diagram or service manual
TRANSCRIPT
HCD-VX222E ModelSERVICE MANUAL
MINI HI-FI COMPONENT SYSTEM
— Continued on next page —
SPECIFICATIONS
• HCD-VX222 is the tuner, deck, CDand amplifier section in MHC-VX222.
Ver 1.2 2001.09
9-873-210-032001I0200-1
© 2001. 9
Sony CorporationHome Audio Company
Shinagawa Tec Service Manual Production Group
Model Name Using Similar Mechanism NEW
CD CD Mechanism Type CDM58B-K6BD37A
Section Base Unit Name BU-K6BD37A
Optical Pick-up Name KSM-213DCP/Z-NP
Tape deckModel Name Using Similar Mechanism HCD-DX20/RG30
Section
Amplifier section
The following measured at AC 120, 220, 240 V50/60 HzDIN power output (rated) 50 + 50 watts
(6 ohms at 1 kHz, DIN)Continuous RMS power output (reference)
60 + 60 watts (6 ohms at1 kHz, 10% THD)
InputsMD/VIDEO (AUDIO) IN (phono jacks):
voltage 450/250 mV,impedance 47 kilohms
GAME (AUDIO) IN (phono jack):voltage 450 mV,impedance 47 kilohms
MIC 1/2 (mini jack): sensitivity 1 mV,impedance 10 kilohms
OutputsMD/VIDEO (AUDIO) OUT (phono jacks):
voltage 250 mVimpedance 1 kilohms
VIDEO OUT (phono jack):max. output level1Vp-p, unbalanced, Syncnegative, load impedance75 ohms
S-VIDEO OUT (4-pin/mini-DIN jack):Y: 1Vp-p, unbalanced,Sync negative,C: 0.286Vp-p,load impedance 75 ohms
PHONES (stereo mini jack):accepts headphones of8 ohms or more
SPEAKER: accepts impedance of 6 to16 ohms
2
HCD-VX222
CAUTIONUse of controls or adjustments or performance of proceduresother than those specified herein may result in hazardous radiationexposure.
Notes on chip component replacement• Never reuse a disconnected chip component.• Notice that the minus side of a tantalum capacitor may be
damaged by heat.
Flexible Circuit Board Repairing• Keep the temperature of soldering iron around 270˚C
during repairing.• Do not touch the soldering iron on the same conductor of the
circuit board (within 3 times).• Be careful not to apply force on the conductor when soldering
or unsoldering.
NOTES ON HANDLING THE OPTICAL PICK-UPBLOCK OR BASE UNIT
The laser diode in the optical pick-up block may suffer electrostaticbreak-down because of the potential difference generated by thecharged electrostatic load, etc. on clothing and the human body.During repair, pay attention to electrostatic break-down and alsouse the procedure in the printed matter which is included in therepair parts.The flexible board is easily damaged and should be handled withcare.
NOTES ON LASER DIODE EMISSION CHECK
The laser beam on this model is concentrated so as to be focused onthe disc reflective surface by the objective lens in the optical pick-up block. Therefore, when checking the laser diode emission,observe from more than 30 cm away from the objective lens.
SAFETY-RELATED COMPONENT WARNING!!
COMPONENTS IDENTIFIED BY MARK 0 OR DOTTED LINE WITHMARK 0 ON THE SCHEMATIC DIAGRAMS AND IN THE PARTSLIST ARE CRITICAL TO SAFE OPERATION. REPLACE THESECOMPONENTS WITH SONY PARTS WHOSE PART NUMBERSAPPEAR AS SHOWN IN THIS MANUAL OR IN SUPPLEMENTSPUBLISHED BY SONY.
GeneralPower requirementsThai model: 220 V AC, 50/60 HzOther models: 120 V, 220 V or
230 – 240 V AC,50/60 HzAdjustable with voltageselector
Power consumption 120 watts
Dimensions (w/h/d) Approx. 280 x 325 x 421 mm
Mass Approx. 9.0 kg
Design and specifications are subject to changewithout notice.
CD/VIDEO CD player sectionSystem Compact disc and digital
audio and video systemLaser Semiconductor laser
( =780 nm)Emission duration:continuous
Wavelength 780 – 790 nmFrequency response 2 Hz – 20 kHz (±0.5 dB)Signal-to-noise ratio More than 90 dBDynamic range More than 90 dBVideo color system format
NTSC, PALCD OPTICAL DIGITAL OUT(Square optical connector jack, rear panel)Wavelength 660 nmOutput Level –18 dBm
Tape deck sectionRecording system 4-track 2-channel stereoFrequency response 40 – 13,000 Hz (±3 dB),
using Sony TYPE Icassette
Tuner sectionFM stereo, FM/AM superheterodyne tuner
FM tuner section
Tuning rangeTourist model: 76.0 – 108.0 MHzOther models: 87.5 – 108.0 MHzAntenna FM lead antennaAntenna terminals 75 ohm unbalancedIntermediate frequency 10.7 MHz
AM tuner section
Tuning rangeMiddle Eastern and Philippine models:
531 – 1,602 kHz (with theinterval set at 9 kHz)
Other models: 531 – 1,602 kHz (with theinterval set at 9 kHz)530 – 1,710 kHz (with theinterval set at 10 kHz)
Antenna AM loop antennaAntenna terminals External antenna terminalIntermediate frequency 450 kHz
3
HCD-VX222
TABLE OF CONTENTS1. SERVICE NOTE .............................................................. 4
2. GENERAL ......................................................................... 5
3. DISASSEMBY ................................................................. 7
4. TEST MODE ................................................................... 13
5. ELECTRICAL ADJUSTMENTS .............................. 17
6. DIAGRAMS6-1.Circuit Board Location .................................................. 216-2.Block Diagrams –Tuner Section– ................................. 22
Block Diagrams –Main Section– ................................. 23 Block Diagrams –Video Section– ................................ 246-3.Printed Wiring Board –Driver Section– ........................ 256-4.Schematic Diagram –Driver Section– .......................... 256-5.Printed Wiring Board –BD Section– ............................ 266-6.Schematic Diagram –BD Section – .............................. 276-7.Printed Wiring Board –Main Section– .......................... 286-8.Schematic Diagram –Main Section (1/5) – ................... 296-9.Schematic Diagram –Main Section (2/5) – ................... 306-10. Schematic Diagram –Main Section (3/5) – ................ 316-11. Schematic Diagram –Main Section (4/5) – ................ 326-12. Schematic Diagram –Main Section (5/5) – ................ 336-13. Printed Wiring Board –Power AMP Section– ........... 346-14. Schematic Diagram –Power AMP Section– .............. 356-15. Printed Wiring Board –Panel Section– ...................... 366-16. Schematic Diagram –Panel Section– ......................... 376-17. Printed Wiring Board –Trans Section– ...................... 386-18. Schematic Diagram –Trans Section– ......................... 396-19. Printed Wiring Board –Video CD Section– ............... 406-20. Schematic Diagram –Video CD Section (1/2) – ........ 416-21. Schematic Diagram –Video CD Section (2/2) – ........ 426-22. IC Pin Function Description ....................................... 436-23. IC Block Diagrams ..................................................... 48
7. EXPLODED VIEWS7-1.Main Section .................................................................. 527-2.Front Panel Section ........................................................ 537-3.Chassis Section .............................................................. 547-4.CD Mechanism Deck Section ........................................ 55
8. ELECTRICAL PARTS LIST ...................................... 56
4
HCD-VX222SECTION 1
SERVICE NOTE
1 Connector 13p (CN712)
2 Cut the seven melted-connection points with a cutting plier.
4 Cut the six melted-connection points with a cutting plier.
3 Panel board
5 Key board
Panel board(ten screw holes)
Key board(eight screw holes)
Screw hole
In order to re-install the panel board and the key board,fix them by using the screws (+BVTP 2.6 × 8 ) respectively.Screw in to the respective screw holes.Do not tighten the screws excessively.
* The panel board and the key board only are connected to the front panel by means of hot-melting the plastics.
Note for installing the panel board and the key board
REMOVING THE PANEL BOARD AND THE KEY BOARD
Hot melt
5
HCD-VX222This section is extracted frominstruction manual.
SECTION 2GENERAL
6
HCD-VX222
Setting the time
1 Turn on the system.
2 Press CLOCK/TIMER SET on theremote.Proceed to step 5 when “CLOCK” appearsin the display.
3 Press v or V
v V
V
repeatedly to select “SETCLOCK”.
4 Press ENTER.
5 Press or
v
repeatedly to set the hour.
6 Press .The minute indication flashes.
7 Press or repeatedly to set theminute.
8 Press ENTER.
TipIf you made a mistake or want to change the time,start over from step 2.
NoteThe clock settings are canceled when you disconnectthe power cord or if a power failure occurs.
B
7
HCD-VX222SECTION 3
DISASSEMBLY
3-1. CASE (SIDE-R, SIDE-L, TOP)
Note : Disassemble the unit in the order as shown below.
Note : Follow the disassembly procedure in the numerical order given.
Driver board, Moter board, Address sensor board
Chassis section
Case (Side-R, Side-L, Top)
CD door
Front panel section
CD mechanism deck(CDM58B)
Key boardPanel boardTape mechanism deck
Sub trans board, Video out board, Back panel, Power transformer (Trans board)
Main board, Power amp board
Video board, Base unit, BD board
Set
Case (Side-R)
Case (Side-L)
5
qd
qs
qs
q;
Case (Top)
6 Two screws (Case 3 TP2)
8 Screw (+BVTP 3 × 10)
3 Screw (+BVTP 3 × 10)
9 Screw (+BVTT 3 × 8)
4 Screw (+BVTT 3 × 8)
1 Two screws (Case 3 TP2)
qa Two screws (+BVTP 3 × 12)
7 Screw (Case 3 TP2)
2 Screw (Case 3 TP2)
8
HCD-VX222
3-2. CD DDOR
3-3. CD MECHANISM DECK (CDM58B), FRONT PANEL SECTION, CHASSIS SECTION
2 Pull-out the disc tray.
1 Turn the pulley to the direction of arrow.
pulley
CD door
Front panel side
CD mechanism deck (CDM58B)
3
qg
qf
7
CD mechanism deck (CDM58B)
Front panel section
qs Connector (B Deck)
qa Connector (A Deck)
9 Connector (CN714)
4 Screw (+BVTP3X10)
8 Wire (flat type)(CN2)
1 Wire (flat type) (CN102)
2 Connector (CN701)
3 Connector (CN301)
qd Three screws (+BVTP 3 × 6)
q; Screw (+BVTP 3 × 10)
5Screw (+BVTP 3 × 10)
6 Screw (+BVTP 3 × 10)
Chassis section
9
HCD-VX222
3-4. TAPE MECHANISM DECK
3-5. PANEL BOARD
1 Six screws (+BVTP 2.6 × 8)
2 Tape mechanism deck
1 Volume knob
2 Vol knob ring
4 Connector (CN712)
Note: When attching the panel board, refer to "Service Note" on page 4.
6 Panel board
3
5 Cut the seven melted-connection points with a cutting plier.
10
HCD-VX222
3-6. KEY BOARD
3-7. SUB TRANS BOARD, VIDEO OUT BOARD, BACK PANEL, POWER TRANSFORMER (TRANS BOARD)
Note: When attching the Key board, refer to "Service Note" on page 4.
2 Key board
1 Cut the six melted-connection points with a cutting plier.
qf Two screws (+BVTT 4 × 6)
qa Five screws (+BVTP 3 × 10)
q; Two screws (+BVTT 3 × 6)
qs
1 Two screws (+BVTP 3 × 10)
8 Screw (+BVTP 3 × 10)Back panel
qg Two screws (+BVTT 4 × 6)
qh Power transformer (T911)
qd Connector (CN915)
3 Connector (CN2)
5 Connector (CN903)
4 Connector (CN901)
2 Cover (Duct)
9 Video out board
7 Sub trans board
Trans board
6 Two screws (+BVTP 3 × 10)
11
HCD-VX222
3-8. MAIN BOARD, POWER AMP BOARD
3-9. VIDEO BOARD, BASE UNIT, BD BOARD
4 Three screws (+BVTT 3 × 6)
6 Two screws (+BVTT 3 × 6)7 Heat sink
3 Two screws (+BVTP 3 × 16)
1 Two screws (+BVTT 3 × 6)
2 Main board
5 Power amp board
Main board
Base unit
qg
qd Two screws (+PTPWH M2.6)
5 Screw (+PTPWH M2.6)
qf Screw (DIA. 12)
qa Two screws (+BVTP 2.6 × 8)
q; BD board
qh Two insulators
6 Holder (BU) assy
qh Two insulators
qs Two stoppers (BU)
7 Wire (flat type)(CN101)
8 Wire (flat type)(CN102)
9 Screw (+BVTP 2.6 × 8)
2 wire (flat type) (CN502)
1 wire (flat type) (CN502)
3 Screws (+BVTP 2.6 × 8)
4 VIDEO board
12
HCD-VX222
3-10. DRIVER BOARD, MOTOR BOARD AND ADDRESS SENSOR BOARD
9 Pull-out the disc tray.
4 Two screws (+BVTP 2.6 × 8)
q; Screw (+PTPWH 2.6 × 8)
qa Tray
1 Screw (+BVTP 2.6 × 8)
qs Screw (+BVTP 2.6 × 8)
6 Wire (flat type)(CN721)
3 Wire (flat type) (CN702)
8 Motor board
qd Address sensor board
2 Driver board
5 Remove the two solderings of motor.
7 Connector (CN722)
13
HCD-VX222SECTION 4TEST MODE
[MC Cold Reset]• The cold reset clears all data including preset data stored in the
RAM to initial conditions. Execute this mode when returningthe set to the customer.
Procedure:1. Press three buttons x , ENTER , and ?/1 simultaneously.2. The fluorescent indicator tube displays “COLD RESET” and
the set is reset.
[CD Ship Mode]• This mode moves the pickup to the position durable to vibra-
tion. Use this mode when returning the set to the customer afterrepair.
Procedure:1. Press 1/u button to turn the set ON.2. Press CD button and 1/u button simultaneously until
“STANDBY” appears.3. When you releaset he buttons, a message “LOCK” is displayed
on the fluorescent indicator tube, and the CD ship mode is set.
[MC Hot Reset]• This mode resets the set with the preset data kept stored in the
memory. The hot reset mode functions same as if the powercord is plugged in and out.
Procedure:1. Press three buttons x , ENTER , and DISPLAY simultaneously.2. The fluorescent indicator tube becomes blank instantaneously,
and the set is reset.
[CD Service Mode]• This mode can run the CD sled motor freely. Use this mode, for
instance, when cleaning the pickup.Procedure:1. Press ?/1 button to turn the set ON.2. Select the function “CD”.3. Press three buttons x , ENTER , and OPEN/CLOSE simul-
taneously.4. The CD service mode is selected.5. With the CD in stop status, continue to press > to move the
pickup to outside track, continue to press . to inside track.6. To exit from this mode, perform as follows:
1) Move the pickup to the most inside track.2) Press three buttons in the same manner as step 2.
Note: • Always move the pickup to most inside track when exiting fromthis mode. Otherwise, a disc will not be unloaded.
• Do not run the sled motor excessively, otherwise the gear can bechipped.
[Change-over of AM Tuner Step between 9 kHz and10 kHz]• A step of AM channels can be changed over between 9 kHz and
10 kHz.Procedure:1. Press ?/1 button to turn the set ON.2. Select the function “TUNER”, and press TUNER/BAND
button to select the BAND “AM”.3. Press ?/1 button to turn the set OFF.4. Press ENTER and ?/1 buttons simultaneously, and the display
of fluorescent indicator tube changes to “AM 9 k STEP” or“AM 10 k STEP”, and thus the channel step is changed over.
[GC Test Mode]• This mode is used to check the software version, FL tube, LED,
keyboard, headphone and volume.Procedure:1. Press three buttons x , ENTER and DISC 2 simultaneously.2. LEDs and fluorescent indicator tube are all turned on.3. When ENTER and DISC2 are pressed at the same time, the
key number check mode starts up. In this mode, the key numbersof each key series are displayed.
4. In the key check mode, the fluorescent indicator tube displays“KEY 000”. Each time a button is pressed.
5. When ENTER and DISC2 are pressed at the same time, thekey count check mode starts up. In this mode, the message “KEYCNT @@” is displayed on the FL display tube. When eachbutton is pressed, the key row number is incremented first. Thenthe key value is then incremented. However, one the button ispressed, the key value cannot be counted.
6. When ENTER and DISC2 are pressed at the same time, theheadphones check mode starts up. In this mode, the message“H_P ON” is displayed when the headphones are inserted. Whenthe headphones are not inserted. the message “H_P OFF” isdisplayed.
7. When ENTER and DISC2 are pressed at the same time, thevolume check mode starts up. In this mode, the message“VOLUME FLAT” is displayed on the FL display tube. Whenthe volume control knob is rotated in the positive (+) direction,the message “VOLUME UP” is displayed. When the volumecontrol knob is rotated in the negative (-) direction, the message“VOLUME DOWN” is displayed.
8. In order to quit the mode, either press ENTER and DISC2 atthe same time or press the three buttons at the same time as instep 1.
9. To exit from this mode, press three buttons in the same manneras step 1, or disconnect the power cord.
14
HCD-VX222
[MC Test Mode]• This mode is used to check operations of the respective sections
of Amplifier, TUNER, CD and Tape.
Procedure:1. Press the ?/1 button to turn on the set.2. Press the three buttons of x , ENTER and DISC 3
simultaneously.3. A message “TEST MODE” appears on the FL display tube.
• The messages VACS1 to VACS5 are displayed when the VACSis changed in this mode.
• The number of repeats of TAPE and CD is set to the infinitenumber as the default setting.
4 When v (CURSOR UP) button is pressed, GEQ increases toits maximum and a message “GEQ MAX” appears.
5. When V (CURSOR DOWN) button is pressed, GEQ decreasesto its minimum and a message “GEQ MIN” appears.
6. When b (CURSOR LEFT) or B (CURSOR RIGHT) buttonis pressed, GEQ is set to flat and a message “GEQ FLAT”appears.
7. In the test mode, the default-preset channel is called even whenthe TUNER is selected and an attempt is made to call the presetchannel that has been stored in memory, by operating the Shuttleknob. (It means that the memory is cleared.)
8. When a tape is inserted in the Deck B and the TAPE B functionis selected, and when the REC PAUSE/START button ispressed twice, recording starts.The VIDEO function is selected automatically as the inputsource.
9. Select the desired loop by pressing the PLAY MODE buttonin the TAPE B function. Insert a test tape AMS-110A or AMS-RO to Deck A.
10. Press the SPECTRUM button to enter the AMS test mode.11. After a tape is rewound first, the FF AMS is checked, and the
mechanism is shut off after detecting the AMS signal twice.12. Then the REW AMS is checked and the mechanism is shut off
after detecting the AMS signal twice.13. When the check is complete, a message of either OK or NG
appears.14. When the two buttons of SPECTRUM and DISC1 are pressed
at the same time in any function modes, either the “VACS ON”display to enable the VACS function or the “VACS OFF” displayto disable the VACS function can be selected.
15. When you want to exit this mode, press the ?/1 button twice.The cold reset is enforced at the same time.
[Microprocessor version display]• If the following operation is performed during the POWER OFF
in the modes other than the POWER SAVE mode (i.e., while theDemo display shows the watch time),1. When three buttons of STOP , ENTER , V (CUSOR DOWN)
are pressed at the same time, the MC and the GC microprocessorversion numbers are displayed as “M1.00 G1.00”.
2. When three buttons of STOP , ENTER , v (CUSOR UP) arepressed at the same time, the model name and destination aredisplayed as “BG1 AS1A3”.
15
HCD-VX222
[Aging Mode]This mode can be used for operation check of CD section and tape deck section.• If an error occurred:
The aging operation stops and display status.• If no error occurs:
The aging operation continues repeatedly.
1. Operating method of Aging ModeTurn on the main power and select “CD” of the function.1) Set a disc in DISC1 tray. Select ALL DISC CONTINUE, and REPEAT OFF.2) Load the tapes recording use into the decks A and B respectively.3) Press three buttons x , ENTER , and
DISC SKIP EX-CHANGE simultaneously.4) Aging operations of CD and tape are started at the same time.5) To exit the aging mode, perform [MC Cold Reset].
3. Aging Mode in CD section1) Display state• No error occurs
Note:[*][*][*][*] : Number of aging operations
Error display
E **s ## $$ %%12 3 4 5
• When the buttons x , ENTER and DISC 1 are pressed simultaneously, number of time of the mechanism error and the NO DISC errorcan be checked.Display: EMC**EDC** **: Number of times of error (Maximum three times)
EMC: Mechanism errorEDC: NO DISC error
• When aging operation is complete, be sure to perform the MC Cold Reset to reset the error history.
D: No disc error
01: FOCUS ERROR02: GFS ERROR03: SETUP ERROR
01: NO DISC judgment without chucking retry02: NO DISC judgment after chucking retry
Status at the time of NO DISC judgment(High order digits only)1: STOP2: SETUP3: TOC READ4: ACCESS5: PLAY BACK6: PAUSE7: MANUAL SEARCH (PLAY)8: MANUAL SEARCH (PAUSE)
AGING[*][*][*][*]
1 **
2 s
3 ##
4 $$
5 %%
M: Mechanism error
Don’t care
High order digits onlyD: Stopped during closing due to problems other than mechanism.E: Stopped during opening due to problems other than mechanism.C: Stopped during chucking due to problems other than mechanism.F: Stopped during EX-opening due to problems other than mechanism.
Emergency related errors (High order digits only)1: Stopped during chuck-up2: Stopped during chuck-down3: Time out by EX-OPEN5: Time out by EX-CLOSE
The error No. 00 indicates the newest error. As the error No. increases, it means the older error.When you want to retrieve the error history, press the PLAY MODE button in the case of mechanism error.Or press the REPEAT button in the case of NO DISC error.
Display
16
HCD-VX222
2) Operation during aging modeIn the aging mode, the program is executed in the followingsequence.(1) The disc tray opens and closes.(2) The mechanism accesses DISC 2 and makes an attempt to
read TOC. However, since there are no discs, a message“CD2 NO DISC” appears.
(3) The mechanism accesses DISC 3 and a message “CD3 NODISC” appears.
(4) The disc tray turns to select a disc1.(5) A disc is chucked.(6) TOC of disc is read.(7) The pickup accesses to the track 1, and playing 2 seconds.(8) The pickup accesses to the last track, and playing 2 seconds.(9) Every time when an aging operation of step 1 to step 8 is
complete, the display “AGING[*][*][*][*]” value increasesas the number of aging operations is counted up.
(10) Returns to step 1.
3. Aging Mode in Tape Deck section1) Display state• No error occurs
Display action now• Error occurred
Display action last time
2) Operation during aging modeIn the aging mode, the program is executed in the followingsequence.(1) Rewind is executed up to the top of tape A and B.(2) A tape on FWD side is played for 2 minutes.(3) FF is executed up to either made for 20 second or the end of
tape.(4) B tape is reversed, and the tape on REV side is played for 2
minutes.(5) Rewind is executed up to the top of tape.(6) Returns to step 2, and repeat steps from 2 to 5.
[Function Change Mode]* elect either VIDEO or MD of the external FUNCTION input.
Procedure:1. Turn on the power.2. Press the two buttons MD (VIDEO) and ?/1 at the same
time.The main power is turned on and the other function of theprevious function is selected and displayed. “MD” or“VIDEO”.
NO. Display action Action contents Final timing
1TAPE A AG-6 Rewind the TAPE A
The top of tapeTAPE B AG-1 Rewind the TAPE B
2 TAPE A AG-2 FWD play the TAPE A 2 minutes playing
3 TAPE A AG-3 F.F. the TAPE A20 second FF or the endof tape
4 TAPE A AG-4 REV play the TAPE A 2 minutes playing
5 TAPE A AG-5 Rewind the TAPE A The top of tape
6 TAPE B AG-2 FWD play the TAPE B 2 minutes playing
7 TAPE B AG-3 F.F. the TAPE B20 second FF or the endof tape
8 TAPE B AG-4 REV play the TAPE B 2 minutes playing
9 TAPE B AG-5 Rewind the TAPE B The top of tape
[VIDEO CD Color-bars Mode]On this mode, the data of the color-bars signal as a picture signaland the 1 kHz sine wave signal as a sound signal are output by themechanism controller (IC502) for the video CD signal check. Whenmeasurement of the voltage and waveform on the VIDEO board,perform it in this mode.For reference, the color-bars signal can be observed at J705 (VIDEOOUT board) using an oscilloscope.Procedure:1.Short the both ends of the land of SL503 of the VIDEO board.2.Turn the power on. Press the CD button to select CD.3.The color-bars appears when the CD is in stop status, and it disappears when the CD goes in play status.4.After measuring, remove the lead wire connected.
[CD Servo ON/OFF Mode]Procedure:1. Short SL502 on the VIDEO board by soldering.2. Turn on the main power. Set a disc on the DISC1 tray. Select
CD.3. Press the hH button to play back CD.4. When the > button is pressed, 100 track jump is executed.5. Also, every pressing of the PLAY MODE button triggers
between ON and OFF of TRACKING SERVO and SLEDSERVO.
How to quit the CD servo ON/OFF mode:1. Press the ?/1 button to turn off the main power.2. Remove soldering from SL502.
VIDEO board (SIDE A)
J301
CN301
CN501
CN503
SL503SL502
SL501
CHECK LED
CN502
17
HCD-VX222SECTION 5
ELECTRICAL ADJUSTMENTS
FM Tuned Level Adjustment
Procedure:1. Supply a 98 MHz signal at 28 dB from the ANTENNA terminal.2. Tune the set to 98 MHz.3. Adjust RV101 to the point (moment) when the TUNED
indicator will change from going off to going on.
Adjustment Location: MAIN board
Null Adjustment
Procedure:1. Supply a 98 MHz signal at 60 dB from the ANTENNA terminal.2. Tune the set to 98 MHz.3. Measure voltage between pin 21 and pin 23 of IC 101. Adjust
T101 ubtil the voltage becomes 0 V.
Adjustment Location: MAIN board
Adjustment Location
[MAIN BOARD] Component side
FM RF Signalgenerator
75 Ω coaxial
Carrier frequency : 98 MHzModulation : AUDIO 1 kHz, 75 kHz deviation (100%)Output level : 28 dB (at 75 Ω open)
FM ANTENNA terminal(TM101)
set
FM RF Signalgenerator
75 Ω coaxial
Carrier frequency : 98 MHzModulation : AUDIO 1 kHz, 75 kHz deviation (100%)Output level : 60 dB (at 75 Ω open)
FM ANTENNA terminal(TM101)
set
CD SECTION
Note :1. CD Block is basically designed to operate without adjustment.
Therefore, check each item in order given.2. Use YEDS-18 disc (3-702-101-01) unless otherwise indicated.3. Use an oscilloscope with more than 10MΩ impedance.4. Clean the object lens by an applicator with neutral detergent
when the signal level is low than specified value with thefollowing checks.
S-Curve Check
Procedure :1. Connect oscilloscope to TP (FEO).2. Connect between TP (FEI) and TP (VC) by lead wire.3. Connect between TP (AGCCON) and TP (D GND) by lead wire.4. Turn Power switch on.5. Load a disc (YEDS-18) and actuate the focus search. (In
consequence of open and close the disc tray, actuate the focussearch)
6. Confirm that the oscilloscope waveform (S-curve) issymmetrical between A and B. And confirm peak to peak levelwithin 4 ±1 Vp-p.
7. After check, remove the lead wire connected in step 2 and 3.Note : • Try to measure several times to make sure than the ratio
of A : B or B : A is more than 10 : 7.• Take sweep time as long as possible and light up the
brightness to obtain best waveform.
RF Level Check
Procedure :1. Connect oscilloscope to TP (RF).2. Connect between TP (AGCCON) and TP (D GND) by lead wire.3. Turned Power switch on.4. Load a disc (YEDS-18) and playback.5. Confirm that oscilloscope waveform is clear and check RF signal
level is correct or not.6. After check, remove the lead wire connected in step 2.
BD boardOscilloscope
TP(FEO)TP(VC)
symmetry
S-curve waveform
within 4 ±1Vp-p
A
B
TP(RF)TP(VC)
BD boardoscilloscope
T101
RV661
RV101
IFT101T102
RV661:TAPE SPEED
T101:NULL
RV101:FM TUNED LEVEL
18
HCD-VX222
Note : Clear RF signal waveform means that the shape “ ◊ ” can be clearlydistinguished at the center of the waveform.
E-F Balance (1 Track jump) Check
Procedure :1. Connect oscilloscope to TP (TEO) and TP (VC).2. Turned Power switch on.3. Load a disc (YEDS-18) and playback the number five track.4. Press the gG button. (Becomes the 1 track jump mode.)5. Confirm that the level B and A (DC voltage) on the oscilloscope
waveform.
6. After check, remove the lead wire connected in step 1.
RF PLL Free-run Frequency CheckProcedure :1. Connect frequency counter to test point (XPCK) with lead wire.
2. Turned Power switch on.3. Put the disc (YEDS-18) in to play the number five track.
Confirm that reading on frequency counter is 4.3218MHz.
RF signal waveform
VOLT/DIV : 200mVTIME/DIV : 500ns
level : 1.45 ± 0.3Vp-p
TP(TEO)TP(VC)
BD boardoscilloscope
level=1.3±0.6Vp-p symmetry
A (DC voltage)
center ofwaveform
B
0V
1 track jump waveform
Specified level: –– × 100=less than ±22%BA
BD board
TP (XPCK)
frequency counter
TP(XPCK)
TP(TEO)
TP(FEO)
TP(FEI)
TP(RF)
TP(VC)
TP(DGND)
TP(AGCCON)
112
241
2021
40
60
8041
61
IC101
IC103
Adjustment Location:
[BD BOARD] (Conductor Side)
19
HCD-VX222
VIDEO SECTION
Frequency AdjustmentConnection:
Procedure:1. Connect the frequency counter to check point of the VIDEO
board.2. Turned power switch on.3. Press the CD button to select the CD.4. Adjust CT503 on the VIDEO board so that the frequency counter
reading 27.0 MHz ± 80 Hz at stop status.
Adjustment Location:
[VIDEO BOARD] (Component Side)
VIDEO board
(27 MHz)
frequency counter
J301
CN301
CN501
CN503
SL503SL502
SL501
CHECK LED
CN502
IC507
(GND)
(27MHz)CT503VIDEOFrequencyAdjustment
20
HCD-VX222SECTION 6DIAGRAMS
Note on Schematic Diagram:• All capacitors are in µF unless otherwise noted. pF: µµF
50 WV or less are not indicated except for electrolyticsand tantalums.
• All resistors are in Ω and 1/4 W or less unless otherwise
specified.• ¢ : internal component.• C : panel designation.
Note on Printed Wiring Boards:• X : parts extracted from the component side.• b : Pattern from the side which enables seeing.• Indication of transistor.
Note:The components identified by mark ! ordotted line with mark ! are critical forsafety.Replace only with part number specified.
• A : B+ Line.• B : B– Line.• H : adjustment for repair.• Voltages and waveforms are dc with respect to ground
under no-signal (detuned) conditions.• Voltages are taken with a VOM (Input impedance 10 MΩ).
Voltage variations may be noted due to normal produc-tion tolerances.no mark : FM( ) : CD[ ] : TAPE
• Waveforms are taken with a oscilloscope.Voltage variations may be noted due to normal produc-tion tolerances.
• Circled numbers refer to waveforms.• Signal path.
F : FMf : AME : PB (DECK A)d : PB (DECK B)G : REC (DECK B)J : CDc : digital out
• AbbreviationSP : Singapore modelTH : Thai modelEA : Saudi Arabia modelTW : Taiwan modelIA : Indonesian modelE91 : 200VAC model
THIS NOTE IS COMMON FOR PRINTED WIRING BOARDS AND SCHEMATIC DIAGRAMS.(In addition to this, the necessary note is printed in each block.)
C
B
These are omitted.
E
Q
B
These are omitted.
C E
Q
• AbbreviationSP : Singapore modelTH : Thai modelEA : Saudi Arabia modelTW : Taiwan modelIA : Indonesian modelE91 : 200VAC model
2121
HCD-VX222
6-1. CIRCUIT BOARD LOCATION • WAVEFORMS
– MAIN BOARD – – PANEL BOARD –– BD BOARD –
TRANS board
SUB TRANS board
MAIN board
POWER AMP board
PANEL board
KEY board
BD board
DRIVER boardMOTOR board
ADDRESS SENSOR board
VIDEO OUT board
VIDEO board
4 IC101 wg (MDP)2 IC101 ra (TE)(CD Play mode)
1 IC101 t; (RFAC)(CD Play mode)
3 IC101 el (FE)(CD Play mode)
2.6 Vp-p
15.1 µs
0.2 Vp-p
0.5 Vp-p
1.3 Vp-p
1 IC102 wf STOP MODE
4.1Vp-p4.5MHz
2 IC401 qd STOP MODE
3 IC401 qa STOP MODE
4.0Vp-p16.0MHz
3.0Vp-p32.768kHz
1 IC701 4 STOP MODE
5.3Vp-p5MHz
4 J301 3 (COUT)
9 IC505 (VCK-IN)
7 IC505 od (VSYNC)
8 IC505 (HSYNC)
3 J301 4 (YOUT)
1 IC502 qd (XOUT)
37 nsec
4.6 Vp-p
10 MHz
3.5 Vp-p
20 ms
3.2 Vp-p
64 µs
2.0 Vp-p
H
H2.0 Vp-p
5.4 Vp-p
101
106
2 IC502 wh (BGP)
5 CN301 2 (VIDEO OUT)
6 IC505 ih (DA-XCLK)
3.6 Vp-p
17 MHz
q; IC505 (DA-LRCK)108
qa IC505 (DA-BCK)111
qs IC509 w; (384FSO)
qd IC509 wf (XT2)
qf IC509 4 (MCKO)
4.5 Vp-p
H
1.3 Vp-pH
4.5 Vp-p
22.7 µs
4.5 Vp-p
472 ns
5.0 Vp-p59 ns
2.0 Vp-p37 ns
5.2 Vp-p37 ns
– VIDEO BOARD –
2222
HCD-VX222
6-2. BLOCK DIAGRAMSTUNER SECTION
OPTICAL PICK-UPBLOCK
(KSM-213DCP)
A
B
C
D
E
F
LD
VC
+5V
GND
PD
VR
LDDRIVE
FOCUSCOIL
TRACKINGCOIL
Q101
RF AMPIC103
VC12
A5
B6
C7
D8
E11
F10
LD3
PD4
IC102MOTOR/COIL DRIVE
CH1RO13
CH1FO14
CH2RO11
CH2FO12
CH3RO18
CH3FO17
M
M102SLED
MOTOR
CH4RO16
CH4FO15
M
M101SPINDLEMOTOR
F-
F+
T-
T+
3CH1RI
2CH1FI
6CH2RI
5CH2FI
26CH3RI
27CH3FI
23CH4INS
20STBY2
MDP25
SFDR24
SRDR30
TRDR32
TFDR31
FRDR34
FFDR33
DIGITAL SIGNAL PROC.D/A CONV.
IC101
DIGITAL SERVO
64D OUT
RFAC50
17RFI
16RFO
14FE
13TE
22LD ON
21HOLD SW
RFDC43
FE39
TE41
SE40
DIGITALOUT
OPTICAL CDDIITAL OUT
PH671
4DATA
6CLOK
5XLAT
3MUTE
76SQSO
77SQCK
7SENS
27SSTP
2XRST
S101LIMITIN SW
IIC DATA30
IIC CLK29
XRST43
XRST
TBL ADDRESSSENSOR49T SENS
IC711
48BU UP/DOWN SW
46OPEN SW
47CLOSE SW
44LOAD IN
OPEN/CLOSES701
UP/DOWNS711
45LOAS OUT
MOTORDRIVE
9
7
4
2
M
IC701
TURNMOTOR
M721
9STBY1
66PCMD
67BCLK
65LRCK
14C2PO
71XTAI
65XTSL
B VIDEOSECTION(Page 24)
CD DATA
CD BCK
CD LRCK
C2PO
C VIDEOSECTION(Page24)
CD MECHA CONTIC502(1/2)
30IIC DATADSP DATA95
8SCLK
15SCOR
12XRESET
DSP CLK5
DSP LATH97
DSP MUTE10
SUBQ DATA36
SUBQ CLK37
SENSE1
SENSE CLK2
SCOR18
CTRL111
LDON28
LPH27
29IIC CLK
G VIDEOSECTION(Page 24)
384FS
: FM
: AM
: CD
• Signal Path
• RCH is omitted
: DIGITAL OUT
FM 75Ω
AM
TM101
ANT IN1 7IF OUT
8OSC OUT
5VT
FE101
JR109
+B A+12VQ102
10
FM OSC15
VT1 IN18
VT117
PD119
PLLIC102
12IFFM/AM7FM
14AM OSC
2VCO STOP
8IF REQ
6DO4DI
5CL
3CE
XIN1
XOUT24
X1014.5MHz
RF IFAMP
Q101CF101 CF102
T101
DOD108DI
CL
CE
1
13
3
455
122
14
1511
6 7
9
RB101
19AM MIX OUT
IF OUT9
AM/IF12
AM OSC24
VCO STOP13
IF MUTE8
AM RF20
OSC22
V REG23
FM IF1
FM DET5
AM/FM FRONT-END, IFAMP, MPX
IC10111L OUT
10R OUT
AMPQ103
18AM IF INIFT101
IFT101
16FM/AM DET
15MPX
14MPX
R-CHMAIN
SECTION(Page 23)
6TU LED
7ST LED
3FM SD ADJ
FM SD ADJRV611
ST MUTE22
ST CE25ST CLK28ST DOUT26ST DIN27
STEREO (IN)23TUNED24
MASTER CONTROL
IC401(1/2)
DO
CL
CE
DI
DI
AMTRACKING
L-CH
AMFREQUENCYCOVERRAGE
FM IF
AM IF
A
2323
HCD-VX222
MAIN SECTION
R-CH
RESET
: FM
: CD
: VIDEO
• Signal Path
• RCH is omitted
: PB (DECK A)
: PB (DECK B)
: REC (DECK B)
TUNERSECTION(Page 22)
VIDEOSECTION
VIDEOSECTION(Page 24)
GAMEIN
J703
MIC1
RV703
MICLEVEL
RV702
ECHOLEVEL
L
+ +
R
L
R
L
R
24OUT L
MUTEQ301
MUTECONT
Q361,362POWER
AMP
IC5011
12
6
7
MUTEDRIVE
Q581
MUTEBUFFER
Q503,504
OVER LOADDETECTOR
Q501D502
DCDETECT
Q381,382
PROTECTCONT
Q383
RERAYDEIVE
Q384,385
PROTECTSWITCH
Q386,387
MUTECONT
Q365
MUTEQ363
PHONES
R CH
R CH
L
R
JK302
SPEAKERIMPEDANCEUSE 6-16Ω
67 B REC REV
89 A SHUT
71 B PLAY
70 A PLAY
69 B HALF
68 A HALF
A TRIGDRIVE
CAPSTAN MOTORCAPM+
RV661MOTORSPEED
B-SOL
A-SOL
REC(REV)
A-PHOTO
A-MODE
B-MODE
A-HALF
B-HALF
DRIVE
Q605,606
Q601,602
B TRIGDRIVE
Q603,604
A TRIG60
B TRIG61
CAP M CONT65
POW
ERKE
Y74
POW
ER97
LED
S7 S29
G0 G11
34
LED
33
LED
32
LED
31
LED
30
LED
29
LED
28
GR O
OVE
35
KEY
0
22
KEY
1
21
KEY
2
20
DVD
5.1
26
DISP
LAY
KEY
73
LEDDRIVER
FLUORECENTINDICATOR TUBE
FLD1
Q701
EVER 5.7V
F1F2VP (-30V)
IC401(2/2)
IC302
MASTER CONTROL
SURR AMP
IC701DISPLAY CONTROL
83
LINE
MUT
84
STK
MUT
88
FRON
T-RE
LAY
85
PROT
ECT
10
XC IN
11
XC O
UT
15
X IN
13
X OU
T
32.768kHzX601
16MHzX602
3
X1
4
X2
5MHzRES701
T911
JW911
S901F919
E,EA,IA,SP,TW
E,EA,IA,SP,TW
F914
E,EA,IA,SP,TW
E,EA,IA,SP,TW
E,EA,IA,SP,TW
-VREG
+5VREG
Q911,D911-913
D541
VP (-30V)
+B
-B
POWERAMP
D681-684
EVER +5.7V
F1
AC1
AC1
AC3
AC3
AC4
AC4
F2
D902-905
ACIN
RELAYDRIVE
Q901
IC901 T901
31
+5.7VREG 13
RY901
+12VREG 31
+9VREG 31
CD POWERSWITCH
+5VREG 31
IC681 Q681,682
IC682
IC683
IC684
D+5V(SW)
A+5V(SW)
RDS +5V
BD +5V
EVER +5V
EVER +5.7V
D +5V
+5V(SW)
MIC +12V
+9V
M+7V
+7VD687-690
D686
D667
D661
D669
D670
STBY RELAY 86
38CD POWER
RESET 12 3 1
Q661 IC661
D383
D691-693
D664
D543 D542
JW912 JW6
JW3
JW1
66 B REC KEYREC(FWD)
90 B SHUTB-PHOTO
A
F
D
R-CH
VIDEO
VIDEO SW
R-CH
(Page 24)
VIDEOSECTIONE (Page 24)
L-CH
LOUT
L-CH
J301
R-CH
R-CH
L-CH
R-CH
ERASE
L-CH
L-CH
JK704
INPUT SELECTTONE/VOL CONT
IC301
TUNER L43
CD L42
MD L47
REC L51
32
24OUT R R CH31
MIC56
TC R
ELAY
MIC AMP
IC702(1/2)
AMP
IC702(2/2)
IC703
R-CH
19 6
9
2
1
11
5
AMCDETECT
BUFFER
Q213
Q229
Q226
REMOTECONTROLRECEIVER
SEN701
Q210,211D203,204
A/B
Q217
Q227 Q222,225
D206
MIC +12V
Q220,221
BIAS OSC
Q223,L201 Q224,228
5681 8082915958577879727677
VIDE
O SW
2
9475
A
B
PB
REC
IC201
Q214
39 38 37 36 35 34
TAPE/ L45
INLE GAME49
DPLL1
DPLL2
57
58
D302
BPOU
T
C B A SCK
SI
–A DECK–HP101
PLAYBACKHEAD
–B DECK–HRPE101RECOD/
PLAYBACK/ERASEHEAD
CASETTEDECKUNIT
BIAS
PB A
/B
AMS
REC-
MUT
E
PB M
UTE
3878
-DAT
3878
-LAT
3878
-CLK
SP L
ATA
SP L
ATB
SP L
ATC
SP V
ACS
SUR3
SUR2
SUR1
7
REC/ PB AMP
ECHO AMP
J702
MIC2
VIDEO
AUDIO
OUT
IN
MOT
OR H
MOT
OR L
S701`/1
D701`/1
S726DISPLAY
37-58, 61-68 69-80
LED DRIVERQ702-709,712
KEY MATRIXS702-712S713-725S727-738
VOL
13
VOL
14
VDD
25
REM
OTE
IN
4
RESE
TM
-RES
ET
6
41
SBSY
S-BS
Y
10
3
SS-
LCK
7
2
SS-
OUT
9
1
SS-
IN
8
100
HEAD
PHON
ES
17
D702-709,711,D716-720
ROTARYENCODER
VR701
VOLUME
+5V (SW) D713
EVER +5V
D685E91,TH
E91,TH
JW4
S901
VOLTAGE SELECTOR
230-240Vr
220Vr
120V
RY371
J701
F920
321
107
CONT
3
CONT
2
BR/S
R
L-OU
T
L-IN
MD/VIDEO(AUDIO IN)
LPF2 OUT2 9 LPF IN
g
2424
HCD-VX222
VIDEO SECTION
CD MECHA CONT
IC502(2/2)
3RESOLUTION
4CHROMA LEVEL
26BGP
32
1 4
13 105 8
DATA1 I
31DATA1 O
22DF LATH
33CLK1
25H SYNC BUFFERQ501
20HINT
45V SYNC BUFFERQ502
21HSEL
23HRDY
24RESET
65V MUTE
HD OUT112
HD IN119
HCK111
H SYNC101
V SYNC93
HINT114
HSEL121
HRDY113
RESET60
CD DATACD DATA
4
CD BCKCD BCK
3
CD LRCK5
CD C2PO
CD LRCK
C2PO6
MPEG VIDEO/AUDIO DEC
LEVEL SHIFT
IC501
VIDEO SIGNAL PROCIC505
MD9
MC8
ML7
DATA18
BCK17
LRCK19
384FSO20
MCKO4
110DA DATA
11DA BCK
86DA XCLK
106VCK
75C OUT
DIGITAL FILTERD/A CONVIC509
108DA LRCKIC104
IC50427MHz
RSTB10
14V OUT L
11V OUT R
1XT1
24XT2
L.P.FIC101
R-CH
X50327MHz
MAINSECTION(Page 23)
L-CH
TUNERSECTION(Page 22)
384FS
L.P.F VIN1BGP5
6VOUT
C AMPIC302
TINT8
VIN10
CCT5
1VOUT
Y AMPIC303
69Y OUT
TUNERSECTION(Page 22)
CD DATA/CD BCK/CD LRCK/C2PO
TUNERSECTION(Page 22)
XRST
DEVICE RST77
S VIDEOOUT
J3014
3
2
1
Y IN2
1
4
3
2 5
7
C IN7
MUTE A1
MUTE B8
VIDEO AMP
VIDEO SW
VIDEO
IC304
VIDEO SELECTORIC704
15Y OUT1
9C OUT
12MIX OUT1
11MIX OUT2
14Y OUT2
VIDEOOUT
J705
: VIDEO
• Signal Path
: CD
MD0
MD15
54
52
50
48.
46
58
56.
.
44
17
19
21.
23.
1015.
29
.
.
MA0
MA10
16
19
22
26
.
DQ1
DQ16
A0
A8
RAS14
UCAS28
LCAS29
WE13
DRAMIC507
DQ1
DQ16
A0
A8
CE22
MICRO ROMIC506
12
5
27.
26
23.
. 17
21
25.
4.
1315.
28
29
3
.
.2
30.
.
.
42RAS0
40CAS
38MWE
37MCE
11 10IC301
C
Y
7
10
31.
34.
25.
36
34
MAINSECTION(Page 23)
MAINSECTION(Page 23)
D
C
B
G E
F
2525
HCD-VX222
6-3. PRINTED WIRING BOARD – DRIVER SECTION – • See page 21 for Circuit Boards Location.
Ref. No. Location
D701 B-7
IC701 B-8IC711 B-5
• SemiconductorLocation
6-4. SCHEMATIC DIAGRAM – DRIVER SECTION – • See page 50 for IC Block Diagrams.
1 2
A
B
C
D
3 4 5 6 7 8 9 10
IC71
1
IC70
1
14
14
14
14
14
14
(Page 28)
B
4
C712
CN1(Page 32)
(4/5)
B
IC B/D
A C
EK
MTZ
J-T-
77-3
.9A
C7120.1
2626
HCD-VX222
6-5. PRINTED WIRING BOARD – BD SECTION – • See page 21 for Circuit Boards Location.
1212
1212
HBE
(KSM-213DCP)
1 2
A
B
C
D
3 4 5 6 7
TOVIDEO BOARD
(Page 40)
Ref. No. Location
IC101 C-6IC102 B-5IC103 C-5IC104 D-2
Q101 D-3
• SemiconductorLocation
2727
HCD-VX222
6-6. SCHEMATIC DIAGRAM – BD SECTION – • See page 21 for Waveforms. • See page 48,49 for IC Block Diagrams.
L
(KSM-213DCP)
41CN501
H
The components identified by mark 0 or dottedline with mark 0 are critical for safety.Replace only with part number specified.
2828
HCD-VX222
D101 D-11D104 C-9D108 C-8D203 E-5D204 E-5D205 F-5D206 E-3D207 G-5D301 E-6D302 C-5D303 B-6D361 F-8D372 G-10D383 E-9D601 D-3D602 D-3D661 B-4D662 B-4D663 B-5D664 B-5D665 B-5D666 C-4D667 B-4D668 B-4D669 B-4D670 B-6D681 G-9D682 H-8D683 G-9D684 H-8D685 G-6D686 F-7D687 G-9D688 G-9D689 G-9D690 G-9D691 F-6D692 F-6D693 F-6D694 G-10D695 G-10
IC101 C-10IC102 A-9IC201 F-4IC301 D-7IC302 C-6IC401 C-3IC661 B-5IC681 C-7IC682 G-6IC683 G-7IC684 G-6
Ref. No. Location
• Semiconductor LocationRef. No. Location
Q101 C-9Q102 A-10Q103 C-9Q104 D-9Q210 E-5Q211 E-5Q212 G-4Q213 E-3Q214 F-5Q215 G-5Q216 F-3Q217 F-3Q218 G-3Q219 G-3Q220 G-3Q221 G-3Q222 F-5Q223 H-4Q224 H-4Q225 F-5Q226 E-4Q227 G-5Q228 H-5Q229 E-4Q230 G-4Q301 H-6Q302 H-6Q361 D-3Q362 D-4Q363 F-9Q364 F-9Q365 F-9Q381 F-10Q382 F-10Q383 F-10Q384 E-10Q385 E-9Q386 E-9Q387 E-9Q601 D-3Q602 D-3Q603 D-3Q604 D-3Q605 D-3Q606 D-3Q661 B-5Q681 C-7Q682 D-8
6-7. PRINTED WIRING BOARD – MAIN SECTION – • See page 21 for Circuit Boards Location.
JW031JW032
JW035 JW034
GND1
JW02
9
JW030
JW3
JW4
JW5
CLP3
JW054
JW059JW058
JW057
JW056
JW055
JW06
5
JW06
4JW
063
JW06
2
JW06
0JW
061
JW02
6JW
027
JW02
8
JW073
JW075JW13
JW14
JW074JW072
JW076
JW077
JW078
JW079
JW108
JW10
7JW
106
JW10
5
JW10
3
JW10
2JW
116
JW11
5
JW10
9
JW11
0
JW05
3
JW052
JW07
0
JW06
9
JW06
8 JW06
7JW
066
JW07
1
JW11
7
JW11
4 JW11
3JW
112
JW11
1
JW051
JW050
JW049
JW048
131
JW037
JW03
8
JW03
6
JW04
1JW039JW040
JW04
2JW
043
JW04
4
JW15
7
JW15
6JW
153
JW15
5JW
154
JW15
2JW
151
JW04
6
JW04
5
1 13
JW150
JW04
7
12
13
JW018
JW01
7
JW016
JW001
JW021
JW014
JW013
JW02
0
JW01
5
1
24JW01
9
JW025
JW022
JW002
JW00
3
JW004
JW005
JW00
7
JW006
JW012
JW011
JW010JW009
JW008
12
1324
1JW08
4
JW08
3
JW08
2
JW08
5
JW08
7
JW08
6
131 5 10
JW08
9
JW08
8
JW023JW024
JW312
JW080
JW17JW16
JW081
JW101
JW09
1JW
092
JW09
3
JW09
0
JW104
JW314
JW313
JW09
6
JW217
JW098
JW09
9
JW09
5
JW097
JW09
4
10
CLP2
JW232
JW23
1
JW23
0JW
228JW
229
JW100
1
JW23
9JW
238
JW23
7JW
236
JW23
5JW
234
JW24
JW23
JW22
JW24
3
JW24
2JW
241
JW24
0
JW250
JW251
JW22
3JW
222
JW22
1
JW22
0JW
219
JW256
JW227JW22
6
JW25
4
JW22
4JW
225
JW252
JW25
3JW260
JW259
JW258JW257
JW316
JW315
JW26
9
JW289
JW290
JW298
JW29
9
JW297JW296
JW291JW292JW293
JW281JW282
JW283JW285JW284
JW286JW287 JW288
JW294
JW319
JR15
JW246JW248
JW24
9
JW247
JW244
JW303
JW304
JW305
JW306
JW307
JW302
JW245
JW301
JW308
JW309JW310
JW311
30
JW30
0
29
JW16
1
JW16
2
JW15
8
JW16
3JW
164
JW15
9JW16
0JW173
JW165
JW171
JW17
4
JW172
JW16
7
JW166
JW17
5
JW16
9JW
170
JW176
JW17
8
JW147
JW148 JW31
7
JW318
JW12
2JW
125
JW12
8
JW133JW134 JW
118
JW12
3JW
124
JW139
JW130
JW137JW138
JW131
JW132JW13
5
JW136
JW145
JW146
JW11
9JW
120
JW12
1
JW12
6
JW129
JW20
3
JW214JW215
JW21
2
JW21
3
JW12
7JW
15
JW202
JW21
8 JW216
JW21
0JW
209
JW20
8JW
207
JW20
6
JW20
5JW
204
JW26
1
2
JW26
5JW
266
JW26
2
JW26
3JW
264
JW19
8
JW200
1
JW144
JW143
JW140
JW18
9JW
190
JW142JW141
JW19
3
JW191
JW19
2
JW19
5
JW19
9
JW19
7
JW19
6
JW18
8JW
187
JW18
5JW
186
JW18
3
JW18
2
JW27
2
JW27
3
17
16
JW268
JW26
7JW270
JW271JW277JW278
JW279JW280
JW201
JW275
12
JW274
CLP1
JW18
1
RG30
D694
D695
RB101
Q382
C382
RY371
Q381
C302
C301
C381
JK101
Q383
D688
Q386
Q384
Q365
C362
R362
Q364
C361
Q363
R361
C363
C697
Q385
C383
Q387
C308
C306
C305
C681
C311
C307
IC683
C685C690C691
JW8D683
CN403
D681
D689
C683
C684
C693
CN402
D682
D684C694
D687
D690
JW9
C104
FE101
RG30
IC101
C676
Q102
T102
L671
C140
C133
C114
C113
C137
JW1
RV101
C106 C108
C135
C143
C144
C127
C136IFT101
CF101
C125
CF102
Q101
T101
C116
C117
X101
IC102
C677
CN102
C675C671
C658
Q682
C304
C312
C314
C303
C310C354 C309
C687
1 2 3
C686
Q681E
E
EEE
E
EE
E
E
E
E
E
IC681
C319
C327C339
C325
C328
C326
C333
C337
C338
C313
C318
C320 C315
1 64
32 33
C356
C316
C353
C317
C300
CN1
X602 C665 C661
C321
C662
Q661
IC66
1
C602
C663
X601
C364
C610
Q361
C699
C222
C698
C348
C689 C688
C347
Q301 Q302
JW16
8
Q227
C225
Q223
C239
C215
C234
Q215C230
Q212 C2
72
C214
C212
Q228
Q224C2
40
Q230
IC684
Q225C221
Q222
C257
IC682
C692
D691
D692
D693
C344
C334
C340
1617
4948
C342
C343
C349C345 C346
JW31
C256
CN2
Q362JW
32Q2
26
C218
C232
C233
C217
Q210 Q211
C236
C235
Q214
Q229 C2
70
C211
C213 C231
C229
C219
IC201
C209
CN203
Q219
Q218
Q213
C271
JW33
Q605
Q603
Q601
Q602
Q604E
E
E
E
EE
E
E Q606
RV661
CN70
1
C241
C242
Q221
Q220
C210
L201CN202
C223
.1
0
JR607
.1
E
E
L107 L108
C666
C657
R60
1
R60
3
FB4
C204
E
E
E E
E E
E
E E
E E
EE
E
E
E
E
E
EE
E
1 2 3 1 2 3 1 2 3
E
E
C205
R27
7R247
R205
R27
1
R202
R27
3R
275
C202
C201R201R240
R239
Q217Q216
R203
C203
C206
C208
R21
0
R22
4
R20
9
R229
C227R223
R227R22
1
C207
R20
7
C243
R215C265
R218
R270
R259
R26
2
R673 R670
R21
7
R20
4D
206
R656
R640
R64
1 C605
R32
5
D30
2
R309
FB5
C664
C601
R63
3
R67
7R
674
R676R678
R60
6
D601JR10
JR8 R
679
R67
1
R628
R626R627 R659
R642
R657
R658
R66
0
R63
2
R680 R63
7R
636
R63
5
R369
R37
0 R675
R672
R639
R638
JW255 JW30
JW25JW26JW27
JR4
R60
5
D602R602
R604
C611
R64
3
R63
4
R630
R629
R631
IC401
R308
R30
5
R30
6R
307
R31
5
R324
C350
R322R320
R321R31
8
R313
R314
R317
R31
6
IC301
D301
R23
1
R32
3
R34
2 R34
1R237
R219
R24
6
R256C235A1
R245
R249
D204
JR17R263
R25
7
D20
3
R235
R233
D20
5
R22
0
R250
D686
R26
1 R258
R22
2R
238
R264
C236
AR
231A
C237
C266
C224
R25
3
C226
JR7
R260R226
C238R225
R274
R27
2R
276 R22
8
R23
0R2
78R
214
R23
6
C244
R23
4R232
R23
2A
R20
8 C228
R25
2R
241R242
R20
6
R25
1R
248
D685
R24
3R
254
R36
8
R333
R337 R33
5
R331
R33
2
R338
R336
R334
R216
R25
5
D20
7R
244
R327
R391
D303
R340
R694
C355
JR11
JR16
D670 JR15
C673
R64
7
R64
8R
654
R65
3
JR14
D66
2
R646
R655
D661
D66
7
D66
8
R662R66
1D
664
D669
D66
5
D66
3C6
56
R66
4
R644
JR1
C607
C608
R66
3D
666
R665
C603
R607
R651
C606
R62
5
R66
6
C644
R615R61
4
R610
R613
R61
2
C613
R60
9
C612
R66
7
R650
R649
R64
5
FB6R61
1R
608
C604
R668R
616
R618
R101JR642
R11
2
R3
C112
R113PH671
1
3
R114
R116
C115
JR60
2
R104 JR641R12
3
C105
R7R109
C103
R107 JR109
C118
C123
R12
0
C124
C121
C122
R13
6
JR60
3
C119
JR60
6
C120
R12
2
R13
5
R11
1
C101
R121
R119 JR633
FB2
FB7 FB3
C672
C659
FB1
C674
D10
8R12
6 R11
8
R106
C375
C376
D37
2
JR63
8
D36
1
C322
R36
7
Q104
R130
R129R128
R105C102
C359C358
C357R103
R13
8
R68
1R682 R683
R32
9
R693
R33
9
C660
R32
8
R326
C29
R11
5R
117
R13
9
D10
1
C111
C109
C110
C128
JR634
C107
R110
JR635
R10
8
R125
C130
C129
C126
D10
4
R13
2
R131
R13
7
C141
R127C134
C131
C132
R4
C138
JR11
0
C139
C142Q
103
R10
2R
124
R134
R133
R382
R381
R383
C351
C352
R30
4
R303
R301
R302
C366
R31
2
C365
R31
1
C360
R38
7
R39
3
R38
5R
366
R36
5 R36
3R
364
R38
4
R38
8
R39
4
R386
R389
D38
3
E
3
1
E
31 30
80 81
5051
1100
1 12
1324
1458
8 5 4 1
31
7
1
8
916
1 IC302
MAIN BOARD
11(14)1-681-440-
DPOWER AMP
BOARD(Page 34)
POWER AMPBOARD
(Page 34)
F
APANELBOARD
(Page 36)
B
DRIVERBOARD
(Page 25)
E
VIDEOBOARD
(Page 40)
PH671CD DIGITAL OUT
OPTICAL
R-CH
L-CH
ERASE
R-CH
L-CH
A DECKPLAYBACK
TAPE DECK BLOCKSUPPLIED WITHTHE ASSEMBLED
BLOCK
B DECKRECORD/PLAYBACK/ERASE
J302SPEAKER
IMPEDANCEUSE 6-16Ω
–
+
L
–
+R
FM75Ω
AM
L JK301MD/VIDEO(AUDIO)
R
L
R
IN
OUT
2 3 4 5 6 7 8 9 10 11 12
A
1
B
C
D
E
F
G
H
I
2929
HCD-VX222
6-8. SCHEMATIC DIAGRAM – MAIN SECTION (1/5) – • See page 50 for IC Block Diagrams.
IC201
Q210Q211
Q217
Q219
Q220
Q221
Q224
Q218
Q222
Q223
Q216
Q214
Q215
R234
R232
R232A
R214
R216 C244
R272
R278
R276
R274R237 R220
R208
R206
R201
R202
R239
R240
R210
C206
C203
C204
C201
C202
R228 R230
R222
R224
C224
JR17
R258
R256
R249
R257 R261R250 R218
R238
R264
C235A
R262R263
R236
R217 C265 C207R209
C205
C208
R205
R223
C237R229 R227
R207R271
R273
R275
R277
R215R247C243
R226
R231
R231A
R233
JR7
R252
R241R242
R245
R243R244
R246
R251 R248
C266
R260
R253
R254
C240
C215C221
C256
C235
C236
C270
R270
C230
C229
C217
C210
R203
R204
CN202
C209
C271 C213
C272
C218
C257
C236A
C233
C242
C241
C239
L201
C223
Q213
R225
R221
C211
C214 C212
Q212
R235
Q228Q225
Q227
D206
D203
D204
D207
D205
Q229Q226
Q230R255
R259
CN203
C228
C227
C238
R219
C219
C232
C222
C231
C226
C225
R265 C245
C246R266
C234
TA8189N
2SC27852SC2785
2SC3623A
2SC2785
2SC2785
2SC2785
2SC2785
2SC2785
2SC2785
2SC2001
2SC3623A
2SC3623A
2SC3623A
68k
2.2k
1k
4.7k
100k 0.0015
1M
100k
4.7k
1.5k10k 22k
8.2k
47
10
10
10k
10k
270k
220p
680p
680p
680p
680p
120k 1.8k
220
180k
470p
0
220
10k
680k
390 390180k 180k
680k
10k
47p
100k10k
4.7k
10k 0.01 220p270k
220p
220p
47
180k
470p1.8k 120k
8.2k1M
1.5k
4.7k
100k
4.7k100k0.0015
22k
2.2k
1k
68k
0
27k
4.7k4.7k
10k
2.2k27k
4.7k
2.2k 12k
0.022
390
10k
4.7k
4716V
2.250V4.7
50V
150V
150V
10016V
10016V
220
10010V
10010V
4716V
4716V
10
10
4716V
150V
150V
150V
4716V
0.150V
47p
0.047MC
0.001MC
0.0047MC
0.015MC 0.022
MC
2SC2785
22k
10k
0.018MC
150V
0.018MC
2SC2785
4.7k
2SB1116A2SB1116A
2SB1116ABUFFER
1SS355TE
1SS355TE
1SS355TE
1SS355TE
1SS355TE
2SC3623A-LKMUTE
DTA124ESSWITCH
2SC3623A-LKMUTE
1k
1k
3P
47p
47p
0.0018
10k
2.250V
0.4750V
4.750V
0.4750V
0.0018
4.750V
820k 0.22
0.22820k
0.01MC
89
10
11
12
7 6 54 3 2 113
REC/PB PRE AMP
HEADPLAYBACK
L-CH
R-CH
ERASEHEAD
RECORD/PLAYBACK
HRP101-B DECK-
-A DECK-HP101
L-CH
R-CH
AMPQ210,211
MUTE
MUTE
OSCBIAS
BIAS OSC
123
4
5
6
7 8
9
SWITCHQ220,221
AMP
SWITCHQ218,219
BIAS OSCQ224,228
B+ SWITCH
SWITCH
SWITCH
AMP
SWITCHQ222,225
GND
REC
NF GND
MIX
PRE
MET
AL
NF CH1/
A
CH1/
B
OUT
OUT
OUT
M/H
REC
OUT
IN
PRE
MET
AL
OUT
OUT NFREC NFIN
REC
OUT
TAPE A/B
CH2/
B
CH2/
ACD VCC
ALC
(3/5)
(2/5)
(4/5)
(Page 30)
(Page 31)
(Page 32)
3030
HCD-VX222
6-9. SCHEMATIC DIAGRAM – MAIN SECTION (2/5) – • See page 21 for Waveforms. • See page 49,50 for IC Block Diagrams.
JK101 R3
C103
R104
C104
R107
R101
R102
R108
R103
CF101
CF102
C102 R105
R139
C110 R117
C111
R111
R112
R113
R114
R115
R116
C112 C114 C115
C116 C117
C118
R135
R136
C119
R118
R119
R120
R121
R122
R123
C120X101
C123 C124
R124 C125 C126 RV101C128
C129 C130C134
C135
C136
C127
R126
R127
R128
R129
C106C107
C108
R110
C141
C143
C137
R131
R132
R137
C140 R130
R4
R138
R7
R109
D101
C144
C101
C113
C121 C122
Q103
Q104
C133
R125
T101
JR633
Q102
C105
Q101
JR606
L107
JR634
JR635
JR603
JR60
7
JR10
9
JR641
JR642 JR602
D104
D108
C142
R106
C139
C131 C132
R133 R134
C109
0
0.01
150
4716V
0
47
680
330
680
0.01 1.5k
0
0.01 100k
0.01
100
4.7k
4.7k
4.7k
10k
100
0.0147
16V 0.01
2.250V
4716V
0.01
4.7k
3.3k
0.01
100
10k
10k
1k
10k
10k
0.014.5MHz
0.001 0.001
22047
16V 0.01 22k0.01
0.01 0.010.047
4.750V
4.750V
150V
4.7k
2.2k
560
560
10016V 0.01
1050V
10k
0.047
2216V
1050V
12k
2.2k
100
150V
10k
0
100
0
47
DA204K
4716V
0.01
0.4750V
22pCH
33pCH
2SC1623
2SC1623
0.2250V
4.7k
0
UN4111
0.01
2SC2410SN
0
0
0
0
0
0 0
0
0 0
DTZ-TT11-6.8B
1SS355TE
100p
330
220p
0.015 0.015
470 470
4p
54 1613 14
10
TU R TU L
222324
25 26 2728FM
75Ω
AM
XIN
VCO
CE DI CLK
DO FM MW
FM IFIF F
EO
FM/A
M
XOUT
GMND VT
2
PD1
PD2
VT1I
N
VT1 B+ SW
VT2I
N
FM O
SC
AM O
SC
REG
AFC
AGC
MPX
MPX
OSC/
OUT
AM R
F
AM M
IX
AM IF
AM/F
M O
UT
VCO
STOPOS
C
VCC
GND
AM/F
M
L OU
T
R OU
T
IF O
UT
IF M
UT
ST L
ED
TU L
ED
FM D
ET
FM S
D
FM IF
ST L
ED
TU L
ED
ST M
UTE
+BGND
VTGND
GND
ANT
IN
OSC
OUTGA
FE101
IF O
UT
RB101
IFT101
IC102LC72130
IC101BA1450
PB641
PLL
FM/AMFRONTEND,
IF AMP,MPX
AMPQ103,104
FM TUNED LEVEL
+BSWITCH
RF IF AMP
(4/5)
(1/5)
(3/5) (5/5)
(Page 29)
(Page 32) (Page 33)(Page 31)
3131
HCD-VX222
6-10. SCHEMATIC DIAGRAM – MAIN SECTION (3/5) –
R301
R303
R304
R307
R308
R309
R363
R364
R365R366
R367
R368
R369
R393 R394
R341
R342
R331
R332
R333
R334
R335
R336
R337
R338
Q301
Q302
R325R326
R328
R329
R305R306
R327
C301
C302
C303
C304
C312
C313
C315
C356
C300
C317
C318
C319
C307C308 C309 C310
C311
C333 C334
C337
R313
R314
R315
R316
C338
C339
C340
C344
R317
R318
C342
C343
R320
C345
C346
C347
C348
R323
C349
C350
C321
Q363
Q364
C364
C363
C360
C322
R339 R340
C325 C326
C361 R361
R362C362
C320 C327 C328
JK301
R322
R321
D302
D303
D361
D301
C314
Q365
Q362
Q361
C323C324 C354 C359
C357C358 R391
C353
C355
C316
R392
R344
R343
R324
C351
C352
R370
C306
C305
R312 C366
C365R311
R302
10k
27k
27k
15k
15k
1M
1k
1k
47k10k
1k
100k
22k
56 56
220
220
4.7k
4.7k
2.2k
2.2k
100k
100k
10k
10k
2SC3623A
2SC3623A
15k10k
3.3k
3.3k
2.2k2.2k
2.2k
4.750V
4.750V
4.750V
4.750V
0.1
0.047
4.750V
4.750V
0.1
0.22
0.22
0.22
4.750V
4.750V
4.750V
4.750V
1050V
0.0022 0.0022
0.047
100k
100k
33k
33k
0.047
0.047
0.047
1050V
100k
270k
0.1
0.1
150k
22016V
0.27
1050V
1050V
220
10010V
0.22
0.033
2SC3623A
2SC3623A
2.250V
4750V
0.1
0.1
6.8k 6.8k
0.022 0.022
4.7100V
BP
6802W
6802W
4.7100V
BP
0.22 0.022 0.022
10k
10k
1SS3
55TE
1SS355TE
1SS355TE
UDZSTE-179.1B
4.750V
DTA124ES
DTA124ES
DTC114ES
4.750V
4.750V
4.750V 0.1
0.10.01 10k
4.750V
4.750V
4.750V
100
33k
33k
12k
470p
470p
1.5k
4.750V
4.750V
100k 1000p
1000p100k
10k
36 37 38 48 41
52
21
20
515049
43
18
812
13 14
2728
11
9
53TU R TU L
567808182ABC
E D575859
VCC
NC LPFC
AGC
GUR
GLR
L OU
T
R OU
T
VREF
HPFC GN
D
CONT
3
CONT
2
L IN
R IN
BP/S
P
F1L1
F1L2
F1R1
F1R2
F2L1
F2L2
F2R1
F2R2
F3L1
F3L2
F3R1
F3R2
F4L1
F4L2
F4R1
F4R2
F5L
F5R
VCC
CAP
FILTER
HPFL1
HPFL2
HPFL3
HPFR1
HPFR2
HPFR3
ALCC
ALCR
BASS1
BASS2
BASS3
OUT R
OUT L
C B A
SCK SI
SETP
C
MD
R
TAPE
R
TUNE
R R
CD R
MD
L
TAPE
L
TUNE
R L
CD L
BP N
F
BP O
UT
INLEGAME
GAMEINRE
PS1
PS2
DPLR2
DPLR1
DPLL2
DPLL1
REC R
REC L
VFC1
GND
VFC2
MIC
IC301BH3878KS2
R
L
(AUDIO)MD/VIDEO
MUTE
MUTE
MUTECONTROL
MUTECONTROL
Q361,362MUTE
Q363,364
INPUT SELECT,TONE/VOLUME CONTROL
IC302LA2615
R
L
IN
OUT
POWER ON
(5/5)
(1/5)
(2/5) (4/5)
(4/5)
(5/5)
(4/5)
(5/5)
(Page 33)
(Page 29)
(Page 30) (Page 32)
(Page 33)
(Page 32)
(Page 32)
(Page 33)
3232
HCD-VX222
6-11. SCHEMATIC DIAGRAM – MAIN SECTION (4/5) – • See page 21 for Waveforms. • See page 43 for IC Pin Function Description.
R601
R602
JR10
R603
R604
R605
R606
JR8
D691C692
R676 R677 R678 R679R671 R672 R674 R675
Q661
CN1
R607
R608
R610
R612R613
R614
R615
R616
R618
JR15JR1
C607C608
R644
X601X602
R645
R649R650
JR11R655
R665
R661
R663
R664 C665
R632
R634
R635
R633
R636
R637
R643
C601
C602
FB5
C664
C603
C604
C605
C606
R656
R626 R627 R628 R629 R630 R631 R658
R657C6
11
C610
FB4
R625
C644 FB6
RV661
CN2
D692 D693
TP71
R647
JR14
R648
R646
C656
C663
C662
R662
C681
JR4
C666
C613
C612
D601
D602
D669
D670
D665
D661 D662
D664 D667
D668
D663
D666
R670
C657
C658
C659
C660
R660
R659
R680
CN701
R611
R609
Q601
Q603
Q605
Q602
Q604
Q606
R640
R639
R638
R642
R641
R666
R651
R653 R654
R668
R667
C661 R673
R652
D603
1k
680
0
1k
680
1k
680
0
11ES247016V
47k 47k 47k 47k47k 47k 47k 47k
2SC2785
10P
100
100
100
10010k
100
100
100
10k
00
18p15p
330k
32.7
68kH
z
16MHz10k
10k10k
00
10k
4.7k
47k
47k 10006.3V
10k
10k
100
100
100
100
1k
0.1
1050V
0
0.01
220p
220p
220p
220p
100
100 100 100 100 100 100
100
10k
0.01 10
50V
0
10k
0.1 0
2.2k
17P
11ES2 11ES2
00
0
10k
0.1
0.1
0.1
1k
0.1
0
0.1
0.001
0.001
1SS355TE
1SS355TE
1SS355TE
1SS355TE
1SS355TE
1SS355TE 1SS355TE
1SS355TE
1SS3
55TE
1SS3
55TE
1SS355TE
1SS355TE
3.3k
0.1
0.1
0.1
0.1
100
10k
10k
30P
10k
10kDTC114ES
DTC114ES
DTC114ES
2SB1116A
2SB1116A
2SB1068
47k
47k
1.5k
1k
00
10k 10k
0
47k
2250V
10k
1k
1SS355
6
54
52
43
4039
4950
3534
51
24 25
17
26 2930
4647
7 53
2223
44
4 5 1 3 213
E5V
57
1234
1
234
97
100
E
D
C
41
A
B
F
GH
66
67
68
69
7071
89
90
22232425262728
43
44
45
46
47
48
49
60 61 65 66 67 68 69 70 71 73 74
80 81 82
J
I
K
95
918384
85
86
60
61
65
4445
46474849
83
84
85
86
88
91
89
90
7374
100
38
41
88
6
95
IJK
97
94
2930
57 58 59
94
*2
1
5
10
15
20
25
304.7
4.7
4.7
SENS
HOLD
XLT
XRST
OPEN
CLOSE
SQ DAT
SQ CLK
CD DAT OUT
CANT USE
CD CLK
CD POWER
CLOCK OUT
M RESET
LOAD IN
LOAD OUT
UP/DOWN
T SENS
GAME/DVD
PROTECT
VACS
AVSS
POWER
AVCC
S IN
AV REF
VIDEO SW2
SPEC IN
MODE IN
SP/VACS
B SHUT
ASHUT
FRONT RELAY
REAR RELAY
STB RELAY
STK MUT
LINE MUT
SP LATC
SP LATB
VDD
VSS
AMS
BIAS
SP L
ATA
REC
MUT
PB M
UT
TC R
ELAY
PB A
/B
POW
ER K
EY
DISP
LAY
KEY
B PL
AY
A PL
AY
B HA
LF
A HA
LF
B RE
C RE
W
B RE
C KE
Y
CAPM
CON
T
SOFT
TES
T
B TR
G
A TR
G
SUR3
SUR2
SUR1
494
LT
494
CLK
494
DAT
REAR
MUT
CENT
MUT
NO U
SE
SCOR
NMI
VCC
XIN
VSS
XOUT
RESE
T
BYTE
NO USE
S OU
T
S CL
K
S BS
Y
REM
OTE
IN
3878
DAT
3878
LAT
3878
CLK
XC IN
XC O
UT
RDS
INT
RDS
DATA
ST M
UTE
STER
EO(IN
)
TUNE
D
ST C
E
ST D
OUT
ST D
IN
ST C
LKIC401
IC661M51943BSL
GND
VFVP
VFVFGND
GAME LGAME GNDGAME R
POWER ONVIDEO SWPOWER KEYDISPLAY KEYM RESETREMOTE INS BSYS CLKS OUTS INNO USELED GNDMIC +12VMIC SIGMIC GNDHP RHP GNDHP LD GNDEVER +5V+5V(SW)
MTR CTN2M GND
MTR CTN1M +7VD +5VOPEN SWCLOSE SWUP/DOWN SWADDRESS SWD GND
GND NC
CAPM
+
NCNC
A HA
FEA
MOD
EA
PHOT
OA
SOL
B HA
FEB
MOD
EB
PHOT
OB
SOL
RESET
MOT
OR H
MOT
OR L
REC(
FWD)
REC(
REW
)
MT GND
MASTERCONTROL
RESETQ661
INV.
10k
*2 R641
1.5k
TAPE SPEED
TAPE DECK BLOCK
SUPPLIED WITHTHE ASSSENBLED
BLOCK( (
Q601,602A TRIG DRIVE
A TRIG DRIVEQ603,604
Q605,606CAP MOTOR DRIVE
EAEXCEPT EA
M30622MAA-A98FP
I2C
DATA
I2C
CLK
AC C
UT
CNVS
S
(3/5)
(2/5)
(3/5)
(5/5)
(5/5)
(1/5) (3/5)
BOARDPANEL
CN711
BOARD
(5/5)
(5/5)
CN701
DRIVER
(Page 29) (Page 31)
(Page 37)
(Page 25)
(Page 33)
(Page 33)
(Page 33)
(Page 31)
(Page 33)
(Page 30)
(Page 31)
3333
HCD-VX222
6-12. SCHEMATIC DIAGRAM – MAIN SECTION (5/5) –
Q381 Q382
Q385
Q386
Q387
C686
C688
C690C689 C691
C698C697
RY371
R383R384
R385
R386
R387
R388
R389
C381
C375C376
C382
C383
L671100µH
0µH
C676C674C675
CN403
JW8
JW9
C683 C684
C672
C673
C693 C694
C671
C677
D686
D383
D372
D685
JK302
Q384
Q383
D687 D688
D689 D690
D694 D695
C699
JR638
FB2 0µH
Q682
D681 D682
D683 D684
CN402
FB10µH
JW18
JW19
R693
FB1FB2
FB3
FB30µH
R381
R382
GND1
R681
R682
R683
C685
Q681
C687
CN102
R694
FB7
2SC2785 2SC2785
2SC2785
2SC2785
2SC2785
1050V
1050V
1050V
10010V
10010V
1050V
220025V
10k10k
33k
22k
4.7k
22k
5.6k
10010V
1000p1000p
2.250V
2.250V
10010V
100p4706.3V
0.1 0.1
100p
100p
0.01 0.01
10006.3V
47010V
1SS355TE
1SS355TE
1SS355TE
1SS355TE
DTC114ES
2SA1175
11ES2N 11ES2N
11ES2N 11ES2N
11ES2N 11ES2N
47016V
0
DTC114ES
11ES2N 11ES2N
11ES2N 11ES2N
13P
33k
00
0
56k
47k
2.7k
2.7k
2.7k
470016V
2SC2785
33006.3V
13P
10k
1746 47
3637
38
3940
48
2524
2827
30
41
29
26
2223
1644 35 34 21 20
18
E5V
H
38
F G
43
2930
10
PH671
CD DIGITALOUT+5V
OUTIC681UPC7805A UPC7805A
IC682 IC683UPC7812A
IC684
VF VF -B VP
L OU
T
R OU
T
SP G
NDSP
GND
PW G
ND AC4
AC4
AC3
AC3
STBY
PROTECTOR
L OUT
R OUTA GND
+12V GNDREG+12VFAN ON
EVER +5VD GNDSTK MUT
+B SWITCHQ681,682
+12V REG+5V REG +5V REG
OUTING
OUTING
OUTING
OPTICAL
OUTING
+9V REG
XRSTA+5V(SW)ROUTAGNDLOUTDGNDDOUTD+5V(SW)+5V
MGND
SPEAKER+-
+-
AVDD
DVDD
CD/R
CD/L
R
LIMPEDANCEUSE 6-16Ω
DRIVERELAY
Q384,385
PROTECTSWITCH
PROTECTSWITCH
PROTECTSWITCH
PROTECTQ381,382
DETECTOR
M5F7809AFH
GND
M+7V
EXCEPT
TW
TW
TW
EXCEPTTW
EXCEPTTW
TW
PH671TOTX178A
(CHASSIS)
I2C CLKI2C DATA
BOARDCN502
(4/5)
BOARD
BOARD
(2/5)(4/5) (4/5) (3/5) (3/5)
(4/5)
(3/5)
POWER AMP
POWER AMP
VIDEO
(Page 32) (Page 30) (Page 32) (Page 31) (Page 31)
CN503(Page 35)
(Page 32)
CN502(Page 41)
(Page 35)
(Page 32)
(Page 31)
3434
HCD-VX222
6-13. PRINTED WIRING BOARD – POWER AMP SECTION – • See page 21 for Circuit Boards Location.
Ref. No. Location
D501 B-5D502 B-4D541 C-5D542 A-3D543 A-3D551 B-4
IC501 A-5
Q501 B-5Q503 B-5Q504 B-5Q551 B-4Q581 B-5
• SemiconductorLocation
POWER AMP BOARD
11(14)1-681-448-
D
FMAIN BOARD(Page 28)
MAIN BOARD(Page 28)
C TRANS BOARD(Page 38)
(CHASSIS)
TW
C592
TW(CHASSIS)
E E
E
EER
513
R59
3
R519
TW
R56
1
_+
1
13
1
13
1
13
2 3 4 5 6 7
A
1
B
C
D
3535
HCD-VX222
6-14. SCHEMATIC DIAGRAM – POWER AMP SECTION –
Q504
Q501
Q551
Q503
C542C592
C541
C591
C501
C503
C511
C543
R501
R502
R512
R561
CN501
R505
R506
D501
D502R507
C507
C508
D551
D542D543
C545C544
C551R551 C553
C554
C559
R552
R581
R582
R514
R515
R516 R517
R556
R557C557
C558
R559
C509 R511
EP502
Q581
R509
R513
R519
R510R508
R558
R560
R555
R541 R591
D541
CN502
CN503
R518
R503
C504
C502
C552
R553
R554
R593
R592
R504
2SC1841
2SC1841
2SC1841
2SA988
220050V 2200
50V
0.1100V
0.1100V
1050V
100p
0.01
0.1
1k
56k
11/4W
1001/4W
1k
15k
1SS133T
1SS133T100k
0.068
0.068
1SS133T
11ES211ES2
330035V
100025V
1050V 1k 100p
2225V
2250V
56k
33k
33k
2.2k
22k
10k 2.2k
15k
100k0.068
0.068
101/2W
2250V
1001/4W
2SC1841
101/2W
22k
22k
0.222W 0.22
2W
0.222W
0.222W
1k
22k1/2W 22k
1/2W
D5SBA204101
13P
13P
10k
1.2k
2225V
0.001
0.001
1.2k
56k
0.11/4W
0.11/2W
56k
+VCCPRE
BIAS
+VCC
-VCC
CH1 IN
CH1 NFCH1 +VE
CH1 -VE
CH2 +VE
CH2 -VE
PRE -VCCSUB GND
CH2 NF
CH2 IN
PROT
ECTO
R
L OU
T
R OU
TA
GND
+12V
GND
REG+
12V
FAN
ON
EVER
+5V
D GN
DST
K M
UT VF VF -B VP
L OU
T
R OU
T
SP G
NDSP
GND
PW G
ND AC4
AC4
AC3
AC3
AC4AC4
AC3AC3
VFVFVPD GNDEVER +5V
STBY
REL
AY
STBY RELAY
AC1GNDAC1
IC501
POWER AMP
(CHASSIS)
MUTEDRIVER
BUFFERMUTE
Q503,504 PROTECTION
PROTECTION
STK402-0705(1/2)
IC501STK402-0705(2/2)
BOARDTRANS
MAIN MAINBOARD(5/5) BOARD(5/5)
CN402(Page 33)
CN403(Page 33)
CN915(Page 39)
3636
HCD-VX222
PANEL BOARD
KEY BOARD
11(14)1-681-447-
11(14)
1-681-446-
J702MIC2
(CHASSIS)(CHASSIS)
AMAIN
BOARD(Page 28)
(CHASSIS)
>
MxX
Z
B
B
B
B
gG>M
E
VIDEO OUT BOARD
11(14)
1-681-441-
1
1 2
L
R
J703MIC1
J702J703
VR702
CN714 CN713
VR703
VR702ECHO LEVEL
VR703MIC LEVEL
1 2 1 2
CN714 CN713
1 2G
GVIDEO BOARD
(Page 40)
C753
D715
D714
D712
2 3 4 5 6 7 8 9 10
A
1
B
C
D
E
F
G
H
I
(CHASSIS)
CLP4 CN714
JK705VIDEOOUT
2
IC702
IC704
IC703
12
67 5
43
1
J701PHONES
VOLUME
S701-738J701,J707,J703
267 5
43
12
67 5
43
12
67 5
43
12
3029
TUNER/BAND
E
E
E
E
61 60
20 21
80
1
41
40
E
DX20
1
R793
C768
C767
4
R79
5
C76
4
JW70
3
JW81
9
C76
9
R79
4
58
113
1
JW84
7
13
DISPLAY
MUSIC EQ
S737EFFECTON/OFF S703,D711
GROOVE
GAME EQ
JW841
Q712
JW839
R804
D711
S703
S711PICTURE
EFECT
DISC SKIPEX–CHANGE
DISC 1
DISC 2
DISC 3OPEN/LCOSE
P.FILE
ENTER
SPECTRUM
MOVIE EQ
TUNER MEMORY/PLAY MODE
E
E
KARAOKE PON
DIRECTION/EDITSTEREO/MONO
REPEAT
+
E
31
AUDIO
INPUT
VIDEO
IC701
R80
0
R77
9
R78
0
R78
1
R77
7
R77
8
R77
6
R80
1
R775JW823
JW822
R782
R767
R751
R773
C743C742
R751
R774R799
C77
4
C77
2
C75
2
C74
1
C74
8
C74
0
C74
6
C74
9
C74
7
C74
4C
750
C78
1C
773
C71
8
C77
1C
719
C74
5
14
5
C776
J704
8
1
16 9
8
JW714
6-15. PRINTED WIRING BOARD – PANEL SECTION – • See page 21 for Circuit Boards Location.
Ref. No. Location
D701 A-9D702 B-2D703 B-2D704 A-2D705 A-2D706 B-9D707 H-3D708 F-4D709 G-7D710 G-7D711 G-7D712 C-6D713 C-4D714 B-8D715 B-8D716 B-2D717 B-2D718 A-2D719 A-2D720 B-9D721 D-3
IC701 B-5IC702 D-7IC703 C-6IC704 B-8SEN701 A-7
Q701 A-8Q702 B-3Q703 B-3Q704 B-3Q705 B-3Q706 B-8Q707 F-3Q708 G-3Q709 G-6Q711 B-6Q712 G-6
• SemiconductorLocation
3737
HCD-VX222
6-16. SCHEMATIC DIAGRAM – PANEL SECTION – • See page 21 for Waveforms. • See page 45 for IC Block Diagrams.
C708 C709
R747
R749
R750
R752
R753
R756C710 C711
R758C712 C713
R760C714 C715
R762
C722
C723
C724
C725
C726
C727
C728
C729
C730
C731
C732
C733
R797
R746R745
S726
R727R728R729R730R731R732R733R734R735R736R737
S727S731S732S733S734S735S736S738
S713
R714R715R716R717R718R719R720R721
S714S715S716S717S718S719S720S721
R703R704R705R706R707R708R709R710R711
S704S705S706S707S708
S709S710
R713
R726
S725
R725
S724S723
R702
R722 R723 R724
C735
C734
JW70
6
C720
R765RES701
C716
C721
S728S729S730S737
C704C705
R769
R796
R805R806
C778
C779
R743
R744
R741
R742
JW713
CN714
R755
JW70
8
C701
C702
R701
R748
CN715
C703
C770
D702
Q702
D716
Q703
D717
D703
Q704
D718
D704
Q705
D719
D705
Q706
D720
D706
D701
Q701
C777
J705CN174
WIRE701
WIRE704
WIRE702
C736
C737
CN711
D721FB7010uH
D713
Q709
Q707
Q708
D707
D709
CN712
S712
R768
R764
R763
R761
R759
R757
WIRE703
R740
S701
C775
D708
CN713
JW712
JW711
C771
R751C773
C774
R800C719D714
R799C718
C772
C781D715
R801
R793 C768
C769 R794
C754
R784C756 R783
R787
C759
C738
R772
C739
R771
R770
Q711
C766
IC702(2/2)
IC702(1/2)
R790
C763R791
R792
RV703
C762
C761
R789
C760
R788C758
R776
D712C746
R777
RV702
C750
R779 R780
R781C749C751
C764R795
C753
R782C752
R778
C747
C744
R775C745
R774 R773
C743C742
C740
C741
IC703
C748
C757R785
C755R786
JW704
JW705
C767
JW709
JW70
7
C780
J703
J702
S702
C776
R738
C707
C706
JW714
S703
D711
R804
Q712
J701
WRE703
S722
S711
100p 100p
10k
10k
10k
10k
10k
100100p 100p
100100p 100p
100100p 100p
100
100p
100p
100p
100p
100p
100p
100p
100p
100p
100p
100p
100p
330
3303303304705606801k1.2k1.8k2.7k3.3k4.7k6.8k
3304705606801k1.2k1.8k2.7k
4705606801k1.2k1.8k2.7k3.3k4.7k
270
270
10k
330
3.3k 4.7k 6.8k
0.01
0.01
0.01
1M5MHZ
0.022
4710V
4710V
0.001
47
47
180120
0.1
0.1
27k
27k
10k
10k
10k
3350V
3350V
270
10k
0.01
0.1
SEL5955A
DTC114ESLED
DRIVE
SEL5955A
DTC114ESLED
DRIVE
SEL5955A
SEL5955A
DTC114ESLED
DRIVE
SEL5955A
SEL5955A
DTC114ESLED
DRIVE
SEL5955A
SEL5955A
DTC114ESLED
DRIVE
SEL5955A
SEL5955A
SEL223C
DTA124ESLED
DRIVE
0.1
0.001
0.001
30P
1SS133T
1SS133T
DTC114ESLED
DRIVE
DTC114ESLED
DRIVEDTC114ES
LEDDRIVE
SEL5223S
SEL5923A
13P
100
10k
10k
10k
10k
10k
820.01
SEL5223S
1050V
47k
4710V
47010V
10k68p1SS133T
470.01
1050V
100p1SS133T
75
10k 0.01
1k
47p
100k0.001 1k
47k
220p
10010V
10k
10010V
15k
1k
2SC2785BUFFER
1050V
M5218AFP-T E2
M5218AFP-TE2
180k
2.250V 100
100k
50k
100p
47p
10k
2.250V
1000.150V
270
RD5.1ESB247
10V
120k
50k
0.001
22k 22k
22k0.0680.0068
2.250V15k
0.047
15k1
50V
47k
0.15
0.068
22k1
50V 22k 22k
0.0010.068
0.4750V
0.4750V
M65850FP
4716V
0.0110k
0.2250V 1k
0.1
0.1
0.1
2.2k
0.001
0.001
SEL5923A
330
DTC 114ESLED
DRIVE
6
13
14
7
8
9
10
21 22 26 28 29
30 31 32 33 34
37 38 39 4041
42
43
44
45
46
47
48
49
50
51
52
53
54
55
56
57
58
6162636465666768697071727374757677787980
68 67 66 65 64 63 62 61 58 57 56 55 54 53 52 51 50 49 48 47 46 45 44 43 42 41 40 39 38 37 69 70 71 72 73 74 75 76 77 78 79 80
69 70 71 72 73 74 75 76 77 78 79 80
31 32 33 34 30
21 22 2628 29
6
789
10
13
14
17
17
35
35
*50V
1
5
10
15
20
25
30
OP2O
UTVCC
CLOC
K
REF
OP2I
N
LPF2
IN
LPF2
OUT
GND
CC2
CC1
OP1I
N
OP1O
UT
LPF1
OUT
LPF1
IN
NCNCECHO AMP
ECHO LEVEL
IC701
DISPLAYCONTROL
GND
VFVP
VFVFGND
GAME LGAME GNDGAME R
POWER ONVIDEO SWPOWER KEYDISPLAY KEYM RESETREMOTE INS BSYS CLKS OUTS INNO USELED GNDMIC +12VMIC SIGMIC GNDHP RHP GNDHP LD GNDEVER +5V+5V(SW)
DISC 1DISC 2DISC 3 DISK SKIP
CD SYNCREC PAUSE/START
EFFECT ON/OFF P.FILE ENTERPLAY MODE
STEREO/MONOREPEAT
DIRECTION DISPLAY
TAPE A/B TUNER/BAND CD
4
3
2
1
87
6
5
(CHASSIS)
(CHASSIS)
(CHASSIS)
KEY1
KEY0
VSS
AVDD
VDD
DVD5
.1
LED
LED
LED
LED
LED
LED
LED
LED
NC S29
S28
S27
S26
VLOOD
VDD2
S8
S9
S10
S11
S12
S13
S14
S15
S16
S17
S18
S19
S20
S21
S22
S23
S24
S25
G0 G1 G2 G3 G4 G5 G6 G7 G8 G9 G10
G11 S0 S1 S2 S3 S4 S5 S6 S7
VDD
VSS
X1
X2
IC
RESET
S
S
S
SBSY
NC
NC
VOL
VOL
NC
NC
HEADPHONE
AVSS
NC
KEY2
FLUORESCENTINDICATOR
TUBE
FLD1
(CHASSIS)
MD(VIDEO) TAPE A/B CD TUNER/BAND GAME
I/
VIDEOOUT
R
L
VIDEO
AUDIO
GAME
VR701ROTARY
ENCODER
VOLUME
SEN701NJL64H400A-1
REMOTECONTROL
RECEIVERGAME
GROO
VE
GROOVEKARAOKE PON
KARAOKE PON EX-CHANGEOPEN/CLOSE
MOVIE EQ MUSIC EQ GAME EQ TUNER MEMORY/EDIT
SPECTRUM
+ -
UPD780232GC-031-8BT
MICAMP
MIC LEVEL
I/
RECPAUSE/START ENTER
VIN1
SW1
VIN2
SW2
GND
VOUT
VCC
VIN3
IC704NJM2244M
VIDEOSELECTOR
(CHASSIS)
MIC1
MIC2
*C7690.1
0.22E91EXCEPT E91
GROOVE
PHONES
INPUT
MD/(VIDEO)
PICTURE EFFECT
BOARDMAIN
(4/5)
BOARDVIDEO
CN701(Page 32)
(Page 41)CN301
3838
HCD-VX222
6-17. PRINTED WIRING BOARD – TRANS SECTION –
Ref. No. Location
D901 C-4D902 B-3D903 B-2D904 B-3D905 B-2D911 E-6D912 E-7D913 F-8
IC901 C-2
Q901 C-3Q911 F-7
• SemiconductorLocation
• See page 21 for Circuit Boards Location.
CPOWER AMP
BOARD(Page 34)
11(13)1-681-444-
11(13)1-681-445-
SUB TRANS BOARD
TRANS BOARD
E
B
T911POWER TRANSFORMER
S901VOLTAGE
SELECTOR
240V
220-
230V
120V
E91,
TH
E91,
TH
E91,TH
E,EA,IA,SP,TW
E,EA,IA,SP,TW
AC IN
1
2
3
4
1234
2 3 4 5 6 7 8
A
1
B
C
D
E
F
1
13
3
1
3
E
E91,TH
E,EA,IA,SP,TW
E,EA,IA,SP,TW
E,EA,IA,SP,TW
E,EA,IA,SP,TW
3939
HCD-VX222
6-18. SCHEMATIC DIAGRAM – TRANS SECTION –
C902C903
D902D903
D904D905
JW3
JW4
JW911
JW912
R919
R911
R912 R913
R915
R916
R905
C911
C912
C913
D911
C915
CN3 CN2
R902
JW6
S901
JW1
T901CN903CN913
D912
CN901
D901
RY901
F914
F920
R920
Q911
D913
CN915
Q901
F919
C901
220016V
10016V
11ES211ES2
11ES211ES2
0.33 1/4W
11/4W
1k 10k
100
100
100
22063V
1050V
10050V
11ES2
0.1
10k
3P3P
MTZJ-30B
2P
1SS133T
T6.3AL/250V
T6.3AL/250V
0.33 1/4W
2SA1932-30V REG.
RD5.
6ESB
2
13P
2SC2785
T4AL/250V
0.01250V
STBY RELAY
EVER +5.7V
D GND
STBY RELAY
EVER +5.7V
D GND
5.6 9
-28.1 -40
-28.7
0.60.2
IC901
AC IN
+5.7V REG
POWERTRANSFORMER
T911
AC4AC4
AC3
AC3
VFVF
VP
D GND
EVER +5VSTBY RELAY
AC1
GNDAC1
VOLTAGE SELECTOR
120V
220-230V
240V
CN3
CN2
POWERTRANSFORMER
TA78057S
RELAYDRIVER
E91,TH
E,EA,IA,SP,TW
2P:E91,TH
4P:E,EA,IA,SP,TW
2P:E91,TH
4P:E,EA,IA,SP,TW
E,EA,IA,SP,TW
E,EA,IA,SP,TW
E,EA,IA,SP,TW
E91,TH
BOARDPOWER AMP
CN501(Page 35)
4040
HCD-VX222
6-19. PRINTED WIRING BOARD – VIDEO CD SECTION – • See page 21 for Circuit Boards Location.
2
1
22
23
TOPANELBOARD
(Page 36)
3 2 1
1313
13
13
H
G
E
1 2
A
B
C
D
E
F
G
3 4 5 6 7 8 9 10
(Page 26)
(Page 28)
E C B E C B
E C B
Ref. No. Location
D501 C-2
IC101 F-4IC301 B-9IC302 B-9IC303 B-4IC304 B-7IC501 D-8IC502 E-9IC504 E-4IC505 C-3IC506 D-7IC507 C-4IC509 E-5
Q501 C-3Q502 C-2Q531 C-9
• SemiconductorLocation
4141
HCD-VX222
6-20. SCHEMATIC DIAGRAM – VIDEO CD SECTION (1/2) –
CN3013P
PANELBOARDCN713
(Page 37)
M30620MCA-B22FP
1
3
33
MAIN BOARD(5/5)
CN102
1
23
4
5
IC B/DIC B/D
IC B/D
G
(Page 42)
E
BD BOARDCN101
(Page 27)
H
CN501
• See page 21 for Waveforms.• See page 46 for IC Pin Function Description.• See page 51 for IC Block Diagrams.
4242
HCD-VX222
6-21. SCHEMATIC DIAGRAM – VIDEO CD SECTION (2/2) –
IC506MT23C020-H001S
C5616p
50VCH
10p
IC B/D
6
7
8
9
q;
qa
qs
qd
qf
(Page 41)
• See page 21 for Waveforms.• See page 51 for IC Block Diagrams.
43
HCD-VX222
6-22. IC PIN FUNCTION DESCRIPTION• MAIN BOARD (4/5) IC401 M30622MAA-A98FP (MASTER CONTROL)
Pin No.
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32
33
34
35
36
37
38
39
40
41
42
43
44
45
46
47
48
49
50
I/O
O
O
I
I
O
O
O
—
—
I
O
I
O
—
I
I
I
I
I
I
I
O
I
I
O
O
I
O
O
O
—
I
I
I
O
—
O
O
O
O
O
O
O
O
O
I
I
I
I
—
Description
Serial data output the display control.
Serial clock output from main controller.
Busy signal input from the display control. “L” : busy
Pemoto commander input.
Data signal output for IC301(BH3878KS2)
Latch signal output for IC301(BH3878KS2)
Clock signal output for IC301(BH3878KS2)
Connected to ground.
Connected to ground.
SUB SYSTEM CLOCK input.(32.768MHz)
SUB SYSTEM CLOCK output.(32.768MHz)
System reset input.
MAIN SYSTEM CLOCK output.(16MHz)
Connected to ground.
MAIN SYSTEM CLOCK input.(16MHz)
Power supply.(+5V)
PULL UP.(EVER+5V)
AC CUT ON(L)/OF(H) CHECK.
CD Q-data request signal input.
RDS interrupt signal input.
RDS data signal input.
Tuner mute signal output.
STEREO detect signal input.L=ON,H=OFF
TUNER detect signal input.L=ON,H=OFF
TUNER chip eneble output.
TUNER data output.
TUNER data input.
TUNER clock signal output.
I2C SCL output.
I2C SDA output.
Not used.
Subcode Q data input(CD data).
Subcode Q clock input(CD clock). (Not used)
BD condition signal input. (Connected to ground)
CD data output. (Not used)
Not used.
CD clock output. (Not used)
CD-POWER ON/OFF signal output.H=ON,L=OFF
Not used (open).
HOLD signal output. (Not used)
Micom reset signal output to the display control. “L” : reset
CD latch signal output. (Not used)
CD reset signal output.
Loading motor control signal output (Loading).
Loading motor control signal output (un Loading).
Tray open detect signal input.
Tray close detact signal input.
Pick-up up/down detect signal input.
CD table detect signal input.
Not used.
Pin Name
S-OUT
S-CLK
S-BSY
REMOTE IN
3878-DAT
3878-LAT
3848-CLK
BYTE
CN VSS
XC IN
XC OUT
RESET
X OUT
VSS
X IN
VCC
NMI
AC-CUT
SCOR
RDS-INT
RDS-DATA
ST-MUTE
STEREO(IN)
TUNED
ST-CE
ST-DOUT
ST-DIN
ST-CLK
I2C CLK
I2C DATA
NO USE
SQ-DAT IN
SQ-CLK
SENS
CD-DAT OUT
CAN’T-USE
CD-CLK
CD-POWER
CLOCK-OUT
HOLD
M-RESET
XLT
XRST
LOAD-IN
LOAD-OUT
OPEN
CLOSE
UP/DOWN
T-SENS
GAME/DVD
44
HCD-VX222
Pin No.
51
52
53
54
55
56
57
58
59
60
61
62
63
64
65
66
67
68
69
70
71
72
73
74
75
76
77
78
79
80
81
82
83
84
85
86
87
88
89
90
91
92
93
94
95
96
97
98
99
100
I/O
—
—
—
—
—
—
O
O
O
O
O
I
I
—
O
I
I
I
I
I
I
I
O
O
O
O
O
O
O
O
O
O
O
O
I
O
O
O
O
O
I
I
I
—
I
—
O
—
—
I
Description
Not used.
Not used.
Not used.
Not used.
Not used.
Not used.
Surround control signal output.
Surround control signal output.
Surround control signal output.
A deck trigger control signal output.H=ON,L=OFF
B deck trigger control signal output.H=ON,L=OFF
Power supply.(+5V)
Not used.
Connected to ground.
Capstan motor REV/FWD/STOP control signal output.H=REV,L=FWD/STOP
Detection input from the deck-B rec forward detect switch. “L” : rec
Detection input from the deck-B rec reverse detect switch. “L” : rec
A deck hafe detect signal input.
B deck hafe detect signal input.
A deck play detect signal input.
B deck play detect signal input.
AMS signal input.L=ON,H=OFF
DISPLAY KEY control signal output.
POWER KEY control signal output.
BIAS ON/OFF signal output.H=ON,L=OFF
Playback deck A/B select signal output.H=High,L=Normal
Tape deck relay ON/OFF signal output.H=ON,L=OFF
PB mute ON/OFF signal output .H=ON,L=OFF
REC mute ON/OFF signal output .H=ON,L=OFF
Serial data latch pulse output to BH3878KS2 (IC301)
Serial data latch pulse output to BH3878KS2 (IC301)
Serial data latch pulse output to BH3878KS2 (IC301)
Line mute signsl output.L=ON,H=OFF
Power amplifier mute ON/OFF signal output.H=ON,L=OFF
Speaker protect signal input.L=ON,H=OFF
STANDBY relay control signal output.
Rear speaker relay control output.
Front speaker relay control output.
A deck reel pulse detect signal output.
B deck reel pulse detect signal output.
SP/VACS (tape) select signal input.
Destination setting terminal.
Version select signal input.
Not used
Tape recording level input.
Connected to ground.
POWER ON/OFF signal output.H=ON,L=OFF
Analog reference voltage.
Power supply.(+5V)
Serial data input the display control.
Pin Name
NO USE
CENT-MUTE
REAR-MUT
494-DAT
494-CLK
494-LT
SUR1
SUR2
SUR3
A-TRG
B-TRG
VDD
SOFT TEST
VSS
CAMP-CONT
B-REC FWD
B-REC REW
A-HAFE
B-HAFE
A-PLAY
B-PLAY
AMS-IN
DISPLAY KEY
POWER-KEY
BIAS
PB-A/B
TC-RELAY
PB-MUT
REC-MUT
SP-LATA
SP-LATB
SP-LATC
LINE-MUT
STK-MUT
PROTECT
STB-RELAY
REAR-RELAY
FRONT-RELAY
A-SHUT
B-SHUT
SP/VACS
MODE IN
SPEC-IN
VIDEO SW2
VACS
AVSS
POWER-KEY
AV-REF
AVCC
S-IN
45
HCD-VX222
Pin No.
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20 - 22
23
24
25
26
27
28
29
30
31
32
33
34
35
36
37 - 58
59
60
61 - 67
68 - 80
I/O
I
—
O
I
—
I
I
I
O
O
—
—
I
I
—
—
I
—
—
I
—
I
I
O
O
O
O
O
O
O
O
O
—
—
O
I
I
O
O
Description
Power supply.(+5V)
Connected to ground.
System clock output terminal.(5MHz)
System clock input terminal.(5MHz)
Connected to ground.
Reset signal input from main controller.
Serial clock input from main controller.
Serial data input from main controller.
Serial data output from main controller.
Busy signal output.
Not used.
Not used.
VOLUME A signal input.
VOLUME B signal input.
Not used.
Not used.
Headphone detect signal input. H=ON,L=OFF
Connected to ground.
Not used.
KEY input.(AD)
Connected to ground.
Power supply.(+5V)
Power supply.(+5V)
KARAOKE LED driver output.
GROOVE LED driver output.
ENTER LED driver output.
REC LED driver output.
GAME LED driver output.
MD(VIDEO) LED driver output.
TAPE LED driver output.
CD LED drover output.
TUNER LED driver output.
Not used.
Not used.
FL segment signal output.
Power supply.(+5V)
Power supply (-30V) at FL driver.
FL segment signal output.
FL gride output.
Pin Name
VDD
VSS
X1
X2
IC
RESET
S-CLK
S-IN
S-OUT
SBSY
NO USE
NO USE
VOL-A
VOL-B
NO USE
NO USE
HEADHONE
AVSS
NO USE
KEY2-KEY0
VSS
AVDD
VDD
DV5.1-LED
PRO-LED
ENTER-LED
REC-LED
GAME-LED
MO/VIDEO-LED
TAPE-LED
CD-LED
TUNER-LED
GROOVE
NO USE
S29-S8
VDD2
VLOOD
S7-S0
G11-G0
• PANEL BOARD IC701 UPD780232GC-031-8BT (DISPLAY CONTROL)
46
HCD-VX222
VIDEO BOARD IC502 M30620MCA-B22FP (CD MECHANISM CONTROLLER)
Pin No.
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32
33
34
35
36
37
38
39
40
41
42, 43
44
45
46
47
48
49
50
51
I/O
I
O
O
O
O
O
I
I
—
O
O
I
O
—
I
I
I
I
O
I
O
O
I
O
I
O
O
O
I/O
I/O
O
I
O
O
O
I
O
O
I
O
I
O
I
I
O
O
O
O
O
I
Description
Internal status (SENSE) signal input from the CXD3008Q (IC101)
Sense serial data reading clock signal output to the CXD3008Q (IC101)
Y resolution output
Chroma level output
Serial data transfer clock signal output to the CXD3008Q (IC101)
Not used (open)
Remote control signal input terminal. Not used (open)
External data bus line byte selection signal input “L”: 16 bit, “H”: 8 bit (fixed at “L”)
Ground terminal
Muting on/off control signal output to the CXD3008Q (IC101) “H”: muting on
Clock selection signal output to the CXD3008Q (IC101) “L”: 16.9344 MHz (double speed), “H”: 33.8688 MHz
Reset signal input from the system controller (IC501) “L”: reset
For several hundreds msec. after the power supply rises, “L” is input, then it changes to “H”
Main system clock output terminal (10 MHz)
Ground terminal
Main system clock input terminal (10 MHz)
Power supply terminal (+5V)
Non-maskable interrupt input terminal (fixed at “H” in this set)
Subcode sync (S0+S1) detection signal input from the CXD3008Q (IC101)
Not used (open)
Interrupt request signal input from the host MPU (IC505)
Video CD select data of the host MPU (IC505)
Serial data latch pulse output to the D/A converter (IC509) “L” active
Ready signal input for communication to the host MPU (IC505)
Reset signal output to the MPEG video/audio decoder (IC505) “L”: reset
Horizontal sync signal input
Burst gate pulse signal output
AGC hold signal output
Laser power selection signal output to the CXA2568M (IC103) “H”: laser on
I2C clock signal from CD mechanism control (IC501).
I2C data signal from CD mechanism control (IC501).
Serial data output to the MPEG video/audio decoder (IC506) and D/A converter (IC509)
Serial data input from the MPEG video/audio decoder (IC506)
Serial data transfer clock signal output to the MPEG video/audio decoder (IC506) and D/A converter (IC509)
RTS signal to serial port (check connector).
Not used (open)
Sub-code Q data input from the CXD3008Q (IC101)
Sub-code Q data reading clock signal output to the CXD3008Q (IC101)
Power on/off control signal output terminal. Not used (open)
Ready signal input terminal. Not used (fixed at “H”)
Not used (open)
Hold signal input terminal. Not used (fixed at “H”)
Not used (open)
OSD language select input terminal “H”: English, “L”: China
Vertical sync signal input
Bus write signal output.
Not used (open)
Audio muting on/off control signal output terminal “L”: muting on. Not used (open)
Loading motor drive signal output terminal. Not used (open)
Loading motor drive signal output terminal. Not used (open)
Disc detection (load in) switch input terminal. Not used (fixed at “H”)
Pin Name
SENSE
SENSE CLK
RESOLUTION
CHROMA LEVEL
DSP CLK
TSENS
REMOTE IN
BYTE
CN VSS
DSP MUTE
CTRL1
XRESET
XOUT
VSS
XIN
VCC
NMI
SCOR
DSENS
CL680 HINT
CL680 HSEL
DF LATCH
CL680 HRDY
CL680 RESET
H.SYNC IN
BGP
LPH
LD ON
12C.CLK
12C.DATA
DATA1O
DATA1I
CLK1
RTS1
XVLEVEL.DOWN
SUBQ DATA
SUBQ CLK
P.ON
BUS XRDY
BUS
BUS XHOLD
BUS
OSD.LANGUAGE
VSYNC
BUS XWRL
LO.BOOST
AUDIO MUTE
LOAD OUT
LOAD IN
INSW
47
HCD-VX222
Pin No.
52
53
54
55
56
57 to 59
60, 61
62
63
64
65
66 to 72
73
74
75
76
77
78
79
80
81 to 88
89
90 to 92
93
94
95
96
97
98
99
100
I/O
I
I
I
—
—
—
—
I
—
—
O
O
O
I
I
I
O
O
O
O
I/O
—
I
I
—
O
—
O
I
I
—
Description
Disc detection (load out) switch input terminal. Not used (fixed at “H”)
Destination setting terminal (fixed at “L”)
Destination setting terminal (fixed at “L”)
Not used (open)
Not used (open)
Not used (open)
Not used (open)
Power supply terminal (+5V)
Not used (open)
Ground terminal
Video muting on/off control signal output
Address signal output for the external device. Not used (open)
LED drive signal output for the self diagnosis indicator (D502) Normally: “L” (LED on)
Setting terminal for the test mode 1 (for VCD check) Normally: fixed at “H” (“L”: test mode)
Setting terminal for the test mode 2 (for SERVO check) Normally: fixed at “H” (“L”: test mode)
Setting terminal for the test mode 3 Normally: fixed at “H” (“L”: test mode) Not used (fixed at “H”)
System reset signal output to the CXD3008Q (IC101), BA5974FP (IC102) and D/A converter (IC509) “L”: reset
Standby on/off control signal output terminal. Not used (open)
Chip select signal output terminal. Not used (open)
Blank control signal output terminal. Not used (open)
Two-way data bus with the external device. Not used (open)
Not used.
Key input terminal. Not used (fixed at “H”)
Video system select input terminal (open: AUTO)
Not used.
Serial data output to the CXD3008Q (IC101)
Ground terminal (for A/D conversion)
Serial data latch pulse output to the CXD3008Q (IC101)
Reference voltage (+5V) input terminal (for A/D conversion)
Power supply terminal (+5V) (for A/D conversion)
Not used.
Pin Name
OUTSW
MODEL1
MODEL2
TBLL
TBLR
ENC1 to ENC3
VCC
VSS
V.MUTE
A6 to A0
TEST LED
TEST1
TEST2
TEST3
DEVICE RESET
STANDBY
FL CS
FLBLK
D7 to D0
MIC CTRL
KEY1 to KEY3
NT/PAL
MUSIC VOL
DSP DATA
AVSS
DSP LATCH
VREF
AVCC
AMP ON
48
HCD-VX222
IC101 CXD3008Q (BD BOARD)
6-23. IC BLOCK DIAGRAMS
26 27 28 29 30 31 32 33 34 35 36 37 38 39 40
TES1 SEFEVC
TFDR
DVSS
1
FRDR
FFDR
TRDR
SRDR
SFDR
DVDD
1
FST0
SSTP
TES1
80 79 78 77 76 75 74 73 72 71 70 69 68 67 66
XTSL
PCM
DBC
KEM
PH
XOLT
XTA1
XTA0
SOUT
SOCK
SQSO
SQCK
SCSY
EXCK
EXCK
DVSS
2
12
3
4567
89101112131415
1617
18
19
202122
232425
XRSTVDD
MDPLOCK
PWM1
DFCTMIRR
COUT
DVSS
WDCK
FDK
SCORC2P0
XPCKXUGFWFCKATSK
SENSCLOKXLATDATA
SENSCLOKXLATDATA
MUTE
SCLK
GFS
C4M
63
62
61
605958
57
56
55545352
51
504948
65
64
47
464544434241
LRCK
DOUT
VPC0
ASYE
MD2
FIL0CLTV
ASY0ASY1RFAC
AVSS1
FIL1PCO
DVDD2
BIAS
V16M
CETE
RFDCAD10AVSS01GEN
AVDD
CLOCK GENERATOR
ASYMMETYCORRECTOR
DIGITALPLL
EFMDEMODURATOR
DIGITALPLL
CPUINTERFACE
SERVOAUTO
SEQUENCER
SERVOINTERFACE SUB
CODEPROCESSOR
DIGITALOUT
ERRORCORRECTOR
32KRAM
D/AINTERFACE
MIRRDFCTFOK
OP AMP
ANALOGSW
A/DCONVERTER
FOCUS SERVO
TRACKINGSERVO
SERVO DSP
SLED PWMGENERATOR
TRACKING PWMGENERATOR
FOCUS PWMGENERATOR
PWM GENERATOR
SLED SERVO
49
HCD-VX222
IC103 CXA2568M-T6 (BD BOARD)
11
12
10
VC
VC
VC
VC
VCVC
VC
VCC
VCC
RF SUMMING AMP RF_EQ_AMP
ERROR AMPFOCUS
TRACKINGERROR AMPVC BUFFER
VCC
VCC
VC
VC
VC
VC
VEE
VEE
VEE
VEE
VEE
VREF
13
14
15
6
5
1
2
3
4
7
8
9
16
19
2021
2223
24
1817
HOLD
LD
PD
A
B
C
D
VEE
F
E
VC
AGCVTH
AGCCONT
VCC
LC/PDLD_ON
HOLD_SW
RF_BOT
RFTCRF_1RFO
RFE
FE
TE
(50%/30%OFF)
APC PD AMP
APC LD AMP
IC102 BA5982FM (BD BOARD)
IC102 LC72130 (MAIN BOARD)
1 2 3 4 5 6 7 8
XIN
B03CE IF
IN
AOUT
2
AIN1
AIN2
D1 CL B04D0 B01
I01
B02
XOUT
PD1
VSS
PD2
FMIN
AMIN
AOUT
1
VDD
I02
B05
9 10 11 12
131415161718192021222324
PHASE DETECTORCHARGE PUMP
SWALLOW COUNTER1/16.1/17 4bits
SWALLOW COUNTER1/16.1/17 4bits
POWERON
RESET1/2
C BI / F
REFERENCEDIVIDER
REFERENCEDIVIDER
C BI / F
2 DATA SHIFT REGISTERLATCH
2
3
1
5OPIN2 +
6OPIN2 –
7OPOUT2
8GND
9STBY1
4
BIAS IN
OPIN1 +
OPIN1 –
OPOUT1
11
12
13
14
10PowVcc1
VO2 (–)
VO2 (+)
VO1 (–)
VO1 (+)
OPIN3 +
OPIN3 –
OPOUT3
GND
STBY2
PreVcc
OPIN4 +
OPIN4 –
OPOUT4
PowVcc2
VO3 (–)
VO3 (+)
VO4 (–)
VO4 (+)
Vcc
STAND BYCH1 2 3
LevelShift
LevelShift
LevelShift
Vcc
STAND BYCH4
Vcc
LevelShift
27
26
28
24
23
22
21
20
25
18
17
16
15
19
10k
10k
10k
10k
10k
10k 10k 10k
10k10k
10k
10k
10k
10k
20k
10k
10k10k10k
10k 10k
10k
10k 10k
50
HCD-VX222
IC101 BA1450 (MAIN BOARD)
IC701 BA6956AN (DRIVER BOARD)
CH2/A CH2/B NF VCC CG NF ALCMETAL
OUTPREOUT
TAPE A/TAPE B
RECOUT
RECIN
CH1/A CH1/B NF GND1 M/H NF
CH2CH2
ALC
M/N
CH1
GNDGND
CH1+–
+–
+– +
–
A/B
GNDMETALOUT
PREOUT
MIXOUT
RECOUT
RECIN
IREFVREF2
VREF1
24 23 22 21 20 19 18 17 16 15 14 13
1 2 3 4 5 6 7 8 9 10 11 12
1 2 3 4 5 6 7 8 9
CONTROL LOGIC
TSD
VREF
OUT2
OUT1
RNF
VM VCC
FIN
GND
RIN
1 2 3 4 5 6 7 8 9 10 11 12
161718192021222324 15 14 13
AMOSC
AMMIX
AM IF
FMIF
FMDET
AMDET
SDDET
AGC
LEDDRIVER COMP
SD
SW
VCO
PD
1/2
DECODER
VREG
1/2
FM IN
FM D
ET
TUNE
D
STER
EO
IF O
UT
R OU
T
L OU
T
AM/F
M
FM/A
M D
ET O
UT
AM M
PX IN
FM M
PX IN
IN R
EQ M
UTE
FM S
D AD
J
VCC
GND
AM O
SC O
UT
AM O
SC
VCO
STOP
AM R
F IN
AM IF
IN
AM A
GC
AM M
IX O
UT
FM B
AND
WID
TH
V . R
EG
IC201 TA8189N (MAIN BOARD)
51
HCD-VX222
IC303 NJM2209M (VIDEO BOARD)
IC302 NJM2255M (VIDEO BOARD)
IC304 BA7665FS-E2 (VIDEO BOARD)
IC509 PCM1727E-2/T2 (VIDEO BOARD)
1 2 3 4 5 6 7
14
VIDE
OOU
TPUT N.
C
N.C
N.C
GND
N.C
V +
CONT
ROL
N.C
DIFF
EREN
TIAT
ION
INPU
T
VIDE
OIN
PUT
PHAS
EDE
LAY
DIFF
EREN
TIAT
ION
OUTP
UT
13 12 11 10 9 8
FREQ
UENC
YCH
ARAC
TERI
STIC
COM
PENS
ATIO
N
LPF
SWITCHCONTROL
SECONDARYDIFFERENTIATION
GAIN ADJ
LOWERLIMITER
(1)
LOWERLIMITER
(2)
CLAMP
(SYNC)CHIP
1
15
16
2
3
4
5
6
7
8 9
6dB 75Ω
6dB 75Ω
6dB 75Ω
20k
MUTEA
INA
GND
GND
GND
N.C.
INB
MUTEBCHROMA MUTE
MUTE VCC1
OUTA1
OUTA2
VCC2
MIXOUT1
MIXOUT2
N.C.
OUTB
14
13
12
11
10
7
1 2 3 4
568
TINT
GND
V+BG
P
COLO
R
V IN
COLO
ROF
FSET
H
L
VOUT
HUE ADJ
SATURATION ADJ(COLOR MAIN)
SATURATION ADJ(COLOR BURST)
1
23
456
78910
11
12
24
23222120
19
18
17
16
POWERSUPPLY
CLOCK MANAGER•
DUAL PLL
AUDIODATA INPUTINTERFACE
8 TIME OVERSAMPLING DIGITAL
FILTER•
FUNCTIONCONTROL
MODECONTROL
MULTI LEVEL ∆Σ
MODULATOR
MULTI LEVEL ∆Σ
MODULATOR
5 LEVELDAC
5 LEVELDAC
CR LPF•
OUTPUTAMP
CR LPF•
OUTPUTAMP
BPZCONTROL
13
OPEN
XT1
PGNDVCP
NCKORSV
SCKO3
MLMCMC
RSTB
VOUTR
AGND VCA
ZERO
BCK
DATA
LRCK
SCKO2SCKO1VDDDGND
XT2
384fs
15
14 VOUTL
CAP
52
HCD-VX222SECTION 7
EXPLODED VIEWS
7-1. MAIN SECTION
NOTE:• Items marked “*” are not stocked since they are
seldom required for routine service. Some delayshould be anticipated when ordering these items.
• The mechanical parts with no reference number inthe exploded views are not supplied.
• Hardware (# mark) list and accessories and pack-ing materials are given in the last of this parts list.
Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark
The components identified bymark 0 or dotted line with mark0 are critical for safety.Replace only with part numberspecified.
• AbbreviationEA : Saudi Arabia modelSP : Singapore modelTH : Thai modelTW : Taiwan modelIA : Indonesian model
CD mechanism deck
#6
#3
#3#3
#7
#7
#3
#5
4
311
1
1
2
2
front panel section
chassis section
not supplied
#3
#1
#3
#3 #3#3
#3
10
7
9
8
56
14
15
12
13
1 3-363-099-01 SCREW (CASE 3 TP2)2 3-363-099-41 SCREW (CASE 3 TP2)3 4-224-549-01 CASE (SIDE-L)4 4-234-009-41 CD DOOR…(BLACK) (E,EA,IA,SP,TH,TW)4 4-237-846-01 CD DOOR…(SILVER)
5 4-224-550-01 CASE (TOP)6 1-681-441-11 VIDEO OUT BOARD7 4-234-091-21 PANEL BACK (E,EA,IA,SP,TW)7 4-234-091-81 PANEL BACK (TH)8 4-227-984-11 COVER (DUCT)
9 1-681-445-11 SUB TRANS BOARD10 4-225-252-01 CUSHION (FOOT) (E,EA,IA,SP,TH,TW)11 X-4952-994-1 CASE (R) ASSY, SIDE12 A-4726-022-A VIDEO BOARD, COMPLETE (A)(E,EA,IA,SP)12 A-4726-025-A VIDEO BOARD, COMPLETE (A) (TW)
12 A-4726-027-A VIDEO BOARD, COMPLETE (A) (TH)13 1-769-986-11 WIRE (FLAT TYPE) (13 CORE)14 1-792-246-11 WIRE (FLAT TYPE) (23 CORE)15 4-951-620-01 SCREW (2.6X8), +BVTP
Ver 1.2 2001.09
• Color indication of Appearance PartsExample :KNOB, BALANCE (WHITE)• • • (RED)
↑ ↑Parts color Cabinet's color
53
HCD-VX222
7-2. FRONT PANEL SECTION
Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark
55
54
56
53
51
52
58
60
59
59
FLD1 not supplied
6363
69
70
57
61
62
63 *63*63 *63
*63
64 65
66
6861
67
not supplied
* For service only (Be sure to refer to "Service note" on page 4.)
51 4-234-019-11 VOLUME KNOB… (BLACK)51 4-237-847-01 VOLUME KNOB… (SILVER)52 4-234-015-01 VOL KNOB RING53 X-4953-783-1 FRONT PANEL ASSY… (BLACK)53 X-4954-351-1 FRONT PANEL ASSY… (SILVER)
54 4-225-252-01 CUSHION (FOOT) (E,EA,IA,SP,TH,TW)55 X-4953-759-1 CASSETTE WINDOW (R) ASSY… (BLACK)55 X-4954-350-1 CASSETTE WINDOW (R) ASSY… (SILVER)56 X-4953-758-1 CASSETTE WINDOW (L) ASSY… (BLACK)56 X-4954-349-1 CASSETTE WINDOW (L) ASSY… (SILVER)
57 4-231-805-01 KNOB (MIC)58 4-233-981-01 CASSETTE DOOR SPRING L59 4-224-104-01 DAMPER (E,EA,IA,SP,TW)59 4-224-104-11 DAMPER (TH)
60 4-224-562-01 BRACKET (HEART CAM L)
61 4-224-803-01 SPRING (PUSH), COMPRESSION62 4-224-560-01 CAM (L), HEART63 4-951-620-01 SCREW (2.6X8), +BVTP64 1-681-447-11 KEY BOARD65 4-234-016-01 FL HOLDER
66 A-4476-992-A PANEL BOARD, COMPLETE (E,EA,IA,SP)66 A-4725-701-A PANEL BOARD, COMPLETE (TW)66 A-4726-002-A PANEL BOARD, COMPLETE (TH)67 4-224-559-01 CAM (R), HEART68 4-224-561-01 BRACKET (HEART CAM R)
69 4-233-982-01 CASSETTE DOOR SPRING R70 1-796-123-11 DECK, MECHFLD1 1-518-729-11 INDICATOR TUBE, FLUORESCENT
Ver 1.2 2001.09
54
HCD-VX222
7-3. CHASSIS SECTION
Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark
#5#7
#4
#2
#7
#2
109
108
103
107
106
101112
102
104
105T911
EA, SP, TW
EA, SP, TW, E91
EA, IA, TH
E, IA
not supplied
110
111
The components identified bymark 0 or dotted line with mark0 are critical for safety.Replace only with part numberspecified.
101 1-773-049-11 WIRE (FLAT TYPE) (17 CORE)102 A-4476-995-A MAIN BOARD, COMPLETE (E,IA,SP)102 A-4476-999-A MAIN BOARD, COMPLETE (EA)102 A-4725-703-A MAIN BOARD, COMPLETE (TW)102 A-4726-005-A MAIN BOARD, COMPLETE (TH)
102 A-4726-272-A MAIN BOARD, COMPLETE (E91)* 103 4-988-533-01 HOLDER, PWB
104 1-769-986-11 WIRE (FLAT TYPE) (13 CORE)105 A-4476-990-A POWER BOARD, COMPLETE (E,EA,IA,SP)105 A-4725-699-A POWER BOARD, COMPLETE (TW)
105 A-4726-000-A POWER BOARD, COMPLETE (TH)105 A-4726-270-A POWER BOARD, COMPLETE (E91)
106 3-703-244-00 BUSHING (FBS001), CORD (EA,SP,TW,E91)106 3-703-571-11 BUSHING (S) (4516), CORD (TH)106 4-966-266-01 BUSHING (S) (FBS002), CORD (E,IA)
107 1-681-444-11 TRANS BOARD0108 1-777-071-81 CORD, POWER (EA,SP,TW)0108 1-790-880-11 CORD, POWER (WITH CONNECTOR) (E91)0109 1-569-008-21 ADAPTOR, CONVERSION (EA,SP,TW)0110 1-791-901-11 CORD, POWER (E,IA,TH)
0111 1-569-007-11 ADAPTOR, CONVERSION 2P (E,IA)112 4-223-777-03 CHASSIS
0T911 1-437-221-11 TRANSFORMER, POWER
55
HCD-VX222
7-4. CD MECHANISM DECK SECTION
Ref. No. Part No. Description Remarks Ref. No. Part No. Description Remarks
266
notsupplied
notsupplied
not supplied
251
252
253
254
255
256
274
275 276
269
257
259
258
258
258
258
260
261262
263
251
264
271
265
268
279
271284267
271
270
270
270
283
283
283258
M721
282
284
286
287
288
The components identified bymark 0 or dotted line with mark0 are critical for safety.Replace only with part numberspecified.
251 4-933-134-11 SCREW (+PTPWH M2.6X8)252 4-221-679-01 CAM (RELAY)253 4-231-452-01 TABLE (NEW)254 4-221-686-01 LEVER (CHANGE)255 4-221-676-01 TRAY
256 4-933-134-51 SCREW (+PTPWH 2.6X8)257 1-675-910-14 MOTOR BOARD258 4-951-620-01 SCREW (2.6X8), +BVTP259 1-791-983-11 WIRE (FLAT TYPE) (8 CORE)260 1-675-911-14 SENSOR BOARD
261 1-675-912-14 DRIVER BOARD262 X-4952-608-1 CAM (U/D) ASSY263 4-221-681-01 LEVER (EX)264 4-221-682-01 LEVER (LIFTER)265 4-221-688-01 PULLEY (B), CHUCKING
266 1-471-035-11 MAGNET ASSY267 X-4952-019-1 PULLEY (A) ASSY, CHUCKING268 X-4951-889-1 HOLDER (BU) ASSY269 4-222-095-01 BELT
270 4-227-045-11 SPRING (INSULATOR), COIL
271 4-985-672-01 SCREW (+PTPWH M2.6), FLOATING274 4-221-678-01 CAM (CONTROL)275 4-221-683-01 GEAR (U)276 4-221-685-01 PULLEY (S)279 4-227-899-01 SCREW (DIA. 12), FROATING
282 4-222-097-01 SCREW, STEP283 4-227-549-11 INSULATOR284 4-231-151-01 STOPPER (BU)
0286 8-820-116-01 DEVICE,OPTICAL KSM-213DCP/Z-NP287 A-4725-001-A BD BOARD, COMPLETE (E91,TH)
287 A-4725-003-A BD BOARD, COMPLETE (E,EA,IA,SP,TW)288 1-782-817-11 WIRE (FLAT TYPE) (16 CORE)M721 A-4672-826-A MOTOR ASSY
56
Ref. No. Part No. Description Remarks Ref. No. Part No. Description Remarks
HCD-VX222SECTION 8
ELECTRICAL PARTS LIST
Ref. No. Part No. Description Remarks Ref. No. Part No. Description Remarks
NOTE:• Due to standardization, replacements in the
parts list may be different from the partsspecified in the diagrams or the componentsused on the set.
• -XX, -X mean standardized parts, so theymay have some difference from the originalone.
• Items marked “*” are not stocked since theyare seldom required for routine service.Some delay should be anticipated whenordering these items.
• CAPACITORS:uF: µF
• RESISTORSAll resistors are in ohms.METAL: metal-film resistorMETAL OXIDE: Metal Oxide-film resistorF: nonflammable
• COILSuH: µH
• SEMICONDUCTORSIn each case, u: µ, for example:uA...: µA... , uPA... , µPA... ,uPB... , µPB... , uPC... , µPC... ,uPD..., µPD...
• AbbreviationEA : Saudi Arabia modelSP : Singapore modelTH : Thai modelTW : Taiwan modelIA : Indonesian modelE91 : 220VAC model
BD
When indicating parts by referencenumber, please include the boardname.
The components identified bymark 0 or dotted line with mark0 are critical for safety.Replace only with part numberspecified.
1-675-911-14 ADDRESS SENSOR BOARD*******************
< CAPACITOR >
C712 1-164-159-21 CERAMIC 0.1uF 50V
< IC >
IC711 8-749-014-38 PHOTO INTERRUPTER SG-264
< RESISTOR >
R711 1-247-876-11 CARBON 75K 5% 1/4WR712 1-249-409-11 CARBON 220 5% 1/4W FR713 1-249-429-11 CARBON 10K 5% 1/4W
< SWITCH >
S711 1-771-821-11 SWITCH, PUSH (1 KEY) (UP/DOWN)******************************************************
A-4725-001-A BD BOARD, COMPLETE (E91,TH)A-4725-003-A BD BOARD, COMPLETE (E,EA,IA,SP,TW)
************************
< CAPACITOR >
C101 1-163-005-11 CERAMIC CHIP 470PF 10% 50VC102 1-163-038-00 CERAMIC CHIP 0.1uF 25VC103 1-163-005-11 CERAMIC CHIP 470PF 10% 50VC105 1-126-206-11 ELECT CHIP 100uF 20% 6.3VC106 1-164-346-11 CERAMIC CHIP 1uF 16V
C107 1-164-346-11 CERAMIC CHIP 1uF 16VC108 1-164-004-11 CERAMIC CHIP 0.1uF 10% 25VC109 1-163-145-00 CERAMIC CHIP 0.0015uF 5% 50VC110 1-164-161-11 CERAMIC CHIP 0.0022uF 10% 100VC111 1-163-251-11 CERAMIC CHIP 100PF 5% 50V
C112 1-163-038-00 CERAMIC CHIP 0.1uF 25VC113 1-163-038-00 CERAMIC CHIP 0.1uF 25VC115 1-126-607-11 ELECT CHIP 47uF 20% 4VC116 1-126-607-11 ELECT CHIP 47uF 20% 4VC117 1-126-209-11 ELECT CHIP 100uF 20% 4V
C118 1-163-275-11 CERAMIC CHIP 0.001uF 5% 50VC119 1-163-106-00 CERAMIC CHIP 36PF 5% 50VC120 1-109-982-11 CERAMIC CHIP 1uF 10% 10VC121 1-125-838-11 CERAMIC CHIP 2.2uF 10% 6.3VC122 1-163-009-11 CERAMIC CHIP 0.001uF 10% 50V
C123 1-163-021-11 CERAMIC CHIP 0.01uF 10% 50VC124 1-163-017-00 CERAMIC CHIP 0.0047uF 5% 50V
C126 1-124-779-00 ELECT CHIP 10uF 20% 16VC130 1-163-038-00 CERAMIC CHIP 0.1uF 25VC140 1-163-038-00 CERAMIC CHIP 0.1uF 25V
C141 1-163-038-00 CERAMIC CHIP 0.1uF 25VC154 1-163-038-00 CERAMIC CHIP 0.1uF 25VC159 1-163-017-00 CERAMIC CHIP 0.0047uF 5% 50VC161 1-163-038-00 CERAMIC CHIP 0.1uF 25VC170 1-163-038-00 CERAMIC CHIP 0.1uF 25V
C171 1-163-038-00 CERAMIC CHIP 0.1uF 25VC180 1-163-137-00 CERAMIC CHIP 680PF 5% 50VC181 1-163-137-00 CERAMIC CHIP 680PF 5% 50VC182 1-163-137-00 CERAMIC CHIP 680PF 5% 50VC183 1-163-137-00 CERAMIC CHIP 680PF 5% 50V
C184 1-163-037-11 CERAMIC CHIP 0.022uF 10% 25VC185 1-163-037-11 CERAMIC CHIP 0.022uF 10% 25VC186 1-128-065-11 ELECT CHIP 68uF 20% 10VC187 1-163-038-00 CERAMIC CHIP 0.1uF 25V
< CONNECTOR >
CN101 1-770-706-11 CONNECTOR, FFC/FPC 23PCN102 1-777-937-11 CONNECTOR, FFC/FPC 16P
< IC >
IC101 8-752-397-42 IC CXD3008QIC102 8-759-640-22 IC BA5982FMIC103 8-752-085-51 IC CXA2568M-T6IC104 8-759-398-25 IC TC7SH04F(TE85L)
< COIL >
L101 1-414-234-11 FERRITE 0uHL102 1-410-377-31 INDUCTOR CHIP 4.7uH
< TRANSISTOR >
Q101 8-729-049-31 TRANSISTOR 2SB710A-RTX
< RESISTOR >
R101 1-216-077-00 RES-CHIP 15K 5% 1/10WR102 1-216-097-11 RES-CHIP 100K 5% 1/10WR103 1-216-077-00 RES-CHIP 15K 5% 1/10WR104 1-216-085-00 RES-CHIP 33K 5% 1/10WR105 1-216-073-00 RES-CHIP 10K 5% 1/10W
R106 1-216-049-11 RES-CHIP 1K 5% 1/10WR107 1-216-073-00 RES-CHIP 10K 5% 1/10WR108 1-216-061-00 RES-CHIP 3.3K 5% 1/10WR109 1-216-121-11 RES-CHIP 1M 5% 1/10W
ADDRESS SENOR
57
Ref. No. Part No. Description Remarks Ref. No. Part No. Description Remarks
HCD-VX222BD DRIVER
R110 1-216-295-00 SHORT 0
R112 1-216-025-11 RES-CHIP 100 5% 1/10WR123 1-216-073-00 RES-CHIP 10K 5% 1/10WR124 1-216-097-11 RES-CHIP 100K 5% 1/10WR125 1-216-033-00 METAL CHIP 220 5% 1/10WR126 1-216-033-00 METAL CHIP 220 5% 1/10W
R127 1-216-033-00 METAL CHIP 220 5% 1/10WR131 1-216-033-00 METAL CHIP 220 5% 1/10WR135 1-216-295-00 SHORT 0R136 1-216-295-00 SHORT 0R137 1-216-295-00 SHORT 0
R138 1-216-295-00 SHORT 0R143 1-216-103-00 METAL CHIP 180K 5% 1/10WR144 1-216-103-00 METAL CHIP 180K 5% 1/10WR145 1-216-121-11 RES-CHIP 1M 5% 1/10WR146 1-216-121-11 RES-CHIP 1M 5% 1/10W
R147 1-216-041-00 METAL CHIP 470 5% 1/10WR148 1-216-001-00 METAL CHIP 10 5% 1/10WR149 1-216-003-11 RES-CHIP 12 5% 1/10WR150 1-216-073-00 RES-CHIP 10K 5% 1/10WR154 1-216-025-11 RES-CHIP 100 5% 1/10W
R155 1-216-025-11 RES-CHIP 100 5% 1/10WR156 1-216-025-11 RES-CHIP 100 5% 1/10WR157 1-216-025-11 RES-CHIP 100 5% 1/10WR158 1-216-073-00 RES-CHIP 10K 5% 1/10WR159 1-216-089-00 RES-CHIP 47K 5% 1/10W
R161 1-216-295-00 SHORT 0R162 1-216-101-00 METAL CHIP 150K 5% 1/10WR171 1-216-025-11 RES-CHIP 100 5% 1/10WR172 1-216-025-11 RES-CHIP 100 5% 1/10WR173 1-216-025-11 RES-CHIP 100 5% 1/10W
R175 1-216-025-11 RES-CHIP 100 5% 1/10WR180 1-216-097-11 RES-CHIP 100K 5% 1/10WR181 1-216-100-00 RES-CHIP 130K 5% 1/10WR182 1-216-081-00 METAL CHIP 22K 5% 1/10WR183 1-216-081-00 METAL CHIP 22K 5% 1/10W
R184 1-216-070-00 METAL CHIP 7.5K 5% 1/10WR185 1-216-070-00 METAL CHIP 7.5K 5% 1/10WR186 1-216-081-00 METAL CHIP 22K 5% 1/10WR187 1-216-081-00 METAL CHIP 22K 5% 1/10WR188 1-216-070-00 METAL CHIP 7.5K 5% 1/10W
R189 1-216-070-00 METAL CHIP 7.5K 5% 1/10WR190 1-216-081-00 METAL CHIP 22K 5% 1/10WR191 1-216-081-00 METAL CHIP 22K 5% 1/10WR192 1-216-070-00 METAL CHIP 7.5K 5% 1/10WR193 1-216-070-00 METAL CHIP 7.5K 5% 1/10W
R194 1-216-295-00 SHORT 0R203 1-216-025-11 RES-CHIP 100 5% 1/10WR204 1-216-025-11 RES-CHIP 100 5% 1/10WR205 1-216-025-11 RES-CHIP 100 5% 1/10WR206 1-216-295-00 SHORT 0
R210 1-216-295-00 SHORT 0
< SWITCH >
S101 1-771-853-11 SWITCH, DETECTION (LIMIT)******************************************************
1-675-912-14 DRIVER BOARD************
< CAPACITOR >
C702 1-126-964-51 ELECT 10uF 20% 50V
< CONNECTOR >
CN701 1-785-336-11 PIN, CONNECTOR(LIGHT ANGLE)10PCN702 1-785-550-11 CONNECTOR, FFC/FPC 8P
< DIODE >
D701 8-719-983-15 DIODE MTZJ-T-77-3.9A
< IC >
IC701 8-759-598-69 IC BA6956AN
< RESISTOR >
R701 1-249-411-11 CARBON 330 5% 1/4WR702 1-249-401-11 CARBON 47 5% 1/4W F
******************************************************
1-681-447-11 KEY BOARD*********
< DIODE >
D707 8-719-058-04 DIODE SEL5223S-TP15 (REC PAUSE/START)D708 8-719-058-04 DIODE SEL5223S-TP15 (ENTER)D709 8-719-057-97 DIODE SEL5923A-TP15 (KARAOKE PON)D711 8-719-057-97 DIODE SEL5923A-TP15 (GROOVE)
< TRANSISTOR >
Q707 8-729-900-80 TRANSISTOR DTC114ESQ708 8-729-900-80 TRANSISTOR DTC114ESQ709 8-729-900-80 TRANSISTOR DTC114ESQ712 8-729-900-80 TRANSISTOR DTC114ES
< RESISTOR >
R703 1-249-413-11 CARBON 470 5% 1/4WR704 1-249-414-11 CARBON 560 5% 1/4WR705 1-249-415-11 CARBON 680 5% 1/4WR706 1-249-417-11 CARBON 1K 5% 1/4WR707 1-249-418-11 CARBON 1.2K 5% 1/4W
R708 1-249-420-11 CARBON 1.8K 5% 1/4WR709 1-249-422-11 CARBON 2.7K 5% 1/4WR710 1-247-843-11 CARBON 3.3K 5% 1/4WR711 1-249-425-11 CARBON 4.7K 5% 1/4WR713 1-249-410-11 CARBON 270 5% 1/4W
R714 1-249-411-11 CARBON 330 5% 1/4WR715 1-249-413-11 CARBON 470 5% 1/4WR716 1-249-414-11 CARBON 560 5% 1/4WR717 1-249-415-11 CARBON 680 5% 1/4WR718 1-249-417-11 CARBON 1K 5% 1/4W
R719 1-249-418-11 CARBON 1.2K 5% 1/4WR720 1-249-420-11 CARBON 1.8K 5% 1/4WR721 1-249-422-11 CARBON 2.7K 5% 1/4WR726 1-249-410-11 CARBON 270 5% 1/4WR727 1-249-411-11 CARBON 330 5% 1/4W
R728 1-249-413-11 CARBON 470 5% 1/4WR729 1-249-414-11 CARBON 560 5% 1/4WR730 1-249-415-11 CARBON 680 5% 1/4WR731 1-249-417-11 CARBON 1K 5% 1/4WR732 1-249-418-11 CARBON 1.2K 5% 1/4W
KEY
58
Ref. No. Part No. Description Remarks Ref. No. Part No. Description Remarks
HCD-VX222
R733 1-249-420-11 CARBON 1.8K 5% 1/4WR734 1-249-422-11 CARBON 2.7K 5% 1/4WR735 1-247-843-11 CARBON 3.3K 5% 1/4WR736 1-249-425-11 CARBON 4.7K 5% 1/4WR737 1-249-427-11 CARBON 6.8K 5% 1/4W
R745 1-249-411-11 CARBON 330 5% 1/4WR746 1-249-411-11 CARBON 330 5% 1/4WR797 1-249-411-11 CARBON 330 5% 1/4WR804 1-249-411-11 CARBON 330 5% 1/4W
< SWITCH >
S703 1-762-875-21 SWITCH, KEYBOARD (GROOVE)S704 1-762-875-21 SWITCH, KEYBOARD (DISC SKIP, EX-CHANGE)S705 1-762-875-21 SWITCH, KEYBOARD (DISC 1)S706 1-762-875-21 SWITCH, KEYBOARD (DISC 2)S707 1-762-875-21 SWITCH, KEYBOARD (DISC 3)
S708 1-762-875-21 SWITCH, KEYBOARD OPEN/CLOSE Z )S709 1-762-875-21 SWITCH, KEYBOARD (v)S710 1-762-875-21 SWITCH, KEYBOARD (V)S711 1-762-875-21 SWITCH, KEYBOARD (PICTURE EFFECT)S712 1-762-875-21 SWITCH, KEYBOARD (KARAOKE PON)
S713 1-762-875-21 SWITCH, KEYBOARD (m – )S714 1-762-875-21 SWITCH, KEYBOARD (.)S715 1-762-875-21 SWITCH, KEYBOARD (x)S716 1-762-875-21 SWITCH, KEYBOARD (gG)S717 1-762-875-21 SWITCH, KEYBOARD (X)
S718 1-762-875-21 SWITCH, KEYBOARD (> )S719 1-762-875-21 SWITCH, KEYBOARD (M + )S720 1-762-875-21 SWITCH, KEYBOARD (CD SYNC)S721 1-762-875-21 SWITCH, KEYBOARD (REC PAUSE/START)S726 1-762-875-21 SWITCH, KEYBOARD (DISPLAY)
S727 1-762-875-21 SWITCH, KEYBOARD (SPECTRUM)S728 1-762-875-21 SWITCH, KEYBOARD (DIRECTION/EDIT)S729 1-762-875-21 SWITCH, KEYBOARD (STEREO/MONO REPEAT)S730 1-762-875-21 SWITCH, KEYBOARD
(TUNER MEMOPY/PLAY MODE)S731 1-762-875-21 SWITCH, KEYBOARD (GAME EQ)
S732 1-762-875-21 SWITCH, KEYBOARD (ENTER)S733 1-762-875-21 SWITCH, KEYBOARD (P. FILE)S734 1-762-875-21 SWITCH, KEYBOARD (B)S735 1-762-875-21 SWITCH, KEYBOARD (b)S736 1-762-875-21 SWITCH, KEYBOARD (MUSIC EQ)
S737 1-762-875-21 SWITCH, KEYBOARD (EFFECT ON/OFF)S738 1-762-875-21 SWITCH, KEYBOARD (MOVIE EQ)
******************************************************
A-4476-995-A MAIN BOARD, COMPLETE (E,IA,SP)A-4476-999-A MAIN BOARD, COMPLETE (EA)A-4725-703-A MAIN BOARD, COMPLETE (TW)A-4726-005-A MAIN BOARD, COMPLETE (TH)A-4726-272-A MAIN BOARD, COMPLETE (E91)
************************
7-685-646-79 SCREW +BVTP 3X8 YPE2 N-S7-685-872-09 SCREW +BVTT 3X8 (S)
< CAPACITOR >
C101 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25VC102 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25VC103 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25VC104 1-126-947-11 ELECT 47uF 20% 16VC105 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V
C106 1-126-933-11 ELECT 100uF 20% 16VC107 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25VC108 1-126-964-11 ELECT 10uF 20% 50VC109 1-162-935-11 CERAMIC CHIP 4PF 0.25PF 50VC110 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V
C111 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25VC112 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25VC113 1-126-959-11 ELECT 0.47uF 20% 50VC114 1-126-947-11 ELECT 47uF 20% 16VC115 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V
C116 1-126-961-11 ELECT 2.2uF 20% 50VC117 1-126-947-11 ELECT 47uF 20% 16VC118 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25VC119 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25VC120 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V
C121 1-162-919-11 CERAMIC CHIP 22PF 5% 50VC122 1-162-921-11 CERAMIC CHIP 33PF 5% 50VC123 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50VC124 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50VC125 1-126-947-11 ELECT 47uF 20% 16V
C126 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25VC127 1-126-960-11 ELECT 1uF 20% 50VC128 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25VC129 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25VC130 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V
C131 1-164-245-11 CERAMIC CHIP 0.015uF 10% 25VC132 1-164-245-11 CERAMIC CHIP 0.015uF 10% 25VC133 1-126-957-11 ELECT 0.22uF 20% 50VC134 1-104-760-11 CERAMIC CHIP 0.047uF 10% 50VC135 1-126-963-11 ELECT 4.7uF 20% 50V
C136 1-126-963-11 ELECT 4.7uF 20% 50VC137 1-126-964-11 ELECT 10uF 20% 50VC139 1-162-957-11 CERAMIC CHIP 220PF 5% 50VC140 1-126-960-11 ELECT 1uF 20% 50VC141 1-104-760-11 CERAMIC CHIP 0.047uF 10% 50V
C142 1-162-953-11 CERAMIC CHIP 100PF 5% 50VC143 1-126-965-11 ELECT 22uF 20% 50VC144 1-126-947-11 ELECT 47uF 20% 16VC201 1-162-963-11 CERAMIC CHIP 680PF 10% 50VC202 1-162-963-11 CERAMIC CHIP 680PF 10% 50V
C203 1-162-963-11 CERAMIC CHIP 680PF 10% 50VC204 1-162-963-11 CERAMIC CHIP 680PF 10% 50VC205 1-162-960-11 CERAMIC CHIP 220PF 10% 50VC206 1-162-960-11 CERAMIC CHIP 220PF 10% 50VC207 1-162-960-11 CERAMIC CHIP 220PF 10% 50V
C208 1-162-960-11 CERAMIC CHIP 220PF 10% 50VC209 1-126-947-11 ELECT 47uF 20% 16VC210 1-126-947-11 ELECT 47uF 20% 16VC211 1-130-486-00 MYLAR 0.018uF 10% 50VC212 1-130-486-00 MYLAR 0.018uF 10% 50V
C213 1-126-960-11 ELECT 1uF 20% 50VC214 1-126-960-11 ELECT 1uF 20% 50VC215 1-126-961-11 ELECT 2.2uF 20% 50VC217 1-126-947-11 ELECT 47uF 20% 16VC218 1-126-947-11 ELECT 47uF 20% 16V
C219 1-126-961-11 ELECT 2.2uF 20% 50VC221 1-126-963-11 ELECT 4.7uF 20% 50VC222 1-126-963-11 ELECT 4.7uF 20% 50VC223 1-130-487-00 MYLAR 0.022uF 5% 50VC224 1-162-962-11 CERAMIC CHIP 470PF 10% 50V
MAINKEY
59
Ref. No. Part No. Description Remarks Ref. No. Part No. Description Remarks
HCD-VX222
C225 1-126-963-11 ELECT 4.7uF 20% 50VC226 1-162-977-11 CERAMIC CHIP 0.0018uF 10% 50VC227 1-162-949-11 CERAMIC CHIP 47PF 5% 50VC228 1-162-949-11 CERAMIC CHIP 47PF 5% 50VC229 1-104-665-11 ELECT 100uF 20% 10V
C230 1-104-665-11 ELECT 100uF 20% 10VC231 1-126-959-11 ELECT 0.47uF 20% 50VC232 1-126-959-11 ELECT 0.47uF 20% 50VC233 1-130-483-00 MYLAR 0.01uF 5% 50VC234 1-130-483-00 MYLAR 0.01uF 5% 50V
C235 1-126-960-11 ELECT 1uF 20% 50VC235A 1-162-949-11 CERAMIC CHIP 47PF 5% 50VC236 1-126-933-11 ELECT 100uF 20% 16VC236A 1-162-949-11 CERAMIC CHIP 47PF 5% 50VC237 1-162-962-11 CERAMIC CHIP 470PF 10% 50V
C238 1-162-977-11 CERAMIC CHIP 0.0018uF 10% 50VC239 1-130-485-00 MYLAR 0.015uF 5% 50VC240 1-126-947-11 ELECT 47uF 20% 16VC241 1-130-479-00 MYLAR 0.0047uF 5% 50VC242 1-130-471-00 MYLAR 0.001uF 5% 50V
C243 1-162-965-11 CERAMIC CHIP 0.0015uF 10% 50VC244 1-162-965-11 CERAMIC CHIP 0.0015uF 10% 50VC245 1-165-128-11 CERAMIC CHIP 0.22uF 16VC246 1-165-128-11 CERAMIC CHIP 0.22uF 16VC256 1-126-960-11 ELECT 1uF 20% 50V
C257 1-126-956-11 ELECT 0.1uF 20% 50VC265 1-162-974-11 CERAMIC CHIP 0.01uF 50VC266 1-162-995-11 CERAMIC CHIP 0.022uF 50VC270 1-126-933-11 ELECT 100uF 20% 16VC271 1-126-960-11 ELECT 1uF 20% 50V
C272 1-126-960-11 ELECT 1uF 20% 50VC300 1-136-165-00 FILM 0.1uF 5% 50VC301 1-126-963-11 ELECT 4.7uF 20% 50VC302 1-126-963-11 ELECT 4.7uF 20% 50VC303 1-126-963-11 ELECT 4.7uF 20% 50V
C304 1-126-963-11 ELECT 4.7uF 20% 50VC305 1-126-963-11 ELECT 4.7uF 20% 50VC306 1-126-963-11 ELECT 4.7uF 20% 50VC307 1-126-963-11 ELECT 4.7uF 20% 50VC308 1-126-963-11 ELECT 4.7uF 20% 50V
C309 1-126-963-11 ELECT 4.7uF 20% 50VC310 1-126-963-11 ELECT 4.7uF 20% 50VC311 1-126-964-11 ELECT 10uF 20% 50VC312 1-136-165-00 FILM 0.1uF 5% 50VC313 1-130-491-00 MYLAR 0.047uF 5% 50V
C314 1-126-963-11 ELECT 4.7uF 20% 50VC315 1-126-963-11 ELECT 4.7uF 20% 50VC316 1-126-963-11 ELECT 4.7uF 20% 50VC317 1-136-169-00 FILM 0.22uF 5% 50VC318 1-136-169-00 FILM 0.22uF 5% 50V
C319 1-136-169-00 FILM 0.22uF 5% 50VC320 1-136-169-00 FILM 0.22uF 5% 50VC321 1-136-171-00 FILM 0.33uF 5% 50VC322 1-164-156-11 CERAMIC CHIP 0.1uF 25VC323 1-126-963-11 ELECT 4.7uF 20% 50V
C324 1-126-963-11 ELECT 4.7uF 20% 50VC325 1-130-487-00 MYLAR 0.022uF 5% 50VC326 1-130-487-00 MYLAR 0.022uF 5% 50VC327 1-130-487-00 MYLAR 0.022uF 5% 50VC328 1-130-487-00 MYLAR 0.022uF 5% 50V
C333 1-130-475-00 MYLAR 0.0022uF 5% 50VC334 1-130-475-00 MYLAR 0.0022uF 5% 50VC337 1-130-491-00 MYLAR 0.047uF 5% 50VC338 1-130-491-00 MYLAR 0.047uF 5% 50VC339 1-130-491-00 MYLAR 0.047uF 5% 50V
C340 1-130-491-00 MYLAR 0.047uF 5% 50VC342 1-136-165-00 FILM 0.1uF 5% 50VC343 1-136-165-00 FILM 0.1uF 5% 50VC344 1-126-964-11 ELECT 10uF 20% 50VC345 1-126-934-11 ELECT 220uF 20% 16V
C346 1-136-170-00 FILM 0.27uF 5% 50VC347 1-126-964-11 ELECT 10uF 20% 50VC348 1-126-964-11 ELECT 10uF 20% 50VC349 1-104-665-11 ELECT 100uF 20% 10VC350 1-165-128-11 CERAMIC CHIP 0.22uF 16V
C351 1-162-962-11 CERAMIC CHIP 470PF 10% 50VC352 1-162-962-11 CERAMIC CHIP 470PF 10% 50VC353 1-126-963-11 ELECT 4.7uF 20% 50VC354 1-126-963-11 ELECT 4.7uF 20% 50VC355 1-126-963-11 ELECT 4.7uF 20% 50V
C356 1-126-963-11 ELECT 4.7uF 20% 50VC357 1-164-156-11 CERAMIC CHIP 0.1uF 25VC358 1-162-974-11 CERAMIC CHIP 0.01uF 50VC359 1-164-156-11 CERAMIC CHIP 0.1uF 25VC360 1-164-156-11 CERAMIC CHIP 0.1uF 25V
C361 1-107-721-11 ELECT 4.7uF 20% 100VC362 1-107-721-11 ELECT 4.7uF 20% 100VC363 1-107-717-11 ELECT 47uF 20% 50VC364 1-109-953-11 ELECT 2.2uF 20% 50VC365 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50V
C366 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50VC375 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50VC376 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50VC381 1-104-665-11 ELECT 100uF 20% 10VC382 1-126-961-11 ELECT 2.2uF 20% 50V
C383 1-126-961-11 ELECT 2.2uF 20% 50VC601 1-164-156-11 CERAMIC CHIP 0.1uF 25VC602 1-126-964-11 ELECT 10uF 20% 50VC603 1-162-960-11 CERAMIC CHIP 220PF 10% 50VC604 1-162-960-11 CERAMIC CHIP 220PF 10% 50V
C605 1-162-960-11 CERAMIC CHIP 220PF 10% 50VC606 1-162-960-11 CERAMIC CHIP 220PF 10% 50VC607 1-162-918-11 CERAMIC CHIP 18PF 5% 50VC608 1-162-917-11 CERAMIC CHIP 15PF 5% 50VC610 1-126-964-11 ELECT 10uF 20% 50V
C611 1-162-974-11 CERAMIC CHIP 0.01uF 50VC612 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50VC613 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50VC644 1-164-156-11 CERAMIC CHIP 0.1uF 25VC656 1-164-156-11 CERAMIC CHIP 0.1uF 25V
C657 1-164-156-11 CERAMIC CHIP 0.1uF 25VC658 1-164-156-11 CERAMIC CHIP 0.1uF 25VC659 1-164-156-11 CERAMIC CHIP 0.1uF 25VC660 1-164-156-11 CERAMIC CHIP 0.1uF 25VC661 1-126-965-11 ELECT 22uF 20% 50V
C662 1-136-165-00 FILM 0.1uF 5% 50VC663 1-136-165-00 FILM 0.1uF 5% 50VC664 1-162-974-11 CERAMIC CHIP 0.01uF 50VC665 1-126-916-11 ELECT 1000uF 20% 6.3VC666 1-164-156-11 CERAMIC CHIP 0.1uF 25V
MAIN
60
Ref. No. Part No. Description Remarks Ref. No. Part No. Description Remarks
HCD-VX222
C671 1-126-916-11 ELECT 1000uF 20% 6.3VC672 1-162-953-11 CERAMIC CHIP 100PF 5% 50VC673 1-162-953-11 CERAMIC CHIP 100PF 5% 50VC674 1-162-953-11 CERAMIC CHIP 100PF 5% 50VC675 1-126-935-11 ELECT 470uF 20% 10V
C676 1-104-665-11 ELECT 100uF 20% 10VC677 1-126-935-11 ELECT 470uF 20% 10VC681 1-136-165-00 FILM 0.1uF 5% 50VC683 1-136-165-00 FILM 0.1uF 5% 50VC684 1-136-165-00 FILM 0.1uF 5% 50V
C685 1-126-937-11 ELECT 4700uF 20% 16VC686 1-126-964-11 ELECT 10uF 20% 50VC687 1-126-917-11 ELECT 3300uF 20% 6.3VC688 1-126-964-11 ELECT 10uF 20% 50VC689 1-104-665-11 ELECT 100uF 20% 10V
C690 1-126-964-11 ELECT 10uF 20% 50VC691 1-126-933-11 ELECT 100uF 20% 16VC692 1-126-935-11 ELECT 470uF 20% 16VC693 1-130-483-00 MYLAR 0.01uF 5% 50VC694 1-130-483-00 MYLAR 0.01uF 5% 50V
C697 1-126-943-11 ELECT 2200uF 20% 25VC698 1-126-964-11 ELECT 10uF 20% 50VC699 1-126-935-11 ELECT 470uF 20% 16V
< FILTER >
CF101 1-760-023-11 FILTER, CERAMICCF102 1-760-023-11 FILTER, CERAMIC
< CONNECTOR >
CN1 1-785-336-11 PIN, CONNECTOR(LIGHT ANGLE)10PCN2 1-784-778-11 CONNECTOR, FFC 17PCN102 1-784-735-11 CONNECTOR, FFC 13P
* CN203 1-564-705-11 PIN, CONNECTOR (SMALL TYPE) 3PCN402 1-778-982-21 CONNECTOR, BOARD TO BOARD 13P
CN403 1-778-982-21 CONNECTOR, BOARD TO BOARD 13PCN701 1-793-766-11 CONNECTOR, BOARD TO BOARD 30P
< DIODE >
D101 8-719-914-42 DIODE DA204KD104 8-719-978-33 DIODE DTZ-TT11-6.8BD108 8-719-988-61 DIODE 1SS355TE-17D203 8-719-988-61 DIODE 1SS355TE-17D204 8-719-988-61 DIODE 1SS355TE-17
D205 8-719-988-61 DIODE 1SS355TE-17D206 8-719-988-61 DIODE 1SS355TE-17D207 8-719-988-61 DIODE 1SS355TE-17D301 8-719-069-60 DIODE UDZSTE-179.1BD302 8-719-988-61 DIODE 1SS355TE-17
D303 8-719-988-61 DIODE 1SS355TE-17D361 8-719-988-61 DIODE 1SS355TE-17D372 8-719-988-61 DIODE 1SS355TE-17D383 8-719-988-61 DIODE 1SS355TE-17D601 8-719-988-61 DIODE 1SS355TE-17
D602 8-719-988-61 DIODE 1SS355TE-17D603 1-216-864-11 CONDUCTOR, CHIP (1608)6WD661 8-719-988-61 DIODE 1SS355TE-17D662 8-719-988-61 DIODE 1SS355TE-17D663 8-719-988-61 DIODE 1SS355TE-17
D664 8-719-988-61 DIODE 1SS355TE-17D665 8-719-988-61 DIODE 1SS355TE-17
D666 8-719-988-61 DIODE 1SS355TE-17D667 8-719-988-61 DIODE 1SS355TE-17D668 8-719-988-61 DIODE 1SS355TE-17
D669 8-719-988-61 DIODE 1SS355TE-17D670 8-719-988-61 DIODE 1SS355TE-17D681 8-719-080-70 DIODE 11EQS04N-TB5D682 8-719-080-70 DIODE 11EQS04N-TB5D683 8-719-080-70 DIODE 11EQS04N-TB5
D684 8-719-080-70 DIODE 11EQS04N-TB5D685 8-719-988-61 DIODE 1SS355TE-17D686 8-719-988-61 DIODE 1SS355TE-17D687 8-719-083-89 DIODE 11ES2N-TB5D688 8-719-083-89 DIODE 11ES2N-TB5
D689 8-719-083-89 DIODE 11ES2N-TB5D690 8-719-083-89 DIODE 11ES2N-TB5D691 8-719-083-89 DIODE 11ES2N-TB5D692 8-719-083-89 DIODE 11ES2N-TB5D693 8-719-083-89 DIODE 11ES2N-TB5
D694 8-719-083-89 DIODE 11ES2N-TB5D695 8-719-083-89 DIODE 11ES2N-TB5
< FERRITE BEAD >
FB1 1-550-907-21 FERRITE 0uH (TW)FB1 1-216-864-11 METAL CHIP 0 5% 1/16W
(EXCEPT TW)FB2 1-550-907-21 FERRITE 0uH (TW)FB2 1-216-864-11 METAL CHIP 0 5% 1/16W
(EXCEPT TW)FB3 1-550-907-21 FERRITE 0uH (TW)
FB3 1-216-864-11 METAL CHIP 0 5% 1/16W(EXCEPT TW)
FB4 1-216-864-11 METAL CHIP 0 5% 1/16WFB5 1-216-864-11 METAL CHIP 0 5% 1/16WFB6 1-216-864-11 METAL CHIP 0 5% 1/16WFB7 1-550-907-21 FERRITE 0uH
< FRONT END >
FE101 1-693-477-12 FRONT END (3 GANGS)
< TERMINAL >
* GND1 1-537-738-21 TERMINAL, EARTH
< IC >
IC101 8-759-652-00 IC BA1450IC102 8-759-288-54 IC LC72130IC201 8-759-242-58 IC TA8189NIC301 8-759-832-80 IC BH3878KS2IC302 8-759-652-01 IC LA2615
IC401 8-759-829-83 IC M30622MAA-A98FPIC661 8-759-635-63 IC M51943BSL-TPIC681 8-759-039-69 IC uPC7805AHFIC682 8-759-039-69 IC uPC7805AHFIC683 8-759-088-08 IC uPC7812AHF
IC684 8-759-701-59 IC M5F7809L
< IFT >
IFT101 1-435-295-12 TRANSFORMER, IF
< JACK >
JK101 1-694-555-12 TERMINAL BOARD (4P) (ANTENNA)
MAIN
61
Ref. No. Part No. Description Remarks Ref. No. Part No. Description Remarks
HCD-VX222
JK301 1-770-613-11 JACK, PIN 4P (MD/VIDEO (AUDIO))JK302 1-694-635-12 TERMINAL BOARD (4P) (SPEAKER)
< JUMPER RESISTOR >
JR1 1-216-864-11 METAL CHIP 0 5% 1/16WJR4 1-216-864-11 METAL CHIP 0 5% 1/16WJR7 1-216-864-11 METAL CHIP 0 5% 1/16WJR8 1-216-864-11 METAL CHIP 0 5% 1/16WJR10 1-216-864-11 METAL CHIP 0 5% 1/16W
JR11 1-216-864-11 METAL CHIP 0 5% 1/16WJR14 1-216-864-11 METAL CHIP 0 5% 1/16WJR15 1-216-864-11 METAL CHIP 0 5% 1/16WJR16 1-216-864-11 METAL CHIP 0 5% 1/16WJR17 1-216-864-11 METAL CHIP 0 5% 1/16W
JR109 1-216-864-11 METAL CHIP 0 5% 1/16WJR602 1-216-864-11 METAL CHIP 0 5% 1/16WJR603 1-216-864-11 METAL CHIP 0 5% 1/16WJR606 1-216-864-11 METAL CHIP 0 5% 1/16WJR607 1-216-864-11 METAL CHIP 0 5% 1/16W
JR633 1-216-864-11 METAL CHIP 0 5% 1/16WJR634 1-216-864-11 METAL CHIP 0 5% 1/16WJR635 1-216-864-11 METAL CHIP 0 5% 1/16WJR638 1-216-864-11 METAL CHIP 0 5% 1/16WJR641 1-216-864-11 METAL CHIP 0 5% 1/16W
JR642 1-216-864-11 METAL CHIP 0 5% 1/16W
< COIL >
L107 1-216-864-11 METAL CHIP 0 5% 1/16WL201 1-437-220-11 TRANSFORMER, BIAS OSCILLATIONL671 1-414-189-31 INDUCTOR 100uH
< PHOTO INTERRUPTER >
PH671 8-749-923-04 IC TOTX178A (CD DIGITAL OUT OPTICAL)
< TRANSISTOR >
Q101 8-729-922-66 TRANSISTOR 2SC2410SNQ102 8-729-422-57 TRANSISTOR UN4111Q103 8-729-120-28 TRANSISTOR 2SC1623-L5L6Q104 8-729-120-28 TRANSISTOR 2SC1623-L5L6Q210 8-729-119-78 TRANSISTOR 2SC2785-HFE
Q211 8-729-119-78 TRANSISTOR 2SC2785-HFEQ212 8-729-119-78 TRANSISTOR 2SC2785-HFEQ213 8-729-119-78 TRANSISTOR 2SC2785-HFEQ214 8-729-141-30 TRANSISTOR 2SC3623A-LKQ215 8-729-141-30 TRANSISTOR 2SC3623A-LK
Q216 8-729-141-30 TRANSISTOR 2SC3623A-LKQ217 8-729-141-30 TRANSISTOR 2SC3623A-LKQ218 8-729-119-78 TRANSISTOR 2SC2785-HFEQ219 8-729-119-78 TRANSISTOR 2SC2785-HFEQ220 8-729-119-78 TRANSISTOR 2SC2785-HFE
Q221 8-729-119-78 TRANSISTOR 2SC2785-HFEQ222 8-729-119-78 TRANSISTOR 2SC2785-HFEQ223 8-729-142-46 TRANSISTOR 2SC2001-LKQ224 8-729-119-78 TRANSISTOR 2SC2785-HFEQ225 8-729-140-04 TRANSISTOR 2SB1116A-L
Q226 8-729-900-63 TRANSISTOR DTA124ESQ227 8-729-140-04 TRANSISTOR 2SB1116A-LQ228 8-729-140-04 TRANSISTOR 2SB1116A-LQ229 8-729-141-30 TRANSISTOR 2SC3623A-LKQ230 8-729-141-30 TRANSISTOR 2SC3623A-LK
Q301 8-729-141-30 TRANSISTOR 2SC3623A-LK
Q302 8-729-141-30 TRANSISTOR 2SC3623A-LKQ361 8-729-900-80 TRANSISTOR DTC114ESQ362 8-729-900-63 TRANSISTOR DTA124ESQ363 8-729-141-30 TRANSISTOR 2SC3623A-LK
Q364 8-729-141-30 TRANSISTOR 2SC3623A-LKQ365 8-729-900-63 TRANSISTOR DTA124ESQ381 8-729-119-78 TRANSISTOR 2SC2785-HFEQ382 8-729-119-78 TRANSISTOR 2SC2785-HFEQ383 8-729-119-76 TRANSISTOR 2SA1175-HFE
Q384 8-729-900-80 TRANSISTOR DTC114ESQ385 8-729-119-78 TRANSISTOR 2SC2785-HFEQ386 8-729-119-78 TRANSISTOR 2SC2785-HFEQ387 8-729-119-78 TRANSISTOR 2SC2785-HFEQ601 8-729-900-80 TRANSISTOR DTC114ES
Q602 8-729-140-04 TRANSISTOR 2SB1116A-LQ603 8-729-900-80 TRANSISTOR DTC114ESQ604 8-729-140-04 TRANSISTOR 2SB1116A-LQ605 8-729-900-80 TRANSISTOR DTC114ESQ606 8-729-116-57 TRANSISTOR 2SB1068-K
Q661 8-729-119-78 TRANSISTOR 2SC2785-HFEQ681 8-729-141-83 TRANSISTOR 2SB1094-LKQ682 8-729-900-80 TRANSISTOR DTC114ES
< RESISTOR >
R3 1-216-864-11 METAL CHIP 0 5% 1/16WR4 1-216-864-11 METAL CHIP 0 5% 1/16WR7 1-216-864-11 METAL CHIP 0 5% 1/16WR101 1-216-805-11 METAL CHIP 47 5% 1/16WR102 1-216-819-11 METAL CHIP 680 5% 1/16W
R103 1-216-819-11 METAL CHIP 680 5% 1/16WR104 1-216-811-11 METAL CHIP 150 5% 1/16WR105 1-216-823-11 METAL CHIP 1.5K 5% 1/16WR106 1-216-815-11 METAL CHIP 330 5% 1/16WR107 1-216-864-11 METAL CHIP 0 5% 1/16W
R108 1-216-815-11 METAL CHIP 330 5% 1/16WR109 1-216-805-11 METAL CHIP 47 5% 1/16WR110 1-216-833-11 METAL CHIP 10K 5% 1/16WR111 1-216-809-11 METAL CHIP 100 5% 1/16WR112 1-216-829-11 METAL CHIP 4.7K 5% 1/16W
R113 1-216-829-11 METAL CHIP 4.7K 5% 1/16WR114 1-216-829-11 METAL CHIP 4.7K 5% 1/16WR115 1-216-833-11 METAL CHIP 10K 5% 1/16WR116 1-216-809-11 METAL CHIP 100 5% 1/16WR117 1-216-845-11 METAL CHIP 100K 5% 1/16W
R118 1-216-809-11 METAL CHIP 100 5% 1/16WR119 1-216-833-11 METAL CHIP 10K 5% 1/16WR120 1-216-833-11 METAL CHIP 10K 5% 1/16WR121 1-216-821-11 METAL CHIP 1K 5% 1/16WR122 1-216-833-11 METAL CHIP 10K 5% 1/16W
R123 1-216-833-11 METAL CHIP 10K 5% 1/16WR124 1-216-813-11 METAL CHIP 220 5% 1/16WR125 1-216-829-11 METAL CHIP 4.7K 5% 1/16WR126 1-216-829-11 METAL CHIP 4.7K 5% 1/16WR127 1-216-825-11 METAL CHIP 2.2K 5% 1/16W
R128 1-216-818-11 METAL CHIP 560 5% 1/16WR129 1-216-818-11 METAL CHIP 560 5% 1/16WR130 1-216-833-11 METAL CHIP 10K 5% 1/16WR131 1-216-834-11 METAL CHIP 12K 5% 1/16WR132 1-216-825-11 METAL CHIP 2.2K 5% 1/16W
R133 1-216-817-11 METAL CHIP 470 5% 1/16WR134 1-216-817-11 METAL CHIP 470 5% 1/16W
MAIN
62
Ref. No. Part No. Description Remarks Ref. No. Part No. Description Remarks
HCD-VX222MAIN
R135 1-216-829-11 METAL CHIP 4.7K 5% 1/16WR136 1-216-827-11 METAL CHIP 3.3K 5% 1/16WR137 1-216-809-11 METAL CHIP 100 5% 1/16W
R138 1-216-809-11 METAL CHIP 100 5% 1/16WR139 1-216-864-11 METAL CHIP 0 5% 1/16WR201 1-216-797-11 METAL CHIP 10 5% 1/16WR202 1-216-797-11 METAL CHIP 10 5% 1/16WR203 1-216-797-11 METAL CHIP 10 5% 1/16W
R204 1-216-797-11 METAL CHIP 10 5% 1/16WR205 1-216-805-11 METAL CHIP 47 5% 1/16WR206 1-216-805-11 METAL CHIP 47 5% 1/16WR207 1-216-832-11 METAL CHIP 8.2K 5% 1/16WR208 1-216-832-11 METAL CHIP 8.2K 5% 1/16W
R209 1-216-850-11 METAL CHIP 270K 5% 1/16WR210 1-216-850-11 METAL CHIP 270K 5% 1/16WR214 1-216-829-11 METAL CHIP 4.7K 5% 1/16WR215 1-216-829-11 METAL CHIP 4.7K 5% 1/16WR216 1-216-845-11 METAL CHIP 100K 5% 1/16W
R217 1-216-833-11 METAL CHIP 10K 5% 1/16WR218 1-216-848-11 METAL CHIP 180K 5% 1/16WR219 1-216-833-11 METAL CHIP 10K 5% 1/16WR220 1-216-837-11 METAL CHIP 22K 5% 1/16WR221 1-216-833-11 METAL CHIP 10K 5% 1/16W
R222 1-216-813-11 METAL CHIP 220 5% 1/16WR223 1-216-848-11 METAL CHIP 180K 5% 1/16WR224 1-216-848-11 METAL CHIP 180K 5% 1/16WR225 1-216-837-11 METAL CHIP 22K 5% 1/16WR226 1-216-837-11 METAL CHIP 22K 5% 1/16W
R227 1-216-846-11 METAL CHIP 120K 5% 1/16WR228 1-216-846-11 METAL CHIP 120K 5% 1/16WR229 1-216-824-11 METAL CHIP 1.8K 5% 1/16WR230 1-216-824-11 METAL CHIP 1.8K 5% 1/16WR231 1-216-825-11 METAL CHIP 2.2K 5% 1/16W
R232 1-216-825-11 METAL CHIP 2.2K 5% 1/16WR233 1-216-843-11 METAL CHIP 68K 5% 1/16WR234 1-216-843-11 METAL CHIP 68K 5% 1/16WR235 1-216-829-11 METAL CHIP 4.7K 5% 1/16WR236 1-216-829-11 METAL CHIP 4.7K 5% 1/16W
R237 1-216-833-11 METAL CHIP 10K 5% 1/16WR238 1-216-855-11 METAL CHIP 680K 5% 1/16WR239 1-216-833-11 METAL CHIP 10K 5% 1/16WR240 1-216-833-11 METAL CHIP 10K 5% 1/16WR241 1-216-829-11 METAL CHIP 4.7K 5% 1/16W
R242 1-216-829-11 METAL CHIP 4.7K 5% 1/16WR243 1-216-825-11 METAL CHIP 2.2K 5% 1/16WR244 1-216-838-11 METAL CHIP 27K 5% 1/16WR245 1-216-833-11 METAL CHIP 10K 5% 1/16WR246 1-216-829-11 METAL CHIP 4.7K 5% 1/16W
R247 1-216-845-11 METAL CHIP 100K 5% 1/16WR248 1-216-834-11 METAL CHIP 12K 5% 1/16WR249 1-216-855-11 METAL CHIP 680K 5% 1/16WR250 1-216-848-11 METAL CHIP 180K 5% 1/16WR251 1-216-825-11 METAL CHIP 2.2K 5% 1/16W
R252 1-216-838-11 METAL CHIP 27K 5% 1/16WR253 1-216-833-11 METAL CHIP 10K 5% 1/16WR254 1-216-829-11 METAL CHIP 4.7K 5% 1/16WR255 1-216-821-11 METAL CHIP 1K 5% 1/16WR256 1-216-833-11 METAL CHIP 10K 5% 1/16W
R257 1-216-816-11 METAL CHIP 390 5% 1/16WR258 1-216-813-11 METAL CHIP 220 5% 1/16W
R259 1-216-821-11 METAL CHIP 1K 5% 1/16WR260 1-216-816-11 METAL CHIP 390 5% 1/16WR261 1-216-816-11 METAL CHIP 390 5% 1/16W
R262 1-216-845-11 METAL CHIP 100K 5% 1/16WR263 1-216-833-11 METAL CHIP 10K 5% 1/16WR264 1-216-833-11 METAL CHIP 10K 5% 1/16WR265 1-218-917-11 RES-CHIP 820K 5% 1/16WR266 1-218-917-11 RES-CHIP 820K 5% 1/16W
R270 1-216-813-11 METAL CHIP 220 5% 1/16WR271 1-216-857-11 METAL CHIP 1M 5% 1/16WR272 1-216-857-11 METAL CHIP 1M 5% 1/16WR273 1-216-823-11 METAL CHIP 1.5K 5% 1/16WR274 1-216-823-11 METAL CHIP 1.5K 5% 1/16W
R275 1-216-829-11 METAL CHIP 4.7K 5% 1/16WR276 1-216-829-11 METAL CHIP 4.7K 5% 1/16WR277 1-216-845-11 METAL CHIP 100K 5% 1/16WR278 1-216-845-11 METAL CHIP 100K 5% 1/16WR301 1-216-833-11 METAL CHIP 10K 5% 1/16W
R302 1-216-833-11 METAL CHIP 10K 5% 1/16WR303 1-216-838-11 METAL CHIP 27K 5% 1/16WR304 1-216-838-11 METAL CHIP 27K 5% 1/16WR305 1-216-825-11 METAL CHIP 2.2K 5% 1/16WR306 1-216-825-11 METAL CHIP 2.2K 5% 1/16W
R307 1-216-835-11 METAL CHIP 15K 5% 1/16WR308 1-216-835-11 METAL CHIP 15K 5% 1/16WR309 1-216-857-11 METAL CHIP 1M 5% 1/16WR311 1-216-845-11 METAL CHIP 100K 5% 1/16WR312 1-216-845-11 METAL CHIP 100K 5% 1/16W
R313 1-216-845-11 METAL CHIP 100K 5% 1/16WR314 1-216-845-11 METAL CHIP 100K 5% 1/16WR315 1-216-839-11 METAL CHIP 33K 5% 1/16WR316 1-216-839-11 METAL CHIP 33K 5% 1/16WR317 1-216-845-11 METAL CHIP 100K 5% 1/16W
R318 1-216-850-11 METAL CHIP 270K 5% 1/16WR320 1-216-847-11 METAL CHIP 150K 5% 1/16WR321 1-216-833-11 METAL CHIP 10K 5% 1/16WR322 1-216-833-11 METAL CHIP 10K 5% 1/16WR323 1-216-813-11 METAL CHIP 220 5% 1/16W
R324 1-216-834-11 METAL CHIP 12K 5% 1/16WR325 1-216-835-11 METAL CHIP 15K 5% 1/16WR326 1-216-833-11 METAL CHIP 10K 5% 1/16WR327 1-216-825-11 METAL CHIP 2.2K 5% 1/16WR328 1-216-827-11 METAL CHIP 3.3K 5% 1/16W
R329 1-216-827-11 METAL CHIP 3.3K 5% 1/16WR331 1-216-829-11 METAL CHIP 4.7K 5% 1/16WR332 1-216-829-11 METAL CHIP 4.7K 5% 1/16WR333 1-216-825-11 METAL CHIP 2.2K 5% 1/16WR334 1-216-825-11 METAL CHIP 2.2K 5% 1/16W
R335 1-216-845-11 METAL CHIP 100K 5% 1/16WR336 1-216-845-11 METAL CHIP 100K 5% 1/16WR337 1-216-833-11 METAL CHIP 10K 5% 1/16WR338 1-216-833-11 METAL CHIP 10K 5% 1/16WR339 1-216-831-11 METAL CHIP 6.8K 5% 1/16W
R340 1-216-831-11 METAL CHIP 6.8K 5% 1/16WR341 1-216-813-11 METAL CHIP 220 5% 1/16WR342 1-216-813-11 METAL CHIP 220 5% 1/16WR343 1-216-833-11 METAL CHIP 10K 5% 1/16WR344 1-216-833-11 METAL CHIP 10K 5% 1/16W
R361 1-215-891-11 METAL OXIDE 680 5% 2WR362 1-215-891-11 METAL OXIDE 680 5% 2W
63
Ref. No. Part No. Description Remarks Ref. No. Part No. Description Remarks
HCD-VX222MAIN
R363 1-216-821-11 METAL CHIP 1K 5% 1/16WR364 1-216-821-11 METAL CHIP 1K 5% 1/16WR365 1-216-841-11 METAL CHIP 47K 5% 1/16W
R366 1-216-833-11 METAL CHIP 10K 5% 1/16WR367 1-216-821-11 METAL CHIP 1K 5% 1/16WR368 1-216-845-11 METAL CHIP 100K 5% 1/16WR369 1-216-837-11 METAL CHIP 22K 5% 1/16WR370 1-216-823-11 METAL CHIP 1.5K 5% 1/16W
R381 1-216-842-11 METAL CHIP 56K 5% 1/16WR382 1-216-841-11 METAL CHIP 47K 5% 1/16WR383 1-216-833-11 METAL CHIP 10K 5% 1/16WR384 1-216-833-11 METAL CHIP 10K 5% 1/16WR385 1-216-839-11 METAL CHIP 33K 5% 1/16W
R386 1-216-837-11 METAL CHIP 22K 5% 1/16WR387 1-216-829-11 METAL CHIP 4.7K 5% 1/16WR388 1-216-837-11 METAL CHIP 22K 5% 1/16WR389 1-216-830-11 METAL CHIP 5.6K 5% 1/16WR391 1-216-833-11 METAL CHIP 10K 5% 1/16W
R392 1-216-809-11 METAL CHIP 100 5% 1/16WR393 1-216-806-11 RES-CHIP 56 5% 1/16WR394 1-216-806-11 RES-CHIP 56 5% 1/16WR601 1-216-821-11 METAL CHIP 1K 5% 1/16WR602 1-216-819-11 METAL CHIP 680 5% 1/16W
R603 1-216-821-11 METAL CHIP 1K 5% 1/16WR604 1-216-819-11 METAL CHIP 680 5% 1/16WR605 1-216-821-11 METAL CHIP 1K 5% 1/16WR606 1-216-819-11 METAL CHIP 680 5% 1/16WR607 1-216-809-11 METAL CHIP 100 5% 1/16W
R608 1-216-809-11 METAL CHIP 100 5% 1/16WR609 1-216-833-11 METAL CHIP 10K 5% 1/16WR610 1-216-809-11 METAL CHIP 100 5% 1/16WR611 1-216-833-11 METAL CHIP 10K 5% 1/16WR612 1-216-809-11 METAL CHIP 100 5% 1/16W
R613 1-216-833-11 METAL CHIP 10K 5% 1/16WR614 1-216-809-11 METAL CHIP 100 5% 1/16WR615 1-216-809-11 METAL CHIP 100 5% 1/16WR616 1-216-809-11 METAL CHIP 100 5% 1/16WR618 1-216-833-11 METAL CHIP 10K 5% 1/16W
R625 1-216-833-11 METAL CHIP 10K 5% 1/16WR626 1-216-809-11 METAL CHIP 100 5% 1/16WR627 1-216-809-11 METAL CHIP 100 5% 1/16WR628 1-216-809-11 METAL CHIP 100 5% 1/16WR629 1-216-809-11 METAL CHIP 100 5% 1/16W
R630 1-216-809-11 METAL CHIP 100 5% 1/16WR631 1-216-809-11 METAL CHIP 100 5% 1/16WR632 1-216-833-11 METAL CHIP 10K 5% 1/16WR633 1-216-809-11 METAL CHIP 100 5% 1/16WR634 1-216-833-11 METAL CHIP 10K 5% 1/16W
R635 1-216-809-11 METAL CHIP 100 5% 1/16WR636 1-216-809-11 METAL CHIP 100 5% 1/16WR637 1-216-809-11 METAL CHIP 100 5% 1/16WR638 1-216-823-11 METAL CHIP 1.5K 5% 1/16WR639 1-216-841-11 METAL CHIP 47K 5% 1/16W
R640 1-216-841-11 METAL CHIP 47K 5% 1/16WR641 1-216-833-11 METAL CHIP 10K 5% 1/16W
(EA)R641 1-216-823-11 METAL CHIP 1.5K 5% 1/16W
(EXCEPT EA)R642 1-216-821-11 METAL CHIP 1K 5% 1/16WR643 1-216-821-11 METAL CHIP 1K 5% 1/16W
R644 1-216-851-11 METAL CHIP 330K 5% 1/16WR645 1-216-833-11 METAL CHIP 10K 5% 1/16WR646 1-216-833-11 METAL CHIP 10K 5% 1/16WR647 1-216-864-11 METAL CHIP 0 5% 1/16WR648 1-216-864-11 METAL CHIP 0 5% 1/16W
R649 1-216-833-11 METAL CHIP 10K 5% 1/16WR650 1-216-833-11 METAL CHIP 10K 5% 1/16WR651 1-216-864-11 METAL CHIP 0 5% 1/16WR652 1-216-821-11 METAL CHIP 1K 5% 1/16WR653 1-216-833-11 METAL CHIP 10K 5% 1/16W
R654 1-216-833-11 METAL CHIP 10K 5% 1/16WR655 1-216-864-11 METAL CHIP 0 5% 1/16WR656 1-216-809-11 METAL CHIP 100 5% 1/16WR657 1-216-833-11 METAL CHIP 10K 5% 1/16WR658 1-216-809-11 METAL CHIP 100 5% 1/16W
R659 1-216-833-11 METAL CHIP 10K 5% 1/16WR660 1-216-809-11 METAL CHIP 100 5% 1/16WR661 1-216-829-11 METAL CHIP 4.7K 5% 1/16WR662 1-216-821-11 METAL CHIP 1K 5% 1/16WR663 1-216-841-11 METAL CHIP 47K 5% 1/16W
R664 1-216-841-11 METAL CHIP 47K 5% 1/16WR665 1-216-833-11 METAL CHIP 10K 5% 1/16WR666 1-216-864-11 METAL CHIP 0 5% 1/16WR667 1-216-841-11 METAL CHIP 47K 5% 1/16WR668 1-216-864-11 METAL CHIP 0 5% 1/16W
R670 1-216-827-11 METAL CHIP 3.3K 5% 1/16WR671 1-216-841-11 METAL CHIP 47K 5% 1/16WR672 1-216-841-11 METAL CHIP 47K 5% 1/16WR673 1-216-833-11 METAL CHIP 10K 5% 1/16WR674 1-216-841-11 METAL CHIP 47K 5% 1/16W
R675 1-216-841-11 METAL CHIP 47K 5% 1/16WR676 1-216-841-11 METAL CHIP 47K 5% 1/16WR677 1-216-841-11 METAL CHIP 47K 5% 1/16WR678 1-216-841-11 METAL CHIP 47K 5% 1/16WR679 1-216-841-11 METAL CHIP 47K 5% 1/16W
R680 1-216-833-11 METAL CHIP 10K 5% 1/16WR681 1-216-826-11 METAL CHIP 2.7K 5% 1/16WR682 1-216-826-11 METAL CHIP 2.7K 5% 1/16WR683 1-216-826-11 METAL CHIP 2.7K 5% 1/16WR693 1-216-839-11 METAL CHIP 33K 5% 1/16W
R694 1-216-833-11 METAL CHIP 10K 5% 1/16WR231A 1-216-821-11 METAL CHIP 1K 5% 1/16WR232A 1-216-821-11 METAL CHIP 1K 5% 1/16W
< COMPOSITION CIRCUIT BLOCK >
RB101 1-234-457-11 ENCAPSULATED COMPONENT
< VARIABLE RESISTOR >
RV101 1-241-765-11 RES, ADJ, CARBON 22K (TUNED)RV661 1-241-762-11 RES, ADJ, CARBON 2.2K (TAPE SPEED)
< RELAY >
RY371 1-755-373-11 RELAY
< TRANSFORMER >
T101 1-435-195-31 TRANSFORMER, DISCRIMINATOR
< VIBRATOR >
X101 1-760-549-31 VIBRATOR, CRYSTAL (4.5MHz)X601 1-567-098-41 VIBRATOR, CRYSTAL (32.768kHz)
64
Ref. No. Part No. Description Remarks Ref. No. Part No. Description Remarks
HCD-VX222
X602 1-781-107-21 VIBRATOR, SERAMIC (16MHz)*****************************************************
1-675-910-14 MOTOR BOARD***********
< CAPACITOR >
C721 1-162-306-11 CERAMIC 0.01uF 30% 16V
< CONNECTOR >
CN721 1-770-516-31 CONNECTOR, FFC 8PCN722 1-785-330-11 PIN, CONNECTOR (LIGHT ANGLE)4P
< SWITCH >
S701 1-771-822-11 SWITCH, LEVER (SLIDE) (OPEN/CLOSE)******************************************************
A-4476-992-A PANEL BOARD, COMPLETE (E,EA,IA,SP)A-4725-701-A PANEL BOARD, COMPLETE (TW)A-4726-002-A PANEL BOARD, COMPLETE (TH)A-4726-110-A PANEL BOARD, COMPLETE (E91)
*****************************
4-234-016-01 FL HOLDER7-685-872-09 SCREW +BVTT 3X8 (S)
< CAPACITOR >
C701 1-126-966-11 ELECT 33uF 20% 50VC702 1-126-966-11 ELECT 33uF 20% 50VC703 1-162-306-11 CERAMIC 0.01uF 30% 16VC704 1-124-589-11 ELECT 47uF 20% 16VC705 1-162-294-31 CERAMIC 0.001uF 10% 50V
C706 1-162-294-31 CERAMIC 0.001uF 10% 50VC707 1-162-294-31 CERAMIC 0.001uF 10% 50VC708 1-162-282-31 CERAMIC 100PF 10% 50VC709 1-162-282-31 CERAMIC 100PF 10% 50VC710 1-162-282-31 CERAMIC 100PF 10% 50V
C711 1-162-282-31 CERAMIC 100PF 10% 50VC712 1-162-282-31 CERAMIC 100PF 10% 50VC713 1-162-282-31 CERAMIC 100PF 10% 50VC714 1-162-282-31 CERAMIC 100PF 10% 50VC715 1-162-282-31 CERAMIC 100PF 10% 50V
C716 1-161-494-00 CERAMIC 0.022uF 25VC718 1-162-306-11 CERAMIC 0.01uF 30% 16VC719 1-162-219-31 CERAMIC 68PF 5% 50VC720 1-162-306-11 CERAMIC 0.01uF 30% 16VC721 1-124-589-11 ELECT 47uF 20% 16V
C722 1-162-282-31 CERAMIC 100PF 10% 50VC723 1-162-282-31 CERAMIC 100PF 10% 50VC724 1-162-282-31 CERAMIC 100PF 10% 50VC725 1-162-282-31 CERAMIC 100PF 10% 50VC726 1-162-282-31 CERAMIC 100PF 10% 50V
C727 1-162-282-31 CERAMIC 100PF 10% 50VC728 1-162-282-31 CERAMIC 100PF 10% 50VC729 1-162-282-31 CERAMIC 100PF 10% 50VC730 1-162-282-31 CERAMIC 100PF 10% 50VC731 1-162-282-31 CERAMIC 100PF 10% 50V
C732 1-162-282-31 CERAMIC 100PF 10% 50VC733 1-162-282-31 CERAMIC 100PF 10% 50VC734 1-162-306-11 CERAMIC 0.01uF 30% 16VC735 1-162-306-11 CERAMIC 0.01uF 30% 16VC736 1-162-294-31 CERAMIC 0.001uF 10% 50V
C737 1-162-294-31 CERAMIC 0.001uF 10% 50VC738 1-104-665-11 ELECT 100uF 20% 10VC739 1-104-665-11 ELECT 100uF 20% 10VC740 1-126-959-11 ELECT 0.47uF 20% 50VC741 1-126-959-11 ELECT 0.47uF 20% 50V
C742 1-136-495-11 FILM 0.068uF 5% 50VC743 1-162-294-31 CERAMIC 0.001uF 10% 50VC744 1-162-305-11 CERAMIC 0.0068uF 30% 16VC745 1-126-960-11 ELECT 1uF 20% 50VC746 1-126-947-11 ELECT 47uF 20% 16V
C747 1-136-167-00 FILM 0.15uF 5% 50VC748 1-126-947-11 ELECT 47uF 20% 16VC749 1-136-495-11 FILM 0.068uF 5% 50VC750 1-162-294-31 CERAMIC 0.001uF 10% 50VC751 1-162-305-11 CERAMIC 0.0068uF 30% 16V
C752 1-126-960-11 ELECT 1uF 20% 50VC753 1-110-671-31 CERAMIC 47000PF 50VC754 1-162-215-31 CERAMIC 47PF 5% 50VC755 1-126-957-11 ELECT 0.22uF 20% 50VC756 1-162-294-31 CERAMIC 0.001uF 10% 50V
C757 1-162-306-11 CERAMIC 0.01uF 30% 16VC758 1-126-956-11 ELECT 0.1uF 20% 50VC759 1-162-290-31 CERAMIC 470PF 10% 50VC760 1-126-961-11 ELECT 2.2uF 20% 50VC761 1-162-215-31 CERAMIC 47PF 5% 50V
C762 1-162-282-31 CERAMIC 100PF 10% 50VC763 1-126-961-11 ELECT 2.2uF 20% 50VC764 1-126-961-11 ELECT 2.2uF 20% 50VC765 1-126-964-11 ELECT 10uF 20% 50VC766 1-126-964-11 ELECT 10uF 20% 50V
C767 1-164-159-21 CERAMIC 0.1uF 50VC768 1-162-306-11 CERAMIC 0.01uF 30% 16VC769 1-126-956-11 ELECT 0.1uF 20% 50V
(E91)C769 1-126-957-11 ELECT 0.22uF 20% 50V
(EXCEPT E91)C770 1-164-159-21 CERAMIC 0.1uF 50V
C771 1-126-964-11 ELECT 10uF 20% 50VC772 1-126-964-11 ELECT 10uF 20% 50VC773 1-126-947-11 ELECT 47uF 20% 10VC774 1-126-935-11 ELECT 470uF 20% 10VC775 1-162-306-11 CERAMIC 0.01uF 30% 16V
C776 1-162-306-11 CERAMIC 0.01uF 30% 16VC777 1-164-159-21 CERAMIC 0.1uF 50VC780 1-164-159-21 CERAMIC 0.1uF 50VC781 1-162-282-31 CERAMIC 100PF 10% 50V
< CONNECTOR >
CN711 1-793-767-11 CONNECTOR, BOARD TO BOARD 30PCN712 1-785-339-11 PIN, CONNECTOR(LIGHT ANGLE)13P
< DIODE >
D701 8-719-071-44 DIODE SELS5223C-TP15D702 8-719-084-40 DIODE SEL5955A-TP15D703 8-719-084-40 DIODE SEL5955A-TP15D704 8-719-084-40 DIODE SEL5955A-TP15D705 8-719-084-40 DIODE SEL5955A-TP15
D706 8-719-084-40 DIODE SEL5955A-TP15D712 8-719-109-85 DIODE RD5.1ESB2D713 8-719-991-33 DIODE 1SS133T-77D714 8-719-991-33 DIODE 1SS133T-77D715 8-719-991-33 DIODE 1SS133T-77
MOTOR PANELMAIN
65
Ref. No. Part No. Description Remarks Ref. No. Part No. Description Remarks
HCD-VX222
D716 8-719-084-40 DIODE SEL5955A-TP15D717 8-719-084-40 DIODE SEL5955A-TP15D718 8-719-084-40 DIODE SEL5955A-TP15D719 8-719-084-40 DIODE SEL5955A-TP15D720 8-719-084-40 DIODE SEL5955A-TP15
D721 8-719-991-33 DIODE 1SS133T-77
< FERRITE BEAD >
FB701 1-412-473-21 INDUCTOR 0UH
< FLUORESCENT INDICATOR >
FLD1 1-518-729-12 INDICATOR TUBE, FLUORESCENT
< IC >
IC701 6-800-220-01 IC uPD780232GC-031-8BTIC702 8-759-710-97 IC NJM4565M(TE2)IC703 8-759-496-41 IC M65850FP-E1IC704 8-759-295-90 IC NJM2244M-TE2SEN701 8-759-827-70 IC NJL64H400A-1
< JACK >
J701 1-691-293-21 JACK (PHONES)J702 1-815-603-11 JACK (MIC 2)J703 1-815-603-11 JACK (MIC 1)J704 1-815-684-11 JACK, PIN 3P (INPUT)
< TRANSISTOR >
Q701 8-729-900-63 TRANSISTOR DTA124ESQ702 8-729-900-80 TRANSISTOR DTC114ESQ703 8-729-900-80 TRANSISTOR DTC114ESQ704 8-729-900-80 TRANSISTOR DTC114ESQ705 8-729-900-80 TRANSISTOR DTC114ES
Q706 8-729-900-80 TRANSISTOR DTC114ESQ711 8-729-119-78 TRANSISTOR 2SC2785-HFE
< RESISTOR >
R701 1-249-410-11 CARBON 270 5% 1/4WR702 1-249-411-11 CARBON 330 5% 1/4WR722 1-247-843-11 CARBON 3.3K 5% 1/4WR723 1-249-425-11 CARBON 4.7K 5% 1/4WR724 1-249-427-11 CARBON 6.8K 5% 1/4W
R725 1-249-429-11 CARBON 10K 5% 1/4WR738 1-249-421-11 CARBON 2.2K 5% 1/4WR740 1-249-404-00 CARBON 82 5% 1/4WR741 1-249-429-11 CARBON 10K 5% 1/4WR742 1-249-429-11 CARBON 10K 5% 1/4W
R743 1-249-434-11 CARBON 27K 5% 1/4WR744 1-249-434-11 CARBON 27K 5% 1/4WR747 1-249-429-11 CARBON 10K 5% 1/4WR748 1-249-429-11 CARBON 10K 5% 1/4WR749 1-249-429-11 CARBON 10K 5% 1/4W
R750 1-249-429-11 CARBON 10K 5% 1/4WR751 1-249-437-11 CARBON 47K 5% 1/4WR752 1-249-429-11 CARBON 10K 5% 1/4WR753 1-249-429-11 CARBON 10K 5% 1/4WR755 1-249-429-11 CARBON 10K 5% 1/4W
R756 1-247-807-31 CARBON 100 5% 1/4WR757 1-249-429-11 CARBON 10K 5% 1/4WR758 1-247-807-31 CARBON 100 5% 1/4WR759 1-249-429-11 CARBON 10K 5% 1/4WR760 1-247-807-31 CARBON 100 5% 1/4W
R761 1-249-429-11 CARBON 10K 5% 1/4WR762 1-247-807-31 CARBON 100 5% 1/4WR763 1-249-429-11 CARBON 10K 5% 1/4WR764 1-249-429-11 CARBON 10K 5% 1/4WR765 1-247-903-00 CARBON 1M 5% 1/4W
R767 1-249-429-11 CARBON 10K 5% 1/4WR768 1-247-807-31 CARBON 100 5% 1/4WR769 1-249-401-11 CARBON 47 5% 1/4WR770 1-249-417-11 CARBON 1K 5% 1/4WR771 1-249-430-11 CARBON 12K 5% 1/4W
R772 1-249-429-11 CARBON 10K 5% 1/4WR773 1-249-433-11 CARBON 22K 5% 1/4WR774 1-249-433-11 CARBON 22K 5% 1/4WR775 1-249-433-11 CARBON 22K 5% 1/4WR776 1-249-410-11 CARBON 270 5% 1/4W
R777 1-247-881-00 CARBON 120K 5% 1/4WR778 1-249-437-11 CARBON 47K 5% 1/4WR779 1-249-433-11 CARBON 22K 5% 1/4WR780 1-249-433-11 CARBON 22K 5% 1/4WR781 1-249-433-11 CARBON 22K 5% 1/4W
R782 1-249-431-11 CARBON 15K 5% 1/4WR783 1-249-417-11 CARBON 1K 5% 1/4WR784 1-249-441-11 CARBON 100K 5% 1/4WR785 1-249-429-11 CARBON 10K 5% 1/4WR786 1-249-417-11 CARBON 1K 5% 1/4W
R787 1-249-437-11 CARBON 47K 5% 1/4WR788 1-247-807-31 CARBON 100 5% 1/4WR789 1-249-429-11 CARBON 10K 5% 1/4WR790 1-247-885-00 CARBON 180K 5% 1/4WR791 1-247-807-31 CARBON 100 5% 1/4W
R792 1-249-441-11 CARBON 100K 5% 1/4WR793 1-249-429-11 CARBON 10K 5% 1/4WR794 1-249-417-11 CARBON 1K 5% 1/4WR795 1-249-431-11 CARBON 15K 5% 1/4WR796 1-249-401-11 CARBON 47 5% 1/4W
R799 1-249-401-11 CARBON 47 5% 1/4WR800 1-249-429-11 CARBON 10K 5% 1/4WR801 1-247-804-11 CARBON 75 5% 1/4WR805 1-247-807-31 CARBON 100 5% 1/4WR806 1-249-403-11 CARBON 68 5% 1/4W
< VIBRATOR >
RES701 1-795-058-21 VIBRATOR, CERAMIC (5MHz)
< SWITCH >
S701 1-762-875-21 SWITCH, KEYBOARD (I/ 1)S702 1-762-875-21 SWITCH, KEYBOARD (GAME)S722 1-762-875-21 SWITCH, KEYBOARD (MD (VIDEO))S723 1-762-875-21 SWITCH, KEYBOARD (TAPE A/B)S724 1-762-875-21 SWITCH, KEYBOARD (TUNER/BAND)
S725 1-762-875-21 SWITCH, KEYBOARD (CD)
< VARIABLE RESISTOR >
VR701 1-418-725-11 ENCODER, ROTARY (12 TYPE) (VOLUME)VR702 1-225-739-11 RES, VAR CARBON 50K (ECHO LEVEL)VR703 1-225-739-11 RES, VAR CARBON 50K (MIC LEVEL)
******************************************************
PANEL
66
Ref. No. Part No. Description Remarks Ref. No. Part No. Description Remarks
HCD-VX222
The components identified by mark 0 ordotted line with mark 0 are critical forsafety.Replace only with part number specified.
A-4476-990-A POWER AMP BOARD, COMPLETE (E,EA,IA,SP)A-4725-699-A POWER AMP BOARD, COMPLETE (TW)A-4726-000-A POWER AMP BOARD, COMPLETE (TH)A-4726-270-A POWER AMP BOARD, COMPLETE (E91)
********************************
< CAPACITOR >
C501 1-126-964-11 ELECT 10uF 20% 50VC502 1-162-294-31 CERAMIC 0.001uF 10% 50VC503 1-162-282-31 CERAMIC 100PF 10% 50VC504 1-128-551-11 ELECT 22uF 20% 25VC507 1-130-493-00 MYLAR 0.068uF 5% 50V
C508 1-130-493-00 MYLAR 0.068uF 5% 50VC509 1-126-965-11 ELECT 22uF 20% 50VC511 1-162-306-11 CERAMIC 0.01uF 30% 16VC512 1-162-294-31 CERAMIC 0.001uF 10% 50V
(TW)C513 1-162-294-31 CERAMIC 0.001uF 10% 50V
(TW)
C541 1-137-749-11 MYLAR 0.1uF 100VC542 1-135-832-11 ELECT 2200uF 20% 50VC542 1-135-832-21 ELECT 2200uF 20% 50VC543 1-164-159-21 CERAMIC 0.1uF 50VC544 1-126-942-61 ELECT 1000uF 20% 25V
C545 1-128-549-11 ELECT 3300uF 20% 35VC551 1-126-964-11 ELECT 10uF 20% 50VC552 1-162-294-31 CERAMIC 0.001uF 10% 50VC553 1-162-282-31 CERAMIC 100PF 10% 50VC554 1-128-551-11 ELECT 22uF 20% 25V
C557 1-130-493-00 MYLAR 0.068uF 5% 50VC558 1-130-493-00 MYLAR 0.068uF 5% 50VC559 1-126-965-11 ELECT 22uF 20% 50VC591 1-137-749-11 MYLAR 0.1uF 100VC592 1-135-832-11 ELECT 2200uF 20% 50V
C592 1-135-832-21 ELECT 2200uF 20% 50V
< CONNECTOR >
CN502 1-778-981-21 CONNECTOR, BOARD TO BOARD 13PCN503 1-778-981-21 CONNECTOR, BOARD TO BOARD 13P
< DIODE >
D501 8-719-991-33 DIODE 1SS133T-77D502 8-719-991-33 DIODE 1SS133T-77D541 8-719-510-68 DIODE D5SBA204101D542 8-719-200-82 DIODE 11ES2D543 8-719-200-82 DIODE 11ES2
D551 8-719-991-33 DIODE 1SS133T-77
< TERMINAL >
EP501 1-537-738-21 TERMINAL, EARTH (TW)* EP502 1-537-738-21 TERMINAL, EARTH
< IC >
IC501 8-749-016-93 IC STK402-070S
< TRANSISTOR >
Q501 8-729-140-84 TRANSISTOR 2SC1841-PAFAEAQ503 8-729-140-82 TRANSISTOR 2SA988-PAFAEAQ504 8-729-140-84 TRANSISTOR 2SC1841-PAFAEAQ551 8-729-140-84 TRANSISTOR 2SC1841-PAFAEA
Q581 8-729-140-84 TRANSISTOR 2SC1841-PAFAEA
< RESISTOR >
R501 1-249-417-11 CARBON 1K 5% 1/4WR502 1-249-438-11 CARBON 56K 5% 1/4WR503 1-249-418-11 CARBON 1.2K 5% 1/4WR504 1-249-438-11 CARBON 56K 5% 1/4WR505 1-249-417-11 CARBON 1K 5% 1/4W
R506 1-249-431-11 CARBON 15K 5% 1/4WR507 1-249-441-11 CARBON 100K 5% 1/4W
0R508 1-217-151-00 METAL 0.22 10% 2WR509 1-260-076-11 CARBON 10 5% 1/2W
0R510 1-217-151-00 METAL 0.22 10% 2W
0R511 1-212-881-11 FUSIBLE 100 5% 1/4W0R512 1-202-972-61 FUSIBLE 1 5% 1/4W
R513 1-249-433-11 CARBON 22K 5% 1/4WR514 1-249-421-11 CARBON 2.2K 5% 1/4WR515 1-249-433-11 CARBON 22K 5% 1/4W
R516 1-249-429-11 CARBON 10K 5% 1/4WR517 1-249-421-11 CARBON 2.2K 5% 1/4WR518 1-249-429-11 CARBON 10K 5% 1/4WR519 1-249-433-11 CARBON 22K 5% 1/4WR541 1-260-115-11 CARBON 22K 5% 1/2W
R551 1-249-417-11 CARBON 1K 5% 1/4WR552 1-249-438-11 CARBON 56K 5% 1/4WR553 1-249-418-11 CARBON 1.2K 5% 1/4WR554 1-249-438-11 CARBON 56K 5% 1/4WR555 1-249-417-11 CARBON 1K 5% 1/4W
R556 1-249-431-11 CARBON 15K 5% 1/4WR557 1-249-441-11 CARBON 100K 5% 1/4W
0R558 1-217-151-00 METAL 0.22 10% 2WR559 1-260-076-11 CARBON 10 5% 1/2W
0R560 1-217-151-00 METAL 0.22 10% 2W
0R561 1-212-881-11 FUSIBLE 100 5% 1/4WR581 1-249-435-11 CARBON 33K 5% 1/4WR582 1-249-435-11 CARBON 33K 5% 1/4WR591 1-260-115-11 CARBON 22K 5% 1/2W
0R592 1-219-591-11 FUSIBLE 0.1 5% 1/2W
0R593 1-219-119-11 FUSIBLE 0.1 5% 1/4W******************************************************
1-681-445-11 SUB TRANS BOARD***************
< CAPACITOR >
0C901 1-113-925-11 CERAMIC 0.01uF 20% 250VC902 1-126-768-11 ELECT 2200uF 20% 16VC903 1-126-933-11 ELECT 100uF 20% 16V
< CONNECTOR >
CN2 1-568-106-11 PIN, CONNECTOR 4P (E,EA,IA,SP,TW)CN2 1-564-321-00 PIN, CONNECTOR 2P (E91,TH)CN901 1-564-321-00 PIN, CONNECTOR 2PCN903 1-785-315-11 PIN, CONNECTOR (STRAIGHT) 3P
< DIODE >
D901 8-719-991-33 DIODE 1SS133T-77D902 8-719-200-82 DIODE 11ES2D903 8-719-200-82 DIODE 11ES2
SUB TRANSPOWER AMP
67
Ref. No. Part No. Description Remarks Ref. No. Part No. Description Remarks
HCD-VX222
D904 8-719-200-82 DIODE 11ES2D905 8-719-200-82 DIODE 11ES2
< IC >
IC901 8-759-158-62 IC TA78057S
< TRANSISTOR >
Q901 8-729-119-78 TRANSISTOR 2SC2785-HFE
< RESISTOR >
R902 1-249-429-11 CARBON 10K 5% 1/4W
< RELAY >
0RY901 1-755-276-11 RELAY, POWER
< TRANSFORMER >
0T901 1-435-828-11 TRANSFORMER, POWER********************************************************
1-681-444-11 TRANS BOARD***********
1-533-217-31 HOLDER, FUSE
< CAPACITOR >
C911 1-128-553-11 ELECT 220uF 20% 63VC912 1-126-964-11 ELECT 10uF 20% 50VC913 1-126-968-11 ELECT 100uF 20% 50VC915 1-164-159-21 CERAMIC 0.1uF 50V
< CONNECTOR >
CN915 1-564-528-11 PLUG, CONNECTOR 13P
< DIODE >
D911 8-719-200-82 DIODE 11ES2D912 8-719-982-20 DIODE MTZJ-30BD913 8-719-109-89 DIODE RD5.6ESB2
< FUSE >
0F914 1-533-473-11 FUSE, GLASS TUBE (DIA. 5) T6.3AL 250V0F919 1-533-471-11 FUSE, GLASS TUBE (DIA. 5) T4AL 250V
(E,EA,IA,SP,TW)0F920 1-533-473-11 FUSE, GLASS TUBE (DIA. 5) T6.3AL 250V
< TRANSISTOR >
Q911 8-729-048-52 TRANSISTOR 2SA1932(TP)
< RESISTOR >
R905 1-249-429-11 CARBON 10K 5% 1/4W0R911 1-217-637-00 FUSIBLE 1 5% 1/4W
R912 1-249-417-11 CARBON 1K 5% 1/4WR913 1-249-429-11 CARBON 10K 5% 1/4WR915 1-247-807-31 CARBON 100 5% 1/4W
R916 1-247-807-31 CARBON 100 5% 1/4W0R919 1-219-122-91 FUSIBLE 0.33 5% 1/4W0R920 1-219-122-91 FUSIBLE 0.33 5% 1/4W
< SWITCH >
0S901 1-786-055-21 SELECTOR, VOLTAGE (VOLTAGE SELECTOR)(E,EA,IA,SP,TW)
< TRANSFORMER >
0T911 1-437-221-11 TRANSFORMER, POWER******************************************************
A-4726-022-A VIDEO BOARD, COMPLETE (E,EA,IA,SP)A-4726-025-A VIDEO BOARD, COMPLETE (TW)A-4726-027-A VIDEO BOARD, COMPLETE (TH)A-4726-071-A VIDEO BOARD, COMPLETE (E91)
*****************************
< CAPACITOR >
C101 1-124-778-00 ELECT CHIP 22uF 20% 6.3VC102 1-163-143-00 CERAMIC CHIP 0.0012uF 5% 50VC103 1-163-017-00 CERAMIC CHIP 0.0047uF 5% 50VC201 1-124-778-00 ELECT CHIP 22uF 20% 6.3VC202 1-163-143-00 CERAMIC CHIP 0.0012uF 5% 50V
C203 1-163-017-00 CERAMIC CHIP 0.0047uF 5% 50VC304 1-163-127-00 CERAMIC CHIP 270PF 5% 50VC305 1-163-235-11 CERAMIC CHIP 22PF 5% 50VC306 1-163-127-00 CERAMIC CHIP 270PF 5% 50VC307 1-163-235-11 CERAMIC CHIP 22PF 5% 50V
C308 1-163-263-11 CERAMIC CHIP 330PF 5% 50VC309 1-163-263-11 CERAMIC CHIP 330PF 5% 50VC310 1-165-319-11 CERAMIC CHIP 0.1uF 50VC311 1-124-778-00 ELECT CHIP 22uF 20% 6.3VC312 1-163-017-00 CERAMIC CHIP 0.0047uF 5% 50V
C313 1-163-259-91 CERAMIC CHIP 220PF 5% 50VC314 1-163-235-11 CERAMIC CHIP 22PF 5% 50VC315 1-163-255-11 CERAMIC CHIP 150PF 5% 50VC316 1-165-319-11 CERAMIC CHIP 0.1uF 50VC317 1-126-193-11 ELECT 1uF 20% 50V
C318 1-165-319-11 CERAMIC CHIP 0.1uF 50VC319 1-126-206-11 ELECT CHIP 100uF 20% 6.3VC320 1-126-206-11 ELECT CHIP 100uF 20% 6.3VC321 1-126-206-11 ELECT CHIP 100uF 20% 6.3VC322 1-126-206-11 ELECT CHIP 100uF 20% 6.3V
C323 1-126-206-11 ELECT CHIP 100uF 20% 6.3VC324 1-165-319-11 CERAMIC CHIP 0.1uF 50VC325 1-165-319-11 CERAMIC CHIP 0.1uF 50VC401 1-165-319-11 CERAMIC CHIP 0.1uF 50VC402 1-124-778-00 ELECT CHIP 22uF 20% 6.3V
C504 1-165-319-11 CERAMIC CHIP 0.1uF 50VC505 1-126-206-11 ELECT CHIP 100uF 20% 6.3VC506 1-165-319-11 CERAMIC CHIP 0.1uF 50VC507 1-126-206-11 ELECT CHIP 100uF 20% 6.3VC508 1-126-206-11 ELECT CHIP 100uF 20% 6.3V
C509 1-163-275-11 CERAMIC CHIP 0.001uF 5% 50VC510 1-165-319-11 CERAMIC CHIP 0.1uF 50VC531 1-126-206-11 ELECT CHIP 100uF 20% 6.3VC532 1-165-319-11 CERAMIC CHIP 0.1uF 50VC535 1-165-319-11 CERAMIC CHIP 0.1uF 50V
C536 1-126-193-11 ELECT 1uF 20% 50VC537 1-126-206-11 ELECT CHIP 100uF 20% 6.3VC539 1-165-319-11 CERAMIC CHIP 0.1uF 50VC540 1-126-206-11 ELECT CHIP 100uF 20% 6.3VC541 1-165-319-11 CERAMIC CHIP 0.1uF 50V
C542 1-126-206-11 ELECT CHIP 100uF 20% 6.3VC543 1-126-206-11 ELECT CHIP 100uF 20% 6.3VC544 1-165-319-11 CERAMIC CHIP 0.1uF 50V
SUB TRANS TRANS
The components identified by mark 0 ordotted line with mark 0 are critical forsafety.Replace only with part number specified.
VIDEO
68
Ref. No. Part No. Description Remarks Ref. No. Part No. Description Remarks
HCD-VX222
C545 1-165-319-11 CERAMIC CHIP 0.1uF 50VC546 1-165-319-11 CERAMIC CHIP 0.1uF 50V
C547 1-126-193-11 ELECT 1uF 20% 50VC548 1-165-319-11 CERAMIC CHIP 0.1uF 50VC549 1-165-319-11 CERAMIC CHIP 0.1uF 50VC550 1-163-275-11 CERAMIC CHIP 0.001uF 5% 50VC551 1-165-319-11 CERAMIC CHIP 0.1uF 50V
C552 1-165-319-11 CERAMIC CHIP 0.1uF 50VC553 1-126-206-11 ELECT CHIP 100uF 20% 6.3VC555 1-124-778-00 ELECT CHIP 22uF 20% 6.3VC556 1-165-319-11 CERAMIC CHIP 0.1uF 50VC559 1-126-206-11 ELECT CHIP 100uF 20% 6.3V
C561 1-163-089-00 CERAMIC CHIP 6PF 50VC563 1-165-319-11 CERAMIC CHIP 0.1uF 50VC564 1-165-319-11 CERAMIC CHIP 0.1uF 50VC565 1-126-206-11 ELECT CHIP 100uF 20% 6.3VC566 1-165-319-11 CERAMIC CHIP 0.1uF 50V
C568 1-126-206-11 ELECT CHIP 100uF 20% 6.3VC569 1-126-206-11 ELECT CHIP 100uF 20% 6.3VC570 1-126-206-11 ELECT CHIP 100uF 20% 6.3VC571 1-128-065-11 ELECT CHIP 68uF 20% 10VC573 1-163-235-11 CERAMIC CHIP 22PF 5% 50V
C574 1-163-235-11 CERAMIC CHIP 22PF 5% 50VC576 1-163-235-11 CERAMIC CHIP 22PF 5% 50VC577 1-163-235-11 CERAMIC CHIP 22PF 5% 50V
< CONNECTOR >
CN301 1-564-506-11 PLUG, CONNECTOR 3PCN501 1-779-343-21 CONNECTOR, FFC/FPC 23PCN502 1-779-416-11 CONNECTOR,FFC(LIF(NON-ZIF))13P
< TRIMMER >
CT503 1-141-539-11 CAP, ADJ 10PF
< DIODE >
D501 8-719-056-77 DIODE UDZ-TE-17-3.9B
< IC >
IC101 8-759-701-40 IC NJM2100M(TE2)IC301 8-759-530-30 IC TC74VHCU04FT(EL)IC302 8-759-662-94 IC NJM2255M(TE2)IC303 8-759-711-47 IC NJM2209M(TE2)IC304 8-759-662-95 IC BA7665FS-E2
IC501 8-759-530-30 IC TC74VHCU04FT(EL)IC502 6-800-186-01 IC M30620MCA-B22FPIC504 8-759-530-30 IC TC74VHCU04FT(EL)IC505 8-759-535-48 IC CL680T-D1IC506 6-800-133-01 IC HT23C020-H001S
IC507 8-759-342-01 IC MSM514260C-60JSIC509 8-759-535-62 IC PCM1727E-2/T2
< JACK >
J301 1-537-943-11 TERMINAL, S (S VIDEO OUT)
< JUMPER RESISTOR >
JW101 1-216-295-00 SHORT 0JW201 1-216-295-00 SHORT 0JW301 1-216-295-00 SHORT 0JW302 1-216-025-11 RES-CHIP 100 5% 1/10W
JW304 1-216-295-00 SHORT 0
JW413 1-216-295-00 SHORT 0JW504 1-216-295-00 SHORT 0JW505 1-216-295-00 SHORT 0JW513 1-216-295-00 SHORT 0
< COIL >
L301 1-410-372-21 INDUCTOR 1.8uHL302 1-410-372-21 INDUCTOR 1.8uHL303 1-410-658-31 INDUCTOR CHIP 220uHL501 1-216-296-11 SHORT 0L502 1-216-296-11 SHORT 0
L504 1-410-375-11 INDUCTOR CHIP 3.3uHL505 1-216-296-11 SHORT 0L506 1-216-296-11 SHORT 0L507 1-216-296-11 SHORT 0L508 1-216-296-11 SHORT 0
L509 1-216-296-11 SHORT 0L510 1-216-296-11 SHORT 0L511 1-469-705-21 INDUCTOR 0uHL512 1-469-705-21 INDUCTOR 0uHL513 1-469-705-21 INDUCTOR 0uH
< TRANSISTOR >
Q501 8-729-900-53 TRANSISTOR DTC114EKA-T146Q502 8-729-900-53 TRANSISTOR DTC114EKA-T146Q531 8-729-140-75 TRANSISTOR 2SD999-T1-CLCK
< RESISTOR >
R101 1-216-073-00 RES-CHIP 10K 5% 1/10WR102 1-208-441-61 RES-CHIP 1.5K 2% 1/10WR103 1-208-441-61 RES-CHIP 1.5K 2% 1/10WR201 1-216-073-00 RES-CHIP 10K 5% 1/10WR202 1-208-441-61 RES-CHIP 1.5K 2% 1/10W
R203 1-208-441-61 RES-CHIP 1.5K 2% 1/10WR302 1-216-624-11 METAL CHIP 75 0.5% 1/10WR303 1-216-624-11 METAL CHIP 75 0.5% 1/10WR306 1-216-624-11 METAL CHIP 75 0.5% 1/10WR308 1-216-073-00 RES-CHIP 10K 5% 1/10W
R309 1-216-073-00 RES-CHIP 10K 5% 1/10WR310 1-216-057-00 METAL CHIP 2.2K 5% 1/10WR311 1-216-029-00 METAL CHIP 150 5% 1/10WR312 1-216-073-00 RES-CHIP 10K 5% 1/10WR313 1-216-073-00 RES-CHIP 10K 5% 1/10W
R314 1-216-059-00 METAL CHIP 2.7K 5% 1/10WR315 1-216-624-11 METAL CHIP 75 0.5% 1/10WR316 1-216-022-00 METAL CHIP 75 5% 1/10WR317 1-216-022-00 METAL CHIP 75 5% 1/10WR318 1-216-295-00 SHORT 0
R319 1-216-624-11 METAL CHIP 75 0.5% 1/10WR320 1-216-295-00 SHORT 0R403 1-216-057-00 METAL CHIP 2.2K 5% 1/10WR404 1-216-057-00 METAL CHIP 2.2K 5% 1/10WR501 1-216-025-11 RES-CHIP 100 5% 1/10W
R502 1-216-025-11 RES-CHIP 100 5% 1/10WR503 1-216-025-11 RES-CHIP 100 5% 1/10WR504 1-216-025-11 RES-CHIP 100 5% 1/10WR505 1-216-025-11 RES-CHIP 100 5% 1/10WR506 1-216-025-11 RES-CHIP 100 5% 1/10W
R507 1-216-073-00 RES-CHIP 10K 5% 1/10W
VIDEO
69
Ref. No. Part No. Description Remarks Ref. No. Part No. Description Remarks
HCD-VX222
R508 1-216-073-00 RES-CHIP 10K 5% 1/10WR516 1-216-073-00 RES-CHIP 10K 5% 1/10WR517 1-216-073-00 RES-CHIP 10K 5% 1/10WR518 1-216-073-00 RES-CHIP 10K 5% 1/10W
R519 1-216-025-11 RES-CHIP 100 5% 1/10WR520 1-216-057-00 METAL CHIP 2.2K 5% 1/10WR521 1-216-073-00 RES-CHIP 10K 5% 1/10WR523 1-216-013-00 METAL CHIP 33 5% 1/10WR530 1-216-025-11 RES-CHIP 100 5% 1/10W
R531 1-216-025-11 RES-CHIP 100 5% 1/10WR532 1-216-295-00 SHORT 0R533 1-216-295-00 SHORT 0R534 1-216-073-00 RES-CHIP 10K 5% 1/10WR535 1-216-073-00 RES-CHIP 10K 5% 1/10W
R536 1-216-033-00 METAL CHIP 220 5% 1/10WR537 1-216-025-11 RES-CHIP 100 5% 1/10WR538 1-216-073-00 RES-CHIP 10K 5% 1/10WR539 1-216-295-00 SHORT 0R540 1-216-295-00 SHORT 0
R542 1-216-651-11 METAL CHIP 1K 0.5% 1/10WR543 1-216-685-11 METAL CHIP 27K 0.5% 1/10WR544 1-216-659-11 METAL CHIP 2.2K 0.5% 1/10WR545 1-216-025-11 RES-CHIP 100 5% 1/10WR546 1-216-049-11 RES-CHIP 1K 5% 1/10W
R548 1-216-049-11 RES-CHIP 1K 5% 1/10WR549 1-216-025-11 RES-CHIP 100 5% 1/10WR550 1-216-025-11 RES-CHIP 100 5% 1/10WR551 1-216-025-11 RES-CHIP 100 5% 1/10WR552 1-216-025-11 RES-CHIP 100 5% 1/10W
R555 1-216-121-11 RES-CHIP 1M 5% 1/10WR556 1-216-025-11 RES-CHIP 100 5% 1/10WR557 1-216-025-11 RES-CHIP 100 5% 1/10WR560 1-216-653-11 METAL CHIP 1.2K 0.5% 1/10WR561 1-216-651-11 METAL CHIP 1K 0.5% 1/10W
R562 1-216-073-00 RES-CHIP 10K 5% 1/10WR563 1-216-073-00 RES-CHIP 10K 5% 1/10WR577 1-216-081-00 METAL CHIP 22K 5% 1/10WR578 1-216-081-00 METAL CHIP 22K 5% 1/10WR579 1-216-073-00 RES-CHIP 10K 5% 1/10W
R580 1-216-073-00 RES-CHIP 10K 5% 1/10W
< VIBRATOR >
X501 1-767-510-11 VIBRATOR, CERAMIC (10MHz)X503 1-767-519-11 VIBRATOR, CRYSTAL (27MHz)
*******************************************************
1-681-441-11 VIDEO OUT BOARD**************
< CONNECTOR >
CN714 1-564-505-11 PLUG, CONNECTOR 2P
< JACK >
JK705 1-774-227-11 JACK, PIN 1P (VIDEO OUT)******************************************************
MISCELLANEOUS*************
13 1-769-986-11 WIRE (FLAT TYPE) (13 CORE)14 1-792-246-11 WIRE (FLAT TYPE) (23 CORE)70 1-796-123-11 DECK, MECH101 1-773-049-11 WIRE (FLAT TYPE) (17 CORE)104 1-769-986-11 WIRE (FLAT TYPE) (13 CORE)
0108 1-777-071-81 CORD, POWER (EA,SP,TW)0108 1-790-880-11 CORD, POWER (WITH CONNECTOR) (E91)0109 1-569-008-21 ADAPTOR, CONVERSION (EA,SP,TW,EA,SP,TW)0110 1-791-901-11 CORD, POWER (E3,IA,TH)0111 1-569-007-11 ADAPTOR, CONVERSION 2P (E,IA)
259 1-791-983-11 WIRE (FLAT TYPE) (8 CORE)266 1-471-035-11 MAGNET ASSY
0286 8-820-116-01 DEVICE,OPTICAL KSM-213DCP/Z-NP288 1-782-817-11 WIRE (FLAT TYPE) (16 CORE)FLD1 1-518-729-11 INDICATOR TUBE, FLUORESCENT
M721 A-4672-826-A MOTOR ASSY******************************************************
**************HARDWARE LIST**************
#1 7-685-871-01 SCREW +BVTT 3X6 (S)#2 7-685-880-09 SCREW +BVTT 4X6 (S)#3 7-685-647-79 SCREW +BVTP 3X10 TYPE2 N-S#4 7-685-650-79 SCREW +BVTP 3X16 TYPE2 IT-3#5 7-685-872-09 SCREW +BVTT 3X8 (S)
#6 7-685-648-79 SCREW +BVTP 3X12 TYPE2 N-S#7 7-685-646-79 SCREW +BVTP 3X8 TYPE2 N-S
VIDEO VIDEO OUT
The components identified by mark 0 ordotted line with mark 0 are critical forsafety.Replace only with part number specified.
HCD-VX222
REVISION HISTORY
Clicking the version allows you to jump to the revised page.Also, clicking the version at the upper right on the revised page allows you to jump to the next revisedpage.
Ver. Date Description of Revision1.2 2001.09 Addition of Thai (silver) model. ( ENG-01003 )
1.1 2001. 07 Addition of Service note, Disassembly, Test mode, Adjustment andDiagrams.
1.0 2001. 06 New