5, chemical safety data (coshh assessments)documents.motorclean.co.uk/mmsdocuments/chemical...

COSHH ASSESSMENT PRODUCT NAME : Autowash HAZARD : SUPPLIER : Autosmart Not classified SDS No : 10438

PROD No : 909-13

ACTIVITY : Washing Vehicles PERSONNEL : Valeting Staff

LOCATION : Wash Bay

COLOUR : Green DILUTION RATIO : 40 - 1 DILUTION METHOD : Through wall mixer into bucket APPLICATION METHOD : From bucket via wash mitt or sponge

RISK LEVEL : Level 2 Some Risk, No means to improve Low if good standard of occupational hygiene are observed and correct PersonalProtective Equipment worn.

WORKPLACE EXPOSURE LIMIT (WEL) NAME TWA – 8HRS STEL – 15MIN

None stated - - Further information is available from the Motorclean MSDS Manual. MSDS REVIEW DATE: Autosmart – 28/05/12 Motorclean – 31/12/18

TIME AND FREQUENCY OF ACTIVITY Daily dependant on volume of cars to be cleaned. An average service washer would prepare up to 15 – 20 vehicles per day.

PERSONAL PROTECTIVE EQUIPMENT REQUIREMENTS (PPE) Safety Glasses / Goggles Safety Boots Nitrile Gloves

All to be used when decanting and applying this product. PRESENT CONTROL OUTSIDE PPE Must use in a well ventilated area

COMMENTS / ACTIONS REQUIRED The use of safety equipment provided Store product at a temperature below must be obligatory. 35degrees C. Avoid contact with skin. Do not discharge into drains. Do not ingest product.

Prepared By: Motorclean Ltd ‐ Jan 2019 of 66

COSHH ASSESSMENT

PRODUCT NAME : Hazsafe XLS HAZARD : SUPPLIER : Autosmart R35 – Causes severe burns SDS No : 10612 R22 – Harmful if swallowed PROD No : 228-5 R41 – Risk serious damage to eyes R37 – irritating to respiratory system ACTIVITY : Removing traffic film from Vehicles PERSONNEL : Valeting Staff

LOCATION : Wash Bay

COLOUR : Pale Straw DILUTION RATIO : 12 - 1 DILUTION METHOD : Through wall mixer into 6L Sprayer APPLICATION METHOD : Via 6L Pre-Sprayer onto vehicle

RISK LEVEL : Level 2 Some Risk, No means to improve Low if good standard of occupational hygiene are observed and correct Personal Protective Equipment worn.


Disodium Metasilicate - 2 mg/m3 Sodium Hydroxide - 2 mg/m3 Further information is available from the Motorclean MSDS Manual. MSDS REVIEW DATE: Autosmart – 10/02/14 Motorclean – 31/12/18

TIME AND FREQUENCY OF ACTIVITY Daily dependant on volume of cars to be cleaned. Would not necessarily be used on every vehicle valeted

PERSONAL PROTECTIVE EQUIPMENT REQUIREMENTS (PPE)

Safety Glasses / Goggles Safety Boots

Nitrile Gloves All to be used when decanting and apply ing this product.

PRESENT CONTROL OUTSIDE PPE None COMMENTS / ACTIONS REQUIRED The use of safety equipment provided Store product at a temperature below must be obligatory. 35degrees C. Avoid contact with skin. Do not discharge into drains. Do not ingest product.


COSHH ASSESSMENT

PRODUCT NAME : Wheel Cleaner Concentrate HAZARD : SUPPLIER : Autosmart R35 – Causes severe burns SDS No : 11147 R20/21/22-Harmful by inhalation,

in contact with skin and swallowed PROD No : 255-3 R36 – Irritating to eyes

ACTIVITY : Cleaning wheels PERSONNEL : Valeting Staff LOCATION : Wash Bay

COLOUR : Dark Brown DILUTION RATIO : 4- 1 DILUTION METHOD : Through wall mixer into 6L Sprayer APPLICATION METHOD : Via 6L Pre-Sprayer onto wheels and then agitated with an Alasta wheel brush.



2-(2-Butoxyethoxy)Ethanol 10 ppm 67.5 mg/m3 15 ppm 101.2 mg/m3 2-Butoxyethanol 25 ppm 123 mg/m3 50 ppm 246 mg/m3 Sodium Hydroxide - 2 mg/m3 Further information is available from the Motorclean MSDS Manual. MSDS REVIEW DATE: Autosmart – 19/09/12 Motorclean – 31/12/18

TIME AND FREQUENCY OF ACTIVITY Daily dependant on volume of cars to be cleaned. Up to 40 vehicles per day.

PERSONAL PROTECTIVE EQUIPMENT REQUIREMENTS (PPE)Safety Glasses / Goggles Safety Boots Nitrile Gloves All to be used when decanting and applying this product.

PRESENT CONTROL OUTSIDE PPE None COMMENTS / ACTIONS REQUIREDThe use of safety equipment provided Store product at a temperature belowmust be obligatory. 35degrees C. Avoid contact with skin. Do not discharge into drains. Do not ingest product.


COSHH ASSESSMENT

PRODUCT NAME : Tardis HAZARD : SUPPLIER : Autosmart R10 – Flammable SDS No : 10022 R38 – Irritating to Skin PROD No : 023-14 R20 - Harmful by inhalation R21- Harmful in contact with skinACTIVITY : Removal of Tar and Glue R65 – May cause lung damage ifPERSONNEL : Valeting Staff Swallowed. LOCATION : Wash Bay/Valet Bay

COLOUR : Clear DILUTION RATIO : Undiluted DILUTION METHOD : N/A APPLICATION METHOD : Via Pre-Spray Bottle onto tar on paintwork, leave to dwell and then rinse off.

Some Risk, No means to improve RISK LEVEL : Level 2 Low if good standard of occupational hygiene are observed and correct Personal Protective Equipment worn.


Hydrocarbons 1000 mg/m3 - Exylene 50 ppm 220 mg/m3 100 ppm 441 mg/m3 Further information is available from the Motorclean MSDS Manual. MSDS REVIEW DATE: Autosmart – 09/10/12 Motorclean – 31/12/18 TIME AND FREQUENCY OF ACTIVITY Daily dependant on volume of cars to be cleaned and if necessary to use.

PERSONAL PROTECTIVE EQUIPMENT REQUIREMENTS (PPE) Safety Glasses / Goggles 3M Mask (if ventilation is insufficient) Nitrile Gloves Safety Boots All to be used when decanting and applying this product.

PRESENT CONTROL OUTSIDE PPE Used in a well ventilated area

COMMENTS / ACTIONS REQUIRED Do not ingest product. Store product at a temperature below 35degrees C.

Avoid contact with skin. Do not discharge into drains.


COSHH ASSESSMENT

PRODUCT NAME : Biobrisk HAZARD : SUPPLIER : Autosmart R10 - Flammable SDS No : 10135 R65 – May cause lung damage if swallowed PROD No : 119-6 R38 – Irritating to skin R41 – Risk of serious damage to eyes ACTIVITY : Biological interior cleaner PERSONNEL : Valeting Staff

LOCATION : Valet Bay COLOUR : Milky

DILUTION RATIO : 10 - 1 DILUTION METHOD : Decant into a spray bottle APPLICATION METHOD : Spray onto fabric, agitate with cloth and wipe down with cloth. RISK LEVEL : Level 2 Some Risk, No means to improve Low if good standard of occupational hygiene are observed and correct Personal Protective Equipment worn. WORKPLACE EXPOSURE LIMIT (WEL) NAME TWA – 8HRS STEL – 15MIN 2-Butoxyethanol 25 ppm 123 mg/m3 50 ppm 246 mg/m3 Further information is available from the Motorclean MSDS Manual. MSDS REVIEW DATE: Autosmart – 10/12/12 Motorclean – 31/12/18

TIME AND FREQUENCY OF ACTIVITY Daily dependant on volume of cars to be cleaned. Could be used on up to 20 vehicles per day.


Safety Glasses / Goggles Safety Boots Nitrile Gloves All to be used when decanting and apply ing this product.

PRESENT CONTROL OUTSIDE PPE None COMMENTS / ACTIONS REQUIRED The use of safety equipment provided Do not ingest product. must be obligatory. Avoid contact with skin. Do not discharge into drains.


COSHH ASSESSMENT

PRODUCT NAME : G101 HAZARD : SUPPLIER : Autosmart R41 – Risk of serious damage toSDS No : 11028 eyes PROD No : 237-3 R38 – Irritating to Skin

ACTIVITY : Interior Cleaning PERSONNEL : Valeting Staff

LOCATION : Valet Bay

COLOUR : Green DILUTION RATIO : 12-1 DILUTION METHOD : Through wall mixer into spray bottle APPLICATION METHOD : Via Spray Bottle onto cloth or microfiber cloth



Sodium Hydroxide - 2 mg/m3 Further information is available from the Motorclean MSDS Manual. MSDS REVIEW DATE: Autosmart – 30/07/13 Motorclean – 31/12/18

TIME AND FREQUENCY OF ACTIVITY Daily dependant on volume of cars to be cleaned. This product may not be used on every vehicle


Safety Glasses / Goggles 3M Mask (if ventilation is insufficient) Nitrile Gloves Safety Boots

All to be used when decanting and applying this product. PRESENT CONTROL OUTSIDE PPE None



COSHH ASSESSMENT

PRODUCT NAME : Cherry Glaze HAZARD : SUPPLIER : Autosmart R10 – Flammable SDS No : 10322 R22 – Harmful if swallowed PROD No : 453-10 R34 - Causes Burns

R50- Toxic to aquatic organisms ACTIVITY : PDI Polish R65 – May cause lung damage if PERSONNEL : Valeting Staff swallowed. LOCATION : Valet Bay R66-may cause skin dryness/cracking

COLOUR : Pink DILUTION RATIO : Undiluted DILUTION METHOD : N/A APPLICATION METHOD : Decant into a polish applicator bottle and apply Using a polishing sponge, remove using a microfiber cloth.



Aluminium Silicate 2 mg/m3 - Distillates (petroleum) 1000 mg/m3 - Hydrotreated light Hydrocarbons, c9-c11 1000 mg/m3 - Further information is available from the Motorclean MSDS Manual. MSDS REVIEW DATE: Autosmart – 10/01/13 Motorclean – 31/12/18

TIME AND FREQUENCY OF ACTIVITY Daily dependant on volume of cars to be cleaned.

PERSONAL PROTECTIVE EQUIPMENT REQUIREMENTS (PPE) Safety Glasses / Goggles Safety BootsNitrile Gloves All to be used when decanting and applying this product.

PRESENT CONTROL OUTSIDE PPE None

COMMENTS / ACTIONS REQUIRED The use of safety equipment provided Do not ingest product. must be obligatory. Avoid contact with skin. Do not discharge into drains.


COSHH ASSESSMENT

PRODUCT NAME : Mirror Image HAZARD : SUPPLIER : Autosmart R34 – Causes burns SDS No : 10109 R10 - Flammable PROD No : 140-22 R65 – May cause lung damage if swallowed

ACTIVITY : Body Polish

PERSONNEL : Valeting Staff

LOCATION : Valet Bay COLOUR : Yellow DILUTION RATIO : Undiluted

DILUTION METHOD : N/A APPLICATION METHOD : Decant into a polish applicator bottle and apply Using a polishing sponge, remove using a microfiber cloth. RISK LEVEL : Level 2 Some Risk, No means to improve Low if good standard of occupational hygiene are observed and correct Personal Protective Equipment worn.

WORKPLACE EXPOSURE LIMIT (WEL) NAME TWA – 8HRS STEL – 15MIN Aluminium Silicate 2 mg/m3 - Hydrocarbons 1000 mg/m3 - Further information is available from the Motorclean MSDS Manual. MSDS REVIEW DATE: Autosmart – 03/12/12 Motorclean – 31/12/18






COSHH ASSESSMENT

PRODUCT NAME : Glass Cleaner HAZARD : SUPPLIER : Autosmart R10 – Flammable SDS No : 10059 R67 – Vapours may cause drowsiness PROD No : 307-15 and dizziness

ACTIVITY : Cleaning of glass PERSONNEL : Valeting Staff LOCATION : Valet Bay

COLOUR : Green DILUTION RATIO : Undiluted DILUTION METHOD : N/A APPLICATION METHOD : Decant into a spray bottle and apply to glass. Use paper towel or a microfiber cloth clean the glass.


WORKPLACE EXPOSURE LIMIT (WEL) NAME TWA – 8HRS S TEL – 15MIN

1-Methoxy-2-Propanol 100 ppm 375 mg/m3 150 ppm 560 mg/m3 Further information is available from the Motorclean MSDS Manual. MSDS REVIEW DATE: Autosmart – 30/11/12 Motorclean – 31/12/18




COMMENTS / ACTIONS REQUIREDThe use of safety equipment provided Store product at a temperature belowmust be obligatory. 35degrees C. Avoid contact with skin. Do not discharge into drains. Do not ingest product.


COSHH ASSESSMENT

PRODUCT NAME : Glass Glow HAZARD : SUPPLIER : Autosmart R38 – Irritating to skin SDS No : 10974 R67 – Vapours may cause drowsinessPROD No : 188-2 and dizziness R51/R53 – Toxic to aquatic organismsACTIVITY : Cleaning of glass may cause long term effects in the PERSONNEL : Valeting Staff aquatic environment. LOCATION : Valet Bay

COLOUR : Green (emulsion) DILUTION RATIO : Undiluted DILUTION METHOD : N/A APPLICATION METHOD : Decant into a polish applicator bottle and apply to Glass using a polishing sponge. Remove using a microfiber cloth.



Aluminium Silicate 2 mg/m3 - Hydrocarbons 1000 mg/m3 - Further information is available from the Motorclean MSDS Manual. MSDS REVIEW DATE: Autosmart – 24/09/12 Motorclean – 31/12/18 TIME AND FREQUENCY OF ACTIVITY Daily dependant on volume of cars to be cleaned.

PERSONAL PROTECTIVE EQUIPMENT REQUIREMENTS (PPE) Safety Glasses / Goggles Safety Boots Nitrile Gloves All to be used when decanting and applying this product.

PRESENT CONTROL OUTSIDE PPE Use in a well ventilated area

COMMENTS / ACTIONS REQUIRED The use of safety equipment provided Store product at a temperature below must be obligatory. 35degrees C. Avoid contact with skin. Do not discharge into drains. Do not ingest product. Prepared By: Motorclean Ltd ‐ Jan 2019 of 66

COSHH ASSESSMENT

PRODUCT NAME : Highstyle HAZARD : SUPPLIER : Autosmart R10 – Flammable SDS No : 10150 R66 – Repeated exposure mayPROD No : 314-14 Cause skin dryness or cracking

R67 – Vapours may cause ACTIVITY : Dressing of Tyres drowsiness or dizziness PERSONNEL : Valeting Staff R65 – Harmful – may cause lung

damage if swallowed LOCATION : Valet Bay

COLOUR : Orange DILUTION RATIO : Undiluted DILUTION METHOD : N/A APPLICATION METHOD : Decant into Spray Bottle, apply to dressing sponge And then apply to tyre.



Hydrocarbons 1000 mg/m3 - Further information is available from the Motorclean MSDS Manual. MSDS REVIEW DATE: Autosmart – 03/10/12 Motorclean – 31/12/18


PERSONAL PROTECTIVE EQUIPMENT REQUIREMENTS (PPE)Safety Glasses / Goggles Safety Boots Nitrile Gloves All to be used when decanting and apply ing this product.

PRESENT CONTROL OUTSIDE PPE None COMMENTS / ACTIONS REQUIREDThe use of safety equipment provided Store product at a temperature belowmust be obligatory. 35degrees C. Avoid contact with skin. Do not discharge into drains. Do not ingest product. Slip hazard if spilt on floor surface


COSHH ASSESSMENT

PRODUCT NAME : Non Silicone Highstyle HAZARD : SUPPLIER : Autosmart R10 – Flammable SDS No : 10196 R66 – Repeated exposure may PROD No : 329-11 Cause skin dryness or cracking R67 – Vapours may cause ACTIVITY : Dressing of Tyres drowsiness or dizziness PERSONNEL : Valeting Staff


COLOUR : Orange DILUTION RATIO : Undiluted DILUTION METHOD : N/A APPLICATION METHOD : Decant into Spray Bottle, apply to dressing spongeAnd then apply to tyre.

Some Risk, No means to improve RISK LEVEL : Level 2 Low if good standard of occupational hygiene are observed and correct PersonalProtective Equipment worn.


Hydrocarbons 1000 mg/m3 - Liquid Paraffin 5 mg/m3 10 mg/m3 Propan-2-ol 400 ppm 999 mg/m3 500 ppm 1250 mg/m3 Further information is available from the Motorclean MSDS Manual. MSDS REVIEW DATE: Autosmart – 03/10/12 Motorclean – 31/12/18



Safety Glasses / Goggles Safety Boots Nitrile Gloves All to be used when decanting and applying this product.

PRESENT CONTROL OUTSIDE PPE None COMMENTS / ACTIONS REQUIRED The use of safety equipment provided Store product at a temperature below must be obligatory. 35degrees C. Avoid contact with skin. Do not discharge into drains. Do not ingest product. Slip hazard if spilt on floor surface


COSHH ASSESSMENT

PRODUCT NAME : Leather Cleaner HAZARD : SUPPLIER : Autosmart R41 – Risk of serious damage to SDS No : 10515 eyes PROD No : 331-18 R36/38-Irritating to Eyes and Skin

ACTIVITY : Cleaning of leather upholstery R22 – Harmful if swallowed

PERSONNEL : Valeting Staff


COLOUR : Yellow DILUTION RATIO : Undiluted DILUTION METHOD : N/A APPLICATION METHOD : Via Spray Bottle onto cloth or microfiber cloth



None stated - - Further information is available from the Motorclean MSDS Manual. MSDS REVIEW DATE: Autosmart – 10/01/13Motorclean – 31/12/18



Safety Glasses / Goggles Safety Boots Nitrile Gloves




COSHH ASSESSMENT

PRODUCT NAME : Upholstery and Interior Cleaner HAZARD : SUPPLIER : Autosmart R34 – Causes Burns SDS No : 10452 R20/21/22- skin, swallowed or inhaled

PROD No : 317-18 R36/38 – Irritating to eyes/skin

ACTIVITY : Interior upholstery cleaning PERSONNEL : Valeting Staff


COLOUR : Blue DILUTION RATIO : 5-1 DILUTION METHOD : Dilute with water into a spray bottle or Wet Vac. APPLICATION METHOD : Via Wet Vac extraction or spray bottle RISK LEVEL : Level 2 Some Risk, No means to improve Low if good standard of occupational hygiene are observed and correct PersonalProtective Equipment worn.


2-Butoxyethanol 25 ppm 123 mg/m3 50 ppm 246 mg/m3 Further information is available from the Motorclean MSDS Manual. MSDS REVIEW DATE: Autosmart – 04/03/13 Motorclean – 31/12/18

TIME AND FREQUENCY OF ACTIVITY Daily dependant on volume of cars to be cleaned. Could be used on up to 20vehicles per day.


Safety Glasses / Goggles 3M Mask (if ventilation is insufficient) Nitrile Gloves

Safety Boots All to be used when decanting and apply ing this product.



COSHH ASSESSMENT

PRODUCT NAME : Ali Shine HAZARD : SUPPLIER : Autosmart R34 – Causes Burns SDS No : 10490 R22 – Harmful if swallowed PROD No : 143-13 R36/38 – Irritating to eyes/skin

R50 – Toxic to aquatic organisms ACTIVITY : Cleaning Alloy Wheels R41 – Risk of serious damage to

eyes PERSONNEL : Valeting Staff LOCATION : Wet Bay

COLOUR : Red DILUTION RATIO : 4-1 DILUTION METHOD : 5 ltrs into a 25ltr Container & top up with Water APPLICATION METHOD : Via 6ltr sprayer and agitate with brush RISK LEVEL : Level 2 Some Risk, No means to improveLow if good standard of occupational hygiene are observed and correct Personal Protective Equipment worn.


Hydrochloric Acid 1ppm-2mg/m3 5ppm-8mg/m3 Further information is available from the Motorclean MSDS Manual. MSDS REVIEW DATE: Autosmart – 19/09/12 Motorclean – 31/12/18




COMMENTS / ACTIONS REQUIREDThe use of safety equipment provided Store product at a temperature belowmust be obligatory. 35degrees C. Avoid contact with skin. Do not discharge into drains. Do not ingest product.


COSHH ASSESSMENT

PRODUCT NAME : Aquawax HAZARD : SUPPLIER : Autosmart R34 – Causes burns SDS No : 10441 R20/21/22 – Harmful by

inhalation, skin, swallowed PROD No : 475-8 R11 – Highly flammable

R67- Vapours may cause dizziness and drowsiness ACTIVITY : Vehicle Pain Protector R50 – Very Toxic to aquatic

organisms PERSONNEL : Valeting Staff LOCATION : Wet Bay

COLOUR : Blue Green DILUTION RATIO : 150 - 1 DILUTION METHOD : Dilute with water into a sprayer APPLICATION METHOD : Using a 6Ltr Sprayer then rinse with cold pressurewasher RISK LEVEL : Level 2 Some Risk, No means to improve Low if good standard of occupational hygiene are observed and correct PersonalProtective Equipment worn.


2-Butoxyethanol 25ppm-123mg/m3 50ppm-246mg/m3 Propan -2-ol 400ppm-999mg/m3 500ppm-1250mg/m3Further information is available from the Motorclean MSDS Manual. MSDS REVIEW DATE: Autosmart – 14/06/12 Motorclean – 31/12/18




COMMENTS / ACTIONS REQUIRED The use of safety equipment provided Store product at a temperature belowmust be obligatory. 35degrees C. Do not ingest product. Do not discharge into drains.


COSHH ASSESSMENT

PRODUCT NAME : Autofresh HAZARD : SUPPLIER : Autosmart R22 – Harmful if swallowed SDS No : 10632 R41 – Risk of serious damage to

eyes PROD No : 407-3

ACTIVITY : Odourising Vehicles PERSONNEL : Valeting Staff LOCATION : Dry Bay

COLOUR : DILUTION RATIO : 4-1 DILUTION METHOD : Dilute with water into a sprayer APPLICATION METHOD : Via spray bottle RISK LEVEL : Level 2 Some Risk, No means to improveLow if good standard of occupational hygiene are observed and correct Personal Protective Equipment worn.


- - Further information is available from the Motorclean MSDS Manual. MSDS REVIEW DATE: Autosmart – 15/04/13 Motorclean – 31/12/18




COMMENTS / ACTIONS REQUIREDThe use of safety equipment provided Do not ingest product must be obligatory. Avoid contact with skin. Do not ingest product


COSHH ASSESSMENT

PRODUCT NAME : Blast (Aerosals) HAZARD : SUPPLIER : Autosmart R12 – Extremely flammable SDS No : 10865 R36 – Irritating to eyes PROD No : R67 – Vapours may cause

dizziness and drowsiness ACTIVITY : Odourising vehicles PERSONNEL : Valeting Staff LOCATION : Dry Bay

COLOUR : N/A DILUTION RATIO : N/A DILUTION METHOD : N/A APPLICATION METHOD : Spray Direct into Vehicle via Aerosol



Butane 600ppm-1450mg/m3 750ppm-1810mg/m3 Propane -2-Ol 400ppm-999mg/m3 500ppm-1250mg/m3 Further information is available from the Motorclean MSDS Manual. MSDS REVIEW DATE: Autosmart – 15/10/12 Motorclean – 31/12/18



PRESENT CONTROL OUTSIDE PPE None COMMENTS / ACTIONS REQUIREDThe use of safety equipment provided Store product at a temperature belowmust be obligatory. 35degrees C. Avoid contact with skin. Do not ingest product.


COSHH ASSESSMENT

PRODUCT NAME : Brisk Extra HAZARD : SUPPLIER : Autosmart R22 – Harmful if swallowed SDS No : 10609 R11 – Highly flammable PROD No : 497-7 R38 – Irritating to Skin

R41 – Risk of serious damage to eyes ACTIVITY : Fabric Stain Removal PERSONNEL : Valeting Staff LOCATION : Dry Bay

COLOUR : Lightly Coloured DILUTION RATIO : 10- 1 DILUTION METHOD : Decante into spray bottle with water APPLICATION METHOD : Using Spray bottle RISK LEVEL : Level 2 Some Risk, No means to improveLow if good standard of occupational hygiene are observed and correct Personal Protective Equipment worn.


Propan – 2- Ol 400ppm-999mg/m3 500ppm-1250mg/m3 Further information is available from the Motorclean MSDS Manual. MSDS REVIEW DATE: Autosmart – 06/12/11 Motorclean – 31/12/18




COMMENTS / ACTIONS REQUIRED The use of safety equipment provided Store product at a temperature belowmust be obligatory. 35degrees C. Avoid contact with skin. Do not discharge into drains. Do not ingest product.


COSHH ASSESSMENT

PRODUCT NAME : Brushwash HAZARD : SUPPLIER : Autosmart Not classified SDS No : 10480

PROD No : 470-6

ACTIVITY :Applying Vehicle Shampoo PERSONNEL : Valeting Staff

LOCATION : Wet Bay

COLOUR : Pink DILUTION RATIO : 60 - 1 DILUTION METHOD : Via Wall mixer or 2.5ltr into 150ltrs water APPLICATION METHOD : Apply with brush from bucket RISK LEVEL : Level 2 Some Risk, No means to improve Low if good standard of occupational hygiene are observed and correct PersonalProtective Equipment worn.









COSHH ASSESSMENT

PRODUCT NAME : Carpet Grey (Aerosol) HAZARD : SUPPLIER : Autosmart R12 – Extremely flammable SDS No : 10325 R22-Harmful if swallowed PROD No : A203-6 R41-Risk of extremely damaging eyes R37/38-Irritating to respiratory system ACTIVITY : Restoring Car mats R66 – May cause skin dryness or cracking PERSONNEL : Valet Staff LOCATION : Dry Bay COLOUR : Grey Paint

DILUTION RATIO : N/A DILUTION METHOD : N/A APPLICATION METHOD : Spray Direct from Aerosol onto Car mat RISK LEVEL : Level 2 Some Risk, No means to improve Low if good standard of occupational hygiene are observed and correct Personal Protective Equipment worn.

WORKPLACE EXPOSURE LIMIT (WEL) NAME TWA – 8HRS STEL – 15MIN 2-Methoxy-1- 50ppm-274mg/m3 100ppm-548mg/m3 Methylethyl Acetate Acetone 500ppm-1210mg/m3 1500ppm-3620mg/m3 Butane 600ppm-1450mg/m3 750ppm-1810mg/m3 Butanol-norm 50ppm-154mg/m3 Propan- 2-Ol 400ppm-999mg/m3 500ppm-1250mg/m3 Further information is available from the Motorclean MSDS Manual. MSDS REVIEW DATE: Autosmart – 16/10/12 Motorclean – 31/12/18




PRESENT CONTROL OUTSIDE PPE None COMMENTS / ACTIONS REQUIRED

The use of safety equipment provided Do not ingest product.


COSHH ASSESSMENT

PRODUCT NAME : Clear View HAZARD : SUPPLIER : Autosmart R11 – Highly flammable SDS No : 10416 R39/23/24/25- Danger of very

Serious irreversible effects through inhalation, in contact with skin and if swallowed PROD No : 37-21 R36 – Irritating to eyes

ACTIVITY : Glass Cleaner PERSONNEL : Valet Staff LOCATION : Dry bay

COLOUR : Blue DILUTION RATIO : Undiluted DILUTION METHOD : N/A APPLICATION METHOD : Via Spray bottle RISK LEVEL : Level 2 Some Risk, No means to improve Low if good standard of occupational hygiene are observed and correct Personal Protective Equipment worn.


Ethanediol 20ppm-10mg/m3 40ppm-104mg/m3 Methanol 200ppm-266mg/m3 250ppm-333mg/m3 Propan- 2-Ol 400ppm-999mg/m3 500ppm-1250mg/m3Further information is available from the Motorclean MSDS Manual. MSDS REVIEW DATE: Autosmart – 21/09/12 Motorclean – 31/12/18




COMMENTS / ACTIONS REQUIRED The use of safety equipment provided Store product at a temperature belowmust be obligatory. 35degrees C. Avoid contact with skin. Do not ingest product.


COSHH ASSESSMENT

PRODUCT NAME : Dash Dand y HAZARD : SUPPLIER : Autosmart R12 – Extremely Flammable SDS No : 10524 R52/53 – Toxic to aquatic organisms PROD No : A107-8

ACTIVITY : Dressing PERSONNEL : Valeting Staff

LOCATION : Dry Bay

COLOUR : N/A DILUTION RATIO : N/A

DILUTION METHOD : N/A APPLICATION METHOD : Apply via Microfibre cloth RISK LEVEL : Level 2 Some Risk, No means to improve Low if good standard of occupational hygiene are observed and correct Personal Protective Equipment worn. WORKPLACE EXPOSURE LIMIT (WEL) NAME TWA – 8HRS STEL – 15MIN Butane 600ppm1450mg/m3- 750ppm-1810mg/m3 Special boiling point -1000mg/m3

spirit 60/95n-Hexane Further information is available from the Motorclean MSDS Manual. MSDS REVIEW DATE: Autosmart – 16/10/12 Motorclean – 31/12/18


PERSONAL PROTECTIVE EQUIPMENT REQUIREMENTS (PPE) Safety Glasses / Goggles Nitrile Gloves Safety Boots All to be used when decanting and applying this product.


COMMENTS / ACTIONS REQUIRED The use of safety equipment provided Store product at a temperature below must be obligatory. 35degrees C.

Avoid contact with skin. Use in well ventilated area


COSHH ASSESSMENT

PRODUCT NAME : Envirowash HAZARD : SUPPLIER : Autosmart R22 – Harmful if swallowed SDS No : 10243 R41 – Serious damage to eyes PROD No : 230-1 R40 – Limited evidence of

carcinogenic effect ACTIVITY : Cleaning Agent PERSONNEL : Valet Staff LOCATION : Wet Bay

COLOUR : Light Pale Straw DILUTION RATIO : 14-1 DILUTION METHOD : Via Wall mixer or 12.5ltr into 205ltr Drum and top up APPLICATION METHOD : Via 6ltr sprayer RISK LEVEL : Level 2 Some Risk, No means to improve Low if good standard of occupational hygiene are observed and correct Personal Protective Equipment worn.



TIME AND FREQUENCY OF ACTIVITY Daily dependant on volume of cars to be cleaned. U to 40 vehicles per day.

PERSONAL PROTECTIVE EQUIPMENT REQUIREMENTS (PPE) Safety Glasses / Goggles Safety BootsNitrile Gloves All to be used when decanting and applying this product.


COMMENTS / ACTIONS REQUIRED The use of safety equipment provided Store product at a temperature belowmust be obligatory. 35degrees C. Avoid contact with skin. Do not discharge into drains. Do not ingest product.


COSHH ASSESSMENT

PRODUCT NAME : Evo1 HAZARD : SUPPLIER : Autosmart R65- May cause lung damage if

swallowed SDS No : 10643 R66 – May cause skin dryness

and cracking PROD No : 235-1 R41 – Risk of serious damage to

eyes ACTIVITY : Polish PERSONNEL : Valeting Staff LOCATION : Dry Bay

COLOUR : White DILUTION RATIO : Undiluted DILUTION METHOD : APPLICATION METHOD : Apply using straight lines before T -CuttingRISK LEVEL : Level 2 Some Risk, No means to improve Low if good standard of occupational hygiene are observed and correct Personal Protective Equipment worn.


Alaminium Oxide -10mg/m3 - Distillated(Petroleum) -1000mg/m3

Hydrotreated light Liquid Paraffin -5mg/m3 10mg/m3 Further information is available from the Motorclean MSDS Manual. MSDS REVIEW DATE: Autosmart – 23/05/13 Motorclean – 31/12/18




COMMENTS / ACTIONS REQUIREDThe use of safety equipment provided must Store product at a temperature belowbe obligatory. 35degrees C. Avoid contact with skin. Do not ingest product.


COSHH ASSESSMENT

PRODUCT NAME : Evo3 HAZARD : SUPPLIER : Autosmart R65 – May cause lung damage if swallowed SDS No : 10642 R41 – Serious risk to the eyes PROD No : 234-1 R66 – May cause skin dryness or cracking ACTIVITY : Polish PERSONNEL : Valeting Staff

LOCATION : Dry Bay

COLOUR : White

DILUTION RATIO : Undiluted DILUTION METHOD : Undiluted APPLICATION METHOD : Apply using machine polisher or cloth RISK LEVEL : Level 2 Some Risk, No means to improve Low if good standard of occupational hygiene are observed and correct Personal Protective Equipment worn.

WORKPLACE EXPOSURE LIMIT (WEL) NAME TWA – 8HRS STEL – 15MIN Alaminium Oxide --10mg/m3 - Distillated(Petroleum) -1000mg/m3

Hydrotreated light Liquid Paraffin 5mg/m3 10mg/m3 Further information is available from the Motorclean MSDS Manual. MSDS REVIEW DATE: Autosmart – 23/05/13 Motorclean – 31/12/18





COMMENTS / ACTIONS REQUIRED The use of safety equipment provided must Store product at a temperature below be obligatory. 35degrees C. Avoid contact with skin. Do not discharge into drains. Do not ingest product.


COSHH ASSESSMENT

PRODUCT NAME : Fallout Remover HAZARD : SUPPLIER : Autosmart R21/22- Harmful in contact with skin and if swallwed SDS No : 11192 R36/37/38- irritating to eyes, respiratory system and skin PROD No : 241-1

ACTIVITY : Removing Fallout from vehicles PERSONNEL : Valeting Staf

LOCATION : Wet Bay

COLOUR :

DILUTION RATIO : Undiluted DILUTION METHOD : APPLICATION METHOD : Use 6L sprayer or 600ml Spray bottle agitate using a sponge RISK LEVEL : Level 2 Some Risk, No means to improve Low if good standard of occupational hygiene are observed and correct Personal Protective Equipment worn. WORKPLACE EXPOSURE LIMIT (WEL) NAME TWA – 8HRS STEL – 15MIN Oxalic Acid -1mg/m3 -2mg/m3 Further information is available from the Motorclean MSDS Manual. MSDS REVIEW DATE: Autosmart – 06/02/12 Motorclean – 31/12/18

TIME AND FREQUENCY OF ACTIVITY Daily dependant on volume of cars to be cleaned. May not be used in every vehicle


Safety Glasses / Goggles Safety Boots Nitrile Gloves All to be used when decanting and applying this product. PRESENT CONTROL OUTSIDE PPE Use in a well Ventilated area COMMENTS / ACTIONS REQUIRED The use of safety equipment provided Store product at a temperature below must be obligatory. 35degrees C. Avoid contact with skin. Do not discharge into drains. Do not ingest product.


COSHH ASSESSMENT

PRODUCT NAME : Finish HAZARD : SUPPLIER : Autosmart SDS No : 10149

PROD No : 305-17

ACTIVITY : Dressing PERSONNEL : Valeting Staff

LOCATION : Dry Bay

COLOUR : Milky White

DILUTION RATIO : Undiluted DILUTION METHOD : APPLICATION METHOD : Using a spray bottle RISK LEVEL : Level 2 Some Risk, No means to improve Low if good standard of occupational hygiene are observed and correct PersonalProtective Equipment worn.



TIME AND FREQUENCY OF ACTIVITY Daily dependant on volume of cars to be cleaned. Very few have paint protection kits






COSHH ASSESSMENT

PRODUCT NAME : Highstyle Non- HAZARD : Silicone SUPPLIER : Autosmart R10 - Flammable SDS No : 10196 R65 – May cause lung damage if

swallowed PROD No : 329-11 R36 – Irritating to eyes

R66 – Repeated exposure may cause skin dryness and cracking ACTIVITY : Dressing Tyres R67 – Vapours may cause

dizziness and drowsiness PERSONNEL : Valeting Staff LOCATION : Dry Bay

COLOUR : Orange DILUTION RATIO : Undiluted DILUTION METHOD : APPLICATION METHOD : Decant into small bucket and apply with 4” brush RISK LEVEL : Level 2 Some Risk, No means to improve Low if good standard of occupational hygiene are observed and correct Personal Protective Equipment worn.


Hydrocarbons, -1000mg/m3 - Liquid Paraffin -5mg/m3 -10mg/m3 Propan- 2-Ol 400ppm-999mg/m3 500ppm-1250mg/m3 Further information is available from the Motorclean MSDS Manual. MSDS REVIEW DATE: Autosmart – 03/10/12 Motorclean – 31/12/18


PERSONAL PROTECTIVE EQUIPMENT REQUIREMENTS (PPE)Safety Glasses / Goggles Safety Boots Nitrile Gloves Face Mask All to be used when decanting and applying this product.

PRESENT CONTROL OUTSIDE PPE Use in a well Ventilated area

COMMENTS / ACTIONS REQUIRED The use of safety equipment provided Store product at a temperature belowmust be obligatory. 35degrees C. Avoid contact with skin. Do not ingest product.


COSHH ASSESSMENT

PRODUCT NAME : Jelsol (Aerosol) HAZARD : SUPPLIER : Autosmart R12 – Extremely flammable SDS No : 10459 R20/21 – Harmful by inhalationPROD No : A44-6 R65 – May cause lung damage if swallowed

ACTIVITY : Adhesive & graffiti remover R38 – Irritating to skin

PERSONNEL : Valet Staff

LOCATION : Dry Bay

COLOUR : Undiluted

DILUTION RATIO : DILUTION METHOD : N/A APPLICATION METHOD : Spray affected area,remove with microfibre cloth RISK LEVEL : Level 2 Some Risk, No means to improve Low if good standard of occupational hygiene are observed and correct PersonalProtective Equipment worn.


Butane 600ppm-1450mg/m3 750ppm-1810mg/m3 Hydrocarbons -1000mg/m3 Methanol 200ppm-266mg/m3 250ppm-333mg/m3 Xlyene 50ppm-220mg/m3 100ppm-441mg/m3 Further information is available from the Motorclean MSDS Manual. MSDS REVIEW DATE: Autosmart – 17/10/12 Motorclean – 31/12/18



Safety Glasses / Goggles Safety Boots Nitrile Gloves Face Mask All to be used when decanting and applying this product.

PRESENT CONTROL OUTSIDE PPE Use in a well ventilated areaCOMMENTS / ACTIONS REQUIRED

The use of safety equipment provided Store product at a temperature belowmust be obligatory. 35degrees C. Avoid contact with skin. Do not discharge into drains. Do not ingest product.


COSHH ASSESSMENT

PRODUCT NAME : Kril HAZARD : SUPPLIER : Autosmart R12 – Extremely flammable SDS No : 10248 R20/21- Harmful by inhalation

and irritating to the skin PROD No : A45-6 R51/53- Toxic to aquatic

organisms R65 – May cause lung damage if swallowed ACTIVITY : Dressing Engines (laquer) R67 – Vapours may cause

dizziness or drowsiness PERSONNEL : Valeting Staff LOCATION : Dry Bay

COLOUR : Yellow DILUTION RATIO : Undiluted DILUTION METHOD : Undiluted APPLICATION METHOD : Using Spray bottle RISK LEVEL : Level 2 Some Risk, No means to improve Low if good standard of occupational hygiene are observed and correct PersonalProtective Equipment worn.


Butane 600ppm-1450mg/m3 750ppm-1810mg/m3 Ethylbenzene 100ppm-441mg/m3 125ppm-552mg/m3Hydrocarbons 1000mg/m3 Xylene 50ppm-220mg/m3 100ppm-441mg/m3 Further information is available from the Motorclean MSDS Manual. MSDS REVIEW DATE: Autosmart – 18/03/10 Motorclean – 31/12/18


PERSONAL PROTECTIVE EQUIPMENT REQUIREMENTS (PPE)Safety Glasses / Goggles Safety Boots Nitrile Gloves Face Mask All to be used when decanting and apply ing this product.

PRESENT CONTROL OUTSIDE PPE Use in a well ventilated area COMMENTS / ACTIONS REQUIREDThe use of safety equipment provided Do not ingest product.


COSHH ASSESSMENT

PRODUCT NAME : Matt Black (Aerosol) HAZARD : SUPPLIER : Autosmart R12 – Extremely flammable SDS No : 10536 R36/37 – Irritating to eyes and

PROD No : A47-5 respiratory system

ACTIVITY : Paint PERSONNEL : Valet staff

LOCATION : Dry bay

COLOUR : Black DILUTION RATIO : N/A DILUTION METHOD : N/A APPLICATION METHOD : Spray Sparingly onto Affected area RISK LEVEL : Level 2 Some Risk, No means to improve Low if good standard of occupational hygiene are observed and correct PersonalProtective Equipment worn.


1-Methoxy-2- 100ppm-375mg/m3 150ppm-560mg/m3 Propanol Acetone 500ppm-1210mg/m3 1500ppm-3620mg/m3 Butane 600ppm-1450mg/m3 750ppm-1810mg/m3 Butyl Acetate 150ppm-724mg/m3 200ppm-966mg/m3 Further information is available from the Motorclean MSDS Manual. MSDS REVIEW DATE: Autosmart – 16/10/12 Motorclean – 31/12/18




All to be used when decanting and applying this product. PRESENT CONTROL OUTSIDE PPE Use in a well ventilated area

COMMENTS / ACTIONS REQUIRED The use of safety equipment provided Do not ingest product. must be obligatory.



COSHH ASSESSMENT

PRODUCT NAME : Mechoil HAZARD : SUPPLIER : Autosmart R12 – Extrenely Flammable SDS No : 10129 R65 – May cause lung damage if

PROD No : A207-4 swallowed

ACTIVITY : Lubricant PERSONNEL : Valet Staff

LOCATION : Dry Bay

COLOUR : Brown DILUTION RATIO : N/A DILUTION METHOD : N/A APPLICATION METHOD : Spray onto area requiring lubrication RISK LEVEL : Level 2 Some Risk, No means to improve Low if good standard of occupational hygiene are observed and correct PersonalProtective Equipment worn.


Butane 600ppm-1450mg/m3 750ppm-1810mg/m3 Hydrocarbons -1000mg/m3

Mineral Oil -5mg/m3 -10mg/m3 Further information is available from the Motorclean MSDS Manual. MSDS REVIEW DATE: Autosmart – 25/10/12 Motorclean – 31/12/18






COSHH ASSESSMENT

PRODUCT NAME : Midnight HAZARD : SUPPLIER : Autosmart R11 – Highly flammable SDS No : 10571 R36 – Irritating to eyes PROD No : 1004-1 R37/38 – Irritating to respiratory

system and skin R23/24/25 – Toxic by Inhalation ACTIVITY : Spray on Dye for Carpets PERSONNEL : Valeting Staff LOCATION : Dry Bay

COLOUR : Dark Grey DILUTION RATIO : Undiluted DILUTION METHOD : Undiluted APPLICATION METHOD : Using Spray bottle very sparingly wipe off anyExcess and allow to dry RISK LEVEL : Level 2 Some Risk, No means to improve Low if good standard of occupational hygiene are observed and correct PersonalProtective Equipment worn.


1-methoxy-2 100ppm-375mg/m3 150ppm-560mg/m3propanol Butanone 200ppm(sk)-600mg/m3(sk) 300ppm(sk)-899mg/m3(sk)Ethanol 1000ppm-1920mg/m3 Ethyl Acetate 200ppm 400ppm ISO-Butanol 50ppm-154mg/m3 75ppm-231mg/m3Methanol 200ppm-266mg/m3 250ppm-333mg/m3 Further information is available from the Motorclean MSDS Manual. MSDS REVIEW DATE: Autosmart – 18/09/12 Motorclean – 31/12/18

TIME AND FREQUENCY OF ACTIVITY Daily dependant on volume of cars to be cleaned. Not used on all vehicles

PERSONAL PROTECTIVE EQUIPMENT REQUIREMENTS (PPE)Safety Glasses / Goggles Nitrile Gloves All to be used when decanting and applying this product.

PRESENT CONTROL OUTSIDE PPE Use in a well ventilated area COMMENTS / ACTIONS REQUIREDAvoid contact with skin. Do not ingest product.


COSHH ASSESSMENT

PRODUCT NAME : Multifresh HAZARD : SUPPLIER : Autosmart R35 – Causes severe burns SDS No : 11106 R10 - Flammable PROD No : 471-5 R36/38 – Irritating to eyes and

skin ACTIVITY : Cleaning Agent PERSONNEL : Valet Staff LOCATION : Dry Bay

COLOUR : Yellow DILUTION RATIO : Undiluted DILUTION METHOD : Undiluted APPLICATION METHOD : Using Spray bottle very sparingly wipe off anyRISK LEVEL : Level 2 Some Risk, No means to improve Low if good standard of occupational hygiene are observed and correct Personal Protective Equipment worn.


1-Methoxy-2- 100ppm-375mg/m3 150ppm-560mg/m3Propanol Sodium Hydroxide -2mg/m3 Further information is available from the Motorclean MSDS Manual. MSDS REVIEW DATE: Autosmart – 19/05/14 Motorclean – 31/12/18





COSHH ASSESSMENT

PRODUCT NAME : Pazzaz HAZARD : SUPPLIER : Autosmart R10 - Flammable SDS No : 10558 R65 – May cause lung damage if swallowed PROD No : 6-3 R38 – Irritating to skin R41 – Risk of serious damage to eyes ACTIVITY : Dressing for plastic trim PERSONNEL : Valeting Staff

LOCATION : Dry Bay COLOUR : White

DILUTION RATIO : Undiluted DILUTION METHOD : Undiluted APPLICATION METHOD : Using a slightly damp clean microfiber cloth RISK LEVEL : Level 2 Some Risk, No means to improve Low if good standard of occupational hygiene are observed and correct Personal Protective Equipment worn.

WORKPLACE EXPOSURE LIMIT (WEL) NAME TWA – 8HRS STEL – 15MIN Glycerine -10mg/m3 - Further information is available from the Motorclean MSDS Manual. MSDS REVIEW DATE: Autosmart – 05/05/12 Motorclean – 31/12/18 TIME AND FREQUENCY OF ACTIVITY Daily dependant on volume of cars to be cleaned. May not be used on every vehicle





Avoid contact with skin. Do not discharge into drains. Do not ingest product.


COSHH ASSESSMENT

PRODUCT NAME : Platinum HAZARD : SUPPLIER : Autosmart R10 - Flammable SDS No : 10231 R65 – May cause lung damage if swallowed PROD No : 246-1 R38 – Irritating to skin R41 – Risk of serious damage to eyes ACTIVITY : Polish for Vehicle paintwork PERSONNEL : Valeting Staff

LOCATION : Dry Bay COLOUR : White

DILUTION RATIO : Undiluted DILUTION METHOD : APPLICATION METHOD : Using a slightly damp clean microfiber cloth Apply using lines instead of swirls to reduce swirl marks RISK LEVEL : Level 2 Some Risk, No means to improve Low if good standard of occupational hygiene are observed and correct Personal Protective Equipment worn. WORKPLACE EXPOSURE LIMIT (WEL) NAME TWA – 8HRS STEL – 15MIN Aluminium Silicate -2mg/m3 - Hydrocarbons -1000mg/m3 Paraffin Wax -2mg/m3 -6mg/m3 Further information is available from the Motorclean MSDS Manual. MSDS REVIEW DATE: Autosmart – 26/09/12 Motorclean – 31/12/18

TIME AND FREQUENCY OF ACTIVITY Daily dependant on volume of cars to be cleaned. May not be used on every vehicle


Safety Glasses / Goggles Safety Boots Nitrile Gloves All to be used when decanting and applying this product.

PRESENT CONTROL OUTSIDE PPE None COMMENTS / ACTIONS REQUIRED

The use of safety equipment provided Store product at a temperature belowmust be obligatory. 35degrees C. Avoid contact with skin. Do not discharge into drains. Do not ingest product.


COSHH ASSESSMENT

PRODUCT NAME : Preptone HAZARD : SUPPLIER : Autosmart R10 – Flammable SDS No : 10013 R20/21 – Harmful by inhalationPROD No : 027-5

ACTIVITY : Removal of protective coatings PERSONNEL : Valeting Staff

LOCATION : Wet Bay

COLOUR : Clear DILUTION RATIO : Undiluted

DILUTION METHOD : N/A APPLICATION METHOD : Using Spray bottle direct onto grease, tar or

RISK LEVEL : underseal

Some Risk, No means to improve Level 2 Low if good standard of occupational hygiene are observed and correct PersonalProtective Equipment worn.


Xlyene 50ppm-220mg/m3 100ppm-441mg/m3 Further information is available from the Motorclean MSDS Manual. MSDS REVIEW DATE: Autosmart – 09/10/12 Motorclean – 31/12/18








COSHH ASSESSMENT

PRODUCT NAME : Rubber

Dressing HAZARD : SUPPLIER : Autosmart R66 – Repeated exposure may

SDS No : 11363 Cause skin dryness or cracking PROD No : 269-2 R67 – Vapours may cause dro sine ACTIVITY : Tyre Dressing PERSONNEL : Valet Staff LOCATION : Dry Bay

COLOUR : Orange DILUTION RATIO : Undiluted

DILUTION METHOD : N/A APPLICATION METHOD : Decant into Small bucket and apply with 4” Brush RISK LEVEL : Level 2 Some Risk, No means to improve

Low if good standard of occupational hygiene are observed and correct Personal Protective Equipment worn. WORKPLACE EXPOSURE LIMIT (WEL)

NAM TWA – 8HRS STEL – 15MIN Glycerine -10mg/m3 - Further information is available from the Motorclean MSDS Manual.

MSDS REVIEW DATE: Autosmart – 02/10/13 Motorclean – 31/12/18 TIME AND FREQUENCY OF ACTIVITY Daily dependant on volume of cars to be cleaned.

PERSONAL PROTECTIVE EQUIPMENT REQUIREMENTS (PPE) Safety Glasses / Goggles Safety Boots Nitrile Gloves All to be used when decanting and apply ing this product.

PRESENT CONTROL OUTSIDE PPE None COMMENTS / ACTIONS REQUIRED The use of safety equipment Store product at a temperature

provided must be obligatory. below 35degrees C. Avoid contact with skin. Do not discharge into drains.

Do not ingest product.


COSHH ASSESSMENT

PRODUCT NAME : Safe T Strip HAZARD : SUPPLIER : Autosmart R35 – Causes severe burns SDS No : 10145 R22 – Harmful if swallowed PROD No : 373-18 R36/38 – Harmful to eyes and skin R40 – Limited evidence of a carcinogenic effect ACTIVITY : Removal of protective wax R37 – irritating to respiratory system PERSONNEL : Valeting staff

LOCATION : Wet Bay

COLOUR : Clear Straw Amber

DILUTION RATIO : 4-1 DILUTION METHOD : APPLICATION METHOD : Apply with 6ltr sprayer RISK LEVEL : Level 2 Some Risk, No means to improve Low if good standard of occupational hygiene are observed and correct Personal Protective Equipment worn.

WORKPLACE EXPOSURE LIMIT (WEL) NAME TWA – 8HRS STEL – 15MIN 2-Aminoethanol 1ppm-2.5mg/m3 3ppm-7.6mg/m3 2-Butoxyethanol 25ppm-123mg/m3 50ppm-246mg/m3 Sodium Hydroxide -2mg/m3 Further information is available from the Motorclean MSDS Manual. MSDS REVIEW DATE: Autosmart – 04/04/13 Motorclean – 31/12/18

TIME AND FREQUENCY OF ACTIVITY Daily dependant on volume of cars to be cleaned. May not be used on all vehicles cleaned







COSHH ASSESSMENT

PRODUCT NAME : Satin Black HAZARD : SUPPLIER : Autosmart R12 – Extremely flammable SDS No : 10537 R36/37 – Irritating to eyes and respiratory system PROD No : A51-5

ACTIVITY : Applied to enhance black

paintwork PERSONNEL : Valeting Staff

LOCATION : Dry Bay

COLOUR : Black

DILUTION RATIO : Undiluted DILUTION METHOD : N/A APPLICATION METHOD : Spray Direct from Aerosol to Metal or Plastic RISK LEVEL : Level 2 Some Risk, No means to improve Low if good standard of occupational hygiene are observed and correct Personal Protective Equipment worn.

WORKPLACE EXPOSURE LIMIT (WEL) NAME TWA – 8HRS STEL – 15MIN 1-Methoxy-2- 100ppm-375mg/m3 150ppm-560mg/m3 Propanol

Acetone 500ppm-1210mg/m3 1500ppm-3620mg/m3 Butane 600ppm-1450mg/m3 750ppm-1810mg/m3 Butyl Acetate-norm 150ppm-724mg/m3 200ppm-966mg/m3 Further information is available from the Motorclean MSDS Manual. MSDS REVIEW DATE: Autosmart – 16/10/12 Motorclean – 31/12/18 TIME AND FREQUENCY OF ACTIVITY Daily dependant on volume of cars to be cleaned. May not be used on every vehicle cleaned


Safety Glasses / Goggles Nitrile Gloves All to be used when decanting and applying this product. PRESENT CONTROL OUTSIDE PPE Use in a well ventilated area

COMMENTS / ACTIONS REQUIRED The use of safety equipment provided Store product at a temperature below must be obligatory. 35degrees C. Avoid contact with skin. Do not ingest product.


COSHH ASSESSMENT

PRODUCT NAME : Silver King HAZARD : SUPPLIER : Autosmart R12 – Extremely flammable SDS No : 10539 R65 – May cause lung damage is swallowed PROD No : A53-6 R36/37 – Irritating to eyes and respiratory system ACTIVITY : Applied to enhance paintwork PERSONNEL : Valeting Staff

LOCATION : Dry Bay

COLOUR : Silver

DILUTION RATIO : Undiluted DILUTION METHOD : APPLICATION METHOD : Spray direct onto Metal or Plastic trim or engine parts


WORKPLACE EXPOSURE LIMIT (WEL) NAME TWA – 8HRS STEL – 15MIN 1-Methoxy-2- 100ppm-375mg/m3 150ppm-560mg/m3 Propanol Acetone 500ppm-1210mg/m3 1500ppm-3620mg/m3 Butane 600ppm-1450mg/m3 750ppm-1810mg/m3 Butyl Acetate-norm 150ppm-724mg/m3 200ppm-966mg/m3 Further information is available from the Motorclean MSDS Manual. MSDS REVIEW DATE: Autosmart – 16/10/12 Motorclean – 31/12/18

TIME AND FREQUENCY OF ACTIVITY Daily dependant on volume of cars to be cleaned. May not be used on all vehicles cleaned


Safety Glasses / Goggles Safety Boots, Nitrile Gloves All to be used when decanting and applying this product.

PRESENT CONTROL OUTSIDE PPE Use in a well ventilated area COMMENTS / ACTIONS REQUIRED

The use of safety equipment provided Store product at a temperature belowmust be obligatory. 35degrees C. Avoid contact with skin. Do not ingest product


COSHH ASSESSMENT

PRODUCT NAME : Smart Dash (Aerosol) HAZARD : SUPPLIER : Autosmart R12 – Extremely flammable SDS No : 10105

PROD No : A52-8

ACTIVITY : Dressing PERSONNEL : Valet Staff

LOCATION : Dry bay

COLOUR : Clear DILUTION RATIO : N/A DILUTION METHOD : N/A APPLICATION METHOD : Spray Direct and buff with Microfibre cloth RISK LEVEL : Level 2 Some Risk, No means to improve Low if good standard of occupational hygiene are observed and correct PersonalProtective Equipment worn.


Butane 600ppm-1450mg/m3 750ppm-1810mg/m3 Liquid Paraffin -5mg/m3 -10mg/m3 Further information is available from the Motorclean MSDS Manual. MSDS REVIEW DATE: Autosmart – 17/10/12 Motorclean – 31/12/18








COSHH ASSESSMENT

PRODUCT NAME : Stardust (Aerosol) HAZARD : SUPPLIER : Autosmart R8 – Contact with combustible material may cause fire SDS No : 10619 R12 – Extremely flammable PROD No : A209-3 R65 – May cause lung damage if swallowed R25 – Toxic if swallowed ACTIVITY : Polish PERSONNEL : Valeting Staff

LOCATION : Dry Bay

COLOUR : White

DILUTION RATIO : N/A DILUTION METHOD : N/A APPLICATION METHOD : Spray affected area and buff with microfiber cloth RISK LEVEL : Level 2 Some Risk, No means to improve Low if good standard of occupational hygiene are observed and correct Personal Protective Equipment worn.

WORKPLACE EXPOSURE LIMIT (WEL) NAME TWA – 8HRS STEL – 15MIN Butane 600ppm-1450mg/m3 750ppm-1810mg/m3 Hydrocarbons - 1000mg/m3 Further information is available from the Motorclean MSDS Manual. MSDS REVIEW DATE: Autosmart – 17/10/12 Motorclean – 31/12/18




Nitrile Gloves All to be used when decanting and applying this product. PRESENT CONTROL OUTSIDE PPE None COMMENTS / ACTIONS REQUIRED The use of safety equipment provided Store product at a temperature below must be obligatory. 35degrees C. Avoid contact with skin. Do not discharge into drains. Do not ingest product.


COSHH ASSESSMENT

PRODUCT NAME : Tango HAZARD : SUPPLIER : Autosmart R11 – Highly flammable SDS No : 10050 R34 – Causes burns PROD No : 032-13 R36/38 – Irritating to eyes and skin R50- Very toxic to aquatic organisms ACTIVITY : Dressing for plastic R65 – May cause lung damage if swallowed PERSONNEL : Valeting staff LOCATION : Wet/Dry bay COLOUR : Orange

DILUTION RATIO : Undiuted DILUTION METHOD : APPLICATION METHOD : Using Spray bottle onto area and buff with microfibre cloth RISK LEVEL : Level 2 Some Risk, No means to improve Low if good standard of occupational hygiene are observed and correct Personal Protective Equipment worn. WORKPLACE EXPOSURE LIMIT (WEL) NAME TWA – 8HRS STEL – 15MIN Distillates(petroleum)Hydrotreated -1000mg/m3 - light Propan- 2-OL 400ppm-999mg/m3 500ppm-1250mg/m3 Further information is available from the Motorclean MSDS Manual. MSDS REVIEW DATE: Autosmart – 08/10/12 Motorclean – 31/12/18




COMMENTS / ACTIONS REQUIRED Avoid contact with skin Do not ingest product.


COSHH ASSESSMENT

PRODUCT NAME : Topaz HAZARD : SUPPLIER : Autosmart R10-Flammable SDS No : 11493 R65-May cause lung damage if

PROD No : 287-1 swallowed

ACTIVITY : Polish PERSONNEL : Valeting Staff

LOCATION : Dry Bay

COLOUR : Purple DILUTION RATIO : Undiluted DILUTION METHOD : N/A

APPLICATION METHOD : Using spray bottle, wipe off with polish sponge



Hydrocarbons -1000mg/m3 - Further information is available from the Motorclean MSDS Manual. MSDS REVIEW DATE: Autosmart – 10/09/14 Motorclean – 31/12/18




Nitrile Gloves All to be used when decanting and applying this product. PRESENT CONTROL OUTSIDE PPE None COMMENTS / ACTIONS REQUIRED The use of safety equipment provided Store product at a temperature below must be obligatory. 35degrees C.



COSHH ASSESSMENT

PRODUCT NAME : Treble X HAZARD : SUPPLIER : Autosmart R34 – Causes Burns SDS No : 10429 R36/37/38 – Irritating to Eyes,

skin and respiratory system PROD No : 053-20

ACTIVITY : Cleaning alloy wheels PERSONNEL : Valeting Staff LOCATION : Wet Bay

COLOUR : Blue Green DILUTION RATIO : Undiluted DILUTION METHOD : N/A APPLICATION METHOD : Spray onto Alloy wheels and agitate with brush,

wash off before drying RISK LEVEL : Level 2 Some Risk, No means to improve Low if good standard of occupational hygiene are observed and correct Personal Protective Equipment worn.


Hydrochloric Acid 1ppm-2mg/m3 5ppm-8mg/m3 Further information is available from the Motorclean MSDS Manual. MSDS REVIEW DATE: Autosmart – 08/10/12 Motorclean – 31/12/18


PERSONAL PROTECTIVE EQUIPMENT REQUIREMENTS (PPE)Safety Glasses / Goggles Safety BootsNitrile Gloves All to be used when decanting and applying this product.



COSHH ASSESSMENT

PRODUCT NAME : Vinyl Shield HAZARD : SUPPLIER : Autosmart R11-Highly flammable SDS No : 10321 R65 – May cause lung damage if swallowed PROD No : 3-15 R36 – Irritating to eyes

ACTIVITY : Dressing Tyres PERSONNEL : Valeting Staff

LOCATION : Dry Bay

COLOUR : Green DILUTION RATIO : Undiluted DILUTION METHOD : N/A

APPLICATION METHOD : Apply with sponge or cloth direct to tyres



Hydrocarbons -1000mg/m3 - Propan-2-OL 400ppm-999mg/m3 500ppm-1250mg/m3 Further information is available from the Motorclean MSDS Manual. MSDS REVIEW DATE: Autosmart – 04/03/14 Motorclean – 31/12/18



Safety Glasses / Goggles Safety Boots Nitrile Gloves All to be used when decanting and apply ing this product. PRESENT CONTROL OUTSIDE PPE Use in a well ventilated area COMMENTS / ACTIONS REQUIRED The use of safety equipment provided Store product at a temperature below must be obligatory. 35degrees C. Avoid contact with skin. Do not discharge into drains.


COSHH ASSESSMENT

PRODUCT NAME : Wax Detail Sp ray HAZARD : SUPPLIER : Autosmart SDS No : 11422 PROD No : 279-0

ACTIVITY : Paint wax spray PERSONNEL : Valeting Staff LOCATION : Dry Bay

COLOUR : Light Brown DILUTION RATIO : Undiluted DILUTION METHOD : APPLICATION METHOD : Apply using Spray bottle wipe of with microfibre

cloth RISK LEVEL : Level 2 Some Risk, No means to improve Low if good standard of occupational hygiene are observed and correct Personal Protective Equipment worn.





PRESENT CONTROL OUTSIDE PPE None COMMENTS / ACTIONS REQUIREDThe use of safety equipment provided Store product at a temperature belowmust be obligatory. 35degrees C. Avoid contact with skin. Do not discharge into drains.


COSHH ASSESSMENT

PRODUCT NAME : 20-20(Aerosol) HAZARD : SUPPLIER : Autosmart R8-Contact with Combustible

Material may cause a fire SDS No : 10253 R12 – Extremely flammable PROD No : A86-7 R20/21/22-Harmful by inhalation

and contact with skin R36 -Irritating to eyes ACTIVITY : Glass Cleaner R25 – Toxic if swallowed PERSONNEL : Valeting Staff R50-Very toxic to aquatic organismLOCATION : Dry Bay

COLOUR : White DILUTION RATIO : Undiluted DILUTION METHOD : N/A APPLICATION METHOD : Spray onto Glass and buff with microfibre cloth



2-Butoxyethanol 25ppm-123mg/m3 50ppm-246mg/m3 Butane 600ppm-1450mg/m3 750ppm-1810 Propan- 2-OL 400ppm-999mg/m3 500ppm-1250mg/m3 Further information is available from the Motorclean MSDS Manual. MSDS REVIEW DATE: Autosmart – 03/05/13 Motorclean – 31/12/18



PRESENT CONTROL OUTSIDE PPE Use in a well ventilated area COMMENTS / ACTIONS REQUIREDThe use of safety equipment provided Store product at a temperature belowmust be obligatory. 35degrees C. Avoid contact with skin. Do not discharge into drains. Do not ingest product.


COSHH ASSESSMENT

PRODUCT NAME : Wheel Protector HAZARD : Aerosol

SUPPLIER : Supaguard R12 – Extremely Flammable Part No : HZAWP R66 – Repeated exposure may cause skin dryness or cracking

ACTIVITY : Applying vehicle protection kit PERSONNEL : Valeting Staff LOCATION : Dry Bay

COLOUR : White DILUTION RATIO : Undiluted

DILUTION METHOD : N/A APPLICATION METHOD : Spray onto Alloy Wheels in well ventilated area and allow to dry


WORKPLACE EXPOSURE LIMIT (WEL) NAME TWA – 8HRS STEL – 15MIN White Spirit 600mg/m3

Butane 600ppm 750ppm Propane Asphyxiating Asphyxiating Further information is available from the Motorclean MSDS Manual. MSDS REVIEW DATE: Motorclean – 31/12/18

TIME AND FREQUENCY OF ACTIVITY Daily dependant on volume of cars to be cleaned. Not used on every vehicle






COSHH ASSESSMENT

PRODUCT NAME : Wheel Cleaner HAZARD : Aerosol SUPPLIER : Supaguard R35 – Causes severe burns PROD No : TA3549 R36/38 – Irritating to eyes and skin R37 – Irritating to respiratory

ACTIVITY : Applying vehicle protection kit system R41 – Risk of serious damage to

PERSONNEL : Valeting Staff eyes

LOCATION : Wet Bay

COLOUR : White Foam DILUTION RATIO : Undiluted

DILUTION METHOD : N/A APPLICATION METHOD : Spray Direct to alloy wheels and agitate foam with wheel brush

Some Risk, No means to improve RISK LEVEL : Level 2 Low if good standard of occupational hygiene are observed and correct Personal Protective Equipment worn.


Butoxyethanol Hydrochloric Acid

Phosphoric Acid Further information is available from the Motorclean MSDS Manual.



Safety Glasses / Goggles Safety Boots Nitrile Gloves All to be used when decanting and applying this product. PRESENT CONTROL OUTSIDE PPE Use in a well ventilated area

COMMENTS / ACTIONS REQUIRED The use of safety equipment provided Store product at a temperature below must be obligatory. 35degrees C. Avoid contact with skin. Do not discharge into drains.


COSHH ASSESSMENT

PRODUCT NAME : 100 plus paint HAZARD : sealant SUPPLIER : Supaguard R65 – May cause lung damage if swallowed PROD No : R11 – Highly flammable R36/38 – Irritating to eyes and skin ACTIVITY : Applying vehicle protection kit PERSONNEL : Valeting Staff

LOCATION : Dry Bay

COLOUR : Opaque DILUTION RATIO : Undiluted

DILUTION METHOD : N/A APPLICATION METHOD : Apply with Protection kit applicator


WORKPLACE EXPOSURE LIMIT (WEL) NAME TWA – 8HRS STEL – 15MIN Distillates 200ppm Solvent Napatha 200ppm heavy/light Further information is available from the Motorclean MSDS Manual. MSDS REVIEW DATE: 31/07/09 Motorclean – 31/12/18



Safety Glasses / Goggles Safety Boots Nitrile Gloves All to be used when decanting and apply in g this product.

PRESENT CONTROL OUTSIDE PPE None COMMENTS / ACTIONS REQUIRED The use of safety equipment provided Store product at a temperature below must be obligatory. 35degrees C. Avoid contact with skin. Do not discharge into drains.


COSHH ASSESSMENT

PRODUCT NAME : Aftercare Shampoo HAZARD : SUPPLIER : Supaguard R36/38 – Irritating to eyes and skinPROD No :

ACTIVITY : Applying paint protection kit PERSONNEL : Valeting Staff

LOCATION : Wet Bay

COLOUR : Blue DILUTION RATIO : 50-1 DILUTION METHOD : N/A

APPLICATION METHOD : Dilute into water and apply with sponge



Methoxy propanol 50ppm Further information is available from the Motorclean MSDS Manual. MSDS REVIEW DATE: Motorclean Motorclean – 31/12/18








COSHH ASSESSMENT

PRODUCT NAME : Carpetgard(Aerosol) HAZARD : SUPPLIER : Supagard R12 – Extremely flammable PROD No : ACTIVITY : Carpet and upholstery

Protection PERSONNEL : Valeting Staff LOCATION : Dry Bay

COLOUR : Clear

DILUTION RATIO : Undiluted DILUTION METHOD : N/A APPLICATION METHOD : Spray onto fabric in well ventilated area and allow to dry


WORKPLACE EXPOSURE LIMIT (WEL) NAME TWA – 8HRS STEL – 15MIN Alkanes 2000ppm Propane/Butane 1000ppm Further information is available from the Motorclean MSDS Manual. MSDS REVIEW DATE: 27/04/15 Motorclean Motorclean – 31/12/18 TIME AND FREQUENCY OF ACTIVITY Daily dependant on volume of cars to be cleaned. Could be used on up to 40 vehicles per day.






COSHH ASSESSMENT

PRODUCT NAME : Paint sealant cream HAZARD : SUPPLIER : Supaguard R11 – Highly flammable PROD No : R36 – Irritating to eyes

ACTIVITY : Paint Protector PERSONNEL : Valeting Staff

LOCATION : Dry Bay

COLOUR : Light Blue DILUTION RATIO : Undiluted DILUTION METHOD : N/A APPLICATION METHOD : Apply with Sponge applicator and buff with microfibre cloth



Ammonia Solution 50ppm Distillates 200ppm Propan-2-Ol 200ppm Further information is available from the Motorclean MSDS Manual. MSDS REVIEW DATE: 06/03/02 Motorclean – 31/12/18







COSHH ASSESSMENT

PRODUCT NAME : UPT – Fabric HAZARD : Protector (Aerosol) SUPPLIER : Supaguard R12 – Extremely flammable PROD No : R66 – Repeated exposure causes

skin dryness and cracking ACTIVITY : Fabric Protector PERSONNEL : Valeting Staff LOCATION : Dry Bay

COLOUR : Aerosol DILUTION RATIO : N/A DILUTION METHOD : N/A APPLICATION METHOD : Spray direct onto fabric in well ventilated area



Alkanes 2000ppm Propane/Butane 1000ppm Further information is available from the Motorclean MSDS Manual. MSDS REVIEW DATE: 27/03/02 Motorclean Motorclean – 31/12/18


PERSONAL PROTECTIVE EQUIPMENT REQUIREMENTS (PPE)Safety Glasses / Goggles Nitrile Gloves Safety Boots All to be used when decanting and applying this product.

PRESENT CONTROL OUTSIDE PPE None COMMENTS / ACTIONS REQUIREDThe use of safety equipment provided Store product at a temperature belowmust be obligatory. 35degrees C. Avoid contact with skin. Do not discharge into drains.


COSHH ASSESSMENT

PRODUCT NAME : Conserver HAZARD : SUPPLIER : Gardx R36/38 – Irritating to eyes and skin PROD No : M159 R50 – Very toxic to aquatic

organisms ACTIVITY : Paint Sealant PERSONNEL : Valeting Staff LOCATION : Dry Bay

COLOUR : Pink DILUTION RATIO : Undiluted DILUTION METHOD : N/A APPLICATION METHOD : Apply by Hand with microfibre cloth

RISK LEVEL : Level 2 Some Risk, No means to improveLow if good standard of occupational hygiene are observed and correct Personal Protective Equipment worn.


Butoxythenol 25 - 123 50-246 Propan 400ppm-999mg/m3 500ppm-1250mg/m3Further information is available from the Motorclean MSDS Manual. MSDS REVIEW DATE: Gardx 22/04/13 Motorclean – 31/12/18


PERSONAL PROTECTIVE EQUIPMENT REQUIREMENTS (PPE)Safety Glasses / Goggles Nitrile Gloves Safety Boots All to be used when decanting and apply in g this product.



COSHH ASSESSMENT

PRODUCT NAME : Stain Guard Aerosol HAZARD : SUPPLIER : Gardx R12 – Extremely Flammable PROD No : A0773/01 R38 – Irritating to skin R65 – May cause lung damage if swallowed

ACTIVITY : Fabric Protector PERSONNEL : Valeting Staff LOCATION : Dry Bay

COLOUR : Aerosol DILUTION RATIO : N/A DILUTION METHOD : N/A

APPLICATION METHOD : Spray Direct to Fabric in well ventilated area RISK LEVEL : Level 2 Some Risk, No means to improve Low if good standard of occupational hygiene are observed and correct Personal Protective Equipment worn. WORKPLACE EXPOSURE LIMIT (WEL) NAME TWA – 8HRS STEL – 15MIN Hyrdrocarbon 1000ppm-1750mg/m3 1250ppm-2180mg/m3 propellant Ethyl Alcohol 1000ppm-1920mg/m3

Butyl Acetate 150ppm-724mg/m3 200ppm-966mg/m3 Further information is available f rom the Motorclean MSDS Manual. MSDS REVIEW DATE: Gardx – 09/03/15 Motorclean - Motorclean – 31/12/18






COSHH ASSESSMENT

PRODUCT NAME : Leather Guard HAZARD : SUPPLIER : Gardx R12 – Extremely Flammable PROD No : A0720 R65 – May cause lung damage if swallowed R50 – Very toxic to aquatic organisms ACTIVITY : Leather Protector PERSONNEL : Valeting Staff

LOCATION : Dry Bay COLOUR : DILUTION RATIO : Undiluted

DILUTION METHOD : N/A APPLICATION METHOD : Apply with Microfibre cloth


WORKPLACE EXPOSURE LIMIT (WEL) NAME TWA – 8HRS STEL – 15MIN Distillates 1000mg/m3

(petroleum)Hydrotreated

Hydrocarbon propellant 600ppm-1430mg/m3 750ppm – 1780mg/m3 Petroleum Distillates 350mg/m3 Further information is available from the Motorclean MSDS Manual. MSDS REVIEW DATE: Gardx 23/04/13 Motorclean Motorclean – 31/12/18





COMMENTS / ACTIONS REQUIRED The use of safety equipment provided must Store product at a temperature be obligatory. below 35degrees C. Avoid contact with skin. Do not discharge into drains.


COSHH ASSESSMENT

PRODUCT NAME : Stage 1 HAZARD : SUPPLIER : Gardx R10 – Flammable PROD No : M167 R65 – May cause lung damage if

swallowed R50 – Toxic to aquatic organismsACTIVITY : Paint Sealant PERSONNEL : Valeting Staff LOCATION : Dry Bay

COLOUR : DILUTION RATIO : Undiluted DILUTION METHOD : N/A APPLICATION METHOD : Wipe on with microfibre cloth and allow to dry



Petroleum distillates 350mg/m3 Stage 1 Further information is available from the Motorclean MSDS Manual. MSDS REVIEW DATE: Gardx – 22/04/13 Motorclean Motorclean – 31/12/18




COMMENTS / ACTIONS REQUIREDThe use of safety equipment provided Store product at a temperature belowmust be obligatory. 35degrees C. Avoid contact with skin. Do not discharge into drains.


COSHH ASSESSMENT

PRODUCT NAME : Stage 2 HAZARD : SUPPLIER : Gardx R10 - Flammable PROD No : M169 R65 – May cause lung damage if

swallowed ACTIVITY : Paint Sealant PERSONNEL : Valeting Staff LOCATION : Dry Bay

COLOUR : DILUTION RATIO : Undiluted DILUTION METHOD : N/A APPLICATION METHOD : Apply over stage 1 and buff with microfibre cloth



Alaminium Silicate 5mg/m3 Petroleum distillate 350mg/m3 Treated Kaolin 2mg/m3 Further information is available from the Motorclean MSDS Manual. MSDS REVIEW DATE: Gardx 22/04/15 Motorclean – 31/12/18






COSHH ASSESSMENT

PRODUCT NAME : Glass Guard HAZARD : SUPPLIER : Gardx R11 – Extremely flammable PROD No : B1524

R39/23/24/25 – Toxic danger of very serious irreversible effects through inhalation, in contact with skin and if swallowed ACTIVITY : Glass Cleaner polish PERSONNEL : Valeting Staff LOCATION : Dry Bay

COLOUR : Clear DILUTION RATIO : Undiluted DILUTION METHOD : N/A APPLICATION METHOD : Apply sparingly with microfibre cloth buff when dry



Methanol 200ppm – 266mg/m3 250ppm – 333mg/m3 Ethanol 1000ppm-1920mg/m3 Further information is available from the Motorclean MSDS Manual. MSDS REVIEW DATE: Gardx – 24/11/05 Morclean – Motorclean – 31/12/18




COMMENTS / ACTIONS REQUIRED The use of safety equipment provided Store product at a temperature belowmust be obligatory. 35degrees C. Avoid contact with skin. Do not discharge into drains.


COSHH ASSESSMENT

PRODUCT NAME : Mist Guard HAZARD : SUPPLIER : Gardx R11 – Highly Flammable PROD No : B4520

ACTIVITY : Interior glass protector PERSONNEL : Valeting Staff

LOCATION : Dry Bay

COLOUR : Undiluted

DILUTION RATIO : DILUTION METHOD : N/A

APPLICATION METHOD : Apply with microfibre cloth and buff

RISK LEVEL : Level 2 Some Risk, No means to improve Low if good standard of occupational hygiene are observed and correct PersonalProtective Equipment worn. WORKPLACE EXPOSURE LIMIT (WEL)

NAME TWA – 8HRS STEL – 15MIN Ethanol 1000ppm-1920mg/m3

Further information is available from the Motorclean MSDS Manual. MSDS REVIEW DATE: Gardx 24/11/05 Motorclean Motorclean – 31/12/18 TIME AND FREQUENCY OF ACTIVITY Dependent on volume of cars requiring Vehicle paint protection packs to be applied






COSHH ASSESSMENT

PRODUCT NAME : Wash n Wax HAZARD : SUPPLIER : Gardx R22 – Harmful if swallowed PROD No : M392 R41 – Risk of serious damage to

eyes R38 – Irritating to skin ACTIVITY : Cleaning Shampoo PERSONNEL : Valeting Staff LOCATION : Wet Bay

COLOUR : Blue DILUTION RATIO : 500-1 DILUTION METHOD : 3 caps full into bucket of waterAPPLICATION METHOD : Apply with Sponge and rinse off with water



Gardx Wash n Wax 2mg/m3

Further information is available from the Motorclean MSDS Manual. MSDS REVIEW DATE: 22/04/13 Motorclean – 31/12/18

TIME AND FREQUENCY OF ACTIVITY Dependent on volume of cars requiring Vehicle paint protection packs to be applied





COSHH ASSESSMENT

PRODUCT NAME : G3Liquid compound HAZARD : SUPPLIER : 3M R10 - Flammable PROD No : AG3CSF R36/37/38 – Irritating to eyes/skin and respiratory system R65 – May cause lung damage if swallowed ACTIVITY : Paint Restorer PERSONNEL : Valeting Staff

LOCATION : Dry Bay COLOUR : White DILUTION RATIO : Undiluted

DILUTION METHOD : N/A APPLICATION METHOD : Applied with mopping pad/ polishing pad


WORKPLACE EXPOSURE LIMIT (WEL) NAME TWA – 8HRS STEL – 15MIN Kerosene 100ppm 600mg/m3 Further information is available from the Motorclean MSDS Manual. MSDS REVIEW DATE:



PRESENT CONTROL OUTSIDE PPE None COMMENTS / ACTIONS REQUIRED The use of safety equipment provided Store product at a temperature below must be obligatory. 35degrees C. Avoid contact with skin. Do not discharge into drains.


5, chemical safety data (coshh assessments)documents.motorclean.co.uk/mmsdocuments/chemical...

Documents