dth - armouree

A

B

c

D

1 2 3 4 5

,------------------------------------------------------------------------------------------------- -

COMPONENTS

AUTO VALVE (AV)

CHECK VALVE (CV)

COMPRESSOR

CONVERTER SIGNAL (UA) FREQUENCY (UF)

DETECTOR SENSOR (DT) FIRE (DTF') GAS (DTG;

ELECTRIC FAN/MOTOR (M)

ELEMENT /SENSOR FLOW (FE) PRESSURE (PE) SPEED (SE) TEMPERATURE (TE) VIBRATION (VE)

FIL TER/COALESCER (F)

FILTER, STRAINER (F)

FIRE DAMPER (FD)

FLAME ARRESTOR (XFA)

FLOW CONTROL VALVE, ELECTRIC, 2 POSITION (FCE)

FLOW CONTROL VALVE, ELECTRIC, 3 POSITION (FCE)

FLOW CONTROL VALVE, MECHANICAL (FCM)

FLOW ORIFICE (FO)

GAS TURBINE (T)

GAS TURBINE (T)

HAND VALVE (HV)

11.,---· :1 f : ........ II

0 •

HAND VALVE, BLOCK AND BLEED (HV) ~ LJ'I

HAND VALVE, TRANSFER 3 WAY (HV)

HAND VALVE, TRANSFER 5 WAY (HV)

DEVICE ID AND SYMBOL LEGEND

COMPONENTS

HEATER (H)

HEAT EXCHANGER (HE)

INDICATOR FLOW (FI) LEVEL (LI) PRESSURt: (PI) PRESSURE DIFFERENTIAL (POl) TEMPERATURE (TI)

INDUCTANCE (LB)

MOTOR, PNEUMATIC (M)

MOTOR, ELECTRIC (M)

NOISE REDUCER/MUFFLER (NR)

NOZZLE, FIRE SYSTEM (N)

PRESSURE CONTROL ELECTRICAL (PCE)

PRESSURE CONTROL VALVE (PCV)

PRESSURE CONTROL VALVE AND REGULATOR (PCV)

PRESSURE SAFETY VALVE (PSV)

PUMP (P)

RESERVOIR, ENGINE CLEANING (T)

RESERVOIR, FIRE SYSTEM BOTTLE (R)

SIGHT GLASS (SG)

SOLENOID VALVE, 2 POSITION (SV)


SOLENOID VALVE, 4 WAY (SV)

2

I EW0l I

0

I l$i I

3

COMPONENTS


SOLENOID DRIVING PNEUMATIC BALL VALVE (SV)

SOLENOID VALVE, 2WAY-4WAY ASSY (SV)

SWITCH FLOW (FS) LEVEL (LS) POSITION (ZS) PRESSURE (PS) PRESSURE DIFFERENTIAL (PDS) TEMPERATURE (TS) VIBRATION (VS)

TEMPERATURE CONTROL ELECTRICAL (TCE)

TEMPERATURE CONTROL VALVE (TCV)

THERMOWELL, NPT CONNECTION (TW)

THERMOWELL, FLANGED CONNECTION (TW)

TRANSMITTER FLOW (FTI LEVEL (L T) POSITION (ZT) PRESSURE (PT) PRESSURE DIFI"ERENTIAL (PDT) TEMPERATURE (TT) VIBRATION (VT)

a ~ kfol ~

4

SYMBOLS

CONTROL SYSTEM INTERFACE, WITH CROSS REFERENCE TO ELECTRIC LOOP SCHEMATIC, SHEET 44, DRAWING ZONE Cl HH HIGH SHUTDOWN H HIGH ALARM L LOW ALARM LL LOW SHUTDOWN

CUSTOMER INTERFACE REFER TO MECHANICAL INTERFACE DRAWING FOR CONNECTION INFORMATION

CYLINDER, HYDRAULIC

DECREASER/INCREASER

=ELS/44C1

DtH DLL

SOLAR CUSTOMER SUPPLY SUPPLY

C] DRAIN TO TANK, BELOW FLUID LEVEL UNLESS OTHERWISE NOTED l DRAIN TO TANK, ABOVE FLUID LEVEL UNLESS OTHERWISE NOTED

FIND NUMBER SYMBOL (FN)

FLANGED, CONNECTION

PORT PLUGGED/NPT CONNECTION

FLOW DIRECTION

LINES CROSSING

LINES JOINING

VENT, AIR

MAIN LINE

SECONDARY PROCESS, INSTRUMENT LINE

/

....

-t+

PNEUMATIC LINE U I I I

HYDRAULIC LINE '

SKID LIMIT ----

FLOAT, LIQUID LEVEL e

5

6 7 8

REVISION HISTORY RELEASE - REV _351

REV DESCRIPTION DATE APPROVED

A INITIAL SUBMITTAL 5/23/2013

B CUSTOMER REQUEST 8/2/2013

c CUSTOMER REQUEST 9/25/2013

D AS SHIPPED 3/3/2014

GENERAL NOTES: ffi SYMBOLS IN THE LEGEND ARE DERIVED FROM ISA S5.1 AND ARE CONSIDERED BASIC

STANDARDS. NOT ALL SYMBOLS MAY BE USED ON THIS DRAWING. SYMBOLS MAY BE COMBINED.

ffi PIPE AND TUBE SIZES SHOWN ARE MINIMUM DIAMETERS. ACTUAL SIZES MAY BE LARGER. ALL LINE SIZES ARE IN INCHES. NO METRIC EQUIVALENTS HAVE BEEN ADOPTED. STATIC PRESSURE MONITORING, SENSING AND ORIFICED HOT DRIP DRAIN LINES TO BE 3/8" TUBING.

& REFERENCE ONLY, PART OF ENGINE.

& CUSTOMER FURNISHED.

& LOOSE SHIPPED FOR SITE INSTALLATION.

& VALVE TYPE IS NOT EXPLICITLY DEPICTED ON DRAWING. USING THE PART NUMBER, SEE OMI FOR VALVE TYPE.

& VALVES THAT MOVE ON LOSSS OF INPUT SIGNAL WILL BE LABELED AS SUCH: FO = FAIL OPEN FC = FAIL CLOSE

INSTRUMENT ABBREVIATIONS ASY ASSEMBLY PE PRESSURE ELEMENT AV AUTO/TRANSFER VALVE PI PRESSURE INDICATOR CV CHECK VALVE PS PRESSURE SWITCH CYL CYLINDER PSV PRESSURE SAFETY VALVE DT SENSOR DETECTOR PT PRESSURE TRANSMITTER DTF FIRE DETECTOR R RESERVOIR DTG GAS DETECTOR SE SPEED ELEMENT F FILTER/SEPARATOR/COALESCER SG SIGHT GLASS FCE FLOW CONTROL VALVE. ELECTRICAL SV SOLENOID VALVE FCM FLOW CONTROL VALVE. MECHANICAL T GAS TURBINE FD FIRE DAMPER TCE TEMPERATURE CONTROL ELECTRICAL FE FLOW ELEMENT TCV TEMPERATURE CONTROL VALVE Fl FLOW INDICATOR TE TEMPERATURE ELEMENT FO FLOW ORIFICE Tl TEMPERATURE INDICATOR FS FLOW SWITCH TS TEMPERATURE SWITCH FT FLOW TRANSMITTER TT TEMPERATURE TRANSMITTER H HEATER TW THERMOWELL HE HEAT EXCHANGER UA SIGNAL CONVERTER HV HAND VALVE UF FREQUENCY CONVERTER Ll LEVEL INDICATOR VE VIBRATION ELEMENT LS LEVEL SWITCH VS VIBRATION SWITCH L T LEVEL TRANSMITTER VT VIBRATION TRANSMITTER M MOTOR XFA FLAME ARRESTOR N NOZZLE. FIRE SYSTEM ZS POSITION SWITCH MS MOTOR/STARTER ZT POSITION TRANSMITTER NR NOISE REDUCER P PUMP PCE PRESSURE CONTROL ELECTRIC PCV PRESSURE CONTROL VALVE POl PRESSURE DIFFERENTIAL INDICATOR PDS PRESSURE DIFFERENTIAL SWITCH PDT PRESSURE DIFFERENTIAL TRANSMITTER

TAG NUMBERING SYSTEM CUSTOMER TAG NUMBERING

EXAMPLE BELOW: 0000 1000 2000 3000 4000 5000 6000 7000 8000 9000

CONTROLS TURBINE FUEL

CUSTOMER TAG PREFIX WITH "003-"

LUBE OIL DRIVEN EQUIPMENT DRY SEAL GENERAL BALANCE OF PLANT STEAM TURBINE/EMD SPARE

APPROVED

PROJECT MGR. DATE

PDSHH-02-5310F 003-PDSHH-02-5310F

CUSTOMER

DEVON CANADA CORPORATION FERRIER CPF

LSD" 11-02-039-08 W5M WBS" 01-00348.01

DRAWING TITLE

TAURUS 70 - COMPRESSOR SET PROCESS & INSTRUMENTATION DIAGRAM

LEGEND AND GENERAL NOTES

Z. LEE

Z. LEE

Z. LEE

Z. LEE

K. TER HORST 2/11/2013 Solar Turbines PROJECT ENGR. DATE Z. LEE 2111/2013

DESIGN T. ZASPAL JR.

RELEASE STAMP PD-3P861

DATE 2/11/2013

CAGE CODE

A Caterpillar Company DRAWING NO. SIZE D ~~~~ D

@ D

66195 3P861-149446 SHEET 1 OF 19

6 'THIS COPYRIGHTED WORK AND THE INFORMATION HEREIN IS PROPRIETARY TO CATERPILLAR INC .. SOLAR TURBINES INCORPORATED AND/OR SUBSIOIARIES OF EITHER. WITHOUT EXPRESS WRITTEN PERMISSION FROM CATERPILLAR INC. OR SOLAR TURBINES INCORPORATED, ANY COPYING, DISCLOSURE, OR USE EXCEPT THAT FOR WHICH IT IS LOANED. IS PROHIBITED."

A

B

c

D

z 0 > w 0

1 2 3 4 5

A

B SKID EDGE

& ELS/4A3

ELS/27A3 I ~ /uF\ I

'-1. 309;

Q ELS/2781

W.!,RE .. M ~ ~

B B I

UF1300 I MI300

c

D

2 3 4 5

6

GT

6

7 8

I NOTE: SEE LEGEND SHEET FOR GENERAL AND FLAG NOTES. SEE SHEET 1 FOR NOTES 1 THROUGH 5.

~REFERENCE PRODUCT INFORMATION LETTER IPILIJ4g FOR START MOTOR LOAD PROFILES, VOLTAGE REQUIREMENTS, MAX NUMBER OF STARTS AND OTHER INFORMATION.

~NOT USED

CUSTOMER


LSD" 11 -02-03g-08 W5M WBS" 01-00348.01

DRAWING TITLE


START SYSTEM

Solar Turbines A Caterpillar Company

DRAWING NO. DWG D ISHT D REV REV

3P861-149446 SHEET 2 OF 19

"THIS COPYRIGHTED WORK AND THE INFORMATION HEREIN IS PROPRIETARY TO CATERPILLAR INC .. SOLAR TURBINES INCORPORATED AND/OR SUBSIDIARIES OF EITHER. WITHOUT EXPRESS WRITTEN PERMISSION FROM CATERPILLAR INC. OR SOLAR TURBINES INCORPORATED, ANY COPYING, DISCLOSURE. OR USE EXCEPT THAT FOR WHICH IT IS LOANED. IS PROHIBITED."

A

B

c

D

z 0 > w 0

1 2

& *ASY6500

A

T 0 SINGLE STAGE '<---------')I<C-------1 SELF CLEANING "' BARRIER AIR I I INLET FILTER PCV6530

I I 1 ____________ 1

B

TURBINE f--------1 AIR

INLET

HE6530

£ 8

ELS/28A1

TE

1110

TE1110

3

~-----------------------------------------r------~~--~~~----~~

c

0

701 V1

@) ON-CRANK ~ CLEANING FLUID PER SOLAR ES9-62

@) ON-LINE ~ CLEANING I FLUID PER SOLAR ES9-62 I

@~: I

602

IA9

F1720

F1710

3/4"

HI

POT1110

LO

3/8"

HV1110

ELS/22C1

~ SV1720 ~

ELS/22C1

3/8"

@ ~

SV1710

HAND WAND CONNECTION

F01720

F1721

F1711 F01710

CV1110 1\ ~

2

3/4"

3

ELS/2201 HH

PDS

1500

HI

3/8"

4

EL S/23A1

PT

1120 ELS/23A1

3/8"

PT PT1120

F01120 -, 1\ <HOTl DRAIN~~ TO DRIP PAN l '

PT

3/8"

HV6531 1/2"

SKID EDGE

T1000

FRONT SEAL AIR

1/2"

SEE PAGE 4, DETAIL

<D

ELS/25A1

FCE FCE1440

F06530

SEE PAGE 4, DETAIL

0

rLJ§ / ....... R1700

4

PT1121

ELS/24A1

FCE FCE1420

FC

TORCH

1/2'

COMBUSTOR

'-----( )

1/2" 3 8'

114"

5

TURBINE EXHAUST

SEE PAGE 4, DETAIL

SEE SEE PAGE PAGE

4, 4, DETAIL DETAIL

G)

5

0 ®

REAR SEAL AIR

1/2'

1/2"

ELS/34A1

PE H

1520

1/2"

PE PEl520 1\ ~

* ASY1520 ,------- ------

1

I

I I I HV1521 HVl522 I

L __________ _

6

PCV1031

6

7 8

NOTE: SEE LEGEND SHEET FOR GENERAL AND FLAG NOTES.

SEE SHEET 1 PAGE FOR NOTES 1 THROUGH 5.

MF01120 SHALL BE INSTALLED AT THE LOWEST POINT OF THE TRAP. THE MINOR NON-CONTINUOUS CONDENSATE DRAINAGE IS TO BE DRAINED TO THE DRIP PAN.

£BAM (BURNER ACOUSTIC MONITOR! COIL MUST BE MOUNTED BETWEEN 6 AND 36 INCHES.OF TORCH "P.T." PORT. NO SHARP BENDS PERMITTED IN TRANSFER TUBE. <MINIMUM BEND RADIUS 3 INCHES TO !DI.

~NOT USED

MNOT USED

MNOT USED

MINSTALL CV1110 IN HORIZONTAL PLANE.

£NOT USED

MNOT USED

M 10 INCHES (254 MMI OF 3/8" TUBING REQUIRED BETWEEN PDS1500 AND F01500 FOR PROPER TIMING.

~NOT USED

MNOT USED

~NOT USED

gNOT USED

gNOT USED

~NOT USED

CUSTOMER


LSD" 11-02-039-08 W5M WBS" 01-00348.01

DRAWING TITLE


TURBINE SYSTEM PACE 1


DRAWING NO.

3P861-149446 DWG D REV

SHT D REV

SHEET 3 oF 19

'THIS COPYRIGHTED WORK AND THE INFORMATION HEREIN IS PROPRIETARY TO CATERPILLAR INC .. SOLAR TURBINES INCORPORATED AND/OR SUBSIDIARIES OF EITHER. WITHOUT EXPRESS WRITTEN PERMISSION FROM CATERPILLAR INC. OR SOLAR TURBINES INCORPORATED, ANY COPYING, DISCLOSURE, OR USE EXCEPT THAT FOR WHICH IT IS LOANED, IS PROHIBITED."

A

B

c

D

z 0 > w 0

A

B

c

0

1

DETAIL (D

ELS/3281 1/ '\ HH

VE H

1~21~

dJ"" ELS/3201

1/ "HH VE H

1'.[265;

0D262

ELS/2981

I/ TE "\ HH H

1'.[26~

0"'" ELS/26A1

I/ SE '\ ~H

1~26_9;

ELS/3281 / \ HH

VE H

021y

0"'"' ELS/32A1

/vE\

'.[26:V

0""" ELS/3301

/vE\ HH H

'.[20y

0"""

~E1260 ELS/2981

0 0TE1261

2

DETAIL @

ELS/32C1 / '\ HH

VE H

'.[22_9;

0"""

2

DETAIL G)

ELS/32C1 / '\ HH

VE H

~22y

0""''

3

ELS/32C1 1/ '\ HH

VE H

1~23y

0""''

3

DETAIL @

ELS/3381 1/ '\ HH

VE H

1~24~

0"""

ELS/29C1

1/ TE '\ HH H

1~27~

@"""

ELS/3381 1/ '\ HH

VE H

1~24~

4

0"'"'

ELS/29C1

0TE1271

4

DETAIL @

ELS/33C1 I/ '\ HH

VE H

1~25~

0"""' ELS/33C1 I/ "\ HH

VE H

I'-! 27 5;

0""" ELS/3081

1/ TE '\ HH H

1~15~

@"""'

ELS/3181 1/ '\ HH

TE H

1~15~

@""" ELS/2681

1/ SE '\ HH

1~27~ LL

0"'"''

ELS/33CI 1/ '\ HH

VE H

1~25y

0"'"' ELS/33A1

I/ VE "\

l'-!27j;

0""" ELS/3081

1/ TE '\ HH H

1~15y

@"""'

ELS/3181 1/ "\ HH

TE H

1~15~

@"""

5

ELS/30C1

I/ TE '\ HH H

1~15~

@'"'"'

ELS/3181 1/ "\ HH

TE H

1~15~

@"'"" ELS/26C1

/ SE \ HH

~27}/

0 "''"'

5

ELS/30C1 I/ TE '\

HH H

1~15~

@"""'

ELS/31C1 I/ "\ HH

TE H

1~15~

c0""""

ELS/3001 I/ TE "\

HH H

1~15~

@"""'

ELS/31C1 I/ "\ HH

TE H

1~16~

@""c'

6

ELS/3001

/TE"\ HH H

~15:V

@"""'

ELS/3101 / \ HH

TE H

016y

@"""

6

7 8

I NOTE: SEE LEGEND SHEET FOR GENERAL AND FLAG NOTES.

CUSTOMER


LSD" 11-02-039-08 W5M W8S" 01-00348.01

DRAWING TITLE


TURBINE SYSTEM PAGE 2


DWG D ISHT D REV REV

DRAWING NO.

3P861-149446 SHEET 4 OF 19

'THIS COPYRIGHTED WORK AND THE INFORMATION HEREIN IS PROPRIETARY TO CATERPILLAR INC .. SOLAR TURBINES INCORPORATED AND/OR SUBSIDIARIES OF EITHER. WITHOUT EXPRESS WRITTEN PERMISSION FROM CATERPILLAR INC. OR SOLAR TURBINES INCORPORATED, ANY COPYING, DISCLOSURE. OR USE EXCEPT THAT FOR WHICH IT IS LOANED. IS PROHIBITED."

A

B

c

D

z 0 > w 0

1 2

A

B

c

0

2

3 4 5

C41ML COMPRESSOR INTERNAL DEVICES

TE4438 ELS/51A1

/TE\

VE4460 ELS/5081 I/ \ HH

VE H

1~45§Jt

TE4414 ELS/52A1

/TE\

~ ~ EL~~~ ~vC~

0p /TE\

~43_?; ELS/5181 TE4437

TE4414-SP

DE

TE4413-SP

~~46J; ~H ELS/5081

VE4461

~41]; ELS/5281

3

@ HP

I SUCTION I

I

I DISCHARGE

DETAIL @ @ COMPRESSOR

I 1~43y 1041§;

~~S/52C1 ~ TE4434 ~~ ~TE4418

TE4434-SP

NOE

TE4433-SP

TE4433 ~~ ~TE4417 ~~S/5201 y

',----------------------------------~ -~~ ~~ I I/T0 1/TE\

I

4

1~43_} ELS/5201

1~41_?; ELS/51D1

5

ELS/50C1

/ VE '\ ~H

~47_9;

6

VE4470

VE

r- D

ELS/50A1

1/vE\ 1~4 7;}

VE VE4473

<:10 .CH62

1/ VE '\

~~45_3, ~H ELS/50C1

9 """ /vE\

~47~ ~H ELS/50C1

6

7 8


CUSTOMER


LSD" 11-02-039-08 W5M W8S" 01-00348.01

DRAWING TITLE


COMPRESSOR DEVICES



DRAWING NO.

3P861-149446 SHEET 5 OF 19

'THIS COPYRIGHTED WORK AND THE INFORMATION HEREIN IS PROPRIETARY TO CATERPILLAR INC .. SOLAR TURBINES INCORPORATED AND/OR SUBSIDIARIES OF EITHER. WITHOUT EXPRESS WRITTEN PERMISSION FROM CATERPILLAR INC. OR SOLAR TURBINES INCORPORATED, ANY COPYING, DISCLOSURE. OR USE EXCEPT THAT FOR WHICH IT IS LOANED, IS PROHIBITED."

A

B

c

D

z 0 > w 0

A

B

c

0

GAS SUPPLY PER SOLAR ES 9-98. FUEL SYSTEM IS NACE COMPLIANT.

1

* ASY2100

HV2101

3"

ELS/4281

LS2101

LS 2101

H

HV2102

2

ELS/42A1

POT H

2100

HI LO

AI_-----------

ELS/37A1

A7

) GF1

SKID EDGE

@

~I I

0 ~:

CLEAN DRY AIR 100-200 PSIG

HH

PT2120

3/8"

F6400

ELS/38B1

@ ~

SV2120

1/2"

AV2120

ELS/57A1

PT H

6400 L

PT PT6400

_ _j HV6400

1"

CYL

3/8"

PSV6410

2

I

~

C4 GF2

ELS/38C1 F02121

FC

3/8"

AV2121

B6 IA4

FC

3

ELS/37A1

PT

2121

PT

2"

3/8"

3/8"

HH H

PT2121

TO ENGINE CLEANING SYSTEM

3

ELS/3701 HH

TE2120

TW2120

ELS/38C1

@ ~

SV2150

FC

* ASY2124

I ELS/38A1

I

I

I

@ ~ SV2124

AV2150 3/8"

4

2"

4

ELS/37B1

2"

B3 GF2

PCV2152

PT

2126

HH H

PT2126

PT

ELS/39C1

FT

2108

5

FT2108

§ y

A FE2108

@

ELS/40Al

FCE2140 FC ELS/36A1

PT 2130

ELS/36A1

PT 2131

ELS/35A1

FCE2130 FC

PT

3/8" 1--------~TO GAS

FUEL TORCH VIA TUBE

PT2131

5

2"

D2 ]A4

ELS/3801

sv 2143

6

SV2143

AV2143

PILOT GAS FUEL MANIFOLD #2

FO

ELS/41A1 1\ PT ~

2141

PT2140

PILOT GAS FUEL MANIFOLD

MAIN GAS FUEL MANIFOLD

6

F2106

1/2'

1-112"

1-1/2"

1 1/2"

TO GAS FUEL INJECTOR

7

C1

GF1

VIA STAINLESS STEEL FLEX HOSES

8

NOTE: SEE LEGEND SHEET FOR GENERAL AND FLAG NOTES. SEE SHEET 1 PAGE FOR NOTES 1 THROUGH 5.

Mcv2t50 TO BE LOCATED WITHIN 6 INCHES OF TORCH.

~PCV2152 TO BE ADJUSTED FOR BEST TORCH PERFORMANCE.

~PILOT AIR IS REQUIRED FOR ALL PHASES OF PACKAGE OPERATION.

M FOR FUEL SHUTOFF CERTIFIED REQUIREMENTS REFER TO "FUEL SHUT -OFF VALVE ASSEMBLY GUIDE". COMPLIANCE ENGINEER MUST APPROVE ANY CHANGES OR REPLACEMENTS OF THESE PARTS. CERTIFIED ASSEMBLY DRAWING IS 149098.

~INSTALL AS CLOSE TO SKID OVER PRESSURE PROTECTION

~VENT TO A SAFE LOCATION.

EDGE AS POSSIBLE. PROVIDED BY OTHERS.

MEFFLUENT WATER.

WILL BE HYDROCARBON FLUIDS AND

~NOT USED

~TRANSMITTER HAS NOT ADJUSTABLE.

FACTORY PRESET CAL! BRA TION,

~NOT USED

~NOT USED

~NOT USED

~INSTALL AS CLOSE TO SKID EDGE AS POSSIBLE.

CUSTOMER


LSD" 11-02-039-08 W5M WBS" 01-00348.01

DRAWING TITLE


CAS FUEL SYSTEM


DRAWING NO. OWG D SHT D REV REV

3P861-149446 SHEET 6 OF 19


A

B

c

D

z 0 > w 0

A

B

c

0

1

§ 8

2

'==::::7 XFA3270 r ---~ .... ~§

3

~~y rl f ~ :f---------__j ~ ,---------------------------,

~:

6" ~ll'

-'---

~! /~'"'------1~ 1=-11

CYL3220

~ ,;,F03220 M ELS/49Al

~------/§""3~3:-7f-----::::;_~_; ELS/49Bl I/ vs"'- H fz~ - ""' G ~~22~ v

M3220 v ~S3220, y dr

HEJ220 Cvs) !

r-Vvvl :if- ~ I

:~1 L--------------------------- J ,------1~

-- - - - .. -=r----- - - - ~

0V 0~ _L.--------Jy ~

--§~--~;:::-

M ELS/45Al ~~6" vPDT'-I~H

~10"'-' F3100 I

I -~0~ A'*' LO HI ~ PDT3100

3Cl ) Vl

~@ v -

~*'"~'

- -

R3100

- -

~ FO l\0 _

3/8" ,.

LJ

- -

LJ

• ~3'

:k •k '

.~3'

• ~3'

GT r=c~~)PJl1° BB2

FJ110 I~( ----LI lJLo~s~< IR F03111

,~6'

- - - - - -

••

2

- -

ELS/45Al

L T' H

'

~ ~10~ tL

~A 0 l LT )LT3100 \,_ Ll)

- - -

3

j ~3/8"

4

ELS/45Bl

l/pol" H

~~ 1 PDT3240

)~/~~-~~--~~ HI LO

,1. ------ ~

I /1 I IHV3240

L_ -- ---t-J

* ASY3240 ~----------------

1 ~ ~ I

I r ~ I

I I I HV3245 r I

I

5

~~3/8"

6 7 8

NOTE: SEE LEGEND SHEET FOR GENERAL AND FLAG NOTES.

I SEE SHEET 1 FOR NOTES 1 THROUGH 5.

II &LUBE OIL TANK LEVELS

BOTTOM AT FILL PORT. ARE MEASURED FROM TANK

MF03220 MUST HIGH POINT.

BE PLUMBED TO THE PIPING

~EXTERNAL PIPING IS TO BE VERIFIED TO BE CLEAN OF DIRT AND RUST PRIOR TO MAKING CONNECTIONS. UNDER NO CIRCUMSTANCES IS PIPING TO BE CLEANED AFTER CONNECTIONS ARE MADE TO THE TURBINE OR OIL COOLER.

~ F03110 TO BE CONNECTED TO PUMP DISCHARGE VENT PORT WITH F03110 ORIENTED VERTICALLY, FLOWING UPWARD.

M HV3242 MUST BE OPEN TO PERMIT HV3250 ACTUATION.

MNOT USED

II HV3250/ 4" 4" I 4"

r-----~~--~ . ~~~~~}-+-'J-----~·~--------------------------------------------------4~·----~8~A~l~ 1 -rs --.. /},_ F3240 ... ~ ____, i ... .. ~ LD

2 '>

I

I

I

I

I

I

I

I

I

I

I

I

I

I

I

I

I

I

I

I

I

I

I

I

I

I

I

I

I

I

I

I

I

I

£TERMINATE F3100 VENT LINE AT SKID EDGE ROUTE TUBING FOR CONTINUOUS DRAINAGE AWAY FROM TRANSMITTER.

8B4 LOl (

ELS/44Al

/TE\

\2_109; LL

' ~4'

I HV3242 HV3255 I

I dr I

I .. 1'\.3/ :·:. 4. I

I --... I

I F3250 I

I I I HV3246

I V3256 I

I , .. , ., .. I

3/4' 3/4" I

I_ - - _ _I_ - - - - - - - - - - - I

®~-

3" ::..

HV3150~- ---t ' g f----[><1----

31..§." ....

SAl

~L020(

2" I PCV3150 .: --[>l::J-.. ,.2"

1-1/2" .: ...

ELS/ 4 7Bl

LJ

PSV3l50

7J

TE3100

TE TANK ~G FILL/ ""''IIIIV M

P3150

TW

TW3100

M3150

F 3101

F3150 ~•a

~~3'

- - - - - - - - -

ELS/48Bl

Jl lQQQQI ~· LU

H3103

4

' - - -

5

- -

ELS/46Al

1/ps'

~17~

e PS3170

1-1/2" "0: .. - CV3170

r

F3171

~1-1/2" j ~-

BA2 jL03 )

I

I

I

I

I

I

I

I

I

I

M TRANSMITTER (PDT31001 SENSING LINES TO BE ROUTED FOR CONTINUOUSLY SLOPED DRAINAGE AWAY FROM TRANSMITTER WITH NO LOW POINTS OR TRAPS.

MNOT USED

~NOT USED

MNOT USED

~ATMOSPHERIC VENT. DO NOT PLUG.

~VALVES TO BE CLOSED BEFORE OPERATING LUBE PUMPS.

• .!.' PSV3170 +-------------1

I

-

F03170 ,,_ 112, "" 7\' '~' '1/Q" y l__--jll / ''-------[~~u____.

-

P3170

ELS/4701

M

M3170 .~1-1/2"

IRF3170

~1-1/2" j ~-

- - -

6

LU

I

I

I

I

I

I

I

- - - - -

CUSTOMER


LSD" 11-02-039-08 W5M WBS" 01-00348.01

DRAWING TITLE


LUBE SYSTEM PAGE 1


DRAWING NO.

3P861-149446 DWG D REV

SHT D REV

SHEET 7 OF 19

'THIS COPYRIGHTED WORK AND THE INFORMATION HEREIN IS PROPRIETARY TO CATERPILLAR INC, SOLAR TURBINES INCORPORATED AND/OR SUBSIDIARIES OF EITHER. WITHOUT EXPRESS WRITTEN PERMISSION FROM CATERPILLAR INC. OR SOLAR TURBINES INCORPORATED, ANY COPYING, DISCLOSURE, OR USE EXCEPT THAT FOR WHICH IT IS LOANED, IS PROHIBITED."

A

B

c

D

z 0 > w 0

787

A )_02

B

c

0

1

ELS/44A1 / \HH

TE H

~20~ L

TE3200

TE

TW3200

TW

7C5

( L020

2

4" ' ~ '1 3" .. .; ~ / ~

, r 1-112·

-

CV3320

~

, '1-1/2' ,

'2' 7C6 1" ) L03 ..:. ...

/ " 1-112" ... ...

F3310 F3320

~ ' ~ 702

L05

ELS/43A1

/TE\H

~519;

, '2''

ACCESSORY GEARBOX

5"

r\

,,6

SG3510

SG

,,6

TE3510 ~/"'\ ~}---o~---K

TW3510

f---7< , '1"

GAS PRODUCER

TURBINE

, 2" 2"

SG3520 SG

ELS/43A1

1/TE'\ ~H

1'-?52_9;

SG3530

SG

,, 3" , .. .. 3"

TE35~/"'\ ~,}---o--1

TW3520

LJ LJ LJ

2

3

3" .; ~

3" , r ELS/4601

/ps\

" ~205Y LL

""" ~ I 832" \__)

2", r

F3340

~ >----7< , r

1-1/2"

POWER TURBINE

4"

SG3540

SG

1r 4" ELS/43B1

ELS/45C1

/pT\ H

~20~ L LL

d0"" ~

3/8" .. -

/ TE '\ ~H

~545Y

x---~o-~~ '''"''

TW3540

LJ

3

4

\I F03425

J , ~

7B3

LOl

1/2" ,,

4

3" .. ~

rl" , r , '1" 2"

F3410 ~ 3.34 F3420

F3430

~

1/2"jl ,, , r 1",, Jl 112"

1" 1-1/2"

HP COMPRESSOR C41ML

5"

SG3630

SG

SG3620

SG

1/2' ,,

LJ LJ LJ LJ

5 6

5 6

7 8


MNOT USED

gNOT USED

gNOT USED

~START UP STRAINERS COMMISSIONING.

TO BE REMOVED AFTER UNIT

~NOT USED

~REFER TO ENGINE CONTROL SPEC FOR LUBE OIL HEADER PRESSURE SET POINTS.

CUSTOMER


LSD" 11-02-039-08 W5M WBS" 01-00348.01

DRAWING TITLE


LUBE SYSTEM PAGE 2


OWG D ISHT D REV REV

DRAWING NO.

3P861-149446 SHEET 8 OF 19


A

B

c

D

z 0 > w 0

A

B

c

0

1

ELS/5601

@ ~ r---$- SV5120

,---------:-11 ~7}~2 l2i ~~

2 3 4

ELS/55C1

1/po-f\ H

1~13~

,-------{6 POT 5130

HI LD

5 6 7

~M~~ I

I 8~ XFA5167 8~ XFA5177

I r .r

I I I

8

NOTE: SEE LEGEND SHEET FOR GENERAL AND FLAG NOTES. SEE SHEET 1 FOR NOTES 1 THROUGH 5.

~MAXIMUM ALLOWABLE VENT BACK PRESSURE IS 5 PSIG l0.345 BARGI.

£SEAL GAS SUPPLY FROM COMPRESSOR DISCHARGE. RECOMMEND THAT SUPPLY COME FROM DOWNSTREAM OF GAS COOLER. IF COOLER IS DOWNSTREAM OF COMPRESSOR DISCHARGE ISOLATION VALVE, AN OFF SKID ISOLATION VALVE IS REQUIRED. SEE PIL 140 FOR REQUIREMENTS.

~BUFFER AIR/N2 PER PIL 140. SUPPLY ~ FC ,,3/8'

1" (\ AV5120 1" CV5120 1"

1 :~-... ------'/~'-------~:~ec~J~--·---------... ----------------------~1 ~~~~----~--------------------~

,1;- - - - - - -· -. ---;],

I I

L ____ @~~r-------@~~=- REQUIRED WHENEVER COMPRESSOR CASE IS PRESSURIZED ll.E. STARTUP SHUTDOWN, PRESSURIZED HOLD AND RUNJ, OR WHEN PUMP IS ON. SUPPLY TEMPERATURE RANGE IS 32F TO 200F 10-93CI.

~8 ~

II ~/4' I•

FC

\0 L-----~~~--------~

ELS/5501

1/POT'\ H

1~10~

,-----16PDT5104

HI LD

,1,-------- -;J,

'i' '1' I I HV5!04 L_ ------ _j

~ L_ ,--

3/8"Jl F5104 ~~3/ 8 " CV5100

HV5101

F5105

DRAIN TO u DRIP PAN

I

85 V2

PSV 5160 ~f--------. ELS/5581

1/pT\ ~H

1~16~

~~Y'""' ELS/56A1

1/ FT'\ HH

~16~

]" n:

FT516~ ~ 86

~V7

1" J•·

/ " R5165 ,-----

F05160 ....__L-----'

1" Jl'

SG5165 HV5165

SG ~

LJ

LUBE OIL DRAIN

C5 LD6

l

•lr 3/4"

HV5132

3/B" .. ...

I IHV5130 L_ -- --- _j

F5140 318" u-

,,318"

SG5134

'--------'/~'----f

SG

~ HV5134 HV5144

I :f-------_j

S G 514 4+-----__j

SG , 1r 3/4"

ELS/5581

1/poT

~~150 ~L

ELS/55A1

1/ PT '\

1~15~

PSV5170

FOO~ 1\1------1~3/~8-" ____ ~,=L-'-{0~150 , I J ••318"

PT PT5153

~ L/pcv5150 -~ HV5153

+----::-~_//"'----HI~/1 -:...::___,1 ;-;:-3;.../ 4;..."_ ... ~~/~4·_· ________ _,,, ¥4' ~

• ELS/54A1 • I

3/4"

--7<

F 0 51,~5-J2 ,______.

/TE"'\ ~H 1 L 3/4" -

~43~

TE4430

TE

TW

TW4430

SEE --

F05154 ___,L----'

1 " ~~'

C3 ) L06

SUCTION PAGE 5, DETAIL DISCHARGE ® --

ELS/53A1

I/ PS "'\ HV5500 HV5502

ELS/53B1 1/ HH L--{::92:]-_l_ {.:::*::}--

83 )V2

1" ll"

1" ..:

1" J~·

F05170

LJ

....__L-----'

1" ~It:

LUBE OIL DRAIN

1/2" u 1/2"

1\(140].,

PS4401

VG It PT H

1~43~

1/2" , .. ~~ r1/2"

ELS/55C1

IIPm" H

~~10~ ~L

+-----16 PDT5100

LO HI

ELS/56B1

I/ FT"'\

l{i10_§-

j(0-FT5108

ELS/53B1

I/ PT"

~~41_'/ ~L

PT PT 4410

PS

L/"'\~ ___ __, .... _~ 1 L72'

ELS/53C1

/poT" /\. ~40_9t ~

c__ __ -16POT4400

HI LO

ELS/56C1

1/ FT"'\

(\ l{i10);

1/2' 1/2" 1/2" 1 FT5109

FO

2

PCV5100

~----.. ~--~~-~·----J/''------------~~~-----------------~~~ • • •

LUBE OIL DRAIN

F5108

LJ

3 4

PT PT4430

1/2" ~

F5109

LUBE OIL DRAIN u

5

,, --

ELS/55A1

1/pT\ ~H

1~17~

2" ~., M FLAME ARRESTOR IS DESIGNED FOR VERTICAL INSTALLATION.

~RESERVOIR MOUNTED IN LOW POINT OF SECONDARY SEAL VENT LINE. VENT LINE TO HAVE NO LIQUID

/\_ TRAPS OR LOW POINTS.

~DRAIN TO A SAFE LOCATION.

(~)''"'" ~VENT LINE TO HAVE NO LIQUID TRAPS OR LOW POINTS.

~NOT USED

~ HV5101 TO REMAIN OPEN UNLESS ALL LUBE OIL PUMPS

... •

VENT LINE TO LUBE OIL TANK TOP

B2 ) V7

2" Jl'

ELS/56B1 /FT\ HH

{i17j;

FT;6-175

FT 1" .•. /\.

/ R5175 ~

~G5175 HV511-75---,

~ l ~

&~ ) (I)

F4440 COMPRESSOR SUCTION STRAINER

COMPRESSOR MAXIMUM 2250 PSIG 115513.2 KPAGI DISCHARGE RATING AT 300F 1177CI

=----c-,----=---=--1 COMPRESSOR MAXIMUM 2250 PSIG 115513.2 KPAGI SUCTION RATING AT 300F 1177CI SEAL SYSTEM COMPONENT /PIPING !500 PSIG 1103,..,4"'2,--,--,K""PA-:cG;::-:1---I MAXIMUM DISCHARGE PRE~SURE AT 250F 1121CI

~,--,-:-;::--:c;::-:---l SEAL SYSTEM COMPONENT /PIPING 1500 PSIG 110342 KPAGJ MAXIMUM SUCTION PRESSURE AT 250F 1121CJ

----------'

ARE SECURED AND COMPRESSOR IS ISOLATED FROM ANY GAS SOURCE !INCLUDING DRY SEAL VENT LINES!.

ROCESS TAPS FOR COMPRESSOR SUCTION AND ISCHARGE PRESSURE TO BE APPROXIMATELY 5 PIPE

DIAMETERS +/- I FOOT UP AND DOWNSTREAM OF COMPRESSOR, IN STRAIGHT SECTIONS AND INSIDE OF STRAINERS, CHECK VALVES, ETC. SEE PIL 140 FOR COMPLETE REQUIREMENTS.

~POT4400 IS MOUNTED ON COMPRESSOR ABOVE SUCTION PORT. TUBING SHOULD HAVE A CONTINUOUS DOWNWARD SLOPE TO THE SUCTION PORT AND INLET STATOR PRESSURE PORT.

~COMPRESSOR MAXIMUM RATE: 290 PSIG/MIN

~NOT USED

DEPRESSURIZATION

~OVER PRESSURE PROTECTION PROVIDED BY OTHERS •

~TEMPORARY TYPE CONE STRAINERS !MINIMUM 150/. EQUIVALENT PIPE AREAIARE RECOMMENDED TO BE INSTALLED ON ANY NEW COMPRESSOR INSTALLATION. IF THE INCOMING LINES CANNOT BE AOEQUATEL Y CLEANED PRIOR TO INSTALLATION A 40X40 MESH MAY BE INSTALLED ON THE TEMPORARY STRAINER. THE MESH MUST BE REMOVED AFTER ONE MONTH OF OPERATION AND THE TEMPORARY STRAINER MUST BE REMOVED AFTER THREE MONTHS OF OPERATION. FAILURE TO DO SO MAY RESULT IN DEGRADATION OF THE STRAINER AND CONSEQUENTIAL DAMAGE TO THE COMPRESSOR.

~NOT USED

CUSTOMER


LSD" 11-02-039-08 W5M WBS" 01-00348.01

DRAWING TITLE


DRY SEAL SYSTEM - HP


DRAWING NO.

3P861-149446 DWG D REV

SHEET

SHT D REV

g OF 1 g

6 'THIS COPYRIGHTED WORK AND THE INFORMATION HEREIN IS PROPRIETARY TO CATERPILLAR INC, SOLAR TURBINES INCORPORATED AND/OR SUBSIDIARIES OF EITHER. WITHOUT EXPRESS WRITTEN PERMISSION FROM CATERPILLAR INC. OR SOLAR TURBINES INCORPORATED, ANY COPYING, DISCLOSURE, OR USE EXCEPT THAT FOR WHICH IT IS LOANED, IS PROHIBITED."

A

B

c

D

z 0 > w 0

A

B

c

0

1

Cl ) COl

Cl > C02 I

ENCLOSURE INLET

TURBINE AIR INLET

~

~0

<Iu

N -o <Iu

) (

+

+

2

3/4" • ~ l/2" ... N6601

N6606

,' -... /N'

L .. -~·

N6602

N6608

N6603

ELS/60A2

/DTG\ ~H ~56J;

8 DTG6561

3 4

TO FlR~ DAMPERS ELS/60C3

/DTG\ ~H 657J;

ELS/59Cl

lips\

1~61g_, -B ecccw

~

~ """"

ELS/61A3

/cnF' ELS/61A2

liDT~ ELS/61C3

1/DT~ ELS/61C2

"DTF\

DTF6510 DTF6511 DTF6512 DTF6513

ELS/58A2 /Ts\ HH

ELS/5BA2 I/ 'HH

TS '

1~54y

ELS/58B2 / TS \ HH

~59

c~) G 010 TS6540 TS6541 TS6542

ELS/61B2

"CnF'

DTF6514

ELS/5BB2 / TS \ HH

{?_54}

010 TS6543

•

I

ELS/61B3

liDT~

DTF 6515

(. 8 8 8 8 (. r~~----~--~----~~----/\~SY66~---------------------------------------------l ...

ELS/63Bl

/zso' ~61y

ELS/63Al

1/zsc' 1~61y

ELS/6301

1/zso' 1~62J;

ELS/63Cl

zsc ~62y

~~~~----~~~~-------------------~~~--, ~ ~

ZS06611 ZSC6611

zso zsc

L---~~~----~

HV6611

-

CV6611 r

ZS06621 ZSC662

zso zsc

L-----lv-~--J HV6621

CV6612

PRIMARY RELEASE SYSTEM

ELS/63Al ELS/62AI

1/ps' ~ 1'-661y ~

~ SV6611 ~ 1--------{\:) --ctr-

PS6611 A ~ \ FC

>cr <( 2 cr Q_

R6611

FIRE SYSTEM MODULE REFERENCE MECHANICAL INTERFACE DRAWING

2

et: Q_

A I

PCV6612 FC

I

~ ......... R6612

3

ELS/63Cl

lips\

PCV66(-~ 81~62y S6621

~ s

(~ A,------+

~ FC

--0 w z w f-X w

R6621

4

N -0 w z w f-X w

PCV6622 FC

R6622

5

5

ELS/60A3

li[nG\ ~H 1~58J;

DTG6581

6

6

7 8


+ ENCLOSURE EXHAUST

+ TURBINE AIR EXHAUST

CUSTOMER


LSD" 11-02-039-08 W5M WBS" 01-00348.01

DRAWING TITLE


FIRE AND CAS SYSTEM



DRAWING NO.

3P861-149446 SHEET 10 OF 19

'THIS COPYRIGHTED WORK AND THE INFORMATION HEREIN IS PROPRIETARY TO CATERPILLAR INC .. SOLAR TURBINES INCORPORATED AND/OR SUBSIDIARIES OF EITHER. WITHOUT EXPRESS WRITTEN PERMISSION FROM CATERPILLAR INC. OR SOLAR TURBINES INCORPORATED, ANY COPYING, DISCLOSURE. OR USE EXCEPT THAT FOR WHICH IT IS LOANED. IS PROHIBITED."

A

B

c

D

z 0 > w 0

A

B

c

0

1

* ASY6210

~-ELSfGlAl-1 I ~~'PDs' H I

: ~21_s; :

ELS/69C1 TY62101/ TY\

~21~

1\ ELS/6701 ~ 1/TE\ ~H

2 3

~21_9; Q ELS/66A1

~E TE6210 ~ fPDs\

~ \ ~21!JtL .-----------------'*'------(~ PDS6211

LO~H1

1 ~101 ENCLOSURE! 1

INLET I I -6

~ I I I I + I I I I I I I

TURBINE AIR

INLET

+

i F6210 I

D6210

L ______ J

NR6210 ELS/69AI

1/TY\

~21_Y

~ f--------{0 TY6211

0 6211 f------------1 v

i FROM

ENCLOSED BUILDING

~ "" ASY6310 ,-----=-----------, I ELS/71A1 I

I ffpoi" ~H I

I ~31~ I

I (~PO I : KAoT6310 :

I I

I I I I

I I :

I F5310 I l __________________ l

2

M6211

~

NR5300

I FD6210

ELS/65A1

vPDT'

~1s_s; ~L

c_ __ -j]E-----{~ POT6180

LO~HI

3

ELS/65C1 I/ '\ HH 1/ TE H

1\.6110

0"'"'

4

ELS/6483

/EL\

EL6130

4

EL6131

ELS/6485

1/ EL '\

EL6132

5

5

6

I FD6240 NR6240

ELSI70C1 1/TY\

TY6242 ~5

d0r------

I 05242

ELS/70A1

/TY\

l.t24_9;

7

ENCLOSURE EXHAUST

+

8


£ATMOSPHERIC VENT. DO NOT PLUG.

~ 06240 ~ f-----{G """ c v 52 4 0 1-------1

~ v......-......-......-__...-

6

TO ENCLOSED BUILDING

TURBINE AIR

EXHAUST

+

CUSTOMER


LSD" 11-02-039-08 W5M W8S" 01-00348.01

DRAWING TITLE


ENCLOSURE SYSTEM



DRAWING NO.

3P861-149446 SHEET 11 OF 19

'THIS COPYRIGHTED WORK AND THE INFORMATION HEREIN IS PROPRIETARY TO CATERPILLAR INC .. SOLAR TURBINES INCORPORATED AND/OR SUBSIDIARIES OF EITHER. WITHOUT EXPRESS WRITTEN PERMISSION FROM CATERPILLAR INC. OR SOLAR TURBINES INCORPORATED, ANY COPYING, DISCLOSURE. OR USE EXCEPT THAT FOR WHICH IT IS LOANED, IS PROHIBITED."

A

B

c

D

z 0 > w 0

1 2 3 4 5 6 7 8

PAGE REVISION DESCRIPTION 1 B LEGEND AND GENERAL NOTES 2 D START SYSTEM

A 3 D TURBINE SYSTEM PAGE 1 A

4 D TURBINE SYSTEM PAGE 2 5 D COMPRESSOR DEVICES 5 D GAS FUEL SYSTEM 7 D LUBE SYSTEM PAGE 1 8 D LUBE SYSTEM PAGE 2 9 D DRY SEAL SYSTEM - HP 10 D FIRE AND GAS SYSTEM 11 D ENCLOSURE SYSTEM

B B

c c

0 D


DRAWING NO. DWG D ISHT D z REV REV 0

Table of Contents (PI D) 3P861-149446 SHEET > 12 OF 19 w

0 'THIS COPYRIGHTED WORK AND THE INFORMATION HEREIN IS PROPRIETARY TO CATERPILLAR INC .. SOLAR TURBINES

1 2 3 4 5 6 INCORPORATED AND/OR SUBSIDIARIES OF EITHER. WITHOUT EXPRESS WRITTEN PERMISSION FROM CATERPILLAR INC. OR SOLAR TURBINES INCORPORATED, ANY COPYING, DISCLOSURE, OR USE EXCEPT THAT FOR WHICH IT IS LOANED, IS PROHIBITED."

1 2 3 4 5 6 7 8

DEVICE 10 PAGE CUSTOMER COMPONENT COMPONENT DESCRIPTION SYSTEM FUNCTION COMPONENT SETTING SYSTEM NORMAL OR OPERATING VALUE NOTES ZONE TAG PART NUMBER

ASY1520 3.C6 303504-100 ASSEMBLY BURNER ACOUSTIC MONITOR

ASY2100 6.Al PK-02-5320 1056369-3P861 ASSEMBLY CLEAN/DRAIN GAS SUPPLY 5

ASY2124 6.C4 1052883-100 ASSEMBLY GAS FUEL SECONDARY SHUTOFF VALVE

ASY3200 7 .B3 1024 780-137 ASSEMBLY LUBE PRESSURE/TEMPERATURE CONTROL

ASY3240 7.A4 1054 721-102 ASSEMBLY MAIN LUBE FILTER

ASY5210 !LA 1 SEE MID ASSEMBLY ENCLOSURE INLET FILTER ASSEMBLY 5

ASY5310 lLC 1 SEE MID ASSEMBLY TURBINE AIR INLET FILTER ASSEMBLY 5 A ASY6500 3.Al SEE MID ASSEMBLY PCD AIR TREATMENT 5 A

ASY6600 10.C2 PK-02-5280 1086509-100 ASSEMBLY FIRE SUPPRESSION SYSTEM C02 CABINET 5

AV1710 3.D2 XV-02-5323 185548-300 AUTOMATIC VALVE ON-LINE CRANK CLEANING SHUTOFF VALVE cv - 38 MAX PRESSURE= 2200 PSIG (15159 KPAGl, -

AV1720 3.D2 XV-02-5324 185648-300 AUTOMATIC VALVE ON-CRANK CRANK CLEANING SHUTOFF VALVE cv - 38 MAX PRESSURE= 2200 PSIG (15169 KPAGl, -

AV2120 6.C2 XV-02-5320 186232-2900 AUTOMATIC VALVE PRIMARY GAS FUEL SHUTOFF cv - 130 MAX PRESSURE= 675 PSIG (4556 KPAGl -

NORMALLY CLOSED

AV2121 6.C3 XV-02-5320A 190537-303 AUTOMATIC VALVE GAS VENT cv - 0.9 MAX DESIGN PRESS= 1500 PSIG 00340 KPAGl -MAX ACTUATOR PRESSURE: 200 PSIC 0380 KPAGl NORMALLY CLOSED

AV2124 6.C4 XV-02-5320B PART OF ASY2124 AUTOMATIC VALVE SECONDARY GAS FUEL SHUTOFF cv - 430 MAX PRESSURE= 700 PSIC (4827 KPAGl -

NORMALLY CLOSED

AV2143 6.C6 XV-02-5320C 186232-1300 AUTOMATIC VALVE SPAC GAS FUEL SHUTOFF cv - 130 MAX PRESSURE= 675 PSIG (4556 KPACl -

NORMALLY OPEN

AV2150 6.D4 XV-02-5320D 190537-303 AUTOMATIC VALVE GAS TORCH SHUTOFF cv - 0.9 MAX DESIGN PRESS= 1500 PSIC 00340 KPAGl -MAX ACTUATOR PRESSURE: 200 PSIC 0380 KPAGl NORMALLY CLOSED

AV5120 9.A2 XV-02-5410 1099332-100 AUTOMATIC VALVE SEAL GAS SUPPLY, HP COMPRESSOR cv = 32 NORMALLY CLOSED

CV1110 3.D2 915498Cl CHECK VALVE AIR INLET DUCT DRAIN 0.25 PSIC (1.7 KPAGl CRACKING

CV2150 6.D4 1030794-12 CHECK VALVE GAS TORCH 2 PSIC 03.9 KPACl CRACKING

CV3150 7.C4 1059701-5 CHECK VALVE PRE/POST LUBE OIL PUMP 0.5 PSIC (3,45 KPAGl CRACKING PRESSURE

CV3170 7 .C6 1059701-10 CHECK VALVE ISOLATE BACKUP PUMP 0.5 PSID (3,45 KPADl CRACKING PRESSURE

CV3200 7.B4 1059701-2 CHECK VALVE MAIN LUBE SUPPLY 0.5 PSIG (3,45 KPAGl CRACKING PRESSURE

B CV3320 8.A2 1059700-1 CHECK VALVE BACKUP PUMP FLOW CONTROL 0.5 PSIC (3,45 KPAGl CRACKING PRESSURE

B CV3340 8.A3 1059700-5 CHECK VALVE BACKUP LUBE OIL SUPPLY ENGINE BEARING 0.5 PSIC (3,45 KPAGl CRACKING PRESSURE

CV5100 9.D2 1030794-12 CHECK VALVE BUFFER AIR, HP COMPRESSOR cv - L5, 2 PSI (14 KPAl CRACKING -

CV5120 9.A3 190303-15 CHECK VALVE EXTERNAL SEAL GAS SUPPLY, HP COMPRESSOR CV = 13.0, 1 PSI (5.89 KPAl CRACKING

CV5240 1LB5 SEE MID CHECK VALVE BACK DRAFT DAMPER, 5 ENCLOSURE EXHAUST

CV5611 10.Dl PART OF ASY6600 CHECK VALVE PRIMARY RELEASE SYSTEM

CV6612 10.D2 PART OF ASY6600 CHECK VALVE EXTENDED RELEASE SYSTEM

CYL3220 7.A2 PART OF HE3220 CYLNIDER, HYDRUALIC HYDRAULIC ACTUATORS, HYDRAULIC ACTUATORS: 35-250 PSIC, 3-5 SCFM PULSE 5 AIR INTAKE/DISCHARGE SHUTTERS

D5210 !LA 1 SEE MID VENTILATION DAMPER ENCLOSURE DAMPER, OUTSIDE AIR FAIL MODE L (QPENl 5

05211 lLB 1 SEE MID VENTILATION DAMPER ENCLOSURE DAMPER, BUILDING AIR FAIL MODE R (CLOSEDl 5

D5240 1LB5 SEE MID VENTILATION DAMPER ENCLOSURE EXHAUST VENTILATION DAMPER FAIL MODE R (CLOSEDl

D5242 1LA7 SEE MID VENTILATION DAMPER ENCLOSURE EXHAUST VENTILATION DAMPER FAIL MODE L (QPENl 5

DTF5510 10.B3 AIT -02-5200C 1078595-27 FIRE DETECTOR MULTI-SPECTRUM WIREl OPEN: 1,2,3,4,6,8 CLOSED: 5, 7

DTF5511 10.B4 AIT -02-52000 1078595-27 FIRE DETECTOR MULTI-SPECTRUM WIREl OPEN: 2,3,4,5,8 CLOSED: 1,5, 7

DTF5512 10.B4 AIT -02-5200E 1078595-27 FIRE DETECTOR MULTI -SPECTRUM (FJREl OPEN: 1,3,4,6,8 CLOSED: 2,5, 7

DTF5513 10.B4 AIT -02-5200F 1078595-27 FIRE DETECTOR MULTI -SPECTRUM WIREl OPEN: 3,4,5,8 CLOSED: 1,2,5, 7

DTF5514 10.B5 AIT -02-5200G 1078595-27 FIRE DETECTOR MULTI -SPECTRUM WIREl OPEN: 1,2,4,6,8

c CLOSED: 3,5,7 c DTF5515 10.B5 AIT -02-5200H 1078595-27 FIRE DETECTOR MULTI -SPECTRUM WIREl OPEN: 2,4,5,8

CLOSED: 1,3,5, 7

DTG6561 10.B2 AIT -02-5200 1078325-7 GAS DETECTOR ENCLOSURE AIR INLET OPEN: 4,5,8 CLOSED: 1,2,3,5,7

DTG5571 10.A4 AIT -02-5200A 1078325-7 GAS DETECTOR FUEL MODULE AREA OPEN: 1,2,3,4,8 CLOSED: 5,5, 7

DTG5581 10.B6 AIT -02-5200B 1078325-7 GAS DETECTOR ENCLOSURE AIR EXHAUST OPEN: 1,2,4,5,8 CLOSED: 3,6, 7

EL5130 ll.A4 1069407-1 LIGHT SOURCE AC FLUORESCENT 120-277 VAC, 50/60 HZ, 54 WATTS

EL6131 ll.A4 1069407-1 LICHT SOURCE AC FLUORESCENT 120-277 VAC, 50/60 HZ, 54 WATTS

EL5132 ll.A5 1069407-1 LIGHT SOURCE AC FLUORESCENT 120-277 VAC, 50/60 HZ, 64 WATTS

Fl710 3.Dl FL-02-5323 120848-4 FILTER ON-LINE ENGINE CLEANING SUPPLY 40 MESH

F1711 3.D2 FL-02-5327 PART OF ENGINE FILTER PROTECT SPRAY RING (QN-LINEl 100 MESH

F1720 3.Dl FL-02-5324 120848-4 FILTER ON-CRANK ENGINE CLEANING SUPPLY 40 MESH

Fl721 3.D2 FL-02-5328 PART OF ENGINE FILTER PROTECT SPRAY RING (QN-CRANKl 100 MESH

F2100 5.A2 FL-02-5321 PART OF ASY2100 FILTER SEPARATOR REMOVE LIQUIDS/DIRT 10 MICRON NOMINAL 5

F2106 6.A6 FL-02-5322 1050817-3P861 FILTER FILTER CAS FUEL 10 MICRON ABSOLUTE MAX DESIGN PRESS= 690 PSIC AT 160F (4758 KPAC AT 71Cl 5 ELEMENT CHANGE OUT: 14 PSID (96 KPADl ELEMENT COLLAPSE: 90 PSID (521 KPAOl

0 D



Schemat1c F unct1onal Ccmponent L1st 3P861-149446 SHEET > 13 OF 19 w



1 2 3 4 5 6 7 8

DEVICE ID PAGE CUSTOMER COMPONENT COMPONENT DESCRIPTION SYSTEM FUNCTION COMPONENT SETTING SYSTEM NORMAL OR OPERATING VALUE NOTES ZONE TAG PART NUMBER

F3100 7.C1 FL-02-5333 700872C1 FILTER PDT3100 REFERENCE PRESSURE 40 MICRON NOMINAL

F3101 7.D4 FL-02-5329 190187-300 FILTER LUBE OIL TANK FILL 20 MESH

F3110 7.D2 FL-02-5346 REFERENCE FILTER MAIN PUMP SUCTION 6 MESH

F3150 7 .D4 FL-02-5347 190098-3 FILTER PRE/POST PUMP SUCTION 6 MESH

F3170 7.D5 FL-02-5348 1055240-2300 FILTER BACKUP LUBE OIL PUMP SUCTION 5 MESH

F3171 7.C5 FL-02-5349 185278-400 FILTER POST LUBE BACKUP 10 MICRON, EFFICIENCY 98.7%

F3240 7 .B4 FL-02-5335 PART OF ASY3240 FILTER MAIN LUBE FILTER 10 MICRON. EFFICIENCY 99.9% A F3250 7 .B4 FL-02-5335 PART OF ASY3240 FILTER MAIN LUBE FILTER 10 MICRON. EFFICIENCY 99.9% A

F3270 7.A1 FL-02-5334 185145-11 FILTER SEPARATOR TANK VENT 120 SCFM, 95% EFFICIENT 5

F3310 8.B2 FL -02-5312 1025189-5 FILTER STARTUP, ACCESSORY GEARBOX 70 MICRON

F3320 8.B2 FL-02-5313 1025189-4 FILTER STARTUP, GAS PRODUCER 70 MICRON NOMINAL

F3340 8.B3 FL -02-5314 1025189-5 FILTER STARTUP, "4 AND "5 ENGINE BEARING 70 MICRON

F3410 8.A4 118502-23 FILTER STARTUP, HP COMPRESSOR SUCTION JOURNAL BEARING 70 MICRON NOMINAL

F3420 8.A5 FL-02-5412 1025189-5 FILTER STARTUP, HP COMPRESSOR SUCTION THRUST BEARING 70 MICRON NOMINAL

F3430 8.A5 FL -02-5413 118502-23 FILTER STARTUP, HP COMPRESSOR DISCHARGE 70 MICRON NOMINAL

F4440 9.D5 CUSTOMER SUPPLIED FILTER HP COMPRESSOR SUCTION STRAINER

F5104 9.D1 FL-02-5420 170595-100 FILTER BUFFER AIR, HP COMPRESSOR 0.1 MICRON, BETA = 14

F5105 9.D2 FL -02-5421 948282C1 FILTER BUFFER AIR, HP COMPRESSOR

F5108 9.D3 FL-02-5422 948282C1 FILTER BUFFER AIR, SUCTION END, HP COMPRESSOR

F5109 9.D5 FL-02-5423 948282C1 FILTER BUFFER AIR, DISCHARGE END, HP COMPRESSOR

F5130 9.B3 FL-02-5425 190247-101 FILTER SEAL GAS, HP COMPRESSOR 0.1 MICRON, BETA - 14 -

F5140 9.B4 FL-02-5426 190247-101 FILTER SEAL GAS, HP COMPRESSOR 0.1 MICRON, BETA - 14 -

F5210 1l.A 1 FL-02-5290 SEE MID FILTER ENCLOSURE INLET FILTER 5

F6310 1l.C 1 FL -02-5215 PART OF ASY5310 FILTER TURBINE AIR INLET 5

F6400 6.D1 FL -02-5318 1089034-1 FILTER FILTER PACKAGE AIR SUPPLY 3 MICRON ABSOLUTE 200 PSIG 0380 KPAGl MAX OPERATING PRESSURE

F5530 3.A1 FL-02-5225 PART OF ASY5500 FILTER SEPARATOR PCD AIR FOR FILTER CLEANING (4 STAGESl 5

FCE1420 3.A5 FCV-02-5310B PART OF ENGINE FLOW CONTROL, ELECTRIC COMPRESSOR BLEED AIR, MOTOR DRIVEN (BVJ 120 VDC, 0.5 A CONTINUOUS, 5 A PEAK FOR 120 MILLISECONDS

B 20 A TRANSIENT FOR 50 MILLISECONDS B FCE1440 3.B3 FCV-02-5310 PART OF ENGINE FLOW CONTROL, ELECTRIC COMPRESSOR VARIABLE GUIDE VANE 120 VDC, 0.5 A CONTINUOUS,

5 A PEAK FOR 120 MILLISECONDS 20 A TRANSIENT FOR 60 MILLISECONDS

FCE2130 5.C5 FCV-02-5320 1088209-900 FLOW CONTROL, ELECTRIC MAIN ELECTRIC GAS FUEL 120 VDC, 0.5 A CONTINUOUS, 5 A PEAK FOR 120 MILLISECONDS 20 A TRANSIENT FOR 50 MILLISECONDS

FCE2140 5.C5 FCV-02-5320A 1042018-3300 FLOW CONTROL, ELECTRIC ELECTRIC PILOT GAS FUEL 120 VDC, 0.5 A CONTINUOUS, 5 A PEAK FOR 120 MILLISECONDS 20 A TRANSIENT FOR 50 MILLISECONDS

FD6210 11.A3 SEE MID FIRE DAMPER ENCLOSURE INLET FIRE DAMPER 5

FD5240 11.A6 SEE MID FIRE DAMPER ENCLOSURE EXHAUST FIRE DAMPER 5

FE2108 5.A5 FE-02-5322 1055717-100 FLOW ELEMENT GAS FUEL FLOW MEASUREMENT 5 F01120 3.A4 F0-02-5310C 124427-4401 FLOW ORIFICE PCD CONDENSATE DRAIN 0.06 INCH (1.5 MMl DIAMETER

F01500 3.A4 F0-02-5310D 908501C1 FLOW ORIFICE FLAMEOUT TIME DELAY 8800 LOHMS, 0.02 INCH (0.51 MMl

F01710 3.D2 F0-02-5327 PART OF ENGINE FLOW ORIFICE CLEANING FLUID INJECTION (QN-LINEl

F01720 3.D2 F0-02-5328 PART OF ENGINE FLOW ORIFICE CLEANING FLUID INJECTION (ON-CRANK)

F02121 6.C3 F0-02-5320B 124427-4401 FLOW ORIFICE RESTRICT VENT BLEED 0.05CJ INCH (1.5 MMl, DIAMETER ORIFICE

F03110 7.01 F0-02-5337 124427-5000 FLOW ORIFICE P3110 PRIMING ASSIST, AIR VENT 0.157 INCH (4 MMl DIAMETER ORIFICE

F03111 7.D2 F0-02-5337A 124427-6800 FLOW ORIFICE MAIN LUBE OIL PUMP WETTING 0.05CJ INCH (1.5 MMl DIAMETER ORIFICE

F03170 7 .C5 F0-02-5340 124427-4401 FLOW ORIFICE P3170 THROTTLING 0.06 INCH (1.5 MMl DIAMETER ORIFICE

F03220 7.B2 F0-02-5342 PART OF HE3220 FLOW ORIFICE OIL COOLER VENT 0.125 INCH (3.2 MMl DIAMETER 5

F03425 8.A4 F0-02-5335 131217-23 FLOW ORIFICE COMPRESSOR LUBE OIL 0.75 INCH DIAMETER ORIFICE c F05152 CJ.C4 F0-02-5410D 182627-2125 FLOW ORIFICE LIMIT SEAL GAS FLOW, SUCTION END 0.125 INCH (3.2 MMl DIAMETER c

HP COMPRESSOR

F05154 CJ.C5 F0-02-5410E 182627-2125 FLOW ORIFICE LIMIT SEAL GAS FLOW, DISCHARGE END 0.125 INCH (3.2 MMl DIAMETER HP COMPRESSOR

F05160 CJ.B3 F0-02-5410F 182527-1125 FLOW ORIFICE MEASURE PRIMARY SEAL LEAKAGE, 0.125 INCH (3.2 MMl DIAMETER SUCTION END HP COMPRESSOR

F05170 CJ.B5 F0-02-5410G 182527-1125 FLOW ORIFICE MEASURE PRIMARY SEAL LEAKAGE, 0.125 INCH (3.2 MMl DIAMETER DISCHARGE END HP COMPRESSOR

F05530 3.B4 F0-02-5310A 124427-4 700 FLOW ORIFICE LIMIT PCD TO AIR INLET FILTER 0.22 INCH (5.5CJ MMl DIAMETER

FT2108 6.A5 FT-02-5322 PART OF FE2108 FLOW TRANSMITTER MONITOR GAS FUEL FLOW 4 - 20 MA= 0 - 12000 LB/H (0 - 5440 KG/H) 5

FT5108 9.D3 FT -02-5410 1083867-7 FLOW TRANSMITTER SEPARATION GAS FLOW (SUCTION) 4 - 20 MA - 0 - 20 SCFM (0.63 - 32.2 NM3/HRJ -

HP COMPRESSOR

FT5109 9.D5 FT -02-5410A 1083867-7 FLOW TRANSMITTER SEPARATION GAS FLOW (OJSCHARGEl 4 - 20 MA - 0 - 20 SCFM (0.53 - 32.2 NM3/HRJ -

HP COMPRESSOR

FT5155 9.B2 FT -02-5415 1083857-8 FLOW TRANSMITTER SECONDARY SEAL VENT FLOW (SUC T IONl HIGH SHUTDOWN: REFERENCE SOFTWARE FOR SET POINTS 4 - 20 MA - 0 - 40 SCFM (0 - 64.3 NM3/HRl -

HP COMPRESSOR

FT5175 9.C6 FT-02-5415 1083857-8 FLOW TRANSMITTER SECONDARY SEAL VENT FLOW (OJ SCHAR GEl HIGH SHUTDOWN: REFERENCE SOFTWARE FOR SET POINTS 4 - 20 MA - 0 - 40 SCFM (0 - 64.3 NM3/HRl -

HP COMPRESSOR

0 D




0 "THIS COPYRIGHTED WORK AND THE INFORMATION HEREIN IS PROPRIETARY TO CATERPILLAR INC .. SOLAR TURBINES


1 2 3 4 5 6 7 8


H3103 7 .D4 EH-02-5331 1089956-150 HEATER LUBE OIL TANK HEATER SET PROCESS THERMOSTAT TO 125F 152CI 575 VAC, 3-PH, 25 HP ()9 KWI HIGH LIMIT THERMOSTAT INON-ADJUSTABLEI

HE3220 7 .B2 E-02-5342 3P861-154765 HEAT EXCHANGER LUBE OIL COOLER 5 HE6530 3.A2 HE-02-5226 SEE MID HEAT EXCHANGER PCD COOLER HV 1110 3.C2 186426-5 HAND VALVE BLOCK AND BLEED, PDT1110 BLOCK OPEN, BLEED CLOSED HV1521 3.C5 PART OF ASY1520 HAND VALVE BAM ISOLATION AIR NORMALLY OPEN HV1522 3.C6 PART OF ASY1520 HAND VALVE BAM: PCD DRAIN NORMALLY CLOSED

A HV1721 3.D2 1012230-2 HAND VALVE AUXILIARY WATER WASH PORT MAX DESIGN 800 PSIG 15515 KPAGI A

HV2100 6.A2 PART OF ASY2100 HAND VALVE BLOCK AND BLEED BLOCK OPEN, BLEED CLOSED 5 HV2101 6.A1 PART OF ASY2100 HAND VALVE VENT, GAS FUEL FILTER/COALESCER NORMALLY CLOSED 5 HV2102 6.B2 PART OF ASY2100 HAND VALVE INLET N2 PURGE, GAS FUEL NORMALLY CLOSED 5 HV2103 6.A2 PART OF ASY2100 HAND VALVE DRAIN, UPPER SUMP, GAS FUEL NORMALLY CLOSED 5 HV2104 6.B2 PART OF ASY2100 HAND VALVE DRAIN, LOWER SUMP, GAS FUEL NORMALLY CLOSED 5 HV3100 7.D1 SUPPLIED BY OTHERS HAND VALVE LUBE OIL TANK DRAIN NORMALLY CLOSED HV3150 7.C4 186488-2 HAND VALVE INSTRUMENTATION ISOLATION, AC PRE/POST BLOCK OPEN, BLEED CLOSED HV3170 7 .C6 186488-2 HAND VALVE INSTRUMENTATION ISOLATION, POST LUBE BACKUP BLOCK OPEN, BLEED CLOSED HV3240 7.A4 186426-5 HAND VALVE TRANSMITTER BLOCK AND BLEED BLOCK OPEN, BALANCE CLOSED HV3242 7.B4 PART OF ASY3240 HAND VALVE FILTER CROSSOVER NORMALLY CLOSED HV3245 7 .A5 PART OF ASY3240 HAND VALVE VENT, OIL FILTER NORMALLY CLOSED HV3246 7.B4 PART OF ASY3240 HAND VALVE FILTER DRAIN, DIRTY SIDE NORMALLY CLOSED HV3250 7.B4 PART OF ASY3240 TRANSFER VALVE MAIN LUBE FILTER HV3255 7 .B5 PART OF ASY3240 HAND VALVE VENT, OIL FILTER NORMALLY CLOSED HV3256 7.B4 PART OF ASY3240 HAND VALVE FILTER DRAIN, DIRTY SIDE NORMALLY CLOSED HV5101 9.D1 1093582-2 HAND VALVE BUFFER AIR SHUTOFF, HP COMPRESSOR NORMALLY OPEN HV5104 9.D1 186426-5 HAND VALVE BLOCK AND BLEED, PDT5104 BLOCK OPEN, BLEED CLOSED HV5130 9.A4 186426-5 HAND VALVE BLOCK AND BLEED, PDT5130 BLOCK OPEN, BLEED CLOSED HV5131 9.B3 120240-10 HAND VALVE SEAL GAS FILTER ISOLATION cv - 7.35 -

HP COMPRESSOR HV5132 9.B4 120240-10 HAND VALVE SEAL GAS FILTER ISOLATION cv - 7.35 B - B

HP COMPRESSOR HV5134 9.B4 1098092 HAND VALVE SEAL GAS FILTER DRAIN, HP COMPRESSOR NORMALLY CLOSED HV5141 9.B4 120240-10 HAND VALVE SEAL GAS FILTER ISOLATION cv - 7.35 -

HP COMPRESSOR HV5142 9.B4 120240-10 HAND VALVE SEAL GAS FILTER ISOLATION cv - 7.35 -

HP COMPRESSOR HV5144 9.B4 1098092 HAND VALVE SEAL GAS FILTER DRAIN, HP COMPRESSOR NORMALLY CLOSED HV5153 9.B5 186488-2 HAND VALVE INSTRUMENTATION ISOLATION, HP COMPRESSOR BLOCK OPEN, BLEED CLOSED HV5165 9.C3 915370C1 HAND VALVE SECONDARY VENT DRAIN, HP COMPRESSOR NORMALLY CLOSED HV5175 9.C7 915370C1 HAND VALVE SECONDARY VENT DRAIN, HP COMPRESSOR NORMALLY CLOSED HV5500 9.C4 186071-6 HAND VALVE COMPRESSOR CASE DRAIN, BLOCK NORMALLY CLOSED HV5502 9.C4 186071-6 HAND VALVE COMPRESSOR CASE DRAIN, BLOCK NORMALLY CLOSED HV6400 6.D2 190392-3 HAND VALVE BLOCK AND BLEED, PT6400 BLOCK OPEN, BLEED CLOSED HV6530 3.A2 PART OF ASY6500 HAND VALVE PCD AIR FOR FILTER CLEANING NORMALLY OPEN 5 HV6531 3.A3 120010-18 HAND VALVE PCD AIR FOR FILTER CLEANING NORMALLY OPEN HV6611 10.D1 PART OF ASY6600 HAND VALVE, LOCKABLE MANUAL LOCKOUT FOR PRIMARY RELEASE OF C02 HV6621 10.D1 PART OF ASY6600 HAND VALVE, LOCKABLE MANUAL LOCKOUT FOR EXTENDED RELEASE OF C02 Ll3100 7 .D3 LG-02-5330A 116091-11 LEVEL INDICATOR LUBE OIL TANK LEVEL WHITE= INITIAL FILL, GREEN= OPERATING RANGE,

YELLOW: ALARM ZONE, RED: ENGINE SHUTDOWN LS2101 6.B2 LSH-02-5321 PART OF ASY2100 LEVEL SWITCH GAS FUEL COALESCING 5

LIQUID LEVEL, UPPER SUMP

c LS2102 6.B2 LSH-02-5321A PART OF ASY2100 LEVEL SWITCH GAS FUEL COALESCING 5 c LIQUID LEVEL, LOWER SUMP L T3100 7.D3 LT-02-5330 1064829-4 LEVEL TRANSMITTER TANK OIL LEVEL LOW ALARM: 19 IN 148.3 CMI 4 - 20 MA = 8 - 22.9 IN 120.3 - 58.2 CMI,

LOW SHUTDOWN: 16 IN 140.6 CMI ABOVE TANK FLOOR AT FILL PORT HIGH ALARM: 22 IN 155.9 CMI

M1300 2.B5 GM-02-5311 1012991-40 MOTOR TURBINE DIRECT MOUNT AC START 380 VAC, 0-133 HZ, 3-PH, 75 HP 156 KWI RATED SPACE HEATER: 120 VAC, 50/60 HZ, 1-PH, 200 WATTS MAX 11Hl, 1H2 POWER LEADSI

M3150 7.D5 PM-02-5338 190464-3P861 MOTOR AC PRE/POST LUBE PUMP MOTOR COUPLING: 1060045-69, ADAPTOR: 1019138-1 575 VAC, 3-PH, 60 HZ, 10 HP 17.5KWI, 12.0 FLA, SPACE HEATER: 120 VAC, 1-PH, 60 HZ, 200 WATTS MAX

M3170 7.D6 PM-02-5340 1100969-1 MOTOR DC BACKUP LUBE PUMP MOTOR 120 VDC, L5 HP 11.1 KWI M3220 7 .B3 CFM-02-5343 PART OF HE3220 MOTOR LUBE OIL COOLER FAN 575 VAC, 3-PH, 60 HZ, 15 HP 01.2 KWI, 5

SPACE HEATER: 120 VAC, 1-PH, 60 HZ, 200 WATTS MAX M6211 11.A2 CFM-02-5293 1100613-3P861 MOTOR VENTILATION FAN 575 VAC, 3-PH, 60 HZ, 25 HP 118.64 KWI RATED,

SPACE HEATER: 120 VAC, 1-PH, 200 WATTS MAX N6601 10.A2 70-30739-1 NOZZLE FIRE EXTINGUISH SYSTEM N6602 10.A2 70-30739-1 NOZZLE FIRE EXTINGUISH SYSTEM N6603 10.A3 70-30739-1 NOZZLE FIRE EXTINGUISH SYSTEM N6606 10.A2 1083009 NOZZLE FIRE EXTINGUISH SYSTEM N6607 10.A2 1083009 NOZZLE FIRE EXTINGUISH SYSTEM N6608 10.A3 1083009 NOZZLE FIRE EXTINGUISH SYSTEM

0 D






1 2 3 4 5 6 7 8


NR6210 1l.A2 SL-02-5292 SEE MID NOISE REDUCER ENCLOSURE INLET SILENCER 5

NR6240 1l.A6 SL-02-5294 SEE MID NOISE REDUCER ENCLOSURE EXHAUST SILENCER 5

NR6300 1l.C2 SL-02-5220 SEE MID NOISE REDUCER TURBINE AIR INLET SILENCER 5

P3110 7 .D2 P-02-5337 1073753-5 PUMP MAIN LUBE OIL PUMP, ENGINE DRIVEN 393 GPM 0488 LPMl, 150 PSIG 0035 KPAGl, 2200 RPM

P3150 7.D4 P-02-5338 1063390-1 PUMP PRE/POST LUBE, AC MOTOR DRIVEN 129 GPM (488 LPMJ, 20 PSIG (138 KPAGJ, 3550 RPM

P3170 7.D6 P-02-5340 1066618-1 PUMP BACKUP LUBE, DC MOTOR DRIVEN 30 GPM (114 LPMl, 25 PSIG () 72 KPAGl, 1800 RPM

PCV1030 3.C6 PCV-02-5310C 1020281-100 PRESSURE CONTROL VALVE EXHAUST COLLECTOR DRAINAGE CLOSES AT 2-5 PSIG ()4-34 KPAGl INLET NORMALLY OPEN A PCV1031 3.C6 PCV-02-5310B 1020281-100 PRESSURE CONTROL VALVE EXHAUST COLLECTOR DRAINAGE CLOSES AT 2-5 PSIG (14-34 KPAGJ INLET NORMALLY OPEN A

PCV2151 6.C4 PCV-02-5320G 186273-42 PRESSURE CONTROL VALVE TORCH COARSE ADJUST REGULATOR 35 PSIG (241 KPAGl SET ADJUSTABLE RANGE= 25-50 PSIG 072-345 KPAGl

PCV2152 6.D4 PCV-02-5320H 186273-40 PRESSURE CONTROL VALVE TORCH FINE ADJUST REGULATOR 10 PSIG (69 KPAGJ SET ADJUSTABLE RANGE= 0-50 PSIG (0-345 KPAGJ

PCV3150 7 .C5 PCV-02-5338A 1038428-3 PRESSURE CONTROL VALVE PRE/POST LUBE OIL PRESSURE CONTROL 10 PSIG (69.0 KPAGJCRACKING

PCV3200 7.C3 PCV-02-5337 PART OF ASY3200 PRESSURE CONTROL VALVE MAIN LUBE PRESSURE CONTROL 50-60 PSIG (345-414 KPAGl 55 PSIG (379 KPAGl NOMINAL

PCV5100 9.D2 PCV-02-5410F 120759-4 PRESSURE CONTROL VALVE BUFFER AIR, HP COMPRESSOR

PCV5120 9.B2 PCV-02-5410 186273-1 PRESSURE CONTROL VALVE PILOT FOR SEAL GAS SHUTOFF VALVE, 95 PSIG (655 KPAGJ 95 TO 195 PSIG (555 TO 1344 KPAGJ HP COMPRESSOR

PCV5150 9.B4 PCV-02-5410G 120247-4 PRESSURE CONTROL VALVE SEAL GAS 20 PSID 038 KPADl HP COMPRESSOR

PCV6410 6.D2 PCV-02-5318A 185273-1 PRESSURE CONTROL VALVE PRESSURE CONTROL, PILOT AIR 90 +/- 5 PSIG (521 +/- 34.5 KPAGJ ADJUSTABLE RANGE= 75-200 PSIG (517-1380 KPAGJ

PCV6530 3.A2 PCV-02-5225 PART OF ASY6500 PRESSURE CONTROL VALVE PCD AIR TREATMENT 5

PCV6611 10.D3 PCV-02-5281 PART OF ASY6600 PRESSURE CONTROL VALVE MANUAL RELEASE OF PRIMARY "1

PCV5612 10.D3 PCV-02-5282 PART OF ASY6600 PRESSURE CONTROL VALVE MANUAL RELEASE OF PRIMARY "2

PCV5521 10.D4 PCV-02-5285 PART OF ASY5500 PRESSURE CONTROL VALVE MANUAL RELEASE OF EXTENDED "1 PCV6622 10.D4 PCV-02-5286 PART OF ASY6600 PRESSURE CONTROL VALVE MANUAL RELEASE OF EXTENDED "2 PCV6629 10.D4 PCV-02-5285A PART OF ASY6600 PRESSURE CONTROL VALVE MANUAL RELEASE

PDS1500 3.A4 PDSHH-02-5310F 1053929-15 PRESSURE DIFF SWITCH FLAMEOUT PROTECTION HIGH SHUTDOWN: 2 PSID (13.8 KPADJ INCREASING DPDT

PDS6210 1l.A 1 PDSH-02-5290 PART OF ASY6210 PRESSURE DIFF SWITCH ENCLOSURE VENT FILTER HIGH ALARM: 1 INH20 (0.25 KPAl

PDS6211 1l.A3 PDSLL-02-5200A 1035679-10 PRESSURE DIFF SWITCH ENCLOSURE VENT FAN FAIL LOW ALARM: 0.5 INH20 (0.124 KPADl LOW SHUTDOWN: SEE SOFTWARE

PDT1110 3.C2 PDT -02-5310 1052120-1 PRESSURE DIFF TRANSMITTER TURBINE AIR INLET DUCT LOSSES 4 - 20 MA - 0 - 15 INH20 (0 - 3.74 KPADl -B

PDT2100 6.A2 PDT-02-5321 PART OF ASY2100 PRESSURE DIFF TRANSMITTER GAS FUEL COALESCING FILTER HIGH ALARM: 221 INH20 (55 KPADl 4 20 MA 0 300 INH20 (0 - 7 4 KPADl 5 B

- - --

PDT3100 7.C1 PDT-02-5330 1052120-1 PRESSURE DIFF TRANSMITTER LUBE OIL TANK VENT PRESSURE HIGH ALARM: 8.5 INH20 (2.1 KPADl 4 - 20 MA - 0 - 15 INH20 (0 - 3.74 KPADJ -

HIGH SHUTDOWN: 10 INH20 (2.488 KPADl

PDT3240 7.A4 PDT-02-5335 1052120-4 PRESSURE DIFF TRANSMITTER MONITOR LUBE OIL FILTER HIGH ALARM: 30 PSID (207 KPADl 4 - 20 MA - 0 - 100 PSID (0 - 689 KPADl -

PDT4400 9.D4 PDT -02-5410A 1052120-2 PRESSURE DIFF TRANSMITTER IMPELLER EYE DEL TA-P, HP COMPRESSOR 4 - 20 MA - 0 - 7.23 PSID (0 - 49.8 KPADl -

PDT5100 9.D2 PDT -02-5410E 1052120-4 PRESSURE DIFF TRANSMITTER BUFFER AIR DIFFERENTIAL PRESSURE, LOW ALARM: 15 PSID (103 KPADl 4 - 20 MA - 0 - 100 PSID (0 - 689 KPADl -

HP COMPRESSOR LOW SHUTDOWN: 13 PSID (90 KPADl HIGH ALARM: 22 PSID (152 KPADl

PDT5104 9.D1 PDT-02-5420 1052120-4 PRESSURE DIFF TRANSMITTER BUFFER AIR FILTER DIFFERENTIAL PRESSURE, HIGH ALARM: 30 PSID (207 KPADl 4 - 20 MA - 0 - 100 PSID (0 - 689 KPADl -

HP COMPRESSOR

PDT5130 9.A4 PDT-02-5425 1052120-4 PRESSURE DIFF TRANSMITTER SEAL GAS FILTER DIFFERENTIAL PRESSURE, HIGH ALARM:20 PSID (138 KPADl 4 - 20 MA - 0 - 100 PSID (0 - 689 KPADl -

HP COMPRESSOR

PDT5150 9.B4 PDT -02-5410H 1052120-4 PRESSURE DIFF TRANSMITTER SEAL GAS DIFFERENTIAL, LOW ALARM: 7 PSID (48 KPADl 4 - 20 MA - 0 - 100 PSID (0 - 689 KPADl -

HP COMPRESSOR LOW SHUTDOWN: 4 PSID (28 KPADl

PDT6180 1l.C3 PDT-02-5200B 1052120-11 PRESSURE DIFF TRANSMITTER ENCLOSURE PRESSURE DELTA (PRIMARY) LOW ALARM: 0.25 INH20 (0.62 KPADl 4 - 20 MA - 0 - 3 INH20 (0. 75 KPADl -

LOW SHUTDOWN: 0.15 INH20 (0.37 KPADl

PDT6310 1l.C 1 PDT -02-5215 PART OF ASY6310 PRESSURE DIFF TRANSMITTER TURBINE AIR INLET FILTER HIGH ALARM: 3 INH20 (0.075 KPADJ 4 - 20 MA - 0 - 10 INH20 (0 - 2.49 KPADl -

HIGH SHUTDOWN: 5 INH20 (1.5 KPADl

PE1520 3.C5 PE -02-5310A 1071327-1 PRESSURE ELEMENT COMBUSTOR PRESSURE MONITOR REFERENCE SOFTWARE FOR SET POINTS

PI5530 3.A2 PG-02-5225 PART OF ASY5500 PRESSURE INDICATOR PRESSURE SUPPLY TO FILTER 5

PS3150 7.C4 PS-02-5338 1053923-14 PRESSURE SWITCH AC PRE/POST PUMP CHECK 4 PSIG (27.6 KPAGJ DECREASING, BY 6 PSIG (41.4 KPAGJ INCREASING

PS3170 7.C6 PS-02-5340 1053923-53 PRESSURE SWITCH BACKUP PUMP LOW PRESSURE TEST 12 +/- 1 PSIG (83 +/- 7 KPAGl INCREASING, c BY 9 PSIG (62 KPAGJ DECREASING c

PS3200 8.A3 PSLL -02-5314 1053923-14 PRESSURE SWITCH BACKUP LUBE PUMP ACTIVATION, PLC FAILURE 4 PSIG (27.6 KPAGl DECREASING, BY 6 PSIG (41.4 KPAGJ INCREASING

PS4401 9.C3 PS-02-5410D 1053923-31 PRESSURE SWITCH COMPRESSOR CASE PRESSURE, 4 PSIG (27.5 KPAGl DECREASING, HP COMPRESSOR BY 8 PSIG (55 KPAGJ INCREASING

PS5510 10.A3 PS-02-5200 1053923-53 PRESSURE SWITCH C02 RELEASE CONFIRM 25 PSIG () 73 KPAGl DECREASING, BY 32 PSIG (221 KPAGl INCREASING

PS5511 10.D2 PS-02-5281A PART OF ASY5500 PRESSURE SWITCH C02 PRIMARY RELEASE CONFIRM 25 PSIG () 73 KPAGl DECREASING, 5 BY 32 PSIG (221 KPAGJ INCREASING

PS5521 10.D4 PS-02-5285A PART OF ASY5500 PRESSURE SWITCH C02 EXTENDED RELEASE CONFIRM 25 PSIG () 73 KPAGl DECREASING, 5 BY 32 PSIG (221 KPAGJ INCREASING

PSV3110 7.C3 PSV-02-5337A PART OF ASY3200 PRESSURE SAFETY VALVE MAIN LUBE RELIEF 150 PSIG 0034 KPAGl

PSV3150 7 .C5 PSV-02-5338B 120712-11 PRESSURE SAFETY VALVE PRE/POST PUMP RELIEF 15 PSIG ()03 KPAGl CRACKING

PSV3170 7 .C6 PSV-02-5340A 190575-11 PRESSURE SAFETY VALVE BACKUP PUMP RELIEF 25 PSI (172 KPAl

PSV5150 9.B2 PSV-02-5410M 120652-5 PRESSURE SAFETY VALVE PRIMARY SEAL VENT ORIFICE BYPASS, 30 PSI (207 KPAJ CRACKING SUCTION END HP COMPRESSOR

PSV5170 9.B5 PSV-02-5410N 120652-5 PRESSURE SAFETY VALVE PRIMARY SEAL VENT ORIFICE BYPASS, 30 PSI (207 KPAl CRACKING DISCHARGE END HP COMPRESSOR

0 D






1 2 3 4 5 6 7 8


PSV6410 6.D2 PSV-02-5318B 967664C1 PRESSURE SAFETY VALVE LIMIT PILOT AIR PRESSURE 100 PSIG (690 KPAGl

PT1120 3.A3 PT -02-5310E 1052168-23 PRESSURE TRANSMITTER MONITOR PCD 4 - 20 MA - 0 - 700 PSIG (0 - 4827 KPAGl -

PT1121 3.A4 PT -02-5310D 1052168-23 PRESSURE TRANSMITTER MONITOR PCD "2 4 - 20 MA - 0 - 700 PSIG (0 - 4827 KPAGl -

PT2120 6.C1 PT-02-5320 1052168-3 PRESSURE TRANSMITTER GAS FUEL PRESSURE LOW ALARM: REFERENCE SOFTWARE FOR SET POINTS 4 - 20 MA - 0 - 700 PSIG (0 - 4827 KPAGl -

HIGH ALARM: 500 PSIG (344 7 KPAGl HIGH SHUTDOWN: 505 PSIG (3482 KPAGl

PT2121 6.C3 PT-02-5320A 1052168-23 PRESSURE TRANSMITTER GAS VALVE CHECK HIGH ALARM: 500 PSIG (344 7 KPAGl 4 - 20 MA - 0 - 700 PSIG (0 - 4827 KPAGl -

A HIGH SHUTDOWN: 505 PSIG (3482 KPAGl

A PT2126 6.C4 PT-02-5320B 1052168-23 PRESSURE TRANSMITTER FUEL CONTROL UPSTREAM PRESSURE HIGH ALARM: 500 PSIG (344 7 KPAGl 4 - 20 MA - 0 - 700 PSIG (0 - 4827 KPAGl -

HIGH SHUTDOWN: 505 PSIG (3482 KPAGl

PT2130 6.C5 PT-02-5320C 1052168-23 PRESSURE TRANSMITTER MAIN GAS MANIFOLD 4 - 20 MA - 0 - 700 PSIG (0 - 4827 KPAGl -

FUEL VALVE DISCHARGE PRESSURE "1 PT2131 6.C5 PT-02-5320D 1052168-23 PRESSURE TRANSMITTER MAIN GAS MANIFOLD 4 - 20 MA - 0 - 700 PSIG (0 - 4827 KPAGl -

FUEL VALVE DISCHARGE PRESSURE "2 PT2140 6.C6 PT-02-5320E 1052168-23 PRESSURE TRANSMITTER PILOT GAS MANIFOLD 4 - 20 MA - 0 - 700 PSIG (0 - 4827 KPAGl -

FUEL VALVE DISCHARGE PRESSURE "1 PT2141 6.C6 PT-02-5320F 1052168-23 PRESSURE TRANSMITTER PILOT GAS MANIFOLD 4 - 20 MA - 0 - 700 PSIG (0 - 4827 KPAGl -

FUEL VALVE DISCHARGE PRESSURE "2 PT3200 8.A3 PT -02-5314A 1052168-2 PRESSURE TRANSMITTER LUBE OIL HEADER PRESSURE REFERENCE SOFTWARE FOR SET POINTS 4 - 20 MA - 0 - 150 PSIG (0 - 1034 KPAGl -

PT4410 9.D3 PT -02-5410B 1052168-4 PRESSURE TRANSMITTER SUCTION PRESSURE, HP COMPRESSOR LOW ALARM: 269.8 PSIG ()860 KPAGl 4 - 20 MA - 0-1500 PSIG (0-10342 KPAl -

LOW SHUTDOW: 255.3 PSIG (1 760 KPAGl

PT4430 9.D5 PT-02-5410D 1052168-4 PRESSURE TRANSMITTER DISCHARGE PRESSURE, HP COMPRESSOR HIGH ALARM: 1080.5 PSIG (7450 KPAGl 4 - 20 MA - 0-1500 PSIG (0-10342 KPAGl -

HIGH SHUTDOWN: 1109.5 PSIG (7650 KPAGl

PT5153 9.B5 PT -02-5410J 1052168-4 PRESSURE TRANSMITTER BALANCE PISTON STATIC PRESSURE 4 - 20 MA - 0-1500 PSIG (0-10342 KPAl -

MEASUREMENT, HP COMPRESSOR

PT5160 9.B3 PT-02-5410L 1052168-2 PRESSURE TRANSMITTER PRIMARY SEAL VENT SUCTION FLOW, HIGH ALARM: 8 PSIG (55 KPAGl 4 - 20 MA - 0 - 150 PSIG (0 - 1034 KPAGl -

HP COMPRESSOR HIGH SHUTDOWN: 20 PSIG (138 KPAGl

PT5170 9.B6 PT -02-5410K 1052168-2 PRESSURE TRANSMITTER PRIMARY SEAL VENT DISCHARGE FLOW, HIGH ALARM: 8 PSIG (55 KPAGl 4 - 20 MA - 0 - 150 PSIG (0 - 1034 KPAGl -

HP COMPRESSOR HIGH SHUTDOWN: 20 PSIG (138 KPAGl

PT6400 6.D2 PT -02-5318 1052168-3 PRESSURE TRANSMITTER MONITOR AIR SUPPLY LOW ALARM: 80 PSIG (551 KPAGl 4 - 20 MA - 0 - 700 PSIG (0 - 4827 KPAGl -

HIGH ALARM: 200 PSIG 0380 KPAGl

B R1700 3.D4 V-02-5325 1056012-3P511 RESERVOIR ENGINE CLEANING SYSTEM TANK CHARGE WITH D.!. WATER/CLEANING FLUID/AIR: 200F (93.3Cl, 130 PSIG (896 KPAGl MAX 5 B 26 GAL 000 Ll AND 85-100 PSIG (586-690 KPAGl

R3100 7.D1 T-02-5330 PART OF SKID RESERVOIR OIL STORAGE

R5165 9.C2 V-02-5415 185616-2301 RESERVOIR SECONDARY SEAL VENT, SUCTION END, HP COMPRESSOR

R5175 9.C6 V-02-5416 185616-2301 RESERVOIR SECONDARY SEAL VENT, DISCHARGE END, HP COMPRESSOR

R6611 10.D2 V-02-5281 954290C1 RESERVOIR C02 FIRE SYSTEM PRIMARY BOTTLE "1 5

R6612 10.D3 V-02-5282 %4290C1 RESERVOIR C02 FIRE SYSTEM PRIMARY BOTTLE "2 5

R6621 10.D4 V-02-5285 954290C1 RESERVOIR C02 FIRE SYSTEM EXTENDED BOTTLE "1 5

R6622 10.D4 V-02-5286 954290C1 RESERVOIR C02 FIRE SYSTEM EXTENDED BOTTLE "2 5

SE1260 4.C1 SE -02-5310 PART OF ENGINE SPEED ELEMENT GAS PRODUCER SPEED (NGPl REFERENCE SOFTWARE FOR SET POINTS

SE1270 4.C4 SE -02-5310A PART OF ENGINE SPEED ELEMENT POWER TURBINE SPEED (NPTl REFERENCE SOFTWARE FOR SET POINTS

SE1271 4.C5 SE -02-5310B PART OF ENGINE SPEED ELEMENT BACKUP POWER TURBINE SPEED (NPTl REFERENCE SOFTWARE FOR SET POINTS

SG3510 8.C2 FG-02-5310E 1039199-5 (2 EACHl SIGHT GLASS "1 BEARING LUBE DRAIN

SG3520 8.C2 FG-02-5310F 1039199-4 (2 EACHl SIGHT GLASS "2 AND "3 ENGINE BEARING DRAIN

SG3530 8.C2 FG-02-5310G 1039199-4 (2 EACHl SIGHT GLASS "2 AND "3 ENGINE BEARING DRAIN

SG3540 8.C3 FG-02-5310H 1039199-5 (2 EACHl SIGHT GLASS POWER TURBINE

SG3620 8.C5 FG-02-5410B 1039199-5 (2 EACHl SIGHT GLASS COMPRESSOR SUCTION, HP

SG3630 8.C5 FG-02-5410C 1039199-4 (2 EACHl SIGHT GLASS COMPRESSOR OISCHARGE,HP

SG5134 9.B3 FG-02-5425 908489C1 SIGHT GLASS SEAL GAS FILTER, HP COMPRESSOR

c SG5144 9.B4 FG-02-5426 908489C1 SIGHT GLASS SEAL GAS FILTER, HP COMPRESSOR c SG5165 9.C2 FG-02-5415 908489C1 SIGHT GLASS SECONDARY VENT DRAIN, HP COMPRESSOR

SG5175 9.C6 FG-02-5416A 908489C1 SIGHT GLASS SECONDARY VENT DRAIN, HP COMPRESSOR

SV1710 3.D2 XY-02-5323 1067311-1 SOLENOID VALVE ON-LINE CLEANING SHUTOFF CV=0.4 MAX PRESSURE= 508 PSIG (3502 KPAGl

SV1720 3.C2 XY-02-5324 1067311-1 SOLENOID VALVE ON-CRANK CLEANING SHUTOFF CV=0.4 MAX PRESSURE= 508 PSIG (3502 KPAGl

SV2120 6.C2 XY-02-5320 1091605-100 SOLENOID VALVE PRIMARY GAS FUEL PILOT SHUTOFF VALVE CV = 0.11 PRESSURE, CV - 8.8 VENT MAX DESIGN PRESS= 125 PSIG (861 KPAGl, -

NORMAL RANGE: 80-100 PSIG (552-689 KPAGl

SV2121 6.C2 XY-02-5320A 1067311-1 SOLENOID VALVE GAS FUEL VENT, PILOT MAX PRESSURE= 508 PSIG (3502 KPAGl NORMAL RANGE: 80-100 PSIG (552-689 KPAGl

SV2124 6.C4 XY-02-5320B PART OF ASY2124 SOLENOID VALVE SECONDARY GAS FUEL SHUTOFF VALVE, PILOT cv - 0.7, EXHAUST CV = 3.95 MAX PRESSURE= 145 PSIG (100 KPAGl, -


SV2143 6.B6 XY-02-5320C 1067310-100 SOLENOID VALVE SPAC PILOT VALVE CONTROL cv - 0.4 PRESSURE, CV = 9.6 VENT MAX DESIGN PRESS= 261 PSIG (1800 KPAGl -


SV2150 6.D3 XY-02-5320D 1067311-1 SOLENOID VALVE GAS TORCH SHUTOFF, PILOT MAX PRESSURE= 508 PSIG (3502 KPAGl NORMAL RANGE: 80-100 PSIG (552-689 KPAGl

SV5120 9.A2 XY-02-5410 1067311-1 SOLENOID VALVE SEAL GAS SUPPLY SHUTOFF 24 VDC, 12 WATTS HP COMPRESSOR

SV6611 10.D3 XV-02-5281 PART OF ASY6600 SOLENOID VALVE PRIMARY RELEASE "1 C02

Tl000 3.B3 GT -02-5310 TURBINE GAS TURBINE

D D






1 2 3 4 5 6 7 8


TCV3200 7 .B3 TCV-02-5342 PART OF ASY3200 TEMPERATURE CONTROL VALVE OIL TEMPERATURE CONTROL VALVE TRANSFER RANGE: 129 - 145 F (53.9 - 62.8 C)

TE1110 3.C3 TE -02-5310 918801C1 TEMPERATURE ELEMENT ENGINE AIR INLET TEMPERATURE 100 OHM PLATINUM TE1150 4.B4 TE -02-5310C PART OF ENGINE TEMPERATURE ELEMENT T5 THERMOCOUPLE REFERENCE SOFTWARE FOR SET POINTS TYPE K, CHROMEL/ALUMEL TE1151 4.B5 TE -02-5310D PART OF ENGINE TEMPERATURE ELEMENT T5 THERMOCOUPLE REFERENCE SOFTWARE FOR SET POINTS TYPE K, CHROMEL/ALUMEL TE1152 4.B5 TE -02-5310E PART OF ENGINE TEMPERATURE ELEMENT T5 THERMOCOUPLE REFERENCE SOFTWARE FOR SET POINTS TYPE K, CHROMEL/ALUMEL TE1153 4.B5 TE -02-5310F PART OF ENGINE TEMPERATURE ELEMENT T5 THERMOCOUPLE REFERENCE SOFTWARE FOR SET POINTS TYPE K, CHROMEL/ALUMEL

A TE1154 4.B5 TE -02-5310G PART OF ENGINE TEMPERATURE ELEMENT T5 THERMOCOUPLE REFERENCE SOFTWARE FOR SET POINTS TYPE K, CHROMEL/ALUMEL A

TE1155 4.B6 TE -02-5310H PART OF ENGINE TEMPERATURE ELEMENT T5 THERMOCOUPLE REFERENCE SOFTWARE FOR SET POINTS TYPE K, CHROMEL/ALUMEL TE1155 4.C4 TE -02-5310J PART OF ENGINE TEMPERATURE ELEMENT T5 THERMOCOUPLE REFERENCE SOFTWARE FOR SET POINTS TYPE K, CHROMEL/ALUMEL TE1157 4.C5 TE -02-5310K PART OF ENGINE TEMPERATURE ELEMENT T5 THERMOCOUPLE REFERENCE SOFTWARE FOR SET POINTS TYPE K, CHROMEL/ALUMEL TE1158 4.C5 TE -02-5310L PART OF ENGINE TEMPERATURE ELEMENT T5 THERMOCOUPLE REFERENCE SOFTWARE FOR SET POINTS TYPE K, CHROMEL/ALUMEL TE1159 4.C5 TE -02-5310M PART OF ENGINE TEMPERATURE ELEMENT T5 THERMOCOUPLE REFERENCE SOFTWARE FOR SET POINTS TYPE K, CHROMEL/ALUMEL TE1150 4.C5 TE -02-5310N PART OF ENGINE TEMPERATURE ELEMENT T5 THERMOCOUPLE REFERENCE SOFTWARE FOR SET POINTS TYPE K, CHROMEL/ALUMEL TE1151 4.C5 TE -02-5310P PART OF ENGINE TEMPERATURE ELEMENT T5 THERMOCOUPLE REFERENCE SOFTWARE FOR SET POINTS TYPE K,CHROMEL/ALUMEL TE1250 4.B1 TE -02-5310A PART OF ENGINE TEMPERATURE ELEMENT GAS PRODUCER THRUST BEARING TEMPERATURE REFERENCE SOFTWARE FOR SET POINTS 100 OHM PLATINUM TE1261 4.C1 PART OF ENGINE TEMPERATURE ELEMENT GAS PRODUCER THRUST BEARING (SPARE) REFERENCE SOFTWARE FOR SET POINTS TE1270 4.B3 TE -02-5310B PART OF ENGINE TEMPERATURE ELEMENT POWER TURBINE THRUST BEARING TEMPERATURE REFERENCE SOFTWARE FOR SET POINTS TE1271 4.B4 PART OF ENGINE TEMPERATURE ELEMENT POWER TURBINE THRUST BEARING \SPARE) REFERENCE SOFTWARE FOR SET POINTS TE2120 5.C3 TE-02-5320 131230-5 TEMPERATURE ELEMENT GAS FUEL TEMPERATURE LOW ALARM: -18 F (-27.8 Cl -328 TO + 752 F (-200 TO + 400 C)

LOW SHUTDOWN: -20 F (-28.9 Cl HIGH ALARM: 200 F (93 Cl HIGH SHUTDOWN: 215 F 002 Cl

TE3100 7.D3 TE-02-5330 959839C1 TEMPERATURE ELEMENT MONITOR LUBE OIL TANK HEATER ON: 65 F (18 Cl 100 OHM PLATINUM (SYSTEM CONTROU OFF: 70 F (21 Cl

START PERMIT: 52 F (11 C) TE3200 8.A1 TE-02-5335 964192C1 TEMPERATURE ELEMENT LUBE OIL HEADER LOW ALARM: 110F (43Cl 100 OHM PLATINUM

HIGH ALARM: 160 F (71Cl HIGH SHUTDOWN: 155F (74Cl

TE3510 8.C1 TE -02-53100 918777C1 TEMPERATURE ELEMENT "1 BEARING DRAIN HIGH ALARM: HEADER TEMP + 45F (25Cl 100 OHM PLATINUM B TE3520 8.D2 TE -02-5310R 918777C1 TEMPERATURE ELEMENT "2 AND "3 BEARING COMMON DRAIN HEADER TEMP+110F (61 Cl 100 OHM PLATINUM B

HIGH SHUTDOWN: HEADER TEMP+125F (59 C) TE3540 8.C3 TE -02-5310S 918777C1 TEMPERATURE ELEMENT "4 AND "5 ENGINE BEARING COMMON DRAIN HIGH ALARM: HEADER TEMP + 45F (25Cl 100 OHM PLATINUM

HIGH SHUTDOWN: HEADER TEMP+50F (28Cl TE4413 5.C3 TE-02-5410A DRIVEN COMMON TEMPERATURE ELEMENT HPC SUCTION JOURNAL BEARING COMP SETTING SYS NORM/OPER VALUE

(UPPER PADl TE4413-SP 5.C3 DRIVEN COMMON TEMPERATURE ELEMENT HPC SUCTION JOURNAL BEARING

(UPPER PAD - SPAREl TE4414 5.B3 TE-02-5410B DRIVEN COMMON TEMPERATURE ELEMENT HPC SUCTION JOURNAL BEARING COMP SETTING SYS NORM/OPER VALUE

(LOWER PADl TE4414-SP 5.B3 DRIVEN COMMON TEMPERATURE ELEMENT HPC SUCTION JOURNAL BEARING

(LOWER PAD - SPARE) TE4417 5.C5 TE-02-5410C DRIVEN COMMON TEMPERATURE ELEMENT HPC INBOARD THRUST BEARING COMP SETTING SYS NORM/OPER VALUE

(UPPER PADl TE4418 5.B5 TE-02-5410D DRIVEN COMMON TEMPERATURE ELEMENT HPC INBOARD THRUST BEARING COMP SETTING SYS NORM/OPER VALUE

(LOWER PADl TE4430 9.C4 TE -02-5410 1055035-13 TEMPERATURE ELEMENT HIGH GAS DISCHARGE TEMPERATURE SHUTDOWN, HIGH ALARM: 338 F (170 Cl

HP COMPRESSOR HIGH SHUTDOWN: 347 F ()75 C) TE4433 5.C5 TE -02-5410E DRIVEN COMMON TEMPERATURE ELEMENT HPC DISCHARGE JOURNAL BEARING COMP SETTING SYS NORM/OPER VALUE

(UPPER PADl TE4433-SP 5.C5 DRIVEN COMMON TEMPERATURE ELEMENT HPC DISCHARGE JOURNAL BEARING

(UPPER PAD - SPAREl TE4434 5.B5 TE -02-5410F DRIVEN COMMON TEMPERATURE ELEMENT HPC DISCHARGE JOURNAL BEARING COMP SETTING SYS NORM/OPER VALUE

(LOWER PADl c TE4434-SP 5.B5 DRIVEN COMMON TEMPERATURE ELEMENT HPC DISCHARGE JOURNAL BEARING c

(LOWER PAD - SPARE) TE4437 5.C2 TE -02-5410G DRIVEN COMMON TEMPERATURE ELEMENT HPC OUTBOARD THRUST BEARING COMP SETTING SYS NORM/OPER VALUE

(UPPER PAD) TE4438 5.B2 TE -02-5410H DRIVEN COMMON TEMPERATURE ELEMENT HPC OUTBOARD THRUST BEARING COMP SETTING SYS NORM/OPER VALUE

(LOWER PADl TE6110 11.A4 TE-02-5200C 918801C1 TEMPERATURE ELEMENT ENCLOSURE TEMPERATURE HIGH ALARM: 167 F (75C)

HIGH SHUTDOWN: 185F (85Cl TE5210 11.A2 TE-02-5200D 918801C1 TEMPERATURE ELEMENT ENCLOSURE VENTILATION INLET MIXED AIR TS5540 10.B4 TSHH-02-5200 70-30104-1 TEMPERATURE SWITCH THERMAL DETECTOR, ENCLOSURE DRIVER HIGH SHUTDOWN: 325 F (153 C) TS5541 10.B4 TSHH-02-5200A 70-30104-1 TEMPERATURE SWITCH THERMAL DETECTOR, ENCLOSURE DRIVER HIGH SHUTDOWN: 325 F (153 C) TS5542 10.B4 TSHH-02-5200B 70-30104-1 TEMPERATURE SWITCH THERMAL DETECTOR, ENCLOSURE DRIVER HIGH SHUTDOWN: 325 F (153 C) TS5543 10.B4 TSHH-02-5200C 70-30104-1 TEMPERATURE SWITCH THERMAL DETECTOR, ENCLOSURE DRIVEN HIGH SHUTDOWN: 325 F (153 C) TW2120 5.C3 TW-02-5320 1039733-1 THERMOWELL GAS FUEL TEMPERATURE FOR TE2120 TW3100 7.D3 TW-02-5330 1039733-3 THERMOWELL LUBE OIL TANK TEMPERATURE TW3200 8.A1 TW-02-5335 1039733-1 THERMOWELL LUBE OIL HEADER TEMPERATURE TW3510 8.C2 TW-02-53100 1039733-2 THERMOWELL "1 BEARING DRAIN TW3520 8.D2 TW-02-5310R 1039733-2 THERMOWELL GAS PRODUCER DRAIN TW3540 8.C3 TW-02-5310S 1039733-2 THERMOWELL POWER TURBINE

0 D




0 "THIS COPYRIGHTED WORK AND THE INFORMATION HEREIN IS PROPRIETARY TO CATERPILLAR INC .. SOLAR TURBINES


1 2 3 4 5 6 7 8


TW4430 9 .. C4 TW-02-5410 1008764 THERMOWELL HP COMPRESSOR DISCHARGE

TY6210 1l.A 1 TY-02-5200E PART OF D6210 ACTUATOR ENCLOSURE VENTILATION INLET FAIL MODE L (OPEN I LOUVER DIVERTER DAMPER IOUTSIDEl

TY6211 1l.B2 TY-02-5200F PART OF D6211 ACTUATOR ENCLOSURE VENTILATION INLET FAIL MODE R ICLOSEDl LOUVER D!VERTER DAMPER IBUILDINGl

TY6240 1l.B7 TY-02-5200G PART OF D6240 ACTUATOR ENCLOSURE VENTILATION EXHAUST FAIL MODE R ICLOSEDl LOUVER DIVERTER DAMPER IBUILDINGI

TY6242 11.A6 TY-02-5200H PART OF D6242 ACTUATOR ENCLOSURE VENTILATION EXHAUST A FAIL MODE L IOPENI LOUVER DIVERTER DAMPER IOUTSIDEI A

UF1300 2.B4 1077496-1405 FREQUENCY CONVERTER START MOTOR SPEED CONTROL 16 INPUT= 600VAC, 60 HZ, 3-PH, 250 HP 1186 KWl, 200 KVA, 5 IPOWERFLEX 700HI 261 A CONTINUOUS, 375 A MAX

VE1204 4.B1 VE -02-5310D 120649-18 VELOCITY ELEMENT ENGINE ACCESSORY DRIVE GEARBOX HIGH ALARM: 0.35 tn/s rms 18.89 mm/s rmsl HIGH SHUTDOWN: 0.44 tn/s rms 111.17 mm/s rmsl

VE1210 4.A1 VE -02-5310 PART OF ENGINE VIBRATION ELEMENT ENGINE BEARING "1 HIGH ALARM: 2.5 mtls 164 uml RANGE: 0 - 10 mtls 10 - 254 uml IGP X-AXISI HIGH SHUTDOWN: 4.0 mtls 1102 uml

VE1211 4.A1 VE -02-5310A PART OF ENGINE VIBRATION ELEMENT ENGINE BEARING "1 HIGH ALARM: 2.5 mtls 164 uml RANGE: 0 - 10 mtls 10 - 254 uml IGP Y-AXISI HIGH SHUTDOWN: 4.0 mtls 1102 uml

VE1220 4.A2 VE -02-5310E PART OF ENGINE VIBRATION ELEMENT ENGINE BEARING "2 HIGH ALARM: 2.5 mtls 164 uml IGP X-AXISI HIGH SHUTDOWN: 4.0 mtls 1102 uml

VE1221 4.A2 VE -02-5310F PART OF ENGINE VIBRATION ELEMENT ENGINE BEARING "2 HIGH ALARM: 2.5 mtls 164 uml RANGE: 0 - 10 mtls 10 - 254 uml IGP Y-AXISI HIGH SHUTDOWN: 4.0 mtls 1102 uml

VE1230 4 .. A3 VE -02-5310G PART OF ENGINE VIBRATION ELEMENT ENGINE BEARING "3 HIGH ALARM: 2.5 mtls 164 uml RANGE: 0 - 10 mtls 10 - 254 uml IGP X-AXISI HIGH SHUTDOWN: 4.0 mtls 1102 uml

VE1231 4.A3 VE -02-5310H PART OF ENGINE VIBRATION ELEMENT ENGINE BEARING "3 HIGH ALARM: 2.5 mtls 164 uml RANGE: 0 - 10 mtls 10 - 254 uml IGP Y-AXISI HIGH SHUTDOWN: 4.0 mtls 1102 uml

VE1240 4 .. A3 VE -02-5310J PART OF ENGINE VIBRATION ELEMENT ENGINE BEARING "4 HIGH ALARM: 2.5 mtls 164 uml RANGE: 0 - 10 mtls 10 - 254 uml IPT X-AXISl HIGH SHUTDOWN: 4.0 mtls 1102 um)

VE1241 4.A4 VE -02-5310K PART OF ENGINE VIBRATION ELEMENT ENGINE BEARING "4 HIGH ALARM: 2.5 mtls 164 uml RANGE: 0 - 10 mtls 10 - 254 uml IPT Y-AXISl HIGH SHUTDOWN: 4.0 mtls 1102 um)

VE1250 4.A4 VE -02-5310L PART OF ENGINE VIBRATION ELEMENT ENGINE BEARING "5 HIGH ALARM: 2.5 mtls 164 uml RANGE: 0 - 10 mtls 10 - 254 uml IPT X-AXISI HIGH SHUTDOWN: 4 .. 0 mtls 1102 uml

VE1251 4.A5 VE -02-5310M PART OF ENGINE VIBRATION ELEMENT ENGINE BEARING "5 HIGH ALARM: 2.5 mtls 164 uml RANGE: 0 - 10 mtls 10 - 254 uml B IPT Y-AXISI HIGH SHUTDOWN: 4.0 mtls 1102 uml B

VE1262 4.B1 VE -02-5310B PART OF ENGINE VIBRATION ELEMENT GAS PRODUCER HIGH ALARM: 4 mtls 10.102 mml RANGE: -25 to 25 mtl s I -0.635 to 0.635 mml IAXIALI HIGH SHUTDOWN: 7.0 mtls 10.178 mml

VE1263 4.81 VE -02-5310C PART OF ENGINE VIBRATION ELEMENT GAS PRODUCER MONITORING ONLY !KEY PHASORI

VE1272 4 .. B4 VE -02-5310N PART OF ENGINE VIBRATION ELEMENT POWER TURBINE lAX I ALl HIGH ALARM: 4 mtls 10.102 mml RANGE: -25 to 25 mtls 1-0.635 to 0 .. 635 mml HIGH SHUTDOWN: 7 .. 0 mtls 10.178 mml

VE1273 4 .. B5 VE -02-5310P PART OF ENGINE VIBRATION ELEMENT POWER TURBINE KEY PHASOR MONITORING ONLY

VE4460 5.B3 VE -02-53100 DRIVEN COMMON VIBRATION ELEMENT HP COMPRESSOR FORWARD END HIGH ALARM: 2.5 mtls 164 uml RANGE: 0 - 5 mtls 10 - 127 uml IX-AXIS! HIGH SHUTDOWN: 3.0 mtls 176 uml

VE4461 5.C3 VE -02-5310R DRIVEN COMMON VIBRATION ELEMENT HP COMPRESSOR FORWARD END HIGH ALARM: 2.5 mtls 164 uml RANGE: 0 - 5 mtls 10 - 127 uml IY -AXIS! HIGH SHUTDOWN: 3.0 mtls 176 uml

VE4462 5.C6 VE -02-5310S DRIVEN COMMON VIBRATION ELEMENT HP COMPRESSOR FORWARD END HIGH ALARM: 6 mtls 1.152 mml RANGE: -25 to 25 mtls 1-0.635 to 0.635 mml AXIAL "1 IZ-AXISI HIGH SHUTDOWN: 11 mds 1279 mml END-PLAY WILL BE DETERMINED DURING INSTALLATION

VE4470 5.B6 VE -02-5310T DRIVEN COMMON VIBRATION ELEMENT HP COMPRESSOR AFT END HIGH ALARM: 2.5 mtls 164 uml RANGE: 0 - 5 mtls 10 - 127 uml IX-AXISI HIGH SHUTDOWN: 3.0 mds 176 uml

VE4471 5.C6 VE -02-5310U DRIVEN COMMON VIBRATION ELEMENT HP COMPRESSOR AFT END HIGH ALARM: 2.5 mtls 164 uml RANGE: 0 - 5 mtls 10 - 127 uml IY-AXISI HIGH SHUTDOWN: 3.0 rmls 176 uml

VE4473 5 .. B6 VE -02-5310V DRIVEN COMMON VIBRATION ELEMENT HP COMPRESSOR AFT END COMP SETTING SYS NORM/OPER VALUE IKEYPHASORI

VS3220 7.B3 VSHH-02-5343 PART OF HE3220 VIBRATION SWITCH LUBE OIL COOLER FAN VIBRATION 5

XFA3270 7.A2 FA-02-5332 1065667-4 FLAME ARRESTOR TANK VENT VERTICAL MOUNTING 5

XFA5167 9.A6 FA-02-5427 1065667-1 FLAME ARRESTOR SEAL VENT PROTECTION, PRIMARY, VERTICAL MOUNTING 5

c HP COMPRESSOR c XFA5177 9.A6 FA-02-5428 1065667-1 FLAME ARRESTOR SEAL VENT PROTECTION, SECONDARY, VERTICAL MOUNTING 5

HP COMPRESSOR

ZSC5511 10.01 ZSC-02-5281 PART OF ASY6600 POSITION SWITCH DETECT VALVE OPERATION CLOSED

ZSC6621 10.D2 ZSC-02-5285 PART OF ASY6600 POSITION SWITCH DETECT VALVE OPERATION CLOSED

ZS05611 10 .. D1 ZS0-02-5281 PART OF ASY6600 POSITION SWITCH DETECT VALVE OPERATION OPEN

ZS06621 10.D1 ZS0-02-5285 PART OF ASY6600 POSITION SWITCH DETECT VALVE OPERATION OPEN

0 D






dth - armouree

Documents