exhibit e acceptable equipment and material supplier...
Post on 16-May-2018
214 Views
Preview:
TRANSCRIPT
Brown CCRT Exhibit E EXHIBIT E
ACCEPTABLE EQUIPMENT AND MATERIAL SUPPLIER LISTS
BROWN
The following sub-suppliers have been pre-approved by the Owner to provide the corresponding components. Pre-approval of a supplier for one component category is not blanket acceptance for other components by that supplier. If Contractor proposes to substitute a sub-supplier not on this list, then the sub-supplier’s credentials shall be submitted to Owner for approval. Any cost savings to Contractor shall be credited to Owner if a substitute sub-supplier is requested and approved. Sufficient data must be provided to Owner in a timely manner to prove that the proposed equipment is of an equivalent quality and has proven operation in similar service conditions, including capacity, to that provided by the pre-approved sub-suppliers. If an offshore sub-supplier is proposed, Contractor shall provide information proving satisfactory domestic stockpiling of any required spare parts. Final decision concerning acceptance of an alternate sub-supplier shall be solely at Owner’s discretion. Owner will have access to Contractor’s equipment bids and will have ultimate approval / right of refusal on selection of suppliers / manufacturers. Where multiple sub-suppliers are identified, those indicated in bold text are preferred by Owner and should be used for base bid purposes. Where no sub-supplier is named, Contractor shall select based on previous successful service in similar utility power plant applications. Contractor shall indicate on the fill-in data sheets which sub-contractors and/or sub-suppliers shown are to be the source of the indicated equipment and those provided only as “typical” of the intended by Contractor. The following listing and categories of Acceptable Subcontractor are general and may include categories outside the scope of the Agreement COMPONENT PREAPPROVED SUBSUPPLIER Actuators (Motor operated valves)
Rotork – On/Off Service Beck – Modulating Service REXA – Modulating Service Limitorque Promation
Agitators, mechanical tank Chemineer Ekato Lightnin
Air Conditioning Units Trane York International
Page 1 of 33
Brown CCRT Exhibit E
McQuay
Anemometers Manufacture’s standard.
Ammonia Receiving, Pump Forwarding and Injection Skids
Toromont
Auxiliary Relays Allen-Bradley Bulletin 700 Type P
Allen-Bradley Bulletin 700 Type PK General Electric Type HFA or HGA ABB Type MG-6 Allen –Bradley Type 700P, IDEC Potter and Brumfield (Tyco) type KRP
Bin Activators Bottom Ash Equipment
Kinergy Corp. Vibranetics, Division of Carrier Vibra Screw Carman Close Allen Sherman Hoff Alstom Clyde Bergemann United Conveyor Corporation
Bridge Cranes Columbus McKinnon Corp. Demag Cranes and Components EMH, Inc Harrington Hoists, Inc. KCI Konecranes America Morris Material Handling OMI Crane Systems Proservce Anchor Crane Group
Cable Trays B-Line Systems Chalfant Products Husky Products (Burndy) P-W Industries T.J. Cope US Gypsum Globe Div.
Cable – Coaxial and Triaxial Belden Brand Rex Rockbestos
Page 2 of 33
Brown CCRT Exhibit E Cable-600V Power Cable Brand Rex
Cablec Okonite Rockbestos Rome Houston Wire & Cable
Cable-600V Control Cable Brand Rex Continental Okonite Rockbestos Rome Thermo Electric Wire & Cable Tefzel Insulation
Cable – FiberOptic 3M Chromatic Technologies Brand Rex BIW
Cable – Instrumentation / Thermocouple Extension
Brand Rex Continental Delta-Surprenant L&N Okonite Rockbestos Samuel Moore Thermo Electric Wire & Cable Houston Wire & Cable
Cable & Motor Termination and Splice Kits, (medium and low voltage)
3M – 7600, 5500, 5600, 5300 Series Raychem – HVT/GCA kit, HVS, MCK-5, MCK or RVC
Cable Trays B-Line Systems Chalfant Products Husky Products (Burndy) P-W Industries T.J. Cope US Gypsum Globe Div.
Cathodic Protection Harco Magna Western Cathodic Engineering Allied
Page 3 of 33
Brown CCRT Exhibit E
Corrpro
Clarification, Filtration Equipment, and Thickeners
Envirex Graver Water Infilco Degremont L.A. Water Treatment Sanitaire Smith & Loveless Westech Engineering U.S. Filter
Compressed Air Fittings (Threaded) Swagelok
Conduit (aluminum) Alflex Breeze-Illinois Condux International New Jersey Aluminum Easco Reynolds Metal Company VAW of America, Inc.
Conduit (flexible steel) Flexible Technology Corp. Eletric-flex Company International Metal Hose Company
Conduit (rigid steel, EMT) Allied Tube and Conduit Clifton Conduit Corp. The Steelduct Co. Torrance Turbine Div. Triangle Conduit/Cable Westmoreland Conduit Wheatland Tube Col Youngstown Sheet and Tube
Conduit (PVC) coated (prefer not to use above ground PVC)
Rob Roy Stahl Ocal Inc.
Conduit (PVC) Carlon Products Division, Continental Oil Co. Certain-Teed Products Corp. FRE Composites Allied Tube and Conduit
Connectors (ground) (must be exothermic)
Burndy Cadweld Thermoweld Thomas & Betts Co.
Page 4 of 33
Brown CCRT Exhibit E Connectors (control) 3M – MNG-18, MNG-14, MNG-10
AMP Special Industries - PIDG Panduit Corporation – PN18, PN14, PN10 Thomas & Betts Co. – RA18, RB14, RC10
Connectors (power, 600V and below) 3M – M10, M8, M6, M4, 30000 Series, 31100 Series AMP Special Industries – Solistrand, Ampower Panduit Corporation – P10, P8, P6, P4, LCA, LCC Thomas & Betts Co. – C10, D8, E6, F4, 54100 Series, 54200 Series
Connectors (power, above 600V) 3M – 30000 Series, 31100 Series AMP Special Industries – Ampower (5kV and below) Panduit Corporation – LCA (5kV and below) LCC (5kV and below) Thomas & Betts Co. – 54400 Series
Contactors Allen-Bradley
Contactors (Lighting) ASCO Cutler-Hammer Siemens Square D
Control Component Devices Manufacturer’s standard with approval by Owner
Controls Drives – Electric REXA Beck
Control Drives – Pneumatic Bailey Controls Rosemount (Hagan) Ktech
Control Panels Comsip Customline Hatch Inc. Johnson Controls KEMCO Powell Sewell Hoffman
Control Stations (local) Allen Bradley Crouse Hinds
Page 5 of 33
Brown CCRT Exhibit E
Cutler Hammer Square D
Controllers (Local) Fisher 2502 for Level Fisher 4160 or 4195 Series for Pressure Fisher 4166 or 4196 Series for Temperature Foxboro 43AP series Siemens, Masoneilan
Controllers (Photoelectric) Fisher Pierce N7790B
Control Valves and Regulators Fisher Controls Fujikin (with Beck drive) Masonelian International Flowserve
Control Valves and Regulators (steam service) Fisher Fujiken Copes Vulcan CCI Masonelian International
Control Valves – Rotary Fisher Controls Jamesbury Beck Masonelian International
Control Valves – Slurry Fujikin
Convenience Receptacles (Duplex and Single) Hubbell (Generic Cat. No. 5362) Pass & Seymour Cooper Wiring Leviton International
Convenience Receptacles (Duplex, gray for finished areas, brown for unfinished areas)
Hubbell (Generic Cat. No. 5362) Pass & Seymour Cooper Wiring Leviton
Convenience Receptacles (Single, gray for finished areas, brown for unfinished areas)
Hubbell (Generic Cat. No. 5361) Pass & Seymour Cooper Wiring Leviton
Convenience Receptacles (Isolated Ground) Hubbell (Generic Cat. No. IG5362)
Page 6 of 33
Brown CCRT Exhibit E
Pass & Seymour Cooper Wiring Leviton
Convenience Receptacles (Ground Fault Interrupting)
Hubbell (Generic Cat. No. GF20L) Pass & Seymour Cooper Wiring Leviton
Convenience Receptacles (Hazardous Rated, Class I, Group D and Class II, Group F areas)
Appleton EFS "U-Line" or Crouse-Hinds ENR Series
Conveyors, Ash and Gypsum Allen-Sherman-Hoff (ASH) TLT Babcock United Conveyor Corp. (UCC)
Conveyor – Bearings Dodge PTC (Link Belt) SKF
Conveyor – Flexable Couplings Browning Dodge (Waldron) Falk Kop-Flex PTC (Link-Belt) Philadelphia Rexnord Flender Transfluid
Conveyor – Idlers Continenetal Conveyor FMC Goodman Hewitt-Robins Precision Rexnord Metso (Svedala)
Conveyor – Belting Georgia Duck Goodyear Scandura (Uniroyal) U.S. Rubber
Crushers American Pulverizer Metso Penn Crusher
Page 7 of 33
Brown CCRT Exhibit E
Gundlach Dampers (guillotine or louver man-safe isolation, or louver control)
WahlcoMetroflex, NEM Power, TLT, Bachman
Detectors (Belt Rip) Conveyor Components Contractor’s Standard
Detectors (hopper level)
Kay Ray Texas Nuclear Endress Hauser Milltronics Drexelbrook Baker Bonnert
Detectors (liquid level) Drexelbrook Engineering Endress Hauser Magnetrol Guided Wave Radar Milltronics Rochester Gauge
Detectors (admittance type high ash level) Drexelbrook Engineering Colconda Bindicator Princo Instruments
Detectors (Powder level) Drexelbrook Engineering Company Bindicator FLS or equal (for point level) Rosemount Saab Krone (or equal) for continuous measurement (radar)
Dew Point Test Apparatus EG&G Chandler Engineering Company “Catalog No. 13-75 with thermometer No. 13-2”
Direct DCS and Components (Temperature Controls Panels and Room Thermostats)
Hoffman Engineering Company (temp control panel) Honeywell Johnson Controls Siebe CSI
Direct DCS (Terminal Strips) Entrelec
Page 8 of 33
Brown CCRT Exhibit E
Phoenis Weidmuller Marathon 1500
Direct DCS (Auxiliary Relays) Allen-Bradley Type 700P IDEC
Direct DCS (Contactors) Allen-Bradley Type 700P
Direct Digital Control System (Temp Sensors & Moister Sensors)
Honeywell Johnson Controls Siemens Automatic Logic
Direct Digital Control System (Pressure Sensors)
Honeywell Johnson Controls Siemens Automatic Logic
Direct Tension Indicators (DTIs) TurnaSure LLC
Distribution Panelboards – 120VAC/125VDC
General Electric ITE Square D Westinghouse Cuttler Hammer
Distributed Control System (DCS) Foxboro I/A Doors (Fire Rated) Amweld “Series 3700”
Ceco “Regent” Mesker “PyroDor” Pioneer “Series C”
Doors (Insulated Rolling Steel) Atlas “Thermal Series” Cornell “Thermiser” Overhead Door “625”
Drives - Variable Speed (600V and below) (600V and above)
Allen Bradley Emerson GEC/CEG Electric Square D Toshiba - Houston International Reliance Robicon ABB
Page 9 of 33
Brown CCRT Exhibit E
Ductwork Fabricators Merrill
JT Cullen Custom Metals PSP CPF
Duct Slide PlatesDuct Slide Plates American Bearings Merriman Inc. R. M. Engineered Products Con-ServAmerican Bearings Merriman Inc. R. M. Engineered Products Con-Serv
Dust Collectors (dry) American Air Filter Flex-Kleen Mikropul
Electronic Control Systems (Draft Gauges) Dwyer
Elevators ThyssenKrupp (Formerly Dover) Kone (Formerly Montgomery) Otis Schindler/Houghton Westinghouse Murphy
Electronic Control Systems (Duct Thermostat) Honeywell Johnson Controls Siemens Automatic Logic
Electronic Control Systems (Fan Control Thermostat)
Honeywell Johnson Controls Siemens Automatic Logic
Electronic Control Systems (Pressurization Sensors & Pressure Indicators) Ethernet Communications
Honeywell Johnson Controls Siemens Automatic Logic N-Tron
Expansion Anchor Hilti Kwikbolt
Page 10 of 33
Brown CCRT Exhibit E ITT Philips Red Head Wedge and Sleeve Anchors
Ramset Trubolt and Dynabolt Drilco Maxi-Bolt
Expansion Joints Pathway R. M. Engineered Products Wahlco Metroflex EFFOX Papco Bachman
Fans (Ceiling mounted centrifugal exhaust fan)
Penn Greenheck Loren Cook Twin City Fan – Commercial
Fans (Centrifugal) Aerovent Hartzell, Twin City Fan - Industrial
Fans (Centrifugal exhaust) Penn Greenheck Loren Cook Twin City Fan – Commercial
Fans (propeller) Aerovent Hartzell Twin City Fan - Industrial
Fans (Venaxial and Tubeaxial) Aerovent Hartzell, Twin City Fan - Industrial
Fans (power roof ventilation wall fans) Aerovent Greenheck Hartzell Fan Loren Cook
Fasteners Best Quality Fabco self-tapping Buildex TEKs self-drilling, self-tapping screws
Feeders (gravimetric, weigh) Merrick Ramsey Stock
Page 11 of 33
Brown CCRT Exhibit E
Feeders (volumetric) Merrick Ramsey Stock
Fiber Optic Panels Leviton
Filter Bags
Flakt-Carborundum Menardi Southern Nomex
Fire Protection System (Heat Detection) Fenwal “21500 Series” Rate Compensated
Firestopping Bio-Fireshield Flamemaster Corporation Firestop Systems
Fittings (Integrally reinforced branch outlet fittings)
Bonney Forge WFI WOI
Fittings (PP lined, PVDF lined, and PTFE lined)
Dow Chemical Company Resistoflex Corporation Peabody Dore
Fittings - Rubber lined Dow Chemical Company
Fittings - FRP Centrifugally cast Fibercast Company – Fibercast
Fittings - FRP Filament wound Ameron Corrosion Control Division - Bondstrand Reinforced Plastics Systems Inc. - ABCO Plastics Division Smith Fiberglass Products Inc. Fibercast Company – Fibercast
Fittings - HDPE Factory Mutual (FM) approved
Phillips Petroleum Company - Driscopipe 1000 FM Class 200 Amsted Industries - Plexco EHMW - Class 200 - FM Bluestripe - Class 200 - FM Redstripe - Class 200 - FM Poly Systems Incorporated KWH Class 200
Page 12 of 33
Brown CCRT Exhibit E
Fittings - HDPE Non-FM applications Phillips Petroleum Company - Driscopipe 1000
Amsted Industries - Plexco PE 3408 Poly Systems Incorporated, KWH – Sclairpipe
Fittings - Tubing Crawford Swagelok Parker Hannifin
Flow Elements Fly Ash Equipment
Daniel Industries Vickery Simms Fluidic Techniques Allen Sherman Hoff Clyde Bergemann United Conveyor Corporation
Fuses (Slow Blow) Gould Shawmut/GDL Bussman/MDL
Fuses (Fast Acting) Gould Shawmut/OT Bussman/NON
Fuses (Extremely Fast Acting)
Bussman/KAB
Gaskets (Compressed Fiber) Richard Klinger, Inc. – Klingersil Garlock, Inc. – Blue-Gard
Gaskets (Cloth Inserted Rubber) Manville
Gaskets (Spiral Wound) Flexitallic Gasket company
Gasket (Spiral Wound Filler) Flexitallic Gasket Company – Flexite Super Garlock
Geomembrane Liner (FML) GSE Lining Technology, Inc. Poly-Flex, Inc.
Glass (Tempered (Clear or Tinted)) L-O-F “Tuf Flex” PPG “Herculite”
Grating Tru-Weld Grating Klemp Corporation IKG Industries
Ground Rods ITT Blackburn Co.
Page 13 of 33
Brown CCRT Exhibit E Grout Embeco
Five Star
Gypsum Dewatering Equipment Heat Exchangers-Plate
FL Smidth Westech APV Crepaco Alfa – Laval Thermal Graham Manufacturing ITT Fluid Technology
Heat Exchangers-Shell/Tube Heaters (Electric Unit)
Hoffman Process Hydro Dyne Manning & Lewis Senior Engineering (Southwest) Struthers Industries Yuba Basco Thermal Transfer Young Radiator Trane Markel Qmark
High Strength Bolts Approved US Supplier
Hoists ACCO (Wright) Chester Columbus McKinnon (CM) Lift-Tech (Shaw/Box/Budgit) Robbins & Myers (R&M) Shepard Niles Yale (A)
Hopper Heaters Isopad (Hotfoil)
Hoses (rubber or wash down) Gates Goodall Rubber Co. Rubber Engineering
HVAC (controls) Honeywell Inc. Johnson Controls Inc.
Page 14 of 33
Brown CCRT Exhibit E Indicators (flow) Universal
Rosemount Micromotion
Indicators (pressure) Ashcroft Rosemont Perma-Cal Industries
Indicators (temperature) Ashcroft
Induction Motors (Low Voltage) ABB Baldor-Reliance General Electric Siemens Toshiba-USA TECO – Westinghouse Motor U.S. Motors WEG Marathon
Induction Motors (Medium Voltage) ABB General Electric Hitachi Hyundai Reliance Siemens TECO – Westinghouse Motor Co. WEG Marathon HICO
Integrally Reinforced Forged Branch Outlet Fittings
Bonney Forge WFI WOI
Insulation (Calcium Silicate) Industrial Insulation Group LLC “Calsilite”
Insulation (Elastomeric Anti-sweat) Armstrong “Armaflex”
Adhesive for Elastomeric Antisweat Insulation Armstrong 520 Adhesive
Insulation (Fiberglass) CertainTeed Manson Owens-Coming
Page 15 of 33
Brown CCRT Exhibit E Insulation (Mineral Fiber) Delta “Rock Wool”
Fibrex Industrial Insulation Group
Insulation (Perlite) Industrial Insulation Group LLC “Sproulle” Knauf “Innova”
Insulation (Treated Rigid Fiber) Owens-Coming
Insulation – Welded Studs for Attachment Nelson
Instrument Enclosures, heated Thermon – ThermoCase O’Brien – Vipak, A Series
Instruments (chute plugs) Drexelbrook
Instruments (fittings) Parker
Instruments (general control and indication) General Electric (type CR2940 control switch) Honeywell (type CMC control switch) Master Specialties Corporation (indicating lamps) Allen Bradley United Electric
Instruments (laboratory) Fisher Scientific Mettler Instrument Corp. Perkin Elmer
Instruments - (pressure switches)
SOR Barksdale Dwyer United Electric ASCO
Instruments – (solenoids) ASCO Rexroth Mac Temp Trans – Rosemount
Instruments - (temperature switches) ASCO Ashcroft United Electric Controls Barksdale
Page 16 of 33
Brown CCRT Exhibit E Instruments – Medium Voltage Switchgear (control switches, indicating lamps, etc.)
General Electric (Type SB-1 control switches, ET-16 lamp holder) ABB Yokogawa Multilin SEL (Schweitzer Engineering Labs)
Instruments – 480V Instrument Metering and Relaying Equipment
ABB General Electric Westinghouse Yokogawa Multilin SEL (Schweitzer Engineering Labs)
Intra-Plant Communications and Telephone Systems
C.W. Thomson Comtrol FEMCO/Gaitronics
Inverter Cyberex Elgar Exide Liebert Solid State Controls
I/P Converters Fischer Controls Foxboro Masoneilan International Action Pak
Insulation (thermal) Johns Manville Corp. Owens Corning
Louvers (Building, HVAC, Vertical Storm Proof)
Ruskin Manufacturing EME6625 Arrow United Industries EA-662-VSL Construction Specialties R5-5605 Greenheck
Jib Cranes Abell Howe Co. Anchor Crane and Hoist Service Co. Gorbel, Inc. Kone-Landel, Inc. Lift-Tech International, Inc. Orley Meyers Robbins and Meyers Seppard Niles, Inc.
Page 17 of 33
Brown CCRT Exhibit E
Lighting Abolite
Crouse Hinds Co. General Electric Holophane Lithonia
Lighting (panelboard) General Electric ITE Square D Cuttler Hammer
Lighting (Photo electric light) Sigma Instruments Co. Tork Electric Company
Lighting (receptacles) Crouse Hinds Co. Hubbell, Inc.
Limit Switches Crouse Hinds Co. Cutler Hammer Honeywell Namco (Snap Lock) TopWorx (formerly GO Switch)
Linings (alloy) Stainless Steel Haynes Int. Inco Alloys Rolled Alloys VDM
Linings (alloy clad) Creusot-Marrell, Inc. Lukens Steel Co.
Linings (borosilicate)
Pennwalt
Linings (ceramic) Mechanical Ceramic Solutions(MCS) C.L. Smith Cerline CBP
Linings (flakeglass) Ceilcote Dudick
Local Pneumatic Instrumentation Fisher Controls
Page 18 of 33
Brown CCRT Exhibit E Louvers (Bldg. HVAC)
Foxboro Masonelian International Moore Products Ruskin Construction Specialties Greenheck
Lubricants Mechanical Bulks
Chevron Frischkorn Ferguson McJunkin Wilson
Mechanical Seals BWIP Type RIS FlowServe
Meters General Electric (Model AB-40 or DB-40) Yokogawa (404-253700)
Meters (gas flow in duct) Environmental Measurement Research Corp.
Meters (pH) TBI-Bailey Yokagawa Honeywell Great Lakes Instruments
Meters (slurry density) Foxboro ITT Barton KayRay/Sensall Inc Model #3680CA Ohmart Texas Nuclear
Meters (slurry flow) Krohne Honeywell
Meters (slurry flow—magnetic)
Endress & Hauser Honeywell
Meters (ultrasonic flow and tank level) Milltronic Controlotron Dupont Polysonics Endress Hauser
Page 19 of 33
Brown CCRT Exhibit E
Panametric Magnetrol Guided Wave Radar
Mixers, Static Koch Chemineer Lightnin Sulzer
Monitor (Level) Ultrasonic: Milltronics Ultrasonic: Milltronics Strain Gauge: Kistler-Morse Load Cell: Vishay BLH Revere (RT)
Monitor (vibration) Bently-Nevada IRD Metrix Instrument Company
Monorails ACCO Chain & Lifting Products (Louden) American Monorail Cleveland Tramrail, Shepard Niles Trambeam Corp.
Motor Control Centers General Electric Allen – Bradley Square D GE 8000 Siemens
Motors – 4.0 kV and Above Electric Machinery General Electric TECO-Westinghouse Seimens Toshiba
*Motors (booster fans & Small) Electric Machinery Reliance Electric Westinghouse General Electric
Motors – 600V and Below (including variable speed)
General Electric TECO-Westinghouse Reliance Electric Siemens Baldor
Page 20 of 33
Brown CCRT Exhibit E Non-Segregated Phase Bus Duct or Cable Bus- – Medium Voltage
ABB Delta-Unibus Husky Products (Burndy) Trench Electric Crown Electric
Nozzles (slurry or water) Bete Fog Nozzle Lechler Spraying Systems
O2 Probes Rosemont
Opacity Analyzer Enviroplan Lear Siegler/ Monitor Labs Thermo Environmental Inst. Spectrum Environmental Monitoring System
Paint (field) Ameron Carboline Keeler & Long Porter Tnemec Valspar Rustoleum
Pipe Supports Basic Engineers Anvil (Formerly Grinnell Corp.) Power Piping Lisega Fronek Carpenter & Patterson
Piping (FRP for slurry or water) ABCO RPS Ershigs Smith Fibrex
Piping (HDPE) J.M.Eagle Performance Piping Poly Pipe
Piping (PP lined, PVDF lined, PTFE lined) Dow Chemical Company
Page 21 of 33
Brown CCRT Exhibit E
Resistoflex Corporation Peabody Dore
Piping (rubber lined for slurry) (not for use with gypsum)
ARDCO Holz Rubber Company Rubber Engineering Dow Chemical Company
Plug Resistant Orifices CU Services
Post Installed Mechanical Anchor Bolts Hilti Kwik-Bolt TZ
Positioner CCI “QuickTak” Fisher Controls – “Fieldvue” DVC 6000 Series Siemens – “Sipart PS2” Valtek - Logix 3200IQ
Pressure Indicator (Wetted Parts) Weksler AA44 Ashcroft 1279SS US Gauge 1981 3-D Instruments Accu-Drive Series 25 Perma-Cal 111TIDxxAx3LT Dwyer Series 4000
Programmable Logic Controllers (PLC) Rockwell Control Logics (Allen-Bradley)
Pressure Switch -Gauge Dwyer Instruments, Inc. – (Capsu-Photohelic) S-O-R, Inc United Electric
Pressure Switch - Differential Dwyer Instruments, Inc. – (Capsu-Photohelic) S-O-R, Inc United Electric
Pumps (cantilever) ASH (BGA) Hazelton Lawrence Warman Nagle
Pumps – Lube Oil Service IMO Delaval Viking Rivett Tuthill
Page 22 of 33
Brown CCRT Exhibit E
Pumps – Miscellaneous Service Goulds
Flowserve Lawrence Weir KSB
Pumps - Slurry ASH (BGA)
Denver Duchting Hazelton with Inpro Seals Lawrence Warman Townley
Pumps (water, except filtrate pumps) Rebar
Durco/Duriron Goulds Flowserve TBD
Relays – Auxiliary Control
Allen Bradley Diversified Electronics General Electric Square D Potter Brumfield Cutler Hammer
Relays – Timing
Agastat Eagle Adalake Potter Brumfield Diversified Electronics Allen Bradley
Relays – Lockout ABB Electro Switch General Electric
Relay Test Switches ABB
Page 23 of 33
Brown CCRT Exhibit E Relays – Protective Type for Generators, Motors, Transformers, and Switchgear
ABB Basler General Electric/Multilin SEL (Schweitzer Engineering Labs)
RTDs Foxboro Rosemont Tem-Pro, Inc. Ronan Honeywell RAM
Sealants and Chalking Bostik Construction Products Div. Dow Corning Corp. General Electric Co. Pecora Corporation Sika Chemical Corp. Sonneborn Building Products Tremco Manufacturing Company W. R. Meadows, Inc.
Sealant Backer Rod (Closed-cell) Bostik Construction Products Div.
Sonneborn Building Products - Sonofoam W. R. Meadows - Sealtight Backer Rod or Cera-Rod
Sealant Backer Rod (Open-cell)
Bostik Construction Products Div. Denver Foam
Signal Converters (electric to pneumatic) Rosemount 3311 Foxboro E69F ITT – Conoflow GT 8
Silencers Glynn-Johnson 64
Silos, Concrete Hamon Custodis, Inc. Marietta Silos LLC Pullman Power San-Con Industries, Inc.
Submerged Flight Conveyors (Remote) Allen-Sherman-Hoff (ASH) Clyde Bergeman (ASHCON) United Conveyor Corp. (UCC) F.L. Smidth
Switches (Belt Misalignment) Allen-Bradley
Page 24 of 33
Brown CCRT Exhibit E
Cutler-Hammer Honeywell Micro-Switch Namco Thermo Ramsey Pro-Line (Model ROS) Square D Cooper Crouse-Hinds
Switches (Control) General Electric Type SB-1 with large cover General Electric Type SB-10 with large cover Electro-Switch Type 24 Electro-Switch Type W Electro-Switch Type 20K
Switches (Disconnect) Square D Switches (Level Switch – Enclosed Cage, 2SPDT)
Magnetrol S-O-R, Inc.
Switches (Level Switch – Float Type, SPDT) Warrick Series “M” ITT Flygt ENM 10 Series
Switch Flow (SPDT) Manufacturer’s Standard
Switches (Four way) Hubbell (Generic Cat. No. 1224) Pass & Seymour Cooper Wiring Leviton
Switches (Momentary Contact) Pass & Seymour Cooper Wiring Leviton
Switches (Plugged Chute) Tilt: Thermo Ramsey Pro-line Nuclear: Thermo Measuretech Nuclear: Ohmart Vega Rotary: Binedicator Rotary: Conveyor Components (Model CR) Rotary: Monitoring Mfr (Model FX) Microwave Point Level: Delavan (L&J Technology)
Switches (Position Switch – Mechanically Actuated
NAMCO Controls EA-170 Honeywell Microswitch Type LS A-B 802T-ATP Telemacanique/R.B. Denison
Page 25 of 33
Brown CCRT Exhibit E
Square D
Switches (Proximity) Topworx (Go Switch) 7G23528-A2
Switches (Pull Cord) Conveyor Components - Model RS. Cooper Crouse-Hinds - Model AFU. Thermo Ramsey Pro-Line - Safety Pull Switch (SPS). Material Control - Safety Stop Switch.
Switches (Push Buttons and Selector Switches)
Allen Bradley 800H Series, corrosion resistant Square D Class 9001 Type K
Switches (Gas Filled Temp.) Allen-Bradley Bulletin 837 Ashcroft Type 400B United Electric Series 400 S-O-R, Inc.
Switches (Selector) Allen-Bradley 800H or 800P, Square D
Switches (Underspeed) Hubbell Euclid – Mod Illtronics. Thermo Ramsey Pro-Line Bindicator Roto-Guard III Motion Detector
Switches (Vibration) Entek Robertshaw (Models 375 and 376)
Switchboards-AC and DC ABB General Electric Square D
Switchgear – Medium Voltage, Metal-clad Siemens ABB General Electric
Switchgear/Substations – 480V Load Centers ABB General Electric Square D Siemens
Tags (identification) AMP W.H. Brady Electromark Company Raychem Corporation
Page 26 of 33
Brown CCRT Exhibit E
Stanco Products Inc. The Thomas and Betts Co.
Tanks (FRP) Palmer Manufacturing and Tank Inc. Augusta Fiberglass Ershigs
Tanks (metal) Chicago Bridge & Iron RECO Rocky Mountain Enerfab Mississippi Tank Trinity Modern Welding
Testing (flue gas) Entropy, E.ON Engineering Radian EDN PGT FERCO Catalyst ESA
Teflon Slide Plates Fluorocarbon Co. “Flurogold Type”
Terminal Block (Thermocouple Extension Wire)
Manufacturer's Standard
Terminal Block (Feed-Through DCS I/O and PLC I/O)
Manufacturer's Standard
Terminal Block (Power 600V) Manufacturer's Standard
Terminal Block (General Purpose Feed-Through)
Marathon 1500
Terminal Block (Shorting) Marathon 1500
Terminal Strips Entrelec Phoenis Weidmuller Marathon 1500
Thermocouples RDF Temp-Pro YSI Inc. Rosemount Pyco Thermo-Electric
Page 27 of 33
Brown CCRT Exhibit E
Thermowell Connections Bonney Forge WFI WOI
Thermocouples
RDF Temp-Pro YSI Inc. Rosemount Pyco Thermo-Electric
Thickener (consultant) Codan Associates
Thickeners (slurry) Denver Dorr-Oliver Eimco
Timing Relays Agastat Series 7000 Agastat Series 7000, Intermatic
Tracing – Electrical Heat Chemelex Nelson Electric Thermon Manufacturing Raychem
Transducers (electrical) Moore Industries Rochester Instruments Scientific Columbus (Type VT110A2) Scientific Columbus (Type CT510A2) Transdata (Type 10PS501) Transdata (Type 10CS501) Woodex Model DCV-2000X
Transformers – Low Voltage Dry Type General Electric Hevi-Duty ABB Square D
Transformers – Power and Loadcenter ABB
Page 28 of 33
Brown CCRT Exhibit E Siemens
Square D General Electric
Transmitter (Flow) Rosemount – 3051 C or T Honeywell – ST 3000 Yokogawa – EJA Series Anderson Greenwood, Swagelock, PGI, or Rosemount manifolds
Transmitter (Flow – Non-differential Pressure Types)
Micromotion Brooks/Daniel Rosemount Yokogawa
Transmitter (Electronic Process) Rosemont Smart Endress & Hauser Honeywell Yokogawa Foxboro Smart
Transmitter (Level) Rosemount – 3051 C or T Honeywell – ST 3000 Yokogawa – EJA Series Anderson Greenwood, Swagelock, PGI, or Rosemount manifolds
Transmitter (Level) (4-20 mA) Magnetrol International Fisher Controls Milltronics Rosemount –3051 C or T Honeywell – ST 3000Yokogawa – EJA Series Anderson Greenwood, Swagelock, or PGI manifolds for DP style transmitters
Transmitter (Pressure) Rosemount – 3051 C or T Honeywell – ST 3000 Yokogawa – EJA Series Anderson Greenwood, Swagelock, PGI, or Rosemount manifolds
Transmitter (Vibration) Metrix Robertshaw Rockwell/Entek
Page 29 of 33
Brown CCRT Exhibit E
STI Bently Nevada
Truck Quick-Connect Camlok Tubing Fittings Crawford Swagelok
Parker Hannifin
Tubing – Grip Type Fittings Swagelok
Tubing - Socket-Weld Fittings Swagelok
Tubing – Manufactured Bundles O’Brien – Tracepak Parker – SL, IS, or CS Thermon – TubeTrace
Vacuum Belt Filters (Horizontal)
Metso Siemens F.L. Smidth
Valve Manifolds
Swagelok
Valves (Air) Clayton Mark- Pacific Lunkenheimer Powell Rockwell Edward
Valves (Water) Clayton Mark- Pacific Lunkenheimer Powell Rockwell Edward Velan Vogt Valve Technologies
Valves (Check – Insert Type) Keystone / Anderson Greenwood Power & Process (Technocheck) MGM
Valves (Check – Tilting Disc) Anchor / Darling Atwood & Morrill Pacific Townley Vogt
Valves (Ball - Manual) Anchor / Darling
Page 30 of 33
Brown CCRT Exhibit E
Edwards ITT – Engineered Valve Jenkins Neles-Jamesbury Parker Valve Technologies
Valves (Ball – Manual) For slurry drain at pumps
Xomox Jamesbury
Valves (Bronze - Manual) Jenkins Lunkenheimer William Powell
Valves (Butterfly - Manual) Anchor / Darling BIF Industries Dezurik Duriron / Durco Fisher Controls International Keystone Neles-Jamesbury Rodney Hunt (Allis Chalmers) Power & Process (Norris) Pratt
Valves (Diaphragm – Manual) Mfr’s Standard Shell and Seat Tests Required
Hill-McCanna ITT-Engineered Valve
Valves (Plug - Manual) Duriron/Durco Newcon Nordstrom/Tufline (Division of Xomox) Velan
Valves (Segregation and hopper isolation) DeZurik UCC Alstom Power ASH Fuller Bulk Handling Fabrivalve ITT Clarkson KGA (or KGD) Wye Valve
Valves (Manual - S.S. and C.S.) 2½ in. and larger
Anchor/Darling Crane
Page 31 of 33
Brown CCRT Exhibit E
Eagle Edwards Lunkenheimer Pacific Valves Velan William Powell
Valves (Manual – Slurry Control) Clarkson RKL Fujikin
Valves (Manual – Slurry Control or Isolation) Ceramic Ball
Fujikin
Valves (Cooling Water)
Apollo with Bettis Actuator
Valves (Safety and Relief) Consolidated Crosby Farris Lonergan Vickers Fulflo Fluid Controls Dyex-Rivett
Valves (Miscellaneous) Blowdown or Bleed Flush Water Valves
Tank Drains Slurry Feed and Bypass
Slurry Pumps Suction and Discharge Sample Valves
Gypsum Tank Inlet Pumps Drain
Newcon Knife Gage Durco T-Line or Durco Atomax Lined Ball Valves Newcon Fujikin Newcon Strahman Ram Valves Dezurik / Unival Ported Knife w/ Alloy Gate Durco Automatic Lined Ball Valves Xomox Lines Ball Valves
Page 32 of 33
Brown CCRT Exhibit E
Valve (Solenoid) (Type H) ASCO – EFHB8320G174xx (Brass ExP) ASCO – EFHB8320G200xx (Stainless Steel ExP) ASCO – JKH8320G172xx (Brass NEMA 4,<100 dp) ASCO – JKB8320G174xx (Brass NEMA 4)
Welding Consultants Nickel Development Institute Theilsch Structural Integrity Associates
Valves PreAction (Fire Protection) Match existing equipment
Vibration Monitoring Bently Nevada XL3300
Warning (Bells, Horns, Lights): Cooper Crouse-Hinds ESR2612 Federal Signal General Signal
Wall and Roof Panels Centria Fabral Morin
Weatherproof Coatings Manville “Insulkote”
Welding Outlets & Plugs Meltric DS100
Page 33 of 33
top related