flame spread over liquid pools
DESCRIPTION
Flame Spread Over Liquid Pools. Brendan Paxton Dr. Peter Disimile Aviation Fire Dynamics April 5 th 2013. Agenda. Definition Impact Research Fluid dynamics Review Regimes of flame propagation Environmental disturbances Suppression. Definition. Governing factors - PowerPoint PPT PresentationTRANSCRIPT
![Page 1: Flame Spread Over Liquid Pools](https://reader036.vdocuments.mx/reader036/viewer/2022081503/568163d8550346895dd529cb/html5/thumbnails/1.jpg)
Flame Spread Over Liquid PoolsBrendan Paxton Dr. Peter Disimile Aviation Fire Dynamics April 5th 2013
![Page 2: Flame Spread Over Liquid Pools](https://reader036.vdocuments.mx/reader036/viewer/2022081503/568163d8550346895dd529cb/html5/thumbnails/2.jpg)
Agenda
• Definition• Impact• Research
– Fluid dynamics• Review• Regimes of flame propagation• Environmental disturbances
– Suppression
![Page 3: Flame Spread Over Liquid Pools](https://reader036.vdocuments.mx/reader036/viewer/2022081503/568163d8550346895dd529cb/html5/thumbnails/3.jpg)
• Governing factors– Initial pool temperature and the flash point of the fuel– Environmental conditions
Definition
• Flame spread over liquid pools:
the result of a combustion process heating, vaporizing, and igniting proximal liquid fuel
![Page 4: Flame Spread Over Liquid Pools](https://reader036.vdocuments.mx/reader036/viewer/2022081503/568163d8550346895dd529cb/html5/thumbnails/4.jpg)
Impact
• Why research this phenomenon?– Fire presents danger to living beings and structures– Flame propagation over liquid fuels enlarges and intensifies a fire
• Greater heat generation, leading to rapid vaporization of surrounding liquid fuel• Greater volume of toxic gases• Greater difficulty in extinguishment
– Traveling flames may spread to fire-sensitive locations
• Knowledge is power– Research is necessary for controlling fire propagation, isolating the pool’s
source, and ultimately extinguishing the flames
![Page 5: Flame Spread Over Liquid Pools](https://reader036.vdocuments.mx/reader036/viewer/2022081503/568163d8550346895dd529cb/html5/thumbnails/5.jpg)
Impact
• Aircraft crashes• Oil spills
– Storage facilities– Tankers – marine, railway, road vessels– Marine drill sites
• Solvent handling– Ethanol– Methanol– n-Propanol
“…it looked like the sun exploded.”- Witness of an ethanol fire caused by the July 2012 train derailment in Columbus, Ohio
![Page 6: Flame Spread Over Liquid Pools](https://reader036.vdocuments.mx/reader036/viewer/2022081503/568163d8550346895dd529cb/html5/thumbnails/6.jpg)
Railcar DerailmentColumbus, Ohio, July 2012
Effect: Catastrophic liquid ethanol fire
![Page 7: Flame Spread Over Liquid Pools](https://reader036.vdocuments.mx/reader036/viewer/2022081503/568163d8550346895dd529cb/html5/thumbnails/7.jpg)
China Airlines Flight 120Okinawa, Japan, August 2007
Cause: Punctured fuel tankhttp://www.youtube.com/embed/2tY2HzWCvhw?rel=0
![Page 8: Flame Spread Over Liquid Pools](https://reader036.vdocuments.mx/reader036/viewer/2022081503/568163d8550346895dd529cb/html5/thumbnails/8.jpg)
Buncefield Oil Depot ExplosionsHertfordshire, England, December 2005
Cause: Liquid gasoline spill
![Page 9: Flame Spread Over Liquid Pools](https://reader036.vdocuments.mx/reader036/viewer/2022081503/568163d8550346895dd529cb/html5/thumbnails/9.jpg)
Buncefield Oil Depot ExplosionsHertfordshire, England, December 2005
Cause: Liquid gasoline spill
![Page 10: Flame Spread Over Liquid Pools](https://reader036.vdocuments.mx/reader036/viewer/2022081503/568163d8550346895dd529cb/html5/thumbnails/10.jpg)
Buncefield Oil Depot ExplosionsHertfordshire, England, December 2005
Cause: Liquid gasoline spill
![Page 11: Flame Spread Over Liquid Pools](https://reader036.vdocuments.mx/reader036/viewer/2022081503/568163d8550346895dd529cb/html5/thumbnails/11.jpg)
Buncefield Oil Depot ExplosionsHertfordshire, England, December 2005
Cause: Liquid gasoline spill
![Page 12: Flame Spread Over Liquid Pools](https://reader036.vdocuments.mx/reader036/viewer/2022081503/568163d8550346895dd529cb/html5/thumbnails/12.jpg)
• Characteristic regimes of flame propagation
1. Pseudo-uniform, subflash2. Pulsating3. Transition4. Uniform, near-flash5. Uniform, superflash
• Complex thermophysical interactions– Liquid convection, eddies, thermal currents– Pre-mixed gas-phase interactions
Research – Fluid Dynamics
![Page 13: Flame Spread Over Liquid Pools](https://reader036.vdocuments.mx/reader036/viewer/2022081503/568163d8550346895dd529cb/html5/thumbnails/13.jpg)
• Characteristic regimes of flame propagation
1. Pseudo-uniform, subflash2. Pulsating3. Transition4. Uniform, near-flash5. Uniform, superflash
• Complex thermophysical interactions– Liquid convection, eddies, thermal currents– Pre-mixed gas-phase interactions
Research – Fluid Dynamics
![Page 14: Flame Spread Over Liquid Pools](https://reader036.vdocuments.mx/reader036/viewer/2022081503/568163d8550346895dd529cb/html5/thumbnails/14.jpg)
• What is the flash point?– The lowest temperature at which a substance can vaporize enough of its volume
to form an ignitable mixture in air (this volume concentration is roughly the LFL)– Lower than the boiling point
• What is vaporization? – Vaporization is the phase transition from liquid to gas
• Evaporization – vaporization near the surface (at temperatures below boiling point)• Boiling – vaporization below the surface (at temperatures equal to and above boiling point)
– Boiling occurs when the pressure of the atmosphere can no longer hold the molecules of substance in a liquid state
– This occurs at the boiling point, the temperature at which the vapor pressure reaches the environmental pressure
Review
![Page 15: Flame Spread Over Liquid Pools](https://reader036.vdocuments.mx/reader036/viewer/2022081503/568163d8550346895dd529cb/html5/thumbnails/15.jpg)
• What is vapor pressure?– The pressure exerted by a vapor on the
environment– Dependent on the substance’s chemical
properties and temperature
Pv = vapor pressure T = fluid temperature A, B, C = chemical properties
T → Pv → mv
![Page 16: Flame Spread Over Liquid Pools](https://reader036.vdocuments.mx/reader036/viewer/2022081503/568163d8550346895dd529cb/html5/thumbnails/16.jpg)
• Buoyancy effects
– The density of a cold, unburned, gaseous fuel-air mixture is greater than the densities of its combustion products
• In an unconfined environment, a combustion process can be considered isobaric (constant pressure)
• Temperature changes lead to density changes
– Buoyancy effects are seen when the lighter combustion products pass upward above heavier, unburned reactants
– As the combustion products leave, cold air and vaporized fuel are entrained, or drawn toward the base of the flame
![Page 17: Flame Spread Over Liquid Pools](https://reader036.vdocuments.mx/reader036/viewer/2022081503/568163d8550346895dd529cb/html5/thumbnails/17.jpg)
![Page 18: Flame Spread Over Liquid Pools](https://reader036.vdocuments.mx/reader036/viewer/2022081503/568163d8550346895dd529cb/html5/thumbnails/18.jpg)
Torch Torch
![Page 19: Flame Spread Over Liquid Pools](https://reader036.vdocuments.mx/reader036/viewer/2022081503/568163d8550346895dd529cb/html5/thumbnails/19.jpg)
![Page 20: Flame Spread Over Liquid Pools](https://reader036.vdocuments.mx/reader036/viewer/2022081503/568163d8550346895dd529cb/html5/thumbnails/20.jpg)
![Page 21: Flame Spread Over Liquid Pools](https://reader036.vdocuments.mx/reader036/viewer/2022081503/568163d8550346895dd529cb/html5/thumbnails/21.jpg)
1. Pseudo-uniform, subflash2. Pulsating3. Transition4. Uniform, near-flash5. Uniform, superflash
Regimes of flame propagation
![Page 22: Flame Spread Over Liquid Pools](https://reader036.vdocuments.mx/reader036/viewer/2022081503/568163d8550346895dd529cb/html5/thumbnails/22.jpg)
• Slow propagation over cold liquid fuel – (Subflash temperature)– Laminar air entrainment with turbulent gas-phase mixing at flame front
Pseudo-uniform, subflash regime
![Page 23: Flame Spread Over Liquid Pools](https://reader036.vdocuments.mx/reader036/viewer/2022081503/568163d8550346895dd529cb/html5/thumbnails/23.jpg)
![Page 24: Flame Spread Over Liquid Pools](https://reader036.vdocuments.mx/reader036/viewer/2022081503/568163d8550346895dd529cb/html5/thumbnails/24.jpg)
• Spread appears uniform and steady
• Long, slow pulsations– (a) and (b) represent diffusion burning
• Heating of fuel downstream of the flame front• Slow and smooth flame propagation
– (c) and (d) represent premixed burning• Once the fuel becomes sufficiently heated, it vaporizes• Vaporized air-fuel mixing creates a flammable layer• The flammable gas-phase layer is ignited after reaching a
sufficiently mixed state• Rapid pre-mixed consumption
• After burning quickly through the premixed vapors, the overall flame spread returns to reduced speeds, termed “crawl”
Pseudo-uniform spread
![Page 25: Flame Spread Over Liquid Pools](https://reader036.vdocuments.mx/reader036/viewer/2022081503/568163d8550346895dd529cb/html5/thumbnails/25.jpg)
• Flames that extend through the premixed flammable layer may quench after arrival
– Termed “precursor” flames– The liquid fuel at their new location might not be
readily heated enough to sustain combustion– The flame front advances, but does not reach the
location where the precursor flame quenches
• Experiment, high-speed video– Capture: 300 fps, duration: 3 seconds– Playback: 30 fps, duration: 30 seconds
Experiment performed at the University of Cincinnati Fire Test CenterAssistants: Dr. Samir Tambe and Derick Endicott
Pseudo-uniform spread
![Page 26: Flame Spread Over Liquid Pools](https://reader036.vdocuments.mx/reader036/viewer/2022081503/568163d8550346895dd529cb/html5/thumbnails/26.jpg)
Video not attached due to size
![Page 27: Flame Spread Over Liquid Pools](https://reader036.vdocuments.mx/reader036/viewer/2022081503/568163d8550346895dd529cb/html5/thumbnails/27.jpg)
1. Pseudo-uniform, subflash2. Pulsating3. Transition4. Uniform, near-flash5. Uniform, superflash
Regimes of flame propagation
![Page 28: Flame Spread Over Liquid Pools](https://reader036.vdocuments.mx/reader036/viewer/2022081503/568163d8550346895dd529cb/html5/thumbnails/28.jpg)
• Characterizations– Behavior similar to pseudo-uniform spread– Pulsations function with higher frequency and
reduced wavelength (premixed propagation covers shorter distances during each pulsation)
• High-speed video of precursor flame pulsations
– Capture: 1000 fps, duration: 1.8 seconds– Playback: 30 fps, duration: 1 minute
• Normal video of pseudo-uniform and pulsating spread
– Capture: 30 fps, duration: 1 minute– Playback: 30 fps, duration: 1 minute
Pulsating regime
![Page 29: Flame Spread Over Liquid Pools](https://reader036.vdocuments.mx/reader036/viewer/2022081503/568163d8550346895dd529cb/html5/thumbnails/29.jpg)
Video not attached due to size
![Page 30: Flame Spread Over Liquid Pools](https://reader036.vdocuments.mx/reader036/viewer/2022081503/568163d8550346895dd529cb/html5/thumbnails/30.jpg)
Video not attached due to size
![Page 31: Flame Spread Over Liquid Pools](https://reader036.vdocuments.mx/reader036/viewer/2022081503/568163d8550346895dd529cb/html5/thumbnails/31.jpg)
• Observations– Cold ambient temperature, 40°F, and low-volatility fuel, flash point = 100-151°F– Spread acceleration (pulsations) even under concurrent and opposed air flow– Average flame spread rate did not exceed 3.0 cm/s– Boiling occurred after 2:30 beneath the flames, boiling point = 293-575°F– Fuel began readily ejecting from the pan, even without wind flow
• Personal thoughts– Experiment could only visualize subflash flame regimes– Served as realistic scenario of an ignited Jet-A pool
• Flame height for 16-inch diameter pool easily exceeded 20 inches• Approximately 2.5 oz of Jet-A required 3 minutes to be fully consumed
• Empirical support
Experiment notes and conclusions
![Page 32: Flame Spread Over Liquid Pools](https://reader036.vdocuments.mx/reader036/viewer/2022081503/568163d8550346895dd529cb/html5/thumbnails/32.jpg)
• Empirical support
– A = Pseudo-uniform, subflash– B = Pulsating– C = Uniform, near-flash– D = Uniform, superflash
– Methanol flash-point = 52°F– Ethanol flash-point = 56°F– n-Propanol flash-point = 72°F
– Methanol pulsating spread rate = 6.0 cm/s– Ethanol pulsating spread rate = 5.5 cm/s– n-Propanol pulsating spread rate = 4.8 cm/s
![Page 33: Flame Spread Over Liquid Pools](https://reader036.vdocuments.mx/reader036/viewer/2022081503/568163d8550346895dd529cb/html5/thumbnails/33.jpg)
• Methanol pulsations reach over 15 cm/s, averaging around 6 cm/s
![Page 34: Flame Spread Over Liquid Pools](https://reader036.vdocuments.mx/reader036/viewer/2022081503/568163d8550346895dd529cb/html5/thumbnails/34.jpg)
1. Pseudo-uniform, subflash2. Pulsating3. Transition4. Uniform, near-flash5. Uniform, superflash
Regimes of flame propagation
![Page 35: Flame Spread Over Liquid Pools](https://reader036.vdocuments.mx/reader036/viewer/2022081503/568163d8550346895dd529cb/html5/thumbnails/35.jpg)
• Characterizations– Very high pulsation frequencies, if pulsations even occur– Increased flame spread rate– Decreased liquid flow velocity relative to flame spread rate
Transition regime
![Page 36: Flame Spread Over Liquid Pools](https://reader036.vdocuments.mx/reader036/viewer/2022081503/568163d8550346895dd529cb/html5/thumbnails/36.jpg)
1. Pseudo-uniform, subflash2. Pulsating3. Transition4. Uniform, near-flash5. Uniform, superflash
Regimes of flame propagation
![Page 37: Flame Spread Over Liquid Pools](https://reader036.vdocuments.mx/reader036/viewer/2022081503/568163d8550346895dd529cb/html5/thumbnails/37.jpg)
• Characterizations– Uniform spread, pulsations eliminated– Further reductions in liquid flow velocity– Primary heat transfer mechanisms
• Gas-phase radiation• Gas-phase convection• Liquid-phase conduction
– Minimized liquid-phase convection away from the flame front because the flame spread rate now exceeds the liquid flow velocity
Uniform, near-flash regime
![Page 38: Flame Spread Over Liquid Pools](https://reader036.vdocuments.mx/reader036/viewer/2022081503/568163d8550346895dd529cb/html5/thumbnails/38.jpg)
![Page 39: Flame Spread Over Liquid Pools](https://reader036.vdocuments.mx/reader036/viewer/2022081503/568163d8550346895dd529cb/html5/thumbnails/39.jpg)
![Page 40: Flame Spread Over Liquid Pools](https://reader036.vdocuments.mx/reader036/viewer/2022081503/568163d8550346895dd529cb/html5/thumbnails/40.jpg)
1. Pseudo-uniform, subflash2. Pulsating3. Transition4. Uniform, near-flash5. Uniform, superflash
Regimes of flame propagation
![Page 41: Flame Spread Over Liquid Pools](https://reader036.vdocuments.mx/reader036/viewer/2022081503/568163d8550346895dd529cb/html5/thumbnails/41.jpg)
• Characterizations– Uniform, fast flame spread– Liquid fuel consumption maximized– Mostly occurs if the liquid fuel is heated above its flash point prior to ignition– Rarely occurs after flames have spread through cooler regimes
• Example: gasoline combustion at room temperature• High volumes of vapors ignited under superflash conditions will appear explosive
– Often yields a “triple flame,” a premixed flame followed by a diffusion flame• Air is entrained behind the premixed flame front• This air undergoes diffusion combustion with the rapidly vaporizing fuel
• If T0 > Tst the flame propagation rate is 4-5 times faster than the stoichiometric laminar flame speed, Sl
Uniform, superflash regime
http://www.youtube.com/embed/yoDhfB5DyBQ?rel=0
![Page 42: Flame Spread Over Liquid Pools](https://reader036.vdocuments.mx/reader036/viewer/2022081503/568163d8550346895dd529cb/html5/thumbnails/42.jpg)
• 4-5 times faster than stoichiometric laminar flame speed?– Flame front is very curved, causing a significant pressure gradient across its surface– Gas-phase motion ahead of flame front– Gas-phase motion behind flame front, low-density products expanding– This expansion displaces unburned gas layers ahead of the flame front– Flame propagation rate increases
Uniform, superflash regime
![Page 43: Flame Spread Over Liquid Pools](https://reader036.vdocuments.mx/reader036/viewer/2022081503/568163d8550346895dd529cb/html5/thumbnails/43.jpg)
![Page 44: Flame Spread Over Liquid Pools](https://reader036.vdocuments.mx/reader036/viewer/2022081503/568163d8550346895dd529cb/html5/thumbnails/44.jpg)
• Airflow, gusts of wind– Concurrent airflow, in the direction of flame propagation– Opposed airflow, against the direction of flame propagation– Considering uniform, superflash flame spread
• If the concurrent airflow exceeds the static flame spread rate, the flame spread rate will match the magnitude of the concurrent airflow
• Opposed airflow very gradually decreases the flame spread rate
Disturbances from the environment
![Page 45: Flame Spread Over Liquid Pools](https://reader036.vdocuments.mx/reader036/viewer/2022081503/568163d8550346895dd529cb/html5/thumbnails/45.jpg)
![Page 46: Flame Spread Over Liquid Pools](https://reader036.vdocuments.mx/reader036/viewer/2022081503/568163d8550346895dd529cb/html5/thumbnails/46.jpg)
Strong opposed airflow
Weak concurrent airflow
Strong concurrent airflow
![Page 47: Flame Spread Over Liquid Pools](https://reader036.vdocuments.mx/reader036/viewer/2022081503/568163d8550346895dd529cb/html5/thumbnails/47.jpg)
![Page 48: Flame Spread Over Liquid Pools](https://reader036.vdocuments.mx/reader036/viewer/2022081503/568163d8550346895dd529cb/html5/thumbnails/48.jpg)
• Obstacles– Beds of solid material have been studied to simulate liquid pools that encounter
porous surfaces or obstacles• Solid material will reduce convective heat transfer• Conductive heat transfer through the pool’s constituents will come into play
– Balls or beads made out of sand, glass, and metal were tested– Flame propagation rates were reduced by factors between 30 and 50– The slow flame speeds compared more closely with solid than with liquid fuels
• Obstacles only affect near-flash and preflash flame spread regimes• Gas-phase flame spread will not “see” the solids
• Airflow and obstacles– Opposed airflow greatly cuts flame propagation over a pool filled with solids– Considerable flow circulation and turbulent interactions around obstacles can
even lead to instability and blow-off
Disturbances from the environment
![Page 49: Flame Spread Over Liquid Pools](https://reader036.vdocuments.mx/reader036/viewer/2022081503/568163d8550346895dd529cb/html5/thumbnails/49.jpg)
![Page 50: Flame Spread Over Liquid Pools](https://reader036.vdocuments.mx/reader036/viewer/2022081503/568163d8550346895dd529cb/html5/thumbnails/50.jpg)
• Contamination– Contaminants
• Water (by rain or condensation)• Combustion products (soot, vapors)
– Changes the thermocapillarity of the fuel, diminishing convective pre-heating
Disturbances from the environment
![Page 51: Flame Spread Over Liquid Pools](https://reader036.vdocuments.mx/reader036/viewer/2022081503/568163d8550346895dd529cb/html5/thumbnails/51.jpg)
• Class B fire extinguishants– Dry chemical (powders)
• Pro – Separation of the fire tetrahedron• Pro – Interference with the chain reaction, through reacting• Pro – Halts production of fire-sustaining free-radicals• Pro – Slows fire propagation• Con – Difficulty in cooling the fuel, potential for flashback
– Liquid-solid foams (frothy blanket)• Pro – Some dry chemical properties, smothering• Pro – Cooling of the fuel• Con – Does not interfere with the chain reaction, takes longer
– Water, wet chemical (soapy foam)• Pro – Cooling of the fuel• Con – Mixes with the fuel, does not effectively displace oxygen
– Clean agents (gases)• Pro – Clean interaction, little residue • Pro – Interrupts chemical reaction• Pro – Displaces oxygen• Con – Hazardous toxins (Halon)
– Halon replacement Bromo–trifluoro–propene (BTP) generates hydrogen fluoride
Suppression
![Page 52: Flame Spread Over Liquid Pools](https://reader036.vdocuments.mx/reader036/viewer/2022081503/568163d8550346895dd529cb/html5/thumbnails/52.jpg)
Water mist
BTP
![Page 53: Flame Spread Over Liquid Pools](https://reader036.vdocuments.mx/reader036/viewer/2022081503/568163d8550346895dd529cb/html5/thumbnails/53.jpg)
5% BTP
10% BTP
![Page 54: Flame Spread Over Liquid Pools](https://reader036.vdocuments.mx/reader036/viewer/2022081503/568163d8550346895dd529cb/html5/thumbnails/54.jpg)
![Page 55: Flame Spread Over Liquid Pools](https://reader036.vdocuments.mx/reader036/viewer/2022081503/568163d8550346895dd529cb/html5/thumbnails/55.jpg)
• Dry chemical
• Liquid-solid foams
• Water, wet chemical
Suppression
http://www.youtube.com/embed/eHzUhm-3HX8
http://www.youtube.com/embed/LbExsN4jdcA
http://www.youtube.com/embed/tavsFhniNVY
![Page 56: Flame Spread Over Liquid Pools](https://reader036.vdocuments.mx/reader036/viewer/2022081503/568163d8550346895dd529cb/html5/thumbnails/56.jpg)
• Gravel or sand could be useful in preventing liquid pool fire propagation at ground-based oil storage sites
• Water mist could be useful in preventing liquid pool fires if it was sprayed/injected when a leak is detected, before ignition
Prevention – concluding thoughts
Questions?
![Page 57: Flame Spread Over Liquid Pools](https://reader036.vdocuments.mx/reader036/viewer/2022081503/568163d8550346895dd529cb/html5/thumbnails/57.jpg)
[1] Guo, J., Lu, S., Li, M., and Wang, C., “Flame spread over aviation kerosene with an obstacle in liquid phase,” Journal of Thermal Science, 20, 6, 543-547, 2011. (http://link.springer.com.proxy.libraries.uc.edu/content/pdf/10.1007%2Fs11630-011-0508-z)
[2] Hirano, T., and Suzuki, T., “Flame propagation across liquids—A review of gas phase phenomena,” Fire Safety Journal, 21, 3, 207-229, 1993. (http://www.sciencedirect.com/science/article/pii/037971129390028O)
[3] Ishida, H., “Flame tip traveling in boundary layer flow with flammable mixture along fuel-soaked ground,” Journal of Fire Sciences, 30, 1, 17-27. (http://jfs.sagepub.com.proxy.libraries.uc.edu/content/29/2/99)
[4] Remick, E. M., “Flame spread over liquid fuels,” Cornell University, 1981. (http://search.proquest.com/docview/303016167?accountid=2909)
[5] Zhou, J., Chen, G., Li, P., Chen, B., Wang, C., and Lu, S., “Analysis of flame spread over aviation kerosene,” Chinese Science Bulletin, 55, 17, 1822-1827, 2009. (http://link.springer.com/article/10.1007/s11434-010-3014-x)
[6] Xiaomin Ni, W.K. Chow, Performance evaluation of water mist with bromofluoropropene in suppressing gasoline pool fires, Applied Thermal Engineering, Volume 31, Issues 17–18, December 2011, Pages 3864-3870, ISSN 1359-4311, 10.1016/j.applthermaleng.2011.07.034. (http://www.sciencedirect.com/science/article/pii/S1359431111003930)
References