catalogo partes y piezas gram hc 8100

Spare Parts List

Red rocatin (am resson, I!pe HC HGI../HGH 6100/8100

GB 82..600-0053 ..00

.Gram RefrigerationYORK INTERNATIONAL AISDK-6500 Vojens . Tel.: (+45) 74 20 40 00 . Fax: (+45) 74 20 40 40

Reciprocating Compressor ManualilGram Refrig-=e-=--r=a-=.::ti::.....:::o:.....::...n=-- --=-_-=-- _Spare Parts List

HC/HCL/HCH 6100/8100Article No. 82-600-0053-01

Contents

ln general:

Introduction............................................................................................................. 1

Lists of Spare Parts:

Spare Part List HC 6100/8100.................................................................................... 2100 mm Compresser, Front View 6Longitudinal Section, 100 mm Compressor 7Sectional View, 100 mm Compressor 8100 mm Compresser, Back View...................................................................... 9100 mm Compressor, Sectional View, Cylinder 10100 mm Compressor, Longitudinal Section, mech. seal 11Oil Pump for 100 mm Compressor 12

By-pass Valve 023 mm, 25 and 12 bar......... 13Connecting Rod + Piston, complete, for 100 mm Compressor 14Cylinder with Capacity Control for 100 mm Compressor 15Cylinder without Capacity Control for 100 mm Compressor 16Discharge Valve Complete for 100 mm Compressor 17Suction Filter Complete for 100 mm Compressor........................................................... 18Pressure Gauge Panel for 100 mm Compressor 19Oil Cooler for 100 mm Compressor 20Liquid spring for 100 mm Compressor 21Coupling for 100 mm Compressor 22Manometers 23Oil Filling Valve GVAC 24Electrical Heater and Stem Bulb.................................................................................. 26

Further documentation:- Technical Data.- Service Directions for HC 6100/8100.- Installation Directions for HC 6100/8100.- Operating and Maintenance Directions for HC 6100/8100.- Design Data.

Redprocating Compressor Manual~Gram Refrig-=e-=-r-=-=a.....:::...;ti:......:=o=--=-n-=-.. ~ _Spare Parts List


Page 1

Introduction

ApplicationThis manual is used when ordering spare parts.

Compressors of the HC type are intended fornormal cold-storage rooms.HCH compressors are intended for higherpressure and temperature conditions, e.g. airconditioning and heat pumps.HCl compressors are used as law-pressurecompressors at two-stage plants.

IdentificationThe compressor is provided with a name plateshowing manufacturing year, seriai number,type, refrigerant etc.

Order for spare partsln case of inquiries and orders for spare parts,please always give model, seriai number,refrigerant, and order number, if indicated.

Redprocating Compressor Manual_Gram Refrig....::::..e-=--ra=t..=.::i:....=:o--=-.;n:::.-~ -----:. _

Spare Parts ListHC/HCL/HCH 6100/8100

Article No. 82-600-0053-01Page 2

Spare Part List He 6100/8100

Item Designation No. Remark2 Compressor body. 6 cvl.. 100mm 776002003

Compressor body. 8 cvl., 100mm 7760020043 Bearing cover. rear 7760020064 Gasket for end cover at shaft seal 7760020395 Inside hexagon screw. M 16x50 42078 12856 Bearing cover, front 7760020057 Gasket for bearing cover at shaft seal 7760020378 Inside hexagon screw. M 16x50 42078 12859 Top cover LT 77600201010 Gasket for top cover 77600203511 Inside hexagon screw. M16x140 42078 129812 Side cover 77600200713 Gasket for side cover 77600203614 Inside hexagon screw. M 16x70 42078 128815 Cover for suction filter 77 600201316 Gasket for suction filter 77600203817 Inside hexagon screw. M 16x30 42 078 128118 Cover for shaft seal 77600200819 Gasket for shaft seal. 1005-T 77600075620 Inside hexagon screw, M 16x40 42078 128321 Cover for suction chamber 77615201522 Gasket for suction cham ber 77615 101923 Inside hexagon screw, M 16x40 42078 128324 Cover for discharge cham ber 77600201425 Gasket for discharge cham ber 77600204026 Inside hexagon screw, M16x40 42078 128327 Blanking plug 77 600216028 O-ring 2347PRP223. 40,87x3,53 55084011429 Plug, 1 1/2" RG 77 255 127230 Plug M30 77 600216531 Allen plug, RC 1/2" 46152101232 Allen plug, RC 1/8" 46 152 100333 Plug, M20 77 600 216734 Aluminium ring, 30 x 21 x 2 55065704436 Sight glass, 060 x 7 470400008

Reciprocating Compressor Manual Gram Refrig-=e-=-r==a~ti=-=o=-=n-=-~ ---=_--=-- _Spare Parts List

HC/HCl/HCH 6100/8100Article No. 82-600-0053-01

Page 3

Item Designation No. Remark37 O-ring 2347 PRP 125, 32.99 x 2.62 55084006238 Inside hexagon screw, M6x20 42078 110139 Ring screw DIN 580. M24 42 246 110540 Insert pipe for heater, L2=260, 75/100/125-152 77 580 1136

mm

41 Aluminium ring, 35 x 27 x 3 55065702142 Aluminium ring, 36 x 31 x 2 55065705944 Aluminium ring, 58 x 48 x 2 55065705645 Allen plug, RC 1/4" 46 152 100650 ail screen 77600207251 Inside hexagon screw, M8x30 42078 114352 Lock nut. M8 42 153200659 a-ring 2347 PRP 333, 62.87 x 5.33 55084018160 ail cylinder 77600209061 Nut 42 122201362 Piston rod for capacity control 77 600209163 a-ring. 8,73x1 ,78 55089000864 Piston plate for capacity control 77600209765 U-sleeve 55 110085066 Spring guide for capacity control 77600209367 Spring for capacity control 77600209668 Crossbar for capacity control 77600209469 Lifting arm for capacity control 77600209570 Disc spring. 28x10,2xO,80 46 158 106271 Lock nut, M 10 42 148 211273 Screwed connection, WE-8-LLRG 46085200674 Spacer for capacity conmtrol 77600 116775 Main bearing 77600202076 Thrust bearing 77 600202177 Screwed connection, A-8-RLL 46097 200680 Crankshaft. 6 cyl., 100mm 776000725

Crankshaft. 8 cvl., 100mm 77 600051081 Driver for ail pump 77600206582 Bush for driver 77600205783 Countersunk hex. screw. M6x12 42080 104785 Key type A. 18x11 x80 46 154 114586 Locking plate/flywheel 77600117287 External tab washer. 021 42 184101888 Machine screw. M20x50 42009228190 Spring holder for shaft seal 776000750

Reciprocating Compressor Manual_Gram Refrig-=.e-=-ra=t-=:;i:...=o....::...;n::....-1Ill _

Spare Parts ListHC/HCl/HCH 6100/8100


Item Designation No. Remark91 Spring for shaft seal 77 600075192 O-ring 2347PRP337. 75,57x5,33 55084018593 Wearless ring 77600075294 Carbon ring 77600075395 O-ring 2346PRP338 550840186100 Oil pump, complete 77 6006610 See detail101 O-ring 2347PRP255. 142,47x5,53 550840149104 Inside hexagon screw. Ml0x120 42078 1200105 Magnet for ail filter 522000010

._-

111 Oilfilter, complete 77 6006613 See detailFilter cartridge 0106. ST5-120 46 191 0013O-ring 2347PRP2341. 88,27x5,33 550840189

116 Screwed connection, screw - in type. WE PLR-3/8" 460852030RC

120 Bypass valve. 25 bar 023 723000100 See detail121 O-ring 2347PRP223. 40,87x3,53 550840114125 Spindle for oil pressure valve, 125 mm 77 615 1094126 Spring for ail pressure valve, 8 cvl., 152 mm 77 630 1021127 Nipple for ail pressure control 776002115128 Cylinder screw. Ml Ox30 42078 1184129 Guard for ail control valve 776002117130 Disc. M6 42 164 1106140 Charge / drain valve, RC 1/2" 724002071 See detail145 Schrader valve, 1/8" RC 720550021150 Connecting rad and piston with slide bearing. 776006618 See detail

100mm170 Cylinder complete with capacity control See detail171 Cylinder complete without capacity control See detail175 Valve lifting ring 77 6002121176 Gasket for cylinder 776000822178 Inside hexagon screw. M6x50 42078 1108200 Discharge valve complete See detail220 Liquid slug-over spring 77 6100350 See detail240 Suction filter, complete, lowside 776006646 See detail250 Pressure gauge panel, complete. R717 776006640 See detail

Pressure gauge panel, complete. HCFC 776006641 See detail251 Dise. M12 42 1682058252 Connecting pipe, 6 cylindr. 776006665

Connecting pipe, 8 cylindr. 776006666

Redprocating Compressor Manual.Gram Refrig----'-e_r-"-a_t_io:::-.:n~.. _Spare Parts List


Page 5

Item Designation No. Remark253 Screwed connection, WE-6-LLRG 460852005254 Screwed connection, A-6-RLL 46097 2005269 Coil for solenoid valve, 220-240V, 50/60Hz 41 361 5201

Coil for solenoid valve, 110-120V, 50/60Hz 41 361 5202Coil for solenoid valve, 48V, 50/60Hz 41 361 5206Coil for solenoid valve, 24V, 50/60Hz 41 361 5204

270 Solenoid valve, bottom part, 3 way, BS-V401, NC 41 361 0176271 Gasket for solenoid valve. 1OOS-T 776002041272 Inside hexagon screw, M8x30 42078 1143

Reciprocating Compressor Manual.Gram Refrig-=e...:::....r==a:..=.:ti=--=o::....::.n-=--l!l__----.:....-_--=_~_'_____



100 mm Compressor, Front View

Reciprocating Compressor ManuaL~Gram Refrig...=..e..::..-ra.=.=.t....:::..:i:.....=o:.....:::..n.::::..-. _Spare Parts List


Page 7

Longitudinal Section, 100 mm Compressor

7760001 86DA2004

15

Reciprocating Compressor Manual_Gram Refrig--",--e-,--ra~t-=--:.i.....::::::o---,-,-,n=---~ _



Sectional View, 100 mm Compressor

776000 186DA3004

Reciprocatinq Compressor Manual.Gram Refrig~e_r....;::...a:..=t..:::....:io~n:....::..e _Spare Parts List


Page 9

100 mm Compressor, Back View

7760001 86DA5004

Reciprocating Compressor Manual_Gram Refrig...=.e_ra-=---t....:....;;.i--=o-----'n...:....-.ll' _


Article No. 82-600-0053-01Page 10

100 mm Compressor1 Sectional View 1 Cylinder

1-1--

1

..qoo..q-cCl\l)co

ooo-or-r-

Redprocating Compressor ManuaL.Gram Refrig-=e-=-r-=.:a::...=.t.=.....:io=-:n:..::... _

Spare Parts ListHC/HCl/HCH 6100/8100

Article No. 82-600-0053-01Page 11

100 mm Compressor, Longitudinal Section, mech. seal

--~M"T'---rnr----1---::.----

7760001 86DA6004

Redprocating Compressor Manual_Gram Refrig....:;;...e_ra-,,---t_i---,,-o_"_1!!> _


Article No. 82-600-0053-01Page 12

Oil Pump for 100 mm Compressor

Part. No. 77-600-6610

Item Designation No. Remarks1 Housing for ail pump. 100mm 7760020502 Rotor for ail pump. 100mm 77 60020513 Gearwheel for ail purnp, 100mm 7760020524 Shaft pin for ail pump. 100mm 7760020535 O-ring 2347PRP248. 120,24x3,53 5508452486 Pump caver, inside. 100mm 7760020547 Caver for ail pump. 100mm 7760020558 O-ring 2347 PRP 211 20,22x3,53 5508401029 Cylinder screw. M 1Ox80 42078 119410 Cylinder screw. M10x30 42078 118411 Allen plug, RC 1/8" 46 152 100312 Pipe plug. RC 3/8" 46 152 100913 Name plate for ail pump. 100mm 72005007714 Drive rivet RH RF, No. 4x6 42291 802915 Steel retaining ring. U 35 42313 103216 Bali bearing. NO 6207 51 007000817 Bali, steel, 7/16" 51 041 101218 Spring for ail circulation, 100 mm 77600206719 Spring guide for compr. 100-125 mm 77600206320 Holder for spring guide 776002064

Redprocating Compressor Manual~Gram Refrig-=-e-=--ra=t-=..::i:...=o~n=-- --=-_-=--- _Spare Parts List


Page 13

By-pass Valve 023 mm, 25 and 12 bar

Part No. 25 bar: 723000100/12 bar: 723000105

"

Reciprocating Compressor Manual.Gram Refrig-=-e-=--ra=t=.::i:...=o-=...:n=---~ --=------.:: _Spare Parts List


Page 14

Connecting Rod + Piston, complete, for 100 mm Compressor

Part No.: 776006618

1"')ooo

Redprocating Compressor Manual~Gram Refrig-=e-=-r=a~ti=--=o::.....::.n-=- ---=_-:..- _Spare Parts List


Page 15

Cylinder with Capacity Control for 100 mm Compressor

ONLY HCFC(RI34a-R22)--.- 5

65

2

R717 HCfC+R134a lifting Depthheight

Item Designation No. HC HCl HCH HC HCl HCH h dCylinder, complete 77600 6620 X 1,8Cylinder, complete 77 600 6621 X 1,9Cylinder, complete 77 6066620 X 1,8Cylinder, complete 77 606 6621 X 1,8Cylinder, complete 776076620 X 1,9Cylinder, complete 77 607 6621 X 2,2

1 Cylinder 100mm 77 600 0821 1 1 1 1 1 12 lValve lifting pin 77 600 0518 6 6 6 6 6 63 Gasket 77 600 0844 1 1 1 1 1 14 Suction valve seat plate 77 600 2125 1 5,6

Suction valve seat plate 77 600 2126 1 1 7,05Suction valve seat plate 77 606 2125 1 4,8Suction valve seat plate 77 606 2126 1 6,0Suction valve seat plate 77 607 2126 1 7,4

5 Suction valve plate 77 600 2140 1 1 2 2Suction valve plate 77600 2141 1 2

6 Suction valve spring 8 77 600 2143 2 2 2Suction valve spring C 77 600 2144 2Suction valve spring A 77600 2145 2Suction valve spring D 77 600 2147 2

7 Guiding rino 77 600 2127 1 1 1 1 1 18 Hexa socket head cap 42 078 1106 2 2 2 2 2 2

screw

Reciprocating Compressor Manual.Gram Refrig....;;;;...e--=-r.=:::a-:::..:ti=-=o:....:::.n..:::.....-~ -..:..- _Spare Parts List


Page 16

Cylinder without Capacity Control for 100 mm Compressor

ONLY HCFC{RI34o-R22J ---- 5

"U ..c:.

1R717 HCFC+R134a Lifting Depth

heightItem Designation No. HC HCl HCH HC HCl HCH h d

Cylinder, complete 776006625 X 1,8Cylinder, complete 776006626 X 1,9Cylinder, complete 776066625 X 1,8Cylinder, complete 776066626 X 1,8Cylinder, complete 776076625 X 1,9Cylinder, complete 776076626 X 2,2

1 Cylinder 100mm 77 6000821 1 1 1 1 1 13 Gasket 776000844 1 1 1 1 1 14 Suction valve seat plate 77 6002125 1 5,6

Suction valve seat plate 77 6002126 1 1 7,05Suction valve seat plate 77 606 2125 1 4,8Suction valve seat plate 77 606 2126 1 6,0Suction valve seat plate 77 607 2126 1 7,4

5 Suction valve plate 776002140 1 1 2 2Suction valve plate 776002141 1 2

6 Suction valve spring B 77 6002143 2 2 2Suction valve sprlnq C 77 6002144 2Suction valve spring A 77 6002145 2Suction valve spring 0 776002147 2

7 Guidlnq rinl 77 6002127 1 1 1 1 1 18 Hexa socket head cap 42078 1106 2 2 2 2 2 2

screw

Reciprocating Compressor Manual.Gram Refrig--=-e-=--ra.=..;:.t-:...:.i--=o:......:;,."-=-- _Spare Parts List


Page 17

Discharge Valve Complete for 100 mm Compressor

====~~R717 HCfC+R134a Lifting Depth

heightItem Designation No. HC HCl HCH HC HCl HCH h d

Discharge valve. complete 776006630 X X 1.3Discharge valve, complete 77 6006631 X 1.9Discharge valve, complete 77 6066631 X 1.9Discharge valve, complete 77 6076630 X 1.9Discharge valve, complete 77 6076631 X 2.1

1 Discharge valve seat 77 600 1201 1 1 1 1 1 12 Discharge valve plate 77 6002146 1 1 1 1 1 13 Discharge valve spring 77 6002149 2 2 2 2 0.7

Discharge valve spring 77 6002150 2 2 0.74 Discharge valve holder 77 6002136 1 1 3.9

Discharge valve holder 77 6002137 1 1 1 4.5Discharge valve holder 77 607 2136 1 4.7

5 Countersunk hex. screw, 420802099 1 1 1 1 1 1M12x55

6 Self lock nut, M 12 42 1532008 1 1 1 1 1 17 l.ock-nut, M 12 42 122 1107 1 1 1 1 1 1

Redprocating Compressor Manual.Gram Refrig-=e-=-r=a....=.:ti=--=o:::....=n-=-~ --=-_-=-- _Spare Parts List


Page 18

Suction Filter Complete for 100 mm Compressor

Part No. 77 600 6646

~~~._--4

776006646DA0004

Item Designation No. Remarks1 Shell, perforated for suction filter 77600 21052 Filter for suction filter 77600 21073 Sprlnq for suction filter 77600 21084 O-ring 2347 PRP 153 88,57x2,62 55084 0089

Redprocating Compressor Manual~Gram Refrig-=--e_ra-=--t_i--=.o_n"'---- _Spare Parts List


Page 19

Pressure Gauge Panel for 100 mm Compressor

Part No. R717: 77600 6640/HCFC: 776006641

77600664IDA0004

Item Designation No. Remarks1 Pressure gauge panel 7760021682 Double Mano., with rim, 2x3/8" RG, -1-30 bar, R717 77 035 0516

Double Mano., with rim, 2x3/8" RG, -1-30 bar, HCFC 7703505603 Differentiai Mano.,with rim, 2x3/8"RG,-1-12 barl1- 77 035 0517

6bar,R717Differentiai Mano.,with rim,2x3/8" RG,-1-12 bar/O- 7703505615bar,HCFC

4 Cutting screw NSF, cylindrical head M5x15 42281 10585 Pressure gauge valve, steel tube, TN 25-1 724000048

Reciprocating Compressor ManualilGram Refrig--"-e_ra.::..-t...:..-'-.i-=--o-=-.=n'-----e _Spare Parts List


Page 20

Oll Cooler for 100 mm Compressor

Part No.: 77 600 6700

~ooo-cgor-\0oo\0......

......

Item Designation No. Remark1 Hose for oil cooler 7760021752 O-ring 2677 PRP 208, 15.47 x 3.53 5508452083 Sealing for O-ring 77610 11415 Lock-nut, 3/8W RG 77 580 1207

Reciprocating Compressor ManualiIIGram Refrig-=-e-=-ra~ti=--=o=-=-n-=-" ---=-- _S-p-are-Parts-ttsr----


Page 21

Liquid spring for 100 mm Compressor

Part No.: 77 610 0350

'

Spare Parts iJsF-HC/HCl/HCH 6100/8100

Article No. 82-600-0053-01Page 22

Reciprocating Compressor Manual_Gram Refrig=:e::=ra=t=:i=o=:-"::::e========================

Coupling for 100 mm Compressor

Part No.:ZM67G: 50-033-0052ZM90G: 50-033-0053

Couplina tvpe ZM67GItem Description Seriai number Comment1 1 Caupling element 50-033-01022 Caupling hub far compresser 50-033-01243 Caupling hub far rnotor 50-033-01524 Spacer element 50-033-01725-7 Balt set 50-033-0192

Split bushing f. motor shaft type 3020, shaft diameter 48 571032705Split bushing f. motor shaft type 3020, shaft diameter 55 57 1032107Split bushing f. rnotor shaft type 3020, shaft diameter 60 571032108Split bushing f. rnotor shaft type 3020, shaft diameter 65 571032109Split bushing f. rnotor shaft type 3020, shaft diameter 75 571032111

ZM90GC reuenns typeItem Description Seriai number Comment1 Caupling element 50-033-01042 Caupling hub far compresser 50-033-01263 Caupling hub far motor 50-033-01544 Spacer element 50-033-01745-7 Balt set 50-033-0194

Split bushing f. rnotor shaft type 3525, shaft diameter 55 571033041Split bushing f. motor shaft type 3525, shaft diameter 60 571033042Split bushing f. motor shaft type 3525, shaft diameter 65 571033043Split bushing 1. rnotor shaft type 3525, shaft diameter 75 571033045Split bushing f. motor shaft type 3525, shaft diameter 80 571033046Split bushino f. rnotor shaft type 3525, shaft diameter 90 571033048

Reciprocating Compressor Manual~Gram Refrig-::..e-,,-r~a...::..:ti:;,..c::o;...::..n.:::.-

Redprocating Compresser ManualilGram Refrig-=.e...:::...-ra=t=.::i:...=o....=:....:"=--$__---:.-.-_-=---------= _Spare Parts List

He/HCl/HCH 6100/8100Article No. 82-600-0053-01

Page 24

Qil Filling Valve GVAC

Part No.: 72 400 2071

59-998-3650

,

Reciprocating Compressor Manual.Gram Refrig_e_ra_t_i_o_n_.. _Spare Parts List


Page 25

Item Designation No. Remarks1 Short spindle 7240031662 Long Spindle 7240031673 Packing screw 72400345210 Union nut 72400320011 Bush 72400347512 Valve seat 72400332013 Seal 55 070001216 U-sleeve 55 094021817 O-ring 55 084511119 Gasket 55 070001825 Cap 72400360526 Gasket 72400365545 Gasket 72400342346 O-ring 550845018

Reciprocating Compressor Manual_Gram Refrig-=e..:::.-ra=t.=.::i=-=o~n::::....-

catalogo partes y piezas gram hc 8100

Documents