2005_supplement_s40(04-)_v50_wiring_diagram.pdf
TRANSCRIPT
-
7/27/2019 2005_Supplement_S40(04-)_V50_wiring_diagram.pdf
1/121
2005SUPPLEMENT
VOLVO
TP 3984202
-
7/27/2019 2005_Supplement_S40(04-)_V50_wiring_diagram.pdf
2/121
Volvo Car Corporation
Vehicles with SRS (Airbag)/SIPS bag/IC (Inflatable
Curtain)
Warning!
Extra caution must be exercised when working on vehicles equipped with SRS/SIPS bag/IC
in order to avoid:
1. Personal injuries when performing repair work.2. Damage or malfunction of the SRS/SIPS bag/IC system.
Work involving the SRS/SIPS bag/IC systems or other components in the vehicle that may
affect the SRS/SIPS bag/IC systems must always be performed by an authorized Volvo
workshop.
In case of doubt, consult the SRS and SIPS bag/IC service manual.
Is the vehicle equipped with SRS/SIPS bag/IC?
Vehicles with SRS are most easily recognized by the letters SRS in the center of the steering
wheel. If the vehicle also has a passenger side airbag, the letters SRS are stamped on thedashboard above the glove compartment. SRS vehicles from 1993 and onward also have
explosive seat belt tensioners. SIPS bags are only installed on SRS vehicles from 1995 and
onward. SIPS bag decals are located on the windshield and seat compartment. Vehicles with
IC can be recognized by the letters IC on the C/D panel (4 door) or the B panel (5 door).
General recommendations
Be especially careful when working on or around SRS, SIPS, and IC components.
Make sure that no wires are pinched, frayed, or pierced.
Never install accessories by the sensors.
Where applicable, work on the steering wheel, steering shaft, or steering gear must be done
in accordance with the methods in the SRS section of VADIS.
Certain components of the aforementioned systems must be grounded while working. Read
the appropriate sections in VADIS. Install no accessories in the areas between the A and B posts, the B and C posts, and the C
and D posts.
Test terminal
Data link connector in the passenger compartment.
Modifications introduced up to August 2004Any changes made to the vehicles after this date are not included in the
manual. If necessary refer to service bulletins.
Volvo models are sold in versions adapted for different markets. These
adaptations depend on factors such as legal requirements, taxation, and
market demands.
This manual may therefore include illustrations and text that do not apply to
the vehicles in your country.
Order number TP 3984202This publication contains updated information for model year 2005 late version. For otherelectrical systems, see publication TP 3978202, available inElectronic Wiring Diagram(EWD) TP 3983002 or later.
We retain the right to make modifications.
-
7/27/2019 2005_Supplement_S40(04-)_V50_wiring_diagram.pdf
3/121TP3984202 S40 (04-)/V50 2005
Vehicles with SRS (Airbag)/SIPS bag/IC (Inflatable
Curtain) .......................................................................... 2
Abbreviations................................................................. 5
How to use the wiring diagrams 1:2............................... 6
Electrical distribution 1:2................................................ 8
FusesEngine compartment distribution box F1-F8.................10
Engine compartment distribution box F9-F18............... 11Engine compartment distribution box F20-F32............. 12
Engine compartment distribution box F33-FH1 ............ 13
Central Electronic Module (CEM) F43-F52...................14
Central Electronic Module (CEM) F53-F66...................15
Central Electronic Module (CEM) F68-F86...................16
Battery, PF1-PF2..........................................................17
RelaysIgnition switch and relays............................................. 18
Distribution box in engine compartment R1-R14......... 19
Central Electronic Module (CEM) R15-R18................. 20
Relays - soldered......................................................... 21
Ground connectionsOverview...................................................................... 22
31/3 - 31/10 ................................................................. 23
31/11 - 31/66 ............................................................... 24
31/67 - 31/84 ............................................................... 25
31/88 - 31/114 ............................................................. 26
31/115 - Ground connections in chassis...................... 27
Control modulesOverview of locations................................................... 28
Overview of designations............................................. 29
Data communication Low speed CAN 1:2................... 30Data communication LIN 1:2 ....................................... 32
Data communication High speed CAN........................ 34
Data communication MOST ........................................ 35
Group 23 Fuel systemEngine management system, 4-cyl 1.6l 1:2................. 36
Engine management system 4-cyl. 1.6l Diesel 1:2...... 38
Engine management system, 4-cyl 1.8l 1:2................. 40
Engine management system 5-cyl. Turbo 1.8l 1:2....... 42
Group 26 Cooling systemCooling fan................................................................... 44
Cooling fan Diesel........................................................ 45
Group 27 Engine controlCruise control 1.6l.........................................................46
Cruise control 1.8l.........................................................47
Cruise control 5-cyl. ......................................................48
Cruise control 4-cyl. Diesel ...........................................49
Group 32 Generator and voltage regulatorPower supply 4-cyl....................................................... 50
Power supply 5-cyl....................................................... 51
Group 33 Starting systemStarting system 4-cyl.................................................... 52
Starting system 5-cyl.................................................... 53
Group 35 LightingReversing lights ........................................................... 54
Group 36 Additional electrical equipmentElectronic immobilizer ................................................. 55
Anti-theft alarm ............................................................ 56
Group 39 Other
Multimedia & Traffic Information .................................. 57Audio Low Level 1:2 .................................................... 58
Cellular phone 1:2........................................................ 60
Subwoofer.................................................................... 62
Table of Contents 1:2
-
7/27/2019 2005_Supplement_S40(04-)_V50_wiring_diagram.pdf
4/121TP3984202 S40 (04-)/V50 2005
Group 43 TransmissionAutomatic transmission CFT 23................................... 63
Automatic transmission AW 55-51, 5-cyl..................... 64
Differential Electronic Module (DEM)........................... 65
Group 87 Climate controlsClimate controls 4-cyl. 1:2 ........................................... 66
Climate controls 5-cyl. 1:2 ........................................... 67
Climate control system Diesel 1:2 ............................... 68
Climate controls 4-cyl., 5-cyl. & Diesel 2:2 .................. 69
Connectors................................................. 70
Branching points .......................................87
Component illustrations ............................94
Index ......................................................... 117
List of components 1:3
Table of Contents 2:2
-
7/27/2019 2005_Supplement_S40(04-)_V50_wiring_diagram.pdf
5/121TP3984202 S40 (04-)/V50 2005 5
Explanations
Abbreviations
Groups
Group 23 = Fuel system
Group 26 = Cooling system
Group 27 = Engine controls
Group 32 = Generator and voltage regulator
Group 33 = Starting system
Group 35 = Lighting
Group 36 = Additional electrical equipment
Group 37 = Wiring and fuses
Group 38 = Instruments
Group 39 = Other
Group 43 = Transmission
Group 59 = Brake system
Group 64 = Steering
Group 83 = Doors and openings
Group 84 = Exterior decorative elements, etc.
Group 85 = Interior equipment
Group 87 = Climate controls
Group 88 = Internal equipment
Ignition switch symbols
X = Accessories (audio position)
S = Powered upon insertion of key
15 = Contact remains connected during
start
15l = Contact is broken while starting
30 = Constant power from the battery
50 = Start
Countries/Markets
A = Austria
AUS = AustraliaB = Belgium
CDN = Canada
CH = Switzerland
D = Germany
DK = Denmark
E = Spain
EU/OS = Markets outside USA and Canada
FIN = Finland
GB = Great Britain
ISR = Israel
J = Japan
KOR = KoreaN = Norway
NL = Netherlands
S = Sweden
USA = United States of America
WEU = Western Europe
Other
AUTO = Automatic transmission
AWD = Four-wheel drive
CAN = CAN communication
DIESEL = Diesel
DPY = Display
ECC = Electronic climate control system
ETA = Engine throttle body
EXT. X = Extended X-feed
GDL = Gas discharge lamp
HISPEED = High speed data bus
IR = Infrared sensor
LIN = LIN communication
LHD = Left-hand drive
LOSPEED = Low speed data bus
MAN = Manual transmission
MEMORY = Memory driver seat
MMS = Mass Movement Sensor
GASOLINE = Gasoline
RHD = Right-hand driveSCR = Screen
SRS = Airbag
T = Turbocharged engine
W/O = Without
2WD = Two-wheel drive
4CYL = 4-cylinder engine
5CYL = 5-cylinder engine
Colors
BK, SB = Black
BN = Brown
BU, BL = BlueGN = Green
GY, GR = Gray
LGN = Light Green
OG, OR = Orange
PK, P = Pink
RD, R = Red
VT, VO = Violet
WH, W = White
YE, Y = Yellow
-
7/27/2019 2005_Supplement_S40(04-)_V50_wiring_diagram.pdf
6/121TP3984202 S40 (04-)/V50 2005 6
The descriptions below apply in generalto all wiring diagram manuals, althoughnot all sections are necessarily con-tained in this manual.
How to use the wiring diagrams 1:2
A. Component designation
Every component has a component designation that
consists of two parts.
The first part is a type number that describes the
type of component in question, for example 3/xx.
The second part of the designation is a serial num-
ber, e.g. x/2.
Together, this constitutes a component designation,
e.g. 3/2.
At the end of the manual is a list of components,where, with the help of the component designation,
you can read off the name of the component, for
example, 3/2 = light switch.
List of type numbers
The list shows which type of component that respec-
tive type numbers refer to, for example, 3/x = switch,
6/x = electric motor, etc.
1 Battery
2 Relay
3 Switch
4 Control module
5 Driver information module
6 Electric motor
7 Sensor
8 Actuator
9 Heating element
10 Lamp
11 Fuse
15 Electrical distribution rail/box
16 Audio
17 Service/diagnostics
18 Contact reel19 Meter
20 Ignition component/shunt
27 Optics
31 Ground connection
63 Junction point
64 Connector
B. Junction points
The wiring diagrams contain numbered junction
points, e.g. 63/352.
This manual contains a section with a list of junction
points. This list shows all the components that are
connected to each junction point.
The location of the junction points is shown in the
"Cable harness routing in vehicle" section.
C. Connectors
Connectors provide a bridge between two cable har-nesses and are described in the "Connectors" sec-
tion.
D. Electrical distribution
Operation of the fuses and relays is shown in the
"Electrical distribution" section.
E. Data communication
Todays cars contain CAN and MOST networks that
transfer information. Connections to these networks
are not shown in their entirety in the respective wir-
ing diagram. Complete information on CAN andMOST communication is found in the section "Con-
trol modules".
F. Abbreviations
A number of different abbreviations are used in the
manual. These are explained in the section "Abbre-
viations".
G. Component location
There is a section at the end of the manual in which
the appearance and location of components isdescribed in numerical order.
-
7/27/2019 2005_Supplement_S40(04-)_V50_wiring_diagram.pdf
7/121TP3984202 S40 (04-)/V50 2005 7
How to use the wiring diagrams 2:2
List of symbols
= System voltage
= Ground connection
via wiring
= Ground connection oncomponent/chassis
= Screened wire
= Junction point
= Twisted cable
= Electrical connection
= Variant
= CAN communication
= CAN high data signal
(CAN H)
= CAN low data signal
(CAN L)
= MOST communication
= LIN communication
= DIN cable, coaxial cable,etc.
= Data communication
= CAN communication
= Connection with distribution
box
= Further connection to...
= Connector between
cable harnesses
= Connector connected
to component
CAN
1
1
G
A E C F B D
10/17-18
BK
GN-BK
CAN
CAN
63/211
31/11 31/12
F:14
F:16
D:14
D:15
A:6
A:8
TCM
4/28 30+
F18
2
11
2
F4
MAN
63/53
MAN
GN-YEGN-YE
64/90
10
31/52
E:14
4/56
CEM
3/10 1
2
GN-BKGN-BK
BK
V50
10/55
10/48
BK
V50
BK
F79
2
1
LIN
15/31
C:45
E:21
E:22
GN-BK
S40 S40
BK
BK
2/80
R2
TAIL
FOG
BACK
10/18
10/18
A:4
C:4
C:2
A:2
TAIL
FOG BACK
GND GND2
TURNSTOP
10/55
10/17
A:2
A:4
TAIL
FOGBACK
GNDGND2
TURNSTOP
10/48
TURN
STOP
A:2A:3 C:3 C:1
A:4
TAIL
FOG
BACK
10/17
C:2
C:4
TURN
STOP
A:2 A:3C:1C:3
A:4
C:4 C:2
A:1 C:1C:3C:4C:2C:1A:3C:3
V50V50
S40S40
LIN
3/156
64/90A:7 WH-RD RD
33
64/111
2 A:2
LIN
3/155GSMWH-RD
AUTO
RD-YE
RD-BU
GN-BK
UP
UP
UP UP
-
7/27/2019 2005_Supplement_S40(04-)_V50_wiring_diagram.pdf
8/121TP3984202 S40 (04-)/V50 2005 8
Electrical distribution 1:2
Overview
FEC
31/114
63/120
BK
BK
63/121
BK
RD
1
F36
F34
F33
F35
F32
3
2
5
5
3
1 2
1 2
35
35
1 2
F10
F17
F14
GY
BK-W
H
GN-B
U
2/32R14
R52/142
R13
2/35
R10
2/82
F12
F13
F24
F9
RD-OG
RD-OG
RD-BK
RD-GN
RD-OG
RD-OG
A
15/31
6/2550
31
M
ACM
30
A:3
B:16/26
B+
31
L
G
B:1
A:1
RD
RD
12V BK
31/3
1/1
BK
31/4
PF2 PF1
RD
RD-O
G
40
14
39
64/90=15/31A
64/90=15/31A
11
6
4BK-RD
GY
GN-RD
64/90=15/31A
41
12
21BK-BU
GN-BU
GN-BU
GN-YE
GN-BU
GN-YE
B
DIESE
L
GN-B
U
PETROL
2
11
2
GN-YE
GN-YE
5CYLT
W/O
T
D
35
1 2
64/90
31GY-OG
64/113
6GN-BU
GY-BK
2/165
ONLY I4 & DV6 ENGINES
GN-Y
E
-
7/27/2019 2005_Supplement_S40(04-)_V50_wiring_diagram.pdf
9/121TP3984202 S40 (04-)/V50 2005 9
Electrical distribution 2:2
Overview
RD-WH
RD-BK
RD-GN
RD-OG
RD-BU
RD-OG
RD-BU
21
3
5
3
1
5
2
3
1
5
2
2
5
3
1
CAN
CEM
4/56
LIN
BK-YE
G:11
C
G:18
E:9
E:30
3/130
15X
5
50 S
B:7
A:42
A:15
A:30
A:17
B:
5
B:
2
B
:1
B:
3
GY-B
K
RD-G
N
YE
GN-W
H
64/111
5
G:9
E:22
E:23
E:20
E:21RD-YE
RD-B
U
RD-OG
RD
RD
BK-BU
2/182
2/159.2
R9
2/34R4
2/22R11
R2
2/17
F20
F26
F3
F30
F31
F2
F16
F6
F23
F4
F18
F27
F29
F11
F8
F7
F1
F5
F21
A
RD-O
G
GY
E
BK-W
H
F
GN-B
U
15/31
21
3
5
R12
BK-RD
13
64/90=15/31A
RD
23
64/90=15/31A
RD
RD-WH
17
64/90=15/31A
BK-YE
18GN-YE
PETROL
GN-B
U
DIESEL
B
64/861
1RD
D
GN-Y
E
E:1
F22
F28
-
7/27/2019 2005_Supplement_S40(04-)_V50_wiring_diagram.pdf
10/121TP3984202 S40 (04-)/V50 2005 10
Fuses
Engine compartment distribution box F1-F8
15/31 Engine compartment distribution box
No. Fuse function via A
F1 4/71 Cooling fan control module - 50F2 6/71 Electrical Power Steering Module (EPS) - 80
F3 2/193 Relay, comfort functions
F45 Fuse in the Central Electronic Module (CEM)
F48-F49 Fuses in the Central Electronic Module (CEM)
F60-F61 Fuses in the Central Electronic Module (CEM)
F62-F63 Fuses in the Central Electronic Module (CEM)
F68-F69 Fuses in the Central Electronic Module (CEM)
F80-F82 Fuses in the Central Electronic Module (CEM)
F84-F85 Fuses in the Central Electronic Module (CEM)
-
2/193
2/193
2/193
-
2/193
-
-
60
F4 2/63 Relay, high beam
F55 Fuses in the Central Electronic Module (CEM)
F58-F59 Fuses in the Central Electronic Module (CEM)
F74 Fuses in the Central Electronic Module (CEM)F77 Fuses in the Central Electronic Module (CEM)
-
-
2/63
--
60
F5 9/41 PTC element, Diesel - 80
F6 4/109 Glow plug control module - 60
F7 4/16 Brake Control Module (BCM), pump - 30
F8 4/16 Brake Control Module (BCM), valves - 20
continues
-
7/27/2019 2005_Supplement_S40(04-)_V50_wiring_diagram.pdf
11/121TP3984202 S40 (04-)/V50 2005 11
Fuses
Engine compartment distribution box F9-F18
15/31 Engine compartment distribution box
No. Fuse function via A
F9 2/32 Main relay, engine management systemF32-F36 Fuses in the engine compartment distribution box
-2/32
30
F10 4/31 Fan control module - 40
F11 6/104 Pump, high pressure headlight washer 2/182 20
F12 2/82 Relay, heated rear window
9/2 Heated rear window
-
2/82
30
F13 6/25 Starter motor 2/35 30
F14 4/110 Trailer Module (TRM) - 40
F16 2/159 Relay, infotainment
16/105 Audio Module (AUD)
F43 Fuse in the Central Electronic Module (CEM)
F64 Fuse in the Central Electronic Module (CEM)
F65-F67 Fuses in the Central Electronic Module (CEM)
-
-
-
-
2/159
30
F17 6/1 Wiper Motor Module (WMM) - 30
F18 2/80 Relay, reversing lights
2/89 Relay, interior lighting
4/56 Central Electronic Module (CEM)
F46-F47 Fuses in the Central Electronic Module (CEM)
F56-F57 Fuses in the Central Electronic Module (CEM)
F79 Fuse in the Central Electronic Module (CEM)
F81-F83 Fuses in the Central Electronic Module (CEM)
F86 Fuse in the Central Electronic Module (CEM)
-
-
-
2/89
-
2/80
-
2/89
40
continues
-
7/27/2019 2005_Supplement_S40(04-)_V50_wiring_diagram.pdf
12/121TP3984202 S40 (04-)/V50 2005 12
Fuses
Engine compartment distribution box F20-F32
15/31 Engine compartment distribution boxNo. Fuse function via A
F20 2/17 Relay, horn16/10 Horn 1
16/11 Horn 2
-2/17
2/17
15
F21 4/7 Combustion Preheater Module (CPM) - 20
F22 16/79 Subwoofer Module (SUB) 2/159 15
F23 4/28 Transmission Control Module (TCM)
4/46 Engine Control Module (ECM)
-
-
10
F24 9/38 Heated fuel filter, Diesel 2/142 20
F26 2/35 Relay, starter motor
3/1 Start Control Module (SCU)
4/46 Engine Control Module (ECM)
4/56 Central Electronic Module (CEM)
F44 Fuse in the Central Electronic Module (CEM)F51-F54 Fuses in the Central Electronic Module (CEM)
F73 Fuse in the Central Electronic Module (CEM)
3/1
4/56
3/1
3/1
3/13/1
3/1
15
F27 8/3 Electromagnetic clutch, climate control system 2/22 10
F28 3/112 Climate Control Module (CCM)
16/108 Multimedia Module (MMM)
-
2/159
10
F29 2/34 Relay, front fog lights
10/5 Fog light, front left
10/6 Fog light, front right
-
2/34
2/34
15
F30 4/46 Engine Control Module (ECM), Diesel - 3
F31 6/26 Generator, Diesel - 10
F32 2/142 Relay, pre-heater, fuel filter
7/15 Heated oxygen sensor, front7/82 Heated oxygen sensor, rear
8/6-8/10 Injectors, Gasoline
8/121 Valve coolant
8/122 Heated oxygen sensor, rear
-
--
-
-
-
10
continues
-
7/27/2019 2005_Supplement_S40(04-)_V50_wiring_diagram.pdf
13/121TP3984202 S40 (04-)/V50 2005 13
Fuses
Engine compartment distribution box F33-FH1
15/31 Engine compartment distribution box
No. Fuse function via A
F33 6/114 Vacuum pump7/15 Heated oxygen sensor, front
7/82 Heated oxygen sensor, rear
7/186 Heated oxygen sensor, rear
7/187 Heated oxygen sensor middle
8/84-
-
-
-
20
F34 4/46 Engine Control Module (ECM) I5
8/6-8/9 Injection valves
8/11 Injector
8/77 Control valve, fuel volume, Diesel
20/3 -20/7 Spark plug and ignition coil
20/17 Transformer, ignition coils
9/32 PTC resistor, oil trap
8/119
-
-
-
-
-
-
10
F35 2/22 Relay, climate control system
6/67 Pump, fuel leakage control6/99 Engine EGR
7/17 Mass airflow sensor (MAF)
7/192 Water detection sensor
8/6 Injection valves
8/7 Injection valves
8/8 Injection valves
8/9 Injection valves
8/18 EVAP valve
8/19 Solenoid, variable valve timing, intake
8/28 Turbocharger control valve
8/65 Power steering pressure switch
8/81 Solenoid, variable valve timing outlet
8/68 Bypass valve, Diesel
8/82 Solenoid, variable turbo geometry, Diesel
8/114 Valve mixing air/fuel
8/132 Control valve, intake, Diesel
9/32 PTC-resistor air preheating
-
2/22-
-
-
-
-
-
-
-
-
-
-
-
-
-
-
-
-
15
F36 4/46 Engine Control Module (ECM)
7/51 Accelerator pedal sensor
-
-
10
FH1 10/65 Auxiliary light, front right
10/69 Auxiliary light, front left
2/64 20
-
7/27/2019 2005_Supplement_S40(04-)_V50_wiring_diagram.pdf
14/121TP3984202 S40 (04-)/V50 2005 14
Fuses
Central Electronic Module (CEM) F43-F52
4/56 Central Electronic Module (CEM)
No. Fuse function via A
F43 16/46 RTI Display16/60 Phone Module (PHM)
16/107 Media Player Module (MPM)
--
-
15
F44 4/9 Supplemental Restraint System Module (SRS) - 10
F45 9/1 Front 12V outlet
9/25 Rear 12V outlet
-
-
15
F46 3/111 Switch unit, lights
5/1 Driver Information Module (DIM)
10/29 Glove compartment lighting
10/97 Courtesy lighting, left
10/102 Courtesy lighting, right
-
-
-
-
-
5
F47 10/22 Ceiling light
10/150 Rear reading light
10/114 Vanity mirror lighting, left
10/115 Vanity mirror lighting, right
-
-
-
5
F48 2/16 Relay, rear window wiper
2/92 Relay, windshield washer motor
2/93 Relay, rear window washer motor
6/2 Washer pump
6/2 Washer pump
6/32 Rear window wiper motor
-
-
-
2/92
2/93
2/16
15
F49 4/9 Supplemental Restraint System Module (SRS)
7/93 Occupant Weight Sensor (OWS), USA/CDN
-
-
10
F51 10/1 Lamp housing, front left, beam length adjustment
10/2 Lamp housing, front right, beam length adjustment
4/112 Control module, gas discharge lamp master, left4/113 Control module, gas discharge lamp slave, right
9/41 PTC element, Diesel
4/112
4/113
--
-
10
F52 4/16 Brake Control Module (BCM) - 5
continues
-
7/27/2019 2005_Supplement_S40(04-)_V50_wiring_diagram.pdf
15/121TP3984202 S40 (04-)/V50 2005 15
Fuses
Central Electronic Module (CEM) F53-F66
4/56 Central Electronic Module (CEM)
No. Fuse function via A
F53 6/71 Electrical Power Steering Module (EPS) - 10F54 4/28 Transmission Control Module (TCM)
6/26 Generator
-
-
10
F55 4/93 Keyless Vehicle Module (KVM) - 20
F56 16/35 Siren Control Module (SCM) 4/56 10
F57 4/46 Engine Control Module (ECM)
4/56 Central Electronic Module (CEM)
17/13 Data link connector
3/9
3/9
-
15
F58 2/64 Relay, auxiliary light (accessory)
4/113 Control module, gas discharge lamp slave, right
10/64 High beam, right
3/60
-
-
7.5
F59 4/112 Control module, gas discharge lamp master, left
10/68 High beam, left
-
-
7.5
F60 9/12 Seat Heater Module (SHM), drivers side - 15
F61 9/13 Seat Heater Module (SHM), passenger side - 15
F62 4/33 Sunroof control module - 20
F63 3/129 Right Rear Door Module (RDM) - 20
F64 16/49 Traffic Message Channel Module (TMC)
16/94 AM/FM Tuner Module (AFM)
16/139 Global Positioning System Module (GPS)
-
-
-
5
F65 7/182 Remote control IR sensor, RTI
16/46 RTI Display
16/105 Audio Module (AUD)
16/107 Media Player Module (MPM)
-
-
-
-
5
F66 2/159 Relay, infotainment
16/1 Infotainment Control Module (ICM)
-
-
10
continues
-
7/27/2019 2005_Supplement_S40(04-)_V50_wiring_diagram.pdf
16/121TP3984202 S40 (04-)/V50 2005 16
Fuses
Central Electronic Module (CEM) F68-F86
4/56 Central Electronic Module (CEM)
No. Fuse function via A
F68 3/254 Steering Wheel Module (SWM) - 5F69 7/149 Rain Sensor Module (RSM)
6/48 Damper motor, recirculation
6/95 Damper motor, temperature, left-hand side
6/96 Damper motor, temperature, right-hand side
6/102 Damper motor, defroster
6/103 Damper motor, floor/ventilation
7/159 Air quality sensor
-
-
-
-
-
-
-
5
F73 3/217 Belt buckle contact, left rear
3/218 Belt buckle contact, center rear
3/219 Belt buckle contact, right rear
4/33 Sunroof control module
8/48 Auto-dimming rearview mirror
10/22 Ceiling light
-
-
-
-
-
-
5
F74 4/83 Fuel pump control module, gasoline 2/23 15
F77 17/19 12V outlet, cargo compartment - 15
F79 8/48 Auto-dimming rearview mirror
10/48 Reversing light, right
10/55 Reversing light, left
2/80
-
-
5
F80 - - 5
F81 3/128 Left Rear Door Module (LDM) - 20
F82 3/127 Passenger Door Module (PDM) - 25
F83 3/126 Drivers Door Module (DDM) - 25
F84 3/27 Switch unit, power passenger seat - 25
F85 3/26 Switch unit, power drivers seat - 25F86 3/26 Switch unit, power drivers seat
3/27 Switch unit, power passenger seat
10/24 Cargo compartment lighting
-
-
-
5
-
7/27/2019 2005_Supplement_S40(04-)_V50_wiring_diagram.pdf
17/121TP3984202 S40 (04-)/V50 2005 17
Fuses
Battery, PF1-PF2
1/1 Battery
No. Fuse function via A
PF1 6/25 Starter motor 6/26 Generator
--
150
PF2 F1-F14 Fuses in the engine compartment distribution box
F16-F18 Fuses in the engine compartment distribution box
F20-F21 Fuses in the engine compartment distribution box
F23-F24 Fuses in the engine compartment distribution box
F26-F27 Fuses in the engine compartment distribution box
F29-F31 Fuses in the engine compartment distribution box
-
-
-
-
-
-
150
-
7/27/2019 2005_Supplement_S40(04-)_V50_wiring_diagram.pdf
18/121TP3984202 S40 (04-)/V50 2005 18
Relays
Ignition switch and relays
B
A
Position
Key Out
0
II
I
III
X
Terminal
30
S X 15
X
X X
X
X X
X X
X
X X
X
50
X
4
8
1
3
Relays, general
The diagram indicates two or three different designations for the relays position. Thisis described below.
A = Corresponds to the position on the back
of the relay box (wiring side)
B = Corresponds to the position on the relayC = An old designation that may be found on
the relay
A B C
4
2(85)
3
5(87)
2
1(86)
4(87a)5
3(30)
1
-
7/27/2019 2005_Supplement_S40(04-)_V50_wiring_diagram.pdf
19/121TP3984202 S40 (04-)/V50 2005 19
Relays
Distribution box in engine compartment R1-R14
15/31 Engine compartment distribution box
Pos Relay function
R1 2/165 Relay immobilizer
R2 2/17 Relay, horn
R4 2/34 Relay, front fog lights
R5 2/142 Relay, pre-heater, fuel filter
R8 2/159.2 Relay, infotainment, extra
R9 2/182 Relay, headlight washer motor
R10 2/82 Relay, heated rear window
R11 2/22 Relay, climate control system
R13 2/35 Relay, starter motor
R14 2/32 Main relay, engine management system
-
7/27/2019 2005_Supplement_S40(04-)_V50_wiring_diagram.pdf
20/121TP3984202 S40 (04-)/V50 2005 20
Relays
Central Electronic Module (CEM) R15-R18
4/56 Central Electronic Module (CEM)
Pos Relay function
R15 2/23 Fuel pump relay, gasoline
R18 2/193 Relay, comfort functions
-
7/27/2019 2005_Supplement_S40(04-)_V50_wiring_diagram.pdf
21/121TP3984202 S40 (04-)/V50 2005 21
Relays - soldered
Central Electronic Module (CEM) R1 - R11B
4/56 Central Electronic Module (CEM)
Pos Relay function
R1 2/89 Relay, interior lighting
R2 2/80 Relay, reversing lights
R7A 2/92 Relay, windshield washer motor
R7B 2/93 Relay, rear window washer motor
R8 2/63 Relay, high beam
R11A 2/16 Relay, rear window wiper
R11B 2/159 Relay, infotainment
-
7/27/2019 2005_Supplement_S40(04-)_V50_wiring_diagram.pdf
22/121TP3984202 S40 (04-)/V50 2005 22
31/11 31/12
31/66
31/83
31/6
31/115
31/52
31/114
31/3
31/119
31/80
31/4
31/84
31/10
31/116
31/110
31/67
31/89 31/88
31/112
31/107
Ground connections
Overview
-
7/27/2019 2005_Supplement_S40(04-)_V50_wiring_diagram.pdf
23/121TP3984202 S40 (04-)/V50 2005 23
31/3 Left MacPherson strut tower
1/1 Battery
31/4 Engine
1/1 Battery
31/6 A-post, drivers side
3/111 Switch unit, lights
4/102 Steering Column Lock Module (SCL)
6/28 Motor, passenger compartment fan
10/1 Lamp housing, front left
10/2 Lamp housing, front right
10/3 License plate lighting
17/13 Data link connector
31/10 A-post, passenger side2/16 Relay, rear window wiper
2/89 Relay, interior lighting
2/92 Relay, windshield washer motor
2/93 Relay, rear window washer motor
2/193 Relay, comfort functions
3/95 Spin control switch
3/112 Climate Control Module (CCM)
3/117 Switch unit, ceiling light
3/156 Gear Selector Module (GSM)
3/173 Switch, trunk lid/tailgate private lock
4/33 Sunroof control module
4/56 Central Electronic Module (CEM)
6/2 Washer pump
6/48 Damper motor, recirculation
6/95 Damper motor, temperature, left-hand side
6/96 Damper motor, temperature, right-hand side
6/102 Damper motor, defroster
6/103 Damper motor, floor/ventilation
6/117 Interior temperature sensor
7/159 Air quality sensor
8/48 Auto-dimming rearview mirror8/134 Solenoid, reverse interlock, manual
9/1 Front 12V outlet
9/25 Rear 12V outlet
10/22 Ceiling light
10/29 Glove compartment lighting
10/114 Vanity mirror lighting, left
10/115 Vanity mirror lighting, right
10/150 Rear reading light
16/1 Infotainment Control Module (ICM)
Ground connections
31/3 - 31/10
-
7/27/2019 2005_Supplement_S40(04-)_V50_wiring_diagram.pdf
24/121TP3984202 S40 (04-)/V50 2005 24
31/11 Rear left side
10/18 Lamp housing, rear left
16/79 Subwoofer Module (SUB)
16/105 Audio Module (AUD)
16/139 Global Positioning System Module (GPS)
31/12 Rear right side
4/78 Accessory Electronic Module (AEM)
4/86 Control module, Parking Assistance Module (PAM)
4/110 Trailer Module (TRM)
6/37 Lock motor, fuel filler flap
10/17 Lamp housing, rear right
17/19 12V outlet, cargo compartment
31/52 Left MacPherson strut tower
3/10 Reversing light contact4/28 Transmission Control Module (TCM)
4/46 Engine Control Module (ECM)
4/86 Parking Assistance Module (PAM)
7/23 Rear knock sensor
7/24 Front knock sensor
7/192 Water detection sensor
8/3 Electromagnetic clutch, climate control system, Diesel
9/38 Heated fuel filter, Diesel
31/66 Left B-post
3/26 Switch unit, power drivers seat, LHD
3/27 Switch unit, power passenger seat, RHD
3/76 Lock unit, left rear door
3/78 Lock unit, trunk lid/tailgate
3/85 Power window switch, left rear door
3/260 Contact, locking, rear left
3/264 Contact, unlocking, rear left
3/128 Left Rear Door Module (LDM)
4/52 Power Seat Module (PSM), LHD
6/32 Rear window wiper motor, V50
6/35 Fuel pump, auxiliary heater9/12 Seat Heater Module (SHM), drivers side, LHD
9/13 Seat Heater Module (SHM), passenger side, RHD
10/3 License plate lighting, S40
10/19 Auxiliary brake light, V50
Ground connections
31/11 - 31/66
-
7/27/2019 2005_Supplement_S40(04-)_V50_wiring_diagram.pdf
25/121TP3984202 S40 (04-)/V50 2005 25
31/67 Right B-post
3/26 Switch unit, power drivers seat, RHD
3/27 Switch unit, power passenger seat, LHD
3/77 Lock unit, right rear door
3/86 Power window switch, right rear door
3/129 Right Rear Door Module (RDM)
3/261 Locking switch, rear right
3/265 Unlocking switch, rear right
4/52 Power Seat Module (PSM), RHD
4/82 Differential Electronic Module (DEM)
4/93 Keyless Vehicle Module (KVM)
7/93 Occupant Weight Sensor (OWS), USA/CDN
9/12 Seat Heater Module (SHM), drivers side, RHD
9/13 Seat Heater Module (SHM), passenger side, LHD
31/80 Left MacPherson strut tower
4/16 Brake Control Module (BCM), valves
31/83 A-post, drivers side
3/1 Ignition switch
3/6 Switch, hazard warning flashers
3/254 Steering Wheel Module (SWM)
4/103 Remote Entry (RRX)
5/1 Driver Information Module (DIM)
17/13 Data link connector
31/84 A-post, passenger side
4/56 Central Electronic Module (CEM)
7/51 Accelerator pedal sensor
7/149 Rain Sensor Module (RSM)
8/31 Airbag igniter, passenger side
8/32 Igniter, airbag stage 2, passenger side
16/1 Infotainment Control Module (ICM)
16/46 RTI Display
16/60 Phone Module (PHM)
16/93 Control module, cellular phone handsfree
16/107 Media Player Module (MPM)16/108 Multimedia Module (MMM)
Ground connections
31/67 - 31/84
-
7/27/2019 2005_Supplement_S40(04-)_V50_wiring_diagram.pdf
26/121TP3984202 S40 (04-)/V50 2005 26
31/88 Engine
9/32 PTC resistor, oil trap
20/3 Spark plug and ignition coil
20/4 Spark plug and ignition coil
31/89 Engine20/5 Spark plug and ignition coil
20/6 Spark plug and ignition coil
20/7 Spark plug and ignition coil
31/102 Front member
2/192 Relay (230V), electric engine heater
31/107 Tailgate (V50)
16/16 Window antenna amplifier
31/110 Right MacPherson strut tower
3/271 Contact, immobilizer, clutch pedal
4/7 Combustion Preheater Module (CPM)
4/113 Control module, gas discharge lamp slave, right
6/1 Wiper Motor Module (WMM)
6/104 Pump, high pressure headlight washer
7/4 Brake fluid level sensor
7/5 Washer fluid level sensor
8/119 Pressure monitor, climate control system
8/127 Pressure switch, climate control system, Diesel
10/2 Lamp housing, front right
10/6 Fog light, front right
31/112 Right MacPherson strut tower
9/41 PTC element, Diesel
31/114 Left MacPherson strut tower
2/142 Relay, pre-heater, fuel filter
3/62 Hood alarm contact
4/71 Cooling fan control module
4/109 Glow plug control module
4/112 Gas Discharge Lamp Module (GDL), master
6/71 Electrical Power Steering Module (EPS)
6/114 Vacuum pump, gasoline
10/1 Lamp housing, front left
10/5 Fog light, front left
16/10 Horn 1
16/11 Horn 2
16/35 Siren Control Module (SCM)
Ground connections
31/88 - 31/114
-
7/27/2019 2005_Supplement_S40(04-)_V50_wiring_diagram.pdf
27/121TP3984202 S40 (04-)/V50 2005 27
31/115 Left A-post
3/126 Drivers Door Module (DDM), LHD
4/83 Fuel pump control module, RHD, gasoline
31/116 Right A-post
3/127 Passenger Door Module (PDM), LHD4/83 Fuel pump control module, LHD, gasoline
4/111 Additive Dosing Module (ADM)
6/33 Fuel pump
31/119 Left MacPherson strut tower
4/16 Brake Control Module (BCM)
Grounded directly to chassis
3/47 Parking brake contact
4/9 Supplemental Restraint System Module (SRS)
6/25 Starter motor
8/3 Electromagnetic clutch, climate control system, gasoline
8/33 Igniter, belt tensioner, drivers side
8/34 Igniter, belt tensioner, passenger side
8/55 Igniter, left rear belt tensioner
8/56 Igniter, right rear belt tensioner
8/66 Igniter, left inflatable curtain
8/67 Igniter, right inflatable curtain
8/128 Drivers belt force limiter
8/129 Passenger belt force limiter
10/19 Auxiliary brake light, S40
16/16 Window antenna amplifier
16/49 Traffic Message Channel Module (TMC)
16/94 AM/FM Tuner Module (AFM)
16/141 Interference filter, rear window, left
16/142 Interference filter, rear window, right
Ground connections
31/115 - Ground connections in chassis
-
7/27/2019 2005_Supplement_S40(04-)_V50_wiring_diagram.pdf
28/121
TP3984202 S40 (04-)/V50 2005
AQS
17/13
DDM
KVM
PSM
RSM
SCL
AUD
ICM
GPS
SUB
TMC
AFM
TRM
LDM
CCM
AEM
DMM
RRX
SHM
BCM
SWM
DIM
GSM BSC
SHMOWS
SRS
RDM
Control modules
Overview of locations
-
7/27/2019 2005_Supplement_S40(04-)_V50_wiring_diagram.pdf
29/121TP3984202 S40 (04-)/V50 2005 29
Unit Designation
ACM 6/26 Alternator Control Module (ACM)
AEM 4/78 Accessory Electronic Module (AEM)
AFM 16/94 AM/FM Tuner Module (AFM)
AQS 7/159 Air Quality Sensor (AQS)
AUD 16/105 Audio Module (AUD)BCM 4/16 Brake Control Module (BCM)
BSC 7/164 Body Sensor Cluster (BSC)
CCM 3/112 Climate Control Module (CCM)
CEM 4/56 Central Electronic Module (CEM)
CPM 4/7 Combustion Preheater Module (CPM)
DDM 3/126 Drivers Door Module (DDM)
DIM 5/1 Driver Information Module (DIM)
DMM Damper Motor Module (DMM)
-6/48 Damper Motor Module (DMM), recirculation
-6/95 Damper Motor Module (DMM), left-hand side
-6/96 Damper Motor Module (DMM), right-hand side
-6/102 Damper Motor Module (DMM), defroster-6/103 Damper Motor Module (DMM), floor/ventilation
ECM 4/46 Engine Control Module (ECM)
EPS 6/71 Electrical Power Steering Module (EPS)
GDL Gas Discharge Lamp Module (GDL)
-4/112 Control module, gas discharge lamp (GDL), master, left
-4/113 Control module, gas discharge lamp (GDL), slave, right
GPS 16/139 Global Positioning System Module (GPS)
GSM 3/156 Gear Selector Module (GSM)
ICM 16/1 Infotainment Control Module (ICM)
KVM 4/93 Keyless Vehicle Module (KVM)
LDM 3/128 Left Rear Door Module (LDM)MMM 16/108 Multimedia Module (MMM)
MPM 16/107 Media Player Module (MPM)
OWS 7/93 Occupant Weight Sensor (OWS)
PDM 3/127 Passenger Door Module (PDM)
PHM 16/60 Phone Module (PHM)
PSM 4/52 Power Seat Module (PSM)
RDM 3/129 Right Rear Door Module (RDM)
RRX 4/103 Remote Entry (RRX)
RSM 7/149 Rain Sensor Module (RSM)
SCL 4/102 Steering Column Lock Module (SCL)
SCM 16/35 Siren Control Module (SCM)
SCU 3/1 Start Control Module (SCU)
SHM Seat Heater Module (SHM)
-9/12 Seat Heater Module (SHM), drivers side
-9/13 Seat Heater Module (SHM), passenger side
SRS 4/9 Supplemental Restraint System Module (SRS)
SUB 16/79 Subwoofer Module (SUB)
SWM 3/254 Steering Wheel Module (SWM)
TCM 4/28 Transmission Control Module (TCM)
TMC 16/49 Traffic Message Channel Module (TMC)
TRM 4/110 Trailer Module (TRM)
WMM 6/1 Wiper Motor Module (WMM)
17/13 17/13 Data link connector
Control modules
Overview of designations
-
7/27/2019 2005_Supplement_S40(04-)_V50_wiring_diagram.pdf
30/121TP3984202 S40 (04-)/V50 2005 30
16/60
PHM
7
4
#
1
CAN
0
5
8
6
9
2 3
A:3
A:12
3/127
CAN
PDM
A:4
CAN
A:5
4/7
CPM
CAN
3/26
PSM
CAN
3/126
DDM
CAN
SRS
4/9
10
9
CAN
3/27
PSM
B:16
B:15
4/56
CAN
CEM
B:9
B:8 GY-BK
BU-YE
BU-RD
GY-RD
11
17/13
CAN
3
BU-RD
GY-RDG:16
G:32
A:11
A:12
BU-BK B:25
GY-OG B:24
BU-RDA:53
A:56 GY-RD
63/221
WHA:3
A:12 BK
64/43
BK5
WH4
A:51
A:52
BU-YE
GY-BK
63/220
4
5
64/41
GY-RD
BU-RD
63/228
63/232
63/233
63/229
BU-RD
GY-RD
F:30 F:15
A
B
4/93
CAN
KVMB:4
B:3
B:11
B:12
LIN
RHD BU-RD
RHD GY-RD
14
7
1
2
CAN
4/86
PAS
CAN
4/110
TOW
64/322
63/421
63/422
BU-RD
GY-RD
BU-RD
GY-RD
GY-RD
GY-RD
BU-RD
GY-RD
BU-RD
BU-RD
GY-RD
BU-RD
RHD GY-RD
GY-RD
RHD
BU
-RD
BU-RD
RHD
GY
-RD
RHD
BU
-RD
BU-RD
GY-RD
GY-RD
BU-RD
1 2
Control modules
Data communication Low speed CAN 1:2
-
7/27/2019 2005_Supplement_S40(04-)_V50_wiring_diagram.pdf
31/121TP3984202 S40 (04-)/V50 2005 31
Control modules
Low speed CAN data communication 2:2
A
B
9
10
CAN
5/1
DIM
BU-WH
GY-VT
A:9
CAN
A:10ICM
16/1
A:8
A:7 GY-RD
BU-WH
C/F
CAN
11
9
8
10
CCM
3/112
GY-BK
BU-YE
-
7/27/2019 2005_Supplement_S40(04-)_V50_wiring_diagram.pdf
32/121TP3984202 S40 (04-)/V50 2005 32
Control modules
Data communication LIN 1:2
3/156
WH-GN3
7/149
LIN
H:23
WH-GN
WH-GN
G:3
WH-R
D
1
6/1 LHD
WMM
4
6/1 RHD
WH-BK
LIN
G:26
G:1
CEM
4/56
A:11 A:11
LIN
A:12
ECU SLAVE
4/112
GDLECU MASTER
SCM
16/35
2
64/90A:7 RD RD
33
64/111
2 2
LIN
4/102
LIN
A:2
LIN
3/1
GSM
LIN
RSM
LIN
WMM
LIN
4/113
GDL
4/28
LIN
TCM
I5
AW55-51
WH-RD
WH-G
N
WH-GNWH-GN
LIN
4/103
WH
4
5A:35
B:17
RD
SCU
SCL
RRX
63/339G
LIN
64/90A:1 RD RD
33
4/28
LIN
TCM
1.8L
DV 6 , CVT
3/155
-
7/27/2019 2005_Supplement_S40(04-)_V50_wiring_diagram.pdf
33/121TP3984202 S40 (04-)/V50 2005 33
Control modules
LIN data communication 2:2
LIN
16/1
ICM
3/112
7
12
LIN
C/F
CCM
LIN
3/254
SWM
SHM
LIN
9/12
SHM
9/13
LIN
3
64/545
64/1127
6
6
A:2 A:2
WH
WH-G
N
WH WH-GN
WH
WH
WH-GN
WH-GN
C:5A:2 WH-BU
LIN
RDM
3/129
PDM
LIN
3/127
LDM
3/128
LIN
DDM
3/126
LIN
64/47
1
15
64/41
15
64/43
1
64/45
WH-G
N
WH-G
N
BKBK
BK BK
A:13A:13
2
66
AQS
6/102
LIN
7/159 LHD
LIN
ECC
DMM
4 4
BU
BU
RHD
WH
WH-GN
RHD
LHDLHD
64/30 64/31LIN
7/159 RHD
LIN
ECCAQS
6/103
DMM
YE
YE
VT
VT
6/95
6/48 RHD
2
2
2
6/96
6/48 LHD
2
ACM
6/26
LIN
ECM
LIN
4/46
ECM
TURBO
LIN
4/46.1
88
21
WH-RD
WH-RD
-
7/27/2019 2005_Supplement_S40(04-)_V50_wiring_diagram.pdf
34/121TP3984202 S40 (04-)/V50 2005 34
A:8
A:6
CAN
4/28
TCM
AW 55-51
CAN
B:58
B:45
B:57
B:44
4/46.1
ECM
63/223
11
15
CAN
BCM4/16
CAN
4/56
CEM G:14
G:15
F:14
63/216
BU-RD
GY-RD
A:2
A:3
CAN
6/71
63/215
F:16
63/222GY-RD
BU-RD1
15
64/90
GY-RD
BU-RD
GY-RD
BU-RD
29
25
7/164
CAN
1
2
17 1864/113
BU
GY
BU
GY
B:11
B:12
14
CAN
617/13
GY-R
D
BU-R
D
BSC
EPS
ECM
4/46.3
CAN
F:31
F:19
GY-RD
BU-RD
5 cyl
1.6 L
Sigma
DSTC
GY-RD
BU-RD
ECM
4/46.4
CAN
A:A4
A:A3
GY-RD
BU-RD
DV 6
63/226
ECM
4/46.5
CAN
41
30
GY-RD
BU-RD
1.8 L
1
15
1
15
64/90
64/90
1
15
64/90
1
15
64/90
CAN
CFT 23
4/28
TCM
GY-RD
BU-RD
6
2
GY-RDGY-RD
GY-RDGY-RD
BU-RDBU-RD
BU-RDBU-RD
GY-R
D
BU-R
D
CAN
3/254
SWM
CAN
4/111
ADM
5
4
64/112
7
6
64/650
2
6
64/51
5
6
64/50
4
3
64/50
CAN
4/82
DEM
GY-RD
A:7
A:8
C:9
C:8BU-RD
GY-RD
BU-R
D
GY-R
D
BU-RD
GY-RD
BU-RD
GY-RD63/224
63/225
BU-RDBU-RD
GY-RD
BU-RD
GY-RD
BU-RD
GY-RD
BU-RD
GY-RD
BU-RD
GY-RD2 WD & GDL
AWD
GDL/AWD
2WD
63/227
ECM
4/46.2
CAN
A:A4
A:A3
GY-RD
BU-RD
Diesel
DW 10
1
15
64/90
STAGE 5
Control modules
Data communication High speed CAN
-
7/27/2019 2005_Supplement_S40(04-)_V50_wiring_diagram.pdf
35/121TP3984202 S40 (04-)/V50 2005 35
Control modules
Data communication MOST
CAN
16/60
PHM
D:1
D:2
#
7
0
8
1
4 5
2
9
6
3
CAN
ICM
16/1.2
16/105
AUD
2 1 64/977A
16/108
MMM
2 1 64/977
16/139
GPS TMC
16/4916/105
AUD
D:1
D:2
C:1
C:2
21 B:1 B:2
D:2
D:1
C:2
C:1
C:2
C:1
O
O
O
O
OO
O
O
O
O O
O O
O
O O
O
O
O
O
O
OO
O
O
O
O
OG
OG
OG
OG
OG
OG
OG
OG
OG
OG
OG
OG
OG
OG
OG
CAN
IAM
16/1
OGO
O
O
2 164/978
OG
O
OG
IAM
PHM
AUD, GPS
AUD,GPS,
TMC
RTI
OG
-
7/27/2019 2005_Supplement_S40(04-)_V50_wiring_diagram.pdf
36/121TP3984202 S40 (04-)/V50 2005 36
6
5
4
1
2
3
2
1
R14
2
1
2/32
8/81
2
8/91
2
2(85)
1(86)
3(30)
5(87)
8/71
2
2
18/6
30+
BN
BN
BN
WH
7/161
2
1
2
F35F34
2
11
2
F32
ETA
B:F13
RD
6/120
64/60
64/60
63/SH8
63/SH7
C
GN-OG
GN-YE
GN-YE
GN-YE
GN-YE
GN-WH
GN-YE
4/46.3
7/24
7/25
WH-BK
BN-YE
WH-RD
BN-RD
WH-RD
A
A:M27
F16
A:M13
A:M28
A:M12
A:M31
BK
SCR
SCR A:M16
A:M32
B:F37
B:F26
B:F41
B:F42
ECM
A:M21
YE
A:M6BN
CAN
WH-BU
GN-RD
WH-BU
YE-BU
WH-RD
YE
BN
WH-BU
WH-BU
YE-BU
B
GN-RD
D
GN-YE
A:M22
A:M48
1
2
B:F36
B:F37
B:F26
B:F9
1.6 L
SIGMA
WH-GN
GN-WH
A:M52
B:F17
P7/165
3
2
1
4
WH-VT
WH-VTWH-VT
YE-GN
BN-GN
BN-WH
WH-VT
BN-WH
BN-WH
B:F35
7/6
1
P
BK-OG
BK-BU
BK-OG
BK-YE
BK-WH
BK-BU
BK-OG
BK-YE
BK-WH
A:M20
B:F3
15/31
1
2
F30
RD-O
G
RD-O
G
F9
21
64/90
39 64/90
63/99
63/52
12 1413
BK-BU BK-BU
GN-B
U
GN-B
U
GN-Y
E
GN-Y
E
GN-R
D
1
2
F36
41
GN-B
U 8
7
2
3
1
4
1
27/163
B:F38
B:F2711
12
9
10
16
5
15
14
13
1
27/25
B:F29BN-WH12
8/65
BK-OG2
1
8/18
2
3
4
1
1
4
3
2B:F2
A:M49
GN-YE
BK-YE
WH
BN
BN/BU
WH/BU
BK-OG
7/15
2O
O2
GN-RD
7/82
B:F6
B:F14
A:M38
B:F39
Group 23 Fuel system
Engine management system, 4-cyl 1.6l 1:2
-
7/27/2019 2005_Supplement_S40(04-)_V50_wiring_diagram.pdf
37/121TP3984202 S40 (04-)/V50 2005 37
M
5 6
6/33
I4 PETROL
2 WD
1 4 2
ECM
B:F7
B:F40
A:M42
B:16
4/46.3
A BK-BU
B
CAN
3/9 2
1
C
GN-W
H
BK-O
G
63/53
30+
1
2
F18
CAN
CEM
F74
15/31
E:21
LIN
3/1 30
15X
5
50 S
B:7
B:2
64/1115
RD
RD
GY-BK
1
2
4/56
F57
1
2
1
2
F4
1
2
F26
1
2
F23
1
2
F30
RD-Y
E
RD-B
U
RD
RD
64/90
23
13
8
37
28
32
GY
GN-BU
GN-WH
64/111
64/51
7
7/5115
2
6
3
4
2
R15
2/23
5
1 3
E:22
C:16
A:42
E:40
E:10
G:22
G:31
G:7
A:28
B:F9
A:M47
A:M40
B:F21
A:M39
63/56
GN-WH
GN-BU
GY
4B:F30 BK-RD
34A:M10 WH-RD
17A:M9 BK-YE
1A:M33 GY
2A:M7 BU
5B:F22 BK-OG
29A:M17 YE-RD
19B:F34 WH-VT
RDRD
WH
YE
BN
E:28E:41
OG
OG-W
H
BK-Y
E
31/10
7 8
BN-RD
31/84
63/12
BK-Y
E
BK
GN-Y
E
B:F8
1
2
3
20/17
BK-YE
A:M5
A:M1
A:M3
BK-YE
BK-YE
BK-YE
BK-GN
BK-OG
31/52
GN-OG
D GN-RD
BK
GN-W
H
RD
31/11531/116
BK-O
G
63/25
BK
BK
BK-O
G
LHD
RHD
1.6 L
SIGMA
MAN
4
B:45
B:58
B:44
B:57
Group 23 Fuel system
Engine management system, 4-cyl 1.6l 2:2
-
7/27/2019 2005_Supplement_S40(04-)_V50_wiring_diagram.pdf
38/121TP3984202 S40 (04-)/V50 2005 38
3
4
1
6
2
MAF
R14
2
1
2/32
2(85)
1(86)
3(30)
5(87)
30+
BN
WH
7/16
7/190
7/191
1
1
1
2
2
2
1
2
F32
1
2
F35F34
2
11
2
F36
GN-RD
GN-RD
7/17
1
2
5
BK-BU
BN-RD
WH-BU
WH-BU
WH-RD
WH-RD
B:F2
C:C2
8/120
B
63/54
4/46.4
WH-GN
BN-GN
B:G2
B:H3
B:J3
C:A3
C:D4
C:D3
4 CYL
ECM
B:A4YE-GN
B:D2BK-GN
CAN
GN-BK
A
D
C
B:C2
B:H1
DIESEL
A:E3
7/6
1
P
BK-GN
B:E2
B:E1
15/31
RD-O
G
RD-O
G
F9
21
64/90
4
GN-BU
M
BK-BU
BK
31/52
7/174B:K1WH-VT
BN-WH B:F3
YE-VT B:G4
2
1
BK-WH C:G3
C:H1
2
18/7
8/6
BK-YE C:G4
C:G2
3
1
2 7/192
B:J1BK-BU
2
1
8/8 BK-BU C:H4
C:H2
GN-WH
GN-YE
GN-BU
2
2
1
1
8/9 BK-OG
BK-OG
C:H3
C:G1GN-RD
2
1
8/82
7/86
BK-BU
GN-BU
C:E1
2
1
F24
2
1
F6
R52/142
1(86)
2(85)
3(30)
5(87)
WH-VT B:F1
B:L4
P 27/713
1
BN-GN
BN-BU
BN-WH
B:D4
C:D2
WH-GN B:K2
YE-GN B:E4
BN-BU
WH-BU
7/1541
2
B:H2
C:F1
7/25B:B1WH-RD
BN-RD B:C1
YE-RD B:F31
2
3
C:A4WH-BU
BK-YE C:F22
64/90
16
P
P
7/21
B:D1WH-UT
BN-WH B:A1
YE-RD B:F4
2
3
P
2
7/162
3
1
1
BN-GN B:C4
YE-GN B:B4
WH-GN B:G3
4 8 3
5
1267
2
1
2
1
63/121
9/38
BK
GN-Y
E
GN-YE
BK
GN-B
U
64/902627 25 24
64/60034 2 1
2
1
2
1
2
1
GN-O
G
GN-O
G
GN-O
G
GN-O
G
GN-O
G
GN-O
G
GN-O
G
GN-O
G
GN-O
G
GN-O
G
GN-O
G
GN-O
G
GN-O
G
20/25 20/24 20/23 20/22
63/53
BK
31/114
63/120
BK-Y
E
BK
4/109
RD
DRIVER
N
GLOW P4 GLOW P3 GLOW P2 GLOW P1
PUISSANCE
MOS
PUISSANCE
MOS
PUISSANCE
MOS
PUISSANCE
MOS
DRIVER
N
DRIVER
N
DRIVER
N
BK-YE
GLOW PLUG RELAY BOX
WH-BU
BK-BU
RD-B
K
RD
14
64/90
12
39
GN-BU
GN-BU
GN-BK
GN-BU
6 64/90
GN-R
D
GN-R
D
63/41
YE-VT
YE-VTSTAGE 3
STAGE 5 STAGE 5
Group 23 Fuel system
Engine management system 4-cyl. 1.6l Diesel 1:2
-
7/27/2019 2005_Supplement_S40(04-)_V50_wiring_diagram.pdf
39/121TP3984202 S40 (04-)/V50 2005 39
ECM
A:G1
B:M2
4/46.4 8/111
A
CAN
3/9 2
1
B
C
D
1.6
DV6
31/84
30+
1
2
F18
CAN
CEM
15/31
E:21
LIN
3/1 30
15X
5
50 S
B:7
B:2
64/1115
RD
RD
GY-BK
4/56
F57
1
2
1
2
F26
1
2
F30
RD-YE
RD
1
2
F23
64/90
7
8
37
28 GY
GN-BU
GN-WH
GN-WH
64/111
64/51
64/650
7
7/51
CFT 23
15
2
6
3
4
A:42
E:40
E:10
G:22
G:31
G:7
C:B3
A:B3
A:A2
A:C3
GN-WH
GN-BU
GY
BU WH
YE
BN
E:28E:41C:16
OG
OG-WH
BK-YE
BK-OG
BK-OG
BK-OG
GN-WH
BK-RD
GN-OG
63/12
63/42
63/41
6/99
BK-YE
BK
GN-YE
A:H4
A:G4
63/53
BK-YE
BK-YE
31/52 31/11631/115
GN-OG
GN-OG
BK
RHD
WH-GN
A:G3 BK-BU
G:30
13
23
19
A:C4 BK-YE5
C:E2 BK-YE17
A:B2 WH-RD34
B:A3 GY1
C:B1
C:D1
B:K3
B:J2
B:M1
B:F4
B:L1
2
40
9 10 8 1
7
8
C:A1 BK-RD
BN-RD BN-RD
WH-RD
YE-RD
BK-BU
BN-GN
BN-GN
WH-GN
WH-GNYE-RD
BK-GN
5
6
1
4
3
4
B:M4
1 2
BK-YE
GN-YE
12
WH-GN
A:H1 BK-YE
64/90
41
B:G4 RD
A:A3
A:A4
GN-BU
GN-BU
GN-BK
M
8/122
4/111
5
6
1
3
4
M
6/33
1
2
ADM
Group 23 Fuel system
Engine management system, 4-cyl 1.6l Diesel 2:2
-
7/27/2019 2005_Supplement_S40(04-)_V50_wiring_diagram.pdf
40/121TP3984202 S40 (04-)/V50 2005 40
6
5
4
1
2
3
2
1
R14
2
1
2/32
8/81
2
8/91
2
2(85)
1(86)
3(30)
5(87)
8/71
2
2
1
8/6
30+
BN
BN
WH
BN7/16
1
2
1
2
F35F34
2
11
2
F32
GN-BU
ETA
B:16
BK
BK
BK
BK
GN-BK
3 1
2
20/6
WH-BU
GN-RD
3 1
2
20/5
20/4
2
13
GN-BU
WH-RD
WH
GN-YE
3 1
2
20/3
GN-B
U
6/120
GN-RD
C
GN-BU
63/95
WH-GN
GN-RD
GN-BU
GN-YE
GN-WH
63/54
4/46.5
7/24
7/25
WH-BK
GN-BK
YE-GN
SCR SCR
WH-GN
WH-VT
BN-YE
WH-RD
BN-RD
GN-RD
BN-BU
BW-RD
GN-YE
GN-RD
BK-OG
A
B:2
B:3
B:13
B:14
A:41
B:36
B:39
B:27
A:29
B:11
B:46
A:6
A :17
B:23
B:34
A:22
A:10
1.8L
I4
ECM
A:37WH-BU
A:38BN-BU
CAN
WH-BU
YE-BU
BGN-YE
DBK-BU
A:25
A:26
1
2
B:30
A:25
1
3
2
4
WH-BU
BK-GN
A:26
A:5
W/O T
7/6
7/165
1
P
B:31BK-OG
3
21
4
WH-GN
BK-GN
A:27
A:72
43
1
7/15
7/82
63/74
63/67
63/63
1
28/45
GN-YE
B:8BK-YE
1
2
8/18
GN-RD
A:3BK-OG
BK-BU
BK-GN
BU
BK-WH
15/31
RD-O
G
RD-O
G
F9
21
64/90
39 64/90
63/99
12 14
BN-RD
1
2
F36
GN-Y
E
BK-BU BK-BU
GN-B
U
GN-B
U
GN-B
U
41 32
BN-WH B:7
WH-VT B:187/172
2
1
Group 23 Fuel system
Engine management system, 4-cyl 1.8l 1:2
-
7/27/2019 2005_Supplement_S40(04-)_V50_wiring_diagram.pdf
41/121TP3984202 S40 (04-)/V50 2005 41
ECM
A:10
A:11
A:23
B:44
B:32
B:33
B:45
A:35
4/46.5
A BK-BU
B
CAN
3/9 2
1
C
D
1.8L
I4
GN-W
H
BK-O
G
31/84
63/53
30+
1
2
F18
CAN
CEM
F74
15/31
E:21
LIN
LIN
3/1 30
15X
5
50 S
B:7
B:2
64/1115
RD
RD
GY-BK
1
2
4/56
F57
1
2
1
2
F4
1
2
F26
1
2
F23
RD-Y
E
RD-B
U
RD
64/90
23
8
37
28
4
34
17
5
GY
GN -BU
GN-WH
64/1117
7/5115
2
6
3
4
2
R15
2/23
3
1 5
E:22
C:16
A:42
E:40
E:10
G:22
G:31
G:7
A:28
B:54
A:32
A:39
A:46
B:18
B:7
63/56
GN-WH
GN-BU
GY
A:1
A:4
A:12
BK-RD
WH-RD
BK-YE
A:14
A:28
BK-OG
YE-RD
A:13
WH-VT
BN-WH
RDRD
WH
YE
BN
E:28E:41
OG
OG-W
H
BK-Y
E
64/51
6/99
6/26
31/10
7 8
63/12
BK-Y
E
BK
GN-Y
E
A:34
BK-YE
BK-YE
BK-YE
GN-BU
31/52
GN-BU
BK-BU
BK
GN-W
H
RD
31/11531/116
BK-O
G
63/25
BK
BK
BK-O
G
LHD
RHD
W/O T
M
5 6
6/33
31 4 2
MAN
4
B:45
B:58
B:44
B:57
29
19
4
1
3
6
BK-OG
GN-RD
GN-BK
BK-GN
BK-RD
BK-WH
B:20
B:15
1
2
GY
BU
P4
P1
P3
P2
P5P6
M63/54
7/25_22
1
WH-VT
ACM
Group 23 Fuel system
Engine management system 4-cyl. 1.8l 2:2
-
7/27/2019 2005_Supplement_S40(04-)_V50_wiring_diagram.pdf
42/121TP3984202 S40 (04-)/V50 2005 42
6
5
4
1
2
3
2
1
MAF
R14
R11
2
1
2/32
8/81
2
8/91
2
2(85)
1(86)
3(30)
5(87)
8/71
2
2
18/6
30+
2
18/10
GY
WH-GN
BN
WH-VT
BN-WH7/16
3
1
2
2
1
1
2
F32
1
2
F35F34
2
11
2
F36
GN-BU
GN-BU
7/17
4
3
5
BN-BU
WH-RD
BN-RD
ETA
A:67
BK
BK
BK
BK
BK
31/89
31/88
GN-NU
3 1
2
4
20/7
GN-BU
3 1
2
4
20/6
WH-BK
GN-BU
3 1
2
4
20/5
20/4
4
2
13
GN-BU
WH-RD
WH
GN-BU
3 1
2
4
20/3
GN-YE
6/120
GN-BU
D
GN-YE
63/103
WH-GN
WH-BU
GN-YE
GN-YE
GN-YE
GN-YE
GN-YE
63/54
4/46.1
7/24
7/25
WH-BK
BN-YE
WH-RD
BN-RD
GN-RD
BK-OG
A
A:1
A:25
A:3
A:2
A:26
A:18
A:63
A:87
A:80
A:56
A:82
A:58
A:77
A:53
A:35
A:83
A:59
A:75
A:40
5 CYL
ECM
A:19WH-BU
A:74BN-BU
CAN
WH-BU
YE-BU
C
GN-BU
B
GN-BU
A:88
A:65
1
2/22
1
2
A:42
A:17
T
WH-BU
A:66
A:91
P7/156
3
2
1
4
GN-RD
YE-BU
BN-BU
A:33
7/6
1
P
BK-GN
A:62
A:39
BK-OG
BK-BU
BK-GN
BK-YE
BK-WH
A:15
A:44
15/31
RD-O
G
RD-O
G
F9
21
64/90
64/90
63/98
12 14 39
2
BN-RD
WH-RD
A:79
A:55
3
4
2
1
8/28
7/165P
4
GN-BU
A:51BN-YE
BK-GN A:38
M
GN-BU
BK-BU
41 40 35
2
8/84
1
6/114
P
63/121
31/114
BK
GN-R
D
BK
63/120
BK
1
2
F33
GN-Y
E
GN-B
U
GN-Y
E
GN-Y
E
GN-B
U
GN-B
U
GN-Y
E
63/13
GN-YE
1
2
1
9/322 GN-WH
BK-WH
BK-BU
7/15
GN-YE
GN-YE WH-RD
BN-RD
BN-RD
A:73
A:92
A:43
A:49
4
3
7/822 3
1 4
WH
GY
BK-YE
A:70
A:94
6
2
WH
BK-RD
BK-WH
BU
A:69
A:96
A:72
A:93
1
5
GN-BU
GN-BU
GN-BU
2
18/19
2
18/81
BK-OG A:502
18/18
Group 23 Fuel system
Engine management system 5-cyl. Turbo 1.8l 1:2
-
7/27/2019 2005_Supplement_S40(04-)_V50_wiring_diagram.pdf
43/121TP3984202 S40 (04-)/V50 2005 43
ECM
A:3
A:2
A:1
CAN
3/9 2
1
5 CYL
4/836/671
4
2
5
34 3 2 1
WH-B
K
GN-W
H
BK-O
G
31/84
63/53
30+
1
2
F18
CAN
CEM
F74
15/31
E:21
LIN
3/1 30
15X
5
50 S
B:7
B:2
64/1115
RD
RD
GY-BK
1
2
4/56
F57
1
2
1
2
F4
1
2
F26
1
2
F23
RD-Y
E
RD-B
U
RD
64/113
7
12
11
10
13
64/90
23
8
37
28
24
25
26
27
GY
GN-YG
GN-WH
64/1117
7/5115
2
6
3
4
R15
2/23
E:22
C:16
A:42
E:40
E:10
G:22
G:31
G:7
A:28
B:54
B:26
B:41
B:30
B:33
B:23
B:45
B:20
63/56
GN-WH
GN-YE
GY
RDRD
WH
YE
BN
E:28E:41
OG
OG-W
H
BK-Y
E
64/51
31/10
1412 9 10 1 1 7 8
63/12
WH-BK
BK-WH
WH-VT
YE-VT
BK-WH
WH-VT
YE-VT
WH-BK WH-BK
BK-WH
WH-VT
YE-VT
GN-BU
BK-Y
E
BKG
N-Y
E
GN-B
U
B:6
B:4
63/65
BK-YE
BK-YE
BK-YE
GN-BU
GN-BU
31/52
GN-BU
BK
GN-W
H
BK-W
H
WH-V
T
YE-V
T
GN-B
U
RD
1 4
31/11531/116
BK-O
G
63/25
BK
BK
BK-O
G
LHD
RHD
T
M
5 6
6/33.2
I5 PLASTIC
AWD 2WD
I5 PZEV
METAL TANK
6/331 4 2
BK-RD
M
5 6
1
GN-OG
GN-OG
BK-R
D
BK-R
D
B:16
4/46.1
A BK-BU
B:45
B:58
B:44
B:57
MAN
2 5
1 3
4
YE-RD
WH-VT
BN-WH
YE-BK
WH-BK
BN-YE
A:16
A:60
A:36
A:13
A:61
A:37
7/1721
2
3
7/1731
2
3
DCB
BK-O
G
BK-O
G
63/33
Group 23 Fuel system
Engine management system 5-cyl. Turbo 2:2
-
7/27/2019 2005_Supplement_S40(04-)_V50_wiring_diagram.pdf
44/121TP3984202 S40 (04-)/V50 2005 44
6/29
4/71
WH-RD
WH-RD
WH-RD
P
1
3
2
7/8
B:13
B:18
4/46.1
ECMB:7
1
30+
2
BK
31/114
CAN
F1
2
1
4
34
B:2532
29
19
YE-RD
WH-VT
BN-RD
YE-RD
WH-RD
BN-RD BN-RD
64/90
WH
-+
GN-Y
E
BK
2
1
OG-B
U
15/31
1
2
7/16
BN-WH
YE-VT
WH-VT
BN-WH
T
W/O T
T
W/O T
A:42
A:22
A:67
63/120
BK
B:45
B:58
B:44
B:57
63/63
CAN
ECM
1.8 L
I5
4/46.5
A:12
CAN
ECM
1.6L
SIGMA
4/46.3
A:10
Group 26 Cooling system
Cooling fan
-
7/27/2019 2005_Supplement_S40(04-)_V50_wiring_diagram.pdf
45/121TP3984202 S40 (04-)/V50 2005 45
6/29
4/71WH-RD
WH-RD
A:D2
4/46.2
ECMA:B2
1
30+
2
BK
31/114
CAN
F1
2
1
4
34
A:H25
19BK-BU
BU
64/90
WH
-+
GN-Y
E
BK
2
1
OG-B
U
15/31
1
2
7/16
WH
BN C:G1
C:A2
63/120
BK
1
2
8/119
2
14
38/127
BK
31/110
63/108
BK
63/109
BK-RD
BK-B
U
BK-BU
BK-BU
BK-YE
DW10
A:A3
A:A4
H
L
2
1
DV6
CAN
ECM
4/46.4
A:B2
Group 26 Cooling system
Cooling fan Diesel
-
7/27/2019 2005_Supplement_S40(04-)_V50_wiring_diagram.pdf
46/121TP3984202 S40 (04-)/V50 2005 46
A:2
A:3
SWS
3/4
A:118/4
SWM
3/254
C:9
C:8
B:58
B:45
F36
2
1
31/83
7/5165
2
3
1
4
4/46.3
ECM
G:22
G:31
G:7
GY
63/12
BK
BK-Y
E
GN-YE
WH
BN
BK-YE
CAN
CAN
30+
5(87)
3(30)
2(85)
1(86)
1
2
F9
R142/32
WH-BU
WH-RD
BN
YE
WH-BU
YE-BU
ETA
6/120
A:48
A:22
A:6
A:21
B:42
B:41
M
1
2
3
4
5
6
64/111
21I.6 L
SIGMA 28
7
YE
GY
BK-BU
A:47
A:8
CEM
7/123
G:12
G:23
G:21BN
YE
WH
3
2
1
63/5
64/60
BK
C:4BK-WH
31/84
F68
2
1
C:1
A:45
2/193:3
RD-O
G
RD-O
G
15/31
BK-B
U
4/56
4/56
63/30
B:3
B:2
B:5
64/90
RD
WH
BN
7/1241
3
2
CAN
BCM
4/16
15
1122
3
21
OG-B
K
CAN
G:15
G:14
F:14
F:16
MAN
F:6
F:3
F:5D:1
D:3
D:4
8
7
2
3
1
4
Group 27 Engine control
Cruise control 1.6l
-
7/27/2019 2005_Supplement_S40(04-)_V50_wiring_diagram.pdf
47/121TP3984202 S40 (04-)/V50 2005 47
A:2
A:3
SWS
3/4
A:118/4
SWM
3/254
C:9
C:8
B:58
B:45
F36
2
1
31/83
7/5165
2
3
1
4
4/46.5
ECM
G:22
G:31
G:7
GY
63/12
BK
BK-Y
E
GN-YE
WH
BN
BK-YE
CAN
CAN
30+
5(87)
3(30)
2(85)
1(86)
1
2
F9
R142/32
WH-BU
BK-OG
GN-RD
BN-BU
WH-BU
YE-BU
ETA
6/120
A:26
A:25
A:38
A:37
A:10
A:22
M
4 CYL W/O T
4 CYL W/O T
4 CYL W/O T
4 CYL W/O T
4 CYL W/O T
4 CYL W/O T
1
2
3
4
5
6
64/111
21I4
28
7
YE
GY
BK-BU
A:32
A:35
CEM
7/123
G:12
G:23
G:21BN
YE
WH
3
2
1
63/5
BK
C:4BK-WH
31/84
F68
2
1
C:1
A:45
2/193:3
RD-O
G
RD-O
G
15/31
BK-B
U
4/56
4/56
63/30
B:3
B:2
B:5
64/90
RD
WH
BN
7/1241
3
2
CAN
BCM
4/16
15
1122
3
21
OG-B
K
CAN
G:15
G:14
F:14
F:16
MAN
F:6
F:3
F:5D:1
D:3
D:4
Group 27 Engine control
Cruise control 1.8l
-
7/27/2019 2005_Supplement_S40(04-)_V50_wiring_diagram.pdf
48/121TP3984202 S40 (04-)/V50 2005 48
Group 27 Engine control
Cruise control 5-cyl.
A:2
A:3
SWS
3/4
A:118/4
SWM
3/254
C:9
C:8
B:58
B:45
F36
2
1
31/83
7/5165
2
3
1
4
4/46.1
ECM
G:22
G:31
G:7
GY
63/12
BK
BK-Y
E
GN-YE
WH
BN
BK-YE
CAN
CAN
30+
5(87)
3(30)
2(85)
1(86)
1
2
F9
R142/32
YE
BK-OG
GN-RD
BN-BU
WH-BU
YE-BU
ETA
6/120
A:96
A:15
A:72
A:24
A:74
A:75
5CYL T
M
5CYL T
5CYL T
5CYL T
5CYL T
5CYL T
WH-BU A:193
M
5
6
4 A:74
YE-BU
A:88WH-BU
BN-BU
A:65
5CYL W/O T
ETA
6/120
2
1 A:75
BK-OG
GN-RD
A:40
5CYL W/O T
5CYL W/O T
5CYL W/O T
5CYL W/O T
5CYL W/O T
1
2
3
4
5
6
64/111
21I5
28
7
YE
GY
BK-BU
B:26
B:16
CEM
7/123
G:12
G:23
G:21BN
YE
WH
3
2
1
63/5
BK
C:4BK-WH
31/84
F68
2
1
C:1
A:45
2/193:3
RD-O
G
RD-O
G
15/31
BK-B
U
4/56
4/56
63/30
B:3
B:2
B:5
64/90
RD
WH
BN
7/1241
3
2
CAN
BCM
4/16
15
1122
3
21
OG-B
K
CAN
G:15
G:14
F:14
F:16
MAN
F:6
F:3
F:5D:1
D:3
D:4
-
7/27/2019 2005_Supplement_S40(04-)_V50_wiring_diagram.pdf
49/121TP3984202 S40 (04-)/V50 2005 49
Group 27 Engine control
Cruise control 4-cyl. Diesel
SWM
3/254
C:9
C:8
A:A4
A:A3
F36
2
1
31/83
7/5165
2
3
1
4
4/46
ECM
DV6/
DW10
G:22
G:31
G:7
GY
63/12
BK
BK-Y
E
GN-YE
WH
BN
BK-YE
CAN
CAN
30+
5(87)
3(30)
2(85)
1(86)
1
2
F9
R142/32
64/111
21
28
7
YE
GY
BK-BU
A:F3
B:H3
A:B3
B:E1
CEMG:21
G:24BN
GN-YE
63/5
BK
C:4BK-WH
31/84
F68
2
1
C:1
A:45
2/193:3
RD-O
G
RD-O
G
15/31
BK-B
U
4/56
4/56
64/90
RD
WH
BN
7/1241
3
2
CAN
BCM
4/16
15
1122
3
21
OG-B
K
CAN
G:15
G:14
F:14
F:16
MAN
3/39 2
3
D:4 F:3 B:5
D:1
D:3
F:5
F:6
18/4B:3
B:2
63/30
A:3
SWS
3/4
A:1
A:2
1.6 DV6
DW10
DW10
1.6 DV6 GY
BK-BU
-
7/27/2019 2005_Supplement_S40(04-)_V50_wiring_diagram.pdf
50/121TP3984202 S40 (04-)/V50 2005 50
Group 32 Generator and voltage regulator
Power supply 4-cyl.
A:3
VOLT. REG.
6/26
M
6/25
31/4
31/3
BK
BK
7/3
2
1
B:1
BN
WH
B:1
RD
RD
1 2
PF1
1
2
BN
WH
GY
GY
CEM
4/56
CANG:13
LIN
G:6
12V
1/1
- +
A:1 A:2
BU
BU
GY
GY
BU
BU
A:A1
B:H4
B:20
B:15
F31
2
1
20 64/90
PF22
RD
RD
RD
15/31
B+
1
A:1
ECM
4/46.5
CAN
1.8 L
ECM
ACM
4/46.2
CAN
DW10
A:M33
A:M7
ECM
4/46.3
CAN
1,6 L
SIGMA
B:A3
C:B1
ECM
4/46.4
CAN
DV6
-
7/27/2019 2005_Supplement_S40(04-)_V50_wiring_diagram.pdf
51/121TP3984202 S40 (04-)/V50 2005 51
A:2
VOLT.REG.
B+6/26
M
6/25
31/4
31/3
BK
BK
CEM
ACM
CAN
7/3
2
1
B:1
G:13
BN
WH
LIN
B:1
RD
RD
1 2
PF1
1
2
BN
WH
G:6
12V
1/1
- +
A:1
4/56
CAN
4/46.1
ECM
CAN
4/46.1
ECM
Turbo
W/O T
88
21
WH-RD
WH-RD
Group 32 Generator and voltage regulator
Power supply 5-cyl.
-
7/27/2019 2005_Supplement_S40(04-)_V50_wiring_diagram.pdf
52/121TP3984202 S40 (04-)/V50 2005 52
Group 33 Starting system
Starting system 4-cyl.
12V
1/1
1
F26
2
E:9
CEM
4/56
RD
A:42
CAN
GY
3/1 30
15X
5
50 S
B:7
B:2
4 1164/90
64/120
31/3
BK
31/4
BK
1
F13
2
5 64/111
GY
BK-RD
GY-B
K
15/31
2
PF2
1
5
1
R13
2/353
2
2
PF1
1
RD
RD
RD
3/39 2
3
BN
GN-YE
G:24
G:21
RD-GN
6/26 B:1RD
M
A:16/25 B:1
CAN
4/46.5
ECM
A:4 1.8 L
CAN
4/46.3
ECM
B:F30 1.6 LSIGMA
CAN
4/46.4
ECM
C:A1 DV6
MAN
5
1
R1
3
2
2/165
31
CAN
4/46.2
ECM
A:D1 DW 10
GY
GY
GY-OG
BK-R
D
BK-R
D
BK-R
D
BK-R
D
CAN
4/28
TCM
10
GY-O
G
1
F54
2
E:1A:17
B:3 GN-Y
E
MAN
GY-BK
GY
1
-
7/27/2019 2005_Supplement_S40(04-)_V50_wiring_diagram.pdf
53/121TP3984202 S40 (04-)/V50 2005 53
Group 33 Starting system
Starting system 5-cyl.
12V
1/1
1(86)3(30)
1
R132/35
F13
2
E:9
CEM
4/56
RD A:42
CAN
BK-R
D
3/1
30
15X
5
50 S
B:7
B:2
RD
GY-BK
GY
4 31
64/90
5(87) 2(85)
CAN
4/28TCM
A:5
A:9
31/52
BK-Y
E
31/3
BK
31/4
BK
1
F26
2
5 64/111
RD-G
N
RD
RD
CAN
4/46.1
ECM B:15
63/53
BK
B:17
I5
B:8
GN-B
U
BK-R
D11 GY
64/90
GN-B
U
GY-WH
LIN
15/31
B:1 6/26B+
L
G31
2
PF1
1
MAN
AUTO
A:3
3
2
1
7/123BN
WH
YE
G:21
G:23
G:12
M
A:1 6/25 B:1
GN-B
U
2
PF2
1
RD
ACM
-
7/27/2019 2005_Supplement_S40(04-)_V50_wiring_diagram.pdf
54/121TP3984202 S40 (04-)/V50 2005 54
BK
GN-BK
CAN
63/211
31/11 31/12
F:14
F:16
D:14
D:15
A:6
A:8
TCM
4/28
30+
F18
2
11
2
F4
MAN
63/53
MAN
M5
6/M66,I5LT
NA/LT
GN-BUGN-YE
GN-W
H
64/90
10
31/52
E:14
4/56
AW55-51
CFT 23
CEM
3/10 2, 3
1
GN-BKGN-BK
BK
V50
10/55
10/48
BK
V50
BK
F79
2
1
LIN
CAN
LIN
15/31
C:45
E:21
E:22
GN-BK
S40 S40
BK
BK
2/80
R2
TAIL
FOG
BACK
10/18
10/18
A:4
C:4
C:2
A:2
TAIL
FOG BACK
GND GND2
TURNSTOP
10/55
10/17
A:2
A:4
TAIL
FOGBACK
GNDGND2
TURNSTOP
10/48
TURN
STOP
A:2A:3 C:3 C:1
A:4
TAIL
FOG
BACK
10/17
C:2
C:4
TURN
STOP
A:2 A:3C:1C:3
A:4
C:4 C:2
A:1 C:1C:3C:4C:2C:1A:3C:3
V50V50
S40S40
3/156
3/15664/90
A:1 WH-RD RD33
64/111
2 2
LIN
3/155GSMWH-RD
64/90A:1 WH-RD RD
33
64/111
2 2
LIN
3/155GSMWH-RD
AUTO
RD-YE
RD-BU
GN-B
K
UP
UP
UP UP
MAN
IB5
SIGMA
MAN
M56
DW10I4
MAN
MT
X75/MMT6
I4DV6/D
W10
Group 35 Lighting
Reversing lights
-
7/27/2019 2005_Supplement_S40(04-)_V50_wiring_diagram.pdf
55/121TP3984202 S40 (04-)/V50 2005 55
Group 36 Additional electrical equipment
Electronic immobilizer
F4
2
1
30+
1
2
F18
CAN
CEM
4/56
31/83
63/5
E:21 E:22
LIN
RD-Y
E
RD-B
U
15/31
B
K
G:14
1
2
F26
64/1115
63/339G
WH-GN B:17WH-GN
A:15
B:13
BK-Y
E
WH-G
N
RD-B
K
RD-G
N
RD-G
N
A:2A:1A
:3B:5B:6B:8
RD
RD
B:7
PATS
MODULE
0
12
3
KEY ININHIBIT
32 1
0
B05
IMOBILIAIZERSUPPLY
S B1
B2
50
15
XB4
30
POWER
GROUND
3/1
LIN
SCU
G:15
F:16
F:14
A:42GY-BK
BU-R
D
B:2 B:3 B:1
POWER
LIN BUS
GND
31/6
63/6
B
K
BK
WH-GN
OG-BK
3
4
2
4/102
SCL
B:10
R13
2/35
4 5 1
3 2
F13
2
1
64/90 11 4
RD-G
N
BK-R
D
GY
CAN
ECMBK-R
D
B:8
4/46.1
6/25A:1
GN-B
U
Petrol
GY
Diesel
GY
E:9
LIN
63/88
CAN
ECM
DW10
I5
4/46.2
CAN
ECM
1.8 L
DV6
4/46.5
BK-R
D
BK-R
D
BK
-RD
A:D1
A:4
CAN
ECM
1.6L
SIGMA
4/46.3
CAN
ECM4/46.4
B:30
C:A1
-
7/27/2019 2005_Supplement_S40(04-)_V50_wiring_diagram.pdf
56/121TP3984202 S40 (04-)/V50 2005 56
CAN
4/56
CEM
CAN
A:9
A:18
A:14
3/126
DDM
A:12
A:3
BK
WH
16
64/41
8
3/78
M
3
2
8
1