear Housing Drive Shaft (1986-1993) ........................................... 33
Lower Gear Housing - Complete (1986-1993) ................................. 36Lower Gear Housing - Empty (1986-1993) ...................................... 37Lower Gear Housing - Assembly Kit ................................................ 38Lower Gear Housing - Rebuild Kit ....................................................38Lower Gear Housing - Seal Kits (1986-1993) ..................................39Lower Gear Housing - Breakdown (1986-1993) ........................ 40-41Lower Gear Housing Gear Sets ................................................ 42-45Prop Shaft Parts - 4-Cyl. 2.3L (1987-1990), 3.0L (1986-1990) ......... 46Prop Shaft Parts - 4-Cyl. 3.0L (1990), V6 & V8 (1986-1990) ...........46Prop Shaft Parts - ALL (1991-1993) ................................................. 47
Transom Assembly - Breakdown (1986-1993) ........................... 54-55Shift Cable (1986-1993) ...................................................................56Rear Motor Mounts .......................................................................... 56Transom Bellows .............................................................................57Transom Service Kit (1986-1993) ....................................................57Drive Installation Kit (1986-1993) .....................................................57Gimbal Bearing ................................................................................ 57
Upper Gear Housing - Applications .................................................. 62Upper Gear Housing - Complete .....................................................63Upper Gear Housing - Empty ..........................................................64Bearing Retainer - Assemblies ......................................................... 65Upper Gear Housing - Rebuild Kits .................................................. 65Upper Gear Housing - Seal Kits ....................................................... 66Upper Gear Sets .............................................................................67Upper Gear Housing - Breakdown (1973-1985) ........................ 68-69Upper Gear Housing Components ............................................ 70-71Drive Shafts ..................................................................................... 72Steering Components ......................................................................73
OMC STRINGER STERNDRIVE
Upper & Lower Gear Housing - Applications ....................................76Lower Gear Housing - Complete ....................................................77Lower Gear Housing - Empty ..........................................................78Lower Gear Housing - Assembly Kit ................................................79Lower Gear Housing - Seal Kits ....................................................... 79Lower Gear Housing - Breakdown (1978-1985) ........................ 80-81Lower Gear Sets ....................................................................... 82-85Lower Gear Housing Components (1978-1985) ..............................86Prop Shaft Parts - 4-Cyl. w/ Mechanical Shift (1978-1985) .............. 87Prop Shaft Parts - V6 & V8 w/ Mechanical Shift (1978-1985) ..........87Lower Gear Housing - 4-Cyl. w/ Mechanical Shift (1978-1985) ........ 88Lower Gear Housing - V6 & V8 w/ Mechanical Shift (1978-1985) ....89Shift Parts ........................................................................................90Miscellaneous ..................................................................................90 Electric Shift Lower ......................................................................... 91
OMC CobraTransom Assembly Parts (1986-1993) Section 5
Section 4 continued...Lower Gear Housing Components ............................................ 48-49Lower Gear Housing Shift Shaft (1986-1993) ..................................50Lower Gear Housing Drive Shaft (1986-1993) ................................. 51
OMC COBRA STERNDRIVE
OMC COBRA STERNDRIVECOBRA SX STERNDRIVE
OMC & VolvoEngine Gaskets, Rear Main Oil Seals Section 18
OMC Cobra & StringerProp Hardware, Anodes, Tools Section 11
OMC StringerSeawater Pump Parts (1985 & Older) Section 10
OMC StringerIntermediate Housing Parts (1985 & Older) Section 9
VolvoAnodes & Prop Hardware Section 21
Head Gaskets ............................................................................. 144Intake Manifold Gaskets ............................................................ 145Valve Cover Gaskets .................................................................. 145Lifter Side Cover Gaskets .......................................................... 146Oil Pan Gaskets ......................................................................... 146Timing Chain Cover Gasket Kits ............................................... 146Timing Chain Cover Gaskets .................................................... 147Crank Shaft Oil Seals ................................................................. 147Distributor Gaskets .................................................................... 147Engine Gasket Kits ..................................................................... 148
Prop Hardware .......................................................................102-103Anodes .......................................................................................... 104Special Tools ................................................................................. 105
OMC & VOLVO ENGINE
OMC & VolvoElectrical Solenoids, Power Trim Relays Section 17
OMC & VolvoIgnition Section 16
OMC & VolvoFuel Pumps, Filters & Carburetor Parts Section 15
OMC & VolvoInternal Exhaust Hose, Exhaust Gaskets Section 14
OMC & VolvoThermostats, T. Gaskets, & T. Hsgs Section 13
OMC & VolvoRecirculating Water Pumps Section 12
VolvoSeawater Pumps Section 20
Volvo Penta AQ (Up to 1993)Sterndrives & Transom Assemblies Section 19
TABLE OF CONTENTS
Anodes & Prop Hardware .................................................... 164-165
Seawater Pumps ......................................................................... 162
Electrical Solenoids, Power Trim Relays, Voltage Reg ............... 140-141
Water/Fuel Separator Brackets ................................................. 121Water/Fuel Separator Filters ..................................................... 121Water/Fuel Separator Kits ......................................................... 122Fuel Filters .................................................................................. 123Carburetor Kits ........................................................................... 124Carburetor Floats ....................................................................... 125Carburetor Needle & Seats ........................................................ 125Carburetor Mounting Gaskets ................................................... 126Fuel Pumps ................................................................................. 127Fuel Pump Gaskets .................................................................... 127
Exhaust Manifold Gasket Kits .................................................... 114Exhaust Manifold-to-Engine Gaskets ........................................ 115Exhaust Manifold-to-Riser Gaskets ........................................... 116Exhaust Manifold End Cap Gaskets .......................................... 116Internal Exhaust Hose ................................................................. 117Exhaust Flappers for Exhaust Tips ............................................ 117
Recirculating Water Pumps ........................................................... 108
Thermostats & Thermostat Kits ........................................... 110-111Thermostat Gaskets & Housings ............................................... 112
Mallory Ignition ........................................................................... 130Prestolite Ignition ........................................................................ 131Volvo/Bosch Ignition ............................................................ 132-133Delco Points Ignition .................................................................. 134Delco EST Ignition ...................................................................... 135Ford EFI Ignition ......................................................................... 135Delco EST Module ...................................................................... 136Delco EST Pick-up Coil ............................................................. 136Ignition Coils ............................................................................... 136Ignition Components Application ........................................ 137-138
Upper Gear Housing Breakdown ........................................ 150-151Lower Gear Housing Breakdown ........................................ 152-153Intermediate Housing Breakdown ....................................... 154-155Transom Assembly Breakdowns ........................................ 156-157Gear Housing Seal Kits ............................................................. 158Intermediate Housing Parts ....................................................... 159Tilt Bushings ............................................................................... 159U-Joints & Bellows ...................................................................... 160Exhaust Bellows - External ........................................................ 160Drive Cover ................................................................................. 160Transom Assembly Parts ........................................................... 160
Oil Seals - Size Chart ................................................................ 166Oil Seals - Applications ............................................................. 167O-Rings - Size Chart .................................................................. 168Notes ........................................................................................... 169Warranty ............................................................................... 170-172
SIZE CHARTS & WARRANTY
VOLVO STERNDRIVE
OMC COBRA & STRINGER
OMC STRINGER STERNDRIVE CONT.
Intermediate Housing - Breakdown ............................................ 94-95Intermediate Housing - Seal Kit ........................................................ 96Tilt Housing - Seal Kit ......................................................................96Tilt Shaft ..........................................................................................96Ball Gears, Bearings, Seals ............................................................. 97Drive Installation Kits ........................................................................97Transom Boot/Seal .......................................................................... 98
Seawater Pump Parts ................................................................... 100
Cobra
SX S
tern
driv
eSection 1
Cobra SX DriveSterndrives & Transom Assemblies
1994 & Up
Section 1
Upper Gear Housing Breakdown (1994 & Up) ........................... 6-7
Lower Gear Housing Breakdown (1994 & Up) ........................... 8-9
Transom Assembly Breakdown (1994 & Up) .......................... 10-11
U-Joint Bellows.............................................................................12
Exhaust Bellows - External ...........................................................12
Gimbal Bearing.............................................................................12
Thrust Plates ................................................................................12
Drive Shaft Assembly - Upper ......................................................13
U-Joints ........................................................................................ 13
Gear Housing Seal Kits ................................................................ 13
Bearing Carrier Bearings & Oil Seals ........................................... 14
Shift Lever Oil Seal ....................................................................... 14
Drive Shaft - Lower....................................................................... 15
Prop Shaft .................................................................................... 15
Trim Tab ....................................................................................... 16
5
UPPER GEAR HOUSING COMPONENTS (1994 & Up)
6
COBRA SX
No. 87740
28
Seal Kit
O-ring
Gasket
U-Joint Assy.
Yoke - Long
U-Joint
Socket
Yoke
O-ring
Oil Seal
Bearing
O-ring
Bearing
O-ring
Oil Seal
Gasket
Seal
Gasket
Thrust Plate
Thrust Plate
Shim
Retaining Ring
Screw
Screw
Shim
Shim
Shim
Shim
Bushing
Screw
Locknut
Seal Kit
GLM No.
811003552028318
2831528030
2810028317
811808710021583
8237021582
823208711035550
8630031171
1266112662
233602177322384
2238623361
233622336323364
2309422299
2118087740
Ref No. OEM No. Description
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
24
24
24
25
26
27
28
3852045
3852317
3852384
3850815
3850812
3850813
3850814
3852565
3852272
3850853
3852308
3850852
925093
853858
3852279
3852560
3855081
3852561
3852562
3852563
910953
3852454
3852568
911678
911679
911680
911681
3853423
3852309
3852005
3850594
www.glmmarine.com 7
COBRA SXUPPER GEAR HOUSING COMPONENTS (1994 & Up)
8
COBRA SXLOWER GEAR HOUSING COMPONENTS (1994 & Up)
No. 87750Seal Kit
23
For PropHardware KitsSee Section 11
www.glmmarine.com 9
COBRA SX
GLM No.
8648286653
8334021512
215812161131171
2173121586
111542158182420
8590022221
2225222142
221852311111170
8324012777
1268187750
Ref No. OEM No. Description
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
3852315
3854595
3852866
3854250
3854249
3853934
3855081
3854539
3850942
3857675
3854249
3852865
3858303
3852020
3852350
3852056
398042
3854402
3851342
3852959
3855411
3852970
3855275
Grommet
Seal
O-ring
Bearing
Bearing
Bearing
Washer
Screw
Bearing
Prop Shaft
Bearing
O-ring
Oil Seal
Thrust Washer
Spacer
Cotter Pin
Nut & Keeper
Trim Tab
Drive Shaft
O-ring
Anode
Anode
Seal Kit
LOWER GEAR HOUSING COMPONENTS (1994 & Up)
10
COBRA SXTRANSOM ASSEMBLY (1994 & Up)
No. 39631Outdrive Mounting Kit
19
No. 21963Transom Service Kit
18
No. 90072Trailer Clips
21
www.glmmarine.com 11
COBRA SX
O-ring
O-ring
Gimbal Bearing
Screw
O-ring
U-Joint Bellow
Clamp
Seal
O-ring
O-ring
Exhaust Bellow
Clamp
Oil Seal
Anode
Locknut
Transom Mount Seal
Washer
Transom Service Kit
Outdrive Mounting Kit
O-ring
Trailer Clips
GLM No.
82260
8125021905
223288123089200
0109086300
8012081210
891900107086560
1269921180
866902172021963
3963182440
90072
Ref No. OEM No. Description
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
3852044
3852169
3853807
3852473
3852537
3854127
3852604
3852560
3852523
3852535
3850426
3852603
3852548
3854130
3852005
3852550
12-36001
-
-
913810
3847547
TRANSOM ASSEMBLY (1994 & Up)
COBRA SX
12
No. 12661THRUST PLATE - PORTOEM: 3852561
No. 12662THRUST PLATE - STBDOEM: 3852562
No. 23360SHIMOEM: 3852563
No. 21773RETAINER RINGOEM: 910953
No. 21963OEM: N/A
Kit contents:GLM892008919001090010702190586300
OEM385412738504263852604385260338538073852560
ITEMU-Joint BellowExhaust BellowHose ClampHose ClampGimbal BearingSeal
No. 21905GIMBAL BEARINGOEM: 3853807
No. 89200U-JOINT BELLOWOEM: 3854127
No. 89190EXHAUST BELLOWOEM: 3850426
No. 39631OUTDRIVE MOUNTING KITOEM: N/A
No. 86690TRANSOM MOUNT SEALOEM: 3852550
For All “Clone Clutch”Cobra SX (1994 & Up)
Cobra SX (1994 & Up)
Cobra SX (1994 & Up) Cobra SX (1994 & Up) Cobra SX (1994 & Up)
Cobra SX (1994 & Up) Cobra SX (1994 & Up) Cobra SX (1994 & Up)Cobra SX (1994 & Up)
No. 90072TRAILER CLIPSOEM: 3847547
NEW
COBRA SX
www.glmmarine.com 13
No. 87740GEAR HOUSING SEAL KITOEM: 3850594
No. 87750GEAR HOUSING SEAL KITOEM: 3855275
No. 28318U-JOINT ASSYOEM: 3852384, 3860842
No. 81180O-RING - DRIVE SHAFT YOKEOEM: 3852565
No. 28030U-JOINT (HEAVY DUTY)OEM: 3850812
No. 28100SOCKETOEM: 912213
No. 28315YOKEOEM: 912212
100% Hot Forged
No. 28317YOKEOEM: 3850814
Includes:No. 22299SCREWOEM: 3852309
Includes:No. 22299SCREWOEM: 3852309
Cobra SX (1994 & Up)
Cobra SX (1994 & Up)
Cobra SX (1994 & Up) Cobra SX (1994 & Up)
COBRA SX
14
No. 81100O-RING - DIP STICKOEM: 3852045
No. 35520GASKET - TOP COVEROEM: 3852317
No. 31171GASKET - DRAIN PLUGOEM: 3855081
No. 45080O-RING - SHIFT LEVER HOUSINGOEM: 925093
No. 87110OIL SEAL - SHIFT LEVEROEM: 853858
No. 35550GASKET - WATER PASSAGEOEM: 3852279
No. 87100OIL SEAL - BEARING CARRIEROEM: 3852272
No. 21583BEARING - BEARING CARRIEROEM: 3850853
No. 21582BEARING - BEARING CARRIEROEM: 3850852
No. 82370O-RING - BEARING CARRIEROEM: 3852308
COBRA SX
www.glmmarine.com 15
LOWER GEARCASE - PROP SHAFT
LOWER GEAR HOUSING - DRIVE SHAFT (VERTICAL)
No. 11170DRIVE SHAFTOEM: 3851342
No. 83340O-RINGOEM: 3852866
No. 21512TAPERED ROLLER BEARING-UPPEROEM: 3854250
No. 21581TAPERED ROLLER BEARING-LOWEROEM: 3854249
No. 21611PINION BEARINGOEM: 3853934
No. 11154PROP SHAFTOEM: 3857675
No. 21586TAPERED ROLLERBEARING - FRONTOEM: 3850942
No. 21581TAPERED ROLLERBEARING - REAROEM: 3854249
No. 82420O-RINGOEM: 3852865
No. 85900OIL SEAL - PROP SHAFTOEM: 3858303
Cobra SX (1994 & Up)
Cobra SX (1994 & Up)
COBRA SX
16
LOWER GEAR HOUSINGNo. 86482GROMMET - WATER TUBE UPPEROEM: 3852315
No. 86653SEAL - WATER TUBE LOWEROEM: 3854595
No. 23111TRIM TABOEM: 3854402
No. 83240O-RING - GEAR OIL PASSAGEOEM: 3852959
No. 21885SCREEN (2)OEM: 337778
No. 22363SCREW (2)OEM: 337061
No. 21731SCREW SETOEM: 318544
No. 31171GASKETOEM: 311598
OM
C-C
obra
Ste
rndriv
eSection 2
OMC CobraReplacement Sterndrives
1986-1993
Section 2
Sterndrive Unit Application ...........................................................18
Complete Upper Gear Housing Assembly ...................................19
Complete Lower Gear Housing Assembly ...................................19
17
STERNDRIVE UNIT APPLICATION (1986-1993)OMC - Cobra
18
Year Model RatioUpper
HousingLower
HousingUpper
CompleteLower
Complete
1987-1989 2.3L 21:21 29900 N/A N/A N/A
1986 2.5L 21:18 29900 29920 N/A N/A
1986-1989 3.0L 21:18 29900 29920 N/A N/A
1989 3.0L 21:18 29900 29920 N/A N/A
1989 3.0L High Alt 21:19 29900 29940 N/A N/A
1990-1993 3.0L All 21:21 29900 N/A 28800 28820
1986-1987 4.3L All 21:19 29900 29940 28800 28820
1988-1993 4.3L 21:19 29900 29940 28800 28820
1988-1993 4.3L High Alt 21:21 29900 N/A 28800 28820
1986-1988 5.0L 21:17 29900 29930 28800 28820
1988 5.0L High Alt 21:18 29900 29920 28800 28820
1989-1993 5.0L 21:18 29900 29920 28800 28820
1989-1993 5.0L High Alt 21:19 29900 29940 28800 28820
1986-1988 5.7L 21:16 29900 29910 28800 28820
1986-1988 5.7L High Alt 21:18 29900 29920 28800 28820
1989-1992 5.7L 21:16 29900 29910 28800 28820
1989-1992 5.7L High Alt 21:17 29900 29930 28800 28820
1988 350 King 21:16 29900 29910 28800 28820
1988 350 King High Alt 21:18 29900 29920 28800 28820
1989 5.8L 21:16 29900 29910 28800 28820
1989 5.8L High Alt 21:17 29900 29930 28800 28820
1990 5.8L 21:18 29900 29920 28800 28820
1990 5.8L High Alt 21:16 29900 29910 28800 28820
1991-1993 5.8L 21:16 29900 29910 28800 28820
1991-1993 5.8L High Alt 21:17 29900 29930 28800 28820
1993 5.8L EFI 21:17 29900 29930 28800 28820
1987-1989 7.5L 460 King 21:17 29900 29930 N/A N/A
1987-1989 460 King High Alt 21:18 29900 29920 N/A N/A
OMC - CobraCOMPLETE UPPER GEAR HOUSING ASSEMBLY (1986-1993)
No. 29910OEM: 986381Ratio: 21:16
No. 29920OEM: 986382Ratio: 21:18
No. 29930OEM: 986844Ratio: 21:17
No. 29940OEM: 986380Ratio: 21:19
100% Newwith Water Pump
COMPLETE LOWER GEAR HOUSING ASSEMBLY
No. 28820OEM: 987800
1986-1993 V6 & V81990-1993 4-Cylinder 3.0L
100% Newwith Heavy Duty Gears
For more info, see Section 3
For more info, see Section 4
www.glmmarine.com 19
20
21
OM
C-C
obra
Ste
rndriv
eSection 3
OMC CobraUpper Gear Housing Parts
1986-1993
Section 3
Upper Gear Housing - Complete (1986-1993) .............................22
Upper Gear Housing - Empty (1986-1993) ..................................23
Upper Gear Housing - Assembly & Rebuild Kits (1986-1993) ......24
Upper Gear Housing - Seal Kits (1986-1993) ..............................25
Upper Gear Housing Kits - Applications (1986-1993)................... 25
Upper Gear Set Assembly (1986-1993) ....................................... 26
Upper Gear Sets (1986-1993) ......................................................27
Upper Gear Housing - Breakdown (1986-1993) .................... 28-29
Gear Housing Components (1986-1993) ............................... 30-32
Gear Housing Drive Shaft (1986-1993) ........................................ 33
22
UPPER GEAR HOUSING COMPLETE (1986-1993)
100% Newwith water pump
OMC - COBRA
Engine Teeth on Original Gears GLM No. OEM No.
4-Cylinder, 2.3L (1987-1989) 21T/21T - 987064
4-Cylinder, 2.5L (1986) 21T/18T 29920 983826
4-Cylinder, 3.0L (1986-1989) 21T/18T 29920 983826
4-Cylinder, 3.0L (1990-1993) 21T/21T - 987064
V6, 4.3L, 262 CID 21T/19T 29940 985380
V8 Ford, 5.0L, 302 CID 21T/18T 29920 986382
V8 Chevy, 5.0L, 305 CID 21T/17T 29930 986844
V8 Ford EFI, 5.8L, 351 CID 21T/17T 29930 986844
V8 Chevy, 5.7L, 350 CID 21T/16T 29910 986381
V8 Ford, 5.8L, 351 CID 21T/16T 29910 986381
V8 Ford, 7.5L, 460 CID (1987-1989) 21T/17T 29930 988844
No. 29900OEM: 984518
1986-1993 OMC Cobra Empty Gear HousingReady for Your Components
Don’t scrap a boat because of a corroded upper gear housing!Replace it with a NEW housing from GLM.
Sand Cast from superior A356T5 Aluminum Alloy(Original is Die Cast from inferior A380T6)
The GLM #29900 will fit on all 1986-1993 OMC Cobra sterndrives.It will accept the original internal and external OMC components.
www.glmmarine.com 23
UPPER GEAR HOUSING
OMC - COBRA
24
UPPER GEAR HOUSING REBUILD KIT (1986-1993)No. 29911OEM: N/ARatio: 21:16
No. 29921OEM: N/ARatio: 21:18
No. 29931OEM: N/ARatio: 21:17
No. 29941OEM: N/ARatio: 21:19
COMPLETE UPPER GEAR HOUSING ASSEMBLY KITNo. 29919OEM: N/ARatio: 21:16
No. 29929OEM: N/ARatio: 21:18
No. 29939OEM: N/ARatio: 21:17
No. 29949OEM: N/ARatio: 21:19
OMC - COBRA
4-Cylinder, 2.3L (1987-1989) 21T/21T - - 87654
4-Cylinder, 2.5L (1986) 21T/18T 29929 29921 87654
4-Cylinder, 3.0L (1986-1989) 21T/18T 29929 29921 87654
4-Cylinder, 3.0L (1990-1993) 21T/21T - - 87654
V6, 4.3L, 262 CID 21T/19T 29949 29941 87654
V8 Ford, 5.0L, 302 CID 21T/18T 29929 29921 87654
V8 Chevy, 5.0L, 305 CID 21T/17T 29939 29931 87654
V8 Ford EFI, 5.8L, 351 CID 21T/17T 29939 29931 87654
V8 Chevy, 5.7L, 350 CID 21T/16T 29919 29911 87654
V8 Ford, 5.8L, 351 CID 21T/16T 29919 29911 87654
V8 Ford, 7.5L, 460 CID (1987-1989) 21T/17T 29939 29931 87654
www.glmmarine.com 25
OMC - COBRA
UPPER GEAR HOUSING KITS APPLICATION CHART (1986-1993)
No. 87654OEM: 987603
For All Cobra Models (1986-1993)
UPPER GEAR HOUSING SEAL KIT
EngineTeeth on
Original GearsUpper
Assembly KitUpper
Rebuild KitUpper
Seal Kit
26
UPPER GEAR SET ASSEMBLY (1986-1993)No. 22522OEM: 983917
Ratio 21:16
5.7L 350 Chevy V85.8L 351 Ford V8
No. 22532OEM: 983919
Ratio 21:17
5.0L 305 Chevy V85.8L 351 Ford V8 EFI7.5L 460 Ford V8
No. 22562OEM: 983918
Ratio 21:18
4-Cylinder 1986 2.5L4-Cylinder 1986-1989 3.0L5.0L 302 Ford V8
No. 22542OEM: 984013
Ratio 21:19
4.3L 262 Chevy V6
OMC - COBRA
www.glmmarine.com 27
OMC - COBRAUPPER GEAR SETS (1986-1993)
No. 22520OEM: 983825Ratio 21:16
5.7L 350 Chevy V85.8L 351 Ford V8
Comes With:
GLM OEM Item21540 983891 Bearing21541 983892 Bearing21542 983877 Bearing21543 983878 Bearing
No. 22540OEM: 984012Ratio 21:19
4.3L 262 Chevy V6
Comes With:
GLM OEM Item21540 983891 Bearing21541 983892 Bearing21542 983877 Bearing21543 983878 Bearing
No. 22560OEM: 983826Ratio 21:18
4-Cylinder 1986 2.5L4-Cylinder 1986-1989 3.0L5.0L 302 Ford V8
Comes With:
GLM OEM Item21540 983891 Bearing21541 983892 Bearing21542 983877 Bearing21543 983878 Bearing
No. 22544OEM: 983835Ratio 21:17
5.0L 305 Chevy V85.8L 351 Ford V8 EFI7.5L 460 Ford V8
Comes With:
GLM OEM Item21540 983891 Bearing21541 983892 Bearing21542 983877 Bearing21543 983878 Bearing
28
OMC - COBRAUPPER GEAR HOUSING COMPONENTS (1986-1993)
No. 87654
56
Seal Kit
www.glmmarine.com 29
OMC - COBRA
GLM No. Ref No. OEM No. Description
29900
2252022560
225402254421540
2154128460
2832581180
283152803028100
2832086530
823802154222525
2847021543
3477182430
812808661034770
1276089950
123918663034730
3391081100
124052167623202
2111127800
2790027920
824802840428406
1266112662
233602840821773
2336123362
2336323364
984518
983825
983826
984012
983835
983891
983892
911753
98388
3852565
912212
915717
912213
984264
911685
911686
983877
912029
911937
983878
911698
911700
909316
916058
911702
911703
983895
911844
911704
915840
911733
303067
984744
911697
911752
911751
911750
911699
911683
313175
914489
983967
3852561
3582562
3852563
911734
910953
911678
911679
911680
911681
1
2
2
2
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32
33
34
35
36
37
38
39
40
41
42
43
44
45
45
45
45
Upper Gearcase Assembly
Gear Set (21:16 Ratio)
Gear Set (21:18 Ratio)
Gear Set (21:19 Ratio)
Gear Set (21:17 Ratio)
Bearing
Bearing
Pinion Nut
U-Joint & Water Pump Shaft
O-ring
Yoke - Drive Shaft
Universal Joint
Socket
Yoke & Water Pump Shaft
Oil Seal
O-ring
Bearing
Centering Cone
U-Joint Nut
Bearing
Gasket
O-ring
O-ring
Oil Seal
Gasket
Wear Plate
Impeller
Water Pump Liner
Seal
Gasket
Gasket
O-ring
Pump Housing
Washer
Retainer
Cover Nut
Bearing Carrier
Water Pump Adapter
Bearing Carrier
O-ring
Cover Assembly
Cover Assembly
Thrust Plate
Thrust Plate
Shim
Cover Assembly
Retainer Ring
Shim 0.003”
Shim 0.004”
Shim 0.005”
Shim 0.010”
22384
4701022385
223862238721732
2337123372
2337323374
233752337623381
2338223383
866202117028420
2841087654
3852454
912614
912238
3852568
123018
914488
911662
911663
911664
911665
911666
911667
911668
-
-
911705
-
-
-
987603
46
47
48
49
50
51
52
52
52
52
52
52
53
53
53
54
55
55
55
56
Screw
Vent Hose
Screw
Screw
Screw
Dipstick
Shim 0.003”
Shim 0.005”
Shim 0.007”
Shim 0.010”
Shim 0.012”
Shim 0.015”
Shim 0.010”
Shim 0.001”
Shim 0.003”
Seal
Locknut - (use with 28420)
Washer - (use with 21170)
Locknut - Flanged (no washer needed)
Seal Kit
GLM No. Ref No. OEM No. Description
UPPER GEAR HOUSING COMPONENTS (1986-1993)
30
OMC - COBRAUPPER GEAR HOUSING COMPONENTS (1986-1993)
No. 21111NUT - LOWER BEARING CARRIEROEM: 911751
No. 21540UPPER BEARINGOEM: 983891
No. 27800LOWER BEARING CARRIEROEM: 911750
No. 21541LOWER BEARINGOEM: 983892
No. 21676WASHER - DRIVEN GEAROEM: 911697
No. 23202RETAINER - DRIVEN GEAR PINION NUTOEM: 911752
No. 28460PINION NUT - DRIVEN GEAROEM: 911753
SHIM - LOWER BEARING CARRIER
No. 23381SHIM 0.010”OEM: 911668No. 23382SHIM 0.001”OEM: N/ANo. 23383SHIM 0.003”OEM: N/A
www.glmmarine.com 31
OMC - COBRAUPPER GEAR HOUSING COMPONENTS (1986-1993)
No. 23371SHIM 0.003”OEM: 911662No. 23372SHIM 0.005”OEM: 911663No. 23373SHIM 0.007”OEM: 911664
No. 23374SHIM 0.010”OEM: 911665No. 23375SHIM 0.012”OEM: 911666No. 23376SHIM 0.015”OEM: 911667
No. 21543BEARINGOEM: 983878
No. 28470U-JOINT NUT -DRIVE GEAROEM: 911937
No. 22525CENTERING CONE -DRIVE GEAROEM: 212029
No. 27900WATER PUMPADAPTEROEM: 911699
No. 21542BEARINGOEM: 983877
No. 82380O-RING - CARRIEROEM: 911686
No. 27920FRONT BEARING CARRIEROEM: 911683
No. 22384SCREW-CARRIEROEM: 3852454
No. 86610OIL SEALOEM: 916058
No. 86530OIL SEAL - CARRIEROEM: 911685
No. 81280O-RINGOEM: 909316
No. 82430O-RINGOEM: 911700
No. 34771GASKETOEM: 911698
Roller BearingRear Shim
SHIM KITBEARING CARRIER
No. 23365OEM: N/AKit Includes:No. 23361No. 23362No. 23363No. 23364
SHIMSBEARING CARRIERNo. 23361SHIM 0.003”OEM: 911678No. 23362SHIM 0.004”OEM: 911679
No. 23363SHIM 0.005”OEM: 911680No. 23364SHIM 0.010”OEM: 911681
32
OMC - COBRA
No. 81100O-RING - DIPSTICKOEM: 329381
No. 28408WATER POCKETCOVER ASSEMBLYOEM: 911734
No. 21732DIPSTICK - TOP COVEROEM: 914488
UPPER GEAR HOUSING COMPONENTS
No. 12661THRUST PLATE - PORTOEM: 3852561
No. 12662THRUST PLATE - STBDOEM: 3852562
No. 23360SHIMOEM: 3852563
No. 21773RETAINER RINGOEM: 910953
No. 28404TOP COVER ASSEMBLYOEM: 914489
(1986-1993)
No. 22387SCREW - TOP COVEROEM: 123018
No. 28406COVER ASSEMBLYOEM: 983967
No. 22386SCREW - COVEROEM: 3852568
(1986-1993)
No. 33910GASKETOEM: 911733
No. 22384SCREW - COVERASSEMBLYOEM: 911734
No. 82480O-RING - TOP COVEROEM: 313175
www.glmmarine.com 33
OMC - COBRA
No. 81180O-RING FOR DRIVE SHAFT YOKEOEM: 3852565
No. 28030U-JOINT(HEAVY DUTY)OEM: 3850812
No. 28100SOCKETOEM: 912213
No. 28315YOKEOEM: 912212
No. 28320YOKE & WATER PUMP SHAFTOEM: 984264
No. 28325U-JOINT & WATER PUMP SHAFTOEM: 983880
100% Hot Forged
(1986-1993)
(1986-1993)
UPPER GEAR HOUSING DRIVE SHAFT
34
OM
C-C
obra
Ste
rndriv
eSection 4
OMC CobraLower Gear Housing Parts
1986-1993
Section 4
Lower Gear Housing - Complete (1986-1993) .............................36
Lower Gear Housing - Empty (1986-1993) ..................................37
Lower Gear Housing - Assembly Kit ............................................. 38
Lower Gear Housing - Rebuild Kit ................................................ 38
Lower Gear Housing - Seal Kits (1986-1993) ..............................39
Loweer Gear Housing - Breakdown (1986-1993) .................. 40-41
Lower Gear Housing Gear Sets ............................................. 42-45
Prop Shaft Parts - 4-Cyl. 2.3L (1987-1990), 3.0L (1986-1990) ... 46
Prop Shaft Parts - 4-Cyl. 3.0L (1990), V6 & V8 (1986-1990) ......46
Prop Shaft Parts - ALL (1991-1993) ............................................ 47
Lower Gear Housing Components ......................................... 48-49
Lower Gear Housing Shift Shaft (1986-1993) ..............................50
Lower Gear Housing Drive Shaft (1986-1993) .............................51
35
36
OMC - COBRACOMPLETE LOWER GEAR HOUSING ASSEMBLY (1986-1993)
No. 28820OEM: 987800Large Gear HousingRatio: 12:22
Strongest Lower Gear Housing Assemblies in theMarine Industry for 1986-1993 OMC Cobra Sterndrives
No. 28910OEM: 986669Small Gear HousingRatio: 13:26
All GLM #28820 replacement lower gear housingsfor the OMC Cobra sterndrives have the newheavy duty #22666 gear sets. These durablegears are capable of operating with up to 300horsepower. They also have the large 1-1/4 inchdiameter prop shafts with a reverse thrust washerinstalled between the shaft and reverse gear.
All GLM #28910 replacement lower gear housingis an economical replacement for 4-CylinderCobra sterndrives. It is an exact replacement foryour old gear housing. Upgrades include the newstyle bearing carrier and Mercruiser press-in stylepinion bearing.
Model Year Lower Complete
2.3L 4-Cyl. Ford 1987-90 28910
3.0L 4-Cyl. Chevy 1986-89 28910
3.0L 4-Cyl. Chevy 1990-93 28820
4.3L V6 1986-93 28820
5.0 L Chevy/Ford 1986-93 28820
5.7L Chevy 1986-93 28820
5.8L Chevy 1989-93 28820
www.glmmarine.com 37
OMC - COBRAEMPTY LOWER GEAR HOUSING (1986-1993)
No. 28800OEM: 439972Large Gear Housing
Ready for Your Components! Don’t scrap a boat because of a damaged orcorroded lower gear housing! Replace it with a NEW housing from GLM!
No. 28900OEM: 984978Small Gear Housing
Model Year Gear Housing
2.3L 4-Cyl. Ford 1987-1991 28900 Small Housing
3.0L 4-Cyl. Chevy 1986-1989 28900 Small Housing
3.0L 4-Cyl. Chevy 1990-1993 28800 Large Housing
4.3L V6 1986-1993 28800 Large Housing
5.0 L Chevy/Ford 1986-1993 28800 Large Housing
5.7L Chevy 1986-1993 28800 Large Housing
5.8L Chevy 1986-1993 28800 Large Housing
Prop Shaft Carrier
11388
11388
11406 (1990)
11406 (1986-1990)
11406 (1986-1990)
11406 (1986-1990)
11406 (1986-1990)
List of Improvements made to the GLM housing:Sand Cast from superior A356T5 Aluminum Alloy.Mercuiser style pressed fit pinion needle bearing.
Prop Shaft Carrier is retained with bolts and tabs (1991-93 style).Prop Shaft Carrier is prevented from rotating with a key and groove.
Water pick-up screens are removable w/out disassembling the drive (1991-93 style).
Side View Rear View
Top View
Side View Rear View
Top View
38
OMC - COBRACOMPLETE GEAR HOUSING - ASSEMBLY KIT
No. 28860OEM: N/A
1.86 RatioAll Prop Shaft 1-1/4 in. Dia.
1986-1993 V6 & V81990-1993 4-Cyl. 3.0L
COMPLETE GEAR HOUSING - REBUILD KIT
No. 28862OEM: N/A
1.86 RatioAll Prop Shaft 1-1/4 in. Dia.
1991 V6 & V81991 4-Cyl. 3.0L
LOWER GEAR HOUSING SEAL KIT - 3.0L (1990-1993), V6 & V8 (1986-1993)
www.glmmarine.com 39
OMC - COBRA
No. 87656OEM: 439967
3.0L 1990-1993V6 & V8 1986-1993(Except King Cobra)
LOWER GEAR HOUSING SEAL KIT - 2.3L (1987-1990), 3.0L (1986-1989)No. 87655OEM: 985612
3.0L 1986-19892.3L 1987-1990
40
OMC - COBRALOWER GEAR HOUSING COMPONENTS (1986-1993)
No. 87655
87
4-Cyl.Seal Kit
No. 87656
88
V6, V8 &4-Cyl. (1990 & Up)
Seal Kit
For Prop Hardware KitsSee Section 11
www.glmmarine.com 41
OMC - COBRA
GLM No. Ref No. OEM No. Description
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
24
24
25
26
27
28
29
30
31
32
33
34
35
36
37
38
39
40
41
42
43
44
45
46
47
48
49
439972
387817
337778
337061
-
915954
986838
912157
318372
304027
911878
911705
911706
911715
915720
911709
121731
305981
915719
318717
317624
984462
314728
323362
323361
314745
327656
387656
911710
911693
314730
987670
915273
3853818
914535
330265
328096
330263
436745
313715
912127
328701
318544
311598
331999
398042
306394
389455
389039
331880
328825
Gearcase Assembly
Pinion Bearing
Screen
Screw
Washer
Detent
Cover & Seal Assembly
Wiper
O-ring
Screw
Gasket
Seal
Tube
Guide
Water Passage Housing
Upper Drive Shaft
Nut
Washer
Gasket
O-ring
Screw
Bearing Housing
O-ring
Shim .003
Shim .004
Shim .005
Thrust Washer
Thrust Bearing
Plug
Lower Drive Shaft
Nut
P/Forward Gear Set
Reverse Gear (1986-93)
Anode
Screw
Washer
Screw
Screw
Anode
Screw
Screw
Lockwasher
Draining Screw
Gasket
Screw
Nut & Keeper
Cotter Pin
Housing & Bearing Assembly
Bearing
Pin
Pin
28800
2161021885
2236321679
277202775022390
4520022375
339608662012960
1296127760
2240421180
214903397083250
2236227770
813802359023580
2351021645
163301296222406
1119022623
2262412774
223652167422366
2236712776
223682236921761
2173131171
2237122185
221422770022910
2113821137
50
51
52
53
54
55
56
57
58
59
60
60
60
61
62
63
64
64
65
65
66
67
67
68
68
69
70
71
72
73
74
75
76
77
78
79
80
81
82
83
84
85
86
87
88
160084
915995
982422
322941
322938
327669
389042
914716
313448
324369
395209
436888
435022
336565
382408
314731
305123
313446
5000074
5004257
382407
387247
434467
320862
334950
431708
908158
333957
341541
126870
320570
914736
914743
914723
308825
986658
911713
911714
912392
306358
316563
332583
313446
985612
439967
Detent Ball
Spring
Cradle
Shaft
Lever
Thrust Washer
Thrust Bearing
Clutch Dog
Cross Pin
Spring
Prop Shaft 1-3/16 (1986-90)
Prop Shaft (All 4-CYL. 1987-90)
Prop Shaft 1-1/4 (1991-93)
Thrust Washer
Thrust Bearing
Thrust Washer
O-ring
O-ring 4-CYL.
Bearing Carrier (1986-90)
Bearing Carrier (1991-93)
Bearing
Bearing (1986-90)
Bearing (1991-93)
Oil Seal (1986-90) 2-pieces
Oil Seal (1991-93) 2-pieces
Anode
Screw
Tab
Screw
Thrust Washer
Spacer
Shift Rod
Nut
Rod End
Screw
Shift Rod Assembly
Stud
Stud
Trim Tab
Washer
Screw & Seal
Seal
O-ring
Seal Kit - 4-Cyl.
Seal Kit - V6/V8 & 4-Cyl. (1990 & Up)
22491
1105527730
2771027740
216461634022625
2113511052
224142241622417
2165116300
2164282400
823701140611408
2287011410
229508513086810
1273722320
278502237322221
2219021033
2124526440
223882103222471
2247223112
216782230086640
8237087655
87656
GLM No. Ref No. OEM No. Description
LOWER GEAR HOUSING COMPONENTS (1986-1993)
42
OMC - COBRALOWER GEAR HOUSING GEARS
When all three gears need replacing in your OMC Cobra Sterndrive the installation of the GLM#22666 heavy-duty gear set is highly recommended. The heavy-duty gears can be used withall four-cylinder sterndrives* from 1990-1993 and all V6 and V8 OMC Cobra sterndrives from1986-1993. It is recommended that a new clutch GLM #22625 (this clutch is not included withthe gear set) be installed with the heavy-duty gears. The gears can be used with the standard1-3/16" diameter prop shaft (1986-1990) or the heavy-duty 1-1/4” diameter prop shaft (1991-1993).
STRONGEROEM gear sets are machined from8620 forged steel. The GLM gear set ismachined from a higher alloy forgedsteel. The stronger teeth and higheralloy steel results in a gear that is 50%stronger than any other comparablegear set. These durable gears arecapable of operating with up to 300horsepower.
MORE DURABLEThe new GLM gear set has fewer,larger, and stronger teeth. The piniongear has 12 teeth and the forward andreverse gears have 22 teeth. Theoriginal OEM gear set has 14 teeth onthe pinion and 26 teeth on the forwardand reverse gears.
QUIETERDuring the gear machining process,an additional pass is made over eachtooth for a finer surface. This makesthe gear operation especially quiet.
NEW!
The new heavy-duty GLM #22666 gearswill not interchange with the standardCobra gears. For individual Cobra gearreplacement, you must use the standardduty GLM #22623 pinion and forwardgears or the GLM #22624 reverse gear.
IMPORTANT NOTE:
*Except 1990 2.3L**For model year 1991 OMC increased the prop shaft diameter at the carrier needle bearing (not the prop splines) from 1-3/16 to 1-1/4 inches.Some older gearcases may be fitted with the new large diameter prop shaft. The large diameter prop shaft utilizes a thrust washer (includedwith this gear set) between the prop shaft and reverse gear. Discard the thrust washer when using the small diameter prop shaft.
HEAVY DUTYGear Set GLM #22666Includes #21651 thrust washer**
GLM #22666 heavy-duty gears fit theseOMC Cobra Sterndrive units:
3.0L/181CI 4-Cyl. Chev. 1990-934.3L/262CI V6 Chev. 1986-93
5.0L/302CI V8 Ford 1986-935.0L/305CI V8 Chev. 1986-935.7L/350CI V8 Chev. 1986-93
5.8L/351CI V8 Ford 1986-93
www.glmmarine.com 43
OMC - COBRALOWER GEAR HOUSING GEARS
These gearsets are an exact copy of the gears used in the 1986-1993 V6 and V8 OMC CobraSterndrives. They also replace the gears used in the 1990-1993 four-cylinder* OMC Cobrasterndrives. The standard-duty replacement gears are stronger than the original and can beused with the standard 1 3/16" diameter prop shaft (1986 -1990) or the heavy-duty 1 -1/4”diameter prop shaft (1991 -1993).
COMPLETE GEAR SET- Forward/Pinion/Reverse- 14/26 teeth- Comes with the GLM #22625 clutch
FORWARD & PINION SET- May be used with OMC reverse gear- 14/26 teeth
REVERSE GEAR- May be used with OMC forward and pinion gears- 26 teeth- Includes thrust washer #21651**
CLUTCH
GLM #22622
GLM #22623
GLM #22624
GLM #22625
OEM #986980
OEM #987670
OEM #915723
OEM #915272
*Except 1990 2.3L**For model year 1991 OMC increased the prop shaft diameter at the carrier needle bearing (not the prop splines) from 1-3/16 to 1-1/4 inches. Some older gearcases may be fitted with the new large diameter prop shaft. The large diameter propshaft utilizes a thrust washer (included with this gear set) between the prop shaft and reverse gear. Discard the thrustwasher when using the small diameter prop shaft.
STANDARD DUTYReplacement Gear Sets
It is recommended that the above standard duty replacement gears be used onlywith the four-cylinder and V6 powered sterndrives listed below:
3.0L/181CI 4-Cyl. Chev. 1990-934.3L/262CI V6 Chev. 1986-93
GLM recommends theheavy-duty gearset #22666 forall V8 powered sterndrives.
#22625Clutch Dog
#22624Reverse Gear
#22623Forward & Pinion Set
#21651Thrust Washer
44
OMC - COBRA
#22633Clutch Dog
#22632Reverse Gear
#22631Forward & Pinion Set
These gearsets are an exact copy of the gears used in the 4-Cylinder 3.0L from1986-1989 and 1987-1990 2.3L.
4-CYLINDER GEARS
COMPLETE GEAR SET- Forward/Pinion/Reverse- 13/26 teeth- Comes with the GLM #22633 clutch
FORWARD & PINION SET- May be used with OMC reverse gear- 13/26 teeth
REVERSE GEAR- May be used with OMC forward and pinion gears- 26 teeth
CLUTCH
LOWER GEAR HOUSING GEARS
OEM #986979
OEM #985050
OEM #345992
OEM #912607
GLM #22630
GLM #22631
GLM #22632
GLM #22633
www.glmmarine.com 45
OMC - COBRAGEAR SETS & CLUTCH DOGS
Heavy Duty Gears Clutch for Heavy Duty Gears
No. 22666COMPLETE GEAR SETOEM: N/A
No. 22625CLUTCHOEM: 915272
No. 22622(22623+22624+22625)COMPLETE GEAR SET & CLUTCHOEM: 986980
No. 22623PINION & FORWARD GEAR SETOEM: 987670
14:26 Ratio
No.22624REVERSE GEAROEM: 915273
No. 22625CLUTCHOEM: 915272
For Large Gearcase - 3.0L (1990-1993), V6 & V8 (1986-1993)
No. 22630(22631+22632+22633)COMPLETE GEAR SET & CLUTCHOEM: 986979
No. 22631PINION & FORWARD GEAR SETOEM: 985050
13:26 Ratio
No. 22633CLUTCHOEM: 912607
No. 22632REVERSE GEAROEM: 345992
For Small Gearcase - 2.3L (1987-1990), 3.0L (1986-1989)
46
OMC - COBRA
PROP SHAFT PARTS - 4-CYL 3.0L (1990), V6 & V8 (1986-1990)
No. 85130PROP SHAFTSEAL (2)OEM: 320862
FOR 1-3/16” DIA. PROP SHAFTNo. 22414
No. 11410PROP SHAFTBEARINGOEM: 387247
No. 22414PROP SHAFT 1-3/16(1986-1990)OEM: 395209
No. 82400O-RING -BEARING CARRIEROEM: 305123
PROP SHAFT PARTS - 4-CYL 2.3L (1987-1990), 4-CYL 3.0L (1986-1989)
No. 86030PROP SHAFTSEAL (2)OEM: 330137
No. 22860PROP SHAFTBEARINGOEM: 379504
No. 82370O-RING -BEARING CARRIEROEM: 313446
No. 22416PROP SHAFTOEM: 436888
No. 22870REVERSE GEARBEARINGOEM: 382407
No. 21642THRUST WASHER -REVERSE GEAROEM: 314731
No. 16300THRUST BEARING -REVERSE GEAROEM: 382408
No. 22870REVERSE GEARBEARINGOEM: 382407
No. 21642THRUST WASHER -REVERSE GEAROEM: 314731
No. 16300THRUST BEARING -REVERSE GEAROEM: 382408
www.glmmarine.com 47
OMC - COBRA
No. 22373SCREWOEM: 350271
No. 27850TABOEM: 333957
PROP SHAFT PARTS - ALL (1991-1993)
No. 86810PROP SHAFTSEAL (2)OEM: 334950
No. 11408BEARING CARRIEROEM: 5004257
Comes with:86810, 22950, 22870
FOR 1-1/4” DIA. PROP SHAFTNo. 22417
No. 22950PROP SHAFTBEARINGOEM: 434467
No. 21651THRUSTWASHEROEM: 336565
No. 22417PROP SHAFT 1-1/4(1991-93)OEM: 5004765
No. 82400O-RING -BEARINGCARRIEROEM: 305123
No. 22870REVERSE GEARBEARINGOEM: 382407
No. 21642THRUST WASHER -REVERSE GEAROEM: 314731
No. 16300THRUST BEARING -REVERSE GEAROEM: 382408
For the 1991 model year the OMC Cobra lower gear housing was redesignedwith a stronger propellor shaft and bearing carrier.
Propellor Shaft ChangesA shoulder machined into the propellor shaft contacts the reverse gear and prevents the shaftfrom being pulled out of the gear housing when shifted into reverse. The 1991-1993 propellorshaft utilizes a hardened steel thrust washer between the shoulder and the reverse gear. Thishardened thrust washer keeps the shoulder on the prop shaft from damaging the inside of thegear when the boat is shifted into reverse. The shoulder on the 1991-1993 propellor shaft ismachined deeper to accomodate the hardened thrust washer.
Another improvement on the 1991-1993 propellor shaft is an increase in diameter from 1-3/16inches to 1-1/4 inches. The diameter was increased at the needle bearing, the prop shaft sealand the propellor thrust washer locations. The propellor splines remained the same.
Bearing CarrierThe 1991 - 1993 bearing carrier was redesigned with two hold-down tabs and two 5/16 inch boltsholding the carrier to the gear housing. The older carrier installs with four 1/4 inch bolts, a retainerplate and two internal retainer rings. The new carrier GLM #11408 also comes with a largerneedle bearing and prop shaft seals for the larger diameter prop shaft. It can only be installedinto 1991 and newer lower gear housings that have the notches for the hold down tabs.
48
OMC - COBRALOWER GEAR HOUSING - 4-CYL. 2.3L (1987-1990), 4-CYL. 3.0L (1986-1989)No. 11052SPRINGOEM: 324369
No. 21135CROSS PINOEM: 313448
No. 22633CLUTCH DOGOEM: 912607
No. 16310FORWARD GEARTHRUST BEARINGOEM: 385043
No. 21644FORWARD GEARTHRUST WASHEROEM: 324766
No. 27741LEVEROEM: 324037
No. 27710SHAFTOEM: 322941
No. 27730CRADLEOEM: 982422
No. 22870FORWARD GEARBEARINGOEM: 382407
No. 27702HOUSING & BEARING ASSYOEM: 391365
Includes 22870
No. 28482SHAFT & BEARING HSG KITOEM: N/A
No. 27720DETENTOEM: 915954
No. 21135PINOEM: 313448
No. 22491DETENT BALLOEM: 160084
No. 11055SPRINGOEM: 911962
www.glmmarine.com 49
OMC - COBRALOWER GEAR HOUSING - 3.0L (1990-1993), V6 & V8 (1986-1993)
No. 11052SPRINGOEM: 324369
No. 21135CROSS PINOEM: 313448
No. 22625CLUTCH DOGOEM: 915272
No. 16340FORWARD GEARTHRUST BEARINGOEM: 389042
No. 21646FORWARD GEARTHRUST WASHEROEM: 327669
No. 27740LEVEROEM: 322938
No. 27710SHAFTOEM: 322941
No. 27730CRADLEOEM: 982422
No. 22910FORWARD GEARBEARINGOEM: 389039
No. 27700HOUSING & BEARING ASSYOEM: 389455
Includes 22910
No. 28481SHAFT & BEARING HSG KITOEM: N/A
No. 27720DETENTOEM: 915954
No. 21137PINOEM: 328825
No. 22491DETENT BALLOEM: 160084
No. 11055SPRINGOEM: 911962
No. 23112TRIM TABOEM: 912392
No. 22368SCREWOEM: 313715
V6 & V8 (1986-93)3.0L (1990-93)
50
OMC - COBRALOWER GEAR HOUSING SHIFT SHAFT (1986-1993)
No. 21245NUTOEM: 914743
No. 22388SCREWOEM: 308825
No. 21033SHIFT RODOEM: 914736
Fits:1986-1993 with V6 & V81990-1993 with 4 cyl 3.0L
No. 26440ROD ENDOEM: 914723
No. 21032SHIFT ROD ASSEMBLYOEM: 986658
Fits:1986-1993 with V6 & V81990-1993 with 4 cyl 3.0L
No. 22390WIPEROEM: 912157
No. 22375SCREWOEM: 304027
No. 27750COVER & SEAL ASSY.OEM: 986838
No. 33960GASKETOEM: 911878
No. 45200O-RINGOEM: 318372
GLM’S RE-DESIGN OF THE COVER & SEAL ASSEMBLY
GLM proudly uses Smalley*internal snap ring for holding thesealing bushing. Unlike the OEMswhich locks it dead. No specialtools are required for replacing theseal and a service job can befinished in seconds!
*Smalley Steel Ring Co. is a GM vender
A.A. View
No. 27750OEM: 986838
www.glmmarine.com 51
OMC - COBRALOWER GEAR HOUSING DRIVE SHAFT (1986-1993)
No. 86620SEAL - TUBEOEM: 911705
No. 12960TUBEOEM: 911706
No. 12961GUIDEOEM: 911715
No. 22404UPPER DRIVE SHAFTOEM: 911709
No. 21180NUTOEM: 121731
No. 21490WASHEROEM: 305981
No. 27760WATER PASSAGE HOUSINGOEM: 915720
No. 33970GASKETOEM: 915719
Water Passage
No. 83250O-RING - UPPEROEM: 318717
No.22362SCREWOEM: 317624
No. 27770BEARING HOUSINGOEM: 984462
No. 81380O-RING - LOWEROEM: 314728
No. 23590SHIM 0.003”OEM: 323362No. 23580SHIM 0.004”OEM: 323361No. 23510SHIM 0.005”OEM: 314745
No. 21645THRUST WASHEROEM: 327656
No. 16330THRUST BEARINGOEM: 387656
No. 12962PLUGOEM: 911710
No. 22406LOWER DRIVE SHAFTOEM: 911693
Fits:1986-1993 with V6 & V81990-1993 with 4 cylinder 3.0L
No. 21610PINION BEARINGOEM: 387817
Fits:1986-1993 with V6 & V81990-1993 with 4 cyl 3.0L
No. 11190PINION NUTOEM: 314730
No. 22880PINION BEARINGOEM: 384195
Fits:1986-1989 with 3.0L1987-1990 with 2.3L
52
OM
C-C
obra
Ste
rndriv
eSection 5
OMC CobraTransom Assembly Parts
1986-1993
Section 5
Transom Assembly - Breakdown (1986-1993) ....................... 54-55
Rear Motor Mounts ......................................................................56
Shift Cable (1986-1993) ............................................................... 56
Transom Service Kit (1986-1993) .................................................57
Transom Components .................................................................. 57
53
54
OMC - COBRATRANSOM ASSEMBLY (1986-1993)
No. 21962
33
Transom Service Kit
No. 2143536Guide Tube Kit
No. 2145535Shift Cable Assy. Kit
No. 39630
34
Outdrive Mounting Kit
No. 9007137Trailer Clips
www.glmmarine.com 55
OMC - COBRA
Gimbal Bearing
Oil Seal
Shift Cable Assembly
Set Screw
Anchor
Guide
O-ring
Gasket
Seal
O-ring
U-Joint Bellow
Clamp
Exhuast Bellow
Clamp
O-ring
Shift Cable Bellow
O-ring
O-ring
O-ring
O-ring
Fitting
Screw
Lock Nut
Tie Strip
Tie Strip
Anode (1990-1993)
Screw
Lockwasher
Screw
Transom Mount Seal
Washer
O-ring
Transom Service Kit
Outdrive Mounting Kit
Shift Cable Assembly Kit
Guide Tube Kit
Trailer Clips
GLM No.219058656021715
2143321432
214348014034730
8630080120
8920001090
891900107080100
8921081230
822608125081210
2778622328
211802146521466
1269822388
2149622320
866902172082440
2196239630
214552143590071
Ref No. OEM No. Description1
2
3+
4-5-6-7-
8•+
9•+10
11
12
13
14
15
16+
17
18
19
20
21
22
23
24+
25+
26
27
28
29
30
31
32
33
34+
35
36+
37
983937
3852548
987661
912304
915918
914742
304174
915840
3852560
202893
3854127
912667
914036
912628
911311
911826
911871
302337
322501
911718
313607
909636
121731
320107
317893
3853930
308825
306470
908158
3852550
12-36001
913810
-
508105
N/A
N/A
174448
TRANSOM ASSEMBLY (1986-1993)
Included in Kit No. 21962
+ Included in Kit No. 21455
• Included in Kit No. 39630
- Included in Kit No. 21435
56
OMC - COBRA
SHIFT CABLE
REAR MOTOR MOUNTNo. 21812REAR MOTOR MOUNTSERVICE KITOEM: N/A
For Most Cobra
No. 19311BOLTOEM: 318573
No. 21042REAR MOTORMOUNTOEM: 3853806
No. 19321WASHEROEM: 3852542
No. 19352NUTOEM: 3852539
No. 19322WASHEROEM: 3852622
No. 19351LOCK NUTOEM: 313623
No. 19323WASHEROEM: 3852540
Kit contains:GLM OEM ITEM19311 318573 Bolt19321 3852542 Washer19322 3852622 Washer19323 3852540 Washer19351 313623 Lock Nut21042 3853806 Rear Motor Mount19352 3852539 Nut
No. 21435GUIDE TUBE KITOEM: N/A
For All “Clutch Dog” Cobra
No. 90520SHIFT CABLE ADJUSTMENT TOOL KITOEM: 914017 + 915271
NEWNo. 90510SHIFT CABLE TOOLOEM: 915271
No. 90500BELLCRANKALIGNMENT PLATEOEM: 914017
No. 21432ANCHOROEM: 915918
No. 21715SHIFT CABLEASSEMBLYOEM: 987661
Cobra(1986-1993)
No. 21433SET SCREWOEM: 912304
No. 21434GUIDE TUBEOEM: 914742
No. 21455SHIFT CABLEASSEMBLY KITOEM: N/A
Kit contains:GLM OEM ITEM21715 987661 Shift Cable Assembly39630 508105 Drive Installation Kit89210 911826 Bellow21465 320107 Cable Tie21466 317893 Cable Tie
NEW
Kit contains:GLM OEM ITEM21434 914742 Guide Tube21433 (2) 912304 Set Screw21432 915918 Anchor80140 304174 O-ring
NEWNEW
Kit contains:GLM OEM ITEM90500 914017 Bellcrank Alignment Plate90510 915271 Shift Cable Tool
www.glmmarine.com 57
OMC - COBRA
TRANSOM COMPONENTS
No. 21962OEM: N/A
Kit contains:GLM OEM ITEM39630 508105 Seal Kit89210 911826 Shift Cable Bellow89200 3854127 U-Joint Bellow89190 914036 Exhaust Bellow01090 3852604 Hose Clamp01070 912628 Hose Clamp21905 3853807 Gimbal Bearing21465 320107 Cable Tie21466 317893 Cable Tie
TRANSOM SERVICE KIT
No. 89210SHIFT CABLE BELLOWOEM: 911826
Cobra(1986-1993)
Cobra(1986-1993)
No. 89190EXHAUST BELLOWOEM: 914036
No. 21905GIMBAL BEARINGASSEMBLYOEM: 983937
No. 39630OUTDRIVEMOUNTING KITOEM: 508105
No. 89200U-JOINT BELLOWOEM: 3854127
Cobra(1986-1998)
For All “Clutch Dog” Cobra(1986-1993)
NEW
GLM Built in U.S.A.
Kit contains:GLM OEM ITEM34730 915840 Gasket86300 911823 Seal81180 (2) 911851 O-ring
Cobra(1986-1993)
No. 90071TRAILER CLIPSOEM: 174448
For OMC Cobra
58
OM
C-C
obra
Ste
rndriv
eSection 6
OMC CobraSeawater Pump Parts
1986-1993
Section 6
59
60
OMC - COBRAWATER PUMP KIT AND COMPONENTS
No. 12092COMPLETE WATER PUMP KITOEM: N/A
No. 12091WATER PUMP SERVICE KITOEM: 984461
No. 12405PUMP HOUSINGOEM: 984744
No. 12391WATER PUMP LINEROEM: 911844
No. 89950IMPELLEROEM: 777128
No. 12760WEAR PLATEOEM: 911703
No. 34770GASKETOEM: 911702
No. 86630SEALOEM: 911704
No. 47010VENT HOSE WATER PUMP ADAPTEROEM: 912614
No. 22385SCREWOEM: 912238
No. 27900WATER PUMPADAPTEROEM: 911699
No. 86610OIL SEALOEM: 916058
No. 81280O-RINGOEM: 909316
No. 82430O-RINGOEM: 911700
No. 34771GASKETOEM: 911698
61
OM
C-S
tringer S
tern
driv
eSection 7
OMC StringerUpper Gear Housing Parts
1985 & older
Section 7
Upper Gear Housing - Applications .............................................. 62
Upper Gear Housing - Complete ..................................................63
Upper Gear Housing - Empty .......................................................64
Bearing Retainer - Assembies ......................................................65
Upper Gear Housing - Rebuild Kits .............................................. 65
Upper Gear Housing - Seal Kits ...................................................66
Upper Gear Sets ..........................................................................67
Upper Gear Housing - Breakdown (1973-1985) .................... 68-69
Upper Gear Housing Components ......................................... 70-71
Drive Shafts ..................................................................................72
Steering Components ................................................................... 73
OMC - STRINGER
APPLICATION CHART (1973-1985)
COMPLETE UPPER AND LOWER GEAR HOUSING ASSEMBLY
*The GLM #28830 complete lower gear housing is a direct replacement for the 1981-1985 OMClower gear housing. The installation of the 1981-1985 ESA (Electronic Shift Assist) components andshift cable are necessary to replace the lower gear housing on the 1978-1980 OMC sterndrives withhydraulic shift.
#The GLM #28830 complete V6/V8 lower gear housing (large diameter) can be used to replace the1978-1985 four-cylinder lower gear housing (small diameter) if the upper housing gear ratio ischanged to 21:20. The installation of the 1981-1985 ESA (Electronic Shift Assist) components andshift cable are necessary to replace the lower gear housing on the 1978-1980 OMC sterndrives withhydraulic shift.
^The GLM #28600 lower housing will not replace the 1978-1980 OMC lower housings with hydraulicshift.
Model Year UpperComplete
UpperHousing
LowerComplete
LowerHousing
All 4-Cylinder 1973-1977 27500 27000 - -
All 4-Cylinder 1978-1985 27500 27000 28830*# -
V6, 165 HP, 250 CID 1973-1977 27300 27000 - -
V6 Chevy, 3.8L, 229 CID 1981-1985 27400 27000 28830 28600
V6 Chevy, 4.3L, 262 CID 1985 27300 27000 28830 28600
V6 Chevy, 5.0L, 307 CID 1973-1977 27200 27000 - -
V6 Chevy, 5.0L, 305 CID 1978-1985 27200 27000 28830* 28600*
V8 Ford, 5.0L, 302 CID 1974-1977 27200 27000 - -
V8 Chevy, 5.7L, 350 CID 1978-1985 27100 27000 28830* 28600*
V8 Ford, 5.8L, 351 CID 1975-1977 27100 27000 - -
V8 Ford, 5.8L, 351 CID 1978-1979 27100 27000 28830* 28600*
62
OMC - STRINGERCOMPLETE UPPER GEAR HOUSING ASSEMBLY (1973-1985)
100% New
Engine Teeth on Original Gears GLM No. OEM No.
4-Cylinder, All 21T/18T 27500 982488
V6, 3.8L, 229 CID 21T/20T 27400 982739
L6, 165 HP 21T/19T 27300 981229
V6, 4.3L, 262 CID 21T/19T 27300 981229
V8 Ford, 5.0L, 302 CID 21T/17T 27200 982487
V8 Chevy, 5.0L, 305 CID 21T/17T 27200 982487
V8 Chevy, 5.7L, 350 CID 21T/16T 27100 982488
V8 Ford, 5.8L, 351 CID 21T/16T 27100 982488
www.glmmarine.com 63
64
OMC - STRINGERUPPER GEAR HOUSING (1973-1985)
No. 27000OEM: 982226
1973-1985 OMC Empty Gear HousingReady for Your Components
Don’t scrap a boat because of a corroded upper gear housing!Replace it with a NEW housing from GLM.
The GLM #27000 will work on all 1973-1985 OMC sterndrives and will accept the originalinternal and external OMC components.
www.glmmarine.com 65
OMC - STRINGERBEARING RETAINER ASSEMBLIES (1973-1985)
UPPER GEAR HOUSING REBUILD KIT (1973-1985)
No. 22590 21T/16TOEM: 982478No. 22580 21T/17TOEM: 982477No. 22567 21T/18TOEM: 982476No. 22568 21T/19TOEM: 984263No. 22570 21T/20TOEM: 982738
No. 22519 21T/16TOEM: N/ANo. 22516 21T/17TOEM: N/ANo. 22537 21T/18TOEM: N/ANo. 22538 21T/19TOEM: N/ANo. 22539 21T/20TOEM: N/A
66
OMC - STRINGER
UPPER GEAR HOUSING KITS APPLICATION CHART (1973-1985)
No. 87651OEM: 981799
No. 87650OEM: 982949
For All Models (1973-1985)For 100 thru 245 (1968-1972)
UPPER GEAR HOUSING SEAL KITS
4-Cylinder, All 21T/18T 22537 22567 87650
V6, 3.8L, 229 CID 21T/20T 22539 22570 87650
L6, 165 HP 21T/19T 22538 22568 87650
V6, 4.3L, 262 CID 21T/19T 22538 22568 87650
V8 Ford, 5.0L, 302 CID 21T/17T 22516 22580 87650
V8 Chevy, 5.0L, 305 CID 21T/17T 22516 22580 87650
V8 Chevy, 5.7L, 350 CID 21T/16T 22519 22590 87650
V8 Ford, 5.8L, 351 CID 21T/16T 22519 22590 87650
EngineTeeth on
Original GearsUpper
Rebuild KitBearing
Retainer KitUpper
Seal Kit
www.glmmarine.com 67
OMC - STRINGER
Different size engines require differentgear ratios in the drive. The manufacturerchanges these ratios with different gearsets. The gear ratio change is in the uppergear housing*. All 1973-1985 OMC uppergear housings are identical** except forthe tooth count on the gears. Below isa chart showing the tooth count for thedifferent size engines used with OMCsterndrives.
UPPER GEAR SETS (1973-1985)
Rebuild your OMC powered boat with high quality GLM parts!GLM is the source for OMC parts!
*All lower gear housing ratios are either 2.0:1 for the four-cylinder engines or 1.83:1 for the six and eight-cylinder engines.
**The original driven gears in 1973 and 1974 upper gear housings are not machined for a centering cone. All 1975 and newer drivengears and all GLM replacement driven gears are machined for a centering cone. A new drive shaft with shorter splines and a centeringcone must be installed when replacing the original (non-centering cone) driven gear.
GLM is first in the marine industry to have all of theOMC upper housing gear ratios.
All GLM upper gear sets come with:
Engine Teeth on Original Gears GLM No. OEM No.
4-Cylinder, All 21T/18T 22518 982244
V6, 3.8L, 229 CID 21T/20T 22530 982835
L6, 165 HP 21T/19T 22514 984262
V6, 4.3L, 262 CID 21T/19T 22514 984262
V8 Ford, 5.0L, 302 CID 21T/17T 22512 982259
V8 Chevy, 5.0L, 305 CID 21T/17T 22512 982259
V8 Chevy, 5.7L, 350 CID 21T/16T 22510 982261
V8 Ford, 5.8L, 351 CID 21T/16T 22510 982261
GLM No. OEM No. Item21544 382212 Bearing21545 379585 Bearing21547 375761 Bearing
68
OMC - STRINGERUPPER GEAR HOUSING (1973-1985)
3
154 5
6
30
7
8
10
11 12 13 1415 17
722
23
24
9
18
25
26
27
28
29
19
20
21
3334 35
31
321
36
37
414243
36 38
39
40
49
50
4847
44
4645
55
52
51
55
54
53
2
56
5716 No. 87650
58
Seal Kit
No. 12190
59
Complete Water Pump Kit
No. 12191
60
Impeller Repair Kit
No. 22050
61
Ball Gear Kit
www.glmmarine.com 69
OMC - STRINGER
GLM No. Ref No. OEM No. Description
1
2
3
3
4
4
5
6
7
7
7
7
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
21
21
22
23
24
25
26
27
28
28
29
30
31
32
33
34
35
36
37
38
39
40
41
42
982226
313175
310327
910582
302540
909140
909139
909048
982261
982259
984262
982835
982244
382212
379585
308621
981196
908069
908064
908052
308592
315189
907866
553126
382165
981268
909121
981220
382883
907774
983298
910238
308928
777130
313176
909753
908087
314491
375761
305282
908870
908871
911316
908890
3852473
308699
308591
318544
311598
308883
314390
Upper Gearcase Assembly
O-ring
O-ring (Electric Shift)
O-ring (400-800)
O-ring (Early Model)
O-ring (Late Model)
Quad Ring
Quad Ring
Gears 21:16
Gears 21:17
Gears 21:19
Gears 21:18
Gears 21:20
Bearing
Bearing
O-ring
Oil Seal
Ball Gear
Nut
Cover
Gasket
Gasket
Lock Nut
O-ring
Bearing
Oil Seal
Drive Shaft (Low Profile)
Drive Shaft (High Profile)
Drive Shaft (High Profile)
Shaft Seal
Pump Housing
O-ring
Key
Impeller Pump Plate
Pump Plate
Pump Drive Shaft (Low Profile)
Pump Drive Shaft (High Profile)
O-ring
Bearing
Screw
Bracket
Retainer
Retainer Ring
Spacer Shaft
Screw
Water Cover - Stbd.
Water Cover - Port
Screw Set
Gasket
Bushing
Gasket
270008248082250
8225082140
8023042140
411202251022512
2251422518
225302154421545
8235086080
2202022330
220303418033050
2231082360
215468609022412
2242222423
8610012390
825208959589760
1259022410
224118022021547
2232927970
2799027840
279802232828440
2845021731
311712782031173
43
44
45
46
47
48
49
50
51
51
51
51
51
52
52
52
52
52
52
53
53
53
53
53
53
53
53
54
54
54
54
54
54
55
55
55
55
55
56
57
58
59
60
61
911317
313184
302290
909386
308768
308590
909123
910240
313202
313203
313204
313205
313206
313163
313164
313165
313166
313167
313168
313193
313194
313195
313196
313197
313198
313199
313200
313185
313186
313187
313188
313189
313190
982476
982738
984263
982477
982478
313228
909638
982949
983218
-
-
Retaining Ring
Bearing Retainer
Lockwasher
Screw
Seal
Spring
Centering Cone
Bearing Housing
Shim .002
Shim .003
Shim .004
Shim .005
Shim .006
Shim .003
Shim .004
Shim .005
Shim .006
Shim .007
Shim .008
Shim .003
Shim .004
Shim .005
Shim .006
Shim .007
Shim .008
Shim .009
Shim .010
Shim .005
Shim .006
Shim .007
Shim .008
Shim .009
Shim .010
Bearing Retainer Assy. 2.5/3.0L
Bearing Retainer Assy. 3.8L
Bearing Retainer Assy. 4.3L
Bearing Retainer Assy. 5.0L
Bearing Retainer Assy. 5.7L
Cover
Screw
Seal Kit
Complete Water Pump Kit
Impeller Repair Kit
Ball Gear Kit
278302796021492
2232786652
1105622515
279502331223313
2331423315
233162332323324
2332523326
2332723328
233332333423335
2333623337
233382333923340
2334523346
2334723348
233492335022567
2257022568
225802259027860
2230787650
1219012191
22050
GLM No. Ref No. OEM No. Description
UPPER GEAR HOUSING (1973-1985)
70
OMC - STRINGER
No. 27960BEARING RETAINEROEM: 313184
No. 22050BALL GEAR KIT
Kit contains:
GLM OEM ITEM82350 308621 O-ring22030 908062 Cover (2)22010 908063 Ball Gear22330 908064 Nut (2)22020 908069 Ball Gear81440 908383 O-ring86010 981195 Seal (2)86080 981196 Seal (2)
No. 22030BALL GEAR COVEROEM: 908062
No. 22330BALL GEAR NUTOEM: 908064
UPPER GEAR HOUSING COMPONENTS
No. 22327SCREWOEM: 909386
No. 86080SEAL - BEARINGRETAINER (2)OEM: 981196
No. 82350O-RING -BEARING - RETAINEROEM: 308621
No. 21544TAPERED ROLLERBEARING - RETAINEROEM: 382212
No. 22020BALL GEAROEM: 908069
No. 22010BALL GEAROEM: 908063
No. 21492LOCKWASHEROEM: 302290
Intermediate Housing
SHIMSNo. 23312 (.002)OEM: 313202No. 23313 (.003)OEM: 313203No. 23314 (.004)OEM: 313204
No. 23315 (.005)OEM: 313205No. 23316 (.010)OEM: 313206No. 23310COMPLETE KITOEM: N/A
No. 21547TAPERED ROLLER BEARINGOEM: 375761
SHIMS - REAR BEARING
No. 23323 (.003)OEM: 313163No. 23324 (.004)OEM: 313164No. 23325 (.005)OEM: 313165No. 23326 (.006)OEM: 313166No. 23327 (.007)OEM: 313167No. 23328 (.008)OEM: 313168No. 23320COMPLETE KITOEM: 313163
www.glmmarine.com 71
OMC - STRINGER
No. 27950BEARING HOUSINGOEM: 910240
UPPER GEAR HOUSING COMPONENTS
No. 22310NUTOEM: 907866
No. 21545UPPER TAPEREDROLLER BEARINGOEM: 379585
No. 21546LOWER TAPEREDROLLER BEARINGOEM: 382165
No. 86090SEAL (2)OEM: 981268
SHIMSNo. 23345 (.005)OEM: 313185No. 23346 (.006)OEM: 313186No. 23347 (.007)OEM: 313187
No. 82360O-RING - BEARING HOUSINGOEM: 553126
No. 23348 (.008)OEM: 313188No. 23349 (.009)OEM: 313189No. 23350 (.010)OEM: 313190
No. 22515CENTERING CONEOEM: 909123
SHIMSNo. 23333 (.003)OEM: 313193No. 23334 (.004)OEM: 313194No. 23335 (.005)OEM: 313195No. 23336 (.006)OEM: 313196No. 23337 (.007)OEM: 313197
No. 23338 (.008)OEM: 313198No. 23339 (.009)OEM: 313199No. 23340 (.010)OEM: 313200No. 23330COMPLETE KITOEM: N/A
22423 Long Shaft
NLA - Short Shaft
22422 Long Shaft
22412 Short Shaft
72
OMC - STRINGER
No. 22412OEM: 909121
DRIVE SHAFTS (1973-1985)
All(1978-1985)
Low Profile(1975-1977)
No. 22422OEM: 981220Short Spline
No. 22423OEM: 382883Long Spline
High Profile(1975-1977)
High Profile(1973-1974)
Electric ShiftUse WITH centering cone No. 22515
Electric ShiftUse WITHOUT centering cone
Model Year Upper Drive Shaft
All Models High Profile*
All Models Low Profile*
All Models High Profile**
All Models Low Profile***
1973-1974
1973-1974
1975-1977
1975-1985
* Starting with model year 1975 all driven gears were machined to accept a centering cone below the drive shaft retaining nut.This centering cone requires a drive shaft with a shorter spline.
Upper gear housings, model year 1973 and 1974, with the original driven gear (no centering cone) require GLM #22423 driveshaft with longer splines. This drive shaft fits only the high profile gear case. GLM does not manufacture the drive shaftwith longer splines for the low profile gear case.
All 1975 and newer upper gear housings and all older upper gear housings utilizing the new driven gear (with centering cone)will utilize drive shaft GLM #22412 (low profile) or GLM #22422 (high profile).
**The high profile upper gear housing was discontinued for 1978.
***All 1978-1985 upper gear housings are low profile.
No. 27970BRACKETOEM: 908870
No. 27820BUSHINGOEM: 308883
No. 27980SPACER SHAFTOEM: 908890
No. 27990RETAINEROEM: 908871
No. 27820BUSHINGOEM: 308883
No. 41120QUAD RINGOEM: 909048
No. 31173GASKETOEM: 314390
No. 27840RETAINEROEM: 911316
No. 80230O-RINGOEM: 909140
No. 42140QUAD RINGOEM: 909139
www.glmmarine.com 73
OMC - STRINGER
STEERING
No. 86652SEALOEM: 308768
No.28440WATER COVER-STBDOEM: 308699
No.28450WATER COVER -PORTOEM: 308591
No. 27860COVEROEM: 313228
No. 11056SPRINGOEM: 308590
No. 34180WATER COVERGASKET (2)OEM: 308592
No. 82480O-RING - COVEROEM:313175
No. 22328SCREWOEM: 3852473
No. 82250O-RINGOEM: 910582
No. 22307SCREWOEM: 9096381
No. 22329SCREWOEM: 305282
74
OM
C-S
tringer S
tern
driv
eSection 8
OMC StringerLower Gear Housing Parts
1985 & Older
Section 8
Upper & Lower Gear Housing - Applications ................................76
Lower Gear Housing - Complete ..................................................77
Lower Gear Housing - Empty .......................................................78
Lower Gear Housing - Assembly Kit .............................................79
Lower Gear Housing - Seal Kits ...................................................79
Lower Gear Housing - Breakdown (1978-1985) .................... 80-81
Lower Gear Sets .................................................................... 82-85
Lower Gear Housing Components (1978-1985) ..........................86
Prop Shaft Parts - 4-Cyl. w/ Mechanical Shift (1978-1985) ..........87
Prop Shaft Parts - V6/V8 w/ Mechanical Shift (1978-1985) ..........87
Lower Gear Housing - 4-Cyl. w/ Mechanical Shift (1978-1985) ...88
Lower Gear Housing - V6/V8 w/ Mechanical Shift (1978-1985) ...89
Shift Parts ..................................................................................... 90
Miscellaneous...............................................................................90
Electric Shift Lower .......................................................................91
75
76
OMC - STRINGER
APPLICATION CHART 1973-1985
COMPLETE UPPER AND LOWER GEAR HOUSING ASSEMBLY
*The GLM #28830 complete lower gear housing is a direct replacement for the 1981-1985 OMClower gear housing. The installation of the 1981-1985 ESA (Electronic Shift Assist) components andshift cable are necessary to replace the lower gear housing on the 1978-1980 OMC sterndrives withhydraulic shift.
#The GLM #28830 complete V6/V8 lower gear housing (large diameter) can be used to replace the1978-1985 four-cylinder lower gear housing (small diameter) if the upper housing gear ratio ischanged to 21:20. The installation of the 1981-1985 ESA (Electronic Shift Assist) components andshift cable are necessary to replace the lower gear housing on the 1978-1980 OMC sterndrives withhydraulic shift.
^The GLM #28600 lower housing will not replace the 1978-1980 OMC lower housings with hydraulicshift.
Model Year UpperComplete
UpperHousing
LowerComplete
LowerHousing
4-Cylinder, All 1973-1977 27500 27000 - -
4-Cylinder, All 1978-1985 27500 27000 28830# -
L6, 165 HP, 250 CID 1973-1977 27300 27000 - -
V6 Chevy, 3.8L, 229 CID 1981-1985 27400 27000 28830 28600
V6 Chevy, 4.3L, 262 CID 1985 27300 27000 28830 28600
V8 Chevy, 5.0L, 307 CID 1973-1977 27200 27000 - -
V8 Chevy, 5.0L, 305 CID 1978-1985 27200 27000 28830* 28600^
V8 Ford, 5.0L, 302 CID 1974-1977 27200 27000 - -
V8 Chevy, 5.7L, 350 CID 1978-1985 27100 27000 28830* 28600^
V8 Ford, 5.8L, 351 CID 1975-1977 27100 27000 - -
V8 Ford, 5.8L, 351 CID 1978-1979 27100 27000 28830* 28600^
www.glmmarine.com 77
OMC - STRINGERCOMPLETE LOWER GEAR HOUSING ASSEMBLY - V6 & V8 (1978-1985)
No. 28830OEM: 987242Ratio: 12:22
Without Shift Assembly
All GLM replacement lower gear housings for the V6 and V8 OMC Stringer sterndrives have thenew heavy duty #22666 gear sets. This new gear set has fewer, larger, stronger teeth. The piniongear has 12 teeth and the forward and reverse gears have 22 teeth. The original OEM gear set has14 teeth on the pinion and 26 teeth on the forward and reverse gears. During the gear machiningprocess an additional pass is made over each tooth for a finer surface. This makes the gearoperation especially quiet. These durable gears are capable of operating with up to 300 horsepower.All GLM lower gear housings have the large 1-1/4 inch diameter prop shafts with a reverse thrustwasher installed between the shaft and reverse gear**.
*Many 1978-1980 OMC sterndrives have had the hydraulic shift lower gear housing replaced with the 1981-85 mechanical shift lower gearhousing. Sterndrives with the original hydraulic shift lower gear housing do not have an ESA (electronic shift assist) box or overstrokeswitches on the shift converter. 1978-1980 sterndrives that have been converted to the mechanical shift lower gear housing do/must havethe ESA and overstroke switches installed.
**For model year 1991 OMC increased the prop shaft diameter at the carrier needle bearing (not the prop splines) from 1-3/16 to 1-1/4inches. The larger prop shaft/needle bearing is a direct replacement into the 1981-1985 lower gear housing and is installed in all GLM lowergear housings.
Strongest Lower Gear Housing Assembly in theMarine Industry for 1978-1985* OMC V6 and V8 Sterndrives
Year
1981-85
1985
1981-85
1981-85
Model
V6, 3.8L
V6, 4.3L
V8, 5.0L, 200-230HP
V8, 5.7L, 260HP
Lower Housing
28600
28600
28600
28600
Lower Complete
28830
28830
28830
28830
78
OMC - STRINGERGEAR HOUSING ASSEMBLY (1978-1985)
No. 28600OEM: 438050
The GLM #28800 will fit on all 1978 -1985 OMC sterndrives with a V6 or V8 engine and mechanicalshift*. It will accept the original internal and external OMC components**.* Will not fit the 1978-1980 with hydraulic shift.** Must use the propellor bearing carrier GLM #11406
List of improvements made to the GLM housing:
1978-1985 OMC Empty Gear HousingReady for Your Components
Don’t scrap a boat because of a damaged or corroded lower gear housing!Replace it with a NEW housing from GLM.
Sand Cast from superior A356T5 Aluminum Alloy(Original is Die Cast from inferior A380T6)
Mercruiser style pressed fit pinion needle bearing(Original is held in place with a screw)
Prop Shaft Carrier is retained with bolts and tabs (1991-1993 Cobra style)(1978-1985 carriers are held in place with internal snap rings and 1/4” bolts)
Prop Shaft Carrier is prevented from rotating with a key and groove
Water pickup screens are removable with out disassembling the drive. (1978-1985 water screens are removed only from the inside of the gear housing)
•
•
•
•
•
www.glmmarine.com 79
OMC - STRINGERCOMPLETE GEAR HOUSING ASSEMBLY KIT
No. 28870OEM: N/A1.86 RatioAll Prop Shaft 1-1/4 in. Dia.
V6 & V8 (1978-1985)with mechanical shift
*Kit comes withoutSHIFT ASSY.
LOWER GEAR HOUSING SEAL KITSNo. 87620OEM: 981797
(1968-1977)with electric shift
No. 87630OEM: 982946
V6 & V8 (1978-1985)with mechanical shift
No. 87640OEM: 982947
4-Cyl. (1978-1985)with mechanical shift
80
OMC - STRINGERLOWER GEAR HOUSING COMPONENTS -
WITH MECHANICAL SHIFT (1978-1985)
No. 87630 69
V6, V8 w/Mech. Shift
Seal Kit
No. 87640 70
4-Cyl. w/Mech. Shift
Seal Kit
No. 87620 71
Electric Shift(1968-1977)
Seal Kit
For Prop Hardware KitsSee Section 11
www.glmmarine.com 81
OMC - STRINGER
GLM No. Ref No. OEM No. Description1
2
2
3
4
5
6
7
8
9
9
9
10
10
9+10
11
12
12
13
14
14
15
15
16
17
17
18
19
19
19
20
21
22
23
24
25
26
27
28
29
30
31
32
33
33
34
34
35
36
37
438050
387817
384195
337778
337061
327656
387656
982424
314728
5004216
435088
986979
910994
345992
-
314730
910236
910338
324670
389455
391365
389039
382407
331880
337774
910578
324369
395209
982416
436888
382408
314731
317624
331999
382407
387247
320862
316563
909604
983494
313448
318544
311598
327669
324766
328825
320145
910310
982422
321467
Gearcase Assembly
Pinion Bearing
Pinion Bearing 4-Cyl.*
Screen
Screw
Thrust Washer
Thrust Bearing
Drive Shaft
O-ring
P/Forward Gear Set M*
P/Forward Gear Set H*
P/Forward Gear Set 4-Cyl.*
Reverse Gear
Reverse Gear 4-Cyl.*
Gear Set (Heavy Duty)
Nut
Gasket
Gasket 4-Cyl.*
Gasket
Housing & Bearing Assembly
Housing & Bearing Assy. 4-Cyl.*
Bearing
Bearing 4-Cyl.*
Pin
Clutch Dog
Clutch Dog 4-Cyl.*
Spring
Prop Shaft M*
Prop Shaft H*
Prop Shaft (1976-1986) 4-Cyl.*
Thrust Bearing
Thrust Washer
Screw
Screw 3/8 x 1-3/4 -16
Bearing
Bearing
Oil Seal
Screw
Gasket
Anode
Cross Pin
Draining Screw
Gasket
Thrust Washer
Thrust Washer 4-Cyl.*
Pin
Pin 4-Cyl.*
Detent
Bearing Housing & Seal
Oil Seal
28600
2161022880*
218852236321645
1633022413
8138022623*22621*
22631*22624
22632*22666
111903472033730*
3302027700
27702*2291022870*
2113822625
22633*11052
22414*22415*22416*
1630021642
223622237122870
1141085130
2230034690
127732113521731
3117121646
21644*2113721135*
2772122730
86060
322938
324037
982422
322941
160084
911962
912127
328701
121731
305981
982439
310649
313353
323362
323361
314745
389042
385043
127084
126870
314503
398042
314502
306394
315810
320570
436745
914535
330265
328096
330263
313715
910311
910539
910309
306358
306376
910551
305123
313446
982946
982947
981797
Lever
Lever 4-Cyl.*
Cradle
Shaft
Detent Ball
Spring
Screw
Lockwasher
Nut
Washer
Swivel Bearing Retainer V6 & V8 +
Oil Seal
Oil Seal
Shim .003
Shim .004
Shim .005
Thrust Bearing
Thrust Bearing 4-Cyl.*
Thrust Washer 4-Cyl.*
Thrust Washer
Nut 4-Cyl.*
Nut & Keeper
Cotter Pin 4-Cyl.*
Cotter Pin
Spacer 4-Cyl.*
Spacer
Anode
Screw 7/16 x 3-1/2 -14
Washer
Screw
Screw 3/8 x 3-1/2 -16
Screw
Rack
Pin
Shift Rod V6 & V8 +
Washer
Cotter Pin
Stud
O-ring
O-ring 4-Cyl.*
Seal Kit V6 & V8 w/ Mech. Shift
Seal Kit 4-Cyl. w/ Mech. Shift
Seal Kit w/ Electric Shift (1968-77)
27740
27741*27730
277102249111055
2236921761
2118021490
27780+
8604086050
2359023580
235101634016310*
22230*22221
22150*2218522120*
2214222250*
2219012776
223652167422366
2236722368
2787027880
27890+
2167822145
2247382400
82370*8763087640
87620
*The 1978-1985 OMC Sterndrives with four-cylinder enginesutilize a small diameter lower gear housing.
+The 1978-1986 OMC sterndrives with V6 or V8 engines usea large diameter lower gear housing.
The lower gear housing parts are interchangeable except where notedwith an asterisk or plus sign.
M* - Mechanical ShiftH* - Hydraulic Shift
38
38
39
40
41
42
43
44
45
46
47
48
49
50
50
50
51
51
52
52
53
54
54
54
55
55
56
57
58
59
60
61
62
63
64
65
66
67
68
68
69
70
71
GLM No. Ref No. OEM No. Description
LOWER GEAR HOUSING COMPONENTS -WITH MECHANICAL SHIFT (1978-1985)
82
OMC - STRINGER
STRONGEROEM gear sets are machined from8620 forged steel. The GLM gear set ismachined from a higher alloy forgedsteel. The stronger teeth and higheralloy steel results in a gear that is 50%stronger than any other comparablegear set. These durable gears arecapable of operating with up to 300horsepower.
MORE DURABLEThe new GLM gear set has fewer,larger, and stronger teeth. The piniongear has 12 teeth and the forward andreverse gears have 22 teeth. Theoriginal OEM gear set has 14 teeth onthe pinion and 26 teeth on the forwardand reverse gears.
QUIETERDuring the gear machining process,an additional pass is made over eachtooth for a finer surface. This makesthe gear operation especially quiet.
NEW!
The new heavy-duty GLM #22666 gearswill not interchange with the standardgears. For individual gear replacement,you must use the standard duty GLM#22623 pinion and forward gears or theGLM #22624 reverse gear.
IMPORTANT NOTE:
*For model year 1990 OMC increased the prop shaft diameter at the carrier needle bearing (not the prop splines) from 1-3/16 to 1-1/4 inches.Some older gearcases may be fitted with the new large diameter prop shaft. The large diameter prop shaft utilizes a thrust washer (includedwith this gear set) between the prop shaft and reverse gear. Discard the thrust washer when using the small diameter prop shaft.
HEAVY DUTYGear Set GLM #22666Includes #21651 thrust washer*
LOWER GEAR HOUSING GEARS - V6 & V8
When all three gears need replacing in your OMC sterndrive the installation of the GLM#22666 heavy-duty gear set is highly recommended. The heavy-duty gears can be usedwith all V6 and V8 OMC sterndrives from 1978-1985 with mechanical shift (not 1978-1980with hydraulic shift).
It is recommended that a new clutch GLM # 22625 (this clutch is not included with the gearset) be installed with the heavy-duty gears.
GLM #22666 heavy-duty gears fit theseOMC Sterndrive units:
3.8L/229CI V6 1981-85
4.3L/262CI V6 1985
5.0L/305CI V8 1981-85
5.7L/350CI V8 1981-85
www.glmmarine.com 83
OMC - STRINGERLOWER GEAR HOUSING GEARS - STANDARD
COMPLETE GEAR SET- Forward/Pinion/Reverse- 14/26 teeth- Comes with the GLM #22625 clutch
FORWARD & PINION SET- May be used with OMC reverse gear- 14/26 teeth
REVERSE GEAR- May be used with OMC forward and pinion gears- 26 teeth- Includes thrust washer #21651**
CLUTCH
GLM #22622
GLM #22623
GLM #22624
GLM #22625
OEM N/A
OEM #5004216
OEM #910994
OEM #337774
**For model year 1990 OMC increased the prop shaft diameter at the carrier needle bearing (not the prop splines) from 1-3/16 to 1-1/4 inches. Some older gearcases may be fitted with the new large diameter prop shaft. The large diameter propshaft utilizes a thrust washer (included with this gear set) between the prop shaft and reverse gear. Discard the thrustwasher when using the small diameter prop shaft.
STANDARD DUTYReplacement Gear Sets
These gearsets are an exact copy of the gears used in the V6 and V8 OMC Sterndrives from1978-1985 with mechanical shift* (not 1978-1980 with hydraulic shift).
*Many 1978-1980 OMC hydraulic shift lower gearcases have been replaced with the 1981-85 mechanical shift lowergearcase. 1978-1980 hydraulic shift gear sets are still available, GLM #22620.
It is recommended that the above standard duty replacement gears be used onlywith V6 powered sterndrives listed below:
GLM recommends the heavy-duty gearset#22666 for all V8 powered sterndrives.
3.8L/229CI V6 Chev. 1981-854.3L/262CI V6 Chev. 1985
#22625Clutch Dog
#22624Reverse Gear
#22623Forward & Pinion Set
#21651Thrust Washer
84
OMC - STRINGER
#22633Clutch Dog
#22632Reverse Gear
#22631Forward & Pinion Set
These gearsets are an exact copy of the gears used in the 4-Cylinder OMCSterndrives from 1978-1985 with mechanical shift (not 1978-1980 with hydraulicshift).
4-CYLINDER GEARS
COMPLETE GEAR SET- Forward/Pinion/Reverse- 13/26 teeth- Comes with the GLM #22633 clutch
FORWARD & PINION SET- May be used with OMC reverse gear- 13/26 teeth
REVERSE GEAR- May be used with OMC forward and pinion gears- 26 teeth
CLUTCH
LOWER GEAR HOUSING GEARS - 4 CYLINDER
OEM N/A
OEM #986979
OEM #345992
OEM #910578
GLM #22630
GLM #22631
GLM #22632
GLM #22633
120/2.5 1981-1985 - 22416 22631 22632 22633 22630140/3.0 1981-1985 - 22416 22631 22632 22633 22630
3.8 1981-1985 22413 22414 22625 -3.8 1981-1985 22413 22414 22623 22624 22625 226224.3 1985 22413 22414 22625 -4.3 1985 22413 22414 22623 22624 22625 22622
200/230/260 1981 22413 22414 22625 -5.0/5.7 1982-1985 22413 22414 22625 -
www.glmmarine.com 85
OMC - STRINGERLOWER GEAR HOUSING GEARS - V6 MECHANICAL / HYDRAULIC SHIFT
* Heavy Duty Gear SetFor the 1978 model year the OMC stringer sterndrive was redesigned, the old electric shift lower gear housing was replaced withthis new hydraulic shift assist, large diameter, V6 gear housing. The hydraulic shift assist lower gear housing did not prove tobe reliable and was replaced with a mechanical shift lower gear housing on the 1979 and newer V6 outboards and the 1981and newer OMC sterndrives. OMC made available to owners of 1978-1980 sterndrives a mechanical shift lower gear housingconversion kit for a very low price. This kit consisted of a complete lower gear housing, an ESA (electronic shift assist) box,ESA activation switch and two shift overstroke switches.
It is the customer’s responsibility to determine if a 1978-1980 OMC sterndrive has the original hydraulic shift assistlower gear housing or has been converted to the mechanical shift lower gear housing.
MECHANICAL SHIFT (1981-1985)
HYDRAULIC SHIFT (1978-1980)
120/140 1978-1980 - - - - 22633 -185/225 1978-1980 22413 22415 22621 22624 22625 22620
240/250 Ford 1978-1979 22413 22415 22621 22624 22625 22620200/230/260 1978-1980 22413 22415 22621 22624 22625 22620
ModelLower Drive
ShaftPinion/Fwd
Gear SetReverse
GearClutch
DogComplete Setw/ Clutch DogYear
22666*22666*
22666*
22666*
LOWER GEAR HOUSING GEARS APPLICATION GUIDE
COMPLETE GEAR SET- Forward/Pinion/Reverse- 14/26 teeth- Comes with the GLM #22625 clutch
FORWARD & PINION SET- 14/26 teeth
REVERSE GEAR & CLUTCH- 26 teeth
CLUTCH
OEM N/A
OEM #5004941
OEM #437297
OEM #337774,914716, 915272
GLM #22620
GLM #22621
GLM #22652
GLM #22625
PropShaft
#22625Clutch Dog
#22652Reverse Gear
#22621Forward & Pinion Set
86
OMC - STRINGERLOWER GEAR HOUSING COMPONENTS (1978-1985)
No. 86040OIL SEAL - SWIVEL BEARINGRETAINEROEM: 310649
No. 86050OIL SEAL - SWIVEL BEARINGRETAINEROEM: 313353
No. 27780SWIVEL BEARING RETAINER - V6 & V8OEM: 982439
No. 86060OIL SEAL (2)OEM: 321467
No. 22362SCREWOEM: 317624
No. 22730BEARING HOUSING & SEALOEM: 982422
No. 81380O-RINGOEM: 314728
No. 23590SHIM 0.003”OEM: 323362
No. 23580SHIM 0.004”OEM: 323361
No. 23510SHIM 0.005”OEM: 314745
No. 21645THRUST WASHEROEM: 327656
No. 16330THRUST BEARINGOEM: 387656
No. 22413DRIVE SHAFT - V6 & V8OEM: 982424
No. 21610PINION BEARING - V6 & V8OEM: 387817
No. 22860PINION BEARING - 4 CYLOEM: 379504
No. 11190NUTOEM: 314730
No. 34720GASKET - V6 & V8OEM: 910236
No. 33730GASKET - 4 CYLOEM: 910338
www.glmmarine.com 87
OMC - STRINGERPROP SHAFT PARTS - 4-CYL W/MECHANICAL SHIFT (1978-1985)
No. 86030OIL SEAL - PROP SHAFT (2)OEM: 330137
No. 22860BEARING - PROP SHAFTOEM: 379504
No. 22870REVERSE GEAR -BEARING CARRIEROEM: 382407
No. 82370O-RING - CARRIEROEM: 313446
No. 21642THRUST WASHER -REVERSE GEAROEM: 314731
No. 16300THRUST BEARING -REVERSE GEAROEM: 382408
No. 22416PROP SHAFTOEM: 436888
PROP SHAFT PARTS - V6 & V8 W/MECHANICAL SHIFT (1978-1985)
No. 85130OIL SEAL - PROP SHAFT (2)OEM: 320862
No. 11410BEARING - PROP SHAFTOEM: 387247
No. 22870REVERSE GEAR -BEARING CARRIEROEM: 382407
No. 82400O-RING - CARRIEROEM: 305123
No. 21642THRUST WASHER -REVERSE GEAROEM: 314731
No. 16300THRUST BEARING -REVERSE GEAROEM: 382408
No. 22414PROP SHAFTOEM: 395209
88
OMC - STRINGERLOWER GEAR HOUSING - 4-CYL. W/MECHANICAL SHIFT (1978-1985)
No. 11052SPRINGOEM: 324369
No. 21135CROSS PINOEM: 313448
No. 22633CLUTCH DOGOEM: 910578
No. 16310THRUST BEARING -FORWARD GEAROEM: 385043
No. 21644THRUST WASHER -FORWARD GEAROEM: 324766
No. 27741LEVEROEM: 324037
No. 27710SHAFTOEM: 322941
No. 27730CRADLEOEM: 982422
No. 22870BEARINGOEM: 382407
No. 27702HOUSING &BEARING ASSYOEM: 391365
No. 28483SHAFT & BEARING HSG KITOEM: N/A
No. 27721DETENTOEM: 910310
No. 21135PINOEM: 313448
NEW
NEW
NEW
www.glmmarine.com 89
OMC - STRINGERLOWER GEAR HOUSING - V6 & V8 W/MECHANICAL SHIFT (1978-1985)
No. 11052SPRINGOEM: 324369
No. 21135CROSS PINOEM: 313448
No. 22625CLUTCH DOGOEM: 337774
No. 16340THRUST BEARING -FORWARD GEAROEM: 389042
No. 21646THRUST WASHER -FORWARD GEAROEM: 327669
No. 27740LEVEROEM: 322938
No. 27710SHAFTOEM: 322941
No. 27730CRADLEOEM: 982422
No. 22910BEARINGOEM: 389039
No. 27700HOUSING &BEARING ASSYOEM: 389455
No. 28480SHAFT & BEARING HSG KITOEM: N/A
No. 27721DETENTOEM: 910310
No. 21137PINOEM: 328825
90
OMC - STRINGER
MISCELLANEOUS
SHIFT PARTSNo. 34690GASKETOEM: 909604
Shift Housing Cover
No. 33960GASKETOEM: 911878
Shift Housing
No. 22145COTTER PINOEM: 306376
No. 27870RACKOEM: 910311
No. 27880PINOEM: 910539
No. 27890SHIFT ROD - V6 & V8OEM: 910309
No. 21731SCREW SETOEM: 318544
No. 31171GASKETOEM: 311598
No. 23112TRIM TAB V6 & V8OEM: 912392
No. 22368SCREWOEM: 313715
www.glmmarine.com 91
OMC - STRINGER
No. 27782SWIVEL BEARING RETAINEROEM: 980014
ELECTRIC SHIFT LOWER
No. 33010GASKETOEM: 313368
No. 27931SHIFT CABLE ASSEMBLYOEM: 379628
Electric Shift
WATER TUBE GROMMETS
No. 86320OEM: 310597
No. 86330OEM: 908594
No. 86340OEM: 909019
4-Cyl.Lower Grommet
AllUpper Grommet
6 & 8-Cyl.Lower Grommet
No. 85110OIL SEAL - PROP SHAFT (2)OEM: 310599
No. 86040OIL SEAL - SWIVEL BEARING RETAINEROEM: 310649
No. 86050OIL SEAL - SWIVEL BEARING RETAINER (2)OEM: 313353
No. 22310PINION NUTOEM: 907866
92
OM
C-S
tringer S
tern
driv
eSection 9
OMC StringerIntermediate Housing Parts
1985 & Older
Section 9
Intermediate Housing - Breakdown ........................................ 94-95
Intermediate Housing - Seal Kit ....................................................96
Tilt Housing - Seal Kit ................................................................... 96
Drive Installation Kits .................................................................... 96
Tilt Shaft ....................................................................................... 97
Ball Gears, Bearings, Seals .........................................................97
Transom Boot/Seal .......................................................................98
93
94
OMC - STRINGERINTERMEDIATE HOUSING
18
16
9
10
11
25
22
2117
12
131415
2324
2324
1
19
26
3
24
6
521
20
2122
23
24
87
27
No. 87652 28
Seal Kit(1973-1977)
No. 87653 29
Seal Kit(1978-1985)
No. 87660 30
Tilt Hsg. Seal Kit(1978-1985)
No. 87670 31
Tilt Hsg. Seal Kit(1981-1985 & 1980)
No. 22050
32
Ball Gear Kit
www.glmmarine.com 95
OMC - STRINGER
GLM No. OEM No. Description1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
15
16
17
18
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32
313246
909515
302337
909902
909529
308626
308799
908194
981195
908383
313992
908062
908064
908063
321467
911019
908855
302540
313080
909527
315189
909533
302290
909386
307551
311598
980183
313244
3854250
981801
982948
-
-
-
Gasket
Gasket
O-ring
Gasket
Gasket
O-ring
Gasket
O-ring
Oil Seal
O-ring
Oil Seal
Cover
Nut
Ball Gear
Oil Seal (1981 & Up, 2 Seals Used)
Oil Seal (1981 & Below, 1 Seal Used)
Oil Seal
O-ring
Plate Seal
Plate Seal
Gasket
Screw
Lockwasher
Screw
Screw
Gasket
Tilt Shaft
Gasket
Bearing
Seal Kit (1973-1977)
Seal Kit (1978-1985)
Tilt Housing Seal Kit (Before 1980)
Tilt Housing Seal Kit (1981-1985 & 1980 K & U Suffix Models)
Ball Gear Kit
34760
3390082260
339503347081270
3306081550
8601081440
850102203022330
2201086060
860708659082140
8670086710
3305022325
214922232722420
3117122040
347502151287652
8765387660
8767022050
INTERMEDIATE HOUSINGRef No.
96
OMC - STRINGER
TILT HOUSING SEAL KITSNo. 87660OEM: N/A
STRINGER MOUNTBefore 1980
No. 87670OEM: N/A
STRINGER MOUNT1981-1985 & 1980K & U Suffix Model
No. 34810OEM: N/A
STRINGER MOUNTMechanical ShiftStringer(1978-1985)
No. 34820OEM: N/A
STRINGER MOUNTElectric ShiftStringer(1971-1977)
DRIVE INSTALLATION KITS
Kit contains:GLM OEM Item Qty.82140 302540 O-Ring 133060 308799 Gasket 131171 311598 Washer 281550 908194 O-Ring 186070 911019 Seal 1
Kit contains:GLM OEM Item Qty.82140 302540 O-Ring 181550 908194 O-Ring 133060 308799 Gasket 131171 311598 Gasket 286060 321467 Seal 2
Kit contains:GLM OEM Item Qty.33470 909529 Gasket 281270 308626 O-Ring 234750 313244 Gasket 2
Kit contains:GLM OEM Item Qty.33480 316499 Gasket 281270 308626 O-Ring 234750 313244 Gasket 2
INTERMEDIATE GEAR HOUSING SEAL KITSNo. 87652OEM: 981801
No. 87653OEM: 982948
For All Models (1973-1977) For All Models (1978-1985)
No. 22050BALL GEAR KITOEM: N/A
Kit contains:GLM OEM ITEM82350 308621 O-ring22030 908062 Cover (2)22010 908063 Ball Gear22330 908064 Nut (2)22020 908069 Ball Gear81440 908383 O-ring86010 981195 Seal (2)86080 981196 Seal (2)
INTERMEDIATE HOUSING - DRIVE SHAFT ASSEMBLY
www.glmmarine.com 97
OMC - STRINGER
No. 85010OIL SEAL -SHAFT INNEROEM: 313992
No. 21512BEARING - SHAFTOEM: 3854250
No. 81440O-RING - BEARING RETAINEROEM: 908383
No. 86010OIL SEAL -SHAFT OUTEROEM: 981195
No. 22010BALL GEAR -INTERMEDIATE HSG.OEM: 908063
No. 22330BALL GEAR NUTOEM: 908064
No. 22030BALL GEARCOVEROEM: 908062
No. 34230GASKET - TILT MOTOROEM: 311508
(1967-1976)
No. 33950GASKET - TILT MOTOROEM: 909902
(1980-1985)
No. 22040TILT WORM SHAFTOEM: 980183
No. 82140O-RING - TILT SHAFT COVEROEM: 302540
No. 21492LOCKWASHEROEM: 302290
No. 22327SCREW - TILT SHAFT COVEROEM: 909386
No. 81550O-RING - TILTCLUTCH COVEROEM: 908194
No. 33060GASKET - TILTCLUTCH COVEROEM: 308799
No. 86070OIL SEAL - TILTCLUTCH SHAFTOEM: 911019
(1971-1979)
INTERMEDIATE HOUSING
No. 86060OIL SEAL - TILTCLUTCH SHAFT (2)OEM: 321467
(1980-1985)
98
INTERMEDIATE HOUSING PARTS
No. 86700OEM: 313080
Electric ShiftStringer(1967-1977)
No. 86710OEM: 909527
Mechanical ShiftStringer(1978-1986)
TRANSOM SEALS
Has 16 Screw Holes Has 22 Screw Holes
No. 33470GASKET -SIDE COVEROEM: 909529
(1978-1985)
No. 33480GASKET -SIDE COVEROEM: 316499
(1971-1977)
No. 34750CORK SEAL -SIDE COVEROEM: 313244
No. 81270O-RING -SIDE COVEROEM: 308626
No. 34760OIL RESERVOIR GASKETOEM: 313246
No. 33900ENGINE BELL HOUSING GASKETOEM: 909515
No. 86590STEERING SHAFT SEALOEM: 908855
No. 33050RUBBER GASKET - LARGE DRAIN PLUGOEM: 315189
No. 31171GASKETOEM: 311598
No. 21492SIDE COVER SCREWLOCKWASHEROEM: 302290
No. 22325SCREW -SIDE COVEROEM: 909533
No. 21731SCREW SET - FILL PLUGOEM: 318544
No. 82260O-RING - INTERMEDIATE HOUSINGBELL HOUSINGOEM: 315189
OMC - STRINGER
99
OM
C-S
tringer S
tern
driv
eSection 10
OMC StringerSeawater Pump Parts
1985 & Older
Section 10
100
OMC - STRINGERSEAWATER PUMP
No. 22411OEM: 908087High Profile Shaft(1973-1977)
No. 22410OEM: 909753Low Profile Shaft(1973-1985)
No. 12190OEM: 983218
For 100-260Sterndrives(1962-1985)
No. 12590WATER PUMP PLATEOEM: 313176
No. 86100DRIVE SHAFT SEALOEM: 907774
No. 89760IMPELLEROEM: 777130
No. 12191OEM: N/A
For 100-260Sterndrives(1962-1985)
No. 89595KEYOEM: 308928
No. 82520WATER PUMP O-RINGOEM: 308928
No. 80220O-RINGOEM: 314491
No. 12390WATER PUMP HOUSINGOEM: 983298
Complete Water Pump Kit
Impeller Repair Kit
Kit contains:GLM OEM Item82100 310584 O-Ring81160 310585 O-Ring12590 313178 Pump Plate80220 314491 O-Ring89760 379475 Impeller86100 907774 Seal82520 910238 O-Ring12390 983298 Pump Housing
Kit contains:GLM OEM Item82100 310584 O-Ring81160 310585 O-Ring12590 313178 Pump Plate80220 314491 O-Ring89760 379475 Impeller86100 907774 Seal82520 910238 O-Ring
101
OM
C-C
obra
& S
tringer
Ste
rndriv
eSection 11
OMC Cobra & StringerProp Hardware, Anodes,
Tools
Section 11
Prop Hardware ................................................................... 102-103
Anodes .......................................................................................104
Special Tools ..............................................................................105
102
OMC - COBRA & STRINGER PROP HARDWARE - 4-CYL (1978-1989) & 2.3L (1990)
No. 22120COTTER PINOEM: 314502
No. 221505/8 X 11 NUTOEM: 314503
No. 2225013 SPLINE WASHEROEM: 315810
No. 222305/8 THICK THRUST WASHEROEM: 127084
No. 22340KIT WITHOUT THRUST WASHEROEM: 175267
No. 22235KIT WITH THRUST WASHEROEM: 5005034
PROP HARDWARE - 4-CYL 3.0L (1990) & V6 / V8 (1978-1990)
No. 22142COTTER PINOEM: 3852056
No. 221853/4 x 16 NUTOEM: 398042
Comes with pin No. 22142
No. 222209/16 THICK THRUST WASHEROEM: 333592
No. 22185NUTOEM: 398042
No. 22225KIT WITH THRUST WASHEROEM: 434153
No. 22200KIT WITHOUT THRUST WASHEROEM: 175266
No. 2219015 SPLINE WASHEROEM: 320570
www.glmmarine.com 103
OMC - COBRA & STRINGER PROP HARDWARE - ALL (1991-1993)
PROP HARDWARE - ALL (1994-1998)
No. 22142COTTER PINOEM: 3852056
No. 221853/4 x 16 NUTOEM: 398042
Comes with pin No. 22142
No. 222219/16 THICK THRUST WASHEROEM: 3852020
No. 22185NUTOEM: 398042
No. 22200KIT WITHOUT THRUST WASHEROEM: 175266
No. 2219015 SPLINE WASHEROEM: 320570
No. 22142COTTER PINOEM: 3852056
No. 221853/4 x 16 NUTOEM: 398042
Comes with pin No. 22142
No. 222219/16 THICK THRUST WASHEROEM: 3852020
No. 22185NUTOEM: 398042
No. 22188KIT WITHOUT THRUST WASHEROEM: N/A(No. 22252 + 22185)
No. 2225219 SPLINE WASHEROEM: 3852350
No. 22186PROP WASHER KITOEM: N/A(No. 22200 + 22221)
No. 22189PROP WASHER KITOEM: N/A(No. 22188 + 22221)
104
OMC - COBRA & STRINGERANODES
No. 12776LOWER GEAR HOUSINGANODEOEM: 436745
Stringer (1982-1985)Cobra, except 460 (1986-1993)
No. 12737PROP SHAFT CARRIERANODEOEM: 431708
No. 12773LOWER GEAR HOUSINGANODEOEM: 983494
No. 12774LOWER GEAR HOUSINGANODEOEM: 3853818
No. 12772TRANSOM ASSEMBLYANODEOEM: 982438
No. 12775TRANSOM ASSEMBLYANODEOEM: 984547
No. 12698TRANSOM ASSEMBLYANODEOEM: 3853930
No. 12699TRANSOM ASSEMBLYANODEOEM: 3854130
No. 12682UPPER GEAR HOUSINGANODEOEM: 3854061
No. 12681PROP SHAFT CARRIERANODEOEM: 3852970
Cobra (1986-1993)Stringer (1984 & 1985)
Cobra (1986)
Cobra (1987-1994) Stringer (1975-1985)
Cobra (1986-1989) Cobra (1990-1993) Cobra (1994-1998)
King Cobra (1990-1995)Cobra (1994-1998)
King Cobra (1990-1995)
No. 12683LOWER GEAR HOUSINGANODEOEM: 397768
460 Cobra (1987-1989)
No. 12893GEARCASE ANODE KITOEM: N/A
Cobra (1986-1993)
No. 12892GEARCASE ANODE KITOEM:N/A
Stringer (1978-1985)
www.glmmarine.com 105
OMC - COBRA & STRINGERSPECIAL TOOLS
No. 90330DRIVESHAFTSHIMING TOOLOEM: N/A
No. 90340PINION NUT ADAPTOR KITOEM: N/A
GLM design one piecevertical shiming toolfor most OMC sterndriveand V6 outboard
GLM design to hold 5/8”pinion nut when removingpinion gear and drive shaft onOMC sterndrive and O/Bcomes with No. 90350
No. 90050ENGINE ALIGNMENT TOOLOEM: 912273
Comes withSHIM FINDERNo. 90335
No. 903332-Cyl. (1988 & before)3-Cyl. (Short Shaft 1975-86)
No. 9033450 HP (1972-74), 45/55 HP (1979 & Up)3-Cyl. (Long Shaft 1972 & Up)V4 90° (1969 & Up)
No. 90335V4 60° (1995 & Up)V6 (1976 & Up)
No. 9033640/48/50 HP(1989 & Up)
No. 90480DRIVE SHAFT ADAPTEROEM: 311875
OMC Cobra
No. 90350DRIVE SHAFT ADAPTEROEM: 314438
Aligns engine and drive unit during installation
No. 90520SHIFT CABLE ADJUSTMENT TOOL KITOEM: 914017 + 915271
Kit contains:GLM9050090510
ItemBellcrank Alignment PlateShift Cable Tool
Qty.11
No. 90510SHIFT CABLE TOOLOEM: 915271
No. 90500BELLCRANKALIGNMENT PLATEOEM: 914017
Shim Finders
NEW
OEM914017915271
No. 90460SPANNER WRENCHOEM: 912272
NEW
NEWNo. 90530HEIGHT GAUGEFOR SHIFT RODOEM: 91227
Tightens & loosens pinion nut on OMC Stringer
106
OM
C &
Volv
o E
ngin
eSection 12
OMC & VolvoRecirculating Water Pumps
Section 12
107
WATER PUMP GASKETS
108
OMC & VOLVO ENGINERECIRCULATING WATER PUMPS
No. 39750OEM: N/A
Ford 302 & 351
No. 31350OEM: N/A
No. 30231OEM: N/A
No. 32690OEM: N/A
No. 31900OEM: N/A
No. 31380OEM: N/A
No. 31770OEM: N/A
Ford 302-351L4 & L6 Cyl. Inline Chevy
(For No. 15100)
V6, 305-350 Chevy(For No. 15201)
454-502 Chevy(For No. 15301)
V6, 305-350 Chevy(For No. 15201)
454-502 Chevy(For No. 15301)
New GLM Water Pump Features:• Machined brass impeller, bi-directional and balanced • Stainless steel backing plate• Stainless steel seal cup and spring • Epoxy painted pump housing• Stainless banded ceramic seal seat
No. 15100OEM: 986779, 3854017
Chevrolet L4 & L-6 Cyl.Inline Marine Engines
153 CID-2.5L181 CID-3.0L250 CID-4.0L
No. 15201OEM: 3853850
Chevrolet V6 & V8Small Block Marine Engine
229 CID-3.8L262 CID-4.3L305 CID-5.0L350 CID-5.7L
NEW STYLENo. 15301OEM: 3855991
Chevrolet V8Big Block Marine Engine
454 CID-7.4L502 CID-8.2L
NEW STYLE
Fits Both Metal & CompositeTiming Chain Cover
Fits Both Tin & AluminumTiming Chain Cover
109
OM
C &
Volv
o E
ngin
eSection 13
OMC & VolvoThermostats, Thermostat Gaskets,
& Thermostat Housings
Section 13
Thremostats & Thermostat Kits ........................................... 110-111
Thermostat Gaskets & Housings ................................................ 112
110
OMC & VOLVO ENGINETHERMOSTATS & KITS
140°No. 13030OEM: 876305
No. 13381OEM: 876305, 875794
KIT CONTAINS:13030 Thermostat35060 Gasket35160 Gasket35170 Gasket82200 O-ring
(1993 & Before) (1993 & Before)
140°
No. 13020THERMOSTATOEM: 3853983
140° No. 13028THERMOSTAT KITOEM: N/A
KIT CONTAINS:13020 Thermostat31560 Gasket82200 O-Ring
140°
NEW
No. 13022THERMOSTATOEM: 3587597
150° No. 13025THERMOSTAT KITOEM: N/A
KIT CONTAINS:13022 Thermostat31560 Gasket82200 O-Ring
150°
NEW NEW
NEW
OMC & VOLVO ENGINE
www.glmmarine.com 111
THERMOSTATS & KITS
No. 13041THERMOSTATOEM: 3831426
160° No. 13045THERMOSTAT KITOEM: N/A
KIT CONTAINS:13041 Thermostat31560 Gasket
160°
NEW NEW
All OMC and Volvo 4-Cyl.Chevy
(1980 & Up)All OMC and Volvo 4-Cyl. Chevy
(1980 & Up)
No. 13070THERMOSTATOEM: 3853799
No. 13440THERMOSTAT KITOEM: N/A
KIT CONTAINS:13070 Thermostat33440 Gasket34260 Gasket
160° 160°160° No. 13441THERMOSTAT KITOEM: N/A
KIT CONTAINS:13070 Thermostat82180 O-ring
All OMC and Volvo(1994 & Up)
(except the 4-Cyl. Chevy)
No. 13060THERMOSTATOEM: 383307, 3856961
No. 13431THERMOSTAT KITOEM: N/A
KIT CONTAINS:13060 Thermostat31560 Gasket82200 O-Ring
All OMC and Volvo (1994 & Up)(except the 4-cyl. Chevy)
160° 160°No. 13065THERMOSTAT KITOEM: N/A
KIT CONTAINS:13060 Thermostat82200 O-Ring82290 O-Ring
160°NEW
No. 13060THERMOSTATOEM: 383307
No. 13430THERMOSTAT KITOEM: N/A
KIT CONTAINS:13060 Thermostat33440 Gasket34260 Gasket35060 Gasket82200 O-Ring
All OMC (Up to 1993)(except the 1980 and newer 4-cyl. Chevy)
All OMC (Up to 1993)(except the 1980 and newer
4-Cyl. Chevy)
160° 160°
NEW
112
OMC & VOLVO ENGINE
THERMOSTAT HOUSING
No. 22600OEM: 986292,987716,3850360
Fits Chevy V6 & V8 (1979 & Up)
No. 22601OEM: 3856265
Fits: 4.3L, 4.3HO, 5.0L, 5.0L EFI, 5.0HO, 5.7L, 5.7LE, 5.8L,5.8L EFI, 5.8L KING EFI, Model 350, 351, 351 King EFI,454, 454HO, 502 OMC King Cobra.
WATER HEATER / CABIN HEATER FITTING KIT
No. 33440OEM: 314809, 3852127
No. 34260OEM: 313416, 3852120
No. 33840OEM: 310913
THERMOSTAT GASKETS & HOUSING
No. 35060THERMOSTAT HOUSING TOINTAKE MANIFOLD GASKETOEM: 835417, 312797, 3701777GM
No. 31560THERMOSTAT HOUSINGTO INTAKE MANIFOLD GASKETOEM: 3852111
No. 35070THERMOSTATHOUSINGTO INTAKEMANIFOLD GASKETOEM: 835645
No. 31340THERMOSTAT HOUSINGTO CYLINDER HEADOEM: 311069, 3789161GM
No. 30500THERMOSTATHOUSINGTO INTAKEMANIFOLDGASKET
For Ford 302/351 with Brass Rivets
For L4 & L6 Inline Chevy
No. 35170OEM: 856004
No. 35160OEM: 835581
No. 82180O-RINGOEM: 3856537
No. 82200O-RINGOEM: 3852071, 307239
For L4 & L6 Inline Chevy
No. 82240O-RINGOEM: 983944, 302588
OM
C &
Volv
o E
ngin
eSection 14
OMC & VolvoInternal Exhaust Hose, Exhaust Gaskets
& Flapper Valves
Section 14
Exhaust Manifold Gasket Kits..................................................... 114
Exhaust Manifold-to-Engine Gaskets ......................................... 115
Exhaust Manifold-to-Riser Gaskets ............................................ 116
Exhaust Manifold End Cap Gaskets ........................................... 116
Internal Exhaust Hose ................................................................ 117
Exhaust Flappers for Exhaust Tips............................................. 117
113
OMC & VOLVO ENGINE
No. 39770OEM: N/AIncludes 33570gasket
No. 39780OEM: N/A
No. 39910OEM: N/A
No. 39920OEM: N/A
EXHAUST MANIFOLD GASKET KITS
No. 39771OEM: N/A
No. 39800OEM: N/A
No. 39790OEM: N/AIncludes 31570gasket
No. 39940OEM: N/A
No. 39773OEM: N/A
No. 39774OEM: N/A
No. 39775OEM: N/A
Chevy V8 5.0L/305CI, 5.7L/350CIOMC (1977-1998), Volvo (1994 & Up)
Chevy V8 5.0L/305CI, 5.7L/350CIVolvo (1993 & Below)
Chevy V6 4.3L/262CIOMC (1991-1998), Volvo (1992 & Up)
Chevy V6 4.3L/262CIVolvo (1991 & Below)
Chevy V8 7.4L/454CI, 8.2L/502CIOMC & Volvo (1990 & Up)
Ford V8 7.5L/460CIOMC (1987-1990)
Ford V8 5.0L/302CI, 5.8L/351CIOMC (1977-1996), Volvo (1994-1996)
Ford 4-Cyl., 2.3LOMC (1987-1990)
Chevy 4-Cyl., 3.0L/181CIOMC (1990-1998), Volvo (1993 & Up)
Chevy 4-Cyl., 2.5L/153CI/100HP/120HPOMC (1965-1985)
Chevy 4-Cyl., 2.5L/153CI/120HP, 3.0L/181CI/140HPOMC (1985-1990)
Chevy 4-Cyl., 3.0L/181CI/140HPOMC (1973-1984)
No. 39776OEM: N/A
114
OMC & VOLVO ENGINEEXHAUST MANIFOLD GASKETS
No. 31100OEM: 856034, 3852468
No. 32170OEM: 856116, 3853412
No. 33760OEM: 3852472
No. 33790OEM: 3852455
No. 33780OEM: 913393
No. 31710OEM: 912405
No. 31440OEM: 907932
No. 31550OEM: 311068
No. 31570OEM: 908079Large Port
No. 33570OEM: 912164Large Port
Chevy 305 5.0L & 350 5.7L
Chevy V6 229 3.8L& 262 4.3L
Chevy V8 454-7.4LFord 302 5.0L
& 351 5.8L Ford 460 7.5L
Ford 140-2.3LChevy Inline L6250CI/165HP
Chevy 4-Cyl.153CI/2.5L/120HP
Chevy 4-Cyl.153-2.5L/181-3.0L
Chevy 4-Cyl.181CI/3.0L/140HP
No. 31101OEM: BARR STYLE CHV-47-0000
Chevy 305/350
No. 33580OEM: 3853256Small Port
Volvo & OMC 3.0 HO (1991 & Up)Chevy 181 3.0L
www.glmmarine.com 115
OMC & VOLVO ENGINE
116
OMC EXHAUST GASKETS
VOLVO EXHAUST GASKETS
No. 33810GASKET - MANIFOLDTO RISEROEM: 3850496
V6 & V8(1977-1998)
No. 33820GASKET - MANIFOLDTO RISEROEM: 910113
V6 3.8L
No. 33030GASKET - MANIFOLDTO RISEROEM: 912477
No. 33770MANIFOLDTO RISEROEM: 3850495
No. 32980EXHAUST ELBOW &FRONT END CAPOEM: 908935
No. 33340FRONT END CAPOEM: 311130
No. 33920MANIFOLD END CAPOEM: 311552
No. 32990MANIFOLD END CAPOEM: 907775
No. 33930MANIFOLD END CAPOEM: 907764
No. 33810GASKET - MANIFOLDTO RISEROEM: 909786, 3850496
V6 & V8 SX(1994 & Up)
No. 35080GASKET - MANIFOLDTO RISEROEM: 857618
AQ V6/V8(1993 & Before)
4-Cyl. SOHC EnginesAQ 120, 125, 131, 140,
145, 151, 230, 250
No. 35030GASKET - MANIFOLDEND CAPOEM: 856036
No. 35040GASKET - REAREXHAUST OUTLETOEM: 831480
Inline L6 AQ165, AQ170
No. 32580REAREND CAPOEM: 907761
4-Cyl. 2.3L
No. 33330FRONTEND CAPOEM: 311121
2.5L/153CI/120HP3.0L/181CI/140HP
No. 33770GASKET - MANIFOLDTO RISEROEM: 3850495
Chevy 3.0L/181CI
No. 37100GASKET - MANIFOLDTO ENGINEOEM: 855967 (4)
OMC & VOLVO ENGINE
www.glmmarine.com 117
APPLICATION
No. 89220EXHAUST HOSE - UPPEROEM: 912374
No. 89222EXHAUST HOSE - LOWEROEM: 3852741
No. 89224EXHAUST HOSE - UPPEROEM: 3852696
No. 89230EXHAUST HOSE - LOWEROEM: 3852742
No. 89220
No. 89222
No. 89224
No. 89230
Fits 7.5 (460) in 1987, 5.0-5.8 Ford in 1989-1990, Fits the 5.71986 late models & all 5.7 1987-1988. “Upper Hose.”
Fits 2.5 in 1986, 3.0 in 1986-1991, 2.3 in 1989-1990, 4.3 in 1990-1991,5.0-5.8 Ford in 1991, 5.7 early 1986 model. “Lower Hose.”
Fits 4.3 in 1991, 5.0-5.8 Ford in 1991, 7.5 (460) in 1988-1989, 5.7LEModels in 1990-1991, all 1990-1991 Cone Clutch. “Upper Hose.”
Fits 2.3 in 1987-1988, 4.3 in 1987-1989, 5.0-5.8 Ford in 1989-1990,5.7 in late 1986, all 5.7 1987-1991, all 1990-1991 Cone Clutch Models(350/454/454HO/460 King). 5.7LE in 1990-1991. “Lower Hose.”
INTERNAL EXHAUST HOSE
EXHAUST FLAPPER VALVES (WITH CLAMPS)
No. 89260OEM: N/A
5” & 6”
No. 89250OEM: 12644A1
4”
No. 89240OEM: 34765A1
3”
3-1/2” x 4-1/2” 3-1/2” x 3-1/2”4” x 4” 3-1/2” x 3-1/2”
118
OM
C &
Volv
o E
ngin
eSection 15
OMC & VolvoFuel Pumps, Filters &
Carburetor Parts
Section 15
Water/Fuel Separator Brackets ..................................................121
Water/Fuel Separator Filters ......................................................121
Water/Fuel Separator Kits ..........................................................122
Fuel Filters .................................................................................123
Carburetor Kits ...........................................................................124
Carburetor Floats .......................................................................125
Carburetor Needle & Seats ........................................................125
Carburetor Mounting Gaskets ....................................................126
Fuel Pumps ................................................................................127
Fuel Pump Gaskets ....................................................................127
119
OMC & VOLVO ENGINE
120
ELIMINATE FUEL STARVATION WITH THENEW GLM LOW-PICKUP WATER/FUELSEPARATOR MOUNTING BRACKETEngine compartment temperatures can soar on hot summer days
creating high gasoline temperatures. High temps and agitation caused byrough seas can aerate the gasoline in the water/fuel separator filter turningit into foam. A fuel pump can’t pull aerated gasoline from the water/fuelseparator and pump it to the carburetoror fuel rail efficiently. The engine will showsigns of gasoline starvation (lean) at highspeeds, a situation very similar to vaporlock.
Because this aerated gasoline risesto the top of the water/fuel separator fil-ter, GLM has introduced a water/fuel filterseparator mounting bracket with a fuelpickup extending deeper into the filter.Through extensive research and testingthe GLM engineers have found the opti-mum location for the fuel pickup. Thedeeper location is low enough to be freeof aerated gasoline but high enough to befree of the water in the bottom of the sepa-rator.
The deeper fuel pickup is only foundon the new GLM water/fuel separatormounting bracket kits. It might solve someof those mysterious fuel delivery problemsyour engine may be experiencing!
*For trouble free boating always remember to replace your water/fuel separator filter after every 50 hours of engine operation!
*PATENT PENDING
New designprevents airfrom enteringthe carburetorsystem
Air moleculesrise to topand into thecarburetorsystem
GLM
CONVENTIONAL
OMC & VOLVO ENGINE
www.glmmarine.com 121
HOW TO CHOOSE THE CORRECT WATER/FUEL SEPARATOR
GLM Fuel Filter Features
* 28 or 10 micron filter paper shaped into 70 pleats total 327 sq. in. filtration. The largest filtering capability in the aftermarket. (4)* BWG #11 heavy duty spring (6).* Gasoline resistant rubber seals (1) (3).* Oxidizing treatment inside powder coated outside for corrosion protection (5).* Minimum 196N.m. torgue strength between adapt plate and canister (2).* Will not separate 2 cycle oil from gasoline!
No. 24940WATER SEPARATORFUEL FILTEROEM: N/A
No. 24941WATER SEPARATORFUEL FILTEROEM: N/A
28 micronHeight 3-3/4”
No. 24942WATER SEPARATORFUEL FILTEROEM: N/A
10 micronHeight 4-7/16”
28 micronHeight 4-7/16”
Water/Fuel Separators are categorized by their capacity tofilter different sized dirt particles. Rated in Microns, (each micronis one millionth of an inch in diameter) marine filters will normallybe available with elements capable of filtering 2 micron particles,10 micron particles, or 28 micron particles. A marine filter capableof filtering 2 micron particles will clean the fuel more efficientlythan a 28 micron filter but will be more restrictive to fuel flow.The 2 micron filter will also become dirty sooner and will needreplacement more often. Fuel flow is rated in Gallons Per Hour (GPH). A typical350/5.7L inboard engine will require 27 GPH at 4,800 rpm, a454/7.4L inboard engine will require 37 GPH at 4,800 rpm.Selecting a fuel/water separator filter should be based on theamount of fuel the engine requires in GPH at wide open throttle. A 2 micron fuel filter is generally too restrictive for theaverage four stroke inboard engine and may separate the
oil from the fuel in two stroke outboard engines. For this reasonGLM sells only the 10 and 28 micron fuel filters. The 28 micron filter is the most common size fuel filter inthe marine industry and is the standard replacement filter for alltwo stroke and four stroke marine engines. The GLM 28 micronfilter exceeds all engine manufacturers’ specifications for particlefiltering, water separating and fuel flow. The GLM 10 micron filter will provide exceptional filteringand only moderate fuel pressure loss. When used with sufficientsized fuel lines it will flow enough fuel for inboard engines up to550 horsepower. It will not separate the oil from the gasoline ona two stroke outboard equipped boat. Because a 10 micron filterclogs faster than a 28 micron filter GLM recommends it only forboaters who are vigilant in replacing the water/fuel separator filterat regular intervals.
SUS316STAINLESS STEEL BRACKETS
DIE CASTALUMINUM BRACKETS
1/4” NPTF Ports(2 inputs & 2 outputs)
No. 25010w/ 2 brass plugs2 extension tubes
No. 25030w/ 2 brass plugs2 extension tubes
3/8” NPTF Ports(2 inputs & 2 outputs)
No. 25000w/ 2 brass plugs2 extension tubes
No. 25020w/ 2 brass plugs2 extension tubes
1/4” NPTF Ports(2 inputs & 2 outputs)
3/8” NPTF Ports(2 inputs & 2 outputs)
TRANSLUCENT REDSTAINLESS STEEL BRACKETS
NEW
1/4” NPTF Ports(2 inputs & 2 outputs)
No. 25011w/ 2 brass plugs2 extension tubes
No. 25031w/ 2 brass plugs2 extension tubes
3/8” NPTF Ports(2 inputs & 2 outputs)
No. 24930WATER SEPARATORFUEL FILTEROEM: OMC 502905
28 micronHeight 4-7/16”
NEW
OMC & VOLVO ENGINE
122
WATER SEPARATING FUEL FILTER KITS
No. 24956(24940+25010)OEM: N/A
ø 1/4” NPTF PortsFlow: 50 GPHwith 2 brass plugs & 2 extension tubes
No. 24957(24942+25010)OEM: N/A
ø 1/4” NPTF PortsFlow: 50 GPHwith 2 brass plugs & 2 extension tubes
No. 24958(24940+25030)OEM: N/A
ø 3/8” NPTF PortsFlow: 75 GPHwith 2 brass plugs & 2 extension tubes
ø 3/8” NPTF PortsFlow: 75 GPHwith 2 brass plugs & 2 extension tubes
No. 24959(24942+25030)OEM: N/A
With Stainless Steel Bracket
With NEW! Translucent Red Stainless Steel Bracket
No. 24960(24940+25011)OEM: N/A
ø 1/4” NPTF PortsFlow: 50 GPHwith 2 brass plugs & 2 extension tubes
ø 3/8” NPTF PortsFlow: 75 GPHwith 2 brass plugs & 2 extension tubes
No. 24962(24940+25031)OEM: N/A
NEW
No. 24950(24940+25000)OEM: N/A
ø 1/4” NPTF PortsFlow: 50 GPHwith 2 brass plugs & 2 extension tubes
No. 24952(24942+25000)OEM: N/A
ø 1/4” NPTF PortsFlow: 50 GPHwith 2 brass plugs & 2 extension tubes
No. 24953(24940+25020)OEM: N/A
ø 3/8” NPTF PortsFlow: 75 GPHwith 2 brass plugs & 2 extension tubes
ø 3/8” NPTF PortsFlow: 75 GPHwith 2 brass plugs & 2 extension tubes
No. 24954(24942+25020)OEM: N/A
With Die Cast Aluminum Bracket
NEW
28 Micron 28 Micron
10 Micron 10 Micron
28 Micron 28 Micron
28 Micron 28 Micron
10 Micron 10 Micron
NEWNEW
OMC & VOLVO ENGINE
www.glmmarine.com 123
FUEL FILTERS & KITSNo. 24980CARB FUEL FILTEROEM: 983870
No. 24900WATER/FUEL SEPARATORCANNISTER STYLE KITOEM: 981920
No. 24910WATER/FUEL SEPARATORCANNISTER STYLEOEM: 982230
OMC CARBURETOR FUEL FILTER APPLICATION GUIDE
No. 24841CARB FUEL FILTERWITH GASKETSOEM: 908034
No. 24970CARB FUEL FILTEROEM: 984491
No. 24850FUEL PUMP FILTER KITOEM: 509263
No. 24880FUEL PUMP FILTER KITOEM: 312456
Models / Description Years GLM No.2.3L 1987 249702.3L, 4-Cyl. Ford, Holley 2-barrel 1987-1991 24970120 HP, 140 HP 1973-1981 248412.5L, 153 C.I., 120 HP Rochester 2-barrel 1972-1986 248402.5L 1982-1956 248803.0L, 181 C.I., 140 HP Rochester 2-barrel 1973-1990 248403.0L, 181 C.I., 4-Cyl. Chevy, Holley 2-barrel 1991-1998 24970165 HP, Inline 6-Cyl., Rochester 2-barrel 1972-1976 248403.8L, 229 C.I., V6 Rochester 2-barrel 1982-1985 249703.8L, 229 C.I., V6 Rochester 4-barrel 1982-1983 249804.3L, 262 C.I., V6 Rochester 2-barrel 1985 249704.3L, 262 C.I., V6 Rochester 4-barrel 1985-1989 249805.0L, 307 C.I., V8 Rochester 2-barrel 1975-1976 249705.0L, 307 C.I., V8 Rochester 4-barrel 1975-1976 249805.0L, 305 C.I., V8 Rochester 2-barrel 1978-1985 249705.7L, 350 C.I., V8 Rochester 4-barrel 1978-1989 24980V8 Chevy with Holley 4-barrel 1990-1998 24970V8 Ford with Holley 4-barrel 1990-1996 24970
No. 24901WATER/FUEL SEPARATORCANNISTER ONLYOEM: 981911
OMC & VOLVO ENGINE
124
Volvo Engine 1-Barrel Carburetors
Holley Carburetors
CARBURETOR KITS
No. 76111OEM: 380186
No. 76150OEM: OMC 983864 VOLVO 834985
No. 76068OEM: 982384
No. 76096OEM: 982539
No. 76081OEM: 982538
No. 76120OEM: OMC 984487 VOLVO 841994
No. 76088OEM: 985052
Rochester 1 Barrel Rochester 2 Barrel
Holley 2 Barrel Holley 4 Barrel351 Ford (1975-1977)
Rochester 4 Barrel(1977-1989)Rochester 2 Barrel
Holley 4 Barrel302, 351, 460 (1978-1998)
Rochester Carburetors
No. 76104OEM: N/A
Holley 4 Barrel740A/M55A
No. 76102OEM: 841293
No. 76101OEM: 841836, 841292 Solex
No. 76103OEM: N/A
No. 76108OEM: 875407
AQ115AB, 125AB, 130CD,AQ131ABCD, 145AB,AQ151ABC, 171AC,
BB115BC, 145AAQ120B, 140A,
BB140A AQ80AQ120, AQ130A,
B, BB115A
OMC & VOLVO ENGINE
www.glmmarine.com 125
8090100110120
120140150155165170175185185190200200200210215225230230235235240245250250260
1968-19691970-19711972-1973
19641965-1971(Dual carb)1972-19851973-19851964-19651967-19721972-1976
19741975-19771978-1981
19891974-19771966-19681979-1985
19891968-1972
19711972-19761975-19761979-19891975-1977
19891978
1972-19751970-1974
19791975-1976
R2R2C1R1C1
R2R2R1R2R2H2H2R2H2H2R2R2H2R4R4R4R4R4H4H4H4R4R4H4R4
2GC2GCRBSBC
RBS
2GC2GCBC
2GC2GC230023002GE23002300
2GC,V2GE23004MV4MV4MV4MV4MV4160
--
4MV4MV
-4MV
7606876068760827611176082
76075760687611176075760687608176081761207608176081760757612076081761607616076160761607615076096760887608876160761607608876160
7720077200
-77210
-
772007720077210
-77200
--
77200---
77200-
7722077220772207722077220
---
7722077220
-77220
260290 JET2.3 L2.5L2.5L2.5L3.0L3.8L4.3L4.3L4.3/2625.0L(GM)5.0L(GM)5.0L(Ford)5.7L5.8L7.5L305 C.I.I./B305 C.I.I./B305 C.I.I./B305 C.I.I./B350350454 C.I.I/B460 C.I.
1979-19891974-19751987-19891982-19851986-1990
19861982-19901979-19851986-19891979-1989
19891979-19851979-1989
19891979-1989
19891987-19881977-19791977-19781979-19831979-19831988-1989
19881977-19781987-1988
R4R4R2R2R2R2R2R2R2R4R2R2R4H2R4H4H4R2R4R4R4R4R2R4H4
4MV4MV2GE2GC2GE2GC2GC2GE2GE4MV2GE2GE4MV23004MV
--
2GE4MV4MV4MV4MV2GE4MV
-
76150761607612076075761207606876068761207612076150761207612076150760817615076088760887612076150761507615076150761207616076088
77220772207720077200772007720077200772207720077220772007720077220
-77220
--
77200772207722077220772207720077220
-
No. 77200OEM: 841634
No. 77220OEM: N/A
BRASS FLOATS
Rochester 4 BarrelV8 305, 307, 350, 454CID
CARB KITNo. 76082OEM: 979719
Carter 1 Barrel
Rochester 2 Barrel
No. 77230OEM: N/A
Rochester 2 BarrelAQ175A, 200DF, 500A
No. 77210OEM: 1397-2610
No. 40760NEEDLE AND SEATOEM: N/A
All Quadrajet Rochester 1 Barrel
OMC CARBURETOR KIT APPLICATIONSModel Years
Mfg.Code
Carb.Model
Carb.Kit Float Model Years
Mfg.Code
Carb.Model
Carb.Kit Float
OMC & VOLVO ENGINE
126
No. 30381INSULATING GASKET1/4” THICKOEM: 908765
No. 31740INSULATING GASKET1/4” THICKOEM: 909758
No. 34700OEM: 315055
No. 30382OEM: 3853283
CARBURETOR MOUNTING GASKETSNo. 31540OEM: N/A
No. 32970OEM: 311555
No. 30580OEM: N/A
No. 32130OEM: N/A
No. 32140OEM: N/A
No. 32180OEM: N/A
No. 30361OEM: N/A
Rochester4 Barrel
Holley4 Barrel
Holley2 Barrel
Holley4 Barrel
Holley2 Barrel
Rochester2 Barrel
No. 30380OEM: N/A
Rochester2 Barrel
No. 31660OEM: N/A
Rochester4 Barrel
Rochester4 Barrel
Rochester2 Barrel
OMC & VOLVO ENGINE
www.glmmarine.com 127
FUEL PUMPS
FUEL PUMP GASKETS
No. 31360OEM: 3705042
No. 31700OEM: 27-42457
No.31800OEM: 27-72805
No.32750OEM: 27-34898
Chevy V8 Chevy V6 Ford V8 Chevy 305/350
Model Year GLM No. OEM No.
Chevrolet / OMC
4-Cyl. 153 C.I. 1964-1971 77010 380455
6-Cyl. 250 C.I. / 165HP 1972-1976 DISCONTINUED 380455, 980525, 982240, 985603
4-Cyl. 2.5L / 153 C.I. / 120HP 1972-1986 DISCONTINUED 380455, 980525, 982240, 985603
4-Cyl. 3.0L / 181 C.I. / 140HP 1973-1986 DISCONTINUED 380455, 980525, 982240, 985603
4-Cyl. 3.0L / 181 C.I. / 140HP 1987-1990 DISCONTINUED 985337
4-Cyl. 3.0.L / 181 C.I. / 140HP 1991-1998 77115 986417, 3854858
V6 3.8L / 229 C.I. / 4.3L / 262 C.I. 1981-1991 77118 982997
V8 5.0L / 305 C.I. / 5.7L / 350 C.I. 1978-1998 77102 981650, 3853792, 3855276
V8 7.4L / 454 C.I. / 8.2L / 502 C.I. 1990 77104 986357
Ford / OMC
V8 5.0L / 302 C.I. / 5.8L / 351 C.I. 1974-1977 77101 980609, 982063
V8 5.0L / 302 C.I. / 5.8L / 351 C.I. 1989-1991 77120 985723
V8 5.0L / 302 C.I. / 5.8L / 351 C.I. 1992-1995 77121 987024, 3854053
128
OM
C &
Volv
o E
ngin
eSection 16
OMC & VolvoIgnition
Section 16
Mallory Ignition ...........................................................................130
Prestolite Ignition ........................................................................131
Volvo/Bosch Ignition ........................................................... 132-133
Delco Points Ignition ...................................................................134
Delco EST Ignition ......................................................................135
Ford EFI Ignition .........................................................................135
Delco EST Module .....................................................................136
Delco EST Pick-up Coil ..............................................................136
Ignition Coils ...............................................................................136
Ignition Components Application ........................................ 137-138
129
IGNITIONMallory Flat Cap
Fits all Volvo and OMC V8 engineswith a Mallory flat cap distributor
No. 71580CAP
No. 71090ROTOR
No. 70060POINTS
No. 70580CONDENSER
No. 71800
Kit contains:GLM Item71090 Rotor70060 Points70580 Condenser
Kit contains:GLM Item71580 Cap71090 Rotor70060 Points70580 Condenser
No. 72680
Mallory Standard CapFits all Volvo and OMC V8 engines
with a Mallory standard cap distributor
No. 71590CAP
No. 71040ROTOR
No. 70060POINTS
No. 70580CONDENSER
No. 72620
No. 71760
Kit contains:GLM Item71040 Rotor70060 Points70580 Condenser
Kit contains:GLM Item71590 Cap71040 Rotor70060 Points70580 Condenser
OMC & VOLVO ENGINE
130
www.glmmarine.com
Kit contains:GLM Item71550 Cap71030 Rotor70040 Points70540 Condenser
V6 PrestoliteFits all Volvo & OMC Chevrolet
4.3L/262CI/V6 engineswith a Prestolite distributor.
GLM Kit No. 72650 also fitsOMC Chevrolet 3.8L/229CI/V6
IGNITIONV8 Prestolite
(Screw-down Cap)Fits all Volvo & OMC V8 engines
with a Prestolite distributor and thenewer style screw-down distributor
cap. Distributor Cap No. 71560and Rotor No. 71060 also fit thePrestolite breakerless distributor.
V8 Prestolite(Clip-on Cap)
Fits all Volvo and OMCV8 engines with a Prestolite
distributor and early styleclip-on distributor cap
No. 71750OEM: N/A
No. 71730OEM: N/A
No. 71740OEM: N/A
No. 70010POINTS
No. 70510CONDENSER
No. 72650
No. 71060ROTOR
No. 71600CAP
Kit contains:GLM Item71060 Rotor70010 Points70510 Condenser
Kit contains:GLM Item71600 Cap71060 Rotor70010 Points70510 Condenser
No. 71060ROTOR
No. 70010POINTS
No. 70510CONDENSER
No. 72650
No. 71560CAP
Kit contains:GLM Item71560 Cap71060 Rotor70010 Points70510 Condenser
Kit contains:GLM Item71060 Rotor70010 Points70510 Condenser
No. 71050ROTOR
No. 70010POINTS
No. 70510CONDENSER
No. 72660
No. 71570CAP
Kit contains:GLM Item71050 Rotor70010 Points70510 Condenser
Kit contains:GLM Item71570 Cap71050 Rotor70010 Points70510 Condenser
OMC & VOLVO ENGINE
131
No. 71770OEM: N/A
No. 71030ROTOR
No. 70040POINTS
No. 70540CONDENSER
No. 72640
No. 71550CAP
Kit contains:GLM Item71030 Rotor70040 Points70540 Condenser
V8 Prestolite(Clip-on Cap)
Fits OMC Stringers (1974-82),OMC Cobra 7.5L (1987) with aPrestolite distributor and early style clip-on distributor cap
*Also fits: Crusader 302 (1975-78) & 305,350,454 (1977-82), PleasureCraft 302 Ford
(1972-86) & 351 / 460 Ford (1975-86)
No. 70591CONDENSEROEM: 241710
OMC & VOLVO ENGINE
132
IGNITION
No. 70500CONDENSEROEM: 841262
No. 70082POINTSOEM: 243799
No. 71000ROTOROEM: 243903
No. 71470CAPOEM: 243797
No. 71480CAPOEM: 841263
Kit contains:GLM Item71000 Rotor70082 Point70500 Condenser
No. 72600Kit contains:GLM Item71000 Rotor70100 Point70610 Condenser
No. 72690
No. 71000ROTOROEM: 243903
No. 70610CONDENSEROEM: 243653
No. 71000ROTOROEM: 243903
Kit contains:GLM Item71000 Rotor70100 Point70591 Condenser
No. 72700
4-Cylinder Volvo Engines with BOSCH Distributors
No. 71490CAPOEM: 870690
No. 70082POINTSOEM: 243799
No. 70100POINTS-TWO PIECEOEM: 1306169
See Application Chart on Following Page.
www.glmmarine.com
One Piece Points / External Mounted Condenser Distributor Points 70082 243799Condenser 70500 841263
- Kit No. 72600 Includes: 70082, 70500 & 71000 Cap 71490 870690Kit 72600 -
Two Piece Points / Internal Mounted Condenser Distributor Points 70100 1306169Condenser 70591 241710
- Kit No. 72700 Includes: 70100, 70591 & 71000 Cap 71470 243797Kit 72700 -
For All Rotor 71000 243903
OMC & VOLVO ENGINE
133
No. 71450CAP - SMALL DIA.OEM: 241669
No. 71460CAP - LARGE DIA.OEM: 243658
IGNITION
6-Cylinder Inline Volvo Engines with BOSCH Distributors
APPLICATION CHART - VOLVO 4-CYL & 6-CYL INLINE ENGINES
No. 71000ROTOROEM: 243903
No. 70100POINTS-TWO PIECEOEM: 1306169
No. 70610CONDENSEROEM: 243653
6-Cyl. CapSmall Diameter 2-9/16” ID
6-Cyl. CapLarge Diameter 3-3/16” ID
Fits 71450Small Diameter Cap
See ApplicationChart Below
See ApplicationChart Below
4-Cyl. Pushrod Engines - AQ 115 & AQ 130Description Ignition Part GLM No. OEM No.
4-Cyl. Single Overhead Cam Engines - AQ 120, 125, 131, 140, 141, 145 & 151For use with Screw Down Distributor Cap Condenser 70610 243653
Cap 71480 841263 - Kit No. 72690 Includes: 70082, 70610 & 71000 Rotor 71000 243903
Kit 72690 -For use with Clip Down Distributor Cap Condenser 70500 841262
Cap 71470 243797 - Kit No. 72600 Includes: 70082, 70500 & 71000 Rotor 71000 243903
Kit 72600 -For All Points 70082 243799
Inline 6-Cyl. Pushrod Engines - AQ 165 & AQ 170One Piece Points / For use with Small Cap Distributor Points - 241652Externally Mounted / For use with Small Cap Distributor Condenser 70610 243653For use with Small Diameter Cap Rotor 71000 243903Small Diameter Cap Cap 71450 241669
Two Piece Points / For use with Internally Mounted Condenser Points 70100 1306169
One Piece Points / For use with Large Cap Distributor Points - 243801Internally Mounted / For use with Large Cap Distributor Condenser - 834546For use with Large Diameter Cap Rotor - 243657Large Diameter Cap Cap 71460 243658
OMC & VOLVO ENGINE
134
Delco Points, 4-CylinderFits all OMC Chevrolet 2.5L/153CI/120HP 4-Cyl. EnginesFits all OMC Chevrolet 3.0L/181CI/140HP 4-Cyl. Engines
Delco Points, Inline 6-CylinderFits all OMC Chevrolet 250CI/165HP
Inline 6-Cyl. Engines (1972-1976)
IGNITION
No. 71720OEM: N/A
No. 72610OEM: 172527
No. 71540CAP
No. 71020ROTOR
No. 70020POINTS
No. 70530CONDENSER
No. 71530CAP
No. 71020ROTOR
No. 70020POINTS
No. 70530CONDENSER
Kit contains:GLM Item71020 Rotor70020 Points70530 Condenser
Kit contains:GLM Item71540 Cap71020 Rotor70020 Points70530 Condenser
No. 72610OEM: 172527
No. 71710OEM: N/A
Kit contains:GLM Item71020 Rotor70020 Points70530 Condenser
Kit contains:GLM Item71530 Cap71020 Rotor70020 Points70530 Condenser
www.glmmarine.com
OMC & VOLVO ENGINE
135
IGNITIONV6 Delco EST BreakerlessOMC Cobra w/ Chevy 4.3L/262CI/V6
Volvo w/ Chevy 4.3L/262CI/V6
V8 Delco EST BreakerlessOMC Cobra w/ Chevy V8
Volvo w/ Chevy V8
4-Cyl. Delco EST BreakerlessOMC Cobra w/ Chevy 3.0L/181CI/ 4-Cyl.
Volvo w/ Chevy 3.0L/181CI/ 4-Cyl.
V8 Ford BreakerlessOMC Volvo & Cobra, Ford 5.0L/302 EFI
& 5.8L/351 EFI (1993-1996)
No. 71400CAPOEM: 3854548
No. 71100ROTOROEM: 3854549
No. 71810OEM: N/AKit contains:GLM Item71400 Cap71100 Rotor
No. 71410CAPOEM: 3854331
No. 71110ROTOROEM: 3854311
No. 71820OEM: N/A
Kit contains:GLM Item71410 Cap71110 Rotor
No. 71830OEM: N/A
No. 71420CAPOEM: 3854260
No. 71120ROTOROEM: 3854261
Kit contains:GLM Item71420 Cap71120 Rotor
No. 71640CAPOEM: 3854217
No. 71140ROTOROEM: 3854218
No. 71850OEM: N/A
Kit contains:GLM Item71640 Cap71140 Rotor
V6 Delco EST BreakerlessVolvo
w/ Chevy 4.3L/V6
No. 71650CAPOEM: 3859019
No. 71160ROTOROEM: 3858977
No. 71890OEM: N/A
Kit contains:GLM Item71650 Cap71160 Rotor
V8 Delco EST BreakerlessVolvo
w/ Chevy 5.0 & 5.7L/V8
No. 71430CAPOEM: 3858975
No. 71160ROTOROEM: 3858977
No. 71890OEM: N/A
Kit contains:GLM Item71430 Cap71160 Rotor
OMC & VOLVO ENGINE
136
IGNITION COILS
IGNITION PARTSNo. 73190IGNITION MODULEOEM: 3854003
No. 72130PICK-UP COILOEM: 3854001
Fits OMC Chevrolet 4-Cyl. V6 & V8 Engineswith Delco Breakerless Distributors
Fits Volvo Chevrolet 4-Cyl. V6 & V8 Engineswith Delco Breakerless Distributors
For Delco ESTBreakerless Ignitions
For Delco ESTBreakerless Ignitions
No. 72116IGNITION COILOEM: 3854161
Fits OMC Chevrolet 4-Cyl. V6 & V8 Engineswith Delco Breakerless Distributors
Fits Volvo Chevrolet 4-Cyl. V6 & V8 Engineswith Delco Breakerless Distributors
For V8 FordBreakerless Ignitions
Fits OMC Cobra with Ford 5.0L/302CI EFI & 5.8L/351CI EFI (1993-1996)
Fits Volvo with Ford 5.0L/302CI EFI& 5.8L/351CI EFI (1993-1996)
No. 72115OIL FILLED COILOEM: 3852217
Use withoutExternal Resistor
No. 72117OIL FILLED COILOEM: N/A
Has Internal Resistor
No. 72110OIL FILLED COILOEM: 3853548
Used with Points Style Ignition
Resistor Wire orExternal Resistor
Used with Points Style Ignition
Used withPrestolite Breakerless Ignition
No. 72122IGNITION COILOEM: 3861267
No. 72118IGNITION COILOEM: 3287677
Fits AQ 171, AQ 251 (1988-92)
Fits Volvo Penta 8.1 Gi - GSi - GXi
No. 72113IGNITION COILOEM: 3854002
For Delco ESTBreakerless Ignitions
Fits OMC Chevrolet 4-Cyl. V6 & V8 Engineswith Delco Breakerless Distributors
Fits Volvo Chevrolet 4-Cyl. V6 & V8 Engineswith Delco Breakerless Distributors
www.glmmarine.com
OMC & VOLVO ENGINE
137
2.3L 1987-1990 4 (A) 70060 70580 - 71040 72620 726202.3L 1990 4 (B) 70010 70510 - 71060 72650 726502.5L 1981-1986 4 982351 (D) 70530 70530 71540 71020 72610 717203.0L 1982-1990 4 982351 (D, G) 70530 70530 71540 71020 72610 717203.8L 1981-1986 6 982846, 983203 (B, F) 70010 70510 (C) 71600 71060 72650 717504.3L 1985-1990 6 (B, F) 70010 70510 (C) 71600 71060 72650 717504.3L 1991-1992 6 986855 (B) - - 71600 71060 - -4.3L 2000 & Up 6 40005334 (D) - - 71650 71160 - 71890
5.0L (GM) 1979-1982 8 (B, E) 70040 70540 71550 71030 72640 717705.0L (GM) 1979-1982 8 (B, E) 70010 70510 (C) 71570 71050 72660 717405.0L (GM) 1981-1988 8 983453 (A) 70060 70580 71590 71040 72620 717605.0L (GM) 1983-1988 8 IBM 7013C (B, F) 70010 70510 (C) 71560 71060 72650 717305.0L (Ford) 1993 8 (B, F) 70010 70510 (C) 71560 71060 72650 71730
5.0L 1991-1992 8 (B, F) - - 71560 71060 - -5.0L 2000 & Up 8 21622232 (D) - - 71430 71160 - 719005.7L 1982-1990 8 983453 (A) 70060 70580 71590 71040 72620 717605.7L 1982-1990 8 IBM 7013C (B, F) 70010 70510 (C) 71560 71060 72650 717305.7L 1991-1992 8 (B, F) - - 71560 71060 - -5.7L 2000 & Up 8 21622232 (D) - - 71430 71160 - 71900
5.8L (Ford) 1989-1990 8 (B, F) 70010 70510 (C) 71560 71060 72650 717305.8L (Ford) 1991-1992 8 (B, F) - - 71560 71060 - -
7.5L 1987 8 (B, E) 70040 70540 71550 71030 72640 717707.5L 1987 8 (B, E) 70010 70510 (C) 71570 71050 72660 717407.5L 1987-1989 8 (B, F) 70010 70510 (C) 71560 71060 72650 71730100 1972-1973 4 384720, 979858 (D) 70020 70530 71540 71020 72610 71720100 1972-1973 4 980500, 982351 (D) 70020 70530 71540 71020 72610 71720110 1964 4 (D) 70020 70530 71540 71020 72610 71720120 1965-1986 4 383581, 384258 (D) 70020 70530 71540 71020 72610 71720140 1973-1989 4 980500, 982351 (D) 70020 70530 71540 71020 72610 71720150 1964-1966 6 1110309, 22 (D) 70030 70530 - - - -155 1967-1972 6 1110376 (D) 70030 70520 - - - -165 1972-1976 6 980156 (D) 70020 70530 71530 71020 72610 71710170 1974 8 (B, E) 70040 70540 71550 71030 72640 71770170 1974 8 (B, E) 70010 70510 (C) 71570 71050 72660 71740175 1975-1977 8 (B, E) 70040 70540 71550 71030 72640 71770175 1975-1977 8 980902 (B, E) 70010 70510 (C) 71570 71050 72660 71740185 1967-1968 8 381775 (A) 70060 70580 71580 71090 72680 71800185 1978-1980 8 (B, E) 70040 70540 71550 71030 72640 71770185 1978-1980 8 981659 (A) 70060 70580 71590 71040 72620 71760185 1978-1980 8 982320 (B, E) 70010 70510 71570 71050 72660 71740190 1974-1977 8 (B, E) 70040 70540 71550 71030 72640 71770190 1974-1977 8 980902 (B, E) 70010 70510 (C) 71570 71050 72660 71740200 1966 9 (D) 70030 70530 71520 71010 - 71700200 1967-1968 8 1111050, 1111053 (D) 70030 70520 71520 71010 72630 71700200 1967-1968 8 1111058, 382127 (D) 70030 70520 71520 71010 72630 71700200 1979-1988 8 981659 (A) 70060 70580 71590 71040 72620 71760200 1979-1982 8 (B, E) 70040 70540 71550 71030 72640 71770200 1979-1982 8 982320 (B, E) 70010 70510 (C) 71570 71050 72660 71740210 1968-1972 8 381775 (A) 70060 70580 71580 71090 72680 71800215 1971 8 (A) 70060 70580 71580 71090 72680 71800225 1978 8 981659, 982320 (A) 70060 70580 71590 71040 72620 71760225 1972-1976 8 381775 (A) 70060 70580 71580 71090 72680 71800230 1969-1978 8 981659 70060 70580 71590 71040 72620 71760230 1979-1982 8 (B, E) 70040 70540 71550 71030 72640 71770230 1979-1982 8 982320 (B, E) 70010 70510 (C) 71570 71050 72660 71760
230 (IB) 1975-1976 8 381775 (A) 70060 70580 71580 71090 72680 71800
IGNITION COMPONENTS APPLICATIONModel Years Cyl. Distributor Points Condenser Distrib.
Cap Rotor Tune-UpKit
CompleteT-Up Kit
235 1971 8 (A) 70060 70580 71580 71090 72680 71800235 1975-1977 8 (B, E) 70040 70540 71550 71030 72640 71770235 1975-1977 8 981080 (B, E) 70010 70510 (C) 71570 71050 72660 71740240 1978 8 (B, E) 70040 70540 71550 71030 72640 71770240 1978 8 981080 (B, E) 70010 70510 (C) 71570 71050 72660 71740245 1972-1975 8 381775 (A) 70060 70580 71850 71090 72680 71780
250 (B) 1970-1974 8 (A) 70060 70580 71850 71090 72680 71780250 1979 8 (B, E) 70040 70540 71550 71030 72640 71770250 1979 8 981080 (B, E) 70010 70510 (C) 71570 71050 72660 71740
260 (B) 1975-1976 8 384193 (A) 70060 70580 71580 71090 72680 71800260 1979-1982 8 (B, E) 70040 70540 71550 71030 72640 71770260 1979-1982 8 981659 (A) 70060 70580 71590 71040 72620 71760260 1979-1982 8 982320 (B) 70010 70510 (C) 71570 71050 72660 71740
262 CID 1989 6 (B, F) 70010 70510 (C) 71600 71060 72650 71750290 JET 1974-1975 8 (A) 70060 70580 71580 71090 72680 71800305 (IB) 1977-1979 8 980680 (A) 70060 70580 71580 71090 72680 71800305 (IB) 1980-1982 8 981659, 982320 (A) 70060 70580 71590 71040 72620 71760350 (IB) 1977-1979 8 981659 (A) 70060 70580 71580 71090 72680 71800350 (IB) 1980-1982 8 982320 (A) 70060 70580 71590 71040 72620 71760350 CID 1988-1989 8 (F) 70060 70580 71590 71040 72620 71760350 CID 1988-1989 8 (B, E) 70010 70510 (C) 71570 71050 72660 71740454 (IB) 1977-1979 8 (A) 70060 70580 71580 71090 72680 71800454 (IB) 1980-1982 8 981659, 982320 (A) 70060 70580 71590 71040 72620 71760460 CID 1988-1989 8 (B, F) 70010 70510 (C) 71560 71060 72650 71730
DISTRIBUTOR PARTS (ELECTRONIC IGNITION)
OMC & VOLVO ENGINE
138
IGNITION COMPONENTS APPLICATIONModel Years Cyl. Distributor Points Condenser Distrib.
Cap Rotor Tune-UpKit
CompleteT-Up Kit
(A) Mallory Ignition (E) Models w/ Clip-On Dist. Cap (I) Elec. Dist. (Counter Rotation)(B) Prestolite Ignition (F) Models w/ Screw-On Dist. Cap (J) Contact Controlled Dist.(C) Wire Type use No. 70540 (G) 90’S Model Point Ignition Only (K) Does Not Include Models(D) Delco Ignition (H) Elec. Dist. (Standard Rotation) w/ Shift Assist Module
Model Pick-Up Pole Pc Rotor CapDistributor No. ModuleYears351 EFI King 1994 3854176 - 72140 N/R 71140 716403.0L 1994 - 73190 72130 - 71120 714204.3L 1994 - 73190 72130 73410 71110 714105.0L EFI 1994 3854175 - 72140 N/R 71140 716405.8L EFI 1994 3854176 - 72140 N/R 71140 716407.4L 1994 3855128 - N/R N/R 71130 715604.3L, 4.3L H.O. (2V Models) 1991-1993 986855 - - - 71060 716005.0L, 5.0L H.O., 5.8 1991-1993 986969, 986970 - N/R N/R 71060 715603.0L, 3.0L H.O. 1990-1993 986653 73190 72130 73420 71120 71420351 EFI King 1993 987734 - 72140 N/R 71140 71640351 King 1993 987527 - N/R N/R 71130 715605.0L EFI 1993 987733 - 72140 N/R 71140 716405.8L EFI King 1993 987734 - 72140 N/R 71140 716405.7L OMC Cobra 1991-1992 986983 - - - 71060 71560351 1992-1993 987527 - N/R N/R 71130 71560454, 454 H.O., 502 1992 987473 - N/R N/R 71130 715605.7LE 1992 986983 - N/R N/R 71060 71560454 H.O. (744APERGF) 1991 987473 - N/R N/R 71130 715603.0, 3.0 H.O. (PWS/PWR) 1990 986653 73190 - 73420 71120 714204.3L, 4.3L H.O. w/ Dis. Ign. 1990 - N/A N/R N/R N/R N/R
139
OM
C &
Volv
o E
ngin
eSection 17
OMC & VolvoElectrical Solenoids, Power Trim Relays
& Voltage Regulators
Section 17
OMC & VOLVO ENGINE
VOLVO VOLTAGE REGULATORSVOLVO POWER TRIM RELAYSNo. 73020OEM: 876037
No. 73010OEM: 876039
5 TerminalFor AQ 175,200,225D, 260,
290A
No. 72220OEM: 841688, 841381
(1975-1989)
No. 72230OEM: 847605, 843547
(1976-1982)5 Terminal
For AQ 270,280
No. 72460OEM: 3853869
No. 72360OEM: 586730
SOLENOIDS
No. 72403OEM: 985063
No. 72490OEM: Delco 1114356, 1114458
No. 72420OEM: 378444
No. 72430OEM: 586180
OMC VOLTAGE REGULATORSNo. 72290OEM: 3853833
No. 72210OEM: 910599
No. 72200OEM: 985713
No. 72270OEM: 384538
No. 72260OEM: 383440
(1964-1981)
140
(1964-1981)
OMC & VOLVO ENGINEVOLTAGE REGULATORS
YearModel GLM No.199419941994199419941994199419941994
1992-19931992-19931990-19931989-19931989-19931988-1993
351 EFI King3.0L4.3L5.0L5.0L EFI5.7L5.8L5.8L EFI7.4L King351 King502454, 454 H.O. King Cobra3.0L, 3.0L H.O.4.3L, 4.3L H.O.5.0L, 5.0L H.O.
-722907229072290
-7229072290
-72290722907229072290722907229072290
STARTER SOLENOIDS
1987-19931990-19921988-19921988-19911988-19901987-19901987-19881986-1988
19881982-1987
19871987198719871987
5.8L5.7LE Cobra5.7L350 King Cobra460 King Cobra2.3L4.3L, 4.3L H.O.3.0L, 3.0L H.O.370 King Cobra2.5L, 3.0L, 3.8L, 4.3L, 5.0L, 5.7L335 Cobra340 King Cobra5.0L, 5.0L H.O.5.7L7.5L
722007220072200722007220072200722007220072200722107220072200722007220072200
1992-19941992-19941986-19941986-19941986-19941983-1994
1965-1994
1992-19931990-19931990-1992
5.0L, 5.0L H.O., 5.8 & EFI351 & EFI3.0L, 3.0L H.O. & PWS/PWR4.3L, 4.3L H.O.5.7LAll w/3-5/8 Starter Mounted -Short Type Delco SolenoidsAll w/4-1/4 Starter Mounted -Long Type Delco Solenoids502454, 454 H.O./OMC King Cobra5.7LE OMC Cobra
--
72460724607246072460
72490
704607246072460
723607236072460723607236072460724037240372360723607236072460
TRIM SOLENOIDS
1992-19931992-19931991-19931991-19931991-19931990-19931990-1993
19931993
1990-19921990-19921988-19911989-19901987-19901987-1990
1988-19891988-1989
351 King Cobra5023.0L, 3.0L H.O.4.3L5.0L, 5.0L H.O., 5.8454, 454 H.O. King Cobra4.3L H.O351 EF1 King Cobra5.0L, 5.8L EFI5.7L5.7LE OMC Cobra350 OMC King Cobra370, 460 CIVIC King Cobra2.3L3.OL, 3.OL H.O. -& PWS/PWR/PWC4.3L, 4.3L H.O.5.0L, 5.7L
723607236072360723607236072360723607236072360723607236072360723607244072440
7244072440
19881986-19871986-1987
198719871986
1975-19781975-19781974-19781973-19771965-19771974-19761972-19761974-1975
19741972-1973
370, 460 King Cobra4.3L (2V and 4V)5.0L, 5.7L (4V)335 Cobra, 340 King Cobra7.5L King Cobra2.5L, 3.0L175235190140120225165245170100
72440724037240372403724037240372410724107241072410724107241072410724107241072410
www.glmmarine.com 141
YearModel GLM No.
YearModel GLM No. YearModel GLM No.
YearModel GLM No. YearModel GLM No.
1989-19911989-19911988-19911989-19901987-19901986-1989
198819881987198719871986
5.0L, 5.0L H.O.5.8L350 OMC King Cobra460 King Cobra2.3L5.0L370 King Cobra460 King Cobra335 Cobra340 King Cobra7.5L2.5L
142
OM
C &
Volv
o E
ngin
eSection 18
OMC & VolvoEngine Gaskets
Rear Main Oil Seals
Section 18
Head Gaskets ............................................................................144
Intake Manifold Gaskets .............................................................145
Valve Cover Gaskets ..................................................................145
Lifter Side Cover Gaskets ...........................................................146
Oil Pan Gaskets .........................................................................146
Timing Chain Cover Gasket Kits ................................................146
Timing Chain Cover Gaskets .....................................................147
Crank Shaft Oil Seals .................................................................147
Distributor Gaskets .....................................................................147
Engine Gasket Kits .....................................................................148
143
Volvo 4-Cylinder
Ford V8
Chevy 4-Cylinder
Chevy Inline 6 Chevy V6 Buick V6
Chevy V8
OMC & VOLVO ENGINE
144
HEAD GASKETS
No. 36160OEM: 914971, 841207, 856474
Chevy305/350 CID engines
(5.0 & 5.7L)
No. 36110OEM: 914849
Chevy454 CID engines
(7.4L)
No. 36170OEM: 916221
Ford351 CID engines
(5.8L)
No. 36120OEM: 912766
Ford460 CID engines
(7.5L)
No. 36140OEM: 908237
Chevy250 CID engines
6-Cyl (4.1L)
No. 36100OEM: 3854299
Chevy262 CID engines
(4.3L)
No. 36190OEM: 985662
Buick231 CID engines
(1964-1972)
No. 36150OEM: 914812
Chevy181 CID engines
(3.0L)
No. 36130OEM: 311210
Chevy153 CID engines
(2.5L)
No. 36080OEM: 1378645
4-Cyl.AQ120B,125A,140A,BB140A
No.36090OEM: 1378646
4-Cyl.AQ145 Engine
OMC & VOLVO ENGINE
www.glmmarine.com 145
INTAKE MANIFOLD GASKETS
No. 39200 No. 30860No. 36280
Ford302 CID
5.0L
No. 39170with oval intake ports
ChevyV6
Chevy305/350 CID
5.0/5.7L(1997 &Below)
Ford351CID
5.8L
Chevy454 CID
7.4L
VALVE COVER GASKETSNo. 32210OEM: 3852693
No. 30340OEM: N/A
No. 30359OEM: 3854300
No. 30353OEM: 912965
No. 30357OEM: 3852687(1987 & Up)
No. 30470OEM: 3852818
No. 30350OEM: 3853513
GM153/181 CID
2.5/3.0L
GM250 CID
4.1L
GM262 CID
4.3L
GM305/350 CID
5.0/5.7(1986 & Below)
GM305/350 CID
5.0/5.7L(1987 & Up)
Ford302/351 CID
5.0/5.8L
GM454/502 CID
7.4/8.2
No. 32680OEM: 912471
Ford140 CID
2.3L
No. 33940OEM: 312737
BuickV6
(1964-72)
No. 33040OEM: 912768
Ford460 CID
7.5L
No. 30358OEM: 3854942 (1996 & Up)
GM4.3L w/ plastic
valve cover
No. 30351OEM: N/A
No. 30349OEM: 312737
ChevyV6
Chevy4-Cyl
(1996 & Up)
No. 30345OEM:27-824326002
4.3L(1996 & Up)
No. 30347OEM: 27-807473A1
5.0/5.7L(1996 & Up)
No. 33580OEM: 3853256
No. 31570OEM: 908079
Chevy4-Cyl, 181, 3.0L
(1968-82)
NEWNEWNEW
NEW
OIL PAN GASKETS
OMC & VOLVO ENGINE
146
LIFTER SIDE COVER GASKETS
No. 39460OEM: N/A
Chevy229 CID3.8L, V6
No. 39130OEM: N/A
GM250 CID, 4.1L
165 Inline 6-Cyl.
No. 39490OEM: N/A
GM454/502CID, 7.4L & 8.2L
Mark IV(1991 & Below)
No. 39160OEM: N/A
Ford302 CID
5.0L
Ford351CID
5.8L
GM 262,265,267,283,302,305,327,350 & 400 Small Block Engines
(1986 & Below)
No. 39500OEM: N/A
No. 39540OEM: N/AReplaces No. 39230 & 39260
GM305/350 CID
5.0/5.7L(1986 & Up)
No. 39850OEM: 3852664
Chevy262 CID4.3L, V6
No. 39840OEM: 3852655
Universal Type
No. 30370OEM: 3851981
TIMING CHAIN COVER GASKET KITSNo. 39710OEM: N/A
No. 39720OEM: N/A(1997& Below)
Chevy 305 & 350 CID
No. 39730OEM: N/A
No. 39740OEM: N/A(1991& Below)
Chevy 262 4.3L CID V6 Chevy 454 CID engines
Drain Plug - Oil Pan
Chevy 4-Cyl. & Inline 6
Mark IV
No. 30120OEM: N/A
No. 32640OEM: 3856443
140/150/160 /165
6-Cyl.
120/1404-Cyl.
w/ stamped cover
No. 30100OEM: 3852692
153 & 181 CIDPush Rod Cover
No. 39470OEM: 508886
GM153/181CID
2.5L &3.0L
Chevy4.3L, V6
No. 39860OEM: 3855801
NEW
OMC & VOLVO ENGINE
www.glmmarine.com 147
DISTRIBUTOR GASKETS
CRANK SHAFT OIL SEALS
No. 30440OEM: N/A
Chevy 454 CIDTiming Chain Cover
4 & 6-Cyl. ChevyTiming Chain Cover
No. 30460OEM: N/A
Ford V8Timing Chain Cover
TIMING CHAIN COVER GASKETS
(1991 & Below)
No. 30360OEM: 3852691
Chevy V6 & SB V8Timing Chain Cover
No. 30530OEM: N/A
(1997 & Below)
No. 85790OEM: 3852657
4.3/5.0/5.7LStandard Rotation
No. 85960OEM: 460571
No. 85490OEM: 473424
Two Piece(1985 & Below)
One Piece(1986 & Up)
7.4/8.2L
No. 85980OEM: 913746
Two Piece(1986 & Below)
Ford 351 CID
No. 30110OEM: 3852658
4 & 6-Cyl Chevy Oil PumpCover Gasket
No. 30490OEM: N/A
Oil Pump MountingGasket
No. 32030OEM: N/A
PrestoliteDistributor Cap
No. 31370OEM: 3852109
V6 & V8 ChevyDistributor Mounting
No. 32300OEM: N/A
4-Cyl.Distributor Mounting
No. 32040OEM: N/A
MalloryV8 Distributor Cap
No. 30354OEM: 3852656
V6, 305, 350Rear Main Seal
Retainer Cover Gasket
All Chevy
DISCONTINUED
No. 85780OEM: 3853341
One Piece(1996 & Below)
All Chevy
NEW
OMC & VOLVO ENGINE
148
ENGINE GASKET KITS
No. 39660TOP ENDGASKET KIT
No. 39680TOP ENDGASKET KIT
No. 39670TOP ENDGASKET KIT
No. 39690TOP ENDGASKET KIT
(1997 &Below)
No. 39830HEAD & INTAKE MANIFOLD GASKET KITOEM: 39830
Buick V6 3.8L/231 CID (1964-1972)
Ford 5.0L/302 CID engines Ford 5.8L/351 CID engines
Chevy 5.0L/305, 5.7L/350 CID engines All Chevy 250 CID 165 HP
Chevy 2.5L/153CI/110, 120HP (1965-1985) Chevy 3.0L/181CI/140HP (1973-1988)
No. 39810REBUILDGASKET KIT
No. 39820REBUILDGASKET KIT
149
Volv
o S
tern
driv
eSection 19
Volvo Penta AQ DriveSterndrives & Transom Assemblies
Up to 1993
Section 19
Upper Gear Housing Breakdown ....................................... 150-151
Lower Gear Housing Breakdown ....................................... 152-153
Intermediate Housing Breakdown ...................................... 154-155
Transom Assembly Breakdown .......................................... 156-157
Gear Housing Seal Kits .............................................................. 158
Intermediate Housing Parts ........................................................159
Tilt Bushings ...............................................................................159
U-Joints & Bellows .....................................................................160
Exhaust Bellows - External .........................................................160
Drive Cover ................................................................................160
Transom Assembly Parts ...........................................................160
VOLVO PENTA AQ DRIVE
150
UPPER HOUSING
1 23 4
6
13
14
9
8
1012
11
5
7
No. 87820
Seal Kit(AQ 280-290, AQSP, AQDP)
1615
No. 87760
Seal Kit(AQ 200-290, AQSP, AQDP)
No. 87730
U-Joint Seal Kit(without U-Joint)
1817
No. 87720
U-Joint Seal Kit(with U-Joint)
VOLVO PENTA AQ DRIVE
151
O-ring - Sealing Ring
Sealing Ring - 280, 290, SP, DP
Oil Seal - 280, 290, SP, DP
Oil Seal - 200, 250, 270
O-ring - Bearing Unit
O-ring - Dipstick
O-ring - Vent Screw
Gasket/Seal - Top Cover
O-ring - Shift Fork Housing
Oil Seal - Shift Shaft
U-Joint
U-Joint Bellows
Exhaust Bellows with Flappers
Exhaust Bellows without Flappers
Rear Cover
Rear Cover Lower Screw
Seal Kit (AQ 200-290, AQSP, AQDP)
Seal Kit (AQ 280-290, AQSP, AQDP)
U-Joint Seal Kit (with U-Joint)
U-Joint Seal Kit (without U-Joint)
GLM No.
45160
2303087030
8704045090
451204514087010
4508087050
280308903089010
8902023100
2323087760
878208772087730
Ref No. OEM No. Description
1
2
3
3
4
5
6
7
8
9
10
11
12
12
13
14
15
16
17
18
956000
832675
839253
942615
925256
955974
955989
832669
925093
958838
853255
875826
875828
875848
832570
941816
-
-
-
-
UPPER HOUSING
www.glmmarine.com
VOLVO PENTA AQ DRIVE
152
LOWER HOUSING
1
11
2
3
45
67
8
910
12
No. 87780
Seal Kit(For Single Prop)
1413
No. 87770
Seal Kit(For Dual Prop)
15No. 87830
Seal Kit(Prop Shaft Only-Single Prop)
16No. 87840
Seal Kit(Prop Shaft Only-Dual Prop)
www.glmmarine.com
VOLVO PENTA AQ DRIVE
153
O-ring - Lower Gear Housing to Intermediate Housing
Prop Shaft Seals
O-ring Prop Shaft Carrier
Zinc Anode AQ280SP, AQ290SP, Single Prop
Zinc Anode AQ250, AQ270, AQ275
Zinc Anode AQ280DP, AQ290DP, Dual Prop
Zinc Anode AQ200
Zinc Anode AQ120
Zinc Anode AQ100
Thrust Ring/Washer AQ280, AQ290 SP
Thrust Ring/Washer/Fishline Cutter AQ280, AQ290SP
Thrust Ring/Washer AQ250, AQ270, AQ275
Plastic Washer
Prop Lock Tab Washer
Prop Spacer Washer
Prop Cone Nut (Includes: No. 23240 Screw)
Screw - Prop Cone Nut
Trim Fin
Fill Screw O-ring
Seal Kit (For Dual Prop)
Seal Kit (For Single Prop)
Seal Kit (Prop Shaft Only - Single Prop)
Seal Kit (Prop Shaft Only - Dual Prop)
GLM No.
45090
8706045180
127871278412788
1278512781
127832315023151
2316023070
2306023050
230402324023110
4512087770
877808783087840
Ref No. OEM No. Description
1
2
3
4
4
4
4
4
4
5
5
5
6
7
8
9
10
11
12
13
14
15
16
925256
897426
925261
875815
875805
875821
875809
876286
875810
839423
872082
839534
850888
897367
851261
850785
850889
851452
955974
876268
876267
-
-
LOWER HOUSING
17
3
4
6
11
10
9
8
12
2
13
13
14
5
VOLVO PENTA AQ DRIVE
154
INTERMEDIATE HOUSING
No. 87710
Steer Stem Repair Kit(AQ 200-290)
15
16
No. 23010
Hose Connector Kit(AQ 200-290)
www.glmmarine.com
VOLVO PENTA AQ DRIVE
155
Water Outlet - AQ270T, AQ280T w/ Power Trim
Water Outlet - AQ200-AQ280 w/ Electric Tilt, AQ290 All
Water Outlet - Plastic DP, DPD, DPE, DPG, DPH, DPX
Gasket-Water Outlet
Tilt Bushings - All AQ Drives with Electric Tilt
Tilt Bushings - AQ270T, AQ280T with Power Trim
Tilt Bushings - All AQ290
Tilt Bushings - DP, DPD, DPE, DPG, DPH, DPX
O-ring - Intermediate Housing to Upper Housing - Large
O-ring - Intermediate Housing to Upper Housing - Small
Pipe - Water AQ270, AQ280, AQ290
Swivel Bushing - Water Pipe AQ250, AQ270, AQ280
Plastic Washer
Spring Reverse Lock
Spring Reverse Lock
Spring Reverse Lock
Spring Kit Includes: No. 23171, 23172, 23173
Shaft Reverse Lock
Seal
O-ring
Steer Stem Repair Kit
Hose Connector Kit (with Gasket)
2301023011
2301323020
230902309123092
2309345100
450102305523130
2318023172
2317123173
231702317487070
4511087710
23010
1
1
1
2
3
3
3
3
4
5
6
7
8
9
10
11
12
13
14
15
16
851452
854031
872752
814356
876278
832820
876279
876507
925259
125017
814386
814388
814390
832534
814332
814396
814419
181620
941820
-
832846 + 814356
GLM No. Ref No. OEM No. Description
INTERMEDIATE HOUSING
VOLVO PENTA AQ DRIVE
156
TRANSOM ASSEMBLY
1
2
3
4
5
5 7
6
3
89
9
9
www.glmmarine.com
VOLVO PENTA AQ DRIVE
157
Transom Mount Seal
O-ring
Clamp
Exhaust Bellow Kit with Flapper (comes with Clamps)
Exhaust Bellow Kit without Flapper (comes with Clamps)
Oil Seal
Bearing
Bearing
Lock Ring
Snap Ring
8671345180
010808901089020
8702021842
218432177721778
1
2
3
4
4
5
6
7
8
9
852868
925260
872531
850004, 875828
875380, 875828
958860-9
181105
11013
914462
914533
GLM No. Ref No. OEM No. Description
TRANSOM ASSEMBLY
VOLVO PENTA AQ DRIVE
158
LOWER GEAR HOUSING SEAL KITSNo. 87780OEM: 876268
Single PropAQ 200-AQ 290, AQSP
NEWNo. 87770OEM: 876267
Dual PropAQ 280DP, 290DP, AQDP
No. 87830OEM: N/A
Prop Shaft Only - Single PropAQ 200-AQ 290, AQSP
No. 87840OEM: N/A
Prop Shaft Only - Dual PropAQ 280DP, 290DP, AQDP
NEW
UPPER GEAR HOUSING SEAL KITSNo. 87820OEM: N/A
AQ 280-290, AQSP, AQDP
No. 87760OEM: 876266
AQ 200-290, AQSP, AQDP
No. 87790OEM: 875741
Includes:8776087770
COMPLETE UPPER & LOWER GEAR HOUSING SEAL KITSNo. 87700OEM: 875192
Includes:8776087780
Single Prop Dual Prop
www.glmmarine.com
VOLVO PENTA AQ DRIVE
159
INTERMEDIATE HOUSINGNo. 87710STEER STEM REPAIR KITOEM: N/A
Kit contains: GLM OEM Item 45010 125017 O-Ring 87070 181620 Seal 23020 814356 Gasket 23130 814388 Plastic Bushing 23180 814390 Plastic Washer 23090 826341 Plastic Bushing 23010 823846 Hose Connector 45090 925256 O-Ring 45110 941820 O-Ring
Fits 200 thru 290
No. 23055PIPE - WATEROEM: 814386
Electric Tilt250, 270, 275, 280
No. 23130SWIVEL BUSHING - FOR PIPEOEM: 814388
No. 23010HOSE CONNECTOROEM: 832846, 851452
No. 23020RUBBER GASKETOEM: 814356
No. 23011HOSE CONNECTOROEM: 854031
No. 23013HOSE CONNECTOR - PLASTICOEM: 872752
DP, DPD, DPE, DPG, DPH, DPX
No. 23092TILT BUSHINGSOEM: 853223
Power TrimDPE, DPX-S1, DPX,
DP-C1, DP-D1
No. 23093TILT BUSHINGSOEM: 872096
NEW NEW
All with Electric Tilt
No. 23090TILT BUSHINGSOEM: 826341, 876278
TILT BUSHINGS
No. 23080SETTING PINOEM: 814301
AQ290, A, DP, SP-A,SP-A1, SP-A2, DP-A,DP-A1, DP-A2, DP-B1
No. 23174SHAFT - REVERSE LOCKOEM: 814419, 814499
No. 23170SPRING KIT -REVERSE LOCKOEM: N/A
No. 23171SPRINGOEM: 814332
No. 23172SPRINGOEM: 832534
No. 23173SPRINGOEM: 814396
Power TrimAQ 290, SP, DP
200 thru 290
AQ 200-290 AQ 200-290
No. 23091TILT BUSHINGSOEM: 832820
Power TrimAQ270T, 280T
No. 23180PLASTIC WASHEROEM: 814390
Intermediate Housing
No. 35010OEM: 853936
Tilt Motor Gasket
No. 23190NYLONOEM: 941855
Comeswith
gasket
No. 87011OEM: 814168
VOLVO PENTA AQ DRIVE
160
TOP COVER GASKETS
No. 23100AQ DRIVE COVEROEM: 832570
No. 89020EXHAUST BELLOW KITOEM: 875380, 875848
Without Flapper
No. 89010EXHAUST BELLOW KITOEM: 850004, 875828
With Flapper
No. 89030UNIVERSAL JOINTBELLOW KITOEM: 875826
No. 23230SCREWOEM: 941816
AQ 270-290, AQ SP, AQ DP
No. 87720U-JOINT SEAL KIT (WITH U-JOINT)OEM: N/A
Kit contains: GLM OEM Item 45010 125017 O-Ring 23030 832675 Seal Washer 28020 853255 U-Joint (2) 87030 853670 Seal 45090 925256 O-Ring (2) 45100 925259 O-Ring 45120 955974 O-Ring 45160 956000 O-Ring
No. 87730U-JOINT SEAL KIT (WITHOUT U-JOINT)OEM: N/A
Kit contains: GLM OEM Item 45010 125017 O-Ring 23030 832675 Seal Washer 87030 853670 Seal 45090 925256 O-Ring 45100 925259 O-Ring 45120 955974 O-Ring 45160 956000 O-Ring
AQ 270-290, AQ SP, AQ DP
No. 23030SEAL WASHEROEM: 832675
No. 28020UNIVERSALJOINTOEM: 853455
No. 87030SEALOEM: 853670
AQ 270-290, AQ SP, AQ DP For Flywheel Housing
TRANSOM MOUNT SEALNo. 86713TRANSOMMOUNT SEALOEM: 852868
AQ 290, A, DP, SP-A, SP-A1, SP-A2, SP-C, SP-C1, DP-A1, DP-A2, DP-B, DP-B1, DP-C, DP-C1, DP-D, DP-D1, DPX
No. 87010OEM: 832669
No. 87020SEALOEM: 958860-9
For Flywheel Housing
161
Volv
o S
tern
driv
eSection 20
VolvoSeawater Pumps
Section 20
VOLVO
162
Gasoline Engines
SEAWATER PUMPS
Diesel Engines
WATER PUMP DRIVESNo. 12850OEM: 831009, 806256
No. 12851OEM: 829433
No. 12852OEM: 858467
AQ120, 120B, 125, 130, 131, 140A, 145, 151,165, 170, 171, 230A, 250A, 251AMD3B, 17C, D; MD 21A, MD 21B
MD 30A, MD 40APumps with 6 screws on cover MD 31, MD 41
No. 89610OEM: 835512, 3854286
AQ 200A,B,C, 225A,B,C, 255A
No. 89620OEM: N/AIncludes: 89610
No. 89611OEM: 835874
AQ 190A, AQ 240A
No. 89510OEM: 875807Jabsco 863-0001Johnson 09-806B
MD
No. 89513OEM: 875583
MD 5A,B,C, MD 6B, MD 7A,B, MD 11C,D2001, 2002, 2003
No. 89550OEM: 875593Jabsco 920-0001Johnson 09-1028B
AQ 30, 31 - AQD 32 - AQ 40, 41, KAMD 42A,B, KAD42A,B,TAMD70B,C,D,E, THAMD70B,C, AQD70B,C,D, KAD43, 44, 300
No. 89560OEM: 875660Jabsco 836-0001Johnson 09-1029B
AQAD 40A,B, TAMD61A, 62A - TAMD 40A,B, TAMD 71A,B - TAMD100A, TAMD120A, TAMD72A, TAMD122 - MD100A,B, MD120,A
No. 89540OEM: 8758113862281, 3862567Jabsco 1210-0001Johnson 09-1027B
AQ 150A,B, 175A, 200C,D,F,211A, 225C,D,F, 231A, 255A,B, 260A,
271A,C, 290A, 311A,B, 430A,B, 431A,B,500A,B, 501A,B, 570A, 571A, 572A
No. 89530OEM: 875575Jabsco4568-0001Johnson09-801B
AQ 120B, 125, 131, 140, 145, 151,165, 170, 171, 230A, 250A, 251A
No. 89621OEM: N/AIncludes: 89611
No. 89520OEM: 875808Jabsco673-0001Johnson09-1026B
AQ 100, 110, 115, 120A, 130
163
Volv
o S
tern
driv
eSection 21
VolvoAnodes & Prop Hardware
Section 21
VOLVO
164
ANODES
No. 12781OEM: 876286
AQ120S, 120SB
No. 12783OEM: 875810
No. 12788OEM: 875821
AQ280DP, 290DP
No. 12787OEM: 875815
AQ280, 280T, 280PT, 290, 290A
No. 12786OEM: 875812
AQ110S
No. 12785OEM: 875809
AQ200
No. 12784OEM: 875805
AQ250, 270, 270T, 275 AQ100, 100B, 100S
No. 12780OEM: 832598
AQ200, 250, 270,275, 280, 280DPAQ290, 290DP
No. 12782OEM: 852835
No. 12789OEM: 838929
Diesel Engine, MD19,21, 27, 29, 32, AQ30,
31, 40, 41
No. 12777ZINC ANODEOEM: 3855411
Cobra SX, DP-S/SI
No. 12699ZINC ANODEOEM: 3854130
No. 12778OEM: 872793
290, 290DP, DP-X
No. 12681ZINC ANODEOEM: 3852970
No. 12899ANODE KIT
AQ290DP
No. 12898ANODE KIT
AQ280DP
No. 12896ANODE KIT
AQ280, 280T, 280PT
No. 12897ANODE KIT
AQ290, 290A
No. 12895ANODE KIT
AQ250, 270, 270T, 275
No. 12894ANODE KIT
AQ200
Cobra SX Cobra SX
No. 12933ANODE KITOEM: N/A
DPH-DPR
No. 12973OEM: 3588748
No. 12972OEM: 3588770
DPH-DPR DPH-DPR
No. 12938ANODE KITOEM: N/A
SXA-DPSA
No. 12976OEM: 3888813
No. 12975OEM: 3888816
SXA-DPSA SXA-DPSA
No. 12854OEM: 873395
DPX
VOLVO
www.glmmarine.com 165
PROP NUTS & WASHERS - VOLVO SX COBRA
PROP NUTS & WASHERS - VOLVO PENTA AQ
No. 23120PROP SERVICE KIT
No. 23240SCREWOEM: 850889
No. 23040PROP CONEOEM: 854045
No. 23050SPACER WASHEROEM: 854047
No. 23060PROP LOCKTAB WASHEROEM: 897367
No. 23070PLASTIC WASHEROEM: 850888
with No. 23240 Screw
No. 23150THRUST RINGOEM: 839423
No. 23160THRUST RINGOEM: 839534
No. 23152THRUST RINGOEM: 3858457
No. 23153THRUST RINGOEM: 3858458
No. 23151THRUST RINGOEM: 872082
280-290 SP SP Fishing Line Cutter 250, 270, 275 DP DP
No. 22142COTTER PINOEM: 3852056
No. 22185PROP NUT,KEEPER & PINOEM: 398042
No. 222219/16 THICKTHRUST WASHEROEM: 3852020
No. 22188KIT WITHOUTTHRUST WASHEROEM: N/A(No. 22252 + 22185)
No. 2225219 SPLINE WASHEROEM: 3852350
No. 22189PROP WASHER KITOEM: N/A(No. 22188 + 22221)
Prop Service Kits
Comeswith pinNo. 22142
Part No.Kit No. No. 23121
PROP SERVICE KITNo. 23123
PROP SERVICE KITNo. 23124
PROP SERVICE KIT
No. 23070PLASTIC WASHER
No. 23060TAB WASHER
No. 23050SPACER WASHER
No. 23040PROP CONE
No. 23240SCREW
No. 23122PROP SERVICE KIT
OMC
166
OIL SEALS
Table By OEM NumbersGLM No. OEM No. Shaft Size Bore Size GLM No. OEM No. Shaft Size Bore Size
Table By Shaft Size
86510 324639 0.4375 0.937586750 326716 0.7500 1.375086450 327031 0.4375 0.875086240 329922 0.8750 1.375086250 329923 0.8750 1.375086030 330137 1.1250 1.625086270 330327 0.6250 1.125086790 331103 1.1250 1.625086460 332205 0.7500 1.125086520 332261 0.6250 1.375086470 332942 1.6250 2.062586810 334950 1.2500 1.687586440 339620 1.6250 2.125086011 341280 0.8750 1.375086012 314281 1.2500 1.687586590 908855 0.6250 1.000086070 911019 1.0000 2.500086530 911685 2.0000 2.500086550 911788 1.0000 1.375086010 981195 1.5000 2.125086080 981196 1.7500 2.500086090 981268 1.6250 2.500087100 3852272 45MM 75MM86610 3853655 0.5000 0.906287110 3853858 25MM 35MM86260 3858303 1.2500 1.7500
86350 302564 0.7813 1.375086360 303345 0.5625 1.000086380 305987 1.0000 1.375086370 309989 1.3750 2.000085110 310599 1.0000 1.500086040 310649 2.5000 3.000086390 313282 0.5540 1.062586740 313283 0.8125 1.312586410 313284 0.6250 1.125086050 313353 1.9375 2.437585010 313392 1.1875 1.875086400 314167 0.4219 0.937586120 318972 0.5000 0.875085130 320862 1.1875 1.687585120 321453 0.8750 1.250086150 321459 0.6250 1.125086160 321466 0.7500 1.125086060 321467 1.0000 1.375086170 321480 0.5000 1.250086180 321481 0.6875 1.250086420 321786 0.6250 1.125086190 321787 0.6250 1.125086430 321788 0.5000 1.000086760 321831 0.7500 1.250086770 321895 1.6250 1.921986200 321928 0.6250 1.3750
86400 314167 0.4219 0.937586450 327031 0.4375 0.875086510 324639 0.4375 0.937586120 318972 0.5000 0.875086170 321480 0.5000 1.250086430 321788 0.5000 1.000086610 3853655 0.5000 0.906286390 313282 0.5540 1.062586360 303345 0.5625 1.000086410 313284 0.6250 1.125086150 321459 0.6250 1.125086190 321787 0.6250 1.125086200 321928 0.6250 1.375086270 330327 0.6250 1.125086420 321786 0.6250 1.125086520 332261 0.6250 1.375086590 908855 0.6250 1.000086180 321481 0.6875 1.250086160 321466 0.7500 1.125086460 332205 0.7500 1.125086750 326716 0.7500 1.375086760 321831 0.7500 1.250086350 302564 0.7813 1.375086740 313283 0.8125 1.312585120 321453 0.8750 1.250086011 341280 0.8750 1.375086240 329922 0.8750 1.3750
86250 329923 0.8750 1.375087110 3853858 25mm 35mm85110 310599 1.0000 1.500086060 321467 1.0000 1.375086070 911019 1.0000 2.500086380 305987 1.0000 1.375086550 911788 1.0000 1.375086030 330137 1.1250 1.625086790 331103 1.1250 1.625085010 313392 1.1875 1.875085130 320862 1.1875 1.687586012 314281 1.2500 1.687586810 334950 1.2500 1.687586260 385830 1.2500 1.750086370 309989 1.3750 2.000086010 981195 1.5000 2.125086090 981268 1.6250 2.500086440 339620 1.6250 2.125086470 332942 1.6250 2.062586770 321895 1.6250 1.921986080 981196 1.7500 2.500087100 3852272 45mm 75mm86050 313353 1.9375 2.437586530 911685 2.0000 2.500086040 310649 2.5000 3.0000
OMC
www.glmmarine.com 167
OIL SEAL APPLICATONSModel Years GLM No. Application Qty.
Cobra Transom Mount
Cobra Upper Gearcase
Cobra Lower Gearcase
Stringer Mount Upper Gearcase
Model Years GLM No. Application Qty.
262 - 460 1988-1990 86560 Driveshaft 1
350 - 460 1988 86550 Pivot Shaft 2
2.3L - 7.5L 1986-1988 86550 Pivot Shaft 2
2.3L - 7.5L 1986-1990 86550 Driveshaft 1
262 - 460 1988-1989 86530 Brg. Carrier 1
262 - 460 1988-1990 86610 Pump Shaft 1
2.3L - 7.5L 1986-1990 86610 Pump Shaft 1
2.3L-7.5L (A) 1986-1990 86530 Brg. Carrier 1
(A) 5,7L 1990 574 AMPWS, ARPWS
262 - 460 1988-1989 85130 Prop Shaft 2
2.3L 1990 86030 Prop Shaft 2
2.3L - 3.0L 1986-1989 86030 Prop Shaft 2
3.0L 1990 85130 Prop Shaft 2
4.3L - 7.5L 1986-1990 85130 Prop Shaft 2
80 - 245 1968-1972 86090 Ball Gear 1
80 - 260 1969-1981 86090 Impeller Hsg 2
88 - 200 1964-1966 86370 Ball Gear 1
90 (C) 1967 86370 Ball Gear 1
90 (D) 1967 86090 Ball Gear 1
100 - 245 1972-1973 86090 Ball Gear 1
100 - 260 1973-1981 86080 Ball Gear 2
120 (A) 1967 86090 Ball Gear 1
120 (B) 1967 86370 Ball Gear 1
120 (A) 1967 86090 Impeller Hsg 2
120 - 210 1968 86090 Impeller Hsg 2
155 1967 86090 Impeller Hsg 2
155 (E) 1967 86370 Ball Gear 1
155 1967 86090 Ball Gear 1
185 1967 86370 Ball Gear 1
200 (F) 1967 86370 Ball Gear 1
200 (G) 1967 86090 Impeller Hsg 2
200 (G) 1967 86090 Ball Gear 1
2.5L - 5.7L 1981-1986 86080 Ball Gear 2
2.5L - 5.7L 1981-1986 86090 Impeller Hsg 2
(A) CU,CUE 16C Models (E) HU,HUE 15S Models
(B) CU 15S Models (F) TU,TUE 15S Models
(C) DU, DUE 14D Models (G) TU,TUE 16C Models
(D) DU,DUE 15S Models
80 / 90 1968-1971 86070 Brg. Ret.-Lower 2
80 / 90 1968-1971 86070 Prop shaft 2
88 / 90 1964-1968 85110 Brg. Retainer 1
80-260 1968-1981 86040 Brg Ret.-Upper 1
80-260 1968-1981 86050 Brg. Ret.-Middle 2
110-200 (A) 1964-1967 85110 Brg. Retainer 2
11 0-245 (A) 1964-1977 85110 Prop Shaft 2
Stringer Mount Lower Gearcase
110/120 (B) 1964-1967 85110 Brg. Retainer 1
120-245 1968-1977 85110 Brg. Ret-Lower 2
120-260 1978-1981 86060 Brg. Ret-Lower 2
120/140 1978-1981 86030 Prop Shaft 2
155 (C) 1967 86050 Brg. Ret.-Middle 2
155 (C) 1967 86040 Brg. Ret.-Upper 1
185-260 1978-1981 85130 Prop Shaft 2
210-260 (D) 1972-1975 86070 Impeller Hsg. 1
230/260 (D) 1976 86060 Impeller Hsg. 1
305/350/454 (D) 1977-1978 86060 Impeller Hsg. 1
2.5L/3.0L 1982-1986 86030 Prop Shaft 2
2.5L-5.7L 1981-1986 86040 Brg. Ret.-Upper 1
2.5L-5.7L 1981-1986 86050 Brg. Ret.-Middle 2
2.5L-5.7L 1981-1986 86060 Brg. Ret.-Lower 2
3.8L-5.7L 1981-1986 85130 Prop Shaft 2
(A) 110,120 HP (1964-67) Heavy Duty Drive (B) Standard Drive
(C) HU, HUE 16 C Models (D) Inboard Engines
Stringer Mount Lower Gearcase Cont...
Stringer Mount Intermediate Housing80-235 1964-1971 86370 Ball Gear-Outer 1
80-245 1964-1972 86030 Ball Gear-Inner 1
80-260 (B) 1964-1980 86070 Clutch 1
100-245 1972 86370 Ball Gear-Outer 2
100-260 1973-1979 85010 Ball Gear-Inner 1
100-260 1973-1981 86010 Ball Gear-Outer 2
120-260 1980-1981 85010 Ball Gear-Inner 2
120-260 (A) 1980-1981 86060 Clutch 2
2.5L-5.7L 1981-1986 86060 Clutch 2
2.5L-5.7L 1981-1986 85010 Ball Gear-Inner 2
(A) 120, 140 1980C Models 185-260 1980 K & U Models.
(B) C Models IN 1980.
Notes:
O-RINGS
OMC
168
Table By OEM Numbers
GLM OEM I.D. O.D. W. GLM OEM I.D. O.D. W. GLM OEM I.D. O.D. W.
Table By Nominal Size
80120 202893 3/8 1/2 1/1681070 310824 7/32 13/32 3/3245230 301877 31/128 73/128 21/12881170 301967 13/16 1 3/3282260 302337 2 2-1/4 1/882170 302493 1-3/16 1-7/16 1/881260 302537 1-3/8 1-9/16 3/3282140 302540 1 1-1/4 1/882240 302588 1-3/4 2 1/881100 303067 3/8 9/16 3/3280110 303191 5/16 7/16 1/1681110 303347 7/16 5/8 3/3282150 303360 1-1/16 1-5/16 1/880140 304174 1/2 5/8 1/1682400 305123 3-3/4 4 1/882080 305146 5/8 7/8 1/882030 305242 5/16 9/16 1/882230 305270 1-5/8 1-7/8 1/880100 305739 1/4 3/8 1/1682310 307082 2-5/8 2-7/8 1/880130 307450 7/16 9/16 1/1680090 307853 7/32 11/32 1/1682350 308621 3-1/8 3-3/8 1/881290 308458 1-9/16 1-3/4 3/3281190 308624 15/16 1-1/8 3/3281270 308626 1-7/16 1-5/8 3/3282280 308627 2-1/4 2-1/2 1/881400 308876 2-1/4 2-7/16 3/32
81230 309731 1-3/16 1-3/8 3/3282250 310327 1-7/8 2-1/8 1/882390 310414 3-5/8 3-7/8 1/882100 310584 3/4 1 1/881160 310585 3/4 15/16 3/3281160 310967 3/4 15/16 3/3280180 311338 3/4 7/8 1/1682480 313175 4-3/4 5 1/881310 313340 1-11/16 1-7/8 3/3282370 313446 3-3/8 3-5/8 1/881340 313754 1-7/8 2-1/16 3/3280220 314491 1 1-1/8 1/1681380 314728 2-1/8 2-5/16 3/3280100 317178 1/4 3/8 1/1645200 318372 8mm 16mm 4mm83250 318717 1-1/2 1-7/8 3/1683200 319085 1-1/8 1-1/12 3/1681330 319662 1-13/16 2 3/3282130 320140 15/16 1-3/16 1/882320 320303 2-3/4 3 1/880080 321117 3/16 5/16 1/1681250 322501 1-5/16 1-1/2 3/3280090 322598 7/32 11/32 1/1681140 326649 5/8 13/16 3/3282460 326741 4-1/2 4-3/4 1/882440 326849 4-1/4 4-1/2 1/845230 326956 31/128 73/128 21/12881140 329380 5/8 13/16 3/32
81100 329381 3/8 9/16 3/3280100 332583 1/4 3/8 1/1680100 332584 1/4 3/8 1/1681080 333572 1/4 7/16 3/3281450 338518 2-9/16 2-3/4 3/3281300 338522 1-5/8 1-13/16 3/3281120 339543 1/2 11/16 3/3282360 553126 3-1/4 3-1/2 1/881220 554545 1-1/8 1-5/16 3/3281550 908194 4 4-3/16 3/3281440 908383 2-1/2 2-11/16 3/3281140 909047 5/8 13/16 3/3241120 909048 1/2 11/16 3/3242140 909139 1 1-1/4 1/880230 909140 1-1/16 1-3/16 1/1681280 909316 1-1/2 1-11/16 3/3281090 909747 5/16 1/2 3/3282520 910238 5-1/4 5-1/2 1/882250 910582 1-7/8 2-1/8 1/880100 911311 1/4 3/8 1/1682380 911686 3-1/2 3-3/4 1/882430 911700 4-1/8 4-3/8 1/881210 911718 1-1/16 1-1/4 3/3281230 911871 1-3/16 1-3/8 3/3245080 925093 70mm 76mm 3mm81180 3852565 7/8 1-1/6 3/32
80080 321117 3/16 5/16 1/1680090 307853 7/32 11/32 1/1680090 322598 7/32 11/32 1/1680100 305739 1/4 3/8 1/1680100 317178 1/4 3/8 1/1680100 332583 1/4 3/8 1/1680100 332584 1/4 3/8 1/1680100 911311 1/4 3/8 1/1680110 303191 5/16 7/16 1/1680120 202893 3/8 1/2 1/1680130 307450 7/16 9/16 1/1680140 304174 1/2 5/8 1/1680180 311338 3/4 7/8 1/1680220 314491 1 1-1/8 1/1680230 909140 1-1/16 1-3/16 1/1641120 909048 1/2 11/16 3/3280170 301824 7/32 13/32 3/3281080 333572 1/4 7/16 3/3281090 909747 5/16 1/2 3/3281100 303067 3/8 9/16 3/3281100 329381 3/8 9/16 3/3281110 303347 7/16 5/8 3/3281120 339543 1/2 11/16 3/3281140 326649 5/8 13/16 3/3281140 329380 5/8 13/16 3/3281140 909047 5/8 13/16 3/3281160 310585 3/4 15/16 3/3281160 310967 3/4 15/16 3/32
81170 301967 13/16 1 3/3281180 3852565 7/8 1-1/16 3/3281190 308624 15/16 1-1/8 3/3281210 911718 1-1/16 1-1/4 3/3281220 554545 1-1/8 1-5/16 3/3281230 309731 1-3/16 1-3/8 3/3281230 911871 1-3/16 1-3/8 3/3281250 322501 1-5/16 1-1/2 3/3281260 302537 1-3/8 1-9/16 3/3281270 308626 1-7/16 1-5/8 3/3281280 909316 1-1/2 1-11/16 3/3281290 308458 1-9/16 1-3/4 3/3281300 338522 1-5/8 1-13/16 3/3281310 313340 1-11/16 1-7/8 3/3281330 319662 1-13/16 2 3/3281340 313754 1-7/8 2-1/16 3/3281380 314728 2-1/8 2-5/16 3/3281400 308876 2-1/4 2-7/16 3/3281440 908383 2-1/2 2-11/16 3/3281450 338518 2-9/16 2-3/4 3/3281550 908194 4 4-3/16 3/3242140 909139 1 1-1/4 1/882030 305242 5/16 9/16 1/882080 305146 5/8 7/8 1/882100 310584 3/4 1 1/882130 320140 15/16 1-3/16 1/882140 302540 1 1-1/4 1/882150 303360 1-1/16 1-5/16 1/8
82170 302493 1-3/16 1-7/16 1/882230 305270 1-5/8 1-7/8 1/882240 302588 1-3/4 2 1/882250 310327 1-7/8 2-1/8 1/882250 910582 1-7/8 2-1/8 1/882260 302337 2 2-1/4 1/882280 308627 2-1/4 2-1/2 1/883210 307082 2-5/8 2-7/8 1/882320 320303 2-3/4 3 1/882350 308621 3-1/8 3-3/8 1/882360 553126 3-1/4 3-1/2 1/882370 313446 3-3/8 3-5/8 1/882380 911686 3-1/2 3-3/4 1/882390 310414 3-5/8 3-7/8 1/882400 305123 3-3/4 4 1/882430 911700 4-1/8 4-3/8 1/882440 326849 4-1/4 4-1/2 1/882460 326741 4-1/2 4-3/4 1/882480 313175 4-3/4 5 1/882520 910238 5-1/4 5-1/2 1/845230 301877 31/128 73/128 21/12845230 326956 31/128 73/128 21/12883200 319085 1-1/8 1-1/2 3/1683250 318717 1-1/2 1-7/8 3/1645080 925093 70mm 76mm 3mm45200 318372 8mm 16mm 4mm
15100
13441 71830 15100 51340 51450
89540 13441 71830 15100 51340 51450
89540 13441 71830 15100 51340 51450
89540 13441 71830 15100 51340 51450
VOLVO PENTA - QUICK REFERENCE / DRIVE SIDE
www.glmmarine.com 169
Volvo Penta
Models ImpellerKit
CompleteTune-Up Kit
RecirculatingWater Pump
ExhaustElbow
ExhaustManifold
3.0GL MMDA3.0GS PMDA
ThermostatKit
89540 13440 71830 15100 51340 51450
3.0GS MHUB / MNCA3.0GS PHUB / PNCA
3.0GS MLKD / MBYMCE3.0GS PLKD / PBYMCE
89540 13440 71830 15100 51340 51450
89540 13441 71830 15100 51340 51450
3.0GS MWTR / MWTS3.0GS PWTR / PWTS
3.0GS MEFS / PFES
89540 13441 71830 15100 51340 51450
3.0GSM-A / B / C3.0GSP-A / B / C
3.0GLM-A / B / C3.0GLP-A / B / C
3.0GLP-D / E3.0GLP-J / N
89310
1308089310
3.0GXi-J3.0GXiC-J - - -
430A431A -
13381 71750 15201 51520 51640
170
Volvo PentaVOLVO PENTA - QUICK REFERENCE / DRIVE SIDE
Models ImpellerKit
CompleteTune-Up Kit
RecirculatingWater Pump
ExhaustElbow
ExhaustManifold
ThermostatKit
13381 71750 15201 51520 51640
430B431B
432A434A
89540
-
13431 71820 15201 51330 51480
13025
13045
89310 13025
4.3GLP HUB4.3GSP HUB4.3GSP HUS
4.3GL PNCA / PNCM4.3GL PNCS / PNCB4.3GS PNCA / PNCM4.3GS PNCS / PNCB4.3Gi PNCA / PNCM4.3Gi PNCS/ PNCB
4.3GL-EF
4.3GL-G4.3GL-GF
13381 71820 15201 51520 51640
89540
4.3GLM MDA4.3GLP MDA4.3GSP MDA
89540 13431 71820 15201 51330 51480
89540 13431 71820 15201 51330 51480
4.3GL PLK / PBY4.3GS PLK / PBY4.3Gi PLK / PBY
89540 13431 71820 15201 51330 51480
4.3GL PWT / PEF4.3GLP-A4.3GS PWT4.3Gi PWT / PEF
89540 13431 71820 15201 51330 51480
4.3GLP-B / C / D4.3GL-E
89540 71820 15201 51330 51480
89540 71820 15201 51330 51480
71820 15201 51330 51480
13045
89540 13431 15201 51330 51480
www.glmmarine.com 171
Volvo PentaVOLVO PENTA - QUICK REFERENCE / DRIVE SIDE
Models ImpellerKit
CompleteTune-Up Kit
RecirculatingWater Pump
ExhaustElbow
ExhaustManifold
ThermostatKit
89310 13025 71820
-
51336
-4.3GL-J
4.3GL-JF4.3GL-J1)
89310 13045 71820
-
51336
-
89540 13431 71820 15201 51330 51480
71890
13045
13025
89310 13045 71890
4.3GXi-A
4.3GX1-B4.30Si-B
4.3GXi-BF / CF4.3GXi-DF / EF4.3OSi-BF / CF4.3OSi-DF / EF
4.3GXi-C / D / E4.3OSi-C / D / E
4.3GXi-JF4.3GXi-J1)4.3OSi-JF4.3GXiE-M1)
89540 15201 5133071890 51480
89540 15201 5133071890 51480
4.3GXi-F / G4.3OSi-F / G
13025 15201 5133071890 5148089310
15201 5133071890 5148089310
4.3GXi-FF / GF4.3OSi-FF / GF
4.3GXi-J4.3OSi-J4.3GXiE-M
89310 13025 71890
-
51336
-
- -
51336
89310 71880 15201 51330 51430
51330 514301520189540
13431 51330 514301520189540
13431 51330 5143071730 1520189540
172
Volvo PentaVOLVO PENTA - QUICK REFERENCE / DRIVE SIDE
Models ImpellerKit
CompleteTune-Up Kit
RecirculatingWater Pump
ExhaustElbow
ExhaustManifold
ThermostatKit
13381 71730 15201 51510 51630
500B501B570A572A
89540
13431 51330 51430
5.0GL-A5.0GL PEF5.0GL PWT5.0GL PBY
5.7GS PLK5.7GS PBY5.7GS PWT5.7GS PEF
71880
5.0GL-B5.7GL-B
13025 71880
5.0GL-C / D / E5.7GL-C / D / E
13025 71880 15201 51330 51430
5.0GL-F5.0GL-G
89310
13045
5.0GL-FF5.0GL-GF
13025 51338
5.0GL-J
13045 51338
5.0GL-JF5.0GL-J1)
71730 1520189540
5.7GL-A5.7GL PMDA5.7GL PNCS5.7GL PLK
13431 51330 5143071730 1520189540
89310 15201 5143071880
71880 15201 5143089310
71900 15201 51330 51430
71900 15201 51330 51430
71900 15201 51330 5143089540
71900 15201 51330 5143089540
13431 71880 15201 51330 5143089540
www.glmmarine.com 173
Volvo PentaVOLVO PENTA - QUICK REFERENCE / DRIVE SIDE
Models ImpellerKit
CompleteTune-Up Kit
RecirculatingWater Pump
ExhaustElbow
ExhaustManifold
ThermostatKit
13431 71880 15201 51330 514305.7Gi PHUS5.7Gi PMDA5.7Gi PNCA5.7Gi PNCB5.7Gi PNCM5.7Gi PNCS
89540
5.0Gi5.0Gi PBY5.0GXi-A5.7Gi-A5.7Gi PLK5.7GLi PLK
5.7GSi PLK5.7GSi PBY5.7GSi PWTR5.7GSi PEFS5.7GXi-A / B
71900
5.0GXi-B5.0OSi-B5.7Gi-B5.7OSi-A5.7GXi-C5.7OSXi-A
5.0GXi-BF5.0OSi-BF5.7Gi-BF5.7OSi-AF5.7GXi-CF5.7OSXi-AF
13025 71900 15201 51330 51430
5.0GXi-C / D5.0OSi-C / D5.7Gi-C / D5.7OSi-B / C5.7GXi-D / E5.7OSXi-B / C 895405.0GXi-CF / DF5.0OSi-CF / DF5.7Gi-CF / DF5.7OSi-BF / CF5.7GXi-DF / EF5.7OSXi-BF / CF
13025
5.0GXi-E5.0OSi-E5.7Gi-E5.7OSi-D5.7GXi-F5.7OSXi-D
13045
5.0GXi-EF5.0OSi-EF5.7Gi-EF5.7OSi-DF5.7GXi-FF5.7OSXi-DF
13025
5.0GXi-F / G5.0OSi -F / G5.7Gi-F / G5.7OSi-E / G5.7GXi-G / H5.7OSXi -E / G 89310
13431 71880 15201 51330 5143089540
13431 15201 51330 5143089540
7190013045 15201 51330 5143089540
13045
89540
-
51490
-
13431
71730 51330 51490
-
1343189540
13431 71730 51330 51490
15201 5143089310 5133871900
15201 5143089310 5133871900
15201 5143089310 51338
71900 15201 5143089310
174
Volvo PentaVOLVO PENTA - QUICK REFERENCE / DRIVE SIDE
Models ImpellerKit
CompleteTune-Up Kit
RecirculatingWater Pump
ExhaustElbow
ExhaustManifold
ThermostatKit
13045 71900 15201 51330 51430
5.0GXi-FF / GF5.0OSi-FF / GF5.7Gi-FF / GF5.7OSi-EF / GF5.7OSXi-EF / GF5.7GXi-GF / HF 89310
13025 51338
5.0GXi-J / N5.0OSi-J5.7Gi-J / N5.7OSi-J5.7GXi-J / N5.7OSXi-J
13045
5.0GXi-JF / J1) / N1)5.0OSi-JF5.7Gi-JF / J1) / N1)5.7OSi-JF5.7GXi-JF / J1) / N1)5.7OSXi-JF
13025
5.0GXiE-J / K / M / N5.0SiE-J5.7GiE-J / K / M / N5.7OSiE-J5.7GXiE-J / K / M / N5.7OSXiE-J
13045
5.0GXiE-JF / KF / MF / N1)5.0OSiE-JF5.7GiE-JF / KF / MF / N1)5.7OSiE-JF5.7GXiE-JF / KF / MF / N1)
13431 71730
-
51330 51490
5.0FLPMDA5.8FLPMDA
89610
-
5.0FLPHU5.0FLPNCA5.0FLPNCM5.0FLPNCS5.0FLPNCB 89540
5.8FLPHU5.8FLPNCA5.8FLPNCM5.8FLPNCS5.8FLPNCB
51334 - stbd51332 - port
5.0FiPMDA5.0FiPMDM5.8FiPMDA5.8FiPMDM
89610
5.0FiPHU5.8FiPHU5.8FSiPHU
89540
71900
-
51490
-
13431
51334 - stbd51332 - port
7188013028 15301 51330 5150089540
7188013028 15301 51330 5150089540
13028 71730 15301 51330 51500
-
51490
-
134318954051334 - stbd51332 - port
5.0FiPNCA5.0FiPNCM5.8FiPNCA5.8FiPNCM5.8FSiPNCA
5.0FiPNCS5.0FiPNCB5.8FiPNCS5.8FiPNCB5.8FSiPNCD5.8FSiPNCS
-
51490
-
134318954051334 - stbd51332 - port
www.glmmarine.com 175
Volvo PentaVOLVO PENTA - QUICK REFERENCE / DRIVE SIDE
Models ImpellerKit
CompleteTune-Up Kit
RecirculatingWater Pump
ExhaustElbow
ExhaustManifold
ThermostatKit
13381 71730 15301
- -740A740B
-
13028 71730 15301
7.4GLPMD8.2GLPMD
896107.4GL PHU7.4GL PLK7.4GL PNCA7.4GL PNCB7.4GL PNCM7.4GL PNCS 89540
71880
7.4GSiXNCB7.4GiPBY8.2GSiXNCBDPX385 / DPX415LK / BY
7.4Gi PWT7.4Gi PEF
7.4GSi XWT / XEF8.2GSi XWT / XEFDPX385 XWT / XEFDPX415 XWT / XEF
13065
-
15330 51330 51500
8.1Gi-A / B8.1GSi-A8.1GXi-ADPX375-A / BDPX420-A / B
89540
51330 51500
13028 15301 51330 5150089540
7.4Gi-PHUB / PNCA7.4Gi-PNBM7.4GSi-PHUB / XNCM7.4Gi-PNCS / PNCB7.4Gi-PLKD / PLKE
7188013028 15301 51330 5150089540
51500
-
15330 5133089310 13065
51500
-
15330 5133089310 13065
-
15330 51330 5150089310
-
15330 51330 5150089310
13065
-
15330 51330 51500
8.1Gi-G / H / J8.1GXi-F / G / J8.1OSi-C / D
89310
13045
8.1Gi-GF / HF8.1GXi-FF / GF8.1OSi-CF / DF
13065
8.1GI-E / J / K / M8.1GXiE-J / K / M8.10Si-J8.1OSiE-J
8.1Gi-JF / J1)8.1GiE-JF / KF8.1GiE-MF / M1)8.1GXi-JF / J1)
8.1GXiE-JF / KF8.1GXiE- MF / M1)8.1OSi-JF8.1OSiE - JF
- - - -
DPX500DPX525DPX600
8.1Gi-C / D / E / F8.1GXi-B / C / D / E8.1OSi-A / B
13045
-
15330 51330 51500
8.1OSi-AF / BFDPX375-BF / CFDPX420-BF / CF
89540
13065
-
15330 51330 5150089540
1533089310
176
Volvo PentaVOLVO PENTA - QUICK REFERENCE / DRIVE SIDE
Models ImpellerKit
CompleteTune-Up Kit
RecirculatingWater Pump
ExhaustElbow
ExhaustManifold
ThermostatKit
13045
-
15330 51330 51500
8.1Gi-BF / CF / DF8.1Gi- EF / FF8.1GXi-AF / BF / CF8.1GXi-DF / EF
89540
8902089030 87780
87760-
12897
87780
87760
23090/23130
23090/230912313023080 23120/23122 87780
87760
12780/127848902089030 23080
23121 87780
87760
23080
www.glmmarine.com 177
Volvo PentaVOLVO PENTA - QUICK REFERENCE / ENGINE SIDE
Models U-JointBellow Kit
AnodeKit
SettingPin Kit
TiltBushings
PropService Kit
ExhaustBellow Kit
89020 12785 23080 23090 23121
200
89030
250
270270T
275275A285A
280280TA280PT
280DP
290290A
SP-ASP-A1SP-A2
SP-CSP-C1SP-E
290DP
Gear HousingSeal Kit
87780
12780/12785 23090/23130
12780/1278423090/23091
23130 23122
23090/23130 23120
12896
12898
-
12897
-
23092 23123
23093 23124
12899 23092
-
87760
8902089030
8902089030 23080 87780
87760
87780
87760
8902089030
8902089030 8902089030 23080 87770
87760
8902089030
87780
87760
12897
-
23092 231238902089030
87770
87760-
8902089030
129218919089200
129218919089200
12899 23093
-
87770
-
8902089030
12899 23092
-
87770
87760-
8902089030
178
Volvo Penta
87740
-
8902089030
VOLVO PENTA - QUICK REFERENCE / ENGINE SIDE
Models U-JointBellow Kit
AnodeKit
SettingPin Kit
TiltBushings
PropService Kit
ExhaustBellow Kit
DP-A / A1 / A2DP-B / B1
DP-C / C1DP-D / D1DP-E
DP-G
DPX-SDPX-S1DPX-R
DPX-A
DPH-A / BDPR-A / B
SX-S
SX-CSX-RSX-M
DP-S
DP-SM
Gear HousingSeal Kit
12933
-
12921
-
89030
-
89020
-
8919089200
87760
12899 23093
- -
-- --
87760
- -- - -
- - - --
87740/87750
-- -
-- -
129218919089200
-- -
-- -
87740
87740
www.glmmarine.com 179
Volvo PentaVOLVO PENTA - QUICK REFERENCE / ENGINE SIDE
Models U-JointBellow Kit
AnodeKit
SettingPin Kit
TiltBushings
PropService Kit
ExhaustBellow Kit
-
12938
- - -SX-A
89200
DPS-A / BDPS-A OXiDPS-B OXi
XDP
Gear HousingSeal Kit
-
-
12938
- - -
89200
-
12941
- - - - -
- - - - --
www.glmmarine.com