ANSULANSUL INCORPORATEDMARINETTE, WI 54143-2542

MATERIAL SAFETY DATA SHEET

QUICK IDENTIFIER (In Plant Common Name)

Manufacturer’s ANSUL INCORPORATED Emergency CHEMTRECName: Telephone No.: (800) 424-9300 or (703) 527-3887

Address: One Stanton Street, Marinette, WI 54143-2542 Other Information (715) 735-7411Calls:

Prepared By: Safety and Health Department Date Prepared:

SECTION 1 – IDENTITYCommon Name: (used on label) CAS No.:(Trade Name and Synonyms)

Chemical ChemicalName: Family:

Formula:

SECTION 2 – INGREDIENTSPART A – HAZARDOUS INGREDIENTSPrincipal Hazardous Component(s) (chemical and common name(s)): Wt. % CAS No. ACGIH TLV Acute Toxicity Data

PART B – OTHER INGREDIENTSOther Component(s) (chemical and common name(s)): Wt. % CAS No. ACGIH TLV Acute Toxicity Data

SECTION 3 – PHYSICAL AND CHEMICAL CHARACTERISTICS (Fire and Explosion Data)Boiling Specific Vapor PressurePoint: Gravity (H2O = 1): (mm Hg):

Percent Volatile Vapor Density Evaporation Rateby Volume (%): (Air = 1): ( = 1):

Solubility Reactivity inin Water: Water:

Appearanceand Odor:

Flash Point: Flammable Limits Extinguisher Auto-Ignitionin Air % by Volume: Media: Temperature:

Special FireFighting Procedures:

Unusual Fire andExplosion Hazards:

SECTION 4 – PHYSICAL HAZARDSStability: Unstable □ Conditions

Stable � to Avoid:

Incompatibility(Materials to Avoid):

HazardousDecomposition Products:

Hazardous May Occur □ ConditionsPolymerization: Will Not Occur � to Avoid:

ANSULEX – R-102

June, 2001

N/A

Mixture

ANSULEX R-102

N/A This is a Mixture

N/A

113 °C 1.43 NotDetermined

Approx. 50 1.03 0.13

100% Mild exothermic reaction

Pink colored liquid, mild odor.

None N/A N/A N/Ato boiling

NONE – THIS IS AN EXTINGUISHING AGENT

None

Potassium Carbonate 35 584-08-7 Oral LD50 (rat)1870 mg/kg

N/A

Reactive metals, electrically energized equipment, any material reactive with water.

Not established, acrid fumes.

N/A

Proprietary Mixtures of: 18 127-08-2 Oral LD50 (rat)Potassium Acetate 3250 mg/kg

Phenopthalein 2 ppm 77-09-8 ip LD50 (rat)500 mg/kg

Water Balance 7732-18-5 N/E NDA

SECTION 5 – HEALTH HAZARDSThresholdLimit Value:

Routes of Entry:Eye Contact:

Skin Contact:

Inhalation:

Ingestion:

Signs and Acute Overexposure:Symptoms: Chronic Overexposure:

Medical Conditions GenerallyAggravated by Exposure:

Chemical Listed as Carcinogen National Toxicology Yes □ I.A.R.C. Yes □ OSHA: Yes □or Potential: Program: No � Monographs: No � No �

SECTION 6 – EMERGENCY AND FIRST AID PROCEDURESEye Contact:

Skin Contact:

Inhalation:

Ingestion:

SECTION 7 – SPECIAL PROTECTION INFORMATIONRespiratory Protection(Specify Type):

Ventilation: Local MechanicalExhaust: (General):

Protective EyeGloves: Protection:

Other ProtectiveClothing or Equipment:

SECTION 8 – SPECIAL PRECAUTIONS AND SPILL/LEAK PROCEDURESPrecautions to be Takenin Handling and Storage:

OtherPrecautions:

Steps to be Taken in CaseMaterial is Released or Spilled:

Waste DisposalMethods:

HAZARDOUS MATERIAL IDENTIFICATION SYSTEM RATINGSHAZARD INDEX:4 Severe Hazard ______ HEALTH

3 Serious Hazard2 Moderate Hazard ______ FLAMMABILITY

1 Slight Hazard0 Minimal Hazard ______ REACTIVITY

N/A = Not Applicable NDA = No Data Available

ANSUL INCORPORATED, ONE STANTON STREET, MARINETTE, WI 54143-2542 715-735-7411 Form No. F-85324-8 ©2001 Ansul Incorporated Litho in U.S.A.

ANSUL and ANSULEX are registered trademarks.

None Established

Irritant. Prolonged contact can cause chemical burns.

Irritant. prolonged contact can cause chemical burns.

Not an expected route of entry. Can be irritating to mucous membranes.

Irritating to mucous membranes.

Due to alkaline nature, material irritates skin, eyes, and all mucous membranes. Prolongedcontact may cause skin burns.None known.

None known.

Flush and irrigate with water for 15 minutes while holding eyelids open. If irritation persists, seek Medical attention.

Wash thoroughly with soap and water; if irritation persists, seek Medical attention.

Fresh air if symptoms occur. Seek Medical attention if irritation persists.

Dilute by drinking large quantities of water.

N/A

N/A N/A

Rubber gloves for spill/leak. Chemical goggles recommended during spill/leak procedures.

Eye wash and safety showers are good safety practice.

Store in original container. Keep tightly closed. Keep separate from acid.

See incompatibility information in Section 4.

Stop leaks. Contain Spill. Remove as much as possible. Place in closed container for proper disposal.Wash spill area with large amounts of water to remove traces and neutralize.

Dispose of in compliance with local, state, and federal regulations.

1

0

0

ANSULEX – R-102 (Continued)

MSDS AVAILABILITYMSDS AVAILABLE AT www.ansul.com MSDS FAX ON DEMAND: 1-800-323-8493 or 715-735-7411, extension 3091

AGENT INDEX NUMBERANSULEX – R-102 85324

WHMIS RATING: D2B – Irritating to eyes; may be irritating to skinand mucous membrane.