manual material handling
DESCRIPTION
Manual Material Handling. Back Injury Facts 70% of cases – Average weight of object lifted was 40-100# and 30% were over 100# The distance traveled at the time of injury was less than 5 feet 50% of the cases, the object was lifted from the ground level - PowerPoint PPT PresentationTRANSCRIPT
1www.doas.georgia.gov/risk
Risk Management Services
Manual Material Handling
2www.doas.georgia.gov/risk
Risk Management Services
Back Injury Facts
• 70% of cases – Average weight of object lifted was 40-100# and 30% were over 100#
• The distance traveled at the time of injury was less than 5 feet
• 50% of the cases, the object was lifted from the ground level
• 83% of the cases, the back was fully or partially flexed or bent
3www.doas.georgia.gov/risk
Risk Management Services
Back Injuries…• They are exceedingly painful, difficult to heal, and have
an affect on everything you do.
• After suffering one back injury, you are much more likely to experience another one later.
• The most costly type of injury for the State of Georgia.
• According to the Bureau of Labor Statistics, more than one million workers suffer back injuries each year; and back injuries account for one of every five workplace injuries.
4www.doas.georgia.gov/risk
Risk Management Services
InjuriesSprain• Injury or tear of ligaments.
• Ligaments are tough connective tissue that connect bone to bone.
Strain• Injury to muscles that have been stretched or used too
much.
• Both strains and sprains irritate the muscles around them.
5www.doas.georgia.gov/risk
Risk Management Services
Causes of Back Injuries and Back Pain
Repeated Lifting of Materials Lifting Too Much Weight Sudden Movements, Shift of Load Whole Body Vibrations Lifting & Twisting at the same time Bending over for long periods of time
6www.doas.georgia.gov/risk
Risk Management Services
Our BacksOur Backs• The spine’s vertebrae are held together by
ligaments.
• Muscles are attached to the vertebrae by bands of tissue called tendons (think of them as rubber bands).
• Between each vertebra is a cushion known as a disc (think of it as a pad or pillow).
• Spinal Column (think of the vertebrae as building blocks).
7www.doas.georgia.gov/risk
Risk Management Services
Our BacksOur Backs
• Openings in each vertebra line up to form a long, hollow canal.
• The spinal cord runs through this canal from the base of the brain.
• Nerves from the spinal cord branch out and leave the spine through the spaces between the vertebra.
8www.doas.georgia.gov/risk
Risk Management Services
Forces Involved in LiftingForces Involved in Lifting
Think of your back as a lever. With the fulcrum in the center of the lever, how many pounds would it take to lift a 10 pound object?
5 pounds10 pounds15 pounds
9www.doas.georgia.gov/risk
Risk Management Services
Forces Involved in Lifting:Forces Involved in Lifting:
You’re right! It takes 10 pounds of pressure to lift a 10 pound object.
Will it take more or less force to lift the same 10 pound object with the fulcrum shifted to one side?
10www.doas.georgia.gov/risk
Risk Management Services
Forces Involved in LiftingForces Involved in Lifting
You’re right! With the fulcrum shifted away from the object, it takes more force to lift the object.
The human back operates on a 10:1 ratio, with the waist acting as the fulcrum.
11www.doas.georgia.gov/risk
Risk Management Services
Risky Moves!Risky Moves!Anytime you find yourself doing one of these things, you should think:
DANGER! My back is at risk!
Heavy lifting...especially repetitive
lifting over a long period of time.
Twisting at the waist while lifting or
holding a heavy load. (This frequently
happens when using a shovel).
Reaching and lifting...over your head,
across a table or out the back of a truck.
12www.doas.georgia.gov/risk
Risk Management Services
Risky Moves! Risky Moves! Common Lifting ErrorsCommon Lifting Errors
• Poor planning• Poor communication• Insufficient strength• Lifting with flexed spine and the legs straight• Using a fast, jerky movement• Bending and twisting at the same time
13www.doas.georgia.gov/risk
Risk Management Services
Manual Handling
Seek help:
• When a load is too bulky to properly grasp or lift.
• When you can’t see around or over the load.
• When you can’t safely handle the load.
• Attach handles to loads to reduce the chances of getting fingers smashed.
14www.doas.georgia.gov/risk
Risk Management Services
Safe Lifting
•Break load into parts.
•Get help with heavy or bulky items.
•Lift with legs, keep back straight, do not twist.
•Use handling aids such as steps, trestles, shoulder pads, handles, and wheels.
•Avoid lifting above shoulder level.
15www.doas.georgia.gov/risk
Risk Management Services
Poor posture…
…is another contributing factor. When your
mother told you to sit and stand up straight,
she was giving you good advice. It is best to
try to maintain the back in its natural "S"
shaped curve. You want to avoid leaning
forward (unsupported) when you sit,
or hunching over while you're standing.
Contributing FactorsContributing Factors
16www.doas.georgia.gov/risk
Risk Management Services
Contributing FactorsContributing Factors
Poor Physical Condition
Your stomach muscles provide a lot of the support needed by your back. If you have weak, flabby stomach muscles, your back may not get all the support it needs, especially when you're lifting or carrying heavy objects. Good physical condition, in general, is important for preventing
strains, sprains, and other injuries.
17www.doas.georgia.gov/risk
Risk Management Services
Contributing FactorsContributing FactorsExtra weight…
can be a big problem. Remember the fulcrum/lever principle? The more you weigh, the more stress it puts on your back every time you bend over--on a 10:1 ratio. That pot belly is not helping the health of your back.
18www.doas.georgia.gov/risk
Risk Management Services
Injury Prevention Injury Prevention Analysis ToolsAnalysis Tools
• The closer to the body the more strength you have.
• Other tools:▪ ACGIH Lifting TLV
▪ NIOSH Lifting Equation
• Most models show approximately 35 pounds to be the maximum load for repeated lifting.
19www.doas.georgia.gov/risk
Risk Management Services
Injury PreventionInjury Prevention
Use carts and dollies to move objects, instead of carrying themyourself. (Remember that it is better on your back to push cartsthan it is to pull them). Use cranes, hoists, lift tables, and other lift-assist deviceswhenever you can.
20www.doas.georgia.gov/risk
Risk Management Services
Avoid lifting and bending whenever you can.
Place objects off the floor; that way you won’t have to reach down to pick them up again.
Raise/lower shelves.
Injury PreventionInjury Prevention
21www.doas.georgia.gov/risk
Risk Management Services
Injury PreventionInjury Prevention -
When lifting a box, think out of the box! • Is there a better way?
Don’t wait for someone to get injured before changing a job.
• Just because we have done it this way in the past, do we have to continue using the same method to handle a loading and unloading task?
22www.doas.georgia.gov/risk
Risk Management Services
Injury Prevention Injury Prevention Reducing frequent lifts:Reducing frequent lifts:
• Use mechanical assistance
• Avoid unnecessary lifting
• Use mobile storage shelves
23www.doas.georgia.gov/risk
Risk Management Services
Proper LiftingProper Lifting• You can't always avoid lifting, but there are ways to
reduce the amount of pressure placed on the back when you do so.
• By bending the knees, you keep your spine in a better alignment, and you essentially take away the lever principle forces.
• Instead of using your back like a crane, allow your legs to do the work.
Think of your body as more of an elevator than a
crane.
24www.doas.georgia.gov/risk
Risk Management Services
Proper LiftingProper Lifting BEFORE YOU LIFT• Plan Your Route: Path clear? Trip hazards removed? Dry?• Assess the Load: Too heavy? Can I use a hand truck or forklift?
Can I slide it? WHEN YOU LIFT • Lift It Right: Position your body close to the object. Keep your
back straight.• Lower It Right: When you put the load down, bend your knees not
your waist. GET HELP IF YOU NEED IT• Work Together: Don't be a hero. Communicate with your partner!
25www.doas.georgia.gov/risk
Risk Management Services
Proper Lifting Procedures Lifting Options – Proper Lifting Procedures Lifting Options – Golfers LiftGolfers Lift
Only appropriate for light objects that can be lifted with one hand
Good lift for those with painful knees• Bend at hip with while raising one leg
behind you• Leg lift helps maintain a neutral spine• Place one hand on thigh or fixed object• Push hand off thigh or object while
lowering leg to complete lift
26www.doas.georgia.gov/risk
Risk Management Services
Prevent Back InjuriesPrevent Back Injuries
Body Management
Rest your back
Take frequent, short (micro) breaks (seconds not minutes).
Stretch. If you've ever been working in an awkward position for a long time, then stood up and felt stiff and sore, you know you've been in that position too long,
and your body is now protesting.
Taking a one minute stretch break every now and then can help you avoid that.
27www.doas.georgia.gov/risk
Risk Management Services
ConclusionPoint Take-A-Way
Basic anatomy of the back Blocks, rubber bands, pillows
Forces involved with lifting 1:10 ratio,Keep load close to body
Risky moves associated with lifting No twisting with loadsNo reaching
Contributing factors to materials handling injuries
Fitness, age, walking surfaces
Injury prevention Reduce your lifts, THINK! Mechanical help
Proper lifting procedures Elevator vs. CraneUse proper lift for load
Body Management Stretch, Exercise, Rest as needed