htn 27k-28k-tcsl ride-on power trowel · page 6 — htn 31v htn 27k-28k † ride-on power trowel...

PARTS MANUAL

HTN 27K-28K-TCSLRIDE-ON POWER TROWEL

P/N 21728

Revision #0 (05/12/06)

KOHLER 27 HPKOHLER 28 HP EFI

THIS MANUAL MUST ACCOMPANY THE EQUIPMENT AT ALL TIMES.

To find the latest revision of thispublication, visit our website at:

www.multiquip.com

HTN 27K-28K • RIDE-ON POWER TROWEL — PARTS MANUAL — REV. #0 (05/12/06) — PAGE 3

Grinding/cutting/drilling of masonry, concrete, metal andother materials with silica in their composition may giveoff dust or mists containing crystalline silica. Silica is abasic component of sand, quartz, brick clay, granite andnumerous other minerals and rocks. Repeated and/orsubstantial inhalation of airborne crystalline silica cancause serious or fatal respiratory diseases, includingsilicosis. In addition, California and some otherauthorities have listed respirable crystalline silica as asubstance known to cause cancer. When cutting suchmaterials, always follow the respiratory precautionsmentioned above.

WARNING

Grinding/cutting/drilling of masonry, concrete, metal andother materials can generate dust, mists and fumescontaining chemicals known to cause serious or fatalinjury or illness, such as respiratory disease, cancer,birth defects or other reproductive harm. If you areunfamiliar with the risks associated with the particularprocess and/or material being cut or the composition ofthe tool being used, review the material safety datasheet and/or consult your employer, the materialmanufacturer/supplier, governmental agencies such asOSHA and NIOSH and other sources on hazardousmaterials. California and some other authorities, forinstance, have published lists of substances known tocause cancer, reproductive toxicity, or other harmfuleffects.

Control dust, mist and fumes at the source wherepossible. In this regard use good work practices andfollow the recommendations of the manufacturers orsuppliers, OSHA/NIOSH, and occupational and tradeassociations. Water should be used for dustsuppression when wet cutting is feasible. When thehazards from inhalation of dust, mists and fumes cannotbe eliminated, the operator and any bystanders shouldalways wear a respirator approved by NIOSH/MSHA forthe materials being used.

WARNING

SILICOSIS WARNING RESPIRATORY HAZARDS

— HTN 31VHTN 27K-28K • RIDE-ON POWER TROWEL — PARTS MANUAL — REV. #0 (05/12/06) — PAGE 4

HTN 27K-28K—TABLE OF CONTENTS

MQ WHITEMAN — HTN 27K-28KRIDE-ON POWER TROWELProposition 65 Warning ............................................. 2Silicosis/Respiratory Warnings .................................. 3Table Of Contents ..................................................... 4Parts Ordering Procedures ....................................... 5Explanation Of Codes In Remarks Column .............. 6Suggested Spare Parts ............................................. 7

Component DrawingsNameplate and Decals ........................................... 8-9Pivot Assembly (Right/ Left) ............................... 10-11Steering Handles Assembly (Right/Left) ............ 12-13Steering Assist Control Assembly (Right/Left) ... 14-15Gearbox Assembly (Right-Side) ........................ 16-17Gearbox Assembly (Left-Side) ........................... 18-19Twin Pitch Assembly (Left/Right) ........................ 20-21Twin Pitch Miter Box Assembly (Left/Right) ....... 22-23Drive Assembly .................................................. 24-25Engine/Muffler/V-Belt Kohler 27 HP ................... 26-27Air Cleaner/Oil Filter/ Oil Cooler Assy. 27 HP .... 28-29Engine/Muffler/V-Belt Assy. 28 HP EFI ............... 30-31Air Cleaner/Oil Filter/ Oil Cooler Assy. 28 HP ...32-33CVT Clutch/Lower Pulley Assembly ................... 34-35V-Belt Cover/Outer Muffler Shield Assembly ..... 36-37Spider Assembly (Right) .................................... 38-39Spider Assembly (Left) ....................................... 40-41Yoke Assembly ................................................... 42-43Throttle Cable/Foot Pedals Assembly ................ 44-45Control Panel Assembly 27 HP ......................... 46-47Control Panel Assembly 28 HP EFI ................... 48-49Fuel Assembly 27 HP......................................... 50-51Fuel Assembly 28 HP EFI .................................. 52-53Battery Assembly ............................................... 54-55Spray Assembly ................................................. 56-57Light Assembly ................................................... 58-59Seat Frame Assembly ........................................ 60-61EZ-Mover Assembly ........................................... 62-63

Terms And Conditions Of Sale ................................ 64


HTN 27K-28K— PARTS ORDERING PROCEDURES

ww

w.m

ultiq

uip

.com

Ordering parts has never been easier!Choose from three easy options:

WE ACCEPT ALL MAJOR CREDIT CARDS!

When ordering parts, please supply:❒❒❒❒❒ Dealer Account Number

❒❒❒❒❒ Dealer Name and Address

❒❒❒❒❒ Shipping Address (if different than billing address)

❒❒❒❒❒ Return Fax Number❒❒❒❒❒ Applicable Model Number

❒❒❒❒❒ Quantity, Part Number and Description of Each Part

❒❒❒❒❒ Specify Preferred Method of Shipment:✓ Fed Ex/UPS ✓ DHL

■ Priority One ✓ Truck■ Ground■ Next Day■ Second/Third Day

Unless otherwise indicated by customer, all orders are treated as Standard Orders and will shipwithin 24 hours. We will make every effort to ship Air Shipments the same day the order is received,if received prior to 2PM PST. Stock Orders must be noted on fax or web order form.

If you have an MQ Account, to obtain aUsername and Password, E-mail us at:[email protected].

To obtain an MQ Account, contact yourDistrict Sales Manager for more information.

Order via Internet (Dealers Only):Order parts on-line using Multiquip’s SmartEquip website!

■ View Parts Diagrams■ Order Parts■ Print Specification Information

Note: Discounts Are Subject To Change

Goto www.multiquip.com and click on

Order Parts to log in and save!

Use the internet and qualify for a 5% Discounton Standard orders for all orders which includecomplete part numbers.*

Order via Fax (Dealers Only):All customers are welcome to order parts via Fax.Domestic (US) Customers dial:1-800-6-PARTS-7 (800-672-7877)

Fax your order in and qualify for a 3% Discounton Standard orders for all orders which includecomplete part numbers.*

Order via Phone: Domestic (US) Dealers Call:1-800-427-1244

Best Deal!

International Customers should contacttheir local Multiquip Representatives forParts Ordering information.

Non-Dealer Customers:Contact your local Multiquip Dealer forparts or call 800-427-1244 for help inlocating a dealer near you.

Effective: June 1st, 2005

Note: Discounts Are Subject To Change

NOTE


HTN 27K-28K— EXPLANATION OF CODE IN REMARKS COLUMN

The contents and part numbers listed in the parts section aresubject to change without notice. Multiquip does notguarantee the availibility of the parts listed.

NOTEWhen ordering a part that has morethan one item number listed, checkthe remarks column for help indetermining the proper part to order.

QTY. Column

Numbers Used - Item quantity can be indicated by a number,a blank entry, or A/R.

A/R (As Required) is generally used for hoses or other partsthat are sold in bulk and cut to length.

A blank entry generally indicates that the item is not soldseparately. Other entries will be clarified in the “Remarks”Column.

REMARKS Column

Some of the most common notes found in the “Remarks”Column are listed below. Other additional notes needed todescribe the item can also be shown.

Assembly/Kit - All items on the parts list with the same uniquesymbol will be included when this item is purchased.

Indicated by:“INCLUDES ITEMS W/(unique symbol)”

Serial Number Break - Used to list an effective serial numberrange where a particular part is used.

Indicated by:“S/N XXXXX AND BELOW”“S/N XXXX AND ABOVE”“S/N XXXX TO S/N XXX”

Specific Model Number Use - Indicates that the part is usedonly with the specific model number or model number variantlisted. It can also be used to show a part is NOT used on aspecific model or model number variant.

Indicated by:“XXXXX ONLY”“NOT USED ON XXXX”

“Make/Obtain Locally” - Indicates that the part can bepurchased at any hardware shop or made out of availableitems. Examples include battery cables, shims, and certainwashers and nuts.

“Not Sold Separately” - Indicates that an item cannot bepurchased as a separate item and is either part of anassembly/kit that can be purchased, or is not available forsale through Multiquip.

The following section explains the different symbols and remarksused in the Parts section of this manual. Use the help numbersfound on the back page of the manual if there are any questions.

NO. Column

Unique Symbols - All items with same unique symbol(*, #, +, %, or >) in the number column belong to the sameassembly or kit, which is indicated by a note in the “Remarks”column.

Duplicate Item Numbers - Duplicate numbers indicatemultiple part numbers are in effect for the same general item,such as different size saw blade guards in use or a part thathas been updated on newer versions of the same machine.

PART NO. Column

Numbers Used - Part numbers can be indicated by a number,a blank entry, or TBD.

TBD (To Be Determined) is generally used to show a part thathas not been assigned a formal part number at time ofpublication.

A blank entry generally indicates that the item is not soldseparately or is not sold by Multiquip. Other entries will beclarified in the “Remarks” Column.

Sample Parts List:NO. PART NO. PART NAME QTY. REMARKS1 12345 BOLT ....................... 1 .... INCLUDES ITEMS W/*2* WASHER, 1/4 IN. ........... NOT SOLD SEPARATELY2* 12347 WASHER, 3/8 IN. .... 1 .... MQ-45T ONLY3 12348 HOSE .................... A/R .. MAKE LOCALLY4 12349 BEARING ................ 1 .... S/N 2345B AND ABOVE


HTN 27K-28K— SUGGESTED SPARE PARTS

Part numbers on this Sug-gested Spare Parts List maysupersede/replace the P/Nshown in the text pages ofthis book.

HTN 27K/28K KOHLER ENGINES

1 UnitQty. P/N Description4 21495 ............TROWEL ARM, LH4 2829 ..............TROWEL ARM, RH4 11903 ............LEVER TROWEL ARM (L.S.)4 11904 ............LEVER TROWEL ARM (R.S.)2 20938 ............THRUST COLLAR KIT2 12785 ............SPIDER KIT

20 0166 A ...........WASHER20 1876 ..............JAM NUT20 0164 B ...........SCREW4 11039 ............BUSHING4 11595 ............SPRING (L.S.)4 11594 ............SPRING (R.S.)

20 1875 ..............WASHER20 1322 ..............SCREW ASSY, ARM RETAINING20 1162 A ...........CAP GREASE FITTING4 0131 A ...........SCREW (HHC 1/4 - 20 X 3/4)4 0948 ..............WASHER, FLAT1 20138 ............BELT, DRIVE CVT

20 0181 B ...........WASHER 1/4 IN1 11418 ............FUEL CAP/GAUGE (ENG)1 19633 ............BUSHING, RUBBER FUEL1 2124 ..............CABLE, THROTTLE (FOOT PEDAL)1 2153 ..............ROD END, FEM RH (THROTTLE CABLE)6 11143 ............ROD END, FEM RH 1/2 - 20 (STEERING)4 2063 ..............ROD END, MALE RH 3/8 - 24 (STEERING)2 11142 ............ROD END, MALE RH 1/2 - 20 (STEERING)4 ......................BLADE ASSY. CONTACT UNIT SALES DEPT/ ACCESSORY ITEM

Qty. P/N Description10 10031 .................... WASHER 1/4 IN.1 12548 .................... SPRAY PUMP1 392292 .................. SPRAY NOZZEL1 2108 ...................... CAP, SPRAY TANK1 2673 ...................... CIRCUIT BREAKER 30A, 12V1 4682 ...................... TOGGLE SWITCH1 8381 ...................... BOOT, TOGGLE SWITCH1 12005 .................... ENGINE-OFF SAFETY SWITCH1 12018 .................... CONNECTOR, RELAY1 12017 .................... RELAY, ENGINE-OFF SWITCH1 2405002S.............. FUEL FILTER, PRIMARY, 27 HP1 2405010S.............. FUEL FILTER, SECONDARY, 27 HP1 0450905002 .......... FUEL FILTER, CANNISTER 28 HP1 2439320S.............. FUEL PUMP, 28 HP1 2408303S.............. ELEMENT, AIR FILTER 27/28 HP1 2408303S.............. ELEMENT, PRE-CLEAN 27/28 HP1 5205002S.............. OIL FILTER, 27HP1 1205001S.............. OIL FILTER, 28, HP2 2513212S.............. SPARK PLUG, 27 HP2 1213202S.............. SPARK PLUG, 28 HP1 20138 .................... BELT, CVT-COMET1 5475521S.............. REGULATOR, RECTIFIER 27HP1 2540308S.............. REGULATOR, RECTIFIER 28HP

NOTE


HTN 27K-28K— NAMEPLATE AND DECALS

DECALS


HTN 27K-28K— NAMEPLATE AND DECALS

NAMEPLATE AND DECALS

NO. PART NO. PART NAME QTY. REMARKS1 11246 DECAL SET, INTERNATIONAL STDS ................... 1 ............. INCLUDES ITEMS W/*1A* DECAL, BELT DRIVE 11B* DECAL, GEAR DRIVE 11C* DECAL, CHECK OIL 11D* DECAL, HOT SURFACE 11E* DECAL, LIFT POINT 11F* DECAL, LUBRICATION 11G* DECAL, CLOCKWISE ROTATION 11H* DECAL, COUNTER-CLOCKWISE ROTATION 12 13118 DECAL, POWDER COATED 13 10818 DECAL, MQ-WHITEMAN 24 X 3 14 2300 DECAL, AL PITCH RH 15 2332 DECAL, AL PITCH LH 16 2634 DECAL, SPRING SAFETY 27 1499 DECAL, MQ-WHITEMAN RED/TOWER 28 36099 DECAL, SAFETY CLOTHING ISO BLUE ...............1 ............. REPLACES 112479 2814 DECAL, CONTROL PANEL 110 20923 DECAL, HTN SERIES 111 SERIAL PLATE....................................................... 1 ............. CONTACT PARTS DEPT.12 35137 DECAL, READ OPERATOR'S MANUAL 1


HTN 27K-28K— PIVOT ASSY. (RIGHT/LEFT)

PIVOT ASSY. (RIGHT/LEFT)


PIVOT ASSY. (RIGHT/LEFT)

NO. PART NO. PART NAME QTY. REMARKS1 1023 SCREW, HHC 3/8 - 16 X 1-1/4 162 0166 A WASHER, LOCK, 3/8 MED. 203 2304 ROCKER BLOCK WITH BUSHING 44 2146 PIVOT, DOUBLE ROCKER 15 10138 SCREW, SHS 5/16 - 18 X 5/16 46 12412 ARM, PIVOT RIGHT 17 4196 SCREW, HHC 3/8 - 16 X 3/4 48 5054 WASHER, LOCK 1/2 MED 29 8136 SCREW, HHC 1/2 - 20 X 1-1/2 210 12413 ARM, PIVOT LEFT 111 2312 ROCKER BLOCK, WITH SET 212 2145 PIVOT JOINT, SINGLE ROCKER 113 1394 SCREW, FHSC 3/8 - 16 X 1 414 11248 PLATE, GEARBOX ADAPTOR 2

HTN 27K-28K— PIVOT ASSY. (RIGHT/LEFT)


HTN 27K-28K— STEERING HANDLES ASSY. (RIGHT/LEFT)STEERING HANDLES ASSY. (RIGHT/LEFT)


HTN 27K-28K— STEERING HANDLES ASSY. (RIGHT/LEFT)

STEERING HANDLES ASSY. (RIGHT/LEFT)

NO. PART NO. PART NAME QTY. REMARKS1 0189 GRIP, HANDLE LT 12 11142 ROD END, 1/2 - 20 MALE RH 33 11177 HANDLE, TUBE 24 2197 NUT, ACORN, 1/4 - 20 25 5277 SCREW HHC 1/4 - 20 X 1-1/2 26 12425 HANDLE, STEERING, LOWER 27 11141 SPACER, ROD END 58 11143 ROD END, 1/2 - 20 FEMALE RH 39 11173 THREADPIECE, 1/2 - 20 X 2 PLTD 110 11146 NUT, HEX JAM 1/2 - 20 511 11144 SCREW, SHC 1/2 - 20 X 2 PLTD 112 10133 NUT, NYLOC 3/8 -16 813 11145 SCREW, SHC 1/2 -20 X 3 PLTD 114 0131 A SCREW HHC 1/4 - 20 X 3/4 115 11205 ROD, L/R MOTION 116 10024 NUT, NYLOC 1/4 - 20 117 0447 WASHER, FLAT 1/2 SAE 318 12426 NUT, SLOTTED 3/4 - 16 PLTD 219 1023 SCREW, HHC 3/8 - 16 X 1-1/4 GR5 820 10136 WASHER, FLAT SAE 3/8 1621 2219 PIN, COTTER 1/8 X 1-1/2 222 10176 NUT, NYLOC 1/2 - 13 223 12193 LEVER, L/R CONTROL 124 2267 GRIP, HANDLE RT 125 EM963105 SCREW, HHC 1/2 - 13 X 2 .....................................3 .................. REPLACES 6159 A26 8151 WASHER, FLAT SAE 3/4 427 12374 STEERING CONTROL RS ASSIST 128 12375 STEERING CONTROL LS ASSIST 129 0735 BEARING CUP, TIMKEN #A6157 430 0735 A BEARING CONE TIMKEN #A6075 431 11149 BEARING, SB-204-12 432 11138 BEARING HSG, P-BLOCK 47MPB(2PC) 4


HTN 27K-28K— STEERING ASSIST CONTROL ASSY. (LEFT/RIGHT)

STEERING ASSIST CONTROL ASSY. (LEFT/RIGHT)


HTN 27K-28K— STEERING ASSIST CONTROL ASSY. (LEFT/RIGHT)

STEERING ASSIST CONTROL ASSY. (LEFT/RIGHT)

NO. PART NO. PART NAME QTY. REMARKS1 11146 NUT, HEX JAM 1/2 -20 PLTD 62 11142 ROD END, 1/2 - 20 MALE RH 63 EM963105 SCREW, HHC 1/2 -13 X 2 .................................... 10 .................. REPLACES 6159 A4 10176 NUT, NYLOC 1/2 -13 105 12200 STEERING ASSIST ASSEMBLY 26 0447 WASHER, FLAT 1/2 SAE 87 11143 ROD END, 1/2 - 20 FEMALE RH 48 5054 A WASHER, LOCK 1/2 MED 29 8136 SCREW, HHC 1/2 - 20 X 1-1/2 210 11127 LEVER, STEERING CONTROL 211 0131 A SCREW/ HHC 1/4 - 20 X 3/4 1212 11150 BEARING, SB-201 - 8 613 11139 HOUSING SET, BEARING FLANGE 40M-2 6


HTN 27K-28K— GEARBOX ASSY. (RIGHT-SIDE)GEARBOX ASSY (RIGHT-SIDE)


HTN 27K-28K— GEARBOX ASSY. (RIGHT-SIDE)GEARBOX ASSY (RIGHT-SIDE)NO. PART NO. PART NAME QTY. REMARKS1% 12906 SHAFT, GEARBOX INPUT W/FAN 12% 5031 A SCREW, RHM 1/4-20 X1/2 43% 0948 WASHER, FLAT, 1/4 SAE 54% 12981 SHROUD, GB FIN COVER, RIGHT 15% 12765 GEAR BOX HD RIDER 1-1/4 SHAFT .....................1 .................. HOUSING ONLY6% 0121 A FITTING, PLUG 3/8MP SQUARE HEAD 37% 10989 STUD, N10 - 32 X 3/4 18% 12908 RIGHT HAND WORM 19% 1132 VENT, AIR 110% 12583 SPACER, X 11D X 1.168L 111*% 9045 BEARING, CONE TIMKEN #1986 212*% 0232 A BEARING, CUP, TIMKEN #1932 213+% 2309 O-RING, 2 -13/16” VINTON 214+% GASKET, RED ........................................................ 1 .................. SOLD AS KIT ONLY15% 2307 FLANGE, COUNTERSHAFT 216% 10031 WASHER, EXT SHKP 1/4 817% 2295 SCREW, HHC 1/4-20 X 7/8 818% 12909 SEAL, OIL, NATIONAL #471689V 219% 10921 FAN, RIGHT (CW) 120% 0730 SCREW, HHC 1/4-20 X 1 121% 19477 SCREW, HHC, WASHER 10-32 X 1/2 122% 2203 WASHER, FLAT #10 SAE 423% 10019 NUT, NYLOC 10-32 124% 10894 RIGHT-SIDE FAN COVER 125 12788 GEAR BOX ASSY., COMPLETE RIGHT-SIDE....... 1 .................. INCLUDES ITEMS W/%26 2618 GASKET KIT ..........................................................1 .................. INCLUDES ITEMS W/+27% 12833 BEARING KIT ........................................................ 1 .................. INCLUDES ITEMS W/*28% 1313 SCREW, FHSC 3/8 - 24 X 3/4 PLAIN 129% 9120 RETAINER, DRIVEN PULLEY 130% 2048 COUPLER - 7/8” ID 131% 2323 KEY, 1/4 X1/4 X13/16 132% 10450 SCREW, SHS 10-32 X1/4 133% 1139 KEY, WOODRUFF #21 HARDENED 134+% 12769 SEAL, 1-1/4 DIA NAT # 471766V 135% 20875 SCREW, FHS 5/16 -18 X 3/4 436% 12770 RING, SNAP TRUARC #5100 - 125 137% 12766 COVER, HD GEARBOX 1-1/4 SHAFT 138+% 9038 O-RING, A - 264 VITON 139*% 12767 BEARING, CUP, TIMKEN #15245 240*% 12768 BEARING, CONE TIMKEN #15126 241% 12764 SHAFT, MAIN HD RIDER 1-1/4 SHAFT 142% 9180 KEY, 5/16 X 2 -1/4 HRDND 143% 12772 GEAR, WORM RH. HT 1-1/4 144+% GASKET, RED ........................................................ 1 .................. SOLD AS KIT ONLY45+% GASKET, GREEN ..................................................1 .................. SOLD AS KIT ONLY46+% GASKET, BLUE ...................................................... 1 .................. SOLD AS KIT ONLY47+% GASKET, BROWN ..................................................1 .................. SOLD AS KIT ONLY48+% GASKET, YELLOW.................................................1 .................. SOLD AS KIT ONLY


HTN 27K-28K— GEARBOX ASSY. (LEFT-SIDE)GEARBOX ASSY (LEFT-SIDE)


HTN 27K-28K— GEARBOX ASSY. (LEFT-SIDE)

GEARBOX ASSY (LEFT-SIDE)NO. PART NO. PART NAME QTY. REMARKS1% 12906 SHAFT, GEARBOX INPUT W/FAN 12% 5031 A SCREW, RHM 1/4-20 X1/2 43% 0948 WASHER, FLAT, 1/4 SAE 54% 12982 SHROUD, GB FIN COVER, LEFT 15% 12765 GEAR BOX HD RIDER 1-1/4 SHAFT .....................1 .................. HOUSING ONLY6% 0121 A FITTING, PLUG 3/8MP SQUARE HEAD 37% 10989 STUD, N10 - 32 X 3/4 18% 12907 LEFT HAND WORM 19% 1132 VENT, AIR 110% 12583 SPACER, X 11D X 1.168L 111*% 9045 BEARING, CONE TIMKEN #1986 212*% 0232 A BEARING, CUP, TIMKEN #1932 213+% 2309 O-RING, 2 -13/16” VINTON 214+% GASKET, RED ........................................................ 1 .................. SOLD AS KIT ONLY15% 2307 FLANGE, COUNTERSHAFT 216% 10031 WASHER, EXT SHKP 1/4 817% 2295 SCREW, HHC 1/4-20 X 7/8 818% 12909 SEAL, OIL, NATIONAL #471689V 219% 10922 FAN, LEFT (CCW) 120% 0730 SCREW, HHC 1/4-20 X 1 121% 19477 SCREW, HHC, WASHER 10-32 X 1/2 122% 2203 WASHER, FLAT #10 SAE 423% 10019 NUT, NYLOC 10-32 124% 10893 LEFT-SIDE FAN COVER 125 12789 GEAR BOX ASSY., COMPLETE LEFT-SIDE .........1 .................. INCLUDES ITEMS W/%26 2618 GASKET KIT ..........................................................1 .................. INCLUDES ITEMS W/+27% 12833 BEARING KIT ........................................................ 1 .................. INCLUDES ITEMS W/*28% 1313 SCREW, FHSC 3/8 - 24 X 3/4 PLAIN 129% 9120 RETAINER, DRIVEN PULLEY 130% 2048 COUPLER - 7/8” ID 131% 2323 KEY, 1/4 X1/4 X13/16 132% 10450 SCREW, SHS 10-32 X1/4 133% 1139 KEY, WOODRUFF #21 HARDENED 134+% 12769 SEAL, 1-1/4 DIA NAT # 471766V 135% 20875 SCREW, FHS 5/16 -18 X 3/4 436% 12770 RING, SNAP TRUARC #5100 - 125 137% 12766 COVER, HD GEARBOX 1-1/4 SHAFT 138+% 9038 O-RING, A - 264 VITON 139*% 12767 BEARING, CUP, TIMKEN #15245 240*% 12768 BEARING, CONE TIMKEN #15126 241% 12764 SHAFT, MAIN HD RIDER 1-1/4 SHAFT 142% 9180 KEY, 5/16 X 2 -1/4 HRDND 143% 12771 GEAR, WORM LH. HT 1-1/4 144+% GASKET, RED ........................................................ 1 .................. SOLD AS KIT ONLY45+% GASKET, GREEN ..................................................1 .................. SOLD AS KIT ONLY46+% GASKET, BLUE ...................................................... 1 .................. SOLD AS KIT ONLY47+% GASKET, BROWN ..................................................1 .................. SOLD AS KIT ONLY48+% GASKET, YELLOW.................................................1 .................. SOLD AS KIT ONLY


HTN 27K-28K— TWIN PITCH ASSY. (LEFT /RIGHT)TWIN PITCH ASSY. (LEFT/RIGHT)


HTN 27K-28K— TWIN PITCH ASSY. (LEFT /RIGHT)

TWIN PITCH ASSY. (LEFT/RIGHT)NO PART NO PART NAME QTY. REMARKS1#$ 4403 KNOB, SHIFT 12#$ 3231 SPACER 13# 1615 CRANK LEVER 14#$ 1733 HARDENED WASHER 15#$ 1616 SHOULDER BOLT 16+% 2620 SCREW, BHC 10 – 24 X 5/8 47 10114 WASHER, EXT. SHKP, #8 48 2621 FITTING GREASE 19 1162 A CAP, GREASE ZERK/2 110# 4014 SCREW, 2–3/16 P-K TYPE U-DRIVE 211 2300 DECAL, AL PITCH, RH ..................................... 1 ............ RIGHT-SIDE ONLY12# 1528 SCREW, SHSS 1/4–20 X 5/16" 213# 0185 SCREW, SHSS 3/8–16 X 3/8" 114+% 2649 COVER, PITCH CONT HOUSING 115+% 1579 SCREW, HHC 1/4–20 X 1/2 116+% 0181 B WASHER, LOCK, 1/4 MED 417+% 0948 WASHER, FLAT, 1/4 SAE 118+% 1530 GEAR, SLAVE, TPC 119+% 1733 WASHER, 1/32 X 1/2 HARDENED 820+% 1529 GEAR, MASTER, TPC 121+% 0161 C WASHER, LOCK 5/16 MED 122+% 0655 SCREW, HHC 5/16 –18 X 3/4 123+% 10546 HOUSING, PITCH CONTROL, 1–3/4 124+% 2621 ZERK, GREASE STR 1/4–28 125+% 1162 A CAP, GREASE ZERK 126 1617 LEVER ASSY, TROWEL ADJUSTMENT .......... 1 ............ INCLUDES ITEMS W/#27 2737 KNOB, KIT ........................................................ 1 ............ INCLUDES ITEMS W/$28 2332 DECAL, AL PITCH, LH ..................................... 1 ............ LEFT SIDE ONLY29 12386 TOWER ASSEMBLY, LEFT TPC....................... 1 ............ INCLUDES ITEMS W/+29 12385 TOWER ASSEMBLY, RIGHT TPC .................... 1 ............ INCLUDES ITEMS W/%30+% 10512 RING, SNAP, TRUARC 5160 – 75 131+% 2170 BEARING, RACE, TORR #TRA 1220 332+% 1604 BEARING, BALL THRUST 133+% 1612 BEARING, ALUM – PITCH CONTR 134+% 2169 BEARING, THRUST, TORR #NTA 1220 135+% 2367 SET COLLAR .................................................... 1 ............ INCLUDES ITEM W/■36+%■ 0685 SCREW, SHS 5/16 - 18 X 5/16 137+% 0126 KEY, WOODRUFF #9 138+ 10511 SHAFT, PITCH CONTROL, LH TPC ................. 1 ............ LEFT SIDE ONLY39% 10510 SHAFT, PITCH CONTROL, RH TPC ................. 1 ............ RIGHT SIDE ONLY40+% 1733 WASHER, 1/32 X 1/2 HARDENED 441+% 2007 SHAFT 142+% 1578 KEY, WOODRUFF, #3 143+% 11654 PIN, ROLL 1/8 X 1 PLATED 144+% 2311 SPACER, 3/4 X 1/2 X 0.8L 145+% 11583 U-JOINT, PITCH CONTROL 146+% 1586 PIN, ROLL 1/8 X 3/4 147+% 12365 SHAFT, PITCH CONTROL 148+ 10722 SLIDE BLOCK, LH PITCH CONTROL .............. 1 ............ LEFT SIDE ONLY49 % 10721 SLIDE BLOCK, RH PITCH CONTROL.............. 1 ............ RIGHT SIDE ONLY50+% 10382 BOLT, SHOULDER 3/8 X 3/8 LONG 151+% 10723 PIN, SPIROL 3/16 X 1 3/8 HD 152+% 12460 CABLE, PITCH ASSEMBLY 153+% 1116 NUT, BRASS JAM 5/16 –18 2NOTE: INDICATED QUANTITIES ARE FOR ONE PITCH TOWER. IF ORDERING FOR TWO PITCH TOWERS DOUBLE QUANTITY.


HTN 27K-28K— TWIN PITCH MITER BOX ASSY. (LEFT/ RIGHT)TWIN PITCH MITER BOX ASSY. (LEFT/RIGHT)


HTN 27K-28K— TWIN PITCH MITER BOX ASSY. (LEFT /RIGHT)

TWIN PITCH MITER BOX ASSY. (LEFT/RIGHT)

NO PART NO PART NAME QTY. REMARKS1* 0181 B WASHER, LOCK, 1/4 MED 102* 11583 U-JOINT, PITCH CONTROL 13* 1162 A CAP, GREASE ZERK 14 10548 TUBE, PITCH CONTROL 15* 11654 PIN, ROLL 1/8 X 1" 36* 1578 KEY, WOODRUFF, #3 67* 1733 WASHER, 1/32 X 1/2 HARDENED 68 2012 SLEEVE, ADJ – LONG, RIDER 19 2156 SPRING, COIL 110* 2621 ZERK, GREASE STR 1/4 – 28 111 0202 SCREW, HHC 5/16 –18 X 1 412 0300 B WASHER, FLAT, 5/16 SAE 413* 0730 SCREW, HHC 1/4 –20 X 1 814* 11653 SLEEVE, W/U-JOINT 115* 1577 SET COLLAR, 1/2 116* 1987 MITER BOX, PITCH CONTROL 117* 1988 MITER BOX, BEARING CAP RIDERS 118* 2021 SHAFT, MITER VERTICAL 119* 2022 SHAFT, MITER 220* 2062 GEAR, MITER 121* 2845 SHAFT, MITER BOX HORIZ 122* 4514 SCREW, HHC 1/4 –20 X 5/8 423 5283 NUT, NYLOC 5/16 –18 424 11655 MITER BOX ASSEMBLY ........................................... 1 ............ INCLUDES ITEMS W/*

NOTE: INDICATED QUANTITIES ARE FOR ONE MITER BOX. IF ORDERING FOR TWO MITER BOXES, DOUBLE QUANTITY.


HTN 27K-28K— DRIVE ASSY.DRIVE ASSEMBLY


HTN 27K-28K— DRIVE ASSY.DRIVE ASSEMBLY

NO. PART NO. PART NAME QTY. REMARKS1 21494 DRIVE ASSEMBLY, W/COMET ....................................... 1 ............ INCLUDES ITEMS W/*2* 20186 PLATE, BEARING MOUNT 23* 300518C KEY, 1/4 X 3/16 X 3" 14* 0126 KEY, WOODRUFF #9 45* 2090 RING, SNAP TRUARC #5100 - 106 46* 1146 SCREW, FHSC 5/16 - 18 X 1 NYLOC 27* 2037 WASHER, RETAINING 28* 2029 COUPLER, 1 ID. RIDER 19* 10337 BEARING, PILLOW BLOCK FAF YAK- 1 210* 20044 SPACER, BEARING SHAFT 111* 10136 WASHER, FLAT 3/8 SAE 412* 10133 NUT, NYLOC 3/8 - 16 413* 21475 PULLEY, CVT LOWER COMET 302538C 114* 20043 SHAFT, DRIVE BEARING 115* 20116 O-RING, SIZE- 031 BUNA 116* 21491 PANEL, SPLASH RIGHT 117* 12590 COUPLER, CV JOINT COMET CLUTCH 118* 20056 SCREW, HHC 1/4 - 28 X 3/4 GRD. 8 319* 2052 JOINT, CV W/BOOT ........................................................ 4 ............ INCLUDES ITEM W/%20* 11108 GASKET, CV JOINT BOOT 421* 1662 TIE WRAP, BLACK 422* 0243 SCREW, SHC 5/16 - 18 X 1-3/4 323* 0161 C WASHER, LOCK, 5/16 MEDIUM 1224* 2074 SHAFT, CV JOINT, 9.13 LG 125*% 2259 BOOT, CV JOINT 426* 2186 SCREW, SHC 5/16 -18 X 2 -1/4 PLTD 927* 10748 SHAFT, CV JOINT 10.81 LG 128* 20187 SCREW, HHC 3/8-16 X 1-1/2 SS 429* 10909 KEY, 3/16 X 11/16 1


HTN 27K-28K— ENGINE/MUFFLER/BELT ASSY. (KOHLER 27 HP)

ENGINE/MUFFLER/BELT ASSY. (KOHLER 27 HP)


HTN 27K-28K— ENGINE/MUFFLER/BELT ASSY. (KOHLER 27 HP)

ENGINE/MUFFLER/BELT ASSY. (KOHLER 27 HP)

NO. PART NO. PART NAME QTY. REMARKS1 M841080S NUT, FLANGE MUFFLER 42 2404149S GASKET, EXHAUST MANIFOLD 23 2507204S STUD, EXHAUST 44 M650012S SCREW, HEX FLANGE 45 2431404S INNER HEAT SHIED, MUFFLER 17 2406836S MUFFLER, O.F. SIDE OUTLET 18 2412690S BRACKET, MUFFLER 19 M839020S SCREW, HEX FLANGE 210 21421 ENGINE, KOHLER 27HP 111 1207 SCREW, HHC 5/16 -18 X 1-3/4 412 0300 B WASHER, FLAT 5/16 SAE 413 0161 C WASHER, LOCK 5/16 MED 815 20444 KEY, 0.25 SQ X 2.75 116 20138 BELT, CVT - COMET 117 20846 CLUTCH, 1 - 7/16 CVT COMET 118 21528 SPACER, 1.415 O.D. X .66 I.D. X 1.5 L 129 4703 WASHER, LOCK, 5/8 MED 120 21316 SCREW, HHC 5/8 - 18 X 3 121 5283 NUT, NYLOC 5/16 - 18 422 21489 WASHER, FLAT 1.437 X .032 THK 1


HTN 27K-28K— AIR CLEANER/OIL FILTER/OILCOOLER ASSY. (27HP)

AIR CLEANER/OIL FILTER/COOLER ASSY. (27 HP)


AIR CLEANER/OIL FILTER/COOLER ASSY. (27 HP)

NO. PART NO. PART NAME QTY. REMARKS1 5475501S KIT, KNOB W/SEAL ................................... 1................ INCLUDES ITEMS W/*2* 2534104S KNOB, AIR CLEANER COVER 13* 2415320S O-RING 14 2409667S COVER, AIR CLEANER 15 1210001S WINGNUT 16 2409601S COVER, INNER AIR CLEANER 17 230046S SEAL BREATHER 18 2408305S ELEMENT, PRE-CLEANER 19 2408303S ELEMENT, AIR FILTER 110 2408653S SCREW, HEX. FLANGE M6X1.0X16 211 2412688S BRACKET, AIR CLEANER BASE 112 2409437S BASE, A/C W/STRTR SIDE DIMPLE 113 2404106S GASKET, AIR CLEANER BASE 114 2655 HOUR METER 115 8239 RIVET, POP 1/8 DIA X .400 ALUMINUM 216 2513212 SPARK PLUG 217 5205002S FILTER, OIL 118 19317 PLUG, OIL DRAIN 119 TBD FITTING, 90 DEGREE 120 370628 FITTING, BRASS 45 6 BARB 1/4MP 121 60045 HOSE, 3/8 ID PUSHLOCK 122 1947 CLAMP, HOSE WORM 1/4 - 5/8 223 12237 FITTING, PUSH-ON 6 HOSE 6MJ 124 5475521S ALUMINUM BASE OIL COOLER .............. 1................ INCLUDES ITEMS W/#24A# 2813601S NIPPLE, OIL FILTER 124B# 2415321S O-RING, OIL COOLER 125 2540305S REGULATOR, RECTIFIER 126 12236 FITTING, CAP 6F JHEX 127 24126130S BRACKET, AIR CLEANER 128 2404106S GASKET, AIR CLEANER BASE 129 2416454S MANIFOLD, INTAKE .................................. 1................ INCLUDES ITEMS W/%30% 2404153S GASKET, CARBURETOR 131% 2415327S O-RING, INTAKE PORT 232% M651040S SCREW, HEX. FLANGE M6X1.0X40 4

HTN 27K-28K— AIR CLEANER/OIL FILTER/OILCOOLER ASSY. (27HP)


HTN 27K-28K— ENGINE/MUFFLER/BELT/CLUTCH ASSY. (28 HP EFI)

ENGINE/MUFFLER/BELT/CLUTCH ASSY. ( 28 HP EFI)


HTN 27K-28K— ENGINE/MUFFLER/BELT/CLUTCH ASSY. (28 HP EFI)

ENGINE/MUFFLER/BELT/CLUTCH ASSY. ( 28 HP EFI)

NO. PART NO. PART NAME QTY. REMARKS1 M841080S NUT, FLANGE MUFFLER 42 2404149S GASKET, EXHAUST MANIFOLD 23 2507204S STUD, EXHAUST 44 M650012S SCREW, HEX FLANGE 45 2431421S INNER HEAT SHIED, MUFFLER 16 2441805S SENSOR, OXYGEN 17 2406851S MUFFLER 18 2412690S BRACKET, MUFFLER 19 M839020S SCREW, HEX FLANGE 210 21422 ENGINE, KOHLER 28HP EFI 111 1207 SCREW, HHC 5/16 -18 X 1-3/4 412 300 B WASHER, FLAT 5/16 SAE 413 0161 C WASHER, LOCK 5/16 MED 815 20444 KEY, 0.25 SQ X 2.75 116 20138 BELT, CVT - COMET 117 20846 CLUTCH, 1 - 7/16 CVT COMET 118 21528 SPACER, 1.415 O.D. X .66 I.D. X 1.5 L 129 4703 WASHER, LOCK, 5/8 MED 120 21316 SCREW, HHC 5/8 - 18 X 3 121 11819 SCREW, HHC FLNGD 1/4 - 20 X 3/4 722 21489 WASHER, FLAT 1.437 X .032 THK 1


HTN 27K-28K— AIR CLEANER/OIL FILTER/COOLER ASSY. (28 HP EFI)

AIR CLEANER/OIL FILTER/COOLER ASSY. ( 28 HP EFI)


HTN 27K-28K— AIR CLEANER/OIL FILTER/COOLER ASSY. (28 HP EFI)

AIR CLEANER/OIL FILTER/COOLER ASSY. ( 28 HP EFI)

NO. PART NO. PART NAME QTY. REMARKS1 5475501S KIT, KNOB W/SEAL .............................................. 1 ............. INCLUDES ITEMS W/*2* 2534104S KNOB, AIR CLEANER COVER 13* 2415320S O-RING 14 2409667S COVER, AIR CLEANER 15 1210001S WINGNUT 16 2409601S COVER, INNER AIR CLEANER 17 2403212S SEAL BREATHER 18 2408305S ELEMENT, PRE-CLEANER 19 2408303S ELEMENT, AIR FILTER 110 2408654S SCREW, M6 X1X12 211 2407207S STUD 112 2409435S BASE, AIR CLEANER 113 2404136S GASKET, AIR CLEANER BASE 114 2655 HOUR METER 115 8239 RIVET, POP 1/8 DIA X .400 ALUMINUM 216 1213202S SPARK PLUG 217 1205001S FILTER, OIL 118 19317 PLUG, OIL DRAIN 119 TBD FITTING, 90 DEGREE 120 370628 FITTING, BRASS 45 6 BARB 1/4MP 121 60045 HOSE, 3/8 ID PUSHLOCK 122 1947 CLAMP, HOSE WORM 1/4 - 5/8 223 12237 FITTING, PUSH-ON 6 HOSE 6MJ 124 2459431S KIT, COOLER 125 2540308S REGULATOR, RECTIFIER EFI 126 12236 FITTING, CAP 6F JHEX 127 2451902S COIL, IGNITION 228 24126130S BRACKET, AIR CLEANER BASE 1


HTN 27K-28K— CVT CLUTCH/LOWER PULLEY ASSY.CVT CLUTCH/LOWER PULLEY ASSY.


CVT CLUTCH/LOWER PULLEY ASSY.

NO. PART NO. PART NAME QTY. REMARKS1 302608C FIXED FACE & POST 12 302607C MOV. FACE & BRUSH ASSY. 13 302669C SPRING KIT (RED) 14 302235C ARM ASSY. (138 GRMS.) 35 300919C RETAINING RING 16 300917C RETRACTOR 17 300920C SPACER 18 302723C RAMP PLATE ASSY. W/STOPS 19 302520C RETAINING WASHER 110 302170C KEY-ENGINE, 3/8 X 1/4 111 302512C FIXED FACE, W/NUTS AND FAN 112 302657C MOVEABLE FACE ASSY. W/FAN 113 302307A CAM SLIPPER KIT (6) 114 300021C SPRING (GREEN) 115 300061C WOODRUFF KEY 116 302655C FIXED CAMP, 35 DEG. SHAVED 117 300047C RETAINING RING 118 300518C KEY-SHAFT, 1/4 X 3/16 119 302505C SPACER 1.39 ID X .27 THK. 1

HTN 27K-28K— CVT CLUTCH/LOWER PULLEY ASSY.


HTN 27K-28K— V-BELT C0VER/OUTER MUFFLER SHIELD ASSY.

V-BELT COVER/OUTER MUFFLER SHIELD ASSY.


HTN 27K-28K— V-BELT C0VER/OUTER MUFFLER SHIELD ASSY.

V-BELT COVER/OUTER MUFFLER SHIELD ASSY.

NO. PART NO. PART NAME QTY. REMARKS1 21462 SHIELD, MUFFLER OUTER 12 11819 SCREW, HHC FLANGED 1/4-20X3/4" 73 21312 GUARD, BELT REAR 14 21309 GUARD, BELT 15 11534 NUT, U-TYPE 1/4-20 7


HTN 27K-28K— SPIDER ASSY. (RIGHT)SPIDER ASSY. (RIGHT)


HTN 27K-28K— SPIDER ASSY. (RIGHT)SPIDER ASSY. (RIGHT)

NO. PART NO. PART NAME QTY. REMARKS1% 11419 PLATE, WEAR THRUST COLLAR 12% 11431 THRUST COLLAR W/ BUSHING...................................1 ..... INCLUDES ITEMS W/+3% 2621 ZERK, GREASE STR 1/4 - 24 14% 12779 BEARING, THRUST 6017 2RS W/ FLANGE 15 12101 KEY, 5/16 SQ. X 2-5/8 HRDND 16* 12097 SCREW, SQHS 3/8 - 16 X 1-3/4 CONE 8 27* 1456 NUT, HEX FINISH 3/8 - 16 29* 11039 BUSHING,TROWEL ARM 2-PIECE 810* 11594 SPRING, TROWEL ARM LEVER RIGHT 411* 11904 LEVER, TROWEL ARM HAND RIDE SIDE 412* 9006 PIN, ROLL 5/16 X 2 NO PLATE 413* 2829 ARM, TROWEL HD EXT. 415* 1207 SCREW, HHC 5/16 -18 X 1-3/4 1216* 0161 C WASHER, LOCK, 5/16 MED 1217* 1162 A CAP, GREASE ZERK #2 518* 1322 SCREW ASSEMBLY, ARM RETAINING 419* 1875 WASHER, INT. SHKP. 3/8 420* 0164 B SCREW, TROWEL ADJUSTMENT 421* 1876 NUT, HEX JAM 3/8 - 16 CLASS 2B 422* 0166 A WASHER, LOCK, 3/8 MEDIUM 423*# 11602 SCREW, HHC 3/8 -16 X 1/4 424 12072 SPIDER/ARM ASSY. R.S. 4BLD 1-1/4 MAIN SHAFT...1 ..... INCLUDES ITEMS W/*25* 12785 SPIDER, SERVICE 4BLD 1-1/4 SHAFT .......................1 ..... INCLUDES ITEMS W/#26 BLADE ASSEMBLY ..................................................... 4 ..... CONTACT UNIT SALES DEPT./

.............................................................................................. ACCESSORY ITEM27+% 12316 THRUST COLLAR BUSHING 128% 20938 THRUST COLLAR KIT ..................................................1 ..... INCLUDES ITEMS W/%


HTN 27K-28K— SPIDER ASSY. (LEFT)SPIDER ASSY, (LEFT)


HTN 27K-28K— SPIDER ASSY. (LEFT)SPIDER ASSY. (LEFT)

NO. PART NO. PART NAME QTY. REMARKS1% 11419 PLATE, WEAR THRUST COLLAR 12% 11431 THRUST COLLAR W/ BUSHING................................ 1............. INCLUDES ITEMS W/+3% 2621 ZERK, GREASE 1/4 - 28 14% 12779 BEARING, THRUST 6017 2RS W/ FLANGE 15 12101 KEY, 5/16 SQ. X 2 - 5/8 HRDND 16* 12097 SCREW, SQHS 3/8 - 16 X 1-3/4 CONE 8 27* 1456 NUT, HEX FINISH 3/8 - 16 29* 11039 BUSHING,TROWEL ARM 2-PIECE 810* 11595 SPRING, LEFT TROWEL ARM LEVER 411* 11903 LEVER, TROWEL ARM LEFT SIDE 412* 9006 PIN, ROLL 5/16 X 2 NO PLATE 413* 21495 ARM, TROWEL L.S. 415* 1207 SCREW, HHC 5/16 -18 X 1-3/4 1216* 0161 C WASHER, LOCK, 5/16 MED 1217* 1162 A CAP, GREASE ZERK #2 518* 1322 SCREW ASSY, ARM RETAINING 419* 1875 WASHER, INT. SHKP. 3/8 420* 0164 B SCREW, TROWEL ADJUSTMENT 421* 1876 NUT, HEX JAM 3/8 - 16 CLASS 2B 422* 0166 A WASHER, LOCK, 3/8 MEDIUM 423*# 11602 SCREW, HHC 3/8 -16 X 1/4 424 21310 SPIDER ASSY., L.S. 4BLD 1-1/4 MAIN SHAFT ........ 1............. INCLUDES ITEMS W/*25* 12785 SPIDER, SERVICE 4BLD 1-1/4 SHAFT .................... 1............. INCLUDES ITEMS W/#26 BLADE ASSEMBLY ................................................... 4............. CONTACT UNIT SALES DEPT./

................................................................................................... ACCESSORY ITEM27+% 12316 THRUST COLLAR BUSHING 128% 20938 THRUST COLLAR KIT ............................................... 1............. INCLUDES ITEMS W/%


HTN 27K-28K— YOKE ASSY.YOKE ASSY.


HTN 27K-28K— YOKE ASSY.YOKE ASSY.

NO. PART NO. PART NAME QTY. REMARKS1 12100 YOKE 22 0683 PIN, COTTER 3/32 X 3/4 43 10136 WASHER, FLAT 3/8 SAE 64 9028 PIN, YOKE 25 1116 NUT, BRASS JAM 5/16 -18 46 12460 CABLE ASSEMBLY 26.38 HT-V PITCH 2


HTN 27K-28K— THROTTLE CABLE/FOOT PEDALS ASSY.THROTTLE CABLE/FOOT PEDALS ASSY.


HTN 27K-28K— THROTTLE CABLE/FOOT PEDALS ASSY.THROTTLE CABLE/FOOT PEDALS ASSY.

NO. PART NO. PART NAME QTY. REMARKS1 2124 CABLE, CONTROL (RT) 12 2754 ADAPTER, THROTTLE SPRING, LONG 13 2753 SPRING, THROTTLE RETURN 14 2755 ADAPTER, THROTTLE SPRING, SHORT 15 0937 NUT, HEX 10 - 32 ZINC PLTD 26 10019 NUT, NYLOC 10 - 32 17 2203 WASHER, FLAT #10 SAE 28 2153 ROD END, 10 - 32 FEMALE RH 19 10018 SCREW, SHC 10 - 32 X 1 110 6014 B PIN, COTTER 3/32 X 1 211 12635 RISER, LEFT FOOT 112 12637 RISER, RIGHT FOOT 113 10136 WASHER, FLAT 3/8 SAE 214 3083 SPACER, 3/4 X 3/8 X 7/8 LONG 115 2772 PIN, ACCELERATOR PEDAL 116 3233 WASHER, FENDER 1.50D X 3/8 ID 417 0300 B WASHER, FLAT 5/16 SAE 418 5283 NUT, NYLOC 5/16 -18 419 2086 PEDAL ACCELERATOR 120 0202 SCREW, HHC 5/16 - 18 X 1 ZINC 421 10019 NUT, NYLOC 10-32 222 2884 BRACKET, THROTTLE CABLE 123 5065 B SCREW, RHM 10-32 X 1/2 224 2192 SPRING, EXTENSION RT 225 2194 NUT, THROTTLE 126 2153 ROD END, 10 - 32 FEMALE RH 127 2190 SPACER, THROTTLE 128 10018 SCREW, SHC 10-32 1 NP (1) 129 0937 NUT, FULL HEX 10 - 32 ZINC PLTD 1


HTN 27K-28K— CONTROL PANEL ASSY. (27 HP)CONTROL PANEL ASSY. (27 HP)


CONTROL PANEL ASSY. (27 HP)

NO. PART NO. PART NAME QTY. REMARKS1 21458 CONTROL PANEL 12 4682 SWITCH, LIGHT TOGGLE 13 8381 BOOT, TOGGLE SWITCH 14 2509904S IGNITION SWITCH, W/KEY 14A 4834001S1 KEY, IGNITION (SET) 15 11029 CABLE, CHOKE 16 2673 CIRCUIT BREAKER, 30A, 12V 17 10019 NUT, NYLOC 10 - 32 48 5065 B SCREW, RHM 10 - 32 X 1/2 49 2203 WASHER, FLAT #10 SAE 410 0205 SCREW, HHC 3/8 - 16 X 1 211 4001 WASHER, FLAT USS 3/8 PLD 412 10133 NUT, NYLOC 3/8 - 16 213 2945 HARNESS, WIRE ENGINE 114 60101 TIE WRAP 315 21523 WIRE, YELLOW 10 AWG 116 1475 CONNECTOR, SPLICE TAP 117 2769 WIRE, LITE SWITCH 1

HTN 27K-28K— CONTROL PANEL ASSY. (27 HP)


HTN 27K-28K— CONTROL PANEL ASSY. (28 HP)CONTROL PANEL ASSY. ( 28 HP)


HTN 27K-28K— CONTROL PANEL ASSY. (28 HP)CONTROL PANEL ASSY. ( 28 HP)

NO. PART NO. PART NAME QTY. REMARKS1 4682 SWITCH,TOGGLE ELECTRIC #9061 12 2734 SWITCH, ONAN IGNITION 12A TBD KEY, IGNITION (SET) 13 11382 LIGHT, RED IND 3/4 DIA PL- 20 RC 14 8133 SCREW, RHM 10 - 32 X 3/4 105 10133 NUT, NYLOC 3/8 - 16 26 10019 NUT, NYLOC 10 - 32 107 2673 CIRCUIT BREAKER, 30A, 12V 18 0205 SCREW, HHC 3/8 - 16 X 1 29 4001 WASHER, FLAT USS 3/8 PLD 410 8381 BOOT, TOGGLE SWITCH 111 06827-032 SCREW, RHM 10 - 32 X 2.00 112 06827-028 SCREW, RHM 10 - 32 X 1 - 3/4 113 21539 WIRE ASSEMBLY, 16 GA. X 16L RED 114 21540 WIRE ASSEMBLY, 16 GA. 16L GRAY 115 2716 CONNECTOR, 5-WIRE 116 3233 WASHER, FENDER 1.5 OD X 3/8 ID 217 2686 TERMINAL, FEMALE 16 - 14 GA 218 20283 HARNESS, WIRE 119 21458 CONTROL PANEL 120 1475 CONNECTOR, SPLICE TAP 121 21523 WIRE, YELLOW 10 AWG 122 60101 TIE WRAP 323 2769 WIRE, LITE SWITCH 1


HTN 27K— FUEL ASSY. ( 27 HP)

FUEL ASSY. ( 27 HP ASSY.)


FUEL ASSY. ( 27 HP)

NO. PART NO. PART NAME QTY. REMARKS1 12404 TANK, FUEL FIVE GALLON 12 11418 FUEL CAP/GAUGE (10.5) 13 4514 SCREW, HHC 1/4 - 20 X 5/8 64 0948 WASHER, FLAT, 1/4 SAE 65 19633 BUSHING, RUBBER FUEL 16 20795 VALVE, SCREENED DAPCO 12570 17 19473 CLAMP, WORM HOSE, #4 (1/4 - 5/8) 38 60079 HOSE, FUEL 5/16 ID ..............................................3 .................. SOLD IN 1 FT. LENGTHS9 0181 B WASHER, LOCK, 1/4 MED 410 2405002S FILTER, FUEL PRIMARY 1/4" INLET 111 2555901S FUEL PUMP, 12 VDC 112 2405010S FILTER, FUEL SECONDARY 113 2429 HOLDER, SPARE BELT 1

HTN 27K— FUEL ASSY. (27 HP)


HTN 28K—FUEL ASSY. ( 28 HP EFI)FUEL ASSY. ( 28 HP EFI)


HTN 28K—FUEL ASSY. ( 28 HP EFI)FUEL ASSY. ( 28 HP EFI)

NO. PART NO. PART NAME QTY. REMARKS1 20292 TANK, FUEL FIVE GALLON 12 11418 FUEL CAP/GAUGE (10.5) 13 4514 SCREW, HHC 1/4 - 20 X 5/8 64 0948 WASHER, FLAT, 1/4 SAE 65 19633 BUSHING, RUBBER FUEL 26 W12023 FITTING, 90 05 BARB-4 BARB FUEL 27 19473 CLAMP, WORM HOSE, #4 (1/4- 5/8) 28 60079 HOSE, FUEL 5/16 ID 79 0181 B WASHER, LOCK, 1/4 MED 410 12010 SCREEN, FILTER DAPCO10656 111 60028 HOSE, FUEL .312 ID 112 60058 HOSE, FUEL 1/4 X 3/8 X 2 113 2439320S FUEL PUMP, KOHLER 114 2440302S FUEL REGULATOR, KOHLER 115 0450905002 FILTER, FUEL, CANNISTER TYPE, BOSCH 116 2429 HOLDER, SPARE BELT 1


HTN 27K-28K—BATTERY ASSY.BATTERY ASSY.


HTN 27K-28K—BATTERY ASSY.BATTERY ASSY.

NO. PART NO. PART NAME QTY. REMARKS1 2509 WING NUT, PLATED 22 10031 WASHER, EXT SHKP 1/4 23 11105 BRACKET BATTERY HOLD DOWN 14 2449 BOX, BATTERY GR UI 15 0131 A SCREW, HHC 1/4 - 20 X 3/4 26 BATTERY, ................................................ 1 ....... PURCHASE LOCALLY, INTERSTATE #SP407 0181 B WASHER,LOCK, 1/4 MEDIUM 28 0949 NUT, HEX FINISH 1/4 - 20 29 12022 CABLE, BATTERY NEG 4GA 20 - 1/2" 110 12675 CABLE, BATTERY POS 4GA 36" 111 1597 CABLE, BATTERY NEG 4GA 16 - 1/2" 112 0655 SCREW, HHC 5/16 - 18 X 1- 3/4 413 20146 BRACKET BATTERY BOX 214 2866 SCREW, HHC M8 X 1.25 X 20MM 115 13339 WASHER, EXT SHKP 5/16 116 5283 NUT, NYLOC 5/16 - 18 4


HTN 27K-28K—SPRAY ASSY.SPRAY ASSY.


HTN 27K-28K—SPRAY ASSY.SPRAY ASSY.

NO. PART NO. PART NAME QTY. REMARKS1 392292 NOZZLE, SPRAY 12 2898 WASHER, BONDED NEOPRENE 1 X 1/2 13 11222 MOUNT, SPRAY NOZZLE 14 1023 SCREW, HHC 3/8 -16 X 1 1/4 25 10136 WASHER, FLAT 3/8 SAE 46 10024 NUT, NYLOC 1/4 - 20 47 2912 FITTING, 90 4BARB-1/4FP 18 8128 CLAMP, HOSE SUPPORT 5/16 19 0948 WASHER, FLAT 1/4 SAE 410 0131 A SCREW, HHC 1/4 - 20 X 3/4 411 2914 HOSE, 1/4 ID.........................................................1.......SOLD IN FOOT LENGTHS12 10022 FITTING, PLASTIC 6BARB - 4BARB 113 2918 CLAMP, HOSE .475 - .536 ID 414 2913 HOSE, 3/8 ID.........................................................1.......SOLD IN FOOT LENGTHS15 12548 PUMP, SPRAY ASSY SHURFLO 100-000-21 116 2925 FITTING, PLASTIC 90 6BARB - 3/8 MP 117 2398 CLAMP, 6 - 1/2 HOSE SIZE 96 218 2926 SCREEN, STRAINER 119 2108 CAP, SPRAY TANK 120 2916 TANK, WATER NPT BOSSES 121 2478 DRAIN COCK 122 2399 U-BOLT, 1 ID PLTD W/NUTS 223 2887 MOUNT, TANK LEFT 124 2886 MOUNT, TANK RIGHT 125 10133 NUT, NYLOC 3/8 -16 426 8125 CLAMP, HOSE SUPPORT 5/8 127 11430 SWITCH ASSY, SPRAY 128 2656 NUT, NYLOC 5/16 - 24 4


LIGHT ASSY.Y

HTN 27K-28K—LIGHT ASSY.


HTN 27K-28K—LIGHT ASSY.

LIGHT ASSY.

NO. PART NO. PART NAME QTY. REMARKS1 2896 LIGHT ASSEMBLY "92" 42 5283 NUT, NYLOC 5/16 - 18 43 0300 B WASHER, FLAT 5/16 SAE 44 2531 FRONT MOUNTING BRACKET 25 2534 CLAMP, FRONT LIGHTS 1 - 3/4 26 2959 LOOM, LITE WIRE 28 11124 WIRE HARNESS, REAR LITE 19 0655 HHCS, 5/16"-18X3/4 210 10320 BRACKET LIGHT, REAR 211 0161 D NUT, HEX FINISH 5/16"-18 212 0181 B WASHER, LOCK1/4" 413 0300 A SCREW, HHC 5/16"-18X2 2


HTN 27K-28K—SEAT FRAME ASSY.SEAT FRAME ASSY.


HTN 27K-28K—SEAT FRAME ASSY.SEAT FRAME ASSY.

NO. PART NO. PART NAME QTY. REMARKS1 21861 SEAT, MICHIGAN-ADJUSTABLE W/O ARMS 12 11472 SEAT PLATE 13 0300 B WASHER, FLAT, SAE 5/16 44 5283 NUT, NYLOC 5/16 - 18 45 10896 FRAME, SEAT 16 11644 SCREW, HHC, WASHER 10 - 32 X 5/8 17 10237 WASHER, EXT. SHKP, #10 18 8156 SCREW, HHC 3/8 - 16 X 2 - 1/2 19 4001 WASHER, FLAT 3/8 PLTD STD. USS 110 11593 SPRING, SEAT 111 10133 NUT, NYLOC 3/8 - 16 112 0183 PIN, COTTER 1/8 1 - 1/4 213 8081 PIN, CLEVIS 1/2 X 2.75 EFF. 214 10307 SCREW, HHC 1/2 - 13 X 5 415 12014 WIRE, RELAY GROUND 116 10176 NUT, NYLOC1/2 - 13 417 10019 NUT, NYLOC 10 - 32 118 12018 CONNECTOR, RELAY 119 12017 RELAY, KILL 120 12005 SWITCH, KILL COLE- HER #90036- 02 121 12020 TERMINAL, WIRE 4


EZ-MOVER ASSY.

HTN 27K-28K—EZ-MOVER ASSY.


EZ-MOVER ASSY.

NO. PART NO. PART NAME QTY. REMARKS1 0189 HAND GRIP 22 2336 HANDLE, UPPER 13 1869 PIN, SNAP 14 7170 CLIP 25 11684 AXLE, DOLLY 26 10440 WHEEL & TIRE 27 8151 WASHER, FLAT 3/4 SAE 28 0183 PIN, COTTER 29 10446 WASHER, FLAT 3/4 410 0655 SCREW, HHCS 5/16 - 18 X 3/4 211 0161 C WASHER, LOCK 5/16 212 0300 B WASHER, FLAT 5/16 213 2364 WHEEL, 2 X 8 MOLDED RUBBER 214 4684 WASHER, FLAT 5/8 215 10445 FRAME 1

EZ-MOVER ASSEMBLY -- PURCHASE THROUGH MQ UNIT SALES DEPT.

HTN 27K-28K—EZ-MOVER ASSY.


PAYMENT TERMS

Terms of payment for parts are net 30 days.

FREIGHT POLICY

All parts orders will be shipped collect orprepaid with the charges added to the invoice.All shipments are F.O.B. point of origin.Multiquip’s responsibility ceases when a signedmanifest has been obtained from the carrier,and any claim for shortage or damage must besettled between the consignee and the carrier.

MINIMUM ORDER

The minimum charge for orders from Multiquipis $15.00 net. Customers will be asked forinstructions regarding handling of orders notmeeting this requirement.

RETURNED GOODS POLICY

Return shipments will be accepted and creditwill be allowed, subject to the followingprovisions:

1. A Returned Material Authorization (RMA)must be approved by Multiquip prior toshipment.

2. To obtain a Return Material Authorization,a list must be provided to Multiquip PartsSales that defines item numbers,quantities, and descriptions of the items tobe returned.

a. The parts numbers and descriptionsmust match the current parts pricelist.

b. The list must be typed or computergenerated.

c. The list must state the reason(s) forthe return.

d. The list must reference the salesorder(s) or invoice(s) under whichthe items were originally purchased.

e. The list must include the name andphone number of the personrequesting the RMA.

3. A copy of the Return MaterialAuthorization must accompany the returnshipment.

4. Freight is at the sender’s expense. Allparts must be returned freight prepaid toMultiquip’s designated receiving point.

PRICING AND REBATES

Prices are subject to change without priornotice. Price changes are effective on a specificdate and all orders received on or after that datewill be billed at the revised price. Rebates forprice declines and added charges for priceincreases will not be made for stock on hand atthe time of any price change.

Multiquip reserves the right to quote and selldirect to Government agencies, and to OriginalEquipment Manufacturer (OEM) accounts whouse our products as integral parts of their ownproducts.

SPECIAL EXPEDITING SERVICE

A $35.00 surcharge will be added to the invoicefor special handling including bus shipments,insured parcel post or in cases where Multiquipmust personally deliver the parts to the carrier.

LIMITATIONS OF SELLER’S LIABILITY

Multiquip shall not be liable hereunder fordamages in excess of the purchase price of theitem with respect to which damages are claimed,and in no event shall Multiquip be liable for lossof profit or good will or for any other special,consequential or incidental damages.

LIMITATION OF WARRANTIES

No warranties, expressed or implied, are madein connection with the sale of parts or tradeaccessories nor as to any engine notmanufactured by Multiquip. Such warrantiesmade in connection with the sale of new,complete units are made exclusively by astatement of warranty packaged with suchunits, and Multiquip neither assumes norauthorizes any person to assume for it anyother obligation or liability whatever inconnection with the sale of its products. Apartfrom such written statement of warranty, thereare no warranties, expressed, implied orstatutory, which extend beyond the descriptionof the products on the face hereof.

5. Parts must be in new and resalablecondition, in the original Multiquip package(if any), and with Muiltiquip part numbersclearly marked.

6. The following items are not returnable:

a. Obsolete parts. (If an item is in theprice book and shows as being re-placed by another item, it is obsolete.)

b. Any parts with a limited shelf life(such as gaskets, seals, “O” rings,and other rubber parts) that werepurchased more than six monthsprior to the return date.

c. Any line item with an extended dealernet price of less than $5.00.

d. Special order items.

e. Electrical components.

f. Paint, chemicals, and lubricants.

g. Decals and paper products.

h. Items purchased in kits.

7. The sender will be notified of any materialreceived that is not acceptable.

8. Such material will be held for five workingdays from notification, pendinginstructions. If a reply is not receivedwithin five days, the material will bereturned to the sender at his expense.

9. Credit on returned parts will be issued atdealer net price at time of the originalpurchase, less a 15% restocking charge.

10. In cases where an item is accepted forwhich the original purchase documentcan not be determined, the price will bebased on the list price that was effectivetwelve months prior to the RMA date.

11. Credit issued will be applied to futurepurchases only.

PRICING AND REBATES

Prices are subject to change without priornotice. Price changes are effective on a specificdate and all orders received on or after that datewill be billed at the revised price. Rebates forprice declines and added charges for priceincreases will not be made for stock on hand atthe time of any price change.

Effective: October 1, 2002 TERMS AND CONDITIONS OF SALE — PARTS


HTN 27K-28K—NOTES

PARTS MANUAL

Your Local Dealer is:

HERE'S HOW TO GET HELPPLEASE HAVE THE MODEL AND SERIAL

NUMBER ON-HAND WHEN CALLING

© COPYRIGHT 2006, MULTIQUIP INC.

Multiquip Inc, the MQ logo and the MQ Whiteman logo are registered trademarks of Multiquip Inc. and may not be used, reproduced, or altered without written permission.All other trademarks are the property of their respective owners and used with permission.

This manual MUST accompany the equipment at all times. This manual is considered a permanent part of the equipment and should remain with the unit if resold.

The information and specifications included in this publication were in effect at the time of approval for printing. Illustrations are based on the HTN 27K/28K Ride-On PowerTrowel. Illustrations, descriptions, references and technical data contained in this manual are for guidance only and may not be considered as binding. Multiquip Inc. reservesthe right to discontinue or change specifications, design or the information published in this publication at any time without notice and without incurring any obligations.

UNITED STATESMultiquip Corporate Office MQ Parts Department18910 Wilmington Ave. Tel. (800) 421-1244 800-427-1244 Fax: 800-672-7877Carson, CA 90746 Fax (800) 537-3927 310-537-3700 Fax: 310-637-3284Contact: [email protected] Parts Warranty Department800-306-2926 Fax: 800-672-7877 800-421-1244, Ext. 279 Fax: 310-537-1173310-537-3700 Fax: 310-637-3284 310-537-3700, Ext. 279Service Department Technial Assistance800-421-1244 Fax: 310-537-4259 800-478-1244 Fax: 310-631-5032310-537-3700

MEXICO UNITED KINGDOMMQ Cipsa Multiquip (UK) Limited Head OfficeCarr. Fed. Mexico-Puebla KM 126.5 Tel: (52) 222-225-9900 Hanover Mill, Fitzroy Street, Tel: 0161 339 2223Momoxpan, Cholula, Puebla 72760 Mexico Fax: (52) 222-285-0420 Ashton-under-Lyne, Fax: 0161 339 3226Contact: [email protected] Lancashire OL7 0TL

Contact: [email protected]

CANADA BRAZILMultiquip Multiquip4110 Industriel Boul. Tel: (450) 625-2244 Av. Evandro Lins e Silva, 840 - grupo 505 Tel: 011-55-21-3433-9055Laval, Quebec, Canada H7L 6V3 Fax: (450) 625-8664 Barra de Tijuca - Rio de Janeiro Fax: 011-55-21-3433-9055Contact: [email protected] Contact: [email protected], [email protected]

htn 27k-28k-tcsl ride-on power trowel · page 6 — htn 31v htn 27k-28k † ride-on power trowel...

Documents