explosives and blasting - underground coal mining
Post on 07-Jul-2018
230 Views
Preview:
TRANSCRIPT
-
8/18/2019 Explosives and Blasting - Underground Coal Mining
1/13
EXPLOSIVES AND
BLASTING IN
UNDERGROUND COAL
M INING
-
8/18/2019 Explosives and Blasting - Underground Coal Mining
2/13
INTRODUCTION
All seams in underground coal mines areconsidered gassy, the degree of gassiness
may vary from I to III.Methane gas that is released from duringecavation !hen mied in the "ro"ortions#et!een $%&'( forms an e"losive miture.
In underground coal mines, there is also anadditional ris) as coal dust !hich undergoesa dust e"losion !hen suita#ly ignited !ithair.
-
8/18/2019 Explosives and Blasting - Underground Coal Mining
3/13
Methane ignition is )no!n to ta)e "lace dueto follo!ing reasons*
⇒Direct action of shoc) !ave from thee"losive.
⇒ Indirect action of the shoc) !ave after ithas #een re+ected from solid surfaces in thevicinity of e"losives.
⇒ot gaseous "roducts of detonationmiing !ith the methane%air miture.
⇒ot reacting solid "articles of e"losivesgetting e-ected in to the methane%air
-
8/18/2019 Explosives and Blasting - Underground Coal Mining
4/13
ence , s"ecially designed e"losives anddetonators are reuired for use inunderground coal mines.
/0RMITT0D 01/2O3I403
Only those e"losives, !hich are included inthe o5cial list of authorised e"losives issued#y the Chief Controller of 0"losives in India,may #e used for #lasting in mines.
Only on "assing the tests in an e"losivea""roved as a 6"ermitted7 e"losive.
In India there are 8 ty"es of "ermitted
-
8/18/2019 Explosives and Blasting - Underground Coal Mining
5/13
/%& Ty"e /ermitted 0"losives* Thesee"losives can #e used for drifting or ri""ingand simultaneously 9ring in anundercut:middlecut:overcut and in de"illaringfaces, in coal seams of 9rst degree ofgassiness.
/%8 Ty"e /ermitted 0"losives* These are0uivalent%to%3heathed 0"losives used fordrifting or ri""ing and simultaneously 9ring an
undercut:middlecut:overcut and in de"illaringfaces, in coal seams of 9rst degree ofgassiness.
/%$ Ty"e /ermitted 0"losives* These are
-
8/18/2019 Explosives and Blasting - Underground Coal Mining
6/13
NON /0RMITT0D 01/2O3I403
=or certain o"erations such as shaft sin)ingand stone drifting, !here there is no gas or
coal dust "resent, e"losives other than "ermitted e"losives can #e used, su#-ect tosuch conditions as may #e laid do!n #y theD>M3 in s"eci9c instances.
-
8/18/2019 Explosives and Blasting - Underground Coal Mining
7/13
D0TONATOR3 In con-unction !ith /ermitted 0"losives,only a""roved detonators may #e used for
coal #lasting.Only electric detonators !ith co""er tu#e are
"ermitted for use in coal #lasting.There are ? ty"es of detonators* @ Instantaneous Co""er 0lectricDetonatorsBC0D @ Co""er Non%Incendive 3hort Delay
DetonatorsBCDD
-
8/18/2019 Explosives and Blasting - Underground Coal Mining
8/13
/RINCI/203 O= IN
COA2
Underground coal mining o"erations could
#e divided into t!o categories , namely,Develo"ment and De"illaring.
-
8/18/2019 Explosives and Blasting - Underground Coal Mining
9/13
ON A /R0%CUT =AC0
In many mines coal%cutting machines areused to "rovide an additional free face for#lasting. hile this may #e under , over,middle or side cut, the most common "ractisein Indian mines is to have undercut face. =or#lasting on cut faces the follo!ing conditionsmust #e com"iled !ith*
⇒The length of the shot hole should #e atleast &$cm BE inches less than the de"th ofthe cut.⇒ The detonators in a round should #e 9red
simultaneously , "refera#ly in series.
-
8/18/2019 Explosives and Blasting - Underground Coal Mining
10/13
3O2ID O= COA2B
-
8/18/2019 Explosives and Blasting - Underground Coal Mining
11/13
COD0 O= >OOD /RACTI303 INUND0R>ROUND
4elocities of Air Current BD>M3
sti"ulations*
The velocity of air current measured
in metres "er minutes at the "lace sho!n incolumn B? shall not #e less than that sho!nin columnB8 for the dierent seams sho!n incolumnB& of the ta#le
-
8/18/2019 Explosives and Blasting - Underground Coal Mining
12/13
Degree ofGassiness
Place where the velocity of air isto be measured
Velocity ofair
First, Second or Third Degree
Intermediate out by ventilation connectionfrom the face 3
First, second
degree
!i"#$% mts from any face whether wor&ing or
discontinued on the inta&e side of thebrattice or 'artition
3
!ii"($% mts out by the discharge end of anair 'i'e )%!iii" *t the ma+imum s'an of a ongwallface -
Third Degree !i"#$% mts from any face whether wor&ing ordiscontinued on the inta&e side of thebrattice or 'artition
#%
!ii"($% mts out by the discharge end of an
air 'i'e .%!iii"*t the ma+imum s'an of a ongwall face (%
-
8/18/2019 Explosives and Blasting - Underground Coal Mining
13/13
TANJ KOU
top related