core.ac.uk · the crystallisation and dissolution of lead sulphate and barium sulphate have been...
Post on 20-Oct-2020
2 Views
Preview:
TRANSCRIPT
-
https://theses.gla.ac.uk/
Theses Digitisation:
https://www.gla.ac.uk/myglasgow/research/enlighten/theses/digitisation/
This is a digitised version of the original print thesis.
Copyright and moral rights for this work are retained by the author
A copy can be downloaded for personal non-commercial research or study,
without prior permission or charge
This work cannot be reproduced or quoted extensively from without first
obtaining permission in writing from the author
The content must not be changed in any way or sold commercially in any
format or medium without the formal permission of the author
When referring to this work, full bibliographic details including the author,
title, awarding institution and date of the thesis must be given
Enlighten: Theses
https://theses.gla.ac.uk/
research-enlighten@glasgow.ac.uk
http://www.gla.ac.uk/myglasgow/research/enlighten/theses/digitisation/http://www.gla.ac.uk/myglasgow/research/enlighten/theses/digitisation/http://www.gla.ac.uk/myglasgow/research/enlighten/theses/digitisation/https://theses.gla.ac.uk/mailto:research-enlighten@glasgow.ac.uk
-
An Electrochemical Study o f the
.lisa tio n and D issolution
o f Sparingly Soluble S a lts .
A Thesis by
Dorothy M. S. L it t le , B.Sc. Supervisor, Dr» G. Ha Nancollase
presented for the degree of Doctor o f Philosophy
to
The University o f Glasgow, October, 1964°
-
ProQuest Number: 10984182
All rights reserved
INFORMATION TO ALL USERS The quality of this reproduction is dependent upon the quality of the copy submitted.
In the unlikely event that the author did not send a com p le te manuscript and there are missing pages, these will be noted. Also, if material had to be removed,
a note will indicate the deletion.
uestProQuest 10984182
Published by ProQuest LLC(2018). Copyright of the Dissertation is held by the Author.
All rights reserved.This work is protected against unauthorized copying under Title 17, United States C ode
Microform Edition © ProQuest LLC.
ProQuest LLC.789 East Eisenhower Parkway
P.O. Box 1346 Ann Arbor, Ml 48106- 1346
-
CONTENTS,,
PREFACE . . . . . . . . . . ................................. . . . . . . .
GENERAL INTRODUCTION . . . .
APPARATU S AND EXPERIMENTAL TECHNIQUE . . . . . . . . . . . .
Measurement of Resistance ..................... ...
; Control .................... . . . o
...... ....... . .. _. , ivx fcy Water •» . . . o . o o . o .
The conductivity Cell . *
Preparation o f Stock and Cell Solutions . . . . . . . .
Determination o f Concentration of Seed Suspensions . . .
Determination o f Cell Constant ..................... . . . . . . .
PART 1. C rysta llisation o f Sparingly Soluble S a lts . . . . .
INTRODUCTION . . . . . . . . . . ......................... . . . . . . .
PART l a . C rystallisation of lead Sulphate. .................... . .
INTRODUCTION................................................. .
EXPERIMENTAL . . . . . . . . . . ..................... . . . . . . . .
Preparation o f Solutions ............................. . . . . . . . .
Preparation of Seed Suspensions ........................ . .
Determination o f S o lu b ility ......................... . . . . . . .
RESULTS . . . . . . . . . . ................. . . . . ..................... .
Ionic M obility and Equivalent Conductivity . . . . . .
Equivalent Ionic Concentrations ..................... . . . . . .
In Presence of Adsorbates . . . . . . . . . . . . . . .
Non-equivalent Ionic Concentrations . . . . .....................
-
P-AEg_-lh.- C ry s ta llis a tio n of Barium Sulphate. . . . . . . . . .99*
INTRODUCTION . . . . . . . . . . . ............................. 0 100 „
EXPERIMENTAL .............................................................. .... . 102 .
Preparation o f S o lu t io n s ...................................... . . 9 I) • 102 .
Preparation of Seed Suspensions ..................... 9 102 .
T'flf .©r-sl i.TvS 1 t̂ T . » « • • • • » 9 9 . . 9 0 0 103 o
- ................. .... • 105.
Ionic M obility and Equivalent Conductivity • O 9 O 0 • • 105.
Equivalent Ionic Concentrations ..................... O 9 • • • 107.
DISCUSSION OF RESULTS ..................... ........................ .... . • - 116 o
PART 2. D issolution o f Sparingly Soluble S a lts „ 9 9 9 « 9 © o 127.
INTRODUCTION . . . . . . . . . ................. . . . . • O O 9 e 0 9 128 o
PART 2a D issolution of Lead Sulphate . . . . . o • • 132c
INTRODUCTION ................................. . . . . . . . . . • • 132c
EXPERIMENTAL . . . . . . . . . . . . . . . . . . 0 9 9 C « • • 135 c
Preparation o f Seed Crystals . . . . . . . O 9 9 9 o 0 - 135«
Preparation of Cell Solution ......................... 0 ° 0 135 o
RESULTS . . . . . . . . . . . ...................................... • 0 135.
Equivalent Ionic Concentrations . . . . . . © 0 136 .
In Presence o f Adsorbates . . ..................... . 9 9 O © 9 - • 137 o
PART 2b. D issolution o f Barium Sulphate . . . • 0 153.
INTRODUCTION ® . . . o « . o » . . e o o 6 < > . < > o O fi O 0 • . 0 15/,»
EXPERIMENTAL . . . . . . . . . . . . . . . . . . O 0 0 9 • • . 156.
Conductimetric Technique . . . . . . . . . . 0 156.
Radiochemical Technique .......................................... . . . . . . . 156.
-
Iso to p ic Tracers . . . . . . . . 156.
Counting Technique . . . . . . . . . . . . . 157.
P reparation o f Labelled Seed Suspensions . . . . . . . . 0 157.Experimental Technique ..................... . . . . . . . . . . . . 15B.
RESULTS ..................................... 160 .
160.
DISCUSSION OF RESULTS . . ................................................................. . 180.
BIBLIOGRAPHY . ................. . . . . . . . . . . . . . 189.
-
The c ry sta llisa tio n and d isso lu tio n o f lead sulphate and
barium sulphate have been studied by following the change in
conductivity which occurs when supersaturated or subaaturated
so lutions o f these s a lt s are inoculated with seed cry s ta ls» The
d isso lu tion in to water o f barium sulphate crystals* lab elled with
^Sulphur has a lso been studied by a radiochemical technique*
In P art 1 o f t h i s th esis* essperiments on th© c ry s ta l l is a t io n
o f lead sulphate and barium sulphate are described,. Th© growth of
u tions has been found to follow
a second order ra te law, which i s preceded, in th e case o f lead
su lphate , by an i n i t i a l growth surge, o f order g rea te r than two*
This surge has been interpreted in terms o f two-dimensional
nueleation on the surface o f the added seed crystals* The
c iy s ta llisa t io n of lead sulphate from supersaturated so lu tio n s
containing non-equivalent ion ic concentrations of lead and sulphate
has a lso been studied*
Sodium dodecylsu lphate , sodium pyrophosphate, sodium trim e ta
phosphate and sodium tetrametaphosphate have a l l been found to re ta rd
th e r a te o f growth, and i f p resen t in s u f f ic ie n t ly high concentrations,
to stop i t en tire ly * I t was observed th a t th e duration a id apparent
k in e tic order o f the i n i t i a l growth surge increased w ith increasing
concentration o f im purity , and th i s was raor© pronomeed when th©
conductiv ity w ater used had been prepared by an ion-exchange method
-
ra th e r than by d is t i l la t io n * Th® ad d itiv e i s assumed to be p re fe ren tia l
adsorbed a t ac tiv e s i te s on th e crystal su rface , and thus fewer s i te s
are available for normal second order growth* Fresh s it e s have
therefore to be created by surface nucleation* I t would seem that
some organic matter i s leached o f f the ion-exchange resin* and th a t
th is a lso occupies some o f the available growth sites* thus enhancing
the need for two-dimensional nueleation.
The growth o f barium sulphate has been studied at various temper
atures ranging from 15° - 4 5°C» 9 and a value for the energy of activ a te
for growth was obtained; E == 8 KhCals* / mole*
js essperiments on the d isso lu tion of
j.eaa suxpna'66 and uarxum sulphate* The d isso lu tion of both sa lts
in to subsaturated so lution , and o f barium sulphate in to water, has
been found to follow a second order rate law, a f te r a small in i t ia l
surge o f order greater than two* Anionic a&sorbates have been found
to retard the rate o f solution o f lead sulphate, although the
concentration required to stop i t almost en tire ly was considerably
greater than for growth*
Barium sulphate d isso lu tion in to water has been investigated
conduct imet r ic a lly and radio chemically at various temperatures between
15° and 45°Go, and the energy o f activation for d isso lution i s
approximately 12 K.Cals. / mole*
-
K inetic Studies o f tha Precipitation and
D issolution o f Sparingly Soluble
E33BctrolyteSo
Interest in cr y sta llisa tio n dates from the 8 th Century, when
re cry s t a l i i gat ion was found ter be u sefu l as a method o f p u rifieation 0
In 1691, Robert Boyle noted the m odification o f crysta l habit by
the rate o f deposition from so lu tion , while in th e 19th Century,
Sveigger ( l ) rea lised that a certain minimum s is s o f seed crysta l
was necessary in order to in it ia t e erystaXlis&tiono
Modem in terest in the subject, however, dates from 1897* when
Ostwald (2) determined that the upper lim it for the e ffe c tiv e s ize
o f a nucleating crysta l o f sodium chlorate was 10**^ grams 0 Modem
theories o f growth s t i l l incorporate many o f Get w all5a id eas, thus
he was th e f ir s t to recognise that there are two c l e a r l y defined
regions o f supersaturation, th© metactable and th e l a b i l e 0 In th©
former region, no nueleation m ill take place unless i t i s induced by
mechanical shock, ©r ad.dit5.on o f seed cry sta ls | as the supersaturation
-
i s increased* hcwavox', a m etastable l im it i s reached* beyond w
immediate nueleation tak es p lace 0 Work in t h i s la b i le region
d i f f i c u l t to reproduce, since suwh fac to rs as d u s t, age and h i
o f th e so lu tio n s , contact w ith the w alls o f th e containing ver
have a l l been shown to induce spontaneous nucleation
O rig in a lly i t was believed th a t growth and d isso lu tio n ah
be rec ip ro ca l processes, but th i s was disproved by Marc (4,5)■
found th© rat© o f d isso lu tio n to be very much fa s te r than th a t
c r y s ta l l i s a t io n , and th i s was supported by th e re s u l ts o f Leht
Scbmandt ( 6)0 From a study o f the growth ©f seod c ry s ta ls ' f r r
supersatu rated so lu tio n , using a o o n d u ctiastric technique, May
le d to propose th a t a t low values o f supersa tu ra tion c ry s ta l! :
was a second order reaction* He in te rp re te d th© k in e tic s in v
©f a very th in adsorbed layer* probably ©f m olecular dimension
which ex is ted a t th e c ry s ta l su rface„
More recen tly Davies and Jones (?) hav© reached a s im ila r
from th e i r study o f s i lv e r ch loride 0 Bircumshau and R idd ifo rr
proposed th a t th e steps a t th e c ry s ta l - so lu tio n in te rfa c e wr
f iv e -fo ld s -
1- Transport o f so lu te t© the interface*
2- Adsorption o f so lu te a t the in te r fa c e *
Chemical reac tio n a t the in terface*
4=f» Desorption ©f products from th e interface*
5- Transport o f so lu te from th e in te rfa c e to the bulk o f ‘
-
E ith e r growth ©r d isso lu tio n would take p lace , depending ©n th
re la t iv e ra te s o f th© s te p s„
Davies and Jones (7) have combined s teps 2,3 and 4 to glv
o v e ra ll in te rfa c e co n tro l step* and proposed th a t in c ry s ta l l !
2 i s f a s te r than 4 * while the reverse holds fo r d isso lu tion*
id ea has been supported by Turnbull (9 ) , Doremus (10) and GIBc
and Johnson {I I ) * Turnbull has studied th e p re c ip ita tio n o f 1:
sulphate, using a conductimetric technique * He found th a t in
e a r l ie s t s tages o f p re c ip ita tio n th© rat© o f growth o f th© cry
was independent o f th e i r s iz e , and lim ited by a reaction a t t h
c ry s ta l - so lu tio n in terface; a f te r th© c ry s ta ls reached a cer
size* however, d iffusion became th e co n tro llin g mechanism^ Be
derived growth equations fo r an in te rfa c e co n tro lled process*
found good agreement with the experimental r e s u l ts reported f t
s i lv e r chrooate, strontium sulphate and barium sulphate* OeRc
and Johnson, in a study o f barium sulphate p rec ip ita tio n * a r r i
a s im ila r conclusion*
On the o ther hand* C ollins and Leineweber (1 2 ), who a lso
in v es tig a ted barium sulphate p re c ip ita tio n , concluded th a t d i i
was th e r a t ©-contro ll in g p rocess, and interpreted t h e i r re su lt
terms o f a theory o f two-dimensional surface nueleation on lev
p lanes, proposed by Becker and Boring (l3 )o
Gibbs (14) suggested th a t a p e rfec t c ry s ta l should grow 1
repeated two-dimensional nueleation of new la y e rs , with the pc
-
©f each nucleus providing a growth s te p a t which molecules could
incorporated In to th e crystal* Thus, energetica lly* th e re should
a c r i t i c a l supersa tu ra tion below which th e c ry s ta l should not grc
Voimer and Schultzs (1 5 ), who found a number o f systems in. which
such c r i t i c a l supersa tu ra tion e x is ted , suggested th a t th e re was a
mobile se lf-absorbed la y e r in thermodynamic equilibrium with the
c ry s ta l surface* Frequent c o llis io n s would be expected between
co n stitu en t p a r t ic le s in th i s la y e r , and from th ese the germ -rf
two-dimensional c ry s ta l could be formed, which would a tta c h i
to th e l a t t i c e plane below*
Frank (1 6 ), however, suggested th a t the surfaces of re a l ©
are ra re ly p e rfec t , n early always containing d islocations* T:.i- ■
presence o f a d is lo ca tio n which term inates in the c ry s ta l sur p
ensures th a t th e re are always exposed m olecular te r ra c e s on w
growth can tak e p la ce ; assim ila tio n o f th e so lu te occurs a t k
th e growth steps* Hence, th e need fo r two-dimensional nuclea
does not a r is e a t low supersaturationso Indeed, Burton* Cabror.-
Frank ( l? ) have p ostu la ted th a t a su p srsa tu ra tio n g rea te r tba- •'
necessary before surface nueleation w ill take places below th •;
value screw d is lo ca tio n s should be th e only source of growth \lv
However, when d iffu s io n In th© medium i s o f importance, owrfa^
nueleation would be expected to occur a t the corners o f the cry:
re su ltin g in d en d ritic branching (IS) * In many cases the gro I !
-
c ry s ta ls i s slower than p red ic ted by th is theory, and Burton, «
and Frank have suggested two p ossib le reasons:
1) That there are too many d islocation s to© close togeth?
preventing a c r it ic a l nucleus from passing between th e s p ira ls
or
2) That th e re are not enough d is lo ca tio n s in th e c ry s ta l
The authors favour th© l a t t e r a l te rn a t iv e , although 'Cabrera an:
YermiXyea (19) believ© th a t on© d is lo c a tio n should ho euffiele*
to grow a la rg e crystalo
Albon ( 20) considered th a t in the in i t ia l stages o f grout:'
from a nucleus o f c r it ic a l sis© th© c ry s ta ls are probably d ia l '
free , sine© th i s would enhance th e ir s ta b i l i ty , but th a t coota*
between the crysta ls would resu lt in th e formation o f d is lo e a t
Frank -(18), on the o th er hand, a t tr ib u te d the m ajority ox d i a l
to im p u rities in the cry sta ls , and evidence fo r th i s has boon
provided by Hewkirk ( 21 , 22) from the growth o f cadmium Iodide,
Much experimental evidence has been produced in support v.
Frank* s d is lo ca tio n theory o f growth, thus Soars (23) has obee:
potassium chloride and mercury whiskers to grow by dislocation
Newkirk ( 21) has found a s im ila r phenomenon with cadmium iodick-
while Reynolds and -Greene (25) have shown th e growth of oadndv
sulphide c ry s ta ls from the vapour to proceed by a d is lo ca tio n
mechanism*
-
On tha o ther hand* O-Eourko and Johnson (11) end Hieloo.
believe th a t the growth of barium sulphate proceeds by 8 two-
dim ensional surface nueleation mechanism, re su ltin g in a fou
order ra te law, whereas, in stud ios o f n ea r-p e rfec t c ry s ta ls
Sears (24 , 27, 28) has found both the Frank mechanism and g:o
by two-dimensional nueleation to be operative on d iffe re n t p
o f a s in g le crystal*
Since p re c ip ita tio n i s so important in q u a n tita tiv e ino
an a ly s is , most o f th e work has been done on spontaneous
c r y s ta l l i s a t io n from th e la b i le region o f supersaturatiozio
p re c ip ita tio n s have often been found to ex h ib it an induction
during which nucleus formation was assumed to be proceeding,
th e o re t ic a l analyses o f spontaneous c ry s ta l l is a t io n have rax;
the build-up o f a c r i t i c s ! nucleus as a s te a d y -s ta te process
co n sis tin g o f stepwise incorporation o f ions in to ion-embryo
G hristiansen (29) has shorn th a t delays in nueleation may bo-
a n tic ip a te d on th e b as is o f the re lax a tio n time required fo r
attainm ent of the s tea d y -s ta te concentrations o f the embryo'
evaluation o f th i s re lax a tio n time i s p ro h ib itiv e ly d i f f ic u !
C ollins (30) however, has developed a so lu tio n with which f
re lax a tio n time can ba determined from experim ental values o
surface ten sio n , supersa tu ra tion and m olecular encounter
frequency 0
Yon Weimam (31) suggested th a t the ra te o f p ree ip ita t.b
-
and th e number of p a r t ic le s was p roportional to the degree of
supersa tu ra tio n a t th e time of p rec ip ita tio n * C hristiansen and
N ielsen (32) have developed a sim ilar idea, and have shown th a t
the tim e o f c ry s ta l l is a t io n varied in v erse ly as some s ig n if ic a n t
power o f th e i n i t i a l concentration ,
k - c0P T ,
where e0 i s th© i n i t i a l concentration of the supersaturated so lu t
T i s th e induction period , and k and p -a re constan ts , p being the
number o f ions requ ired to form th e c r i t i c a l nucleus* This the or
p re d ic ts a constant nucleus sis® , with l i t t l e dependence o f the
nuelea tion rat© on th e supersaturation5 the c r i t i c a l nucleus i s
therefor© r e la t iv e ly small * Indeed, values (32) o f 8 , 9 and 6
fo r p have been obtained fo r barium su lphate , calcium flu o rid e
and s i lv e r ch lo rid e , respectively* K lein , Gordon and Walnut ( 33)
using a sim ilar re la tio n sh ip , found a nucleus o f five ions to ha
in d ica ted fo r s i lv e r chloride*
These views are in d ire c t co n tras t w ith th® theory o f
Vo3jbq3$ and Becker and Doring, in which i t i s assumed th a t the
su p ersa tu ra tio n i s b u il t up slowly and homogeneously u n t i l a
c r i t i c a l super sa tu ra tio n I s reached* This would re su lt In a fair-
la rg e nucleus* Support fo r th i s theory has been given by Duke an
Brown (34) who concluded th a t a nucleus o f s u ff ic ie n t s ize to bo
stable in contact with a supersaturated so lu tio n should contain
-
sev era l ten s o f io n s , and by La Mar and Dinegar (3 5 ), who ca lcu la ted
th a t the rad ius of th e c r i t i c a l nucleus fo r 'barium sulphate web 0 .01/11
I f spontaneous c ry s ta l l is a t io n occurs by homogeneous
nuelea tion and growth, th e question then a r is e s as to whether
n u e lea tio n has ceased before growth s e ts in , or whether th ese process©
tak e p lace concurrently . C ollins and Leineweber (1 2 ), Turnbull (9) s
and Dorsmus (10) a l l favour consecutive p rocesses, with nueleation
tak ing p lace in an i n i t i a l b u rs t, and followed by growth th e re a f te r .
C hristiansen and N ielsen , and OsRourke and Johnson, however,
believe th a t n ueleation and c ry s ta l l is a t io n occur sim ultaneously?
and Johnson and O’Rourke (3 6 ), who studied barium su lphate ,
derived equations fo r the two processes. They represented the
i n i t i a l p a rt of the p re c ip ita tio n by a re la t io n accounting fo r
simultaneous n ueleation and growth, and a good f i t with
experim ental d a ta was obtained fo r the f i r s t s ix minutes o f the
re ac tio n . For th© remainder o f th© p re c ip ita tio n they assumed
th e nueleation rat© to be n e g lig ib le , and developed a ra te
equation involving only growth on a fixed number o f p a r t ic le s .
Once again they obtained good agreement w ith th e experim ental
r e s u l t s .
Many o f these workers, however, have considered th a t the
p re c ip ita tio n was not tak ing place purely by a homogeneous prcnesfj.
In experiments where the supersaturated so lu tio n is prepared by
-
lo ca l concentration excesses, which would favour nucleationo
La Msr and Dinegar (3 5 ), in an attempt to overcome th is objection,
studied the precip itation o f barium sulphate, and produced sulphate
ions in s itu by the reaction
+ ^S2°3^~—> 2S0^^“ + ,and .obtained constant values for the c r it ic a l supersaturation0
C ollins and Leineweber, however, using a sim ilar technique, conclud
that even in th is ease the nueleation was heterogeneous, since
they found the value of the c r it ic a l supsrsaturation to be
strongly dependent on the purity o f the reagents, and other
workers have supported these ideas0 N ielsen (37) found that
steaming out o f the reaction v esse l prior to use reduced the
number o f nuclei formed by a factor o f ton, and Fischer even geos
as far as to predict that pure homogeneous nueleation cannot, be
aehievedo
Thus there are many factors which a ffect the v a lid ity of
studies o f spontaneous cry sta llisa tio n , and which make reprodueibiX
almost impossible o I t i s obviously more informative to study
cry sta llisa tio n under conditions which ensure that only growth,
or only nueleation , i s taking p lace6 This can be done very
e a s ily by the method exploited by C» W. Davies and h is co-workers,
who prepared supersaturated solutions of s ilv er chloride which
remained stable u n til seed crysta ls were added (7 , 38 ~ 40) A ll
-
growth then took place on these c ry s ta ls (41) $ and th e ra te of
c ry s ta l l is a t io n was measured conductim etricaH y0 This technique
has been su ccessfu lly extended to s i lv e r chromate (42) , magnesium
oxalate ( 43) 9 and s i lv e r iodate (44)°
The d isso lu tio n o f many e le c tro ly te s has been shown to
follow a f i r s t order ra te law® This has been in te rp re te d in terms
o f d iffu s io n o f so lu te away from the hydrated c ry s ta l surface 0
D iffusion con tro l has been observed fo r most systems, but some
exceptions have been recorded, a t tem peratures o ther than 25o0°(45)°
This th e s is i s in two p a r ts , th e f i r s t describ ing a study of
th e k in e tic s o f c ry s ta l l is a t io n of lead sulphate and barium,
sulphate® Measurements have been made in the presence of added
im p u ritie s , to t e s t the adequacy o f the e x is tin g th e o rie s when
th e re i s adsorption on the surface o f the crystals® Barium
sulphate growth has been studied a t various tem peratures, from
15° ~ 45°Go
Th© second p a r t o f th© th e s is i s concerned with a study of
th e d isso lu tio n o f lead sulphate in to eubsaturated so lu tio n a t
25°Go, and a lso in th e presence o f adsorbates® The d isso lu tio n
o f barium sulphate in to water a t tem peratures ranging from
15° - 45°C« has a lso been in v es tig a ted , both conductim etrically
and by a rad io tra c e r method® D isso lu tion in to subsaturated
so lu tio n a t 25°0* has been followed®
-
Apparatus end Experimental Techniqueo
Th© c ry s ta l growth o f lead sulphate and barium sulphate from
supersatu ra ted so lu tio n s has been xollowedo Supersaturated
so lu tip n s o f lead sulphate were prepared by mixing sodium sulphate
and lead n i t r a te so lu tions o f known c o n ce n tra tio n s S im ila rly ,
fo r barium su lphate , supersaturated so lu tions were prepared from
sodium sulphate and barium ch lo rid e0 The ra te o f c ry s ta l l is a t io n
a f te r inocu la tion with seed c ry s ta ls was followed by measuring
th© decrease in conductiv ity with time*
D isso lu tion o f lead sulphate in to subsaturated solution,, and
of barium sulphate in to water and subsaturated so lu tio n s , fcavo
been stud ied in the same manner* In ad d itio n , d isso lu tio n of barii
sulphate in to water has been studied by a radiochem ical method.,
using 3f>Sulphur as tracer*
Measurement o f R esistances
An a-c screened Wheatstone network o f th e type d e s c r ib e by
Jones and Joseph {46) and Shedlovsky (A7) was used fo r the
conductiv ity measurements ( f ig D l ) 0
% was the conductiv ity c e l l , B2 a S u llivan and G rif f ith s
non-reactive resistance, box, reading from 0*1 to 10,000
The r a t io arms E3 and were provided by a Sullivan high
frequency 100 ohm decade potentiom eter, subdivided in to four ck-^4
-
'IK
B
R , R
Fi gur e 1.
-
from 0.01 to 100 ohms. To enable readings to be made to 0*001 ohms
th e bridge was made more se n s itiv e by th e add ition of a 1*2 ohm
Pye p rec is io n s lid e wire in se r ie s with the decade potentiometer*
Since th e c e l l i t s e l f behaves as a condenser, a v ariab le
S u llivan s ta b le decade mica condenser, C j, reading from 0 to 1/cF.,
was= connected across % or R2 to balance out any capacity e f fe c ts
between the e lec tro d es , and between the e lec trodes and the c e ll
wallo In p ra c tic e , the condenser was always connected across
The output from the bridge was am plified by a high gain mains
operated am p lifie r (EXesco E lec tro n ics Limited)* A mains operated
v a riab le frequency o s c i l la to r (Advance model H - l ) was used as a
source of frequency* A frequency of 1000 cycles p er second was
normally used, th i s being the optimum fo r au ra l detection*
Earthed and screened leads connected th© o s c i l la to r to a balanced
and screened S u llivan transformer* This transform er was designed
to screen th e supply source from th e bridge without a ffec tin g tho
balance o f th e l a t t e r to earth* The transform er was connects to
the bridge by screened, earthed leads*
A modified Wagner Earth o f the type described by Joneo and
Joseph ( 46) was employed to ensure th a t the telephone ear-piene
was m aintained a t ground p o te n tia l , so th a t th e re was no
o f current between th e telephone c o ils and th© operator# who
Wagner Earth (fig* l ) i s represented by the re s is ta n ces R^,
-
v ariab le condenser Gg and s lid in g contact go One© the bridge was
balanced in th e usual way, the d e tec to r , D, was connected to ground
by switch S^,R^ and R ̂ were then ad justed through the contact g 9
so th a t R^/ R ̂ = R j/ R^, thus ensuring th a t B was a t e a rth potent la
The bridge was again balanced and the process was repeated u n t i l
no change in th e sound minimum was observed between successive
measurements*
The c e l l was brought In to c ir c u i t by two copper leads s tre tc h !
from th e platinum - mercury contacts o f the e lec trodes to mercury
cups supported in the thermostat* The copper leads were o f equal
len g th to compensate fo r th e i r re s is ta n c e , as were screened leads
from th e mercury cups to the re s is tan ce box Rgo Th© mercury cups
were kept in the therm ostat to ensure th a t they were a t the same
tem perature as the cell*
When water and so lu tions o f high re s is tan ce were being moa&urs-
a 10,000 ohm non»re&ctive standard re s is tan ce was connected in
p a ra l le l with the cell*
-
Thermostat and Temperature Con t r o l8
A ll conductiv ity experiments were ca rrie d out in a constant
tem perature room, maintained a t 250Co$ th is prevented condensation
on th e c e l l cap* Th© c e l l was placed in a la rg e earthed and heat
in su la ted m etal tank , f i l l e d w ith transform er o i l , to reduce capacity
e r ro rs (46)0 Tho o i l was s t i r r e d by an e ffe c tiv e ro ta ry paddle
s t i r r e r , to ensure an even tem perature was m aintained throughout
th e tank* The tem perature of the bath a t 25°Co was co n tro lled
to ± dQ05°Go by a mercury - toluene s p ir a l reg u la to r, f i t t e d with
a Sunvic p roportionating head* Heat was supplied by a 60 watt
bulb , and a continuous stream o f cooling water passed through copper
c o ils immersed in th e bath*
Experiments a t 15°, 35° and 45°G« were ca rried out using a
w ater f i l l e d therm osta t, which was f i t t e d with a booster heater
and a re fr id g e ra tin g u n it to a s s is t in tem perature control* The
conductiv ity c e l l was held in a small box, which contained
transforms]? o i l , to elim inate the capacity e f fe c ts discussed
previously® Temperature con tro l was maintained to ± 0o01°Co at
15°, 35°, and 45°Co Measurement of a l l tem peratures was made with
Beckmann thermometers which had been standard ised against a
c a lib ra ted platinum re s is tan ce thermometer (48)*
During experiments a t 35° and 45°G# th e tem perature of th©
a i r in th e v ic in i ty o f the top of the c e l l was ra ised by means of
-
two 60 watt red bulbs, to prevent condensation on the c e l l cap*
Seed suspensions for use at 25°C« were aged in the constant
temperature room. Those for use at other temperatures were
maintained at the required temperature for a few days prior to
use*
P reparation o f Conductivity Water*
The early part o f the work was don© using deionised water,
which was prepared by passing d is t i l le d water over a mixed«*bed
resin (4 9 ). Two resins were used:
1) Amberlite IR 120 ( H) acid re s in and Amberlite IRA 400
b asic re s in , mixed in a proportion of 1 j 2 by volume* With such
a column an in tim ate mixture was e s s e n tia l , so th a t H* ions
l ib e ra te d from the re s in by exchange o f ca tions ware immediately
n e u tra lised by OH” ions l ib e ra te d from the basic re s in by anions*
2) Perm utit ”Bioderninrolitn which i s supplied ready fo r use
as both a ca tion and an anion exchanger*
Water obtained in th is way was sto red in a pyrex f la sk , f i t t e d
with a eoda-lime guard tube to exclude carbon d ioxide. The
s p ec ific conductiv ity o f th i s w ater v aried from 0.03 to 0*3 x 10
rec ip ro ca l ohms.
In l a t e r experiments a gas f ir e d Bourdilloa s t i l l with a t i n
fra c tio n a tin g column was used fo r preparing conductiv ity water, to
-
ensure th a t i t was free from contamination by organic im purity0
The supply of pure a i r was obtained by passing compressed a i r
through tubas f i l l e d with g lass beads| two o f the tubas contained
a 30% potassium hydr02ri.de so lu tio n , and the l a s t contained water*
The sp e c ific conductiv ity of th i s water was 0*2 to 0 .6 x 10”
rec ip ro ca l ohms*
L a tte r ly , water from an e le c t r ic a l ly heated a l l -g la s s s t i l l ,
constructed on th e model of th e Bourdillon s t i l l was used* This/!
gave water w ith a sp e c ific conductiv ity o f 0*3 to 0o6 x 10
rec ip ro ca l ohms*
Th© Con d u c tiv ity Cell*gj.»«i»MKijmtAr.',jiif>HMta*iaa>rMKciaPnafiWTrittti4n^m,iV> . Ml' ‘‘JH h .-..ntnirMW
Th© conductiv ity c o ll was o f th e type described by H artley
and B arre tt (5 0 ), and was constructed from pyrsx glass* The -"body
was supplied by Q u ick fit, and had a B*55 ground g lass jo in t a t the
neck* The cap c a rrie d the e lec tro d es , an apertu re through which
th e s t i r r e r passed, another fo r add ition of so lu tio n s , and a
h o rizo n ta l side arm f i t t e d with a ta p , through which carbon diorido
free n itrogen was admitted ( P la te l ) »
Th© e lec tro d es were of greyed platinum , perfo ra ted to ensure
s t i r r in g of th e so lu tio n between th e p la te s , which were held firm ly
a t a fixed d istance by four small pyrex g lass rivets® Th© Gleetroeb
-
P l a t e 1..
-
were ca rried by platinum wires which were fused into the glass
supports 5 but since i t i s not possible to make a perfect platinum «•
g la ss sea l, a l i t t l e powdered Araldite thermosetting epoxy resin
was se t in th e bottom o f each support® This was l e f t overnight
at 60°Go to fuse , and then allowed to cool slow ly, making a
permanent seal® The electrodes were situated near the wall of the
s o i l 3 and th e i r supports were fixed to the cap by two Be 10 Q uickfit
jo in ts , and sealed in to p o s itio n with Araldite® Alignment o f a
mark on c e l l and cap ensured th a t the electrodes were placed in the
same p o sitio n re la t iv e to th e o u ter con tainer for each experiment®
•Stirring was supplied by a Yibroraix motor (Shandon S c ie n tif ic
Company)5 the a c tu a l s t i r r e r being a c irc u la r glass d isk , perforated
'with conical holes and fused to a g lass rodo The maximum amplitude
o f the o s c il la t io n s was 0*03 inches, and the rate o f s tirr in g could
be v aried widely® With th i s type o f s tir re r i t was possible to
ensure th a t the d isc was in the same place re la tiv e to the electrodes
in every experim ent.
The c e l l was kept free of carbon dioxide by the passage of
a continuous stream of nitrogen, which was introduced through the
side ana® A dust cap sealed the aperture through which additions
of solutions were made, and dust was prevented from entering through
the s tir re r aperture by a rubber te a t .
-
P reparation o f Stock and Cell Solutions®
Pyrex g lass apparatus was used in th e p reparation and sto rin g
o f a l l solutions® P ip e tte s were of Grade A standard® Flasks were
cleaned with chromic acid and steamed out p r io r to use; they were
f i l l e d with d i s t i l l e d water when not in use®
Solids were weighed in pyrex sample tubes on a Stanton Model S.M d
balance, using platinum p la ted weights® Solutions were made up by
weight from conductiv ity w ater, using a S a rto riu s balance o f 2 Kg®
cap ac ity , which was sen s itiv e to 0 e0Q5go The weights fo r both
balances had been ca lib ra ted by the method of Kohlrausch ( 51) , and
a l l weights were vacuum corrected®
Analar s a l t s were used throughout, and potassium chloride used
in c e l l constant determ inations was re c ry s ta l l is e d th ree tim es from
conductiv ity w ater. Stock so lu tio n s were prepared by weight from
conductiv ity w ater. D ilu te so lu tio n s were fre sh ly made up fo r each
experiment from these stock so lu tio n s , the concentration of the
former being such th a t 10 ml® added from a c a lib ra ted p ip e tte to about 300 g® o f conductiv ity water in the c e l l would give a c e l l
so lu tio n of the required concentration® The d ilu te so lu tio n s were
prepared by weight from the stock so lu tions in exactly th e same
way.
A ty p ic a l experiment involved washing the c e l l thoroughly with
d i s t i l l e d and conductiv ity w ater, f i l l i n g i t w ith conductiv ity w ater,
-
and weighingo I t was then placed in the therm osta t, and carbon
dioxide was removed by passing n itro g en , which had been p resa tu ra ted
with water a t 25°C*, in to the c e l l . Mien tem perature and carbon
dioxide equilibrium had been reached, the d ilu te so lu tions were added,
th e second one drop by drop over a period o f 5 - 10 m inutes, to
prevent the formation of high lo c a l concentrations which would
favour spontaneous n u d e a t ion® A fter each add ition th e c e l l was
allowed to come to equilibrium, again® The conductiv ity would then
remain steady fo r 24 - 4-8 hours, but in p ra c tic e , seed c ry s ta ls
were u su a lly added a f te r one hour®
Carbon dioxide was removed from the seed suspension before
ad d itio n to the c e l l by passing a rap id stream of n itrogen over i t
fo r 30 - 60 minutes® The seed c ry s ta ls were added to the c e l l from
a rap id de liv ery pipette® Zero time fo r the reac tio n was taken
as the time when h a lf o f the seed suspension had reached the c.ell
contents® The change in conductiv ity was determined a t minute in tervali
a t the s ta r t of the experiment, then a t 15 minute and l a t t e r ly a t
30 minute intervals® Many runs were followed fo r 24 hours or more.
Determ ination o f the Concentration of the Added Seed Suspensions.
, The concentration o f each p reparation of seed c ry s ta ls was
determined by f i l t r a t i o n o f a 5 ml® sample through a number 4- s in te r ,
drying and weighing. G enerally, the average o f th ree such estim ations
-
was used.
In l a t e r work, when very high concentrations of seed suspensi
were being used, i t was d i f f i c u l t to add a reproducible amount of
so lid to each experiment. The concentration o f seed c ry s ta ls aclde
in each run was then determined by f iltr a t io n o f the f in a l c e l l
so lu tio n , in the manner described above.
Determ ination of Cell Constant.
The c e l l constant was determined by the method o f F raser t i
H artley (52)* Thrice re c ry s ta ll is e d potassium chloride was used,
in the p reparation of the stock so lu tio n s . A small quan tity of f t
pure m ateria l was heated In a platinum crucib le to a d u ll red heat,
fo r about 10 m inutes, and allowed to cool in a desiccator- About
Xgo was then weighed out in a pyrex sample tube and the re su lt:’ v
stock so lu tio n was approximately decinormale
The c e l l was weighed, and then about 250g„ conductiv ity wnto.v
were added® I t was then allowed to come to carbon dioxide and
tem perature equilibrium ; th i s was u su a lly a tta in e d in 2 - 3 hours,
and re s is ta n ce readings would then remain constant fo r 24 hours
o r more0
Once the conductiv ity had remained steady fo r about one he i ■
add itions o f the stock so lu tion of potassium chlorj.de were made to
-
th e c e l l , using a weight 'burette . Equilibrium was u sually reached
again a f te r about 20 - 30 m inutes, when th e re s is tan ce was measured.®
The re s is ta n ce box Rg was ad justed u n t i l the balance p o s itio n was
close to th e cen tre o f the r a t io arms and R^y Values o f both
R3 and R ̂ were obtained, and the value o f R2 was then changed by-
f iv e ohms, and two fu rth e r readings made on th e r a t io arms. The
average conductiv ity value was ca lcu la ted from both p a irs of r a t io
arms read ings, and then corrected fo r the water re s is ta n ce .
Further add itions from the w ig h t b u re tte were mads u n t i l the
concentration of potassium ch loride in the c e l l was about QoQQllu
The c e l l was removed, and a f te r i t s outer surface had been cleaned
and d ried i t was weighed again®
The c o ll constant was ca lcu la ted by comparing each measured
value with the conductiv ity derived by Shedlovsky (5 3 ), a t the same
concentration , using the in te rp o la tio n formula
A = 149o92 - 93o85 C2 + 50c
where A i s the equivalent conductiv ity o f potassium chloride of
norm ality e (54)• The value o f the c e l l constant for each c e ll
used was obtained from a t le a s t twelve determ inations ( th re e series)®
Cell A had a c e l l constant o f 0.0700 t 0ol%
Cell B had a c e l l constant o f 0.07124 - 0«1%
Cell D had a c e l l constant of 0 o06949 * 0 ol%
Cell E had a c e l l constant of 0 o07312 * 0*1%.
-
The conductiv ity technique described above was used in the
f i r s t two p a r ts o f th i s work. The radiochem ical technique used
i s described in d e ta il in part 2b,
-
EM .JU C rystallisation o f Sparingly Soluble Salte
la .
lb .
in Aqueous Solutions,
M M .SuljaM ae.
Bariwa Sulphat e .■ w .iumini)i »iaW « » ti < w n w i q r n «»WB«KUMcai
-
INTRODUCTION.
An equation o f the type
- 5fl = k s (m - m0)n . * . o . o ( ldt
*where k i s the ra te constan t, s i s a function o f surface a rea , »>
the instan taneous io n ic concentration , mQ i s th e s o lu b il i ty vali
and n the order o f the re ac tio n , has been generally accepted as
rep resen ting the cry sta llisa tio n process, but opinions have d ifx
about the value o f n. Values o f 2, 3 , 4 and even 8 (32) have b'
repo rted , and each explained by a d iffe re n t mechanism o f cry s i a
growtho Values o f n g rea te r than 2 , however, have generally bs
obtained from s tu d ies of nucleation ra th e r than growths
In a study o f th e growth o f s i lv e r ch loride seed c ry s ta ls ,
Davies and Jones (7) found a value of 2 for n , and in te rp re te d t
k in e tic s in terms o f an adsorbed monolayer o f ions a t the crysta
surfaceo They made the follow ing two assumptions?
(1) A c ry s ta l in contact with an aqueous so lu tio n always
tends to be covered with a monolayer of hydrated ions, and secon-
adsorption on th is monolayer i s n eg lig ib le .
(2) C ry s ta llis a tio n occurs through simultaneous dehydration
of p a irs of anions and ca tio n ss
When the surface reaches equilibrium the ra te of adsorption
-
of ions from the so lu tion must foe s u ff ic ie n t to m aintain the
monolayer in ta c t , and i t i s assumed th a t every ion s tr ik in g the
surface from a sa tu ra ted so lu tion en te rs th i s mobile adsorbed la y e r
Then th e ra te o f adsorption o f ca tions = k^sfA®*], and o f anions ~
where the subscrip t aero in d ica te s the s o lu b il i ty value
o f each ion species. In an unsaturated so lu tio n , ions leave the
su rface .;fa s te r than they are replaced, while in a supersaturated
so lu tio n , a l l ions reaching the surface do not en te r the monolayer,
and those which do n o t, ■([Am+] - [Aq'!* ]) fo r ca tio n s , and ( [Bn’=j - !
for anions, are av a ilab le fo r deposition . These ions e i th e r su ffe r
e la s t ic c o llis io n s a t the surface of the monolayer, o r, should a
ca tion and an anion a rriv e sim ultaneously a t a growth s i t e , the
underlying ion p a ir can become dehydrated and incorporated in to the
cry sta l l a t t i c e . For a „symmetrical e le c tro ly te such as s i lv e r chlo:
o r lead su lphate , m = 'n , and the ra te equation would become
- = k ( [a®*] - [a®+])( [b“- 3 - [B y ])d t ° Q
= k ( m - m0 ) 2 o o . . o . o o ( 2 )
Waltoh (54) has a rriv ed a t a s im ila r ra te equation from a
more th e o re tic a l view point, by considering the adsorption o f ions
upon so ls o f the same m ateria l as following the Gibbs Adsorption
Isotherm ,
P A * ~ % I n [A + ] -s- c o n s t a n t ^ « • • ° » ( 3 )
-
where \\+ rep resen ts the t o t a l concentration o f adsorbed ea tio r .
A s im ila r suppression holds fo r anions,
I i+ ' ‘ ” k2 In [Br] + constant2 « (A)
The ra te o f surface reac tion per u n it area may be expressed as
• J = - k U+ + B") ' o . . . . . • . . . (4)
By su b s titu tio n from (3) and ( 4 ) f (5) reduces to
k k , ku _J * . L Z ( e .. o0)2
°°in th e sp ec ia l case where th e io n ic concentrations are e q u iv a len t,
and c —yc0o S im ilar euqpressions can be derived fo r non™ eq u iv a l
ent io n ic concen tra tions, and non-symmetrical e le c tro ly te s 0
Doreaus (10) has suggested two possib le mechanisms fo r the
t ra n s fe r o f dehydrated ions from th e adsorbed la y e r to the g ro t ':
s i t e s . In Model A he proposed th a t the adsorbed ions combined
th e surface la y e r to form n e u tra l wmol©culesn 9 which then d if it
along the c ry s ta l surface u n t i l they reached a -su ita b le growth
To explain c e r ta in experim ental r e s u l ts , in which a th i rd orde;
r a te law was found to apply9 he p o stu la ted , by analogy with gas
phase re ac tio n s , th a t an ad d itio n a l adsorbed ion takes p a rt in
surface combination process. In Model B, the adsorbed ions are
considered to co llid e d ire c tly with a kink in the growth s tep ,
re su ltin g in a lte rn a tiv e incorporation o f cations and anions in
th e c ry s ta l l a t t i c e . This modal gives r is e to a second order i
-
equation fo r a symmetrical e le c tro ly te 0
Doremus showed th a t r e s u lts obtained from spontaneous c r y s ta l l i
a tio n experiments on barium sulphate by Turnbull ( 9 ) , and by Johnson
and O'Rourke (3 6 ), and on s i lv e r chromate by Van Hook (56) could
be explained s a t i s f a c to r i ly % Model JL On the o ther hand, data
obtained by Howard and Nancollas (4 2 ), fo r the c ry s ta l l is a t io n of
s i lv e r chromate on added seed c ry s ta ls , f i t t e d Model B, as d id re su l
fo r s i lv e r ch loride (38) and barium sulphate (5 7 )o Doremus in te rp re
t h i s d isp a r i ty in te rn s o f the widely d iffe re n t supersatu ra tions
used in the two se ts of experiments.
For Model A, an.d a symmetrical e le c tro ly te , the ra te of
p re c ip ita tio n should be p roportional to th e th i rd power of the so ln t
concen tra tion , whereas fo r a I s 2 e le c tro ly te such as s ilv e r chrom ate
th e ra te should vary with the fourth power o f th© so lu te concent r a t i
With Model B, however, and a symmetrical e le c tro ly te , the ra te of
p re c ip ita tio n should depend on th e second power o f concentration ,
while the ra te should be p roportional to th e th ird power fo r a ls2
e le c tro ly te . Thus, a t high sup ersa tu ra tio n s , conditions should
favour Model A, while a t lower concentrations, Model B should apply,
The supersa tu ra tions used in the spontaneous c ry s ta l l is a t io n
experiments (9 , 36, 56) are much higher than those used in. seeded
growth (38 , 42, 57) and Doramus considered th i s to explain the
apparently co n flic tin g r e s u lts obtained with s i lv e r chromate and
-
barium sulphate,,
In the above th eo rie s o f growth, i t was assumed th a t the
adsorbed monolayer contained equal numbers o f p o s itiv e and negativ
io n s , but in general i t w ill not be so0 I f one ion i s adsorbed
snore strongly to th e p re c ip ita te than th e o th e r, due to d ifference
in th e adsorption energ ies, the surface w ill assume an e le c t r ic a l
charge, re su ltin g in an e le c t r ic a l double la y e r being se t up aroun
th e p a r t ic le . However, fo r concentration ra t io s equal or near to
th e s to ich iom etric one th i s se le c tiv e adsorption w ill b© n e g lig ib l
When th e io n ic concentrations are non-equivalent, a d iffe re n t
s itu a tio n a r is e s . When seed c ry s ta ls are added to a so lu tio n in.
which [Am+] / [Bn“ ] = r , where r > 1, more Am* ions w ill be adsorb
and a p o te n tia l d iffe ren ce , nfs s w ill be se t up between the adsorbs
la y e r and the solution*. In such a s i tu a tio n , the c ry s ta l growth
w ill be co n tro lled by the concentration o f the d e f ic ie n t ion Bn~
only, since th e surface concentration o f excess ions remains effso
iv e ly constan t. The equilibrium value o f ^ i s such th a t cations
and anions en te r the adsorbed lay e r in equivalent amounts.
The a v a i la b i l i ty of cations a t the surface i s then given by
8 [Am‘ ] ©xp. ( -Y V HP)
and th a t of anions by
kg s [Bn“ ] expo ( \ / RT).
These are equal when m = n , hence
exp. { > / El) = [A**]* / [Bn~ b = A
-
Sinca the numbsr o f ions of each type en tering the monolayer i s m0,
th e ra te o f c ry s ta l l is a t io n i s given by
- = k a ( [ A ^ ] r " ^ - m 0)([B“- ] r i - a 0)d t
= k s - nip) 2
which reduces, when [A111*] = [Bn~ ], to equation ( l ) ? with n = 2a
C ry s ta llis a tio n o f symmetrical e le c tro ly te s could therefor©
be expected to follow a second order r a te law, even when th e ion ic
concentrations are not equ ivalen t. This has been shorn to be-the
case fo r s i lv e r chloride ( ? ) , barium su lphate , (5 6 ), and-m agnesia
oxalate (43) °
Another method o f a l te r in g the surface o f the seed c ry s ta ls
i s th e ad d itio n o f im purity molecules which are l ik e ly to adsorbed
by the cx y s ta ls0 Davies and DJancollas (39) have studied c ry s ta l
growth in th e presence o f a v a r ie ty o f such a d d itiv e s , and found
th a t whil© they a l l had a considerable e f fe c t on the ra te of growth,,
th e mechanism was unchanged.
P art l a o f th i s th e s is describes a conductim etric study of bho
c r y s ta l l is a t io n of lead sulphate from supersatura ted so lu tions of
equivalent and non-equivalent io n ic concentrationso Experiments
were a lso made in the presence of surface ac tiv e agents.
R esults obtained a t equivalent ion ic concentrations were in
agreement with the theory described above. Second order growth wars
observed fo r most o f the reac tio n , with th e exception o f an i n i t i o l •
-
very f a s t growth surge, which has been in te rp re te d in terms of
enhanced two-dimensional nucle&tion on the surface o f the added
seed c ry s ta ls . Growth in th e presence o f adsorbates was a lso fon
to follow a second order ra te law, but dev ia tions from th i s were
observed when the concentration o f add itive was high. CrystaUJ.«
a t non-equivalent io n ic concentrations d id not follow the propose,
mechanism, and no sa tis fa c to ry ©explanation o f the re s u l ts has bee.-:
mads so f a r .
P a rt lb i s concerned with th e c ry s ta l l is a t io n of barium sul/r
a t various tem peratures. The ra te o f reac tio n was found to be
tem perature dependent, and followed second order k in e tic s . Heatr
o f c ry s ta l l is a t io n have been evaluated.
PART, l a , Lead Sulphate 0
Of th e th ree common sparing ly so luble su lphates, th a t o f bar
has been most s tu d ied , because o f i t s importance in q u an tita tiv e
an a ly s is . Much o f th e work on lead sulphate has been concerned
with i t s p re c ip ita tio n and aging, and th e re i s l i t t l e to be found,
in th e l i t e r a tu r e concerning th e growth process i t s e l f .
The presen t study was undertaken with the object of determin:
th e s im i la r i t ie s , i f any, between th e c ry s ta l l is a t io n behaviour o:
t h i s s a l t and barium ' sulphate. In p a r t ic u la r i t would be in ters© ’
-
to see i f the growth of lead sulphate was charac terised by an i n i t
very f a s t growth surge s im ila r to th a t found by Nancollas and Purd.
fo r the barium s a l t .
Hahnert (58) described the great d iffe ren ces in the shapes of
lead sulphate c ry s ta ls produced by varying the mixing time o f the
reag en ts, and by the presence of added im p u ritie s0 He observed
th a t the most p e rfec t rhombohedra were formed from d ilu te so lu tio n
and th a t as the reagent concentrations were increased , im perfect
c ry s ta ls , which he described as 55somatoide?! appeared.
K olthoff and h is co-workers (59, 60) made s im ila r observation
and noted th a t as the concentrations o f reagents were increased,, t
sis© o f the p re c ip ita te p a r t ic le s passed through a maximumo They
a lso reported (61) th a t a considerable supersa tu ra tion could ha
m aintained before spontaneous c ry s ta l l is a t io n took p lace , end
determined the c r i t i c a l concentration product to be 200 tim es grea
than th e a c t iv i ty product o f a sa tu ra ted so lu tio n of the s a l t 0
In an e a r l ie r study, K olthoff and Rosenblum (60, 62) studied
the ra te o f aging o f lead sulphate p re c ip i ta te s , and found i t to 1
independent of s t i r r in g speed. Since th e speed of a g ita tio n would
be im portant in Ostwald ripen ing , they concluded th a t th i s was rev;
tak ing p lace , and suggested th a t the aging occurred by r e c ry s ta l l !
in a l iq u id lay e r round the p a r t ic le s » K olthoff and Rosenblum (11
a lso showed th a t n e ith e r sodium sulphate nor lead n i t r a te was
-
sp e c if ic a lly adsorbed on the surface of the crystalso On the oils
hand, dyes such as wool v io le t ( 6.4) , wore very strongly adsorbed 5,
to th e ex ten t o f one dye ion per 1 05 lead ions on the surface in
n e u tra l so lu tio n . I f the concentration o f wool v io le t was
s u f f ic ie n t ly h igh, no e z y s ta liis a tio n o f lead sulphate took place
I t has been long known th a t small amounts o f im purities may
appreciably a l t e r the growth behaviour o f c ry s ta ls (6 $ ), and many
workers (23 , 66 - 68) have observed a considerable reduction in
th e ra te o f growth in the presence of adsorbates. Small concentr
o f orthophosphate, trip h o sp h a te , and pyrophosphate ions have he
found to decrease the ra te o f p re c ip ita tio n o f strontium su lp h a " -
and, i f p resen t in su ff ic ie n tly high concentrations, to in h ib it
p re c ip ita tio n e n tire ly (66, 67)„ In h ib itio n of nucleation has v-1
been described by R ig terink and Franco (6 9 ), Reitems5b r and
Buehrer (7 0 ), and o thers (71, 72). Habit m odification has also
been observed in many systems (72 - 75), due to slowing of growth
by se le c tiv e adsorption of im purities on p a r t ic u la r faces , while
th e remaining faces continued to grow a t the normal r a te .
Sears (76) has suggested th a t small molecules are most liko l:
to be adsorbed a t kinks in growth s tep s , and th a t monostep
coverage (77) would be necessary to cause an appreciable reductxo:
in the ra te o f step motion. He proposed (78) th a t the adsorbed
im purities must prevent assim ila tio n of fu rth e r growth molecules
-
in to th e l a t t i c e . I f th i s were not the case, the im purity would
be b u i l t in to the c ry s ta l , and the growth ra ta would not be much
re ta rd ed . Further advance o f a s te p , once poisoned, can only occur
by n ucleation of a new step of su b stra te atoms a t th e poisoned step .
Adsorption o f a poison a t a growth step should reduce the step energ
and hence th e c r i t i c a l energy fo r two-dimensional n ucleation , and
an increase in th e ra te of surface nucleation should r e s u l t .
For la rg e m olecules, however, Gabrera and Vermilyea (19)
considered th a t the e f fe c t i s not u su a lly sp e c if ic , sine© these
iTOuid be adsorbed a t any point on the c ry s ta l because of the
d ispersion fo rces . In such a s itu a tio n , th e re fo re , the s ize of oho
molecule would be one of the most im portant fa c to rs governing In
e ffec tiv en ess as a growth in h ib ito r .
Sears (78) has shown, th a t a concentration o f 2 s - 10“ ^ mole
f ra c tio n s o f f e r r ic flu o rid e was su ff ic ie n t to hinder step motion
in lith iu m f lu o r id e , and th a t a s im ila r concentration caused an
appreciable increase o f two-dimensional nucleation on p e rfec t
lith iu m flu o rid e su rfaces. S im ilarly (2 3 ), potassium chloride
c ry s ta ls , in the presence o f two p a r ts per m illion by weight of
lead ch lo rid e , were observed to th icken without impingement on
another, a phenomenon which must a lso be due to two-dimensional
surface n u clea tion , since the presence o f lead ch3.or.ide would X ;
th e s tep energy. Nucleation o f etch p i t s in presence of im purity 1 x
-
considered to be due to the same effect*
I t would be in te re s tin g to determine i f any s im ila r
phenomena could be detected in the study o f lead sulphate
c r y sta llisa tio n in the presence o f im purities*
o f Solutions
Analar reagents were used throughout, unless otherwise s ta te d
Stock so lu tio n s o f lead n i t r a te and sodium sulphate were' prepared
by w eight, the concentration u su a lly being about ICT^ molar*
D ilu te so lu tions were made up fo r each run, and 10 ml. of these
so lu tio n s were added to the known weight o f water in the c e l l , an
described previously .
This method of p reparation of the supersaturated so lu tion
re su lte d in a high concentration of the supporting e le c tro ly te ,
sodium n i t r a t e , being p resen t. Attempts were made to prepare leadout
sulphate supersatura ted so lu tions withAsuch a supporting e le c tro ly te ,
using ion-exchange techniques
-
washed again , u n t i l the e fflu en t tms free of lead ions*
A so lu tio n o f sodium sulphate of the required concent.rat:}
Was then passed through, a t a ra te o f about one drop every 20
and th e e fflu e n t was delivered d ire c tly in to the c e l l , and we:'
The conductiv ity o f th i s so lu tion was higher than the ca lcu la t
va lu e , and t e s t s with a flame photometer showed some sodium ic>
s t i l l to be p resen t. The a f f in i ty o f the re s in fo r lead, ions
g re a te r than th a t fo r sodium io n s, and a complete exchange of
fo r sodium x/as never achievedo
Attempts were then made using an anion exchange re s in , Pe
D e-acid ite FF ( SEA 69). The re s in was prepared in the chloric '
and converted to sulphate with 2 Molar sodium sulphate soluble
The column was washed thoroughly before use. A lead n i t r a te •;
o f th e requ ired concentration was then passed through, but the,
exchange o f n i t r a te fo r sulphate was even le s s complete than i
o f sodium fo r le ad , and lead sulphate was seen to have precipa
on the column.
P reparation o f Adsorbate so lu tio n s .
1 o Sodium DpdQQv ls iilnhate .
^ % ) i o 3 Molecular Ifeight - P
A pure sample, k indly given 'by Im perial Chemical In d u s tr ie s , L
was used without fu r th e r p u r if ic a tio n . Solutions o f various
concentrations were made up by weight0
-
2° Sodium Pyrophosphate.
Nag Pg Qy XOHgO. M olecular Weight. = 446o il
An a la r sodium pyrophosphate was used without fu r th e r p u r if ic a tio n ,
and so lu tio n s made up as before,
3 , Sodium T e t r amet aphosohat e .
(Na PQ3 4 HgO. M olecular W eight = 4BQ
A pure sample, kindly given by Dr. G. B. Monk, was us8d without
fu r th e r p u rifica tio n *
4 o Sodium Trimetaphosphate•1 ^wcwa»a8i>ttia'atriiaB»aBw 414*
A pure sample, k indly given by Messrs, A lbright and Wilson L td , ,
was used without fu rth e r p u r if ic a tio n .
5. Cetvl Trimethvl Ammonium Bromide.
gh3 ( ^ a ) l4 m 2 ^ m 3 B ir M olecular Weight = 346„35
A pur© sample, k indly given by Im perial Chemical In d u s tr ie s , Ltd, ?
was used without fu r th e r p u r if ic a tio n •
Since lead sulphate has a low tem perature c o e ffic ie n t of
s o lu b i l i ty , p repara tion of seed c ry s ta ls by re c ry s ta l l is a t io n :
not fe a s ib le , and p re c ip ita tio n techniques were used. Various methods
-
wars t r i e d , and the most successful was found to be dropwise add ition
o f 100 ml. po rtions o f 0»1 Molar lead n i t r a te and 0ol Molar sulpkiwic
ac id to 200 mlo o f water w ith constant v ib ra to ry s t i r r in g , which was
continued fo r 24 hourso The seeds thus formed were usu a lly w ell-
ch arac te rised rhombs, o f average s ise 40 /fr , but occasionally batah.es
o f c ry s ta ls which showed highly developed faces were found (P la to ^BOD) e
These were genera lly needle-shaped, but some had Hwaist s,!, o r we.ra
th e obtuse-angled cross shape, as has a lso been observed by K olthoff
and Van!t B iet ($ 9 ).
Attempts to obtain reproducible methods fo r the production
o f th e various kinds o f c ry s ta ls have been la rg e ly unsuccessful
ca re fu l con tro l of th e conditions o f p re c ip ita tio n , s t i r r in g ,
-drop**rate, concentration and tem perature has not y ie lded any method
by which th e d esired type o f c ry s ta l shape can be obtained, exes?#
th a t th e more d ilu te so lu tions were- u su a lly found to give b e t te r
rhombs.
When a su ita b le batch o f c ry s ta ls , o f uniform shape and s ise
was ob ta ined ,the c ry s ta ls were washed thoroughly with d i s t i l l e d
.w ater, then with conductiv ity w ater, and s to red in pyrax stock
bo ttleso They were se t aside a t 2f>0C° to age, fo r 2 - 4 weeks baloro
use. D e ta ils o f the suspensions are given in Table 1.
-
c J L20/o 20yU.P l a t e 2 .
-
TABLE. 10
Seed Shape Conc0 (mg/mlo) Plat© 2
k needle 60 B, G, D
B needle 65 B, G, D
B rhombic 100 A
E rhombic 8 A
G rhombic 100 A
Determination Of Solubility .
The s o lu b il i ty o f lead sulphate seed c ry s ta ls was determined
by le t t in g c ry s ta l l is a t io n and d isso lu tio n experiments proceed to
©quilibriumo Values obtained from both methods agreed to w ithin
1% o f each other* The s o lu b il i ty o f lead sulphate was found to bs
lo4*66 x HH4* moles / 1 D a t 25°Go. which i s interm ediate between
lo490 x IQ"4- moles / l c (80) and 1.4-0 moles / 1„ a t 22 - 23°G0 (6.3
The thermodynamic s o lu b il i ty product, K, given by
K ~ [Pb2
-
w ith A = Oo5092p
The s o lu b il i ty value was corrected fo r ion ic stren g th a t the
various concentrations o f supersaturated and subsaturated so lu tions
used*
Determ ination o f Concentration o f C rystals Added to th e C e llo
Since th e concentration o f seed c ry s ta ls added to th e c e l l was
very high - in th e region o f 300 mg / ml0 - rep ro d u c ib ility was
not good* and so th e weight o f seeds added to each experiment
determined by f i l t r a t i o n o f th e c e l l so lu tio n through a Number n:"
a f t e r the run had been eompletedo
Experiments in th e Presence o f Adsorbateso
The requ ired amount o f adsorbate so lu tio n was added to the
supersatu rated so lu tio n in the c e l l , before inocu la tion with seod
c r y s ta ls 0 Once the c e l l so lu tion had again reached tem perature
and carbon dioxide equilibrium , and the conductiv ity had remained
steady fo r one hour, seed c ry s ta ls were added, and th e change in
conductiv ity followed in th e usual wayc
-
RESULTS.
The experiments described in t h i s section were ca rried out in
order to determine th e ra te o f c ry s ta l l is a t io n o f lead sulphate a t
25°Go , and to f in d th e e f fe c t o f inorganic im purities on the growth0
Some experiments were also made with non - equivalent concentrations
o f lead and sulphate ions*
The supersatu ra ted so lu tions were s tab le u n t i l the addition
o f seed c ry s ta ls , and since these had been aged fo r 2 - 4 weeks
p r io r to. u se , i t was not possib le fo r fresh n u c le i to be formed? al'.f
growth th e re fo re took place on the c ry s ta ls supplied (4-1) °
Th© ion ic m obility o f sulphate was taken as 80 o0 (8 2 ), and
that, o f lead as 69.40 (83) a t 25°C.
The equivalent conductiv ity can be obtained from the Onsag^r
equation i f th e conductiv ity a t in f in i te d ilu tio n and th© eonpertration
o f th e so lu tio n are known o For lead su lphate , the equivalent
conductiv ity i s given by (84)
The equivalent conductiv ity can be evaluated in another way
from measured conductiv ity values and the c e l l constan t,
ss 1000 x 1/E x c e l l constant & 6 „ , :
^ e PhSQ̂ , '* «■ (lo 8 2 l6 '4 ° -b 239«44)^§Si
th e concentration m̂ being expressed in g„ mol©« / 1D, and A
-
where E i s th e re s is ta n c e of the so lu tion corrected fo r the
re s is ta n ce of water.. C alculation o f experim ental values using
equation (2) gave re su lts which agreed to w ithin 0,5$ o f the
th e o re t ic a l value fo r a l l c e l l so lu tio n s 0 Hence an independent
check on th© accuracy o f p reparation o f th e c e l l so lu tio n s could
made. ?
The a c t iv i ty o f the so lu tion was taken as the concentration .>
so th a t over the very small concentration changes involved the va
o f 4 was considered constant^ and taken as 140,56 a t the conoen
1.774 x 10“^ moles / 1, The change in concentration in so lu tions
equivalent io n ic concentration was evaluated from th e expression
= & l/R x F
where F i s given by
10G0_ x c e l l constant2 x A
C rysta ll i s a t io n a t Equivalent I onic Concentration sQWM«1I III ■r*T ■■ III III! W fW .M ■ | I I I I- —imm *■
T r ia l esperinients were ca rried out to determine the i n i t i a l
concentration which would give a reasonable rat© of growth, and a
supers a tu ra t ion o f 80% was found to be su ita b le . Typical smooth
p lo ts o f the reciprocal, o f re s is ta n c e against time are shown ir.
Figo 6 , Tables 4> 7 and 8. The i n i t i a l ra te o f c ry s ta l l is a t io n vi i
obtained by malting a short ex trap o la tio n o f th is growth curve to
-
sero tim e. D ifferences between the instantaneous values o f l/R
th i s i n i t i a l value o f l/R were used to c a lcu la te th e amount o f 1
su lphate p re c ip ita te d a t any tim e. P lo ts o f th e in teg ra ted form
th e secbnd order ra te equation
- — - k s (m - m0)^d t °
were found to be good s tra ig h t l in e s with th e exception o f an in
very f a s t growth surge, the order o f which was obviously not two
A ty p ic a l p lo t i s :shown in F ig0 2, using d a ta given in Table 3,
The e f fe c t o f increasing the concentration o f seed c ry s ta ls
and o f reducing th e i n i t i a l super sa tu ra tio n m s te s te d , and the
re s u l ts are summarised in Table 2. The re s u lt o f increasing the
seed concentration can be seen from Runs 9 , 11 and 13, (Table 4)
and ra te p lo ts are shorn in F ig, 3 , Rims 17, 18 and 28 (Table 5
and Runs 31 and 32 (Table 6) show the e f fe c t o f a reduction in
su p ersa tu ra tio n , and the corresponding second order p lo ts are
shown in FigSo 4 and 5 •
R esults w ith D iffe ren t Types of Seed C rysta ls .
The seed c ry s ta ls used in th e experiments described so fa r
were reg u la r rhombs, of average sis© 40 /*i. (P la te 2A). Some bat
o f c ry s ta ls , however, were predominately needle-shaped, although
number had pronounced ’'w aists1' (P la te 2B, 0 , D). These c ry s ta ls
-
JLiiHJUffio
Gr.yj 1 4 c - ^ 4 - 4 ^ ^Ugjr|̂ j:X gig>uXU'.a of Lead Sulphate*afVB^n.iAgyi»»Tmr*rtfej»
ExperimentNumber
SeedSuspension
Seed conco (mg/ml)
x 10^m oles/lo
duration o fin it ia l part f reaotio:
(m ins.) follcus&o
9 E 8 1.-7740 5 34
11 E 30 lo7740 3 .A5
13 \ E 96 lo?740 0 4.2
17 D 100 lo7740 15 33,
ia D 100 1c774-0 15 41
28 D 100 lo6780 9 30
31 G 100 lo7740 15 . 30
32 G 100 1*6250 5 22
14 A 90 1*7702 30 77
15 A 90, lo7740 - 30 53
19 B 100 lo774-0 30 85
-
S f f i l k J k
Tim® 10^ / R 10^ m 10^ (m-m0) 1 0^ j{ m~mQ)
ohms" ̂ m oles/io m oles/lo l 0/mole lo /i
0o3S85
0 o4062 i
0.4636 7
0.5058 11
0.5482 15
0.5981 20
0 o6743 28
0o7722 38
0o8503 46c
C ell Bo F = 042548
0 mixio lo 26250 lo7740 0o2574
lo5 lo 25785 1 o7628 0.2462
6 lo 24719 1 o7323 0.2157
15 lo 23914 1 7M3 0.1977
30 lo 234U Io6990 0.1824
1 h r . lo 22816 106838 0.1672
2 lo 22074 1 o6649 0.1483
3o5 1.21337 1.6461 0.1295
4o5 1.20848 1.6342 0.1176
-
4 8 .
5 0
AO
3 0
20
10
|m - m 0 )-(m ,- mj}x10’4
R un 8
0 1
0
Ti m e (h o u r s )I 3 A
F i g u r e 2.
-
G ry sta lii sa t ion o f Load Sulphate,
Time 103 / R 1CA m XQ4 (m-%) !0^y{ m~m(
ohms*̂ * molos/lo moles/lo lo/mole,
Run 9 o 0 min lo 26030 1.7740 0.2574 0o3885
3 1.25834 1,7690 0,2524 0o3962
15 1.25683 1o7652 0o2486 0o4023
30 lo 25530 1o7613 0.2447 0,4087
2 hrSo lo 24770 lo7419 0o2253 0.4439
3.5 lo 24215 lo7278 0o2112 0,4735
7o5 1*23164 Io7010 0.1844 0.5423
8.25 lo 22965 1.6959 0.1793 0.5577
Run 11.
0 min. 1.25855 lo?740 0.2574 0.3885
3 1.25734 1,7709 0.2543 0.3922
10 lo 25632 1.7683 0.2517 0.3973
15 1.25581 ■1,7670 0.2504 0.3994
30 lo 25479 1.7644 0o2478 0.4036
1 hr. lo 25175 1.7567 0o2401 0.4165
lo5 1 . 249 21 1.7502 0.2336 0.4281
? ^ 10 24417 1.7374 Q^2^;8 0.4529
-
Time 103 / H 10^ m 10̂ * (m-m0) 10~^/(m~m(
OhBB"3- moles/lo moleg/lo lo/mole
M L U k
0 mino 1.25161 1,7740 0,2574 Oo3885
3 1.25073 lo7723 Oo2557 0o3911
7 1,24972 1,7692 062526 Oo3959
15 1.24795 1,7647 0,2481 0 ‘o4031
30 1.24467 1 o 7563 0,2397 0,4172
1 h r. 1.23914 1,7422 0,2256 0o4433
lo5 lo 234*64 lo7315 0o2149 0,4652
2 lo 23065 1,7206 0,2040 0,4902
3o25 lo 22173 1,6979 0,1813 0,5516
C ell Bo F = 0,2548.
-
51 .
{(m- m j '- (m r m0) )x10'86A
20
0 Run 9.
Time (hours)
Run 11.
Time (hours)
,-2
Run 13.
Time (hours )
F i g u r e 3.
-
Cry a t a l l ig a tio n o f Lead Sulphate.
Time 10^ / R 104 m 104 ( m-m0) 10“4 /( m-m0)
ohms'"-*- moles/lo moles/lo/
lo/mole lo/ia«
m T Cell B« F = 0o2548.
0 mipu lo 26275 lo7740 0o2574 0o3885
3 lo 25702 lo7594 0o2428 0o4119 2
7 lo 25627 lo7575 0o2409 Oo4151
15 lo 25474 lo7536 0o2370 0o4219
30 lo 25291 lo7489 0o2323 0*4305 A
1 h r0 lo 24966 lo7406 0 0 2240 0 o44^4
2o5 I®24189 lo7208 0o2042 0o4897 1!
4 lo 23532 lo7041 0ol875 0*5333 14
Run 18„ Cell Bo I? ~ 0o2548c
0 min lo 27270 lo7740 0o2574 0o3885
3 lo 26747 lo760? 0o2441 0o4097 t ..
9 lo 26619 1o7574 0*2408 0o4153 ;;
15 lo 26491 lo?521 0o2355 0 o4246 -
30 lo 26276 1.7487 0*2321 0o4308 4
lo25 hr« I* 25717 1*7345 0 o2179 0o4589 r ••
2 io 25312 1 o7241 0o2075 0,4819 C
3 lo 24882 lo?132 0«1966 0*5086 12
4o75 lo 23976 lo6901 0ol735 0*5764 18
-
TABLEo 5* (conto)
Time 103 / R
ohms**̂
lO ̂ m
moies/lo
1C)4 (m-m0)
moles/lo
10~4/( io-.m0)
lo/moleo l./s io le
Sun 28 o
0 mi&o lo 23260 1o6780 Ool669 0.5992
3 lo 22884 106687 ‘ 0.1576 0o6345 3° 53
9 lo 22775 1o6659 0.1548 006460 ,4 0 68
15 lo 22680 106636 Ool525 Oo6557 [j o O ; ;
30 lo 22502 1.6592 0ol481 0.6752 7 c 61'
1 hr. 1.22915 1o6516 0.1405 0o7117 1 7 0-
lo5 1.21924 106449 0 d 3 38 0.7474 ' )A, . . / 'H ;
2 lo 2168? lo6390 0ol279 0o7819
3 1 o-2129 5 1o6292 0.1181 0.8467 v A. !7 7
C ell Do F = 0 o243lo
I* = ^(m - m0)*”^ ~ (mi - m0) | x 1CT^
-
Run 18.
Run 17
T i m e ( h o u r s ), .... I
0 2 3
24
2220181614
1210
86420
Run 28.
Time ( h o u r s )_______________ l___3
F i g u r e 4.
-
£gjM4AMkj-m,oOfi^_Sj3l-piiate.
f t — L’lLBM
Tims X03 / R !Q4 m 104 (m-m0) 10“V(m«mo) I*
ohms'"-*-* moles/lo moles/1. l./m o le . l./m o le .
Run 31.
0 ndn. lo 21870 1.7740 0.2574 0.3885 « .
1 lo 21771 1.7714 0.2548 0.3925 0 0 4O
3 lo 21545 Xo7655 0.2489 0.4018 1.33
9 lo 21104 1.7546 0.2380 0.4202 3 .1?
15 1.20864 1.7477 0.2311 0.4327 4o42
30 lo 20431 1.7364. 0.2198 0.4550 6065
lo5 hr* 1.19246 1 o'7054 0.1888 0.5297 14.12
1.75 lo 18957 1.6978 ; 0.1812 0.5519 16,34
Sea 32.
0 min» 1.12775 lo6250 0.1174 0.8518 -
3 1.12680 1.6225 0.1149 0.8703 3-o 35
9 I ; 12572 1.6197 0.1121 0.3921 4,. 03
15 lo 12495 1.6177 0.1101 0.9083 5 = 65
30 1.12379 1.6147 0.1071 0.9337 "? 0O r. X ' J
1 h r. l a 12049 1.6061 0.0985 1.0152 16,34
2.73 1.11318 lo5S70 0.0794 1.2954 4-4,36
C all E« 51= 0.2614c
-
Time ( h o u r s )- i ------------------------------------------------------------------------------------■-----------------------------------------------------------------------------------1_
1 2 3
40
3530
252015
10
50
Run 32,
I ime (hours )■ * - - in0
F i g u r e 5.
-
57.
TABLEa 7£,
'T'Jj I]1
sf 1
of I
sa tion o f Load Surohate.
Tims X03 / R % 0 10^ (n-m0) 10~4/( m-m0) I*
ohms-3- mol©s/lo m oles/l. l*/mole. l./m ole,
Run 14.oawaMHUiaani
0 min. 1.26950 1*7702 0*2536 0.3943 -
1*5 1.24882 1.7172 0.2006 0*4985 11*00
6 1 o 24126 1.6982 0.1816 0*5507 16.22
15 1*23680 1*6869 0*1703 0.5872 19o87
30 1.23201 1.6747 0*1581 0*6325 24o40
2 hrso 1.21399 1*6288 0*1122 0*8913 50*28
3 1.20617 1.6088 0.0922 1.0846 69*61
4o5 1.19735 1.5864 0.0698 1.4327 104*42
Ran 15 >
0 min. 1.26510 1.7740 0*2574 0*3885 -
1.5 1.23700 1.7024 0.1858 0*5382 14.97
6 1*23077 1*6865 0.1699 0.5886 20*01
15 1*22670 1.6762 0*1596 006266 23.81
30 1.22333 106676 0.1510 006623 27*38
1 h r 0 1.21840 1.6550 0.1384 0*7225 33.40
2o5 lo 20734 I 06268 0.1102 0.9074 51*89
4»5 1.19765 1.6021 0*0855 1,1696 78.11
S§AUk F = 0,2548, j* | ( m - m01
J”1 - (mi - mo)”1] x 1
-
TABLES* „B,» . C rystallisation o f Lead Satcibgfce.
Tim© 103 / R 10^ a 10̂ - (a*»a0)
ohms”'*- mole?/l.. a o le s / l .
Sun 19.
0 a in . lo 26510 1.7740 0.2574 0.3885
1.5 1.24-076 1.7120 = 0.1954 0.51M > ')■>
6 1.23196 1.6896 0.1730 0.9m
15 1.22709 1.6771 0.1605 0.6231
30 1.22249 1.6654 O0I 48S 0.6720
1 h r . I . 21639 1.6499 0.1333 0.7502
3 1.19745 1.6016 : 0.0850 1.1765 • i - , v ' .
5 1.18751 1.5763 0.0597 1.6750
6.5 1.18273 1.5641 0.0475 2.1053 ^ .,V ’
C ell B F = 0,2458.
I# = £(m - ®0)'"^ - (b^ — 3E 1BT®
-
59.
1 / R scale: 1cm=5x10”feohm s-'
Run1 / R
Run15.
F i g u r e 6.
-
generally la rg e r than the rhombs, of average size 70/ t a When th 8se
c ry s ta ls were used in c ry s ta l l is a t io n experiments, the i n i t i a l
growth surge was much more pronounced than with the rhombic type.
This e f fe c t was demonstrated by seed suspensions A and B, and the
re s u l ts are shown in Tables 7 and 8 , and Figs. 6 and7. Due to the
very steep i n i t i a l slope of. the p lo ts o f the rec ip ro ca l of
re s is ta n ce ag a in st tim e, i t was d i f f ic u l t to obtain an accurate
value o f l/R ^ fo r Runs 14* 15 and 19 (F ig . 6) „
C ry s ta llis a tio n In th e Presence o f Adsorbates.
The adsorbates studied in the present work were sodium
dodecylsulphate? sodium pyrophosphate, sodium trim etaphosphate,
sodium tetram etaphosphate and cetyi. trim ethy l ammonium bromide. In
a l l cases th e adsorbate so lu tion was added to the supersaturated
so lu tio n , and allowed to reach carbon dioxide and temperature
equilibrium before inocu la tion with seed c ry s ta ls .
Anionic A dditives,
The r e s u l ts are summarised in Tables 10 and 15, and ty p ic a l
smooth curves obtained or p lo tt in g l/R against time are shown in
F igs, 8 - 11, Tables 11 - 14. The ra te of growth o f lead sulphate
decreased w ith increasing concentration o f im purity, u n t i l f in a lly
a concen tration was 'reached a t which growth stopped completely.
-
A very low concentration o f sodium tetrametaphosphate ( iCr%h)
markedly re ta rd ed the ra te of growth, with sodium trimetaphosphateP
sodium pyrophosphate, and sodium dodecyl sulphate being increasingly
le s s e f fe c t iv e , in that order. A comparison of the concentrations
of these ions necessary just to retard the growth rate, and to stop
growth.-almost en tire ly i s made in Table 9 .
GonCc slowing Cone. almostAdditive, growth stopping growth
(molesA) (moles/lo)
Dodecylsulphate 3o8 x 10” ̂ 8 .3 x ICT^
Pyrophosphate 3.6 x 10”^ 2.0 x 10”^
Trimetaphosphate 9 .5 x 10”^ 1,5 x 1CT̂
Tetrametaphosphate ; 6 .7 x 10“^ 7.7 x 1CT^
The c r y s ta l l i s a t io n process can be represented by the expression
dm . / \ n= k s a «?■ mQ rd t
where n i s th e order of the reac tio n , and can be evaluated from a
p lo t o f l o g —- against log (m~mQ) , For lead su lphate, th i s graphdt
was composed o f two in te rse c tin g s tra ig h t l in e s , of gradient and
nor> (Fige 13) where n-j rep resen ts the in 3 .tia l growth surge and np
-
63 o
rep resen ts the major p a r t of the growth. In experiments in the
presence of im purity , th e duration of the fa s t p a rt and the value of
were both shown to increase with increasing concentration of the
foreign substance (Tables 10 and 15)*
In experiments ca rried out with so lu tions prepared from deionised
w aters a very low concentration o f adsorbate was found to a ffe c t np
also* in s tead o f the main p a rt o f the growth following a second
order ra te law, i t was found th a t np a lso increased with increasing
concentration of ad d itiv e (Table 10) *
When w ater prepared in a Bourdillon s t i l l was used, a much
higher concentration of im purity could be added before any deviation
from second order growth was observed in the main p a rt of the reac tio n
(Table 15)„
Ac DEIONISED WATER,
1® Sodium D ode cv lsu ln h ate ,
Concentrations o f th is adsorbate used ranged from 3®76 x 10“ * M»
which caused a n o ticeab le slowing of the growth ra te o f lead su lphate ,
to Bo3 x ICH- M. ? a t which no growth took place a t all* The re su lts
are summarised in Table 10, and l/R against time p lo ts are shorn in
Figo 8 (Table 11)* Since log-log p lo ts ind icated the value of np to
bs g re a te r than 2 , i t was not possib le to draw second order ra te
plots* Even a t the highest concentration stud ied , the c r i t i c a l
mice,lie concen tra tion , 7*7 x 10“^ moles /lo ( 85) was not exceeded*
-
64.o
2o Sodium Pyrophosphate.
S lig h tly lo v e r concentrations o f th is add itive affec ted the
c ry s ta l l i s a t io n o f lead sulphate $ 3 4.1 x 10~6 moles/lo decreased the
r a te o f growth*, and 2,0 x 10“ 5 moles/lo was su ff ic ie n t to stop growth
en tire ly o The re s u l ts are shown in Table 12, and p lo ts o f l/R
against tim e are p resented in Fig* 9®
lo Sodium Trimetanhosphate.f l a i ii — in m hi ii i— «n> i ij > m m iniH««ii ww*i in mi mr*«— ~
This a d d itiv e had a g rea te r e ffe c t on the growth of lead sulphate
than th e two adsorbates discussed previously* A concentration of
9*4.5 x 1CT8 mol@s/lo slowed th e growth, while a t a concentration o f
1 *4-9 x iCT^. m o les/l* , c ry s ta l l is a t io n was stopped almost e n tire ly .
The r e s u l ts are summarised in Table 10, and time p lo ts o f 1/B. are
shown in Fig* 10 (Table 13)»
This ad d itiv e proved to be the most e ffec tiv e in re tard in g the
growth o f lead sulphate* A concentration of 7*0 x 1Q~ ̂ m oles/la was
s u ff ic ie n t to have a marked e f fe c t on the ra te o f c ry s ta l l is a t io n ,
while a t 7*69 x 10”? xaoles/l* s growth was extremely slow* A summary
o f th e r e s u l ts i s made in Table 10, and l/R against time p lo ts are
shown in Fig* 11 (Table 1A)„
From Table 10 i t can be seen th a t each adsorbate studied had
-
biy
ExperimentHumber
Adsorbateconc.
m o les/l.
Seed Conco (mg/ml.)
ni n2 Duration of I n i t i a l Surge
( rains)
D odecylsnlphate. SjaeflJEL,
43 •* 18 2 12
44 3.76 x 10“5 - 21 3 15
50 5 066 x 1 0 ^ - (100 36 60 )
51 6.56 x 10“^ *=• (430 53 90 )
48 8c29 s 10^ •» No growth •
?yropho sphat e 0i— WwiiawabaMrwMiaMiWiirtMriitot'iBtiwi
68
Seed
16 2 9
61 3.41 x 10~6 4 .8 35 6 15
60 8 050 x 10“6 3.1 55 3 20
34 I 0O8 x 10~5 5.6 (73 8 30 )
- 55 2015 x 10“ 5 6.
top related