92971446 510623 in 0 - american autowire
TRANSCRIPT
![Page 1: 92971446 510623 IN 0 - American Autowire](https://reader033.vdocuments.mx/reader033/viewer/2022042604/6262e56ff9226b2923553804/html5/thumbnails/1.jpg)
Page 1
92971446Mating Connectoris plugged into
accessory connector
www.americanautowire.com 856-933-0801
eng
fl
NSS
Back Up
Turn SignalIgnition SwitchHeadlight
Wiper
Rear Body
EmergencyBrake
Ground
Clock
PowerAccessory
Instrument Cluster
CigarLighter
Cigar LighterLight
Radio
CourtesyLight
HeaterLight
GloveBox
BrakeSwitch
DimmerSwitch
Horn Relay
A B C D
4B
4B4C
4C
4A & 130
100 50 300
3C 3G
3G
3C
39A,B,C
107
3D
3D
3B 3A
11616A
16A
104 93 3B40A,C,E
8A,B,C
2E
2E
2D2C
2C
2B 2A 44
40 27A 40B
99A,B
115
2F
2727
A
16
300
14A,B
29
12
11A,B 402400401
15A,B
25,130
9A,B
2A
91
92
949339A121
316 33A, B
107 100
103
104 115
116
30 33B
11B 14A 15A 25121
150A 8A,D
39B
2F
28 29
40B
43 99B
40F 156C
50
8C
40G
40H
5
6
24 39C
40C,G
17A,B
28
14B
15B 27 19
17B18
16
156A,B
2B
44
9B
10 3A 4A2D40
92
9491
17A
24156A
30
9A 18 19
40A
33A
3F
7
3F
10
11A 12
35
9C
150A
9C
8E
8D
7
NOTE: wires 400 & 401, must be twisted together.
(electric speedo)
401402151139
400
A B C D E FE F G H J
31 35
A B C D
PNMLKJHGFED
5
99A
72
5152A, B72 51
52A
52B
heater harness
CircuitBranch #1
CircuitBranch #2
CircuitBranch #3
CircuitBranch #4
CircuitBranch #5
CircuitBranch #6
CircuitBranch #9
CircuitBranch #10
PART #
DESCRIPTION:
510623
92971446 Rev. 0.1 2/29/2016
1969 Pontiac FirebirdClassic Update Series Kit
CircuitBranch #7
CircuitBranch #8
Connector“A”
Connector“C”
Connector“D”
Connector“E”
Connector“B”
Tach Light
4D, 43
4D
103, 139
8B,E
Ground
RheostatLight
15140E,F156B,C
CourtesyLight
HeaterFeed
Gbag
![Page 2: 92971446 510623 IN 0 - American Autowire](https://reader033.vdocuments.mx/reader033/viewer/2022042604/6262e56ff9226b2923553804/html5/thumbnails/2.jpg)
Page 2www.americanautowire.com 856-933-0801
Note: Prior to installing the Dash Harness, obtain the Fuse, Flasher, and Relay Kit #500707 and plug all of the Fuses and Flashers in the Fuse Block (See page 7 for the location of the fuses and flashers). Install the Horn Relay to the Dash Harness (see circuit branch #7).
Fuse Block Attachment
Locate the original factory Bulkhead rectangular hole in the center of the Firewall. The new Fuse Block/Bulkhead Assembly will mount in this Firewall hole, using screws “A” (see Page 7 – the Parts Legend).
Dash Harness Installation Instructions
The Dash Harness routing will be the same as the original factory Instrument Panel Wiring Harness routing. Be sure to duplicate this routing. Now proceed to the individual Circuit Branch Instructions below.
Circuit Branch #1Headlight Dimmer Switch Connector Route this wiring branch to the Dimmer Switch (500042), which is included in this Dash Kit, and connect. Now attach the Dimmer Switch to the floor pan.
Wire # Wire Color Printing Description
10 Yellow DIMMER SW FEED Feed from the Headlight Switch.
11A Light Green HEADLIGHT-HI BEAM Feed for the High Beam Headlights.
12 Tan HEADLIGHT-LOW BEAM Feed for the Low Beam Headlights.
Tach Light
Wire # Wire Color Printing Description
4D Brown no printing Feed for factory Tach; requires use of original Tach harness. If you do not have the original Tach harness, see the Instrument Cluster instruction drawing, 92971449, for available AAW Tach harnesses.
Accessory Connector Use the provided 6-way empty connector, which is attached to the 6-way Accessory connector on the Dash Harness, and terminals “D” and “E” (see Page 7 – the Parts Legend) to add power wires (not provided) for the following optional systems:
Wire # Wire Color Printing Name on Fuse Block Fuse Rating Description
100 Tan no printing ACCY1 30A Fused 12 volt ACCESSORY feed (may also be used to feed power to an accessory circuit).
103 Dark Blue no printing FUEL 15A Fused 12 volt IGNITION feed for fuel pump (may also be used to feed power to another ignition circuit).
104 Orange no printing BAT1 20A Fused 12 volt BATTERY feed for power seats (may also be used to feed power to another battery circuit).
107 Pink no printing IGN1 20A Fused 12 volt IGNITION feed for cruise control (may also be used to feed power to another ignition circuit).
115 Red no printing BAT2 30A Fused 12 volt BATTERY feed for power door locks (may also be used to feed power to another battery circuit).
116 Yellow no printing PWRWDO 30A Fused 12 volt IGNITION feed for power windows (may also be used to feed power to another ignition circuit).
Emergency Brake Connect to the emergency brake switch.
Wire # Wire Color Printing Description
33A Tan no printing This is the ground circuit for the parking brake switch light.
Circuit Branch #2Brake Switch
Stop Light Switch Connector Plug this connector into the factory brake switch.
Wire # Wire Color Printing Description
17A Light Blue THIRD BRAKE LIGHT For optional third brake light, in the Rear Body harness.
17B White BRAKE SW Brake Switch output feed for the Turn Signal Switch.
40C, G Orange 12V BATTERY-FUSED 12V Battery Fused feed from the Fuse Block.
PART #
DESCRIPTION:
5106231969 Pontiac Firebird
Classic Update Series Kit
Mating Connectoris plugged into
accessory connector
eng
fl
PowerAccessory
BrakeSwitch
DimmerSwitch
A B C D
4B
4B4C
4C
4A & 130
100 50 300
3C 3G
3G
3C
39A,B,C
107
3D
3D
3B 3A
11616A
16A
104 93 3B40A,C,E
8A,B,C
2E
2E
2D2C
2C
2B 2A 44
40 27A 40B
99A,B
115
2F
27
27A
16
300
14A,B
29
12
11A,B 402400401
15A,B
25,130
9A,B
2A
91
92
949339A121
316 33A, B
107 100
103
104 115
116
40C,G
17A,B
33A
3F
7
3F
10
11A 12
35
CircuitBranch #1
CircuitBranch #2
Tach Light
4D, 43
4D
EmergencyBrake
103, 139
92971446 Rev. 0.1 2/29/2016
![Page 3: 92971446 510623 IN 0 - American Autowire](https://reader033.vdocuments.mx/reader033/viewer/2022042604/6262e56ff9226b2923553804/html5/thumbnails/3.jpg)
Page 3
PART #
DESCRIPTION:
5106231969 Pontiac Firebird
Classic Update Series Kit
Circuit Branch #3
LH Courtesy Light Connector Plug this connector into the supplied 500708 Courtesy Light Kit, on the driver side.
Wire# Wire Color Printing Description
40E, F Orange 12V CTSY SW 12V Battery feed for the Courtesy Light.
156B, C White CTSY GROUND Courtesy Light ground. Attach this ring terminal to a good ground.
Rear Body Connector This 9-way connector will plug into the 9-way connector of the Rear Body Harness (reference: Rear Body Harness Kit 500673).
Wire # Wire Color Printing Description
9A Brown PARK LIGHTS Feed for the Tail Lights, License Light, and the Rear Side Marker Lights.
17A Light Blue THIRD BRAKE LIGHT Feed for an optional aftermarket Third Brake Light.
18 Yellow LEFT REAR TURN Feed for the Left Rear Stop and Turn Light.
19 Dark Green RIGHT REAR TURN Feed for the Right Rear Stop and Turn Light.
24 Light Green BACK UP LT SW � LIGHTS Feed from the Back-up Light Switch for the Back-up Lights.
30 Tan GAS GAUGE For the Fuel Tank Sender.
40A Orange 12V BATTERY-FUSED Feed for the Dome/Courtesy Light.
156A White CTSY GROUND Dome Light ground for the Headlight/ LH Courtesy Light Switches.
Circuit Branch #4
Wiper Switch Connector Plug this connector to the Wiper Switch.
Wire # Wire Color Printing Description
91 Black no printing Ground circuit for low speed.
92 Light Blue no printing Ground circuit for hi speed.
94 Dark Blue no printing Ground circuit for washer.
Headlight Switch Connector Plug this connector onto the Headlight Switch (500332), which is included in this Dash Kit, and connect. Now attach the Headlight Switch to the Dash.
Wire # Wire Color Printing Description
2B Red 12V BATTERY Battery feed for the Headlight Switch for the Headlights.
9B Brown PARK LIGHTS Feed for the Front Park Lights.
9C Brown PARK LIGHTS Feed for the Front Park Lights.
10 Yellow DIMMER SW FEED Feed for the Dimmer Switch.
40 Orange 12V BATTERY-FUSED 12V Battery feed for the Headlight Switch, for the Park Lights and the Courtesy Lights.
44 Dark Green no printing Headlight Switch feed to the Fuse Block, for the Dash Lights.
156A, B White CTSY GROUND Courtesy Light/Dome Light ground through the Headlight Switch.
Circuit Branch #5
Ground
Wire # Wire Color Printing Description
150A Black GROUND Ground wire for aftermarket gauges; attach to a good chassis ground.
Circuit Branch #6
Instrument Cluster Connections These connections will plug into the Cluster Connector Kit 510624. Instructions are included in that kit.
Cluster Connector “A”
Wire # Wire Color Printing Description
8A, D Gray DASH LIGHTS Fused 12V from the Fuse Block for the Cluster Illumination Lights.
9C Brown PARK LIGHTS Supplies signal to aftermarket gauges with nighttime dimming function.
39B Pink 12V IGNITION Fused 12V Ignition feed.
150A Black GROUND Cluster ground.
Headlight
Wiper
Rear Body
Ground
Instrument Cluster
150A 8A,D
39B
156A,B
2B
44
9B
1040
92
9491
17A
24156A
30
9A 18 19
40A
9C
150A
9C
A B C D E FE F G H J
A B C D
CircuitBranch #3
CircuitBranch #4
CircuitBranch #5
CircuitBranch #6
Connector“A”
40E,F156B,C
LHCourtesy
Light
92971446 Rev. 0.1 2/29/2016
![Page 4: 92971446 510623 IN 0 - American Autowire](https://reader033.vdocuments.mx/reader033/viewer/2022042604/6262e56ff9226b2923553804/html5/thumbnails/4.jpg)
Page 4
PART #
DESCRIPTION:
5106231969 Pontiac Firebird
Classic Update Series Kit
Circuit Branch #6 (continued)
Cluster Connector “B”
Wire # Wire Color Printing Description
11B Light Green HI BEAM INDICATOR LIGHT Feed for the High Beam Indicator Light.
14A Light Blue LEFT DASH IND Feed for the Left Turn Signal Indicator Light.
15A Dark Blue RIGHT DASH IND Feed for the Right Turn Signal Indicator Light.
25 Brown ALTERNATOR IGN Feed for the Alternator light.
30 Tan GAS GAUGE Fuel Gauge Signal from the Fuel Tank Sending Unit.
31 Dark Blue OIL PRESSURE SENDER Oil Pressure Sender Signal from the Engine.
33B Tan BRAKE LIGHT/SWITCH Brake and Parking/Low Pressure Warning Light.
35 Dark Green WATER TEMP SENDER Water Temperature Sender Signal from the Engine.
121 White COIL --> TACH Tachometer feed for the Ignition Coil.
Cluster Connector “C” This connector contains the wires for an Aftermarket Electric Speedometer. NOTE: Wires “400” and “401” must remain twisted together.
Wire # Wire Color Printing Description
139 Pink/White SPEEDO POWER 12V feed for the Electric Speedometer.
151 Black/White SPEEDO GROUND Electric Speedometer Ground.
400 Yellow VSS GROUND Vehicle Speed Sensor Ground.
401 Purple VSS SIGNAL Vehicle Speed Sensor Signal.
402 Purple/White VSS POWER Vehicle Speed Sensor Power.
Clock For factory clock.
Wire # Wire Color Printing Description
99A Yellow CLOCK BAT 12V Battery feed for the Clock.
Rheostat Light Rheostat illumination.
Wire # Wire Color Printing Description
8B, E Gray DASH LIGHTS Rheostat ilumination.
Circuit Branch #7
Horn Relay Connector If you haven’t already, plug the Horn Relay (included in kit #500707) into this connector.
Wire # Wire Color Printing Description
2F Red 12V BATTERY 12V Battery feed for the Horn Relay.
28 Black HORN RELAY GROUND Relay ground circuit for the Steering Column Horn Switch.
29 Dark Green HORN Feed for the Horns.
Turn Signal Switch Connector This will plug into your original turn signal connector. If you are using a different column you will need to convert the connector on the column, with the parts supplied in the kit, following the instructions on page 7.
Wire # Wire Color Printing Description
14B Light Blue LEFT FRONT TURN Left Front Turn Signal feed.
15B Dark Blue RIGHT FRONT TURN Right Front Turn Signal feed.
16 Purple TURN SWITCH FEED Turn Signal Switch feed from the Turn Signal Flasher.
17B White BRAKE SW Brake Switch feed for the Turn Signal Switch.
18 Yellow LEFT REAR TURN Feed for the Left Rear Turn Signal Light.
19 Dark Green RIGHT REAR TURN Feed for the Right Rear Turn Signal Light.
27 Brown TURN SW – HAZARD Feed from the Hazard Flasher.
28 Black HORN RELAY Ground from the Horn Relay for the Horn Switch. Turn Signal
Clock
Instrument Cluster
Horn Relay
30 33B
11B 14A 15A 25121
2F
28 29
28
14B
15B 27 19
17B18
16
NOTE: wires 400 & 401, must be twisted together
their entire length.(electric speedo)
401402151139
400
A B C D E FE F G H J
31 35
PNMLKJHGFED99A
CircuitBranch #6
CircuitBranch #7
Connector“C”
Connector“B”
8B,E
92971446 Rev. 0.1 2/29/2016
RheostatLight
![Page 5: 92971446 510623 IN 0 - American Autowire](https://reader033.vdocuments.mx/reader033/viewer/2022042604/6262e56ff9226b2923553804/html5/thumbnails/5.jpg)
Page 5
Circuit Branch #7 (continued)
Back-up Light Switch Connector
Wire # Wire Color Printing Description
24 Light Green BACK UP LT SW -> LIGHTS Feed wire for the Back-up Lights.
39C Pink 12V IGNITION 12V Ignition feed from the Fuse Block.
Neutral Safety Switch Connector Plug into original Neutral Safety Switch. If you are not using a NSS, these wires must be tied together, in order for the car to start.
Wire# Wire Color Printing Description
5 Purple STARTER SOLENOID-S Goes from NSS to starter solenoid.
6 Purple NEUTRAL SAFETY SWITCH Feed from Ignition Switch to NSS.
Ground Note: Be sure to attach this ground ring terminal to a good vehicle ground; only necessary if using an aftermarket electric speedo.
Wire# Wire Color Printing Description
151 Black/white SPEEDO GROUND Ground for aftermarket electric speedo; attach to a good chassis ground.
Circuit Branch #8
Ignition Switch Connector “D”
Wire # Wire Color Printing Description
2D Red 12V BATTERY 12V Battery Feed.
Ignition Switch Connector “E”
Wire # Wire Color Printing Description
3A Pink IGNITION FEED 12V Ignition Feed.
4A Brown IGNITION SW ACCY 12V Accessory Feed.
5 Purple STARTER SOLENOID - S Start circuit.
7 Yellow no printing Resistor Bypass.
Circuit Branch #9
Cigar Lighter Connector Plug this connector onto the Cigar Lighter.
Wire# Wire Color Printing Description
40B Orange no printing Fused 12V Battery feed for the Cigar Lighter.
Radio These circuits are provided for your Radio.
Wire# Wire Color Printing Description
43 Tan RADIO 12V Fused Keyed Accessory feed for the Radio “On/Off power.
99B Yellow RADIO BAT 12V Fused Battery feed for the Radio Memory.
8D Gray DASH LIGHTS Feed for Radio illumination.
Cigar Lighter Light
Wire# Wire Color Printing Description
8E Gray DASH LIGHTS Feed for Cigar Lighter illumination.
PART #
DESCRIPTION:
5106231969 Pontiac Firebird
Classic Update Series Kit
NSS
Back Up
Ignition Switch
CigarLighter
Radio
40B
43 99B
5
6
24 39C
3A 4A2D
8E
8D
7
PNMLKJHGFED
5
CircuitBranch #9
CircuitBranch #7
CircuitBranch #8
Connector“D”
Connector“E”
Cigar LighterLight
Ground
151
92971446 Rev. 0.1 2/29/2016
![Page 6: 92971446 510623 IN 0 - American Autowire](https://reader033.vdocuments.mx/reader033/viewer/2022042604/6262e56ff9226b2923553804/html5/thumbnails/6.jpg)
Page 6
Circuit Branch #10
Glove Compartment Light Connector Plug this connector to your Glove Compartment Light.
Wire# Wire Color Printing Description
40G Orange 12V BATTERY – FUSED Feed for the Glove Compartment Light.
40H Orange 12V BATTERY – FUSED Extension for original Glove Compartment Light.
Heater Light
Wire# Wire Color Printing Description
8C Gray DASH LIGHTS Feed for the Heater Light.
HEATER FEED Plug this connector onto the back of the heater.
Wire# Wire Color Printing Description
50 Brown HEATER/AC FEED Feed for the Heater and A/C.
RH Courtesy Light Connector Plug this connector into the supplied 500708 Courtesy Light Kit, on the passenger side.
Wire# Wire Color Printing Description
40F Orange 12V CTSY SW 12V Switched feed for the Courtesy Light.
156C White CTSY GROUND Courtesy Light ground.
PART #
DESCRIPTION:
5106231969 Pontiac Firebird
Classic Update Series Kit
RHCourtesy
Light
HeaterLight
HeaterFeed
GloveBox
40F156C
50
8C
40G
40H
CircuitBranch #10
92971446 Rev. 0.1 2/29/2016
![Page 7: 92971446 510623 IN 0 - American Autowire](https://reader033.vdocuments.mx/reader033/viewer/2022042604/6262e56ff9226b2923553804/html5/thumbnails/7.jpg)
Page 7
dk greenyellowpurplebrowndk blue
lt blueblack
DIAGRAM ‘A’ - AAW Turn Signal Switch Wires
TURN SIGNALAMERICAN AUTOWIRE DASH HARNESS CONNECTION SWITCH WIRING
BLANKBLANK
BLANK
CB
white
AAW Turn Signal Switch wires to stock 1969 FirebirdTurn Signal Switch
NOTE: The Steering Column Horn Button switches ground for a Horn Relay, which then switches power to the Horns, similar to the AAW design.
“Table A”
AAW AAW AAW ConnectorWire # Wire Color Wire Printing Cavity Function
17B White Brake SW P White19 Dark Green Right Rear Turn N Dark Green18 Yellow Left Rear Turn M Yellow16 Purple Turn Switch Feed L Purple27 Brown Turn SW - Hazard K Brown15B Dark Blue Right Front Turn J Dark Blue14B Light Blue Left Front Turn H Light Blue28 Black Horn Relay Ground G BlackNone None None F NoneNone None None E NoneNone None None D None
A
B
C
D
E
F
G H
J K
L
M
N
P
PN
ML
KJ
HG
FE
D
PART #
DESCRIPTION:
5106231969 Pontiac Firebird
Classic Update Series Kit92971446 Rev. 0.1 2/29/2016
10A
10A
10A
15A
15A
30A
30A20A 20A
30A
30A
30A
10A
10A
5A
10A
10A
15AACCY 1
Populated Fuse Block
Parts Legend
A
B
C
D
E
A
B
C
D
E
F
G H
J K
L
M
N
P
(3” screw, fuse blockmounting, 2 pcs)
(terminal, turn signalconnector, 10 pcs)
(terminal, double,accessory connector,
4 pcs)
(terminal, single,accessory connector,
6 pcs)
(14 pin turn signalconnector, 1 pc)
![Page 8: 92971446 510623 IN 0 - American Autowire](https://reader033.vdocuments.mx/reader033/viewer/2022042604/6262e56ff9226b2923553804/html5/thumbnails/8.jpg)
Page 8
PART #
DESCRIPTION:
5106231969 Pontiac Firebird
Classic Update Series Kit
THIS PAGE INTENTIONALLY
LEFT BLANK
92971446 Rev. 0.1 2/29/2016