icom ic f 30 31 gs gt

S-13805MZ-C1-w© 2002 Icom Inc.1-1-32, Kamiminami, Hirano-ku, Osaka 547-0003, Japan

VHF TRANSCEIVER

iC-f30gt

iC-f30gs

iC-f31gt

iC-f31gs

iC-f30gt ic

-f30gs iC

-f31gt ic

-f31gs

INTRODUCTION

This service manual describes the latest service information for the IC-F30GT/GS and IC-F31GT/GS VHF TRANSCEIVER at the time of publication.

To upgrade quality, all electrical or mechanical parts and inter-nal circuits are subject to change without notice or obligation.

DANGER

NEVER connect the transceiver to an AC outlet or to a DC power supply that uses more than 10 V. This will ruin the transceiver. DO NOT expose the transceiver to rain, snow or any liq-uids.DO NOT reverse the polarities of the power supply when connecting the transceiver. DO NOT apply an RF signal of more than 20 dBm (100 mW) to the antenna connector. This could damage the transceiver’s front end.

ORDERING PARTS

Be sure to include the following four points when ordering replacement parts:1. 10-digit order numbers2. Component part number and name3. Equipment model name and unit name4. Quantity required

<SAMPLE ORDER>1110001810 S.IC TA7368F IC-F30GT MAIN UNIT 1 piece8930053170 2337 Key board IC-F31GS CHASSIS 5 pieces

Addresses are provided on the inside back cover for your convenience.

REPAIR NOTES

1. Make sure a problem is internal before disassembling the transceiver.2. DO NOT open the transceiver until the transceiver is disconnected from its power source.3. DO NOT force any of the variable components. Turn them slowly and smoothly.4. DO NOT short any circuits or electronic parts. An insulated tuning tool MUST be used for all adjustments.5. DO NOT keep power ON for a long time when the transceiver is defective.6. DO NOT transmit power into a signal generator or a sweep generator.7. ALWAYS connect a 40 dB or 50 dB attenuator between the transceiver and a deviation meter or spectrum analyser when using such test equipment.8. READ the instructions of test equipment thoroughly before connecting equipment to the transceiver.

INTERINSICALLY SAFE QUALIFICATION

When servicing intrinsically safe versions of the IC-F30GT/GS and IC-F31GT/GS the following conditions must be met.Failing to satisfy any of these conditions will invalidate the INTRINSICALLY SAFE certification.

1. Servicing the transcever should only be undertaken by suitably qualified personnel in a non-hazardous area. Never attempt to remove the case in a hazardous area.

2. ONLY the approved battery, ICOM’s BP-210FM may be used.

3. USE ONLY safety critical components as specified in the parts list (SECTION 6), should replacement of any item be necessary.

Communication EquipmentHimmelgeister Str. 100, D-40225 Düsseldorf, GermanyPhone : 0211 346047 Fax : 0211 333639URL : http://www.icomeurope.com

Unit 9, Sea St., Herne Bay, Kent, CT6 8LD, U.K.Phone : 01227 741741 Fax : 01227 741742URL : http://www.icomuk.co.uk

Zac de la Plaine, Rue Brindejonc des MoulinaisBP 5804, 31505 Toulouse Cedex, FrancePhone : 561 36 03 03 Fax : 561 36 03 00URL : http://www.icom-france.com

Crta. de Gracia a Manresa Km. 14,75008190 Sant Cugat del Valles Barcelona, SPAINPhone : (93) 590 26 70 Fax : (93) 589 04 46URL : http://www.icomspain.com

<Corporate Headquarters>2380 116th Avenue N.E., Bellevue, WA 98004, U.S.A.Phone : (425) 454-8155 Fax : (425) 454-1509URL : http://www.icomamerica.com<Customer Service>Phone : (425) 454-7619

Glenwood Centre #150-6165 Highway 17 Delta, B.C., V4K 5B8, CanadaPhone : (604) 952-4266 Fax : (604) 952-0090URL : http://www.icomcanada.com

A.B.N. 88 006 092 575290-294 Albert Street, Brunswick, Victoria, 3056, AustraliaPhone : 03 9387 0666 Fax : 03 9387 0022URL : http://www.icom.net.au

146A Harris Road, East Tamaki,Auckland, New ZealandPhone : 09 274 4062 Fax : 09 274 4708URL : http://www.icom.co.nz

6F No. 68, Sec. 1 Cheng-Teh Road, Taipei, Taiwan, R.O.C.Phone : (02) 2559 1899 Fax : (02) 2559 1874

1-1-32, Kamiminami, Hirano-ku, Osaka 547-0003, JapanPhone : 06 6793 5302Fax : 06 6793 0013URL : http://www.icom.co.jp/world/index.html

IC-F30GSIC-F31GS

IC-F30GTIC-F31GT

TABLE OF CONTENTS

SECTION 1 SPECIFICATIONS

SECTION 2 INSIDE VIEWS

SECTION 3 DISASSEMBLY INSTRUCTIONS

SECTION 4 CIRCUIT DESCRIPTION

4 - 1 RECEIVER CIRCUITS ................................................................................................... 4 - 1

4 - 2 TRANSMITTER CIRCUITS ............................................................................................ 4 - 2

4 - 3 PLL CIRCUITS................................................................................................................. 4 - 3

4 - 4 POWER SUPPLY CIRCUITS ......................................................................................... 4 - 4

4 - 5 CPU PORT ALLOCATIONS ........................................................................................... 4 - 4

SECTION 5 ADJUSTMENT PROCEDURES

5 - 1 PREPARATION................................................................................................................ 5 - 1

5 - 2 PLL ADJUSTMENT.......................................................................................................... 5 - 4

5 - 3 SOFTWARE ADJUSTMENT ........................................................................................... 5 - 5

SECTION 6 PARTS LIST

SECTION 7 MECHANICAL PARTS AND DISASSEMBLY

SECTION 8 SEMI-CONDUCTOR INFORMATION

SECTION 9 BOARD LAYOUTS

9 - 1 FRONT UNIT ................................................................................................................... 9 - 1

9 - 2 MAIN UNIT....................................................................................................................... 9 - 2

SECTION 10 BLOCK DIAGRAM

SECTION 11 VOLTAGE DIAGRAM

Measurement method

Frequency coverage

Type of emission

Number of conventional channels

Power supply requirement

Current drain (approx.)

Frequency error

Usable temperature range

Dimensions (proj. not included)

Weight (with BP-210)

RF output power

Modulation system

Maximum permissible deviation

Spurious emissions

Adjacent channel power

Audio frequency response

Audio hormonic distortion

FM hum and noise (typical)

Residual modulation (typical)

Limitting charact of modulator

Ext. microphone connector

Receive system

Intermediate frequencies

Sensitivity (typical)

Squelch sencitivity (at threshold) (typical)

Adjcent channel selectivity (typical)

Spurious response

Intermoduration (typical)

FM hum and noise (typical)

Hum and noise (with CCITT filter) (typical)

Audio output power (at 7.2 V DC)

External SP connector

1 - 1

All stated specifications are subject to change without notice or obligation.

USA/GEN EUR

RE

CE

IVE

RT

RA

NS

MIT

TE

RG

EN

ER

AL

EIA-152-C/204D or TIA-603 ETS 300 086 (GEN)

136.000–174.000 MHz

16K0F3E [25 kHz; Wide], 8K50F3E [12.5 kHz; Narrow]

Max. 256 ch (16 channels × 16 banks)

7.2 V DC (negative ground; supplied battery pack)

TX at High 2.0 ARx rated audio 300 mA

stand-by 95 mA (typical)

±2.5 ppm ±1.5 kHz

–30˚C to +60˚C (–22˚F to +140˚F) –25˚C to +55˚C (–13˚F to +131˚F)

54(W) × 139(H) × 38(D) mm; 21⁄8(W) × 515⁄32(H) × 11⁄2(D) inch

420 g; 14.8 oz

5 W / 2 W / 1 W (High/Low2/Low1)

Variable reactance frequency modulation

±5.0 kHz [Wide], ±2.5 kHz [Narrow]

73 dBc typical 0.25 µW

70 dB [Wide], 60 dB [Narrow]

+2 dB to –8 dB of 6 dB/octarverange from 300 Hz to 3000 Hz [Wide]/2550 Hz [Narrow]

3% typical at 1 kHz, 40% deviation

46 dB [Wide], 40 dB [Narrow] ——

—— 45 dB [Wide], 43 dB [Narrow]

60–100% of max. deviation

9-pin multi connector/2.2 kΩ

Double-conversion superheterodyne system

1st: 31.65 MHz, 2nd: 450 kHz

0.25 µV at 12 dB SINAD –4 dBµV (emf) at 20 dB SINAD

0.25 µV –4 dBµV (emf)

73 dB [Wide], 63 dB [Narrow]

70 dB

74 dB 70 dB

46 dB [Wide], 40 dB [Narrow] ——

—— 45 dB [Wide], 43 dB [Narrow]

500 mW typical at 5% distortion with a 8 Ω load600 mW typical at 5% distortion with a 6 Ω load

9-pin multi connector/8 Ω

SECTION 1 SPECIFICATIONS

2 - 1

SECTION 2 INSIDE VIEWS

• FRONT UNITBottom view

• MAIN UNITTop view

• MAIN UNITBottom view

KEY LED switch(Q1, Q2: 2SC4116)

LCD module(DS10: EDMMU1FA0)

Internal speaker switch circuit(Q6, Q7: CPH3403, Q8: 2SC4081, Q9: DTC144EUA)

Expander IC(IC1: TC74VHC373FT)

Antenna switching(D1, D25, D24: MA77 D1 is bottom side)

D/A converter(IC27: M62334FP)

PLL IC(IC1: SA7025DK)

Power amplifier(Q1: 2SK2974)

Pre-drive amplifier(Q2: 2SK2973)

YGR amplifier(Q3: 2SC4226)

TX/RX switch(D5, D4: MA77)

TX/RX VCO circuit

3.58 MHz crystal(X4: CR-563 3.579545 MHz)

PTT/MD1 switch and INT/EXT microphone switch(IC19: BU4053BCF)

2nd IF filter (450 kHz) (FI2: SFPCA450KE4A)(FI3: SFPCA450KG1A)

Discreminator(X2: CDBCB450KCA24 450 kHz)

T5 regulator(Q29: 2SA1362)

R5 regulator(Q30: 2SA1362)

S5 regulator(Q31: 2SA1362)

+5 regulator(Q32: 2SB1132)

Crystal oscillator for CPU clock(X3: CR-681 12.288 MHz)

1st IF amplifier(Q18: 2SC4215)

AF amplifier(IC5: TA7368F)

RF amplifier(Q20: 3SK293)

1st mixer(Q19: 3SK206)

1st IF filter(FI1: FL-322 31.650 MHz)

Splatter filter(IC7: NJM2902V)

2nd mixer/IF detect/SQL amplifier(IC3: TA31136FN)

D/A converter(IC13: M62364FP)

DTMF decoder(IC17: LC73872M)

CPU(IC14: HD64F2238FA13)

Expander IC(IC23: BU4094BCFV)

EEPROM(IC16, IC24: HN58X2464TI)

Microphone amplifier/mute/compander(IC9: TC35453F)

TCXO(X1: CR-667 15.600 MHz )

APC amplifier(IC4: TC75S51F)

Power detector(D2: MA713)

3 - 1

SECTION 3 DISASSEMBLY INSTRUCTIONS

1 Removing the chassis panel

2 Removing the shield plate

3 Removing the MAIN unit

4 Removing the FRONT unit

q Remove 2 knobs A, and unscrew 1 nut B.w Unscrew 1 screw C (ICOM screw), and 2 screws D (2 ×

4 mm, black) from the 9-pin connector.e Unscrew 2 screws E (2 × 8 mm, silver) from the chassis.r Take off the chassis in the direction of the arrow.

q Unplug the flexible cable from J1 on the FRONT unit toseparate the chassis.

w Take off the flexible cable in the direction of the arrow. e Unscrew 8 screws F (2 × 3 mm, black) to separate the

shield plate.

q Unsolder 2 points G. w Unscrew 2 nuts H.e Unscrew 6 screws I (2 × 4 mm, silver), and 2 screws J

(2 × 4 mm, black) from the MAIN unit.r Take off the MAIN unit in the direction of the arrow.

q Unplug the LCD flexible cable from J2 on the FRONT unitto separate the front panel.

w Unscrew 6 screws K (2 × 3.5 mm, silver) from the FRONTunit.

e Unsolder the leads of speaker.

A

B

C

D

E

Chassis

Front panel

9-pin connector

Shield plate

MAIN unit

Chassis

Flexible cable

F

F

F

F

MAIN unit

Chassis

NutH

JI

G

I

Front panel

Front unit

J2

J1

LCD flexible cable

K

K

4 - 1

SECTION 4 CIRCUIT DESCRIPTION

4-1 RECEIVER CIRCUITS4-1-1 ANTENNA SWITCHING CIRCUITThe antenna switching circuit functions as a low-pass filterwhile receiving and a resonator circuit while transmitting.This circuit does not allow transmit signals to enter thereceiver circuits.

Received signals enter the antenna connector (CHASSIS;MP44) and pass through the low-pass filter (L1–L3, C1–C3,C416–C419). The filtered signals are passed through the λ⁄4type antenna switching circuit (D25, L39, D24) and thenapplied to the RF circuit.

4-1-2 RF CIRCUITThe RF circuit amplifies signals within the range of frequen-cy coverage and filters out-of-band signals.

The signals from the antenna switching circuit pass throughthe two-stage tunable bandpass filters (D21, D20, L38, L37).The filtered signals are amplified at the RF amplifier (Q20)and then passed through the another two-stage tunablebandpass filters (D19, D18, L36, L33) to suppress unwant-ed signals. The filtered signals are applied to the 1st mixercircuit.

D18–D21 employ varactor diodes, that are controlled by theCPU via the D/A converter (IC27), to track the bandpass fil-ter. These varactor diodes tune the center frequency of anRF pass band for wide bandwidth receiving and good imageresponse rejection.

4-1-3 1ST MIXER AND IST IF CIRCUITSThe 1st mixer circuit converts the received signal into fixedfrequency of the 1st IF signal with the PLL output frequency.By changing the PLL frequency, only the desired frequencypasses through a cristal filter at the next stage of the 1stmixer.

The RF signals from the bandpass filter are mixed with the1st LO signals, where come from the RX VCO circuit via theattenuator (R360–R358), at the 1st mixer circuit (Q19) toproduce a 31.65 MHz 1st IF signal. The 1st IF signal ispassed through a monolithic filter (FI1) in order to obtainselection capability and to pass only the desired signals. Thefiltered signal is applied to the 2nd IF circuit after beingamplified at the 1st IF amplifier (Q18).

4-1-4 2ND IF AND DEMODULATOR CIRCUITSThe 2nd mixer circuit converts the 1st IF signal into a 2nd IFsignal. The double-conversion superheterodyne system(which convert receive signals twice) improves the imagerejection ratio and obtains stable receiver gain.

The 1st IF signal from the IF amplifier (Q18) is applied to the2nd mixer section of the FM IF IC (IC3, pin 16), and is mixedwith the 2nd LO signal to be converted into a 450 kHz 2ndIF signal.

The FM IF IC (IC3) contains the 2nd mixer, 2nd local oscil-lator, limiter amplifier, quadrature detector, active filter andnoise amplifier circuits. A 2nd LO signal (31.2 MHz) is pro-duced at the PLL circuit by doubling it’s reference frequency(15.6 MHz).

The 2nd IF signal from the 2nd mixer (IC3, pin 3) passesthrough the ceramic filters (FI2, FI3) during narrow channelspacing selection or FI2 only (bypassing FI3) during widechannel spacing selection to remove unwanted heterodynedfrequencies. It is then amplified at the limiter amplifier sec-tion (IC3, pin 5) and applied to the quadrature detector sec-tion (IC3, pins 10, 11) to demodulate the 2nd IF signal intoAF signals.

The demodulated AF signals are output from pin 9 (IC3) andapplied to the AF circuit via the receiver mute circuit.

• 2nd IF and demodulator circuits

Mixer

16

Limiteramp.

2nd IF filter450 kHz X1

15.6 MHz31.2 MHz

IC3 TA31136FN12 1st IF from the IF amplifier (Q18)

"RSSI" signal to the CPU (IC14, pin 50)

11109

8 7

AF signal "DSIN"

R5V

X2

Squelch levelcontroller (IC13)

2

Activefilter

Noisedetector

FMdetector

13

"NOIS" signal to the CPU (IC14, pin 75)

RSSI

Noisecomp.

×2

Doubler

Q15

23

24

FI2

5

FI3

3

4 - 2

4-1-5 AF AMPLIFIER CIRCUITThe AF amplifier circuit amplifies the demodulated AF sig-nals to drive a speaker.

The AF signals from the FM IF IC (IC3, pin 9) are amplifiedat the AF amplifier section of the compander IC (IC9, pins 5,4) and are then applied to the high-pass filter circuit (IC7a).

The high-pass filter characteristics are controlled by theFSW signal from the I/O expander IC (IC23, pin 14). WhenFSW signal is high, the cut-off frequency is shifted higher toremove CTCSS or DTCS signals.

The filtered AF signals from the high-pass filter (IC7a, pin 1)are applied to the de-emphasis section of compander IC(IC9, pin 3) with frequency characteristics of –6 dB/octave,and are then passed through the low-pass filter, high-passfilter, expander sections of compander IC (IC9). The outputsignal from IC9 (pin 38) is applied to the electronic volumecontroller (IC13, pin 1).

The output AF signals from the electronic volume controller(IC13, pin 2) are applied to the AF power amplifier (IC5) todrive the speaker.

4-1-6 RECEIVE MUTE CIRCUITS• NOISE SQUELCHA squelch circuit cuts out AF signals when no RF signals arereceived. By detecting noise components in the AF signals,the squelch circuit switches the AF mute switch.

Some noise components in the AF signals from the FM IF IC(IC3, pin 9) are passed through the level controller (IC13,pins 24, 23). The level controlled signals are applied to theactive filter section in the FM IF IC (IC3, pin 8). Noise com-ponents about 10 kHz are amplified and output from pin 7.

The filtered signals are converted into the pulse-type signalsat the noise detector section and output from pin 13 (NOIS).

The NOIS signal from the FM IF IC is applied to the CPU(IC14, pin 75). Then the CPU analyzes the noise conditionand controls the AF mute signal via “AFMT” line (IC23, pin13) to the AF regulator (Q23, Q24).

• CTCSS AND DTCSThe tone squelch circuit detects AF signals and opens thesquelch only when receiving a signal containing a matchingsubaudible tone (CTCSS or DTCS). When tone squelch is inuse, and a signal with a mismatched or no subaudible toneis received, the tone squelch circuit mutes the AF signalseven when noise squelch is open.

A portion of the AF signals from the FM IF IC (IC3, pin 9)passes through the low-pass filter (IC20b/a) to remove AF(voice) signals and is applied to the CTCSS or DTCSdecoder inside of the CPU (IC14, pin 46) via the “RXDT” lineto control the AF mute switch via the I/O expander IC (IC23).

4-2 TRANSMITTER CIRCUITS4-2-1 MICROPHONE AMPLIFIER CIRCUITThe microphone amplifier circuit amplifies audio signalswithin +6 dB/octave pre-emphasis characteristics from themicrophone to a level needed for the modulation circuit.

The AF signals (MIC+) from the FRONT unit via J3 (pin 22)are passed through the internal/extenal microphone switch(IC19, pins 12, 14) and level controller (IC13, pins 9, 10) tothe microphone amplifier circuit.

The AF signals from the level controller (IC13) are applied tothe microphone amplifier section of compander IC (IC9, pin12). The amplified signals are passed through the compres-sor, low-pass filter and high-pass filter sections of IC9.

The filtered AF signals are amplified at the buffer amplifier(Q47) and pre-emphasized with +6dB/octave at the pre-emphasis circuit (C203, R166), and are then applied to theIDC amplifier section of IC9 (pin 8).

The amplified AF signals are passed through the limitteramplifier and low-pass filter sections of IC9 after beingpassed through the AF mute switch inside of IC9.

The output signals from pin 6 are passed through the splat-ter filter (IC7c) and level controller (IC13, pins 21, 22), andare then applied to the modulation circuit (D7).

4-2-2 MODULATION CIRCUITThe modulation circuit modulates the VCO oscillating signal(RF signal) using the microphone audio signals.

The AF signals from the level controller (IC13) change thereactance of varactor diode (D7) to modulate the oscillatedsignal at the TX VCO circuit (Q12, D8, D43–D45). The mod-ulated VCO signal is amplified at the buffer amplifiers (Q8,Q6) and is then applied to the drive amplifier circuit via theT/R switch (D4).

The CTCSS/DTCS signals from the CPU (IC14, pin 44) arepassed through the low-pass filter (IC7d), level controller(IC13, pins 12, 11) and mixer circuit (IC7b), and are thenapplied to the VCO circuit via the splatter filter (IC7c).

• APC circuit

Q1Poweramp.

Q2Driveramp.

IC4

+

–

T5V

RF signalfrom PLL

to antenna

T4

TMUTQ22

S5V

APC control circuit

Power detectorcircuit (D2)

D2

L5

4 - 3

4-2-3 DRIVE/POWER AMPLIFIER CIRCUITSThe drive/power amplifier circuits amplify the VCO oscillat-ing signal to an output power level.

The signal from the VCO circuit passes through the T/Rswitch (D4), and is amplified at the YGR (Q3), drive (Q2),power (Q1) amplifiers to obtain 5 W of RF power (at 7.2 VDC).

The amplified signal is passed through the APC detector,antenna switching circuit (D1) and low-pass filter, and isthen applied to the antenna connector.

The bias current of the drive (Q2) and power (Q1) amplifiersis controlled by the APC circuit.

4-2-4 APC CIRCUITThe APC circuit (IC4, Q22) protects the drive and poweramplifiers from excessive current drive, and selects outputpower of HIGH, LOW2 or LOW1.

The power detector circuit (D2) detects the transmit poweroutput level and converts it into DC voltage. The output volt-age is at a minimum level when the antenna impedance ismatched at 50 Ω and is increased when it is mismatched.

The detected voltage is applied to the differential amplifier(IC4, pin 3), and the “T4” signal from the D/A converter(IC27, pin 4), controlled by the CPU (IC14), is applied to theother input for reference. When antenna impedance is mis-matched, the detected voltage exceeds the power settingvoltage. Then the output voltage of the differential amplifier(IC4, pin 4) controls the input current of the drive amplifier(Q2) and power amplifier (Q1) to reduce the output power.

4-3 PLL CIRCUITS4-3-1 PLL CIRCUITA PLL circuit provides stable oscillation of the transmit fre-quency and receive 1st LO frequency. The PLL output com-pares the phase of the divided VCO frequency to the refer-ence frequency. The PLL output frequency is controlled bythe divided ratio (N-data) of a programmable divider.

The PLL circuit contains the TX/RX VCO circuit (Q12, Q11).The oscillated signal is amplified at the buffer amplifiers (Q8,Q7) and then applied to the PLL IC (IC1, pin 5).

The PLL IC contains a prescaler, programmable counter,programmable divider and phase detector, etc. The enteredsignal is divided at the prescaler and programmable countersection by the N-data ratio from the CPU. The divided signalis detected on phase at the phase detector using the refer-ence frequency.

If the oscillated signal drifts, its phase changes from that ofthe reference frequency, causing a lock voltage change tocompensate for the drift in the oscillated frequency.

4-3-2 VCO CIRCUITThe VCO circuit contains a separate RX VCO (Q11, D6,D40–D42) and TX VCO (Q12, D7, D8, D43–D45). The oscil-lated signal is amplified at the buffer amplifiers (Q8, Q6) andis then applied to the T/R switch (D5, D4). Then the receive1st LO (Rx) signal is applied to the 1st mixer (Q19) and thetransmit (Tx) signal to the YGR amplifier circuit (Q3).

A portion of the signal from the buffer amplifier (Q8) is fedback to the PLL IC (IC1, pin 5) via the buffer amplifier (Q7)as the comparison signal.

• PLL circuit

Shift register

×2

PrescalerPhasedetector

Loopfilter

Programmablecounter

Programmabledivider

X115.6 MHz

31.2 MHz signalto the FM IF IC 8

BufferQ8

BufferQ6

BufferQ7

Doubler

123

SCKSOPLST

to transmitter circuit

to 1st mixer circuit

D4

D5

14 5

Q15

IC1 SA7025DK-T

Q12, D7, D8, D43–D45

TX VCO

Q11, D6, D40–D42

RX VCO

4 - 4

4-4 POWER SUPPLY CIRCUITVOLTAGE LINE

4-5 PORT ALLOCATIONS4-5-1 CPU (IC14)

4-5-2 I/O EXPANDER (IC23)

LINE

HV

VCC

CPU5V

+5V

S5V

T5V

R5V

DESCRIPTION

The voltage from the attached battery pack.

The same voltage as the HV line (battery volt-age) which is controlled by the power swtich([VOL] control).

Common 5 V converted from the VCC line by thereference regulator circuit (IC12). The output volt-age is applied to the CPU (IC14), 5 V regulator cir-cuit (Q32, Q33) and reset circuit (IC15), and etc.

Common 5 V converted from the VCC line by the+5V regulator circuit (Q32, Q33).

Common 5 V converted from the +5V line by theS5V regulator circuit (Q31).

5 V for transmitter circuits regulated by the T5Vregulator circuit (Q29).

5 V for receiver circuits regulated by the R5Vregulator circuit (Q30).

Outputs data signals for the PLL IC(IC1), compamder IC (IC9), expanderIC (IC23), D/A converter (IC13), etc.

Outputs strobe signals to the D/A con-verter (IC13).

Output clock signal to the DTMFdecoder (IC17).

Outputs single tone signal.

Outputs CTCSS/DTCS tone signal.

Single tone signal input port for decod-ing.

CTCSS/DTCS signals input port fordecoding.

Input port for the volume control [VOL].High : [VOL] is maximum clockwise.

Input port for the PLL lock voltage.

Input port for the RSSI detection.

Input port for the reset signal.

Outputs serial data signals to theDTMF decoder IC (IC17).

Outputs transmit mute signal.Low : During unlock or while muted

Outputs R5 regulator control signal.Low: While receiving

Outputs T5 regulator control signal.Low: While transmitting

Input port for noise signals (pulse-type) for noise squelch operation.

I/O port for data signals from/to theD/A converter (IC27).

I/O port for data signals from/toEEPROMs (IC16, IC24).

Outputs beep audio signals.

Outputs clock signal to EEPROMs(IC16, IC24).

Outputs clock signal to the D/A con-verter (IC27).

SO

DAST

DTAC

SENC

CTDA

SDEC

RXDT

AFVI

LVIN

RSSI

RES

DTSD

TMUT

R5C

T5C

NOIS

SDA

MSO

BEEP

MSCK

SCL

35

36

39

43

44

45

46

47

49

50

59

68

70

71

73

75

81

82

87

94

95

4

5

6

7

13

15

16

17,18,19,

21

22–25

26

28

29

34

RESB

RMUT

MMUT

PTOT

EXST

APST

DIN

RGS1,RGS2,MSKE,

FCLR

CB10–CB13

VCOS

PLST

ULCK

SCK

Outputs reset signal for the expader IC(IC23).

Input port for AF mute signal from theoptional units via J1 or J2.

Input port for MIC mute signal from theoptional units via J1 or J2.

Input port for the [PTT] switchLow : While [PTT] switch is pushed.

Outputs strobe signals to the expanderIC (IC23).

Outputs strobe signals to the compan-der IC (IC9).

Outputs serial data signals to the com-pander IC (IC9).

Output control signal for the compan-der IC (IC9).

Outputs reset signal for the compan-der IC (IC9).

Input ports for rotary selector [SEL].

Outputs TX VCO/RX VCO switchingsignal for the VCO switch (Q9, Q10).

High : While transmitting

Outputs strobe signals to the PLL IC(IC1).

Input port for the PLL unlock signal.Low : PLL is unlocked.

Outputs clock signal for the PLL IC(IC1), compamder IC (IC9), expanderIC (IC23), D/A converter (IC13), etc.

Pin PortDescriptionnumber name


4

6

7

11

12

13

14

BUSY

DUSE

W/N

S5C

SPCN

AFMT

FSW

Outputs BUSY detection.Low : The channel is busy.

Outputs low-pass filter cut-off frequen-cy control signal when DTCS is acti-vated.

Outputs IF bandwidth control signal.High : While IF bandwidth is narrow.

Outputs S5 regulator control signal.

Outputs internal speaker select signal.

Outputs control signal for the AFamplifier regulator circuit.

High: While AF amp. is activated.

Outputs high-pass filter’s characteris-tics select signal.


5 - 1

5-1 PREPARATIONWhen you adjust the contents on pages 5-5 and 5-6, SOFTWARE ADJUSTMENT, the optional CS-F30G ADJ ADJUSTMENT SOFT-WARE (Rev. 1.0 or later), *OPC-966 JIG CABLE (modified OPC-966 CLONING CABLE) are required.

REQUIRED TEST EQUIPMENT

SECTION 5 ADJUSTMENT PROCEDURES

SYSTEM REQUIREMENTS• IBM PC compatible computer with an RS -232C serial port

(38400 bps or faster).• Microsoft Windows 95 or Windows 98• Intel i486DX processor or faster (Pentium 100 MHz or

faster recommended)• At least 16 MB RAM and 10 MB of hard disk space• 640×480 pixel display (800×600 pixel display recommend-

ed)

ADJUSTMENT SOFTWARE INSTALLATIONq Boot up Windows.

- Quit all applications when Windows is running.w Insert the ‘CS-F30G’ into the appropriate drive.e Select ‘Run’ from the [Start] menu.r Type the setup program name using the full path name,

then push [Enter] key.(ex. D:\CSF30GADJ\disk1\Setup.exe)

t Follow the prompts.y Program group ‘CS-F30G ADJ’ appears in the ‘Programs’

folder of the [Start] menu.

STARTING SOFTWARE ADJUSTMENTq Connect IC-F30GT, F30GS, F31GT or F31GS and PC

with *OPC-966 JIG CABLE.w Turn the transceiver power ON.e Boot up Windows, and click the program group ‘CS-F30G

ADJ’ in the ‘Programs’ folder of the [Start] menu, thenCS-F30G ADJ’s window appears.

r Click ‘Connect’ on the CS-F30G’s window, then appearsIC-F30GT, F30GS, F31GT or F31GS’s up-to-date condi-tion.

t Set or modify adjustment data as desired.

IBM is a registered trademark of International BussinessMachines Corporation in the U.S.A. and other countries.Microsoft and Windows are registered trademarks ofMicrosoft Corporation in the U.S.A. and other countries.Screen shots produced with permission from MicrosoftCorporation. All other products or brands are registeredtrademarks or trademarks of their respective holders.

• High power transmittionWhen you adjust the output power (high power), the batterytype detector must be connected to GND (see illustration atbelow). Otherwise the transceiver does not transmit highpower, the output power will be low.

EQUIPMENT

DC power supply

FM deviation meter

Frequency counter

Digital multimeter

RF power meter(terminated type)

GRADE AND RANGE

Output voltage : 7.5 V DCCurrent capacity : 5 A or more

Frequency range : DC–300 MHzMeasuring range : 0 to ±10 kHz

Frequency range : 0.1–300 MHzFrequency accuracy : ±1 ppm or betterSensitivity : 100 mV or better

Input impedance : 10 MΩ/V DC or better

Measuring range : 1–10 WFrequency range : 100–300 MHzImpedance : 50 ΩSWR : Less than 1.2 : 1

EQUIPMENT

Audio generator

Attenuator

Standard signal generator (SSG)

DC voltmeter

Oscilloscope

AC millivoltmeter

GRADE AND RANGE

Frequency range : 300–3000 HzOutput level : 1–500 mV

Power attenuation : 40 or 50 dBCapacity : 10 W or more

Frequency range : 100–300 MHzOutput level : 0.1 µV–32 mV

(–127 to –17 dBm)

Input impedance : 50 kΩ/V DC or better

Frequency range : DC–20 MHzMeasuring range : 0.01–20 V

Measuring range : 10 mV–10 V

Battery type detector

+

–DC power supply

7.5 V/5.0 A

Battery type detector

Connect to GND

5 - 2

CS-F30G ADJ Rev.1.0File

COM 1: OPEN

Option

Connect Reload (F5) Disp para

[A / D]VIN : 197 : C5h : 7.73 VTEMPS : 190 : BEh : 32.23 'CLVIN : 67 : 43h : 1.31 VSD : 27 : 1Bh : 0.53 VBDET : 0 : 00h : 0.00 V (Ni-Cd, Ni-MH)

Power (Hi) : 98 [ # # # # # # # # – – – – – – – – – – – ] Power (L2) : 54 [ # # # # – – – – – – – – – – – – – – – ]Power (L1) : 54 [ # # – – – – – – – – – – – – – – – – – ]

Ballance : 132 [ # # # # # # # # # # – – – – – – – – – ]MOD W : 95 [ # # # # # # # – – – – – – – – – – – – ]MOD N : 47 [ # # # # – – – – – – – – – – – – – – – ]

CTCS/DTCS : 113 [ # # # # # # # # # – – – – – – – – – – ]SQL : 0 [ – – – – – – – – – – – – – – – – – – – ]

BPF ALL : [Enter] to sweepBPF T1 : 23 [ # # # # # # # # # # # # – – – – – – – ] [Enter] to sweepBPF T2 : –22 [ # # # # # # # # – – – – – – – – – – – ] [Enter] to sweepBPF T3 : 9 [ # # # # # # # # # # # – – – – – – – – ] [Enter] to sweepBPF T4 : –7 [ # # # # # # # # # – – – – – – – – – – ] [Enter] to sweep

TXF : [Enter] to startS-METER : [Enter] to start

[D / A]BPF T1 : 90 : 5Ah : 1.76 VBPF T2 : 45 : 2Dh : 0.88 VBPF T3 : 76 : 4Ch : 1.49 VT4/POW : 60 : 3Ch : 1.18 VREF : 112 : 70h : 2.20VMOD BAL : 90 : 5Ah : 1.76 VDev : 45 : 2Dh : 0.88 VCTCSS : 76 : 4Ch : 1.49 VSQL Lev : 0 : 00h : 1.18 V

CH No. : 01 RX Freq = 155.000, TX Freq = <– RF Power: Low1 Mode: Wide

: Transceiver's connection state

: Reload adjustment data

: Receive sensitivity measurement

: Connected DC voltage

: PLL lock voltage

: Operating channel select

: RF output power

: Modulation balance

NOTE:

• Screen display exampe

1

5

4

6

1011

12

15

9

14

16

1

2

3

4

5

6

9

10

7

8

11

12

13

: FM deviation

: CTCSS/DTCS deviation

: Squelch level

: Receive sensitivity (automatically)

: Receive sensitivity (manually)

: Reference frequency

: S-meter

: Adjustment items

14

15

16

The above values for settings are example only. Each transceiver has its own specific values for each setting.

3

2

8

7

13

5 - 3

+

+

–

Audio generator300 Hz to 3 kHz

ACmillivoltmeter

SP+

SP–

MICEMIC

PTTPTTE

Add a jumper wire here

• *OPC-966 (JIG CABLE)

Electrolytic capacity47 µF

OPC-966(Cloning cable)

SINAD meter

Speaker (8 Ω)

Audio generator

• Connection

to the antenna connector

RF power meter0.1–10 W/50 Ω

Frequencycounter

Attenuator40 dB or 50 dB

FMdeviation meter

Standard signal generator0.1 µV to 32 mV

(–127 dBm to –17 dBm)

CAUTION:DO NOT transmit whileSSG is connected to theantenna connector.

to an RS-232C port

DB9 female plug(incl. level converter circuit)

Personalcomputer

RS-232C cable (straight) *OPC-966(JIG CABLE)

5 - 4

5-2 PLL ADJUSTMENT

PLL LOCKVOLTAGE

1

2

3

4

• Operating freq. : 136.000 MHz• Receiving

• Transmitting

• Operating freq. : 174.000 MHz• Receiving

• Transmitting

MAIN Connect a digital multi-meter or an oscillo-scope to the checkpoint, “LV”.

1.2 V

1.0 V

3.0–4.5 V

MAIN C372

C373

Verify

ADJUSTMENT ADJUSTMENT CONDITIONSUNIT LOCATION

VALUEUNIT ADJUST

MEASUREMENT ADJUSTMENT

LVPLL lock voltage check point

C372PLL lock voltage adjustment for RX

C373PLL lock voltage adjustment for TX

• MAIN unit

5 - 5

5-3 SOFTWARE ADJUSTMENTSelect an operation using [↑] / [↓] keys, then set specified value using [←] / [→] keys on the connected computer keyboard.

1

1

2

3

1

1

2

1

• Operating freq. : 174.000 MHz• Output power : Low1• Connect an RF power meter or 50 Ω

dummy load to the antenna connector.• Transmitting

• Operating freq. : 136.000 MHz• Output power : High• Transmitting

• Output power : Low2• Transmitting

• Output power : Low1• Transmitting

• Operating freq. : 155.000 MHz• Output power : Low1• Set an FM deviation meter as:

HPF : OFFLPF : 20 kHzDe-emphasis : OFFDetector : (P–P)/2

• Push [P0] key while transmitting

• Operating freq. : 155.000 MHz• Output power : Low1• IF bandwidth : Wide• Set the FM deviation meter as:

HPF : OFFLPF : 20 kHzDe-emphasis : OFFDetector : (P–P)/2

• Connect the audio generator to the multiconnector through the JIG cable (*OPC-966) and set as : 1.0 kHz/150 mVrms

• Transmitting

• IF bandwidth : Narrow• Transmitting

• Operating freq. : 155.000 MHz• Output power : Low1• IF bandwidth : Wide• CTCSS : 88.5 Hz• DTCS code : 007• No audio applied to the [MIC] input.• Transmitting

REFERENCEFREQUENCY[TXF]

OUTPUTPOWER[Power (Hi)]

[Power (L2)]

[Power (L1)]

MODULATIONBALLANCE[Ballance]

FMDEVIATION[MOD W]

[MOD N]

CTCSS/DTCSDEVIATON[CTCS/DTCS]

Toppanel

Toppanel

Toppanel

Toppanel

Toppanel

Loosely couple a frequnecycounter to the antenna connec-tor.

Connect an RF power meter tothe antenna connector.

Connect an FM deviation meterwith an oscilloscope to theantenna connector through anattenuator.

Connect an FM deviation meterto the antenna connectorthrough the attenuator.

Connect an FM deviation meterto the antenna connectorthrough the attenuator.

174.0000 MHz

5.0 W

2.0 W

1.0 W

±4.1 kHz

±2.1 kHz

0.7 kHz

ADJUSTMENT ADJUSTMENT CONDITIONMEASUREMENT

VALUEUNIT LOCATION

Set to square wave form

5 - 6

*The output level of the standard signal generator (SSG) is indicated as the SSG’s open circuit.

SOFTWARE ADJUSTMENT – continuedSelect an operation using [↑] / [↓] keys, then set specified value using [←] / [→] keys on the connected computer keyboard.

Minimum distortionlevel

Push [ENTER] keyon the connectedcomputer keyboardto set “S3 level”.

Push [ENTER] keyon the connectedcomputer keyboardto set “S1 level”.

Set “SQL level” toclose squelch.

Then set “SQL level”at the point wherethe audio signalsjust appears.

1

1

2

1

• Operating freq. : 136.000 MHz• IF bandwidth : Wide• Connect a standard signal generator to

the antenna connector and set as:Frequency : 136.000 MHzLevel : 10 µV* (–87 dBm)Modulation : 1 kHzDeviation : ±3.5 kHz

• Receiving

• Operating freq. : 136.000 MHz• IF bandwidth : Wide• Connect an SSG to the antenna con-

nector and set as:Frequency : 136.000 MHzLevel : 14 µV* (–84 dBm)Modulation : 1 kHzDeviation : ±3.5 kHz

• Receiving

• Set an SSG as :Level : 0.45 µV* (–114 dBm)Modulation : 1 kHzDeviation : ±3.5 kHz

• Receiving

• Operating freq. : 155.000 MHz• IF bandwidth : Wide• Connect an SSG to the antenna con-

nector and set as:Frequency : 155.000 MHzLevel : 0.2 µV* (–121 dBm)Modulation : 1 kHzDeviation : ±3.5 kHz

• Receiving

RXSENSITIVITY[BPF T1] – [BPF T4]

S-METER[S-METER]

SQUELCHLEVEL[SQL]

MAIN

MAIN

Frontpanel

Connect a SINAD meter with an8 Ω load to the multi connectorthrough the JIG cable (*OPC-966).

Internal speaker

ADJUSTMENT ADJUSTMENT CONDITIONMEASUREMENT

VALUEUNIT LOCATION

CONVENIENT:The BPF T1–BPF T4 can be adjusted automatically.q-1: Set the cursol to “BPF ALL” on the adjustment program and then push [ENTER] key.q-2: The connected PC tunes BPF T1–BPF T4 to peak levels.

orw-1: Set the cursol to one of BPF T1, T2, T3, or T4 as desired.w-2: Push [ENTER] key to start tuning.w-3: Repeat w-1 and w-2 to perform additional BPF tuning.

[GT]: IC-F30GT/F31GT, [GS]: IC-F30GS/F31GS, [F30G]: IC-F30GT/F30GS, [F31G]: IC-F31GT/F31GS[IS]: Intrinsically safe version

[FRONT UNIT][FRONT UNIT]

*=Safety critical components S.=Surface mount

IC1 1130009860 S.IC TC74VHC373FT (EL)IC2 1110002750 S.IC TA75S01F (TE85R)

Q1 1530002850 S.TRANSISTOR 2SC4116-BL (TE85R)Q2 1530002850 S.TRANSISTOR 2SC4116-BL (TE85R)Q3 1590002150 S.TRANSISTOR DTC144TE TLQ4 1590002150 S.TRANSISTOR DTC144TE TLQ5 1590002150 S.TRANSISTOR DTC144TE TLQ6 1560001130 S.FET CPH3403-TLQ7 1560001130 S.FET CPH3403-TLQ8 1530002060 S.TRANSISTOR 2SC4081 T106 RQ9 1590000430 S.TRANSISTOR DTC144EUA T106

D1 1790001280 S.DIODE MA111 (TX)D2 1790001280 S.DIODE MA111 (TX)D3 1790001200 S.DIODE MA6S121 (TX)D4 1790001280 S.DIODE MA111 (TX)

R1 7030007300 S.RESISTOR ERJ2GEJ 332 X (3.3 kΩ)R2 7030005030 S.RESISTOR ERJ2GEJ 152 X (1.5 kΩ)R3 7030007250 S.RESISTOR ERJ2GEJ 220 X (22 Ω)R4 7030009150 S.RESISTOR ERJ2GEJ 824 X (820 kΩ)R5 7030009150 S.RESISTOR ERJ2GEJ 824 X (820 kΩ)R6 7030006610 S.RESISTOR ERJ2GEJ 394 X (390 kΩ)R7 7030008310 S.RESISTOR ERJ2GEJ 564 X (560 kΩ)R8 7030008370 S.RESISTOR ERJ2GEJ 561 X (560 Ω)R9 7030004990 S.RESISTOR ERJ2GEJ 221 X (220 Ω)R10 7030005030 S.RESISTOR ERJ2GEJ 152 X (1.5 kΩ)R11 7030007300 S.RESISTOR ERJ2GEJ 332 X (3.3 kΩ)R12 7030005060 S.RESISTOR ERJ2GEJ 333 X (33 kΩ)R13 7030007280 S.RESISTOR ERJ2GEJ 331 X (330 Ω)R14 7030005090 S.RESISTOR ERJ2GEJ 104 X (100 kΩ)R17 7030005090 S.RESISTOR ERJ2GEJ 104 X (100 kΩ)R18 7410000750 S.ARRAY EXB-V4V 104JV (100 kΩ)R20 7030005170 S.RESISTOR ERJ2GEJ 474 X (470 kΩ)R21 7030005090 S.RESISTOR ERJ2GEJ 104 X (100 kΩ)R22 7030005170 S.RESISTOR ERJ2GEJ 474 X (470 kΩ)R23 7030005050 S.RESISTOR ERJ2GEJ 103 X (10 kΩ)R24 7030005240 S.RESISTOR ERJ2GEJ 473 X (47 kΩ)R25 7030008300 S.RESISTOR ERJ2GEJ 184 X (180 kΩ)R26 7030007340 S.RESISTOR ERJ2GEJ 153 X (15 kΩ)R27 7030008010 S.RESISTOR ERJ2GEJ 123 X (12 kΩ)

C1 4030016930 S.CERAMIC ECJ0EB1A104KC2 4030016930 S.CERAMIC ECJ0EB1A104KC3 4030016930 S.CERAMIC ECJ0EB1A104KC4* 4550006150 S.TANTALUM ECST1CY105RC6* 4550006150 S.TANTALUM ECST1CY105RC7* 4550006150 S.TANTALUM ECST1CY105RC8* 4550006150 S.TANTALUM ECST1CY105RC9* 4550006150 S.TANTALUM ECST1CY105RC10* 4550006150 S.TANTALUM ECST1CY105RC11* 4550006150 S.TANTALUM ECST1CY105RC12 4030014180 S.CERAMIC ECUE1H470JCQC13 4030014180 S.CERAMIC ECUE1H470JCQC14 4030014180 S.CERAMIC ECUE1H470JCQC15 4030014180 S.CERAMIC ECUE1H470JCQC16 4030013850 S.CERAMIC ECUE1E102KBQC17 4030014180 S.CERAMIC ECUE1H470JCQC18 4030014180 S.CERAMIC ECUE1H470JCQC19 4030016930 S.CERAMIC ECJ0EB1A104KC20 4030014180 S.CERAMIC ECUE1H470JCQC21* 4550006150 S.TANTALUM ECST1CY105RC22 4030016930 S.CERAMIC ECJ0EB1A104KC23* 4550006150 S.TANTALUM ECST1CY105RC24 4030016790 S.CERAMIC ECJ0EB1C103KC25 4030014180 S.CERAMIC ECUE1H470JCQC26 4030016930 S.CERAMIC ECJ0EB1A104KC27 4030017230 S.CERAMIC ECUE1E271KBQC28 4030016790 S.CERAMIC ECJ0EB1C103KC29 4030013850 S.CERAMIC ECUE1E102KBQC30 4030016930 S.CERAMIC ECJ0EB1A104K

J1 6510022360 S.CONNECTOR 26FLZ-SM1-TBJ2 6510022200 S.CONNECTOR 40FLZ-SM1-R-TB

DS1 5010000160 S.LED LNJ310M6URADS2 5010000160 S.LED LNJ310M6URADS3 5010000160 S.LED LNJ310M6URADS4 5010000160 S.LED LNJ310M6URADS5 5040002170 S.LED LNJ210C6ARADS6 5010000120 S.LED LN1371G-(TR) [GT]DS7 5010000120 S.LED LN1371G-(TR) [GT]DS8 5010000120 S.LED LN1371G-(TR) [GT]DS9 5010000120 S.LED LN1371G-(TR) [GT]DS10 5030001870 LCD EDMMUD1FA0DS11 5010000120 S.LED LN1371G-(TR) [GT]DS12 5010000120 S.LED LN1371G-(TR) [GT]DS13 5010000160 S.LED LNJ310M6URADS14 5010000120 S.LED LN1371G-(TR) [GS]DS15 5010000120 S.LED LN1371G-(TR) [GS]

MC1 7700002310 MICROPHONE EM-140

S1 2230001060 S.SWITCH EVQ-PUL 02KS2 2230001060 S.SWITCH EVQ-PUL 02KS3 2230001060 S.SWITCH EVQ-PUL 02KS4 2230001060 S.SWITCH EVQ-PUL 02KS5 2230001060 S.SWITCH EVQ-PUL 02K

SP1* 2510001060 SPEAKER K036NA500-47

W1 7120000470 JUMPER ERDS2T0W3 7030003860 S.JUMPER ERJ3GE JPW V

EP1 0910055257 PCB B 5489G

6 - 1

SECTION 6 PARTS LIST

REF ORDER DESCRIPTIONNO. NO.REF ORDER DESCRIPTIONNO. NO.


[MAIN UNIT][MAIN UNIT]

IC1 1130009130 S.IC SA7025DK-TIC2 1130008560 S.IC TC75S51F (TE85L)IC3 1110003490 S.IC TA31136FN (D, EL)IC4 1130008560 S.IC TC75S51F (TE85L)IC5 1110001810 S.IC TA7368F (TP1)IC7 1110003780 S.IC NJM2902V-TE1IC9 1130009330 S.IC TC35453F (BR, DRY)IC12 1110003390 S.IC AN8005M-(E1)IC13 1190001350 S.IC M62364FP 600DIC14 1140010140 S.IC HD64F2238BFA13IC15 1110005770 S.IC S-80942CNMC-G9C-T2IC16 1140008650 S.IC HN58X2464TIIC17 1130009700 S.IC LC73872M-TRMIC18 1110002750 S.IC TA75S01F (TE85R)IC19 1130008230 S.IC BU4053BCFV-E2IC20 1110003800 S.IC NJM2904V-TE1IC23 1130007570 S.IC BU4094BCFV-E2IC24 1140008650 S.IC HN58X2464TIIC27 1190001340 S.IC M62334FP 600CIC29 1130008230 S.IC BU4053BCFV-E2IC30 1130007020 S.IC TC7S66FU (TE85R)IC31 1130008560 S.IC TC75S51F (TE85L)

Q1 1560001050 S.FET 2SK2974Q2 1560001020 S.FET 2SK2973 (MTS101P)Q3 1530002920 S.TRANSISTOR 2SC4226-T1 R25Q6 1530002600 S.TRANSISTOR 2SC4215-O (TE85R)Q7 1530002600 S.TRANSISTOR 2SC4215-O (TE85R)Q8 1530002600 S.TRANSISTOR 2SC4215-O (TE85R)Q9 1590000430 S.TRANSISTOR DTC144EUA T106Q10 1590001400 S.TRANSISTOR XP1214 (TX)Q11 1530002920 S.TRANSISTOR 2SC4226-T1 R25Q12 1530002920 S.TRANSISTOR 2SC4226-T1 R25Q13 1590001190 S.TRANSISTOR XP6501-(TX) .ABQ14 1560000540 S.FET 2SK880-Y (TE85R)Q15 1530002690 S.TRANSISTOR 2SC4116-GR (TE85R)Q16 1590000720 S.TRANSISTOR DTA144EUA T106Q17 1530002690 S.TRANSISTOR 2SC4116-GR (TE85R)Q18 1530002600 S.TRANSISTOR 2SC4215-O (TE85R)Q19 1580000430 S.FET 3SK206-T1 U78Q20 1580000730 S.FET 3SK293 (TE85L)Q21 1560000840 S.FET 2SK1829 (TE85R)Q22 1590000720 S.TRANSISTOR DTA144EUA T106Q23 1520000460 S.TRANSISTOR 2SB1132 T100 RQ24 1590001190 S.TRANSISTOR XP6501-(TX) .ABQ26 1590000430 S.TRANSISTOR DTC144EUA T106Q27 1530003090 S.TRANSISTOR 2SC4213-B (TE85R)Q29 1510000580 S.TRANSISTOR 2SA1362-GR (TE85R)Q30 1510000580 S.TRANSISTOR 2SA1362-GR (TE85R)Q31 1510000580 S.TRANSISTOR 2SA1362-GR (TE85R)Q32 1520000460 S.TRANSISTOR 2SB1132 T100 RQ33 1590001190 S.TRANSISTOR XP6501-(TX) .ABQ39 1530002690 S.TRANSISTOR 2SC4116-GR (TE85R)Q40 1590001400 S.TRANSISTOR XP1214 (TX)Q41 1590000430 S.TRANSISTOR DTC144EUA T106Q43 1530002690 S.TRANSISTOR 2SC4116-GR (TE85R)Q44 1590000430 S.TRANSISTOR DTC144EUA T106Q45 1590002530 S.TRANSISTOR UN911H (TX)Q46 1590000430 S.TRANSISTOR DTC144EUA T106Q47 1530002690 S.TRANSISTOR 2SC4116-GR (TE85R)

D1 1790000620 S.DIODE MA77 (TX)D2 1790000650 S.DIODE MA713 (TX)D4 1790000620 S.DIODE MA77 (TX)D5 1790000620 S.DIODE MA77 (TX)D6 1750000710 S.VARICAP HVC350BTRFD7 1720000400 S.VARICAP 1SV245 (TPH3)D8 1750000710 S.VARICAP HVC350BTRFD10 1160000060 S.DIODE DAN202U T106D13 1160000050 S.DIODE DAP202U T106D14 1160000050 S.DIODE DAP202U T106D15 1160000060 S.DIODE DAN202U T106D16 1160000060 S.DIODE DAN202U T106D18 1750000710 S.VARICAP HVC350BTRFD19 1750000710 S.VARICAP HVC350BTRFD20 1750000710 S.VARICAP HVC350BTRFD21 1750000710 S.VARICAP HVC350BTRFD22 1790001250 S.DIODE MA2S111-(TX)D23 1790001250 S.DIODE MA2S111-(TX)D24 1790000620 S.DIODE MA77 (TX)

D25 1790000620 S.DIODE MA77 (TX)D26 1790001250 S.DIODE MA2S111-(TX)D27 1790000620 S.DIODE MA77 (TX)D29 1790001250 S.DIODE MA2S111-(TX)D30 1730002360 S.ZENER MA8062-M (TX)D31 1790001250 S.DIODE MA2S111-(TX)D33 1790001250 S.DIODE MA2S111-(TX)D34 1790000950 S.ZENER MA8056-M (TX)D35 1790000950 S.ZENER MA8056-M (TX)D36 1790000950 S.ZENER MA8056-M (TX)D38 1790001250 S.DIODE MA2S111-(TX)D39 1730002260 S.ZENER MA8030-H (TX)D40 1750000710 S.VARICAP HVC350BTRFD41 1750000710 S.VARICAP HVC350BTRFD42 1750000710 S.VARICAP HVC350BTRFD43 1750000710 S.VARICAP HVC350BTRFD44 1750000710 S.VARICAP HVC350BTRFD45 1750000710 S.VARICAP HVC350BTRFD46 1790000980 S.DIODE MA742 (TX)D47 1730002270 S.ZENER MA8024 (TX)

FI1 2010002510 S.XTAL FL-322 (31.650 MHz)FI2 2020001490 S.CERAMIC SFPCA450KE4A-R1FI3 2020001080 S.CERAMIC SFPCA450KG1A-R1FI4 2040001440 S.LC NFE31PT152Z1E9L

X1 6050010960 S.XTAL CR-667 (15.600 MHz)X2 6070000190 S.DISCRIMINATOR CDBCB450KCAY24-R0X3 6050011000 S.XTAL CR-681 (12.288 MHz)X4 6050009910 S.XTAL CR-563 (3.579545 MHz)

L1 6200008580 S.COIL 0.30-1.4-6TL 32NL2 6200008150 S.COIL 0.35-1.6-7TL 44NL3 6200008280 S.COIL 0.30-1.7-7TL 50NL4 6200002960 S.COIL NL 322522T-4R7J-3L5 6200008280 S.COIL 0.30-1.7-7TL 50NL7 6200008490 S.COIL 0.30-0.9-3TR 7.5NL8 6200008330 S.COIL 0.45-1.4-4TL 15NL9 6200003590 S.COIL EXCCL3225U1L10 6200009450 S.COIL 0.20-1.0-6TL 25NL13 6200007690 S.COIL LQW2BHN18NJ01LL14 6200003590 S.COIL EXCCL3225U1L15 6200005690 S.COIL ELJRE 18NG-FL17 6200006980 S.COIL ELJRE R10G-FL18 6200006980 S.COIL ELJRE R10G-FL19 6200007170 S.COIL MLF1608A 3R3K-TL20 6200008190 S.COIL 0.25-1.9-8TL 80NL21 6200005540 S.COIL ELJNC R47K-FL22 6200004950 S.COIL NL 252018T-1R8JL23 6200008390 S.COIL 0.25-1.9-9TLL24 6200005540 S.COIL ELJNC R47K-FL25 6200004950 S.COIL NL 252018T-1R8JL26 6200004950 S.COIL NL 252018T-1R8JL27 6200004950 S.COIL NL 252018T-1R8JL28 6200004950 S.COIL NL 252018T-1R8JL29 6200005720 S.COIL ELJRE 33NG-FL31 6200002790 S.COIL ELJFC R82M-FL33 6200007750 S.COIL LQW2BHN56NJ01LL35 6200001980 S.COIL NL 252018T-1R0JL36 6200007750 S.COIL LQW2BHN56NJ01LL37 6200007750 S.COIL LQW2BHN56NJ01LL38 6200007750 S.COIL LQW2BHN56NJ01LL39 6200009290 S.COIL LQW18AN47NG00DL40 6200009290 S.COIL LQW18AN47NG00DL41 6200003590 S.COIL EXCCL3225U1L42 6200004950 S.COIL NL 252018T-1R8JL43 6200002860 S.COIL NL 252018T-4R7JL44 6200001980 S.COIL NL 252018T-1R0JL45 6200004660 S.COIL MLF1608A 1R8K-TL46 6200007170 S.COIL MLF1608A 3R3K-TL47 6200001980 S.COIL NL 252018T-1R0JL48 6200009460 S.COIL 0.25-1.9-7TL 67NL49 6200008390 S.COIL 0.25-1.9-9TLL50 6200006980 S.COIL ELJRE R10G-FL51 6200002150 S.COIL ELJNC 56NK-FL52 6200006980 S.COIL ELJRE R10G-FL53 6200003960 S.COIL MLF1608A 1R0K-T

6 - 2





R1 7030003670 S.RESISTOR ERJ3GEYJ 823 V (82 kΩ)R2 7030000280 S.RESISTOR MCR10EZHJ 150 Ω (151)R3 7030003480 S.RESISTOR ERJ3GEYJ 222 V (2.2 kΩ)R4 7030003480 S.RESISTOR ERJ3GEYJ 222 V (2.2 kΩ)R5 7030005040 S.RESISTOR ERJ2GEJ 472 X (4.7 kΩ)R6 7030005040 S.RESISTOR ERJ2GEJ 472 X (4.7 kΩ)R7 7030003240 S.RESISTOR ERJ3GEYJ 220 V (22 Ω)R8 7030008290 S.RESISTOR ERJ2GEJ 183 X (18 kΩ)R10 7030005590 S.RESISTOR ERJ2GEJ 680 X (68 Ω)R12 7030005050 S.RESISTOR ERJ2GEJ 103 X (10 kΩ)R14 7030005530 S.RESISTOR ERJ2GEJ 100 X (10 Ω)R15 7030007570 S.RESISTOR ERJ2GEJ 122X (1.2 kΩ)R16 7030005590 S.RESISTOR ERJ2GEJ 680 X (68 Ω)R17 7030007570 S.RESISTOR ERJ2GEJ 122X (1.2 kΩ)R18 7030004980 S.RESISTOR ERJ2GEJ 101 X (100 Ω)R19 7030005050 S.RESISTOR ERJ2GEJ 103 X (10 kΩ)R20 7030005120 S.RESISTOR ERJ2GEJ 102 X (1 kΩ)R21 7030004980 S.RESISTOR ERJ2GEJ 101 X (100 Ω)R22 7030005240 S.RESISTOR ERJ2GEJ 473 X (47 kΩ)R23 7030009320 S.RESISTOR ERJ2GEJ 4R7 X (4.7 Ω)R24 7030004990 S.RESISTOR ERJ2GEJ 221 X (220 Ω)R25 7030005070 S.RESISTOR ERJ2GEJ 683 X (68 kΩ)R26 7030004980 S.RESISTOR ERJ2GEJ 101 X (100 Ω)R28 7030005070 S.RESISTOR ERJ2GEJ 683 X (68 kΩ)R29 7030005050 S.RESISTOR ERJ2GEJ 103 X (10 kΩ)R30 7030008400 S.RESISTOR ERJ2GEJ 182 X (1.8 kΩ)R31 7030008410 S.RESISTOR ERJ2GEJ 392 X (3.9 kΩ)R32 7030007250 S.RESISTOR ERJ2GEJ 220 X (22 Ω)R33 7030007280 S.RESISTOR ERJ2GEJ 331 X (330 Ω)R34 7030008400 S.RESISTOR ERJ2GEJ 182 X (1.8 kΩ)R35 7030008410 S.RESISTOR ERJ2GEJ 392 X (3.9 kΩ)R36 7030005530 S.RESISTOR ERJ2GEJ 100 X (10 Ω)R37 7030009280 S.RESISTOR ERJ2GE 391 X (390 Ω)R38 7030007290 S.RESISTOR ERJ2GEJ 222 X (2.2 kΩ)R39 7030005530 S.RESISTOR ERJ2GEJ 100 X (10 Ω)R40 7030004980 S.RESISTOR ERJ2GEJ 101 X (100 Ω) [F30G]

7030005530 S.RESISTOR ERJ2GEJ 100 X (10 Ω) [F31G]R41 7030005110 S.RESISTOR ERJ2GEJ 224 X (220 kΩ)R42 7030005090 S.RESISTOR ERJ2GEJ 104 X (100 kΩ)R43 7030009270 S.RESISTOR ERJ2GEJ 821 X (820 Ω) [F30G]

7030005030 S.RESISTOR ERJ2GEJ 152 X (1.5 kΩ) [F31G]R44 7030005290 S.RESISTOR ERJ2GEJ 682 X (6.8 kΩ) [F30G]

7030005040 S.RESISTOR ERJ2GEJ 472 X (4.7 kΩ) [F31G]R45 7030005530 S.RESISTOR ERJ2GEJ 100 X (10 Ω)R46 7030005040 S.RESISTOR ERJ2GEJ 472 X (4.7 kΩ) [F30G]

7030008010 S.RESISTOR ERJ2GEJ 123 X (12 kΩ) [F31G]R47 7030005050 S.RESISTOR ERJ2GEJ 103 X (10 kΩ) [F30G]

7030009710 S.RESISTOR ERJ2GEJ 203 X (20 kΩ) [F31G]R48 7030005050 S.RESISTOR ERJ2GEJ 103 X (10 kΩ)R49 7030005290 S.RESISTOR ERJ2GEJ 682 X (6.8 kΩ)R50 7030005120 S.RESISTOR ERJ2GEJ 102 X (1 kΩ)R51 7030005050 S.RESISTOR ERJ2GEJ 103 X (10 kΩ)R52 7030004980 S.RESISTOR ERJ2GEJ 101 X (100 Ω)R53 7030005110 S.RESISTOR ERJ2GEJ 224 X (220 kΩ)R54 7030004980 S.RESISTOR ERJ2GEJ 101 X (100 Ω)R55 7030005220 S.RESISTOR ERJ2GEJ 223 X (22 kΩ)R57 7030009700 S.RESISTOR ERJ2GEJ 202 X (2 kΩ)R58 7410000950 S.ARRAY EXB-V8V 102JVR59 7030009700 S.RESISTOR ERJ2GEJ 202 X (2 kΩ)R60 7030005090 S.RESISTOR ERJ2GEJ 104 X (100 kΩ)R61 7030005110 S.RESISTOR ERJ2GEJ 224 X (220 kΩ)R62 7030007570 S.RESISTOR ERJ2GEJ 122X (1.2 kΩ)R63 7030005580 S.RESISTOR ERJ2GEJ 560 X (56 Ω)R64 7030005240 S.RESISTOR ERJ2GEJ 473 X (47 kΩ)R65 7030005240 S.RESISTOR ERJ2GEJ 473 X (47 kΩ)R66 7030005240 S.RESISTOR ERJ2GEJ 473 X (47 kΩ)R67 7030005090 S.RESISTOR ERJ2GEJ 104 X (100 kΩ)R69 7030005090 S.RESISTOR ERJ2GEJ 104 X (100 kΩ)R73 7030005090 S.RESISTOR ERJ2GEJ 104 X (100 kΩ)R75 7030005090 S.RESISTOR ERJ2GEJ 104 X (100 kΩ)R77 7030007340 S.RESISTOR ERJ2GEJ 153 X (15 kΩ)R78 7030005220 S.RESISTOR ERJ2GEJ 223 X (22 kΩ)R79 7030008010 S.RESISTOR ERJ2GEJ 123 X (12 kΩ)R80 7030005220 S.RESISTOR ERJ2GEJ 223 X (22 kΩ)R81 7030009320 S.RESISTOR ERJ2GEJ 4R7 X (4.7 Ω)R82 7030007340 S.RESISTOR ERJ2GEJ 153 X (15 kΩ)R85 7030007280 S.RESISTOR ERJ2GEJ 331 X (330 Ω)R86 7030005080 S.RESISTOR ERJ2GEJ 823 X (82 kΩ)R87 7030008410 S.RESISTOR ERJ2GEJ 392 X (3.9 kΩ)R88 7030005240 S.RESISTOR ERJ2GEJ 473 X (47 kΩ)R89 7030005030 S.RESISTOR ERJ2GEJ 152 X (1.5 kΩ)R90 7030004970 S.RESISTOR ERJ2GEJ 470 X (47 Ω)

R91 7030005050 S.RESISTOR ERJ2GEJ 103 X (10 kΩ)R92 7030005240 S.RESISTOR ERJ2GEJ 473 X (47 kΩ)R93 7030005240 S.RESISTOR ERJ2GEJ 473 X (47 kΩ)R94 7030007300 S.RESISTOR ERJ2GEJ 332 X (3.3 kΩ)R95 7030009320 S.RESISTOR ERJ2GEJ 4R7 X (4.7 Ω)R96 7030008410 S.RESISTOR ERJ2GEJ 392 X (3.9 kΩ)R97 7030005010 S.RESISTOR ERJ2GEJ 681 X (680 Ω)R98 7030005090 S.RESISTOR ERJ2GEJ 104 X (100 kΩ)R99 7030005120 S.RESISTOR ERJ2GEJ 102 X (1 kΩ)R102 7030008280 S.RESISTOR ERJ2GEJ 271 X (270 Ω)R103 7030004990 S.RESISTOR ERJ2GEJ 221 X (220 Ω)R105 7030005040 S.RESISTOR ERJ2GEJ 472 X (4.7 kΩ)R109 7030004980 S.RESISTOR ERJ2GEJ 101 X (100 Ω)R110 7030005040 S.RESISTOR ERJ2GEJ 472 X (4.7 kΩ)R111 7030005100 S.RESISTOR ERJ2GEJ 154 X (150 kΩ)R112 7030005050 S.RESISTOR ERJ2GEJ 103 X (10 kΩ)R113 7030005110 S.RESISTOR ERJ2GEJ 224 X (220 kΩ)R114 7030005050 S.RESISTOR ERJ2GEJ 103 X (10 kΩ)R115 7030005050 S.RESISTOR ERJ2GEJ 103 X (10 kΩ)R116 7030005090 S.RESISTOR ERJ2GEJ 104 X (100 kΩ)R117 7030008280 S.RESISTOR ERJ2GEJ 271 X (270 Ω)R118 7030005090 S.RESISTOR ERJ2GEJ 104 X (100 kΩ)R119 7030006610 S.RESISTOR ERJ2GEJ 394 X (390 kΩ)R120 7030007340 S.RESISTOR ERJ2GEJ 153 X (15 kΩ)R121 7030009320 S.RESISTOR ERJ2GEJ 4R7 X (4.7 Ω)R122 7030008400 S.RESISTOR ERJ2GEJ 182 X (1.8 kΩ)R123 7030005240 S.RESISTOR ERJ2GEJ 473 X (47 kΩ)R124 7030005170 S.RESISTOR ERJ2GEJ 474 X (470 kΩ)R125 7030005050 S.RESISTOR ERJ2GEJ 103 X (10 kΩ)R126 7030005090 S.RESISTOR ERJ2GEJ 104 X (100 kΩ)R127 7030004980 S.RESISTOR ERJ2GEJ 101 X (100 Ω)R128 7030005090 S.RESISTOR ERJ2GEJ 104 X (100 kΩ)R129 7030008410 S.RESISTOR ERJ2GEJ 392 X (3.9 kΩ)R130 7030005050 S.RESISTOR ERJ2GEJ 103 X (10 kΩ)R131 7030005230 S.RESISTOR ERJ2GEJ 334 X (330 kΩ)R132 7030008300 S.RESISTOR ERJ2GEJ 184 X (180 kΩ)R133 7030007290 S.RESISTOR ERJ2GEJ 222 X (2.2 kΩ)R134 7030003200 S.RESISTOR ERJ3GEYJ 100 V (10 Ω)R135 7030003200 S.RESISTOR ERJ3GEYJ 100 V (10 Ω)R136 7030005290 S.RESISTOR ERJ2GEJ 682 X (6.8 kΩ)R137 7030009140 S.RESISTOR ERJ2GEJ 272 X (2.7 kΩ)R138 7030007300 S.RESISTOR ERJ2GEJ 332 X (3.3 kΩ)R139 7030005120 S.RESISTOR ERJ2GEJ 102 X (1 kΩ)R140 7030005160 S.RESISTOR ERJ2GEJ 105 X (1 MΩ)R141 7030005070 S.RESISTOR ERJ2GEJ 683 X (68 kΩ)R150 7030005110 S.RESISTOR ERJ2GEJ 224 X (220 kΩ)R151 7030005100 S.RESISTOR ERJ2GEJ 154 X (150 kΩ)R152 7030005100 S.RESISTOR ERJ2GEJ 154 X (150 kΩ)R153 7030009320 S.RESISTOR ERJ2GEJ 4R7 X (4.7 Ω)R155 7030007350 S.RESISTOR ERJ2GEJ 393 X (39 kΩ)R157 7030005220 S.RESISTOR ERJ2GEJ 223 X (22 kΩ)R159 7030005090 S.RESISTOR ERJ2GEJ 104 X (100 kΩ)R161 7030005070 S.RESISTOR ERJ2GEJ 683 X (68 kΩ)R162 7030005070 S.RESISTOR ERJ2GEJ 683 X (68 kΩ)R163 7030005060 S.RESISTOR ERJ2GEJ 333 X (33 kΩ)R164 7030005110 S.RESISTOR ERJ2GEJ 224 X (220 kΩ)R165 7030005240 S.RESISTOR ERJ2GEJ 473 X (47 kΩ)R166 7030005050 S.RESISTOR ERJ2GEJ 103 X (10 kΩ)R167 7030005170 S.RESISTOR ERJ2GEJ 474 X (470 kΩ)R168 7030007350 S.RESISTOR ERJ2GEJ 393 X (39 kΩ)R171 7030005070 S.RESISTOR ERJ2GEJ 683 X (68 kΩ)R172 7030005070 S.RESISTOR ERJ2GEJ 683 X (68 kΩ)R173 7030005100 S.RESISTOR ERJ2GEJ 154 X (150 kΩ)R174 7030005600 S.RESISTOR ERJ2GEJ 273 X (27 kΩ)R175 7030009290 S.RESISTOR ERJ2GEJ 562 X (5.6 kΩ)R176 7030005720 S.RESISTOR ERJ2GEJ 563 X (56 kΩ)R177 7030008290 S.RESISTOR ERJ2GEJ 183 X (18 kΩ)R178 7030005600 S.RESISTOR ERJ2GEJ 273 X (27 kΩ)R179 7030005600 S.RESISTOR ERJ2GEJ 273 X (27 kΩ)R180 7030007340 S.RESISTOR ERJ2GEJ 153 X (15 kΩ)R181 7030005600 S.RESISTOR ERJ2GEJ 273 X (27 kΩ)R182 7030005600 S.RESISTOR ERJ2GEJ 273 X (27 kΩ)R183 7030005030 S.RESISTOR ERJ2GEJ 152 X (1.5 kΩ)R184 7030008010 S.RESISTOR ERJ2GEJ 123 X (12 kΩ)R185 7030005310 S.RESISTOR ERJ2GEJ 124 X (120 kΩ)R186 7030005070 S.RESISTOR ERJ2GEJ 683 X (68 kΩ)R187 7030005040 S.RESISTOR ERJ2GEJ 472 X (4.7 kΩ)R188 7030005090 S.RESISTOR ERJ2GEJ 104 X (100 kΩ)R189 7030005000 S.RESISTOR ERJ2GEJ 471 X (470 Ω)R190 7030005090 S.RESISTOR ERJ2GEJ 104 X (100 kΩ)R192 7030005090 S.RESISTOR ERJ2GEJ 104 X (100 kΩ)R193 7210003060 VARIABLE TP76N00N-15F-10KA-2251

6 - 3





R195 7030005040 S.RESISTOR ERJ2GEJ 472 X (4.7 kΩ)R196 7030005050 S.RESISTOR ERJ2GEJ 103 X (10 kΩ)R197 7030005040 S.RESISTOR ERJ2GEJ 472 X (4.7 kΩ)R198 7030005050 S.RESISTOR ERJ2GEJ 103 X (10 kΩ)R199 7030005040 S.RESISTOR ERJ2GEJ 472 X (4.7 kΩ)R200 7030005050 S.RESISTOR ERJ2GEJ 103 X (10 kΩ)R201 7030007290 S.RESISTOR ERJ2GEJ 222 X (2.2 kΩ)R202 7030005120 S.RESISTOR ERJ2GEJ 102 X (1 kΩ)R203 7030005050 S.RESISTOR ERJ2GEJ 103 X (10 kΩ)R206 7030004980 S.RESISTOR ERJ2GEJ 101 X (100 Ω)R207 7030005220 S.RESISTOR ERJ2GEJ 223 X (22 kΩ)R208 7030007340 S.RESISTOR ERJ2GEJ 153 X (15 kΩ)R209 7030005230 S.RESISTOR ERJ2GEJ 334 X (330 kΩ)R210 7030006610 S.RESISTOR ERJ2GEJ 394 X (390 kΩ)R211 7030007570 S.RESISTOR ERJ2GEJ 122X (1.2 kΩ)R212 7030003830 S.RESISTOR ERJ3GEYJ 185 V (1.8 MΩ)R215 7030005160 S.RESISTOR ERJ2GEJ 105 X (1 MΩ) [GT]

7030005090 S.RESISTOR ERJ2GEJ 104 X (100 kΩ) [GS]R216 7030005090 S.RESISTOR ERJ2GEJ 104 X (100 kΩ)

[GT] onlyR217 7030005000 S.RESISTOR ERJ2GEJ 471 X (470 Ω)R218 7030007350 S.RESISTOR ERJ2GEJ 393 X (39 kΩ)R219 7030005050 S.RESISTOR ERJ2GEJ 103 X (10 kΩ)R220 7030005090 S.RESISTOR ERJ2GEJ 104 X (100 kΩ)R221 7030005060 S.RESISTOR ERJ2GEJ 333 X (33 kΩ)R222 7030005090 S.RESISTOR ERJ2GEJ 104 X (100 kΩ)R223 7410000580 S.ARRAY EXB-V4V 224JV (220 kΩ)R224 7030005090 S.RESISTOR ERJ2GEJ 104 X (100 kΩ)R225 7030005090 S.RESISTOR ERJ2GEJ 104 X (100 kΩ)R226 7510001470 S.THERMISTOR NTCG20 4AG 473JTR227 7030005090 S.RESISTOR ERJ2GEJ 104 X (100 kΩ)R228 7030010080 S.RESISTOR ERJ2RHD 104 X (100 kΩ)R229 7030010080 S.RESISTOR ERJ2RHD 104 X (100 kΩ)R230 7030008010 S.RESISTOR ERJ2GEJ 123 X (12 kΩ)R231 7030008010 S.RESISTOR ERJ2GEJ 123 X (12 kΩ)R232 7030008010 S.RESISTOR ERJ2GEJ 123 X (12 kΩ)R233 7030005090 S.RESISTOR ERJ2GEJ 104 X (100 kΩ)R234 7030005050 S.RESISTOR ERJ2GEJ 103 X (10 kΩ)R235 7030005120 S.RESISTOR ERJ2GEJ 102 X (1 kΩ)R236 7410000950 S.ARRAY EXB-V8V 102JVR237 7410000950 S.ARRAY EXB-V8V 102JVR238 7410000950 S.ARRAY EXB-V8V 102JVR239 7410000950 S.ARRAY EXB-V8V 102JVR240 7410000770 S.ARRAY EXB-V4V 102JV (1 kΩ)R242 7410000700 S.ARRAY EXB-V8V 105JV (1 MΩ)R243 7410000900 S.ARRAY EXB-V4V 105JV (1 MΩ)R244 7410000950 S.ARRAY EXB-V8V 102JVR245 7410000770 S.ARRAY EXB-V4V 102JV (1 kΩ)R246 7410000950 S.ARRAY EXB-V8V 102JVR247 7410000950 S.ARRAY EXB-V8V 102JVR248 7030005120 S.RESISTOR ERJ2GEJ 102 X (1 kΩ)R249 7410000950 S.ARRAY EXB-V8V 102JVR250 7410000950 S.ARRAY EXB-V8V 102JVR251 7410000950 S.ARRAY EXB-V8V 102JVR252 7410000950 S.ARRAY EXB-V8V 102JVR253 7410000750 S.ARRAY EXB-V4V 104JV (100 kΩ)R254 7030008300 S.RESISTOR ERJ2GEJ 184 X (180 kΩ)R257 7030005220 S.RESISTOR ERJ2GEJ 223 X (22 kΩ)R258 7030005220 S.RESISTOR ERJ2GEJ 223 X (22 kΩ)R259 7030005240 S.RESISTOR ERJ2GEJ 473 X (47 kΩ)R260 7030005240 S.RESISTOR ERJ2GEJ 473 X (47 kΩ)R261 7030005240 S.RESISTOR ERJ2GEJ 473 X (47 kΩ)R262 7030009290 S.RESISTOR ERJ2GEJ 562 X (5.6 kΩ)R264 7030005000 S.RESISTOR ERJ2GEJ 471 X (470 Ω)R266 7030005240 S.RESISTOR ERJ2GEJ 473 X (47 kΩ)R267 7030005240 S.RESISTOR ERJ2GEJ 473 X (47 kΩ)R268 7030004980 S.RESISTOR ERJ2GEJ 101 X (100 Ω)R269 7030005310 S.RESISTOR ERJ2GEJ 124 X (120 kΩ)R270 7030008290 S.RESISTOR ERJ2GEJ 183 X (18 kΩ)R271 7030005110 S.RESISTOR ERJ2GEJ 224 X (220 kΩ)R272 7030005070 S.RESISTOR ERJ2GEJ 683 X (68 kΩ)R273 7030005220 S.RESISTOR ERJ2GEJ 223 X (22 kΩ)R274 7030005220 S.RESISTOR ERJ2GEJ 223 X (22 kΩ)R275 7030005220 S.RESISTOR ERJ2GEJ 223 X (22 kΩ)R276 7030004970 S.RESISTOR ERJ2GEJ 470 X (47 Ω)R277 7030005120 S.RESISTOR ERJ2GEJ 102 X (1 kΩ)R278 7030005120 S.RESISTOR ERJ2GEJ 102 X (1 kΩ)R279 7030005120 S.RESISTOR ERJ2GEJ 102 X (1 kΩ)R280 7030005120 S.RESISTOR ERJ2GEJ 102 X (1 kΩ)R281 7030005600 S.RESISTOR ERJ2GEJ 273 X (27 kΩ)R284 7030005120 S.RESISTOR ERJ2GEJ 102 X (1 kΩ)R285 7030005050 S.RESISTOR ERJ2GEJ 103 X (10 kΩ)

R288 7030005050 S.RESISTOR ERJ2GEJ 103 X (10 kΩ)R289 7030005090 S.RESISTOR ERJ2GEJ 104 X (100 kΩ)R291 7030005090 S.RESISTOR ERJ2GEJ 104 X (100 kΩ)R292 7030009290 S.RESISTOR ERJ2GEJ 562 X (5.6 kΩ)R293 7030005090 S.RESISTOR ERJ2GEJ 104 X (100 kΩ)R294 7030005240 S.RESISTOR ERJ2GEJ 473 X (47 kΩ)R295 7030005240 S.RESISTOR ERJ2GEJ 473 X (47 kΩ)R296 7030005240 S.RESISTOR ERJ2GEJ 473 X (47 kΩ)R297 7410000950 S.ARRAY EXB-V8V 102JVR298 7030005090 S.RESISTOR ERJ2GEJ 104 X (100 kΩ)R299 7030005120 S.RESISTOR ERJ2GEJ 102 X (1 kΩ)R307 7030005090 S.RESISTOR ERJ2GEJ 104 X (100 kΩ)R312 7030005220 S.RESISTOR ERJ2GEJ 223 X (22 kΩ)R313 7030005060 S.RESISTOR ERJ2GEJ 333 X (33 kΩ)R314 7030005060 S.RESISTOR ERJ2GEJ 333 X (33 kΩ)R315 7030005060 S.RESISTOR ERJ2GEJ 333 X (33 kΩ)R316 7030009140 S.RESISTOR ERJ2GEJ 272 X (2.7 kΩ)R317 7030005170 S.RESISTOR ERJ2GEJ 474 X (470 kΩ)R318 7030005060 S.RESISTOR ERJ2GEJ 333 X (33 kΩ)R321 7030007290 S.RESISTOR ERJ2GEJ 222 X (2.2 kΩ)R322 7410000710 S.ARRAY EXB-V8V 224JV (220 kΩ)R323 7030005090 S.RESISTOR ERJ2GEJ 104 X (100 kΩ)R324 7030005000 S.RESISTOR ERJ2GEJ 471 X (470 Ω)R325 7030005050 S.RESISTOR ERJ2GEJ 103 X (10 kΩ)R327 7030004970 S.RESISTOR ERJ2GEJ 470 X (47 Ω)R328 7030005120 S.RESISTOR ERJ2GEJ 102 X (1 kΩ)R329 7030005050 S.RESISTOR ERJ2GEJ 103 X (10 kΩ)R330 7030009320 S.RESISTOR ERJ2GEJ 4R7 X (4.7 Ω)R331 7030005170 S.RESISTOR ERJ2GEJ 474 X (470 kΩ)R332 7030005090 S.RESISTOR ERJ2GEJ 104 X (100 kΩ)R333 7030005120 S.RESISTOR ERJ2GEJ 102 X (1 kΩ)R334 7030005040 S.RESISTOR ERJ2GEJ 472 X (4.7 kΩ)R336 7030005090 S.RESISTOR ERJ2GEJ 104 X (100 kΩ)R340 7030008300 S.RESISTOR ERJ2GEJ 184 X (180 kΩ)R341 7030005600 S.RESISTOR ERJ2GEJ 273 X (27 kΩ)R342 7030005120 S.RESISTOR ERJ2GEJ 102 X (1 kΩ)R343 7410000770 S.ARRAY EXB-V4V 102JV (1 kΩ)R344 7030005120 S.RESISTOR ERJ2GEJ 102 X (1 kΩ)R345 7030005120 S.RESISTOR ERJ2GEJ 102 X (1 kΩ)R347 7030009320 S.RESISTOR ERJ2GEJ 4R7 X (4.7 Ω)R349 7030005120 S.RESISTOR ERJ2GEJ 102 X (1 kΩ)R352 7030005050 S.RESISTOR ERJ2GEJ 103 X (10 kΩ)R354 7030008410 S.RESISTOR ERJ2GEJ 392 X (3.9 kΩ)R355 7030005240 S.RESISTOR ERJ2GEJ 473 X (47 kΩ)R356 7030008300 S.RESISTOR ERJ2GEJ 184 X (180 kΩ)R358 7030003210 S.RESISTOR ERJ3GEYJ 120 V (12 Ω)R359 7030005000 S.RESISTOR ERJ2GEJ 471 X (470 Ω)R360 7030005000 S.RESISTOR ERJ2GEJ 471 X (470 Ω)R361 7030005000 S.RESISTOR ERJ2GEJ 471 X (470 Ω)R362 7030009290 S.RESISTOR ERJ2GEJ 562 X (5.6 kΩ)R363 7030005090 S.RESISTOR ERJ2GEJ 104 X (100 kΩ)R364 7030005090 S.RESISTOR ERJ2GEJ 104 X (100 kΩ)R365 7030007350 S.RESISTOR ERJ2GEJ 393 X (39 kΩ)R366 7030005080 S.RESISTOR ERJ2GEJ 823 X (82 kΩ)R367 7030005030 S.RESISTOR ERJ2GEJ 152 X (1.5 kΩ)R368 7030006610 S.RESISTOR ERJ2GEJ 394 X (390 kΩ)R369 7030008300 S.RESISTOR ERJ2GEJ 184 X (180 kΩ)R370 7030005240 S.RESISTOR ERJ2GEJ 473 X (47 kΩ)R371 7030005220 S.RESISTOR ERJ2GEJ 223 X (22 kΩ)R372 7030005060 S.RESISTOR ERJ2GEJ 333 X (33 kΩ)R373 7030005040 S.RESISTOR ERJ2GEJ 472 X (4.7 kΩ)R374 7030005240 S.RESISTOR ERJ2GEJ 473 X (47 kΩ)R375 7030005040 S.RESISTOR ERJ2GEJ 472 X (4.7 kΩ)R376 7030005120 S.RESISTOR ERJ2GEJ 102 X (1 kΩ)

C1 4030007070 S.CERAMIC C1608 CH 1H 330J-TC2 4030007070 S.CERAMIC C1608 CH 1H 330J-TC3 4030007040 S.CERAMIC C1608 CH 1H 180J-TC4 4030006860 S.CERAMIC C1608 JB 1H 102K-TC5 4030013850 S.CERAMIC ECUE1E102KBQC6 4030013850 S.CERAMIC ECUE1E102KBQC7 4030014180 S.CERAMIC ECUE1H470JCQC8 4030006860 S.CERAMIC C1608 JB 1H 102K-TC9 4030007050 S.CERAMIC C1608 CH 1H 220J-TC12 4030007050 S.CERAMIC C1608 CH 1H 220J-TC14 4030007100 S.CERAMIC C1608 CH 1H 560J-TC16* 4030008680 S.CERAMIC C2012 JF 1C 105Z-TC17 4030013850 S.CERAMIC ECUE1E102KBQC18 4030013850 S.CERAMIC ECUE1E102KBQC19 4030007150 S.CERAMIC C1608 CH 1H 151J-TC20 4030013850 S.CERAMIC ECUE1E102KBQ

6 - 4




C21 4030014220 S.CERAMIC ECUE1E471KBQC22 4030013850 S.CERAMIC ECUE1E102KBQC23* 4550006660 S.TANTALUM ECST1CC226RC24 4030014220 S.CERAMIC ECUE1E471KBQC26 4030013850 S.CERAMIC ECUE1E102KBQC27 4030013850 S.CERAMIC ECUE1E102KBQC28 4030014180 S.CERAMIC ECUE1H470JCQC29 4030013850 S.CERAMIC ECUE1E102KBQC30 4030016930 S.CERAMIC ECJ0EB1A104KC31 4030016930 S.CERAMIC ECJ0EB1A104KC34 4030006860 S.CERAMIC C1608 JB 1H 102K-TC35 4030013850 S.CERAMIC ECUE1E102KBQC36 4030014180 S.CERAMIC ECUE1H470JCQC37 4030013850 S.CERAMIC ECUE1E102KBQC38 4030013850 S.CERAMIC ECUE1E102KBQC39 4030014240 S.CERAMIC ECUE1H180JCQC42 4030013850 S.CERAMIC ECUE1E102KBQC43 4030013850 S.CERAMIC ECUE1E102KBQC46 4030014240 S.CERAMIC ECUE1H180JCQC47 4030013850 S.CERAMIC ECUE1E102KBQC48 4030014100 S.CERAMIC ECUE1H070CCQC49 4030014130 S.CERAMIC ECUE1H120JCQC50 4030014020 S.CERAMIC ECUE1H020BCQC51 4030013850 S.CERAMIC ECUE1E102KBQC52 4030013850 S.CERAMIC ECUE1E102KBQC53 4030014180 S.CERAMIC ECUE1H470JCQC54 4030014220 S.CERAMIC ECUE1E471KBQC55 4030016790 S.CERAMIC ECJ0EB1C103KC56 4030016820 S.CERAMIC ECUE1HR75BCQC57 4030014130 S.CERAMIC ECUE1H120JCQC58 4030014130 S.CERAMIC ECUE1H120JCQC59 4030007090 S.CERAMIC C1608 CH 1H 470J-TC61 4030014150 S.CERAMIC ECUE1H220JCQC62* 4550006700 S.TANTALUM ECST1AY106RC63* 4550006700 S.TANTALUM ECST1AY106RC64 4030013850 S.CERAMIC ECUE1E102KBQC65 4030014220 S.CERAMIC ECUE1E471KBQC66 4030014420 S.CERAMIC ECUE1H0R5BCQC67 4030014130 S.CERAMIC ECUE1H120JCQC68 4030014240 S.CERAMIC ECUE1H180JCQC69 4030007050 S.CERAMIC C1608 CH 1H 220J-TC70 4030014070 S.CERAMIC ECUE1H040BCQC71 4030016820 S.CERAMIC ECUE1HR75BCQC72 4030014440 S.CERAMIC ECUE1H820JCQC73 4030014180 S.CERAMIC ECUE1H470JCQC74 4550006810 S.TANTALUM ECST1VY473RC76 4030007130 S.CERAMIC C1608 CH 1H 101J-TC77 4550006360 S.TANTALUM ECST1VY104R [F30G]

4550006130 S.TANTALUM ECST1VY224R [F31G]C78 4030013850 S.CERAMIC ECUE1E102KBQC79 4030016930 S.CERAMIC ECJ0EB1A104K [F30G]

4030013850 S.CERAMIC ECUE1E102KBQ [F31G]C80 4030016930 S.CERAMIC ECJ0EB1A104KC81 4030014180 S.CERAMIC ECUE1H470JCQC82 4030014120 S.CERAMIC ECUE1H100CCQC83 4030016790 S.CERAMIC ECJ0EB1C103KC84 4030014130 S.CERAMIC ECUE1H120JCQC85 4030014030 S.CERAMIC ECUE1H2R5BCQC86 4030014080 S.CERAMIC ECUE1H050BCQC87 4030014050 S.CERAMIC ECUE1H030BCQC88 4030013850 S.CERAMIC ECUE1E102KBQC89 4030014140 S.CERAMIC ECUE1H150JCQC90 4030014140 S.CERAMIC ECUE1H150JCQC91 4030014180 S.CERAMIC ECUE1H470JCQC95 4030014180 S.CERAMIC ECUE1H470JCQC96 4030014180 S.CERAMIC ECUE1H470JCQC97 4030014180 S.CERAMIC ECUE1H470JCQC98 4030016790 S.CERAMIC ECJ0EB1C103KC99 4030014180 S.CERAMIC ECUE1H470JCQC100 4030013850 S.CERAMIC ECUE1E102KBQC101 4030013850 S.CERAMIC ECUE1E102KBQC102 4030016760 S.CERAMIC ECUE1E472KBQC103 4030014120 S.CERAMIC ECUE1H100CCQC104 4030016930 S.CERAMIC ECJ0EB1A104KC105 4030013850 S.CERAMIC ECUE1E102KBQC106 4030016930 S.CERAMIC ECJ0EB1A104KC107 4030014180 S.CERAMIC ECUE1H470JCQC108 4030014180 S.CERAMIC ECUE1H470JCQC109 4030016930 S.CERAMIC ECJ0EB1A104KC110 4030016930 S.CERAMIC ECJ0EB1A104KC111 4030014330 S.CERAMIC ECUE1H221JCQC112 4030014330 S.CERAMIC ECUE1H221JCQ

C113 4030016790 S.CERAMIC ECJ0EB1C103KC114 4030016930 S.CERAMIC ECJ0EB1A104KC115 4030013850 S.CERAMIC ECUE1E102KBQC116 4030014220 S.CERAMIC ECUE1E471KBQC117 4030013850 S.CERAMIC ECUE1E102KBQC118 4030013850 S.CERAMIC ECUE1E102KBQC119 4030013850 S.CERAMIC ECUE1E102KBQC120 4030013850 S.CERAMIC ECUE1E102KBQC121 4030016930 S.CERAMIC ECJ0EB1A104KC122 4030014180 S.CERAMIC ECUE1H470JCQC123 4030014200 S.CERAMIC ECUE1H101JCQC124* 4550006700 S.TANTALUM ECST1AY106RC125 4030014200 S.CERAMIC ECUE1H101JCQC126 4030014220 S.CERAMIC ECUE1E471KBQC127* 4550006170 S.TANTALUM ECST1AY225RC128 4030014100 S.CERAMIC ECUE1H070CCQC130 4030013850 S.CERAMIC ECUE1E102KBQC131 4030014160 S.CERAMIC ECUE1H270JCQC132 4030016790 S.CERAMIC ECJ0EB1C103KC133 4030013850 S.CERAMIC ECUE1E102KBQC134 4030013850 S.CERAMIC ECUE1E102KBQC135 4030014080 S.CERAMIC ECUE1H050BCQC137 4030014090 S.CERAMIC ECUE1H060CCQC138 4030013850 S.CERAMIC ECUE1E102KBQC139 4030013850 S.CERAMIC ECUE1E102KBQC140 4030014000 S.CERAMIC ECUE1H1R5BCQC141 4030013850 S.CERAMIC ECUE1E102KBQC142 4030013850 S.CERAMIC ECUE1E102KBQC143 4030014100 S.CERAMIC ECUE1H070CCQC145 4030013850 S.CERAMIC ECUE1E102KBQC146 4030013850 S.CERAMIC ECUE1E102KBQC147 4030013850 S.CERAMIC ECUE1E102KBQC148 4030013850 S.CERAMIC ECUE1E102KBQC149 4030014220 S.CERAMIC ECUE1E471KBQC150 4030014180 S.CERAMIC ECUE1H470JCQC151 4030013850 S.CERAMIC ECUE1E102KBQC154 4030014180 S.CERAMIC ECUE1H470JCQC155 4030013850 S.CERAMIC ECUE1E102KBQC156 4030014080 S.CERAMIC ECUE1H050BCQC157 4550006140 S.TANTALUM ECST1EY474RC158 4030014180 S.CERAMIC ECUE1H470JCQC159 4030013850 S.CERAMIC ECUE1E102KBQC160 4030014100 S.CERAMIC ECUE1H070CCQC161 4030013850 S.CERAMIC ECUE1E102KBQC162 4030013850 S.CERAMIC ECUE1E102KBQC163 4030013980 S.CERAMIC ECUE1H010BCQC165 4030014070 S.CERAMIC ECUE1H040BCQC167 4030014090 S.CERAMIC ECUE1H060CCQC168 4030014110 S.CERAMIC ECUE1H080CCQC170 4030007000 S.CERAMIC C1608 CH 1H 090D-TC171 4030016790 S.CERAMIC ECJ0EB1C103KC172* 4550006540 S.TANTALUM ECST1CY475RC173 4030016790 S.CERAMIC ECJ0EB1C103KC174 4030013850 S.CERAMIC ECUE1E102KBQC175 4030016930 S.CERAMIC ECJ0EB1A104KC176 4030013850 S.CERAMIC ECUE1E102KBQC177 4030014220 S.CERAMIC ECUE1E471KBQC178* 4550006670 S.TANTALUM ECST1AD107RC179 4030016950 S.CERAMIC ECJ0EB1A473KC180 4030014180 S.CERAMIC ECUE1H470JCQC181* 4550006700 S.TANTALUM ECST1AY106RC182 4030016960 S.CERAMIC ECJ0EB1C183KC183 4030013850 S.CERAMIC ECUE1E102KBQC184* 4550006210 S.TANTALUM ECST1CX106RC185 4030016930 S.CERAMIC ECJ0EB1A104KC186 4030016930 S.CERAMIC ECJ0EB1A104KC187 4030014180 S.CERAMIC ECUE1H470JCQC188 4030014180 S.CERAMIC ECUE1H470JCQC189 4030013850 S.CERAMIC ECUE1E102KBQC192 4030016760 S.CERAMIC ECUE1E472KBQC193* 4550006620 S.TANTALUM ECST0JY226RC195 4030014220 S.CERAMIC ECUE1E471KBQC197 4030016790 S.CERAMIC ECJ0EB1C103KC198 4030016760 S.CERAMIC ECUE1E472KBQC199 4030014500 S.CERAMIC ECUE1H121JCQC200 4030014350 S.CERAMIC ECUE1H560JCQC202 4030017230 S.CERAMIC ECUE1E271KBQC203 4030016920 S.CERAMIC ECUE1H222KBQC205 4550006360 S.TANTALUM ECST1VY104RC206 4030016930 S.CERAMIC ECJ0EB1A104KC207 4030016930 S.CERAMIC ECJ0EB1A104KC208* 4550006320 S.TANTALUM ECST0JY475R

6 - 5


*=Safety critical components S.=Surface mount[GT]: IC-F30GT/F31GT, [GS]: IC-F30GS/F31GS, [F30G]: IC-F30GT/F30GS, [F31G]: IC-F31GT/F31GS[IS]: Intrinsically safe version


C213* 4550006320 S.TANTALUM ECST0JY475RC214 4550006360 S.TANTALUM ECST1VY104RC215 4030016930 S.CERAMIC ECJ0EB1A104KC216 4030016950 S.CERAMIC ECJ0EB1A473KC217 4030016930 S.CERAMIC ECJ0EB1A104KC218 4030016760 S.CERAMIC ECUE1E472KBQC219 4030014500 S.CERAMIC ECUE1H121JCQC224 4030016930 S.CERAMIC ECJ0EB1A104KC225 4030016950 S.CERAMIC ECJ0EB1A473KC226 4030016950 S.CERAMIC ECJ0EB1A473KC227 4030017040 S.CERAMIC ECJ0EB1A333KC228 4030014220 S.CERAMIC ECUE1E471KBQC229 4030014180 S.CERAMIC ECUE1H470JCQC230* 4550006700 S.TANTALUM ECST1AY106RC231 4030016760 S.CERAMIC ECUE1E472KBQC232 4030016920 S.CERAMIC ECUE1H222KBQC233 4030016930 S.CERAMIC ECJ0EB1A104KC234 4030014180 S.CERAMIC ECUE1H470JCQC235* 4550006620 S.TANTALUM ECST0JY226RC236* 4550006620 S.TANTALUM ECST0JY226RC237* 4550006620 S.TANTALUM ECST0JY226RC238* 4550006620 S.TANTALUM ECST0JY226RC239 4030016790 S.CERAMIC ECJ0EB1C103KC240 4030016790 S.CERAMIC ECJ0EB1C103KC241 4030016790 S.CERAMIC ECJ0EB1C103KC242* 4550006320 S.TANTALUM ECST0JY475RC243* 4550006950 S.TANTALUM ECST0JX476RC244 4030013850 S.CERAMIC ECUE1E102KBQC246 4030013850 S.CERAMIC ECUE1E102KBQC247* 4550006210 S.TANTALUM ECST1CX106RC248 4030016960 S.CERAMIC ECJ0EB1C183KC249 4030016960 S.CERAMIC ECJ0EB1C183KC250 4030014220 S.CERAMIC ECUE1E471KBQC251* 4550006170 S.TANTALUM ECST1AY225RC252 4030014220 S.CERAMIC ECUE1E471KBQC253 4030013850 S.CERAMIC ECUE1E102KBQC254* 4550006320 S.TANTALUM ECST0JY475RC257 4030016930 S.CERAMIC ECJ0EB1A104KC258 4030016930 S.CERAMIC ECJ0EB1A104KC259 4030016790 S.CERAMIC ECJ0EB1C103KC260 4030013850 S.CERAMIC ECUE1E102KBQC261 4030016930 S.CERAMIC ECJ0EB1A104KC262 4030014220 S.CERAMIC ECUE1E471KBQC263 4030016930 S.CERAMIC ECJ0EB1A104KC264* 4550006950 S.TANTALUM ECST0JX476RC265* 4550006950 S.TANTALUM ECST0JX476RC266 4030014220 S.CERAMIC ECUE1E471KBQC267 4030016790 S.CERAMIC ECJ0EB1C103KC268 4030016930 S.CERAMIC ECJ0EB1A104KC271 4030017030 S.CERAMIC ECJ0EB1A273KC272 4030014180 S.CERAMIC ECUE1H470JCQC273 4030014180 S.CERAMIC ECUE1H470JCQC275 4030014180 S.CERAMIC ECUE1H470JCQC276 4030014150 S.CERAMIC ECUE1H220JCQC277 4030014100 S.CERAMIC ECUE1H070CCQC278 4030016790 S.CERAMIC ECJ0EB1C103KC279 4030016790 S.CERAMIC ECJ0EB1C103KC280 4030014170 S.CERAMIC ECUE1H330JCQC281 4030016930 S.CERAMIC ECJ0EB1A104KC282 4030014180 S.CERAMIC ECUE1H470JCQC283 4030014180 S.CERAMIC ECUE1H470JCQC284 4030014180 S.CERAMIC ECUE1H470JCQC285 4030014180 S.CERAMIC ECUE1H470JCQC286 4030014180 S.CERAMIC ECUE1H470JCQC287 4030014180 S.CERAMIC ECUE1H470JCQC288 4030014180 S.CERAMIC ECUE1H470JCQC289 4030014180 S.CERAMIC ECUE1H470JCQC291 4030014180 S.CERAMIC ECUE1H470JCQC292 4030014180 S.CERAMIC ECUE1H470JCQC293 4030014180 S.CERAMIC ECUE1H470JCQC294 4030014180 S.CERAMIC ECUE1H470JCQC295 4030014180 S.CERAMIC ECUE1H470JCQC296 4030014180 S.CERAMIC ECUE1H470JCQC297 4030014180 S.CERAMIC ECUE1H470JCQC298 4030014180 S.CERAMIC ECUE1H470JCQC299 4030014180 S.CERAMIC ECUE1H470JCQC300 4030014180 S.CERAMIC ECUE1H470JCQC301 4030014180 S.CERAMIC ECUE1H470JCQC302 4030014180 S.CERAMIC ECUE1H470JCQC303 4030014180 S.CERAMIC ECUE1H470JCQC304 4030014180 S.CERAMIC ECUE1H470JCQC305 4030014180 S.CERAMIC ECUE1H470JCQ

C306 4030016930 S.CERAMIC ECJ0EB1A104KC307 4030014180 S.CERAMIC ECUE1H470JCQC308 4030014180 S.CERAMIC ECUE1H470JCQC309 4030014180 S.CERAMIC ECUE1H470JCQC310 4030014180 S.CERAMIC ECUE1H470JCQC311 4030014180 S.CERAMIC ECUE1H470JCQC312 4030014180 S.CERAMIC ECUE1H470JCQC313 4030014180 S.CERAMIC ECUE1H470JCQC314 4030014180 S.CERAMIC ECUE1H470JCQC315 4030014180 S.CERAMIC ECUE1H470JCQC316 4030016760 S.CERAMIC ECUE1E472KBQC317 4030016760 S.CERAMIC ECUE1E472KBQC318 4030016790 S.CERAMIC ECJ0EB1C103KC319 4030014180 S.CERAMIC ECUE1H470JCQC320 4030014180 S.CERAMIC ECUE1H470JCQC321 4030014180 S.CERAMIC ECUE1H470JCQC322 4030014180 S.CERAMIC ECUE1H470JCQC323 4030014180 S.CERAMIC ECUE1H470JCQC324 4030014180 S.CERAMIC ECUE1H470JCQC325 4030014180 S.CERAMIC ECUE1H470JCQC326 4030014180 S.CERAMIC ECUE1H470JCQC327 4030014180 S.CERAMIC ECUE1H470JCQC328 4030014180 S.CERAMIC ECUE1H470JCQC329 4030014180 S.CERAMIC ECUE1H470JCQC330 4030016930 S.CERAMIC ECJ0EB1A104KC331 4030014180 S.CERAMIC ECUE1H470JCQC332 4030014180 S.CERAMIC ECUE1H470JCQC333 4030014180 S.CERAMIC ECUE1H470JCQC334 4030014180 S.CERAMIC ECUE1H470JCQC335 4030014180 S.CERAMIC ECUE1H470JCQC336 4030014180 S.CERAMIC ECUE1H470JCQC337 4030014180 S.CERAMIC ECUE1H470JCQC338 4030014180 S.CERAMIC ECUE1H470JCQC339 4030014180 S.CERAMIC ECUE1H470JCQC340 4030014180 S.CERAMIC ECUE1H470JCQC341 4030014430 S.CERAMIC C1005 JB 1C 153K-T-AC342 4030016930 S.CERAMIC ECJ0EB1A104KC343 4030017250 S.CERAMIC ECUE1E821KBQC345 4030016790 S.CERAMIC ECJ0EB1C103KC346 4030017040 S.CERAMIC ECJ0EB1A333KC347 4030016930 S.CERAMIC ECJ0EB1A104KC348 4030016930 S.CERAMIC ECJ0EB1A104KC349 4030017240 S.CERAMIC ECUE1C682KBQC350 4030016790 S.CERAMIC ECJ0EB1C103KC351 4030016930 S.CERAMIC ECJ0EB1A104KC352 4030016940 S.CERAMIC ECJ0EB1A393KC353 4030013850 S.CERAMIC ECUE1E102KBQC354 4030013850 S.CERAMIC ECUE1E102KBQC355 4030013850 S.CERAMIC ECUE1E102KBQC356 4030014180 S.CERAMIC ECUE1H470JCQC357 4550006770 S.TANTALUM TEMSVD2 1C 476M-12R

except [IS]C358 4030014220 S.CERAMIC ECUE1E471KBQ except [IS]C359 4030013850 S.CERAMIC ECUE1E102KBQ except [IS]C360* 4030012600 S.CERAMIC C2012 JB 1A 105M-TC362 4030017220 S.CERAMIC ECUE1E122KBQC364 4030014180 S.CERAMIC ECUE1H470JCQC365 4030014180 S.CERAMIC ECUE1H470JCQC366 4030014180 S.CERAMIC ECUE1H470JCQC367 4030014180 S.CERAMIC ECUE1H470JCQC369 4030014110 S.CERAMIC ECUE1H080CCQC371 4030014180 S.CERAMIC ECUE1H470JCQC372 4610001590 S.TRIMMER TZC3R100A110R00C373 4610001590 S.TRIMMER TZC3R100A110R00C375 4030016930 S.CERAMIC ECJ0EB1A104KC376 4030013850 S.CERAMIC ECUE1E102KBQC377 4030014180 S.CERAMIC ECUE1H470JCQC378 4030016930 S.CERAMIC ECJ0EB1A104KC379 4030014180 S.CERAMIC ECUE1H470JCQC380 4030014180 S.CERAMIC ECUE1H470JCQC381 4030014180 S.CERAMIC ECUE1H470JCQC382 4030014180 S.CERAMIC ECUE1H470JCQC383 4030016930 S.CERAMIC ECJ0EB1A104KC384 4030013850 S.CERAMIC ECUE1E102KBQC385 4030016930 S.CERAMIC ECJ0EB1A104KC386 4030014180 S.CERAMIC ECUE1H470JCQC393* 4030012600 S.CERAMIC C2012 JB 1A 105M-TC394 4030016960 S.CERAMIC ECJ0EB1C183KC395 4030014190 S.CERAMIC ECUE1H680JCQC396* 4030012600 S.CERAMIC C2012 JB 1A 105M-TC397 4030016760 S.CERAMIC ECUE1E472KBQC398 4030016760 S.CERAMIC ECUE1E472KBQ

6 - 6


*=Safety critical components S.=Surface mount[GT]: IC-F30GT/F31GT, [GS]: IC-F30GS/F31GS, [F30G]: IC-F30GT/F30GS, [F31G]: IC-F31GT/F31GS[IS]: Intrinsically safe version

[MAIN UNIT]

C399 4030016760 S.CERAMIC ECUE1E472KBQC400 4030013850 S.CERAMIC ECUE1E102KBQC401 4030014180 S.CERAMIC ECUE1H470JCQC402* 4550006950 S.TANTALUM ECST0JX476RC403 4030006860 S.CERAMIC C1608 JB 1H 102K-TC404 4030014180 S.CERAMIC ECUE1H470JCQC405 4030014180 S.CERAMIC ECUE1H470JCQC406 4030013940 S.CERAMIC C1005 JB 1E 223K-T-NC407 4030016930 S.CERAMIC ECJ0EB1A104KC408 4030016930 S.CERAMIC ECJ0EB1A104KC409 4030016930 S.CERAMIC ECJ0EB1A104KC410 4030016930 S.CERAMIC ECJ0EB1A104KC411* 4550006320 S.TANTALUM ECST0JY475RC412 4030014180 S.CERAMIC ECUE1H470JCQC413 4030016930 S.CERAMIC ECJ0EB1A104KC414 4030016930 S.CERAMIC ECJ0EB1A104KC415* 4550006170 S.TANTALUM ECST1AY225RC416 4030007010 S.CERAMIC C1608 CH 1H 100D-TC417 4030007010 S.CERAMIC C1608 CH 1H 100D-TC418 4030009920 S.CERAMIC C1608 CH 1H 050B-TC419 4030009540 S.CERAMIC C1608 CH 1H 1R5B-TC420 4030013850 S.CERAMIC ECUE1E102KBQC421 4030016930 S.CERAMIC ECJ0EB1A104KC422 4030016930 S.CERAMIC ECJ0EB1A104KC423 4030016930 S.CERAMIC ECJ0EB1A104KC424 4030014220 S.CERAMIC ECUE1E471KBQC425 4030013850 S.CERAMIC ECUE1E102KBQC426 4030011810 S.CERAMIC C1608 JB 1A 224K-TC427* 4550006320 S.TANTALUM ECST0JY475RC428 4030016930 S.CERAMIC ECJ0EB1A104KC429 4030014180 S.CERAMIC ECUE1H470JCQC430 4030013850 S.CERAMIC ECUE1E102KBQC431 4030013850 S.CERAMIC ECUE1E102KBQC432 4030016930 S.CERAMIC ECJ0EB1A104KC433 4030014180 S.CERAMIC ECUE1H470JCQC434 4030016930 S.CERAMIC ECJ0EB1A104KC437 4030014090 S.CERAMIC ECUE1H060CCQC438 4030013850 S.CERAMIC ECUE1E102KBQC439 4030013850 S.CERAMIC ECUE1E102KBQC440 4030013850 S.CERAMIC ECUE1E102KBQC441 4030007090 S.CERAMIC C1608 CH 1H 470J-TC442* 4550006320 S.TANTALUM ECST0JY475RC443 4030013850 S.CERAMIC ECUE1E102KBQC444 4030014490 S.CERAMIC ECUE1H331KBQC445 4030013940 S.CERAMIC C1005 JB 1E 223K-T-NC446 4030017250 S.CERAMIC ECUE1E821KBQC447 4030017250 S.CERAMIC ECUE1E821KBQC448 4030016950 S.CERAMIC ECJ0EB1A473KC449 4030016930 S.CERAMIC ECJ0EB1A104KC450 4030016930 S.CERAMIC ECJ0EB1A104KC451 4030014180 S.CERAMIC ECUE1H470JCQC452 4030016930 S.CERAMIC ECJ0EB1A104KC453 4030014140 S.CERAMIC ECUE1H150JCQC454 4030014240 S.CERAMIC ECUE1H180JCQC455 4030016930 S.CERAMIC ECJ0EB1A104KC456 4030016930 S.CERAMIC ECJ0EB1A104KC457 4030014200 S.CERAMIC ECUE1H101JCQC458 4030016930 S.CERAMIC ECJ0EB1A104K

J1 6510018430 S.CONNECTOR AXN330C038PJ2 6510018430 S.CONNECTOR AXN330C038PJ3 6510022360 S.CONNECTOR 26FLZ-SM1-TB

F1 5210000710 S.FUSE KAB 2402 322 NA29

S1 2250000180 ENCODER EC10SP16-47

W2 7030003860 S.JUMPER ERJ3GE JPW VW3 7030003860 S.JUMPER ERJ3GE JPW VW4 7030003860 S.JUMPER ERJ3GE JPW VW5 8900009790 CABLE OPC-972

EP1 0910055243 PCB B 5511C

6 - 7

REF ORDER DESCRIPTIONNO. NO.

*=Safety critical componentsS.=Surface mount


7 - 1

SECTION 7 MECHANICAL PARTS AND DISASSEMBLY

MP1 8210017211 2337 front panel-1 assembly [GT] 18210017350 2337 S-front panel assembly [GS] 1

MP2 8310049450 2337 window plate 1MP4 8930052850 2337 release button 1MP5 8930052970 2337 PTT plate 1MP8 8210017100 2337 rear panel 1MP9 8210017080 2337 reflector 1MP10 8930052981 2337 switch plate-1 1MP12 8010018251 2337 chassis-1 1MP13 8930052640 2337 key board [GT] 1

8930053170 2337 4-key [GS] 1MP14 8930053650 2336 main seal 1MP16 8930052840 2337 T-rubber 1MP17 8930054540 2336 top key 1MP18 8930052991 2337 terminal-1 1MP19 8610010910 Knob N281 1MP20 8610010920 Knob N282 1MP21 8510013161 2337 main shield-1 1MP22 8930053670 2337 side plate 1MP23 8930053000 2337 window sheet 1MP25 8510013480 2336 PA shield 1MP26 8830001480 VR nut (O) 1MP29 8930053210 2337 microphone sheet 1MP32 8830001500 2337 nut 1MP33 8830001511 Nut (I)-1 1MP34 8810009220 Screw PH B0 M2 × 8 ZK (BT) 2MP35 8930042080 1922 minus terminal 1MP37 8950004420 1652 9-pin connector 1MP40 8810008970 Screw FH BT No.0 M2 × 3.5 NI-ZU 6MP41 8810009180 Screw FH BT No.0 M2 × 5 NI-ZU 1MP43 8210017091 2337 terminal holder-1 1MP44 8950005310 Antenna connector-103 1MP49 8510013220 2337 antenna plate 1MP50 8930053440 2337 A-PTT plate 1MP51 8930053431 Sponge (GP)-1 2MP52 8810000100 Screw PH M2 x 4 ZK 2MP53 8930053630 Seal O-ring (AH) 1MP54 8930053680 Spring (AG) 1MP55 8810004890 Screw PH No.0 M2 × 6 ZK 2MP56 8810005360 Screw PH No.0 M2 × 3 ZK 8MP57 8810009560 Screw PH BT M2 × 6 ZK 2MP58 8810005700 Screw PH No.0 M2 × 4 ZK 3MP59 8810009510 Screw PH BT M2 × 4 NI-ZU 8MP60 8930046000 1903 microphone sponge [GS] only 1MP61 8930053660 2337 side seal 1MP63 8930053880 2337 key sheet [GT] 1

8930054010 2337 4-key sheet [GS] 1MP64 8930051781 Insulation sheet GA-1 1MP65 8930053890 2337 T-K sheet 1

REF ORDERDESCRIPTIONNO. NO.

[CHASSIS PARTS]

Screw abbreviationsB0, BT: Self-tapping PH: Pan head FH: Flat headNI-ZU: Nickel-Zinc ZK: Black

[GT]: IC-F30GT/F31GT[GS]: IC-F30GS/F31GS

QTY.

DS10 5030001870 LCD EDMMUD1FA0 1

SP1* 2510001060 Speaker K036NA500-47

MC1 7700002310 Microphone EM-140 1

MP1 8510013230 2337 LOGIC shield 1MP2 8930053320 2337 LOGIC spring 1

REF ORDERDESCRIPTIONNO. NO. QTY.

[FRONT UNIT]

MP1 8510013000 2336 VCO case 1MP2 8510011180 1923 VCO cover 1MP3 8410002370 2337 PA heat sink (using Q1:2SK2974) 1MP6 8950005330 2337 9-pin base 1MP7 8950005320 2337 contact 1

W5 8950009790 Cable OPC-972 1


[MAIN UNIT]

EP1 Optional products Antenna FA-SC55V-1 1EP2* Optional products Battery BP-210FM 1

for intrinsically safe versionBattery BP-210 for other version 1

MP1 Optional products 1922 belt clip-1 1MP2 8210017071 2337 C-panel-1 1MP3 8810003700 ICOM screw B4 1


[ACCESSORIES]

EP2 MP1 MP2 MP3EP1

* : Safety critical components

7 - 2

Note(M): MAIN UNIT(F): FRONT UNIT(C): CHASSIS PARTS

FRONT UNIT

MAIN UNIT

MP1 (C) MP1 (C)

MP2 (C)

MP63 (C)

MP58 (C)

MP29 (C)

MP13 (C)

MP63 (C)

MP13 (C)

DS10 (F)

SP1 (F) MP9 (C)MP51 (C)

IC-F30GS and IC-F31GS

IC-F30GT and IC-F31GT parts

MP50 (C)

MP22 (C)

MP37 (C)

MP61 (C)

MP19 (C)MP26 (C)

MP20 (C)MP5 (C)

MP57 (C)

MP59 (C)

MP41 (C)

MP40 (C)

MP40 (C)

MP40 (C)

MP1 (F)

MP2 (F)

MP3 (F)

W1 (F)

MC1 (F)

MP60 (C)

MP2 (M)

MP6 (M)

MP3 (M)

MP49 (C)

MP52 (C)

MP52 (C)

MP25 (C)

MP59 (C)

MP32 (C)

MP33 (C)

VR w/ SW

CHANNEL SW

MP7 (M)MP1 (M)

MP59 (C)

MP59 (C)

MP17 (C)

MP65 (C)

MP10 (C)

MP8 (C)

MP4 (C)

MP54 (C)MP55 (C)

MP34 (C)

MP12 (C)

MP16 (C)

MP35 (C)

MP18 (C)

MP43 (C)

MP64 (C)

MP44 (C)

MP53 (C)

MP58 (C)

MP14 (C)

MP23 (C)

W5 (M)

MP56 (C)

MP56 (C)

MP56 (C)

MP56 (C)

MP56 (C)

MP21 (C)

MA713 MIN

A1A2

C1C2

8 - 1

SECTION PARTS LISTSECTION 8 SEMI-CONDUCTOR INFORMATION

8 - 1 TRANSISTORS AND FETS

8 - 2 DIODES

NAME SYMBOL INSIDE VIEW


MA742 M1U

A C

A C

DAN202U N

C

A1 A2

DAP202U P

A1

C2C1


1SV245 T3HVC350BTRF BO

A C

MA77 4B A C2SK2974 K2974

G G

D D

SS

(TOP VIEW)

2SK880-Y XY

G

S D

2SK2973 K1

G D

S

S

B E

C

XP6501 AB 5N

E1 B2E2

C1 C2B1

B E

C

3SK206-T1 U78 U78

3SK293 UF

D S

G2 G1

UN911H 6P

B E

C

XP1214 9H

E1B1 B2

C1 C2

NAME SYMBOL INSIDE VIEWNAME SYMBOL INSIDE VIEW

2SB1132 R BARB

B E

C

C

2SK1829 K1

G S

D

2SA1362 GR AEG

C

B E

2SC4081 R BR2SC4116 GR LG2SC4213 B AB2SC4215 O QO2SC4226 R25 R25

B E

C

CPH3403-TL KC

D

SG

DTA144EUA 16

DTC144TE TL 06

B E

C

DTC144EUA 26

MA8024 2.4

MA8030-H 3^0

MA8056-M 5-6

MA8062-M 6-2

MA111 1B

MA2S111 A

A C

The combination of this page and the next page showsthe unit layout in the same configuration as the actualP.C. Board.

Surface Inside 1 Inside 2 Under side

1P0

P1

P2

P3

47

2580

369#

MICROPHONE

9 - 1

9 - 1 FRONT UNIT

SECTION 9 BOARD LAYOUTS

• TOP VIEW

Surface Inside 1 Inside 2 Under sideGN

D

SP

CN

D0

FR

ST

PT

T

D5

D4

D3

D2

D1

RD

BW

RB

RS

GN

DR

ES

BV

CC

KR

0K

R1

KR

2K

R3

MIC

+

SP

+

GN

D+

5V D7

D6

NC

D6

VR1

VEE3

NC

D1D2D3D4D5

D7OSC0OSC1VSS

PMODEVDDVEE

CAP–CAP+VEE2

1

5

10

15

20

25

30

35

40

VOUT

VR2

SCLWRBRDBD0

M86

VS/TERESBCSBRSM/S

P/S

V1V2V3

NCNCV0

V4

LCD

PTT F2 F3F3

F0

to MAIN unit J3SPEAKER

9 - 2

The combination of this page and the previous pageshows the unit layout in the same configuration as theactual P.C. Board.

• BOTTOM VIEW

FRONT UNIT

The combination of this page and the next page showsthe unit layout in the same configuration as the actualP.C. Board.

9 - 3

Under sideInside-2Inside-1Surface

S1

ANT

BATTERY+

R193

GN

D

SP

CN

D0

FR

ST

PT

T

D5

D4

D3

D2

D1

RD

BW

RB

RS

GN

DR

ES

BV

CC

KR

0K

R1

KR

2K

R3

MIC

+

SP

+

GN

D+

5V D7

D6

to FRONT unit J1

1 26

8 7 24569

AF

O

VC

C

DE

TE

CT

MIC

E

RE

SE

T

XR

XD

XT

XD

MIC

PT

T

3 1

87

2

BDET

BATTERY

45

69 3 1

12

3

45

6

INT SP SWAF VRPOWER SW

CH SELECT

1

15 16

30

1

15 16

30

UNIVERSALCONNECTORMP6

OPC-966EM-80EM-89AD-52HS-93

9 - 2 MAIN UNIT• TOP VIEW

Under sideInside-2Inside-1Surface

S1

CP3

R193

872 4 5 6 931

87

2 456

931

12

3

4 5

6

INT SP SWAF VRPOWER SW

CH SELECT

PT

T

MIC

XT

XD

XR

XD

RE

SE

T

MIC

E

DE

TE

CT

VC

C

AF

O

• BOTTOM VIEWThe combination of this page and the previous pageshows the unit layout in the same configuration as theactual P.C. Board.

9 - 4

MAIN UNIT

10 - 1

SECTION 10 BLOCK DIAGRAM

IC2TC75S51F

MICAMP

136-174 MHz

D2MA713

Q12SK2974

D1, D24, D25MA77

Q22SK2973

Q32SC4226

MAIN UNIT

MAIN UNIT

VCOSW

VCOS

D4, D5: MA77Q6

2SC4215Q82SC4215

Q9 DTC144EUQ10 XP1214

RX VCO

Q13XP6501

Q11: 2SC4226D6, D40–D42: HVC350B

Q12: 2SC4226D8, D43–D45: HVC350B

S5V

LVINBUFF

Q142SK880

IC1SA7025

X1CR-667

IC2TC75S51F

TCXO

MOD

NOIS

FRACTIONAL N15.6 MHz

31.2 MHz

DSIN

Q152SC4116

SECOND MIXERIF AMP

MOD

TX VCO

D71T365

TA31136FN (D)IC3

IF

X2CDBCA450CX24

Q72SC4215

Q182SC4215

FI1FL-322

31.65 MHz

W/NW/NSW

Q17 2SC4116Q16 DTA144EU

Q193SK206

D19HVC375B

D18HVC375B

RSSI

Q212SK1829

D20HVC375B

PWRDET

T4

IC4TC75S51F

D21HVC375B

MUTESW

TMUT

Q22DTA144EU

UNIVERSALCONNECTOR

CONNECTORJ4

T1

IN/EXTMIC SW

XTXD, XRXD, RES

VCC

IC19BU4053BCFV DETECT

PTT

MIC

AFOUT

T2

AFONAFMT

SW

MICI

Q203SK293

PTT/MD1

IC13DA3

IC19BU4053BCFV

T4 T3

AF AMPREG

VCC

W/NSW

MIXER

Q23 2SB1132 RQ24 XP6501

Q26DTC144EU

W/NFSW

IC7CNJM2902V

FILSW

FI2Q27

2SC4212SFPC450E

W/N W/NSW SW

DETECTORSQL AMP

W/ND15DAN202U

D16DAN202U

FI3

RSSI

SFPC450G

FRCN

IC13M62364FP

SPLOMOD

A

D/AT1T2T3T4

IC10NJM2902V

COMPRE-

MSK MOD

MSKDEMOD

B

EXPAN-DER

COMPANDER

IC5TA7368F

NJM2902V

IC9 TC35453F

IC13DA1

SIG1, SIG2,CTCS, TONE

VOX

PTIN

PTOT

CR-681IC18

IC7B

G

12.288 MHz

SHIFT

SPSW

SP+

SP–

MIC+

D27MA77X3

SPCN

Q6, Q7CPH3403Q82SC4081 INT MIC

INT SP

PTT

EM-140MC1

F0

LCD MODULE

SW

IC1TC74VHC373FT

RDB WRB RESB

D0-D7 RS

Q9DTC144EU

CPUBATT

POWER SW

FUSE

VOXT

TA75S01F

F1

IC13DA2

IC15

BEP1 BEP2TONE

VCC

BEEP

SSOR

MCIN

X4

Q472SC4081

MCOT

CR-5633.58 MHz

REM

MSKETRD

DIN

REGS1REGS2RTMRDTFCLR

D/A

IC27M62334

SCLSDA SCK

APST

OPTION

DTMF

UNIT

BEP1

SIG1

DTSDDTACDDST

CIRQSI

LC73872M

OSCI

IC17

DECODEDTPD

D

SOSCK

DAST

F

AFON

1

OPTION

2UNIT

PTINPTOT

MCIN

MCINMCOT

MCOT

SIG2

BEP2

RMUTMMUT

CCS

OPV11OPV12OPV13OPV21OPV22OPV23

C

E

SO

SCKOPT11OPT12OPT13

OPT21OPT22OPT23

FILSW

FILSW

DUSE

CTCS

J1

J2

Q41DTC144EU

Q40IC13DA4 XP1214

IC7DNJM2902V

CTCSSDTCS

IC30TC7S66FUQ44DTC144EU

CTDA

+5CPU

+5REG

R5REG

+5V

R5V

Q32 2SB1132Q33 XP6501

Q30 2SA1362

Q31 2SA1362

AN8005M

RESET

CPU5V

RES

IC12

SOSCKEXST

IC23 RESB

T5C R5C

BUSYDTPDDUSE

IC14HD64F2238

S-80942ANMP

MSCKMSO

CB10CB11

LED SW

MATRIXKEY

EXPANDD0-D7 KS0-3

KR0-3

FRST

KEYLEDSW

VCC2SC4116BL

BUSY

F1

F2F3

Q1, Q2

DS1-4DS6-9DS11-12DS14-15LN1371G-(TR)

VCC

FRONT UNIT

TX LEDDS5LN210C6ARA

BUSY LED

TX

DS13LMJ310M6RA

VCCCH

SELECT

CB12CB13

S1EC10SP16-47

Q3 DTC144TE

LED SW

Q4 DTC144TE

EEPROM

IC16

EXP-ANDER

W/NFSW

EEPROM

IC24HN58X2464TI HN58X2464TI

S5CAFMTSPCN

BU4094BCFV

S5REG

T5REG

S5V

T5V

Q29 2SA1362

RXDT

DATALPF

IC31

SDEC

TC75S51F

RESTO-RATION

DATALPF

NJM2904VIC20B IC20A

NJM2904V

SW

PTINPTOT

Explanatory notes

COMMON LINE

TX LINE

RX LINE

CONTROL LINE

SQ

IND

SIN

CS

FT

DRIVEAMP

PLL IC

× 2

LPF

BPF

LOOPFILTER

RIPPLEFILTER

BUFF

BUFF BUFF TX/RXSW

AMP XTALBPF

YGRAMP

ATT

BPF BPF BPF

GATECTRL

RFAMP

PREDRIVE

PWRAMP

APCAMP

BPF

ANTSW

LPF

AFAMP

AMP

LPF

LPF

AMP

LIMITAMP

AMP

HPFLPF

AMP

BUFF

HPFLPFAMP

BPFHPF

HPF

AMP

CERAMICBPF

CERAMICBPF

LPF

MIC

11 - 1

OPV21

OPV22

OPV23FCLR

MSKE

RGS2

DS3

LCD

LNJ310M6URA

DS4LNJ310M6URA

NC

12345678940J2

DS2LNJ310M6URA

R8560

DS13LNJ310M6URA

DS5LNJ210C6ARA

R13330

Q4DTC144TE

Q3DTC144TE

Q12SC4116

R21.5k

R13.3k

R322

R5820k

R6390k

C2047p

C20.1

C30.1

R4820k

C220.1

D7D6

C10.1 C4

1C231

C7

DS10 EDMMUD1FA0

1

C91

C81

R18100k

C101

C111

C211

R17100k

F3 F2

S5 S4

F1

D5D4

D3D2D1D0RDBWRB

RS

RESBVCC

S3

F0

KS4

S2

D1MA111

12345678910

IC1TC74VHC373FT

Q5DTC144TE

R14100k

R113.3k

KS2

KS3

Q22SC4116

C1847p

S101

S104

C1347p

DS8LN1371G-[GT] only


DS14LN1371G-[GS] only


C1247p

D2MA111

S102

S105

S103

S106

S110

S111





S112

S16

S109

S12

S108

S11

KS0

KS1

C1547p

S107

S10

R9220

C1447p

R101.5k

D3MA6S121

MIC+

PTT

INT SP

SP+

MC1EM-140

CP2

CP1

KR0KR1KR2KR3S1

SP1

PTT

C190.1

C61

D4MA111C26

0.1

R7560k

DS1LNJ310M6URA

C1747p

PTT

1234567891011121314151617181920212223242526

J1W5

D6D7

+5VGND

SP+

MIC+

KR3KR2KR1KR0VCC

RESBGND

RSWRBRDB

D1D2D3D4D5

PTT

FRST

D0

SPCN

GND

D6D7+5VGND

SP+

MIC+

KR3KR2KR1KR0VCCRESBGNDRSWRBRDB

D1D2D3D4D5

PTT

FRST

D0

SPCN

GND

FRONT UNIT MAIN UNIT

DSIN

LV

FLAC N PLL

CLOCK 1

DATA 2

STROBE 3VSS 4

RFIN 5RFIN 6

VCCP 7REFIN 8

RA 9AUXIN 10 PHA 11VSSA 12PHI 13PHP 14VDDA 15RN 16RF 17LOCK 18TEST 19VDD 20

IC1SA7025DK-T

Q142SK880Y

R46

12k[F31G]4.7k[F30G]

R496.8k

R501k

R51

W410k

C1020.0047

C1090.1

CP7

C1000.001

C1010.001

C10310p

L251.8 H

REF

D

F

+5V

R52 100

R55 22k

R572k

R58 1k

R59 2k

C1040.1

C99 47p

C108 C9147p 47p

1

34

5

2

IC2TC75S51F

R53220k

C4274.7

C10747p

C1050.001

R54100

C1060.1

R34127k

VC

ON

1

GN

D

2

OU

T

3

VC

C

4 X1CR-66715.600 MHz

VCC

LVIN

S5V

BUSY

AFON

SIG1

BEP1

SPLO

FRCN

PLRS

T5V

+5VOPT11OPT12OPT13

AUX

APSTDIN

RGS1

OPT1

OPV11OPV12OPV13

R60100k

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16

1718192021222324252627282930

J1

D10DAN202U

R294 47kR295 47k

R29647k

OPT2

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16

1718192021222324252627282930

J2

R6447k

R6547k

R6647k

OPT21OPT22

SIG2

OPT23 W/N FILTERC

E

R621.2k

C873p

C980.01

C95 C96 C9747p 47p 47p

L271.8 H

L28

PLL

IN

1.8 H

R67

R307100k

100k

3

1 2FI2 SFPCA450KE4A

S5V

BEP2

VCOS

ULCK

REM

R5V

PLST

SCKSO

SCKSO

3 MULTIQ152SC4116

R4510

R61220k

R891.5k

R9047

C76100p

C780.001

R4710k[F30G]20K[F31G]

C800.1

C830.01

C79

0.001[F31G]0.1 [F30G]

C8147p

C8210p

C8412p

C852.5p

C86

C4390.001

5p

L261.8 H

R446.8k[F30G]4.7k[F31G]

R4821.5

R9110k

C770.1 [F30G]0.22[F31G]

IF

Q172SC4116

OSCINOSCOUTMIXOUTVCCIFINDECFILOUTFILIN AFOUT 9

QUAD 10IFOUT 11RSSI 12N-DET 13

N-REC 14GND 15MIXIN 16

IC3 TA31136FN

R8215k

R9347k

R9247k

C1140.1

C12410

C1150.001

C116C4220.1 470p

C1170.001

C125

C420 0.001

100p

C112220p

C1130.01

C110

R943.3k

C118C0.

0.001

R93.

R8847k

C111220p

NO

IS

RS

SIQ16

DTA144EUA

D15DAN202U

D16DAN202U

R7715k

R78

R3474.7

22kR7912k

R814.7

C110

C2670.01

C22947p

0.1C4230.1

C2160.047

C3970.0047

C3990.0047

R8022k

R85330

R873.9k

R75100k

R73100k

R8682k

3

1 2FI3 SFPCA450KG1A

W/N

S5V

SI

RMUT

MMUT

CIRQ

SQ

IN

CCS

PTOT

D14DAP202U

D13DAP202U

MCINMCOT

CH SELECT

G

C36547p

C36647p

C36747p

C2310.0047

R289100k

C40147p

C31047p

R323100k

C1 1

C2 2

1 3

2 4

4 5

8 6

PTOT

CB10CB11CB12CB13

PTIN

PTIN

AF FIL

MCOT

A

MCIN

VAG

VAG

MICI

R18668k

R187 4.7kC2260.047

C2270.033

R188100k

+5V+5V

R17268k

R189470

Q45UN911H

C23010

R185120k

Q272SC4213

R16839k

R18412k

L471.0 H B

3

21

11

4

NJM2902VIC7A

C2250.047

C2134.7

C204.

C2150.1

R317470k

R1831.5k

C2140.1

C2170.1

C2180.0047

C1920.0047

C219 120p

R173150k

R1755.6k

C4550.1

C2240.1

R37122k

R37233k

R3734.7k

Q472SC4116

C4560.1

R37047k

C2330.1

R18015k

R28810k

C2320.0022C203

0.0022 R16610k

R15722k

REG

Q312SA1362

Q322SB1132

1 2 3

456Q33XP6501

R19810k

R1994.7k

R20010k

R2021k

C2410.01

C195470p

C2544.7

R20310k

C4340.1

IC12AN8005M

VCC

MIC

O

Q292SA1362 Q30

2SA1362R1954.7k

R19610k

R1974.7k

C2390.01

C2400.01

R190100kC421

0.1

C23522

C23622

C23722

C23822

Q46DTC144EUA

D46MA742

C4320.1

R298100k

C43347p

VCC

VCC

VCC

AFOUT

FS

W

S5V

S5V

S5VR5V

T5V

R5V+5V

+5V

+5V

VCC

+5V

KR3KR2

KR1KR0

RESB

RSWRBRDB

D1

D2D3D4D5D6D7

FRST

D0

POWER

INT SP SW

C23447p

D31MA2S111

R19310k

F1KAB 2402322NA29

R217470

C3540.001

16151413 4

3 2 1

1211109 8

7 6 5 Z

Z1 Y0 Y1

VSS VEE INH Z0

X1X

Y VDD

CBA

X0

SPCN

AFVI

DC SW

RX SIGNAL

C4450.022

C446 820p

C447820p

R363100k

R364100k

R36539k

R368390k

1

34

5

2

IC31TC75S51F

IC19BU4053BCFV

R369180k

T5C R5C

HV

HV

SE

NC

DS

IN

DTMF DECODE

C2424.7

C2570.1

C2440.001

INPUT 1

NC 2

PD 3

OSCO 4

OSCI 5

NC 6

VSS 7 LOADB 8SD 9ACK 10STD 11EST 12NC 13VDD 14

IC17LC73872M

C240.0

C3840.001

R2012.2k

C3850.1

C38647p

L451.8 H

C24347

C4480.0012

R3671.5k

C4500.1

S5C

DT

PD

SD

EC

RX SIGNAL

DUSE

Q41DTC144EUA

7 6

5

IC20BNJM2904V

R21839k

R27322k

R27422k

R27522k

C3510.1

Q432SC4116

R31222k

R31333k

R31433k

R31533k

R3162.7kC394

0.018C39568p

C3500.01

C3520.039 C349

0.0068

C3961

C4430.001

TX SIGNAL

R27647

R325C4130.1 10k

R3625.6k

C4490.1

C3931

C3530.001

DSIN

RESETXRXD

XTXD

DETECT

VCCAFO

UNIVERSALCONNECTOR

MIC

MICE

PTT

R279 1k

R2781k

R280 1k

C35647p

R285 10k

R192100k

R277 1k

D30MA8062 M

R2841k

C3550.001

C428

C42947p

0.1

C4520.1

C45147p

R3754.7k

D38MA2S111

987654321

MP6

R3761k

R3304.7

AFOUT

XRXD

MD2

XTXD

RES

SPCN

BATTERY

HV

GND

BDET

C3590.001

CP5

CP3

CP4 C358470pexcept[IS] except[IS]except[IS]

C3180.01

L531 H

BDET

D35 D36MA8056 M MA8056 M

D34MA8056 M

AF VR

C4140.1

VCC

987654321

J3

2625242322212019181716151413121110

1 2 3 4 5 6 7 8

OG I

To optional unit

To optional unit

C228470p

C4300.001

PT

TS

P+

SP

CN

MIC

+K

R3

KR

2K

R1

KR

0K

S0

KS

1K

S2

KS

3

11 12 13 14 15 16 17 18 19 20

NC

VR

2V

R1

VO

UT

VE

E3

VE

E2

CA

P+

CA

P–

VE

EV

DD

PM

OD

EV

SS

OS

C1

OS

C0

D7

D6

D5

D4

D3

D2

D1

D0

RD

BW

RB

SC

LP

/SM

86M

/SR

SC

SB

RE

SB

VS

/TE

V4

V3

V2

V1

V0

NC

NC

10202131 1112131415161718192223242526272829303233343536373839

R36682k

C398 0.0047

R4810k

S1EC10SP16-47

INT SP: 0VEXT SP: 4.3V

VOXT

VOX 1

34

5

2 IC18TA75S01F

R206 100

R20815k

R209330k

R210 390k

R2111.2k

C2490.018

C250470p

C2480.018 D29

MA2S111

R20722k

C251

C35747

2.2C252470p

C2530.001

R2121.8M

MICO

Note [GT]: IC-F30GT/F31GT [GS]: IC-F30GS/F31GS

0.1

SPCN

W3

33k 0.00147p

10k

Q6

IC2TA75S01F

CPH3403

Q7CPH3403

470k

Q82SC4081

Q9DTC144EUA

100k470k

INT MICC30

C290.001

R12 C16

C240.01

C280.01

C27270pC25

R23

R20R21R22

R25180k

R2615k

R2712k

R2447k

15

34

2

INT SP : 0VEXT SP: 4.8V

RX: 0VTX : 2.2V

RX: 0VTX : 2.7V

15.6 MHz 970 mVp-p

RX: 5.0VTX: 0V

13.1V

SQL CLOSE: 0VSQL OPEN : 5.0V

RX: 0VTX: 5.0V

LED OFF: 0VLED ON : 5.0V

5.0V

10.3V

RX: 4.6VTX: 0.1V

RX: 5.0VTX: 0.8V

RX: 0.8VTX: 5.0V 0.9V

RX: 0VTX: 5.0V

RX: 5.0VTX: 0V

5.0V

5.0V

5.0V

7.5

5Vf =41 kHz

0V

SECTION 11 VOLTAGE DIAGRAM

UNIT

ANT FILTER

R182k

R2150

C40.001

CP2

C50.001

C60.001

L44.7 H

CP1L2

44nHL3

50nH

C133p

C233p

C41710p

C4185p

C4191.5p

C318p

L132nH

C41610p

D1MA77

L9

L1025nH

EXCCL3225U1L14EXCCL3225U1

C161

C180.001

C747p

C170.001

C21470p

C24470p

C270.001

C2847p

C2322

T5V

R14R18100 10

FI4NFE31PT152Z1E9L

C260.001

C350.001

0.001

C420.001

VCC

FIL5V

R21100

220R26100

VCCT5V

RX VCO

R.FIL

Q112SC4226

D6D40HVC350

D41HVC350

D42HVC350

HVC350

R301.8k

R3222 (mod 38)

R313.9k

R353.9k

(mod 37)

R39R382.2k

R3331k10

C550.01

C54470p

L22

L2080nH

L230.25-1.9-9TL

L490.25-1.9-9TL

C7282p

C6310

C70 6p(mod 39)

1.8 H

R34 1.8k (mod 37)

C5947p

C5812p

L193.3 H

C372

C62

C6122p

10

L4867nH

L210.47 H

R33330

10p

C37310p

C5712p

FLAC N PLL

PHA 11VSSA 12PHI 13PHP 14VDDA 15RN 16RF 17LOCK 18TEST 19VDD 20

5

Q142SK880Y

R46

12k[F31G]4.7k[F30G]

R496.8k

R501k

C1090.1

CP7

C1000.001

C1010.001

L251.8 H

VCOS

LOOP FIL

3 MULTI15SC4116

R4510

R61220k

R891.5k

R9047

C76100p

C780.001

R4710k[F30G]20K[F31G]

C800.1

C79

0.001[F31G]0.1 [F30G]

C8147p

C8210p

H

C74 C4310.0010.047

R446.8k[F30G]4.7k[F31G]

R43820[F30G]1.5k[F31G]

R9110k

R42100k

R3421k

R35547k

R356180k

C770.1 [F30G]0.22[F31G] TX VCO

VCO SW

3

2

1 5

4

Q10XP1214

Q12

Q13 XP6501

2SC4226

D43HVC350

D44

D45HVC350

D8HVC350

HVC350

R36 10(mod 38)

R37390

R41220k

C6922p

D71SV245

C640.001

C65470p

C660.5pC67

12p

C6818p

R40100[F30G]10[F31G] L24 0.47 H L46

3.3 H

C7347p

C3760.001

R97680

C710.75p

R5VS5V

BUFFER AMP

Q62SC4215

Q72SC4215

Q8 2SC4215

Q9DTC144EUA

D5MA77

R201k

R2247k

R234.7

R2568k

R2868k

R2910k

C4618p

C47

C487p

C4912p

C502p

C510.001

C520.001

C5347p

L170.1 H

L180.1 H

L500.1 H

S5V

PLLIN

RF AMP

PRI AMP

YGR

RF AMP

L1518nH

Q32SC4226

MA77

R1214.7C157 0.47

C37

C38

0.001

0.001

C3647p

R1910k

C430.001

C39

D4

18p

L35 1 H

R15

R1668

R171.2k

1.2k

C340.001

FINAL

R1068

R1210k

D2MA713

Q22SK2973

C220.001

C310.1

C300.1

C290.001

C403

C44147p

C1456p

0.001

R8

R722

18k

Q12SK2974C20

0.001

C19150p L7

L815nH

7.5nH

L1318nH

C80.001

C1760.001

C177470p

L550nH

MP3

C9

C1222p

22pR3

R6 4.7k

R5 4.7k

R42.2k 2.2k

Q22DTA144EUA

1

3 4

5

2

IC4TC75S51F

R127100

R1293.9k

R13010k

R131330k

R132180k

C1710.01

C1724.7

C4424.7

C4400.001

C1730.01

C1740.001

R69100k

R1332.2k

R128 100k

C1750.1

T4

TM

UT

APC

RX BPF

Q23 2SB1132

D22MA2S111

D24

D23MA2S111

MA77

D25MA77

NC 1

VCC 2

NC 3

VIN 4

RIPPLE 5 NF 6

PHASE 7PREGND 8PWGND 9POUT 10

IC5 TA7368F

C167

D39MA8030H

L3947nH

L4047nH

R327

R3281k

47

C1688p

C1654p

C1631p 6p

L3856nH

L5156nH C170

9p

L3756nH

Q212SK1829R118

100k

R12015k

R1221.8k

R12347k

R124470k

R126100k

R12510k

C1450.001

C15047p

C15447p

C1550.001

C15847p C159

0.001

C1620.001

Q203SK293 D21

HVC350

D20HVC350

C1510.001

R119390k

R117270

C1565p

C1610.001

C4376p

C1607p

L3656nH

T1R115

10kT2

TON

E

CT

CS

CTCS

SIG

1

SIG

2

RX BPF

L33L520.1 H 56nH

R109100

R114 10k

R111150k

R112 10k

R113220k

R1104.7k

C1340.001

5p

C1390.001

C1420.001

C1480.001

C149470p

R1054.7k

C1330.001

C1320.01

L441 H

Q193SK206

C1401.5p

C4380.001

D19HVC350

D18HVC350

C1380.001

L310.82 H

R359

R3344.7k

470R360470

C1376p

C1410.001

C1437p

R35812

C3698p

T3

T4

MIXER

MCF1 2

46 35FI1FL-32231.650 MHz

C1272.2

C126470p

R103220

Q182SC4215

R99

R954.7

1 k

C13127p

R171 68kR17427k

R98

R361470

100kR340180k

C3601

R167 470kC457100p

C1287p

R102 C1300.001270

IF

Q172SC4116




IC3 TA31136FN

X2CDBCA450AY24

R9347k

R9247k

C12410

C1150.001

C116470p

C1170.001

C125

C420 0.001

100p

C123100p

R943.3k

C118C1190.001

C1200.001

C12247p0.001

R963.9k

L421.8 H

R352 10k

NO

IS

RS

SI

VAG

AUDIOPROCESSOR

1

NJM2902VIC7A

C2134.7

C2084.7

C2150.1

C2070.1

C1932.2

C2140.1

C2170.1

C2180.0047

C219 120p

R173150k

R1755.6k

C4550.1

C2240.1

R37122k

R37233k

R3734.7k

16C4560.1

R37047k

R18015k

R16610k

123456789

MICIN 12

MICGS 13

CALO 14

ALCO 15

CMPIN 16

CCHG 17

CMPO 18

TXFI 19

VDDA 20

VDDD 21

STB 22

23

RE

GS

1

VSSD34VSSA35MSKST 36PWROP 37PWRON 38PWRGS 39PWRIN 40EXPO 41ECHG 42EXPGS 43EXPIN 44

IC9TC35453F

R164 220k

C1210.1

C206 0.1

C1970.01

C2050.1

C2610.1

C1980.0047

C4000.001

R2925.6k

R318

R228100k

R229100k

R3491kC281

0.1R227100k

C2630.1

R336100k

33k

R3441k

R159100k

C199120p

R16547k

R152150k

Q26DTC144EUA

10

98

IC7C

IC29BU4053BCFV

NJM2902M

C4060.022

W/N

AF REG

+5V

75

6

IC7BNJM2902M

R222100k

C1890.001

R15539k

C444330p

C4250.001

C3750.1

D47MA8024

C202270p

C20056p

C3620.0012

R16333k

R16168k

R17656k

R17718k

R17827k

R17927k

R16268k

R1534.7

AF

ON

AF

MT

AF AMP

1 2 3

456

Q24XP6501

R1372.7k

R1383.3k

R1391k

R141 68k

C1850.1

C1860.1

C1830.001R140

1M

D26MA2S111

C18747p

C1820.018

C18847p

C18410 R136

6.8k

VLO

UT

L41EXCCL3225U1

R13410

R13510

C178100

C1790.047

C18047p

C18110R321

2.2k

AFOUT

CSFT

XIN

XOUT

C28847p

C28947p

C29347p

R23012k

R23112k

C27622p

C2780.01

W2

C29147p

C29247p

C28033p

C2790.01

R2381k

R2421M

R2431M

C2777p

C27547p

R23212k

D27MA77

R32910k

X3CR-68112.288MHzR235

1k

OPT22OPT21OPT23 SDAR237 1k

C28747p

R236 1k

R249 1k

C27347p

OPT13OPT11OPT12AUX

MS

CK

MSO

PB3/A11/TIOCD3 25

PB

4/A

12/T

IOC

A4

26

PE5/D5 1

PE6/D6 2

PE7/D7 3

PD0/D8 4

PD1/D9 5

PD2/D10 6

PD3/D11 7

PD4/D12 8

PD5/D13 9

PD6/D14 10

PD7/D15 11

CVCC 12

PC0/A0 13

VSS 14

PC1/A1 15

PC2/A2 16

PC3/A3 17

PC4/A4 18

PC5/A5 19

PC6/A6 20

PC7/A7 21

PB0/A8/TIOCA3 22

PB1/A9/TIOCB3 23

PB2/A10/TIOCC3 24

P41/AN1 51P40/AN0 52

VREF 53AVCC 54

MD0 55MD1 56

OSC2 57OSC1 58

59NMI 60

STBY 61VCC 62XTAL 63VSS 64

EXTAL 65FWE 66MD2 67PF7 68

PF6/AS 69PF5/RD 70

PF4/HWR 71PF3/LWR/ADTRG 72

PF2/WAIT 73PF1/BACK/BUZZ 74PF0/BREQ/IRQ2 75

IC14 HD64F2238FA13

R2391k

C282 47p

C283 47pC284 47p

C285 47p

C32347p

C32647p

C32747p

C32847p

C32947p

C32247p

C32147p

C29547p R247

1k

BEEP RDB WRB RS

D0

D1D2D3D4

D5D6D7RESB

RMUTMMUT

PTOT

SCLCCSFRST

L434.7 H

C26447

C26547

R226NTCG20 4M 473JT

C40247

C266470p

C262470p

R150220k

SP

LO

D/A

CPU5V+5V

VCC

VCC VCC

C2600.001

C4080.1

R3451k

R343

3.58 MHz2.8 Vp-p

1k 2X4 CR-5633.579545 MHz

C45418p

C45315p

R216R2151M [GT]100k [GS]

100k[GT] only

R15722k

C4090.1

R3543.9k

R221 33k

VIN1 1

VOUT1 2

VOUT2 3

VIN2 4

VDD 5

LD 6

CLK 7

DI 8

VIN3 9

VOUT3 10

VOUT4 11

VIN4 12

VIN5 13VOUT5 14VOUT6 15VIN6 16DO 17VDAREF 18RESET 19GND 20VIN7 21VOUT7 22VOUT8 23VIN8 24

IC13M62364FP

SQ

IN

DIN

SC

KR

GS

1R

GS

2

MS

KE

TR

D

RT

MR

DT

FC

LR

AP

ST DSIN

VAG VAG

MOD

MO

D

BD

ET

AD

SL

MM

OD

MA

PD

AN

1

AN

0

REG

1A1362

Q322SB1132

1 2 3

45633P6501

R2021k

C195470p

C2544.7

R20310k

C4340.1

IC12AN8005M

VCC

MIC

OC43347p

S5VR5V

DTMF DECODE

C2424.7

C257

C4100.1

0.1

C2440.001

INPUT 1

NC 2

PD 3

OSCO 4

OSCI 5

NC 6


IC17LC73872M

C2460.001

R2012.2k

85

86p

5H

R225

R28127k

R18227k

R18127k

100k

C24710

C24347

C4500.1

DD

ST

DTA

C

DT

PD

EEPROM

D/A

C2590.01

A0 1

A1 2

A2 3

VSS 4 SDA 5SCL 6WP 7VCC

8IC16 HN58X2464TI

A0 1

A1 2

A2 3

VSS SDA 5SCL 6WP 7VCC 8

IC24HN58X2464TI

1234 5

678

IC27M62334FP

R324470

C4070.1

C2580.1

C4114.7

C424470p

DA

ST

TON

E

BE

P2

BE

P1

BE

EP

SOSC

K

DT

SD

T1

T2

T3

T4

SC

LS

DA

CPU5V

CPU5V

CPU5V

CPU5V

C33847p

C29447P

C32547p

C33647p

C33547p

R219 10k

R220 100k

C383 0.1

C2680.1

R151150k

MS

CK

MS

O

FRCN

EXST

DINRGS1

RGS2MSKEFCLR

APST

C29647p

C32047p

C29847p

C28647p

C29747p

R2401k

C31947p R245

1k

R2481k

R2511k

C3060.1

R223220k

R322220k

C36447p

KR2

KR1KR0

KR3

R233100k

C40547p

C31247p

C31147p

C40447p

C30947p

R23410k

W3

R246 1k

D33MA2S111

C3160.0047

C3170.0047

R5C

NOIS

DDST

AN1

T5C

TMUT

RES

DTSD

AN0

RESET

C2710.027

C3300.1

OUT 1

VDD 2

VSS 3 NC4

CD5

R291100k

C27247p

Q392SC4116

MD2

R2501k

R2521k

C30447p

R2991k

R253100k

MM

OD

RT

M

TR

D

XR

XD

ULC

K

RS

SI

LVIN

VO

XT

RX

DT

AF

VI

AD

SL

CT

DA

SI SE

NC

SD

EC

C29947p

C30047p

C33147p

C33247p C458

0.1

C34047p

C3780.1

C33447p

C33347p

C33947p

R293

R224100k

100k

.STR 1

D 2

CLK 3

OE 15

Q1 4Q2 5

Q3 6

Q4 7Q5

14Q6 13

Q7 12

Q8 11

QS 9

QS. 10

16

8IC23 BU4094BCFV

EXSTSOSCK

XTXD

PLST

VCOSDEST

RESB

DAST

SCKSO

PLRSDUSE

C37947p

C31447p

C31547p

C31347p

C38047p

C38147p C382

47p

C30747p

C30847p

C30347p

C30247p

C30147p

R2971k

R244 1k

C37747p

REM

DTPD

RXDT

SPCN

RDTCB10CB11CB12CB13

BUSY

W/N

FSWAFMT

CTDA

S5C

12

13 14

IC7DNJM2902V

R25822k

R25947k

R26047k

R26147k

R268100

C3420.1

R264470

3

21

4

8

IC20ANJM2904V

3

2

1 5

4

Q40XP1214

C4152.2

C343820p

C3460.0033

R26647k

R26747k

R269120k

R271220k

R27268k

R254180k

R25722k

R332100k

1 2 3

5

4

IC30 TC7S66FU

R331470k

C3410.015

R2625.6k

C4260.22

R37447k

RX SIGNAL

DUSE

Q41DTC144EUA

7 6

5

IC20BNJM2904V

R21839k

R27322k

R27422k

C347

C3450.01

0.1

C3480.1C351

0.1

Q432SC41165

R3162.7k5

C3500.01

29 C349

0.0068

C3961

C4430.001

1 2 3 4 5 6 7 8

OG I

4

TO ANTENNA

C4300.001

C33747p

C324 47p

C30547p

C37147p

C41247p

R116100k

C1470.001

C1460.001

R27018k

Q44DTC144EUA

DTA

C

CIR

Q

DIN

DC

K

RE

GS

2X

OU

TX

INM

SK

ET

RD

RT

MR

DT

FC

LR

CS

TA

GN

DT

XF

OID

CIN

IDC

GS

TX

OU

TM

SK

INM

SK

GS

RX

INR

XG

SR

XF

O

PB

5/A

13/T

IOC

B4

PB

6/A

14/T

IOC

A5

PB

7/A

15/T

IOC

B5

PA0/

A16

PA1/

A17

/TX

D2

PA2/

A18

/RX

D2

PA3/

A19

/SC

K2

P10

/TIO

CA

0/A

20

P11

/TIO

CB

0/A

21

P14

/TIO

CA

1/IR

Q0

P13

/TIO

CD

0/T

CLK

P12

/TIO

CC

0/T

CLK

P15

/TIO

CB

1/T

CLK

P16

/TIO

CA

2/IR

Q1

P17

/TIO

CB

2/T

CLK

AV

SS

P97

/DA

1P

96/D

A0

P47

/AN

7P

46/A

N6

P45

/AN

5P

44/A

N4

P43

/AN

3

P42

/AN

2

27 28 29 30 31 32 33 34 35 36 37 39 40 41 42 43 44 45 46 47 48 49 5038

100 99 98 97 96 95 94 93 92 91

91939596

96

959391

90 89 88 87 86 85 84 83 82 81 80 79 78 77 76

PE

4/D

4P

E3/

D3

PE

2/D

2

PE

1/D

1P

E0/

D0

PG

4/C

S0

PG

3/C

S1

PG

2/C

S2

PG

1/C

S3/

IRQ

7

PG

0/IR

Q6

P70

/TM

RI0

1

P71

/TM

RI2

3P

72/T

MO

0/C

S6

P73

/TM

O1/

CS

7

P74

/TM

O2/

MR

ES

P75

/TM

O3/

SC

K3

P76

/RX

D3

P77

/TX

D3

P36

P35

/SC

K1/

SC

L0

P34

/RX

D1/

SD

A0

P33

/TX

D1/

SC

L1P

33/S

CK

0/S

DA

1P

31/R

XD

0

P30

/TX

D0

RES

24 25 26 27 28 29 30 31 32 33

1011

R4810k

C56 0.75p

IC15S-80942CNMC-G9C

C135

R24

R6356

C880.001

C8915p

C9015p

L29 33nH

1

2

34

5

6

161514134

321

121110

8 9765 Z

Z1 Y0 Y1

VSS VEE INH Z0

X1X

Y VDD

CBA

X0

S5V

[F30G]: IC-F30GT/ IC-F30GS[F31G]: IC-F31GT/ IC-F31GS

Hz 970 mVp-p

RX: 2.6VTX: 2.5V

RX: 0.9VTX: 0V

RX: 2.6VTX: 0V

RX: 3.9VTX: 0V

RX: 2.3VTX: 2.4V

RX: 0VTX: 4.9V

RX: 4.1VTX: 4.2V

3.6V

3.4V3.7V

RX: 0VTX: 4.8V

RX: 0VTX: 2.8V

AF ON : 7.5VAF OFF: 0V

RX: 0VTX: 5.0V

12.29 MHz3.4 Vp-p

RX: 5.0VTX: 0V

5.0V

5.0V

7.5V


11 - 1

UPIC-F30GT/GS VOLTAGE DIAGRAM 195 195 195210

OPV21

OPV22

OPV23FCLR

MSKE

RGS2

DS3

LCD

LNJ310M6URA

DS4LNJ310M6URA

NC

12345678940J2

DS2LNJ310M6URA

R8560

DS13LNJ310M6URA

DS5LNJ210C6ARA

R13330

Q4DTC144TE

Q3DTC144TE

Q12SC4116

R21.5k

R13.3k

R322

R5820k

R6390k

C2047p

C20.1

C30.1

R4820k

C220.1

D7D6

C10.1 C4

1C231

C7

DS10 EDMMUD1FA0

1

C91

C81

R18100k

C101

C111

C211

R17100k

F3 F2

S5 S4

F1

D5D4

D3D2D1D0RDBWRB

RS

RESBVCC

S3

F0

KS4

S2

D1MA111

12345678910

IC1TC74VHC373FT

Q5DTC144TE

R14100k

R113.3k

KS2

KS3

Q22SC4116

C1847p

S101

S104

C1347p





C1247p

D2MA111

S102

S105

S103

S106

S110

S111





S112

S16

S109

S12

S108

S11

KS0

KS1

C1547p

S107

S10

R9220

C1447p

R101.5k

D3MA6S121

MIC+

PTT

INT SP

SP+

MC1EM-140

CP2

CP1

KR0KR1KR2KR3S1

SP1

PTT

C190.1

C61

D4MA111C26

0.1

R7560k

DS1LNJ310M6URA

C1747p

PTT

1234567891011121314151617181920212223242526

J1W5

D6D7

+5VGND

SP+

MIC+

KR3KR2KR1KR0VCC

RESBGND

RSWRBRDB

D1D2D3D4D5

PTT

FRST

D0

SPCN

GND

D6D7+5VGND

SP+

MIC+

KR3KR2KR1KR0VCCRESBGNDRSWRBRDB

D1D2D3D4D5

PTT

FRST

D0

SPCN

GND

FRONT UNIT MAIN UNIT

DSIN

ANT FILTER

R182k

R2150

C40.001

CP2

C50.001

C60.001

L44.7µH

CP1L2

44nHL3

50nH

C133p

C233p

C41710p

C4185p

C4191.5p

C318p

L132nH

C41610p

D1MA77

L9

L1025nH

EXCCL3225U1L14EXCCL3225U1

C161

C180.001

C747p

C170.001

C21470p

C24470p

C270.001

C2847p

C2322

T5V

R14R18100 10

FI4NFE31PT152Z1E9L

C260.001

C350.001

0.001

C420.001

VCC

FIL5V

R21100

220R26100

VCCT5V

RX VCO

R.FIL

Q112SC4226

D6D40HVC350

D41HVC350

D42HVC350

HVC350

R301.8k

R3222 (mod 38)

R313.9k

R353.9k

(mod 37)

R39R382.2k

R3331k10

C550.01

C54470p

L22

L2080nH

L230.25-1.9-9TL

L490.25-1.9-9TL

C7282p

C6310

C70 6p(mod 39)

1.8 µH

R34 1.8k (mod 37)

C5947p

C5812p

L193.3µH

C372

C62

C6122p

10

L4867nH

L210.47µH

R33330

10p

C37310p

C5712p

LV

FLAC N PLL

CLOCK 1

DATA 2

STROBE 3VSS 4

RFIN 5RFIN 6

VCCP 7REFIN 8

RA 9AUXIN 10 PHA 11VSSA 12PHI 13PHP 14VDDA 15RN 16RF 17LOCK 18TEST 19VDD 20

IC1SA7025DK-T

Q142SK880Y

R46

12k[F31G]4.7k[F30G]

R496.8k

R501k

R51

W410k

C1020.0047

C1090.1

CP7

C1000.001

C1010.001

C10310p

L251.8µH

REF

D

F

+5V

R52 100

R55 22k

R572k

R58 1k

R59 2k

C1040.1

C99 47p

C108 C9147p 47p

1

34

5

2

IC2TC75S51F

R53220k

C4274.7

C10747p

C1050.001

R54100

C1060.1

R34127k

VC

ON

1

GN

D

2

OU

T

3

VC

C

4 X1CR-66715.600 MHz

VCC

LVIN

S5V

BUSY

AFON

SIG1

BEP1

SPLO

FRCN

PLRS

T5V

+5VOPT11OPT12OPT13

AUX

APSTDIN

RGS1

OPT1

OPV11OPV12OPV13

R60100k

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16

1718192021222324252627282930

J1

D10DAN202U

R294 47kR295 47k

R29647k

OPT2

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16

1718192021222324252627282930

J2

R6447k

R6547k

R6647k

OPT21OPT22

SIG2

OPT23 W/N FILTERC

E

R621.2k

C873p

C980.01

C95 C96 C9747p 47p 47p

L271.8µH

L28

PLL

IN

1.8µH

R67

R307100k

100k

3

1 2FI2 SFPCA450KE4A

S5V

BEP2

VCOS

VCOS

ULCK

REM

R5V

PLST

SCKSO

SCKSO

LOOP FIL

×3 MULTIQ152SC4116

R4510

R61220k

R891.5k

R9047

C76100p

C780.001

R4710k[F30G]20K[F31G]

C800.1

C830.01

C79

0.001[F31G]0.1 [F30G]

C8147p

C8210p

C8412p

C852.5p

C86

C4390.001

5p

L261.8µH

C74 C4310.0010.047

R446.8k[F30G]4.7k[F31G]

R43820[F30G]1.5k[F31G]

R9110k

R42100k

R3421k

R35547k

R356180k

C770.1 [F30G]0.22[F31G] TX VCO

VCO SW

3

2

1 5

4

Q10XP1214

Q12

Q13 XP6501

2SC4226

D43HVC350

D44

D45HVC350

D8HVC350

HVC350

R36 10(mod 38)

R37390

R41220k

C6922p

D71SV245

C640.001

C65470p

C660.5pC67

12p

C6818p

R40100[F30G]10[F31G] L24 0.47µH L46

3.3µH

C7347p

C3760.001

R97680

C710.75p

R5VS5V

BUFFER AMP

Q62SC4215

Q72SC4215

Q8 2SC4215

Q9DTC144EUA

D5MA77

R201k

R2247k

R234.7

R2568k

R2868k

R2910k

C4618p

C47

C487p

C4912p

C502p

C510.001

C520.001

C5347p

L170.1µH

L180.1µH

L500.1µH

S5V

PLLIN

RF AMP

PRI AMP

YGR

RF AMP

L1518nH

Q32SC4226

MA77

R1214.7C157 0.47

C37

C38

0.001

0.001

C3647p

R1910k

C430.001

C39

D4

18p

L35 1µH

R15

R1668

R171.2k

1.2k

C340.001

FINAL

R1068

R1210k

D2MA713

Q22SK2973

C220.001

C310.1

C300.1

C290.001

C403

C44147p

C1456p

0.001

R8

R722

18k

Q12SK2974C20

0.001

C19150p L7

L815nH

7.5nH

L1318nH

C80.001

C1760.001

C177470p

L550nH

MP3

C9

C1222p

22pR3

R6 4.7k

R5 4.7k

R42.2k 2.2k

Q22DTA144EUA

1

3 4

5

2

IC4TC75S51F

R127100

R1293.9k

R13010k

R131330k

R132180k

C1710.01

C1724.7

C4424.7

C4400.001

C1730.01

C1740.001

R69100k

R1332.2k

R128 100k

C1750.1

T4

TM

UT

APC

RX BPF

Q23 2SB1132

D22MA2S111

D24

D23MA2S111

MA77

D25MA77

NC 1

VCC 2

NC 3

VIN 4

RIPPLE 5 NF 6

PHASE 7PREGND 8PWGND 9POUT 10

IC5 TA7368F

C167

D39MA8030H

L3947nH

L4047nH

R327

R3281k

47

C1688p

C1654p

C1631p 6p

L3856nH

L5156nH C170

9p

L3756nH

Q212SK1829R118

100k

R12015k

R1221.8k

R12347k

R124470k

R126100k

R12510k

C1450.001

C15047p

C15447p

C1550.001

C15847p C159

0.001

C1620.001

Q203SK293 D21

HVC350

D20HVC350

C1510.001

R119390k

R117270

C1565p

C1610.001

C4376p

C1607p

L3656nH

T1R115

10kT2

TON

E

CT

CS

CTCS

SIG

1

SIG

2

RX BPF

L33L520.1µH 56nH

R109100

R114 10k

R111150k

R112 10k

R113220k

R1104.7k

C1340.001

5p

C1390.001

C1420.001

C1480.001

C149470p

R1054.7k

C1330.001

C1320.01

L441µH

Q193SK206

C1401.5p

C4380.001

D19HVC350

D18HVC350

C1380.001

L310.82µH

R359

R3344.7k

470R360470

C1376p

C1410.001

C1437p

R35812

C3698p

T3

T4

MIXER

MCF1 2

46 35FI1FL-32231.650 MHz

C1272.2

C126470p

R103220

Q182SC4215

R99

R954.7

1 k

C13127p

R171 68kR17427k

R98

R361470

100kR340180k

C3601

R167 470kC457100p

C1287p

R102 C1300.001270

IF

Q172SC4116




IC3 TA31136FN

X2CDBCA450AY24

R8215k

R9347k

R9247k

C1140.1

C12410

C1150.001

C116C4220.1 470p

C1170.001

C125

C420 0.001

100p

C112220p

C1130.01

C123100p

R943.3k

C118C1190.001

C1200.001

C12247p0.001

R963.9k

L421.8µH

R8847k

C111220p

R352 10k

NO

IS

RS

SIQ16

DTA144EUA

D15DAN202U

D16DAN202U

R7715k

R78

R3474.7

22kR7912k

R814.7

C110

C2670.01

C22947p

0.1C4230.1

C2160.047

C3970.0047

C3990.0047

R8022k

R85330

R873.9k

R75100k

R73100k

R8682k

3

1 2FI3 SFPCA450KG1A

W/N

S5V

SI

RMUT

MMUT

CIRQ

SQ

IN

CCS

PTOT

D14DAP202U

D13DAP202U

MCINMCOT

CH SELECT

G

C36547p

C36647p

C36747p

C2310.0047

R289100k

C40147p

C31047p

R323100k

C1 1

C2 2

1 3

2 4

4 5

8 6

PTOT

CB10CB11CB12CB13

PTIN

PTIN

AF FIL

MCOT

A

MCIN

VAG

VAG

MICI

R18668k

R187 4.7kC2260.047

C2270.033

R188100k

+5V+5V

R17268k

R189470

Q45UN911H

C23010

R185120k

Q272SC4213

R16839k

R18412k

L471.0µH

AUDIOPROCESSOR

B

3

21

11

4

NJM2902VIC7A

C2250.047

C2134.7

C2084.7

C2150.1

C2070.1

C1932.2

R317470k

R1831.5k

C2140.1

C2170.1

C2180.0047

C1920.0047

C219 120p

R173150k

R1755.6k

C4550.1

C2240.1

R37122k

R37233k

R3734.7k

Q472SC4116

C4560.1

R37047k

C2330.1

R18015k

R28810k

C2320.0022C203

0.0022 R16610k

123456789

MICIN 12

MICGS 13

CALO 14

ALCO 15

CMPIN 16

CCHG 17

CMPO 18

TXFI 19

VDDA 20

VDDD 21

STB 22

23

RE

GS

1

VSSD34VSSA35MSKST 36PWROP 37PWRON 38PWRGS 39PWRIN 40EXPO 41ECHG 42EXPGS 43EXPIN 44

IC9TC35453F

R164 220k

C1210.1

C206 0.1

C1970.01

C2050.1

C2610.1

C1980.0047

C4000.001

R2925.6k

R318

R228100k

R229100k

R3491kC281

0.1R227100k

C2630.1

R336100k

33k

R3441k

R159100k

C199120p

R16547k

R152150k

Q26DTC144EUA

10

98

IC7C

IC29BU4053BCFV

NJM2902M

C4060.022

W/N

AF REG

+5V

75

6

IC7BNJM2902M

R222100k

C1890.001

R15539k

C444330p

C4250.001

C3750.1

D47MA8024

C202270p

C20056p

C3620.0012

R16333k

R16168k

R17656k

R17718k

R17827k

R17927k

R16268k

R1534.7

AF

ON

AF

MT

AF AMP

1 2 3

456

Q24XP6501

R1372.7k

R1383.3k

R1391k

R141 68k

C1850.1

C1860.1

C1830.001R140

1M

D26MA2S111

C18747p

C1820.018

C18847p

C18410 R136

6.8k

VLO

UT

L41EXCCL3225U1

R13410

R13510

C178100

C1790.047

C18047p

C18110R321

2.2k

AFOUT

CSFT

XIN

XOUT

C28847p

C28947p

C29347p

R23012k

R23112k

C27622p

C2780.01

W2

C29147p

C29247p

C28033p

C2790.01

R2381k

R2421M

R2431M

C2777p

C27547p

R23212k

D27MA77

R32910k

X3CR-68112.288MHzR235

1k

OPT22OPT21OPT23 SDAR237 1k

C28747p

R236 1k

R249 1k

C27347p

OPT13OPT11OPT12AUX

MS

CK

MSO

PB3/A11/TIOCD3 25

PB

4/A

12/T

IOC

A4

26

PE5/D5 1

PE6/D6 2

PE7/D7 3

PD0/D8 4

PD1/D9 5

PD2/D10 6

PD3/D11 7

PD4/D12 8

PD5/D13 9

PD6/D14 10

PD7/D15 11

CVCC 12

PC0/A0 13

VSS 14

PC1/A1 15

PC2/A2 16

PC3/A3 17

PC4/A4 18

PC5/A5 19

PC6/A6 20

PC7/A7 21

PB0/A8/TIOCA3 22

PB1/A9/TIOCB3 23

PB2/A10/TIOCC3 24

P41/AN1 51P40/AN0 52

VREF 53AVCC 54

MD0 55MD1 56

OSC2 57OSC1 58

59NMI 60

STBY 61VCC 62XTAL 63VSS 64

EXTAL 65FWE 66MD2 67PF7 68

PF6/AS 69PF5/RD 70

PF4/HWR 71PF3/LWR/ADTRG 72

PF2/WAIT 73PF1/BACK/BUZZ 74PF0/BREQ/IRQ2 75

IC14 HD64F2238FA13

R2391k

C282 47p

C283 47pC284 47p

C285 47p

C32347p

C32647p

C32747p

C32847p

C32947p

C32247p

C32147p

C29547p R247

1k

BEEP RDB WRB RS

D0

D1D2D3D4

D5D6D7RESB

RMUTMMUT

PTOT

SCLCCSFRST

L434.7µH

C26447

C26547

R226NTCG20 4M 473JT

C40247

C266470p

C262470p

R150220k

SP

LO

D/A

CPU5V+5V

VCC

VCC VCC

C2600.001

C4080.1

R3451k

R343

3.58 MHz2.8 Vp-p

1k × 2X4 CR-5633.579545 MHz

C45418p

C45315p

R216R2151M [GT]100k [GS]

100k[GT] only

R15722k

C4090.1

R3543.9k

R221 33k

VIN1 1

VOUT1 2

VOUT2 3

VIN2 4

VDD 5

LD 6

CLK 7

DI 8

VIN3 9

VOUT3 10

VOUT4 11

VIN4 12

VIN5 13VOUT5 14VOUT6 15VIN6 16DO 17VDAREF 18RESET 19GND 20VIN7 21VOUT7 22VOUT8 23VIN8 24

IC13M62364FP

SQ

IN

DIN

SC

KR

GS

1R

GS

2

MS

KE

TR

D

RT

MR

DT

FC

LR

AP

ST DSIN

VAG VAG

MOD

MO

D

BD

ET

AD

SL

MM

OD

MA

PD

AN

1

AN

0

REG

Q312SA1362

Q322SB1132

1 2 3

456Q33XP6501

R19810k

R1994.7k

R20010k

R2021k

C2410.01

C195470p

C2544.7

R20310k

C4340.1

IC12AN8005M

VCC

MIC

O

Q292SA1362 Q30

2SA1362R1954.7k

R19610k

R1974.7k

C2390.01

C2400.01

R190100kC421

0.1

C23522

C23622

C23722

C23822

Q46DTC144EUA

D46MA742

C4320.1

R298100k

C43347p

VCC

VCC

VCC

AFOUT

FS

W

S5V

S5V

S5VR5V

S5VR5V

T5V

R5V+5V

+5V

+5V

VCC

+5V

KR3KR2

KR1KR0

RESB

RSWRBRDB

D1

D2D3D4D5D6D7

FRST

D0

POWER

INT SP SW

C23447p

D31MA2S111

R19310k

F1KAB 2402322NA29

R217470

C3540.001

16151413 4

3 2 1

1211109 8

7 6 5 Z

Z1 Y0 Y1

VSS VEE INH Z0

X1X

Y VDD

CBA

X0

SPCN

AFVI

DC SW

RX SIGNAL

C4450.022

C446 820p

C447820p

R363100k

R364100k

R36539k

R368390k

1

34

5

2

IC31TC75S51F

IC19BU4053BCFV

R369180k

T5C R5C

HV

HV

SE

NC

DS

IN

DTMF DECODE

C2424.7

C257

C4100.1

0.1

C2440.001

INPUT 1

NC 2

PD 3

OSCO 4

OSCI 5

NC 6


IC17LC73872M

C2460.001

C3840.001

R2012.2k

C3850.1

C38647p

L451.8µH

R225

R28127k

R18227k

R18127k

100k

C24710

C24347

C4480.0012

R3671.5k

C4500.1

S5C

DD

ST

DTA

C

DT

PD

SD

EC

EEPROM

D/A

C2590.01

A0 1

A1 2

A2 3

VSS 4 SDA 5SCL 6WP 7VCC

8IC16 HN58X2464TI

A0 1

A1 2

A2 3

VSS SDA 5SCL 6WP 7VCC 8

IC24HN58X2464TI

1234 5

678

IC27M62334FP

R324470

C4070.1

C2580.1

C4114.7

C424470p

DA

ST

TON

E

BE

P2

BE

P1

BE

EP

SOSC

K

DT

SD

T1

T2

T3

T4

SC

LS

DA

CPU5V

CPU5V

CPU5V

CPU5V

C33847p

C29447P

C32547p

C33647p

C33547p

R219 10k

R220 100k

C383 0.1

C2680.1

R151150k

MS

CK

MS

O

FRCN

EXST

DINRGS1

RGS2MSKEFCLR

APST

C29647p

C32047p

C29847p

C28647p

C29747p

R2401k

C31947p R245

1k

R2481k

R2511k

C3060.1

R223220k

R322220k

C36447p

KR2

KR1KR0

KR3

R233100k

C40547p

C31247p

C31147p

C40447p

C30947p

R23410k

W3

R246 1k

D33MA2S111

C3160.0047

C3170.0047

R5C

NOIS

DDST

AN1

T5C

TMUT

RES

DTSD

AN0

RESET

C2710.027

C3300.1

OUT 1

VDD 2

VSS 3 NC4

CD5

R291100k

C27247p

Q392SC4116

MD2

R2501k

R2521k

C30447p

R2991k

R253100k

MM

OD

RT

M

TR

D

XR

XD

ULC

K

RS

SI

LVIN

VO

XT

RX

DT

AF

VI

AD

SL

CT

DA

SI SE

NC

SD

EC

C29947p

C30047p

C33147p

C33247p C458

0.1

C34047p

C3780.1

C33447p

C33347p

C33947p

R293

R224100k

100k

.STR 1

D 2

CLK 3

OE 15

Q1 4Q2 5

Q3 6

Q4 7Q5

14Q6 13

Q7 12

Q8 11

QS 9

QS. 10

16

8IC23 BU4094BCFV

EXSTSOSCK

XTXD

PLST

VCOSDEST

RESB

DAST

SCKSO

PLRSDUSE

C37947p

C31447p

C31547p

C31347p

C38047p

C38147p C382

47p

C30747p

C30847p

C30347p

C30247p

C30147p

R2971k

R244 1k

C37747p

REM

DTPD

RXDT

SPCN

RDTCB10CB11CB12CB13

BUSY

W/N

FSWAFMT

CTDA

S5C

12

13 14

IC7DNJM2902V

R25822k

R25947k

R26047k

R26147k

R268100

C3420.1

R264470

3

21

4

8

IC20ANJM2904V

3

2

1 5

4

Q40XP1214

C4152.2

C343820p

C3460.0033

R26647k

R26747k

R269120k

R271220k

R27268k

R254180k

R25722k

R332100k

1 2 3

5

4

IC30 TC7S66FU

R331470k

C3410.015

R2625.6k

C4260.22

R37447k

RX SIGNAL

DUSE

Q41DTC144EUA

7 6

5

IC20BNJM2904V

R21839k

R27322k

R27422k

R27522k

C347

C3450.01

0.1

C3480.1C351

0.1

Q432SC4116

R31222k

R31333k

R31433k

R31533k

R3162.7kC394

0.018C39568p

C3500.01

C3520.039 C349

0.0068

C3961

C4430.001

TX SIGNAL

R27647

R325C4130.1 10k

R3625.6k

C4490.1

C3931

C3530.001

DSIN

RESETXRXD

XTXD

DETECT

VCCAFO

UNIVERSALCONNECTOR

MIC

MICE

PTT

R279 1k

R2781k

R280 1k

C35647p

R285 10k

R192100k

R277 1k

D30MA8062 M

R2841k

C3550.001

C428

C42947p

0.1

C4520.1

C45147p

R3754.7k

D38MA2S111

987654321

MP6

R3761k

R3304.7

AFOUT

XRXD

MD2

XTXD

RES

SPCN

BATTERY

HV

GND

BDET

C3590.001

CP5

CP3

CP4 C358470pexcept[IS] except[IS]except[IS]

C3180.01

L531µH

BDET

D35 D36MA8056 M MA8056 M

D34MA8056 M

AF VR

C4140.1

VCC

987654321

J3

2625242322212019181716151413121110

1 2 3 4 5 6 7 8

OG I

4

To optional unit

To optional unit

TO ANTENNA

C228470p

C4300.001

C33747p

C324 47p

C30547p

C37147p

C41247p

R116100k

C1470.001

PT

TS

P+

SP

CN

MIC

+K

R3

KR

2K

R1

KR

0K

S0

KS

1K

S2

KS

3

11 12 13 14 15 16 17 18 19 20

NC

VR

2V

R1

VO

UT

VE

E3

VE

E2

CA

P+

CA

P–

VE

EV

DD

PM

OD

EV

SS

OS

C1

OS

C0

D7

D6

D5

D4

D3

D2

D1

D0

RD

BW

RB

SC

LP

/SM

86M

/SR

SC

SB

RE

SB

VS

/TE

V4

V3

V2

V1

V0

NC

NC

10202131 1112131415161718192223242526272829303233343536373839

C1460.001

R27018k

Q44DTC144EUA

DTA

C

CIR

Q

R36682k

DIN

DC

K

RE

GS

2X

OU

TX

INM

SK

ET

RD

RT

MR

DT

FC

LR

CS

TA

GN

DT

XF

OID

CIN

IDC

GS

TX

OU

TM

SK

INM

SK

GS

RX

INR

XG

SR

XF

O

PB

5/A

13/T

IOC

B4

PB

6/A

14/T

IOC

A5

PB

7/A

15/T

IOC

B5

PA0/

A16

PA1/

A17

/TX

D2

PA2/

A18

/RX

D2

PA3/

A19

/SC

K2

P10

/TIO

CA

0/A

20

P11

/TIO

CB

0/A

21

P14

/TIO

CA

1/IR

Q0

P13

/TIO

CD

0/T

CLK

P12

/TIO

CC

0/T

CLK

P15

/TIO

CB

1/T

CLK

P16

/TIO

CA

2/IR

Q1

P17

/TIO

CB

2/T

CLK

AV

SS

P97

/DA

1P

96/D

A0

P47

/AN

7P

46/A

N6

P45

/AN

5P

44/A

N4

P43

/AN

3

P42

/AN

2

27 28 29 30 31 32 33 34 35 36 37 39 40 41 42 43 44 45 46 47 48 49 5038

100 99 98 97 96 95 94 93 92 91

91939596

96

959391

90 89 88 87 86 85 84 83 82 81 80 79 78 77 76

PE

4/D

4P

E3/

D3

PE

2/D

2

PE

1/D

1P

E0/

D0

PG

4/C

S0

PG

3/C

S1

PG

2/C

S2

PG

1/C

S3/

IRQ

7

PG

0/IR

Q6

P70

/TM

RI0

1

P71

/TM

RI2

3P

72/T

MO

0/C

S6

P73

/TM

O1/

CS

7

P74

/TM

O2/

MR

ES

P75

/TM

O3/

SC

K3

P76

/RX

D3

P77

/TX

D3

P36

P35

/SC

K1/

SC

L0

P34

/RX

D1/

SD

A0

P33

/TX

D1/

SC

L1P

33/S

CK

0/S

DA

1P

31/R

XD

0

P30

/TX

D0

RES

24 25 26 27 28 29 30 31 32 33

1011C398 0.0047

R4810k

C56 0.75p

IC15S-80942CNMC-G9C

S1EC10SP16-47

INT SP: 0VEXT SP: 4.3V

VOXT

VOX 1

34

5

2 IC18TA75S01F

R206 100

R20815k

R209330k

R210 390k

R2111.2k

C2490.018

C250470p

C2480.018 D29

MA2S111

R20722k

C251

C35747

2.2C252470p

C2530.001

R2121.8M

MICO

C135

R24

R6356

C880.001

C8915p

C9015p

L29 33nH

1

2

34

5

6

161514134

321

121110

8 9765 Z

Z1 Y0 Y1

VSS VEE INH Z0

X1X

Y VDD

CBA

X0

S5V


[F30G]: IC-F30GT/ IC-F30GS[F31G]: IC-F31GT/ IC-F31GS

0.1

SPCN

W3

33k 0.00147p

10k

Q6

IC2TA75S01F

CPH3403

Q7CPH3403

470k

Q82SC4081

Q9DTC144EUA

100k470k

INT MICC30

C290.001

R12 C16

C240.01

C280.01

C27270pC25

R23

R20R21R22

R25180k

R2615k

R2712k

R2447k

15

34

2

INT SP : 0VEXT SP: 4.8V

RX: 0VTX : 2.2V

RX: 0VTX : 2.7V

15.6 MHz 970 mVp-p

RX: 2.6VTX: 2.5V

RX: 0.9VTX: 0V

RX: 2.6VTX: 0V

RX: 3.9VTX: 0V

RX: 5.0VTX: 0V

13.1V

SQL CLOSE: 0VSQL OPEN : 5.0V

RX: 0VTX: 5.0V

LED OFF: 0VLED ON : 5.0V

5.0V

10.3V

RX: 2.3VTX: 2.4V

RX: 0VTX: 4.9V

RX: 4.1VTX: 4.2V

RX: 4.6VTX: 0.1V

3.6V

3.4V3.7V

RX: 0VTX: 4.8V

RX: 0VTX: 2.8V

AF ON : 7.5VAF OFF: 0V

RX: 0VTX: 5.0V

12.29 MHz3.4 Vp-p

RX: 5.0VTX: 0.8V

RX: 0.8VTX: 5.0V 0.9V

RX: 0VTX: 5.0V

RX: 5.0VTX: 0V

5.0V

5.0V

5.0V

7.5V

5Vf =41 kHz

0V

Note [GT]: IC-F30GT/F31GT [GS]: IC-F30GS/F31GSSECTION 11 VOLTAGE DIAGRAM

INTRODUCTION

This service manual describes the latest service information for the IC-F30GT/GS and IC-F31GT/GS VHF TRANSCEIVER at the time of publication.

To upgrade quality, all electrical or mechanical parts and inter-nal circuits are subject to change without notice or obligation.

DANGER

NEVER connect the transceiver to an AC outlet or to a DC power supply that uses more than 10 V. This will ruin the transceiver. DO NOT expose the transceiver to rain, snow or any liq-uids.DO NOT reverse the polarities of the power supply when connecting the transceiver. DO NOT apply an RF signal of more than 20 dBm (100 mW) to the antenna connector. This could damage the transceiver’s front end.

ORDERING PARTS

Be sure to include the following four points when ordering replacement parts:1. 10-digit order numbers2. Component part number and name3. Equipment model name and unit name4. Quantity required

<SAMPLE ORDER>1110001810 S.IC TA7368F IC-F30GT MAIN UNIT 1 piece8930053170 2337 Key board IC-F31GS CHASSIS 5 pieces

Addresses are provided on the inside back cover for your convenience.

REPAIR NOTES

1. Make sure a problem is internal before disassembling the transceiver.2. DO NOT open the transceiver until the transceiver is disconnected from its power source.3. DO NOT force any of the variable components. Turn them slowly and smoothly.4. DO NOT short any circuits or electronic parts. An insulated tuning tool MUST be used for all adjustments.5. DO NOT keep power ON for a long time when the transceiver is defective.6. DO NOT transmit power into a signal generator or a sweep generator.7. ALWAYS connect a 40 dB or 50 dB attenuator between the transceiver and a deviation meter or spectrum analyser when using such test equipment.8. READ the instructions of test equipment thoroughly before connecting equipment to the transceiver.

INTERINSICALLY SAFE QUALIFICATION

When servicing intrinsically safe versions of the IC-F30GT/GS and IC-F31GT/GS the following conditions must be met.Failing to satisfy any of these conditions will invalidate the INTRINSICALLY SAFE certification.

1. Servicing the transcever should only be undertaken by suitably qualified personnel in a non-hazardous area. Never attempt to remove the case in a hazardous area.

2. ONLY the approved battery, ICOM’s BP-210FM may be used.

3. USE ONLY safety critical components as specified in the parts list (SECTION 6), should replacement of any item be necessary.

Communication EquipmentHimmelgeister Str. 100, D-40225 Düsseldorf, GermanyPhone : 0211 346047 Fax : 0211 333639URL : http://www.icomeurope.com

Unit 9, Sea St., Herne Bay, Kent, CT6 8LD, U.K.Phone : 01227 741741 Fax : 01227 741742URL : http://www.icomuk.co.uk

Zac de la Plaine, Rue Brindejonc des MoulinaisBP 5804, 31505 Toulouse Cedex, FrancePhone : 561 36 03 03 Fax : 561 36 03 00URL : http://www.icom-france.com

Crta. de Gracia a Manresa Km. 14,75008190 Sant Cugat del Valles Barcelona, SPAINPhone : (93) 590 26 70 Fax : (93) 589 04 46URL : http://www.icomspain.com

<Corporate Headquarters>2380 116th Avenue N.E., Bellevue, WA 98004, U.S.A.Phone : (425) 454-8155 Fax : (425) 454-1509URL : http://www.icomamerica.com<Customer Service>Phone : (425) 454-7619

Glenwood Centre #150-6165 Highway 17 Delta, B.C., V4K 5B8, CanadaPhone : (604) 952-4266 Fax : (604) 952-0090URL : http://www.icomcanada.com

A.B.N. 88 006 092 575290-294 Albert Street, Brunswick, Victoria, 3056, AustraliaPhone : 03 9387 0666 Fax : 03 9387 0022URL : http://www.icom.net.au

146A Harris Road, East Tamaki,Auckland, New ZealandPhone : 09 274 4062 Fax : 09 274 4708URL : http://www.icom.co.nz

6F No. 68, Sec. 1 Cheng-Teh Road, Taipei, Taiwan, R.O.C.Phone : (02) 2559 1899 Fax : (02) 2559 1874

1-1-32, Kamiminami, Hirano-ku, Osaka 547-0003, JapanPhone : 06 6793 5302Fax : 06 6793 0013URL : http://www.icom.co.jp/world/index.html

IC-F30GSIC-F31GS

IC-F30GTIC-F31GT

S-13805MZ-C1-w© 2001 Icom Inc.1-1-32, Kamiminami, Hirano-ku, Osaka 547-0003, Japan

VHF TRANSCEIVER

iC-f30gt

iC-f30gs

iC-f31gt

iC-f31gs

iC-f30gt ic

-f30gs iC

-f31gt ic

-f31gs

icom ic f 30 31 gs gt

Documents

ic ta7368f

icf31gtgs vhf transceiver

parts list section

db narrow

db wide

power supply circuits

khz narrow

khz wide