enclosed is submittal data for the … plus/calabasas hs submittals - splits.pdf · enclosed is...

Carrier Direct Sales 3050 Enterprise St.

Brea, CA 92821

(P) 714-985-5200 (F) 714-985-5336

www.commercial.carrier.com

EQUIPMENT SUBMITTAL

JOB NAME: CALABASAS HS PERFORMING ARTS CENTER

JOB LOCATION: CALABASAS, CA

ENGINEER: JAYCO

CUSTOMER: AIR PLUS CORP

ADDRESS: 15537 CABRITO ROAD VAN NUYS, CA 91406

PREPARED BY: KYLE HEINSEN

DATE: 12/22/10

REVISION #: 0

ENCLOSED IS SUBMITTAL DATA FOR THE FOLLOWING EQUIPMENT:

Qty Model Number Description

2 25HBB318A003 13 SEER Heat Pump with Puron, 1.5 Tons Cooling, 208/230-1-60 Mark For: CU-1.5-1,1.5A-1 Field-Installed Accessories ♦ Low Ambient Pressure Switch ♦ Start Assist – Capacitor and Relay ♦ Crankcase Heater ♦ Evaporator Freeze Thermostat ♦ Isolation Relay ♦ Hard Shutoff TXV

2 25HBB336A003 13 SEER Heat Pump with Puron, 3 Tons Cooling, 208/230-1-60 Mark For: CU-3A-1,3-2 Field-Installed Accessories ♦ Low Ambient Pressure Switch ♦ Start Assist – Capacitor and Relay ♦ Crankcase Heater ♦ Evaporator Freeze Thermostat ♦ Isolation Relay ♦ Hard Shutoff TXV

1 FB4CNF018000 Direct Drive Fan Coil Unit, 1.5 Tons Cooling, 208/230-1-60

Mark For: FC-1.5-1 1 FB4CNF036000 Direct Drive Fan Coil Unit, 3 Tons Cooling, 208/230-1-60

Mark For: FC-3-2

25HBB3Base 13 Heat Pumpwith Puronr Refrigerant1---1/2 to 5 Nominal Tons (Sizes 18 to 60)

Product Data

the environmentally sound refrigerant

Carrier heat pumps with Puronr refrigerant provide a collection offeatures unmatched by any other family of equipment. The 25HBBhas been designed utilizing Carrier’s Puron refrigerant. Theenvironmentally sound refrigerant allows consumers to make aresponsible decision in the protection of the earth’s ozone layer.As an Energy Starr Partner, Carrier Corporation has determinedthat this product meets the Energy Starr guidelines for energyefficiency. Refer to the combination ratings in the Product Data forsystem combinations that meet Energy Starr guidelines.NOTE: Ratings contained in this document are subject tochange at any time. Always refer to the AHRI directory(www.ahridirectory.org) for the most up--to--date ratingsinformation.

INDUSTRY LEADINGFEATURES / BENEFITSEfficiencyS 13 SEER/ 10.1 -- 10.8 EER/ 7.7 -- 8.3 HSPF (nominal)S Microtube Technologyt refrigeration systemS Indoor air quality accessories available

SoundS Sound level as low as 72 dBAS Sound levels as low as 70 dBA with accessory sound blanket

ComfortS System supports Edger Thermidistatt or standard thermostatcontrols

ReliabilityS Puronr refrigerant -- environmentally sound, won’t deplete theozone layer and low lifetime service cost.

S Scroll compressorS Internal pressure relief valveS Internal thermal overloadS High pressure switchS Loss of charge switchS Filter drierS Balanced refrigeration system for maximum reliability

DurabilityWeatherArmort protection package:S Solid, durable sheet metal constructionS Dense wire coil guard availableS Baked--on powder paint

ApplicationsS Long--line -- up to 250 feet (76.20 m) total equivalent length, upto 200 feet (60.96 m) condenser above evaporator, or up to 80 ft.(24.38 m) evaporator above condenser (See Longline Guide formore information.)

S Low ambient (down to --20_F/--28.9_C) with accessory kit

cbst6wz

Text Box

CU-1.5A-1

3

PHYSICAL DATAUNIT SIZE SERIES 18---31 24---31 30---31 36---31 42---31 48---31 60---31

Operating Weight lb (kg)173(78.5)

173(78.5)

191(86.6)

192(87.1)

255(115.7)

265(120.2)

287(130.2)

Shipping Weight lb (kg)202(91.6)

202(91.6)

223(101.2)

224(101.6)

287(130.2)

297(134.7)

319(144.7)

Compressor Type ScrollREFRIGERANT Puron� (R---410A)

Control TXV (Puron Hard Shutoff)Heating Piston Size 42 46 55 57 61 61 76

Charge lb (kg)6.63(3.01)

6.58(2.98)

6.56(2.98)

7.57(3.43)

11.07(5.02)

11.3(5.13)

12.58(5.71)

COND FAN Propeller Type, Direct DriveAir Discharge VerticalAir Qty (CFM) 2611 2611 3810 3810 3810 4046 4046Motor HP 1/10 1/10 1/5 1/5 1/5 1/4 1/4Motor RPM 1100 1100 800 800 800 800 800

COND COILFace Area (Sq ft) 19.40 19.4 20.12 25.15 20.12 20.12 25.15Fins per In. 20 20 20 20 20 20 20Rows 1 1 1 1 2 2 2Circuits 5 5 5 6 6 8 8

VALVE CONNECT. (In. ID)Vapor 5/8 5/8 3/4 3/4 7/8 7/8 7/8Liquid 3/8

REFRIGERANT TUBES* (In. OD)Vapor 5/8 5/8 3/4 3/4 7/8 7/8 1---1/8Liquid 3/8

* For tubing sets between 80 and 200 ft. (24.38 and 60.96 m) horizontal or 20 ft. (6.09 m) vertical differential, consult the Longline Guideline.Note: See unit Installation Instruction for proper installation.

VAPOR LINE SIZING AND COOLING CAPACITY LOSSLONG LINE APPLICATION: An application is considered ”Longline” when the total equivalent tubing length exceeds 80 ft. (24.38m) or when there is more than 20 ft. (6.09 m) vertical separationbetween indoor and outdoor units. These applications requireadditional accessories and system modifications for reliable systemoperation. The maximum allowable total equivalent length is 250ft. (76.2 m). The maximum vertical separation is 200 ft. (60.96 m)

when outdoor unit is above indoor unit, and 60 ft. (18.3 m) whenthe outdoor unit is below the indoor unit. Refer to AccessoryUsage Guideline below for required accessories. See LonglineApplication Guideline for required piping and systemmodifications. Also, refer to the table below for vapor tubediameters based on the total length to minimize the coolingcapacity loss.

UnitNominal

Size (Btuh)

MaximumLiquidLine

Diameters(In. OD)

VaporLine

Diameters(In.) OD

Cooling Capacity Loss (%)Total Equivalent Line Length ft. (m)

StandardApplication Long Line Application Requires Accessories

26---50(7.9---15.2)

51---80(15.5---24.4)

81---100(24.7---31.5)

101---125(30.8---38.1)

126---150(38.4---45.7)

151---175(46.0---50.3)

176---200(53.6---60.0)

201---225(61.3---68.6)

226---250(68.9---76.2)

18,0001---StagePuron HP

3/8

1/2 1 2 3 4 6 7 8 9 10

5/8 0 0 1 1 1 2 2 3 3


5/8 0 1 1 2 3 3 4 4 5

3/4 0 0 0 0 1 1 1 1 1


5/8 1 2 3 3 4 5 6 7 83/4 0 0 1 1 1 2 2 2 37/8 0 0 0 0 1 1 1 1 1


5/8 1 2 4 5 6 7 9 10 113/4 0 0 1 1 2 2 3 3 47/8 0 0 0 0 1 1 1 1 2


3/4 0 1 2 2 3 4 4 5 6

7/8 0 0 1 1 1 2 2 2 3


3/4 0 1 2 3 4 5 5 6 7

7/8 0 0 1 1 2 2 2 3 3


3/4 1 2 4 5 6 7 9 10 117/8 0 1 2 2 3 4 4 5 5

1---1/8 0 0 0 1 1 1 1 1 1Applications in this area are long line. Accessories are required as shown recommended on Long Line Application GuidelinesApplications in this area may have height restrictions that limit allowable total equivalent length, when outdoor unit is below indoor unit See Long Line Applica-tion Guidelines

25HBB3C

cbst6wz

Line

7

ELECTRICAL DATAUNITSIZE---

VOLTAGE,SERIES

V/PHOPER VOLTS* COMPR FAN

MCA

MINWIRESIZE†

MINWIRESIZE†

MAXLENGTH(FT)‡

MAXLENGTH(FT)‡

MAXFUSE**or BRKAMPSMAX MIN LRA RLA FLA 60° C 75° C 60° C 75° C

18---31

208/230/1 253 197

48 9.4 0.8 12.5 14 14 63 60 2024---31 58.3 12.8 0.8 16.8 14 14 47 45 2530---31 77 15.2 1.2 20.2 12 12 62 59 3036---31 79 16.7 1.2 22.0 12 12 57 54 3542---31 109 21.3 1.2 27.8 10 10 72 68 4048---31 117 21.8 1.2 28.4 10 10 70 67 4060---31 134 26.3 1.2 34.1 8 10 91 56 50

* Permissible limits of the voltage range at which the unit will operate satisfactorily{ If wire is applied at ambient greater than 30_C, consult table 310---16 of the NEC (ANSI/NFPA 70). The ampacity of non---metallic---sheathed cable (NM),

trade name ROMEX, shall be that of 60_C conditions, per the NEC (ANSI/NFPA 70) Article 336---26. If other than uncoated (no---plated), 60 or 75_Cinsulation, copper wire (solid wire for 10 AWG or smaller, stranded wire for larger than 10 AWG) is used, consult applicable tables of the NEC (ANSI/NFPA70).

} Length shown is as measured 1 way along wire path between unit and service panel for voltage drop not to exceed 2%.** Time---Delay fuse.FLA --- Full Load AmpsLRA --- Locked Rotor AmpsMCA --- Minimum Circuit AmpsRLA --- Rated Load AmpsNOTE: Control circuit is 24---V on all units and requires external power source. Copper wire must be used from service disconnect to unit.All motors/compressors contain internal overload protection.Complies with 2001 requirements of ASHRAE Standards 90.1

A--WEIGHTED SOUND LEVEL (dBA)

UNIT SIZE --- VOLTAGE,SERIESSTANDARDRATING(dBA)

TYPICAL OCTAVE BAND SPECTRUM (dB, without tone adjustment)

125 250 500 1000 2000 4000 8000

18---31 74 51.5 61.5 67.0 68.5 66.5 63.5 58.524---31 74 53.0 62.0 68.0 70.5 67.0 63.5 59.030---31 75 56.0 62.0 66.5 71.5 66.0 62.0 54.536---31 75 50.5 61.5 65.0 71.0 65.0 61.0 54.542---31 75 59.5 63.0 66.5 71.0 67.0 62.0 55.548---31 79 57.5 64.5 67.5 71.5 73.0 64.5 58.560---31 80 57.5 59.0 65.5 71.5 74.0 63.0 57.5

NOTE: Tested in accordance with AHRI Standard 270---95. (Not listed with AHRI).

A--WEIGHTED SOUND LEVEL (dBA) WITH SOUND SHIELD



125 250 500 1000 2000 4000 8000

18---31 73 51.5 62.0 67.0 68.0 66.0 63.0 58.524---31 74 53.0 62.0 67.5 69.0 66.5 63.0 58.030---31 74 57.0 61.5 66.0 70.0 65.0 60.5 52.536---31 73 51.0 61.5 64.5 69.0 63.5 60.5 53.042---31 73 60.0 63.5 66.5 69.5 66.0 60.5 52.548---31 77 57.0 65.5 67.5 69.5 71.0 61.0 53.560---31 77 57.5 58.5 65.0 68.5 71.0 60.0 53.0


CHARGING SUBCOOLING (TXV--TYPE EXPANSION DEVICE)UNIT SIZE --- VOLTAGE,SERIES REQUIRED SUBCOOLING ° F (° C)

18---31 8 (4.4)24---31 10 (5.6)30---31 10 (5.6)36---31 11 (6.1)42---31 11 (6.1)48---31 12 (6.7)60---31 11 (6.1)

25HBB3C

cbst6wz

Highlight

cbst6wz

Line

cbst6wz

Rectangle

9

DIMENSIONS -- ENGLISH

B

3 13/16”

K

1 1/8”L

C 3 1/2”1 7/8”

N

P

M

E

F

G

A

208-230-1-60

230-1-60

208/230-3-60

460-3-60

UNIT SERIES ELECTRICALCHARACTERISTICSA B C D E F G K L M N P OPERATING

WEIGHT (lbs)SHIPPING

25HBB318 0 X O O O 25 3/4” 35 1/4” 3 3/4” 5/8” 4 7/16” 21 1/4” 9 1/8” 2 13/16” 1/2” 13 1/2” 14 1/2” 14” 148 174

25HBB324 0 X O O O 31 3/16” 28 15/16” 3 3/4” 5/8” 6 9/16” 24 11/16” 9 1/8” 2 13/16” 1/2” 15 5/8” 16 3/4” 14 1/2” 162 189

25HBB330 0 X O X O 31 3/16” 39 1/8” 3 3/4” 3/4” 6 9/16” 24 11/16” 9 1/8” 2 13/16” 1/2” 16 1/2” 15 1/2’ 17” 186 215

25HBB336 0 X O X X 35” 28 15/16” 3 3/4” 3/4” 6 9/16” 28 7/16” 9 1/8” 2 13/16” 1/2” 15 1/2” 15 3/4” 12 1/2” 172 207

25HBB342 0 X O X X 35” 39 1/8” 3 7/8” 7/8” 6 9/16” 28 7/16” 9 1/8” 2 15/16” 5/8” 17 1/4” 19 1/8” 15 3/4” 246 278

25HBB348 0 X O X X 35” 28 15/16” 3 7/8” 7/8” 6 9/16” 28 7/16” 9 1/8” 2 15/16” 5/8” 17” 16” 12” 240 273

25HBB360 0 X O O O 35” 28 15/16” 3 7/8” 7/8” 6 9/16” 28 7/16” 9 1/8” 2 15/16” 5/8” 17” 16” 12” 250 282

25HBB360 1 X O X X 35” 28 15/16” 3 7/8” 7/8” 6 9/16” 28 7/16” 9 1/8” 2 15/16” 5/8” 17” 16” 12” 250 282

1824,30,36

36,42,48,60

AIRDISCHARGE

AIR DISCHARGE

SQ. AIR IN

VAPOR LINE CONN.D

3/8”LIQUID LINE CONN.

AIR IN

AIR IN

3/8” TIEDOWN KNOCKOUTS(2) PLACES

FIELD CONTROLSUPPLY CONN.

7/8” HOLE

FIELD POWER SUPPLY CONN.7/8” HOLE WITH

1 1/8” KNOCKOUT

X = YESO = NO

NOTES:

1. ALLOW 30” CLEARANCE TO SERVICE SIDE OF UNIT,48” ABOVE UNIT, 6” ON ONE SIDE, 12” ON REMAINING SIDE,AND 24” BETWEEN UNITS FOR PROPER AIRFLOW.

2. MINIMUM OUTDOOR OPERATING AMBIENT IN COOLINGMODE IS 55

F, MAX. 125

25HBB3

cbst6wz

Rectangle

10

CLEARANCES

Clearances (various examples)

Wall6”

(152.4)

24”(609.6) Service

Wall

Wall

Wall

12” (304.8)

12”(304.8)

18” (457.2)

24”(609.6) Service

6” (152.4)

12”(304.8)

24”(609.6) Service

24”(609.6) Service

24”(609.6) Service

Note: Numbers in ( ) = mm

18” (457.2)

18” (457.2)

12” (304.8)

A07832

25HBB3C

Unit Report For FC/CU-1.5-1 Project: Calabasas School 12/21/2010 Prepared By: Kyle Heinsen 06:00AM

Residential Carrier Products Bldr 1.16 Page 1 of 12

Outdoor Unit Parameters Unit Quantity: ..................................................... 1 Unit Model: ...............................................25HBB Unit Size: ............................................... 1.5 Tons Voltage: .......................................... 208/230-1-60 V-Ph-Hz

Indoor Unit Parameters Unit Quantity: ..................................................... 1 Unit Model: ................................................. FB4C Unit Size: ......................................... 18,000 Btuh Cabinet Insulation:Single-piece cabinet with 1-in. super thick insulation ............................................................... Voltage: .......................................... 208/230-1-60 V-Ph-Hz

System Parameter System Quantity: ............................................... 1 Heating Size: .......................................... No Heat Outdoor Unit Dimensions and Weight Unit Length: ............................................... 2' 3.0'' Unit Width: ................................................. 2' 6.0'' Unit Height: ................................................ 2' 9.0'' Unit Shipping Weight: .................................... 174 lb Note:Outdoor unit dimensions may vary depending on the minor series sent from the factory. .....................

Indoor Unit Dimensions and Weight Unit Length: ............................................. 1' 10.1'' Unit Width: ................................................. 1' 2.0'' Unit Height: ................................................ 3' 7.0'' Unit Shipping Weight: .................................... 112 lb

Warranty Information Indoor FB4C First Year - Parts Only (Standard) Warranty Information Outdoor 25HBB First Year - Parts Only (Standard) Ordering Information

Part Number Description Quantity Base Unit - Outdoor

25HBB318A003 25HBB Heat Pump with Puron 1.5 Tons Cooling 1 13 SEER @ ARI Conditions 1

Accessories KSAHS1701AAA Start Assist - Capacitor and Relay 1 KSALA0301410 Low Ambient Controller Switch 1

KAACH1701AAA Crankcase Heater 1 KAAFT0101AAA Evaporator Freeze Thermostat 1 KHAIR0101AAA Isolation Relay 1 KSATX0201PUR Thermostatic Expansion Valve (Hard Shutoff) 1

Base Unit - Indoor FB4CNF018000 FB4C Base Series Fan Coil with Puron 18000 BTU Cooling 1

Single-piece cabinet with 1-in. super thick insulation 1

cbst6wz

Text Box

FC/CU-1.5-1

Performance Summary For FC/CU-1.5-1 Project: Calabasas School 12/21/2010 Prepared By: Kyle Heinsen 06:00AM


System: ........................................ 25HBB/FB4C System Quantity: ............................................... 1 Altitude: .......................................................... 0.0 ft Linear Pipe Length: ........................................ 0.0 ft Actual SEER: ................................................ 13.0 EER @ ARI Conditions:................................ 11.0 Outdoor Unit Parameters Unit Quantity: ..................................................... 1 Unit Model: ................................ 25HBB318A003 Unit Size (Nominal):............................... 1.5 Tons Voltage: .......................................... 208/230-1-60 V-Ph-Hz Clg Ent Air DB Ambient: ............................... 95.0 °F Htg Ent Air DB Ambient: ............................... 47.0 °F

Indoor Unit Parameters Unit Quantity: ..................................................... 1 Unit Model: ................................ FB4CNF018000 Unit Size (Nominal): ......................... 18,000 Btuh Voltage: .......................................... 208/230-1-60 V-Ph-Hz Actual Airflow: ............................................. 600.0 CFM Standard Airflow: ........................................ 600.0 CFM Total Net Clg Capacity: ............................... 18.00 MBH Net Sensible Clg Capacity: ......................... 13.50 MBH Ent Air DB: .................................................. 80.00 °F Ent Air WB: ................................................. 67.00 °F Ent Enthalpy: .............................................. 31.44 BTU/lb Lvg Air DB: ................................................. 59.17 °F Lvg Air WB: ................................................ 57.59 °F Lvg Enthalpy: .............................................. 24.77 BTU/lb Heating Size (Nominal): .......................... No Heat Indoor Unit External Static: ........................... 0.40 in wg Total System Power: .................................... 1.48 kW

Heat Pump Htg HP Capacity: ........................................ 18.00 MBH Htg HP Integrated Capacity: ....................... 18.00 MBH Heating HP Compressor Power: .................. 1.46 kW Htg Ent Air DB: ............................................. 70.0 °F Htg Lvg Air DB: ............................................. 97.8 °F COP @ 47 F: ................................................ 3.64 COP @ 17 F: ................................................ 2.34

Outdoor Electrical Data Unit Voltage: ................................... 208/230-1-60 V-Ph-Hz Fan Motor FLA:............................................. 0.77 Amps MCA: ............................................................ 12.5 Amps Max Fuse: ........................................................ 20 Amps Operating Range Min: ................................... 197 V Operating Range Max: .................................. 253 V Compressor RLA: ........................................... 9.4 Amps Compressor LRA: ......................................... 48.0 Amps Min Wire Size @ 60C: ..................................... 14 Min Wire Size @ 75C: ..................................... 14 Max Length Wire Size @ 60C: ........................ 66 ft Max Length Wire Size @ 75C: ........................ 62 ft

Indoor Electrical Data: (For units with no factory or field installed electric heaters) Unit Voltage: ................................... 208/230-1-60 V-Ph-Hz Unit FLA: ........................................................ 1.5 Amps Unit MCA: ....................................................... 1.9 Amps Unit MOCP: .................................................. 15.0 Amps Unit Min Wire Size: ....................................... 14.0 Unit Fuse/Ckt Bkr Amps: .............................. 15.0 Amps Motor HP: ....................................................... 1/5 HP

Acoustic Summary For FC/CU-1.5-1 Project: Calabasas School 12/21/2010 Prepared By: Kyle Heinsen 06:00AM


Outdoor Unit Parameters: Tag Name: .................................................................................................................................................................... FC-1.5-1 Unit Model: ..................................................................................................................................................................... 25HBB Unit Size: ..................................................................................................................................................................... 1.5 Tons

Octave Band Center Frequency, Hz 63 125 250 500 1k 2k 4k 8k dBA Sound Power,dB 0.0 51.5 61.5 67.0 68.5 66.5 63.5 58.5 A-Weighted Sound Power, dBA 74.0

Indoor Unit Parameters: Tag Name: FC-1.5-1 Unit Model: FB4C Unit Size: 18,000 Btuh Cabinet Insulation: Single-piece cabinet with 1-in. super thick insulation


Certified Drawing for FC/CU-1.5-1 Project: Calabasas High School 12/21/2010 Prepared By: Kyle Heinsen 06:00AM


8

DIMENSIONS

25HBB3

cbst6wz

Rectangle

Certified Drawing for FC/CU-1.5-1 Project: Calabasas School 12/21/2010 Prepared By: Kyle Heinsen 06:00AM


5

DIMENSIONS (cont.)

A-COIL

NOTES:1. CONDENSATE PAN DRAIN CAPS NOT SHOWN FOR CLARITY. 2. ALL DIMENSIONS ARE IN "INCHES" UNLESS NOTED.

* HORIZONTAL MOUNT LOCATIONS - DIMPLES PROVIDED IN TOP PANEL, AND BACK OF CABINET. IN CABINET BOTTOM. HOLES PROVIDED

SLOPE COIL

3 1/4"2 9/16"

2 7/8"

2 3/16" TYP.

(2 PLACES)*

7/16" TYP. (2 PLACES)*

1" TYP. (2 PLACES)*

1 1/4"

AIRFLOW

SECONDARY DRAIN

PRIMARY DRAIN

UPFLOW(AS SHIPPED)

7/8"TYP.*

1/2"TYP.* 2 1/8"

1 5/8"

F 1 1/4"

PRIMARY DRAIN

SECONDARY DRAIN

HORIZ. RIGHT(FIELD CONVERTED)

1 1/4"

3 1/4"

1" TYP. (2 PLACES)*


2 3/16" TYP.(2 PLACES)*

G F

AIRFLOW

SECONDARY DRAIN

PRIMARY DRAIN

DOWNFLOW(FIELD CONVERTED)

1 13/16"TYP.*

5/16" TYP.*

1 5/8"

5/16" TYP.*

7/8"TYP.*

2 7/8"

5"

1 1/4"

1/2"TYP.*

SECONDARY DRAIN

PRIMARY DRAIN

HORIZ. LEFT (AS SHIPPED)

1 13/16"TYP.

5/16" TYP.*

1" TYP. (2 PLACES)*

7/16" TYP,(4 PLACES)*

4 3/4"

3 1/16" F

2 3/16" TYP.(2 PLACES)*

G

AIRFLOW


SECONDARY DRAIN

PRIMARY DRAIN

7 7/8"1 3/16"

1 1/2"

1/2"TYP.*

1 13/16"TYP.

5 7/8"

5/16" TYP.*

7/8"TYP.* HORIZ. RIGHT

(FIELD CONVERTED)

PRIMARY DRAIN

SECONDARY DRAIN

7 7/8"1 3/16"

1 1/2"

1 13/16"TYP*

5/16" TYP*

7/8"TYP*

1/2"TYP* 5 7/8"

PRIMARY DRAIN

SECONDARY DRAIN


2 3/16" TYP.

(2 PLACES)*

1" TYP. (2 PLACES)

7/16" TYP.(4 PLACES)

2 11/16"

3" 1/8

3 1/16"

4 3/4"

AIRFLOW

UPFLOW(AS SHIPPED)

PRIMARY DRAIN

SECONDARY DRAIN

A10006

Fig. 2 -- FB4CNF --English

FB4C

Certified Drawing for FC/CU-1.5-1 Project: Calabasas School 12/21/2010 Prepared By: Kyle Heinsen 06:00AM


4

DIMENSIONS

UNIT A B C D E F G H J COIL

CONFIGURATION SHIPPING WT

(LBS) NON TIN-COATED

SHIPPING WT (LBS)

TIN-COATEDSLOPE "A"

FB4CNF018 42 11/16" 14 5/16" 12 7/16" 12 5/16" 10 7/16" 18 1/8" 18 5/8" - 12" X - 112 112

FB4CNF024 42 11/16" 14 5/16" 12 7/16" 12 5/16" 10 7/16" 18 1/8" 18 5/8" - 12" X - 112 112

FB4CNF030 49 5/8" 17 5/8" 15 3/4" 15 5/8" 15 3/8" 23 1/8" 23 5/8" - 17" X - 122 122

FB4CNF036 49 5/8" 17 5/8" 15 3/4" 15 5/8" 15 3/8" 23 1/8" 23 5/8" - 17" X - 122 122

FB4CNF042 49 5/8" 21 1/8" 19 1/4" 19 1/8" 15 11/16" 23 7/16" 23 1/8" - - - X 157 157

FB4CNF048 49 5/8" 21 1/8" 19 1/4" 19 1/8" 15 11/16" 23 7/16" 23 1/8" - - - X 157 157

FB4CNF060 53 7/16" 21 1/8" 19 1/4" 19 1/8" 19 1/2" 27 1/4" 26 15/16" - - - X 175 175

NOTE: 1. SERIES DESIGNATION IS THE 14TH POSITION OF UNIT PRODUCT NUMBER 2. ALL DIMENSIONS ARE IN "INCHES" UNLESS NOTED.

NOTE: ALLOW 21" FROM FRONT FOR SERVICE

1 7/8"

1 3/8"1 15/16" 1"

TOP VIEW

7/8"DIA. K.O. FOR LOW VOLTAGE CONTROL WIRING

7/8", 1 3/32" 2" DIA. K.O.'SFOR HIGH VOLTAGEPOWER WIRING

6 3/16"

2 5/8"

10 7/16"

1"

15/16"

5"

D

BLOWER, CONTROL,& ELECTRIC HEATER ACCESS PANEL

COIL ACCESS PANEL

DISCONNECT OR CIRCUIT BREAKER LOCATION

LIQUID LINE CONNECTION

SUCTION LINE CONNECTION

FILTER ACCESS PANEL

FITTING PANEL

B C

FRONT VIEWSHOWN WITH "A" COIL DETAILS CONNECTION

LOCATIONS FOR UPFLOW OR HORIZ. APPLICATIONS

INLET AIR

OPENING

10 3/4"

3 1/16"

4 11/16"

E

9 1/2"

ACCESS PANEL CONFIG. FOR

SLOPE COILS DOWNFLOW OR HORIZ.RIGHT APPLICATIONS

AND

"A" COILS DOWNFLOW APPLICATIONS



SUCTION LINECONNECTION

SLOPE COIL DETAILSCONNECTION LOCATIONS SHOWN

FOR UPFLOW OR HORIZ.LEFT APPLICATIONS

INLET AIR

1 1/2"

2 1/2"

1"

10 3/16"

3/4"

22 1/16"

OPENING 19 13/16"

2 1/8"

1 1/4"

A

FOR MODULAR UNITS

1 3/16"

MAX

7/8"11"

1 3/4"

19"

NOTE: MODULAR UNITS WILL HAVE A TWO-PIECE CABINET

RIGHT SIDE VIEW

OPTIONAL FIELD CONVERTEDRIGHT SIDE RETURN OPENING (SLOPE COIL UNITS ONLY)

ALTERNATE 7/8"DIA. K.O.

FOR LOW VOLTAGE CONTROL WIRING

ALTERNATE 7/8",1 3/32",2"DIA. K.O.'S FOR HIGH VOLTAGEPOWER WIRINGOPPOSITE SIDE

INLET AIR

OUTLET AIR

H J

SUCTION: 018 & 024 - 5/8" I.D. SWEAT 030 & 036 - 3/4" I.D. SWEAT 042 THRU 060 - 7/8" I.D. SWEAT LIQUID: 3/8" I.D. SWEAT CONDENSATE: 3/4" FPT

UNIT CONNECTION SIZES

A10005


FB4C

cbst6wz

Rectangle

Unit Report For FC/CU-3-2 Project: Calabasas School 12/21/2010 Prepared By: Kyle Heinsen 06:00AM


Outdoor Unit Parameters Unit Quantity: ..................................................... 1 Unit Model: ...............................................25HBB Unit Size: .................................................. 3 Tons Voltage: .......................................... 208/230-1-60 V-Ph-Hz

Indoor Unit Parameters Unit Quantity: ..................................................... 1 Unit Model: ................................................. FB4C Unit Size: ......................................... 36,000 Btuh Cabinet Insulation:Single-piece cabinet with 1-in. super thick insulation ............................................................... Voltage: .......................................... 208/230-1-60 V-Ph-Hz

System Parameter System Quantity: ............................................... 1 Heating Size: .......................................... No Heat Outdoor Unit Dimensions and Weight Unit Length: ............................................. 4' 10.0'' Unit Width: ................................................. 3' 4.0'' Unit Height: ................................................ 2' 9.0'' Unit Shipping Weight: .................................... 207 lb Note:Outdoor unit dimensions may vary depending on the minor series sent from the factory. .....................

Indoor Unit Dimensions and Weight Unit Length: ............................................. 1' 10.1'' Unit Width: ................................................. 1' 9.0'' Unit Height: ................................................ 4' 1.0'' Unit Shipping Weight: .................................... 122 lb

Warranty Information Indoor FB4C First Year - Parts Only (Standard) Warranty Information Outdoor 25HBB First Year - Parts Only (Standard) Ordering Information

Part Number Description Quantity Base Unit - Outdoor

25HBB336A003 25HBB Heat Pump with Puron 3 Tons Cooling 1 13 SEER @ ARI Conditions 1

Accessories KSAHS1701AAA Start Assist - Capacitor and Relay 1 KSALA0301410 Low Ambient Pressure Switch 1

KAACH1701AAA Crankcase Heater 1 KAAFT0101AAA Evaporator Freeze Thermostat 1 KHAIR0101AAA Isolation Relay 1 KSATX0201PUR Thermostatic Expansion Valve (Hard Shutoff) 1

Base Unit - Indoor FB4CNF036000 FB4C Base Series Fan Coil with Puron 36000 BTU Cooling 1

Single-piece cabinet with 1-in. super thick insulation 1

cbst6wz

Text Box

FC/CU-3-2

Performance Summary For FC/CU-3-2 Project: Calabasas School 12/21/2010 Prepared By: Kyle Heinsen 06:00AM


System: ........................................ 25HBB/FB4C System Quantity: ............................................... 1 Altitude: .......................................................... 0.0 ft Linear Pipe Length: ........................................ 0.0 ft Actual SEER: ................................................ 13.0 EER @ ARI Conditions:................................ 11.2 Outdoor Unit Parameters Unit Quantity: ..................................................... 1 Unit Model: ................................ 25HBB336C003 Unit Size (Nominal):.................................. 3 Tons Voltage: .......................................... 208/230-1-60 V-Ph-Hz Clg Ent Air DB Ambient: ............................... 95.0 °F Htg Ent Air DB Ambient: ............................... 47.0 °F

Indoor Unit Parameters Unit Quantity: ..................................................... 1 Unit Model: ................................ FB4CNF036000 Unit Size (Nominal): ......................... 36,000 Btuh Voltage: .......................................... 208/230-1-60 V-Ph-Hz Actual Airflow: ........................................... 1050.0 CFM Standard Airflow: ...................................... 1050.0 CFM Total Net Clg Capacity: ............................... 33.37 MBH Net Sensible Clg Capacity: ......................... 24.04 MBH Ent Air DB: .................................................. 80.00 °F Ent Air WB: ................................................. 67.00 °F Ent Enthalpy: .............................................. 31.44 BTU/lb Lvg Air DB: ................................................. 58.80 °F Lvg Air WB: ................................................ 56.97 °F Lvg Enthalpy: .............................................. 24.37 BTU/lb Heating Size (Nominal): .......................... No Heat Indoor Unit External Static: ........................... 0.40 in wg Total System Power: .................................... 2.98 kW

Heat Pump Htg HP Capacity: ........................................ 34.92 MBH Htg HP Integrated Capacity: ....................... 34.92 MBH Heating HP Compressor Power: .................. 2.99 kW Htg Ent Air DB: ............................................. 70.0 °F Htg Lvg Air DB: ........................................... 100.8 °F COP @ 47 F: ................................................ 3.58 COP @ 17 F: ................................................ 2.52

Outdoor Electrical Data Unit Voltage: ................................... 208/230-1-60 V-Ph-Hz Fan Motor FLA:............................................. 0.90 Amps MCA: ............................................................... 22 Amps Max Fuse: ........................................................ 35 Amps Operating Range Min: ................................... 197 V Operating Range Max: .................................. 253 V Compressor RLA: ......................................... 16.7 Amps Compressor LRA: ......................................... 79.0 Amps Min Wire Size @ 60C: ..................................... 12 Min Wire Size @ 75C: ..................................... 12 Max Length Wire Size @ 60C: ........................ 58 ft Max Length Wire Size @ 75C: ........................ 56 ft

Indoor Electrical Data: (For units with no factory or field installed electric heaters) Unit Voltage: ................................... 208/230-1-60 V-Ph-Hz Unit FLA: ........................................................ 2.7 Amps Unit MCA: ....................................................... 3.4 Amps Unit MOCP: .................................................. 15.0 Amps Unit Min Wire Size: ....................................... 14.0 Unit Fuse/Ckt Bkr Amps: .............................. 15.0 Amps Motor HP: ....................................................... 1/3 HP

Acoustic Summary For FC/CU-3-2 Project: Calabasas School 12/21/2010 Prepared By: Kyle Heinsen 06:00AM


Outdoor Unit Parameters: Tag Name: ....................................................................................................................................................................... FC-3-2 Unit Model: ..................................................................................................................................................................... 25HBB Unit Size: ........................................................................................................................................................................ 3 Tons


Indoor Unit Parameters: Tag Name: FC-3-2 Unit Model: FB4C Unit Size: 36,000 Btuh Cabinet Insulation: Single-piece cabinet with 1-in. super thick insulation


Certified Drawing for FC/CU-3-2 Project: Calabasas School 12/21/2010 Prepared By: Kyle Heinsen 06:00AM


8

DIMENSIONS

25HBB3

cbst6wz

Rectangle



5

DIMENSIONS (cont.)

A-COIL

NOTES:1. CONDENSATE PAN DRAIN CAPS NOT SHOWN FOR CLARITY. 2. ALL DIMENSIONS ARE IN "INCHES" UNLESS NOTED.

* HORIZONTAL MOUNT LOCATIONS - DIMPLES PROVIDED IN TOP PANEL, AND BACK OF CABINET. IN CABINET BOTTOM. HOLES PROVIDED

SLOPE COIL

3 1/4"2 9/16"

2 7/8"

2 3/16" TYP.

(2 PLACES)*


1" TYP. (2 PLACES)*

1 1/4"

AIRFLOW

SECONDARY DRAIN

PRIMARY DRAIN

UPFLOW(AS SHIPPED)

7/8"TYP.*

1/2"TYP.* 2 1/8"

1 5/8"

F 1 1/4"

PRIMARY DRAIN

SECONDARY DRAIN

HORIZ. RIGHT(FIELD CONVERTED)

1 1/4"

3 1/4"

1" TYP. (2 PLACES)*


2 3/16" TYP.(2 PLACES)*

G F

AIRFLOW

SECONDARY DRAIN

PRIMARY DRAIN


1 13/16"TYP.*

5/16" TYP.*

1 5/8"

5/16" TYP.*

7/8"TYP.*

2 7/8"

5"

1 1/4"

1/2"TYP.*

SECONDARY DRAIN

PRIMARY DRAIN


1 13/16"TYP.

5/16" TYP.*

1" TYP. (2 PLACES)*

7/16" TYP,(4 PLACES)*

4 3/4"

3 1/16" F

2 3/16" TYP.(2 PLACES)*

G

AIRFLOW


SECONDARY DRAIN

PRIMARY DRAIN

7 7/8"1 3/16"

1 1/2"

1/2"TYP.*

1 13/16"TYP.

5 7/8"

5/16" TYP.*

7/8"TYP.* HORIZ. RIGHT

(FIELD CONVERTED)

PRIMARY DRAIN

SECONDARY DRAIN

7 7/8"1 3/16"

1 1/2"

1 13/16"TYP*

5/16" TYP*

7/8"TYP*

1/2"TYP* 5 7/8"

PRIMARY DRAIN

SECONDARY DRAIN


2 3/16" TYP.

(2 PLACES)*

1" TYP. (2 PLACES)

7/16" TYP.(4 PLACES)

2 11/16"

3" 1/8

3 1/16"

4 3/4"

AIRFLOW

UPFLOW(AS SHIPPED)

PRIMARY DRAIN

SECONDARY DRAIN

A10006


FB4C



4

DIMENSIONS

UNIT A B C D E F G H J COIL

CONFIGURATION SHIPPING WT

(LBS) NON TIN-COATED

SHIPPING WT (LBS)

TIN-COATEDSLOPE "A"

FB4CNF018 42 11/16" 14 5/16" 12 7/16" 12 5/16" 10 7/16" 18 1/8" 18 5/8" - 12" X - 112 112

FB4CNF024 42 11/16" 14 5/16" 12 7/16" 12 5/16" 10 7/16" 18 1/8" 18 5/8" - 12" X - 112 112

FB4CNF030 49 5/8" 17 5/8" 15 3/4" 15 5/8" 15 3/8" 23 1/8" 23 5/8" - 17" X - 122 122

FB4CNF036 49 5/8" 17 5/8" 15 3/4" 15 5/8" 15 3/8" 23 1/8" 23 5/8" - 17" X - 122 122

FB4CNF042 49 5/8" 21 1/8" 19 1/4" 19 1/8" 15 11/16" 23 7/16" 23 1/8" - - - X 157 157

FB4CNF048 49 5/8" 21 1/8" 19 1/4" 19 1/8" 15 11/16" 23 7/16" 23 1/8" - - - X 157 157

FB4CNF060 53 7/16" 21 1/8" 19 1/4" 19 1/8" 19 1/2" 27 1/4" 26 15/16" - - - X 175 175

NOTE: 1. SERIES DESIGNATION IS THE 14TH POSITION OF UNIT PRODUCT NUMBER 2. ALL DIMENSIONS ARE IN "INCHES" UNLESS NOTED.

NOTE: ALLOW 21" FROM FRONT FOR SERVICE

1 7/8"

1 3/8"1 15/16" 1"

TOP VIEW

7/8"DIA. K.O. FOR LOW VOLTAGE CONTROL WIRING

7/8", 1 3/32" 2" DIA. K.O.'SFOR HIGH VOLTAGEPOWER WIRING

6 3/16"

2 5/8"

10 7/16"

1"

15/16"

5"

D

BLOWER, CONTROL,& ELECTRIC HEATER ACCESS PANEL

COIL ACCESS PANEL

DISCONNECT OR CIRCUIT BREAKER LOCATION


SUCTION LINE CONNECTION

FILTER ACCESS PANEL

FITTING PANEL

B C

FRONT VIEWSHOWN WITH "A" COIL DETAILS CONNECTION

LOCATIONS FOR UPFLOW OR HORIZ. APPLICATIONS

INLET AIR

OPENING

10 3/4"

3 1/16"

4 11/16"

E

9 1/2"

ACCESS PANEL CONFIG. FOR

SLOPE COILS DOWNFLOW OR HORIZ.RIGHT APPLICATIONS

AND

"A" COILS DOWNFLOW APPLICATIONS



SUCTION LINECONNECTION

SLOPE COIL DETAILSCONNECTION LOCATIONS SHOWN

FOR UPFLOW OR HORIZ.LEFT APPLICATIONS

INLET AIR

1 1/2"

2 1/2"

1"

10 3/16"

3/4"

22 1/16"

OPENING 19 13/16"

2 1/8"

1 1/4"

A

FOR MODULAR UNITS

1 3/16"

MAX

7/8"11"

1 3/4"

19"

NOTE: MODULAR UNITS WILL HAVE A TWO-PIECE CABINET

RIGHT SIDE VIEW

OPTIONAL FIELD CONVERTEDRIGHT SIDE RETURN OPENING (SLOPE COIL UNITS ONLY)

ALTERNATE 7/8"DIA. K.O.

FOR LOW VOLTAGE CONTROL WIRING

ALTERNATE 7/8",1 3/32",2"DIA. K.O.'S FOR HIGH VOLTAGEPOWER WIRINGOPPOSITE SIDE

INLET AIR

OUTLET AIR

H J

SUCTION: 018 & 024 - 5/8" I.D. SWEAT 030 & 036 - 3/4" I.D. SWEAT 042 THRU 060 - 7/8" I.D. SWEAT LIQUID: 3/8" I.D. SWEAT CONDENSATE: 3/4" FPT

UNIT CONNECTION SIZES

A10005


FB4C

cbst6wz

Rectangle

25HBB3Base 13 Heat Pumpwith Puronr Refrigerant1---1/2 to 5 Nominal Tons (Sizes 18 to 60)

Product Data

the environmentally sound refrigerant

Carrier heat pumps with Puronr refrigerant provide a collection offeatures unmatched by any other family of equipment. The 25HBBhas been designed utilizing Carrier’s Puron refrigerant. Theenvironmentally sound refrigerant allows consumers to make aresponsible decision in the protection of the earth’s ozone layer.As an Energy Starr Partner, Carrier Corporation has determinedthat this product meets the Energy Starr guidelines for energyefficiency. Refer to the combination ratings in the Product Data forsystem combinations that meet Energy Starr guidelines.NOTE: Ratings contained in this document are subject tochange at any time. Always refer to the AHRI directory(www.ahridirectory.org) for the most up--to--date ratingsinformation.

INDUSTRY LEADINGFEATURES / BENEFITSEfficiencyS 13 SEER/ 10.1 -- 10.8 EER/ 7.7 -- 8.3 HSPF (nominal)S Microtube Technologyt refrigeration systemS Indoor air quality accessories available

SoundS Sound level as low as 72 dBAS Sound levels as low as 70 dBA with accessory sound blanket

ComfortS System supports Edger Thermidistatt or standard thermostatcontrols

ReliabilityS Puronr refrigerant -- environmentally sound, won’t deplete theozone layer and low lifetime service cost.

S Scroll compressorS Internal pressure relief valveS Internal thermal overloadS High pressure switchS Loss of charge switchS Filter drierS Balanced refrigeration system for maximum reliability

DurabilityWeatherArmort protection package:S Solid, durable sheet metal constructionS Dense wire coil guard availableS Baked--on powder paint

ApplicationsS Long--line -- up to 250 feet (76.20 m) total equivalent length, upto 200 feet (60.96 m) condenser above evaporator, or up to 80 ft.(24.38 m) evaporator above condenser (See Longline Guide formore information.)

S Low ambient (down to --20_F/--28.9_C) with accessory kit

cbst6wz

Text Box

CU-3A-1

3

PHYSICAL DATAUNIT SIZE SERIES 18---31 24---31 30---31 36---31 42---31 48---31 60---31

Operating Weight lb (kg)173(78.5)

173(78.5)

191(86.6)

192(87.1)

255(115.7)

265(120.2)

287(130.2)

Shipping Weight lb (kg)202(91.6)

202(91.6)

223(101.2)

224(101.6)

287(130.2)

297(134.7)

319(144.7)

Compressor Type ScrollREFRIGERANT Puron� (R---410A)

Control TXV (Puron Hard Shutoff)Heating Piston Size 42 46 55 57 61 61 76

Charge lb (kg)6.63(3.01)

6.58(2.98)

6.56(2.98)

7.57(3.43)

11.07(5.02)

11.3(5.13)

12.58(5.71)

COND FAN Propeller Type, Direct DriveAir Discharge VerticalAir Qty (CFM) 2611 2611 3810 3810 3810 4046 4046Motor HP 1/10 1/10 1/5 1/5 1/5 1/4 1/4Motor RPM 1100 1100 800 800 800 800 800

COND COILFace Area (Sq ft) 19.40 19.4 20.12 25.15 20.12 20.12 25.15Fins per In. 20 20 20 20 20 20 20Rows 1 1 1 1 2 2 2Circuits 5 5 5 6 6 8 8

VALVE CONNECT. (In. ID)Vapor 5/8 5/8 3/4 3/4 7/8 7/8 7/8Liquid 3/8

REFRIGERANT TUBES* (In. OD)Vapor 5/8 5/8 3/4 3/4 7/8 7/8 1---1/8Liquid 3/8

* For tubing sets between 80 and 200 ft. (24.38 and 60.96 m) horizontal or 20 ft. (6.09 m) vertical differential, consult the Longline Guideline.Note: See unit Installation Instruction for proper installation.

VAPOR LINE SIZING AND COOLING CAPACITY LOSSLONG LINE APPLICATION: An application is considered ”Longline” when the total equivalent tubing length exceeds 80 ft. (24.38m) or when there is more than 20 ft. (6.09 m) vertical separationbetween indoor and outdoor units. These applications requireadditional accessories and system modifications for reliable systemoperation. The maximum allowable total equivalent length is 250ft. (76.2 m). The maximum vertical separation is 200 ft. (60.96 m)

when outdoor unit is above indoor unit, and 60 ft. (18.3 m) whenthe outdoor unit is below the indoor unit. Refer to AccessoryUsage Guideline below for required accessories. See LonglineApplication Guideline for required piping and systemmodifications. Also, refer to the table below for vapor tubediameters based on the total length to minimize the coolingcapacity loss.

UnitNominal

Size (Btuh)

MaximumLiquidLine

Diameters(In. OD)

VaporLine

Diameters(In.) OD

Cooling Capacity Loss (%)Total Equivalent Line Length ft. (m)

StandardApplication Long Line Application Requires Accessories

26---50(7.9---15.2)

51---80(15.5---24.4)

81---100(24.7---31.5)

101---125(30.8---38.1)

126---150(38.4---45.7)

151---175(46.0---50.3)

176---200(53.6---60.0)

201---225(61.3---68.6)

226---250(68.9---76.2)


3/8

1/2 1 2 3 4 6 7 8 9 10

5/8 0 0 1 1 1 2 2 3 3


5/8 0 1 1 2 3 3 4 4 5

3/4 0 0 0 0 1 1 1 1 1


5/8 1 2 3 3 4 5 6 7 83/4 0 0 1 1 1 2 2 2 37/8 0 0 0 0 1 1 1 1 1


5/8 1 2 4 5 6 7 9 10 113/4 0 0 1 1 2 2 3 3 47/8 0 0 0 0 1 1 1 1 2


3/4 0 1 2 2 3 4 4 5 6

7/8 0 0 1 1 1 2 2 2 3


3/4 0 1 2 3 4 5 5 6 7

7/8 0 0 1 1 2 2 2 3 3


3/4 1 2 4 5 6 7 9 10 117/8 0 1 2 2 3 4 4 5 5

1---1/8 0 0 0 1 1 1 1 1 1Applications in this area are long line. Accessories are required as shown recommended on Long Line Application GuidelinesApplications in this area may have height restrictions that limit allowable total equivalent length, when outdoor unit is below indoor unit See Long Line Applica-tion Guidelines

25HBB3C

cbst6wz

Line

7

ELECTRICAL DATAUNITSIZE---

VOLTAGE,SERIES

V/PHOPER VOLTS* COMPR FAN

MCA

MINWIRESIZE†

MINWIRESIZE†

MAXLENGTH(FT)‡

MAXLENGTH(FT)‡

MAXFUSE**or BRKAMPSMAX MIN LRA RLA FLA 60° C 75° C 60° C 75° C

18---31

208/230/1 253 197

48 9.4 0.8 12.5 14 14 63 60 2024---31 58.3 12.8 0.8 16.8 14 14 47 45 2530---31 77 15.2 1.2 20.2 12 12 62 59 3036---31 79 16.7 1.2 22.0 12 12 57 54 3542---31 109 21.3 1.2 27.8 10 10 72 68 4048---31 117 21.8 1.2 28.4 10 10 70 67 4060---31 134 26.3 1.2 34.1 8 10 91 56 50

* Permissible limits of the voltage range at which the unit will operate satisfactorily{ If wire is applied at ambient greater than 30_C, consult table 310---16 of the NEC (ANSI/NFPA 70). The ampacity of non---metallic---sheathed cable (NM),

trade name ROMEX, shall be that of 60_C conditions, per the NEC (ANSI/NFPA 70) Article 336---26. If other than uncoated (no---plated), 60 or 75_Cinsulation, copper wire (solid wire for 10 AWG or smaller, stranded wire for larger than 10 AWG) is used, consult applicable tables of the NEC (ANSI/NFPA70).

} Length shown is as measured 1 way along wire path between unit and service panel for voltage drop not to exceed 2%.** Time---Delay fuse.FLA --- Full Load AmpsLRA --- Locked Rotor AmpsMCA --- Minimum Circuit AmpsRLA --- Rated Load AmpsNOTE: Control circuit is 24---V on all units and requires external power source. Copper wire must be used from service disconnect to unit.All motors/compressors contain internal overload protection.Complies with 2001 requirements of ASHRAE Standards 90.1

A--WEIGHTED SOUND LEVEL (dBA)



125 250 500 1000 2000 4000 8000

18---31 74 51.5 61.5 67.0 68.5 66.5 63.5 58.524---31 74 53.0 62.0 68.0 70.5 67.0 63.5 59.030---31 75 56.0 62.0 66.5 71.5 66.0 62.0 54.536---31 75 50.5 61.5 65.0 71.0 65.0 61.0 54.542---31 75 59.5 63.0 66.5 71.0 67.0 62.0 55.548---31 79 57.5 64.5 67.5 71.5 73.0 64.5 58.560---31 80 57.5 59.0 65.5 71.5 74.0 63.0 57.5


A--WEIGHTED SOUND LEVEL (dBA) WITH SOUND SHIELD



125 250 500 1000 2000 4000 8000

18---31 73 51.5 62.0 67.0 68.0 66.0 63.0 58.524---31 74 53.0 62.0 67.5 69.0 66.5 63.0 58.030---31 74 57.0 61.5 66.0 70.0 65.0 60.5 52.536---31 73 51.0 61.5 64.5 69.0 63.5 60.5 53.042---31 73 60.0 63.5 66.5 69.5 66.0 60.5 52.548---31 77 57.0 65.5 67.5 69.5 71.0 61.0 53.560---31 77 57.5 58.5 65.0 68.5 71.0 60.0 53.0


CHARGING SUBCOOLING (TXV--TYPE EXPANSION DEVICE)UNIT SIZE --- VOLTAGE,SERIES REQUIRED SUBCOOLING ° F (° C)

18---31 8 (4.4)24---31 10 (5.6)30---31 10 (5.6)36---31 11 (6.1)42---31 11 (6.1)48---31 12 (6.7)60---31 11 (6.1)

25HBB3C

cbst6wz

Highlight

cbst6wz

Rectangle

cbst6wz

Line

cbst6wz

Line

9

DIMENSIONS -- ENGLISH

B

3 13/16”

K

1 1/8”L

C 3 1/2”1 7/8”

N

P

M

E

F

G

A

208-230-1-60

230-1-60

208/230-3-60

460-3-60

UNIT SERIES ELECTRICALCHARACTERISTICSA B C D E F G K L M N P OPERATING

WEIGHT (lbs)SHIPPING

25HBB318 0 X O O O 25 3/4” 35 1/4” 3 3/4” 5/8” 4 7/16” 21 1/4” 9 1/8” 2 13/16” 1/2” 13 1/2” 14 1/2” 14” 148 174

25HBB324 0 X O O O 31 3/16” 28 15/16” 3 3/4” 5/8” 6 9/16” 24 11/16” 9 1/8” 2 13/16” 1/2” 15 5/8” 16 3/4” 14 1/2” 162 189

25HBB330 0 X O X O 31 3/16” 39 1/8” 3 3/4” 3/4” 6 9/16” 24 11/16” 9 1/8” 2 13/16” 1/2” 16 1/2” 15 1/2’ 17” 186 215

25HBB336 0 X O X X 35” 28 15/16” 3 3/4” 3/4” 6 9/16” 28 7/16” 9 1/8” 2 13/16” 1/2” 15 1/2” 15 3/4” 12 1/2” 172 207

25HBB342 0 X O X X 35” 39 1/8” 3 7/8” 7/8” 6 9/16” 28 7/16” 9 1/8” 2 15/16” 5/8” 17 1/4” 19 1/8” 15 3/4” 246 278

25HBB348 0 X O X X 35” 28 15/16” 3 7/8” 7/8” 6 9/16” 28 7/16” 9 1/8” 2 15/16” 5/8” 17” 16” 12” 240 273

25HBB360 0 X O O O 35” 28 15/16” 3 7/8” 7/8” 6 9/16” 28 7/16” 9 1/8” 2 15/16” 5/8” 17” 16” 12” 250 282

25HBB360 1 X O X X 35” 28 15/16” 3 7/8” 7/8” 6 9/16” 28 7/16” 9 1/8” 2 15/16” 5/8” 17” 16” 12” 250 282

1824,30,36

36,42,48,60

AIRDISCHARGE

AIR DISCHARGE

SQ. AIR IN

VAPOR LINE CONN.D

3/8”LIQUID LINE CONN.

AIR IN

AIR IN

3/8” TIEDOWN KNOCKOUTS(2) PLACES

FIELD CONTROLSUPPLY CONN.

7/8” HOLE

FIELD POWER SUPPLY CONN.7/8” HOLE WITH

1 1/8” KNOCKOUT

X = YESO = NO

NOTES:

1. ALLOW 30” CLEARANCE TO SERVICE SIDE OF UNIT,48” ABOVE UNIT, 6” ON ONE SIDE, 12” ON REMAINING SIDE,AND 24” BETWEEN UNITS FOR PROPER AIRFLOW.

2. MINIMUM OUTDOOR OPERATING AMBIENT IN COOLINGMODE IS 55

F, MAX. 125

25HBB3

cbst6wz

Rectangle

10

CLEARANCES

Clearances (various examples)

Wall6”

(152.4)

24”(609.6) Service

Wall

Wall

Wall

12” (304.8)

12”(304.8)

18” (457.2)

24”(609.6) Service

6” (152.4)

12”(304.8)

24”(609.6) Service

24”(609.6) Service

24”(609.6) Service

Note: Numbers in ( ) = mm

18” (457.2)

18” (457.2)

12” (304.8)

A07832

25HBB3C

enclosed is submittal data for the … plus/calabasas hs submittals - splits.pdf · enclosed is...

Documents