briggs & stratton quantum 35 engine - owner's manual
TRANSCRIPT
-
8/7/2019 Briggs & Stratton Quantum 35 Engine - Owner's Manual
1/12
-
8/7/2019 Briggs & Stratton Quantum 35 Engine - Owner's Manual
2/12
IMPORTANT SAFETY INFORMATION AND
INSTRUCTIONS FORENGINE SELECTION
ENGINE INSTALLATION
ENGINE OPERATION
Keep these instructions for future reference.
In the USA and Canada,our 24 hour hotline is:
18002333723
Briggs & Stratton CorporationMilwaukee, Wisconsin 53201
www.briggsandstratton.com
Before installing and operating this engineread and observe all warnings, cautions and
instructions on both sides of this sheet, on the engine,and in the operating & maintenance instructions.
NOTE: This sheet of instructions and safety information is not meant to cover allpossible conditions and situations that may occur. Read entire Operating &Maintenance Instructions for this engine AND the instructions for the equipmentthis engine powers. Failure to follow instructions and safety information couldresult in serious injury or death.
The safety alert symbol ( ) is used to identify safety HAZARD SYMBOLS AND MEANINGS
-
8/7/2019 Briggs & Stratton Quantum 35 Engine - Owner's Manual
3/12
ENGINE SELECTION
WARNING
Failure to select the correct engine couldresult in fire or explosion.
Some engines are unique and designed for specific applicationsor types of equipment. If this engine will be used to build newequipment, contact Briggs & Stratton to ensure that the engine isappropriate for the intended use.
Note:For all Go-karts use only a model 136200 series en-gine, which offers improved safety and performance.
Replacement engines should be the same model as the originalengine, or be the Briggs & Stratton designated replacementengine. Refer to the Operation & Maintenance Instructions forengine identification information.
Note:For all Go-karts use only a model 136200 series en-gine, which offers improved safety and performance.
Do not use Briggs & Stratton engines on 3-wheel All-TerrainVehicles (ATVs), motor bikes, air craft products, or vehiclesintended for use in competitive events. Briggs & Stratton does notapprove of or authorize such uses.
ENGINE INSTALLATION[1] Do not attempt to install this engine if you do not have the
appropriate tools and knowledge of small engine installationprocedures. Use only Briggs & Stratton parts. Contact your
Authorized Service Dealer for assistance.[2] Do not modify the engine in any way without Briggs & Stratton
factory approval. Any such modification is at the owners solerisk.
[3] If the exhaust system on the old engine was supplied by the
[8]
WARNINGAll engine parts, including fuelcap, spark plug, muffler, air
cleaner, and covers and guardsfor drive components (gears,belts, shafts, couplings, etc.)must be in place before attempt-ing to start engine.
[9]
WARNINGIf engine is installed on walkbehind lawn mower, all mowercomponents, including cuttingblade, must be correctlyinstalled before attempting to
start engine.
[10]
WARNINGWhen working on the engine orequipment, remove spark plugwire from spark plug. For electricstart, remove negative wire frombattery.
[11]
WARNING Do not check for spark withspark plug removed. Use Briggs
& Stratton spark tester #19368.
ENGINE OPERATION
WARNING
When adding fuel:
Turn engine off and let engine cool at least 2 minutes beforeremoving gas cap.
Fill fuel tank outdoors or in well- ventilated area. Fill tank to about1 i h b l l t ti f k t ll f f l i
-
8/7/2019 Briggs & Stratton Quantum 35 Engine - Owner's Manual
4/12
-
8/7/2019 Briggs & Stratton Quantum 35 Engine - Owner's Manual
5/12
-
8/7/2019 Briggs & Stratton Quantum 35 Engine - Owner's Manual
6/12
-
8/7/2019 Briggs & Stratton Quantum 35 Engine - Owner's Manual
7/12
-
8/7/2019 Briggs & Stratton Quantum 35 Engine - Owner's Manual
8/12
-
8/7/2019 Briggs & Stratton Quantum 35 Engine - Owner's Manual
9/12
-
8/7/2019 Briggs & Stratton Quantum 35 Engine - Owner's Manual
10/12
-
8/7/2019 Briggs & Stratton Quantum 35 Engine - Owner's Manual
11/12
-
8/7/2019 Briggs & Stratton Quantum 35 Engine - Owner's Manual
12/12