models dv8 (n,l) dv14 (n,l) dv21 (n,l)
TRANSCRIPT
Page 1
TESTED &LISTED BY
OMNI-TEST LABORATORIES, INCREPORT NO.:215-S-31-4
PORTLANDOREGON, USA
USC
MODELS
DV8 (N,L)DV14 (N,L)DV21 (N,L)
NEED HELP ?
DO NOT RETURN THIS PRODUCT TO THESTORE WHERE YOU PURCHASED IT.If you have questions about assembling oroperating this appliance or if it seems defectiveor parts are missing or replacement partsrequired:Please contact our Customer Support 1-800-750-2723
Page 2
Heater ............................
Page 3
610 m610 m
MDV8
MDV8MDV8
MDV8
MDV14
MDV14MDV14
MDV14
MDV21
MDV21MDV21
MDV21
The efficiency rating of the appliance is a product thermal efficiency rating
determined under continuous operating
conditions and was determined
independently of any installed system.
or /NG
/NG
Propane//NG
/NG /NG/LP /LP
Page 4
MDV8
MDV14
MDV21
12 15/64”
19 39/64”
25 19/32”
5 1/32” (MDV8-MDV14)7 1/32” (MDV21)
24 5/64”
Do not use this appliance if any part has been under water. Immediately call a qualified technician to inspect the appliance and to replace any part of the control system and any gas control which has been under water.
Page 5
* This installation information applies in the USA, for Canadian installation refer to page 7 of this manual
*
(For U.S. vent terminal installations)
Page 6
4.
Clearance above grade, veranda, porch, deck, or balcony
12 inches (30cm)
Clearance to window or door that may be opened
6 inches (15 cm) for appliances < 10,000 Btuh (3 kW), 9 inches (23 cm) for appliances > 10,000 Btuh (3 kW) and < 50,000 Btuh (15 kW), 12 inches(30 cm) for appliances > 50,000 Btuh(15 kW).
Clearance to permanently closedwindow
Vertical Clearance to ventilated soffitlocated above the terminal within ahorizontal distance of 2 feet (61 cm)from the center line of the terminal
Clearance to unventilated soffit Clearance to outside corner.Clearance to inside corner.Clearance to each side of center lineextended above meter/regulator assembly.
Clearance to service regulator ventoutlet.
Clearance to nonmechanical air supply inlet to building or the combustion air inlet to any building or other appliance.
6 inches (15 cm) for appliances <10,000 Btuh (3 kW), 9 inches (23 cm) for appliances > 10,000 Btuh (3 kW) and < 50,000 Btuh (15 kW), 12 inches (30 cm) for appliances > 50,000 Btuh(15 kW).
Clearance to mechanical air supplyinlet.
Clearance above paved side walk orpaved driveway located on publicproperty. Clearance under veranda, porch,deck or balcony.
3 feet (91 cm) above if within 10 feet(3 m) horizontally.
Canadian Installations¹
6 inches (15 cm) for appliances < 10,000 Btuh (3 kW), 12 inches (30 cm) for appliances > 10,000 Btuh (3kW) and <100,000 Btuh (30kW), 36 inches (91 cm)for appliances > 100,000 Btuh (30kW).
3 feet (91 cm) within a height 15 feet(4.57 m) above the meter/regulatorassembly.
6 inches (15 cm) for appliances < 10,000Btuh (3 kW), 12 inches (30 cm) forappliances > 10,000 Btuh (3kW) and< 100,000 Btuh (30kW), 36 inches (91cm) for appliances > 100,000 Btuh(30kW).
6 feet (1.83 m)
7 feet (2.13m)
12 inches (30cm)
3 feet (91 cm)
3 feet (91 cm) 3 feet (91 cm)
12 inches (30cm) 2
Page 7
Page 8
A vent shall not terminate directly above a sidewalk or paved driveway that is located between two single family dwellings and serves both dwellings.
Permitted only if veranda, porch, deck, or balcony is fully open on a minimum of two sides beneath the floor.
Page 9
MDV8MDV14MDV21
Do not connect this appliance to a chimney flue serving a separate solid fuel appliance.
Page 10
7 1/4”” 1./4”
5/8”
6 1./2””1 3/8””
3 7/8”” 3 1./2””
MDV8MDV14MDV21
HEATER
8 1./2””1 3/8”” 3/8”
4 7/8””
Page 11
Pilot Hole
Wall Bracket Template
3-1/2”FLOOR LINE
Marking for Flue Outlet
Hole
Marking for Wall BracketMounting Holes - 4 Qty.
Marking for Gas Inlet
Hole 3-1/2”FLOOR LINE
93-1/2”
Page 12
Holes
10
Page 13
10
10
Page 14
10
Gases OutletCap
Attach the gases outlet cap making sure that the threaded rod comes through the center hole in the cap. Secure the gases outlet cap by attaching the washers and the brass blind nut to the threaded rod using a screwdriver, tightening to stabilize the vent kit.
Page 15
ElectrodeWires
Frontof Unit
Backof Cabinet
heater
Page 16
Page 17
Page 18
Call our customer service at 1 800 750 2723.
Page 19
Call our customer service.
Page 20
Page 21
THERMOCOUPLE
PILOTIGNITOR
CONTROL KNOB
IGNITION BUTTON
DESCRIPTION
GLASS VIEWERVIEWER FRAME
VIEWER GASKETSIGNITOR
IGNITOR LOCKIGNITOR WIREPUSHBUTTON
CONTROL KNOBTHERMOCOUPLEPILOT SPARKER
PILOT SPARKER WIREPILOT UNIT
PILOT GASKETPILOT INJECTOR NGPILOT INJECTOR LPG
BURNER INJECTOR NGBURNER INJECTOR LPG
THERMOSTATIC VALVE NGTHERMOSTATIC VALVE LPG
COMMAND PANELGROUND WIRE
PIPE, VALVE TO PILOTPIPE, VALVE TO BURNER
COMMAND RODAIR INLET PIPE
FLUE OUTLET PIPECOMBUSTION CHAMBER
AIR INLET RINGCAP
THREADED RODBLIND NUT
FRONT CABINETBURNER UNIT
COMMAND PANEL LOCKNAMEPLATE
DISTRIBUTION CHAMBERAIR INLET GASKET
FLUE OUTLET GASKETGRILL
DEFLECTOR SHIRTDEFLECTOR SHIRT SUPPL.DEFLECTOR, RIGHT SIDE
DEFLECTOR, TOPBURNER COVER
BURNER COVER GASKETBURNER INJECTOR FITTING
CHAMBERS CLAMPSREAR PANEL
WALL BRACKETVENTING SYSTEM GASKET
SPACER
Dv14PART NUMBER
MPZA10280SPZA30098MPZA30096MVAR10453MPZA12847MCAB12846MPZP12511SPZI11263
MVAR10704MVAR10712MCAB12852MVAR10706MPZA30646MTOR10708MTOR10710STOR32542STOR30122MVAL10692MVAL10694SPZI10809
MCAB10455SPZA32508SPZA32509MTOR11600SPZA32515SPZA32516SPZA32514SUNT30227SPZT30233MFER10097MTOR10113SUNT40143SUNT32530MPZA10450MIMP20226SUNT32513MVAR12770MPZA12769SUNT30186SPZA30196SPZA30158SPZA30152SPZA30193SUNT40120SPZA31386MTOR10119SPZA40199SPZT32528SUNT32520MPZA12868SPZT32555
Dv21PART NUMBER
MPZA10280SPZA30098MPZA30096MVAR10453MPZA12847MCAB12846MPZP12511SPZI11263
MVAR10704MVAR10712MCAB12853MVAR10706MPZA30646MTOR10708MTOR10710STOR32543STOR31177MVAL10692MVAL10694SPZI10923
MCAB10455SPZA32532SPZA32533MTOR11600SPZA32515SPZA32516SPZA32537SUNT30227SPZT30233MFER10775MTOR10113SUNT40141SUNT30868MPZA10450MIMP20226SUNT32536MVAR12769MPZA12769SUNT30061SPZA30818SPZA30158SPZA30824SPZA30800SUNT32557SPZA31386MTOR10836SPZA40199SPZT32534SUNT32761MPZA12868SPZT32555
Dv8PART NUMBER
MPZA10280SPZA30098MPZA30096MVAR10453MPZA12847MCAB12846MPZP12511SPZI11263
MVAR12855MVAR10712MCAB12843MVAR10706MPZA30646MTOR10708MTOR10710STOR32535STOR32544MVAL10692MVAL10694SPZI10809
MCAB10455SPZA32497SPZA32498MTOR11600SPZA32494SPZA30174SPZA32491SUNT30179SPZT30178MFER10098MTOR10113SUNT40145SUNT32561MPZA10450MIMP20226SUNT32490MVAR12768MPZA12767SUNT36066SPZA30157SPZA30158SPZA30152SPZA30154SUNT32496SPZA31384MTOR10119SPZA40199SPZT31987SUNT32760MPZA12867SPZT32499
ITEM
123456789
101112131414151516161718192021222324252627282930313233343536373839404142434445464748
Page 22
PARTS LIST
Page 23
Page 24
FAULTS TO BE PREVENTED
If for any reason this appliance is removed from the wall for maintenance or repair then re-installed, the venting must be properly reassembled and resealed to prevent any venting leaks. Refer to the “VENT KIT INSTALLATION” section of this manual.
Page 25
PILOT
THERMOCOUPLEIGNITOR
Correct pilot flame pattern
PILOT
THERMOCOUPLEIGNITOR
Incorrect pattern (no flame)
PILOT
THERMOCOUPLEIGNITOR
Incorrect pilot flame pattern
Yellow TipsBlue Flame
Correct pilot flame patternat high position
Incorrect pilot flame patternat high position
The Company reserves the right of introducing any modifcation deemed convenient in order to improve the products, or due to any man-ufacture or commercial requirements, without previous notice, provided those modifcations are in accordance with the local gas code.This manual will help you obtain effcient, dependable service from your HomComfort heater, and enables you to obtain repair parts correctly. Parts may be ordered through your service person, dealer, or directly from the factory. Parts can be shipped directly to you or to your service person/dealer.All parts in the Parts List have part numbers. When ordering parts, frst obtain the model number from the name plate on your appliance. Then determine the part number (not the index number) and description of the component of which you wish to order. Be sure to give all of the following information:? Appliance Model Number: ___________________________ ? Part Number: ____________________________________? Appliance Serial Number: ____________________________ ? Part Description: __________________________________? Type of Gas (Propane or Natural): _____________________
United States Stove Company warrants to the original purchaser its heaters against premature failure of any component due to workman-ship, quality, or materials as follows:
CLAIMPROCEDURE
Any defects should be reported to United States Stove Company or its dealer and/or distributor giving descriptions and pertinent data, including proof of purchase which will be returned upon request.Providing the heater has been installed and used in accordance with the Owners Manual supplied with the heater, United States Stove Company will either:
? Replace the defective part free of charge
? Replace the heater free of charge
? Where the defect is of a cosmetic (non-functional) nature, United States Stove Company will bear reasonable expense to refurbish the heater, including such items as welding, painting, and incidental labor, Reasonable is defned by terms of this warranty as $30.00/hour with full refund for any of parts purchased from U.S.S.C.
NOTCOVERED
Specifcally not covered under terms of this limited warranty or any other warranty are problems relating to smoking or sooting – which is entirely related to the installation of the heater itself. Also, not covered are:
? Removal and re-installation cost.
? Service calls to diagnose trouble (unless authorized in writing by the manufacturer, distributor, or dealer)
? Damage or defect caused by improper installation, accidents, misuse, abuse or alteration.
? Transportation or shipping costs.
TIMEPERIOD
Controls / Valves One YearThermocouple / Thermopile One YearAll Electrical Components One Year
Combustion Chamber and Burner Three Years
LIMITATIONsand
ExCLUsIONs
? United States Stove Company shall not be liable for incidental, consequential, special, or contingent damages anyone might suffer as a result of their breach of this written warranty or any implied warranty.
? Should the heater be replaced by United States Stove Company “free of charge” all further warranty obligations are thereby met.
? Parts and/or service replacements made under the terms of this warranty are warranted only for the remaining period of the original heater warranty.
? Without specifc written exclusionary waivers, no one has authority to add to or vary this limited warranty, or to create for United States Stove Company any further obligation of liability in connection with this heater or any other applicable accessory. Any further warranty implication applicable to this heater or any applicable accessory is limited in duration to the same time period as the original statement in the above schedule.
This warranty gives you specifc legal rights and you may also have other rights which vary state to stat
The warrantor of record is:
United States Stove Company • PO Box 151, 227 Industrial Park Road • South Pittsburg, TN 37380 • Ph. #: (800) 750-2723
YOURDUTIEs
? This heater, including all applicable accessories, must be installed and operated in accordance with local authorities having jurisdiction and the instructions furnished with the Owners Manual.
? You should keep as permanent record your proof of purchase (or canceled check or invoice).
PRObLEM/REsOLUTION
? As purchaser, you must frst contact the dealer and/or distributor from whom you purchased your heater.
? If within a reasonable period of time you do not receive satisfactory service from the distributor and/or dealer, write United States Stove Company, Customer Service Department, including complete details of the problem and/or problems you are experiencing, details of our installation, your proof of purchase, and the heater serial number or test agency code number. You may call us with this same information.
26
HOW TO ORDER REPAIR PARTs
LIMITED WARRANTY
Page 27
Manufactured for:United States Stove Company227 Industrial Park Road, P.O.Box 151, South Pittsburg, TN 37380PH: (423) 837-2100
HOMCOMFORT is a registered trademark of United States Stove Company.