[,.,. CkllemF!#Mr’rsC.ATALOG

ErviGenerating Set

Introduction

This Parts Manual applies to the Generator Set(s) Listed below. The illustrations arearranged in an assembly of related parts, and each part or assembly is identified by areference number. All parts illustrated are typical, and unless otherwise mentioned inthe description column of the parts list, the parts are interchangeable between allmodels.

These typical illustrations are subject to change and reflect only the latest replace-ment for the original factory installed parts. The Right and Left sides of theGenerator Set are determined by FACING the engine end (FRONT) of the Set.

Set Rata Table

MODEL IDENTIFICATION I KW RATING I RPM RATING , BATTERY VOLTAGE,

75.0 ENT-*/#@ 75,000 WATTS 1800 RPM 12 VDC

Electrical flata Table

‘VOLTAGE CODE VOLTS HERTZ WIRE PHASE NOTES

B (3) 120/240 60 3 iE (6D) 240/48C 60 4 3F (7) 220/380 60 4 3H (9X) 347/600 60 3L. (15) 120/240 60 1: 1 +

L (15] 120/208 60 12 3 +

120/240127/220139/240240/416254/440277/480

N (53) 120/240 50 1z (515) 110/220 50 1: 1 +

115/230z (515) 110/190 50 12 3 +

110/220115/200115/230120/208127/220220/380230/400240/416254/440

* - Voltage Codes follow Model Letter designations.#“ Specification number: number 1 is standard, all others indicate variations.@ - S~ecification letter: letter advances ( A to B, B to C, etc) with major

‘ manufacturing changes.+- These Generators are reconnectable, refer to Operator’s Manual for wiring data.

Engine Replacement Parts

All Engine replacement parts must be ordered from the engine manufacturer, excePt th~aemodified or added by Onan. When ordering engine parts, refer to the engine manufact-urer’s nameplate and supply the Model, Specification, Serial Numbers and other available

,,.’”:, information. Refer to the engine manufacturer ‘s manuals for your nearest authorized1 I distributor or parts center; or contact the Onan distributor from whom you purchasdd

,,, this Set , for assistance in ordering replacement parts. Ford Model Number for this setis CSG-875-6005A.

Index

Actuator 37Adapter, Carburetor 15,19,21Adapter, Cooler - Oil 29Adapter, Filter - Oil 13Adapter, Generator to Engine 11Adapter, Pulley - Drive 25Adapter, Throttle Unit 19,21Alternator 23Ammeter 49.51,55,53Arm, Adjusting - Alternator 23

Bar, Tie - Circuit Breaker 53Base, Housing - Thermostat 25,27,29Bearing, Ball - Generator 65Bell, End - Generator 65Belt, Drive - V 7,23Block, Terminal 45,49,51,53,55,71Board, Delay - Time 47Board, Sensor - Magnetic 47Bc]dy, Carburetor 15,19,21Elox, Control - Generator 49,51,53,55Brace 25Bracket Assembly - Overspeed 65Bracket Assembly, Terminal 11Bracket, “J” 25,27,29Bracket, Mounting - Alternator 23Bracket. Mountina - CaDacitor 61Bracket;Bracket,Bracket,Bracket,Bracket,Bracket,Bracket,Bracket,Bracket,Bracket,Bracket,Bracket,Bracket,Bracket,Bracket,Breaker,Bushing,

Mountin; - Circuit Breaker 63Mounting - Engine 36Mounting - Engine Control 45Mounting - Flasher 45Mounting - Governor 7Mounting - Heat Exchanger 27Mounting - Manual System 19,21Mounting - Oil Cooler 29Mounting - Relay 49,53,55,69Mounting - Terminal Board 11Mounting - Transformer 57Mounting - Voltage Regulator 55Mounti~g - Water Heater 41,43Mounting - Watt Transducer 71,72Support - Muffler Mounting 35Circuit 49,51,53,55,63Insulating 66

Cable, Battery 9Cable, Electrical 58,59,68Cap, Exchanger - Heat 27Cap, Pipe 17Cap, Radiator 25Capacitor 23,45,61Catch, Latch 33Chassis 36Chassis, Rear 33Clamp, Loop 47,51Cleaner, Air 4Clip, Cai>le 49,53,55,66Clip, Fastener 55Cock, Drain 17,25,27,29,31,41,43Coil, Ignition 11Connector, Exhaust 35Connect~r, Male - Inverted 31,21Control, Engine 45,47Control, Generator 49Contiol, Heater 58,59Controller, Governor 37Converter, Gas - LPG 17Cooler, Oil 13,27,29Cover, 80X - Transducer 71Cover, Hole - Starter Mounting 9Cover , Housing - Thermostat 25,27,29Cover , Mounting Hole - Switch 47Cover , Thermostat 58,59Cranker, Control 45Cross, Pipe 9

2

Dampener, Vibration 49,53,55Dial, Wattmeter 71,72Diode, Rectifier 39,66Disk, Drive - Generator 65Door, Contro’ - Engine 47Door , Control - Generator 51Doors, Housing - Set 33

Elbow, Mixer to Turbocharger 15,19,21Elbow, Pipe - Inverted Male 19Elbow, Pipe - Street 45” 25,27,29Elbow, Pipe - Street 90” 13.17,19,

21,25,27,29,31,33,41,43Elbow, Pipe to Hose - 909 4Element, Cleaner - Air 4Exchanger, Heat 27Exhaust System 31

Fan, Alternator 23Fan, Generator 65Fan, Radiator 25Fastener, Door 33Fastener, Snap-in 45Fiiter, Coolant 38Filter, Oil 13Filter, Regulator - Voltage 62Flange, Duct - Air 25Flange, Manifold - Exhaust 35Flange, Oil - Drain 13Flange, Pipe - Exhaust Outlet 31Flasher 45Flywheel 11Frame, Holddown - Battery 36Fuse, Cartridge 47.49

Gasket, Body - Carburetor 15Gasket, Flange - Exhaust Manifold 33Gasket, Flange - Oil 13Gasket, Housing - Thermostat 25,2’7,29Gasket, Mixer - Air/Gas 19,21Gasket, Pipe Flange - Exhaust Outlet 31Gasket, Tube Assembly - Exhaust 31Gauge, Pressure - Oil 45,47Gauge, Temperature - Oil 45,47Gauge, Temperature - Water 45,47Gear, Ring 11Generator 65Governor, Electronic 37Governor, Mechanical 7Grille, Housing - Control 60Grommet 49,51,53,55,60,66,67Guard, Belt 7,25,27Guard, Fan 25Gusset 37

Handle, Door - Rear Access 33Harness, Wiring 9,45,47,51,72,73Hasp Set 33Heater, Electrical 58,68Heater, Electrical - Engine Coolant 41Heater, Electrical - Engine Coolant 41,43Heatsink, Diodes - Positive/liegative 66Holddown, Rel?y 69,45Holder, Lamp 47Hose, Rubber 4,13,15,17,19,21,25,27, 29,

41,43,65Housing, Connector 37Housing, Control 60Housing, Set 33Housing, Terminal - PC Board 45Hub 25

Indicator, Service - Air 19,21Insulator 62

Index

—,.pr . Joint, Ball 7Jumper,~ Terminal 45

‘k.Key, Handle 33Key, Machine - Rotor Assembly 6SKey. WOodruff 23Kit, Element - Coolant Filter 38Knob 49,51.53,55Knob, Pointer 49,53,55

Lamp, Incandescent 45,47light, Indicator 49,51,53.55Light, Panel 45Lights, Indicator 45Line, Fuel - Flexible 19,41,43Line, Inlet - Oil 13Lock, Handle - Circuit Breaker 49,53,55Lug, Terminal 62

Manifold, Exhsust 31Meter, Frequency 49,51,53.55Meter, Total izing - Time 49,53,55Meter, Watt 55,72Mixer, Air/Gas 19,21Module 47Module, Indicator - Fault 47Monitor, Control - Engine 45Mount, Shock 72Mount, Vibration 36,51,71,72Muffler, Exhaust 35

O-Ring 15,19,21

Panel , Control - Engine 45‘“” Panel . Control - Generator 49.53,55

Panel , Housing - Front 25Panels, Breaker - Circuit 63Panels, Housing - Set 33Pencil, Zinc 27Pick Up, Magnetic 37,73Plate, Cover - Rear ChEssis 33P?ate, Oi? - Return 13Plate, Support - Transducer 12Plug. Button 47Plug, Keying 45Plug, Pipe - Square Head 27,29,31Plug, Plastic 53,55Pulley 25Pulley, Alternator 23Pulley, Drive - Water Pump 7

Radiator 25Radiator, Remote 29Reactor 49,53Receptacle, Fastener 51,55Receptacle, Fastener -

Turnbutton 49,53,55Rectifier, Bridge 49Regulator, Pressure - Gas Vapor 15,19,21Regulator, Voltage 23,49,51,53,55Relay 45,49,53,55Relay, Run 45,69Resistor, Composition - Fixed 53,55Resistor, Fixed - Wirewound 62Rheostat 49,51,53,55Rod, Throttle 7Rotor Assembly, C&nerator 65Rotor, Exciter

,r

Saddle, Mounting - Control Box 60,, Screen, Air - Generator 65

Seal, Oil - 0 Ring 65Sender, Temperature - Engine Coolant 9Sender , Temperature - Oil 11

Set, Suppressor - Voltage 67Shield. Rain 35Shr~ud, Fan 25Socket . Relay 45,69Socket, Relay 49,53,55Solenoid, Electric - Srart 9Spacer, Adjusting Arm - Alternator 23Spacer , Housing Base - Thermostat 27,29Spacer , Mounting Bracket - Fan Drive 25Spacer, Pulley - Water Pump Drive 7Spacer, Sleeve - Belt Guard 27,29Spacer, Sleeve - Converter Mounting

Bracket 17Spacer, Sleeve - Governor ‘7Spacer, Sleeve - Heat Shield 35Spacer, Sleeve - Heater 58,59Spacer, Sleeve - Rctor 65Spring. Governor 7Spring, Holddown - Relay 45,49,53.55Stator, Exciter 65Strap, Electrical - Ground 36,49,51,53,55Strap. Guard - Belt 27,29Strap, Holddown - Heat Exchanger 27Strap, Support 27Strip, Marker 45,49,51,53,55,71Stud 4.15,31.36.37.65Stud, Fastener 51,53,55Support, Cooler - Oil 27Support, Housing - Center 33Support, Mounting - Engine 36Suppressor, Voltage 67Switch, Level - Low Coolant 39Switct., Overspeed 6S,73Switch, Pressure 19,21,41,43Switch, Pressure - Low Oil 9Switch, Push - Reset/Panei Lamp ~!f

Switch, Push - Run/Stop/Remote 47Switch, Rotary 55Switch, Selector 49,53,55Switch. Thermostat ic 11,41,43Switch, Toggle - Manual System 19,21.45Switch, Vacuum - Regulator 9System, Dual Fuel - LPG Liquid/Natural

Gas 21System, Dual Fuel - LPG Vapor/Natural

Gas 17System, Fuel - LPG or Natural Gas 15System, LPG Gas Conversion Components 17

Tachometer 45,47Tee, Pipe 17,19,21,25,27,29Tee, Pipe - Reducing 19,21Terminal 49Terminal Assembly, Ground 45Terminal, Lug - Ground 36Thermostat 25,27,29,56,59Tie, Cable 62Transducer, Watt 71<72Transformer, Current 49,51,53,55,57Transformer, Voltage 49,53Tube, Coolant - Upper and Lower 25Tube, Exhaust - Flexible 35Tube, Indicator - Oil Level 13Turbocharger 15,19,21,31

Valve, Cock 13Valve, Control 19.21Valve, ContrDl - Temperature

Regulating 27Valve, Globe 27Valve, Solenoid 17,19,21,27Voltmeter 49,51,53,55

Wattmeter 51,71,72Wheel, Sensor - Magnetic Pickup 73

10 If

f% ~~

63,

e=---- ;I 7~ ,,“,; ,,

,.4:[-~>,

‘k c 5,.. “-----““‘ ;,,. ;,, 9,.., .) c

‘>,,>.,’.J~..,7

.+“..,/;.,~“ \

REF PARTNO. No.

1 140-1724

2 865-00063 140-18374 862-00015 850-0040

&----4

QTY PARTUSED DESCRIPTION

1 Cleaner Assembly, Air(Includes Parts Marked

1 *Nut, Wing (!/4-20)1 *Element - Air Cleaner

REF PARTNO. NO.

6 NFS*) 7 503-0547

8 503-10939 502-0237

1 *Nut, Hex (1/4-20)1 Washer, Lock - Spring (1/4”) 10 503-1100

QTYUSED

1211

1

* - Parts Included in

4

*StudC1ampHose,E1bow

(3/8

PARTDESCRIPTION

1/4-20 X 6“LG)Hose

Rubber (5/8”10 x 19’’LG)Pipe to Hose - 90”

NPT x 1/2”10 Hose)Hose, Rubber (1/2”10 x 23’’LG)

140-1724 Air Cleaner Assembly. ~ ‘“:‘!

‘,,’

5

(,lovernor - Blechartical

‘1

‘1,(

,!,

6

NO. NO.

1 511-00342 821-0010

3 130-09914 801-0027

S 850-00456 132-02617 115-00258 850-00409 526-0018

10 150-063911 152-024312 821-0030

~~ 8~&0281

14 151-0584

QTYUSED

13

14

41424

~

13

3

1

00vernor -

PARTDESCRIPTION

Belt, Drive - VScrew, Self-locking - Hex

Washer Head [1:4-20 x 1/2::)Guard, 8eltScrew, Cap - Hex Head

(5/16-24 x 7/8”jWasher, Lock - Spring (5/8”)Pulley - Water Pump DriveNut, Hex (1//4-2!3)Washer, Lock - Spring (1/4”)Washer, Flat (17/64”10 x

5/8”00 X l/16’’THK)J~int, BallRod, ThrottleScrew, Self-locking - Hex

Washer Head (3/8-16 x 1“)Nut, Self-locking - Hex

Washer Head (3/8-16)Governor

Mechanical

REF PARTNO. NO.

15 800-0052

16 850-005017 526-0026

18 130-098819 870-0281

20 800-0048

21 850-005022 800-0069

23 850-005524

150-1521191-2025

25 131-035326 151-0594

QTYUSED

1

12

11

1

11

1

11

:

PARTDESCRIPTION

Screw, Cap - Hex Head(3/8-16 X 1-1/2”)

Washer. Lock - Spring (3/8”)Washer, Flat (13/32”10 x

3/4”OD X 1/16’’THK)Spacer, SleeveNut, Self-locking - }Iex

Washer Head (3/8-16)Screw, Cap - Hex Head

(3/8-16 X 3/4”)Washer, Lock - Spring (3/8”)Screw, Cap - Hex Head

(7/16-14 X 3/4”)Washer, Lock - Spring (7/16”)8racket, Mounting

Used with Motorola AlternatorUsed with Bosch Alternator

Spacer, PulleySpring, Governor - 50 Hz Only

l“! “

11, ,,

Engine co=~onents - l-eft Sids

,,,,

Engine Components - Left Side

REF PARTNo. ND.

QTYUSED

111

1

1~

1

1

i1

1

PARTDESCRIPTION

REF PARTMO. No.

QTYUSED

PARTDESCRIPTION

1 Hs?ness, ~i?ifig - EngineSpec ASpec 8

Sender. Temperature - EngineCoolant (E2)

Screw, Machine - Round Head(iR3-32 x 1/4”)

Cover - Starter Mounting HoleSender. Pressure -Oil (El)Tee, Pipe - Street, Brass

( 1/8 NPT)Switch, Pressure - Low Oil

(s1)Tee, Pipe (1/8 NPT)Switch, Pressure - Low Oil,

Pre-Alarm (S6 - Spec A,S5 - Spec 8)

Cross, Pipe (1/8 NPT)

Nipple, Pipe1/8 NPT X 1-1/2”1/8 NPT X 2“

Bushing, Reducer - Hex(1/4 NPT X 1/8 NPT)

Screw, Self-1ocking - HexWasher Head (1/4-20 x 1/2”)

Lead, Electrical (S2 AiW3 x9“LG)

Cable, BatteryPositive (21’’LG)Negative (29’’LG)

Screw, Cap - Hex Head(1/4-20 X 3/4”)

Washer, Lock - Spring (1/4”)Nut, Hex (1/4-20)Solenoid, Electrical - Start,

12 VDC (K6)

11505-0104505-0061

12 505-0007

338-094?338-2460193-02472

3 812--0075 13 821-0010 2

456

191-0773193-0244502-0058

14 336-3124 1

15416-0021416-0672

16 800-0005305-0544

89

505-0059309-0545 :7 850-0040

18 862-000119 307-1031

10 505-0763

Vacuum Switch - Regulator

REF PART QTY PARTNO. NO. USED DESCRIPTION

REF PART QTYNO. NO. USED

PARTDESCRIPTION

1 ?48-0367 1 Switch, vaCLllJm - Regulator2 505-0039 i Elbow (1/8 X 90”)3 505”0101 1 Nipple, Close (3/8 NPT x l“)

,“, NOTI : To install Items 1, 2, & 3 - Remote plug in/’Intake Manifold and discard

‘“,,:

9

Engine ~om~~nents - Right Side

“.”.. ..009 ..90.h1,

k 111,,1..”.- ..... ............... ..mse$

~~~Is9mtcI:::.c9:0..::tL.............................4 . . . . . . . . . . . . . . . . . . . . ...90.

. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

\

1 (j (’J Q‘V—-J

\............ .............................................................................. ....

,,,,

“

10

Engine Components - Right Side

REF PARTNo. No.

QWUSED

11

1

1

1

1

1

1

1

1

PARTDESCRIPTION

REF PART QTY PARTNO. NO. USED DESCRIPTION

~ 193-02492 505-0007

Sender, Temperature - Oil (E5)Bushing, Reducer - Hex

(1/4 NPTx l/8NPT)Screw, Cap - Hex Head

(7/16-14 X 3/4”)Switch, Thermostatic - Low

Engine Tamp (S5)Switch, Thermostatic - Hi

Engine Coolant Tamp (S2)Plug, Pipe - Square Head

(3/4 NPT)Switch, Thermostatic - Hi

Engine Coolant Tamp - Pre-Alarm (S7 - Spec A, S6 -Spec B)

Bushing, Reducer - Hex(3/4 NPT X 3/B NPT)

Screw, Cap - Hex Head(5/16-18 x 3/4”)

Washer, Lock - EIT (5/16”)

Bracket Assemb?y, Terminal(Includes Parts Marked *)

11 332--1292 1

112 809--0035 *Screw, Thread Cutting -Round Head,(#B x 3/4”)

Washer, Insulating - Fiber(#8)

*Nut, Insulating (#8)*Bracket, Mounting - Terminal

Ceil, Ignition (Tl)Flywheel (Includes Ring Gear)Gear, Ringc. .-”““, “.., Csp - Hex Head

(7/16-14 X 1-1/4”)

3 800-006913 508-0015 1

4 309-026914151617

:

870-0196332-1281166-0278104-1097104-0723800-0072

5 309-0179

6 505-0130

7 309-0178

2021

850-0055231-0260

B1

Washer,Adapter

Lock - Spr;ng (7/16”)- Generator to Engin~

B 505-0499

9 800-0026

10 853-0016

Terminal Bracket* - Parts Included in 332-1292Assembly.

Lub8 Oil Systm

12

6

.

\\._ ~ ,,,)‘s - /’ “’”

‘—”

,,*RE~ PART

it:?!,.:, ?40. No.w!!‘rJm‘%

1 122-01932 503-04463 503-109!3

4 505-0302

5 505-0018

6 8210016

7 870-0257

8 102-11139 102-1097

10 503-013111 503-0966

12 505-0135

13 504-003014

102-0652502-1013502-1013

15

QTYUSED

1

;

2

2

3

3

11

11

1

1

;1

1

:

Lube Oil - -

PARTnscmrp~~~--, *

Filter, OilClamp, HoseHose, Rubber (i/2”ID x 3/4”00

X 29’’LG)Nipple. Pipe - Half (1/4 NPT

x 1-1/2”)8ushing, Reducer - Hex

(1/2NPT x l/4 NPT)Screw, Self-1ocking - Hex

Washer Head (5/16-18x 3/4”)Nut, Self-1ocking - Hex Washer

Head (5/16-1S)Cooler, OilAdapter Unit (Includes “O”

Ring. Housing w/Thermostatand F’emale/Male Hex Adapter)

Clamp, HoseHose, Rubber (5/8”10 x 7/8”00

x 30’’LG)Nipple, Pipe - Half (3/8NpT

X l-i/2”)Valve, Cock (318 NPT)Adapter, Pipe - Hex {1/2-20

UNF X 3/8 NPT)Spec A

Used Through July, 1986Begin August, 1986

Spec BGasket, Oil Drain

Spec AUsed Through July, 1986Begin August. 1986

Spec B

sysxem

REF PhRTNo. ND.

16 123-132217 503-05471s 503-109?

19

502-0302

505-0135

505-013520 800-0026

21 860-004522 121-003623 800-0050

24 850-005025 145-053426 145-053527 121-003728 502-0002

29 505-0007

30 !502-000331 C4TZ 84500B

32 503-0183

QTY

121

2

2

22

212

21111

1

12

2

PARTDE8fXPTItM

Tube - Oil Level IndicatorClamp, HoseHose, Rubber (5/8”ID x

15/16”00 X34’:LG)Fitting

Spec AElbw, Pipe - Used Thrm.%?h

September, 1985Nipple. Pipe - Half -

Begin October, 1985Spec B - Nipple, Pipe - Half

Screw, Cap - Hex Head(5/16-18 X 3/4”)

~~~~~p, L~ck - Spring (5/16”]Plate - Oil ReturnScrew, Cap - Hex Head

(3/8-16x 7/8”)Washer, Lock - Spring (3/8”)F 1ange - Oil Dra%GasketLine - Oil InlatElbuv), Pipe - Street. 90-.

Brass (1/8 NPT x 1/4” Tube)Bushing. Reducer - Hex

{1/4 NPT X 1/8 NPT)Connector, Inverted MaleCap, Tube - Heater Outlet

(Ford *)Clamp, Hose

Fuel S stez{(LPG or Na ural Gas)

,J’‘,...

,’

25

14

No. No.

1 140-09612 140-1260

3 505-0007

4 NFS

5678

1:1112

13

14

151617

145-0532145”0540503-0998145-0590S09-0165503-0465503-117?

145-0541145-0539813-0103

526-0008

850-0030870-0053145-0528

QTYUSED

11

1

4

11

!I21

114

4

441

Fuel S stes!(LPG or Na ural Gas)

PARTDESCRIPTION

Indicator - Air ServiceFitting with Restrictor -

Hex (1/’8 NPT)Flushing, Reducer - Hex

(1/4 NPT X 1/8 NPT)Screw. !&ehine - Fill ister

Head with Lockwasher(#12-24 x5/8”)

Mixer - Air/GasGasketClamp, Hose - “T” Bar TypeElbow - Mixer to Turbochargerll~l! Ring

Clamp, HoseHose, Rubber (2-1/2”ID x 3“LG)Turbocharger

50 Hertz Sets60 Hertz Sets

Screw, Machine - Round Head”(#10-32 X 3/4”)

Washer, Flat (13/64”ID x7/16”OD X l/32’’THK)

Washer, Lock - Spring (#10)Nut, Hex (#10-32)Adapter - Throttle Unit

!?(SF PARTNo. No.

18 145-0S4019 800-0050

20 850-005021 145-0!33822 148-077523 110-044524 526-0065

25 520-0011

26 145-048227 148-0637

28 148-0601

29 505-0129

30 505-010231 503-039832 503-079633 503-0324

QTYUSED

12

21144

4

i1

1

1

1212

PARTDESCRIPTION

GasketScrew, Cap - Hex Head

(3/8-16 x l“)Wa4aw, Lock - Spring (3/8”)

- CarburetorGasketNut, Hex (5/16-24)Washer, Flat (21/64”10 x

9/16”OD X 1/16’’THK)Stud (5/16-18 X 5/16-24 X

1-7/8”)Adapter - CarburetorRegulator, Pressure - Ga~

Vapor (3/4 NPT) - LPG SystemRegulator, Pressure - Gas

Vapor (1 NPT) - Nat GasSystem

Bushing, Reducer - Hex (1 NPTx 3/4 NPT)

Nipple, Pipe (3/4 NPT x 1-3/8”)Clamp, HoseHoseNipple, Pipe - Half

(3/4” x 2“)

LW3 Gas Conversion Components

12

‘5

‘-,.,

,,..

W6

8

-0

7--

16

LPG Gas Conversion Components

rJJ?”REF PART

-6’ NO. NO.

1 503-03982 503-0799

3 505-01024 505-0324

,

56789

10111213

14

15

505-0132505-0084505-047950!5-0331505-0661

505-ooo4503-0183!503-0833503-0261

505-0135

505-0019

QTYUSED

21

:

111

;

1311

3

1

PARTDESCRIPTION

Clamp, HoseHose, Rubber (l”ID x 1-3/8”00

x 30’’LG)Nipple, Pipe - Half (3/4 NPT)Nipple, Pipe - Half (3/4 NPT

x 2“)Elbow, Pi~e - 90” (3/4 NPT)

REF PART QTY,.” . NO. USED

16 505-003917 505-0101 1IL 307-0268 1

19 505-0099 120 504-0005 121 800-0009 2

Nipple, P“ipe (3/4 NPT x 2-1/2”)Cap, Pipe (1 NPT) 22 850-0040 2Nipple, Pipe (1 NPT x 4“LG) 23 148-0625 1

1 NPT 24 800-0069 2Tee, Pipe - Reducing Ix 3/4 NPT X 1 NPT)

Nipple, Pipe (1 NPT xClam~. Hose

1-1/2”) 25 850-0055 226 800-0051 1

Hose’, Rubber (5/8”10 x 24’’LG)Hose, Rubber (5/8:’ID x 27 0!!0-0050 1

8-1/2’’LG) 28 148-0776 1Nipple, Pipe - Half (3/8 NPT 29 148-0773 1

x 1-1/2”)8ushing, Reducer - Hex

(1/2 NPT X 3/8 NPT)

PARTDESCRIPTION

Elbow, Pipe - 90” (3/8 NPT)Nipple, Pipe (3/8 NPT x l“)Valve. Solenoid - 12 VDC

( 1/4 “NPT )Nipple, Pipe (1/4 NPTCock, Drain (1/4 NPT)Screw, Cap - Hex Head

(1/4-20 x 1-1/2”)Washer, ‘.ock - SpringConverter, Gas - LPGScrew, Cap - Hex Head

(7/8-14 x3/4”)‘.’-_l---wdbrler, Lock - SpringScrew, Cap - Hex Head

(3/8-16 X 1-1/4”)Washer, Lock - SpringSoacer, Sleeve

X 7/8”)

( 1/4”)

(7/8”)

(3/8” )

E;acket, Mounting - Converter

17

Dual Fuel System(L$W V@Por-R8tural ~SS)

(Autwsatic/Wanual Changeover)

4

4

45

43

44

I,44

i= *e

I 34 +A &

‘1,’

Dual Fuel sust~,—— ----(LPG-Viipoi-Nitiifal Gas)

(Atitoiaatie;Hariual Changeover)

REF PARTNo. ND.

1 140-09612 140-1260

3 505-0007

4 NFS

5 145-05326 145-05407 503-09988 145-05909 509-0165

10 503-046511 503-1172

12145-0541145-0539

13 813-0103

14 526-0008

15 850-003016 870-005317 145-052818 145-0540~g ~~~=~~~~

.tIT&i~L‘k 20 850-0050

21 145-053822 148-077523 110-044524 526-0065

25 520-0011

26 145-048227 501-0010

28 502-0041

29 148-0627

30 505-0020

31 505-1345

QTYUSED

11

1

4

1111121

114

4

44112

21144

4

11

2

1

1

1

indicator - Air ServiceFitting eith !?estrictor - Hex

(1/8 NPT)Bushing. Reducer - Hex

(1/4 NPT X 1/8 NPr)Screw, Machine - Fillister

Head with Lockwasher(#12-24 x5/8”)

Mixer - Air/GasGasketClamp, Hose - “T” 8ar TypeElbow - Mixer to Turbocharger,,~1, Ring

Clamp, HoseHose, Rubber (2-1/2” ID x

3“LG)Turbocharger

50 Hertz Sets60 Hertz Sets

Screw. Machine - Round Head(#10-32 X 3/4”)

Washer, Flat (13/64”ID x7/16”00 x l/32’’THK)

Washer, Lock - Spring {#10)Nut, Hex (#10-32)Adapter - Throttle UnitGasketScrew, Cap - Hex Head

(3/8-16 X 1“)

Washer, Lock - Spring (3/8”)8ody - CarburetorGasketNut, Hex (5/16-24)Washer, Flat (21/64”10 x

9/16”00 X 1/16’’THK)Stud (5/16-18 X 5/16-24 X

1-7/8”)Adapter - CarburetorLine, Fuel - Flexikle - Auto

systemElbow, Pipe - Inverted Male,

90” - Auto SystemSwitch. Pressure - 12 VDC -

Auto System8ushing, Reducer - Hex

(3/4 NPT X 1./4 NPT) - Autosystem

Tea, Pipe - Reducing (1 NPTX 1 NPT X 3/4 NPT) - Autosystem

REF PARTNo. ND.

32 505-0004

33 307-0836

34 148-0626

35 505-0129

36 505-010237 307-0834

38 505-010239 148-0637

40 505-008441 505-013242 505-008443 503-042944 503-1201

45 505-032446 505-013247 505-010248 505-0051

49 505-016650 505-010251 505-0129

52 148-0601

53 821-0013

54 870-0212

55 130-0797

56 308-000557 308-0150

58 306-0155

59 800-0051

60 850-005061 526-017462 148-0869

QTYUSED

1

1

1

1

~~

11

11121

21

;

111

1

2

2

1

i

1

2

221

PARTDESCRIPTION

Nipple, Pipe - Close (1 NPTx 1-1/’2”) - Nat. Gas System

Valve, ;olenoid - 12 VDC(1 NPT) - Nat. Gas System

Valve, Control (1 NPT) -LPG System

8ushing, Reducer - Hex (1 NPTx 3/4 NPT)

Mipple, Pipe (3/4 NPT x 1-3/8”)U=lw- ~~enoid - 12 VDC.- , -“ ,

(3/4 NPT) - LPG SystemNipple, Pipe (3/4 NPT x 1-3/8”)Regulator, Pressure - Gas

Vapor (3/4 NPT) - LPG SystemNipple, Pipe (3/4 NPT x 2-1/2”~Elbow, Pipe - 90” (3/4 NPT)Nipple, Pipe (3/4 NPT x 2-1/2”~Clamp, HoseHose, Rubber (l”ID .x 1-3/8”00

x 12’’LG)Nipple, Pipe - Half (3/4 NPT)Elbow, Pipe - 90” (3/4 NPT)Nipple, Pipe (3/4 NPT x 1-3/8”;Elbow, Pipe - Street, 90”

(3/4 NPT)Tee, Pipe (3/4 NPT)Nipple, Pipe (3/4 NPT x 1-3/8”)8ushing, Reducer - Hex

{1 NPT x 3/4 NPT)Regulator, Pressure - Gas

Vapor (1 NPT) - Nat. GasSystem

Screw, Self-1ocking - HexWasher Head (1/4-20 x l“)

Nut, Self-locking - HexWasher Head (1/4-20)

Nipple, Pipe with 8racket(1 NPT)

Switch, Toggle - Manual System8racket, Mounting - Switch -

Manual SystemBracket. Mounting - Manual

systemScrew, Cap - Hex Head

(3/8-16 X 1-1/4”)Washer, Lock - Spring (3/8”)Washer, Flat (3/8”)8racket, Mounting

19

Ousl Fuel System(LPC3 Liquid-Natural Oas)

(Automtfc/M8nual Ch8ngoovor)

,

25

20

Dual Fuel Svstem(t.PG L* uid-Natfiral Gas)

?(Automatic Uanual Changeover)T

k! REF PARTND. No.

f 140-09612 140-1260

3 505-ooo7

a NFS

QTVUSEO

11

1

4

1

:

:21

114

4

44

:2

21144

4

11

2

1

1

1

PARTDESCRIPTION

REFNo.

PARTNo.

QTVUSED

1

1

31

1

~

21

1

1

11

11

1

11

1

2

2

1

11

1

2

221

PARTDESCRIPTICM

Nipple, Pipe - Close (1 NPTx 1-1/2”) - Nat. Gas System

Valve, Solenoid - 12 VOC[1 NPT) - Nat. Gas System

Indicator - Air ServiceFitting with Restrictor - Hex

(1/8 NPT)Bushing, Reducer - Hex

{1/4 ?4PT x 1/9 NPT)Screw, Machine - Fillister

Head with LockWasher(#12-24 X 5/8”)

Mixer - Air/GasGasketClamp. Hose - “T” Bar TypeElbow .- Mixer to Turbocharger*IO,’ Ring

Clamp, HoseHose, Rubber (2-1/2” 10 x

3“LG)Turbocharger

50 Hertz Sets60 Hertz Sets

Screw, Machine - Round Head(#10-32 X 3/4”)

Washer, Flat (13/64”1D x7/16”00 X l/32’’THK)

Washer. Lock - Spring (*1O)Nut. Hex (#10-32)Adapter - Throttle UnitGasketScrew. Cap -- Hex Head

(3/8-16 X l“)Masher, Lock - Spring (3/8”)8ody - CarburetorGasketNut, Hex (5/16-24)Washer, Flat (21/64”10 x

9/16”00 X 1/16’’THK)Stud (5/16-18 X 5/16-24 X

1-7/8”)Adapter - CarburetorLine, Fuel - Flexible - Auto

SystemConnector, Line - Inverted

Male - Auto SystemSwitch, Pressure - 12 VDC -

Auto SystemBushing, Reducer - Hex

(3/4 NPT X 1/4 NPT] - Autosystem

Tee, Pipe - Reducing (1 NPTX 1 NPT X 3/4 NPT) - Autosystem

505-0004

33 307-0836

3435

503-0398503-0792

ci~p, iioseHose, Rubber

x 12-1/2’’LG)Hose, Rubber

x 30’’LG)Adepter, Pipe

$:!7n “---A 1 Iv nusw )

l“ID X l-3/8”OD- Nat. Gas SystemI“ID X 1-.3/8”~503-0799

56789

1011

145-0532145-0540503-0998145-0590509-0165503-0465S03-1172

to Hose (1 NP137 505-0?59

Nipple, Pipe - Half (3/4 NP1)3839

505-0324148-0626 Va’lve, Control (1 NPT) - LPG”

systemBushing, Reducer - Hex (1 NPT

x 3/4 NPT)Nipple, Pipe (3/4 NPT x

1-3/8”)Elbow, Pipe - 90” (3/4 NPT]Nipple, Pipe (3/4 NPT x

1-3/8”)Tee, Pipe (3/4 NPT)Nipple. Pipe (3./4 !4PT x

1-3/8”)Bushing, Reducer - Hex

(1 NPT X 3/4 NPT)Elbow, Pipe - 90” (1 NPT)Nipple. Pipe - Close (1 NP1

x 1-1/2”)Reguiator, Pressure - Gas

Vapor (1 NPT) - Nat. GasSystem

Screw, Self-locking - HexWasher Head (1/4--20 x l“)

Nut, Self-locking - HexWasher Head (1/4-20)

Nipple, Pipe with Bracket(1 NPT)

Switch, Toggle - Manual SystemBracket, Mounting - Switch -

Manual System9racket, Mounting - Manual

systemScrew, Cap -. Hex Head

(3/8-16x 1-1/4”)Washer, Lock - Spring (3/8”)Washer, Flat (3/8”)Bracket, Mounting

40 505-0129

41 505-0102145-0541145-0539813-0103

505-0132505-0102

4243

526-0008 4445

505-0166505-0102

1516171819

,1’I

20

‘ii,,,,, 21222324

850-0030870-0053145-0528145-0540800-0050

850--0050145-0538148-0775110-0445526-0065

46 505-0129

4748

505-0041505-0004

49 148-0601

50 821-0013

51 870-021225 520-0011

130-0797522627

28

145-0482501-0011 53

54308-0005308-0150

502-003355 306”0155

29 148-0627800-005156

30 505-0020

z59

850-0050526-0174148-086931 505-1345

‘j’~I‘1”‘1,,

21

22

& Alternator

13

-H

QTVUSED

1

1

1

1

1

1

1

1

1

1

1

1

1

1

4

.~l’”~ REF PART~1,

NO. w.

1511-0131

511-0092

511-0156

2800-0027

800-2058

3850-0045

850-2008

4526-0115

526-2106

5800-0095

800-2097

I 6 850-0065,’ 7

862-0005

870-2056

9

PARTDESCRIPTI(M4

Belt, Drive - VUsed with both Motorola and

Bosch Alternator onMechanical Governor

Used with Motoro?aAlternator and ElectricalGovernor

Used with Bosch Alternatorand Electrical Governor

Screw, Cap - Hex HeadUsed with Motorola

Alternator (5/16-18 x 7/8”)Used with Bosch Alternator

“a~~~ xL1-;/4 X 25), - Spring

Used with MotorolaAlternator (5/16”)

Used with Bosch Alternator(M8]

Washer, FlatUsed with Motorola

Alternator (11/32” ID x11/16” 00 X 1/16:’ Thk)

Used with 8osch Alternator(M8)

Screw, Cap - Hex HeadUsed with Motorola

Alternator (1/2-13 x 2-1/2”)Used with Bosch Alternator

!M1O X 1-1/2 X 80)Washer, Lock -Spring (1/2s’)Nut, Hex

Used with MotorolaAlternator (1/2-13)

Used with 90sch Alternator(Self-Locking M1O x 1-1/2)

REF- PARTNo. MO.

8

191-1388191-1983-01

9 868-000710 850-007011 515-009312 191-139013 312-0?0114

191-1099

191-1982

15 800-0029

16 850-004517 191-086418 862-001519 191-120320 191-198121

191-1564

150-1521

191-2026

191-2025

QTV PARTUSED DESCRIPTION

1111

;1

1

1

1

11111

1

1

1

1

Alternator - 12 VDC (IncludesParts Marked *)

Motoro 1a8osch (Does Not Include Fan)

*Nut, Hex (5/8-18)Washer, Lock - Spring (5/8”)*Key, Woodruff (#5)*Regulator, Voltage*Capacitor

P4J1leySpec A and B (Used with

Motorola Alternator)Spec C (Used with 8osch

Alternator)Screw, Cap - Hex Head

(5/16-18x 1-1/’8”)Waaher, Lock - Spring (5/16”).SpecerNut, Hex (5/16-18)Arm, AdjustingFan (Bosch Alternator)Bracket, Mounting

Usedand

Usedand

Usedand

Usedand

with Motorola AlternatorElectric Governorwith Motorola AlternatorMechanical Governorwith Bosch AlternatorElectric Governorwith Bosch AlternatorWachanical Governor

* - parts included With 191-1388 Alternator.

23

Cooling System(Radiator)

.:

..,,

\.>. \.- -.

‘\ \

I

i’ {3 35

/f

13

24

NO. NO.

1 S03-03652 503-0571

3 130-19984 130-19995 503-01836 503-08337 503-11688 505-0135

9 505-0120

10 505-006011 505-007512 505-0119

13 505-0019

14 505-003915 505-0101

16 800-0029

17 850-004518 309-047719 309-0476?0 309-047921 800-0040

,,.’4( 22 800-0029YL~,t,.

23 850-004524 504’-000525 309-048026 130-102427 130-200028 800-0051

29 870-0133

30 148-027431 511-008432 821-0010

33 512-013634 800-00!55

35 130-096836 821-0016

37 870-0048

38 130-098939 821-0016

QTYUSED

84

118318

1

111

5

11

4

41211

2

311211

1

214

14

12

2

16

PARTDESCRIPTION

Cooling System(Radiator)

Clamp, HoseHose, Rubber (2”10 x 2-3/8”00

x 2“LG)Tube, Coolant - UpperTube, Coolant - LowerClamp, HoseHose, Rubber (5/8”ID x 24’’LG)Hose, Rubber (5/8”10 x 36’’LG)Nio~le, Pipe - Half (3/8 NPT

REFNo.

40

4142

434445

X“ i-1.12”)”Elbow, Pipe - Street,

(3/8 NPT)Tee, Pipe (3/8 NPT)Nipple, Pipe (3/8 NPTElbow, Pipe - Street.

(3/8 NPT)

4690 “

x 2-1/2”)45”

Bushing, Reducer - Hex(1/2 NPT X 3/8 NPT)

Elbow, Pipe - 90” (3/8 NPT)Nipple, Pipe - Close (3/8

NPT X l“)Screw, Cap - Hex Head

(5/16-18 X 1-1/8”)Washer. Lock - Spring (5/16”)Cover - Thermostat HousingThermostatGasketScrew, Cap - Hex Head

(5/16-18 X 3-3/4”)Screw, Cap - Hex Head

(5/16-18 X 1-1/8”)Washer, Lock - Spring (5/16”)Cock, Drain (1/8 NPT)8ase - Thermostat HousingGasketSpacerScrew, Cap - Hex Head

(3/8-16 X 1-1/4”)Nut, Self-locking - Hex

Washer Head (3/8-16)Bracket, “J”8elt, DriveScrew, Self-locking - Hex

Washer Head (1/4-20 x 1/2”)PulleyScrew, Cap - Hex Head

(3/8-16 X 2-1/4”)Adapter - Drive PulleyScrew, Self-locking - Hex

Washer Head (5/16-18 x 3/4”]Nut, Self-locking - Hex Washer

Head (5/16-18)Guard, BeltScrew, Self-locking - Hex

Washer Head (5/16-18 x 3/4”)

47

48

49

505152

53545556

5758

59606162

636465

6667

68

*_

PARTNo.

526-0122

130-1997821-0016

862-0016850-0060526-0035

130-0981

821-0010

512-0059518-0342130-0972130-0970130-0969821-0016

870-0048

800-0048

850-0050130-0973800-0051

850-0050191-0864130-0971821-0010

130-0986815-0181

130-1985504-0003130-2128821-0014

870-0113130-1996815-0181

405-2870821-0014

405-2869

QTY PARTUSED DESCRIPTION

6

12

111

1

4

12

:12

2

1

111

1

;8

112

:16

61

10

18

1

Washer, Flat (11/32”ID x23/32”OD X 1/8’’THK)

FanScrew, Self-locking - Hex

Washer Head (5/16-18 x 3/4”)Nut, Hex (1/2-13)Washer, Lock - Spring (1/2”)Washer, Flat (17/32”10 x

7/8”OD X 1/8’’THK)iiub & Pulley Assembly

(Includes the following non--illustrated replaceable partsmar’,ed *)

* Screw, Self-locking - HexWasher Head (1/4-20 x 1/2”)

* Pulley* Clip, Retaining* Collar* Bearing* Hub

Screw, Self-locking - HexWasher Head (5/16-18 x 3/4”)

Nut, Self-locking - HexWasher Head (5/16-18)

Screw, Cap - Hex Head(3/8-16 X 3/4”)

Washer, Lock - Spring (3/8”)8raceScrew, Cap - Hex Head

(3/8-16 x i-1/4 J. . ..i.

Washer, Lock - Spring (3/8”)SpacerBracket, Mounting - Fan DriveScrew, Self-locking - HexWasher Head (1/4-20 x 1/2”)

Guard, FanScrew, Tapping - Hex Head

with ET Lockwasher(#10-32 X 1/2”)

Shroud, FanCock, Drain (1/4 NPT)Cap, RadiatorScrew, Self-locking - Hex

Washer Head (5/16-18 x 1/2”)Nut, Retainer (5/16-18)RadiatorScrew, Cap - Hex Head with ET

Lockwasher (#10-32 x 1/2”)Flange - Air DuctScrew, Self-1ocking - Hex

Washer Head (5/16=18 x 1/2”)Panel, Housing - Front

Parts Included in 130-0981 Hub & Pulley Assemb y.

25

Cooling System(Heat Exchanger)

‘)

,-

UJ 65—.

26

Cooling System(Heat Exchanger]

REFNo.

PARTNo.

QWUSED

21

21

8228

1

1~

1

5

33

4

41211

2

3112142

2

22

2

61

2

PART REF PARTDESCRIPTION ND. No.

Clamp, Hose 37 102-1114Hose, Rubber - Lower (2”[D x 38 505-01.30

2-3/8”OD x 20’’LG) 39 505-1301Clamp, HoseHose, Rubber - Upper (2”ID x 40 505-0129

2-3/8”OD X 24’’LG)Clamp, Hose 41 505-0051Hose, Rubber (5/8”10 x 24’’LG)Hose, Rdbber (5/8’’ICI x 36’’LG)

.—.—42 505-0385

Nipple, Pipe - Half (3/8 NPTx 1-1/2”) 43 505-0043

Elbow, Pipe - Street, 90” 44 505-0109(3/8 NPT)

Tee, Pipe (3/8 NPT) 45 821-0011Nipple, Pipe (3/8 NPT x 2-1/2”)

~TY PARTJSED DESCRIPTION

12

503-0274503-0846

111

1

1

1

~1

7

7

2

11

:18

3

11

1

111

1

22

:

:2

Cooler, OilPlug, Pipe (3/4 NPT)

#Valve, Control - TemperatureRegulating (1 NPT)

#Bushing, Reducer - Hex(1 NPT X 3/4 NPT)

#Elbow, Pipe - Street, 90”(3/4 NPT)

Nipple, Pipe - Half(1-1/2 NPT X 2“)

El bQw, Pipe - 90” (1-1/2 NPT)Nipple, Pipe (1-1/2 NPT x

2-1/2”)Screw, Self-locking - Hex

Washer Head (1/4-20 x 7/8”)Nut, Self-1ocking - Hex

Washer Head (1/4-20)Strap. Holddown - Heat

ExchangerStrap, SupportSupport - Oil CoolerPencil, Zinc (3/8 NPT)Heat Exchanger (Includes Cap)Cap, Heat Exchanger (7 LB PSI)Screw, Self-locking - Hex

Washer Head (5/16-18 x 3/4”)Nut, Self-locking - Hex

Washsr Head (5/16-18)Bracket, Mounting~vac~e~ U....n. ;n- - u~at, ,-,VUI.L vrwj tr

ExchangerScrew, Cap - Hex Head

(7/16-14 X 3/4”)Washer, Lock - Spring (7/16”)

34

503-0274503-0753

5678

503-0183503-0833503-1168505-0135

9 505-0120

101112

13

505-0060505-0075505-0119 Elbow, Pipe - Street, 45”

(3/8 NP1)Bushing, Reducer - Hex

( 1/2 NPT X 3/8 NPT)Elbow, Pipe - 90- (3/8 NPT]Nipple, Pipe - Close

(3/8 NPT X l“)Screw, Cap - Hex Head

(5/16-18 X 1-1/8”)Washer, Lock - Spring (5/16”)Cover - Thermostat HousingThermostatGasketScrew, Cap - Hex Head

(5/16-18 X 3-3/4”)Screw, Cap - Hex Head

(5/16-18 X 1-1/8”)Washer, Lock - Spring (5/16”)

46 870-0212

47 130-0802

48 130-111249 102-115950 130-134051 130-216252 130-066153 821-0016

54 870-0048

55 130-111056 130-0805

57 800-0069

58 850-005559 130-224560 800-0056

61 800-0051

62 850-005063 526-017464 130-224365 130-224466 130-105067 504-004668 148-0274

505-0019

1415

505-0039505-0101

16 800-0029

850-0045309-0477309-0476309-0479~Q~–~~~fJ

22 800-0029

23242526272829

850-0045504-0005309-0480130-1024130-2000503-0446503-1099

Cock, Drain (1/8-NPT~Base - Thermostat HousingGasketSpacerClamp, HoseHose, Rubber (1/2”ID x 7/8’

X 29’’LG)Nipple, Pipe - Half

(1/4 NPT X 1-1/2”)Elbow, Pipe - 90” (1/4 NPT;Nipple, Pipe - Close

( 1/4 NPT X 7/8”)Bushina. Reducer - Hex

OD

StrapScrew, Cap - Hex Head

(3/8-16 X 2-1/2”)Screw, Cap - Hex Head

(3/8-16 X 1-1/4”)Washer, Lock - SpringWasher, Flat (3/8”)Spacer, SleeveSpacer, SleeveGuard, Be’It

*Valve, Globe (3/4 NP1)Bracket, “J”

3/8” J505-030230

3132

505-0038505-0099

33 505-0018( 1/2 iiPT X 1/4 NPT )

Nipple. Pipe (3/4 NPT x 1-3/8”)Valve, Solenoid - 12 VDC

(3/4 NPT)Elbow, Pipe - 90” (3/4 NPT)

505-0102307-0835

3435 Non-Regulated Systems.

Regu!:ted Systems.* - Parts used on#- Parts used on

36 505-0132

21

Cooling Syst*w(Remote Radiator]

~......‘

-4

7

13

28

Coolin S stem( Remote

Ivadlator)

REF PARTHD. Ho.

1 503-02742 503-0”/53

3 503-0274& 593-0753

5 503-01836 503-083:17 503-11688 505-013S

9 505-0120

10 505-006011 505-007512 S05-0119

13 505-0019

14 505-003915 ~o~-fllf)l., ----

16 800-0029

17 850-004518 309-047719 309-047620 309-0479

,,.., 21 800-0040

“..,. 22 800--0029

23 850-004524 504-000525 309-048026 130-102427’ 130-200028 503-0446

QTYUSED

21

21

8228

1

:1

5

33

4

412

:

2

311214

PART mrcmcr PARTDESCRIPTION ND. ND.

Clamp, Hose 29Hose, Rubber - Lower (2”10

X 2-3/8”OD X 24’’LG) 30Clump, HoseHose, Rubber - Upper (2”ID 33

X 2-3/8”00 X 24’’LG)Clamp, Hose 45Hose, Rubber (5/8”10 x 24’’LG)Hose, Rubber (5/8”ID x 36’’LG) 46Nipple, Pipe - Half

(3/8 NPT X 1-1/2”) 57Elbow, Pipe - Street, 90”

(3/8 NpT) 58Tee, Pipe (3/8 NPT) 59Nirmle, PiDe (3/8 NPT x 2-1/2”) 60Elb@, ”Pipe -“Street, 45” - “

(3/8 NPT)Bushing, Reducer - Hex

(1/2 NPT X 3/8 NPT)Elbow, Pipe - 90” (3/8 NPT)Nipple. Pipe - Close

(3/8 NPT X 1“)Screw, Cap - Hex Head

(5/16-18 X 1-1/8”)Washer, Lock - Spring t5/16”)Cover - Thermostat HousingThermostatGasketScrew. Cap - Hex Head

(5/16-18 X 3-3/4”)Screw, Cap - Hex Head

(5/16-18x 1-1/8”)Washer, Lock - Spring (5/16”)Cock, Drain (1/8 NPT)8ase - Thermostat HousingGasketSpacerCli~mp, Hose

61

62636465666869

70

7172

737475

503-1099

505-0302

505-0018

821-0011

870-0212

800-0069

850-0055130-2245800-0056

800-0051

850-0050526-0174130-2243130-2244130-1050148-0274870-0281

821.-0029

102-1244102-1238

505-0110505-0013102-1097

QTYUSED

2

2

2

1

7

i

1

;

1

2211126

6

21

;1

PARTDESCRIPTICM

H~;g ~;ber (1/2”ID x 7/8”OD88

Nipple. Pipe - Half(1/4 NPT X 1-1/2”)

Bushing, Reducer - Hex( 1/2 NPT X 1/4 NPT)

Screw, Self-locking - HexWasher Head (1/4-20 x 7/8”)

Nut, Self-1ocking - HexWasher Head (1/4-20)

Screw, Cap - Hex Head(7/i6-i4 x 3/4”)

Washer, Lock - Spring (7/16”)StrapScrew, Gap - Hex Head

(3/8-16 X 2-1/2”)Screw. Cap - Hex Head

(3/8-16 X 1-1/4”)Washer, Lock - Spring (3/8”)Washer, Flat (3/8”)Spacer, SleeveSpacer, SleeveGuard, Belt8racket, “J”

*Nut, Hex - Self-locking(3/8-16)

*Screw, Cap - Hex Head(3/8-16 X 3/4”)

*8racket, Mounting - Oil Cooler*Cooler, Oil (Includes Two

Mounting Clamps)Plug, Pipe - Square Head (3/8”)Plug, Pipe - Square Head (1/2”)Ada~ter, Oil Cooler (Includes

l!o;l Ring and Hex Adapter)

* - Use Began During April, 1986 During Spec A

29

Exhaust System

14

\

r\

///.0 \

S2’(b~ “..,,—.;=

4/%

/2 /-

6

k..,.:~,

24

Y)”

..-.,...-,,s.‘... . .

18

,-

-’xI,

30

REF PARTNO. NO.

1 800-0052

2 850-00453 526-0022

4 870-0281

5 154-17396 155-18867 862-00038 850-00509 520-0925

10 145-053311

145-0541145-0539

12 870-0195

13 850-0165

QTYUSE[~

4

84

4

114441

118

4

Exhaust

PARTDESCRIPTION

Sereiv, Cap - Hex Head(3/8-16x 1-1/2”)

Washer, Lock - Spring (5/16”)Washer, Flat (21/64”ID x

9/16”OD X 1/16’’THK)Nut, Self-1ocking - Hex Washer

Head (3/8-16)Flange, Pipe - Exhaust OutletGasketNut, Hex (3/8-16)wa~er, Lock - Spring (3/8”)

-. SST (3/8-16 X 1-1/4”)GasketTurbocharger

50 Hertz Sets60 Hertz Sets

Nut, Self-locking - Hex(5/16-24)

Washer, Lock - Spring - SST(5/16”)

System

REF PARTNo. No.

14 155-189115 154-233616 505-0057

17 504-000518 870-0130

19 526-018820 520-081921 155-192322 154-1766

23 520-0165

24 505-0216

QTYUSED

122

1:

1616

22

8

1

PARTDESCRIPTION

Tube Assembly - ExhaustGasketPlug, Pipe - Square Head

(1/8 NPT)Cock, Drain (1/8 NPT)Nut, Hex - Self-locking

(3/8-24)Washer, Flat (5/16”)Stud (3/8-24 X 3/8-16 X 1-7/8GasketManifold, Exhaust - Liquid

Cooled (Includes EndMounting Studs)

Stud (5/16-24 X 5/16-18 X1-7/8”)

Elbow, Pipe - Street, 90”(2-1/2 NPT)

,“,.,

4$1..,

31

set Mousing

32

27

Set Housing

REF PARTNo. NO.

1 813-0098

2 850--00303 810-00534 406-01055 405-1774

6 405-3012

7 821-0014

8 405-17769 821-0014

10 870-011311 405-302712 812-0149

13 870-0232

14 406-015715 405-008916 809-0059

$TYo

8

:42

4

28

1:

1212

2

113

PARTOESCRIPTICM4

Screw, machine - Round Head(#10-32 X 3/8”)

Washer, Lock - Spring (#10)Nut, Hex (#10-32)Fastener, DoorDoor, Access - Louvered (Does

Not Include Fastener)Panel, Access - Louvered

(Does Not Include Fastener)Screw, Seif-iocking - Hex

Waaher Head (5/16-18 x 1/2”)Support, Hous{ng - CenterScrew, Self-1ocking - HexWasher Head (5/16-18 x 1/2”)

Nut, Clinch (5/16-18)Panel, Housing - TopScrew, Machine - Round Head

(1/4-20 X 9/16”)Nut, Self-locking - Hex with

ET Lockwasher (1/4-20)Handle (IncludesCatch, LatchScrew, Tapping -

( 1/4 x 1/2”)

Key ) “

Pan Head

REF PARTNO. ND.

17 870-010618 405-177719 813-0098

20 850-003021 405-178022 821-0014

23 405-177524 821-0010

25 403-089526 821-0029

27 403-089428 814-0079

29 850-002530 860-000831 406-024932 406-0565

QTYUSED

316

618

18

26

128

2828

41

PARTDESCRIPTION

Nut, Sheet Spring (1/4”)Door, Access - RearScrew, Machine - Round Head

(#10-32 X 3/8”)Washer, Lock - Spring (#IO)Panel, Access - RearScrew, Self-locking - Hex

Washer Head (5/16-18 x 1/2”)Panel, Housing - RearScrew, Self-1ocking - Hex

Washer Head (1/4-20 x 1/2”)Plate, CoverScrew, Self-locking - Hex

Washer Head (3/8-16 x 3/4”)Chassis, RearScrew, Machine - Flat Head

(#8-32 X 1/2”)Washer, Lock - Spring (#8)Nut, Hex [#8-32)Hasp SetKey - Handle

33

Exhaust Muffler

23

2!$ 30

34

Exhaust Nuffler

REF PARTNO. MO.

1 813-0105

2 870-0188

3 155-14224 895-0160

5 800-0031

6 850-00457 526-0022

8 862-00149 154-1739

10 155-188611 505-0216

12 155-1948

13 505-1168

14 800-0031

15 526-0113

16 870-0257

QTY PARTUSED DESCRIPTICM

2

2

11

4

!34

4i

:

1

1

2

4

2

14

4

Screw, %achiae - Round Head(#10-32 X 1“)

Nut, Self-1ocking - Hex(#10-32)

Shield, RainStrip, Asbestos (2”W x

1/16’’THK X 13-1/2’’LG)Screw, Cap - Hex Head

(5/16-18 X 1-1/2”]Washer, Lock - Spring (5/16”)Washer, Flat (21/64”10 x

9/16”OD X 1\16’’THK)Nut, Hex (5/16-18)F 1ange - Exhaust ManifoldGasket

*Elbow, Pipe - Street, 90”(2-1/2 NPT) Thru June 1982

*Tube, Exhaust - Flexible,Reducing (3 NPT x 2-1/2 NPTx 13-1/4’’LG) Thru June 1982

Elbow, Pipe - 90”, Reducing(4 NPT X 3 NPT)

Screw, Cap - Hex Head(5/16-18 X 3“)

Washer, Flat (11/32”ID x11/16”00 X 1/16’’TtiK)

Nut, Self-locking - HexWasher Head (5/16-18)

Muffler, ExhaustScrew, Cap - Hex Head

(5/16-18 X 3“)Nut, Self-locking, - Hex

(5/16-18)

REFNo.

20

212223

24

25

26

27

28

29

30

3132

33

*-

PARTNo.

155-1430

140-0752155-1947/121-0016

870-0048

155-0789

505-0702

1.55-1592

505-0382

505-0668

505-0103

503-0965155-1489

155-1463

QTY PARTUSED DESCRIPTION

4

214

4

2

1

1

1

1

1

21

2

Spacer, Sleeve (1/2”10 xl-1/2”oD x 2“THK)

Band, Mounting (12’’10)Shield, HeatScrew, Self-locking - HexWasher Head (5/16-18 x 3/4”)

Nut, Self-locking - Hex(5/16-18)

8racket, Support - MufflerMounting

*Union (3 NPT) July 1982 thru1983

*Tube, Exhaust - Flexible(3NPTx 12’’LG) July 1982thru 1983

*Nipple, Pipe - Close (3 NPT)July 1982 thru 1983

*Elbow, Pipe - 90”, I?educing(3NPTx 2-1/2NPT) 8eginJuly 1982

*Nipple, Pipe - Close(2-1/2NPT) Begin July 1982

*Clamp, Hose - 8egin 1984*Tube, Exhaust - Flexible

(3’’IDx 9“LG) Begin i984‘Connector, Exhaust (3 NPT)

Begin 1984

NOTE: Various Factory Installed Systems;Recommended Replacement Using Latest Design Parts.

35

Chassis

8 19

&:*-

///

87

6a

REF PARTNO. NO.

1 865-00072 850-00453 526-0115

4 520-0231

5 416-03386 800-0071

7 850-00558 856-00139 800-0071

10 850-005511 862-000412 800-0152

(&

;2

2

16

888

804

PARTDESCRIPTION

Nut, Wing (5/16-18)Washer, Lock - Spring (5/16”)Washer, Flat (11/32”ID x

11/16”OD X 1/16’’THK)Stud (5/16-18 X 5/16-24 X

7-9/16’’LG)Frame, Holddown - BatteryScrew, Cap - Hex Head

(7/16-14 X 1“)Washer, Lock - Spring (7/16”)Washer, Lock - EIT (1/2”)Screw, Cap - Hex Head

(7/16-14 X l“)Washer, Lock - Spring (7/16”)Nut, Hex (7/16-14)Screw, Cap - Hex Head

(3/4-10 x 1-1/4”)

REF PARTNO. NO.

13 850-007914 402-037115 403-119316 800-0071

17 850-005518 856-001319 337-009020 403-119421 821-0016

22 856-000823 870-0257

24 332-147325 403-1942

io

QTYUSED

4428

88121

11

:

PARTDESCRIPTION

Washer, Lock - Spring (3/4”)Mount, VibrationSupport, Mounting - EngineScrew, Cap - Hex Head

(7/16-14 X 1“)Washer, Lock - Spring (7/16”)Washer, Lock - EIT (1/2”)Strap, Electrical - GroundBracket, Mounting - EngineScrew, Self-locking - Hex

Washer Head (5/16-18 x l“)Washer, Lock - EIT (5/16”)Nut, Self-locking - Hex

Washer Head (5/16-18)Terminal, Lug - GroundChassis

,,

),,,,!

36

Governor - Electronic

5“

1

lWF PARTm. ND.

1 150-1898

? 151-060S3 821-0005

4 151-05665 800-0007

6 850-0040

QTY PAWUSED DESCRIPTI~

1 Governor Package (BarberColeman Part No. OYNK 10117)

1 Controller, Governor4 Screw, Self-Locking - Hex

Washer Head (10-32 x 1/2”)1 Actuator4 Screw, Cap - Hex Head

(1/4-20 x l“)4 Washer, Leek - Spring (1/4)

1:L’REF PARTw. m.

‘1 862-00018 520-00869 870-0131

10 526-000811 8?:-”000312 151-0411

13 370-2010

QWUSEO

414

421

1

PARTDESUUPTXM

Wm. thx (1/4-20)Stud (B1O-32 x 4-3/4”)Nut, Self-Locking - Nex

External ToottWasher, FlatScrew, Self-Locking - lie~ HeaoPickup, Magnetic [Engine to

Generator Adapter Mounted]Gusset

37

Filter - Coolant

REF PARTNo. NO.

1 130-0497

2 130-0771

3 130-0772

4 130-07785 130-0775

e!E3

QTY PARTUSED DESCRIPTI~

1 Filter, Coolant (IncludesParts Marked @)

1 Kit, Element (Includes PartsMarked *)

1 Kit, Element (Includes PartsMarked #)

1 *#@Gasket, Cover1 *@Element (Water)

\

2,3

REF PART QTY PARTNo. No. USED DESCRIPTION

6 130-0776 1 #Element (Anti-freeze)7 130-0780 1 *#@Plate, Sacrificial8 502-0155 1 @Plug, Pipe - Brass (3/8 NPT)

@ - Parta Included in Coolant Filter.*- Parts Included in Element (Water) Kit.#- Parts Included in Element (Anti-freeze) Kit.

3a

f?

I-9

REF PARTNo. No.

1 503-04462 503-07433 503-11184 130-20535 503-0395

6 505-0151

‘1 502-0313

8 505-0007

Switch - Low Coolant Level

(/wUSED

41121

1

1

1

PART REF PARTDESCRIPTION NO. NO.

Clamp, Hose 9 821-0011Hose, Rubber (1/4”ID x 18’’LG)Hose, Rubber (1/4”10 x 48’’LG) 10 870-0212Tube - Copper (1/4”OD x 2“LG)Connector, Pipe to Hose 11 193-0329

(1/8 NPT x 3/16”ID Hose) 12? 502-0800Bushing, Reducer - Hex, Brass

( 1/2 NPT X 1/8 NPT)Elbow, Pipe to Hose - 90” 13 357-0030”

(1/8 NPT x l/4”ID Hose)Bushing, Reducer - Hex, 8rass

(1/4 NPT X 1/6 NPT)

4

QTY PARTUSED DESCRIPTION

2 Screw, Self-locking - IiexWasher Head (1/4-20 x 7/8”)

2 Nut, Self-locking - HexWasher Head (1/4-20)

1 Switch, Coolant Level2 Adapter, Tube (Blind Hole

Fitting) 5/8”OD x 1/4”00Tube

2 Diode, Rectifier (Used inWiring Harness Leads)

39

Heater - Engine Coolant(1$79 thru 1982)

25/

15

26

4?.-6$$\% 4

113I

8

\ ‘-y’%

I

w /I

v--- 1, I

I /’ i

/

/“

—/

12’\

10

40

Heater - Enaine Coolant(1978 tfiru 1982)

REF PARTNo. No.

I 501-02252 505-000’?

3 505-07634 505-0098

5 503-01836 503-08327 503-08438 502-0613

10 502-094212 505-0455

13 331-002714 NFS

15 NFS

16332-0014332-0807. . a,...J2.S-lJY~l

17 309-030418 505-0004

19 800-0007

QTVWED

11

;

4112

$

6

44411

4

PARTOESCRIPTIfXi

Line, Fuel - Flexible13ushi$?g, !%K!c!cer - M?x

( 1/4 NPT X 1/8 NPT)Cross, Pipe (1/8 NPT)Nipple, Pipe - Close

( 1/8 NPT X 3/4’-LG)Clamp, HoseHose, Rubber (5/8*ID x 12”LG)Hose, Rubber (5/8”ID x 40’’LG)Connector, Pipe to Hose

(1/4 NPT x 5i’t3’clG Hose)Elbow, Pipe - 90” i3/8 NPT)Bushing, Reducer - Hex

(1 NPT X 3/8 NPT)Connector, CableCord, Electrical (2-#14,

Type SO, 600 Volt)Cable, Electrical (3-!!12 or

4-#14, Type SO, 600 Volt)Terminals (Select as Required)

#lo#8Wire Nut

Switch. ThermostaticNipple, Pipe - Close (1 NPT

x l-1/4’’LG)Screw. Cap - Hex Head

(1/4-20 X 1’:)

R& PARTNo. NO.

20 862-000121 850-004022 309-030723 505-0099

24 333-0i42

25307-1460307-1164

26 821-0016

27 870-0257

28 130-119229 504-000330

333-0158333-0167333-0148333-0141333-0176333-0170333-0147333-0146333-0172

Nut, Hex (1/4-20)Washer. Lock - Spring (1/4”)Switch, PressureNipple, Pipe - Close (1/4 NPT

X 7/8’’LG)8racket, Support with Pipe

TeeContactor. Electrical

230 VAC, 3 Pole460 VAC, 3 Pole

Screw, Self-locking - HexWasher Head (5/16-18 x 3/4”)

Nut. Self-locking - HexWasher Head (5/16-18)

Bracket, Mounting - HeaterCock. Drain (1/4 NPT)Heater, Electrical - Engine

Coolant2000 Watt, 115 VAC, 1 Phase2000 Watt, 208 VAC. 1 Phase2000 Watt, 208 VAC, 3 Phase2000 Watt, 240 VAC. 1 Phase2000 Watt. 380 VAC, 1 Phase2000 Watt, 380 VAC. 3 Phase2000 Watt, 480 VAC, 1 Phase2000 Watt. 440 VAC. 3 Priase

- -.

2500 Watt. 440 VAC, 3 Phase

,’

,,

41

i

II

iI

Heater - Engine Coolant(Begin 1983)

14

LY

11

24

\8

,5 “/ /I II I WA \—

“JZ2’”

-. ..-.

,1,

,,,1

!r,, ,,’

42

Heater - Engine Ccsolant(Begin 1983)

p REF PARTi.I&w’ ‘“ ‘“

1 501-02252 505-0007

3 505-07634 505-0098

5 503-01836 503--08327 503-08438 502-0613

10 502-094212 505-0455

13 331-002714 NFS

15 NFS

16332-0014332-0807323-0957

17 309-030418 505-0004

19 800-0007

20 862-0001

QTVUSED

11

:

4112

22

6

44411

4

4

QADTr-,

DESCRIPTIffl

Line, Fuel - FlexibleBushing, Redueer - Hex~\~&NPT X 1/8NPT)

Pipe (1/8 NPT)Nipple, Pipe - Close

{1/8 NPT X 3/4’’LG)CTamp, HoseHc~se, Rubber (5/8”ID x 12’’LG)Hc{se, Rubber (5/8”ID x 40’’LG)Connector, Pipe to Hose

(1/4 NPT x W’8::ID Hose)Elbow, Pipe - 90” (3/8 NPT)Bushing, Reducer - Hex

(1 NPTx3/8NPT)Connector, CableCord, Electrical (2-#14,

Type SO, 600 Volt)Cable, Electrical (3-$12 or

4-#14, Type SO, 600 Volt)Terminals (Select as Required)

#lo#8Wire Nut

Switch, ThermostaticNipple, Pipe - Close

(1 NPT X 1-1/4’’LG)Screw, Cap - Hex Head

(1/4-20 X ~“)Nut, Hex (1/4-20)

212223

24

PARTNo.

850-0040309-030’7502-0054

333-0224

812-0079

850-002525

26

27

282930

307-1460307-1164821-0016

870-0257

130-1192504-0003

333-0158333-0167333-0148333-0141333-0176333-0170333-0147333-0146333-0172

QTYUSED

411

1

4

4

114

4

21

111

;11

:

PARTDEsCRIPTIO@l

Washer, Lock - Spring (1/4”)Switch, PressureElbow, Pipe - Street. 90”,

Brass (1/4 NPT)Bracket, Mounting - Pressure

SwitchScrew, Machine - Round Head

(#8-32 X 1/2”)Washer, Lock - Spring (#e)

Contactor, Electrical230 VAC, 3 Pole460 VAC, 3 Pole

Screw, Self-locking - HexWasher Head (5/16-18 x 3/4”)

Nut, Self-locking - HexWasher Head (5/16-18)

Bracket, Mounting - HeaterCock, Drain (1/4 NPT)Heater, Electrical - Engine

Coo 1ant2000 Watt, 115 VAC, 1 Phase2000 Watt, 208 VAC, 1 Phase2000 Watt, 208 VAC, 3 Phase2000 Watt, 240 VAC, 1 Phase2000 Watt, 380 VAC, 1 Phase2000 Watt, 380 VAC, 3 Phase2000 Watt, 480 VAC, 1 Phase2000 Watt, 440 VAC, 3 Phase2500 Watt, 440 VAC, 3 Phase

-,.

43

control - Engine(Spec A)

“y 120I II Y II/1%-.

\

50

‘\

“1I

.

44

Control - Engine(Spec A)

REF PARTNO. NO.

QTYUSEIIJ

11411

\4

11

;12

:

11

1

11

i11

i

1

;1

111

1

1112

2

PARTDESCRIPTION

PARTDESCRIPTION

REF PARTNo. No.

QTYUSED

123456789

322-00043~2.0149

307-1157307-1058307-1058307-1058307-1061518-0374

Lamp, Incandescent (12 VDC)Light - PanelSpring, Holddown - RelayRelay (Ignition)Relay (Start Disconnect)Relay (Run Alarm)Relay (Starter Protection)Fastener, Snap-InCrankei-, Control (12 VDC)

Standard

31 870-005332 850-003033 332-005134

1 Nut, Hex (#10-32)Washer, Lock - Spring (#10)Clip - CableHarness, Wiring - Engine

Control (Selection RequiredConsult your Onan PartsDistributor)

Jumper, TerminalBlock, Terminal

20 Place16 Place

Strip, Marker20 Place16 Place

Block, Terminal - 4 PlaceStrip, Marker - 4 PlaceBlock, Terminal - 6 PlaceStrip, Marker - 6 PlaceSocket, Relay - 11 Place

(W/O Terminals)Terminal

Socket, Relay - 8 Place(W/O Terminals)

TerminalHousing, Terminal - PC Board

(W/O Terminals)Terminal

Terminal Assembly, Ground(Includes Parts Marked *)‘Nut, Hex - Brass (#iO-32)*Washer, Lock - IT (#10)*Washer, Lock - EIT (#IO)*Washer, Lock - Spring (#10)*Washer, Flat - Brass

(13/64”10 X 7/32”OD Xl/32’’’~HK)

*Screw, Machine - Round Head,Brass (#10-32 x 7/8”)

Screw, Machine - Truss Head(#10-32 X 3/8”)

Nut, Hex (#10-32)Washer, Lock - Spring {#10)Washer, Lock - ET (#10)Panel, Control - Engine

(Selection Required, ConsultYour Onan Parts Distributor)

Bracket, Mounting - EngineControl

S5 332-104336

332-1005332-0795

37332-1559332-1271

38 332-053739 332-123940 332-069941 332-124042 323-0765

1

300-0733300-0714

i1Cyc 1e

Monitor, Engine Control(12 VDC)Standard (1 Fault Light)Penn State (1 Fault Light)Standard (5 Fault Light)

Plug, KeyingGauge, Pressure - Oil (12 VDC)Gauge, Temperature - Water

(12 VDC)AmmeterGauge, Temperature - Oil

(12 VDC)TachometerLight, Indicator - 14 VDC

Red - OVERCRANKRed - LO OIL PRESSRed - HI ENG TEMPRed - LO ENG TEMPRed - OVERSPEEDRed - FAULTRed - SWITCH OFFRed - (Blank, No Legend)

Switch, Toggle - SelectorStandard SetsPenn State Sets

Flasher (12 VDC)Screw, Machine - Round Head

(#10-32 X 1“)Bracket, Mounting - FlasherSwitch, Toggle (SPST)Capacitor, Fixed, Electrolytic

(4000MFD, 30VDC)Screw, Machine - Round Head

(#6-32 X 3/8”)Washer, Lock - ET (#6)Nut, Hex (#6-32)

Clamp, Mounting - CapacitorScrew, Machine - Round Head

( #6-32 X 1/2”)Washer, Lock - ET (#6)

10

300-0679300-0730300-0681

11 332-127613 193-024314 193-0245

:13

15 302-136216 193-024$

332-128043 323-0764

111

17 302-074918

322-0107322-0108322-0109322-0110322-0111322-0128322-0283322-0136

19308-0138308-0327

20 333-0194-01813-0105

332-128044 332-1271

81

332-126945

22

871-0010854-0010856-0003850-0030526-0049

815-0203 1

46 815-0026 521 301-605322 308-000229 356-0072

47 870-005348 850-003049 856-000350812-0061

853-0003860-0006

30 356-0070812-0063

51 301-3253 1

853-0003 * – parts Included in Ground Terminal Assembly.

45

Control - Engine(Spec B)

...-..

REF P.ARTNO. NO.

1 815-0544

2 300-2897

3

300-2901300-2902

4 300-2905

5 338-1836

6 300-2855

7 338-1835

8

9

14

15

300-2862

300-2809300-2811321-0270

321-0231321-0094

301-8851821-0004

322-0359-01322-0360-01815-0385

870-0183

323-1310

323-1302

QTYUSED

24

1

11i

1

1

1

1

112

12

14

112

2

1

13

Control - Engine(Spec B)

PARTDESCRIPTION

Screw, Machine - Round l-leadWith IT Lock Washer(#6-32 X 1/2”)

8oard - Time Oelay,Start/Stop (A15)

Board - Magnetic Sensor,Start Disconnect/OverspeedSensor (See Separate Pagefor Switch, Sensor andHarness) (A16)

StandardPrecision

Board - Over/Under VoltageSensor (A17)

Harness - Alarm Relay (12Light Control) (A14 to All)

Board - Alarm Relay (12 LightControl) (A14)

Harness - Alarm Relay (7 and12 Light Controls) (A13 toAll)

Board - Alarm Relav [7 and 12Light Controls) (A13)

Board - Enaine Monitor (All)(Includes”Fuses)7 Light Control12 Light Contro’

Fuse, Cartridge -(Fl, F2)

Fuse, Cartridge -Fuse, Cartridge -

(F4. F5)

20 Amp

15 Amp (F3)5 Amp

B;aciet.’MountinaScrew: Selfllo~king - Hex

Washer Head (#10-32 x 5/16”)Module, Indicator - Fault 301-9055-01

(A12) (Includes Connector)7 Light Control 35 338-227712 Light ControlScrew, Machine - Round Head, 36 323-1308

Black (#6-32 x 1/2”)Nut, Self-locking - Hex 323-1302

with ET Lock Washer (#6-32) 37 821-0004ticxsing, Connector - 13 Pin

(33) 38 -Contact, Pin

REF PARTNO. NO.

16 322-0369-01

17 322-0004

18 322-036119 517-013120 308-0853

21 308-0892

22 308-0784

23 870-013124 301-625725

338-1904

338-1940

26 193-035227 193-0351

28 302-164129 302-0885

815-0385

870-0183

30 193-033031 302-1873-0132 517-022133 332-005234

301-9055-02

QTYUSED

1

1

1

;

1

~

41

1

1

11

112

2

1111

1

1

1

1

123

PARTDESCRIPTION

Lamp, Incandescent - 1/3 Watt12 VDC

Lamp, Incandescent (DS1l)12 VDC

Holder, LampPlug, ButtonSwitch, Pushbutton -

Emergency Stop (S14)Switch, Rocker - Restart/

Panel Light (S11)Switch, P~~h - Run/Stop/

Remote (S12)Nut, Hex - With ET (#10-32)Cover - Switch Mounting HoleHarness

Time Delay - Start/Stop(A15 tO All)

Over/Undervoltage Sensor(A17 to All)

Gauge, Pressure - Oil (Mll)Gauge, Temperature - Water

(M12)Voltmeter-DC (M13)Meter, Time Total izing (M14)

Screw, Machine - Round Head(#6-32 X 1/2”)Nut, Hex - Self-locking

With ET (#6-32)Gauge, Temperature - Oil (M15)Tachometer (!416)Plug, ButtonClamp, LoopDoor, Control

Doors With Three RoundGauge Holes

Doors With Five RoundGauge Holes

Harness, Wiring - DC(Includes Connector)

Housing, Connector - 12 Pin(J4)Contact, Pin

Screw, Self-locking - HexWasher Head (#10-32 x 5/16”)

Relay, Run (See Separate Pagefor Components)

Control-?3enerator(Spec A)

\ —==3II35 ~ II /

36 /*4 32 ‘~.x .— >

“$=%%5{

Ill!

I rFkdiR/3’\

‘=-2’”

Control-Generator(Spec A)

REF PARTNO. NO.

1 307-11s72 307-10613

302-0406302-0408302-0410302-0411302-0412302-0413302-0605302-0719302-0720302-0721302-0722302-0723302-0724

4302-0421302-0422302-0612~op-~~~g302-0718

5302-0213302-0221302-0234302-0256

6

.:1

jp302-0809

!$ 302-0810‘}..,,, 302-0811

7302-0466302-0469

8

9

10

11

1213

i;16171819

322-0130322-0131322-0178320-0307815-0203

854-0010871-0010320-0431812-0061

850-0020406-0334

406-0333517-0131303-0076308-0284303-0032303-0170350-0556323-0765

812-0061

853-0003860-0005332-1280

PARTDESCRIPTION

Spring, Holddown - RelayRelayAmmeter

0-50 AmpO-75 Amp0-100 Amp0-200 Amp0-250 Amp0-300 Amp0-400 AmpO-75, 0-150 Amp0-100, 0-200 Amp0-150, 0-300 Amp0-200, 0-400 Amp0-250, 0-500 AmpO-375, 0-7.50 Amp

Voltmeter0-300 VAC0-600 VAC0-500 VAC0-750 VAC0-300, 0-600 VAC

Meter, Frequency - Reed Type115 VAC, 60 Hz230 VAC, 60 tiz115 VAC, 50 Hz230 VAC, 50 tiz

Meter, Frequency - PointerType

120 VAC, 60 Hz208 VAC, 60 tiz240 VAC, 60 Hz

Meter, Time Total izing60 Hz50 Hz

Light, Indicator - 125 VACRed - Upper ScaleRed - Lower ScaleRed - Blank (No Legend)

Lock, Handle - CircuitScrew, Machine - Round Head

(#10-32 X 7/8”)Washer, Lock - ET (#10)Nut, Hex (#10-32)

Breaker, CircuitScrew, Machine - Round Head

(#6-32 X 3/8”)Washer, Lock - Spring (#6)

Clip, Retaining - TurnbuttonFastener

Stud, Turnbutton FastenerPlug, PlasticKnob, PointerSwitch, SelectorKnobRheostatResistor, Fixed, CompositionSocket, Relay - 11 Place

(W/O Terminals)Screw, Machine - Round Head

(#6-32 X 3/8”)Washer, Lock - ET (#6)Nut, Hex (#6-32)Terminal

-P .mm PARTNO. NO.

20 301-324421 870-005322 850-003023 332-005124

332-0607332-0795812-0066

853-0003850-0020

25332-1242332-1248

26 321-020427 812-0065

28 853-000329

332-1268

332-1956

30315-0342315-0431812-0061

853-000331 305-0675

812-0070

850-002032 315-0384

812-0061

853-000333 508-000134 406-033235 800-0045

36 850-004537 402-007838 337-004939 815-0026

40

41 301-315842 821-0010

43

QTYUSED

1

11

112

22

1124

4

1

1

112

212

212

2124

4413

12

PARTDESCRIPTION

Bracket, Mounting - RelayNut, Hex (#10-32)Washer, Lock - Spring (?410)Clip - CableBlock, Terminial

12 Place16 PlaceScrew, Machine - Round Head

(#6-32 X 3/4”)Washer, Lock - ET (#6)Washer, Lock - Spring (#6)

Strip, Marker16 Place12 Place

Fuse, Cartridge (1/4 Amp)Screw, Machine - Round Head

(#6-32 X 5/8”)Washer, Lock - ET (#6)Regulator, Voltage

Used with 120 VAC InputSignal

Used with 240 VAC InputSignal

Transformer, Voltage120 VAC240 VACScrew, Machine - Round Head

(#6-32 X 3/8”)Washer, Lock - ET (#6)

Rectifier, 8ridg9Screw, Machine - Round Head

(#6-32x 1-1/4’”)Washer, Lock - Spring (#6)

ReactorScrew, Machine - Round Head

(#6-32 X 3/8”)Washer, Lock - ET (#6)

GrotwnetReceptacle, Turnbutton FastenerScrew, cap - Hex Head

(5/16-18 X 3/8”)Washer, Lock - Spring (5/16”)Dampener, VibrationStrap, Electrical - GroundScrew, Machine - Truss Head

(#10-32 X 3/8”)Panel, Control - Generator

(Selection Required, ConsultYour Onan Parts Distributor)

Box, ControlScrew, Self-locking - Hex

Washer Head (1/4-20 x 1/2”)Transformer, Current (See

Separate Page for Components)

2322

Control - Generator(Spec B)

4

\

///

/25

/21

m...{’ “

15A

50

,@@i#i,

REF PARTNO. NO.

1 338-2278

812-0065

234

5

6

332-0607332-2723322-:):;:;

302-l14g302-1753

302-1473302-1147302-1683302-1684302-1685~~~-~~~g

302-172S302-1726302-1727302-1728302-1729302-1798302-1799302-1800302-i720

303-0032320-1121303-0261

Control - Generator(Spcc B)

PARTDESCRIPTION

Harness, Wiring - IncludesTerminal B1ock (ControlsWith Meters) [Harness NotUsed on Controls WithoutMeters)

Screw, Machine - Round Head(#6-32 X 5/8”)

Block, Terminal (TB21)Strip. hib~Light, Indicator - Upper/Lower

Scaie (0S21, 0S22)Voltmeter (M21)

6-300/6000-750

?gte122)

0-75/1500-100/2000-150/3000-200/4000-250/5000-375/7500-400/8000-500/10000-600/12000-750/15000-1000/20000-1500/30000-2000/4000

Meter, Frequency (M23)Wattmater (M24) (See Separate

Page for Components)KnobBreaker, Circuit (C821)Rheostat (R21)

REF PARTNo. No.

12 308-088213 332-005214 406-033415 406-033316

301-9054-03301-9054-02301-9054-01

17 871-001518 853-0013

19 821-0004

20 406-033221 300-2880

815-0544

22 337-0049800-0024

856-0008862-0015

23 508-005124 402-0527

800-0045

850-004525 301-806526 821-0010

27 -

28 870-013129 508-0001

QTYUSED

1122

:111

3

216

11

11124

412

:

PARTDESCRIPTION

Switch, Rotary (S21)clamp. Loopclip - FastenerStud - FastenerDoor, Control

Without MetersWithout WattmeterWith Wattmeter

Nut, Hex - Brass (1/4-20)Washer, Locking - With ET

( 1/4”)Screw, -Self-locking - Hex

Washer Head (#10-32 x 5/16”)Receptacle - FastenerRegulator, Voltage (VR21)

Screw. Machine - Round HeadWith IT Lock Washer(#6-32 X 1/2”)

Strap, GroundScrew, Cap - Hex Head

(5/16-18 X 1/2”)Washer. Lock - E[T (5/16”)Nut, Hex (5/16-18)

GrommetMount, Vibration

Screw, Cap - Hex Head(5/16-18 X 3/8”)

Washer, Lock - Spring (5/16”)Box, Control%!rnw*-. -- , Se~f-~Q~king - HexWasher Head (1/4-20 x 1/2”)

Transformer, Current (SeeSeparate Page for Components)

Nut, Hex - With ET (#10-32)Gronunet

Control - Generator(Switching Regulator)

(Spec A)

52

REF PARTNo. No.

307-1157307-1061

322-0436302-0408302-0410302-0411302-0412302-0413302-0605302-071930?-0720302-0721302-0722302-0723302-0724

4302-0421302-0422302-0612302-0779

5

6

A“:,f?’‘i+,

7

8

11

1213

1516171819

302-0213302-0221302-0234302-0256

302-0809302-0810302-0811

302-0466302-0469

322-0130322-0131322-0178320-0307320-0455812-0061

850-0020406-0334

406-0333517-0131

- ;—!:,375

308-0284303-0032303-0170350-0556323-0765

812-0061

853-0003332-1280

Control - Generator(Switching Re ~lator)

( Spec 1

PARTDESCRIPTION

Spring, tiolddown - RelayRelayAmmeter

0-50 AmpO-75 Amp0-100 Amp0-200 Amp0-250 Amp0-300 Amp0-400 AmpO-75, 0-150 Amp0-100, 0-2OO Amp0-150, 0--300 Amp0-200, 0-400 AmpO-250, 0-500 AmpO-375, 0-750 Amp

Voltmeter0-300 VAC0-600 VAC0-500 VAC0-750 VAC

Meter, Frequency - Reed Type115 VAC, 60 Hz230 VAC, 60 Hz115 VAC, 50 Hz230 VAC, 50 Hz

Meter, Frequency - PointerType

120 VAC208 VAC240 VAC

Meter, Time Total izing60 Hz50 Hz

Light, Indicator - 125 VACRea - Upper ScaleRed - Lower ScaleRed - Blank (No Legend)

Lock, Handle - Circuit BreakerBreaker, Circuit

Screw, Machine - Round Head(#6-32 X 3/8”)

Washer, Lock - Spring (#6)Washer, Retaining - Turnbutton

FastenerStud, Turnbutton FastenerPlug, P?astick~ob, PointerSwitch, SelectorKnobRheostatResistor, Fixed CompositionSocket, Relay - 11 Place

(W/O Terminals)Screw, Machine - Round Head

(#6-32 X 3/8”)Washer, Lock - ET (#6)Terminal

REF PARTNO. NO.

20 301-324421 870-005322 850-0030”23 332-005124

332-0607332-0795812-0066

853-0003850-0020

25332-1242332-1248

27 812-0065

28 853-000329

300-1928

300-1929300-1930

30 315-0431812-0061

853-000331 320-020232 315-0384

812-0061

853-000333 508-000134 406-0332

35 800-0045

36 850-004537 402-007838 337-004939 815-0026

40

41 301-315842 821-0010

43

QTYUSED

;11

112

22

;4

4

1

:12

2124

412

4

4413

12

PARTDESCRIPTIW

Bracket, Mounting - RelayNut, Hex (#10-32)Washer, Lock - Spring (#10)Clip - CableBlock, Terminal

12 Place16 PlaceScrew, Machine - Round Head

(#6-32 X 3/4”)Washer, Lock - ET (#6)Washer, Lock - Spring (#6)

Strip, Marker16 Place12 Place

Screw, Machine - Round Head(#6-32 X 5/8”)

Washer, Lock - Spring (#6)Regulator, Voltage - Switching

Semi-Frequency SensitiveType

Voltage Sensitive TypeFrequency Sensitive Type

Transformer, VoltageScrew, Machine - Round Head

(#6-32 X 3/8”)Washer, Lock - ET (#6)

Tie 8ar - Circuit BreakerReactor

Screw, Machine – Round Head(#6-32 X 3/8”)

Washer, Lock - ET (#6)GrommetReceptacle, Turnbutton

FastenerScrew, Cap - Hex Head

(5/16-18 X 3/8”)Washer, Lock - Spring (5/16”)Dampener, VibrationStrap, GroundScrew, Machine - Truss Head

(#10-32 X 3/8”)Panel, Control - Generator

(Selection Required, ConsultYour Onan Parts Distributor)

80X, ControlScrew, Self-locking - Hex

Washer Head (1/4-20 x 1/2”)Transformer, Current (See

Separate Page for Components)

C?nntrnl-------- - Genet-ator(Torque Hatched Regulator)

( Spec A )

II J IC91 3’-7 ii’ 1

.- d

2<

4

40

\3

,!

REFND.

123

PARTNo.

307-1157307-1061

302-0406302-0408302-0410302-0411302-0412302-0413302-0605302-0719302-0729302-0721302-0722302-0723302-0724

4

5

302-0421302-0422302-9512302-0779302-0718

302-0213302-0221302-02343~2.0256

302-0809302-0810302-0811

7302-0466302-0469

8

9

10

11

121314

322-0130322-0131322-0178320-0307815-0203

854-0010871-0010320-0431812-0061

850-0020406-0334

406-0333517-0131303-00’T6

QTYUSER

;

i11

:11Y

i111

1

:

:

1111

111

11

:

:1

1112

42

211

Spring, Holddown - RelayRe 1ayAnuneter

0-50 Amp0-75 Ampo-1oo Amp0-200 Amp0-250 Aslp0-300 Antp0-400 Ampo-75, 0-150 Amp0-100, 0-200 Amp0-150, 0-300 Amp0-200, 0-400 Amp0-250, 0-500 Ampo-375, 0-750 Amp

Voltmeter0-300 VAC0-600 VAC0-500 VW0-750 VAC0-300, 0-600 VAC

Meter, Frequency - Reed Type115 VAC. 60 Hz

230 VAC. 60 tiz

115 VAC, 50 HZ

230 VAC, 50 HzMeter, Frequency - Pointer

Type120 VAC, 60 tiz

208 VAC, 60 Hz

240 VAC, 60 HzMeter, Time Totalizing

60 HZ50 Hz

Light, Indicator - 125 VACRed - Upper ScaieRed - Lower ScaleRed - Blank (No Legend)

Lock, Handle - Circuit BreakerScrew, Machine - Round Heed

(#10-32 X 7/8”)Washer, Lock - ET (#10)Nut, Hex (S10-32)

Breaker. CircuitScrew, Machine - Round Head

(#6-32 X 3/8”)Washer, Lock - Spring (#8)

Waeher, Retaining - TurnbuttonFastener

Stud, Turnbutton FastenerPlug, PlasticKnob. Pointer

REF PARTND. ND.

15 308-0284i6 303-003217 303-026118 350-055619 323-0765

812-0061

853-0003860-0005332-1280

20 301-324421 870-005322 8S0-003023 332-005124

332-0607332-0795812-0066

850-0020853-0003

25332-124B332-1242

26 815-0544

27 300-2880

28 812-0065

29 853-000330 301-9315

33 508-000134 406-033235 800-0045

36 850-004537 402-007838 337-004939 815-0026

40

41 301-315842 821-0010

43

QTYUSED

11111

2

2

1:1

:1

:2

22

116

1

4

41

124

4413

12

PARTDESCRIPTION

Switch, SelectorKnobRheostatResistor, Fixed CompositionSocket, Relay - 11 Place

(W/O Terminals)Screw, Machine - Round Head

(#6-32 X 3/8”)Washer, Lock - ET (#6)Nut, Hex [#6-32)Terminal

Bracket, Mounting - RelayNut. Hex (#10-32)Washer, Lock - Spring (#10)Clip - CableBlock, Terminal

12 Place16 PlaceScrew, Machine - Round Head

(#6-32 X 3/4”)Washer, Lock - Spring (#6)Washer, Lock - IT (#6)

Strip, Marker12 Place16 Place

Screw, Machine - Round Headwith IT LockWasher(#6-32 X 1/2”)

Regulator. Voltage - TorqueMatched

Screw, Machine - Round Head(#6-32 X 5/8”)

Washer, Lock - ET (*6)Bracket, Mounting - Voltage

RegulatorGrommetReceptacle, Turnbutton FastenerScrew, Cap - Hex Head

(5/16-18 X 3/8”)Washer, Lock - Spring (5/16”)Dampener, VibrationStrap, Electrical - GroundScrew, Machine - Truss Head

(~~0-32 x 3/81’)

Panel, Control - Generator(Selection Required. ConsultYour Onan Parts Distributor)

8ox, ControlScrew, Self-locking - HexWasher Head [1/4-20 x 1/2”)

Transformer, Current (SeeSeparate Page for Components)

,,,Ii

,,,

55

Current Transformer

3

2I ii)--- _

/

56\

Iiil

56

REF PARTNo. ND.

1

871-0010854-0010856-0003850-0030526-0049

815-0203

2 813-0110

3 854-00104 302-02355 302-02366 302-02537

302-0117302-1365.fi. fih”a.xJ1-uuto

302-0079302-0106302-0209302-0107

8 302-0729

9

813-0100821-0005

QTY PARTUSED DESCRIPTION

Current Transformer

32112

1

6

6336

33333331

66

*#

*B*#

*

*#

*#

~~Frn~x+! Assembly, Ground(Includes Indented PartsListed 8elow)

Nut, Hex - Brass (#10-32)Washer. Lock - IT (itlO)Washer, Lock - EIT (#IO)Washer, Lock - Spring (*1O)Washer, Flat - 8rass

(13/64”10 X 7/32”00 Xl/32’’THK;

Screw, Machine - Round Head,Brass (#10-32 x 7/8”)

*Straw, Machine - Round Head(#10-32 X 2“)

Washer, Lock - IT (#10)*Clamp, Upper*Clamp, Lower*Shim*Transformer, Current

Ratio 50/5, 3 VARatio 75/5, 2 VARatio 100/5, 2 VARatio 150/5, 1 VARatio 200/5, 1 VARatio 250/5, 1 VARatio 300/5, 1 VA

*Bracket, Mounting -Transformer

Screw, Machine - Round Head(#10-32 X 1/2”)

* Spec A# Spec B

REF..-No.

10

111213

14

*-

#-

PARTw.

526-0008526-0008856-0003870-0053

302-0952302-0864302-0865302-0866302-0608302-0547302-0471

302-1868-01302-1868-02302-1868-03302-1868-04302-1868-05302-1868-06302-1868-07302-1868-08302-1868-09302-1868-10302-1868-11302-1B68-12302-0764

(JTYD PARTDESCRIPT1ffl

1;66

3333333

3333333333331

Washer, Flat (13/64”10 x7/16”00 X l/32”THK)

* Spec A# Spec B

*#Washer, Lock - EIT (#10)*#Nut, Hex (#10-32)

Transformer, CurrentSpec A

* Ratio 75/5, 2 VA* Ratio 150/5, 2 VA* F?atio 200/5, 2 VA* Ratio 250/5, 2 VA* Ratio 400/5, 2 VA* Ratio 500/5, 2 VA* Ratio 750/5, 2 VA

Spec B# Ratio 50/5# Ratio 100/5# Ratio 150/5, 1.5 VA# Ratio 200/5, 2.0 VA# Ratio 300/5, 2.5 VA# Ratio 400/5, 4.0 VA# Ratio 500/5, 6.0 VA# Ratio 750/5, 7.5 VA# Ratio 800/5. 8.0 VA# Ratio 1000/5,# Ratio 1200/5,# Ratio 1500/5,

*#Bracket, Mounting

Parts Used During Spec AParts Used During Spec B

10.0 VA12.0 VA15.0 VA- Transform(

,,f

57

REF PARTNo. No.

1 870”0183

2 301-18863 860-00064 854-00065 812-0070

6 309-01287 800-0034

Heater-Control(Spec A)

8

6

QTY PART REF PARTUSED DESCRIPTION NO. NO.

2 Nut, Self-locking - Hex W/ET 8 526-0113Washer (#6-32) 9 333-0151

1 Cover, ThermostatNut, Hex (#6-32) 10 130-1107

: Washer, Lock - IT (#6) 11 870-02572 Screw, Machine - Round Head

(#6-32 X 1-1/4”) 12 335-01611 Thermostat - Adjustable2 Screw, Cap - Hex Head

(5/16-18 X 2-1/4”)

QTY PARTUSED DESCRIPTION

2 Washer, Flat (5/16”)1 Heater, Electrical - 75 Watt,

120 VAC; 300 Watt, 240 VACSpacer, Sleeve

; Nut, Self-locking - Hex(5/16-18)

1 Cable, Electrical

58

Heater - Control{s@ec 6)

,‘

‘,/ L5 I

I

/.>-K ?

\

0

/’/REF PART j::. PARTMO. No. DESUtIPTI~

/f

“ ;“J’”y; J“/ “--------------.- ../.... ---~

1 333-0151 1 Heater (HR1)2 335-0161 1 Cable3 %00-0034 ? Screw, Cap - Hex Head

,,,! (5/16-18 x 2-1/4”)4 526-0113 2 Washer, F?at (11/32”ID x

1“00 X 3/32’’THK)5 870-0257 2 Nut, Self-Locking - Hex He~d

(5/16-18)

REF PARTNo. m.

6 130-11077 812-0070

8 854-00069 860-0006

10 870-018311 301-188612 309-0128

TY&xD22

42211

PARTOESCRIPTI~

SpacerScrew, Machine - Round Head

(*6-32 X 1-1/4”)Washer, Lock - IT (#6)Nut, Hex (#6-32)Nut, Hex - With ET (#632)CoverThermostat

59

Control Housing

REF PARTm. No.

1 821-0010

2 234-03703 815-0350

4 301-31565 821-0010

6 234-03617 821-0018

$ 856-0006

I...

●

( ●

QTYUSED

8

118

34

16

1

..-”

PARTDESCRIPTION

Screw, Self-locking - HexWasher Head (1/4-20 x 1/2”)

Grill, Air - Generator InletScrew, Tapping - Hex Washer

Head (u1O-32 x 3/8”,’Panel AccessScrsw, Self-locking - Hex

Washer Head (1/4-20 x 1/2”)Wrapper, End BellScrew, Self-locking - Hex

Washer Head (1/4-20 x 5/8”)Washer, Lock - EIT (1/4”)

REF PARTND. ND.

9 526-0018

10 870-021211 301-315512

508-0203508-0051

13 821-0010

14 821-0014

15 301-3154

QTYUSED

5

61

111

8

1

PARTDESCRIPTION

Washer, Flat (17/64”10 x5/8’’Ol) X 1/16’’THK)

Nut, Hex (114-20)Housing, Control BoxGrommet

Thru October 1984Begin November 1984

Screw, Self-locking - HexWasher Head (1/4-20 x 1/2”)

Screw, Self-locking - HexWasher Head (5/16-18 x 1/2”)

Saddle, Control Box Mouoting

60

Capacitor Assembly

ggf$’

L<

II

,

II

*

L..\-)\ ..

REF PART QTY PART REF PARTNO. NO. USED DESCRIPTION No. No.

1 812-0078 2 Screw, Machine - Round Head 6 356-0102(#8-32 X 7/16”) 7 821-0009

2 850-0025 2 Washer , Lock - Spring (#8)3 861-0007 2 Nut, Square (#8-32) 8 356-01044 356-0090 2 Capacitor, Fixed - Electroylic

(1300 MFD)5 812-0078 6 Screw, Machine - Round Head

(#8-32 X 7/16”)

‘3

QTY PARTUSED DESCRIPTION

2 Clamp, Mounting - Capacitor4 Screw, Self--locking - Hex

Washer Head (1/4-20 x 3/8”]1 Bracket, Mounting - Capacitor

Assembly (Bracket NotRequired for Square Output8oxes)

,’

Filter - Voltage Regulator

REF PARTNo. No.

1 332-09412 800-0003

3 850-00405 812-0165

6 862-00017 850-00408 304-04279 304-0292

10 354-0025

--+!2 1

J- *’ J. I--a& -

//76

Y ‘“i8

QTY PARTUSED DESCRIPTION

22

22422

Tie, CableScrew, Cap - Hex Head

(1/4-20 X 1/2”)Washer, Lock -- Spring (1/4”)Screw, Machine - Round Head

(1/4-20 X 4-1/2”)Nut, Hex (1/4-20)Washer, Lock - Spring (1/4”)Washer, CenteringInsulatorResistor, Fixed - Wirewound

(100hm. 100 Watt)

REF PARTNO. NO.

11 813-0098

12 870-005313 850-003014 312-018915 31.-0188

16 232-221817 526-001818

332-0529332-1279

QTY PARTUSED DESCRIPTION

2 Screw, Machine - Round Head(#10-32 X 3/8”)

2 Nut, Hex (#10-32)2 Washer, Lock - Spring (#10)1 Bracket, Mounting - caPi3CitOr

1 Capacitor, Fixed (15 MFC),400 VAC)

1 Bracket, Mounting ~~Filter15 Washer, Flat (1/4”)

Terminal Lug4 flare (14-18 AW3)8 Insulated (14-18 AWG)

‘,

,’

62

Circuit Breaker

‘5

REF PARTNO. NO.

1 815-”0350

2 301-”75403 821-0010

4 301-7541

5 812-0156

6 850-0040

QWUSED

6

1A

1

4

4

PARTDESCRIPTI(M

Screw, Tapping - Hex WasherHead (#10-32 x 3/8”)

Panel, Cover - Circuit 8reakerScrew, Self-locking - Hex

Washer Head (1/4-20 x 1/2”)Bracket, Mounting - Circuit

BreakerScrew, Machine - Round Head

(1/4-20 X 1-1/2”)Washer, Lock - Spring (1/4”)

REF PARTNO. NO.

7320-0380320-0424320-9425320-9653

320-0426.~20-0348320-0422320-1639

320-0423320-1581

320-0620

320-044Y320-0705

7

/1 ●

A/

‘/’,/●

,..”,..

.-— *

-’—

/-

/

QTYUSED

1

:1

1111

11

1

11

PARTDESCRIPTION

Breaker, Circuit100 Amp, 277/480100 Amp, 347/600150 Amp, 277’/480150 Amp, 277/480With Shunt Trip

175 Amp, 220/380200 Amp, 120/208250 Amp, 120/240250 Amp, 120/240

With Shunt Trip300 Amp, 120/208300 tip, 120/208

With Shunt Trip300 Amo, 120/208

/

voltvoltvoltvolt -

voltvoltvoltvolt -

voltvolt -

volt -With Auxiliary Contacts

400 Amp, 120/208 Volt400 Amp, 120/240 Volt

‘,

64

1

23

161718

19202122

23

PARTNo.

800-0003

850-0040150-1456

862-0001853-0013150-0723870-02501s0-1356862-0011!350-005!2

520-0724520-0728503-0611

800-0009

220-2353220-1774509-0125211-0185800-0008

8S0-0040862-0001234-0368

220-2627220-1605220-1457220-1789

220-1460220-1792

800-0048

QTY PARTUSED 0E8CRIPTI(M

2

21

211114A

444

4

~

11112

221

;

:

11

1

Screw, Cap - Hex Head(1/4-20x 1/2”)

Washer, Lock - Spring (1/4”)Bracket Asaaab~y - Overspaad

Switch (Includes Partsi$tsrked ‘)

‘Nut, Hex (1/4-20)Washer, Lock - ET (1/4”)*contact, ------ ----Flaetrieml

*Nut, Insulator*Bracket, Mounting - Contact

Nut, tiex - Grade 8 (3/8-16)K!esher, Lock - Spring (3/8”)Stud [3/8-16 UNC)

18-29/32”LG22-15/16”LG

Hose. Rubber (7/16”10 x5/8”00 X 3“LG)

Screw. Cap - Hex Head(1/4-20x 1-1/2”)

Washer, Lock - Spring (1/4”)Stator, Exciter

StandardEnvironmental Protected

Seal, Oil - “O” RingEnd 8s11, GeneratorScrew. Cap - Hex Head

{1/4-20x 1-1/4”]Washer, Lock - Spring (1/4”)Nut, Hex (1/4-20)Screen, Air - GeneratorStator, Generator

Code 6DCode 9XCode 15Code 15 (Environmental

Protected)Code 15 (Extended Stack)Code 15 (Environmental

Protected & Extended Stack)Screw, Cap - Hex Head

(3/8-16 X 3/4”)

RW PARTNo. No.

24 856-001025 KO-071726

80$-0018805-0019

27

201-2672201-2690

201-2675

201-2693

2% 800-0513

29 850-007930 526-0238

31 510-010132 232-210233

201-1739201-1845

34 515-0145

35

805-0033805-0035

36 S26-0259

37 205-008938 232-2078

QTYUSEO

:

88

11

i

1

1

11

7.~

111

888

11

* - Parts Included in#- Parts Included in

PARTWSCRIPTMN

Washer, Lock - EIT (3/8”)Switch, Overspead8olt - Hex Head (3/8-16 UNC)

1 “LGl-1/4”LG

Rotor Assembly, Oenerator(includes Parts Marked #)Codes 60. 9X, 15, 515Codes 15, 515 (Environmental

Protected)Codes 15, 515 (Extended

stack)Codes 15, 515 (Environmental

Protected & Extended Stack)#Screw, Cap - Hex Head with

3/8-16 Tapped Center Hole#Washer, Lock - Spring (3/4”)#Washer, Flat - Steel Alloy

(13/16” ID X 2“00 X 3/16’’THK)#8earing, Ball#Spacer, Sleeve#Rotor, Assembly - Exciter

(See Separate Page forComponents)

StandardEnvironmental Protected

#Key, Machine (1/4” x 1/4” x7/8” )

#Bolt, Hex Head - Grade 8(;/:;:: U&)

1-1/2” LG#Washer, Flat - Hardened Steel

(11/16”1D X 1-3/8”00 X7/64’’THK)

#Fan, Generator#Disk, Drive - Generator

Dverspeed Bracket Assembly.Generator Rotor Assembly.

65

Exciter Rotor

REF PARTNo. No.

1 813”0100

2 870-00533 850-00304 526-0008

5 813-0110

6 87C-00537 850-00308 526-0009

9 508-018710 332-0050

L

QTY PARTUSED DESCRIPTION

REF PARTNo. NO.

2 Screw, Machine - Round Head 11 508-0093(#10-32 X 1/2”) 12 870-0053

2 Nut, Hex (#10-32) 13 850-00302 Washer, Lock - Spring (#IO) 142 Washer, Flat (13/64”ID x

7/16”OD X l/32’’THK)4

358-0097Screw, Machine - Round Head 358-0044

(#10-32 X 2“)4 Nut, Hex (U1O-32)4 Washer, Lock - Spring4 Washer, Flat (7/32”10

l/2”OD X l/16’’THK)4 8ushing - Insulating2 Clip - Cable

15

(#lo) 358-0096x 358-0043

16 363-005417 363-0055

1/

QTYUSED

33

3311

PARTDESCRIPTION

Grommet, RubberNut, Hex (#10-32)Washer, Lock - Spring (#10)Diode, Rectifier - Positive

(CR1, CR2, CR3)StandardEnvironmental Protected

Diode, Rectifier - Negative(CR4, CR5, CR6)StandardEnvironmental Protected

Heatsink - Positive DiodesHeatsink - Negative Oiodes

66

Voltage Suppressor

REFNo.

1

2

3456

PARTNo.

813-0112

526-0140

850-0030870-0053508-0093305-0526

QWUSED

4

4

4421

PARTOESCRIP11CP4

Screw, Machine - Round Head(#10-32 X 2-1/2”)

Washer, Flat (7/32”10 x3/8”00 X 3/64’’THK)

Washer, Lock - Spring (U1O)Nut, Hex (#10-32)Grommet, RubberSet, Voltage Suppressor

(A Matched Pair)

REF PART QTY PARTND. No. USED OEWRIPTMM

7 526-0140 4 Washer, Flat (7/32”10 x3/8”OD X 3/64’’THK)

8 850-0030 4 Washer, Lock - Spring (#10)9 870-0053 4 Nut, Hex (#10-32)

10 363-0054 Heatsink - Positive Oiodes11 363-0055 : Heatsink - Negative Diodes

67

Heater-6enerator

,’

,,

IIEF PART QTY PART REF PART QTY PART

W. No. USED DESCRIPTION NO. No. USED DESCRIPTIUII

1

335-0146335-0147

2 800-0004

Cable, Electrical (IncludesThermostat)

120 VAC240 VAC

Screw, Cap - Hex Head(1/4-20 X 5/8”)

3 850-00384 526-0158

5333-0059333-0192

Washer, Lock - Spring (1/4”)Washer t Flat (17/64”10 x 1“011

x l/8’’THK)Heater, Electrical

120 VAC, 125 Watt240 VAC, 200 Watt

68

Run Relay(Spec 6)

REF PART QTY PARTNO. NO. USED DESCRIPTICRd

1 307-1058 1 Relay. Run (K1lJ(Quantity as Requirt!d)

2 815-0388 2 *Screw, Pan Head - CrossRecessed Thread(#6-32 X 1/2”)

REF PART Q~O PARTNO. No. DFSCRIPTItM

3 319-0447 1 Bracket, Relay Mounting4 323-0804 1 ‘Socket, Relay5 307-1987 2 *Holddown, Relay

* - Quantities listed are for one mounted relay

I

U*ttmeter(Spec A)

1 2

5II

6.7

,/\

i !’4 n-w

\

@

—19y 2fl

Mattneter(Spec A)

1 615-0026

2 853-00083 301-3476

4 508-00015 860-00086 853-00057 526-0003

8 402-03549

302-1082302-1083302-1113

10 821-0014

11 402-007812 301-3477

13 815-0350

14 812-0063

15 853-000316 860-000617 332-0609

F

“~,

,,,

~,

QTVUSED

2

21

2

:8

4

~

:

8

41

6

4

441

PARTOESCRIPTIUd

Screu, Machine - Truss Head(#10-32 X 3/8”)

Washer, Lock - ET (#IO)Cover - Transducer 80X

(External Installation)Gromet, RubberNut, Hex (#8-32)Washer, Lock - ET (#S)washer, ~~=t (~~/64n1D x

3/8”00 x l/32’’THK)Mount, VibrationTransducer, Watt

3 ?haee. 60 Hertz3 Phase, 50 Hertz1 Phase, 60 Hertz

Screw, Self-locking - HexWasher Head (5/16-18 x 1/2”)

Mount. Vibration80X, Transducer (External

Installation)Screw, Tapping - Hex Washer

Head (#10-32 x 3/8=)Screw. Machine - Round Head

(#6-j2 X 1/2”)Washer, Lock - ETNut, Hex (#10-32)Block. Terminal

(S6)

REF PARTNo. No.

18 332-061019 302-1722

20302-1721-01302-1721-02302-1721-03302-1721-04302-1721-05302-1721-06302-1721-07302-1721-08302-1721-09302-1721-10302-1721-11302-1721-12302-1721-13302-1721-14302-1721-15302-1721-16302-1721-17

21 821-0017

22 862-001423 850-004524 301-6987

PARTOESCRIPTI~

Strip, MarkerWattmeter (Less Replaceable

Dial)Dial. Wattmeter

Scale O-35 KWScale 0-50 KWScale 0-70 KWScale 0-90 KWScale 0-115 KWScale 0-160 KWScale 0-180 KWScaie 0-200 KUScale 0-250 KWScale 0-300 KWScale 0-350 KWScale 0-400 KWScale 0-500 KWScale 0-600 KWScale 0-700 KUScale 0-800 KWScale 0-1200 KW

Screw, Self-locking - HexWasher Head (5/16-18 x 1/2”)

Nut, Hex (5/16-18]Washer, Lock - Spring (5/16”)8racket, Wounting (Internal

Installation)

Uattmeter(SPec B)

4

12

11

9

REF PART QTY PART REF PART (& PARTIUO. ND. USED DESCRIPTION ND. ND. DESCRIPTION

1 821-0017 2 Screw, Self-locking - HWH 8(5/16-18 X 1/2”) 9

2 850-0045 2 Washer, Lock - Spring (5/16”) io3 862-0014 2 Nut, Hex (5/16-18) 114 860-0008 Nut, Hex (#8-32) 125 856-0002 1: Washer, Lock - EIT (*8)6 302-1833-01 1 Transducer, Watt 137 402-0354 4 I%Oiifit, Shock

301-6987 1 Bracket, Mounting338-1936 Harness Wiring302-1722 : Meter, Watt (Less f)ial)30~-1721-04° 1 Dial, Wattmeter813-0102 2 Screw, Machine - Round Head

(#10-32 X 5/8”)319-0030 1 Plate. Support - Transducer

Nagnetic Pickup(Spec B)

Ii

!F‘“1!,

REFNo.

1

23.45

678

1:11

PARTNO.

800-0003

850-0040150-1410150-1406150-2117

862-0001853-0013150-0723870-0250301-9402800-0053

-. -%..--..--%.=

..”-.“ :\.

,’ . . -.

QTY PART REF PART QTY PARTUSED DESCRIPTI~ No. No. USED DESCflIPTIm

Screw, Cap - Hex Head 12(1/4-20 X 1/2”) 13

Washer, l.cjck - Spring (1/4”) 14Cap, Insulator 15Sensor, Speed - Magnetic 16Bracket ad Point Assembly

(Includes Parts Marked *) ;:*Nut. Hex (1/4-20) 19

‘Washer, Lock - ET (1/4”)*Point, Coltact*Nut, Insulator‘Bracket, Mounting *.

S~re~, &D - Hex Head

(3/8-16 x 1-3/4”)

856-0010150-0717526-0077150-1557370-4011854-0031868-0011338-1930

1 Washer, Lock - FIT (3/8”)1 Switch, Overspeed (S3)1 Washer, Flat (3/8”)1 Wheel, Sensoe1 Spacer1 Washer, Lock - IT (3/4”)2 Nut, tie% - Jam (3/4-16)

1 Harness, Wiring - MagneticPickup (A16 tc~ All)

Parts Included in 150-211.7 Bracket and PointAssembly

73

Numertcal Index

Part No.

102-0652102-0664102-1097102-1097102-1113102-!114102-1159102-1238102-1244102-1320104-0723104-1097110-0445110-0445110-0445115-0025121-0036121-0037122-0193123-1322130-0497~~~_~~~;

?30-0771130-0772730-0775130-0776130-0778130-0780130-0797130-0797130-0802130-0805130-0968130-0969130-0970130-0971130-0972130-0973130-0981130-0986130-0988130-0989130-0991130-1024130-1024130-1024130”1050130-1050130-1107130-1107

Page

1313132?31327272929131111151921

71313131338~y

383838383838192127272525252525252525

725

725272927295859

Part No.

130-1110130-1112130-1192130-1192130-1340130-1985130-1996130-1997130-1998130-1999130-2000130-2000130-2000130-2053130-2128130-2162130-2243130-2243130-2244130-2244130-2245130-2245131-0353132-0261140-0752140-0961140-0961140-0961140-1260140-1260140-1260140-1724140-1837145-0482145-0482145-0482145-0528145-0528145-0528145-0532145-0532145-0532145-0533145-0534145-0535145-0538145-0538145-0538145-0539145-0539

Page

27274143272525252525252729392527272927292729

77

35151921151921

44

1519211519211519213113131519211519

Part No.

145-0539145-0539145-0540145-0540145-0540145-0541145-0541145-0541145-0541145-0590145-0590145-0590148-0274148-0274148-0274148-0367148-0601148-0601148-0601148-0625148-0626148-0626148-0627148-0627148-0637148-0637148-0773148-0775148-0775148-0775148-0776?48-0869148-0869150-0638150-0717150-0717150-0723150-0723150-1356150-1406150-1410150-1456150-1521150-1557150-2117151-0411151-0566151-0584151-0594151-0605

Page

213115192115192131151921252729

91519211719211921151917151921171921

‘?5573657365737365

773733737

77

37

Part No.

152-0243154-1739154-1739154-1766154-2336155-0789155-1021155-1422lCCI aa- 1430155-1463155-1489155-1592155-1886155-1886155-1891155-1923155-1947155-1948166-0278191-0773191-0864191-0864lg~-,”==Inan

191-1203191-1388191-1390

191-1564191-1981191-1982

Page

73135313135353535353535313531313535

119

232523

232323

232323

191-1983-01 23191-2025 7191-2(]25 23191-2026 23193-0243 45193-0244 9193-0245 45193-0247 9193-0248 45193-0249 11193-0329 39193-0330 47193-0351 47193-0352 47

201-1739 65201-1845 65201-2672 65201-2675 65201-2690 65201-2693 65

74

w~r

k Part No.

205-0089211-0185220-1457220-1460220-1605220-1774220-1789220-1792220-2353220-2627231-0260232-2078232-2102232-2218234-0361234-6368234-0370300-0679300-0681300-0714300-07303~4)-n7aAv---

300-1928

300-1929

300-1930300-2809300-2811300-2855300-2862300-2880300-2880300-2897300-2901300-2902300-2905301-1886301-1886301-3154301-3155301-3156301-3158301-3158301-3158301-3244301-3244301-3244301-3253301-3476301-3477301-6053

Paga

6565656565656565656511656562606560454545454553535347

7474751554747474758596060604953554953554571‘7145

Numerical Index

Part No. Pa@ Part No.

301-6257301-6987301-6987301-7540301-7541301-8065301-8851301-9054-02301-9054-03301-9055-01301-9055-02301-9315301-9402302-0078302-0079302-0106302-0107302-0117302-0209302-0213302-0213302-0213302-0221302-0221302-0221302-0234302-0234302-0234302-0235302-0236302-0253302-0256302-0256302-0256302-0406302-0406302-0406302-0408302-0408302-0408302-0410302-0410302-0410302-0411302-0411302-0411302-0412302-0412302-0412302-0413

4771726363514751514747557357575757575749535549535549535557575749535549535549535549535549535549535549

302-0413302-0413302-0421302-0421302-0421302-0422302-0422302-0422302-0466302-0466302-0466302-0469302-0469302-0469302-0471302-0547302-0605302-0605302-0605302-0608302-0612302-0612302-0612302-0718302-0718302-0719302-0719302-0719302-0720302-0720302-0720302-0721302-0721302-0721302-0722302-0722302-0722302-0723302-0723302-0723302-0724302-0724302-0724302-0729302-0749302-0764302-0779302-0779302-0779302-0809

Page

5355495355495355

495355495355575749535557495355495549535549535549535549535549535549535557455749535549

Part No.

302-0809302-0809302-0810302-0810302-0810302-0811302-0811~02-0811

302-0864302-0865302-0866302-0885302-0952302-1082302-1083302-1113

302-1147302-1148302-1362302-1365302-14739fi9-*CA**WC— Iuv 1

302-1683302-1684302-1685302-1720

Page

53554953554953555757574757717171

~~

51455751A7-r

51515151

302-1721-01 71302-1721-02 71302-1721-03 71302-1721-04 71302-1721-04 72302-1721-05 71302-1721-06 71302-1721-07 71302-1721-08 71302-1721-09 71302-1721-10 71302-1721-11 71302-1721-12 71302-1721-13 71302-1721-14 71302-1721-15 71302-1721-16 71302-1721-17 71302-1722 71302-1722 72302-1724 51302-1725 51302-1726 51

75

Wumerical Index

Part No. Pa@

302-1?27302-1728302-1?29302-1753302-1798302-1799302-1800302-1833-01302-1868-01302-1868-02302-1868-03302-1868-04302-1868-05302-1868-06302-1868-07302-1863-?2$302-1868-09302-1868-10302-1868-11302-1868-12302-1873-01

303-0032303-0032303-0032303-0032303-0076303-0076303-00763(?3-0170303-0170303-0261303-0261304-0292304-0427305-0526305-0675306-0155306-0155307-0268307-0834307-0835307-0836307-0836307-1031307-1058307-105830’7-1061307-1061307-1061

515151515151517257~~

5757575757~?

5757575747

49515355495355495351556262674919211719271921

94569454953

Part No.

307-1061307-1157307-1157307-1157307-1157307-1164307-1164307-1460307-14603Q7-~987

308-0002308-0005308-0005308-0138308-0150308-6150308-0284308-0284308-0284308-0327308-0784308-0853308-0882308-0892309-0128309-0128309-0178309-0179309-0269309-0304309-0304309-0307309-0307309-0476309-0476309-0476309-0477309-0477309-0477309-0479309-0479309-0479309-0480309-0480309-0480309-0544309”0545312-0188312-0189312-0201

Page

554549535541&~

4143694519214519214953554547475147585911111141434143252729252729252729252729

99

626223

m-t No.

315-0342315-0384315-0384315-0431315-0431319-0030319-0447320-0202320-0307320-0307320-0307320-0348320-0380320-0422320-0423320-0424320-0425320-0426320-0431320-0431320-0449320-0455320-0620320-0653320-0705320-1121320-1581320-1639321-0094321-0204321-0231321-0270322-0004322-0004322-0107322-0108322-0109322-0110322-0111322-0128322-0130322-0130322-013032?-0131322-0131322-0131322-0136322-0149322-0178322-0178

Page

4949534953726953495355636363636363634955635363636351636347494747454745454545454549535549535545454953

Part No. Page

322-0178322-0283322-0359-01322-0360-01322-0361322-0363322-0369-01323-0764~23-Q765

323-0765323-0765323-0765323-0804323-0957323-0957323-1302323-1308323-1310331-0027331-0027332-0014332-0014332-0050332-0051332-0051332-0051332-0051332-0052332-0052332-0149332-0149332-0529332-0537332-0607332-0607332-0607332-0607332-0609332-0610332-0699332-0795332-0795332-0795332-0795332-0941332-1005332-1043332-1239332-1240332-1242

55454747475147454549535569414347474741434143664549‘T.

554751414362454951535571714545495355624545454549 “

76

Numerical Index

*

E Part No.%!,>

332-1242332-1242332-1248332-1248332-124833:!-!268332-1269332-1271332-1271332-1276332-12?!2332-1280332-1280332-1280332-1280332-128122!3-19Q9““- ,--A

332-1473332-1559332-1956332-2723333-0059333-0141333-0141333-0142333-0146333-0146333-0147333-0147333-0148333-0148333-0151333-0151333-0158333-0158333-016733:3-0167333-0170333-0170333-0172333-0172333-0176333-0176333-0192

Page

53554953554945454545~~

454953551111364549516841434141434143414358594143414341434143414368

333-0194-01 45333-0224 43335-0146 68335-0147 68335-0161 58335-0161 59

Part No.

336-3124337-0049337-0049337-0049337-0049337-0090338-094233~-~~35

338-1836338-1904~38-~930

338-1936338-1940338-2277338-2278338-2460350-0556350-0556350-0556354-0025356-0070356-0072356-0090356-0102356-0104357-0030358-0043358-0044358-0096358-0097363-0054363-0054363-0055363-0055370-4011402-0078402-0078402-0078402-0078402-0354402-0354402-0371402-0527403-0894403-0895403-1193403-1194403-1942405-1774405-1775

Page

94951535536

94747477372474751

949535562454561616139666666666667666?73495355717172365133333636363333

77

Part N9.

405-1776405-1777405-1780405-2869405-2870405-3012405-3027406-0089406-0105406-0157406-0249406-0332406-0332406-0332406-0332406-0333406-0333406-0333406-0333406-0334406-0334406-0334,406-0334406-~565416-0021416-0338416-0672501-0010501-0011501-0225501-0225502-0002502-0003502-0033502-0041502-0054502-0058502-0155502-0237502-0302502-0313502-0613502-0613502-0809502-0942502-0942502-1013503-0131503-0183503-0183

Page

33333325253333333332““3349515355495153554951535533

936

9192141431313211943

938

41339414339414313131725

Part N9.

503-o183

503-0183503-0183503-0183503-0261503-0274503-0274503-0324503-036559~-9395

503-0398503-03$?8503-0398503-0429503-0446503-0446503-0446503-0446503-0465503-0465503-0465503-0547503-0547503-05?1

503-0611503-0743503-0753503-0753503-0792503-0796503-0799503-0799503-0832503-0832503-0833503-0833503-0833503-0833503-0843503-0843503-0846503-0965503-0966503-0998503-0998503-0998503-1093503-1097503-IOQ9503-1099

Page

272941431727291525391517

21

19

13

27

29

39

15

19

21,

4

13

25

65

39

27

29

21

15

17

21

41

43

17

25

27

29

41

43

27

35

13

15

19

21

4

13

13’

27

Numerical Index

Pert No.

503-1099503-1100503-1118503-1168503-1168503-1168503-1172503-1172503-?172503-1201504-0003504-0003504-0003504-0005504-0005504-0005504-0005504-0005504-0030504-0046505-0004~~~.~~~~

505-0004505-0004505-0004505-0004505-0007505-0007505-000?505-0007505-0007505-0007505-0007505-0007505-0007505-0013505-0018505-0018505-0018505-0019505-0019505-0019505-0019505-0020505-0020505-0038505-0039505-0039505-0039505-0039

Paga

294

392527291519211!32541431725272931132717IQ

21214143

911131519213941432913272917252729192127

9172527

Part No.

505-0039505-0041505-0043505-0051505-0051505-0057505-0059505-0060505-0060505-0050505-0061505-0075505-0075505-0075505-0084505-0084505-0098505-0098505-0099505-0099505-0099505-0101505-0101505-0101505-0101505-0101505-0102505-0102505-0102505-0102505-0102505-0103505-0104505-0109505-0110505-0119505-0119505-0?19505-0120505-0120505-012050~-o129

505-0129505-0129505-0129505-0130505-0130505-0132505-0132505-0132

Page

292127192731

9252729

925272917194143172741

917252729151719212735

92729252729252729151921271127171921

Part No.

505-0132505-0135505-0135505-0135505-0135505-0135505-0151505-0166505-0166505-0216505-0216505-0302505-0302505-0302505-0324505-0324505-0324505-0331505-0382505-0385505-0455505-0455505-0479505-0499505-0661505-0668505-0702505-0759505-0763505-0763505-0763505-1168505-1301505-1345505-1345508-0001508-0001508-000?508-0001508-0001508-0015508-0051508-0051508-0093508-0093508-0187508-0203509-0125509-0165509-0165

Page

27131725272939192131351327291719211735274143

171117353521

9414335271921495153557?11516066676660651519

Part No.

509-0165510-0101511-0084511-0084511-0131512-0059512-0136515-0093$j:~-n?AG“,-r”517-0131517-0131517-0131517-0131517-0221518-0342518-0374520-0011520-0011520-0011520-0165520-0231520-0724520-0728

520-0819520-0925526-0003526-0008526-0008526-0008526-0008526-0008526-0009526-0018526-0018526-0018526-0022526-0022526-0026526-0035526-0049526-0049526-0065526-0065526-0065526-0077526-0113526-0113526-0113526-0115526-0115

Page

2165

7252325252355

4749535547254515192131366565313171151921576666

760623135

7254557151921733558592336

18

Numerical Indexp,,

L Part No.

526-0122526-0140526-0158526-0174526-0174526-0174526-0174526-0188526-0238526-0259526-2106800-0003800-0003800-0003800-0004800-0005800-0007800-0007800-0008800-0009800-0009800-0024Wo-ofm$800-0026800-0027800-0029800-0029800-0029800-0029800-0029800-0031800-0034800-0034800-0037800-0040800-0040800-0040800-0045800-0045800-0045800-0045800-0048800-0048800-0048800-0050800-0050800-0050800-0050800-0051800-0051

Page

256768192127293165652362657368

941436517655111132323252527293558593525272949515355

72565131519211719

Part No.

800-005180G-G051800-0051800-0051800-0051800-0052800-0052800-0053800-0055800-0056800-0056800-0069800-0069800-0069800-0069800-0069800-0071800-0072800-0095800-0152800-0513800-2058800-2097801-0027805-0018805-00198G5-0033805-0035809-0035809-0059812-0061812-0061812-0061812-0061812-0063812-0063812-0065812-0065812-0065812-0065812-0066812-0066812-0066812-0070812-0070812-0070812-0075812-0078812”’0079812-0149

Pm

2125252729

73173252729

71117272936112336652323

765656565Ii

3345495355457149515355495355495859

9614333

Part %0.

812-0156812-0165613-0098813-0098813-0100813-0100813-0102813-0103813-0103813-0103813-0105813-0105813-0110813-0110813-0112814-0079815-0026815-0026815-0026815-0026815-0026815-0181815-0203815-0203815-0203815-0203815-0350815-0350815-0350815-0385815-0388815-0544815-0544815-0544821-0004$21-0004821-0005821-0009821-0010821-0010821-0010821-0010821-0010821-0010821-0010821-0010821-0010821-0010821-0011821-0011

Page

6362336257667215192135455766673345495355712545495557606371476947515547515761

79

25334951535560632729

Part No.

821-0011821-0013821-0013821-0014821-0014821-0014821-0014821-0016821-0016821-0016821-0016821-0016821-0016821-0016821-0017821-0017821-0018821-0029821-0029821-0030850-0020850-0020850-0020850-0025850-0025850-0025850-0030850-0030850-0030850-0030850-0030850-0030850-0030850-0030850-0030850-0030850-0030850-0030850-0038850-0040850-0040850-0040850-0040850-0040850-0040850-0040850-0040850-0040850-0040850-0045

Page

39192125336071132527353641437172602933

749535533436115192133454953555762666768

479

17414362636573

7

Nuserical Index

Part No.

850-0045850-0045850-0045850-0045850-0045850-0045850-0045850-0045a50-oo45850-0045850-0045850-0045850-0045850-0045850-0050850-0050850-0050850-0050850-0050850-0050850-0050~w-oofio850-0050850-0050850-0050850-0055850-0055850-0055850-0055850-0055850-0055850-0060850-0065850-0070850-0079850-0079850-0165850-2008853-0003853-0003853-0003853-0003853-0003853-0005853-0008853-0013853-0013853-0013853-0016854-0006

Pa$p

1323252729313536495153557172

713151719212527293165

7111727293625232336653123454953557171715165

731158

Part Mo.

854-0006854-0010854-0010854-0010854-0010854-0031856-0002856-0003856-0003856-0006856-0008856-0008856-0010856-0010856-0013860-0005860-0005860-0006860-0006860-0006860-0006860-0008860-0008860-0008861-0007862-0001862-0001862-0001862-0001862-0001862-0001862-0001862-0003862-0004862-0005862-0011862-0014862-0014862-0014862-0015862-0015862-0016865-0006865-0007868-0007868-0011870-0048870-0048870-0048870-0048

Page

59454955577372455760365165733649554558597133717261

49

414362657331362365357172235125

436237325252735

Part NO.

870-0053870-oo53

870-0053870-0053870-0053870-0053870-0053870-0053870-0053870-0053870-0053870-0053870-0106870-0113870-0113870-0130870-0131870-0131870-0133870-0183870-0183870-0183870-0188870-0195870-0196870-0212870-0212870-0212870-0212870-0212870-02128’?0-0232870-0250870-0250870-0257870-0257870-0257870-0257870-0257870-0257870-0257870-0281870-0281870-0281870-2056871-0010871-0010871-0010871-0010871-0015895-0160

Page Part No. Page

1519213345495355576266673325333147512547585935311119212729396033657313353641435859

7293123454955575135

‘,